NC0037371_authorization to construct_19930507

State of North Carolina
Department of Environment, Health and Natural Resources
Division of Environmental Management
512 North Salisbury Street • Raleigh, North Carolina 27611
James B. Hunt, Jr., Governor A. Preston Howard, Jr., P.E.
Jonathan B. Howes, Secretary Director
May 7, 1993
Mr. Jessee B. Register
Iredell-Statesville Schools
Post Office Box 911
Statesville, North Carolina 28677
Subject: Permit No. NC0037371
Authorization to. Construct
Iredell-Statesville Schools
Wastewater Treatment Facility
Iredell County
Dear Mr. Register:
A letter of request for an Authorization to Construct was received January 5, 1993 by the Division
and final plans and specifications for the subject project have been reviewed and found to be satisfactory.
Authorization is hereby granted for the cleaning and refurbishing the existing 12,000 GPD extended
aeration wastewater treatment facility by removing and replacing all existing piping and electrical
equipment, cleaning and recoating all tanks and equipment, relocation of the two existing blowers and the
addition of four blowers, replacing the dual equalization basin pumps with 1/3 hp pumps, replacing the
existing sludge holding basin with a new 3,000 gallon aerated sludge holding basin, and replacing the
existing chlorination and post -aeration basins with a 1,000 gallon chlorination/dechlorination/post-aeration
basin with a tablet type chlorinator and dechlorinator with continued discharge of treated wastewater into
Patterson Creek.
This Authorization to Construct is issued in accordance with Part III, Paragraph A of NPDES
Permit No. NC0037371 issued May 1, 1992, and shall be subject to revocation unless the wastewater
treatment facilities are constructed in accordance with the conditions and limitations specified in Permit No.
NC0037371.
The sludge generated from these treatment facilities must be disposed of in accordance with G.S.
143-215.1 and in a manner approved by the North Carolina Division of Environmental Management.
In the event that the facilities fail to perform satisfactorily, including the creation of nuisance
conditions, the Permittee shall take immediate corrective action, including those as may be required by this
Division, such as the construction of additional or replacement wastewater treatment or disposal facilities.
Regional Offices
Asheville Fayetteville Mooresville Raleigh Washington Wilmington Winston-Salem
704/251-6208 919/486-1541 704/663-1699 919/571-4700 919/946-6481 919/395-3900 919/896-7007
Pollution Prevention Pays
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone]
An Equal Opportunity Affirmative Action Employer

Permit No. NC0037371
Authorization to Construct
Iredell-Statesvlle Schools
May 7, 1993
Page 2
The Mooresville Regional Office, telephone number [phone], shall be notified at least forty-
eight (48) hours in advance of operation of the installed facilities so that an in -place inspection can be
made. Such notification to the regional supervisor shall be made during the normal office hours from 8:00
a.m. until 5:00 p.m. on Monday through Friday, excluding State Holidays.
Upon completion of construction and prior to operation of this permitted facility, a certification
must be received from a professional engineer certifying that the permitted facility has been installed in
accordance with the- NPDES Permit, this Authorization to Construct and the approved plans and
specifications. Mail the Certification to the Permits and Engineering Unit, P.O. Box 29535, Raleigh, NC
27626-0535.
Upon classification of the facility by the Certification Commission, the Permittee shall employ a
certified wastewater treatment plant operator to be in responsible charge (ORC) of the wastewater treatment
facilities. The operator must hold a certificate of the type and grade at least equivalent to or greater than the
classification assigned to the wastewater treatment facilities by the Certification Commission. The
Permittee must also employ a certified back-up operator of the appropriate type and grade to comply with
the conditions of Title 15A, Chapter 8A, .0202. The ORC of the facility must visit each Class I facility at
least weekly and each Class II, III, and IV facility at least daily, excluding weekends and holidays, and
must properly manage and document daily operation and maintenance of the facility and must comply with
all other conditions of Title 15A, Chapter 8A, .0202.
A copy of the approved plans and specifications shall be maintained on file by the Permittee for the
life of the facility.
A leakage test shall be performed on all new tanks to insure that any exfiltration occurs at a rate
which does not exceed twenty (20) gallons per twenty-four (24) hour per 1,000 gallons of tank capacity.
The engineer's certification will serve as proof of compliance with this condition.
Failure to abide by the requirements contained in this Authorization to Construct may subject the
Permittee to an enforcement action by the Division of Environmental Management in accordance with
North Carolina General Statute 143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not preclude the Permittee from complying
with any and all statutes, rules, regulations, or ordinances which may be imposed by other government
agencies (local, state, and federal) which have jurisdiction.
One (1) set of approved plans and specifications is being forwarded to you. If you have any
questions or need additional information, please contact Mr. Dana J. Bolden telephone number 919/733-
5083.
Sincerely,
Freston Howard, Jr., P.E.
cc: Iredell County Health Department
Mooresville Regional Office, Water Quality
Training and Certification Unit
Facilities Assessment Unit