NC0048763_Regional Office Historical File Pre 2018

Governor
William G. Ross Jr., Secretary
Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
.jUjl 0, 4 2902
Mr. D.J. Youngblut
Furst-McNess Company
2000 Expansion Blvd.
Storm Lake IA 50588
Subject: Rescission of NPDES General Permit
Permit No. NCG060128
Furst-McNess Company
Iredell County NC
Dear Mr. Youngblut:
N.C.RE0IFI� E"D
7�1DeV 1 -�
J U N Z 5 2002
Winston-Salem
Regional Office
Reference is made to your May 15, 2002 request for rescission of the subject NPDES General Permit..
Therefore, in accordance with your request, NPDES General Permit No. NCG060128 rescinded, effective
immediately.
Please be advised that this permit rescission is based wholly upon your statement that the activities which
would require general permit coverage at the site have ceased or been eliminated. Division staff has not visited the
site to obtain independent verification. If in the future you wish to again discharge wastewater to the State's
surface waters, you must first apply for and receive a new NPDES Permit. Operating a facility, discharging
wastewater or discharging specific types of stormwater to waters of the state without a valid NPDES Permit will
subject the responsible party to a civil penalty of up to $25,000 per day. Enforcement action will be certain for
person that have voluntarily relinquished permit coverage when, in fact, continuing permit coverage was necessary.
If, in retrospect, you feel the site still requires permit coverage, you should notify this office immediately.
Furthermore, if in the future you wish to again discharge to the State's surface waters, you must first apply for and
receive a new NPDES permit.
If the facility is in the process of being sold, you will be performing a public service if you would inform the
new or prospective owners of their potential need for NPDES permit coverage.
You have questions about this matter, please contact Marcia Lieber at [phone], 530 or the Water
Quality staff in our Winston-Salem at [phone].
Sincerely,
Alan W. Klimek, P.E.
cc: fs•1 • - . t I fl tity�Reuional4S.upertvisor w/attachments JUN 2 7 2002
Stormwater & General permit Unit
Point Source Compliance -Bob Sledge
Mr. Roosevelt Childress, EPA
Central Files - w/attachmentsvJ
Fran McPherson, DWQ Budget Office
4C'x:R 3�
Customer Service Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617
1 800 623-7748 [phone]

I NORTH CAROLINA DEPARTMENT OF
701- ENVIRONMENT AND NATURAL RESOURCES
iS
INVOICE Z �O
Annual Permit Fee
This annual fee is Y
required b the North Carolina Administrative Code. It coffers the administrative costs
q
associated with your .permit. It is required of any person holding a permit for any time during the annual fee
period, regardless of the facility's operating status. Failure to pay the fee by the due date will subject the
permit to revocation. Operating without a valid permit is a violation and is subject to a $10,000 per day fine.
If the permit is revoked and you later decide a.permit is needed, you must reapply, with the understanding
the permit request may be denied due to changes in environmental, regulatory, or modeling conditions.
Permit Number: NCG060128 Annual Fee Period: 3!1/2002 to 2/28/2003
Furst-Mcness Company Invoice Date: April 15, 2002
Account Payable Due Date: May 15, 2002
Furst-Mcness Company
2000 Expansion Blvd Annual Fee: $80.00
Storm Lake IA 50588
Notes:
1. A $20.00 processing fee will be charged for returned checks in accordance with the North Carolina
General Statute 25-3-512.
2. Non -Payment of this fee by the payment due date will initiate the permit revocation process.
3. Remit payment to:
NCDENR -Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
4. Should you have any questions regarding this invoice, please contact the Annual Administering and
Compliance Fee Coordinator at 919-733-5083 extension 210.
ANNUAL PERMIT INVOICE
(Return This Portion With Check)
Permit Number: NCGO60128
Furst-Mcness Company
Account Payable
Furst-Mcness Company
2000 Expansion Blvd
Storm Lake IA 50588
Annual Fee Period: 3/1/2002 to 2/28/2003
Invoice Date:
Due Date:
Annual Fee:
Check Number:
April 15, 2002
May 15, 2002
$80.00
-N�

.Find Records
Main Menu - f,F Print Record
PermitBilling .System);
r i Permt Number NCG060128 County Iredell
Owner's
Name[Account Payable Address 12000 Expansion Blvd
+
Storm Lake
Facility urst- cness Company 11A
Phone'18152356151
PAYMENT PAYMENT
GREEN CARD START
INVOICE
DUE RECEIVED AMOUNT CHECK
NOV SIGNED ENFORCEM .
DATE
FEE _DATE DATE RECEIVED NUMBER PAYOR
DATE DATE DATE
,.4/ S1 AIR
y �dk36" �
'�.6•s,k.a a�w'3'+.u.,yl�:'s'atii"j. �
COMMENTS
PIM2 reml
4/11/2001
$80.00 5/11/2001 5/17/2001 $80.00 344543 FURST MCNESS
o T
EFOITNOV
COMMENTS
4/11/2000
$80.00 5/11/2000 5/1/2000 $80.00 318927 FURST MCNESS
::
I`-'�
COMMENTS
4/15/1999
$80.00 5/15/1999 5/12/1999 $80.00 292513 FURST MCNESS
p o �—
COMMENTS
.
j

Date: September 15, 1986
NPDES STAFF REPORT AND RECOMMENDATIONS
County: Iredell
NPDES Permit No. NC 0048763
PART I - GENERAL INFORMATION
1. Facility and Address: Furst-McNess Company
U. S. Highway 70 East
Statesville, North Carolian"��8677
2. Date of Investigation: September 10, 1986
3. Report Prepared By: G. T. Chen
4. Persons Contacted: Mr. D. W. Riddle, Plant Manager; Mr. Bob Byers, Maintenance
Supervisor; [phone].
5. Directions to Site: Travel I-77 to Statesville, North Carolina and take exit
at Exit 49 (U. S. Highway 70 East). After exit, .turn right and proceed on
U. S. 70 East for approximately 4.4 miles to the S. R. 2527.
junction with Furst McNess Company is on the right (west) side of S. R. with
2527.
6. Discharge Point - Latitude: 35045110"
Longitude: 80047140/1
Attach a USGS Map Extract and indicate treatment plant site and dis
point on map. charge
USGS Quad No. D 15 SE
7. Size (land available for expansion and upgrading): N/A. No treatment facility.
8. Top(Sgraphy (relationship to flood plain included): Relatively flat with 2-5%
slopes.
9. Location of Nearest Dwelling: No dwellings within 1000 feet.
10. Receiving Stream or Affected Surface Waters: Unnamed tributary to Third
Creek.
a. Classification: C
b. River Basin and Subbasin No.: 03-07-06
c. Describe receiving stream features and pertinent downstream uses: Used
for secondary recreation, fish propagation and agriculture.
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
1. Type of Wastewater: 0% Domestic
100% Industrial
a. Volume of Wastewater: N/A
b. Types and quantities of industrial wastewater: The discharge consists
solely of the condensation water from a refrigeration -dehumidification
unit installed in the Preparation -Warehouse building. According to Mr.
Bob Byers, Maintenance Supervisor, the amount of daily discharge from
this facility is less than ten (10) gallons of condensation water.

Page Two
C. Prevalent toxic constituents in wastewater: None
d. Pretreatment Program (POTWs only): N/A
2. Production Rates (industrial discharges only) in Pounds: N/A
3. Description of Industrial Process (for industries only) and Applicable CFR
Part and Subpart: Feed supplements preparation.
4. Type of Treatment (specify whether proposed or existing): None
5. Sludge Handling and Disposal Scheme: N/A
6. Treatment Plant Classification: N/A
PART III - OTHER PERTINENT INFORMATION
1. Is this facility being constructed with Construction Grants Funds (municipals
only)? N/A
2. Special monitoring requests: N/A
3. Additional effluent limits requests: N/A
4. Other: N/A
PART IV - EVALUATION AND RECOMMENDATIONS
The wastewater discharged from this facility consists exclusively of the
condensation water from a refrigeration -dehumidification unit installed in the
Preparation -Warehouse building. The amount of discharge (less than 10 gpd,
according to Mr. Byers) generated from this facility is negligible. This
is due to the fact that the Company no longer discharges cooling water from its
compressor. The heat generated from the compressor is dissipated with the aid of
an auxilliary fan.
It is recommended that the Permit be renewed.
Sig�
natureof Report Preparer

�e - y �`ti .r9'r�'cl� ' �ti !r: �Y _ 11 ,�.�v V: �`2; j � \\ r i/ ���LV I 1 ��� ` _' C 11 i�� �—_� �' `•'� - (C �
R 737
,, __ / /j j j o jai ,; - � � 11 ,�. \� - O-�`----.•'I;
,t"j
868
`�`'^ ram'' � :,� �„'. =/�/-• =1L, � �, .'� -, ,� o' ire - -
%1
1 j� '� SF 0 _ Y. ,y - _ .ter/ �... � - _ � ) -•-i �i -� (1
Ink
�.' �.q.. �.O ,el ll.r :� , ,``r / i � ..1 / •M�_� ..i // \..7`=i.
if
• \;l ` �,_ II E: °I n ___ 1, \ \ ! _ ,,,T¢RIoe-GEOLOGIC IL sVRVEV •wwer.�ae*oL
5 520 CL£VELA7
.516 (SHEPHERDS) 518 47 0' 19 521�"'E.
4855 1// NE ROAD CLASSIFICATION
SCALE 1:24000 1 MILE Light -duty roa
7 p Primary highway, B Y
.000 p 1000 2000 3000 4000 5000 6000
7000 FEET hard surface improved surf
1 KILOMETER f'IllSt McNess CDny Secondary highway,
1 5 0 hard surface Unimproved r
CONTOUR INTERVAL 10 FEET ` ' Interstate Route U. S. Route
• DATUM IS MEAN SEA LEVEL
! ■N C
STATESVILLE

,t
7G
'$j�1f4$40N OF ENV!^O JENTAL h4ANAQENII°A13
�d MAY 12 1988 State of North Carolina
Depi 4: , nt of Natural Resources and Community Development
i Division of Environmental Management
0
512 North-ASalisbury Street • Raleigh, North Carolina 27611 10
i James G. Martin, Governor
' S. Thomas Rhodes, Secretary
i l P! �j
��ti'. �?• Lti�. �'.! Cw k, � r�t;�6• ,rfk.."ri��
J
Dear f1`f:` 9
b f' R. Paul Wilms
Director
Subject: NPDES Permit Application
NPDES Permit No. NC00;.-2'7&,
it"� J,t, � 1 'County
This is to acknowledge receipt of the following documents on li--#w=`n d(p
Application Form, I
Engineering Proposal (for proposed control facilities),
Request for permit renewal,
= Application Processing Fee of $,7 ', f)j,� ,
Other
The items checked below are needed before review can. begin:
Application form _ (Copy enclosed),
Engineering Proposal See Attachment),
Application Processing Fee of $ ,
Other
�`.��;F.'- !„���6 '� ail f_.��'l`r`'7C' i -P �:i 1(`.F ,.r!':,,•c::; G' c
a rig 1'' r,t�' jv E � x'/`♦ A X F r,
•$? F,�r:. ... a''!' f) t' e�Y. ,^ st,�: ss`"_. :.%`;i r'3' i �^? ,:.`.`ii1'I- J8 �?l `i—t/� 0 f" !� Ci J e v3 ,.L�L?'�.�i {....
E
If the application is not made complete within thirty 30) days, it will
be returned to you and may be resubmitted when complete.
This application has been assigned to
(919/733-5083) of our Permits Unit for review. You will be advised of
any comments recommendations, questions or.other information necessary
for the review of the application.
I am, by copy of this letter, requesting that our Regional Office
Supervisor prepare a staff report and recommendations regarding this
discharge. If you have any questions regarding this application, please
contact the review person listed above.
f S ,nce.re1yIV
74--Arthur Mouberry, P.E.
Permits and Engineering
c c `r`f a r"•L:lj f° i/fY �f('tf ,J
Pollution Prevention Pays
P.O. Box 27687, Raleigh, North Carolina 27611-7687 Telephone [phone]
An Equal Opportunity Affirmative Action Employer

n
FURST - McNESS COMPANY
FREEPORT, IL 61032 • STATESVILLE, NC 28677 • STORM LAKE, IA 50588
[phone] [phone] [phone]
April 28, 1986
I U
Mr. M. Dale Overcash, P'E.
Permits and Engineering Unit
N.C. Division of Environmental Management
P. O.'Box 27687
Raleigh, N.C. 27611-7687
Subject: Permit Number 0048763
Dear Sir:
The Furst-McNess Company is requesting the renewal of our
wastewater permit number NC0048763. Our discharge has not chafig6d
and remains less than 999 GPD.
You will find our check number 41427 for $25.00 to cover
the renewal of this permit.
Sincerely,.
D. W. Riddle
Statesville -Plant Manager
- DWR/so
encl.

STATE OF NORTH CAROLINA
DEPARTMENT OF NATURAL :RESOURCES & COMMUNITY DEVELOPMENT
.DIVISION OF ENVIRONMENTAL MANAGEMENT -
PERM IT
To Discharge Wastewater. Under the NATIONAL
G -.POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provisions of North Carolina General Statute 143=215.1,.
other lawful standards and regulations promulgated and adopted by the North Carolina
Environmental Management Commission, andthe Federal Water Pollution Contr.ol'Act, as
I amended,:
I -Furst' McNess, Company
is'hereby authorized to. discharge..wastewater froma facility located;at
States.vi 11 e
Iredel T ,County
to receiving waters
.Unname&Tributary ;to Third Creek in•:the Yadkin River gasi.n
in accordance with effluent limitations, monitoring requirements, and other.
conditions set forth in .Parts I, II; and III hereof._
This permit'shall become effective
This permit and the.authorization to discharge shall expire at midnight
on
. i
j Signed this day of
Robert F. Helms, Director
Division of.Environmental Management
By Authority'of the Environmental
Management Commission'

A. (1). EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
During the period beginning on the effective date and lasting until expiration,
permittee is authorized to discharge from outfall(s) serial number(s). 001.
Such discharges shall be limited and monitored by the permittee as specified below:
Effluent Characteristics Discharge Limitations Monitoring Requirements
Kg/day (Ibs/day) Other Units (Specify) Measurement # Sample ,Sample
Daily Avg. Daily Max. Daily Avg. Daily Max. Frequency Type Location
Temperature* monthly Grab E, U, D
There shall be no chromium, zinc or copper added to the cooling water.
*Sample Locations: I -Influent, E-Effluent, U-Upstream, and D-Downstream *All stream samples shall be grab
***The temperature shall be'such_ as not to cause an increase in the stream water temperature of more than 5OF,above ambient
stream water temperature and i.n. ho case cause the stream, water temperature to exceed 90OF.
The pH shall not be less than 6.0 standard units nor greater than 9.0 standard.units
and shall be monitored monthly at E, U, D, by grab samples.
There shall be no di scharge_;,of fl oat,i ng solids or visible foam, i:n:;::ather =;than ,trace amounts.
J.
C+
C+
/-4 '
z
Q

PART III
Page of
Permit'No'. NC
B. -Previous Permits
All previous State water quality permits issued to this facility,
whether for construction or operation or.discharge, are hereby revoked
. y:issuance of this permit.. The conditions, requirem6nts,.terms, and-
p Osi*ons of ',this' Petmit,�authorizfng disch6rg ' e under Nati'dnal
fo this"'
Pollutant Discharge-El-,imination System governs distharg6s from
facility..
C*. Construction
No. construction of wastewater treatment facilities or additions thereto'
shall be begun.until Final Plans and Specifications have'been submitted
to the Di`visi'on of Environmental Management and written approval and
Authorization to Construct has been issued. If no objections to Final.
Plans and,Specifications has been -made by the DEM after 30 days -following
receipt of the-plans'or -issuance.of,this-permit,,whi.chever-is latter, the
plans may be considered approved and construction 'authorized.
D. ',Certified Operator Not Applicable
Pursuant to'Chapter 90A.of North Carolina General Statutes, the permittee
shall -employ a certified wastewater treatment plant operator in responsible
charge of the wastewater treatment facilities. Such operator must hold a
,certificati,on of the grade equivalent to the classification assigned to
:.ih"e wastewater treatment facilities.
i.
M 15/ & 1'121.

STAB PORT MD RECOr 1ENDATIONS
PART I -
INSPECTION OF WASTEWATER TREATMENT PLANT_'SITE
1.
.. pl ace _ Visited- Furst -McNes s Company ,
Statesville, Iredel1, County.
2.- .
'Date: duly 23, 1981
3.
% +'
� By: Mike Parker. /!
4.
Persons Contacted: Mr. D. Wd. Riddle
5.
Directions to Site: Travel east of Statesville on U.S. 41ghway.70 to.
the intersection of U.S. 70 and SR 2527. The site is -located, at the
end of SR 2t27.
6.
The Bearing and Distance to -the Proposed Point o_f. E-fluent Dischyr. Is:
N/A. °.The coordinates of the discharge are: N - 35 45'.10" 14 - 00 47'40"
7.
"Size: t,J/A. The discharge is non -contact cooling water t4ith,no treatment
facility:
3.
Topography: Relatively' level with a slope of 2 to 5%.
9.
Location of Nearest Neliingg.- None within 500 feet of the si"te..
10.
Receiving Stream: . !Unnamed tributary, -to Third Creek
(a) Classification: 61C"
b Minimum.. 7. Day, INYear Diskharge at Site: 000 cfs (est. )
(c) Usage: Fishing; boating, wading and any other best usage except
for bathing or as a source of +viater supply for -drinking, culinary
or food -processing purposes.
PART II -
DFtCRIPTIQN,� OF TREATL4FNT WORKS
The discharge from Furst-McNesS Crzmpany consists of .non -contact cooling
seater .from, a 25 n.p. compressor.
PART III -
EVALUATION ANQ W.COMMENDATIONS
The discharge consists entirely ,of non -contact cooling water -frrnm a 25 h.0.
cptressor.
i
It is recormiended.an, NPDES' Permit be issued for this, discharge:

er

J`�r��:�atlI .,- ••1� � i-r1 ;'`i �ir�,! /. ��� •'l�\(1(;\�y,�\�:� ��y�%�� ' 1��'\� ti�Ir�/L� IlIurI)ilrrl A�lI,�Ii.i�'l'��r.']�`Y`I�I�(1I] �f�,`1�1�)II�.i./r14I'��I . . ('�'�Ir �1 r t�: 1 I 1%li� I �y'r/I' i�, �'�1�� ' gc)/�I �(.\li1\�1l.I 'r I�' II ' 1 rI 11 tI1L,1b1�l11,11;11�1 �.JI ���`(�1,�1.�I1`1�!1Et]�.1,' �I /I I,, ,'v1��1.,�—_,�� \4�'1�� �.. ,IV`� .. }(.�]. 0 7 v,
'�I,1 1\ �1�jrj\'C,l�ljil�.�Il`,;r /�„_ c-((Il � l;(���,��,�l���v� ;�.�/�l �;�\ .�� ___;t.� �
)�'t,I�`��,��� ,,�1�1�l I_' II�'
�i
1'` . I`fIi'1
Y 41 Y. 0
yv;'
00 X.,
V,
k,.
l I ) I } 1
'N\ ` ��J/ , , ;.,,
j
cl\V _:; `' _. i t�„ _ "/,`r �,3':\ \ \) / %, f rll/ ]''.% 1i._��� F "~' �i ,�'
J)JU
3)
_j
10
-�1��,�\, /;��� �� _. ��� `1 :/�-- J .r ./��' - ''` ' 1/ � f) �,r � .�/ )�li',.: j��-`.� I�'J ,'r -' �1 �`�`1- (" ll'\.. '� ,} - I)�,
l _\L`1\ � \11 `,'/� I r ' \��, I �, .-,�� 1� ��1` \\�� �/ t `� �� (� /�� , �\;�� \ J��.� ;-\'` 1, � 2 , ��,/r. � � S \I I'� � �lh�(�J i/1,.,. \`I•l ) /1
)v
���`�� 'lr� \ 1. (� �'ff -- — \ \. 1 __i l �� ,'.0 1 Yi —)/ � /� � �, S � rr ., 1 � Yjll � � � �1�\ � J� �1 �---,\ \p rti ,�� .— �// `�: �_.
3957000m-N.
N1-
I (�\` -\ .� �1\ �, I\ ���il(� ��� -!)�. /� \��,)��\ �� J/ ­7 V'
;0
k X\\ rim
00.
Y� 1- 35045'
51 IN L41oli—sVOL WAL bLJ14VCY, WAT1141 4. 0
8
(SHEFFIZERDS) 519 520
P t 11 1;
47'30" V I r_ 80'4 5'
4855 Ill NE 521OD"1111, CLIE E. 1 4 1.
SCALE 1:24 000
ROAD CLASSIFICATION
<
Primary highway, Light -duty road, hard o r
?000 3000 4000 5000 6000 7000 FEET hard improved surface
0 Secondary highway,
hard surface Unimproved road
OUR INTERVAL 10 FEET
UM- IS MEAN SEA LEVEL Interstate Route U., 8. Route State Route
■ N. C.
QUADRANGLE LOCATION STATESVILLE EAST, N. C.
VITH NATIONAL MAP ACCURACY STANDARDS N3545—W8045/7.5
-OGICAL SURVEY, WASHINGTON, D.C. 20242
'HIC MAPS AND SYMBOLS IS AVAILABLE ON REQUEST 1969
AMS 4855 IV SE —SERIES V842

DIVISION OF ENVIROWrMi NTAL MIAGEIeMiT October 30, 1981
Mr. D. W. Ridil"'-7
fir:•.., �._.:;;
Furst 2�cNesa fi,omgiay .
Route 70 East S. P. F. 0.
Statesville, North CI olina 28677-
,i n v 1981
9R QUALITY Furst
Permit No. N00043763
Furst McNess Company
SECTION Iredell County
Dear Mr. Riddle:
In accordance with your application for discharge Permit received
April 9, 1931, we are forwarding herewith the subject State NPDE5 Permit.
This permit is issued pursuant to the requirements of North Carolina
General Statutes 143-215.1 and the Memorandum. of Agreement between North
Carolina and the U. S. Environmental Protection Agency dated October 19, 1975.
If any parts, requirements, or limitations contained in this Permit
are unacceptable to you, you have the -right to an adjudicatory hearing
before a hearing officer upon written demand to the Director within 30
days following receipt of this Permit, identifying the specific issues
to be contended. Unless such demand is made, this Permit shall be final
and binding.
Please take notice that this Permit is not transferable:. Part II,
B.2. addresses the requirements to be followed in case: of change In owner-
ship or control of this discharge. -
This Permit does not affect the legal requirement to obtain other
Permits which may be required by the Division of Environmental Management.
If you have any questions concerning this Permit, please contact Mr. Bill
Mills, telephone [phone].
Sincerely yours,
Original Signed By
ROURT F. HELMS
Robert F. Helms
Director
cc: Air. T. Michael Taimi, EPA
Mooresville Regional Office—/
Mooresville Regional Office Manager

,r
Permit No.. NC,
STATE OF NORTH CAROLINA
DEPARTMENT OF NATURAL RESOURCES & COMMUNITY DEVELOPMENT
DIVISION OF ENVIRONMENTAL MANAGEMENT
P E R M I T
To bischarge Wastewater Under the NATIONAL
POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provisions of North Carolina General Statute 143-215.1,
other lawful standards and regulations promulgated and adopted by the North Carolina
Environmental Management Commission, and the Federal Water.Pollution Control Act, as -
amended,
Furst-.McNess Company .
is hereby authorized to discharge wastewater from a facility located at
Statesville
Iredell County
to receiving.waters
Unnamed Tributary to Third Creek in the Yadkin River Basin
in accordance with effluent limitations, monitoring requirements, and other
conditions set forth in Parts I, II, and III hereof.
This permit shall become effective OCT- 3 0 1981
This permit and the authorization to discharge shall expire at midnight
on
OCT 3 0 1986
Signed this day of OOT 3 0 1981
Original Signed By
ROBERT F. HELMS
Robert F. Helms, Director
Division of Environmental Management
By Authority of the Environmental
Management Commission
M1 & I1

Page of
Permit No. NC
SUPPLEMENT TO PERMIT COVER SHEET
Furst—McNess Company
is hereby authorized to:
1. Continue to discharge non -contact cooling water from a 25 h.p.
compressor located at Statesville, North Carolina into an
unnamed tributary to Third Creek which is classified Class "C"
waters (Note Part III of this Permit).

A. (1). EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
During the period beginning on the effective date and lasting until expiration,
permittee is authorized to discharge from outfall(s) serial number(s). 001.
Such discharges shall be limited and monitored by the permittee as specified below:
ffluent Characteristics Discharge Limitations Monitoring Requirements
Kg/day (lbs/day) Other Units (Specify) Measurement ** Sample *Sample
Daily Avg. Daily Max. Daily Avg. Daily Max. Frequency Type Location
Temperature *** Monthly Grab E, U, D
There shall be no chromium, zinc or copper added to the cooling water.
*Sample Locations: I -Influent, E-Effluent, U-Upstream, and D-Downstream **All stream samples shall be grab
***The temperature shall be such as not to cause an increase in the stream water temperature of more than 5 0 F above ambient
stream water temperature and in no case cause the stream water temperature to exceed 90 F.
E
The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units
and shall be monitored monthly at E, U, D, by grab samples.
There shall be no di scharge: of fl oat�i nq solids or vi si hl P fnaro in

Part I
Permit No. NC
B. SCHEDULE OF COMPLIANCE
1. The permittee shall.achieve compliance with the effluent limitations
specified for discharges in accordance with'the following schedule:
NOS
2. No later -than 14..calendar days following a date identified .in the above
schedule of compliance, the permittee shall submit either a:report of
progress or.,, in.the case of specific actions being required by identified
dates,.a written:notice of compliance or noncompliance. In the latter
case, the notice shall include the cause of noncompliance, any remedial
J actions taken, and the probability of meeting the next scheduled requirement.
J.

PART I
Permit No. NC
Act used herein means the Federal Water Pollution Control Act, As amended.
OEM used herein means the Division of Environmental Management of the
Department of Natural Resources .and community Development
"EMC" used herein means the North Carolina Environmental Management
Commission.
C. MONITORING AND REPORTING
1. Representative Sampling
Samples and measurements taken as required herein shall be representative
of the volume and.nature of the monitored discharge.
2. Reporting
Monitoring results obtained during the previous month(s) shall be
summarized for each month and reported on a Monthly Monitoring.Report
Form (DEM No. MR 1.0, 1.1, and 1.4) postmarked no -later than the 45th
day followin the completed reporting period. The first report is due on
'AN 1 1981 The DEM may require reporting of additional monitoring
results by written notification. Signed copies of these, and all other
reports required herein, shall be submitted to the following address:
Division of Environmental Management
_._Water Quality Section
Post Office Box 27687
Raleigh, North Carolina 27611
3. Definitions
a. The "daily average" discharge means the total discharge'by weight
during a calendar month divided by the number of days in the month
that the production or commercial facility was operating. Where less
than daily sampling is required by this permit, the daily average
discharge shall be determined by the summation of all the measured
daily discharges by weight divided by the number of days sampled
during the calendar month when the measurements were made.
b.-The "daily maximum" discharge means the total discharge by weight
. during any calendar day.
4. Test Procedures
Test procedures for the analysis of pollutants shall conform to The EMC
regulations published pursuant to N: C. G. S. 143-215.63 et seq.. The
Water and Air Quality Reporting Act, Section 304(g), 13 USC 1314, of the.
Federal Water Pollution Control Act, As Amended, and Regulation 40 CFR 136..
5. Recording Results
For each measurement or sample taken pursuant to the requirements of
this permit,'the permittee shall record the following information:
I5

Permit No. NC
a. The exact place, date, and time of sampling;
b. The dates the analyses were performed;
c. The person(s) who performed the analyses;
d. The analytical techniques or methods used; and
e. The results of all required ana-lyses.
6. Additional Monitoring by Permittee
If the permittee monitors any pollutant at the locations) designated
herein more frequently than required by this permit, using approved
analytical methods as specified above, the results of such monitoring
shall be included in, the calculation and reporting of the values required
in the Monthly Monitoring Report Form (DEM MR 1.0, 1.1, 1.4)
Such increased monitoring frequency shall also be indicated. The DEM
may require more frequent monitoring or the monitoring of other pollu-
tants not required in this permit by written notification.
7. Records Retention
..All records and information resulting from the monitoring activities
required by this permit including all records of analyses performed and
calibration and maintenance of instrumentation and recordings from
continuous monitoring instrumentation shall. be retained by .the permittee
:for a minimum of three (3) years, or longer if.requested by. the State.
Division of Environmental Management or,the Regional Administrator of
the Environmental Protection Agency.
16.

PART II
Permit No. NC
A. MANAGEMENT REQUIREMENTS
1. Change in Discharge
All discharges authorized herein shall be consistent with the terms and
conditions of this permit. The discharge of any pollutant identified
in this permit more frequently than or at a level in excess of that
authorized shall constitute a violation of the permit. Any anticipated
facility expansions, production increases, or process modifications which
will result in new, different, or increased discharges of pollutants must
be reported by submission of a new NPDES application or, if such changes
will not violate the effluent limitations specified in this permit, by
notice to the DEM of such changes. Following such notice, the permit
may be modified to specify and limit any pollutants not previously limited.
2. Non compliance Notification
If, for any reason, the permittee does not comply with or will be unable
to comply with any effluent limitation specified in this permit, the per-
mittee shall provide the Division of Environmental Management with the
following information, in writing, within five (5) days of becoming aware
of such condition:
a. A description of the discharge and cause of noncompliance; and
b. The period of noncompliance, including exact dates and times; or,
if not corrected; the anticipated time the noncompliance is expected
to continue, and steps being taken to reduce, eliminate and prevent
recurrence of the noncomplying discharge.
3. Facilities Operation
The permittee shall at all times maintain in good working order and
operate as efficiently as possible all treatment or control facilities
or systems installed or used by the permittee to achieve compliance with
the terms and conditions of this permit.
4. Adverse Impact
The permittee shall take all reasonable steps to minimize any adverse
impact to navigable waters resulting from noncompliance with any effluent
limitations specified in this permit, including such accelerated or
additional monitoring as necessary to determine the nature and impact of
the noncomplying discharge.
5. Bypassing
Any diversion from or bypass of facilities necessary to maintain compliance
with the terms and conditions of this permit is prohibited, except (i) where
M8&I7

PART II
Permit No. NC
unavoidable to prevent loss of life or severe property damage, or
(ii) where excessive storm drainage or runoff would damage any
facilities necessary for compliance with the effluent limitations
and prohibitions of this permit. The permittee shall promptly
notify the Water Quality Section of DEM in writing of each such
diversion or bypass.
6. Removed Substances
Solids, sludges, filter backwash, or other pollutants removed in the
course of treatment or control of wastewaters shall be disposed of in
a manner such as to prevent any pollutant from such materials from
entering waters of the State or navigable waters of the United States.
7. Power Failures
In order to maintain compliance with the effluent limitations and
prohibitions of this permit, the permittee shall either:
a. In accordance with the Schedule of Compliance contained in Part I,
provide an alternative power source sufficient to operate the waste-
water control facilities;
or, if such alternative power source is not in existence, and no date for
its implementation appears in Part I,
b. Halt, reduce or otherwise control production and/or all discharges
from wastewater control facilities upon the reduction, loss, or
failure of the primary source of power to said wastewater control
facilities.
8. Onshore or Offshore Construction
This permit does not authorize or approve the construction of any onshore
or offshore physical structures or facilities or the undertaking of any
work in any navigable waters.

PART II
y Permit No. NC
B. RESPONSIBILITIES
1. Right of Entry
The permittee shall allow the Director of the Division of Environmental
Management, the Regional.Administrator, and/or their authorized represen-
tatives, upon the presentations of credentials:.
a. The enter upon the permittee°s premises -where an effluent source is
located or in which any -records are required to be kept under the
terms and conditions of this permit; and.
b. At reasonable times.to have access to and copy any, records required
to be kept under the terms and conditions of this -permit; to inspect
any monitoring equipment or monitoring method required in this permit;
i and to sample any discharge of pollutants.
2. Transfer of Ownership or Control
This permit is not transferable. In the event of any change in control
or.ownership of facilities from which the authorized discharge emanates
or is contemphated, the permittee shall notify the prospective owner or
controller by letter of the existence of this permit and of the need to
obtain a permit'in the name of the prospective owner. 'A copy of.the
letter shall be-Jorwarded to the Division of Environmental Management.
3. Availability.of Reports
Except.for data determined to be confidential under N. C. G. S. 143-215.
3(a)(2)`or Section 308 of the Federal Act, 33 USC 1318, all reports prepared
in accordance with the terms shall be available for public inspection at the
offices of the.Division of Environmental Management. As required by the Act,
effluent data shall not be considered confidential. Knowingly making any
false statement on any such report may result in the im osition of criminal
penalties as provided for in N. C. G. S. 143-215.6(b)(2� or in Section
309 of the Federal Act.
4. Permit Modification
After notice and opportunity for hearing pursuant to N. C. G. S. 143-
215.1(b)(2) and G. S. 143-215.1(e) respectively, this permit may be
modified, suspended, or revoked in whole or in'part during its term for
cause including, but not.limited to, the following:
a. Violation of any terms or conditions of this permit;
b.. Obtaining this permit,by misrepresentation or failure to disclose
fully all relevant facts; or
c. A change in any condition that requires either a temporary or
permanent reduction or elimination of the authorized discharge.
M10&I9

1,
PART II
Permit No. NC
5. Toxic Pollutants
Notwithstanding Part II, B-4 above, if a toxic effluent standard or
prohibition (including any schedule of compliance specified in such
effluent standard or prohibition) is established under Section 307(a)
of the Act for a toxic pollutant which is present in the discharge and
such standard or prohibition is more stringent than any limitation for
such pollutant in this permit, this permit shall be revised or modified
in accordance with the toxic effluent standard or prohibition and the
permittee so notified.
` 6. Civil and Criminal Liability
Except as provided in permit conditions on "Bypassing" (Part II, A-5)
and "Power Failures" (Part II, A-7), nothing in this permit shall be
construed to relieve the permittee from civil or criminal penalties for
noncompliance pursuant to N. C. G. S. 143-215.6 or Section 309 of the
Federal Act, 33 USC 1319.
T. Oil and Hazardous Substance Liability
Nothing in this permit shall be construed to preclude the institution
of any legal action or relieve the permittee from any -,responsibilities,
liabilities, or penalties to which the permittee is or may be subject
under N. C. G. S. 143-215.75 et seq. or Section 311 of the Federal Act,
33 USC 1321.
8. Property Rights
The issuance of this permit does not convey any property rights in either
real or personal property, or any exclusive privileges, nor does it
authorize any injury to private property or any invasion of personal
rights, nor any infringement of Federal,State or local laws or regulations.
9. Severabi 1 i ty
The provisions of this permit are severable, and if any provision of this
permit, or the application of any provision of this permit to any circum-
stance, is held invalid, the appi.ication of such provision to other cir-
cumstances, and the remlinder of this permit shall not be affected thereby.
M11 &I10

PART II
1
Permit No NC
i
10. Expiration of Permit
Permittee is not authorized to discharge after the expiration date.'
In order to receive authorization to discharge beyond,the expiration
date, the permittee shall submit such information, forms, and fees as
are required by the agency authorized to issue permits no later than 180
days prior to the expiration date. Any discharge without a permit after
the expiration will subject the permittee to enforcement procedures as
provided in N. C. G. S. 143-215.6 and 33 USC 1251 et seq..
l`
i

n
PART- III
Page of
Permit No. NC
B. Previous Permits
All previous State water quality permits issued to this facility,
whether for construction or operation or discharge, are hereby revoked
by issuance of this permit. The conditions, requirements, terms, and
provisions of this permit authorizing discharge under the National
Pollutant Discharge Elimination System governs discharges from this
facility.
C. Construction
No construction of wastewater treatment facilities or additions thereto
shall be begun until Final Plans and Specifications have been submitted
to the Division of Environmental Management and written approval and
Authorization to Construct has been issued. If no objections to Final
Plans and Specifications has been made by the DEM after 30 days following
receipt of the plans or issuance of this permit, whichever is latter, the
plans may be considered approved and construction authorized.
D. Certified Operator - Not Applicable
Pursuant to Chapter 90A of North Carolina General Statutes, the permittee
shall employ a certified wastewater treatment plant operator in responsible
charge of the wastewater treatment facilities. Such operator must hold a
certification of the grade equivalent to the classification assigned to
the wastewater treatment facilities.
M 15 & I 12