NCG140495_Application_20210208

3y. Division of Energy, Mineral and Land Resources
Stolritnwater Program
National Pollutant Discharge Elimination System
Environmental Quality NCG140000
NOTICE OF INTENT
IN cCsl N- o 4 G�5
FOR AGENCY USE ONLY
bate Received
Year
Month
Da
(
I 0Z
D
Certificate of Coverage
Check #
I Amount
`f
J(o0
Permit Assigned to
M. M-elo
LIN
N oeo
National Pollutant Discharge Elimination System application for coverage under General Permit NCG140000:
STORMWATER AND PROCESS WASTEWATER DISCHARGES associated with activities classified as:
SIC (Standard Industrial Classification) Code: 3273 and like activities - Ready Mixed Concrete
This NOI may be an application to discharge process wastewater. NOG140000 contains effluent limitations
for process wastewater discharges. Wastewater discharges must meet the requirements of these effluent
limitations. An exceedance of any of these limitations will result in a violation of the permit conditions.
For questions, contact the DEMLR Central Office or Regional Office in your area. (Sew page 8)
(Please print or type)
1) Mailing address of owner/operator (official address to which all permit correspondence will be L� G �021
mailed : PENII-LAND QUALITY
Legal Company Name S&W Ready Mix Concrete Company LLC < 1`ir�€ ;t,4tGTr f� IdLRhraITTING
(Please attach the most recent Annual Report to the NC Secretary of State showing the current legal name. Alternatively
this permit can he given to an individual.) ) 1 _
Signee's Name (as signed for in question 28 below) f` lafeA t t►�IiGL Fi e ire
Street Address 5700 Lake Wright Drive
City Norfolk State VA ZIP Code 23502
Telephone No. Email
Alternate ContactName Hank Gay Email (if different) [e-mail]
Alternate Contact Telephone (if different) 910.284.2664
2) Location of facility producing discharge:
Facility Name
Street Address
City
County Facility
Contact
Telephone No.
S&W Hubert Plant
3248 Freedom Way
Hubert State NC ZIP Code 28539
Onslow
Hank Gay
910 284-2664 Email hoc ay(a.snwreadymix.com
3) Physical location information:
Please provide narrative directions to the facility (use street names, state road numbers, and distance and
direction from a roadway intersection). From NC 24/NC 172 intersection, east on NC 24 for 1.7 miles. Sight is on the right.
(A copy of a county map or USGS quad sheet with facility clearly located on the map is a required part of this application.)
4) Latitude 34 42 55.39 Longitude 77 12 6.19 (dog., min, sec or decimal)
Page 1 of 8
SWU-NCGI4-NO]

NCG140000 N.O.E.
5) This NPDES Permit Application applies to the following (check all that apply):
❑ New or Proposed Facility Date operation is to begin
Existing Facility Date operation began 9.1.2009
6) Consultant's application information:
Consultant:
Consulting Firm:
Mailing Address:
City:
State:
Phone:{ }
Email:
Zip Code:
(Optional)
,Staple Business Card Here:
7) Provide the 4 digit Standard Industrial Classification Code (SIC Code) that describes the primary
industrial activity at this facility:
SIC Code: 3 2 7 3
8) Provide a brief description of the types of industrial activities and products produced at this facility:
(Attach a site diagram showing the process areas present at this facility.)
Readv Mix Concrete Plant
Stormwater Discharge, Wastewater Treatment & Discharge and Permitting Information
9) Discharge points / Receiving waters:
What is the name of the body or bodies of water (creek, stream, river, lake, etc.) that the facility stormwater
and/or wastewater discharges will end up in? Queens Creek) White Oak River Basin
To find the waterbody, please see the NC Surface Waterbody Classifications map at
https://deq.no.gov/about/divisions/water-resources/water-resources-science-data
Receiving water classification(s) for the waters: "SA;NQW"
If the site will discharge to a separate storm sewer system, name the operator of the separate storm sewer
system (e.g. City of Raleigh municipal storm sewer). NA
Page 2 of 8
SWtJ-NCG14-Nt�l

NCG140000 N.O.I.
List discharge points (outfalls) that convey discharge from the site (both on -site and off -site) and location
coordinates, Attach additional sheets if necessary, or note that this information is specified on the site plan.
Be sure to indicate a type for each outfall listed below as Stormwater only, Wastewater only or Wastewater
Commingled with Stormwater
Outfall No. 01 Stormwater only Q Wastewater only
Latitude (degrees/minutes/seconds): 34 42 55.39
Longitude (degrees/minutes/seconds): 7712 6.19
W
-0i
Wastewater Commingled with Stormwater
Outfall No. Stormwater only
❑ Wastewater only Wastewater Commingled with Stormwater
Latitude (degrees/minutes/seconds):
N
Longitude (degrees/minutes/seconds):
W
Outfall No. Stormwater only
❑ Wastewater only Wastewater Commingled with Stormwater
Latitude (degrees/minutes/seconds):
N
Longitude (degrees/minutes/seconds):
W
Outfall No. Stormwater only
❑ Wastewater only Wastewater Commingled with Stormwater
Latitude (degrees/minutes/seconds):
N
Longitude (degrees/minutes/seconds):
W
Outfall No. Stormwater only
❑ Wastewater only Wastewater Commingled with Stormwater
Latitude (degrees/minutes/seconds):
N
Longitude (degrees/minutes/seconds):
W
Outfall No. Stormwater only
❑ Wastewater only Wastewater Commingled with Stormwater
Latitude (degrees/minutes/seconds):
N
Longitude (degrees/minutes/seconds):
W
Outfall No. Stormwater only
❑ Wastewater only Wastewater Commingled with Stormwater
Latitude (degrees/minutes/seconds):
N
Longitude (degrees/minutes/seconds):
W
Will this facility discharge wastewater to SA (Shellfish) waters? © Yes © No
Note: Discharge of process wastewater to receiving waters classified as Critical Area (CA) must be
reviewed by the N.C. Division of Water Resources, Public Water Supply Section ahead of
approval. No new discharges of process wastewater are permitted in receiving waters
classified as WS-1 or freshwater ORW.
You must show all discharge points clearly on the submitted site plan. Be advised that
NCDEQ may require you to apply for an individual permit, based on proposed discharge rates
and receiving stream conditions (low flows, impairments, etc.)
Page 3 of 8
swtt-Nr:nTa_Nnt

NCG140000 N.O.I.
10) Each applicant shall provide the following information (attach additional sheets as necessary):
Two (2) site plans depicting the facility or site with numbered outfalls which indicate stormwater and
wastewater outfalls. The plans shall legibly show. at a minimum, (existing or proposed):
o Outline of drainage areas with topographical lines and features
o Stormwater/wastewater treatment structures
o Location of numbered stormwater/wastewater outfalls (corresponding to which drainage areas)
o Runoff conveyance structures
o Areas and acreage where materials are stored
o Impervious area acreages
o Location(s) of streams and/or wetlands the site is draining to, and any applicable buffers
o Site property lines, North Arrow, and bar scale
o If applicable, the 100-year floodplain line
o Acreage of each stormwater and wastewater topographical area
o Each of the facilities' wastewater or stormwater source and discharge structures and each of its
hazardous waste treatment, storage, or disposal facilities
o Site location (insert)
Site plans shalt be 24" x 36" in size.
a I ine drawing and description: Aline. drawing' of the water flow through the facility A pictorial description
of the nature and amount of any sources of water and any collection and treatment measures.
• A narrative description and identification of each type of process, operation, or production area which
contributes wastewater to the effluent for each outfall, and a description of the treatment the wastewater
receives (or will receive), including the ultimate disposal of any solid or fluid wastes other than by
discharge. Processes, operations, or production areas may be described in general terms (e,g. "ash
silo").
11) Does the applicant have any unresolved Notice of Violations (NOVs)?
® No ❑ Yes
Wastewater:
12) What types of wastewater does your facility generate or discharge?
:::.:;: ;°....::a::::::::: ?
.:Type. o..Author zed Vllas ewater
Trn m.
Vehicle and equipment cleaning VE
❑
❑
Wettinq of raw material stockpiles RM
CO
❑
❑
Mixing drum cleaning MD
O
❑
❑
Further explanation, if necessary:
13) Will your facility spray -down or actively wet aggregate piles?
❑ No L9 Yes
14) Does the facility use any of the following on site?
❑ Phosphorus -containing Detergents
® Non -Phosphorus -containing Detergents
CI Brighteners ❑ Other Cleaning Agents
❑ Other:
Page 4 of 8
QfA(I LN(V31A_N1n1 I o f —A—A QM-110047

NCG140000 N.O.I.
15) Are wastewater treatment facilities planned in the 100-year flood plain?
d No © Yes
16) Will your facility build a closed -loop recycle system (CLRSs) that meets design requirements in 15A
_ NCAC 02T .9000 and hold your facilities' working volume'?
❑ Yes 0 No
If Yes, STOP COMPLETION of this permit. Contact DWR Non -Discharge Permitting Program for permitting
requirements.
17) A wastewater treatment alternatives review is required by 15A NCAC 2H.0105 (c)(2) for any now or
expanding water pollution control facility's discharge in North Carolina. You may attach additional sheets.
a) What wastewaters were considered for this alternatives review? N VE N RM d MD
b) Connection to a Municipal or Regional Sewer Collection System:
i) Are there existing sewer lines within a one -mile radius? ..................................... ❑ Yes Ili No
(1) If Yes, will the wastewater treatment plant (WWTP) accept the wastewater? .... ❑ Yes 0 No
(a) If No, please attach a letter documenting that the WWTP will not accept the wastewater.
(b) If Yes, is it feasible to connect to the WWTP? Why or why not?*
c) Surface or Subsurface Disposal System (e.g., spray irrigation):
i) Is a surface or subsurface disposal technologically feasible (possible)? ....................❑ Yes N No
Why or Why not?
ii) Is a surface or subsurface disposal system feasible to implement?* ...........................❑ Yes N No
Why or Why not?
iii) What is the feasibility of employing a subsurface or surface discharge as compared to a direct
discharge to surface waters?*
d) Direct Discharge to Surface Waters: Is discharge to surface waters the most environmentally sound
alternative of all reasonably cost-effective options of the wastewaters being considered?*... N Yes ❑ No
ij if No, contact DEMLR's Land Application Unit to determine permitting requirements.
e) If this review included all wastewater discharge types, would excluding some types (e.g. raw
stockpile wetting) make any of the above non -discharge options feasible? .............. El Yes N No
* You may be asked to provide further information to support your answers to these questions after the initial review.
Feasibility should take into account initial and recurring costs.
Page 5 of 8

NCG140000 N.O.I.
Stormwater:
18) Does this facility employ any best management practices for Stormwater control? ❑ No El Yes
If yes, please briefly describe: see attached site plan.
19) Does this facility have a Stormwater Pollution Prevention Plan? ❑ No E1 Yes
If yes, when was it implemented? September 1, zoos
20) Are vehicle maintenance activities (VMA) occurring or planned at this facility? a No ❑Yes
If yes, does your VMA area discharge into your wastewater treatment device? I] No ❑ Yes
OtherlPermitting:
21) Does this facility have a Division of Land Resources Erosion & Sedimentation Control (E&SC) Permit?
❑ No 21 Yes
If yes, list the permit numbers for all current E&SC permits for this facility:
22) Is your facility subject to Phase 11 Post -Construction Area? © No ❑ Yes
If yes, who is the permitting authority?
23) Is your facility located in one of the 20 Coastal Counties? B Yes ❑ No
SW8070210
Is your facility adding more than 10,000 ft2 of built -upon area or CAMA Major Permit? ❑ Yes IJ No
24) Is your facility discharging wastewater (treated or untreated) such as water from wetting of aggregate piles, drum
rinse -out, or vehicle and equipment cleaning to a stormwater BMP? ;, No ❑ Yes
If yes, please attach your approval from the permitting authority to do so.
25) Does this facility have any other NPDES permits? E[ No ❑ Yes
If yes, list the permit numbers for all current NPDES permits for this facility:
26) Does this facility have any Non -Discharge permits (ex: recycle permits)? p No ❑Yes
If yes, list the permit numbers for all current Non -Discharge permits for this facility:
27) Hazardous Waste:
a) Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility?
O No ❑Yes
b) Is this facility a Small Quantity Generator (less than 1000 kg. of hazardous waste generated per month) of
hazardous waste?
El No ❑Yes
c) Is this facility a Large Quantity Generator (1000 kg. or more of hazardous waste generated per month) of
hazardous waste?
❑✓ No ❑ Yes
d) Type(s) of waste:
How is material stored: _
Where is material stored:
Page 6 of 8

NCG140000 N.O.[.
How many disposal shipments per year:
Name of transport I disposal vendor: _
Vendor address:
Final Checklist
This application will be returned as incomplete unless all of the following items have been included:
i� Check for $100 made payable to NCDEQ.
i� This completed application and all supporting documentation. See Question 10.
If an Erosion & Sedimentation Control (E&SC) Plan is required from Division of Land Resources (DLR) or
local designee: documentation verifying applicant has developed and submitted that Plan to the governing
agency (required per 15A NCAC 02H .0138).
Two (2) site plans depicting the site plan with numbered outfalls which indicate stormwater and wastewater
outfalls. See Question 10.
A county map or USGS quad sheet with location of facility clearly marked.
28) Signatory Requirements (per 40 CFR 122.22)
All applications, reports, or information submitted to the Director shall be signed and certified.
a. All notices of intent to be covered under this General Permit shall be signed as follows:
(1) For a corporation: by a responsible corporate officer. For the purpose of this permit, a responsible corporate officer means: (a) a
president, secretary, treasurer or vice president of the oorporation in charge of a principal business function, or any other person who
performs similar policy or decision making functions for the corporation, or (b) the manager of one or more manufacturing production or
operating facilities employing more than 250 persons or having gross annual sales or expenditures exceeding 25 million (in second quarter
1980 dollars), if authority to sign documents has been assigned or delegated to the manager in accordance with corporate procedures.
(2) For a partnership or sole proprietorship: by a general partner or the proprietor, respectively; or
(3) For a municipality, state, federal, or other public agency: by either a principal executive officer or ranking elected
official.
Certification: North Carolina General Statute 143-215.6 B(I) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan, or other
document filed or required to be maintained under this Article or a rule implementing this Article; or who knowingly makes a false statement of
a material fact in a rulemaking proceeding or contested case under this Article; or who falsifies, tampers with, or knowingly renders inaccurate
any recording or monitoring device or method required to be operated or maintained under this Article or rules of the (Environmental
Management) Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine not to exceed ten
thousand dollars ($10,000).
I hereby request coverage under the referenced General Permit. I understand that coverage under this permit will
constitute the permit requirements for the discharge(s) and is enforceable in the same manner as an individual
permit.
I certify that I am familiar with the information contained in this application and that to the best of my knowledge
and belief such information is true, complete, and Accurate. , _ _ .1
WA -
(Signature of Applicant) (Date Signed)
Page 7 of 8
SwU-NCGI4-NOI 1 q-t r.,Mq,,r1 Alma 19017

NCG140000 N.0.1.
Notice of Intent must be accompanied by a check or money order for $100.00 made payable to: NCDEQ
Mail the entire package to:
DEMLR - Stormwater Program
Dept. of Environmental Quality
1612 Mail Service Center
Raleigh, North Carolina 27699-1612
Note
The submission of this document does not guarantee the issuance of an NPDES permit.
For questions, please contact the DEMLR Regional Office for your area.
DEMLR Regional Office Contact Information:
Asheville Office ......
[phone]
Fayetteville Office ...
[phone]
Mooresville Office ...
[phone]
Raleigh Office ........
[phone]
Washington Office ...(252)
946-6481
Wilmington Office...
[phone]
Winston-Salem ......
[phone]
Central Office .........(919)
807-6300

Service
Quality
Date: January 29, 2021
S & W Ready Mix Concrete Company
P.O. Box 872 • Clinton, NC 28329.910-592-1733 • Fax: [phone]
DEMLR—Storm Water Program
Department of Environmental Quality
1612 Mail Service Center
Raleigh, NC 27699-1612
Subject: S&W Ready Mix — Hubert Facility
NOI NCG140000 Permit Application
3248 Freedom Way
Hubert, NC 28539
Onslow County
E0F71
FEB 0 S 2021
DENR-LAND QUALITY
STORNAIWATER PERI,IITTING
S&W Ready Mix Concrete Company LLC., is formally requesting coverage under NCG140000. The
completed application along with all supporting documentation is included with this submittal. The
request is a direct result of the inspection that was performed at S&W Hubert location, by Mr. Brian
Lamb Environmental Specialist DEMLR, on November 23, 2020.
Mr. Lamb stated that the Hubert Facility is required to obtain a NCG140000 COC. S&W Ready Mix has
previously applied for this permit and it was determined by previous personal that it was not needed
because of the SW8 070210.
S&W Ready Mix has been maintaining NCG140000 permit conditions and testing to date. Records were
reviewed by Mr. Lambe during the inspection on November 23, 2020, inspection results are attached.
Thank you for your assistance with this matter and if you have any questions or comments concerning
this matter, please call me at [phone].
Kind Regards,
�A
Hank Gay
S&W Ready Mix

North Carolina Secretary of State Search Results
Page 1 of 1
• File an Annual Report/Amend an Annual Report • Upload a PDF Filing • Order a Document Online • Add Entity to My Email
Notification List • View Filings • Print a Pre -Populated Annual Report form • Print an Amended a Annual Report form
Limited Liability Company
Legal Name
S & W Ready Mix Concrete Company LLC
Prev Legal Name
S & W Ready Mix Concrete Company
Information
Sosld: 0184621
Status: Current -Active O
Date Formed: 10/31/2007
Citizenship: Domestic
Annual Report Due Date: April 15th
Registered Agent: Corporation Service Company
Addresses
Reg Office Reg Mailing
2626 Glenwood Ave Ste 550 2626 Glenwood Ave Ste 550
Raleigh, NC 27608 Raleigh, NC 27608
Principal Office
5700 Lake Wright Drive, Suite 300
Norfolk, VA 23502
Company Officials
Mailing
5700 Lake Wright Drive, Suite 300
Norfolk, VA 23502
All LLCs are managed by their managers pursuant to N.C.G.S. 57D-3-20.
Manager Manager
Kevin Baird Karen V. Fittler
5700 Lake Wright Drive, Suite 300 5700 Lake Wright Drive, Suite 300
Norfolk VA 23502 Norfolk VA 23502
Manager
Louis Petrillo
5700 Lake Wright Drive, Suite 300
Norfolk VA 23502
Manager
Jennifer M. Rafferty
5700 Lake Wright Drive, Suite 300
Norfolk VA 23502
Manager
Lawrence H. Wilt, Jr.
5700 Lake Wright Drive, Suite 300
Norfolk VA 23502
Manager
Bill Zarkalis
5700 Lake Wright Drive, Suite 300
Norfolk VA 23502
https://vvww.sosnc.gov/online_services/search/Business_Registration_Results 2/9/2021