NCG520120_Regional Office Historical File Pre 2018 (2)

Water Resources
ENVIRONMENTAL QUALITY
July 28, 2017
Mr. Keith Adams
Tarheel Sand & Stone, Inc.
1108 Tuckda Way
Hamptonville, NC 27020
ROY COOPER
(:­' oI ;
MICHAEL S. REGAN
S. JAY ZIMMERMAN
/hirc lur
RECEIVEDINCDENR/DWR
AUG 10 2017
WQROS
MOORESVILLE REGIONAL OPCICE
Subject: Issuance of Certificate of Coverage NCG520120
NPDES General Permit NCG520000
Longshoals Pit
Lincoln County
Dear Mr. Adams:
The Division has reviewed and approved your request for coverage under the subject General Permit. The
Division hereby issues Certificate of Coverage (CoC) NCG520120 to discharge under wastewater General
Permit NCG520000. This CoC is issued pursuant to the requirements of North Carolina General Statue
143-215.1 and the Memorandum of Agreement between North Carolina and the US Environmental
Protection agency dated October 15, 2007 [or as subsequently amended].
If any parts, measurement frequencies or sampling requirements contained in this General Permit are
unacceptable to you, you have the right to request an individual permit by submitting an individual permit
application. Unless such demand is made, the certificate of coverage shall be final and binding.
Please take notice that this Certificate of Coverage is not transferable except after notice to the Division.
The Division may require modification or revocation and reissuance of the certificate of coverage. Contact
the Asheville Regional Office prior to any sale or transfer of the permitted facility. Regional
Office staff will assist you in documenting the transfer of this CoC
If you have any questions concerning the requirements of the General Permit, please contact
Charles Weaver of the NPDES Unit at [phone] or via e-mail [[e-mail]].
cc:
NPDES Unit
inc rely,
Gam' Jay Zimmerman, D'
Division of Water Resources
State of North Carolina I Environmental Quality I Water Resources
1617 Mail Service Center I Raleigh, NC 27699-1617
919 807 6300 919-807-6389 FAX
https:lldeq.nc.govlabout(divisionstwater-resourceslwater-resources-permits/wastewater-branchlnpdes-wastewater-permits

FFV
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENTAL QUALITY
DIVISION OF WATER RESOURCES
GENERAL PERMIT NCG520000
CERTIFICATE OF COVERAGE NCG520120
DISCHARGE OF INSTREAM MINING WASTEWATER, ASSOCIATED STORMWATER AND
SIMILAR, DISCHARGES UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and
the Federal Water Pollution Control Act, as amended,
Tarheel Sand & Stone, Inc.
is hereby authorized to discharge sand dredging wastewater from the following facility:
Longshoals Pit
3240 Longshoals Rd
Lincolnton
Lincoln County
to receiving waters designated as the South Fork Catawba River, currently classified as
WS-IV CA waters in subbasin 03-08-35 of the Catawba River Basin, in accordance with
the effluent limitations, monitoring requirements, and other conditions set forth in Parts
I, II, III and IV hereof.
This certificate of coverage shall become effective July 28, 2017.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day July 28, 2017
5!
for S. r3 'Zimmerman, P.G. -�
D&ctor, Division of Water Resources
By Authority of the Environmental Management Commission

5'
Latitude: 35°24'56" N CG 520120
Longitude: 81°14'36" Longshoals Pit
USGS Quad: Lincolnton East, N.C.
Stream Class: WS-IV CA
Subbasin: 03-08-35
Receiving Stream: South Fork Catawba River
Facility
Location
A '����l�� Lincoln County
✓V(uL�fG Map not to scale

f:a
Water Resources
ENVIRONMENTAL OUALIT'.
February 9, 2017
Mr. Keith Adams
Tarheel Sand & Stone, Inc.
1108 Tuckda Way
Hamptonville, NC 27020
ROY COOPER
Governor
MICHAEL S. REGAN
Secretary
S. JAY ZIMMERMAN
oireclo,
RECEIVED/NCDENR/DWR
FEB 14 2017
WQROS
MOORESVILLE REGIONAL OFFICE
Subject: NCG520000 Permit Application
Permit#: NCG520120
Longshoals Pit
Dear Mr. Adams:
The Division of Water Resources received your application for coverage under NPDES
General Permit NCG520000 (Check #11873 in the amount of $100.00) on February 1, 2017. The
application has been assigned number NCG520120, and has been given to Charles Weaver for
review.
The reviewer will perform a detailed review and contact you with a request for additional
information if necessary. To ensure the maximum efficiency in processing permit applications, the
division requests your assistant in providing a timely and complete response to any additional
information requested.
Please refer to the above application number when making inquiries on this project. If you
have any questions, please contact Mr. Weaver at 919-807-6391, or via e-mail at
[e-mail].
Permit File NCG520120
Sincerely,
W re*%, TIC- zt f-&r&
Wren Thedford
Wastewater Branch
State of North Carolina I Environmental Quality I Water Resources
1617 Mail Service Center I Raleigh, North Carolina 27699-1617
919-807-6300

A4LIT
NCDENR
r v>{>4rr:rt.Vln Mchn�i.
Division of Water Quality / Water Quality Section
National Pollutant Discharge Elimination System
NCG520000
NOTICE OF INTENT
National Pollutant Discharge Elimination System application for coverage under General Permit
NCG620000: Sand Dredging operations and similar point source discharges
(Please print or type)
1) Mailing address of owner/operator:
Company Name . lie j mango '* Leh
Owner Name f gak damn
Street Address 1 108
City AA-mrito 1U e
Telephone No. �311C 4LI;-4003
* Address to which all permit correspondence will be mailed
2) Location of facility producing discharge:
Facility Name C.b�shoats Ar'f
Facility Contact tlejh Adam
Street Address ;22qo Lana shoo
City
County LigcaJa
Telephone No. 33 ` 1,V 40o
3) Physical location information:
RECEIVEDUDEUDWR
�7,� 0 12017
State Al C ZIP Code 270-20
Fax: 541M6
Stated ZIP Code
Fax: 51W57
Please provide a narrative description of how to get to the facility (use street names. state road
numbers, and distance and direction from a roadwav intersection). 32) (5agA J��-tlncolr,'
-moo 321_bus�� let oh gbiiwN Pa -la end G LanRcha s U
(A copy of a county map or USGS quad sheet with facility clearly located on the map is required to be submitted with this application)
4) This NPDES permit application applies to which of the following:
i
n
New or Proposed
Modification
Please describe the modification:
Renewal
Please specify existing permit number and original issue date:
5) Does this facility have any other NPDES permits?
® No
❑ Yes
If yes, list the permit numbers for all current NPDES permits for this facility:
6) Description of Discharge:
a) Is the discharge directly to the receiving water? ® Yes ❑ No
Page 1 of 4
11107

NGG520000 N.O.I.
if no, submit a site map with the pathway to the potential receiving waters clearly marked. This
includes tracing the pathway of the storm sewer to the discharge point, if the storm sewer is the
only viable means of discharge.
b) Number of discharge points (ditches, pipes, channels, etc. that convey wastewater from the
property): I
c) Volume of discharge per each discharge point (in GPD):
41: T1 2t, 0 #2: #3: #4
d) Please describe the type of process the sand dredging wastewater is being discharged f rom. be
specific. W641eFz- jrgjt1S E � 1 on ii'le 1 (�i'CRf`ls iflrou6ih 0
Skirn1n-ev it)fb `seed s� 14/ pond � hiss pa�nf �1�Irrr dra,n.c
fhr&K, rh LS(XaAd s4.im MeK bcSai e r(ftwo Ins, +o Kiyey
e) Is there any treatment being applied to the wastewater before discharge (check the type of
treatment in use).
gr Settling pond Sk�m m trs
❑ Lagoon
❑ None
❑ Other:
f) How much of the volume discharged is treated (state in percent)? _ I1J°�
g) If any box in item (e) above, other than none, was checked, please include design specifics (i.e.,
design volume, retention time, surface area, etc.) with submittal package. Existing treatment
facilities should be described in detail. Design criteria and/ operational data (including
calculations) should be provided to ensure that the facility can comply with the requirements of the
General Permit.
The treatment shall be sufficient to meet with the limits set by the general permits. The trapping
efficiency should be greater than 75%. The surface area should be as large as possible to insure
sedimentation occurs. To secure optimum efficiency the flow length of the basin to the basin
width should have a ratio of 2: 1
Note: Construction of any wastewater treatment facilities requires submission of three (3) sets
Of plans and specifications along with the application. Design of treatment facilities must
comply with requirements of 15A NCAC 2H .0138. If construction applies to this
discharge, include the three sets of plans and specifications with this application.
7) Discharge Frequency:
a) The discharge is: ❑ Continuous Intermittent ❑ Seasonal
If the discharge is intermittent, describe when the discharge will occur: Du tin �� I Th+
��(({{
5) If seasonal check the month(s) the discharge occurs: ❑ Jan. ❑ Feb. ❑ Mar. ❑ Apr. ❑ May
❑ Jun. ❑ Jul. ❑ Aug. ❑ Sept. ❑ Oct. ❑ Nov. ❑ Dec.
b) How many days per week is there a discharge? C`� -
c) Please check the days discharge occurs:
Sat. ❑ Sun. IB Mon. ® Tue. 0 Wed_ ® Thu. F6 Fri.
Page 2 of 4
l i /07

NCG520000 N.O.t.
8) Receiving waters:
a) What is the name of the body or bodies of water (creek, stream, river, lake, etc.) that the facility
wastewater discharges and up in? If the site wastewater discharges to a separate Storm sew
system (4S), name the operator of the 4S (e.g. City of Raleigh)..50cfVk For k CAav A Kim-
b) Stream Classification:
9) Alternatives to Direct Discharge:
Address the feasibility of implementing each of the following non -discharge alternatives
a) Connection to a Municipal or Regional Sewer Collection System
b) Subsurface disposal (including nitrification field, infiltration gallery, injection wells, etc.)
c) Spray irrigation
The alternatives to discharge analysis should include boring logs and/or other information indicating
that a subsurface system is neither feasible nor practical as well as written confirmation indicating that
connection to a POTW is not an option. It should also include a present value of costs analysis as
outlined in the Division's "Guidance For the Evaluation of Wastewater Disposal Altematives".
10) Additional Application Requirements:
For new or proposed discharges, the following information must be included in triplicate with this
application or it will be returned as incomplete.
a) 7.5 minute series USGS topographic map (or a photocopied portion thereof) with discharge
location clearly indicated.
b) Site map, if the discharge is not directly to a stream, the pathway to the receiving stream must be
clearly indicated. This includes tracing the pathway of a storm sewer to its discharge point.
c) If this application is being submitted by a consulting engineer (or engineering firm), include
documentation from the applicant showing that the engineer (Or firm) submitting the application
has been designated an authorized Representative of the applicant.
d) Final plans for the treatment system (if applicable). The plans must be signed and sealed by a
North Carolina registered Professional Engineer and stamped -"Final Design -Not released for
construction".
e) Final specifications for all major treatment components (if applicable). The specifications must be
signed and sealed by a North Carolina registered Professional Engineer and shall include a
narrative description of the treatment system to be constructed.
I certify that I am familiar with the information contained in this application and that to the best of my
knowledge and belief such information is true, complete, and accurate.
Printed Name of Person Signing: WDIMS
Title: Pce5;dlenf
of Applicant)
(Date Signed)
11107
Page 3 of 4

NCG520000 N.O.I.
North Carolina General Statute 143-215.6 b (i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any
application, record, report, plan or other document filed or required to be maintained under Article 21
or regulations of the Environmental Management Commission implementing that Article, or who
falsifies, tampers with or knowingly renders inaccurate any recording or monitoring device or method
required to be operated or maintained under Article 21 or regulations of the Environmental
Management Commission implementing that Article, shall be guilty of a misdemeanor punishable by a
fine not to exceed $25,000, or by imprisonment not to exceed six months, or by both. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $25,000 or imprisonment not more
than 5 years, or both, for a similar offense.)
Notice of Intent must be accompanied by a check or money order for $100.00 made payable to:
NCDENR
Mail three (3) copies of the entire package to:
NPDES Permits Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Final Checklist
This application will be returned as incomplete unless all of the following items have been
included:
I'Check for $100 made payable to NCDENR
3 copies of county map or USGS quad sheet with location of facility clearly marked on map
C�1 3 copies of this completed application and all supporting documents
d 3 sets of plans and specifications signed and sealed by a North Carolina P.`.
Thorough responses to items 1-10 on this application
Alternatives analysis including present value of costs for all alternatives
Note
The submission of this document does not guarantee the issuance of an NPDES permit
11/0' Page 4 of 4

I
TARREEL SAND & STONE, INC
1108 TuclOa Way Hamptonville, NC 27020
336-468-4003
i
10
not erodp- river fooenfc
1_ f-�c hccl
Poria -D
-Fu rb Iol, i y
w►1,
be reduced
by u�5!rjR
aplit 5etHing
pond 15 wFt�
S�'Irf'Oer6
Grocanol Live l
Skimmer 15 PIPE Grann� Leve-W A E R LEVEL
/0o
30
-- /�
pfF
Pon�1 g Pond "DA+
= i ram
;efiurn Se#ling for}j Md+i Z5'
{=roni 11jeU)
C p Imo 6AL.
4 pprok . Refel) "i6 Time - 2 #Ks
$udace A��� — 225`, ��
FIbw Ienjh+ -,
w ra+I raf-i o - Rpp. 2 �" l
�-1�ernr�c vPf
�rvea rv2
unyder peir+� , of,l c��st w�f� gl e�t�f
ey ��h se�irh v�ds wt ► �/�1a� r�o�r rI �t-va���E
would

NC 28677 to 4144 Oxford School Rd, C... https://www.googie.couuiiiapziuut,,- r -- - -
r ,
164 Winberry Ln, Statesville, NC 28677 to Drive 11.1 miles,14 min
GO -ogle Maps 4144 Oxford School Rd, Catawba, NC 28609
= LlnColnfv�� -
somr.vr. r.c -
��`r T�Tr#e SaksO _
n
�y o
�. te�eom Tem+cep .
gie
Map data 02017 Google 1000 ft '
14 min
via 1-40 W
11.1 miles
Fastest route
via US-70 W and 1-40 W
via US-70 W
15 min
10.8 miles
18 min
11.1 miles
1/25/2017 7:46 A