NC0005126_Regional Office Historical File Pre 2018 (2)

Mr. Daniel Crowe
Tyson Foods, Inc.
501 Sheffield Rd.
Harmony, North Carolina 28634
Dear Mr. Crowe:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Ca1y& Dear ent,of.Et4gtCcgment and Natural Resources
1�1�. i. ,eV1'—%k-1i4 1t14L
AND NATtJF rL RMOURG" W. Klimek, P.E. Director
r00RFSV"! ' ,-4 `'.k`4AAL QFF►*sion of Water Quality
July 28, 2005
AUG 0 3 200'i
WATEr,a ,.,: — , , SECTION
SUBJECT: Authorization to Construct
A to C No. 005126A03
Tyson Foods, Inc.
Harmony Rendering Plant
Iredell County
A letter of request for Authorization to Construct was received May 18, 2005 by the
Division, and final plans and specifications for the subject project have been reviewed and found
to be satisfactory. Authorization is hereby granted for the construction of modifications to the
existing 0.5 MGD Harmony Rendering Plant Wastewater Treatment Plant, with discharge of
treated wastewater into the Hunting Creek in the Yadkin Pee Dee River Basin.
This authorization results in no increase in design or permitted capacity and is awarded
for the construction of the following specific modifications:
Addition of a new 845,000 gallon flow equalization basin with three 25-HP aerators, in
conformity with the project plan, specifications, and other supporting data subsequently
filed and approved by the Department of Environment and Natural Resources.
This Authorization to Construct is issued in accordance with Part III, Paragraph A of
NPDES Permit No. NC0005126 issued March 14, 2005 and shall be subject to revocation unless
the wastewater treatment facilities are constructed in accordance with the conditions and
limitations specified in Permit No. NC0005126.
The sludge generated from these treatment facilities must be disposed of in accordance
with G.S. 143-215.1 and in a manner approved by the North Carolina Division of Water Quality.
In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as may
be required by this Division, such as the construction of additional or replacement wastewater
treatment or disposal facilities.
NamN` hCarolina
aturally
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617
Internet: h2o.enr.state.nc.us 512 N. Salisbury St. Raleigh, NC 27604
An Equal Opportunity/Affirmative Action Employer— 50% Recycledl10% Post Consumer Paper
Phone [phone] Customer Service
FAX [phone]

Mr. Daniel Crowe
July 28, 2005
Page 2
The Mooresville Regional Office, telephone number [phone], shall be notified at
least forty-eight (48) hours in advance of operation of the installed facilities so that an on site
inspection can be made. Such notification to the regional supervisor shall be made during the
normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding State
Holidays.
Upon completion of construction and prior to operation of this permitted facility, a
certification must be received from a professional engineer certifying that the permitted facility
has been installed in accordance with the NPDES Permit, this Authorization to Construct and the
approved plans and specifications. Mail the Certification to Cecil G. Madden, Jr., P.E.,
Construction Grants & Loans, DWQ / DENR, 1633 Mail Service Center, Raleigh, NC 27699-
1633.
Upon classification of the facility by the Certification Commission, the Permittee shall
employ a certified wastewater treatment plant operator to be in responsible charge (ORC) of the
wastewater treatment facilities. The operator must hold a certificate of the type and grade at
least equivalent to or greater than the classification assigned to the wastewater: treatment
facilities by the Certification Commission.
The Permittee must also employ a certified back-up operator of the appropriate type and
grade to comply with the conditions of T15A:8G.0202. The ORC of the facility must visit each
Class I facility at least weekly and each Class 11,111 and IV facility at least daily, excluding
weekends and holidays, must properly manage the facility, must document daily operation and
maintenance of the facility, and must comply with all other conditions of T15A:8G.0202.
A copy of the approved plans and specifications shall be maintained on file by the
Permittee for the life of the facility.
During the construction of the proposed additions/modifications, the permittee shall
continue to properly maintain and operate the existing wastewater treatment facilities at all times,
and in such a manner, as necessary to comply with the effluent limits specified in the NPDES
Permit.
You are reminded that it is mandatory for the project to be constructed in accordance
with the North Carolina Sedimentation Pollution Control Act, and, when applicable, the North
Carolina Dam Safety Act. In addition, the specifications must clearly state what the contractor's
responsibilities shall be in complying with these Acts.
Failure to abide by the requirements contained in this Authorization to Construct may
subject the Permittee to an enforcement action by the Division of Water Quality in accordance
with North Carolina General Statute 143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not preclude the Permittee from
complying with any and all statutes, rules, regulations, or ordinances which may be imposed by
other government agencies (local, state, and federal) which have jurisdiction.

Mr. Daniel Crowe
July 28, 2005
Page 3
One (1) set of approved plans and specifications is being forwarded to you. If you have
any questions or need additional information, please contact Cecil G. Madden, Jr., P.E. at
telephone number [phone].
Sincerely,
Alan W. Klimek, P.E.
ID:cgm
cc: John H. Reid, P.E., Reid Engineering Company, Inc., Fredericksburg, VA
Iredell Count Health Department
ffice, Surface;
Technical Assistance and Certification Unit
Daniel Blaisdell, P.E.
Point Source Branch, NPDES Program
Cecil G. Madden, Jr., P.E.
Ishwar Devkota, P.E.
A to C File

;on Foods, Inc.
o C No. 005126A03
y 28, 2005
Engineer's Certification
I, , as a duly registered Professional Engineer in
the State of North Carolina, having been authorized to observe (periodically/weekly/full time)
the construction of the modifications and improvements to the Tyson Foods (River Valley
Animal Feeds) WWTP, located on Harmony in Iredell County, hereby state that, to the best of
my abilities, due care and diligence was used in the observation of the following construction:
Addition of new 845,000 gallon flow equalization basin with three 25-HP
aerators, in conformity with the project plan, specifications, and other supporting
data subsequently filed and approved by the Department of Environment and
Natural Resources.
I certify that the construction of the above referenced project was observed to be built within
substantial compliance and intent of the approved plans and specifications.
Signature
Date
Registration No.
Send to: Construction Grants & Loans
DENR/DWQ
1633 Mail Service Center
Raleigh, NC 27699-1633

DIVISION OF WATER QUALITY
June 9, 2005
Memo To: Mark Hubbard, Project Review Engineer
Construction Grants and Loans Section
�G
From: Rex Gleason
Prepared By: Michael Parker'/_
Subject: Tyson Foods - Harmony Rendering Plant
Flow Equalization Basin
Authorization to Construct
NPDES Permit Nos. NC0005126
Iredell County
As requested by the memo dated May 18, 2005 from Mr. Mark Hubbard, El, Construction
Grants and Loans, this Office has reviewed the Authorization to Construct (ATC) submitted by
Tyson Foods (Tyson) and offers the following comments and/or recommendations.
Tyson has requested approval to construct a new flow equalization basin (FEB) to augment a
smaller FEB/Dissolved Air Flotation (DAF) unit that exists at the subject facility. The new FEB
will provide increased flow equalization volume and wastewater cooling prior to discharging into
the existing DAF pretreatment unit.
This Office offers no objections to Tyson's request pending final technical review and
approval by the Construction Grants and Loans Section.
If you have any questions, please advise.
/mlp
hAgen`cogurwmo.doc

A T �9pG
o �
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
May 18, 2005 Ac DW. Of 1�pl�-
MEMORANDUM AND CEO
MOOROW `AL OFFICE
TO: Rex Gleason, Regional Water Quality Supervisor
Mooresville Regional Office, Division of Water Quality:`
FROM: Mark Hubbard E.I. Project Review Engineer MAY 2 C 200i
Design Management Unit
SUBJECT: Request for an Authorization to Construct
Harmony Rendering Plant Equalization Basin WATCR
NPDES Permit No. NC0005126
Plans, specifications and supporting documents have been received for the subject
project. It is requested that comments and recommendations, including the items listed below,
be received by June 18, 2005 from the Regional Office Staff:
Procedure No. 4 Comments
Schedule for Issuance of the NPDES Permit
SOC, or Other Schedules Which Must be Met
Status of Stormwater Permit, if applicable
Confirm if the Proposed Method and Sequence for Construction of
Additions/New Facilities is Acceptable.
Groundwater Comments
Standby Power Needs
Compliance With N. C. Well Construction Standards
CAMA
X Recommendations for inclusion in the Authorization to Construct
For your reference, review and comments on the above items, plan documents are submitted as follows:
X Plans and Specifications
Subsurface/Soils Report
Power Outage Information
Other
If you have any questions, please do not hesitate to contact Gil Vinzani at [phone].
Attachment
I►Tim
cc: ATC Files
Mark Hubbard
Construction Grants and Loans Section One
1633 Mail Service Center Raleigh NC 27699-1633 NorthCarolina
Phone: [phone] / FAX: [phone] / Internet: www.nccgi.net
An Equal Opportunity/Affirmative Action Employer — 50% Recycled/10% Post Consumer Paper Naturally

Micha sley, Governor
° N(; CEFT C. - 11V1fiilN North Carolina
AND h,ATf �� i SOURCES r Jr., Secretar
y Vgent of Environm' aral Resources
7 �'j
Alan W. Klimek, P.E., Director
Division of, Water Quality
APR 0 8 2004
April 6, 2004
Mr. Dan Crowe
Tyson Foods, Inc.
P.O. Box 158
Harmony, North Carolina 28634
Subject:
Dear Mr. Crowe:
WATIL-o-w : '"i I I ►iION
Authorization to Construct
ATC No. 005126A02
NPDES Permit No. NC0005126
Harmony Rendering Plant WWTP
Iredell County
The Division of Water Quality's NPDES Unit has reviewed the Tyson Foods, Inc.'s request for an
Authorization to Construct improvements at the Harmony Rendering Plant WWTP, as well as
additional information provided by Reid Engineering. The Division finds the proposed
improvements and design to be satisfactory and hereby grants authorization for the following:
• installation of one 92 ft. diameter x 17 ft. SWD, bolted steel tank with three 50 HP surface
aerators, to serve as an aerated flow equalization basin (FEB),
• installation of one 350 gpm rotary drum screen upstream of the new FEB,
• relocation of the existing DAF influent pump station, to serve as the FEB effluent/ DAF feed
pumping station,
• removal of the existing FEB tank from service, and
• construction or installation of all related structures, equipment, piping, controls, and other
appurtenances, as described in the approved plans and specifications.
This Authorization to Construct is issued in accordance with Part III, Paragraph A of NPDES Permit
No. NC0005126, issued September 13,1999, and shall be subject to revocation unless the wastewater
treatment facilities are constructed in accordance with the conditions and limitations specified in
that permit.
Upon completion of construction and submittal of an acceptable Engineer's Certification (see below),
the approved design capacity of the facility shall remain at 0.040 MGD.
In the event that the facilities fail to perform satisfactorily, including the creation of nuisance
conditions, the Permittee shall take immediate corrective action, including those as may be required
by this Division, such as the construction of additional or replacement wastewater treatment or
disposal facilities.
Notification Requirements
The Permittee shall notify the Mooresville Regional Office, telephone number [phone], at least
forty-eight (48) hours in advance of operation of the installed facilities, so that an in -place inspection
can be made. Such notification to the regional supervisor shall be made during the normal office
hours of 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding State Holidays.
North Carolina Division of Water Quality [phone]
1617 Mail Service Center FAX [phone]
Raleigh, North Carolina 27699-1617 On the Internet at http://h2o.enr.state. nc. us/

Mr. Dan Crowe
Harmony Rendering Plant WWTP
ATC No. 005126A02
Page 2
Engineering Certification
Upon completion of construction and prior to operation of the modified facility, the Permittee shall
provide the Division with a certification from a professional engineer registered in North Carolina
certifying that the permitted facility has been installed in accordance with the NPDES Permit, this
Authorization to Construct, and the approved plans and specifications. The certification should be
mailed to the NPDES Unit,1617 Mail Service Center, Raleigh, North Carolina 27699-1617.
ORC Requirements
The Permittee must continue to employ a certified wastewater treatment plant operator in
responsible charge (ORC) of the wastewater treatment facilities. The operator must hold a certificate
of the type and grade at least equivalent to or greater than the classification assigned to the
wastewater treatment facilities by the Certification Commission. The Permittee must also employ a
certified back-up operator of the appropriate type and grade to comply with the conditions of Title
15A, Chapter 8G, .0200. The ORC of the facility must visit each Class I facility at least weekly and
each Class I1,11I, and IV facility at least daily, excluding weekends and holidays; and must properly
manage and document daily operation and maintenance of the facility and comply with all other
conditions of Title 15A, Chapter 8G, .0200.
Additional Conditions
Failure to abide by the requirements contained in this Authorization to Construct may subject the
Permittee to enforcement action by the Division of Water Quality in accordance with North Carolina
General Statute 143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not relieve the Permittee from its responsibility
to comply with any and all statutes, rules, regulations, or ordinances that may be imposed by other
government agencies (local, state, and federal) which have jurisdiction.
The Permittee shall maintain a copy of the approved plans and specifications on file for the life of
the facility.
If you have any questions about this Authorization to Construct, please contact Mike Templeton at
[phone], extension 541, or by e-mail at [e-mail].
Sin erely,
(' Alan . Klimek, .E.
Director
Enclosures: Approved plans and specifications
Engineer's Certification Form
Copies: John H. Reid, P.E. (w/ engr. cert.) - Reid Engineering Company, Inc.
1211 Princess Anne Street
Fredericksburg, VA 22401
Technical Assistance and Certification Unit
Central Files
NPDES Unit Files

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross, Jr., Secretary
Kerr T. Stevens, Director
I MIL; WA
1••
VIRONMENT
,SOURCES
71NAL OFFICE
2 7 2001
FOR r
CONSTRUCTION OF WASTEWATER TREATMENT F.449 TIES
ATC PROJECT NUMBER: 005126ACB
Tyson Foods Harmony WWTP
NPDES Permit No. NC0005126
I,-AwRFs1eE R. SAam a duly registered Professional Engineer
(please pant)
in the State of North Carolina and have been authorized to observe (circle one: eriodicall)weekly, full
time) the construction of the subject project for the Permittee:
Project No.: 005126ACB
Project: Tyson Foods — Harmony WWTP
Extension of side walls and installation of odor control on equalization basin
Location: Harmony Rendering Plant
Iredell County
The project consists of:
Extension of the side walls on the equalization basin
Installation of a cover on the equalization basin for odor control
I hereby certify that I did regularly observe this project with due care and diligence and that the
construction was cc ngleted in substantial conformance with the Authorization to Construct and with.. the
approved plans and specifications.
Signature Registration No. 132�q
Date 20©
The Division of Water Quality hereby
acknowledges receipt and acceptawe of
this Engineers CtxtiBcation
Upon completion of construction and prior to operation # the modified facility, the Permittee shall provide the
Division with a certification. from a professional engineer certifying that the permitted facility has been installed in
accordance with the NPDES Permit, this Authorization to Construct, and the approved plans and specifications.
The Certification should be submitted to:
NCDENR/DWQ, NPDES Unit, 1617 Mail Service Center, Raleigh, North Carolina 27699-1617

State of North Carolina
Department of Environmen'RECEIVED ` •
and Natural Resources
Division of Water Quality APR 2 6 2001
Michael F. Easley, Governor WATER QUALITY SECTION
William G. Ross, Jr., Secretary ., ,� L,;scharg® Compliance Enf.
Kerr T. Stevens, Director
tP April 16, 2001
S �St, *PT. OF ENVIROW4E`;
Mr. Andy Duvall `� \QD D49ATURAL RES r r
Tyson Foods �1�' �5
1225 W. Hudson Road
Rogers, AR 72756
Subject: Authorization obstruct
ATC No_ 0051ACB MAY 1 1 2001
t> NPDES Permit No. NC0005126
Harmony WWTP
Iredel! County
Dear Mr. Duvall:
The Division.of Water Quality's NPDES Unit has reviewed your request for an Authorization to Construct at
the Tyson Foods Harmony WWTP. The Division finds the proposed improvements to be satisfactory and
hereby grants authorization for the following:
• Extension of the side walls on the equalization basin
• Installation of a cover on the equalization basin for odor coin col.
This Authorization to Construct is issued in accordance with Nf 'ES Permit No. NC0005126, issued
September 13, 1999, and shall be subject to revocation :.:;iless tlx wastewater treatment facilities are
constructed in accordance with the terms and condition -)f the permit.
The Permitted shall notify. the Water Quality Supervisor of the tv'ooresville Regional Office, telephone
number [phone], at least forty-eight (48) hours prior to operation of the installed facilities, so that an
in -place inspection can be made. Notification shall be made duri.., g the normal office hours of 8:00 a.m. until E
5:00 p.m., Monday through Friday.
Engineer's Certification
Upon completion of construction and prior to operation of the modified facility, the Permittee shall provide
the Division with a certification (copy enclosed) from a professional engineer registered in North Carolina
certifying that the permitted facility has been installed in accordance with the NPDES Permit, this
Authorization to Construct, and the approved plans and specifications. The Certification should be submitted
to: NCDENR / DWQ, NPDES Unit, 1617 Mail Service Center, Raleigh, North Carolina 27699-1617.
Requirements for Certified Operator
The Permittee shall employ a certified wastewater treatment plant operator to be in responsible charge (ORC)
of the wastewater treatment facilities. The operator must hold a certificate of the type and grade at least
equivalent to or greater than the classification assigned to the wastewater treatment facilities by the
Certification Commission. The Permittee must also employ a certified back-up operator of the appropriate
type and grade to comply with the conditions of Title 15A, Chapter 8G, .0200. The ORC of the facility must
visit each Class I facility at least weekly and each Class II, III, and IV facility at least daily, excluding
weekends and holidays; and must properly manage and document daily operation and maintenance of the
facility and comply with all other conditions of Title 15A, Chapter 8G, .0200.
Additional Requirements
The Operational Agreement between the Permittee and the Environmental Management Commission is
incorporated herein by reference and is a condition of this Permit_ Noncompliance with the terms of the
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer Internet: http://h2o.enr.state.nc.us/

Tyson Food - Harmony WWTP
NPDES Permit No. NC0005126
ATC No. 005126ACB
Page 2
Operational Agreement shall subject the Permittee to all sanctions provided by G. S. 143-215.6 for violation
of or failure to act in accordance with the terms and conditions of this Permit.
Failure to abide by the requirements contained in this Authorization to Construct may subject the Permittee to
an enforcement action by the Division of Water Quality in accordance with North Carolina General Statute
143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not preclude the Permittee from complying with any and
all statutes, rules, regulations, or ordinances which may be imposed by other government agencies (local,
state, and federal) which have jurisdiction.
The Permittee shall maintain a copy of the approved plans and specifications on file for the life of the facility.
One (1) copy of the approved plans and specifications is enclosed for your records.
If you have any questions about this Authorization to Construct, please contact Mike Myers, at (919) 733-
5083, extension 508.
Sincerely,
Kerr T. Stevens
o_ Director
Enclosures: Project Plans and Specifications (approved)
Engineer's Certification Form
cc: fteigh Regional Office, Water Quality,
Technical Assistance and Certification Unit
Central' Files
NPDES Unit Files
Mr. Danny Wyatt - Tyson Foods, Harmony
1600 River Road
Wilkesboro, North Carolina 28697

of North Carolina
irtment of Environment
Vatural Resources
on of Water Quality
,ael F. Easley, Governor
William G. Ross, Jr., Secretary
Kerr T. Stevens, Director
I
bra NPed � rz
dft
4�z �v�'NC"iIFNR �F
FEB 2 6 2001
February 15, 2001
Mr. Andy DuVall
Tyson Foods
1225 W. Hudson Road
Rogers, AR 72756
Subject: ATC Request Acknowledgment
NPDES Permit NC0005126
ATC Number 005126ACB
Harmony WWTP
Iredell County
Dear Mr. DuVall:
The Division of Water Quality's NPDES Unit hereby acknowledges receipt of your request for
Authorization to Construct (ATC) in accordance with NPDES Permit Number NC0005126. This
application has been assigned the number highlighted above.
Please be aware that the Division's regional office, copied below, must provide recommendations
from the Regional Supervisor prior to final action by the Division.
The ATC review process generally takes 90 days from the date your complete submittal is
received, however, due to current staff shortages that review period may take longer. Should any
additional information be required, the review engineer will contact you. If you have any
questions, please contact Mr. Mike Myers at [phone], extension 508.
PLEASE REFER TO THE ABOVE APPLICATION NUMBER WHEN MAKING ANY
INQUIRIES ABOUT THIS APPLICATION.
Sincerely,
David A. Goodrich
Supervisor, NPDES Unit
cc: AMIN
NPDES Unit Permit File
Mr. Danny Wyatt Tyson Foods - Harmony
1600 River Road
Wilkesboro, NC 28697
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

It's what our amil deserves.'"
y y
Michael Myers
Tyson Foods, Inc.
1225 W. Hudson Rd.
Rogers, AR 72756
NC Division of Water Quality
1617Mail Service Center i F E B 13 2001
Raleigh, NC 27699
Dear Mr. Myers,
We are requesting authorization to construct an extension wall and a covered dome on the equalization
basin at our Harmony, NC rendering facility and modify permit number NC 0005126. The purpose of this
extension is not to increase the capacity of the equalization basin, but rather to allow the water to gravity
flow to the aeration pond in the event of a power failure.
In the event of a power failure, the wastewater pumps will shut down. The water that is in the lines will
gravity flow to the equalization basin causing the basin to overflow onto the ground. This is due to the size
and length of pipe from the plant to the equalization basin and the difference in elevation between the plant
and the equalization basin. The existing basin wall is 20' circular with V concrete walls. To prevent this
discharge, we intend to extend the height of the basin wall 51" with a "sectional" type tank and install an
8" overflow pipe that will allow the excess water to gravity flow into the aeration pond. We also intend to
cover the equalization basin with a dome to control odors. The dome cover will be removable to access the
equipment in the basin. 'The dome will be vented to accommodate change in pressure.
We began construction on this project prior to realizing that we needed to obtain permission to do so. We
have, however, halted construction at this time. A section of the extension wall has been left out and the
dome has not been attached. At this time, no additional capacity has been added and we are, effectively,
operating in compliance with our permit. Upon approval from the State of North Carolina, we will attach
the final panel, the dome, and the overflow pipe.
I have enclosed the documentation which was requested to Danny Wyatt in a letter dated January 05,2001
from Kerr T. Stevens.
Please respond as quickly as possible. You may contact me at [phone] or Danny Wyatt at (336)
838-2171 if you have any questions. Thank you for your time.
Sincerely,
Tyson Foods,ln�
C.
Andy DuVall
Cc: Danny Wyatt
Bo Watson
Dan Crowe
Lewis Gray
Kelly Pogue
Tyson Foods, Inc. Specialty Products Division 1225 West Hudson Road Rogers, AR 72756 800-950-2344 www.tyson.com

FEB 1:32WI
DENR - WATER QUALITY
POINT 30URCE BKANCH
ENGINEERED STORAGE PRODUCTS COMPANY
DEKALB, ILLINOIS 60115
PROJECT NAME: RIVER VALLEY ANIMAL FOODS
PROJECT LOCATION: HARMONY, NC
PROJECT NUMBER: 8010061
20 5 SS GLASSED
RELEASE No.: 1
RELEASE DATE: 1-31-2001
THIS DOCUMENT CONSISTS OF 1(a PAGES
SUBMITTED BY:
DATE: Q/
DATE: EXPIRES:
SEAL
17115 v
DATE:

ROOF MANWI
ROOF F
( 21) REQUIRED
KNUCKLE ROOF IS FLANGED TO
SHELL WITH 2 SETS OF ANGLES
FOR OCCASIONAL REMOVAL AS
SPECIFIED BY OTHERS.
GRADE LEVEL
PLAN
ELEVATION
NOTES:
1. THIS
DRAWING IS NOT TO SCALE.
2. REFER
TO TANK SCHEMATIC DOCUMENT
-013
FOR NUMBER OF RINGS IN TANK
AND
RESPECTIVE SHEET THICKNESSES.
3. THIS
TANK IS NOT DESIGNED FOR
ANY
EXTERNAL HYDROSTATIC LOADING.
mm
DIA.
GRAVITY VENTILATOR
,-TOP OF ROOF CAP
TOP OF SHELL SHEET
3'-11 13/16"
1214 mm
NOM.
SHELL SHEET 5 111/16"
( 7 ) PER RING
/__ FLOOR LEVEL 1668 mm
NOM.
RELI DESCRIPTION
VNREL / 01MIP 8010061
02/01
TANK PANEL INIEKIUK UUAIINb:
GLOBAL GLASS FUSED GLASS WITH
EDGECOAT PROCESS
TANK PANEL EXTERIOR COATING:
FUSED GLASS, COBALT BLUE
ROOF COLOR: COBALT BLUE
[rtilo l u i-.
ENGINEEREO STORAGE
PRODUCTS COMPANY
DEKALB, RLNOIS Wl1S
CONFIDENTIAL
THIS DRAWING IS THE PROPRIETARY PROPERTY OF
O. SMITH ENGINEERED STORAGE PRODUCTS COMPAN
AND SWILL NOT BE USED NOR REPRODUCED W"OUT
THE EXPRESS WRRTEN CONSENT OF THE COMPANY.
AOSESPC COPYRIGHT• 2001
ALL RIGHTS RESERVED
FILE: 8010061A
DRAWN BY DMA
DATE 02/01/01
2005 SSTT
SZ 1
RIVER VALLEY
ANIMAL FOODS
HARMONY, NC
DRWG
NO. 1 8010061-001