NCG020044_Regional Office Historical File Pre 2018

William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
February 13. 2007
Mr. Darrell Carpenter
Martin Marietta
P.O. Box 68
Bessemer City, NC 28016
Dear Mr. Carpenter:
Alan W. Klimek, P.E. Director
Division of Water Quality
We have been notified that on January 1, 2007, you submitted a compliance monitoring sample(s) for
analysis of Settleable Solids and Turbidity [Collected December 27, 2006], to Pace Laboratories Inc. Huntersville
NC. At your request the sample was analyzed even though it was not: ❑ properly preserved ❑Improper
Container ®Outside Holding time ❑ Other as follows:
Please be advised that under provisions of Regulations: 15A NCAC 2H .0805 (7) (N), at any time a
laboratory receives samples which do not meet sample collection, holding time, or preservation requirements, the
laboratory must notify the sample collector or client and secure another sample if possible. If another sample
cannot be secured, the original sample may be analyzed but the results reported must be qualified with the nature
of the infraction(s) and the laboratory must notify the State Laboratory about the infraction(s). The notification
must include a statement indicating corrective actions taken to prevent the problem for future samples. Ref: 15A
NCAC 2H .0805 (7) (N).
We are requesting that you take the appropriate steps to avoid a reoccurrence of this in the future. All
sample preservation and holding requirements must be met in accordance with Federal Register, July 1, 1995; 40
CFR 136. Failure to comply these requirements may result in enforcement action.
If you have questions or need additional information concerning this matter, please contact Mr. Pat
Donnelly at [phone] or me at [phone].
Sincerely,
Chester E. Whiting
Laboratory Section
cc: Pat Donnelly
Mike Parker
NorthCarolina
Natumilil
Mooresville Regional Office Division of Water Quality Phone [phone] Customer Service
Internet: www.ncwateruualit y.org, 610 East Center Ave, Suite 301 Mooresville, NC 28115 . Fax [phone]
An Equal Opportunity/Affirmative Action Employer— 50% Recycledl10% Post Consumer Paper

Februarys
Donald M Moe
Martin Marietta Materials Inc
PO Box 30013
Raleigh, NC 276220013
Su
Dear Permittee:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
7, 2005
NPDES Stormwater Permit Coverage Renewal
Martin Marietta -Kings Mountain
COC Number NCG020044
Cleveland County
In response to your renewal application for continued coverage hinder general permit NCG020000 the Division of Water
Quality (DWQ) is forwarding herewith the reissued stormwater eneral permit. Please review the new permit to familiarize
yourself with the changes in the reissued permit. The general permit authorizes discharges of stormwater and some types of
wastewater. You must meet the provisions of the permit for the types of discharges present at your facility. This permit is
reissued pursuant to the requirements of North Carolina Generz I Statute 143-215.1 and the Memorandum of Agreement
between the state of North Carolina and the U.S. Environmental Protection Agency, dated December 6, 1983.
The following information is included with your, permit package:
• A new Certificate of Coverage
• . A copy of General Stormwater Permit NCG020000
• A copy of a Technical Bulletin for the general permit
• Five copies of Discharge Monitoring Report (DMR) Fo ms - wastewater and stormwater
• Five copies of Qualitative Monitoring Report Form
Your coverage under this general permit is not transferable exc pt after notice to DWQ. The Division may require modification
or revocation and reissuance of the Certificate of Coverage. T is permit does not affect the legal requirements to obtain other
permits which may be required by DENR or relieve the permitteIe from responsibility for compliance with any other applicable
federal, state, or local law, rule, standard, ordinance, order, judgment, or decree.
If you have any questions regarding this permit package pleased contact Aisha Lau of the Central Office Stormwater Permitting
Unit at [phone], ext.578.
J
U r.�
for Alan W. Klimek, P.E.
cc: Central Files
Stormwater & General Permits Unit Files. FEB 2 1 2005
Mooresville Regional Office
,
NorthCarolina
Natmally
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 Phone [phone] Customer Service
Internet: h2o.enr.state.nc.uslsulstormwater.html 512 N. Salisbury St. Raleigh, NC 27604 FAX [phone]
An Equal Opportunity/Affirmative Action Employer— 50% Recycled110% Post Consumer Paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG020000
CERTIFICATE OF COVERAGE No. NCG020044
STORMWATER AND PROCESS WASTEWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and
the Federal Water Pollution Control Act, as amended,
Martin Marietta Materials Inc
is hereby authorized to discharge stormwater and to operate treatment systems and discharges associated
with mine dewatering wastewater and process wastewater from a facility located at
Martin Marietta -Kings Mountain
Hwy 216 S
Kings Mountain
Cleveland County
to receiving waters designated as Kings Creek, a class C stream in the Broad River Basin in accordance
with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, III, IV, V,
and VI of General Permit No. NCG020000 as attached.
This certificate of coverage shall become effective February 7, 2005.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day February 7, 2005
for Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

To: Permits and Engineering Unit
Water Quality Section
Attention: Susan Robson
SOC PRIORITY PROJECT: No
if Yes, SOC No. N/A
Date: June 25, 1993
NPDES STAFF REPORT AND RECOMMENDATIONS
County: Cleveland
NPDES Permit No.: NCG020044
MRO No.: 9.3-135
PART I - GENERAL INFORMATION
1. Facility and Address: Martin Marietta Aggregates
Kings Mountain Quarry
Post Office Box 30013
Raleigh, N.C. 27622
2. Data of investigation: June 22, 1993
3, Report Prepared By: Michael L. Parker, Environ, Engr. ii
4. Person Contacted and Telephone Number: Dexter Tate, (704)
739-4761 (Quarry)
5. Directions to Site: From the junction of T-85 and Hwy, 161
in Cleveland County, travel southwest on the I-85 service
road located in the northwest quadrant of this intersection,
The entrance to the Quarry will be on the right side of the
service road after traveling 0.7 mile.
6. Discharge Point(s), List for all discharge Points: -
Latitude: 350 13, 2211
Longitude: 810 2 0 ' 43'T
Attach a USES Map Extract and indicate treatment plant site
and discharge point on map.
USES Quad No.: G 1.3 NE
7. Site size and expansion area consistent with application:
Yes. If No, explain.
8. Topography (relationship to flood plain included): Rolling
5-15% slopes. The Quarry does not appear to be located in a
flood plain.
9. Location of Nearest Dwelling: No dwellings are located
within 500 feat of the quarry site.

Page Two
10. Receiving Stream or Affected Surface Waters: Kings Creek
a. Classification: C
b. River Basin and Subbasin No.: Broad 030805
G. Describe receiving stream features and pertinent
downstream uses; Receiving stream had flow at the time
of_the site investigation. Channel was small, however,
well defined (_9 feet wide and 1-4 inches deep). Other
known dischargers exists downstream of this facility,
PART iI - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
1_. a. Volume of Wastewater; t MGD (* Intermittent)
b. What is the current permitted capacity: N/A
C. Actual treatment capacity of current facility (current
design capacity): N/A
d. Date(s) and construction activities allowed by previous
ATCs issued in the previous two years: N/A
e. Description of existing or substantially constructed
WWT facilities: The existing WWT facilities consist of
an inorganic solids settling basin. Most of the
wastewater is recycled, however, on occasion a
discharge is necessary after a storm event.
f. Description of proposed WWT facilities: N/n,
g. Possible toxic impacts to surface waters: None
expected.
h. Pretreatment Program (POTWs only): N/A
i. Residual handling and utilization/disposal scheme;
a. If residuals are being land applied specify DEM Permit
No. N/A.
Residuals Contractor: N/A
Telephone No. N/A
b. Residuals stabilization: N/A
C. Landfill: N/A
d. Other disposal/utilization scheme (specify): ResiduaIs
(rock fines) are periodically dYedged from the settling
ponds and stockpiled on -site or occasionally sold.
3. Treatment Plant Classification: Less than .5 points; no.
rating (include rating sheet). Class I

Page Three
4. SIC Code(--): 1423
Wastewater Code( ):
Primary: 42
Secondary:
5. MTU Codes): 50000
PART IIi - OTHER PERTINENT INFORMATION
1. Is this facility being constructed with Construction ^rant
Funds or are any Public monies involved (municipals only)?
No
2_ Special monitoring or limitations (incltldinrl tQxiGitf')
requests: None at this time.
3. Important SOCIjOC or Compliance Schedule dates: N/A
4. Alternative Analysis Evaluation: N/A
PART IV - EVALUATION AND RECOMMENDATIONS
The existing WWT facilities at Martin Marietta's Kings
Mountain Quarry were operating properly at the time of the site
inspection. These facilities are designed to. operate as a re(7ycl-e
system except during periods of excessive rainfall. With the
water loss from evaporation and percolation, discharges from the
ponds rarely occur.
This facility meets the requirements for issuance of a NPDES
General_ Permit. Reissua-r.ce of this Permit as a General Permit ic�
recommended. -
C0 - G /_3
Sig ature Report Preparer Date
".,7-��
v
6-- =�;:3
Wa,e Quality
Regional Sup
visor
Date

MART01 MA91i Mtw 0MrS 'Mr. Ww
UNITED STATES
as DEPARTMENT OF THE INTERIOR
GEOLOGICAL SURVEY 13
81°22'30" 1 890 000 FEET (S.C.) 4680m,.E 20' +70 1
35° 15'
1:' 11
ER I SST
y�
it �f �� I% 900 /,', l / �• ' • '�
r l _�• A� Golf 2 _ eaT�
00RK
N. i, f-- ` Cosi , I ` (,l YOG3i. t A-r— T __P�rk 1
•Ill' �/o���U �_ ^'�' L.; � /`^J `�\'T _ �/ /I'..� II III '� .: 1.4 • r I `C�Jjyr� tral . I� 0 1 /j" er'� IS --. '
SSI'II C RID6E,
mem
��Ch F �Hospl al 11 ✓( sae �� I II Sr
� y j��+- Ity• "Libra �� --- 953�
- -------- -- a + I {— WT 4tra idn
-= Mou AIN I LIl- all• i\/~'s ° �'PIa \ I
BM,"a mory (—�—ir—�r— Moun;a�ri'•,` �•
i�� ,G IIIMN-,,TITTAIN 9ia I��P Rest 1
Q.Ch�%\a-
-East sae'
frr /
SR,96
V \ O� ' ♦ ec
98
kO FEET ` \'I/�` \�: /\ Si,j — i f U' ' ✓ /%' _ - /
.'. /- / / \ - - /Industri
VDTsal�Was,,e.
M n `\ - > Ponds /
_
:7 :S
�•a ' / �1 . .� �•%
k �'� II ��• `?tSand9�\I � � �ah, /�'I�_. � .'"/i '�y', l � ,'i,�— �/C
1
aK de("-
� �/ l �l �,9.35 'Cl \ . - n � /9 r+ ��. /.' r � �, � � �i � %�• •."/'` '�`/% -. = i iE r �' � �, \ I) � / \ 1 .

RATING SCALE FOR CLASSIFICATION OF FACILITIES
Name of Plant:_ e1W711)
Owner or Contact Person:
41,0_7G50^)
Mailing 'Address:
/?D. 1-5e-4- 30D/3
G24 GE Z'Gh! , X C. 2 76ZZ
County:
Telephone: 7
NPDES Permit No. NC00
Nondisc. Per. No.
IssueDate:
Expiration Date:
Existing Facility 44e- s
New Facility
Ra,ted By. 1 1011y'(i�'Klefr .?
Date:_ 13llvZ s
Reviewed (Train. & Cert.) Reg.
Office
Reviewed (Train. & Cert.) Central Office
ORC
Grade
POINTS ITEM
(1) Industrial Pretreatment Units and/or
Industrial Pretreatment Program
(see%delinition No. 33)
(2) D SI ,N FLOW OF PLANT IN GPD
(not applicable to non-conlaminaled cooling
waters, sludge handling facilities for water
purification plants, totally closed cycle
systems (del. No. 11). and facilities
consisting only of Item (4) (d) or Items (4) (d)
and (11) (d))
0 20.000..........................
20,001 -- 50.000..........................
50,001 -• 100.000..... ..................
100.001 -- 250,000..........................
250.001 -• 500,000..........................
500,001-1.000,000..........................
1.000.001 -- 2.000.000 ........................
2.000.001 (and up) - rate 1 point additional for each
200.000 gpd capacity up to a
maximum of 30
1
2
3_
4
5
8
10
Design Flow (gpd) -- /i )/II AP .11,,95,J�
o /J 2 I;UA,4
(3) PRELIMINARY UNITS (see definition no. 32)
(a) Bar Screens ................................ 1
or
(b) Mechanical Screens, Static Screens or
Comminuting Devices ......... ..2
(c) Grit Removal ............................... 1
or
(d) Mechanical or Aerated Grit Removal . • - ... - - - - - 2
(e) Flow Measuring Device ....................... 1
or
(1) Instrumented Flow Measurement . - 2
(9) Preaeralion ............. ................ 2
(h) Influent Flow Equalization .- 2
(i) Grease or Oil Separators - Gravity ...... ...... . 2
Mechanical . - ... . 3
(1) Pretdtlor' Dissolved AirFlotation. 8
malion.............................. S
Poll-,'
(4) PRIMARY TREATMENT UNITS
(a) Septic Tank (see definition no. 43) ............. .
(b) Imhoff Tank ................................. .
(c) Primary Clarifiers ..•-
...... ...... ..:...... .
(d) Settling Ponds of Settling Tanks for Inorganic
Non -toxic Materials (sludge handling facilities
for water purification plants, sand, gravel,
stone,, and other mining operations except
recreational activities such as gem or gold
mining). .. ..... ........................
(5) SECONDARY TREATMENT UNITS
(a) Carbonaceous Stage
(i)Aeration - High Purity Oxygen System ....
Diffused Air System .... ..... .
Mechanical Air System (fixed,
floating or rotor) ... , .... • , , , . .
Separate Sludge Reaeration .... .
(ii) Trickling Filter
HighRate ...................
Standard Rate ...............
Packed Tower ...............
(fii) Biological Aerated Filler or Aerated
Biological Filler ......................
(iv) Aerated Lagoons ...................... .
(v) Rotating Biological Conlaclors ..........
(vi) Sand Filters -
intermittent biological .... .
recirculating biological .... .
(vii) Stabilization Lagoons ...................
(viii)Clarifier .................... . . ....... .
(ix) Single stage system for combined
carbonaceous removal of BOD and
nitrogenous removal by nitrification
(see del. No. 12) (Points for this item
have to be In addition to items (5) (a)
(i) through (5) (a) (viii) ..... ....... .
(x) Nutrient additions to enhance SOD
removal.. ..... ....... .....
(xi) Biological Cullure ('Super Bugs') addition
to enhance organic compound removal .....

(i) Aeration - High Purity Oxygen System ...
20 (i) ` Sludge Holding Tank - Aerated . 5
Diffused Air System ...........
10 Non -aerated 2
Mechanical Air Syslam (fixed,
floating, or rotor) ...... ......
.
0) Sludge Incinerator - {not including activated
6
Separate Sludge Reaeration .....
carbon regeneration) .. 10
3 (k) Vacuum Filler, Centrifuge or Filter Press or
(it) Trickling Filler -
other
similar dewalering devices
HighRate ..............
...................
. 10
Standard Rate ............
5 (8) SLUDGE DISPOSAL (including inldnerated ash)
Packed Tower ............
5 (a) Lagoons .
(iii) Biological Aerated Fitter or Aerated
2
(b) Land Application (surface and subsurface)
Biological Filter ..... , ............
10 (see definition 22a)
(iv) Rotating Biological Contactors ............
10 -where the facility holds the land app.
(v) Sand Filler-
permit .. 1 p
-by contracting to a land application operator
intermittent biological ........
who
2 holds the land application permit
recirculating biological ........
(vi) Clarifier
. 2
3 -land application of sludge by a contractor who does
• • • • . • .. • ... • .. • . • .... • • • . • . • • . •
5 not hold the permit for the wastewater treatment
(6) TERTIARY OR ADVANCED TREATMENT UNIT
facility where the sludge is generated ......... 10
(c) Landfilled (burial) ..............
(a) Activated Carbons Beds -
(9) DISINFECTION ' ' ' ' ' ' 5
without carbon regeneration ..................
5 (a) Chlorination
with carbon regeneration ....................
.... 5.
1.5 (b) Dechlorinalion
(b) Powdered or Granular Activated Carbon Feed -
. 5
• •
(c) Ozone
Without carbon regeneration .................
...........
• . . . . . . . 5
5 (d) Radiation
with carbon regeneration ...................
. 5
15 (10) CHEMICAL ADDITION SYSTEM (S) (See�delinilion No. 9)
(e) Air Stripping .............................
5 (not applicable to chemical additions rated as item
(d) Denitrificalion Process (separate process) .....
10 (3) 6). (5) (a) (xi), (6) (a), (6) (b), (7) (b), (7) (e),
(e) Electrodialysis ........ „ ....................
5 (9) (a), (9) (b), or (9) (c) 5 points each: List:
(f) Foam Separation ...........................
5
(g) Ion Exchange ................................
5 ..... 5
(h) Land Application of Treated Effluent
. ' ' . ' 5
(see definition no. 22b) (not applicable for
5
sand, gravel, stone and other similar mining
(11) MISCELLANEOUS UNITS . . 5
operations)
on agriculturally
(a) Holding Ponds, Holding Tanks or Settling Ponds
,ji) managed sites (See def.
for Organic or Toxic Materials including wastes
No. 4)................................... 10 from mining operations containing nitrogen and/or
(ii) by high rate infiltration on non -agriculturally phosphorous compounds in amounts significantly
managed sites (includes rotary distributors
greater than is common for domestic wastewater 4
and similar fixed nozzle systems) ...........
(iii) by subsurface disposal (includes low
..........
4 (b) Effluent Flow Equalization (not applicable to storage
basins
pressure
which are inherent in land application systems). 2
Pipe systems and gravity systems except at
(c) Stage Discharge (not applicable to storage basins
plants consisting of septic tank and nitrifica-
lion tins only) ..........................:..
- inherent in land application systems ... _...
4 (d) .....:........................ 5
(i) Microscreens..................................
5 (e) Stand -By P " er S --».. __..... _...„.
°�" uPt�y•••.............„:.»............
(j) Phosphorus Removal by Biological Processes
(1) Pollution Ina PoUu r
Thermal Control DevKe.........
(See def. No. 26) .............................
».................. ». .......... 3
22
(k) Polishing Ponds - without aeration .. . .
with aeration ...........
5
(1) Post Aeration - cascade , • , , , • , ,
0
, ..
diffused or mechanical .
(m) Reverse Osmosis . .,,, , •_
5 TOTAL POINTS
5
,,, , , , , , , , • , .
(n) Sand or Mixed•MediaFillers -low rate .........
2
high rate ..........
(o) Treatment processes for removal of metal or
5 CLASSIFICATION
. cyanide ...............................:... •
(p) Treatment processes for removal of tonic
15 �
Class I.__.....»..„....».„.......»„ ................ 5 - 25 Points
Class II....._»
materials other than metal or cyanide .........
»..„. 26. 50 Points
15 Class Ill..........„.„..„»....,_,_,,
. _ 51- 65 Points
(7) SLUDGE TREATMENT
Class IV.„.„,»_„ •»,�„•�». 66• Up Points
'
(a) Sludge Digestion Tank - Heated
Facilities having a rating of one through lour points, inclusive,
...............
to do not require a certified operator. Classification of all other
Aerobic.... _ ..:......
5 facilities requires a comparable grade operator in responsible
Unhealed .............
3 charge.
(b) Sludge Stabilization (chemical or thermal) .......
5
(c) Sludge Drying Beds - Gravity .................
2 Facilities having an activated sludge process will be assigned
Vacuum Assisted .......
(d) Sludge Elulrialion
5 a minimum classification of Class II.
.. , . , . ,
(e) Sludge Conditioner (chemical or Rwt=q ...� ...��
........
5
5 Facilities having treatment processes for the removal of metal
(1) Sludge Thickener (gravity) .................... . .
(9) Dissolved Air Flolation Unit
5 or cyanide will be assigned a minimum classification of Class it.
(not applicable to a unit rates as (3) (i) .... , , • , ,
(h) Sludge Gas Utilization (including gas storage) ....
8 Facilities having treatment processes for the biological removal
2 of phosphorus will be assigned a minimum classification of Class`
III.

3
�1�,ts1 �5�1►,1E �,��Z
State of North Carolina
Department of Environment, Health and Natural Resources
Division of Environmental Management
512 North Salisbury Street • Raleigh, North Carolina 27611
James G. Martin, Governor
William W. Cobey, Jr., Secretary
October 22, 1992
Horace S. Willson
Martin Marietta Corporation
P. O. Box 30013
Raleigh, NC 27622
A. Preston Howard, _Jr., P.E.
Acting Director
Subject: Renewal Application
NPDES: NCG020044
Formerly: NC0005444
Cleveland County
Dear Mr. Willson:
This letter is to acknowledge receipt of your renewal application for Martin Marietta Corp. -Kings
Mountain Quarry's NPDES permit, and to also inform you that this facility qualifies for coverage under the
newly issued General Permit. Your discharge fits into one of the general permit categories. Therefore, the
subject facility has been assigned the new permit number highlighted above.
On July 31, 1992, the Division of Environmental Management issued general permits for a number
of process related discharges and stormwater discharges. A general permit is a permit issued by the state
to cover a category of dischargers, such as mine pit dewatering, noncontact cooling waters and boiler
blowdown discharges, groundwater remediation, sand dredging operations, seafood and freshwater fish
packing and rinsing and fish farms, and.stormwater discharges. These general permits have been taken to
public notice and issued in accordance with the North Carolina Administrative Code (15A NCAC 2H
.0100) and the Memorandum of Agreement between EPA and the state.
Typically, an application for coverage under these general permits consists of completion of the
Notice of Intent (NOI) application form and submittal of the form with the appropriate application fee.
After receipt of the application, the state will review the information and make a determination of the
applicability. of the general permit to your specific discharge. We will evaluate you applicaation for
individual permit, received on *DATE* as if for coverage under the general permit. If the discharge is
deemed appropriate for coverage under the general permit, you will be issued a certificate of coverage under
the general permit. Processing time for the issuance of a certificate of coverage is expected to be less than
90 days as compared to 180 days for the individual application process.
Regional Offices
Asheville Fayetteville Mooresville Raleigh Washington Wilmington Winston-Salem
704/251-6208 -919/486-1541 704/663-1699 919/571-4700 919/946-6481 919/395-3900 919/896-7007
Pollution Prevention Pays
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone]
An Equal Opportunity Affirmative Action Employer

Page 2
. October 22, 1992
NCG0200044
This method of application does not require the application to be sent to public notice, thus the time
to issue the permit is less. Issuance of a general permit for this facility is contingent upon approval from
our regional office staff.
If you have questions regarding this matter, please contact Susan Robson at [phone].
Sincerely,
a'�
Coleen Sullins, P.E.
Supervisor, NPDES Group
cc: Mooresville Regional Office
-Permits and En_ gingering Unit
Central Files

R3
FOR AGENCY USE ONLY
DATE RECEIVED
DATEISSUED
9.10 . �
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
11
-NOTICE OF INTENT REQUESTING COVERAGE UNDER THE
MINING ACTIVITIES GENERAL NPDES PERMIT NCG020000
Complete this Notice of Intent (NOI) and mail to the following address
North Carolina Division of Environmental Management
Water Quality Section, NPDES Group,
P.O. Box 29535
Raleigh, North Carolina, 27626-0535
The NOI must be accompanied with a general permit filing fee of $400.00. The check should be
C-3
made out to the North Carolina Department of Environment, Health, and Natural Resources.
Facility Owner/Operator Information:
Name: lit-1-A-rij r-1,o9-4STT4h,- Kw4CaS 1`100r4T j U eZ--r
Address: PO 13c", 3cx>13
City: State: —
Zip: Phone: 70 1 -
Facility Location Information*
Name:__LiNe*i6 ljourjT&jrj Ouit�X-&K
Address: 120- 6bA -74--7
City: N T� t-A State: NC- Zip: Z808G,
County: GLSVI, L­O.W P -_Phone f704) 739 - 4-74o I
Physical Location Information:,
(Street address, state road number, distance and direction from roadway intersection, and
attach a copy of a county map or USGS quad with the location of the facility marked on the map.)
[Agency use only: Latitude Longitude
NOI 02
PAGE 1

Type of minerals mined at this facility:
Standard Industrial Classification (SIC CODE): 14Z-:�(for activity for which the facility is
primarily engaged)
This is an _X existing facility or a _ proposed facility.
If proposed, date operation -is to begin
Discharges are to Jr1n1yMED 7-F46LMCI.R—( To L���I�aS CREEK
(name of receiving waters or, if to'a separate
storm sewer system, name of the separate storm sewer system)
A. Does this facility have any NPDES Permits? des _no If yes, NPDES No. NG00o544-4-
B. Are vehicle maintenance activities occurring on site? x yes no
C. Are mine dewatering discharges occurring? X yes _no
D..Are discharges of overflows from process wastewater treatment systems occurring? _yes Xno
If yes, complete the following on the wastewater treatment system:
1. Please describe the type of process used to treat and/or recycle the process .
wastewater. Give design specifics (i.e. design volume, retention time, surface area,
etc.). Existing treatment facilities should be described in detail and design criteria or
operational data should be provided (including calculations) to ensure that the facility
can comply with requirements of the General Permit.
NOTE: Construction of any wastewater treatment facilities require submission of three (3)
sets of plans and specifications along with their application. Design of treatment
-facilities must comply with requirements 15A NCAC 2H .0138. If construction of
wastewater treatment facilities applies to the discharge of process wastewater,
include three sets of plans and specifications with this application.
2. Does this facility employ chemical additives to flocculate suspended solids? _yes X no
If yes, please state the name, manufacturer and the quantity of average daily usage of
the chemical additive.
3.. Does this facility overflow only during rainfall events exceeding the 10-year, 24-hour
rainfall event? des X no -. ------
E. Does this facility employ any best management practices for stormwater control? Ryes _no
If yes, please describe "r411s s iTS 6peAAl-ES uNVE2 njNE P P-nlr * 2 -2 wl ,e-4
INorS 60061"ClE uiZI IVE HINiNC, A[-T OF 1971 -MlS PG IT lam✓�f�
EKos►o�J GaNT?,a., SEEv�.ICa or 19 2EcL&r1,wno,J fb-ME' !GITF—
a
NOI 02 PAGE 2'

JIL
F. Number of discharge points
Mine Dewatering I ; Stormwater I ;
Process Wastewater Overflows ' ;
Please provide short narrative description of discharges _HINS 1715r-OAX&t✓ 15
PUrl9 -rb Gw-e:4. 1i1t5 M4F adEnt catiJ FP,oP
4-A o:J-sly POND L.DG,maP-Q 15_L'0 m4F-
I hereby request coverage under the referenced General Permit. I understand that coverage
under this permit will constitute the permit requirements for the discharge(s) and is
enforceable in the same manner as an individual permit.
I agree to abide by the following as a part of coverage under this General Permit:
1. 1 agree to abide by the -approved Mining Permit for this mining activity. ( A copy of the valid mining
permit must be attached to this request.
2. 1 agree to not. discharge any sanitary wastewater from this mining activity except under the
provisions of another NPDES permit specifically issued therefore.
3. 1 agree that bulk storage of petroleum products and other chemicals shall have adequate protection so
as to contain all spills on the site.
4. 1 agree that solid wastes will be disposed of in accordance with N.C. statutes and rules governing
solid waste disposal.
5. 1 agree that maintenance activities for vehicles and heavy equipment will be performed so as to not
result in contamination of the surface or ground waters.
(.agree to abide by the provisions as listed above and recognize that the provisions are to be considered
as enforceable requirements of the General Permit.
I certify that I am familiar with the information contained in the application and that to the best of my
knowledge and belief such information is true, complete, and accurate.
signature
�G R�r � S. W ► LrVso I
name of person signing above (printed or typed)
oz P; Ig9--;,
date
HANAGFJL� Er.l�/IrT.or�IME�ITD.I.� �jFf�„/icFs
title
North Carolina General Statute 143-215.6E (i) provides that: Any person who knowingly
makes any false statement, representation, or certification in any application, record, report,
plan or other document filed or required to be maintained under Article 21 or regulations of the
Environmental Management Commission implementing that Article, or who falsifies, tampers
with or knowingly renders inaccurate any recording or monitoring device or method required to
be operated or maintained under Article 21 or regulations of the Environmental Management
Commission implementing that Article, shall be guilty of a misdemeanor punishable by a fine
not to exceed $10,000, or by imprisonment not to exceed six months, or by both. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment not
more than 5 years, or both, for similar offense.)
NOI 02 PAGE 3

AGGREGATES COMPANY
P.O. BQK 30013, RALEIGH, NORTH CAROLINA 27622-0013
PAY
TOO THE ORDER OF
I
NC DEPT OF NAT RES
P 0 BOX 27687
RALEIGH
DIVIDISTRICT DISBURSEMENT ACCT.
VOID SIXTY DAYS FROM DATE
DATE
61395
09/24/92
WACHOVIA BANK & TRUST CO.
RALEIGH, N.C.
99-017413
$******400.00
MARTIN MARIETTA CORPORATION
GGREG ES COMPANY
NC
2 7 6 1 1 AUTHORIZED SIGNATURE
1110099017413110 1:053107C3331:0L6268 070169110
MITTANCE: If correct NO ACKNOWLEDGMENT is NECESSARY. PLEASE DETACH BEFORE DEPOSITING THIS C
y''
.P.URP.OSE/OTHER,
.. _ .:DATE
INVOICE
INVOICE
. ' ,NUMBER =.;: a.
INVOICE t
,.._; '..'.AMO-U1�ITE.-;
LOC
oEPT'
COST.`
.ACCT
;.EQUIP,'
NO.:<
'AMOONT
GENERAL NPDES
PERMIT
FEE - KINGS
MOUNTAIN
QUARRY
KINGSMTN
09/24/92
PERMIT FEE
400.00
606
70
5718
400
01
99-017413
MARTIN MARIETTA AGGREGATES COMPANY . P.O. BOX 30013, RALEIGH, NORTH CAROLINA 27622-0013

K d �SCA7E o
PPPIPP,
it C. DEFT. OF NAT�JRAI�
ti RESOURCES AND
COMMUNITY (DEVELOPMENT.
&�°""""�OCT 2 6 9992
State of North Carolina ®IVISION OF ENVIRON64EHAt MANAGEMERi
Department of Environment, Health and Natural ReVMS#11E REGIONAL OFFICE
Division of Environmental Management
512 North Salisbury Street • Raleigh, North Carolina 27611 `
James G. Martin, Governor
William W. Cobey, Jr., Secretary
October 22, 1992
Horace S. Willson
Martin Marietta Corporation
P. O. Box 30013
Raleigh, NC 27622,
A. Preston Howard, -Jr., P.E.
Acting Director
Subject: Renewal Application
NPDES: NCG020044
Formerly: NC0005444
Cleveland County
Dear Mr. Willson:
This letter is to acknowledge receipt of your renewal application for Martin Marietta Corp. -Kings
Mountain Quarry's NPDES permit; and to also inform you that this facility qualifies for coverage under the
newly issued General Permit. Your discharge fits into one of the general permit categories. Therefore, the
subject facility has been assigned the new permit number highlighted above.
On July 31, 1992, the Division of Environmental Management issued general permits for a number
of process related discharges and stormwater discharges. A general permit is a permit issued by the state
to cover a category of dischargers, such as mine pit dewatering, noncontact cooling waters and boiler
blowdown discharges, groundwater remediation, sand dredging operations, seafood and freshwater fish
packing and rinsing and fish farms, and. stormwater discharges. These general permits have been taken to
public notice and issued in accordance with the North Carolina Administrative Code (15A NCAC 2H
.O 100) and the Memorandum of Agreement between EPA and. the state.
Typically, an application for coverage under these general permits consists of completion of the
Notice of Intent (NOI) application form and submittal of the form with the appropriate application fee.
After receipt of the application, the state will review the information and make a determination of the
applicability. of the general permit .to your specific discharge. We will evaluate you applicaation for
individual permit, received on *DATE* as if for coverage under the general permit. If the discharge is
deemed appropriate for coverage under the -general permit, you will be issued a certificate of coverage under
the general permit. Processing time for the issuance of a certificate of coverage is -expected to be'less than
90 days as compared to 180 days for the individual application process.
Regional Offices
Asheville Fayetteville Mooresville Raleigh Washington Wilmington Winston-Salem
704/251-.6208 919/486-1541 704/663-1699 .919/571-4700 91.9/946-6481 919/395-3900 919/896-7007
Pollution Prevention Pays
P.O. Box 29535, Raleigh; North Carolina 27626-0535 Telephone [phone]
An Equal Opportunity Affirmative Action Employer

Page 2
October 22, 1992
NCG0200044
This method of application does not require the application to be sent to public notice, thus the time
to issue the permit is less. Issuance of a general permit for this facility is contingent upon approval from
our regional office staff.
If you have questions regarding this matter, please contact Susan Robson at [phone].
Sincerely,
Coleen Sullins, P.E.
Supervisor, NPDES Group
cc: b -resvxlle--R:egio—wLOffice
Permits and Engineering Unit
Central Files

r ECEIVED
Water Quality Section
MAY 2 0 1988
Asheville Regional GIHCe
Asheville, North Carolina
/ State of North Carolina
Department of Natural Resources and Community Development
Division of Environmental Management
512 North Salisbury Street • Raleigh, North Carolina 27611
James G. Martin, Governor R. Paul Wilms
S. Thomas Rhodes, Secretary May 16, 1988 Director
Mr. Horace Willson
Martin Marietta Aggregates
PO Box 30013
Raleigh, NC 27622
Subject: Permit No. NC0005444
Kings Mountain Quarry
Cleveland County
Dear Mr. Willson:
In accordance with your application for discharge permit received on
February 1, 1988, we are forwarding herewith the subject State - NPDES
permit. This permit is issued pursuant to the requirements of North Carolina
General Statute 143-215.1 and the Memorandum of Agreement between North
Carolina and the US Environmental Protection Agency dated December 6, 1983.
If any parts, measurement frequencies or sampling requirements
contained in this permit are unacceptable to you, you may request a waiver
or modification pursuant to Regulation 15 NCAC 2B .0508(b) by written
request to the Director identifying the specific issues to be contended.
Unless such request is made within 30 days following receipt of this permit,
this permit shall be final and binding. Should your request be denied, you
will have the right to request an adjudicatory hearing.
Please take notice that this permit is not transferable. Part II, B.2.
addresses the requirements to be followed in case of change in ownership or
control of this discharge.
This permit does not affect the legal requirement to obtain other
permits which may be required by the Division of Environmental Management or
permits required by the Division of Land Resources, Coastal Area Management
Act or any other Federal or Local governmental permit that may be required.
If you have any questions concerning this permit, please contact Ms.
Lula Harris, at telephone number 919/733-5083.
Sincerely,
ar+t,l' i S 'Ell 11 ,
F0?; R. Paul Wilms
cc:. Mr. J1 ck EPA
Pollutior, Preventibn Pa.'s
/ P.O. Box 27687, Raleigh, North Carolina 27611-7687 Telephone [phone]
d.. F..,,�I (h..,.,rn,n,n• AN:rtn�fivP Arrinn Fmnlmmr

Permit No. NC0005444
STATE OF NORTH CAROLINA
DEPARTMENT OF NATURAL RESOURCES & COMMUNITY DEVELOPMENT
DIVISION OF ENVIRONMENTAL MANAGEMENT
P E R M I T
To Discharge Wastewater Under the NATIONAL
POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provisions of North Carolina General
Statute 143-215.1, other lawful standards and regulations
promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control
Act, as amended,
Martin Marietta Aggregates
is hereby authorized to discharge wastewater from a facility
located at
Kings Moutain Quarry
Cleveland County
to receiving waters designated as an unnamed tributary to Kings
Creek in the Broad River Basin
in accordance with effluent limitations, monitoring requirements,
and other conditions set forth in Parts I, II, and III hereof.
This permit shall become effective June 1, 1988
This permit and the authorization to discharge shall expire
at midnight on May 31, 1993
Signed this day of May 16, 1988 0sIGINAL SIGNED 8Y
AR r H UR MO UBERRY
FOR
R. Paul Wilms, Director
Division of Environmental Management
By Authority of the Environmental
Management Commission

Page 2 of 2
Permit No. NC0005444
SUPPLEMENT TO PERMIT COVER SHEET
Martin Marietta Aggregates
is hereby authorized to:
1. Continue to operate mine dewatering facilities and
a closed system recycle system for the process water
located at the Kings Mountain Quarry
(See Part III of this Permit), and
2. Discharge from said works into an unnamed tributary
to Kings Creek which is classified Class "C" waters in
the Broad River Basin.

A. M .
EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
,
During the period beginning on the effective date of the permit and
authorized to discharge from outfall(s) serial number(s) 001.
lasting until expiration, the permittee is
Such
by the permittee as specified below:
discharges shall be
limited and monitored
Effluent Characteristics Discharge Limitations
Monitoring Requirements
Kg/day (lbs/day) Other Units (Specify)
Daily Avg. Daily Max. Daily Avg, Daily Max.
Measurement
Frequency
Sample *S!r le
Type Location
Flow
Monthly
Instantaneous E
Settleable
Solids 0.1 ml/l 0.2 ml/l
Monthly
Grab E
Turbidity
50 NTU
Monthly
Grab E
*Sample location: E - Effluent
BMP Conditions
1. The permittee shall operate the facilities in a manner which will minimize the impact on the
receiving waters.
2. The permittee shall utilize sound management practices to ensure that contaminates do not enter
the surface waters as a result of blasting at this site.
The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units and shall be monitored
monthly at the effluent by grab samples.
There shall be no discharge of floating solids or visible foam in other than trace amounts.
NC0005444

Part I
B. Schedule of Compliance
1. The permittee shall comply wi.tli Final Effluent: Limitations specified for
discharges in accordance with the following schedule.:
Permittee shall comply with Final. Effluent Limitations by the effective
date of the permit.
2. Permi.ttee, shall at all times provide the operation and maintenance
necessary to operate the existing facilit-ies at optirn:nl efficiency.
3. No later than 14 calendar days following a date. identified in the above
schedule of compliance, the permittee shall submit either a report of
progress or, in the case of specific actions being required by identified
dates, a written notice of compliance or noncompliance. In the latter
case, the notice shall include the cause of noncompliance, any remedial
actions taken, and the probability of meeting the next schedule
requirements.

Part '11
Page 1 of 14
PART II
STANDARD CONDITIONS FOR NPDES PERMITS
SECTION A. GENERAL CONDITIONS
1. Duty to Comply
The permittee must comply with all conditions of this permit. Any permit
noncompliance constitutes a violation of the Clean Water. Act and is grounds
for enforcement action; for permit termination., revocation and r.eissuance,
or modification; or for denial of a. permit r.enew2l ai���li.cation.
2. Penalties for Violations of Permit. Conditions
Any person who violates a permit co;idition :is subject to a civil penalty not
to exceed $1.0,000 per day of such violation. Any person who willfully or
negligently violates a permit condition is guilty of a misdemeanor punishable
by a fine not to exceed $15,000 per day of violation, or by imprisonment
not to exceed six months or both.
3. Dut�to Mitigate
The permittee shall take all reasonable steps to minimize any adverse impact
to navigable waters resulting from noncompliance with any effluent limitations
specified in this permit, including accelerated or additional monitoring as
necessary to determine the nature and impact of the noncomplying discharge.
4. Permit Modification
After notice and opportunity for a hearing pursuant to NCGS 143-21.5.1(b)
(2) and NCGS 143-215.1(e) respectively, this permit may be modified, suspended,
or revoked in whole or in part during its term for cause including, but not
limited to, the following:
a. Violntyon of any, terms or conditions of tl-:.i.s permit;
b. Obtaining this permit: by misrepresentation o.r.• fai_lure to disclose fully
all relevant facts;
C. A change in any condition that requires either a temporary or permanent
reduction or elimination of the authorized discharge; or
d. Information newly acquired by the Division indicating the discharge poses
a threat to human health or welfare.
If the permittee believes that any past or planned activity would be cause for
modification or revocation and reissuance, the permittee must report such
information to the Permit Issuing Authority. The submittal of a new application

Part IT
Paige 2 of 14
may be required of the permittee. The filing of a request by the permittee for
a permit modification, revocation and reissuance, or termination, or a
notification of planned changes or anticipated noncompl..i.ances, does not stay
any permit condition.
5. Toxic Pollutants
Notwithstanding Part II, A-4 above, if a toxic effluent: standard or prohibition
(includiut an;' schedule of cemplianc�; specified in suc:.Y effluent: s''La1-1 :d or
prohibition) is established under Section 307(a) of the Act for a toxic
pollutant which is present in the discharge, if such standard or prohibition
is more stringent than any limitation for such pollutant in t.lh:is permit., this
permit shall be revised or modified in accordance with the toxic effluent
standard prohibition and the permittee. so notified.
The permittee shallcomply with effluent standards or prohil)itions established
under Section 307(a) of the Clean Water Act for toxic poltutants within the
time provided in the regulations that establish those st inci,-.i.r.ds or prohibitions,
even if the permit has not yet. been modified to incorporatrl. the requirement.
6. Civil and Criminal Liability
Except as provided in permit conditions on "Bypassing" (Part .II, B-3) and
"Power Failures" (Part II, B-6), nothing in this permit shalt be construed
to relieve the permittee from any responsibilities, liabili.t:.ies, or penalties
for noncompliance pursuant to NCGS 143-215.3, 143-215.6 or. Section 309 of the
Federal Act, 33 US(7 131.9. Furthermore, the permittee is responsible for
consequential damages, such as .fish kills, even though the responsibility
for effective compliance may be temporarily suspended.
7. oil and llazardcus Substance Liability
idol}ling in Lids permi.-t sbal l ios; co,).strUed to px:eclucle t:tiQ in st..i.t.u'Lion of any
legal actic»> or rel.i.eve. the permittee from any resl?.)11Si.bi tittlls, liabilities,
or penalties to s:hi_,:I, t:he permittee is or may be subject to under NCGS
143-21.5.75 at seq. or Section 311 of the Federal Act, 33 USC 1321. Furthermore,
the permittee is responsible for consequential. damages, such as fish kills,
even though the responsibility for effective compliance may be temporarily
suspended.
8. Property Rights
The issuance of this permit does not convey any property righ.t.s in eitfi.er real
or personal property, or any exclusive privileges, i:,.or dons it authorize any
injury to private property or any invasion of personal ri-ghts, nor any
infringement of. Federal, State or local laws or regulations.

Par.L II
T'age 3 of 14
9. Onshore of Offshore Construction
This permit does not authorize or approve the construction of any onshore or
offshore physical structures or facilities or the undertaking of any work
in any navigable waters.
10. Severability
The provisions of this permit are severable, and if any provision of this
permit, or the application of any provision of this permit to any circumstances,
is held invalid, the app:l.i.cati.on of such provision to otter circumstances, and
the remainder of this permit, shall not be affected thereby.
11. Duty to Provide Information
The permittee s110-1l furnish to the Permit: Issuing Authority, within a reason-
able time, any information which the Permit Issuing Antho.r.ity may request
to determine whether cause exists for modifying, revoking and reissuing,
or terminating this permit or to determine. compliance with this permit. The
permittee shall also furnish to the Permit Issuing Authority upon r.e.quest,
copies of records required to be kept by this permit:.
SECTION B. OPERATION AND MAINTENANCE OF POLLUTION CONT'RQ�S
1. Proper Operation and Maintenance
The permittee shall. at all times maintain in good working order and operate
as efficiently as possible all treatment or control. facilities or systems
installed or used by the permittee to achieve compliance with the terms
and conditions of this permit.
2. Need to Halt or Reduce not a Defense
It shall not be a defense for a permittee in an enforcement action that it
woiil.d have been necessary to hall: or reduce. the permitted activity in
order to maintain compl.i.ance with the conciit:ion of this permit.
3. pap assing
Any diversion from or bypass of facilities is prohi.h:it.ed, except (i) where
unavoidable to prevent loss of life or severe property damage, or (ii)
where excessive storm drainage or runoff would damage any facilities
necessary for compliance with the effluent limitations and prohibitions of this
permit. All permittees who have such sewer bypasses or overflows of t1li.s
discharge shall submit, not .later than six months from the date of issuance
of this permit, detailed data or engineering est.i.mates Which identify:
a. The location of each sewer system bypass or o,,erf.low,
b. The frequency, duration and quantity of flow from each sewer system
bv,,ass or over:FloT;7.

4
5
0
Part II
Page 4 of 14
This requirement is waived where infiltration/inflow analyses are scheduled
to be performed as part of an Environmental Protection Agency f .cili.ties
planning project.
The permittee shall report by telephone to either the central office or
appropriate regional office of the Division as soon as possible, but in
no case more than 24 hours or on the next working day following the
occurrence or first knowledge of the occurrence of any division from or
bypass of facilities.
�ip—set s
"Upset" means an exceptional incident in which there is unintentional and
temporary noncompliance with technology based permit efflne71t limitations
because of factors beyond the .reasonable control of the permittee. An upset
does not include noncompliance to the extent caused by operational error,
improperly designed treatment facilities, inadequate treatment facilities,
lack of preventive maintenance, or careless or improper operation. An upset
constitutes an affirmative defense to an action brought for noncompliance
with such technology based permit limitation if the requirements, of 40 CFR S
122.41(n)(3) are met.
Removed Substances
Solids, sludges, filter backwash, or other pollutants removed i.n the course. of
treatment or control of wastewaters shall be disposed of in accordance with
NCGS 143-21.5.1 and in a manner such as to prevent any pollutant: from such
materials from entering waters of. the State or navigable waters of the United
States.
Power Failures
The permittee is responsible for maintaining adequate safeguards to prevent the
Cl:isehar&e Of ur:tr.eelt-ed or i.nr+degnately t:.r.eit:ed wastes d1iring electrical. power
.failures either by means of alternate power sources, standby generators or
retention of inadequately treated effluent.
SECTION C. MONITORING AND RECORDS
1. Representative Sampling
Samples collected and measurements taken, as required herein, shall be
characteristic of the volume and nature of the permitted discharge. Samples
collected at a frequency less than daily shall be taken on. a day and time that
is characteristic of the discharge over the entire period which the sample
represents. All samples shall be taken at the monitoring points specified in
this permit and, unless otherwise specified , before, the effluent joins or is
diluted by any other wastestream, body of water, or substance. Monitoring points
shall not be changed without notif_i,ati.ol., to and tile, approval of the Permit
Issuing Authority.

Part II
Page 5 of 14
2. Reporting
Monitoring results obtained during the previous month(s) shall be summarized for.
each month and reported on a monthly Discharge Monitoring Report (DMR) Form
(DEM No. MR 1, 1.1, 2, 3) or alternative forms approved by the Director, DEM,
postmarked no later than the 30th day following the completed reporting period.
The first DMR is due on the last clay of the month following the issuance_ of the.
permit or in the case of a new facility, on the last day of the month following
the commencement of discharge. Duplic.te signed copies of these, and all other
reports required herein, shall be submitted to the following address:
Division of Environmental Management
Water. Quality Section
ATTENTION: Central Files
Post Office Box 27687
Raleigh, North Carolina 27611
3 Flow Measurements
Appropriate flow measurement devices and methods consistent with accepted
scientific practices shall be selected and used to insure the accuracy and
reliability of measurements of the volume of monitored discharges. The
devices shall be installed, calibrated and maintained to insure that the
accuracy of the measurements are consistent with the accepted capability of
that type of device. Devices selected shall be capable of measuring flows
with a maximum deviation of less than + 10% from the true discharge rates
throughout the range of expected discharge volumes. Once -through condenser
cooling water .flow which is monitored by pump logs, or pump hour meters as
specified in Part I of this permit and based on the manufacturer's pump
curves shall not be subject to this requirement.
4. Test Procedures
Test procedures for the analysis of pollutaTits shall conform to the EMC
regulations published pursuant to NCGS 143-215.63 et seq, the Water and Air
Quality Reporting Acts, and to regulations published pursuant to Section 304(g),
33 USC 1314, of the Federal Water Pollution Control. Act, as Amended, and
Regulation 40 CFR 136.
5. Penalties for Tampering
The Clean Water Act provides that any person who falsifies, tampers with, or
knowingly renders inaccurate, any monitoring device or method required to be
maintained under this permit shall, upon conviction, by punished by a fine of
not more than $10,000 per violation, or by imprisonment for not more than
six months per violation, or by both.

Fart II
Page o of 14
6. Records Retention
All records and information resulting from the monitoring act.i.vi.ti.es required by
this permit including all records of analyses performed and calibration and
maintenance of instrumentation and recordings from continuous monitoring
instrumentation shall be retained for a minimum of three (3) years by the
permittee. Thisperiod of retention shall be extended during the course
of any unresolved litigation or if requested by the Division of Environmental.
Management or the Regional Administrator of the Environmental Protection Agency.
7. Recording Results
For each measurement or sample taken pursuant to the re(;ui.rements of this
permit, the permittee shall record the following in:farmati.oil
a. The exact place, date, and time of sampling;
b. The dates the analyses were performed;
C. The person(s) who performed the analyses; and
d. The resu.-Its of such analyses.
8. Right of Entry
The permittee shall. allow the Director of the Division of Environmental
Management, the Regional Administrator, and/or their authorized representatives,
upon the presentations of credentials:
a. To enter upon the permittee's premises where an effluent source is located
or in which any records are required to be kept under the terms and
conditions of this permit; arid
' be
b. At r4:i1:�0?7a}71.f. 1":_fl)es to i')=3:'f. iI�C.C�+^ It-0 and cOt"fyr"�I1C' r._CQ]:Ll:' :it'C(U1.'C'(`!i t".�%
kept under the terms and conditions of this permit.; to inspect any
monitoring equipment: or monitoring method rep{aired in this permit; and
to sample any discharge of pollutants.
SECTION D. REPORTING REQUIREMENTS
1. Change in Discharge
All discharges authorized herein shall- be consistent v.ith the terms and
conditions of this permit. The discharge of any pollutant :'identified in
this permit more frequently than or at a. level in excess of that authorized
shall constitute a violation of the permit. Any anticipated facility
expansions, production increases, or process modifi.cat.ions which will result

Part II
Pnge 7 of 14
in new, different, or increased discharges of pollutants must be reported by
submission of a new NPDES application or, if such changes will not violate
the effluent limitations specified in this permit, by notice to the DEM of
such changes. Following such notice, the permit may be modified to specify
and limit any pollutants not previously limited.
2. Anticipated Noncom li.ance
The permittee shall give notice to the Permit Issuing Authority of any planned
change in the permitted facility or activity which may .result in noncompliance.
with permit requirements. Any maintenance of facilities, which might
necessitate unavoidable interruption of operation and degradation of effluent
quality, shall be scheduled during noncritical water quality periods and carried
out in a manner approved by the Permit Issuing Authority.
3. Transfer of Ownership or Control
This permit is not transferable. In the event of any change in name, control
or ownership of facilities from which the authorized discharge emanates or is
contemplated, the permittee shall notify the prospective owner or controller by
letter of the existence of this permit and of the need to obtain. a permit in the
name of the prospective owner. A copy of the letter shall. be forwarded to the
Division of Environmental Management.
4. Additional Monitoring by Permittee
If the permittee monitors any pollutant at the location(s) designated herein
more frequently than required by this permit, using approved analytical methods
as specified above, the results of such monitoring shall be included in the
calculation and reporting of the values is required in the DMR. Such increased
frequency shall also be indicated. The DEM may require more frequent monitoring
or the monitoring of other pollutants not required in this permit by written.
notification.
5. Averaging _of_Measurements
Calculations for limitations which .require averaging of measurements shall
utilize an arithmetic mean unless otherwise specified by t:he Permit Issuing
Authority in the permit.
6. Noncompliance Notification
The permittee shall. report by telephone to either the central office or the
appropriate regional office of the Division as soon as possible, but in
no case more than 24 hours or on the next working day following the
occurrence or first knowledge of the occurrence of any of the following:

7.
Part IT
Page 8 of 14
a. Any occurrence at the water pollution control facility which results in
the discharge of significant amounts of wastes which are abnormal in
quantity or characteristic, such as the dumping of the contents of a
sludge digester; the known passage of a slug of hazardous substance
through the facility; or any other unusual circumstances.
b. Any process unit failure, due to known or unknown reasons, that render
the facility incapable of adequate wastewater treatment such as mechanical
or electrical failures of pumps, aerators, compressors, etc.
C. Any failure of a pumping station, sewer .line, or treatment facility
resulting in a by-pass directly to receiving waters without treatment
of all or any portion of the influent to such station or facility.
d. Any time that self -monitoring information indicates that the facility has
gone out of compliance with its NPDES permit limitations.
Persons reporting such occurrences by telephone shall also file a written
report in letter form within 15 days following first knowledge of the
occurrence.
Changes in Discharges of Toxic Substances:
The permittee shall notify the Permit Issuing Authority as soon as it knows or
has reason to believe:
a. That any activity has occurred or will occur wb ich would result in the
discharge, on a routine or frequent basis, of any toxic: substance(s) (listed
at 40 CFR S 122, Appendix D, Table II and III) which is not limited in the
permit, if that discharge will exceed the highest of the following
"notification levels".
(1) One hundred micrograms per liter (1.00 ug/1);
(2) Two hundred micrograms per liter (200 ug/1) for acrol.e.in and
ac.rylonitrile; five hundred micrograms per. liter (500 ug/1)
for 2,4-dinitrophenol and for 2-methyl-4,6-dinitr.oph.enol; and one
milligram per liter (1 mg/1) for antimony; or.
(3) Five (5) times the maximum concentration value reported for that
pollutant(s) in the permit application.
b. That any activity has occurred or will occur which would result in any
discharge, on a non -routine or infrequent basis, of a toxic pollutant
(listed at 40 CFR S 122, Appendix D. Table II and III) which is not
limited in the permit, if that discharge will exceed the highest of the
following "notification levels":

Part II
Page 9 of 14
(1) Five hundred micrograms per liter (500 ug/1);
(2) One milligram per liter (1 mg/1) for antimony; or
(3) Ten (10) times the maximum concentration value reported for that
pollutant(s) in the permit application.
8. Expiration of Permit
Permittee is not authorized to discharge after the expiration date. In order to
receive a»thoriznti.on to discharge beyond t.l.e expi.r.flti.ort date, the permittee
shall submit such information, forms, and fees as are required by the agency
authorized to issue permits no later. than 180 days prior to the expiration date.
Any discharge without a permit after the expiration will subject the permittee
to enforcement procedures as provided in NCGS 143-215.6 and 33 USC 1251. et seq.
9. Signatory R±quirements
All applications, reports, or information submitted to the Permit Issuing
Authority shall, be signed and certified.
a. All permit applications shall be signed as follows:
(1) For a corporation: by a responsible corporate officer. For the
purpose of this Section, a responsible corporate officer means:
(a) a president, secretary; treasurer or vice president of the
corporation in charge of a principal business function, or any
other person who performs similar policy or decision making
functions for the corporation, or (b) the manager of one or more
manufacturing production or operating facilities employing more
than 250 persons or having gross annual sales or expenditures
exceeding 25 million (in second quarter 1980 dollars), if authority
to sign documents has been assigned or delegated to the manager in
accordance with corporate procedures.
(2) For a partnership or sole proprietorship: by a general partner or
the proprietor, respectively; or
(3) For a municipality, State, Federal, or other public agency: by either
a principal executive officer or ranking elected official.
b. All reports required by the permit and other information requested by the
Permit Issuing Authority shall. be signed by a person described above or by
a duly authorized representative of that person. A person is a duly
authorized representative only if:
(1) The authorization is made in writing by a person described above;
(2) The authorization specified either an individual or a position having
responsibility for the overall operation of the regulated facility or
activity, such as the position of plant manager, operator of a well or

Part II
Page 10 of 14
well field, superintendent, a position of equivalent responsibility,
or an individual or position having overall responsibility for environ-
mental matters for the company. (A duly authorized representative
may thus be either a named individual or any individual occupying a
named position.); and
(3) The written authorization is submitted to the Permit Issuing Authority.
C. Certification. Any person signing a document under paragraphs a. or b. of
this section shall making the following certificat:i.ori:
"I certify, under penalty of law, that this document and all attachments
were prepared under my direction or supervision in accordance with a system
designed to assure that qualified personnel properly gather and evaluate the
information submitted. Based on my inquiry of the person or persons who
manage the system, or those persons directly responsible for gathering the
information, the information submitted is, to the hest of my knowledge and
believe, true, accurate, and complete. I am aware that there are
significant penalties for submitting false information, including the
possibility of fines and imprisonment for knowing violations."
10. Availability of Reports
Except for data determined to be confidential under NCGS .1.43-215.3(a) (2) or.
Section 308 of the Federal Act, 33 USC 1318, all reports prepared in accordance
with the terms shall be available for public inspection at the offices of the
Division of Environmental Management. As required by the Act, effluent data
shall not be considered confidential.. Knowingly making any false statement on
any such report may result in the imposition of criminal penalties as provided
for in NCGS 143-215.1(b) (2) or in Section 309 of the Federal Act.
11. Penalties for. Falsification of Reports
The Clean Water Act provides that any person who know:ir,R:l.} makes any false
statement. representation, or. ce.rtificatior in any record or other document
submitted or required to be maintained under this perm.t., including monitoring
reports or reports of compliance or noncompliance shall, upon conviction, be
punished by a fine of not more than Y10,O00 per violation. or by imprisonment
for not more than six months per violation, or by both.
SECTION E. DEFINITION
1. Permit Issuing Authority
The Director of the Division of Environmental Management.
2. DEM or Division
Means the Division of Environmental Management, Department of Natural
Resources and Community Development.

Part II
Page 11 of 14
3. EMC:
Used herein means the North Carolina Environmental Management Commission.
4. Act or "the Act"
The Federal Water Pollution Control Act, also known as thf,. Clean Water Act, as
amended, 33 USC 1251, et. seq.
5. Mass/Day Measurements
a. The "monthly average discharge: is defined as the total mass of all
daily discharges sampled and/or measured during a calendar month on
which daily discharges are sample and measured, divided by the number
of daily discharges samples and/or measured during such month. It is
therefore, an arithmetic mean found by adding the weights of the
pollutant found each day of the month and then dividing this sum by
the number of days the tests were reported. The .limitation is
identified as "Daily Average" or "Monthly Average" in Part I of the
permit.
b. The "weekly average discharge" is defined as.the total. mass of
all. daily discharges sampled and/or measured during the calendar week
(Sunday -Saturday) on. which daily discharges are sampled and measured,
divided by the number of daily discharges samples and/or measured
during such week. It is, therefore, an arithmetic mean found by
adding the we-' ghts of pollutants found each. day of the week and then
dividing this sum by the number of days the tests were reported. This
1i.mi.tat.:.i.on Is id.ent.:if.ied as Neekly Average" in part. "i of the permit.
C. The "mexi.mum daily discharge" is tha total mass (weight :) of a
pollutant discharged during a calendar clay. If only One sample is
taken during any calendar day the weight of pol.l.uta.>>t calculated from
it is the "maximum daily discharge." This limitation is .identified as
"Daily Maximum," in Part I of the permit.
d. The "average annual discharge" is defined as tile. total mass of all
daily discharges sample and/or measured during the calendar year on
which daily discharges are sampled and measured, divided by the number
of daily discharges sampled and/or measured during such year.. It is,
therefore, an arithmetic mean found by adding the weights of
pollutants found each day of the year and then dividing this sum by the
number of days the tests were reported. This limitation is defined as
"Annual Average" in. Part I of the permit.

Part II
Page 12 of 14
6. Concentration Measurement
a. The "average monthly concentration," other than for fecal coliform
bacteria, is the sum of the concentrations of all daily discharges
samples and/or measured during a calendar month on which daily discharges
are sampled and measured, divided by the number of daily discharges sampled
and/or measured during such month (arithmetic mean of ti.,e daily
concentration values). The daily concentration valve is equal to the
concentration of a composite sample or in the case of grab samples is the
arithmetic mean (weighted by flow value) of all the samples collected
during that calendar day. The average monthly count. for fecal coliform
bacteria is the geometric mean of the counts for samples collected during a
calendar month. This limitation is identified as "Monthly Average" or
"Daily Average" under "Other Limits" in Part I of the permit.
b. The "average weekly concentration," other than for fecal coliform bacteria,
is the sum of the concentrations of all daily discharges sampled and/or
measured during a calendar week (Sunday/Saturday) on which daily discharges
are sampled and measured divided by the number of da-ily discharges sampled
and/or weastired during such week (arithmetic mE�an of the daily
concentration values). The daily concentration value is equal to the
concentration of a composite sample or in the case of grab samples is the
arithmetic mean (weighted by flow value) of all the samples collected during
that calendar day. The average weekly count for fecal coliform bacteria is
the geometric mean of the counts for samples co1l.ected during a calendar
week. This limitation is identified as "Weekly Average" under "Other
Limits" in Part I of the permit.
C. The "maximum daily concentration" is the concentration of a pollutant
discharge during a calendar day. It is identified as "Daily Maximum"
under "Other Limits" ill Part T of the. riermit.
d. The 'average annual concentration," other than for f.ecnl coliform bacteria,
is the sum of the concentrations of all daily di.schar.gc.-s sampled and/or
measured during a calendar year on which daily discharges are sampled and
measured divided by the number of daily discharges sampled and/or measured.
during such year (arithmetic mean of the daily concentration values). The
daily concentration value is equal to the concentration of a composite
sample or in the case of grab samples is the ari.t.hmetic mean (weighted by
flow value) of all the samples collected during that calendar day. The
average yearly count for fecal coliform bacteria is the geometric mean
of the counts for samples collected during a calendar year.. This limitation
is identified as "Annual Average" under "Other. Limits" in Part I of the
permit.

7
W
E
Part JI
Page 13 of 1.4
Other Measurements
a. Flow, (MGD): The flow limit expressed in this permit is the 24 hours
average flow, averaged monthly. It is determined as the arithmetic mean
of the total daily flows recorded during the cal.endar month.
b. An "instantaneous flow measurement" is a measure of flow taken at the time
of sampling, when both the sample and flow will be representative of the
total discharge.
Types of Sam.F les
a. Composite Sample: These samples consist of grab samples collected at
equal intervals and combined proportional to flow, a sample continuously
collected proportionally to flow, or equal volumes taken at varying time
intervals. I£ a composite sample is obtained from grab samples, the
following requirements apply. The intervals between influent grab
samples shall be no greater than hourly. Intervals between effluent grab
samples shall be no greater than hourly except where the detention time
of the wastewater in the facility is greater than 24 hours, in which
case, the interval between grab samples shall be no greater in number of
hours than the detention time in number of days; provided, however, in
no case may the time between effluent grab samples be greater than six
hours nor the number of grab samples less than four during any discharge
period of 24 hours or less.
b. Grab Sample: Grab samples are individual samples collected over a
period of time not exceeding 15 minutes; the grab sample can be taken
manually.
Calculation of Means
a. Arithmetic Mean: The arithmetic mean of any set of values is the summation
of the individual values divided by the number of individual values.
b. Geometric Mean: The geometric mean of any set of values is the Nth root of
the product of the individual values where N is equal to the number of
individual values. The geometric mean is equivalent to the antilog of
the arithmetic mean of the logarithms of the individual values. For
purposes of calculating the geometric mean, values of zero (0) shall be
considered to be one (1).
C. Weighted by Flow Value: Weighted by flow value means the summation of each
concentration times its respective flow divided by the summation of the
respective flows.

Part II
Page 14 of 14
10. Calendar Day
A calendar day is defined as the period from midnight of one day until midnight
of the next day. However, for purposes of this permit, any consecutive 24-hour
period that reasonably represents the calendar day may bee used -for sampling.
11. Hazardous Substance
A hazardous substance means any substance designated under 40 CFR Part 116
pursuant to Section 311 of the Clean Water Act.
12. Toxic Pollutant
A toxic pollutant is any pollutant listed as.toxic under- Section 307(a)(1) of
the Clean Water Act.

PART III
OTHER REQUIREMENTS
A. Previous Permits
All previous State water quality permits issued to this facility, whether for
construction or operation or discharge, are hereby revoked by issuance of this
permit. The conditions, requirements, terms, and provisions of this permit
authorizing discharge under the National Pollutant Discharge Elimination
System govern discharges from this facility.
B. Construction
No constcuc_tion of wastewater treatment facilities or additions thereto shall
be begun until Final Plans and Specifications have beensubmitted to the
Division of Environmental Management and written approval and Authorization
to Construct has been issued.
C. Certified Operator
Pursuant to Chapter 90A of North Carolina. General Statutes, the permittee shall
employ a certified wastewater treatment plant operator in responsible charge
of the wastewater treatment facilities. Such operator must- hold a certification
of the grade equivalent to or greater than the class-ification assigned to the
wastewater treatment facilities.
D. 'Groundwater Monitoring
The permittee shall, upon written notice from the Director of the Division of
Environmental Management, conduct grol.indwater monitoring as may be required
to determine the compliance of this NPDES permitted facility with the current
groundwater standards.
E. Limitations Reopener
This permit shall be modified or alternatively, revoked and reissued, to comply
with any applicable effluent guideline, or wat:er quality standard .issued or
approved w.uler Sections 302(b) (2) (c), and. (d.), 304.(b) (2), and 307(a) (2)
of the Clean Water Act, if the effluent guideline or water quality standard
so issued or approved:
1. contains different conditions or is otherwise more, stringent than any
effluent limitation in the permit; or
2. controls any pollutant not limited in the permit.
The permit as modified or reissued under this paragraph shall also contain any
other requirements in the Act then applicable.

Part III
Continued
F. Toxicity Reopener
This permit shall be modified, or revoked and reissued to incorporate toxicity
limitations and monitoring requirements in -the event toxicity testing or other
studies conducted on the effluent or receiving stream indicate that detrimental
effects may be expected in the receiving stream as a result of this discharge.

1% C. DEPT. OF NATUAM
RESOURCES AND
COMMUNITY DEVELOPM NT
AUG , 0 1999
IQ U.E HROW GW4
August 19, 1992
STEPHEN P. ZELNAK,JR
MARTIN MARIETTA-KINGS MOUNTAI
P 0 BOX 30013
RALEIGH, NC 27622
Subject: NPDES PERMIT NO. NC0005444
CLEVELAND COUNTY
Dear Permittee:
The subject permit issued on 5/16/88 expires on 5/31/93. North Carolina
General Statute (NCGS) 143-215.1(c) requires that an application for permit renewal
be filed at least 180 days prior to the expiration date. As of the date of this
letter, the Division of Environmental Management had not received an application for
renewal.
If operation of a discharge or waste treatment facility is to occur after the
permit's expiration date, or if continuation of the permit is desired, it must not be
allowed to expire. A renewal request must be submitted no later than 180 days prior
to the permit's expiration date. Operation of the waste treatment works or
continuation of a discharge after the expiration date would constitute a violation of
NCGS 143-215.1 and could result in assessment of civil penalties of up to $10,000 per
day. If continuation of the permit is desired, failure to request renewal at least
180 days prior to expiration will result in a civil assessment of at least $250.00;
larger penalties may be assessed depending upon the delinquency of the request.
A renewal application shall consist of a letter requesting permit renewal along
with the appropriate completed and signed application form (copy attached), submitted
in triplicate, referenced in Title 15 of the North Carolina Administrative Code (15
NCAC) Subchapter 2H .0105(a). Primary industries listed in Appendix A of Title 40 of
the Code of Federal Regulations, Part 122 shall also submit a priority pollutant
analysis in accordance with Part 122.21. A processing fee must be submitted with the
application. In addition to penalties referenced above, a permit renewal request
received after the expiration date will be considered as a new application and will
require the higher application fee.

ed is a copy of the fee schedule from 15 NCAC 2B.0105(b). The application
processing fee is based on the design or permitted flow, whichever is appropriate,
listed in the first five categories of facilities. Presently, no facility is allowed
to submit a fee for the general permits listed in the schedule since the Environmental
Protection Agency has not approved the State of North Carolina's general permit. If
the facility covered by this permit contains some type of treatment works, a narrative
description of the sludge management plan must be submitted with the application for
renewal.
The Environmental Management Commission adopted revised rules on October 1, 1990
(attached), requiring the payment of an annual fee for most permitted facilities. You
will be billed separately for that fee (if applicable), after your permit is approved.
The letter requesting renewal, the completed Permit application, and appropriate
fee should be sent to:
Permits and Engineering Unit
Division of Environmental Management
Post Office Box 29535
Raleigh, North Carolina 27626-0535
The check should be made payable to the North Carolina Department of Environment,
Health, and Natural Resources which may be abbreviated as DEHNR.
If there are questions or a need for additional information regarding the permit
renewal procedure, please contact me at telephone number [phone].
Sincerely,
Original Signed By
C®leen H. Sullins
Coleen Sullins, P.E.
Supervisor, NPDES Permits Group
cc: Mooresville Regional Office
Permits and Engineering Unit
Central Files

D ate -� -�
NPDES STAFF REPORT AND RECOMMENDATIONS
County Cleveland
NPDES Permit No. 70005+r4+�-
PART I - GENERAL INFOR14ATION
1 o Facility and Address- Martin Marietta Aggregates
Kings Mountain Quarry
Mr. Stephen P. Zelnak, Jr.
Post Office Box 30013
Raleigh, North Carolina 27622-0013
2. Date of Investigation: February 2, 1988
3. Report ;Prepared By: James R. Reid
4. Persons Contacted and Telephone Number: David Leftwich
704/739-4763
5.
Directions to Site: From the intersection
of U.S. Highway 74 and N.C.
Highway 161 in Kings Mountain, travel south on
Highway 161 approximately
0.9 mile to an access road which parallels I-85
South. Turn right onto the
access road and travel approximately one mile
to Martin Marietta Corporation.
�6.
Discharge Point - Latitude: 350 13'
08"
Longitude: 81' 21'
00"
t
Attach a USGS Map Extract and indicate
discharge
treatment plant site and
point on map.
USGS Quad Noor USGS
Quad Name Kings Mountain
:7.
Size (land available for expansion and
upgrading):
Several acres.
8.
Topography (relationship to flood plain
included):
System is in a valley in the flood plain.
9.
Location of nearest dwelling: Approximately 1,000 feet.
10. Receiving stream or affected surface waters: Kings Creek
a. Classification: C
b. River Basin and Subbasin No BRD 03 08 05
C. Describe receiving stream features and pertinent downstream
uses : Stream is heavily silted and is used for industri%1 and agricultural
purposes.

PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
1. Type of wastewater: _ _ % Domestic
100 % Industrial
a. Volume of Wastewater: MGD
b. Tykes amd quantities of industrial wastewater:
Volume unknown - discharge volume is composed of mine dewatering
wastewater and storm water.
C. Prevalent toxic constituents in wastewater:
None
d. Pretreatment Program (POTWs only)
in development _ approved _
should be required _ not needed
2. Production rates (industrial discharges only) in pounds
a. highest month in the last 12 months
b. highest year in last 5 years
3. Description of industrial process (for industries only) and
applicable CFR Part and Subpart:
4. Type of treatment (.specify whether proposed or existing):
Existing. Recirculating inorganic solids settling basins.
5. Sludge handling and disposal scheme:
Settled solids are dredged as needed and placed on site so that no
contamination of surface waters occurs.
6. Treatment plant classification:
7. SIC Code (s) 1423
Wastewater Code(s) 42 U

PART III - OTHER PERTINENT INFORMATION
1. Is this facility -being constructed with Construction Grants Funds
(municipals only)?
2. Special monitoring requests:
3. Additional effluent limits requests:
4. Other:
PART IV - EVALUATION AND RECOMMENDATIONS
Renewal Iof NPDES Permit No. NC0005444 is recommended.
ture of rex`or. pr4pare
eery Qua ityRe_gio L Super_v or
0

B P14 1a Cen;r ! a'
.._• / I .' _� - ���� _ \\� f � +:_Jt__�y ✓i'_-•!_.-. JC, _ t.RIDGE - G�_ -__
845 11em •- •J :-3, - t��� 1 ''l '! I
6hF Hosv'Lal
Lib dry 353
�i.y - --- �.WT Ft trap ton if
. rF
L j. S: g IL i• MO aln�.�PI3
BMr:m mory - —� —1 :BM i --
j! : ,ter ^�J g• �— hxL\GS jMO I�TAIN �!.97sJ P 9 + Rest \ I,
p ^ ,. Fat Side
�.: - D C p ;•' ! / ` �'` Ch �� 1 i,Ivs—�S-� : / I t _ �\ %-
��°v� 4Chif
lcnA
NN
7
co, - -Rio: 3� � / j �i� r 11
asgE �' � �j �r� �' "`�:��•, - =j`=- � ��,-{_�_,� �1 1'1�b `fit ` / 1,"- � � � ' '-� ' d",i'p/� `y- �'
S10000 FEET! 1i !,i �'�\ ��(i `%✓v=%' .�✓:�` sGzlg �'� ��` L<\ •:x/r'; rr���:% ^` lifa flz(S. C.)� 1 t /�f `� 1� \ • /•/l / �`� r �.\ l' /i�`^1 ' �.1\ '\\`\�-'^' ,jam,/ I 1i` t :�/,
I l � l,i 1 _f'•• •/'can 1` ,�. sI� €,, � J �. I ..,� I (�\ - / ti /�ndvStr� e _-- —. _
Nine / '\ /� Ponds
c I `,:: , a ( •; � • d' + fir' i . ? ' // F � •• -
��'���
1
FOO
.77 le
.Sandpit 0.\
Ir.� � st „'7`RoadS�de _ �`r` � �� -- � `JI `_ _ — '•-�'- �/�
CL
i� n / "Z 1, '\`. \ ` � vs1 "� a3s ��1 -�• \`< � t'•. \ I r ��\ 1
I `,�` r \ ����lrr'�caill��l'(� �_._ ���. �\\`>•\.^�\ i'\ri\�� %'.;,.

lip� 4 r C E i E D
Meer Quality Section
_.- Application
Engineering
Request for
Application
Other
���.,,,. FFB q - 1988
Asheville Regional Office
'e of North Carolina Asheville, North Carolina
Zesources and Community Development
of Environmental Management
v Street • Raleigh, North Carolina 27611
R. Paul Wilms
Director
Subject: NPDES Permit Application
NPDES Permit No. NCO 0,
-1 6rira w'!
- r
County
i
1
t of the following documents on
Form,
Proposal (for proposed control facilities),
permit renewal,
Processing Fee of $ �'f, yr:+
The items checked below are needed before review can begin:
Application form _ (Copy enclosed),
Engineering Proposal 7See Attachment),
Application Processing Fee of $ ,
Other
If the application is not made complete within thirty 30 days, it will
be returned to you and may be resubmitted when complete.
This application has been assigned to J oi" {'{;'�',,
(919/733-5083) of our Permits Unit for review. You will be advised of
any comments recommendations, questions or other information necessary
for the review of the application.
I am, by copy of this letter, requesting that our Regional Office
Supervisor prepare a staff report and recommendations regarding this
discharge. If you have any questions regarding this application, please
contact the review person listed above.
Sincerely,
Arthur Mouberry, P.E.
Supervisor, Permits and Engineering
c c :
Pollution Prevention Pays
P.O. Box 27687, Raleigh, North Carolina 27611-7687 Telephone [phone]
An Equal Opportunity Affirmative Action Employer

.J
j622-00`3
0pX �P,N G18o�g55 2
P�YG 1 �91g1
NEN p • ZE�N
SPP� �OEN�
GGRP-,
P
)?'to ad tageme�
t a '
To
Do not
1. Name, ak
A. K
B. Ma
C. Lom
2.
4.
D. Telephone
2. SIC
eeCir��mertae M oil
mats
and tir of tirJg1 6$� 6$1' eC`evl a d Co Jrty °� erg Crf °� emfl
2� 6 ,na Z et p5�� J eear fo>> e4Jl 0�
ICJ e go* Gat oe 4 e<tn G00 Gee tre �Ct t C e5
e' s Off' NoCtr Jest �Q�Ct QJaCCy �Ctr Qe�ec� f° I
Waee>Np��SM° JntaL� � e a<e sJ coC dan 414 . Q,lcat�°n � 't z
SJblect�Cr�s d�emert, $, lr Lk
���GOoCR` G aQ °JC Q't oQ
ac�ro�ee re 30 III4eCms 3 sr°Ct
Jt �J O d 1 MQ
Gerteemer. rce %I y°, e eXp�te Ceres aerceose Jrdat' QJ
lr accoCda QeCMQ CeGJerG osed� P teC and gC° ,rceCel`1
,ire 'P Jed i1 ere�ae �s is Calroa 5 /
�e e-14 t AL C CeQCeser ev"
GpJ ,5 d1sGraC �e SteJ e
jr
(Leave blank)
3; Number of employees
If all your waste is dischal,
and to the best of your know
permit, proceed to item 4. Ot
4. If -you meet the condition sk
asked for below. After complk,
and signature blocks below an,,
without completing the remaino
A. Name of organization re,
B. Facility receiving waste.
1. Name
2. Street address
3. City
5. State
5_ ;Principal product, ❑ raw material (C
',. Principal process Crushing_ Co
7. Maximum amount of principal product prod`
A. Day
N. Month
C. Year
Basis I 1-99 I 100-199
a
1000-
5000-
10,000-
50,000
4999
9999
49,999
or more
(I,)
(6)
(7)
(H)
-PREVIOUS EDITION MAY -9E USED UNTIL SUPPLY IS EX"AUSTED
i

L_
`

•
I
I
FACILITY
COUNTY I—e vr-- f-,t� CLASS
MAILING ADDRESS 366 1-5
C-,k,yl C, 14W(- Z7&-zz-�ZJ3
V
Responsible
Facility Operator
Official -Representative
Telephone-' No.
H-o Af4 cr pq :))RV Z_1
Where Located, t N/v Al, o n,\CN rA L L (V
lid
q,j '78 1- /4 SSZ)
Cert. Number
Class
NPDES Permit No. NC bo 5444 Other Permit No.
State 0 Federal Date Issued
-
Date Issued 7b
6
Expiration Date'
Stream: Name,
Class
7Q10
Sub -basin

„ Ju1y i, 198RECEIVED
h WaterQuality Division
JUL 7 ,1983
Mr. Horace 5. Wi1lson
Martin Marietta Western Regional Office]
P. 0: fox 3JI313 ®shsville, North Carolina
Ral ei gh, North. Carol i na .27622
SUBJECT: Permit No. NCO005444
Merti n Marietta Kings Mountain
Cleveland -County
Dear Mr. Willson:
In accordance with,your application for discharge. Perfiit received Dece*er 3, , .
1982, we are forwarding here�ri.th t2ie subject State-NPDES Permit, ibis permit is
issued pursuant to the requirements, of forth Carolina General Statutes 1.43-215.1
and 'the Memorandum of Agreement between North Carolina and the U. ' S: Environmental
Protection A ency dated October 19,1975.
If any parts, requirements, 'or 1imitatiohs contained in .this Permit are
unacceptable to you, you have the right to an” adjudicatory hearing before -a
hearing officer upon' written -demand to the Director within 30 clays foll,,wing.
receipt of this Permit, identifying the specific issues to be .conte'nded. Unless,
such demand is made, this Permi b .shal 1 be Final and." bi rldi ng:
Please- take notice that this, Perrnit.. is not transferable. � 'Part 11, 8,:2.
addresses the requirements to be followed in case of change in minership or
control of: this discharge.
iris Permit does not affect th6_ legal requirement to obtain other Permits
whici� may be required .by the division. of Environmental Management. ' If you have
any juesstions concerning this Permit, Please contact Mr: �3.6r►id T. Aclkins,
telephone [phone].
Sincerely yours,
Original Signed By
W. LEE FLEMING, JR.; for
Robert F. Helms
cc: Mr, Jim Patrick, EPA
Asheville'legional Manager

_ ?ermit No. -NC 0005444
STATE OF NORTH CAROLINA
DEPARTMENT OF NATURAL RESOURCES & COMMUNITY DEVELOPMENT.,
DIVISION OF ENVIRONMENTAL MANAGEMENT-'.'
P E R M I T
To Discharge Wastewater Under the NATIONAL
POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provisions of North Carolina General Statute 143-215.1,
other lawful standards and regulations promulgated and adopted by the North Carolina
Environmental Management Commission, and the Federal Water Pollution Control Act, as
amended,
Martin -Marietta Aggregates
is"hereby authorized to discharge wastewater from a facility located at
Kings Mountain Quarry
Cleveland County
to receiving waters designated an unnamed tributary to Kings Creek in the Broad River
Basin
in accordance with effluent limitations, monitoring requirements, and other
conditions set forth in Parts I, II, and III hereof.
This permit shall become effective JUL 0 1 1983
This permit and the authorization to discharge shall expire at midnight
on JUN-30 1988..
Signed this day of jUL 0 1 1583
Original Signed By,
W. LEE FLEMING, JR., for
Robert F. Helms, Director
Division of Environmental Management
By Authority of the Environmental
Management Commission
M1 & I1

Permit No. NC0005444
SUPPLEMENT TO PERMIT COVER SHEET
Martin -Marietta Aggregates
is hereby authorized to:
1. Continue to operate mine dewatering facilities and a closed
system recycle system for the process water located at the
Kings Mountain Quarry (See Part III of this Permit), and
2. Discharge from said works into an unnamed tributary to
Kings Creek which is classified Class "C" waters.

A. (1). EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS -Final
During the period beginning on the effective date and lasting until expiration, the
permittee is authorized to discharge from outfall(s) serial number(s). 001.
Such discharges shall be limited and monitored by the permittee as specified below:
.ffluent Characteristics Discharge Limitations Monitoring Requirements
Kg/day (lbs/day) Other Units (Specify) Measurement Sample '` Sample
Daily Avg. Daily Max. Daily Avg. Daily Max. Frequency Type Location
Flow
Settleable Matter
Total Suspended Residue
Turbidity
0.1 ml/l
The turbidity in the receiving water due
to the discharge shall not exceed 50 NTU.
*E=Effluent, D=Downstream
0.2 ml/l
Quarterly
Quarterly
Quarterly
Quarterly
Instantaneous E
The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units
and Shall be monitored quarterly by grab sample at E and D.
There shall be no discharge of floating solids or visible foam in other than trace amounts.
Grab E
Grab E
Grab E,D

Part I
Permit No. NC
B. SCHEDULE OF COMPLIANCE
1. The permittee shall achieve compliance with the effluent limitations
specified for discharges in accordance with the following schedule:
NOT APPLICABLE
2. No later than 14 calendar ayeitteeishalldate submiteeitherdaireportthe aofve
schedule of compliance, theprmby
progress or, in the case of specific
actions
noncomplianceuirIn thel �atter1ed
dates, a written notice of complianceor
case, the notice shall includethe
cause
meetingothemnextnscheduce, any lederequarement.
actions taken, and the probability of
M4&I4

PART I
Permit No. NC
Act used herein means the Federal Water Pollution Control Act, As amended.
DEM used herein means the Division of Environmental Management of the
Department of Natural Resources and 'Community Development
"EMC" used herein means the North Carolina Environmental Management
Commission.
C. MONITORING AND REPORTING
1. Representative Sampling
Samples and measurements taken as required herein shall be representative
of the volume and nature of the monitored discharge.
2. Reporting
Monitoring results obtained during the previous month(s) shall be
summarized for each month and reported on a Monthly Monitoring Report
Form (DEM No. MR 1.011 1.1, and 1.4) postmarked no .later than the 45th
day following the completed reporting period. The first report is due on
. The DEM may require reporting of additional monitoring
results by written notification. Signed copies of these, and all other
reports required herein, shall be submitted to the following address:
Division of Environmental Management
Water Quality Section
Post Office Box 27687
Raleigh, North Carolina 27611
3. Definitions
a. The "daily average" discharge means the total discharge by weight
during a calendar month divided by the number of days in the month
that the production or commercial facility was operating. Where less
than daily sampling is required by this permit, the daily average
discharge shall be determined by the summation of all the measured
daily discharges by weight divided by the number of days sampled
during the calendar month when the measurements were made.
b. The "daily maximum" discharge means the total discharge by weight
during any calendar day.
4. Test Procedures
Test procedures for the analysis of pollutants shall conform to The EMC
regulations published pursuant to N. C'. G. S. 143-215.63 et seq.. The
Water and Air Quality Reporting Act, Section 304(g), 13 USC 1314, of the.
Federal Water Pollution Control Act, As Amended, and Regulation 40 CFR 136.
5. Recording Results
For each measurement or sample taken pursuant to the requirements of
this permit, the permittee shall record the following information:
15

Permit No. NC
a. The exact place, date, and time of sampling;
b. The dates the analyses were performed;
c. The person(s) who performed the analyses;
d. The analytical techniques or methods used; and
e. The results of all required analyses.
6. Additional Monitoring by Permittee
If the permittee monitors any pollutant at the location(s) designated
herein more frequently than required by this permit, using approved
analytical methods as specified above, the results of such monitoring
shall be included in the calculation and reporting of the values required
in the Monthly Monitoring Report Form (DEM MR 1.0, 1.1, 1.4)
Such increased monitoring frequency shall also be indicated. The DEM
may require more frequent monitoring or the monitoring of other pollu-
tants not required in this permit by written notification.
7. Records Retention
All records and information resulting from the monitoring activities
required by this permit including all records of analyses performed and
calibration and maintenance of instrumentation and recordings from
continuous monitoring instrumentation shall be retained by the permittee
for a minimum of three (3) years, or longer if requested by the State
Division of Environmental .Management or the Regional Administrator of
the Environmental Protection Agency.
16

PART II
Permit No. NC
A. MANAGEMENT REQUIREMENTS
1. Change in Discharge
All discharges authorized herein shall be consistent with the terms and
conditions of this permit. The discharge of any pollutant identified
in this permit more frequently than or at a level in excess of that
authorized shall constitute a violation of the permit. Any anticipated
facility expansions, production increases, or process modifications which
will result in new, different, or increased discharges of pollutants must
be reported by submission of a new NPDES application or, if such changes
will not violate the effluent limitations specified in this permit, by
notice to the DEM of such changes. Following such notice, the permit
may be modified to specify and limit any pollutants not previously limited.
2. Non compliance Notification
If, for any reason, the permittee does not comply with or will be unable
to comply with any effluent limitation specified in this permit, the per-
mittee shall provide the Division of Environmental Management with the
following information, in writing, within five (5) days of becoming aware
of such condition:
a. A description of the discharge and cause of noncompliance; and
b. The period of noncompliance, including exact dates and times; or,
if not corrected; the anticipated time the noncompliance is expected
to continue, and steps being taken to reduce, eliminate and prevent
recurrence of the noncomplying discharge.
3. Facilities Operation
The permittee shall at all times maintain in good working order and
operate as efficiently as possible all treatment or control facilities
or systems installed or used by the permittee to achieve compliance with
the terms and conditions of this permit.
4. Adverse Impact
The permittee shall take all reasonable steps to minimize any adverse
impact to navigable waters resulting from noncompliance with.any effluent
limitations specified in this permit, including such accelerated or
additional monitoring as necessary to determine the nature and impact of
the noncomplying discharge.
5. Bypassing
Any diversion from or bypass of facilities necessary to maintain compliance
with the terms and conditions of this permit is prohibited, except (i) where
M8&I7

PART II
Permit No. NC
unavoidable to prevent loss of.life or severe property damage, or
(ii) where excessive storm drainage or runoff would damage any
facilities necessary for compliance with the effluent limitations
and prohibitions of this permit. The permittee shall promptly
notify the Water Quality Section of DEM in writing of each such
diversion or bypass.
6. Removed Substances
Solids, sludges, filter backwash, or other pollutants removed in the
course of treatment or control of wastewaters shall be disposed of in
a manner such as to prevent any pollutant from such materials from
entering waters of the State or navigable waters of the.United States.
7. Power Failures
In order to maintain compliance with the effluent limitations and
prohibitions of this permit, the permittee shall either:
a. In accordance with the Schedule of Compliance contained in Part I,
provide an alternative power source.sufficient to operate the waste-
water control facilities;
or, if such alternative power source is not in existence, and no date for
its implementation appears in Part I,
b. Halt, reduce or otherwise control production and/or all discharges
from wastewater control facilities upon the reduction, loss, or
failure of the primary source of power to said wastewater control
facilities.
8. Onshore or Offshore Construction
This permit does not authorize or approve the construction of any.onshore
or offshore physical structures or facilities or the undertaking of any
work in any navigable waters.
HE

PART II
Permit No. NC
B. RESPONSIBILITIES
1. Right of Entry
The permittee shall allow the Director of the Division of Environmental
Management, the Regioral Administrator, and/or their authorized represen-
tatives, upon the presentations of credentials:
a. The enter upon the permittee's premises where an effluent source is
located or in which any records are required to be kept under the
terms and conditions of this permit; and
b. At reasonable times to have access to and copy any records required
to be kept under the terms and -conditions of this permit; to inspect
any monitoring equipment or monitoring method required in this permit;
and to sample any discharge of pollutants.
2. Transfer of Ownership or Control
This permit is not transferable. In the event of any change in control
or ownership of facilities from which the -authorized discharge emanates
or is conteTol-ated, the permittee shall notify the prospective owner or
controller by letter of vhe existence of this permit and of the need to
obtain a permit"ir the name of the prospective owner. A copy of the
letter shall. be,frrwarded to the Division of Environmental Management.
3. Availability of Reperts
Except- for data determined to be confidential under N. C. G. S. 143-215.
3(a)(2) or Section 308 of the Federal Act, 33 USC 1318, all reports prepared
in accordance with the terms shall be available for public inspection at the
offices of the Division of Environmental Management. As required by the Act,
effluent data shall not be considered confidential. Knowingly making any
false 'statement on any such report may result in the imposition of criminal
penalties as provided for in N. C. G. S. 143-215.6(b)(2) or in Section
309 of the Federal Act.
4. Permit Modification
After notice and opportunity -`or a hearing pursuant to N. C. G. S. 143-
215.1(b)(2) and a.. S. 143-215.1(e) respectively, this permit may be
modified, suspender;, or revoked in whole or in part during its term for
cause including, but not limited to, the following:
a. 'violation of any terns or conditions of this permit;
b. Obtainirg this permit by misrepresentation or failure to disclose
fully 0, i relevant facts; or
c. A change in any condition that requires either a temporary or
permanent reduction or elimination of the authorized discharge.
M10&I9

PART II
Permit No. NC
5. Toxic Pollutants
Notwithstanding Part II, B-4 above, if a toxic effluent standard or
prohibition (including any schedule of compliance specified in such
effluent standard or prohibition) is established under Section 307(a)
of the Act for a toxic pollutant which is present in the discharge and
such standard or prohibition is more stringent than any limitation for
such pollutant in this permit, this permit shall be revised or modified
in accordance with the toxic effluent standard or prohibition and the
permittee so notified.
6. Civil, and Criminal Liability
Except as provided in permit conditions'on "Bypassing" (Part II, A-5)
and "Power Failures" (Part II, A-7), nothing in this permit shall be
construed to relieve the permittee from civil or criminal penalties for
noncompliance pursuant to N. C. G. S. 143-215.6 or Section 309 of the
Federal Act, 33 USC 1319.
7. Oil and Hazardous Substance Liability
Nothing in this permit shall be construed to preclude the institution
of any legal action or relieve the permittee from any responsibilities,
liabilities, or penalties to which the permittee is or may be subject
under N. C. G. S. 143-215.75 et seq. or Section 311 of the Federal Act,
33 USC 1321.
8. Property Rights
The issuance of this permit does not convey any property rights in either
real or personal property, or any exclusive privileges, nor does it
authorize any injury to private property or any invasion of personal
rights, nor any infringement of Federal,State or local laws or regulations.
9. Severability
The provisions of this permit are severable, and if any provision of this
permit, or the application of any provision of this permit to any circum-
stance, is held invalid, the application of such provision to other cir-
cumstances, and the reminder of this permit shall not be affected thereby.
M11 &I10

PART II
Permit No NC
10. Expiration of Permit
Permittee is not authorized to discharge after the expiration date.
In order to receive authorization to discharge beyond the expiration
date, the permittee shall submit such information, forms, and fees as
are required by the agency authorized to issue permits no later than 180
days prior to the expiration date. Any discharge without a permit after
the expiration will subject the permittee to enforcement procedures as
provided in N. C. G. S. 143-215.6 and 33 USC 1251 et seq..
I 11

• - PART III
Permit No. NC
B. Previous Permits
All previous State water quality permits issued to this facility,
whether for construction or operation or discharge, are hereby revoked
by issuance of this permit. The conditions, requirements, terms, and
provisions of this permit authorizing discharge under the National
Pollutant Discharge Elimination System governs discharges from this
facility.
C. Construction'
No construction of wastewater treatment facilities or additions thereto
shall be begun until Final Plans and Specifications have been submitted
to the Division of Environmental Management and written approval and
Authorization to Construct has been issued. If no objections to Final
Plans and Specifications has been.made by the DEM after 30 days following
receipt.of the plans or.issuance of this permit, whichever is latter, the
plans may be considered approved and construction authorized.
D. Certified Operator
Pursuant to Chapter 90A of North Carolina General Statutes, the permittee
Shall employ a.cer.tified wastewater treatment plant operator in responsible
Charge of the wastewater treatment facilities. Such operator must hold a
Certification of the grade equivalent to the classification assigned to
the wastewater treatment facilities.
M15&.I12

-
L
''�
C
`.
-
�

Permit No. NC0005444
STATE OF NORTH CAROLINA
DEPARTMENT OF NATURAL RESOURCES & COMMUNITY DEVELOPMENT
DIVISION OF ENVIRONMENTAL MANAGEMENT
P E R M I T
To Discharge Wastewater Under the NATIONAL
POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provisions of North Carolina General
Statute 143-215.1, other lawful standards and regulations
promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control
Act, ' as amended,
Martin Marietta Aggregates
is hereby authorized to discharge wastewater from a facility
located at
Kings Moutain Quarry
Cleveland County
to receiving waters designated as an unnamed tributary to Kings
Creek in the Broad River Basin
in accordance with effluent limitations, monitoring requirements,
and other conditions set forth in Parts I, II, and III hereof.
This permit shall become effective
This permit and the authorization to discharge shall expire
at midnight on
�x
Signed this day of
R. Paul Wilms, Director
Division of -Environmental Management
By Authority of the Environmental
Management Commission

Page 2 of 2
Permit No. NC0005444
SUPPLEMENT TO PERMIT COVER SHEET'
Martin Marietta.Aggregates
is hereby authorized to:
1. Continue to operate mine dewatering facilities and
a closed system recycle system for the process water
located at the Kings Mountain Quarry
(See Part III of this Permit), and
2. Discharge from said works into an unnamed tributary
to Kings Creek which is classified Class "C" waters in
the Broad River Basin.

A. (1). EFFLUENT LIMITATIONS AND MONITORING REQUIREZM=S
During the period beginning on the effective date of the permit and lasting until expiration, the permitt,
authorized to discharge from outfall(s) serial number(s) 001. Such discharges shall be limited and monitc
by the permittee as specified below:
Effluent Characteristics Dischar e Limitati
g ons
Kg/day (lbs/day) Other Units (Specify)
Monitoring Requirements
Measurement S*Saple
Daily Avg. Daily Max. Daily Avg. Daily Max.
Frequency cY
Location
Flaw
Monthly
Instantaneous
E
Settleable Solids 0.1 ml/l 0.2 ml/l,
Monthly
Grab.
E
Turbidity 50 NTU
Monthly
Grab
E
*Sample location: E - Effluent
BMP Conditions
1. The permittee shall operate the facilities in a manner which will minimize the impact on the
receiving waters.
2. The permittee shall utilize sound management practices to ensure that contaminates do not enter
the surface waters as a result of blasting at this site.
le pH shall not be less than 6.0 standard units nor greater than 9.0 standard units and shall be monitored
>nthly at the effluent by grab samples.
sere shall be no discharge of floating solids or visible foam in other than trace amounts.
NC0005444

rmit No. NC0005444
STAFF REPORT AND RECOMMENDATIONS
Date: January 25, 1983
PART I - INSPECTION OF WASTEWATER TREATMENT PLANT SITE -
1. Facility: Martin Marietta Corporation
Cleveland County, North Carolina
2.. Inspected by: Jim Reid, Kerry Becker
3. Persons contacted: Jay Powell, Manager
4. Directions to site: From the intersection of U.S. Highway 74 and N.C.
Highway 161 in Kings Mountain, travel south on Highway 161 approxi-
mately 0.9 miles to an access road which parallels I-85. Turn right
onto the access road and travel approximately one mile to the Martin
Marietta Corporation.
5. Latitude: 350 13' 20" Longitude: 810 20' 45"
PART II - WASTEWATER TREATMENT WORKS -
1. Description of waste treatment facility: The system consists of an
inorganic solids settling basin, a sand pump to transfer the waste-
water to the basin, a make up water pump withdrawing from an aban-
doned mine pit, a water supply pond, and ditching to carry storm -
water to the water supply pond.
2. Final disposition of sludge:
Solids are stored in the settling basin and not removed.
PART III - EVALUATION AND RECOMMENDATIONS:
The system appeared to be operating well. The number one settling
basin had filled with solids; the number two basin which was constructed
in 1972 was functioning adequately. The Regional Office Recommendation is
that NPDES Permit No. NC0005444 be renewed.
Prepared byf:JJ,,�ames R. Rei d

North Carolina Department of Natural
Resources &Community[19- velopment
James B. Hunt, Jr., Governor JosQ h W. Grimsley, Secretary
DIVISION OF ENVIRWIENTAL MANAGEMENT Water Quality Div► ►
ENon
33ecembar 6, 1952
Xr. Horace S Willson
Nartisg--Naarietta Aggregatea
PO Box 30013
Ptaleigh, 11C 2762?_-0013
Dear - Mr. _Willman
OEC 8 I9BZ
Western Regional Office
-
Asheville, North Carona
Martin -Marietta Aggregates
SUBJECT: Application for NPDES Permit
s Mountain fhilarry
Claveiand County
Receipt of the following documents is hereby acknowledged:
Application Form
Engineering Proposal (for proposed control facilities)
_Request for permit renewal
Other
If any of the items listed below are checked, the application received is
incomplete and the indicated item(s) must be received before review can begin:
Application Form (copies enclosed)
Engineering Proposal (See (b) 1-5 on attached)
Other
If the application is not made complete within thirty (30) days, it will be
returned to you and may be resubmitted when complete.
This application has been assigned to Mr. David Aeld ns
(919/733-S181) of our Permits Unit for review and preparation of a draft per-
mit. Once the permit is drafted, public notice must be issued for forty-five
(4S) days prior to final action on the issuance or denial of the permit. You
will be advised of any comments, recommendations, questions or other informa-
tion necessary for the review of the application.
l..iulu., .... { , wry - w
J/7C`'_ a �ta-f r-epo , . s ega� i. sc._;�m r
�If you have any questions regarding this application, please contact the review
person listed above.
Sincerely,
ORIGINAL SIGNED BY
/ N
e
(;:1 tiV A � S Supervisor
AWPermits and Engineering Unit
cc _Vay#-ci- k1 i� I i�I,,11 Jj - � -
P. 0. Box 27687 Raleigh, N. C. 27611-7687
An Equal Opportunity Affirmative Action Employer

MARTIN IMARIETTA AGGREGATES
Mr. Robert F. Helms, Director
N. C. Division of Environmental Management
P. 0. Box 27687
Raleigh, NC 27611-7687
Subject: Request for Permit Renewal
NPDES Permit #NC0005444
Kings Mountain, Cleveland County
Dear Mr. Helms:
CONSTRUCTION AGGREGATES DIVISION
P. O. BOX 30013
RALEIGH, NORTH CAROLINA 27622-0013
TELEPHONE [phone]
November 29, 1983
11
EEIE®
DEC U` 190
WATER QUALITY SECTION
OPERATIONS BRANCH
The above subject permit will expire on ,Tune 30, 1983. In accordance with
permit requirements., we would like to request the renewal of Permit #NC0005444.
This. discharge represents pit water and wash water. No changes have been made
and none are proposed for this particular discharge.
Sincerely,
Horace S. Willson
Senior Environmental Engineer
HSW/oe