NCG500323_Regional Office Historical File Pre 2018 (35)

I -or Permit No. NCO072664
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL RESOURCES
DIVISION OF ENVIRONMENTAL MANAGEMENT rip
PUL
PERMIT RESOURCES AND
COMMUNITY DEVELOPMMNT
TO DISCHARGE WASTEWATER UNDER THE J JN 1 6 9993
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
DIVISION OF'EN MENTAL NAIIAGUAW
MORESIM IPIIIIaiii OFFICE
In compliance with the provision of North Carolina General Statute 143-215.1,
other lawful standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Shuford Mills, Inc.
is hereby authorized to discharge wastewater from a facility located at
Stony Point Facility
NC Highway 90
Stony Point
Alexander County
to receiving waters designated as Third Creek in the Yadkin -Pee Dee River Basin
in accordance with effluent limitations, monitoring requirements, and other conditions set forth in
Parts I, H, and III hereof.
This permit shall become effective
This permit and the authorization to discharge shall expire at midnight on July 31, 1994
Signed this day
A. PrestoIrviuronmental.
ar&, Jr., P.E., Director
Division Management
By Authority of the Environmental Management Commission

Permit No. NCO072664
SUPPLEMENT TO PERMIT COVER SHEET
Shuford Mills, Inc.
is hereby authorized to:
1. Continue to operate a 0.010 extended aeration wastewater treatment plant consisting of an
aeration tank, clarifier, sludge holding tank, and a chlorination unit located at Stony Point
Facility, NC Highway 90, Stony Point, Alexander County (See Part III of this Permit), and
2. Discharge from said treatment works at the location specified on the attached map into Third
Creek which is classified Class C waters in the Yadkin -Pee Dee River Basin.

S H i LF o R-b
4755 I NE LENOIR 28 1.
(HIQDENITEJ HIDDENITE .5 MI. 495
�t ` '=' �.. „. ." 1'•, < ". --s . 496 2'30" .497 1 400 000 FEET 1498
900 % ;,
- - yTter
ank ' Scn �P int.
\ •L_�.--�•. -`V. �; c:% \\I`\� -. ✓/ t•� • • V(<,5; �•\/' ,./..' � (jam �/ /03 -' o
%%•:/Water�jtJ,./, ``�•/� / 1 J
1= /osa t ��.� r � ., i_ ,�10.8 y y,`Tankk IV, : j /046",c.
106
LI
Philadelphia
Ch Temple;! ,
Ce
Sco`is
Ne%%-Salem ,¢• /_ / /i I i
_ I
"-ail/035 // h.
_ .• _ / - - 6' - �: / > ! � � � ' _ 1. � \.
1.01
4/030

A. (). EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS FINAL Permit No. NCO07266
During the period beginning on the effective date of the permit and lasting until expiration, the Permittee is authorized to discharge from
outfall(s) serial number 001. Such discharges shall be limited and monitored by the permittee as specified below:
Effluent Characteristics
Flow
BOD, 5 day, 200C
Total Suspended Residue
NH3 as N
Dissolved Oxygen" .
Fecal Coliform (geometric mean)
Total Residual Chlorine
Temperature
Conductivity
Discharge Limitations
Monitoring
Requirements
�
Measurement
Sample
*Sample
Monthly Avg. Weekly Avg.
Daily Max
Frequency
Tyke
Location
0.010 NIGD
Weekly
Instantaneous
I or E
30.0 mg/1
45.0 mg/I
Weekly
Grab
'E
30.0 mg/I
45.0 mg/I
Weekly
Grab
E
Weekly
Grab
E
Weekly
Grab
E, U, D
200.0 /100 ml
400.0 1100 ml
Weekly
Grab
E, U, D
Daily
Grab
E
Weekly
Grab
E, U, D
Weekly
Grab
U, D
* Sample locations: E - Effluent, I - Influent, U - Upstream of the discharge point, D - Downstream approximately 1.6 miles below discharge
** The daily average dissolved oxygen effluent concentration shall not be less than 5.0 mg/l.
The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units and shall be monitored 2/month at the effluent by grab
sample.
There shall be no discharge of floating solids or visible foam in other than trace amounts.

Part III
Permit No. NCO072664
E. Within 60 days of issuance of this NPDES permit, the permittee is required to submit plans for
properly disposing of the sludge generated at the wastewater treatment plant.