NC0072664_Regional Office Historical File Pre 2018 (26)

To: - Permits and Engineering Unit
Water Quality Section
Attention: Charles Weaver
SOC Priority Project: No
Date: March 30, 1999 .
NPDES STAFF REPORT AND RECOMMENDATIONS
County: Alexander
Permit No.: NCO072664
MRO No.: 99-59
PART I - GENERAL INFORMATION
1. Facility and Address: Shuford Mills - Stony Point Plant
Post Office Box 48
Stony Point, North Carolina 28678
2. Date of Investigation: March 25, 1999
3. Report Prepared by: Michael Parker, Environmental Engineer H
4. Persons Contacted and Telephone Number.: Mark Hawes, [phone], ext. 4428.
5. Directions to Site: From the intersection of NC Hwy. 90 and SR 1628 (Hunter Bridge
Road) in eastern Alexander County near the community of Stony Point, travel west on
NC Hwy. 90 approximately 0.15 mile. The Shuford Mills plant is located on the left side
of the Hwy. 90.
6. Discharge Point(s), List for all discharge points:
Latitude: 350 51' 36"
Longitude: 810 03' 23"
Attach a USGS map extract and indicate treatment facility site and discharge point on
map.
USGS Quad No.: D14SE USGS Quad Name: Stony Point, NC
7. Size (land available for expansion and upgrading): There is adequate land available for
expansion and upgrading.
8. Topography (relationship to flood plain included): Flat to moderate slopes; the WWTP is
not located within the 100 year flood plain.
9. Location of nearest dwelling: Several dwellings are located approximately 150 feet from
the WWTP.

Page Two
10. Receiving stream or affected surface waters: Third Creek
a. Classification: C
b. River Basin and Subbasin No.: Yadkin - Pee Dee 030706
C. Describe receiving stream features and pertinent downstream uses: The discharge
enters a small stream that has a 7Q10 flow of 0.17 cfs. Stream has moderate
gradient and a sandy bottom. General "C" classification uses downstream.
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
1. Type of wastewater: 100% Domestic
0% Industrial
a. 'Volume of Wastewater: 0.010 MGD (Design Capacity)
b. Types and quantities of industrial wastewater: N/A
C. Prevalent toxic constituents in wastewater: Chlorine is added for disinfection.
d. Pretreatment Program (POTWs only): N/A
2. Production rates (industrial discharges only) in pounds per day: N/A
3. Description of industrial process (for industries only) and applicable CFR Part and
Subpart: N/A
4. Type of treatment (specify whether proposed or existing): Existing_treatment consists of
a 10,000 gpd extended aeration package plant, which includes-&*�.,`®, an aeration
tank, clarifier, sludge holding tank and chlorination with a tablet type chlorinator. There
are no proposed WWT facilities at this time.
5. Sludge handling and disposal scheme: Sludge is pumped by -Lentz Septic Service and is
transported.for disposal to, the City of Statesville Fourth Creek WWTP.
6. Treatment plant classification: No change from current rating (Class II).
7. SIC Code(s): 2672
Wastewater Code(s): 02
Main Treatment Unit Code: 06600

i
tate of North Carolina
epartment of Environment
nd Natural Resources
Division of Water Quality U,
Jw
0"C f
V�
" 1999
or I
James B. Hunt, Jr., GovernT \\
Wayne McDevitt, Secretary """iS.tf rr
A. Preston Howard, Jr.,RE., Director
atd*��a �}Yd
Mr. Mark Hawes
Shurtape Technologies, Inc.
P.O. Box 1530
Hickory, North Carolina 28603
Dear Mr. Hawes:
January 11, 1999
*M � 0 9 ?1 FKA
L
`I
NCDENR
N TH CAROLINA DEPARTMENT OF
E O 1NMENTT AND NATURAL RESOURCES
Subject: NPDES Permit Renewal Application
Permit NCO072664
Stony Point Tape Plant
Alexander County
The Division received your permit renewal application and permit renewal fee of
$200.00 (paid by check # 32346) on December 14, 1998. Thank you for submitting this
package in a timely fashion.
The permit renewal for this facility will be assigned to a member of the NPDES
Unit staff. That staff member will contact you if further, information is needed to
complete the permit renewal.
If you have any additional questions concerning renewal of the subject permit,
please contact me at [phone], extension 511.
Sincerely,
Charles H. Weaver, Jr.
NPDES Unit
cc: Central Files
--
Moor�es�e'lle Regional_Office` WaterbQ a ty Sections'-�
`NPDES`EileY'�Y
P.O. Box 29535, Raleigh, North Carolina 27626-0535 919 733-5083, extension 511 (fax) 919 733-0719
An Equal Opportunity Affirmative Action Employer [e-mail]

NORTH CAROLINA bEPAIt OF ENVIRONMENT,
HEALTH, AND NATURAL RESOURCES'few-v
DIVISION OF ENVIRONMENTAL MANAGEMENT/ WATER QUALITY s-EcTioN'-'-
1.�:--`--:-
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
APPLICATION FOR f—
PEIZI%WTO DISCHARGE - SHORT FORM D
TO BE FILED ONLY
CHARGES OF 100% DOMESTIC WASTE k �6
I MGDFLO"
wNorth Ca7rtoriri NPDESPernit
N 1. C O 0. 7 2 16 6 q(if known)
Please print or type
w"1. Mail'
. zng address f of applicanti"
Facility, Name Shurtape Technologies,,' Inc. , Hickory Tape
Owner Name.? "4-'5-vshiirtap" ­ e, Tech' nologie§p Inc; - -
Street Addre'
ss-- 1620, Highland: -Av'-: 7,
Avenue,:
City ii"c"ibry-
State
North'Carolina
ZIP Code 28601
Telephone No. (828 3-22-2700-
2. Location producing discharge:
Name (If different from above) Shurtape �echnoiogie Inc., Stony Point Plant
Facility Contact Person- S.
n Wayne Roberts
Street Address or State Road
NC'Hwy 90-
city
Stony' Point:
County —A lex'ande*r' --
Telephone No. 704 ) 585-6511 7-
4.,: Please' provide a description of the Existing treatment facilities,:
Package Dlant,includiffle agaeration tank, a clarifier -tank W'ith a sludge
holding tank' and �a chlorination i­unit '., 7'.
Page 1 of 2
Version `i/-95

S Please mdirate the source of wastewater from the description of facilities Listed (check where
_
F �
app&cable) x',+ < , s
Tune of FacilitX Generating Wastewater
Industrial. >. t y;~x ,,, ,, Number of Employees _. 300
Commercial Number of Employees
Residential Number of Homes
School - Number' of Students/Staff"
Other
Please describe source`of wastewater (example: subdivision, mobile home park, etc.):.
�.
Water from restrooms and caf
6 Number.of separate wastewater discharge pipes/wastewater outfalls (tf applicable)
7. If separate discharge pipes, describe the source(s) of wastewater for each pipe:
8. Name of receiving water or waters: (Please provide a map showing the exact location of discharge)
Third Creek in the Yadkin -Pe ,
I_ certify. that- I am familiar with the information contained in the application, and
that to the best of my knowledge and belief such information is true, complete, and
accurate. _
Mark E.. Hawes, P.E.
Printed Name of Person Signing
Director 'of Environment and Safet .
-7
Date-. Application Signed
Signature of-App ican
North Carolina General Statute 143-215.6(b)(2) provides that: Any person who knowingly makes any
false statement representation, or certification- in any application;' record; report; plan, or other
document files or required to be maintained under Article 21 or regulations of the Environmental
Management Commission implementing that-, Article, or who falsifies, tampers with; or -knowingly
renders_ inaccurate any recording or monitoring device or method required, to be operated or maintained
under Article 21­ or regulations of the Environmental Management Commission implementing that
Article, shall be guilty of a misdemeanor punishable by a fine not to exceed $10,000, or by imprisonment
not to exceed six months, or by both. (18 U.S.C. Section 1001 provides a punishment by a fine of not more
,than $10,000 or imprisonment not more than 5 years, or both for a similar offense.)
Version 1M
Page 2 of 2

Page Three
PART III - OTHER PERTINENT INFORMATION
1. Is this facility being constructed with Construction Grant Funds (municipals only)? N/A
2. Special monitoring requests: None at this time
3. Additional effluent limits requests: N/A
4. Air Quality and/or Groundwater concerns or hazardous materials utilized at this facility
that may impact water quality, air quality, or groundwater: There are no Imown Air
Quality, Groundwater or hazardous materials concerns.
PART IV - EVALUATION AND RECOMMENDATIONS
The permittee, Shuford Mills, Inc., has applied for renewal of the subject Permit. There
have been no changes to the existing WWT facility since the Permit was last issued.
The most recent inspection report indicates that the facility is being well maintained and
generally able to meet existing effluent limits.
It is recommended that the Permit be renewed as requested.
Signature of Report Preparer Date
Water Quality Regional Su isor Date
hAdsr\dsr99\shurtape.dsr