NCG500323_Regional Office Historical File Pre 2018 (21)

hi 1-(
SOC PRIORITY PROJECT: No
To: Permits and Engineering Unit
Water Quality Section
Attention: Charles Weaver
Date: April 23, 2007
NPDES STAFF REPORT AND RECOMMENDATIONS
County: Alexander
NPDES Termit No.: NCG500323
MRO No.: 07-22
PART I - GENERAL INFORMATION
Mailing_ Address Physical Address
1. Facility and address: Shurtape Technologies, LLC 8510 Highway 90 East
Post Office Box 1530 Stoney Point, NC 28678
1620 Highland Ave., NE
Hickory, N.C. 28603
2. - Date of investigation: April 18, 2007
3. Report prepared by: Michael L. Parker, Environmental Engineer II
4. Person contacted and telephone number: Mark Hawes, [phone], ext. 5428 (main
office).
5. Directions to site: From the jct. of SR 1637 (Smith Farm Rd. and Hwy. 90 near the
Iredell/Alexander County line, travel northwest on Hwy. 90 Z 0.5 mile. The Shur -tape
Technologies plant will be on the left side of Hwy. 90.
6.. Discharge point(s), list for all discharge points:
outfall 001
Latitude: 35 ° 5l' 55"
Longitude: 81 ° 03' 10"
Attach a USGS Map Extract and indicate treatment plant site and discharge point on map.
USGS Quad No.: D 14 SE
7. Site size and, expansion area consistent with application: Yes. Sufficient area exists for
the construction of WWT facilities, if necessary.
8. Topography (relationship to flood plain included): Gently rolling, 2-5% slopes. The site
is not located in a flood plain.

Page Two
9. Location of nearest dwelling: Approx. 200f feet from the plant site.
10. Receiving stream or affected surface waters: U.T. to Third Creek"
a. Classification: C
b. River basin and subbasin no.: Yadkin 030706
C. Describe receiving stream features and pertinent downstream uses: Discharges
from outfall 001 enters a dry ditch, which eventually drain to Third Creek. The
ditch pass in close proximity to several off -site residences.
*Applicant proposes to connect the waste stream covered under the subject
Certificate of Coverage (COC) to an existing outfall covered under NPDES
permit no: NC0072664. Once relocated, the wastewater permitted under this
COC will discharge directly to Third Creek.
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
►A
3.
a. Volume of wastewater: outfall 001 - 0.0154
b. What is the current permitted capacity: There is no permitted capacity
C. Actual treatment capacity of current facility (current design capacity): outfall 001
consists of cooling tower (1600 gpd) and air washers (12,700 gpd). Boiler
blowdown wastewater previously permitted in this COC as outfall 002 has been
connected to an existing package W WTP_ covered under NPDES Permit No.
NC0072664.
d. Date(s) and construction. activities allowed by previous ATCs issued in the
previous two years: There have been no ATCs issued to this facility in the past
two years.
e. Description of existing or substantially constructed WWT facilities: There are no
existing WWT facilities.
f. Description of proposed WWT facilities: There are no proposed WWT facilities.
g. Possible toxic impacts to surface waters: Biocides are added to the current waste
streams tributary to outfall 001.
Residual handling and utilization/disposal scheme: There are no residuals generated.
Treatment plant. classification: This facility does not meet -the minimum requirements for
a Class I rating.
4. SIC Code(s): 9999 Wastewater Code(s): 14, 16 MTU Code(s): N/A

Page Three
PART III - OTHER PERTINENT INFORMATION.
1. Is this facility being constructed with Construction Grant Funds or. are any public monies
involved (municipals only)? Public monies were not used in the construction of this
facility.
2. Special monitoring or limitations (including toxicity) requests: None at this time.
3. Important SOC or Compliance Schedule dates: This facility is neither under an SOC nor
. is one being proposed at this time.
4. Alternative analysis evaluation
a. Spray Irrigation: Insufficient area.
b. Connect to regional sewer system: None available to serve the site.
c. Subsurface: Insufficient area.
PART IV - EVALUATION AND RECOMMENDATIONS
The applicant requests that the Certificate of Coverage (COC) be reissued for the
discharges of boiler blowd6wn and non -contact cooling water at the subject facility. Changes
have occurred since the last COC was issued (see paragraph below and Part 11, No. 1(c) above).
During the term,of the current COC, a previously permitted outfall (002) was connected
to an existing outfall serving the facility's package WWTP. This outfall is authorized by NPDES
Permit No. NCO072664 and discharges directly to Third Creek. The applicant is planning to
connect the remaining outfall authorized under this COC.to the outfall permitted under ,
NCO072664 at a point below all current treatment process, but where sampling can be conducted
prior to commingling.
Pending a final review and approval by NPDES Unit, it is recommended that the COC be
reissued as requested.
Water Quality Regional Supervisor
hAdsr\dsr07\shurtape.dsr
V z y/.-> I
Date

T'1�tRb
a
j«
la
fiOn4v '�'a� g D ..: i aFn1p� �n9 Apo y (art a r r�` ._� =ram^, E•v._nr:
;��� itd,E EDSP� J'��v�le 6da§�v13�iBGff ill N/�eb G'ebtG �i6i [F?a"L lr. ea sl` '•,k��ti-'asu `w i�3>
Diiv'Mllon of Water Quaflty
Michael F. Easley, Governor William, G. Ross, Jr., Secretary
Alan W. Klimek, P.E., Director
NOTICE 6F REINI `a�`%A-7, I1",,TTE T,
Amp1zC^�ae:u , -re ew' 21 0 em"S�'�-g CC3F7�ic^" v Wider �Lry-.e_e'="c`1..i 1 � -`T�'t�.'--e5"l3�vl''000 1 v
7
� � a certificate ®f c®veyeage (Coc)s NCG56 s:
(Please print or type)
1) Mailing address' of facility owner/operator: a, : ,�7
Company Name U Pi TA P 1 c. V-)r--
Owner Name .'Ve, 4 -23
Street Address
City State A/L ZIP Code -'
Telephone Number �� -2 . - Z 70 >? 5?: ? Fax:
Email address e n. a r't _� E�•r _ �' %✓I
^,ddress to which all permit correspondence should be mailed
2) Location of fae lity producing discharge:
Facility Name S N (,A7 A LPL io,ry y r S r i✓ T' ! r1 +,7
Facility Contact M AR �_- H pit"1= 5
Street Address c 5' 10 11-) W Y y C)
City Tz!)N Y PO r &-r State IV ZIP Code G,967
County
Telephone Number 82-0 3 22_-2 70J ,NS4•Z,5' Fax::. o s -32 �?7 .
Email address lv1G +.✓ s L S i1 r✓� rye . CoM
3) Description of Discharge:
a) Is the discharge directly to the receiving stream? )4Yes ❑ No
(if no, submit a site map with the pathway to the potential receiving waters clearly marked. This includes tracing the pathway of the
storm sewer to the discharge point, if the storm sewer is the only viable means of discharge.)
b) Number of discharge outfalls (ditches, pipes, channels, etc. that convey wastewater from the property):
c) What type of wastewater is discharged? Indicate which discharge points, if more than one.
g water Out
Non -contact coolinfall(s#: ) Ci
❑ Boiler Blowdown Outfall (s) #:
Page 1 of 3

The following information must be included in triplicate [original + 2 copies] with this application or it will
be returned as incomplete.
9 Site map. If the discharge is not directly to a stream, the pathway to the receiving stream must
be clearly indicated. This includes tracing the pathway of a storm sewer to its discharge point.
9 A,tithe-- iZaticy f©r _epreae-natives. If this application will be submitted by a consulting
engineer (or engineering firm), include documentation from the Permittee showing that the
consultant submitting the application has been designated an Authorized Representative of the
applicant.
I certify that I am familiar with the information contained in this application and that to the best of my
knowledge and belief such information is true, complete, and accm ate.
i
Printed Name of Person Signing: J�W V/D
(Signature of Applicant)'
North Carolina General Sta.ta .te 143-215.6 b () provides that.
(Date Signed)
Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan or other document
filed or required to be maintained under Article 21 or regulations of the Environmental Management Commission implementing that Article, or who
falsifies, tampers with or knowingly renders inaccurate any recording or monitoring device or method required to be operated or maintained under
Article 21 or regulations of the Environmental Management Commission implementing that Article, shall be guilty of a misdemeanor punishable by
a fine not to exceed $25,000, or by imprisonment not to exceed six months, or by both. (18 U.S.C. Section 1001 provides a punishment by a fine
of not more than $25,000 or imprisonment not more than 5 years, or both, for a similar offense.)
This Notice of Renewal gntent does NOT requre a separate fee.
The permitted facility agready pays an annual tee for coverage under NOG500000.
Mail the original and two copies of the entire package to:
Mr. Charles H. Weaver
NC DENR / DWQ / NPDES
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Page 3 of 3