20191209 Ver 2_LUBRA-STAR PLUS SDS 02.21.2017 (1)_20200729

Safety Data Sheet
Lubra-Star Plus
SDS Revision Date:02/21/2017
Page 1 of 9
1. Identification of the substance/mixture and of the company/undertaking
1.1. Product identifier
Product Identity Lubra-Star Plus
Alternate Names Chemical family: Blend
1.2. Relevant identified uses of the substance or mixture and uses advised against
Intended use See Technical Data Sheet.
Application Method See Technical Data Sheet.
1.3. Details of the supplier of the safety data sheet
Company Name NorthStar Fluid Solutions
P.O. Box 271036
Louisville, Colorado 80027, USA
Emergency
CHEMTREC (USA)[phone]
24 hour Emergency Telephone No.International [phone]
Customer Service:NorthStar Fluid Solutions [phone]
2. Hazard identification of the product
2.1. Classification of the substance or mixture
No applicable GHS categories.
2.2. Label elements
Using the Toxicity Data listed in section 11 and 12 the product is labeled as follows.
No applicable GHS categories.
[Prevention]:
No GHS prevention statements
[Response]:
No GHS response statements
[Storage]:
No GHS storage statements
[Disposal]:
No GHS disposal statements
Safety Data Sheet
Lubra-Star Plus
SDS Revision Date:02/21/2017
Page 2 of 9
3. Composition/information on ingredients
This product contains the following substances that present a hazard within the meaning of the relevant State and
Federal Hazardous Substances regulations.
Ingredient/Chemical Designations Weight %GHS Classification Notes
Fatty acid
CAS Number:0061790-12-3
Proprietary Not Classified [1]
Proprietary
CAS Number:0090622-46-1
Proprietary Asp. Tox. 1;H304 [1]
[1] Substance classified with a health or environmental hazard.
[2] Substance with a workplace exposure limit.
[3] PBT-substance or vPvB-substance.
*The full texts of the phrases are shown in Section 16.
4. First aid measures
4.1. Description of first aid measures
General In all cases of doubt, or when symptoms persist, seek medical attention.
Never give anything by mouth to an unconscious person.
Inhalation Remove to fresh air, keep patient warm and at rest. If breathing is irregular or stopped, give
artificial respiration. If unconscious place in the recovery position and obtain immediate
medical attention. Give nothing by mouth.
Eyes Irrigate copiously with clean water for at least 15 minutes, holding the eyelids apart and
seek medical attention.
Skin Remove contaminated clothing. Wash skin thoroughly with soap and water or use a
recognized skin cleanser.
Ingestion Get Medical attention immediately. If swallowed, do not induce vomiting. If person is fully
conscious, give water to drink. Never give anything by mouth to an unconscious person. If
vomiting occurs, keep head lower than hips to help prevent aspiration.
4.2. Most important symptoms and effects, both acute and delayed
Overview Inhalation: Liquid, no dust is generated in normal use.
Skin: May be irritating to the skin with prolonged contact.
Eye: May cause irritation to the eyes and could cause prolonged impairment of vision.
Ingestion: Not anticipated route of exposure. If ingested may be irritating to mouth, throat
and stomach. Exposure to solvent vapor concentrations from the component solvents in
excess of the stated occupational exposure limits may result in adverse health effects such
as mucous membrane and respiratory system irritation and adverse effects on the kidneys,
liver and central nervous system. Symptoms include headache, nausea, dizziness, fatigue,
muscular weakness, drowsiness and in extreme cases, loss of consciousness.
Repeated or prolonged contact with the preparation may cause removal of natural fat from
the skin resulting in dryness, irritation and possible non-allergic contact dermatitis. Solvents
may also be absorbed through the skin. Splashes of liquid in the eyes may cause irritation
and soreness with possible reversible damage. See section 2 for further details.
Safety Data Sheet
Lubra-Star Plus
SDS Revision Date:02/21/2017
Page 3 of 9
5. Fire-fighting measures
5.1.Extinguishing media
Dry chemical, foam, carbon dioxide and water fog.
5.2. Special hazards arising from the substance or mixture
Hazardous decomposition: High temperatures and fires may produce such toxic substances as carbon monoxide and
carbon dioxide.
5.3. Advice for fire-fighters
Cool closed containers exposed to fire by spraying them with water. Do not allow run off water and contaminants from
fire fighting to enter drains or water ways.
ERG Guide No.----
6. Accidental release measures
6.1. Personal precautions, protective equipment and emergency procedures
Remove sources of ignition, do not turn lights or unprotected electrical equipment on or off. In case of a major spill or
spillage in a confined space evacuate the area and check that solvent vapor levels are below the Lower Explosive
Limit before re-entering.
6.2. Environmental precautions
Do not allow spills to enter drains or waterways.
Use good personal hygiene practices. Wash hands before eating, drinking, smoking or using toilet. Promptly remove
soiled clothing and wash thoroughly before reuse.
6.3. Methods and material for containment and cleaning up
Collect and place in suitable container for reuse or disposal.
7. Handling and storage
7.1. Precautions for safe handling
See section 2 for further details.-[Prevention]:
7.2. Conditions for safe storage, including any incompatibilities
Keep from freezing, store in a cool dry place.
Handle containers carefully to prevent damage and spillage or accumulation of dust.
Incompatible materials:Strong oxidizing agents and acids.
See section 2 for further details.-[Storage]:
7.3. Specific end use(s)
No data available.
8. Exposure controls and personal protection
Safety Data Sheet
Lubra-Star Plus
SDS Revision Date:02/21/2017
Page 4 of 9
8.1. Control parameters
Exposure
CAS No.Ingredient Source Value
0061790-12-3 Fatty acid OSHA No Established Limit
ACGIH No Established Limit
NIOSH No Established Limit
Supplier No Established Limit
0090622-46-1 Proprietary OSHA No Established Limit
ACGIH No Established Limit
NIOSH No Established Limit
Supplier No Established Limit
Carcinogen Data
CAS No.Ingredient Source Value
0061790-12-3 Fatty acid OSHA Select Carcinogen:No
NTP Known:No;Suspected:No
IARC Group 1:No;Group 2a:No;Group 2b:No;Group 3:No;Group 4:No;
0090622-46-1 Proprietary OSHA Select Carcinogen:No
NTP Known:No;Suspected:No
IARC Group 1:No;Group 2a:No;Group 2b:No;Group 3:No;Group 4:No;
8.2.Exposure controls
Respiratory If workers are exposed to concentrations above the exposure limit they must use the
appropriate, certified respirators.
Eyes Wear safety glasses or googles with side shields. Maintain eye wash station in work area.
Skin Overalls which cover the body, arms and legs should be worn. Skin should not be exposed.
All parts of the body should be washed after contact.
Engineering Controls Provide adequate ventilation. Where reasonably practicable this should be achieved by the
use of local exhaust ventilation and good general extraction. If these are not sufficient to
maintain concentrations of particulates and any vapor below occupational exposure limits
suitable respiratory protection must be worn.
Other Work Practices Use good personal hygiene practices. Wash hands before eating, drinking, smoking or
using toilet. Promptly remove soiled clothing and wash thoroughly before reuse.
See section 2 for further details.-[Prevention]:
9. Physical and chemical properties
Appearance Brown/Black Liquid
Odor None
Odor threshold Not Measured
Safety Data Sheet
Lubra-Star Plus
SDS Revision Date:02/21/2017
Page 5 of 9
pH 6.7
Melting point / freezing point Not Measured
Initial boiling point and boiling range > 212F
Flash Point > 600F
Evaporation rate (Ether = 1)Not Applicable
Flammability (solid, gas)Not Applicable
Upper/lower flammability or explosive limits Lower Explosive Limit:Not Measured
Upper Explosive Limit:Not Measured
Vapor pressure (Pa)Not Measured
Vapor Density Not Applicable
Specific Gravity 0.9005-0.9305 g/cm3
Solubility in Water Appreciable
Partition coefficient n-octanol/water (Log Kow)Not Measured
Auto-ignition temperature Not Measured
Decomposition temperature Not Measured
Viscosity (cSt)Not Measured
9.2. Other information
No other relevant information.
10. Stability and reactivity
10.1. Reactivity
Hazardous Polymerization will not occur.
10.2. Chemical stability
Stable under normal circumstances.
10.3.Possibility of hazardous reactions
No data available.
10.4. Conditions to avoid
Excessive heat and open flame.
10.5. Incompatible materials
Strong oxidizing agents and acids.
10.6. Hazardous decomposition products
High temperatures and fires may produce such toxic substances as carbon monoxide and carbon dioxide.
11. Toxicological information
Acute toxicity
Exposure to solvent vapor concentrations from the component solvents in excess of the stated occupational exposure
limits may result in adverse health effects such as mucous membrane and respiratory system irritation and adverse
Safety Data Sheet
Lubra-Star Plus
SDS Revision Date:02/21/2017
Page 6 of 9
effects on the kidneys, liver and central nervous system. Symptoms include headache, nausea, dizziness, fatigue,
muscular weakness, drowsiness and in extreme cases, loss of consciousness.
Repeated or prolonged contact with the preparation may cause removal of natural fat from the skin resulting in
dryness, irritation and possible non-allergic contact dermatitis. Solvents may also be absorbed through the skin.
Splashes of liquid in the eyes may cause irritation and soreness with possible reversible damage.
Ingredient Oral LD50,
mg/kg
Skin LD50,
mg/kg
Inhalation
Vapor LD50,
mg/L/4hr
Inhalation
Dust/Mist LD50,
mg/L/4hr
Inhalation
Gas LD50,
ppm
Fatty acid -(61790-12-3)3,200.00, Rat -
Category: 5
No data
available
No data
available
No data
available
No data
available
Proprietary (90622-46-1)No data
available
No data
available
No data
available
No data
available
No data
available
Note: When no route specific LD50 data is available for an acute toxin, the converted acute toxicity point estimate
was used in the calculation of the product's ATE (Acute Toxicity Estimate).
Classification Category Hazard Description
Acute toxicity (oral)---Not Applicable
Acute toxicity (dermal)---Not Applicable
Acute toxicity (inhalation)---Not Applicable
Skin corrosion/irritation ---Not Applicable
Serious eye damage/irritation ---Not Applicable
Respiratory sensitization ---Not Applicable
Skin sensitization ---Not Applicable
Germ cell mutagenicity ---Not Applicable
Carcinogenicity ---Not Applicable
Reproductive toxicity ---Not Applicable
STOT-single exposure ---Not Applicable
STOT-repeated exposure ---Not Applicable
Aspiration hazard ---Not Applicable
12. Ecological information
12.1. Toxicity
No additional information provided for this product. See Section 3 for chemical specific data.
Aquatic Ecotoxicity
Ingredient 96 hr LC50 fish,
mg/l
48 hr EC50 crustacea,
mg/l
ErC50 algae,
mg/l
Fatty acid -(61790-12-3)Not Available Not Available Not Available
Safety Data Sheet
Lubra-Star Plus
SDS Revision Date:02/21/2017
Page 7 of 9
Proprietary (90622-46-1)Not Available Not Available Not Available
12.2. Persistence and degradability
There is no data available on the preparation itself.
12.3. Bioaccumulative potential
Not Measured
12.4. Mobility in soil
No data available.
12.5. Results of PBT and vPvB assessment
This product contains no PBT/vPvB chemicals.
12.6. Other adverse effects
No data available.
13. Disposal considerations
13.1. Waste treatment methods
Observe all federal, state and local regulations when disposing of this substance.
14. Transport information
DOT (Domestic Surface
Transportation)
IMO / IMDG (Ocean
Transportation)
ICAO/IATA
14.1. UN number Not Applicable Not Regulated Not Regulated
14.2. UN proper shipping
name
Not Regulated Not Regulated Not Regulated
14.3. Transport hazard
class(es)
DOT Hazard Class:Not
Applicable
DOT Label:---
IMDG:Not Applicable
Sub Class:Not Applicable
Air Class:Not Applicable
14.4. Packing group Not Applicable Not Applicable Not Applicable
14.5. Environmental hazards
IMDG Marine Pollutant:No
14.6. Special precautions for user
No further information
15. Regulatory information
Safety Data Sheet
Lubra-Star Plus
SDS Revision Date:02/21/2017
Page 8 of 9
Regulatory Overview The regulatory data in Section 15 is not intended to be all-inclusive, only selected
regulations are represented.
Toxic Substance
Control Act ( TSCA)
All components of this material are either listed or exempt from listing on the TSCA
Inventory.
WHMIS Classification Not Regulated
US EPA Tier II Hazards Fire:No
Sudden Release of Pressure:No
Reactive:No
Immediate (Acute):No
Delayed (Chronic):No
EPCRA 311/312 Chemicals and RQs:
To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
EPCRA 302 Extremely Hazardous :
To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
EPCRA 313 Toxic Chemicals:
To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
Proposition 65 -Carcinogens (>0.0%):
To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
Proposition 65 -Developmental Toxins (>0.0%):
To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
Proposition 65 -Female Repro Toxins (>0.0%):
To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
Proposition 65 -Male Repro Toxins (>0.0%):
To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
N.J. RTK Substances (>1%) :
To the best of our knowledge, there are no chemicals at levels which require reporting under this statute.
Penn RTK Substances (>1%):
Edible oil
16. Other information
The information and recommendations contained herein are based upon data believed to be correct. However, no
guarantee or warranty of any kind, expressed or implied, is made with respect to the information contained herein.
We accept no responsibility and disclaim all liability for any harmful effects which may be caused by exposure to our
products. Customers/users of this product must comply with all applicable health and safety laws, regulations, and
orders.
The full text of the phrases appearing in section 3 is:
H304 May be fatal if swallowed and enters airways.
This is the first version in the GHS SDS format. Listings of changes from previous versions in other formats
are not applicable.
The information and data herein are believed to be accurate and have been compiled from sources believed to be
reliable. It is offered for your consideration, investigation and verification. Buyer assumes all risk of use, storage and
Safety Data Sheet
Lubra-Star Plus
SDS Revision Date:02/21/2017
Page 9 of 9
handling of the product in compliance with applicable Federal, State and local law and regulations.NorthStar Fluid
Solutions makes no warranty of any kind, express or implied, concerning the accuracy of completeness of the
information and data herein. The implied warranties of merchantability and fitness for a particular purpose are
specifically excluded.NorthStar Fluid Solutions will not be liable for claims relating to any use of this product.
Emergency Overview:
Risk Classification System:
HEALTH 0
FLAMMABILITY 1
PHYSICAL 0
PPE B
Flammability
1 Physical
0 0
Health B
PPE
End of Document