400148_HISTORICAL_20171231

NORTH CAROLINA
Department at Environmental Qua'
II

z r s �j
PLAN OF ACTION(Poa) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
Facility Number:
40-148
Facility Name: Halfmoon Pigs
County:
Greene
Certified Operator Name: Michael Griffin _ Operator Number:
26541
1. Current liquid level(s) in inches as measured from the current liquid level in the lagoon to the
lowest point on the top of the dam for lagoons without spillways; and from the current liquid level
in the lagoon to the bottom of the spillway for lagoons with spillways.
Lagoon Name/ID:
Spillway(Y or N):
Level(inches):
Lagoon 1 Lagoon 2 Lagoon 3 Lagoon 4 Lagoon 5
A B C
N N N
21 21 28
2. Check all applicable items
Liquid level is within the designed structural freeboard elevations of one or more structures.
Five and 30 day Plans of Action are attached. Hydraulic and agronomic balances are
within acceptable ranges.
X Liquid level is within the 25 year 24 hour storm elevations for one or more structures. A
30 day Plan of Action is attached. Agronomic balance is within acceptable range.
Waste is to be pumped and hauled to off site locations. Volume and PAN content of waste
to be pumped and hauled is reflected in section III tables. Included within this plan is a list
of the proposed sites with related facility numbers, number of acres and receiving crop
information. Contact and secure approval from the DWQ prior to transfer of waste to a site
not covered in the facility's CAWMP.
Operation will be partially or fully depopulated.
'Attach a complete schedule with corresponding animal units and dates fro depopulation
`if animals are to be moved to another permitted facility, provide facility number, lagoon
freeboard levels and herd population for the receiving facility
3. Earliest possible date to begin land application of waste: as conditions permit
I hereby certify that I have reviewed the Information listed above and Included within the
attached Plan of Action, and to the best of my knowledge and ability, the information is
accurate and correct.
Murphy -Brown, LLC Phone: [phone]
Facility Owner/Manager (print)
Date: 1/4/2016
w ignature)

II. TOTAL POUNDS OF PAN STORED WITHIN STRUCTURAL FREEBOARD AND/OR 25 YR.124
HR. STORM STORAGE ELEVATIONS IN ALL WASTE STRUCTURES FOR FACILITY
1.
Structure ID: A & B
line m =
lb PAN
2.
Structure ID: C
line m =
185.0 lb PAN
3.
Structure ID:
line m =
lb PAN
4.
Structure ID:
line m =
lb PAN
5.
Structure ID:
line rn =
lb PAN
6.
Structure ID:
line m =
lb PAN
n.lines I+2+3+4+5+6= 185.Olb, PAN
1p. TOTAL PAN BALANCE REMAINING FOR AVAILABLE CROPS DURING 30 DAY DRAW DOWN
PERIOD_ DO NOT LIST FIELDS TO WHICFI PAN CONNnT RF APPI iFn nIIRINrr. T1114 3n nev PFRinn_
o. tract #
p. field #
q. crop
r. acres
s. remaining IRR
2 PAN balance
(lb/acre)
t. TOTAL PAN
BALANCE FOR
FIELD (Ibs.)
column r x s
u. application window
T6999
H01
Fescue
4.94
162.24
801.5
Aug -July
T6999
H02A
Fescue
1.88
166.99
313.9
Aug -July
T6999
H03
Small Grain
2.65
49.00
129.9
Se 1-A riol
'State current crop ending application date or next crop application beginning date for available
receiving crops during 30 day draw down period.
v. Total PAN available for all fields (sum of column t) = 1245.3 lb. PAN
IV. FACILITY'S PoA OVERALL PAN BALANCE:
w. Total PAN to be land applied (line n from section 11) = 185.0 Ib. PAN
PoA (30 Day) 2121100

x. Crop's remaining PAN balance (line v from section III) = 1245.3 lb. PAN
y. Overall PAN balance (w - x) _ -1060 lb. PAN
Line y must show as a deficit. If line y does not show as a deficit, list course of action here including pump and
haul, depopulation, herd reduction, etc. For pump & haul and herd reduction options, recalculate new PAN
based on new information. If new fields are to be included as an option for lowering lagoon level, add these
fields to the PAN balance table and recalculate the overall PAN balance. If animal waste is to be hauled to
another permitted facility, provide information regarding the herd population and lagoon freeboard levels at the
receiving facility.
Irrigation onto existing spray fields will continue as weather and field conditions permit. Additional land is
available for pumping if needed.
PoA (30 Day) MUM

PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
30 DAY DRAW DOWN PERIOD
I. TOTAL PAN TO BE LAND APPLIED PER WASTE STRUCTURE
1, Structure Name/ldentifier(10): C
2. Current liquid volume in 25 yr.l24 hr. storm storage & structural freeboard
a. current liquid level according to marker
25.0 inches
b. designed 25 yr.I24 hr. storm & structural freeboard
28.4 inches
C. line b - line a (inches in red zone) =
3.4 inches
d. top of dike surface area according to design
(area at below structural freeboard elevation)
33125 ftZ
e. line c112 x line d x 7.48 gallonslft'
70203 gallons
3. Projected volume of waste liquid produced during draw down period
f. temporary storage period according to structural design 180 days
g. volume of waste produced according to structural design 50990 ft3
h. current herd # 6960 certified herd #1 6960
actual waste produced = current herd # x line g = 50990 ft'
certified herd #
i. volume of wash water according to structural design
j. excess rainfall over evaporation according to design
k. (lines h + i + j) x 7.48 x 30 days/line f=
4. Total PAN to be land applied during draw down period
1. current waste anatysis dated 12/16/2015
m. ((lines e + k)11000) x line I
REPEAT SECTION I FOR EACH WASTE STRUCTURE ON SITE.
(Click on the next Structure tab shown below)
PoA (30 Day) 2/21100
ft3
38149 ft3
111127 gallons
1.02 Ibs11000 gal.
185.0 lbs. PAN

Salyer, Marlene 79
From: Queen, Earl <[e-mail]>
Sent: Saturday, January 02, 2016 10:34 AM
To: Salyer, Marlene
Cc: Britt, RO; Nordin, David; Weston, Kevin
Subject: Halfmoon Farm 4125
Marlene,
I wanted to email you with the lagoon information for the Halfmoom Farm (4125) following our earlier phone
conversation.
The A lagoon is at 21", B lagoon is at 21" and the C lagoon is at 25" (start pump is 28.44").
1 will have Kevin Weston to send you the POA at the first of next week when he returns from the weekend and
we will keep you informed of the actions we take to reduce our freeboard level.
Thank you,
Earl Queen
_ti G'` _ur!t:'.'�. r'�_-i, •n,�.Cdf 7 iF •ter •;" x .. '� S :. .."t.;r i"�"'.-n , -
' .. :.f � l�; a"J i�•c^ jE:�v :�c. r:.�3; i;, .'.'�i°, ;di ��' c"7.'. 'it 11� . .�. � !-,f.,r
1

AMA
CDEN
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins
Governor Director
October 1, 2009
Murphy -Brown, LLC
Halfmoon Pigs
PO Box 856
Warsaw, NC 283980856
Dee Freeman
Secretary
Subject: Certificate of Coverage No. AWS400148
Halfmoon Pigs
Swine Waste Collection, Treatment,
Storage and Application System
Greene County
Dear Murphy -Brown, LLC:
In accordance with your renewal request, we are hereby forwarding to you this Certificate of Coverage
(COC) issued to Murphy -Brown, LLC, authorizing the operation of the subject animal waste management
system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the Halfmoon Pigs, located in Greene County, -with a swine animal capacity of no
greater than the following annual averages:
Wean to Finish: Feeder to Finish: Boar/Stud:
Wean to Feeder: 6960 Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
The COC shall be effective from the date of issuance until September 30, 2014, and shall hereby void
Certificate of Coverage Number AWS400148 that was previously issued to this facility. Pursuant to this
COC, you are authorized and required to operate the system in conformity with the conditions and
limitations as specified in the General Permit, the facility's CAWMP, and this COC. An adequate system
for collecting and maintaining the required monitoring data and operational information must be
established for this facility. Any increase in waste production greater than the certified design capacity.'or.,
increase in number of animals authorized by this COC (as provided above) will require a modification to
the CAWMP and this COC and must be completed prior to actual increase in either. wastewater flo or1�\
number of animals.Please carefull read this COC and the enclosed State General Permit. Pleas a car' t�iioentioo the
General Permit. Please continue to use the same record keeviniz forms.
1636 Mail Service Center. Raleigh, North Carolina 27699-1636
Location: 2728 Capital Blvd., Raleigh, North Carolina 27604 p�,- ;,�-
Phone: [phone] FAX; 919-715-05881 Customer Service: 1-877-623-6748 ti 5 thCaro lifia r
Internet- www.ncwaterquality.org n i�/�+ /f/f
An Equal Opporwity ; AfinnaBve Action Employer L=m { gii_y P ✓ r

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per 15A NCAC 2T .0105(h) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, then an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Unit for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition 11.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Newport/Morehead City, NC
National Weather Service office at [phone], or by visiting their website at:
www.erh.noaa.gov/er/mhx/
This facility is located in a county covered by our Washington Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at
[phone].
Sincerely,
for Coleen H. Sullins
Enclosure (General Permit AWG100000)
M. (Certificate of Coverage only for all ccs)
Washington Regional Office, Aquifer Protection Section
Greene County Health Department
Greene County Soil and Water Conservation District
APS Central Files (Permit No. AWS400148)
AFO Notebooks
Murphy -Brown, LLC

May, David
From: Michael Norris[Michael Norris@ m urphyb rown I Ic.com]
Sent: Tuesday, March 23, 2010 10:39 AM
To: May, David
Subject: Lagoon levels at the Halfmoon Farm Facility # 40-148
David,
I am sending you this email to inform your office that the lagoon levels at the Halfmoon farm are now back in compliance
with the farm permit. The levels are # 1 = 20", # 2 = 20", and # 3 = 51 ". If you have any questions please give me a call.
Thanks.
Michael Norris
LNM Specialist
Murphy -Brown LLC
910-293-9364 X 241 (Office)
910-284-0435 (Mbl)

/2009 2822 Hw 24 West
Murphy Brown, LLC 4/3 y
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s): Moses Moye
Farm Name: Halfmoon Pigs
County". Greene
Farm Ca aci :
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder 6960
Feeder to Finish
Storage Structure: Anaerobic t
Storage Period:
Application Method:
>180 days
Irrigation
.agoon
RECEIVED / DENR I DV Q
Aquifer Protection Section
APR 0 6.2009
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the
for pollution, the waste should be applied to a growing crop or applied-r oi;rxiareI an—,
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems. -
P 9 2009 1 `' 1 of 8 j U! AP
i Ji; PLC ,�7�1AL

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
Capacity_Type Waste Produced per Animal Total
Farrow to Wean
3212 gallyr
gallyr
Farrow to Feeder
4015 gal/yr
gal/yr
Farrow to Finish
10585 gal/yr
gallyr
6960
Wean to Feeder
223 gal/yr
1,552,080 gailyr
Feeder to Finish
986 gal/yr
gaVyr
Total 1,552,080 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 lbs/yr
lbs/yr
Farrow to Feeder
6.5 lbs/yr
tbs/yr
Farrow to Finish
26 lbs/yr
ibs/yr
6960
Wean to Feeder
0.48 lbs/yr
3,341 lbs/yr
Feeder to Finish
2.3 lbs/yr
Ibslyr
Total 3,341 lbs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 36.46
Total N Required 1st Year: 4536.79
Total N Required 2nd Year: 0.00
Average Annual Nitrogen Requirement of Crops: 4,536.79
Total Nitrogen Produced by Farm: 3,340.80
Nitrogen Balance for Crops: (1,195.99)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

Halfmoon Pigs
402009
Reception Area Specifications
"WINS., .• ._
..
--------------
-----
-
-----------
------
--
-
3(s) of 8

Halfmoon Pigs
4/312009
Reception .•
Tract Field Irrigated Soil ist Crop Timeto p
Acreage Type Code A2ply Yield
------------------- -
AM V
i
3(b) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Corn - Grain
E Corn - Silage
F Cotton
G Fescue- Grazed
H Fescue- Hay
I Oats
J Rye
K Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
P Pine Trees
Lbs N utilized I unit yield
1.6 lbs N 1 bushel
50 lbs N 1 ton
50 lbs N 1 ton
1.25 lbs N / bushel
12 lbs N / ton
0.12 lbs N 1 lbs lint
50 lbs N 1 ton
50 lbs N 1 ton
1.3 lbs; N 1 bushel
2.4 lbs N 1 bushel
50 lbs N 1 acre
50 lbs N 1 acre
2.5 lbs N / cwt
2.4 lbs N / bushel
4.0 lbs N 1 bushel
40 lbs N 1 acre 1 yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PANT rlanimal Farm Total/ r
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
6960 Wean to Feeder 0.072 501.12
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 501.12 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 2505.6 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayiand at the
rate of 300 pounds of nitrogen per acre, you will need 8 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 20.0448 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
inlhr
* inches
_
T1454-4
1
GoA
G
0.4
1
T1454-4
2A
GoA
G
0.4
1
T1454-4
2B
GoA
B
0.4
1
T1454-4
3
GoA
B
0.4
1
T1454-2, 3
4A
GoA
F
0.4
1
T1454-2,3
4B
GoA
F
0.4
1
T1454-2,3
5A
GoA
F
0.4
1
T1454-2,3
5B
GoA
F
0.4
1
T1454-2,3
6A
GoA
F
0.4
1
T1454-2,3
6B
GoA
F
0.4
1
T 1454-2, 3
7A.
GoA
F
0.4
1
T1454-2,3
7B
GoA
F
0.4
1
Optional
Crops
T1454-2,3 4A-7B GoA D 0.4
T1454-2,3 4A-7B GoA N 0.4
T1454-2,3 4A-713 GoA O 0.4
6 of 8

Additional Comments:
This plan revised to reflect wetted acreage due to a new irrigation system.
Hydrant 2 is half fescue and half bermuda. Producer mqy_plant any optional
instead of cotton if desried.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: Hatfmoon Pigs
Owner: Moses Moye
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Moses Moye
Signature:
Date
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist: M. Kevin Weston
Affiliation: Murphy -Brown, LLC
Signature:
Address: 2822 Hwy 24 West, PO Box 856
_ Warsaw, NC 28398
Telephone: _ [phone]
Date
Date
8 of 8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization flan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Wasteinutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner_
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

Mu by-BfOWn LLC PO Drawer 856
2822 Hwy. 24 West
Warsaw, NC 28398
Tel: [phone]
Fay 910-293-3138
March 1, 2005
Jim Mulligan, Water Quality Supervisor
NCDENR, DWQ
Washington Regional Office
943 Washington Square Mali
Washington, NC 27889
Subject: Revised Nutrient Utilization Plans and
Irrigation Design Parameters for
Hardy Moye Farm, Facility No. 74-71, Pitt County
Halfmoon Pigs Farm, Facility No. 40-148, Greene County
Enclosed are copies of the revised Nutrient Utilization Plans and Irrigation Design Parameters for the
above -mentioned farms. Both facilities will be installing new irrigation systems to replace the old existing
systems. The Nutrient Utilization Plans were revised to reflect the wetted acreages plus the acreages to be
covered by an aerway machine. Please place in the appropriate files.
if you have any questions regarding this matter, please do not hesitate to call me at [phone] ext.
5363.
Sincerely,
Kevin Weston, CID
Environmental Compliance
MAR - 3 -;G

Murphy -Brown, LLC 1/17/2005 2822 HWY 24 West
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s):
Farm Name:
Hardy Moyel leased to Murphy -Brown, LLC
Hardy Moye Farm
County: Pitt
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder 11157
Feeder to Finish
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, A tons, etc.):
Capacitz Type Waste Produced per Animal Total
Farrow to Wean
3212 gallyr
gallyr
Farrow to Feeder
4015 gallyr
gallyr
Farrow to Finish
10585 gallyr
gallyr
11157
Wean to Feeder
223 gallyr
2,488,011 gallyr
Feeder to Finish
986 gaVyr
gall
Total 2,488,011 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 Ibslyr
Ibslyr
Farrow to Feeder
6.5 Ibslyr
Ibslyr
Farrow to Finish
26 Ibslyr
Ibslyr
11157
Wean to Feeder
0.48 Ibslyr
5,355 Ibslyr
Feeder to Finish
2.3 Ibsl
lbs/yr
Total 5,355 Ibs!
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 19.81
Total N Required 1st Year: 5526.71875
Total N Required 2nd Year: 0.00
Average Annual Nitrogen Requirement of Crops: 5,526.72
Total Nitrogen Produced by Farm: 5,355.36
Nitrogen Balance for Crops: (171.36)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized 1 unit yield
A
Barley
1.6 Ibs N / bushel
B
Hybrid Bermudagrass - Grazed
50 Ibs N / ton
C
Hybrid Bermudagrass - Hay
50 Ibs N 1 ton
D
Corn - Grain
1.25 Ibs N 1 bushel
E
Corn - Silage
12 lbs N 1 ton
F
Cotton
0.12 Ibs N 1 Ibs lint
G
Fescue - Grazed
50 Ibs N 1 ton
H
Fescue - Hay
50 Ibs N / ton
I
Oats
1.3 Ibs N 1 bushel
J
Rye
2.4 lbs N / bushel
K
Small Grain - Grazed
50 Ibs N 1 acre
L
Small Grain - Hay
50 Ibs N 1 acre
M
Grain Sorghum
2.5 Ibs N 1 cwt
N
Wheat
2.4 Ibs N ! bushel
V
JUyU Taff
4.0 li.J- IV P UUJIIGI
P
Pine Trees
40 Ibs N 1 acre 1 yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

LM
SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PANT,
Farrow to Wean
Farrow to Feeder
Farrow to Finish
11157 Wean to Feeder
Feeder to Finish
trlanimal Farm TotaVyr
0.84
1
4.1
0.072 803.304
0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 803.304 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 4016.52 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 13 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 32.13216 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
rroyim.im
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
T
Hydrant
Type
Crop
inlhr
inches
T699-1
1
Ly
GIH
0.65
1
T699-1
2
Ly
GIH
0.65
1
T699-2
3
GoB
BIC
0.4
1
T699-2
4
GoB
BIC
0.4
1
T699-1
subl
Ly
GIH
0.65
1
T699-2
sub2
GoB
BIC
0.4
1
6of8

Additional Comments:
This plan revised to reflect wetted acreage due to a new irrigation system.
Fields sub 1 & sub 2 are the remaining field acres not covered by the irrigation
system. These fields will be covered by using an aerway machine.
Thisplan shows a hay/graze combination for both fields. At least half of the
crop should be removed as hay and the remaining half by grazing__
Since 75 Ibs N/ac is being used for the small grain overseed, half of this 75 Ibs
N is to be applied in Se t 15 - Oct and the remaining half in Feb - Mar. Also,
the small grain must be removed from the field by April 7.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm:
Owner:
Manager:
Owner/Manager Agreement:
Hardy Moye Farm
Hardy Moyel leased to Murphy -Brown, LLC
Richard Murphy
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Hardy Moye/ leased to Murphy -Brown, LLC
Signature: _ �' `� v� /`<:�) ,
Date
Name of Manager (if different from owner): Richard Murphy
Signature: p c
Date
Name of Technical Specialist:
M. Kevin Weston
Affiliation:
Murphy -Brown. LLC
Address:..
" " 2822 Hwy 24 West, PO Boz 85fi
Warsaw, IBC 28398
Telephone:
[phone]
Signature: ,�..�.!%/ _ /l/7�zar
Date
8 of 8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing himther the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
inrnrnnrafarl nn rnnvanfinnally fillari rrnnlanrl Whan %gncJp is annliarl fn rnnaPnmfinn fillari
- - --
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed'to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
r• _ „a_. -.: __ __ ; ��—.. _,a • L_ ___1 J lam— ,f _ tl�=_ �_
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

Hardy Mope Farm
Scale: 1 "=300'
Field #1
Tntnl Field = 9.A0 Ar_.
Well w/100' offset
TB
Thrust Block
AV
Air Vent
PR
Pumping Riser
7I
HZdro.
i
4 Classnt 200 PVC

Sheet1
IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Nam,::: Hardy Moye Farm
Addres,:*,: 7243 US Hwy 13
Farmville, NC 27828
Telephone: [phone]
Table i - Field Specifications
County: Pitt
Date: 1 /17/2005
Approximate Maximum
Maximum Maximum Application
Useable Size Application per Irrigation
Field of Field Rate Cycle
Mimhar larrpcl Soil T►inF glnnp M� rrnn(s) llnlhrl finrhPS1 C:nmmPnts
.c
..
4
�t,, - 3

Sheet2
TABLE 2 - Travelling Irrigation Gun Settings
Make, Model and Type of Equipment: ABI PT590 984 traveler wl Xx984' hose wl Nelson 150
Field No.
-per
Travel
Application
-VRAVEL LANE
Wetted
Nozzle
Operating
Operating
and
Speed
Rate
Effe,+.tive Effective
Diameter
Diameter
Pressure
Pressure Arc
Hvdrant No.
min(in/hr.)
Wid th ft. Len th ft
feet
Inches
at Gun(psi)
at reel(psi) Pattern Comments - Acres pull

Sheet4
TABLE 4 - Irrigation System Specifications
TravelinQ
Solid Set
Irrigation Gun
Irrigation
Flow Rate of Sprinkler (gem)205
0
Operating Pressure at Pump si
98.4
#DIV10!
Design Precipitation Rate inlhr
0.43
#DIVIO!
Hose Length (feet)984
xxxxxxXX
Type of Speed Compensation
Mechanical
xxxxxxxx
Pump Type PTO, Engine, Electric
Engine
En ine
Pump Power Requirement h
23.5
#DIVIO!
TABLE 5 - Thrust Block Specifications
6"
4"
2"
THRUST BLOCK
THRUST BLOCK
THRUST BLOCK
LOCATION
AREA (sq. ft.
AREA (sq. ft.
AREA (sq. ft.
90 degree bend
8.8
4.3
1.1
Dead End
6.2
3.0
0.8
Tee
4.4
2.1
0.5
Gate Valve
6.2
3.0
0.8
45 degree bend
4.7
2.3
0.6
Page 1

Sheet5
REV 11V
. S'
IRRIGATION SYSTEM DESIGNER `GP a 0
Name: Mica t-i Kevin Weston, CID 7,
Company: Murk hy-Brown, LLC 7k z
Address: 2822 Hwy 24 West, P.O. Box 856 Warsaw, NC 28398 002919 •
Phone: (910 i 293-3434
OAS! GT�A��
Required Documentation `spRINKL�4
The following details of design and matZ`Aals must accompany all irrigation designs:
1. A scale drawing of the proposed irrigation syst-3m which includes hydrant locations, pipelines, thrust block locations and buffer areas where applicable.
2. Assumptions and computations for determinlr;�;l total dynamic head and horsepower requirements.
3. Computations used to determine all mainline i nd lateral pipe sizes.
4. Sources and/or calculations used for determira'ng application rates.
5. Computations used to determine the size of tlaiust blocks and illustrations of all thrust block configurations required in the system
6. Manufacturer's specifications for the irrigation; )ump, traveler and sprinkler(s).
7. Manufacturer's specifications for the irrigation"pipe and/or USDA -MRCS standard for IRRIGATION WATER CONVEYANCE.
8. The information required by this form are the i .,3Inimum requirements. It is the responsibility of the designer to consider all relevant factors at a particular site and
address them as appropriate.
g. Irrigation pipes should not be installed in lagoon or storage pond embankments without the approval of the designer.
NOTE: A buffer strip of 25' or wider must k:., maintained between the limits of the irrigation system and all
perennial streams and surface wahirs per NC Statutes.

Sheet6
Narrative of Irrigation System Operation
Design And Installatit fin Overview
This design is for an eisting facility. This irrigation system is designed with four inch, Class 200 PVC gasket
pipe and schedule 80 flttings. The system is designed to accommodate the flow velocities, flow rates and
pressure requirements associated with an ABI PT590 984 traveler. Air vents and thrust blocks are to be
installed as indicated o`rthe drawings. Air vents will consist of using a 4" x 2" saddle with a 2" galvanized
threaded pipe and an kV 150. The thrust block areas have been calculated and are listed in Table 4 of this
design. The design of if--ie traveler system requires the use of a 1.18" ring nozzle in the gun. Each pull has a
specific arc setting and,. ---.travel speed which must be used to achieve the desired application. This information is
given in Table 2 of this`_' esign. A detail of the hydrant layout is also included and specifies the type and size of
fittings. All pipe shall bE installed with a minimum of 30" of cover and shall be backfilled in no less than three
passes, leaving enougf-i soil material above original grade to allow for settling. All ditch crossings shall cross at
a minimum of 24" beloiT the bottom of the ditch or shall be encased in a 8" x 20' Class 200 PVC pipe. The
suction assembly for tli:� pump to be used is 6" alluminum. A pressure gauge should be Installed on the
discharge side of the ptImp where it can be seen during start up of the system.
System Start-up And operation
When setting up the res, 1, make sure it is level and the stabilizer legs are down and secured. Engage the
brake, then disengagefne transmission. Pull out the hose at a speed not to exceed 3 mph. Engage the
transmission before di.eengaging the brake. Prime the pump and start the motor. Set all "Murphy" safety
switches to insure imm' diate shut down of the system if a problem occurs. Also, set the timer to shut off the
pump at the time a run will be completed. Check all safety switches on the reel after each start-up to ensure
proper operation. Read. -.and review the manufacturers operator manuals for additional details on start-up
procedures. Grower shii:iuld walk the entire pipeline periodically to check for leaks and other potential
Winterization And Mantenance
Disconnect both ends (if all flexible hoses at the traveler. Remove the drain plug from the gun cart and pull out
the hose at least half wOy to purge enough water to protect from freezing. Wind the hose back onto the reel
and replace the drain pFug. Read and review the manufacturers operator manuals for additional details on
winterization and maint,nance procedures.

Sheet?
CALCULATIONS
Sprinkler SRecifications
Sprinkler Type: Nelson
150
Nozzle Size:
1.18 inches
Sprinkler Pressure:
50 psi
Flowrate(GPM):
205 gpm
Wetted Diameter:
270 feet ` Reflects a 10% reduction from chart
Lane StnacInas
Desired Spacing (%):
70 %
Design Spacing(feet):
189 'PVC irrigation pipe normally comes in 20' pieces,
so round to the nearest multiple of 20.
Actual Spacing (feet):
200 feet
Actual Spacing (%):
74 %
Application Rate
Application Rate =(96.3xFlowrate)/(3.1415x(.9xradius)squared)
Design App. Rate =
0.43 in/hr
300 degree arc =
0.51 inlhr 330 degree arc = 0.46 in/hr
220 degree arc =
0.70 in/hr
180 degree arc =
0.85 in/hr
Traveller Speed
Travel speed =1.605 x Flowrate / Desired application amount x Lane Spacing
Desired app. (in.) = 0.4 inches 360 degree arc = 4.11 ft/min
300 degree arc = 4.94 ft/min 330 degree arc = 5.38 ft/min
220 degree arc = 6.58 ft/min
180 degree arc = 8.23 ft/min
Mainline Velocity
1-IV-c �-'i"F.V. \1.... 4uul Lill' 'IVL�i L•56U. -
"For buried pipelines, velocity should be below 5 feet per second
Pipe size: 4 inches
Velocity= 5.23 ft/sec.
Page 1

Sheet?
Maximum Mainline Friction Loss
Most distant hydrant: 4
Total distance: 750 feet
Friction Loss is figured using HazenlWilliam's Equation
Friction Loss= 2.18 feet/100 feet
Max. Mainline Loss = 16.3 feet or 7.1 psi
Total Dvnamic Head
Sprinkler Pressure: 50 psi
Loss through traveller: 30 psi
Elevation head: 4.3 psi
Mainline loss: 7A psi
Suction head and lift: 2.3 psi
5% fitting loss: 4.7 psi
TOTAL(TDH) = 98.4 psi or 227.2 feet
Horsepower Required
Horsepower = Flowrate x TDH(feet)139601 Pump effeciency
Pump Description: Berkeley B3JQBM
Pump Efficiency: 50 %
Horsepower Required: 23.5 Hp
Thrust_Blockina
Thrust Block Area = Thrust / Soil Bearing Strength
Thrust: 3630 feet
Soil Bearing Strength: 1200 feet
End Cap: 3.0 ft2
90 degree elbow: 4.3 ft2
1 V4.
45 degree elbow: 2.3 ft2
Pipe Pressure Rating Check
Pressure Rating of Pipe to be Used: 200 psi
Max. Pressure on system when running: 98.4 psi
70% of Pressure Rating: 140 psi
If Max. Pressure on system is less than 70% of Pressure Rating, OK
Net Positive Suction Head Check
Page 2

Sheet8 (2)
Hard<< Moe Farm
Acre-pq a Calculations
Width
Length
A:res
Total Acres
Start End
Sto End
Total
Pull #
ft.
ft.
Imidtpc i
dsection
ac.
ac.
PullAct
1
235
131
0'-107
0.707
0.400
0.330
1.44
2
235
653
31523
3.523
0.400
0.330
4.25
3
235
751
x
4�1052
4.052
0.400
0.330
4.78
4
235
284
1 �532
1.532
0.400
0.330
2.26
0
0
0=000
0.000
0.000
1 0.000
0.00
0
0
01000
0.000
0.000
0.000
-
0.00
0
Q
01}00
0.000
0.000
0.000
0.00
0
0
0 i}00
0.000
0.000
0.000
0.00
0
0 -
0--Mo
0.000
0.000
0.000
0.00
0
0
Q 000
0.000
0.000
0.000
0.00
0
0
Wow
0.000
0.000
0.000
0.00
0
0
0l500
0.000
0.000
0.000
0.00
0
0
0f}00
0.000
0.000
0.000
0.00
0
0
Ot}Qo
0.000
0.000
0.000
0.00
0
0
0:1)00
0.000
0.000
0.000
0.00
0
0
0)00
0.000
0.000
0.000
0.00
0
0
0)00
0.000
0.000
0.000
0.00
0
0
0 }00
0.000
0.000
0.000
0A0
0
0
0 000
0.000
0.000
0.000
0.00
0
0
0 )00
0.000
0.000
0.000
0.00
0
0
0}Oo
0.000
0.000
D.000
0.00
Total Acres
12.73
Page 1

'Hardy Moye Farm
Scale: 1 "=300'
Field #1
Tntnl Field = 9 Rn Ar
Well w/100' offset
T8
Thrust Block
AV
Air Vent
PR
Pumping Riser
7R
Hydrant
�*
4 Class 200 PVC

Murphy -Brown, LLC 1/5/2005 2822 Hwy 24 West
P.O. Box 656
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s):
Farm Name:
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish
Storage Structure:
Storage Period:
Application Method:
Moses Moye
Halfmoon Pigs
ureene
Anaerobic Lagoon
>180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
I7n nnf ennlu wee+n on cats gated $nFES when it..0;-raininfl or when the surface is frZen
o
.. »,._..'� ....h ,......., m..-.�.: �.,..:.n.: ..... a i :
Either of these conditions mayresult in ,;
runoff to surface waters which: _;c is no:,.;�.. t a'l owed`
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flebble so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, fe, tons, etc.):
Ca T Waste -Produced mr Animal Total
Farrow to Wean
3212 galtyr
galtyr
Farrow to Feeder
4015 gaVyr
gal/yr
Farrow to Finish
10585 galtyr
gaVyr
6960
Wean to Feeder
223 gaVyr
1,552,080 gallyr
Feeder to Finish
986 galtyr
gawr
Total 1,552,080 gaVyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (ibs):
Capacity Nitr n Produced per Animal Total
Farrow to Wean
5.4 Ibslyr
lbstyr
Farrow to Feeder
6.5 lbstyr
lbstyr
Farrow to Finish
26 Ibsiyr
Ibsfyr
6960
Wean to Feeder
0.48 Ibslyr
3,341 lbstyr
Feeder to Finish
2.3 lbstyr
IbsJyr
Total 3,341 lbstyr
Apptying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this fac:ltity
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
.
Total Irrigated Acreage:
„ 3,,.,„ „
5.46
Total N Required 1st Year:
4536.79
Total N Required 2nd Year:
0.00
Average Annual Nitrogen Requirement of Crops: 4,538.79
Total Nitrogen Produced by Farm: 3,340.80
Nitrogen Balance for Crops: (1,195.99)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utifization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

Halfmoon Pips
11 OOS
Reception Area Specifications
ill
_
_
_
_
zml
3(e) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, andfor silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized 1 unit yield
A
Barley
1.6 lbs N 1 bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N 1 ton
C
Hybrid Bermudagrass - Hay
50 lbs. N 1 ton
D
Corn - Grain
1.25 lbs N 1 bushel
E
Com - Silage
12 lbs N I ton
F
Cotton
0.12 lbs N 1 lbs lint
G
Fescue - Grazed
50 lbs N I ton
H
Fescue- Hay
50 lbs N 1 ton
I
Oats
1.3 lbs N / bushel
J
Rye
2.4 lbs N / bushel
K
Small Grain - Grazed
50 lbs N 1 acre
L
Small Grain - Hay
50 lbs N I acre
M
Grain Sorghum
2.5 lbs N I cwt
N
Wheat
2.4 lbs N 1 bushel
P
Pine Trees
40 Ibs N 1 acre 1 yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications P rlanimal Farm Tota r
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
6960 Wean to Feeder 0.072 501.12
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 501.12 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 2505.6 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid Bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 8 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 20.D448 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it Is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*this is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
-'' �` "Y-sr%a: +~r .^ ;••lCn� ti-n ,rr �s aka -+i r n der-sf=^,4i�r Th application amount shown can be applied under optimum soil conditions.
Your facility is designed for >160 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
inlhr
• inches
T1454-4
1
GoA
G
0.4
1
T1454-4
2
GoA
G
0.4
1
T1454-4
2
GoA
B
0.4
1
T1454-4
3
GoA
B
0.4
1
T1454-2,3
4A
GoA
F
0.4
1
T1454-2,3
4B
GoA
F
0.4
1
T1454-2,3
5A
GoA
F
0.4
1
T1454-2,3
5B
GoA
F
0.4
1
T1454-2,3
6A
GoA
F
0.4
1
T1454-2,3
6B
GoA
F
0.4
1
T1454-2,3
7A
GoA
F
0.4
1
T1454-2,3
7B
GoA
F
0.4
1
Optional
Crops
T1454-2,3 4A-7B GoA D 0.4
T1454-2,3 4A-713 GoA N 0.4
T1454-2,3 4A-713 GoA O 0.4
6 of 8

Additional Comments:
This plan revised to reflect wetted acreage due to a new irri ation s stem.
Hydrant 2 is half fescue and half bermuda. Producer may plant any optional
crops instead of cotton if desded.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: Halfmoon Pigs
Owner: Moses Moye
Manager:
Owner/Manager Agreement:
Itwe understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. IANe know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWO before the -new
animals are stocked.
I/we understand that I must own or have access to equipment; primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rues which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature:
Moses Moye
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist: M. Kevin Weston
_:.., # :.:....:p.�..:.� _, t� y- � 12................
Address: 2822 Hwy 24 West, PO Box 855
Warsaw, NC 28398
Telephone: [phone]
Signature:
r7Q-1+7
- DS
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach ' surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
Z There must be documentation in the design folder that the producer either owns or has
an agreement for use of adequate land on which to properly apply the waste: If the
producer does not own adequate land to properly dispose of the waste, he/she shall
provide evidence of an agreement with a landowner, who is within a reasonable
proximity, allowing him/her -the use of the land for waste application. It is the
responsibility of the owner of the waste production facility to secure an update of the
Nutrient Utilization Plan when there is a change in the operation, increase in the number
of animals, method of application, recieving crop"type, or available land.
3 . Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based upon soil type, available moisture, historical data, climatic conditions,
and level of management, unless there are regulations that restrict the rate of
applications for other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may -bee applied to land eroding at more than 5 tons per acre per year but less than 10
tons per acre per year provided grass filter strips are installed where runoff leaves the
field (See USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
tilled crops or grassland, the waste may be broadcast provided the application does not
occur during a season prone to flooding (See "Weather and Climate in North Carolina"
for guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not cause
drift from the site during application. No ponding should occur in order to control odor
and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such. a manner that the crop is'
not covered with waste to a depth that would inhibit growth. The potential for salt
damage from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new"swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is'applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property
boundary and canal. Animal waste, other than swine waste from facilities sited on or after
October 1, 1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
speciailW. 'Animal •waste--shaii- not be applied on. -grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
-(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation, such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 if animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
18 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should
be kept on site.
20 Animal waste can be used in a rotation.that includes vegetables and other crops for .
direct human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste:during the crop season.
21.. -Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shalt be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the rate�-
dete ma ining-nuiiiient; unless pOther-mstnta ians irt—quire,waste ta be aapplM� based on -other
nutrients, resulting in a lower application rate than a nitrogen based rate. Zinc and copper
levels in the soil shall be monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted and maintained for optimum
crop production. Soil and waste analysis records shall be kept for a minimum of five
years. Poultry dry waste application records shall be maintained for a minimum of three
years. Waste application records for all other waste shall be maintained for a minimum
of five years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

Well w/100'
offset
Hadfrno-on Farm
Scale,* 1*=300'
002919
2/22/2004

Sheet1
IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name: Moses W. Moye - Haifmoon Farm
Address: 211 East Home Ave.
Farmville, NC 27828
Telephone; [phone]
'Fable 1 - Field Specifications
County; Greene
Date: 12/22/2004
Approximate
Maximum
Maximum
Maximum Application
T1454 Useable Size
Application per Irrigation
Field of Field
Rate Cycle
Number (acres) • .• ••
• : .
MAR - 3 '2005

Sheet2
TABLE 2 - Travelling Irrigation Gun Settings
Nelson
Field No. Travel Appilcatlon TRAVEL LANE Wetted Nozzle Operating Operating
and Speed Rate ,affective Effective Diameter Diameter Pressure Pressure Arc
Hvdrant No. lft/min) (in/hr.) Width(ft.) Lenoth(ft) (feet) (inches) at Gun(Dsi) 'at reel{psl) Pattern Comments -Acres Der pull
Fro
KIX

Sheet4
TABLE 4 - Irrigation System Specifications
Traveling_
Solid Set
Ini atlon Gun
Irrigation
Flow Rate of Sprinkler m
205
0
Operating Pressure at Pump i
101.1
#DIV101
Design Precipitation Rate n/hr
0.38
#DIV101
Hose Length feet i
984
xxxxxXXX
Type of Speed Compensation
Mechanical
XXXXXXXX
Pume Type PTO Engine, Electric
Engine
'Fump Power R ulrement h
24.2
#DIV/01
TABLE 5 - Thrust Block Specifications .:
THRUST BLOCK
LOCATION
AREA ft.
90 d2gree bend
4.27
Dead End
3.03
Tee
. 2.12
Gate Valve
3.03
45 degree bend
2.30
Page 1

sheets
IRRIGATION SYSTEM DESIGNER >.
Name: Micah.Kevin Weston, CID %� p
Company: Murphy -Brown, LLC
Address: 2822 HWY 24 West, PO Drawer 856 Warsaw, NC 28398
Phone: [phone]
O4 SI GtVr��'
Required Documentation
The following details of design and materials must accompany all Irrigation designs:
1. A scale drawing of the proposed Irrigation systemiwhlch Includes hydrant locations, pipelines, thrust block locations and buffer areas where applicable.
2. Assumptions and computations for determining 6�l dynamic head and horsepower requirements.
3. Computations used to determine all mainline and lateral plpe sizes.
4. Sources and/or calculations used for determinin!application rates.
5. Computations used to determine the size of thuuo' t blocks and Illustrations of all thrust block configurations required In the system
6. Manufacturer's specifications for the Irrigation ptiinp, traveler and sprinlder(s).
7. Manufacturers specifications for the Irrigation ply' and/or USDA-NRCS standard for IRRIGATION WATER CONVEYANCE.
8, The Information required by this form are the minimum requirements. It is the responsibility of the designer to consider all relevant factors at a particular site and
address them as appropriate.
9. Irrigation pipes should not be Installed In lagoon or storage pond embankments without the approval of the designer.
NOTE: A buffer strip of 2S or wider must be maintained batween the limits of the Irrigation system and all
perennial streams and surfaco waters per NO Statutes.

Sheet6
Narrative of Irrigation System Operation
Design And Installation 04erview
This design is for an existing facility. This Irrigation system Is designed with four inch, Class 200 PVC gasket pipe and
schedule 80 fitttings. The system Is designed to accommodate the flow velocities, flow rates and pressure requirements
associated with an ABI PTP0 984 traveler. Air vents and thrust blocks are to be installed as Indicated on the drawings. Air
vents will consist of using a 4" x 2" saddle with a 2" galvanized threaded pipe and an AV 150. The thrust block areas have
been calculated and are listed In Table 4 of this design. The design of the traveler system requires the use of a 1.18" ring
nozzle in the gun. Each puil;has a specific arc setting and travel speed which must be used to achieve the desired
application. This informatiorti Is given In Table 2 of this design. A detail of the hydrant layout Is also Included and specifies
the type and size of fittings. All pipe shall be Installed with a minimum of 30" of cover and shall be backfilled in no less
than three passes, leaving enough soil material above original grade to allow for settling. All ditch crossings shall cross at
a minimum of 24" below the, bottom of the ditch or shall be encased in a 8" x 20' Class 200 PVC pipe. The suction
assembly for the pump to 66 used is e" alluminum. A pressure gauge should be installed on the discharge side of the
pump where It can be seen during start up of the system.
System Start-up And Operation
When setting up the reel, make sure it is level, and the stabilizer legs are down and secured: Engage the brake, then
disengage the transmission.E Pull out the hose at a speed not to exceed 3 mph. Engage the transmission before
disengaging the brake. Prime the pump and start the motor. Set all "Murphy" safety switches to insure Immediate shut
down of the system if a problem occurs. Also, set the timer to shut off the pump at the time a run will be completed. Check
all safety switches on the reel after each start-up to ensure proper operation. Read and review the manufacturers operator
manuals for additional detalls on start-up procedures. Grower should walk the entire pipeline periodically to check for
leaks and other potential peDblems.
Winterization And Maintenance
Disconnect both ends of all! flexible hoses at the traveler. Remove the drain plug from the gun cart and pull out the hose
least half way to purge enough water to protect from freezing. Wind the hose back onto the reel and replace the drain
plug. Read and review the manufacturers operator manuals for additional detalls on winterization and maintenance
procedures.

Sheet7
, , , a
CALCULATIONS
Sprinkler SEM pAol)s
Sprinkler Type: Nelson 150
Nozzle Size:
1.18 inches
Sprinkler Pressure:
50 psi
Flowrate(GPM):
205 gpm
Wetted Diameter.
270 feet "Reflects 10% reduction from chart.
Lags Spacinas
Desired Spacing (%):
70 %
Design Spacing(feet):
189 "'PVC irrigation pipe normally comes in 20' pieces,
so round to the nearest multiple of 20.
Actual Spacing (feet):
200 feet
Actual Spacing (%):
74 %
Application Rate
Application Rate =(96.3xFlowrate)/(3.1415x(.Sxradius)squared)
Design App. Rate =
0.38 in/hr 360 degree arc = 0.38 in/hr
300 degree arc =
0.46 in/hr 330 degree arc = 0.42 in/hr
220 degree arc =
0.63 in/hr
180 degree arc =
0.77 in/hr
Tf ygller Speed
Travel speed = 1.605 x Flowrate / Desired application amount x Lane Spacing
Desired app. (in.) =
0.4 inches 360 degree arc = 4.11 ft/min
300 degree arc =
4.94 ff/min 330 degree arc = 4.48 ft/min
220 degree are =
6.58 filmin
180 degree are =
8.23 ft1min
,Mainline Velocity
YIC{UGlly — .4tl0 l "ritmrFac 'o f w usasv►'U ayuo/a. ,w.iS....:
"For buried pipelines, velocity should be below 5 feet per second
Pipe size:
4 inches
Velocity--
5.23 ft/sec.
Page 1

Sheet7
A d . %
Maximum Malnline Friction Long
Most distant hydrant: 7
Total distance: 1290 feet
Friction Loss is figured using Hazen/William's Equation
Frictiori Loss= 2.18 feet/100 feet
Max. Mainline Loss = . 28.1 feet or 12.2 psi
Total Dynamic Head
Sprinkler Pressure:
50 psi
Loss through traveller:
30 psi
Elevation head:
2.1 psi
Mainline loss:
12.2 psi
Suction head and lift:
2 psi
5°% fitting loss:
4.8 psi
TOTAL(TDH) =
101.1 psi or 233.5 feet
Horsepower Required
Horsepower = Flowrate x TDH(feet)139601 Pump effeciency
Pump Description: Berkeley B3JQBM
Pump Efficiency: 50 %
Horsepower Required: 24.2 Hp
ThIMst Blocict S
Thrust Block Area = Thrust 1 Soli Bearing Strength
Thrust: 3630 feet
Soil Bearing Strength: 120o feet
End Cap: 3.0 ft2
90 degree elbow: 4.3 ft2
::.........:..:.......:.. :...:.1 E3:.... ......,,L: I F,,2
45 degree elbow. 2.3 ft2
Pipe Pressure_Ratin4 Check
Pressure Rating of Pipe to be Used: 200 psi
Max. Pressure on system when running: 101.1 psi
70% of Pressure Rating: 140 psi
If Max. Pressure on system is less than 70% of Pressure Rating, OK
Page 2

Sheet?
Net Positive Suction Head Check
NPSHA: 17'
NPSHR: 7' *from pump curve
If NPSHA>NPSHR OK
Page 3

Sheet8 (2)
Halfmoon Farm
Acreage Calculations
Width
Len
Acres
Total Acres
Start End
Stop End
Total
Pull #
L1
M
(midsWion)
midsection
ac.
ac.
Pull Acres
1
235-
780
4.21 -
421
0.400
0.330
4.94
2
200
662
3.04
3.04
0.400
0.320
F 3.76
3
100
62
0.14
1.92
0.400
0.330
2.65
235
330
1.78
0.00
0.000
0.000
'0.00
4A
235
556
3.00.
3.00
0.400
0.000
3.40
4B
141
345
1.12
4.57
0.400
0.000
4.97
235
639
3.45
0.00
0.000
0.000
0.00
5A
200
586
2.70
2.70
0.400
0.000
3.10
-58
200
584
2.68
2.68
0.400
0.000
3.08
6A
200
643
2.95
2.95
0.400
0.000
3.35
6B
200
639
2.93
2.93
0.400
0.000
3.33
7A
132
687
2.08
2.08
0.210
0.000
2.29
7B
129
466
1.38
1.38
0.210
0.000
1.59
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0-00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0270
0.00
0
0
0.00
0.00
0.000
0.270
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.270
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
O.oO
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
' 0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
Total Acres
36.46
Page 1

Well w/100'
offset
Halfmoon Farm
Scale: 1 "= 300'
002919
IFS 1 GN�Q'
iN
12/22/2004

MurphrBrown, LLC 1/5/2005 2822 Hwy 24 West
- P.O. Box 856
- F Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s): Maser aifmMoy 9
Farm Name: Hoon Pi
County: Greene
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder 6960
Feeder to Finish
Storage Period: >180 days
Application Method: Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water andlor groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
„n+n Hv u,acta on Cat! rated sof 1s whe-n it s rainlnn or when the surface is frozen.
,:.,.r..-m.,....,-„- ., �..:,,.-- ;•.:-,Y.���: ��..:::.rt , a t.=.. i',-� �J.v 1
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flebble so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, fe, tons, etc.):
Capacity T Waste P uaed r Animal Total
Farrow to Wean
3212 gal/yr
galyr
Farrow to Feeder
4015 gal/yr
galyr
Farrow to Finish
10585 galtyr
gal/yr
6960
Wean to Feeder
223 gallyr
1,552,080 gallyr
Feeder to Finish
986 gaiyr
gallyr
Total 1,552,080 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity DT2Nitrogen Produced per Animal Total
Farrow to Wean
5.4 Ibs/yr
lbs/yr
Farrow to Feeder
5.5 IWO
Ibs/yr
Farrow to Finish
26 Ibsfyr
Ibsyr
6960
Wean to Feeder
0.48 Ibs/yr
3,341 lbslyr
Feeder to Finish
2.3 Ibs/yr
I Ibsyr
Total 3,341 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this fadlity
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage:
36.46
Total N Required 1st Year:
4536.79
Total N Required 2nd Year:
0.00
Average Annual Nitrogen Requirement of Crops: 4,536.79
Total Nitrogen Produced by Farm: 3,340.80
Nitrogen Balance for Crops: (1,195.99)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utif¢ation of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

Haftoon Pigs
1/5/2006
Reception Area Specifications
MENEM
©EQi�®
EMDEN
3(e) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to out the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 lbs N / bushel
B
Hybrid Bermudagrass - Grazed
50 Ibs N / ton
C
Hybrid Bermudagrass - Hay
50 lbs; N / ton
D
Corn - Grain
1.25 lbs N / bushel
E
Corn - Silage
12 lbs N I ton
F
Cotton
0.12 lbs N I lbs; lint
G
Fescue - Grazed
50 lbs; N / ton
H
Fescue - Hay
50 lbs N / ton
I
Oats
1.3 lbs N / bushel
J
Rye
2.4 lbs N I bushel
K
Small Grain - Grazed
50 lbs N / acre
L
Small Grain - Hay
50 lbs N I acre
M
Grain Sorghum
2.5 lbs N / cwt
N
Wheat
2.4 lbs N / bushel
4," i►.4 �.! r n��ahQl
P
Pine Trees
40 lbs N / acre I yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN/ rlanimal Farm Total/ r
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
6960 Wean to Feeder 0.072 501.12
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 501.12 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 2505.6 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid Bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 8 acreas of land. If you apply the sludge
to com at a rate of 125 pounds per acre, you will need 20.0448 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
if surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
'This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
r^tle4ior 7r.z r"xmrr rn
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
in/hr
' inches
T1454-4
'I
GoA
G
0.4
1�
T1454-4
2
GoA
G
0.4
1
T1454-4
2
GoA
B
0.4
1
T1454-4
3
GoA
B
0.4
1
T1454-2,3
4A
GoA
F
0.4
1
T1454-2,3
48
GoA
F
0.4
1
T1454-2,3
5A
GoA
F
0.4
1
T1454-2,3
5B
GoA
F
0.4
1
T1454-2,3
6A
GoA
F
0.4
1
T1454-2,3
6B
GoA
F
o.4
1
T1454-2,3
7A
GoA
F
0.4
1
T1454-2,3
7B
GoA
F
0.4
1
Optional
Crops
T1454-2,3 4A-78 GoA D 0.4 1
T1454-2,3 4A-76 GoA N 0.4 1
T1454-2,3 4A 7B GoA O 0.4 1
6 of 8

Additional Comments:
This plan revised to reflect wetted acreage due to a new irrigation system.
H drant 2 is half fescue and half bermuda. Producer may plant any optional_ __
crops instead of cotton if desried.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: Halfmoon Pigs
Owner: Moses Moye
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Moses Moye
Signature: bl1 - z:,
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist:
Signature:
M. Kevin Weston
Date
Date
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has
an agreement for use of adequate land on which to properly apply the waste. If the
producer does not own adequate land to properly dispose of the waste, he/she shall
provide evidence of an agreement with a landowner, who is within a reasonable
proximity, allowing him/her the use of the land for waste application. It is the
responsibility of the owner of the waste production facility to secure an update of the
Nutrient Utilization Plan when there is a change in the operation, increase in the number
of animals, method of application, recleving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based upon soil type, available moisture, historical data, climatic conditions,
and level of management, unless there are regulations that restrict the rate of
applications for other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10
tons per acre per year provided grass liter strips are installed where runoff leaves the
field (See USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
S When animal waste is to be applied on acres subject to flooding, waste will be soil
i �+Q� rtr+tir��t'x+na4lsr t911aral-�nla+rrd, l��lren.,�„�a ie rr�!?�r1 R�r_. rnnacnr�+9,.n
a��. � �+�...��€:.- .rP--�.ra,- �-,�,.,.,=r'-���: �..-�zF•ck.i: x � ,.:...:-..5:_,.,.;.::..tw_- �=z:a.:a.as.:t::+�..
tilled crops or grassland, the waste may be broadcast provided the application does not
occur during a season prone to flooding (See "Weather and Climate in North Carolina"
for guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not cause
drift from the site during application. No ponding should occur in order to control odor
and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt
damage from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property
boundary and canal. Animal waste, other than swine waste from facilities sited on or after
October 1, 1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
speciailst". Animal waste - Simi riot be appiied of -grassed wdieiWays Ihaf d1sataige
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
18 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should
be kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for
direct human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the rate-
le GtGil Yll4 flY fib'FiaAl.lia.lit,"uiZli'i'":a:3'Ui114r'Iro1.:5l1 itiiiVllJ ivbcuF.�si2:'..�.�Gu �IIVal lt.l
nutrients, resulting in a lower application rate than a nitrogen based rate. Zinc and copper
levels in the soil shall be monitored and altemative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted and maintained for optimum
crop production. Soil and waste analysis records shall be kept for a minimum of five
years. Poultry dry waste application records shall be maintained for a minimum of three
years. Waste application records for all other waste shall be maintained for a minimum
of five years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3 of 3

.. Halfmo-on Farm
Well w/100,
offset
Scale: 1 "= 300'
/01029197-
DES 16:t�4�
IN
���2/22/2004

Sheetl
IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name: Moses W. Moye - Halfmoon Farm
Addres.�: 211 East Home Ave.
Farmville, NC 27828
Telephone: [phone]
Table 1 - Field Specifications
Approximate
Maximum
T1454 Useable Size
Field of Field
IW imhAr larrwcl Anil Tvne l Slnne % CMD/S)
County: Greene
Date: 12/22/2004
Maximum
Maximum
Application
Application
per Irrigation
Rate
Cycle
(in/hr)
finches) Comments
p� ^

Sheet2
TABLE 2 - Travelling Irrigation Gun Settings
F
Make, Model and Tyee of Equipment: ABI PT590 984 traveler w/ 3"x984' hose w/ Nelson 150
Field No. Travel Application TRAVEL LANE Wetted Nozzle Operating Operating
and Speed Rate Effective Effective Diameter Diameter Pressure Pressure Are
Hydrant No. (ft/min) fin/hr.) Width(ft.) Lenoth(ft) (feet) (inches) at Gun(psi) at reel{psi) Pattern Comments - Acres per pull
1
4.48
0.42
235
760
270
1.18
50
80
330
4.94
2
4.48
0.42
i 200
662
270
1.18
50
80
330
3.7e
3
6.23/4.48
.77/.42
i 10=35
62rJ30
270
1.18
50
8o
180r330
2.65
4A
4.48
0.42
235
556
270
1.16
5o
80
330
3.40
4B
8.2314.48
.771.42
;'; 141/235
3451839
270
1.18
so
80
180f330
4.97
5A
4.48
0.42
200
see
270
1.18
so
8o
330
3.10
5B
4.48
0.42
200
554
270
1.18
50
80
330
3.08
6A
4.48
0.42
' 200
643
270
1.18
so
8o
330
3.35
6B
4.48
0.42
200
639
270
1.1a
50
8o
330
3.33
7A
8.23
0.77
132
687
270
1.16
50
80
180
2.29
7B
8.23
o.77
129
486
270
1.18
5o
8o
180
1.59
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
Total
36.46

Sheet4
TABLE 4 - Irrigation System Specifications
Traveling
Solid Set
Irrigation Gun
Irrigation
Flow Rate of Sprinkler m ;
205
0
Operating Pressure at Pump (psi)
101.1
#DIV/01
Design Precipitation Rate in/hr
0.38
#DIV/01
Hose Length feet
984
XXXXXXXX
Type of Speed ome2nsation
Mechanical
XXXXXXXX
Pump lype PTO En Ine Electric i
En ]ne
Pump Power Requirement h
24.2
#DIV/01
TABLE 5 - Thrust Block Specifications:.
THRUST BLOCK
LOCATION
AREA a. ft.
90 degree bend
4.27
Dead End
3.03
Tee
2A2
Gate Valve
3.03
45 degree bend
2.30
Page 1

Sheets
IRRIGATION SYSTEM DESIGNER
Name: Micah :Kevin Weston, CID '•, ` }
Company: Mur,Y`-Brown, LLC 0 )�
Address: 2822 Hwy 24 West, PO Drawer 856 Warsaw, NC 28398
Phone: [phone] }" �
Required Documentation
The following details of design and materials must accompany all irrigation designs:
1. A scale drawing of the proposed Irrigation system which Includes hydrant locations, pipelines, thrust block locations and buffer areas where applicable.
2. Assumptions and computations for determining kctal dynamic head and horsepower requirements.
3. Computations used to determine all mainline and lateral pipe sizes.
4. Sources and/or calculations used for determining lapplication rates.
S. Computations used to determine the size of thrui t blocks and Illustrations of all thrust block configurations required In the system
6. Manufacturers specifications for the Irrigation pump, traveler and sprinkkrr(s).
7. Manufacturer's specifications for the irrigation pijia and/or USDA-NRCS standard for IRRIGATION WATER CONVEYANCE.
8. The Information required by this form are the minimum requirements. It Is the responsibility of the designer to consider all relevant factors at a particular site and
address them as appropriate.
9. Irrigation pipes should not be Installed In lagoon or storage pond embankments without the approval of the designer.
NOTE: A buffer strip of 26 or wider must be maintained between the limits of the irrigation system and all
perennial streams and surface water. per NC Statutes.

SheetB
Narrative of Irrigation System Operation
Design And Installation Overview
This design is for an existing facility. This irrigation system is designed with four inch, Class 200 PVC gasket pipe and
schedule 80 fitttings. The system is designed to accommodate the flow velocities, flow rates and pressure requirements
associated with an ABI PT590 984 traveler. Air vents and thrust blocks are to be Installed as indicated on the drawings. Ai
vents will consist of using a 4" x 2" saddle with a 2" galvanized threaded pipe and an AV 160. The thrust block areas have
been calculated and are listad In Table 4 of this design. The design of the traveler system requires the use of a 1.18" ring
nozzle In the gun. Each pull has a specific arc setting and travel speed which must be used to achieve the desired
application. This information Is given in Table 2 of this design. A detail of the hydrant layout is also Included and specifies
the type and size of fittings. All pipe shall be installed with a minimum of 30" of cover and shall be backfilled in no less
than three passes, leaving anough soil material above original grade to allow for settling. All ditch crossings shall cross at
a minimum of 24" below this, bottom of the ditch or shall be encased in a 8" x 20' Class 200 PVC pipe. The suction
assembly for the pump to 64 used is 8" alluminum. A pressure gauge should be installed on the discharge side of the
pump where it can be seenduring start up of the system.
System Start-up And Operation
When setting up the reel, make sure it Is level. and the stabilizer legs are down and secured. Engage the brake, then
disengage the transmission) Pull out the hose at a speed not to exceed 3 mph. Engage the transmission before
disengaging the brake. Prirrie the pump and start the motor. Set all "Murphy" safety switches to Insure Immediate shut
down of the system if a pro§ iem occurs. Also, set the timer to shut off the pump at the time a run will be completed. Check
all safety switches on the r6el after each start-up to ensure proper operation. Read and review the manufacturers operator
manuals for additional details on start-up procedures. Grower should walk the entire pipeline periodically to check for
leaks and other potential problems.
Winterization And Maintenance
Disconnect both ends of all: flexible hoses at the traveler. Remove the drain plug from the gun cart and pull out the hose at
least half way to purge enough water to protect from freezing. Wind the hose back onto the reel and replace the drain
plug. Read and review the manufacturers operator manuals for additional details on winterization and maintenance
procedures.

Sheet?
CALCULATIONS
Sprinkler Specifications
Sprinkler Type: Nelson 160
Nozzle Size:
1.18 inches
Sprinkler Pressure:
50 psi
Flowrate(GPM):
205 gpm
Wetted Diameter.
270 feet *Reflects 10% reduction from chart.
Lane Spacings
Desired Spacing (%):
70 %
Design Spacing(feet):
189 "PVC irrigation pipe normally comes in 20' pieces,
so round to the nearest multiple of 20.
Actual Spacing (feet):
200 feet
Actual Spacing (%):
74 %
Application Rate
Application Rate =(96.3x>`lowrate)1(3.1415x(.9xradlus)squared)
Design App. Rate =
0.38 inthr 360 degree arc = 0.38 in/hr
300 degree arc =
0.46 in/hr 330 degree arc = 0.42 in/hr
220 degree arc =
0.63 in/hr
180 degree arc =
0.77 in/hr
Traveftr Seed
Travel speed = 1.605 x Flowrate 1 Desired application amount x Lane Spacing
Desired app. (n.) =
0.4 inches 360 degree arc = 4.11 ft/min
300 degree are =
4.94 ft/min 330 degree arc = 4.48 ft/min
220 degree arc =
6.58 ft/min
180 degree are =
8.23 ft/min
Mainline Velocity
VCIV[illr .}UO J` 1'IVw14CjtG t FrI uirnoini
**For buried pipelines, velocity should be below 5 feet per second
Pipe size:
4 inches
Velocity=
5.23 ft/sec.
Page 1

Sheet?
Maximum Mainline F ction Lofil
Most distant hydrant: 7
Total distance: 1290 feet
Friction Loss is figured using Hazenufflifilliam's Equation
Friction Loss-- 2.18 feet/100 feet
Max. Mainline Loss = 28.1 feet or 12.2 psi
Total Dynamic Head
Sprinkler Pressure:
50 psi
Loss through traveller.
30 psi
Elevation head:
2.1 psi
Mainline loss:
12.2 psi
Suction head and lift:
2 psi
5% fitting loss:
4.8 psi
TOTAL(TDH) =
101.1 psi or 233.5 feet
Horsepower Reguised
Horsepower = Fiowrate x TDH(feet) / 3960 / Pump effeciency
Pump Description: Berkeley B3JQBM
Pump Efficiency: 50 %
Horsepower Required: 24.2 Hp
Thrust Blockino
Thrust Block Area = Thrust / Soil Bearing Strength
Thrust: 36630 feet
Soil Bearing Strength: 1200 feet
End Cap: 3.0 ft2
90 degree elbow: 4.3 ft2
45 degree elbow: 2.3 ft2
Pine Pressure Rating Check
Pressure Rating of Pipe to be Used: 200 psi
Max. Pressure on system when running: 101.1 psi
70% of Pressure Rating: 140 psi
If Max. Pressure on system is less than 70% of Pressure Rating, OK
Page 2

Sheet8 (2)
Halfmoon Farm
Acreage Calculations
Width
Length
Acres
Total Acres
Start End
Stop End
Total
Pull #
S-
LU
(midsection)
f9c.1
iml
I
Pull Acres
1
235
780
4.21
4.21
0.400
0.330
4.94
2
200
662
3.04
3.04
0.400
0.320
3.76
3
100
62
0.14
1.92
0.400
0.330
2.65
235
330
1.78
0.00
0.000
0.000
0.00
4A
235
556
3.00
3.00
0.400
0.000
3.40
4B
141
345
1.12
4.57
0.400
0.000
4.97
235
639
3.45
0.00
0.000
0.000
0.00
5A
200
588
2.70
2.70
0.400
0.000
3.10
58
200
564
2.68
2.68
0.400
0.000
3.08
6A
200
643
2.95
2.95
0.400
0.000
3.35
6B
200
639
2.93
2.93
0.400
0.000
3.33
7A
132
687
2.08
2.08
0.210
O.ODO
2.29
7B
129
466
1.38
1.38
0.210
0.000
1.59
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0270
0.00
0
0
0.00
0.00
0.000
0.270
0.00
D
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0270
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.D0
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.D0
0.000
0.000
0.00
0
0
0.00
0.00
0.ODO
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
D
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
0.00
0
0
0.00
0.00
0.000
0.000
D.OD
0
0
0.00
0.00
D.000
0.000
0.00
0
D
0.00
0.00
0.000
0.000
0.00
Total Acres
36.46
Page 1

e 1 p
Well w/100'
offset
Halfmoon Farm
Scale: 1 "=300'
/ ' 7
- 2/22/2004

W'gr�RQ
Michael F. Easley, Governor
�QF
William
G. Ross Jr., Secretary
C/J 7
North Carolina Department of Environment and Natural Resources
Coleco H. Sullins Director
Division of Water Quality
August 11, 2008
Moses Moye
Halfmoon Pigs
PO Box 759
Rose Hill, NC 28458
Subject: Sludge Compliance Requirement Change
Dear Peimittee:
In accordance with Condition II1.19 of State General Permit AWG100000, your facility is
required to maintain compliance regarding sludge accumulation in your animal waste treatment
lagoon(s). As you know, the previous compliance limit was to have a minimum of four (4) feet
of treatment depth between the designed stop pump and the average elevation of the top of the
sludge blanket. This requirement was based on NRCS Standard No. 359, which was recently
modified.
As of July 2008, Standard No. 359 does not use the 4-foot requirement. Sludge compliance is
now to be based on the sludge volume as a percentage of the total treatment volume. The revised
Standard states that sludge accumulation in the permanent treatment zone must be less than 50%
of the planned treatment volume. Also, there must be a minimum of 2.5 feet of liquid above the
sludge at the pump intake location. If either of these conditions is not met then sludge must be
removed or managed in accordance with an approved Plan of Action for Lagoon Sludge
Reduction (POA). A new sludge survey worksheet has been developed to calculate sludge and
treatment volumes to determine compliance.
Our records indicate that you have filed a Sludge POA for one or more of the lagoons at your
facility. Based on the changes to the sludge requirements in Standard No. 359, your lagoon(s)
may already be in compliance without any sludge removal. Using your lagoon design (or as -
built information) and current sludge survey measurements, complete the NEW. -sludge .survey
worksheet. If you have any difficulty in locating or understanding your'lagoon design'�-.-5,'- ' _
information, please contact your technical specialist or county Soil & Water offs"
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636
Internet: www.ncwatggualitv.ore Location: 2728 Capital Boulevard Raleigh, NC 27604
AUG
1 3 2008 !_
VVIA l- INGTON RE.C11O NALOOFFICE
D1. O NorthCarolina
Telephone:-
[phone]
Fax 1:
[phone]
Fax 2:
[phone]
An Equal Opportunity/Affirmative Adon Employer— 50% Recycled110% Post Consumer Paper

Send both sludge survey worksheets, OLD and NEW, to the address below if you feel that your
lagoon(s) is in compliance and wish to withdraw your POA. Our staff will review the
information and notify you of our decision.
NCDENR — DWQ Animal Feeding Operations Unit
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
If you have any questions about the new sludge requirement, sludge survey worksheet, or any
related matter please feel free to contact the Animal Feeding Operations Unit staff at 919-733-
3221.
Sincerely,
Keith Larick, Supervisor
Animal Feeding Operations Unit
Enclosures
cc (w/o enclosures): Greene County Soil and Water Conservation District
Washington Regional Office, Aquifer Protection Section
AFO Unit Central Files - AWS400148

O� \NA7FR Michael F. Easley, Governor
Q William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
j Alan W. Klimek, P. E., Director
Division of Water Quality
October 1, 2004
Moses Moye
Halfmoon Pigs
PO Box 759
Rose Hill NC 28448
Subject: Certificate of Coverage No. AWS400148
Halfmoon Pigs
Swine Waste Collection, Treatment,
Storage and Application System
Greene County
Dear Moses Moye:
On June 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on February 13, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Moses
Moye, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS400148 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Halfmoon Pigs, located in Greene County, with an animal capacity of no greater
than an annual average of 6960 Wean to Feeder swine and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to
Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may
be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4
gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this permit.
Aquifer Protection Section —Animal Feeding Operations Unit
1636 Mail Service Center Raleigh North Carolina 27699-1638
Vierr ;? F
I�ti iir, }i
1
"'• i : OCT 1 5 2004 ,
one
A Northuarolxna
Phone: [phone] FAX [phone]ntemet: h2o,enr.state,nc.u5 i' y:"y1N.�`r•'' �' r' '`" �rrEV,.atura!!r�
An Equal Opportunity/Afinnative Action Employer — 50% Recycled/10% Post Consumer Paper.

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any Iagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Washington Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone].
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Washington Regional Office, Aquifer Protection Section
Greene County Health Department
Greene County Soil and Water Conservation District
Permit File AWS400148
APS Central Files

O� W A rE: Michael F. Easley, Governor
Q William G_ Ross Jr., Secretary
O G North Carolina Department of Environment and Natural Resources
�_
j Alan W. Klimek, P. E., Director
`f Division of Water Quality
O `C
Moses Moye
Halfmoon Pigs
PO Box 759
Rose Hill NC 28448
May 1, 2003
Subject: Certificate of Coverage No. AWS400148
Halfmoon Pigs
Swine Waste Collection, Treatment,
Storage and Application System
Greene County
Dear Moses Moye:
On April 287 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
_.. _--------Division of Water Quality (Division) to extend the expiration date of the Swine Waste OperationGeneral
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on February 13, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Moses
Moye, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS400148 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Halfmoon Pigs, located in Greene County, with an animal capacity of no greater
than an annual average of 6960 Wean to Feeder swine and the application- to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to
Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may
be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4
gilts for every 3 sows
The COC shall be effective from the date of issuance until October -1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization PIan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property. WL
N�' L1iE1r i R.
Non -Discharge Permitting Unit Internet http:/lh2o.enr.state.nc.us/ndpu
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] Fax [phone]
Customer Service Center Telephone [phone]
An Equal Opportunity Action Employer 50% recycled/10% post -consumer paper

Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified. in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, crinvnal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Washington Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you -need additional -information -concerning
this COC or the General Permit, please contact Michelle Barnett at [phone] ext. 544.
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Washington Regional Office, Water Quality Section
Greene County Health Department
Greene County Soil and Water Conservation District
Permit File AWS400148
NDPU Files

PRODUCER: Moses Moye
Halfmoon Pigs
LOCATION: 211 E. Home Ae.
Fanmville, NC 27828
TELEPHONE:
TYPE OPERATION: wean - feeder
NUMBER OF ANIMALS: 6960
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste
should be analyzed before each application cycle. Annual soil tests are strongly encouraged
so that all plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important In Implementing your waste utilization plan in order to maximize
Me fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste'. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when
it is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems_ To maximize the value of nutrients for
crop production and to " reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 2H.0217 adopted by the Environmental Management Commission.
Page 1

AAr gMnt of Mstg Payceq Per Year (gallons. ft. tons, ei0,)
0,960 animals X M. (tons) waste/animaVyear Y
Amount of Plant Available Nitrogen (PAN) Produced Per Year
6,960 animals X 0.48 lbs. PAN/animal/year
Guide Std. 633) -
2,923 (tons) waste/year.
3,341 Ibs. PAN/year. (PAN from N.C.
Tech
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field" Soil Crop Lbs. N Acres Lbs. N Month of
# No. Trtoe Per Acre Utilized Awlication
T1454
2
GoA
Cotton
84
7.00
588
April - Au ust
T1454
3
GoA
Cotton
84
15.00
1260
April - A ust
T1454
4
NoA
Fescue G
130
2.60
338
Sept. - August
T1454
4
GoA
Fescue G
160
3.00
480
Sept. - August
T1454
4
GoA
Bermuda G
245
4.70
1151.5
March - Sept,
T1464
4
GoA
Small Grain
50
4.70
235
Sept. - April
T1454
4
GoA
Cotton
84
11.00
924
April - A ust
0
0
4
0
0
Total 43.30L 4,976.50
*fills N is from animal waste only. If nutrients from other sources such as commercial f Wilzer are
applied, they must be accounted for. N MM be &pe
A 2M LwIlstIc IftLd
NOTE: The applicator Is cautioned that P and K may be over applied while meeting the N
requirements: Beginning in 1996 the Coasts! Zone Management Act will require farmers in some
eastwn counties of North Caroline to have a nutrient management plan that addeesses all nuirlientt
This plan only addresses Nitrvgen.
Page 2

Table 2. ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only If operator does not own adequate land
[see Required Specification 21j
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
" See footnote for Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table f 43.30 4,077
Table 2 0.00 -
Total 43.30 4,977
Amount of N Produced 3,341
Surplus or Deficit (1,636)
NOTE. The Waste Ublizedon Plan must cmdain provisions for periodic land application of sludge at
egronon* rates. The sludge will be nutrienf rich and wift require precautionary measures to prevent over
application of nutrient or odmr elements.
Page 3

See attached map showing the fields to be used for the udNzatfon of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate (IniHr) Amount (in.)
2,3,4
GoA
Cotton
0.4
.5-1
4
NoA
Fescue
0.5
.5-1
4
GoA
Bermuda
0.5
.5-1
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE WILL
BE NEEDED FOR DRY UTTER OR SLURRY.
Your facility is designed for 1160 days of temporary storage and the temporary storage must
be removed on the average of once every 6 MONTHS. In no instance should the volume of
waste being stored in your structure exceed Elevation *see lagoon design.
Cali the local Natural Resources Conservation Service (formerly Soil Conservm on Servke) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the
waste.
Nanatinre of opera an: G2C fi 0 F C-0
This plan revises a plan prepared b . MRCS in 1099 to show a conversion from
sows to a nurse o ration. '
Page 4

REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has
an agreement for use of adequate land on which to properly apply the waste. If the
producer does not own adequate land to property dispose of waste, he/she shall provide
a copy of an agreement with a landowner who is within a reasonable proximity, allowing
him/her the use of the land for waste application. It is the responsibility of the owner of
the facility to secure an update of the Waste Utilization Plan when there is a change in
the operation, Increase in the number of animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based on soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of application for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that Is eroding at 5 or more tons, but less than 16 tons per acre
per year providing grass filter strips are installed where runoff leaves the field. (See
FOTG Standard 393 - Filter Strip).
5 Odors can be reduced by Injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservation tilled crops
or grassland, the waste may be broadcast provided the application does not occur during
a season prone to flooding. (See "Weather and Climate In North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offshe or to surface waters and in a method which does not cause
drift from the site during application. No ponding should occur in order to control odor or
flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface Is frozen.
Page 5

REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt
damage from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held
to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste Is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property
boundary and from any perennial stream or river (other than an irrigation ditch or canal.
Animal waste other than swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters. (See Standard 393 - Filter
Strips).
12
13
14
1s
16
Animal waste shall not be applied closer than 100 feet to wells.
Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
Waste shall be applied in a manner not to reach other property and public right-of-ways.
Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that courses no runoff or drift from the site.
Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18 1f animal production at the facility Is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should
be kept on site.
20 Animal waste can be used In a rotation that Includes vegetables and other crops for
direct human consumption. However, If animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
magic the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 80 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the rate -
determining element. Zinc and copper levels in the soil shall be monitored and
alternative crop sites shall be used when these metal approach excessive levels. pH
shall be adjusted for optimum crop production and maintained. Soil and waste analysis
records shall be kept for five years. Poultry dry waste application records shall be
maintained for three (3) years. Waste application records for all other waste shall be
maintained for five (5) years.
23 Bead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

WASTE UTILIZATIQN PLAN gREEMENT
Name of Farm: Hallmoon Pigs ^T_
Owner / Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before
the new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the
farm office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner: Moses Moye
{please PdhV �.
Signature: %� c� i•e Date:
F
Name of Manager (If different from owner):
Signature:
Date:
Name of Technical Specialist: (F%asep,&Q Kraig A. Westerbeek
Affiliation: Murphyfamily Farms
Address (Agency): P.O. Box 759
Rose Hill. NC
Signature:
Page 8

o��� war�9pc
e
Michael F. Easley, k
William G. Ross Jr., Se �.
North Carolina Department of Environment and Natural Res
3: DIG—)
m
p Alan W. Klimek, P.E., - Di �`
Division of Water Quas. e Q,
August 2, 2002
Moses Moye
Halfmoon Pigs
211 E. Horne Ave
Farmville NC 27828
Subject: Certificate of Coverage No- AWS400148
Halfmoon Pigs
Swine Waste Collection, Treatment,
Storage and Application System
Greene County
Dear Moses Moye:
In accordance with your application received on July 16, 2002, we are forwarding this Certificate of
Coverage (COC) issued to Moses Moye, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG100000- This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the Halfmoon Pigs, located in Greene County, with an animal
capacity of no greater than 6960 Wean to Feeder and the application to land as specified in the Certified
Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003 and shall hereby void COC
Number AWS400148 dated January 28, 2000. Pursuant to this COC, you are authorized and required to
operate the system in conformity with the conditions and limitations as specified in the General Permit,
the facility's CAWMP, and this COC, with no discharge of wastes to surface waters. An adequate
system for collecting and maintaining the required monitoring data and operational information must be
established for this farm. Any increase in waste production greater than the certified design capacity or
increase in number of stocked animals above the number authorized by this COC will require a
modification to the CAWMP and this COC and shall be completed prior to actual increase in either
wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
The facility's CAWMP meets all requirements in place at the time of certification. However, it appears
that the irrigation system on site may not adequately cover all acreage listed in the Waste Utilization Plan.
The owner should begin to address this inconsistency as soon as possible.
Non -Discharge Permitting Unit Internet httpJ/h2o.enr.nc.state.us/ndpu RMENOR
1617 Mail Service Center, Raleigh, NC 27699-1617 'telephone [phone] Fax (919) 71 5-W48
DENR Customer Service Center telephone [phone]
An Equal Opportunity Action Employer 50% recycled110% post -consumer paper �

Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Washington Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Michelle Barnett [phone] ext. 544.
Sincerely,
W. Klimek, P.E:
cc: (Certificate of Coverage only for all cc's)
Greene County Health Department
Washington Regional Office, Water Quality Section
Greene County Soil and Water Conservation District
Water Quality Central Files
NDPU Files
Dim
EI'E
AUG 0 Q 2002
DWQ-WARD

FACILITY NUMBER - REVIEWER:�_�'.o—
FARM NAME:, DATE:
car 4 :tF& j R -> - oz
TYPE
NUMBER
SSLW Cff
SSLW-
# Cff
# ANIMALS
Farrow/Wean
' sow
433
2.5
- -
Farrow/Feeder
sow
522
Z ON5 pp
_ 4.
Farrow/Finish
sow
1417 `'
10
Wean/Feeder
is q lv O head
30 =
ODE gpv
1
Feeder/Finish
head
135
1
Gilt Developer
head
150
-
1
Boar Stud
head
400 -
1
TOTALS
XXXXXXXXXXXX
XXXXXXXX
XXXXX
COMMENTS:

CAWMP Components
Completed Certification Form; DATE:
- = Site schematics= - -�
�e5'tte evafuation,after2196;.(NRCS NCCPA_=9_.7)iricludes wet[ands determination
.. - Hazard classification - _ �. „
Show design needs,(storage) _
-- ' Construction inspection notes, including Iiner inspection &-observation trench (after 9/1/96}
Consideration -for emergency spillway (after.6121/96):^ r_
Land application:max. usable field size, max. application rate,. Max. application rate per."'
cycle (effective prior to 911/96); system type: -- -_ . _ ___ _.. _ . -plus
equipment type, system layout, and settings after 9/1/96 W_
NRCS-irrigation parameters (effective 911/96) or calibration iriformatiion~
Existence of Operation & Maintenance Plan
Existence of Waste Utilization Plan
Amount of plant available nitrogen produced/used annually ( Ibs)
Dominant soil series: - - -
Crops to be grown: r .
Present day foimat WRYES or actual records; application windows 2/1/93;
Stnd. #633 required specifications
REQUIRED RECORDS effective 9/1/96
Waste application records (IRR 1&2)
Maps of spray fields
CAWMP on site -
Waste sample analysis
Annual soil sampling
Existence of Emergency Action Plan
RECOMMENDED
daily rain amounts
freeboard levels (weekly)
crop yields
animal population
Existence of an Odor Control Checklist effective 1/97
Existence of an Insect Control Checklist effective 1/97
Provision for dead animal disposal method effective 1/97
REMOVAL CONFIRMATION
Depopulated; date last operated:
Operating below threshold; animal #:
Pastured operation
Dry litter (poultry)
Freeboard measurements:

�OF WATE9p Michael F. Easley, Governor
dr William G. Ross Jr., Secretary
r North Carolina Department of Environment and Natural Resources
p -r Alan W. Klimek, P.E., Director
Division of Water Quality
August 2, 2002
Moses Moye
Halfmoon Pigs
211 E. Horne Ave
Farmville NC 27828
Subject: Certificate of Coverage No. AWS400148
Halfmoon Pigs
Swine Waste Collection, Treatment,
Storage and Application System
Greene County
Dear Moses Moye:
In accordance with your application received on July 16, 2002, we are forwarding this Certificate of
Coverage (COC) issued to Moses Moye, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG100000_ This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the Halfmoon Pigs, located in Greene County, with an animal
capacity of no greater than 6960 Wean to Feeder and the application to land as specified in the Certified
Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003 and shall hereby void COC
Number AWS400148 dated January 28, 2000. Pursuant to this COC, you are authorized and required to
operate the system in conformity with the conditions and limitations as specified in the General Permit,
the facility's CAWMP, and this COC, with no discharge of wastes to surface waters. An adequate
system for collecting and maintaining the required monitoring data and operational information must be
established for this farm. Any increase in waste production greater than the certified design capacity or
increase in number of stocked animals above the number authorized by this COC will require a
modification to the CAWMP and this COC and shall be completed prior to actual increase in either
wastewater flow or number of animals_
Please be advised that any violation of the terns and. conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
The facility's CAWMP meets all requirements in place at the time of certification. However, it appears
that the irrigation system on site may not adequately cover all acreage listed in the Waste Utilization Plan.
The owner should begin to address this inconsistency as soon as possible.
Nan -Discharge Permitting Unit Internet httpl/t►20.enr.nc_state.us/ndpu
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] Fax [phone]
DENR Customer Service Center Telephone [phone]
An Equal Opportunity Action Employer 50% recycled/10% post -consumer paper

Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division. r ''
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Washington Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Michelle Barnett [phone] ext. 544.
Sincerely,
W. Klimek, P.E:
cc_ (Certificate of Coverage only for all cc's)
Greene County Health Department
Washington Regional Office, Water Quality Section
Greene County Soil and Water Conservation District
Water Quality Central Files
NDPU Files
AUG 0 8 2002
OWQ-WARO

Animal Waste Management Plan Certification
r (Please type or print all information that does not require a signature)
iExistina) or New or- Expanded (please circle one) i
General Information:
Name of Farm: Hal#moon Pigs Facility No: 40-148
Owner(s) Name: Moses Moe Phone No:
Mailing Address: 211 E. Horne Ave. Farmville, NC 27828
Farm Location: County Farm is located in: Greene
Latitude and Longitude: 35 29 55 / 77 32 47 Integrator. Murphy
Please attach a copy of a county road map with location identified and described below (Be specific: road
names, directions, milepost, etc.): From Snow Hill take 248/13 N about 3 miles, turn off on 903
Go through Maury and at the next crossroads (Ormonsv ille), turn left and go approx. 1 mile. Turn left at Halfmoon
Pig sign, go down path about 1 mile.
Operation Description:
Type of Swine No_ of Animals Type of Poultry Na of Animals Type of Cattle Na of Animals
© Wean to Feeder Gib ❑ Dyer ❑ Dairy
❑ Feeder to Finish ❑ Pullets ❑ Beef
❑ Farrow to Wean
❑ Farrow to Feeder
[] Farrow to Finish
0Gift
❑ Boars
irpandmg Operation ORIy r :ra'c r
> t>� Addition al Design capacity - r�n pacify
= F
Acreage Available for Application: 98.7 Required Acreage:
50.5
Number of Lagoons / Storage Ponds: 3 Total Capacity: 475095 Cubic Feet (ft3)
Are subsurface drains present on the farm: _ lies ' ) hr No (please circle one)
If YES. are subsurface drains present in the area of the LAGOON cr �YFIELDease circle one)
Owner / Manager Agreement --
1 (we) verify that all the above information is correct and will be updated upon changing. I (we) understand the operation and
maintenance procedures established in the approved animal waste management plan for the farm named above and will
implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and storage
system or construction of new facilities will require a new cerfihcation to be submitted to the Division of Environmental
Management before the new animals are stocked. l (we) understand that there must be no discharge of animal waste from the
storage or application system to surface waters of the state either directly through a man-made conveyance or from a storm event
less severe than the 25 - year, 24 - hour storm and there must not be run-o€f, from the application of animal waste. I (we)
understand that run-off of pollutants from lounging and heavy use areas must be minimized using technical standards developed
by the Natural Resources Conservation Service. The approved plan will be fled at the farm and at the office of the local Soil and
Water Conservation District. I (we) know that any modific�tion must be approved by a technical specialist and submitted to the
Soil and Water Conservation District prior to implementation. A change in land ownership requires written notification to DEM or a
new certification (if the approved plan is changed) within 60 days of a title transfer.
Name of Land Owner: Moses Moye
Signature: )� �� r ., 7 - Date:
Name of Manager (if different from owner):
Signature: Date
AWC -- August 1, 1997

Technical Specialist Certification
L As a technical specialist designated by the North Carolina Soil and Water Conservation Commission
pursuant to 15A NCAC 6F .0005. 1 certify that the animal waste management system for this farm named
above has an animal waste management plan that meets or exceeds standards and specifications of the
Division of Environmental Management (DEM) as specified in 15A NCAC 21-1.201 and the USDA -Natural
Resources Conservation Service (MRCS) and/or the North Carolina Soil and Water Conservation
Commission pursuant to 15A NCAC 2H.0217 and 15A NCAC 6F .0001.0005. The following elements are
included in the plan as applicable. While each category designates a technical specialist who may sign
each certification (SD, SI, WUP, RC, 1), the technical specialist should only certify parts for which they are
technically competent.
1L Certification of Design
A) Collection. Storage, Treatment System
Check the appropriate box
© Existing facility without retrofit (SD or WUP)
Storage volume is adequate for operation capacity: storage capability consistent with waste
utilization requirements.
* lagoon was retrofitted in Nov. 1997 and certified by W.E. Turnage
ED New, expanded or retrofitted facility (SD)
Animal waste storage and treatment structures, such as but not limited to collection systems,
lagoons and ponds, have been designed to meet or exceed the minimum standards and
specifications.
Name of Technical Specialist (Please P ' i A. Westerbeek
Affiliation Murphy FamilyFarms Date We Completed: )j j j 1
Address (Agenc .O 5 2 Phone No. 19910) 289-2111
Signature: ate: ` 4)1Q DIF
-
B) Land ADdication a (WUP)
e plan provides for minimum separations (buffers); adequate amount of land for waste
ilizatio ,chosen crop is suitable for waste management hydraulic and nutrient loading rates.
Name of Technical Specialist (Please nt): Kraig A. Westerbeek
Affiliation Murphy Date Work Completed:
Address (A e P ox tose Hill Phone No. [phone]
Signature: l 0 3•
C) Runo ntrolsiom Exterior Lots
Check the 14luiaft b
© t Facith without exterior lots (SD or WUP or RC)
Thi44acility does not contain any exterior lots.
0 Faci{itv with exterior lots (RC-)
Metheds to minimize the run off of pollutants from lounging and heavy use areas have been
designed in accordance with technical standards developed by NRCS_
Name of Technical Specialist
Affiliation Murphy FamilV FarpV
Address (Agee O. o
Signature:
A. Westerbeek
Work Completed:
e No. 91 t) 289-2111
AWC — August 1, 199-1 2

D). Application and Handling Eguipment
'Check the,apprgpriate bar
© Existing or expanding facility with existing waste asVication eguipment (WUP or 1)
Animal waste application equipment specified in the plan has been either field calibrated or
evaluated in accordance with existing desigr• charts and tables and is able to apply waste as
necessary to accommodate the waste management plan: (existing application equipment can
cover the area required by the plan at rates not to exceed either the specked hydraulic or nutrient
loading rates. A schedule for timing of applications has been established; required buffers can be
maintained and calibration and adjustment guidance are contained as pan`, of the plan).
❑ New, expgrided or existing facifity without existing waste _application equipment for scrag
irrigation. (1)
Animal waste application equipment specified in the plan has' been designed to apply waste as
necessary to accommodate the waste management plan: (proposed application equipment can
cover the area required by the plan at rates not to exceed either the specked hydraulic or nutrient
loading rates; a schedule for timing of applications has been established: required buffers can be
maintained: calibration and adjustment guidance are contained as part of the plan).
0 New. expanded or existing facility without existing waste application equipment for land spreading
not using spray irrigation. (WUP or 1)
Animal waste application equipment specified in the plan has been selected to apply waste as
necessary to accommodate the waste management plan: (proposed application equipment can
cover the area required by the plan at rates not to exceed either the specked hydraulic or nutrient
loading rates: a schedule for tiriiing of applications has been established; required buffers can be
maintained: calibration and adjustment guidance are contained as a part of the plan).
Name of Technical Specialist (Please
Affiliation Murohv Family Farms
Signature.,
E)
p0" Kraig A. Westerbeek
Date Work Completed:
28458 Phone No. t;910) 289-2111
T waste nagernerrt plan for this facility includes a Waste Management Odor Control
C e:klist, Insect Control Checklist, a.Mortality Management Checklist and an Emergency
coon Pt
. Sources of both odors and insects have been evaluated with respect to this site and
Best Man Bement Practices to Minimize Odors and Best Management Practices to Control Insects
have bee selected and included in the waste management plan. Both the Mortality Management
Plan and the Emergency Action Plan are complete and can be implemented by this facility.
Name of Technical Specialist (Please
Affiliation Murphy_�2rnily Farms
Address (AO
A 759 os
Signature:
9
Kraig A. Westerbeek
Date Work Completed:
Phone No. 910 289-211
Date: Q y
Phe foiloyfrig signature block is only to be used for new or expanding swine farms that begin
consbuctjbn after June 21, 1996. If the facility was built before June 21, 1996, when was it
can or cast expanded
1 (we) that 1 (we) have attempted to contact by cestfiied mail all adjoining property owners
and all property owners who own property located across a public road, street or highway from
this new or expanding swine farm. The notice was in compliance with the requirements of NCGS
146-805_ A copy of the nof►ce and a list of property owners notified is attached.
Name of Land Owner.
Signature: Date:
Name of Manager (f different from owner):
k1uWtigust 1, 1997 .3 ,.__,. Date

111. Certification of Installation
A) Collection Storage, Treatment Installation
New, expanded or retrofitted facility (SI)
Animal waste storage and treatment structures, such as but not limited to lagoons and ponds,
have been installed in accordance with the approved plan to meet or exceed the minimum
standards and specifications.
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation Date Work Completed:
Address (Agency): Phone No.:
Signature: Date:
B) Land Application_ Site (MP)
Check the appropriate box
© The cropping system is in place on all land as speed in the animal waste management plan.
0 Conditional Approval: all required land as specified in the plan is cleared for planting: the
cropping system as specked in the waste utilization plan has not been established and the owner
has committed to establish the vegetation as specked in the plan by
(month/day/year); the proposed cover crap is appropriate for compliance with the waste utilization
plan.
ED Also check this box if appropriate
if the cropping system as speed in the plan can not be established on newly
cleared land within 30 days of this certification, the owner has committed to establish
an interim crop for erosion control:
Name of Technical Specialist (Please Print): Kraig A. Westerbeek
Affiliation Murphy FamilyElffiris Date Work Completed: Cp
Address (A P.O 759, Rase 58 Phone No. 919) 289-2111
Signature: e: lZ O
1.
This follo 'ng sig tune block is only to be used when the box for conditional approval in III.
B above as been pecked.
I (we) certify that I (we) have committed to establish the cropping system as specified in my (our) waste
utilization plan, and if appropriate to establish the interim crop for erosion control, and will submit to DEM a
verification of completion from a Technical Specialist within 15 calendar days following the date specified in
the conditional certification. I (we) realize that failure to submit this verification is a violation of the waste
management plan and will subject me (us) to an enforcement action from DEW
Name of Land Owner.
Signature: Date:
Name of Manager (if different from owner);
Signature: Date
AWC — AugR 1, 1997_- . ... _...

C) Runoff Controls from Exterior Lots (RC)
Facility with exterior lots
Methods to minimize the run oft of pollutants from lounging and heavy use area have been
installed as specified in the plan.
For facilities without exterior lots, no cerf lcation is necessary.
Name of Technical Specialist (Please Print):
Affiliation Date Work Completed:
Address (Agency): Phone No.:
Signature: Date:
D) Application and Handling Equipment Installation (WUP or 1)
Chm* the appropriate black
© Animal waste application and handling equipment specified in the plan is on site and
ready for use, calibration and adjustment materials have been provided to the owners
and are contained as part of the plan.
[] Animal waste application and handling equipment specified in the plan has not been
installed but the owner has produced leasing or third party application and has
provided a signed contract: equipment specified in the contract agrees with the
requirements of the plan: required buffers can be maintained: calibration and
adjustment guidance have been provided to the owners and are continued as part of
the plan.
�] Conditional approval: Animal waste application and handling equipment specked
in the plan has been purchased and will be on site and installed by
(month/day/year); there is adequate storage to hold the waste until the equipment is
installed and until the waste can be land applied in accordance with the cropping
system contained in the plan; and calibration and adjustment guidance have been
provided to the owners and are contained as part of the plan.
Name of Technical Specialist (Please Print):
Affiliation Mu
Address (Age .O. x 9, Rose
Signature:
Kraig A. Westerbeek
Date Work Completed: / S
Phone No. 91 9 289-2111
The followi ignat block is only used when th box�or conditional approval in IH D
above ha n chec d.
I (we) certify I (we) ve committed to purchase the animal waste application and handling equipment as
specified in y (our) to management plan and will submit to OEM a verification of delivery and installation
from a Technical Spej6st within 15 days following the date specified in the conditional certification. I (we)
realize that failure to bmit this verification is a violation of the waste management plan and will subject me
(us) to an enforcernerit action from DEM.
Name of Land Owner.
Signature: Date:
Name of Manager (if different from owner):
Signature: Date
E) Odor Control, Insect Control and Mortality Management (SD, SI WUP RC or 1)
Methods to control odors and insects as specked in the Plan have been installed and are operational. The
mortality management system in the Plan has also been installed and is operational.
Name of Technical Specialist (Please Print):
Affiliation MurphyFa it
Address (Agen • O.13o 5 Rose Hi
Signature:
Kraig A. Westerbeek
-Date Work Completed:
_ hone No. 9102ag-211+1 -- '
AWC — Augusrl, 1997

Please return the completed form to the Division of Water Quality at the following
Address:
Department of Environment, Health, and Natural Resources
Division of Water Quality
Water Quality Section, Compliance Group
P.O. Box 29535
Raleiah. NC 27626-0536
Please remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a
copy in your files with your Animal Waste Management Plan.
AWC — August 1, 1997 6

PRODUCER:
Moses Moye
Halfmoon Pigs
LOCATION:
211 E. Home Ae.
Farmville, NC 27828
TELEPHONE:
1-5�-- 7S -3 =�
TYPE OPERATION:
wean - feeder
NUMBER OF ANIMALS: 6960
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste
should be analyzed before each application cycle. Annual soil tests are strongly encouraged
so that all plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste: Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per -acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when
it is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed ender DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maxdmize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance -with -15A -
NCAC 2H.0217 adopted by the Environmental Management Commission.
Page 1 --_ -- - 1

�� , � r'� ��� ' ` STE�u7`1L�AT�oN�P�, ��:��� �'� � �s
Amount of Waste Produced Per Year (gallons tons etc.)
6,960 animals X 0.42 (tons) waste/animal/year = 2,923 (tons) waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
6,960 animals X 0.48 lbs. PAN/animal/year = 3,341 Ibs. Pear. (PAN from N.C.
Guide Std. 633) - Tech
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
TWO t: ACRES,OWNED BY PRODUCER
Tract Field* Soil Crop Lbs. N Acres/ Lbs. N Month of
# No. - Tvoe 'R�F Per Acre ,/ Utilized Application
T1454
2
GOA
Cotton qZ5
84
7.00
588
April --.August
T1454
3
GoA
Cotton 12S
84
15.00
1260
April - August
T1454
4
NoA
Fescu
131)
2.60
338
Sept. - August
T1454
4
GoA
Fescue(G)
isz 160
3.00
480
Se . - August
T1454
i 4
GoA
Bermuda G .E
.% 245
.,,' 4.70
1151.5
March - Se .
T1454
4
GoA
Small Grain
50
4.70
235
Sept, - April
T1454
4
GoA
Cotton el 2�;
84
11.00
924
April - August
0
0
0
0
0
Total V _ 43.301 4,976.50
"This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield expectation.
HOTS: The applicator Is cautioned that P and K may be over applied while meetlng the N
requirements: Beginning in 1996 the Coastal Zane Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
40 -
Paget _ - -

°�* .m •rrrn.,xn1r4.. r+c ,r '-'•- t .',i`4'c ,r
irvAs-�EauTillza'�'I�N.`PL:AN���:��
Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own adequate land
[see Required Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
9 No. Type Per Acre*
Il�
* See footnote for Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table 1 43.30 4,977
Table 2 0.00 -
Total 43.30 4,977
Amount of N Produced 3,341
Surplus or Deficit {1 fi36
NOTE: The Waste tlnkmMon Pfan must contain provisions fain periodic land application of sludge at
agronaimc rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
applicatiorn of nutrient or other ehurmnts.
Page 3

`WASTEUT1LiZATi_ON#PLAN__
See attached map showing the fields to be used for the utrlizatfon of waste water.
Application of Waste by Imgation / '/
Field Soil Type Crop Application Application
No_ Rate (IniHr) Amount (In.)
2,3,4
GoA
Cotton
0.4
.5-1
4
NoA
Fescue
0.5
.5-1
4
GoA
Bermuda
0.5
.5-1
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE WILL
BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 MONTHS. In no instance should the volume of
waste being stored in your structure exceed Elevation ,`see lagoon design.
CaH the local Natural Resources Conservation Service (formerly Sol! Conservafion Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the
waste.
Narrative of operation: C-?E e o p CO -
This plan revises a plan prepared bye- NRCS in 1999 to show a conversion from
sows to a nursery operation.
Page 4

REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited-
2
There must be documentation in the design folder that the producer either owns or has
an agreement for use of adequate land on which to properly apply the waste. If the
producer does not own adequate land to property dispose of waste, he/she shall provide
a copy of an agreement with a landowner who is within a reasonable proximity, allowing
himther the use of the land for waste application. It is the responsibility of the owner of
the facility to secure an update of the Waste Utilization Plan when there is a change in
the operation, increase in the number of animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based an soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of application for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre
per year providing grass filter strips are installed where runoff leaves the field. (See
FOTG Standard 393 - Fitter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland_ When applied to conservation tilled crops
or grassland, the waste may be broadcast provided the application does not occur during
a season prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not cause
drift from the site during application. No ponding should occur in order to control odor or
flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
Page 5

REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt
damage from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held
to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy-
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property
boundary and from any perennial stream or river (other than an irrigation ditch or canal.
Animal waste other than swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters. (See Standard 393 - Filter
strips).
12
Animal waste shall not be applied closer than 100 feet to wells.
13
Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14
15
16
Waste shall be applied in a manner not to reach other property and public right-of-ways.
Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist" -
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that courses no runoff or drift from the site.
Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

UTILIZTlONPLAN12
`
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence. of
erosion, leakage or discharge.
18 if animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should
be kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for
direct human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 80 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the rate -
determining element. Zinc and copper levels in the soil shall be monitored and
alternative crop sites shall be used when these metal approach excessive levels. pH
shall be adjusted for optimum crop production and maintained. Soil and waste analysis
records shall be kept for five years. Poultry dry waste application records shall be
maintained for three (3) years. Waste application records for all other waste shall be
maintained for five (5) years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

�'Yf J ..F'f �vL� � _�T'y
► - A a r- Y WAST s'UTIL� A IT ON :PLAN E— rt
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Halfmoon Pigs
Owner/ Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEW before
the new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be fled on -site at the
farm office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner. Moses Moye TT
{Freese pmm
Signature:'Date: o
Name of Manager (if different from owner):
Signature: Date:
Name of Technical Specialist: (Please pfing Kraig A. Westerbeek
Affiliation: Murphy Family Fames
Address (Agency):
. Signature:
P.O. Box 759 -
Rose Hilt. NC
7l a /a -a
Page 8

loommak, *4
EL
Flow
...........

ZONE C
�1

Is
OPERATOR: f%9rI_5
000,
NOTE: Design Requirement: 2,zz3GScu.ft. cu.yds.
Estimate of Excavation: cu.ft. =ifs/3 cu.yds.
Estimate of 34*d-& Dike: cu.ft. =.3 z9 cu.yds.
Z Ratio
Job class �_ _� 3- 9e;9
Date
Design By
Name
Design Approvals.-����
Name
Date
DEC 2 7 1994
1

`;•?�•:rCi�/ d�kcC iC•�>JrvG ItTiG �'�'j�J3y7 �� �C7
va�r-f
r/
R
� = � f i. v c ri ! ;..rG�!.� r-''= r ��.�'_�.y v r�7� •�f Pd,!r� p�� C� / >� � / �
C1Or�tl {fir j�� �a( GC �'� v.sOLf J,C1r��y7 I-�f7�rf�'r✓�
e-1 �y�C o..I �i+CO��� tr' c.da
ra,'7/ 9,4 f-T-�0'ry X/
//
✓�T Sa-� v��f� rrf , Z��I p an�
dj f ors Oa�1
It"I0111/9 f d Lr r�I or? rq,,f ofD�Xa -A/q
am 76r? ay< (101 al Z s
�
't .gym, �jry bro�7aS ��� ---n9gtr
/�� p a r'i1C L.o�O Q6/ n ✓cam ��� ;ori✓aft .. oivclu+d
f1 /
4�ewwo?Jo a� `OJr�7r,F}� f1 ter.C'= 7'a.arf-s/(7
j rticC � � a � —'
wC..i� h Gn'�J
�c� �� /�r�1
J9' � / �yS � �j.0 o� 7-7�� ,✓raa
'��/f��
4/
(wp(nwrrverlr
Q'r..Z/�
•�db./.Sy
C��•/]�/r!7 �o�a��r1�F.f �!�' //�1pyS'
J`r✓DO bO'7
prY! f- �7�, �r�i
�"77r/NOS/
�G+,'�i' ay� - rcf�C��J�p � i y,�
✓G�.
0LUrf Dii ��y,� pa
al 0YIP.�,p
iJ "PI C"wd JTiGp �r �! ��f�/ro�
Qn'%%
/
r-a,-rG/ rrv�/aL'�✓off-Pj4sa�i7 `5�:i, /

N E U N T
PO
7rds.
W.J.
J4,
00
1. It
LA

T E- S72: , 6 z�-
!,perator:MOSES MOYE County: GREENE Date: 6/03/96
Distance to nearest. residence (other than owner): 1800.0 feet.
1. AVERAGE LIVE WIEIGHT (ALW)
0 sows (farrow to finish) x 1417 lbs. =
0 lbs
0 sows (farrow to feeder) x 522 lbs. -
0 lbs
0 head (finishing only) x 135 lbs. =
0 lbs
0 sows (farrow to wean) x 433 lbs. -
0 lbs
0 head (wean to feeder) x 30 lbs. =
0 lbs
Describe other :
0
Total Average Live weight =
0 lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 0 lbs. ALW x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/lb. ALW = 1 CF/lb. ALW
Volume = 0 cubic ft (includes 0 cu. ft. add. treat. vol.)
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
4. TOTAL DESIGNED VOLUME
Inside top length (feet)--------------------- - 265.0
Inside top width (feet)----------------------- 125.0
Top of dike elevation (feet)------------------ 53.80
Bottom.of lagoon elevation (feet)------------- 43.00
Freeboard (feet)----------------------------- 1.0
Side slopes (inside lagoon)------------------ 2.5
1
Total design volume using prismoidal formula
SS/ENDI SS/END2 SS/SIDEI SS/SIDE2 LENGTH WIDTH
DEPTH
2.5 2.5 2.5 2.5 260.0 120.0
�9.8
AREA OF TOP
LENGTH * WIDTH =
260.0 120.0 31200 (AREA OF TOP)
AREA OF BOTTOM
LENGTH * WIDTH =
211.0 71.0 14981 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
235.5 95.5 89961 (AREA OF MIDSECTION
* 4)
CU. FT. _ [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM]
* DEPTH/6
31200 89961 14981
1.6
Total Designed Volume'Available =
222365 CU. FT.

5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
( Length * Width ) + Surface area of connecting waste facility
265.0 125.0 33000.0
66125.0 square feet
Buildings (roof and lot water) or impervious area
0.0 square feet Describe this area.
TOTAL DA 66125.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Feces & urine production in gal./day per 135 lb. ALW 1.37
Volume = 0 lbs. ALW/135 lbs. ALW * 1.37 gal/day 180 days
Volume = 0 gals. or 0.0 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or voli-Lme
of fresh water .used -for _-a_flush system. Flush systems that recirculat-
the lagoon water are accounted for in 5A.
Volume = 1400.0 gallons/day * 180 days storage/7.48 gallons
per CF
Volume = 33689.8 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount..
180 days evaporation - 15.5 inches
180 days rainfall- = 22.5 inches
Volume = 22.5 in * DA / 12 in. per ft. = 123964 cubic feet runoff
Vol -Lime = 15.5 in * lagoon DA/12 in./ft = 85411 cubic feet evap.
Volume = 38573 cubic feet

5D. Volume of 25 year ­24 hour storm
Volume = 7.0 inches / 12 inches per foot. * DA
Volume = 38573 cubic feet.
5E. Additional volume as -.-
TOTAL REQUIRED TEMPORARY STORAGE
5A. 0 cubic feet
5B. 33690 cubic feet
5C. 38573 cubic feet
5D. 38573 cubic feet.
5E. 50990 cubic feet
TOTAL 161826 cubic feet
6. SUMMARY
Temporary storage period====________________>
180
days
Rainfall during wettest period of storage===>
22.5
inches
Evaporation during Storage period========___>
15.5
inches
25 year - 24 hour rainfall==________________>
7.0
inches
Freeboard___________________________________>
1.0
feet
2.5
: 1
Inside top length___________________________>
265.0
feet
Inside top width____________________________>
125.0
feet
Top of dike'elevation_______________________>
53.80
feet
Bottom of lagoon elevation====______________>
43.00
feet
Total required volume_______________________>
161826
cu. ft.
Actual design
r222365
cu:-ft.
Seasonal high watertable elevation (SHWT)===>
46.30
fee
Stop pumping elev.__________________________>
46.30
feet
Must be > or = to the SHWT e.lev.====______>
46.30
feet
Must be > or = to min. req. treatment el.x>
49.00
feet
Required minimum treatment volume=====______>
0
cu. ft.
Volume at stop pumping elevation=====_______>
57414
cu. ft.
Start pumping elev._________________________>.
51.50
feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall==>
183792
cu. ft.
Volume at start pumping elevation.====_-__=__>
183392
cu. ft.
Required volume to be Humped=====______=_=__>
123253
cu. ft.
Actual volume planned to be pumped=====_____>
125978
cu. ft..
Min. thickness of soil liner when required==>
1.6
feet'
7. DESIGNED BY: �._E` ��v�--e APPROVED BY: GC'
DATE: 6-3--4 DATE: 6' -
(P
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS: qlPera.�.
/� J
�ia! JJc.: �r:�cr�P�. JJ07iGlT,• .�%a.✓.✓c�✓ �:� ��r✓ �-3.O .bPcn:ir ��.-----
Alec., mar Q//fie Fi/�

/ SHEET 1 OF 2
OPERATION AND MAINTENANCE PLAN ✓
------------------------------
This lagoon is designed for waste treatment (permanent storage) and
180.days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation. Also
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s). If the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initzal
waste entering the lagoon thereby reducing odors.. Solids should be
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 51.5 as marked by permanent marker. Stop pump -
out when the fluid level reaches elevation 46.3 . This temporary
storage, less 25 yr- 24 hr storm, contains 72263 cubic feet or
540525 gallons.

SHEET 2 OF 2
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.3
inch per hour. Refer to the waste utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
B. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.
F.

SHEET 1 OF 2
SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
----------------------------------------------------------
FOUNDATION PREPARATIOrd:
-----------------------
The foundation area of the lagoon embankment and building pad shall be
cleared of trees, logs, stumps, roots, brush, boulders, sod and rubbish.
Satisfactory disposition will be made of all debris. The topsoil from
the lagoon and pad area should be stripped and stockpiled for use on
the dike and pad areas. After stripping, the foundation area of the
lagoon embankment and building pad shall be thoroughly loosened prior
to placing the first lift of fill material to get a good bond.
EXCAVATION AND EARTHFILL PLACEMENT:
-----------------------------------
The completed excavation and earthfill shall conform to the lines,
grades, and elevations shown on the plans. Earthfill material shall
be free of material such as sod, roots, frozen soil, stones over
6 inches in diameter, and other objectionable material. To the extent
they are suitable, excavated materials can be used as fill. The fill
shall be brought up in approximately horizontal layers not to exceed 9
inches in thickness when loose and prior to compaction. Each layer
will be compacted by_complete coverage with the hauling and spreading
equipment or standard tamping roller or other equivalent method.
Compaction will be considered adequate when fill material is observed
to consolidate to the point that settlement is not readily detectible.
NOTE THE SPECIAL REQUIREMENTS FOR PLACEMENT OF LINERS IN THE LINER
SECTION OF THIS SPECIFICATION. The embankment of the lagoon shall be
installed using the -more impervious materials from the required
excavations. Construction of fill heights shall include 5 percent for
settlement.. Dikes over 15 feet in height and with an impoundment
capacity of 10 acre-feet or more fall under the jurisdiction of the NC
Dane Safety Law. The height is defined as the difference in elevation
from the constructed height to the downstream toe of the dike.
Precautions shall be taken during construction to prevent excessive
erosion and sedimentation.
LINER: THE MINIMUM REQUIRED THICEIlESS SHALL BE 1.6 ft.
NOTE: LINERS (PARTIAL OR FULL) ARE REQUIRED WHEN THE ATTACHED SOILS
INVESTIGATION REPORT SO INDICATES OR WHEN UNSUITABLE MATERIAL IS
ENCOUNTERED DURING CONSTRUCTION. A TYPICAL CROSS SECTION OF THE LINER
IS INCLUDED IN THE DESIGN WHEN LINERS ARE REQUIRED BY THE SOILS REPORT.
When areas of unsuitable material are encountered, they will be over -
excavated below finish grade to the specified depth as measured
perpendicular to the finish grade. The foundation shall be backfilled
as specified to grade with a SCS approved material (ie - CL,SC,CH).
REFER TO THE SOILS INVESTIGATION INFORMATION IN THE PLANS FOR SPECIAL
CONSIDERATIONS.

SHEET 2 C} 2
Soil liner material shall come from an approved borrow area. The
minimum water content of the liner material shall be optimum moisture
content which relates to that moisture content when the soil is kneaded
in the hand it will form a ball which does not -readily separate. slater
shall be added to borrow as necessary to insure proper moisture c,:,tent
during placement of the liner. The moisture content of the liner
material shall not be less than optimiml water content during placement.
The maximum water content relates to the soil material being too- wet
for efficient use of hauling equipment and proper compaction. Proper
compaction of the liner includes placement. in 9 inch lifts and
compacted to at. least 90 percent of the maximum ASTM D698 Dry Unit.
Weight of the liner material. When smooth or hard, the previous lift
shall be scarified and moistened as needed before placement of the next
lift.
The single most important factor affecting the overall compacted perme-
ability of a clay liner, other than the type of clay used for the
liner, is the efficient construction processing of the compacted liner.
The sequence of equipment use and the routing of equipment in an estab-
lished pattern helps assure uniformity in the whole placement and
compaction process. For most clay soils, a tamping or sheepsfoot
roller is the preferable type of compaction equipment.
The soil liner shall be protected from the discharge of waste outlet
pipes. This can be done by using some type of energy dissipator(rocks)
or using flexible outlets on waste pipes.
Alternatives to soil liners are synthetic liners and bentonite sealant.
When these are specified, additional construction specifications are
included with this Construction Specification.
CUTOFF TRENCH:
--------------
A cutoff trench shall be constructed under the embankment area when
shown on a typical cross section in the plans. The final depth of the
cutoff trench shall be determined by observation of the foundation
materials.
t.'EGETAT I ON :
All exposed embankment and other bare constructed areas shall be seeded
to the planned type of vegetation as soon as possible after construc-
tion according to the seeding specifications. Topsoil should be placed
on areas of the dike and pad to be seeded. Temporary seeding or mulch
shall be used if the recommended permanent vegetation is out of season
dates for seeding. Permanent vegetation should be established as soon
as possible during the next period of approved seeding dates.
REMOVAL OF EXISTING TILE DRAINS
When tile drains are encountered, the tile will be removed to a minimum
of 10 feet beyond the outside toe of slope of the dike. The the-_
trench shall be-backfilled and compacted with good material- such as
SC, CL, or CH. f ��
l-

id-
tt
- Lt
IJ
17
d
J-1
HL
AA°"vm..".
.*°.OLm"",~°,

0
62'
96'
I 20"sq
77
�18"sq.
96' -
90 w -
3"
631" ��V
L
nimum
outs to receive 4"
r 6" maximum pipe
j F - "
92
MANUFACTURED BY: R.M.C.1.
W-n 002.
Mitchell Concrete
P. 0. Box 585
Smithfield, NC 27577
[phone]
5 1.
Nelson Mitchell
• LIQUID CAPACITY: 1,211.54 Gallons_,
2.20 Xds. - 6,800 1hs.
Square Riser
or Round Riser
]with the use of
adai2tor ring
M
(•�) (•"1 r i�
�. { • ) ..-�{ � �---� 5EAIJINTSEAIJW IL
62
- - -- - - - 56" u,s�)�
_ _ ... C
O
y
59' '
3. 3"
Dote 83}" 59'
24" square _
26" -square '
4
4" w
•

ZSNzo
SCS-ENG-5311 U. S. DEPARTMENT OF AGRICULTURE
Rev. 5-70 SOIL CONSERVATION SERVICE
SOIL INVESTIGATION TO DETERMINE SUITABILITY OF PROPOSED POND SITE
r -
FARMER'S NAKE DRICT f
UNTY
• r SITEET NO. WORK
WATERSHED AREA MEASUREMENTS
CROPLAND-ACRF-S PASTURE -ACRES
rr r rEau=• r
•r r r a r
IMEM■
■
MEMO
PENN
MEMOMMIN
MEN
Mimi
■
■■
■
■MINE
■
l�MIMENNIMME
®e■■■■
■MIME
■
■�i�111
In
m9MOE■
IMMENSE
mmmmmms
■
■■E:■:■■■■�■■■®■■�■■■
■■iu
_�
���■■■■■■■�■■■
MEN
.�e.EN.
®U■■.■..®■■■
N
INE
MEN
IN
IMMIMMIR
■■
01
■
■EOM■
■IS■■
■■■
M
■■
■■■■■■■■■■
■■N■;
■
■■
EM
iw
�E�����EE■�i�■■■
iii■■iiii■®����.:.:.���■�■■
M■
■■MEMO■■■■®■■
�CEEMMIMMMM
■■■N
■E■■
ONE
�iiIMENMEMIN■■MM
■■■■
MINE■Monosson
PROFILEBORING NUMBERAND
9ilog.
Miii■�
'
i314
�ifl((
Mimi
I
I
i
I
I
I I
'■i
I
I
f■1
�i
!
I�
I
►■�
�I
I
ElmI■
l
I
I
!�
1 1
1!
�O!
i�■!
'
!■!
Cl
[
■I�'�I
I�:
'El
IN
t
1
I
I
�I
1■■
■1
(■
I
■f
■I■
I
I
I
I
I
I■I
I■'
f■
■I■IN,
I
'MINIM
I■I
',
I:MINIM
�WMINS
■I■
■KIM
�®
I■!
I
III■I
■ IM=
S
EI■
■UM
■E■�
i�■E■.■
E
i
■,■:■IEfl■i■
■il10
®l■
®!��
BORINGS MADE

U: S. Department of Ugric='- ure NC-ENG-34
Soil Conservation Services September 1580
File Code: 210
HAZARD CLASSIFICATION DATA SPiEET FOR DAMS.
Landowner MAofeS ago u e County. GYM e ��
Community or Group No. Conservation, P,lari, No.
•.I A S 1 ,"TO-E , F. ..' J
Estimated Depth of Water to Top of 11fffm S Ft. Length of .Flood Pool 26-5 _ Ft.
Date of Field Hazard Investigation _ S -96
Evaluation by reach of flood plain.downstream to the point of estimated minor effect
from sudden dam failure...,
Est, Lev. st. ElevaF'ion
:+ Kind of :Improvements: of Breach
Reach: Length: Width: Slope: Land Use Improvements Above .:FIoodwater Above
_ Flood Plain:_ Flood Plain
Ft. Ft. - _ _ _ F,t�. F;t.
:40ov Cvor,I -p d
1 `ro
— -. 7"
io Ob
2
. _ • ��oc�ctaa 1=..
4_6
3
3Z �U . :_COTS iaNrAT.ri: :
Describe potential for loss of life and damage.to existing or probable future downstream
improvements from a sudden breach pT-,?RoYsmen 1vij
��'1y�ti".^.�+ (.�S1G�: r� r. •�ihPr-• ?Q�1 �in.rr)•r.YS 4soa�a � Q. 177[� '�'�.P.� �'Z6p -�4•ln-tir. �.t Ct10 j:�C �� -
-
flazard Classification of $III (mil b, c) (see HEM -Part 520.21)
Dam Classification (I, II III, IV, V)
By
Concurred By
name title
NOTE: 1. Instructions on reverse side.
2. Attach additional sheets as needed.
Date �5_--`1--9I C
Date_ 6 - 3

lu
El
Ai'
MIN,
-14
S" 4
All
lip.
N AP
t"N-II•. . . . . . . . ...

DEVELOPMENT -- .....
H C_ AROLINA 7.5 MINUTE SERIES I
z - I N&I
Q4 KINSTON 15'
-LEI i 69 32'30" t70 we to GREEN2.1KM � !2440000 FEET 772
4 POD ♦ Ce _�' �ar�Cem_• 1 d= `& _.
Cem_- _ .�� • � �o =-cn _— _
•� _ �•� - _ : Cem 22.0
�p - --.: :c r _ r�
23
•) Cem : _ ! _l •' Sainu Delight/20
Ms Ch
1341
Imo' I 13]8
:Cem - _ ��•'� ••lam _ !
2r.5 V993 ~ I 2Q5 \
I'' • 133iN�
`7: ` Cem ! ii
rn
Ormondsville - zos N�
I Cem' 1 f,_
1335 /
4x i--f�-/�' . / - it �2Ao. s I
Grave * \, Cem-- .
- I Cem I 4
\ .
0 CON,
1405
1 �\ Cem
New Zi ` ,Cetus:: - -- - _
Cb

t�,'�l/rj Utr :r` yr 'hq'r,`•�i' off+•' M;� 4 1'�� I�i� , I�
yr' ,. �, aa '�•� �. N �w,ti ;.fy gA
7A
,
h•

. .
|
� SE�DIN8 SPEClFICATIONS'
' . ---_-_--_-__----------
-
MI�T-RE" INDIC/\�E�
-
`
-
(B�GT SUlT�D O� C��Y�Y O� �ET S�IL CO�DI�IUNS)
N�V�MDER 30
FEDR��RY 1 �l) MARCH 30
Y FU� FESCUE)
60.0 L8S. SACOLA' D��I� G�A­S
(��� FOOTWOTE NO. 1)
SEEDIN� CATES: �ARCH 1� TO JU�E 15
H�LLED CO -MUM E !DA G�lASS �T 8 LDS./A��F
(SUIT�� FOR MOST SOlL Cb�DlTIO�S>
S�EDIN(1� DL 1 TO JULY 31
�NHU�LEQ CUMMC � �ER���A GRA£S AT 1O LB5./ACRE
�EEDINGID�TES: JANUARY 1 T0 �ARCH 3�
40.0 L�S. HYE 6RA 'S AT 40 L�S,/ACRE (TEMPOR�RY ��GETATION)
. SEEDlNG DATES: DE: ill DER 1 TO MA.RCH 30
APPLY THE FOU_OWINn:
1000.0 L7_3 C-)F i0-10-10 FERTlLIZ[H (10�0 LBS./ACRE)
2.0 TO�S OF DOLO��TIC LIM�� (� TO«S/ACRE) -
100.0 BA��S 8F S�ALL 6F��IN ��T�AW (100 B'LES/ACRE>
ALL SURFA�E DRAIS SHO�LD �E I�STALLED PRIOR TO SEE�IN8. SH�\PE
,
/\LL DISTU�BED AR�A I��ED3ATBLY AFTER EARTH MOVI %G IS COMPLETEI) ,
APPLY LIME AND FERTlLlZER THE� DIS� �O PREPARE A 3 TO 4 INCH
3MOOTH SEEDB�D. APPLY SE�D A�0 FIFl FED WZTH A CULTIPACKER
OR Sl��iL�� E0�IPMENT . �PPLY MULCH �ND SECURE NITH �\ MULCH
�M���RlNB 7OOL OR �ETTI»�S .
1. PENSACOLA B�HIAGRASS I8 SLO�ER TO ESTADLISH THA�� COMMON
DERMUDA GRASS. USING BAHIA, ECONMENDED THAT 8
LBB./ACRE OF C��`�� F)ERMUDA BE lNCLUDED TO PROVIDE �UVER
U�TIL BAHIAGRASS IS E9TABLISHEED.

Or-VL7-1.44
I
PLANNED
QUANTITY CALCULATIONS
prepared for
MC]�_-31u-_- E3 MC]Y[—=
in
}
US Department of Agriculture
Soil Conservation Service
GREENE County, North Carolina
Designer ELTON TURNAGE Checker
Date 06/03/96 Date
Job Number 1MM
EXCAVATION
I
** EXCAVATION **
1 **
FILL **
Bot
Left
Right
Off-CL I
CL
Dist 1
Area
Volume
I Area
Volume
Width
SS
SS
(ft) I
Sta
(ft) I
1
(SgFt)
(Cu.Yds) I
(SgFt)
1
(Cu.Yds)
71
2.5:1
2.5:1
I
72.0 1
0+10
1
.490.8
1
0.0
1
90 1
1621.6 1
O.0
71
2.5:1
2.5:1
72.0 1
1+00
1
482.1
1
0.0
1
100 1
3449.8 1
0.0
71
2.5:1
2.5:1
72.0 1
2+00
1
505.1
1
0.0
1
56 1
4512.6 1
0.0
71
2.5-:1
2.5:1
72.0 1
2+56
I
519.6
�—'1
0.0
� ,'� 1: f• Z . � �u '"�d
3-7Z�

US Department of Agriculture -
Soil Conservation Service
CROSS-SECTION DATA
QUANTITY CALCULATIONS
prepared for
in
GREENE County* North Carolina
Designer : ELTON TURNAGE Checker
Date : 06/03/96 Date
Job Number 1MM
EXCAVATION
TEMPLATE DATA:
Beginning Elevation = 43
Beginning Station +10
+10 to +10
+10 to .1+00
1+00 to 2+00
2+00 to 2+56
SECTION NUMBER 1
Centerline Station +10
ORIGINAL DATA:
0.0 / 48.6 100.0 / 48.8
c\2.5cl7l/2.5
c\2.5c171/2.5
c\2.5cl71/2.5
c\2.5cl7l/2.5
200.0 / 48.6
SECTION NUMBER 2
Centerline Station 1+00
ORIGINAL DATA:
0.0 / 49.0 100.0 / 48.7 200.0 / 48.3
SECTION NUMBER 3
Centerline Station 2+00
ORIGINAL DATA:
0.0 / 48.9 100.0 /• 49.0 200.0 / 48.4
SECTION NUMBER 4
Centerline Station 2+56
ORIGINAL DATA
0.0 / 49.4 50.0 / 49.2 100.0 / 49.1
0.00000 ft/ft
0.00000 ft/ft
0.00000 ft/ft
0.00000 ft/ft
200. 0 / 48. 6- - -

Top
Width
10
10
10
10_
10
10
10
10
10
10
10
US Department of Agriculture
Soil Conservation Service
PLANNED
QUANTITY CALCULATIONS
prepared for
!"1ClSE_-= � MOYC
in
GREENE County, North Carolina
Designer ELTON TURNAGE Checker
Date 06/03/96 Date
Job Number 2MM
Left
Right
Off-CL
SS
SS
( ft )
3:1
2.5:1
35.0
3:1
2.5:1
35.0
3:1
2.5:1
35.0
3:1
2.5:1
35.0
3:1
2.5:1
15.0
3:1
2.5:1
20.0
3:1
2.5:1
20.0
3:1
2.5:1
20.0
3:1
2.5:1
20.0
3:1
2.5:1
20.0
CL
Sta
0+00
0+95
1+95
2+75
3+35
4+10
4+90
5+90
6+85
7+60
1103_M2
Dist
(ft)
95
100
80
i
60
75
i
80
I
100
1
95 1
75 I
;ILL
** EXCAVATION **
I Area
Vol -Lime
(SgFt)
(Cu.Yds)
0.0
0.0
0.0
0.0
0.0
0.0
0.0
'0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
0.0
**
FILL **
Area
Volume
(SgFt)
(Cu.Yds)
133.9
449.3
121.5
897.5
120.5
1220.3
97.3
1445.7
105.5
1765.1
124.5
2148.3
134.1
2652.6
138.2
3111.3
122.5
3447.5
119.6
3:1 2.5:1 20.0 1 8+20 1 0.0 1 134.2
Some of the data checking (rules) have been disabled.
3729.4

LTS Department of Agriculture
Soil Conservation Service
CROSS-SECTION DATA
QUANTITY CALCULATIONS
prepared for
pal n �7' F-_ E-z; e-3 n Y E-
in
GREENE County, North Carolina
Designer : ELTON TU'RNAGE Checker
Date : 06/03/96 Date
Job Number 2MM
DIKE FILL
TEMPLATE
DATA:
Beginning
Elevation = 53.8
Beginning
Station = 0+00
0+00
to
0+00
D/3CL10\2.5
0+00
to
+95
D/3CL10\2.5
+95
to.
1+95
D/3CL10\2.5
1+95
to
2+75
D/3CL10\2.5
2+75
to
3+35
D/3CL10\2.5
3+35
to
4+10
D/3CL10\2.5
4+10
to
4+90
.--D/3CL10\2.5
4+90
to
5+90
D/3CL10\2.5
5+90
to
6+85
D/3CL10\2.5
6+85
to
7+60
D/3CL10\2.5
7+60
to
8+20
D/3CL10\2.5
SECTION NUMBER 1
Centerline Station 0+00
ORIGINAL DATA:
0.0 / 48.4 50.0 / 48.4 100.0 / 48.8
SECTION NUMBER 2
Centerline Station +95
ORIGINAL DATA:
0.0 / 49.0 100.0 / 48.3
SECTION NUMBER 3
Centerline Station 1+95
ORIGINAL DATA:
0.0 / 48.9 50.0 / 48.7 100.0 / 49.0
0.00000 ft/ft
0.00000 ft/ft
0.00000 ft/ft
0.00000 ft/ft
0.00000 ft/ft
0.00000 ft/ft
0.00000 ft/ft
0.00000 ft/ft
0.00000 ft/ft
0.00000 ft/ft
r 0.00000 ft/ft
nrnmrriwt wrrn�rr,rn e

: i
DIKE FILL (continued) 06/03/96
Centerline Station 2+75
ORIGINAL DATA:
0.0 / 49.4 50.0 / 49.4 100.0 / 49.1
SECTION NUMBER 5
Centerline Station 3+-35
ORIGINAL DATA:
0.0 / 49.2 100.0 / 49.0
SECTION NUMBER 6
Centerline Station 4+10
ORIGINAL DATA:
0.0 / 48.6 25.0 / 48.6 75.0 / 49.2
SECTION NUMBER 7
Centerline Station 4+90
ORIGINAL DATA:
0.0 / 48.4 40.0 / 48.4 70.0 / 48.6
SECTION NUMBER 8
Centerline Station 5+90
ORIGINAL DATA:
0.0 / 48.3 50.0 / 48.3 100.0 / 48.7
SECTION NUMiBER 9
Centerline Station 6+85
ORIGINAL DATA:
0.0 / 48.7 75.0 -/ 48.7
SECTION NUMBER 10
Centerline Station 7+60
ORIGINAL DATA:
0.0 / 48.8 110.0 / 48.7
SECTION NUMBER 11
Centerline Station 8+20
ORIGINAL DATA:
0.0 / 48.4 100.0 / 48.4
Page 2

)tatiimeat B
'r5ke 1 of 3
North Carolina Agricultural Lztension Service
-A i-Waste Management
Biolq&.al W& F.ngj�ri g Noriir Q=zi7= stake Zlranersity
IZVES7Q U= SAHM=, ANAJ-Tzs LM CA1.CVL=Qa
OF LAIM AP_nZCA=O19 VAIg5
James C. Barker*
1. SAM r COIZXC�
& Seri -Solid Lot Manure
i. Scraped directly :ftom lot into spreader
a. From loaded spreader, collect about 2 lbs- of -—a from
,I—? arent locations using nonmetallic colletcors.
U. From storage
a. Collect about 2 lbs of manure from —dar the s=-lace crust
avoiding betiding materials and using nonmarull is collectors.
B. Liquid 2isizure Sl==7
_. Under- slo=ad- floor pit
a. Extend a 1/2' =nm3etal1ic conduit -open on both ends into
=saute to pit floor.
b. Saal upper and of conduit (e.g., by plating a rhumb over and
of conduit) =piling manure that has enured lower and, remove
and empty slurry into plastic bucket or nonmetallic container.
c. Take suhsamples mom S or more locations or at leas:. 1 quart.
d. Xix and add about 3/4 pint to nonmetallic sample container.
il. Exterior storage basin or tank
a. Hake sure manure has been well mimsd 'with a liquid ,a—mrs
chopper -agitator pump or propeller agitator.
b. Take subsamples :mom about 5 pit locations, from agitator p=p
or from manure spreader and place in a plss=4c bucket.
* Professor and Extension Specialist, Biological and Agricultural Engineering
Department, North Carolina State University, Raleigh. NC.

State of North Carolina
Department of Environment, Health, and Natural Resources
512 North Salisbury Street • Raleigh, Norrh Carolina 27604
Division of Environmental Health
James 8- Hunt, Jr., Govemor Jonathan li Howes. Secretary
February 10, 1993 Richard K. Rowe, Director
(919) 733--2895
Mr. Nelson Mitchell
Mitchell Concrete
P. O. Box 585
Smithfield, NC 27577
RE: Approval of Plans and Specifications for 1200-Gallon, Precast,
Reinforced Concrete Pump Tanks
Dear Mr. Mitchell:
Plans and specifications for a one -section, precast, reinforced
concrete pump tank have been reviewed and found acceptable by the
On -Site Wastewater Section and are hereby approved under on -Site
Wastewater Section serial number PT-210, dated February 10, 1993.
The imprint that will identify the manufacturer, serial number, and
capacity of the referenced tanks will be MCP-PT-210-1200. The
imprint will be located to the left of the blockout made on the
outlet end of the tank.
One copy of the plans and specifications bearing the on -Site
Wastewater Section stamp of approval is enclosed, together with a
tank review sheet. One copy of each is being forwarded to the
Chatham, Cumberland, Duplin, Franklin, Greene, Harnett; Johnston,
Nash, Sampson, wake, Wayne, and Wilson County Health Departments.
one copy is being retained in our permanent files. Separate copies
of the review sheet are being sent to the Farmers Home
Administration and the Veterans Administration.
Please note that this approval applies only to pump tanks meeting
the plans and specifications; and, if found in noncompliance, a
Certificate of Completion or Operation Permit will not be issued.
In addition, two -section pump tanks shall be watertight and shall
be subject to a watertightness test, and all one -section pump tanks
shall be watertight and may be subject to a watertightness test as
described in NCAC .1954(b).
PO. Box 27687, Rakigit torch Carolina 276W7687 Te3cpli )m 919-7733-a9g4 Fax i 919. 33475u
An Equal Opwrwniry AFiirnunve A[oon Emp6yer

I i
�ri V6 . LAGDON
. T�9EA rM�N7 le II�ME �Di�J�uTi�Tian's
Operator:MOSES MOYE County: GP.EENE Date: 06/03/96
Distance to nearest. residence (other than owner): 1500.0 feet
Im
AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish)
400 sows (farrow to feeder)
0 head (finishing only)
0 sows (farrow to wean)
0 head (wean to feeder)
Describe other
x 1417
lbs. -
0
lbs
x 522
lbs.
- 206800
lbs
r 135
lbs. -
0
lbs
x 433
lbs.
= 0
lbs
x 30
lbs.
- 0
lbs
0
Total Average Live Weight = 208800 lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON -
Volume = 208800 lbs. ALW x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/lb. ALW = 1 CF/lb, ALW
Volume = 208800 cubic ft (includes 0 cu. ft. add. treat. vol.)
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
4. TOTAL DESIGNED VOLUME
Inside top length (feet)--------------------"--- 586.8
Inside top width (feet) ------------- ------ 55.0
Top of dike elevation (feet)----------------- 48.70
Bottom of lagoon elevation (feet)------------ 36.20
Freeboard (feet)----------------------------- 1.7
Side slopes (inside lagoon)------------------- 1.0 : 1
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
1.0 1.0 1.0 1.0 583.4 51.6 10.8
AREA OF TOP
LENGTH * WIDTH =
583.4 51.6
AREA OF BOTTOM
LENGTH * WIDTH =
561..8 30.0
AREA OF MIDSECTION
LENGTH * WIDTH * 4
572.6 40.8
30103 (AREA OF TOP)
16854 (AREA OF BOTTOM)
93448 (AREA OF MIDSECTION *'40
CU. FT. = [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM_] * DEPTH/6
30103 93448 16854 1.8
Total Designed Volume Available- �-2-54'7'_dJCU. FT.

I
5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
( Length * Width ) } Surface area of connecting waste facility
586.8 55.0 • 0.0
32274.0 square feet
Buildings (roof and lot water) or impervious area
0.0 square feet Describe this area.
TOTAL DA 32274.0 square feet
Design temporary storage period to be 0 days.
5A. Volume of waste produced
Feces & urine production in gal./day per 135 lb. ALW 1.37
Volume = 208800 lbs. ALW/135 lbs. ALW * 1.37 gal/day 0 days
Volume = 0 gals; or 0.0 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculat.-
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 0 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time -when rainfall exceeds evaporation by largest amount.
0 days evaporation = 0.0 inches
0 days rainfall = 0.0 inches
Volume = 0.0 in * DA / 12 in. per ft. = 0 cubic feet runoff
Volume = 0.0 in * lagoon DA/12 in./ft = 0 cubic feet evap.
Volume. = 0 cubic feet

5D. Volume of 25 year - 24 hour storm
Volume = 0.0 inches/ 12 inches per foot * DA
Volume = 0 cubic feet
5E. Additional volume as follows:
TOTAL REQUIRED TEMPORARY STORAGE
5A. 0 cubic feet
5B. 0 cubic feet
5C. 0 cubic feet
5D. 0 cubic feet
5E . 0 cubic feet
TOTAL 0 cubic feet
6. SUMMARY
Temporary storage period====________________>
0
days
Rainfall during wettest period of storage===>
0.0
inches
Evaporation during storage period=====______>
0.0
inches
25 year - 24 hour rainfall=====_____________>
0.0
inches
1.7
feet
1.0
: 1
Inside top length====_______________________>
586.8
feet
Inside top width_____________________-______>
55.0
feet
Top of dike elevation======_________________>
48.70
feet
Bottom of lagoon elevati)on__________________>
36.20
feet
Total required volume=====__________________>
208800
cu. ft.
Actual design
252730
cu. ft.
Seasonal high watertable elevation (SHWT)===>
46.30
feet
Stop pumping elev.__________________________>
47.00
feet
Must be > or = to the SHWT elev.====_--___>
46.30
feet
Must be > or = to min. req. treatment el,=>
42.20
feet
Required minimum treatment volume=====__=___>
208800
cu. ft.
Volume at stop pumping elevation=====_______>
252730
cu. ft.
Start pumping elev.===______________________>
47.00
feet
*.
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall==>
252730
cu. ft.
Volume at start pumping elevation=====______>
252730
cu. ft.
Required volume to be pumped=====___________>
0
cu. ft.
Actual volume planned to be pumped=====_____>
0
cu. ft.
Min. thickness of soil liner when required==>
1.8
feet,
7• T -
i 1
DATE: DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
PE
COMMENTS' s is .ucr 4 c%•� .-� - 7�� P cow �.� �.��---��� ��
�ol/F.�.s-. �y�o �i�i�.✓ 7 /i�J�r�/J.f p� _ c,►if'�i.-�" /^�C -o e.JS._ _� - - -
See 14F1. -1=7e/J 56o-�l

"a^ -�; <4
System Calibration
Information presented in manufacturer's charts are based on average operation
conditions with relatively new equipment. Discharge rates and application rates change
over time as equipment gets older and components wear. In particular, pump wear tends
to reduce operating pressure and flow. With continued use, nozzle wear results in an
increase in the nozzle opening which will increase the discharge rate while decreasing the
wetted diameter.
You should be aware that operating the system differently than assumed in the design will
alter the application rate, diameter of coverage, and subsequently the application
uniformity. For example, operating the system with excessive pressure results in smaller
droplets, greater potential for drift, and accelerates wear of the sprinkler nozzle. Clogging
of nozzles can result in pressure increase. Plugged intakes or crystallization of mainlines
will reduce operating pressure. Operating below design pressure greatly reduces the
coverage diameter and application uniformity.
For the above reason, you should calibrate your equipment on a regular basis to ensure
proper application rates and uniformity. Calibration at least once every three years is
recommended. Calibration involves collecting and measuring flow at several locations in
the application area. Any number of containers can be used to collect flow and
determine the application rate. Rain gauges work best because they already have a
graduated scale from which to read the application amount without having to perform
additional calculations. However, pans, plastic buckets, jars, or anything with a uniform
opening and cross-section can be used provided the liquid collected can be easily
transferred to a scaled container for measuring.
For stationary sprinklers, collection containers should be located randomly throughout the
application area at several distances from sprinklers. For traveling guns, sprinklers
should be located along a transect perpendicular to the direction of pull. Set out
collection containers 25 feet apart along the transect on both sides of the gun cart. You
should compute the average application rate for all nonuniformity of the application. On a
windless day, variation between containers of more than 30 percent is cause for concern.
You should contact your irrigation dealer or technical specialist for assistance.
'Reprinted for Certification Training for Operations of Animal Waste Management Systems Manual
1

OPERATION & MAINTENANCE PLAN
Proper lagoon management should be a year-round priority. It is especially important to manage
levels so that you do not have problems during extended rainy and wet periods.
Maximum storage capacity should be available in the lagoon for periods when the receiving crop is
dormant (such as wintertime for bermudagrass) or when there are extended rainy spells such as a
thunderstorm season in the summertime. This means that at the first sign of plant growth in the
later winter 1 early spring, irrigation according to a farm waste management plan should be done
whenever the land in dry enough to receive lagoon liquid. This will make storage space available in
the lagoon for future wet periods. In the late summer I early fall the lagoon should be pumped down
to the low marker (see Figure 2-1) to allow for winter storage. Every effort should be made to
maintain the lagoon close to the minimum liquid level as long as the weather and waste utilization
plan will allow it.
Waiting until the lagoon has reached its maximum storage capacity before starting to irrigated does
not leave room for storing excess water during extended wet periods. Overflow from the lagoon for
any reason except a 25-year, 24-hour storm is a violation of state law and subject to penalty action.
The routine maintenance of a lagoon involves the following:
Maintenance of a vegetative cover for the dam. Fescue or common bermudagrass
are the most common vegetative covers. The vegetation should be fertilized each
year, if needed, to maintain a vigorous stand. The amount of fertilized applied should
be based on a soils test, but in the event that it is not practical to obtain a soils test
each year, the lagoon embankment and surrounding areas should be fertilized with
800 pounds per acre of 10-10-10, or equivalent.
Brush and trees on the embankment must be controlled. This may be done by
mowing, spraying, grazing, chopping, or a combination of these practices. This
should be done at least once a year and possibly twice in years that weather
conditions are favorable for heavy vegetative growth.
NOTE: If vegetation is controlled by spraying, the herbicide must not be allowed to enter the lagoon
water. Such chemicals could harm the bacteria in the lagoon that are treating the waste.
Maintenance inspections of the entire lagoon should be made during the initial filling of the lagoon
and at least monthly and after major rainfall and storm events. Items to be checked should include,
as a minimum, the following:
Waste Inlet Pipes, Recycling Pipes, and Overflow Pipes -- look for:
1. separation of joints
2. cracks or breaks
3. accumulation of salts or minerals
4. overall condition of pipes

Lagoon surface -- look for:
1. undesirable vegetative growth
2. floating or lodged debris
Embankment -- look for:
1. settlement, cracking, or "jug" holes
2. side slope stability -- slumps or bulges
3. wet or damp areas on the back slope
4. erosion due to lack or vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewalls, thereby weakening the lagoon dam.
A good stand of vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to a lagoon sidewall, baffles in the lagoon may be
used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the dam. If your lagoon has
any of these features, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporary fix if there is a
threat of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with potentially serious consequences and should not be conducted unless
recommended by an appropriate technical expert.
Transfer Pumps -- check for proper operation of:
1. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding
noise, or a large amount of vibration, may indicate that the pump is in need of repair or
replacement.
NOTE: Pumping systems should be inspected and operated frequently enough so that
you are not completely "surprised" by equipment failure. You should perform your
pumping system maintenance at a time when your lagoon is at its low level. This will
allow some safety time should major repairs be required. Having a nearly full lagoon is
not the time to think about switching, repairing, or borrowing pumps. Probably, if your
lagoon is full, your neighbor's lagoon is full also. You should consider maintaining an
inventory of spare parts or pumps.
• Surface water diversion features are designed to carry all surface drainage
waters (such as rainfall runoff, roof drainage, gutter outlets, and parking lot
runoff) away from your lagoon and other waste treatment or storage
structures. The only water that should be coming from your lagoon is that
which comes from your flushing (washing) system pipes and the rainfall that
3

hits the lagoon directly. You should inspect your diversion system for the
following:
1. adequate vegetation
2. diversion capacity
3. ridge Berm height
Identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is predicted, and then
record the level again 4 to 6 hours after the rain (assumes there is no pumping). This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recording your rainfall for this to work). Knowing this should help in
planning irrigation applications and storage. If your lagoon rises excessively, you may
have an overflow problem from a surface water diversion or there may be seepage into
the lagoon from the surrounding land.
Lagoon Operation
Startup:
1_ Immediately after construction establish a complete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new lagoon design treatment volume at least half full of water before waste
loading begins, taking care not to erode lining or bank slopes.
3. Drainpipes into the lagoon should have a flexible pipe extender on the end of the
pipe to discharge near the bottom of the lagoon during initial filling or another
means of slowing the incoming water to avoid erosion of the lining.
4. When possible, begin loading new lagoons in the spring to maximize bacterial
establishment (due to warmer weather).
5. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the fall lagoon liquid
volume. This seeding should occur at least two weeks prior to the addition of
wastewater.
6. Maintain a periodic check on the lagoon liquid pH. If the pH falls below 7.0, add
agricultural lime at the rate of 1 pound per 1000 cubic feet of lagoon liquid volume
until the pH rises above 7.0. Optimum lagoon liquid pH is between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate biological
activity. Consultation with a technical specialist is recommended if these
conditions occur for prolonged periods, especially during the warm season.
4

Loading:
The more frequently and regularly that wastewater is added to a lagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several times daily
are optimum for treatment. Pit recharge systems, in which one or more buildings are
drained and recharged each day, also work well.
• Practice water conservation --- minimize building water usage and spillage from
leaking waterers, broken pipes and washdown through proper maintenance and water
conservation.
• Minimize feed wastage and spillage by keeping feeders adjusted. This will reduce the
amount of solids entering the lagoon.
Management:
• Maintain lagoon liquid level between the permanent storage level and the full
temporary storage level.
• Place visible markers or stakes on the lagoon bank to show the minimum liquid level
and the maximum liquid level. (Figure 2-1).
• Start irrigating at the earliest possible date in the spring based on nutrient
requirements and soil moisture so that temporary storage will be maximized for the
summer thunderstorm season. Similarly, irrigate in the late summer 1 early fall to
provide maximum lagoon storage for the winter.
• F The lagoon liquid level should never be closer than 1 foot to the lowest point of the
dam or embankment.
• Don not pump the lagoon liquid level lower than the permanent storage level unless
you are removing sludge.
• Locate float pump intakes approximately 18 inches underneath the liquid surface and
as far away from the drainpipe inlets as possible.
• Prevent additions of bedding materials, long-stemmed forage or vegetation, molded
feed, plastic syringes, or other foreign materials into the lagoon.
• Frequently remove solids from catch basins at end of confinement houses or
wherever they are installed.
• Maintain strict vegetation, rodent, and varmint control near lagoon edges.
• Do not allow trees or large bushes to grow on lagoon dam or embankment.
• Remove sludge from the lagoon either when the sludge storage capacity is full or
before it fills 50 percent of the permanent storage volume.

• If animal production is to be terminated, the owner is responsible for obtaining and
implementing a closure plan to eliminate the possibility of a pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:
• proper lagoon sizing,
• mechanical solids separation of flushed waste,
• gravity settling of flushed waste solids in an appropriately designed basin, or
• minimizing feed wastage and spillage.
Lagoon sludge that is removed annually rather than stored long term will:
• have more nutrients,
• have more odor, and
• require more land to properly use the nutrients.
Removal techniques:
• Hire a custom applicator.
• Mix the sludge and lagoon liquid with a chopper - agitator impeller pump through large -
bore sprinkler irrigation system onto nearby cropland; and soil incorporate.
• Dewater the upper part of lagoon by irrigation onto nearby cropland or forageland; mix
remaining sludge; pump into liquid sludge applicator; haul and spread onto cropland or
forageland; and soil incorporate.
• Dewater the upper part of lagoon by irrigation onto nearby cropland or forageland;
dredge sludge from lagoon with dragline or sludge barge; berm an area beside lagoon
to receive the sludge so that liquids can drain back into lagoon; allow sludge to
dewater; haul and spread with manure spreader onto cropland or forageland; and soil
incorporate.
Regardless of the method, you must have the sludge material analyzed for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The application of the sludge to fields will be
limited by these nutrients as well as any previous waste applications to that field and crop
requirement. Waste application rates will be discussed in detail in Chapter 3.
When removing sludge, you must also pay attention to the liner to prevent damage.
Close attention by the pumper or drag -line operator will ensure that the lagoon liner
remains intact. If you see soil material or the synthetic liner material being disturbed, you
should stop the activity immediately and not resume until you are sure that the sludge can
6

be removed without liner injury. If the liner is damaged it must be repaired as soon as
possible_
Sludge removed from the lagoon has a much higher phosphorus and heavy metal content
than liquid. Because of this it should probably be applied to land with low phosphorus and
metal levels, as indicated by a soil test, and incorporated to reduce the chance of erosion.
Note that if the sludge is applied to fields with very high soil -test phosphors, it should be
applied only at rates equal to the crop removal of phosphorus. As with other wastes,
always have your lagoon sludge analyzed for its nutrient value.
The application of sludge will increase the amount of odor at the waste application site.
Extra precaution should be used to observe the wind direction and other conditions which
could increase the concern of neighbors.
Possible Causes of lagoon Failure
Lagoon failures result in the unplanned discharge of wastewater from the structure.
Types of failures include leakage through the bottom or sides, overtopping, and breach of
the dam. Assuming proper design and construction, the owner has the responsibility for
ensuring structure safety. Items which may lead to lagoon failures include:
• Modification of the lagoon structure -- an example is the placement of a pipe in the dam
without proper design and construction. (Consult an expert in lagoon design before
placing any pipes in dams.)
• Lagoon liquid levels -- high levels are a safety risk.
• Failure to inspect and maintain the dam.
• Excess surface water flowing into the lagoon.
• Liner integrity -- protect from inlet pipe scouring, damage during sludge removal, or
rupture from lowering lagoon liquid level below groundwater table.
NOTE: If lagoon water is allowed to overtop the dam, the moving water will soon cause
gullies to form in the dam. Once this damage starts, it can quickly cause a large
discharge of wastewater and possible dam failure.

EMERGENCY ACTION PLAN
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ) — Lva- 6Lr6l
EMERGENCY MANAGEMENT SERVICES (EMS) a at -14"11 " 4
SOIL AND WATER CONSERVATION DISTRICT (SWCD) a _ 41-31M
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) a -1447 - 3710s,
COOPERATIVE EXTENSION SERVICE (CES) a5.A,- Z 41 - C583t
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters or
leave your property to consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location
for all employees at the facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be possible. Suggested
responses to some possible problems are listed below.
A. Lagoon overflow - possible solutions are:
a) Add soil to berm to increase elevation of dam.
b) Pump wastes to fields at an acceptable rate.
c) Stop all flow to the lagoon immediately.
d) Call a pumping contractor.
e) Make sure no surface water is entering lagoon.
B. Runoff from waste application field -actions include:
a) Immediately stop waste application.
b) Create a temporary diversion to contain waste.
c) Incorporate waste to reduce runoff.
d) Evaluate and eliminate the reason(s) that cause the runoff.
e) Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers - action include:
a) Stop recycle pump.
b) Stop irrigation pump.
c) Close valves to eliminate further discharge.
d) Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators - action include:
a) Stop recycle pump.
b) Stop irrigation pump.
c) Make sure siphon occurs.
d) Stop all flow in the house, flush systems, or solid separators.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to flowing leaks -
possible action:
a) Dig a small sump or ditch from the embankment to catch all seepage, put in a submersible
pump, and pump back to lagoon.
b) If holes are caused by burrowing animals, trap or remove animals and fill holes and
compact with a clay type soil.
c) Have a professional evaluate the condition of the side walls and the lagoon bottom as soon
as possible.

Assess the extent of the spill and note any obvious damages.
a. Did the waste reach surface waters?
b. Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone #, After hours,
emergency number: [phone]. Your phone call should include: your name, facility
number, telephone number, the details of the incident from item 2 above, the exact location
of the facility, the location or direction of the movement of the spill, weather and wind
conditions. The corrective measures that have been under taken, and the seriousness of
the situation.
b. If the spill leaves property or enters surface waters, call local EMS phone number.
c. Instruct EMS to contact local Health Department.
d. Contact CE's phone number, local SWCD office phone number and the local NRCS
office for advice 1 technical assistance phone number.
4. If none of the above works call 911 or the Sheriffs Department and explain your problem to
them and ask the person to contact the proper agencies for you.
Contact the contractor of your choice to begin repair or problem to minimize offsite damage.
a. Contractors Name: Murphy Family Farms
b. Contractors Address: P.O. Box 759, Rose Hill, NC 28458
c . Contractors Phone: [phone]
6. Contact the technical specialist who certified the lagoon (NRCS, Consulting Engineer, etc.)
a. Name: Kraig Westerbeek
b. Phone: (910) 289 - 2111
7. Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems
with release of wastes from happening again.
9

INSECT CONTROL CHECKLIST FOR ANIMAL OPERATIONS
Source Cause
BMP's to Minimize Odor Site Specific Practices
(Liquid Systems)
Flush Gutters Accumulation of solids
(✓) Flush system is designed and operated
sufficiently to remove accumulated
solids from gutters as designed.
() Remove bridging of accumulated solids at
discharge
Lagoons and Pits Crusted Solids
(✓) Maintain lagoons, settling basins and
pits where pest breeding is apparent to
minimize the crusting of solids to a depth
of no more than 6-8 inches over more than
30% of surface.
Excessive Decaying vegetation
(✓)Maintain vegetative control along banks of
Vegetative Growth
lagoons and other impoundment's to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
(Dry Systems)
Feeders Feed Spillage
O Design, operate and maintain feed systems (e.g..
bunkers and troughs) to minimize the accumulation
of decaying wastage.
O Clean up spillage on a routine basis (e.g. 7-10 day
interval during summer, 15-30 day interval during winter).
Feed Storage Accumulation of feed
() Reduce moisture accumulation within and around
residues
immediate perimeter of feed storage areas by
insuring drainage away from site and/or providing
adequate containment (e.g., covered bin for
brewer's grain and similar high moisture grain
products).
(] Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed.
Animal Holding Accumulation of animal
O Eliminate low area that trap moisture along fences
Areas wastes and feed wastage
and other locations where waste accumulates and
disturbance by animals is minimal.
() Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e. inspect for and remove or break up accumulated
solids as needed).
MIC -- November 11, 1996
10

Dry Manure Handling Accumulations of animal () Remove spillage on a routine basis (e.g. 7-10 day
Systems wastes interval during summer; 15-30 days interval during
winter) where manure is loaded for land application
or disposal.
(} Provide for adequate drainage around manure stockpiles
() Inspect for and remove or break up accumulated wastes
in filter strips around stockpiles and manure handling
areas as needed.
The issues checked ( ) pertain to this operation. The landowner / integrator agrees to use
sound judgment in applying insect control measures as practical.
I certify the aforementioned insect control Best Management Practices have been
reviewed with me.
(Landowner Signature)
For more information contact the Cooperative Extension Service, Department of Entomology, Box
7613, North Carolina State University, Raleigh, NC 27695-7613.
AMIC — November 11, 1996
11

. . ,
SWINE FARM WASTE MANAGEMENT ODOR CONTROL CHECKLIST
Source
Cause
BMP's to Minimize Odor Site Specific Practices
Farmstead
Swine production
(V)Vegetative or wooded buffers:
(✓)Recommended best management
practices;
(V)Good judgment and common sense
Animal body
Dirty manure
( )Dry floors
surfaces
covered animals
Floor surfaces
Wet manure -covered
(-')Slotted floors;
floors
(✓)Waterers located over slotted floors;
(✓)Feeders at high end of solid floors;
(✓)Scrape manure buildup from floors;
( )Underfloor ventilation for drying
Manure collection
Urine
(V)Frequent manure removal by flush, pit
pits
recharge or scrape
Partial microbial
( )Underfloor ventilation
decomposition
Ventilation
Volatile gases
(-")Fan maintenance;
exhaust fans
Dust
(V)Efficient air movement
Indoor surfaces
Dust
(✓)Washdown between groups of animals
( )Feed additives;
( )Feeder covers;
( )Feed delivery downspout extenders to
feeder covers
Flush Tanks
Agitation of recycled
( )Flush tank covers
lagoon liquid while tanks
( )Extend fill lines to near bottom of tanks
are filling
with anti -siphon vents
Flush alleys
Agitation during waste
( )Underfloor flush with underfloor
water conveyance ventilation
Pit recharge
Agitation of recycled
( )Extend recharge lines to near bottom of
points
lagoon liquid while pits
pits with anti -siphon vents
are filling
Lift stations
Agitation during sump
( )Sump tank covers
tank filling and drawdown
Outside drain
Agitation during waste
collection or
water conveyance
junction boxes
End of drain
Agitation during waste
pipes at lagoon
water
Lagoon surfaces
Volatile gas emissions
Biological mixing
Agitation
( )Box Covers
( )Extend discharge point of pipes
underneath lagoon liquid level
(-')Proper lagoon liquid capacity
(V)Correct lagoon startup procedures
( )Minimum surface area -to -volume ratio
(-")Minimum agitation when pumping
( )Mechanical aeration
( )Proven biological additives
12

{4
n
Irrigation sprinkler High pressure agitation
nozzles Wind draft
AMOC — November 11, 1996
()Irrigate on dry days with little or no wind
()Minimum recommended operation pressure
()Pump intake near lagoon liquid surface
( )Pump from second -stage lagoon
Storage tank or Partial microbial ( )Bottom or midlevel loading
basin surface decomposition Mixing while ( )Tank covers
filling Agitation when emptying( )Basin surface mats of solids
( )Proven biological additives or oxidants
Settling basin Partial microbial decom- ( )Extend drainpipe outlets underneath liquid
surface position Mixing while filling level
Agitation when emptying ( )Remove settled solids regularly
Manure, slurry or
Agitation when spreading
( )Soil injection of slung/sludges
sludge spreader
Volatile gas emissions
( )Wash residual manure from spreader after use
outlets
( )Proven biological additives or oxidants
Dead animals
Carcass decomposition
( )Proper disposition of carcasses
Dead animal
Carcass decomposition
( )Complete covering of carcasses in burial pits
disposal pits
( )Proper location ! construction of disposal pits
Incinerators Incomplete combustion ( )Secondary stack burners
Standing water improper drainage ()Farm access road maintenance
around facilities Microbial decomposition of away from facilities
organic matter
Manure tracked Poorly maintained access (f)Farm access road maintenance
onto public roads roads
from farm access
Additional Information: Available From:
Swine Manure Management 0200 Rule / BMP Packet
NCSU-County Extension Center
Swine Production Farm Potential Odor Sources and Remedies, EBAE Fact Sheet
NCSU-BAE
Swine Production Facility Manure Management:Pit Recharge —Lagoon Treatment:EBAE128$8NCSU-BAE
Swine Production Facility Manure Management:Underfloor Fluse-lagoon Treatment 129-88NCSU-BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE103-83NCSU-BAE
Calibration of Manure and Wastewater Application Equipment EBAE Fact Sheet
NCSU-BAE
Controlling Odors from Swine Buildings; PIH-33
NCSU-Swine Extension
Environmental Assurance Program: NPPC Manual
NC Pork Producers
Assoc
Options for Managing Odor, a report from the Swine Odor Task Force
NCSU Agri Communication
Nuisance Concerns in Animal Manure Management: Odors and Flies; PR0101,
Florida Cooperative Extension
1995 Conference Proceedings
The issues checked ( ) pertain to this operation. The landowner / integrator agrees to
use sound judgment in applying odor control measures as practical.
I certify the aforementioned odor control Best Management Practices have been reviewed
with me.Ole
(Landowner Signature)
13

MORTALITY MANAGEMENT METHODS
(Check which method(s) are being implemented)
( ) Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial will be at least 300 feet from any flowing
stream or public body of water.
(✓ ) Rendering at a rendering plant licensed under G. S. 106 - 168.7
( ) Complete incineration
{ ) In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agriculture.
( ) Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
14

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
'Kerr T. Stevens, Director
Moses Moye
Halfmoon Pigs
211 E. Horne Ave
Farmville NC 27828
Dear Moses Moye:
1 � •
A�t-
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
i
WASHG}GTON kEG!OPiAL OFFICE
ova
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 40-148
Greene County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRRI, IRR2, DRY1, DRY2, DRYS, SLUR], SLUR2,
SLD 1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerel /j
• 1A eeo�7
Kerr T. Stevens, Director
Division of Water Quality
cc: Washington Regional Office
Greene County Soil and Water Conservation District .
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
October 5, 1999
MOSES MOPE
HALFMOON PIGS
211 E. HORNE AVE
FARMVILLE NC 27828 R n M R
OCT 12 1999
WASIiINGTON pR1EGGIONAL OFFICE
Dear Moses Moye:
1 A�i
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Application No. AWS400148
Additional Information Request
Halfmoon Pigs
Animal Waste Operation
Greene County
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the subject application. Additional
information is required before we can continue our review. Please address the following by November 4, 1999:
Irrigation parameters musts be included in your Waste Utilization Plan (WUP). Irrigation events are to be
listed in the WUP as the maximum application allowable for that soil type from the time the pumps are
turned on until the time they are shut off_ It is currently recommended that total application amounts not
exceed one inch in any application event for any soil type. If the rates exceed the recommended one inch,
please have your Technical Specialist justify the increased application rate in the narrative of your WUP.
Please note that all WUP revisions must be signed and dated by both the owner and the technical specialist. Please
reference the subject permit application number when providing the requested information. All information should be signed,
sealed, and submitted in duplicate to my attention at the address below. The information requested by this letter must be
submitted on or before November 4, 1999 or the Division will return your application as incomplete in accordance with 15A
N.C.A.C. 2H .0200 and your facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid permit is a violation of North
Carolina General Statute 143-215.1 and will subject you to the enforcement authority of the Environmental Management
Commission.
If you have any questions regarding this request, please call me at [phone], extension 546.
Sincerel ,
S an Cauley
Environmental Engineer
Non -Discharge Permitting Unit
cc: Washington Regional Office, Water Quality
Permit File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
June 22, 1999
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Moses Moye
Halfmoon Pigs
211 E. Horne Ave
Farmville NC 2
Farm Numbe 40 -148
Dear Moses Moye:
,Tk?WA
I'll * '0
A&461 )
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
J U N 2 3 1999
WASHINGTON REGIONAL OFFICE
DWO
You are hereby notified that Halfmoon Pigs, in accordance with G.S. 143-215.1 OC, must apply
for coverage under an Animal Waste Operation General Permit. Upon receipt of this letter, your farm
has six 60 days to submit the attached application and all supporting documentation. In accordance
with Chapter 626 of 1995 Session Laws (Regular Session 1996), Section 19(c)(2), any owner or
operator who fails to submit an application by the date specified by the Department SHALL NOT
OPERATE the animal waste system after the specified date. Your application must be returned
within sixty (60) days of receipt of this letter. Failure to submit the application as required may also
subject your facility to a civil penalty and other enforcement actions for each day the facility is operated
following the due date of the application.
The attached application has been partially completed using information listed in your Animal
Waste Management Plan Certification Form. If any of the general or operation information listed is
incorrect please make corrections as noted on the application before returning the application package.
The signed original application, one copy of the signed application, two copies of a general location
map, and two copies of the Certified Animal Waste Management Plan must be returned to complete the
application package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
Post Office Box 29535
Raleigh, NC 27626-0535
If you have any questions concerning this letter, please call Sue Homewood at [phone]
extension 502 or Carl Dunn with the Washington Regional Office at [phone].
Sin rely,
1
V0_r_MW_-r_r. Stevens
cc: Permit File (w/o encl.)
{Washington Regional 0_ffice.(w/o encl.)
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

WASTE UTILIZATION PLAN
North Carolina Cooperative Extension Service
Thursday, October 14, 1999
Producer: MOSES MOYE
Farm Name: FiALFMOON PIGS
21, E. BORNE AVE.
FARMVILLE,NC 27828
Telephone # : [phone]
Type of Operation : Farrow to Feeder Swine
Number of Animals: 400 sows design capacity
Application Method: irrigation
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface andfor groundwater. The plant nutrients in the animal waste should be
used to reduce the amount of commercial fertilizer required for the crops in the fields where
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil tests are strongly
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
contents of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and avaialable water holding capacities. Normally waste shall not be applied to
land eroding at greater than 5 tons per acre per year. With special pre -cautions, waste may
be applied to land eroding at up to 10 tons per acre per year. Do not apply waste on
saturated soils, when it is raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DEM regulations. Wind
conditions should also be considered to avoid drift and downwind odor problems. To
maximize the value of the nutrients for crop production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied to bare ground not more
than 30 days prior to planting. Injecting the waste or disking will conserve nutrients and
reduce odor problems. This plan is based on waste application through irrigation for this is the
manner in which you have chosen to apply your waste. If you choose to inject the waste in
the future, you need to revise this plan. Nutrient levels for injecting waste and irrigating waste
are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for ananlysis. This waste
utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
4 00 ) Y
Page 1 of 9

AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
400 sows X 7.3 tons wastelsowslyear = 2920 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
400 sows X 6.5 Ibs PAN/sows/year = 2600 PAN/year
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown,
soil type and suface application.
TABLE 1 : ACRES OWNED BY PRODUCER
TRACT FIELD
SOIL TYPE &,CLASS- CROP YIELD LBS AW COMM ACRES LBS AW APPLIC.
DETERMINING PHASE CODE NIACRE NIACRE USED TIME
1454
2
GOLDSBORO 0-2%
CO
700
84
0
71
588
APR-AUG
1454
3
GOLDSBORO 0-2%
CO
700
84
0
15
1260
APR-AUG
1454
4
NORFOL 00-2%
FP
2.6
130
0
2.6
338
SEP-MAY
1454
4
GOLDSBORO 0-2%
FP
3.2
160
0
3
480
SEP-MAY
1454
4
GOLDSBORO 0-2%
BP
4.9
245
01
4.7
1151.5
APR-SEP
1454
4
GOLDSBORO 0-2%
SG
1
50
0
4.7
2351
SEP-MAY
1454
4
GOLDSBORO 0-2%
CO
700
B4
0
11
924
APR-AUG
TOTALS: 4976.5
Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirments. Beginning in 1996 the Coastal Zone Management Act will require farmers in
some eastern counties of NC to have a nutrient management plan that addresses all
nutrients. This plan only addresses Nitrogen.
Page 2 of 9

TABLE 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not awn adequate land. See required specifications 2.)
There are no Acres Leased
-- Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
* Acreage figures may exceed total acreage in field due to overseeding.
**Lbs AW N (animal waste nitrogen) equals total required nitrogen less any commercial
nitrogen (COMM N) supplied.
The following legend explains the crop codes used in TABLES 1 and 2 above:
CROP CODE CROP UNITS LBS NIUNIT
CO
JCOTTON
POUNDS
.12
BP
HYBRID BERMUDAGRASS-PASTURE
TONS
50
SG
SMALL GRAIN OVERSEEDED
AC
50
FP
I TALL FESCUE -PASTURE
TONS
50
Page 3 of 9

TOTALS FROM TABLES 1 AND 2
ACRES LBS AW
N USED
TABLE 1 43.3 4,977
TOTALS: 43.31 4,977
AMOUNT OF N PRODUCED: 2,600
—BALANCE -2,377
*** This number must be less than or equal to 0 in order to fully utilize the animal waste
N produced.
Acres show in each of the proceeding tables are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter
areas not receiving full application rates due to equipment limitations. Actual total acres in the
fields listed may, and most likely will be, more than the acres shown in the tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of
sludge at agronomic rates. The sludge will be nurturient rich and will require precautionary
measures to prevent over application of nutrients or other elements. Your production facility
will produce approximately 440 pounds of plant available nitrogen (PAN) per year in the
sludge that will need to be removed on a periodic basis. This figure is PAN when
broadcasting the sludge. Please be aware that additional acres of land, as well special
equipment, may be needed when you remove this sludge.
See the attached map showing the fields to be used for the utilization of waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of
irrigation such that runoff or ponding occurs. This rate is limited by initial soil moisture
content, soil structure, soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity Of the soil at the time of
irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of the
crop.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 5.92 months. In no instance should the volume of
waste being stored in your structure be within 1.7 feet of the top of the dike.
If surface irrigation is the method of land application for this plan, it is the responsiblity of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application rates and amounts.
APPLICATION APPLICATION
TRACT FIELD SOIL TYPE CROP RATE (inlhr) AMT (inches)
1454
4
NORFOLK 0-2%
FP
0.50
'1
1454
-4
GOLDSBORO 0-2%
SG
0.50
*1
1454
4
GOLDSBORO 0-2%
FP
0.50
'1
1454
2, 3, 4
GOLDSBORO 0-2%
c0
0.50
*1
1454
4
GOLDSBORO 0-2%
BP
0.50
'1
* This is the maximum application amount allowed for the soil assuming the amount of
nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Page 4 of 9

PLANS & SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division of Water Quality for every
day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer either
owns or has long term access to adequate land to properly dispose of waste. If the producer
does not own adequate land to properly dispose of waste, he shall provide NRCS with a copy
of a written agreement with a landowner who is within a reasonable proximity, allowing
him/her the use of the land for waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climate conditions, and level of
management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS) or
an Alternative Conservation System (ACS). if an ACS is used the soil loss shall be no greater
than 10 tons per acre per year and appropriate filter strips will be used where runoff leaves
the field. These filter strips will be in addition to 'Buffers" required by DEM. (See FOTG
Stantard 393 - Filter Strips and Standard 390 Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland, the
waste may be broadcast provided the application does not occur during a season prone to
flooding. (See "Weather and Climate in North Carolina" in the NRCS Technical Reference -
Environment file for guidance.)
*7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order to control conditions conducive
to odor or flies and to provide uniformity of application.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of a crop on bare soil.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
Page 6 of 9

shall be used when these metals approach excessive levels. pH shall be adjusted for
optimum crop production amd maintained. Soil and waste analysis records shall be kept for
five (5) years. Poultry dry waste application records shall be maintained for three (3) years.
Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina Department of
Agriculture regulations.
* Liquid Systems
Page 8 of 9

the outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other that an irrigation ditch or canal. Animal waste
other than swine waste from facilities sited on or after October 1, 1995), shall not be applied
closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal Waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landownwer.
14. Waste shall be applied in a manner not to reach other property and public right - of ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted croplands
provided they have been approved as a land application site by a "technical specialist".
Animal waste should not be applied on grassed waterways that discharge directly into water
courses, except when applied at agronomic rates and the application causes no runoff or drift
from the site.
*16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
*17. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc. are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and accessible. Lagoon berms
and structures should be inspected regularly for evidence of erosion, leakage or discharge.
*18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the possibility
of an illegal discharge, pollution and erosion.
*19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied as a preemergence with no other applications of
animal waste during the crop season.
*21. Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to mark
the maximum storage volume fpr waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soils shall be monitored and alternative crop sites
Page 7 of 9

NAME OF FARM: HALFMOON PIGS
OWNER 1 MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications and the operation and
maintenance precedures estalished in the approved animal waste utilization plan for the farm
named above. I (we) know that any expansion to the existing design capacity of the waste
treatment and/or storage system or construction of new facilities will require a new utilization
plan and a new certification to be submitted to DEM before the new animals are stocked.
(we) understand that I must own or have acces to equipment, primarily irrigation equipment,
to land apply the animal waste described in this waste utilization plan. This equipment must
be available at the appropriate pumping time such that no discharge occurs from the lagoon
in a 25-year 1-day storm event. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates that no runoff occurs.
NAME OF FACILITY OWNER: MOSES MOYE
SIGNATURE: 2n�st
NAME OF MANAGER (if different from owner):_
SIGNATURE:
DATE: / D -1
please print
DATE:
NAME OF TECHNICAL SPECIALIST: BRIAN TINGEN
AFFILIATION: GREENE SWCD
ADDRESS (AGENCY): 3 PROFESSIONAL DR. SUITE D
SNOW HILL, NC 285801332
(252) 747-3YO
SIGNATURE: DATE:
Page 9 of 9

Animal NVaste Management Plan Certification FILE COPY
(Please tyre or priat all information that does net recuirc a siynaturc)
QDor 'l,'e%v or Expanded (please circle one)
General Inform3tion:
Name o f Farris: , � Fac it i t y ti o:
owner(s) Name. 4 i _ Phone \o: qjq-'l 1'
.Mailing Address: crnkvE l­_r1Z"W n 8
Farm Location: Ccuniv Far;—n is located in: i�ktCn
Latitude and Lonsitude: e? i 55 7`� j Z'- c� 7"
Please anach a copy oI a county road mnap with locaiion identified an% descri(;e below (Be Specific: road
nacres. direc:ions. nulegost. CZ:.): 6c jV;ie Lp� . rA�;c i -�1 _A�: - Mctsz L.'2rN .- '.j S4
C- C ^i77iU U A % 41J A ^ti n „f
1"t N �! T-C i'1n1 (L.."rc L !�Z..�i c; +7C:'7.-: �a�t ZtG
Oueration Description:
's'ype of Swirre fVo. of.3rin:afs
Wean to Fecac:
_ Fee ._. to Finish
Farrow to Wean
11"Fa..,aW to Fttd-� 400
Z Fasraw' to Finish
Tape of ?oultn
D Lave.
=.t P•silcts
Na. of.-lrirncls
Other Ttpe of Lire
Tare of Cartle
ZI Dairy
Beef
Nc. of.4cirnals
Number q{Anirra!s:
Erpandina Opera.^.'ors Orslti• -
Previous Design. Capacin: riddiriora! Design Capacky _ -
Torcl Desiv., Ca,vacin:
.acreages available for Aupiication: i .77 Required Acreage: 60,-�.
\umber or Lagoons / Storm_ Ponds: 3 Total Capacity:___ Cubic Fez, (ft3)
Are subsurface drains present on the fa-.—n: YES or NO (please circle one)
If YES: are subsurface drains present in the area or the LAGOO\N or PRAT' FIELD lease circle one)
tie is acxxaex�ac?�xx:,cxxit Y, �c gcx��,�xxse re:*�t tic �r a���le �c�za[z acxx�:zap*rt}[a[st�Y�lcY?t acxsexx xYee�xgezxx zx:e x�[
Owner/.Manager Agreement
I (we) ve:ifv that ail the above inforr_ativo is corec; and w;ll be u:;Iced upon chans!inQ. I (wc) understand the operation and
maintenance procedures estaolis'rcd in the _:proved animal waste mama-zement plan fc: the farm named above and will
implement these yrccedures. I ('mac) .-tow that any e.tlansion to the existing design caraci[v of the waste tre2unent and
s:cra_se sysxrn or const:uc:ion of new facilities will reeuirc a new cenur::cadet, to be submitted to the Division of
Envi r, e:,tal �,'^,1_;C:,i4,^.t 1 t:�r� IhC ne'.t' ail,:.11s are StCC\_.'i.. l (we) underst=d- ii zc i ere mus-, be no disch&r_tg Of dnil:lal
waSre ra 1 the storas_ or apoliCatlon systc n to SU, ale w'atz.s of the slate :".rough a rn=-made convevaricz or
frCM a siorn e': en; less severe ::'xi the 2:`-y==:. 21=-hour storm a.^.0 EhCrc Must not be : i, Jii from the acplicadon or artlmal
tvasi_. I (we) understand that iu--off of pollutants fTt1r:1 lounging W-d heavy ll5e �__ us', be mJniruZed USln? C�:`initial
stare 5 dtveiC_"� by the. :: .a1 R_-$0UrCCS CCn5e7'1('V1 fie^ tCe. TRe _^r- cl:_. ,.Mil be filed at Eh,- i-T1 `nd at the
OiilCe CI r Ie 1CC11 Soil and `4'::_. Car atior .-}tit::... I itv; f that a' aiCl .Cat:C„ rn us: CC 27:rovcd.by a .__inns -'.1
50e:,a1'_, and Sl't=_-'tt'd to the Seal and «'ace. Ccr'ser.,26on DSSi.,_ prior to tt^:ie..,_-.C::an. A chXnSe in land Cwr'.-:ship
re^L:IC��'A':l:re" ni (ail:atlan to DEM cr a .^,e`.1' :_..tt::afCC ;tr i - _-'3t'e 5 -_ __j'.Litil i aO days
Nance of Land Owner: 7�I 5e", I l t =
Sature: t_n-Date:
J
1arne of -a nag rill ut"mm tivvn r1: _--
Si;nature:
���(' .. jr:'nLur" 1. 1Uc)_
Date:

Technical Specialist Certification
I: as a tc.hnscai specialist designated by the ;nor--`h Carolina Soil and Fate; Conservation Co_nmissicn pursuant to NSA
NCAC 6F .0005. 1 certify that the animal waste managernent system for the farm named above has an amzui waste
management Tian that meets or exce-eds standards and specifications of the Division of Environmental Management (DENT)
as ;;.eci fizd in 15 A NCAC 214.0' 17 and the L'SDA-Natural Resources Conservation Service (\RCS) and/or the North
C«roiina Soil and Water Conservation Commission pursuant to ISA NCAC 71-i.0317 and 15A NCAC 6F .0001-.0005. The
foilowing e'ements are included in the plan as applicable. While -each category designates a xchnical specialist who raav
sign each cc::it'tcation (SD. S1. WUP. RC. 1). the technical specialist should only certify parts for which they are te:Znicsfly
comaetert.
II. Certif cation of Design
A) Collection. Storage. Treatment System.
Check the appropriate boz
`3 Existing facility without retrofit (SD or W-UP)
Storage volume is adequate for operation capacity; storage capability consistent with was:c utilization
—requirements.
�'' e%v. ext;anded orretrofir+d facility (SD)
Animal waste storage and treatment structures. such as but not limited to collection systems, lagoons --td ponds,
have been designed to meet or exceed the minimum standards and seeciitcadens. -
\ame of Technical Specialist (Please Print):
Afriliatiori: & R
Address(AEencv): Phone No.: 724 -zn 9&1o1 -
Sianatur-_: Date:
B) Land .application Site (11" P)
The plan provides for rrunimurn separations (buffe:s). addauat: amount of land for warm utilizatioe; choscc crop is
5uitacle for wasie mana,eme:a, hydraulic and nutrient loading rates.
r
Name of Technical Specialist (Piease Print): 4M\I-
Affiliation:
Address (Agencv): 6 t. 'g;�ifi2_ Phone tio.: ck1tI-'7'7-31E
Signature: -
Date:_ 11-eta-a0
C) Runoff Controls from Exterior Lots
Check the appropriate box
-::r Facility «ithout exterior Ions (SD or 5"-- P or RC)
This facility does no[ contain any exterior lots.
l Fac;Iicv %c ith exterior ions (RC)
ale,hads to minimize the run of, .rorn loun_ginz and heavy use —--as h^ve been des_^_..:n
acc rcanc'xith tecanlc�l s=dards de%'e. - pC \RCs.
..
Name of Technical Specialist cPl:c_e Print >? k
�t4U-)
6L 5�k? Phar. No.: ql ` _I` q-
_ Si•nat�rz: - ,`- -..� - --- — - - --- ----Dace 1-Zio�i
AWC - .f r.c: _i. 1.199

D). Applicntinn and HzinG Equipment
Citeck the approprime bo.v
Exi�tirir or ext�anding facility with existing waste application eouic-meat CIA -UP or 1)
Animal waste application cquipmem spec;i;zd in the plan has been tithe: field calibrated or evaluated in
1c:ordance with existing design cans and tables and is able to apply waste as neccssary to acco;, mcdate the
waste management pian: (existing application cquiprnent can cover the area recuired by the plan a, rates not to
cxce_d Cahcr the spe_ified hydraulic or nutrient loading rates. a scheduic for upping of aooiicarons has beta
cstablls it.d: fequtre'' bL'rie:$ Ca.t'. -e �:1a[n::x: r.�d a;id CallbraUOD ;d adill sipper: ?i tc.7.ict 3:G Coat,;n'1 as part of
the plan).
i,..l New. expanded- or existing Facility %yithout_existing 'A'a=ie annil':26on ecuiDmem for spray'
irrigation. (1) - .
Aairnal waste a plicltion ezuin^eot s ec;Fied in the plan has eeca e'csiss:ed :o apply a;tm as rcccssa�, to
accor._madatr the waste management plan: {proposed aepiication e;uip Lent caa cover the asca rcc uired by the
plan -at rates not to G;C:__-d Gtt^.: Lbe Spa=:{:ems hydraulic or Li:'u`.e 1i loadinT rates: a sc'—=-Me for tim'ine of
applications has been esia.bllshed-. re a::Gd buffers can be c3llbra:icn and a& st%.er,t are
ConLained as part of tie plan).
J `ey . expanded. or existing -Facility tt'ititout existingwaste a^C_iication ec inrnent for land
sDreadinz not usinc surav ir„aation.�(NV P or 1) -
Animal waste application equipment specir:cd in the plan has bcen'sc'.ec:cd :o apply wastc as 1=cssary to
accormmodate the waste mana2cmect plan: (proposed application equipmeat can cover the area rewired by the
plan at rates not to exceed tithe: the spe:i:icd hvdraulic or nutrimnt loading rates: a schedule for titmine of
a=Llicltions has beta establish-:: rmqulrcd burftrs can be ma.irL:Ine_: calibration and aulC:strnent guidance arc
contained as pan of the plan).
Name of Technical Specialist (Please PI-int):6_i?sr%N �-N6--ems .
Affiliation: 5WU
Address (AQencv)Z PeCFES5,X 4.qu be- 6_,v5E d Snicw Hitt; Phone No.: Cj m _gy7-3_xg'
E) Odor Control. Insect Controi._-Ntortality'Nfanagement and Emergent.• .fiction Plan (SD.
S1. WUP. RC or 1)
The waste mana2em.c.4c plan for this iuc'.udes a Waste Ma--asement Oder Ccr.=oi Caec-2ist, an L.se: t Corcel'
Checklist. a Mortality .1vfanagemert Checklist gad an Emergency :fiction Plan. Sources of etch odors anal insects
have bean evaluat.d with respect to this size and Best Managt ncnt Practices to M':nirrize Odors and Best
Mana!mment Practices to Control Insets have beta selected and included in the was:e ma -nag - lent plays. Both the
. ruliry Managcmmnt Plan and the Eme gency Action Plan are complete and can ee implementea by tt is faciiit}.
1\ame of Technical Specialist (Please Print): 6_mlq= .v
Affiliation: 6
Addres!
SiEnatu
Date-
F) Written tNotice of New or ExD3ndin¢ Swine Farm
The foilo%%inn signature block is only to be used for ne« or expanding shine farms that begin construction after June
21, 1996. If the faciiity µ•as built before June 21. 1996. v',Ien Lti-as it constructed or last es; anded
1 Iwe) ce:.ifv that I Iwo; I ave atte a..d to car. _, by ._ni::e maii ail a4ioin: = p,t pc own e-s and ail : roceny cwne:s
LL'"o own _pCGp CtL' 1GCaCe'd aC:GSS 1 -+uol.c rc:! .. $;..�.. c: „_ ,Xz :CL)ri. this rivx or ....."'c s'. in:� ;.zr.7... TC' i.�^.t:C� was ;,I
COEnt"llanc: tS'a: the recuiremd 7tS l?t NCCJ 1C'd•� :- r j Gi Cho CCICi ^.0 1 ilSi C�frt C pLrr,e:5 nGl.,._ a
aC..ahCd. _
Nanie of Land Owner :
Si'_mature:
Fame of �lana<<ertit L ir:1: ::i :r.7sr i:e: --
_Sir�natCtt t' — Date:
AWC -- Janucr: 1. 199

III . Certification q'Installation
A) Collection. Storage, Treatment Installation
te%k% ec anded orreiroficred facility (SI)
Animal waste storage and treatment structures. such as but not limited to lagoons and ponds, have been installer in
accordance with the approved plan to meet or exceed the minimum standards and specifications.
For exisring faclli es w'irhout retrofirs, no cerrij cation is necessary.
Name of Technical Specialist (Please Print):_ Ze--' _`/,-a-j
Affiliation:
Address(Agency):� o/✓S2r1�. d Phone o.:_7_744
Date:
B) Land Aolication Site OVUP)
Check the aApropriate box
The cropping system is in place on all land as specified in the animal waste management pian.
0 Conditiorfal Approval: all mouired land as specified in the plan is cleared ;or playting. the cropcin_ system
as specified in the waste utilization plan has not been established and the owr.et has ccr, mated to cstablisa the
veget?tion as specitte in the plats by (monthldaylyear); the propos-d cover crop is appropriaLe
for compliance with the w•asteutilizatior, plan.
0 Also check this box if appropriate
if the cropping System as specified in the plan can not be established on Mewly c!eared land within 30 days
of this certification. the owner has cow -mitt; d to establish an interim crop for crosioa control;
Name of Technical Specialist (Please Print): 5t,M4 �, �.zrlGr +i ..
Affiliation: Svl
Address(Anency):,3 8Z&a51Maat, )(L _�JrM 6 S1y4 Lz�-n!G 0671:�O_ Phone No.: gt-7y5
Signature:
This folloNving signature block is only to be used when the box for conditional approval in III. B
above has been checked.
I (we) cenify that I (we) have com.r:i:red to establish the cropping system as specified in my (our) waste utilization plan. and
if appropriate to establish the interim crop for erosion control. and will wbcs.it to DEM a verification of complcsoa frora a
Technical Specialist within 15 calendar days following the -date specified in the conditional certification. I (we) re lizc that
failure to submit this verification is a violation of ere wase management plan and will subject me (us) to t•n eaforc=eat
action from DEM.
Name of Land Oivner :
Signature:
Marne of N1=32eriif different from own:.:i:
Signature:
Date:
Date:
AWC -- .Iar�u:�r� I. I1`17

C) Runoff Controls from Ex.,rior Lots (RC)
Fuciliry %vith exterior lets
Methods to minimize the runoff of pollutants from lounging and heayv use areas have btsn ins Lolled as specific d
in the plan_ -
For facilities without exterior lots, no certification is necessary.
Name of Technical Specialist (Please Print):
1f:iliacio :
Address(a pence):
SI2n2- E_=;_.
none No..
Date:
D) Application and Handling Equipment Installation OV P or I)
Cr:ecA rh: c� �ropr:ere block
Animal waste application and handling c.;uipr.;e It speciFmd in the plan is on s:, and.readt for use; calibration
and adios neat materials `hate been provided t0 me owners and are coatainr: 2s par. oft c plan.
Animal waste acvlicaticn and handling equipment specified in the pi4a has not been ins=iled but t c owner
hs prposed leasins or third p -,v application and has nrovide^ a sinned ccntrac;; equips cot spccired in the
cenr73z' agrees with the reouireme .ts of the plan: rcquircd buffers can be mainta.ir=, calibration a:-td
:,ciusM—'e :t Quida:t:c have bean provide—d to the o•.vners and are contained as par: of the plan.
�! Conditional approval: Animal waste application and handling equipment specifted in the plan has been
;.urea=:,d and -will be ea site and installed by fmonth/dayIVea the;c is ad;,-:;uate storage to
hold t ,e waste until dlic equipment is installed and until the waste can be land applied in accordance with the
cropping' system cont.�. i—ed in the plan: and calibration and ad}us:me nt guidance have been proVided t0 the
owners ar.d are contained as part of the pian.
Narne of Technical Specialist (Please P.:nt):
Aft.Eaticr'-- 4�9'av-E 5WC>
,e No.: 7y7-37y5�
The following signature block is only to be used when the box for conditional approval in III D
above h c been checked.
c_::i y that I (eve; have committed to purchase the animal waste application and handling couiprnent as
sczc;tted in m.v (our) %vast-- mar,aet.—ncnt plan and will submit to DEyi a verification of delivery and installation
iron a T e_=r,ical Specialist within 15 cale_ndar devs following the date specified in the conditional cerification. I
(we) re:l:i::,;:{ t311t.'r-- t0 submit flits venfication•is a violation of the wastes management pl?n and pill sccrect ine
(us) to an !nforcem--nit action from DEM.
Name of Land Owner:
Signature:
Name of .NIana,er-ii different f,cr;. own--: is
Date:
Signature:_ _ - Date:
E) Odor Control. Insect Control and Mortality liana?ernegt 15D. ST. WUP. RC or I)
tl: :iot's :O car {r01 040r 3i:d =:� as 5ZJe::; e to ...� ?!:.^. �t� ��3 :n?t.2.ti:!and ar4
-150 G:2:.,
Ni!r,ie o Technical Speciali_{ tP!ease P:Int'1• ,I��r�1^I
p' `l}.:
St_ .:{_ramp
Date: 1

Please return the completed form to the Division of 18'2ter Qualit-s- at the -folio wina address:
Department of Environment, Health, and Natural Resources
Division Of Water Quality
11'ater Quality Section, Compliance Group
P.O. Box 29335
Raleigh, i -C 27626-0535
Please also remember to submit a copy of this form along with the complete :animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a copy in
sour Files with your :animal NVa_ste Management PIan.
ANVC -- janu-jr.-v I. 1997

i

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B.. Howes, Secretary
November 13, 1996
Moss Moye
Halfmoon Pigs
211 E. Home Ave
Farmville NC 27828
SUBJECT: Operator In Charge Designation
Facility: Halfmoon Pigs
Facility ID#: 40-148
Greene County
Dear Mr. Moye:
WASHIN TG ONOITICE
NOV 19 996
106 L IL
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 919/733-0026.
Sincere ,
A. Preston Howard, Jr., P.E., Director
Division of Water Quality
Enclosure
cc: Washington Regional Office
Water Quality Files
P.O. Box 27687. �y4CRaleigh, North Carolina 27611-7687 An Equal Opportunity/Affirmotive Action Employer
Voice 919-715-4100 50% recycled/10% post -consumer paper

EMERGENCY ACTION PLAN
PHONE NUMBERS
D'VVQ z 'z—946-6481
E1S.ERGF-NCY MA-NAGE\IT-NT SYSTEM ZSz —7 — a!L
SWCD Za -747-3705.
NRCS i L -747-3705
This plan will be implemented in the event that wastes from your operation are leal:.inC,
overflowing. or running off site. You should not wait until wastes reach surface waters or
leave your property to consider that you have a problem. You should make every effort, to
ensure that this does not happen. This plan should be posted in an accessible location for
all employees at the faCi€ity. The followina a -re some action items you should take.
Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Acid soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from «ante application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c_ Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C: Leakage from the waste pipes and sprinklers -action include.
a. Stop recycle pump.
b. Stop irrigation pump.
c. Ciose valves to elirrunate further discharge.
d. Repair all leaks prior to restartin4 pumps.
D: Leakage from flush sy'st?r<<s, houses, solid separators -action include,
a. Stop recy pump
b. Stop irrigation pump.
C. 'Make sure no siphon occurs.
d. Stop all flows in the hoase, flush s%stems, or solid separators.
D:cember 18, 1996

e. Repair all leaks prior to restarting pumps.
E: Leakage from base or side<< al l of lagoon. Often this is seepage as opposed to
flowing leaks- possible action:
a. Dig, a small sump or ditch a%vay from the embankment to catch all seepage,
put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowinc animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for %vhat Duration?
c. Anv damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
Cr. Are Fotable water yells in danger (either on or off of the property)?
h. How much reached surface water?
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality)
re6onal office, V9-946-6481. After hours, emergency number. 919-733-3942.
Your phone call should include.: your name, facility, telephone number, the details
of the incident from item 2 above, the exact location of the facility, the location or
direction of movement of the spill, weather and wind conditions. The corrective
measures that have been under taken, and the seriousness of the situation.
b. If spill leaves property or enters surface water, call local EMS Phone number
Zf1 -747-2544
c. Instruct EMS to contact local Health Department.
d. Contact CES ZSZ- 747-583.1 , local SWCD office zsZ—747_3705
and Iocal itiRCS office for advice/technical assistance phone number
4: If none of the above works call 911 or the Sheriffs Department and explain your
problem to theist and ask that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off -site
damage.
a. Contractors Name: Yr L` 11_
b. Contractors Address: „ '
c. Contractor_ Phone:
December 18, 1996

6: Contact the technical specialist ,%•ho certified the lagoon (MRCS, Consulting
Engineer, etc.)
a. Dame: 4� Qrr--�` 714C':14
b. Phone: Z5L-747-3705
7: Implement procedures as advised by DN%IQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
3 December 18, 1996

Mortality Management Methods
(check which method(s) are being implemented)
❑ Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
/ stream or public body of water.
C�! Rendering at a rendering plant licensed under G.S. 106-168.7
❑ Complete incineration
❑ In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agriculture
❑ Any method which in the professional opinion of the State 'Veterinarian v.•ould
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must b.
attached)
December 18, 1996

ti
Swine Farm Waste Management Odor Control Checklist
Source cause / BMJf's to Minimize Odur Site Specific Practices
Farmstcad Swine production Vegetative or wooded buffers;
Recommended best managemcut practices;
ft� Good judgment and common sense
Animal body surfaces Dirly manure -covered animals Dry floors
Floor surfaces Wet manure -covered floors ❑ Slotted floors;
CI Waterers located over slotted floors;
d Feeders at high end of solid floors;
ICJ Scrape manure buildup from floors;
❑ Uudcr(]aor ventilation for drying
MWIUre collection pits 0 Urine; V Frequent manurc retnoval by flusli;,pit recharge,
• Partial microbial decomposition or scrape;
❑ Underfloor ventilatiun
VC1161aliL)I1 exhaust bans • volatile gases; - fj Kati maintenance;
Dust t1h Efficient air movement
Indoor surfaces Dust J Wasltdown between groups of animals;
d Feed additives;
❑ Feeder covers;
M Feed delivery downspout extenders to fccdcr
covers
]'lush Lucks Agitation of recycled lagoon ❑ Flush lank covers;
liquid while tanks are filling ❑ Lxtenld fill lines to near bottom of tanks Willi
anti -siphon vents
]lush alleys Agitation during wastewater ❑ Underfloor flush Willi underfloor ventilation
conveyance
I'll rcchalgc points • Agitatiun of recycled lagoon O Extend recharge lines to near bottom of Ails
liquid While pits are filling wills anti•sipllon vents
1,11t stations • Agitation duriu6 sump tank O Sump tank covers
filling and drawdown
Outside drain collection Agitation during waslewalcr O Box covers
or junction boxes conveyance
AMOC - November 1 I, 1996, llai;e 3

0
Source Cause HMPs to Minimize Odor Site Specific i'r.1 Ces
Eiid of drainpipes at
0 Agitation during wastewater
C
Extend dlschuge point of pipes underneath
1a60011
conveyance
lagoon liquid level
Lagoon surfaces
• Volatile gas cnlissials;
94
Proper lagoon liquid capacity;
• Biological Inlxing;
❑/
Correct lagoon startup procedures;
• Agitation
Lv1
Minimum surface area -to -volume ratio;
Minimum agitation when.pumping;
❑
Mechanical aeration;
❑
Proven biological additives
Irrigation sprinkler
I Iigh pressure agitation;
d
Irrigate on dry days with little or no wind;
nutlles
Wind drill
G
Minimum recommended o1wraiing pressure;
d
Purnp intake (tear lagoon liquid surface;
I/
Pump frorn second -stage lagoon
Storage tank or basin
Partial microbial decomposition;
❑
Bottom or midlevel loading;
surface
. Mixing while filling;
❑
'yank covers;
• Agitation when emptying
❑
Basin surface mats of solids;
❑
Proven biological additives or oxidants
Settling basin surface
Partial microbial decomposition;
❑
ENtend drainpipe outlets underneath liquid
• Mixing while filling;
level;
• Agitation when cnsptying
❑
Remove sellied.solids regularly
Manure, slurry or sludge
• Agitation when spreading;
❑
Soil injection of slurry/sludges-,
spreader outlets
Volatile gas emissions
❑
Wash residual manure front spreader after use;
❑
Proven biological additives or oxidants
Uncovered manure,
Volatile g.-rs emissions while
❑
Soil injection of slurry/sludges
slurry or sludge oil field
drying
❑
Soil incorporation within 48 lirs.;
surfaces
❑
Spread in thin uniform layers for rapid drying;
❑
Proven biological additives or oxidants
Dead animals
• Carcass decompositions
Proper disposition of carcasses
Dead animal disposal
Carcass decomposition
❑
Complete covering of carcasses in burial pits;
pits
❑
Proper locationlconstructiun ul'disposal pits
Incinerators
Incomplete combustion
❑
Secondary stack burners
mvloC - Novcniber 11, 1996, Pagc 4

Source Cause BMPs to Minimize Odor Site Sliccilic PI-.1 tires �.
Slandiiag water around a Improper draival;c; _ Grade and landscape ditch that watcr drams
facilities o Microbial decomposition of away froiu facilities
organic Iuattcr
MaiaurC tracked unto a Poorly maintained acccss mauls Vaiut access road maintenance --
public mails from faraii
access
Additional Information:
Swine Manurc Management ; 0200 Rule/BMI' Packet
Swine Production Fanu Potential Odor Sources and Remedies ; EBAE Fact Shect
Swine PTodelctiUn facility hlanaurc Manageulcut; Pit Recllarge - I.agoouTrcalnaCJit ; U-BAE 128-88
Swine: Production Facility Manure Management: Undcrfloor.�Imh - Lagoon Trealmcni ; GUA17 I29-38
Lagoon Design and Management for Livestock Manure "treatment and Storage ; LIME 103-83
Calibration of Manurc ant! Wastewater Application E(jUiprlacut ; Iil3AE fact Shccl
Conlrolling Odurs from Swine Iluildiugs ; P111-33
Environmental Assurance Program ; NPPC Manual
Options for Managing Odor ; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Mimure Mimagunent: Odors and flies ; PRO107, 1995 Conference Proccediings
Available From :
NCSU, Counly Extension Cotter
NCSU - 11AE
NCSU - IiA1;
NCSU - BAE
NCSU - 1lAI:
NCSU - IIAE
NCSU - Swine Extension
NC Pork Producers Assoc
NCSU Agri CUnMMIlieatioel5
Florida Cooperalive Emcw,ion
AMOC - November 11, 1996, Page 5

Insect Control Checklist for Animal Operations
Source
Cause
BMPs to Control Insects Site Specific Practices
Liquid Systems
Flush Guticrs
Accumulation of solids &f
Flush system is designed and operated
sufficiently to rcmovc accumulated solids from
l�
ttters as designed.
Remove bridging of accumulated sulids at
discharge
Lagoons arrd fits
Crusted Solids
Maintain lagoons, settling basins and pits where
Pest breeding is apparent to niinini7A. the
crusting of solids to a depth of no more than G -
9 inches over more than 30% of surface.
Excessive Vegetalivc
Decaying vegetation I/
Maintain vegetative control along hanks of
Growth
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
Dry Systems
Feeders
• Fecd Spillage C3
Design, operate and maintain feed systems
bunkers and troughs) to minimize the
accumulation of decaying wastage.
❑
Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
during winter).
Feed Storage
Accumulations of feed residues ❑
Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containmcgt (e.g.,
covered bin for brewer's grain and similar high
moisture grain produets).
❑
Inspect for and remove or break up accumulated
solids in filter strips around feed storage as
needed.
AMIC - November 11, 1996, Page l

I y 16
r RODUCER r MOS'ES MOPE
L I =r C r. a 10 N- 2::1 1 E Fl i= R NE:7 POVE .
- FAFOMVIILE -a \
PYRE
r- -.'=irT Jili�aa t ' _- erJ
trS J { f�,
NIU'.i -R I!- a�',i,�ilY„":LS: 4.010 iW es i gr: C:ap7.0 I -Y
I, _ rite fr-r:rn your an i rna i = -,= . I i ty must h!e i ant_ a pp i i ed at a s pr,_E_ i f i r
rat e, tc, pr"€i4 pnt po I I ut i on of S+ r-face and/Or { t!l.l i:3 lcter. The n i tint
nuts i erets I n the ar, i ma I was I e Shou l d Cie used 110 r el_uC$ th e ar'io ur,t c f
cori;rr3er c i Fr. I Pert I I i z e r r -C.L.0 I r'eE_ for the cr!-!ps i n t he T I e 1 d s where waste
is tF_: Le appl ie,j. This =asp a u �i 13 ai;iori p i a n us e, s i,itr-iien aS- thiL
1 Iris! t I f1 rrutr i er,t, if;aSte ri,r_s[l l r_' tie ar;a l y�ed hie €?rre each app i I Gat I on
cyc 1 e . Annual so i 1 test, are strongly encciur- jz-i- so th.Yt .=i i i plant
nutrients can tie teal ar,cei' fc.r real i St. i c yi e Ns +_., the crop to tie grown.
Sever -a. I fac tors are i fr por-t•arr - i n i mp i em*ent i rig your was :e Lit i I i zat i rC!n
F' l ar, in order- tci. •ma„ i m € zer. t�,e fertilizer- value f the' -waste and tc!
ensure that it is app l ied in an environmentally safe manner-. A I ways
a.F!p I waste based on t'he needs of the crop to be L:jrUWri and the nutr i erit
content of the waste. Do n!_!;, apply more nitrogen than the crop can
Li i II ze. So i I types are i mpc!rtarrt as they. have d i ffere:nt i of i I i tr-at i i_iri
rates, i each i n3 potent i a s, cat i on exchange capac i t i es, and ava.-i I ate l e
water- ho IV i rig capac i t i es. Norma I I y waste shla I I not tie app I i ed to I and
eroding at ;greater- than, 5 tons per acre per. year. With special pre-
cautions, waste may be app l i ed to land eroding at up to 1i? tons per -
acre per year. Do not apply waste on saturated soi Is, when it is
raining, or when the surface is frozen. Either- of these conditions
may r-esu I t i ri runoff to surface waters wh i ch i s not a l I owed under DEM
regu I at i ons . W i nd c+_!r;!j I t i ons shou I d a I so be cons i dpred to as,,o i d dr i ft
and downwind od-or- problems. To roax I m i ze the value of the nutrients
f, .r crop production and to -reduce educe the potential fCrr rill l l ut i on, thle
waste should tie a pp l i taJ to a growing Cr"i_rFr or clip I I er_ to bar e '_:�r"n and
n>>t more than tii0 days pr i or to p I ant i rig. In i e c t i n9 the Waste or
d i sk i ng w i I I c o n s e r v e nutr i en"ts and reduc e odor- pr-i_it= l ems.
T h i s p I an i s based on waste app I i cat ion through, i rr i gat i on fur th i s
is the manner- in which" you have chosen to apply your waste. If you
choose to inject the waste in the future, you need to r-ev i Se this
p I art. Nutrient levels f!_ r i niect i r:•q waste aril i rr i Siting waste are
not the same.
The est i mated acres nFedod .to app 1 y the an i ma 1 waste i _ based on
t y p ira I nuts i e n t content fi_!r- th, i s type of fai i l f -.r ey_ r-c-qui re-
inents si"fc!u l r1 be tia5ed on the was_._ a.ria i 7 s 3 s r"_ - !=star- wastc-
m. anao+'meri t fa.c , I i t y AAt"`-ched ou w i 1 1 f I r,d I of o mat i oln on pr Q p e r
sarn 1 i P techr, i !Ales; pre;Parr s, i o_;, an transfer !? f Waste =amp i es tCi
t he lab for analysis.
Thi_ isa s to uti I iF. c4'1=i!_!n p13r"r= iT carrieci r_rut, rri;RE s t __uir Er+: ii U=
-irf ! l i arrce w i tit 15 A i4-2I-!.C-ia'1T aI;{rF,tc L
,_=r r
0/ �.-,e _rIv : :,r,Fr, �i-i� ?.l
P'l .r,a-Pe rent C:c,mrn i ss ion G

WASTE UTILIZATION PLAN PAGE Z
AMOUNT OF kASTE FR DUC: `SEA YEAR (S a. 3 lo n s, t p v i s 9 etc.)
40C) t:iiws x f.= tons wnste/sows/year = w'.v_i -ons
AMOUNT 07 PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR'
400 sows m 6.b I b. l=_r: trisows/ y=aJ.r -- 2600 l b_ . P = y2a
fir°p l y I iio the r»biivto alit! u!:t of waste is a big job. You should plan t f ms
ynd hhaveappropriate egrs I equipment to apply the waste in a t imq ly itiattiler-.
Th 'fol lowIng acreage wI I l be needed for waste application based on
the crop to be grown, so i i type and kUr'I'a3Ce application. I

Ij
71-t.I
- - -�.-- T-.L---
'FIE' _1 = _
L 3 �, ---
C=�
!
--
C =ii�:
:
- - -
•'
ERVI I G
PHASE
i C=DE
A_
F
fDE
F
1
f
1
1
!
k
1
1 1 EFR'
f
?tC AC
1
1
1
k V``.1.- D
L
l----�--
f
1
I
1
1
[
1
1
I
1
1
t
•
1
1
i
t
I
S
I
1
T it NE
14
NUR PO!1__K i}--..
,wr
i
r - _
, .•1
E;
F
i�.i'
i.-r=. :
i
1
I
F
1
1
1
14 - N (;
_- �.-----------^-
14'ff. -4
--__--------------------------_
1 i
I G 0 L. Di L:1 � '!-1 _)
_.___--__-_____-------
_- __ __ __
__-___-
--------^--------
1454
14
-----------------_
iGLDS__R_
i�Pi4
aw
-----
iC
-<-_.--------
.F
i 15•Z'L.�,'.I
i
i
i
i
i
i
i
5 �F•_-
i t"IZ� -� �C, I
---------------
--------------------------------------------------------------
-_,
S - NAY
-- - --i ---^
1 4 ._i 4
1 �f ___.._,..
! 4
; --I_--- _ ------_.-."_.
I G O L D S li..• `..E 1 O 0- -Z %
--..�..........._...-
; -_ -
, C.
f - -
1 1 -4 rk
- 1 {----=
.� 1 t 1 -J r_� .
~ i i_..
2. 1 1 0
_ F-�-.-_._.M
1 8. -.
; - - { -
I i. '.= G_' .+ 1 2'
i MAR—JUN
_-----------____________________..----..—__--__--...__--_—_---..-_—_________
1454
4
i RA I NS
C:
.1110
: 137 .
t 10
W __—---
' '2 . 0
.-__— —..-,--
; '275
f
I
1
I
I
MAR-JUN
------------------------_--------------------------------------------------_------
14.54
t G
1 GOLDSBORO c_�-2
i C.
1 12F
. �� 1156.251
0
18. cF
� 11{1Z50
1
i
1
1
1
1
1
{ ���
! MAR-'JUN
____�___--•----_-_-
14t :
; ti
-.__-�-.________________-..-_---__--_.....-_-__.�.___----
; GOLDSBORO 0-2%
C.
125.
01. 156 .25
118.0
-. -_---_
1.2 _ 12.5
I 0
I
i
i
1MAR-JUN
----------
{ ___ __
I
1
END---------------------•'-
1
i
------
1
1
- -_-__
I
l
--------
F
r
------_-
k
1
--------
1
1
--------
k
i
----------------------------------------------------
TOTAL
Indicates that this f i e I d is being clvei-Sepd ,d ! i .e. i n t er pI;-anted
or winter- annuals ful low summer annuals.
NCi7E; The app i i cator- i s cant i coned that P and I-"' may be river- app. I i ed
wh i i e meet i nS the N requ i r-ments . Beq i run i rig i n 1'1'9 the C:toasta I `one
Management Act w i I I requ i re far-rrlers i n Sosme eastern c1,,unt i es of fa+-
have a. nutrient rnarla;c'r;.ent FIIan tisa_t addr-=ssea aI I nutrients. hi
p i ar! cIn I y addresses N i _r-c1Jcr,.

1� AS _I.. " Li _. F_ 1 A i 7 I I1,` i-'
ES WITH AGREEMi�_;'. _i i-iR .-�-'-';yam ,._`li°i L_E.�;;✓�
PAC a
(Ap-eerlient wi h -adjacerls ear, _'' er= ;:i_st be aGieiC del'.}
(Req1_ i r?r7l only if oiler at1jr elfc_= n0 : owri n-deQuate
i `Id. wee regLi i r-ed sr ec i # ] e u i on )
- - --_- - - - - - - - - - - - - - - - - - - - - - - ---_--------------------------------------------------
7.
. i : —. - -1 _. .i-ASS 1 L.:"i'_I!J i �. ��..- Bs 1 -i_!M ill N , 4-4
1 i r_1i= T tE r;r'; I ltt I fi-1A:11 = 1 FV N i FIL!-4 i A is i^.s=_; i
r I 1 1
r 1 1 I 1 r 1 Fr::
1 1 I f 1 1 I
I 1
1 f 1 1 1 1 1
._--------------------.«---......"..-----.....__----.._-------
T OTAL_ I
Indicates that this field is being overseceded (i.e. jrite,-07:n-ier=}
or wi nter annisr I s fo 111_Iw sur:7mer- annuaI s,
In i rlter-p I anted fields (i . e. sma I I grain, etc, i nter-seeded
i n tler-mudagrass 7 , fl_Irage ,bust be rernrrved through 9r-a.z i r{3,
hay and/ear- s i I age. Where gr-az i rig, p I ants shou I d be grazedi
when they reach a he i g h t Iaf s i :; to n i rle i Aches . Ca.tt I e
Shou I d be removed when p I ants are grazed to a he i 3h[t of f oL-Ir-
i riches. Ire f i e l d5 where sma l I grain, etc, i s t1_I be removed
for hay or s i I age, care shou I d be e,.er-c i sed not to I et sma I I
;bra i rl reach maturity, espec ! a l l y late in the seasor•1 ( i. e.
Apr i I or l±I aye . Shad i ng may r-esu i t i IF srn41 I 'ara i n gets tiler
h i 3h ar{d th i s wi I I definitely interfere with the stand of
Llerm dagrass. This toss of stand_ wi I I result in reduce,
yields and I e s s rl i tr-clgen L.e i n ? ut i l i zed. Rather their.
c l-ltt i n�; srriz. I I gr a i ri for hay or s 1 I aqe: ist be'F lore head i r,g c`is j
is the nor-mia l s i t-ua t ion, you are enf our-a.sned to cut the sma l I
grain earl i er . y°c,u may want to c ons i der- harvest i rig hay or
s i l age two to three times during the season, depending on
time smaI I 'grain is pIanted ire the taI 1.
The ideal t i rile to i rsterp I ant sm.a 11 ;brain, etc, i s I ate
SerLternLler- or early October. nr- i I I i r, i - r-ecornrne'nded laver-
broadcas t i n'g. Bermudagrass shou I d be ',jr_a`ed or_ rclwed tc, a
he 1'`hit of a%rrdui 1l r I r4C11e5 LlesGr e 1'S I {rl; t'-1rbest r c'aL� I ts,
ai ,acreage figures fi'- exceed total i rs fields dlic
over seed i nq.
,- l b s i, (- -. ;" rr f a was-e ri i t r- !_I e rl) e c u a l s
t ,_:

P riis =. ii.W 1 s, =r=3 - e S uScaQ i-! tawii
1
----------------------------------
I r_-i_"�� 4...1_i�� i
I"4' s
I
i
FL.�'z-�j
i !:���.':�. L)
k !'-1:...R sl=.S r
i
=
F
�vG; .� •L h I (''!-i tyy _z r, f: i_::. i
'
I
C.
_A.
-
F
�
_ 1
IS IN Al GR�AA NI OV-1-
i
i
TOTALS iTA Fr1 _iN I AIDLIES. 1 i I`MID ,_
--------------------------------
ACRES ACRES
1
LE;S A N USE_. ;
F
TABLE 1
I __
1 50.5
F
It
F
rif 23. 12=s i
TABLE 2
I_.--.—..'---------.-----------------
1 0
-.1- •
F
0 ;
f
1
f
,
[
1
TOTAL
F 50 . I
f
_ r "L . 12 _I ,
AMOUNT
f _ _ 3 __
OFI'Q PrRODUCED i
f
-_---_---2r�.t�c0i--- I
[
F
3
------------------
1
3
TCf i c number fiiu,.t be less than or egUa I to 0 in rsrl-ler to
fuI I uti Iiz- the animal waste N produced.
Acres shown i n each of the preced i rig tab I es; are cores i d e r e d to be the
usaf_I I e acres exc I ud i rig requ i red buffers, f i I ter str- i %' t a I onrg d i tc1"few,
odd areas unab I e to be irrigated, and prer i dieter areas no ti r e C F ! V 1 ng
full application rates due t.o equipment I imitations. Actual total
acres in the fie 1 r.1s I i sted may, and ukost I i k.e I y will be, !.fore than
the acres shown i rf I-fe tat, I es .
NOTE: The Waste Ut i I i zat i or, P I an must cunta 1 n pr�,v i s i clr,s f or- r:er j o0 1 c
I and arIp I i cat i k_In i r f s 1 ul'g e a t agri[num i s rates 11-1e s I uG`? w i I I=r
nutrient rich arid w i I I require pr c:cauU i ore_ ry l.cF
o v e r a 1:r p I i c a t. i [_3 r3 7_I I n u t r i e rr t s i i r [_F t I-! I_ r" elements. Your P. rU C t i OF
fac i I i ty w i I I pre_ d u c e a„r:rox, i Friat: i y ..i 4.0 p o u n d s an's
ava i ]able nitrogen (PAND per year in the = I udge tI"gut w i I ; ne t'n b -
rClr[=I'!e. ter! ct?r ji[E.'j.0 t._: i S. Tr! i = f i _;Lire i }.E= ! Clr= 13Ca= !r
i
T- ! i e 5 I tS IJ ^- e a L_• I r_? w e !. ITS ': ' r" f_'. ice. I-!
3. . i_i ! t j i I rj ;_' ! 7_ C e F_' ri w Y i 1
L seC€�I ayuipiTiiz'r;ip t€k'j` i.w rts'e-fie 4J

�.C: =:e LA s_ ..I 4m--or- v. _ LS'- f i ;..i,
I h i3 i L _, ?; _! r: : _ E I L _ 1 r.:-, r" . c= r.. _ i
! r- - L. I i I ; . = s.:'i a_ `I _ i 1 r. _ I' _I ! �: _ 3 I-: I rl !_ C, C I r
rl t r
C. i t ,., ur-C- i tzI y1t r_sr I r CIP 1 et = =e c"L rl
a r3i I_I I_III t `, I"; C, U nc e e d sI! _ C:.v yni -ai .,. �7' lf! "�.'3i ILL
a ' i_ ii e t rr[ e rI ! E I f ti a - . C r .I L - _ _ _ ! 1 % _ . i E. _
--:rI l i edi :cee'=- the r, ii' it`eI-I ri PcS 4h.'-.: Cr-Ci-I
.T I u r `c1 i; 1 ! I t y I ii !� �:' = I '-f rI e �_! o " .I. i_ ! c I _ _ ��: 'I. t ti -' rr !-1 :» c '�'y c '= :-r r' _'` t-
±r11, the tem. 'DraI-- I_'= r-C ii,-./eC lif the 3Vtr-aCje i:- !i-!ce G':_�;_.
T�
6 mi CI n i i "I S a I r; ri rt j r1 l a ri C_ = I= 1 I'=i i Cl = J rI j f {I t €�' =` 5 -' � 1 r' S `-` r '-[ i n
y._+1ur- _tr11'_tur'e b w i th l ri i A 7 Yee`l- Q} i-.he tii _ r;T _hs5
If 5ur- -ace I r-r- I ga -I 'n i - LhI ri,e t h od c!f I aild a1 I L ai. 1 C=ri iP -r th 15 I cLri J -
i t 15 .the r e s P --,1"iS i b I I i ty ±I{' the (-Pr'ildur—Pr and i r r- i gat I on 1:1=S i gner tI_+ er!*..:!:_I~
that o.rl i rr i gat i cin s.ysterri i s i nsta I I ed to proper- I y i rr- i gate the acres
shi,wn - i n Tab l es .1 and h. Fa i I u r e to a p p I y the r-ec orizri,ended rates and
amounts of N i trogen shown in the tables may make this plan i n. a I i d
Call yclur- technical spec i a I i st after- you receive the waste ana i ys i = report
for a55 i 5tance in deter-rrii n I nS the -amount of waste per acre and the proper
app I i c at i on rzte prior to applying the waste.
NAF;RA T I VE OF i_E1='FR ;T I i -IN'
wnrp- uTrLsz -mcAA
,w irtic'~u,7'cf
,3l..� Ptic.�E� av Go;zri
XK Z d
T►4�itl� SS
�D GGTur bC�•GE
OF Tr SGLsfcC',
N?Lr4 Cx7C{V
PiEEf>� e
� �¢� i otzti S iVar -ViG6Uze��
-r1ha f COe►�[
$ E y S r'< W�SE
rs�1�Yj E PrCI� GJ4e ,

kiAtia 'T €[::. U C 1.! i.
r -..
iN 1 a rl S a in d ,4j' jJ eC I fI C c. _ i _+
Arlima.I waste c-€ i n'?t roach. surface waters olF the State by rtir oPX"y
r] r- i f t F r€"ra r; his:=+ _ 3:-Q y:1 n C , d I r L C t a rP a C._ rt r" I Y _ 1 C_€ r
operation c-r land app l i car i crn Any d i zcr€ r =F C= Was �l
rea -hes sur ace +-ater- i= prohi_ritehz.r
tC. assE'4Ssment C! -C, c i `-1 i !'5•r1a I t i es C. f S; 1 C., 0 _'Le per- day tfy the D? I = i 0i-i
et--,frIV i r'i:r!F€? r€ = i ?': rr€ai �ef€'.ei'k fsrr Etir'r'y r=`3`? r €:w; SC 1F::r Se r" r li +
T he F i e 1 d 0F f i ce r€?S a ha'J;W do.cumen tat i on i P. t[he GE.,s i 2n fee I de•r' %fiat.
the producer e i 'Ier- r_wris or h!'.5 I c; r€'2 tei-r_ aCces'_. to adegLiaie..
I a n d t.ci prc,perl tic;pose of waste. I$` the r'dr-d_d]ucer does ricet Cher
adequate i and o pr o pE r I y f! i spC!se? of Waste 1iF4 Thal I Pr 0 V i de N
W i tf, a c c,py =_€f a 14r- ierI c"L7raemerlt w i th a I ar€d d w n e r who i s With€ i
a reasonab i e pi-o:-: i r,� i t'y, c"1• I I ow i ng h i rii/ner tiie- !_!.S=? eef t h a i a. rid
waste C pr_-r I I eat i on f F:e - the i i fe expectancy ce the produc t I on
fzac i I i ty. It i s ti",*_ re5T)ons i b i I i ty d_ef ti`ie IDWiler e:,f the f a,_ i i i ty
try secure Ei.r€ uprdale ?+f the Waste Ut i I i -at i on F• i an when there i
a charige i n the ciperat I on , i r€crea5.e i rl the nurr4ber of an i m .I s v
methCrd of ut i I i tat i on r or ava i t ab l E land.
Art i rtla 1 -write sh l I C+e app I i ed tit mPei. F but no 4 excee=� = ti:e
Nitrogen needs for real i st i c crop yi e Ids based on so i I type �
avai Iab IQ r€ioi stureS histf_er i cal data, cI ima t—'•_' cond itirj r€sr a,nd
eve I of managers€ent, un I ess there are re u I at i ons that
F eStC' i Ct the "rate of app 1 i cat i r=dn for- r}tiler- r€utr- i erkts.
An i ma I waste' may beer app I i ed to I and that has a Resource
Managerrient System (RMS) or an A i ter rat i ve C:oriser-vat i on System
(AC-S).. If_ an ACTS is used the so i I I oss sha 1 1 be no greater-
tha.r€ its .tons -pet: acre firer- year- and appr op ate f i I ter- str i ps
will Eire usedwhere runoff leaves the fie 1 d. These f i I ter
s t r i ps w i I I be i r, add i t i ern to " B u f fer r e q u i red by D E M
(See FCiTG -Standard 3193 F,i I ter Str- i ps and Standard _,•)i_i
Interim Riparian Fr_rrest Eiuffers) .
. Odors car, be reduced by injecting the waste or disking after
waste application. Waste should not be app i i erg when the
Wind is blowing.
Wher, an i ma I waste i s to be app I i ed on ac r-es subject to
f I ceod i rig y I t w i I I be scd i I i ncorpor-ated on convent I onai I y
t i l l ed crop i and. When app 1 i ed to ci_enservat i on t i I I ed crops
or- grass I arid, the waste may be broadcast provided the
application does not occur- during a season prone to
f I ood i ng. (See "Weather- and C:1 i t€gate in North Carolina" in.
the NRC.-S, Technical Reference — Envi ronme-rit file for guidance.
Liquid waste sha l 1 be app I i ed a.t r-a.tos no i o exceed �� he s„ i l
I of i I t r a t i on rate such that runof f di=E?5 no t. occur {rr'f 5 i to Cir-
to surface waters arid* in a method Which does not- cause dr" i ft
f r lrrkl t I€E? G. E 2 f=+fir : rEL:4 c'. p p I I CdG i i_rr€. 1af_r pd_d3€ L i r€w 5h C, u I d* C,ccuY
i n order - tie onttrc+ 1 conch I i cans c cl n d u c i ve to C.dC.r- or- f I i e5
and t-o prov i r_= €1r€ i form i ty of" app I I cat i on
;rI i r€,a I ways _.t-€a 1 i n o i_ try_ a.pp I 'see; to satur =t--e sf_= i 1 s dur
rairifaI I evc.rit_, or wnen t-.he surface iti =-M.r€.
,nimal t,aM-te Ck:al l to a tee r_rn a.ctivei =y- ,F.:ine Cr_Or,s iri
such a mariner- _€a.t r;+-< more -than Z0 -3 =e; __�rlI.� e_ef the h ea�
area i,s covered.

m
I._� I .1.:... .�. a-.. i 1'-I !''i
t e I -I lS 'i: Ii f� I'I ':... '� I-: r !-! _ ['3 r- a F,' €-i I 14:' 17 I rl i w, i I ��� - __ -
`-''C'f i neia T;-i_iI- j�i ih: y }! I `. p:.te�_-
CcC:"r i ns Waste r!utr" i cre = I !'asJ I r!ra.,%;es Carl th u `?
LI J t`:e !€ei J t c a r r. ir[ r;fUrP ai'I'a a suI Yctt€ie 'wint r C=+ TF
Cr-,ji anted i±, tak.e up r e ; ea s ed n.1tr i e n t s V!a._ha I
r-10 t. b aF.P I i t d m di a ys p,r" ::i7 I aF-1t' P.
[_rup un t!ar a so I w
W5n I rr.a I wa,F,te ssha 1 1 n--�t tie a.1 i t'11 r_ i 0 s e r th an ', =e o
sut-fa..--e wat'2r". 'I h i s d- s ra 1 c e r±lay C, r-P.duc F i} _, - r-
t' iia. t�
a.r _ r!fi rier-enn i a I p :iV i`� ` aC.,P I!! 3.te. vs: _etat I Ve � 1 z_er st t- I -I=
are presant. See S l-1€n d _`:'__ - I'- i I ter- Str- i 'n
1 F.rl i Tr- a. I ww«ste s;ha I I nc. w F,_., a P p I I e. imp r I user thar! IC)
9
1 3. An i s!1a I waaste s h a I I nor. tie =pr:. I I ed c I user - than
d td e ! 1 i n,2 s othler" tl`ir"3. n t1',os e c,wrFed t'y th!e 1 a.nd _p'r'nP .
14. :.=ste shall tie a1-=p I i L�' i r! - r!anner" rl!:'t tuff r"ttaCl€ Y`:et
pr i' D e r`ty ar,d P U b 1 i C r- i 9�: t- 0 -F Way ems.
15. An inia.l waste shaI I n jt tie d I sChar-gel."€,' i nt-j sur-f•a.ce--t'n.t ers,
dr-a I nag ways, or- wet I and by i1 i scha.r$e or by over -spray i rig .
An i ma I waste may be app I i ed to pr- i or cC!r€t: erted wet I ands
provided they have been ap prcved as a land arzp I�i Cat i or€ site
by a "technical sFFecial ist". Animal waste should nut to
applied can grassed waterways that discharge into w�ater-
courses, except when applied at air onom i c rates and the
aDp I i cat i on causes no runoff car- drift from the site.
I . D u m e s t i s and i ndustr- i a 1 waste f r o m wa.shdown far i I i t i es,
showers, to i I etc., s i nF::s, etc . , sha l I not be d i schar-ged i nto
the anima! waste rsiarFa'aerrsent system.
17. l_a'gocans and other uncovered waste containment structures
must maintain a ma..; i rnum operating level to provide adequate
storage for a 25-year, ':4-hour- storm event in addition to
c.ne ( 1 ) f u o t mandatory f reeboard. .
IS r, protective cover of appropriate veoetat i on will b
estat€ ! i shed or, a I I d i stun bed areas (! agocin embank-:rnents,
berm's-, p i pe runs, etc . ) . if needed, spec i a I ve'getat i or,
shaI I be pr ovi ded fthese areas and shaI I be feF,Cr-,7. as
necessary, to protect the vegetat i on Ve'getat i on such as
trees, shrubs, and other woc,dy spec i es, etc . are 1 i r:i l ted to
areas where clans i der-ed ar-Pr-r+pr i ate. l_ag'-"_'n a.r"eas sa ou 1,1 be
!-::ept rnjjwed and m.cCess i b I e. Laacion berms and structures
she-u I d b-2 inspected r-equ i ar I y for evidence of e:r c;: ! om, I ea.'ct'�u
or discharge.
1'"'. If an I riia I Product l or, ---t the fac i I i ty i i. ti, tie SUSIDEFLIJef� Lj>-
rerl€i i nated, the >_iwr,er- i s r-espons i 11 i f for_ obta i ri i n,z a.nd i mp: I r, —
rf= C' r= t I n a' C I? s U r E F° l a ri `' i! I C i F w' i I l e l I rri i ri : t e t i: '_ s = i r, I l 3 y
c,f an i I l ea€ d i si_hL,r ,_e, pu I I ut i on and e r c. s i rl
i ng S ti.r-u_tllr es, p J r, i n`, i-€!�r1}�€=., r"E'C I _ - _- 4f'-._�u i t
tre f ri PF: t;ted !jrf a r-"a!I 1 ar tars f s tij i cs' '`
an E. ! 1 Is. ?. re'Lqu!ar s'nair,tEr!a,rice cheCI:1 icl=i!:<_. _ :"; l
='r: S I to .

OWNER MIANIAGER' AG
i ( = u ;rJ-�r stand and wi 1 i f'J i 1 C,W a.r!ri i:i=?€ewT-1 the E.-E,
u. ! . G-M t 1. _ o i-' c. � 3 1, i c. r. __ r ; d r r! t e n a I S c e 1-',- i C c_.'-_-! � f _ - � r I_l [ - - rt -
S i C .. = f � a 3 -r i r i F cL 1 W1 EL S <. E_- ,. 1 Z a ti. i 0, Fs p I a ^ AP 17_ . i- :h ri Li. m c ' s. F1 !_
4 W ; i k' r; � f W t h -1 t s,l I-! ,r' fl ; 1 r a IF: '--7. I r=i I 1 t c, t: h e --- .x i a t i n d _ I �� I I c a r_h
4?":i.t_ -r ez-- :fi€'ui--F ; cii!+ _''us- >_�.�r_!r _e {` s—i�'rr�; c,r [�:�;!s Y'Ll l I ri
f?.0 i 1 I :1 I eS Will r-equ i t = r,r=w €J,t i 1 is t i ='i'I ;-I i .ii i1"€1" a ncaw r� -; r 1'_ _!.t f iif!
=c b,e Subr€, I tteQ, isi-r ir_i. +=r F Fie new a.n Ii;::':1 a r e StC,C i
d e r" 'a t a jI-.;. L (I 3�� _ h a,T€ � u 'a i..t.. li
[i r,.,� .c, r F ! _: -.! = c' •_ � � : c, e :-
�� u l p (!
m a, r i 1 �; i r r i 3 a Jt, � € _.. i-f e u € =� . P.r i € g o I e € d' a. I_=. p ] -�' [. FI c d rl i rl € _
d v r- i b rj r r€ t 1-1 15 W a x c !a t i I i z .a t i Err€ p I i rl 1 T ?q u I rs t mu _.
ava i i L:b i e at the app o'er-' ate purr, n I rl '� i?i =uC.I€ t1€at- r€o d 15rr€ar- e
r-:cC€ rs -F'ci;n t;:-ie 1 a.'3ocln I n a . 5=,-ye at- 1 - d a-v s'1<o r m evc- r,t 1 ,-a 1 o c:Pr-
t I -Py` t1!al 4.he waste w I 1 1 bR apr-' I i ed cr-ri the 1 c.€.r€d cl..rCE'rd i !l IC o th i 5
p I a, -i _t th e appr-ii1-'r 1 ate t [ (lies and at ra.te that I - €I} i' llrli=i'i s' o--cur-5.
NaAMF I IF F A C I L I TY i�-jWI DER : MC-1-SES lY OYE
SIGNATURE:
NAME OF MANAGER (i f- d ifferer:t fr rrt owner)
please print
SIGNATURE: DATE e
NAMiE 1-"F TECHVi L'CAL S?='ECIALIST: Dede DeBrUhI
AFFILIATION: NRCE5
ADDRESS (AGENCY); 2 Pr-ofe5sicnal Drive S€-ite 1:
Snow Hill NC zc-:5:z-:o
SIGNATURE:
DATE ` _ 7716 j_z L — — —

�.�[; [ Y {.`+. i�::•.���r�i}.i T$. �t=o'Y'*r ,:,. , �+i� '7.9'1 •.•�t:'•i.��r+�ti'� ,wr.�'ti<a(.�,3' .•i yfl�i -������
.66
INV-
W��n
J;
(�,;r i , ai• i :` 1!1 46 rJ �?S1 ? a'S 1HMj' c 4T
. s;�,ti2y y,•_.-��If_.:tl..ti!`'t',IJ�ae,:4yr�j �% ". ��•t� k4- 7iti'�/',', •-
I�
Jyla. ��I ir�t`-`rt� + ,d•� �S! •�.a{� 1.'�i `�^,6 ,• ���hI�C�'��a:'I"'�• ri`
• w � r, " � v� 1. �� 1 y , ; � � I �
J`r�'"'�'k+�, Ih
��//'/p,�{
11"i F
j Jt •� I .. I y!j'
�l'"-.,i� 1 S ••'�I �`3�'y��'4�F!��y."{t;'�.4�u>���
��` ��'�f„ k �• 1\ Ufa" t�FS r�jfi f 'r�' `rh f
� 1 ��'� � i ��w ��tii� fE�•� lii
Sr �.1 � •,fit � Ft t��,�• r� , � � yf� �l,
+t �� : ;I�'��. • �'-^Y� t�1 [�`.' .,' `�,r �'.,` �F4a'gyZL�i��r1?f y�� � ® 5' -� �L�.�� �1i,ir
ffir ��rj�•1 vet :�iRL'IIy'T�!0��;` rr �1 .t .' 'M 74� ��:,� i• . 7,h .�� 1
't' '•• ._4; �'' •` - :;i �,��4''�,�yr.. " it �•° �°��'�•�k";'. , f��, /�q�":;,:,'°} ''
t} rah
15
•� � t4F4 �1 � rr n�''j t - � 2',
�,� i1�' Nf'/.{.!�' ••� { �•dir.: �4�d'!a 4 �Yia �I _".L�
� r� •IF t^r•• 4 t � A ', ry.- '}��r.\J.rri �:b...i`r1Y': -.
�,4„y .•`' , G ' ,�[i�k1!�n�yr�`•. ,u'-, ,� at 4'''"� �s'..
�; r : i..i t �� + .. �.rY�r�. �A► rV•"r fey' 1
jr' .•1± SW+A�n.. ,i'`;..: 1'�. � r� ." ,Jvt �,i � f �'+ •�'li; '' 4'4��' I'� l
1�wya�rC�n'1i i��y S Alp"
. r 'tii`tiM \ • 'JF4 {- 'S. �} ,lv� --�' �' �1''hn1A. � �,' b
�.,r,lti,., i1 � . t ,.t{ ,a 1 • j �1y� ;1� . •5 • I f k' 7�'�'jf� {1ti ��p�{�tr '� j }?�4�
�ihliiJ:��;"��f,���:t,. ;_ �,j rI• ' •r•�i��`,,rjF .. �17 4\'�,� 1; .'�
i 11r 'tt - r%'i f / 1 • ,(. }l `Y�•, �;� �+''4rLTa�•i a{- ,. ,>IVI ;.
��;. �y" 1• �" �7r'� �ti�}�4Jif II' '��.31 +' � 'I fi.' ��1"�°mow ';� �� ;(Y� •{
a,t!-\� �". ��-,p��Z�+.7(le Ar.f„i, ..�,,�" "�'°' y,.y•F �1 ��0•(':i-. 1',h
?-. •l� ayr '�: r a s1 .� t ij _ +lr 1.`.. !. } I f t�S,��Y1�[ 4 �
y1{4 �V -i'Sn' r !}IS I a5 I t I ' ��. � ' . r�• �IY }' � 1y ' � � '.
I�t'r1'If4�,4•"Y5+1 '1"e' ' ✓r 4r. .,,.,^"� f Y'' -t !al`f ":

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
January 28, 2000
MOSES MOYE
HALFMOON PIGS
211 E. HORNE AVE
FARMVILLE NC 27828
-NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRC?.UxIENT AND P4ATU AL RESOURCES
Il
j
FEB - 3 2000 ..,
Subject: Certificate of Coverage No. AWS400148
Halfmoon Pigs
Swine Waste Collection, Treatment,
Storage and Application System
Greene County
Dear Moses Moye:
In accordance with your application received on July 13, 1999, we are forwarding this Certificate of
Coverage (COC) issued to Moses Moye, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Pem-lit
AWG100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the Halfmoon Pigs, located in Greene County, with an animal
capacity of no greater than 400 Farrow to Feeder and the application to land as specified in the Certified
Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and Iimitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Certificate of Coverage AWS400148
Halfmoon Pigs
Page 2
This COC is not automatically transferable. A name/ownership change application must be submitted te.
the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is Iocated in the Washington Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Susan Cauley at [phone] ext. 546.
Sincerely,
Kerr T. Stevens
cc: (Certificate of Coverage only for all cc's)
Greene County Health Department
Washington Regional Office, Water Quality Section
Greene County Soil and Water Conservation District
Permit File
NDPU Files

s . State of North Carolina
Department of Environment and Natural Resources�j,./,rr�
Division of Water Quality
Non -Discharge Permit Application Form JUl
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS ,fN ORIGIN.-tL)
General Permit - Existing Animal Waste Opera#io��shNr . -
The following questions have been completed utilizing information an file with the Division. Vlease
review the information for completeness and make any corrections that are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
1.1 FacilityName: Halfmoon
1.2 Print Land Owner's name: Moses M
1.3 Mailing address: 211 E. Horne Ave
City, State: Farmville NC
Telephone Number (include area code): 252-746-9395
1.4 County where facility is located: Greene
Zip: 27828
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): From Kenansville, take NC 903 N to Snow Hill,
continue on NC 903 N thru Maury to Ormondsville: at Ormondsville turn Lt. onto SR 1335 and oo 1.5 miles to faun
entrance on Lt_
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Murphy Family Farms
1.8 Date Facility Originally Began Operation: 05/01/85
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: 40_ (county number); ____149 (facility number).
2.2 Operation Description: Shine operation
Farrow to Feeder
400- Certified Design Capacity
Is the above information correct? [Kyes; no. if no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum num er or which the waste management structures were designed.
Type of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle No. of Animals
0 Wean to Feeder 0 Layer 0 Dairy
0 Feeder to Finish 0 Non --Layer 0 Beef
0 Farrow to Wean ("M sow) 0 Turi:ev
0 Farrow to Feeder (i sow)
0 Farrow to Finish (4 sow)
Other Type of Livestock on the farm.- No. of Animals:
FOPUM: AWO-G-E 5/28/98 Page I of 4 40 - 148

23 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system).: 98.7 ; Required Acreage (as listed in the AWMP); 50.5
2.4 Number of agaon / storage ponds {circle which is applicable): I
2.5 Are subsurface. drains present within 100' of any of the application fields? ES or NO (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or 9 (please circle one)
2.7 Does this facility meet all applicable siting. requirements? (Swine Farm Siting Act, NRCS Standards, etc_) (Swine Only)
YES or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? N,1
What was the date that this facility's land application areas were sited? I - it
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided neat to each
item.
Applicants Initials
3.1 One completed and signed original and one copy of the application for General Permit -Animal
tn`N
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components. Some of these components may not
have been required at the time the facility was certified but should be added to the
CAWMP far permittingpurposes:
33.I The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.1.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
33.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
33.7 The PAN applied to every land application field.
3.3.9 The waste application windows for every crop utilized in th.e WUP.
3.3.0 The required NRCS Standard specifications.
3.3.10 A site schematic.
33.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
33.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility_
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal..
FORM: AWO-G-E 5/28/98 Page 2 of 4 40 - 148

Facility Number: 40 - 148
Facility Name: Halfmoon Pigs
JFC
iV,-17P nIJ4, O
VU11 E�9�
4. APPLICANT'S. CERTIFICATION: jVan.prscharge juettl-i ,
1, (Land Owner's name listed in question 1._4 attest that
this application for i7Ai.r=PIC': ' PiG S (Facility name listed in question LI)
has been reviewed by me and is accurate and complefE to the best of my knowledge_ I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are. not included; this application
package will be returned to me as incomplete.
Signature Date
J
5. MANAGER'S CERTIFICATION: (complete.only if different from the Land Owner)
(Manager's name listed in question 1.6), attest that this
application for (Facility name listed in.ques:tion 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge.. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, FNCLUDING. ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE. FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5/28/98 Page 3 of 4 40 -148

OPERATOR:
NOTE: Design Requirement: ft. = cu.yds.
Estimate of Excavation: CU.ftcu.yds.
Estimate of JLa-& Dike:
z : % Ratio
Job Class
Date
Cu-ft. =2709Cu.yds.
Design By 4-2. --�_-_�-
Name
Design Approval, e:V '
Name j
Date
DEC 2 7 1994
0

oe, 0 o
mt7 z w
zZ, r
CIL rl -TI r-
C7
w77 e (I Cl) + -4 z J
-I- r/ r 0
I
c r C cz; IC

operator:MOSES MOYE
County:
rGREENE
Date: 6/03/96
--` an - to nearest w!vs_jeRce
(other
r_han r_i7',1:=r):
1800-0 feet
1. AVERTGE LIVE tvETc=HT
(ALAI)
0 sows (farrow t_
finish)
..
1417
lbs . _
0 tow_ U arrow to
teeaer)
,:
522
lb . w
0 heaa (finishing
only)
Y.
135
lbs.
0 `OWw (farrs_>>rt' to
weanl
1_
433
lbt . -
0 heA ( wean to feeder)
-.
30
lbs .
Describe other , ther .
Total Average Live Weight
G. MINI1V7TM REQUIRED ,----1:TrfIsE3T VOLUME OF LAGOON
0 lb=
Volume =
0 lbs . ALW x Treatment. Volume € C°F) /lb. ALW
Treatment
Volume (CF) /lb . ALW = 1
CF/lb . ALW
Volume =
0 cubit_ ft. ('includes- 0
cu. ft.. add. treat-. vol.)
. STORAGE VOLUME
FOR SLUDGE A{`_''CUMULATIO
Volume =
0.0 cubic feet.
4. TOTAL DESIGNED
VOLDME
inside top
length (feet) ---------------------
265.0
Inside top
width (feet)----------------------
125.0
Top of dike
elevation: (feet) -----------------
53.80
Eattem of
lagoon elevation (feet) ------------
43.00
Frs. _,aw3
(feet) -----------------------------
1.0
Side slope
(inside lagoon) ------------------
2.5 1
Total design
volume _:sing prisn'oidal fry_., la
SS/END1
SS/END2 .`.'.S/SIDEI SC/SIDE2. LENGTH
G.IDTH DEPTH
2.5
2,5 2.5 2.5 260.0
120.0 9.8
AREA OF TOP
LENGTH * WIDTH =
200.0 120.0 21200 (AREA OF TOP)
A�.. AREA OF BOTTOM
LENGTH * WIDTH _
2 1 0 r+ a h-= s R7 -� � L.. r-1T.4 t
.mil . .. i. _ _ - - 1 `'-_ -' - _— -•
AREA OF MTDSECTION
LENGTH t 4 W 1-DT . - F
SECTION
C , FT. - [AREA TOT T (44 AREA MIDSECTION! - AREA iOTTOM3 r DEPTH/6
31200 _ '9 r6 l '! 4 9 81 1.6
Total, Designed Volume Available - 222365 CU. FT.

r
5 _ TEMPORARY STORAGE REWIRED
DRAINAGE AREA:
Lagoon (top of dike)
i Length * Width ) + Surface area of conneLtinE waste facility
205.0 125.0 33000.0
66 25.0 square feet
Buildings (roof and lot water) or impervious re
0.0 square feet Describe this area.
TOTAL DA 66125.0 square feet
Design temporary, storage period to be 180 days.
5A. Volume of waste produced
Feces & urine productions in gal./day per 135 A. ALW 1.37
Volume = 0 lbs. ALW/135 lbs. ALL,, * 1.37 gal/day 180 days
Volume = 0 gals. or 0.0 cubic feet
5B. Mune of wash water
This is the amount of fresh water urea for w :_ruing flc: Ors _.r v'�i,wrL
L fresh water for = flush Flush c 1 - mot;
�,, L� .S[; 'r��t•_ __4�.4.. iL� -. flzial: system. �1.I _ .. .yGt.F�f1:� �.(1.=::_ _'}=�.�? � � .._
' the lagoon water are .accounted for in 5A.
Volume = 1400.0 gallons/day X ISO days storag`=/7 , LR gallo._z
per CF
Volume = 13689.8 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
.
160 days evaporation = 1S . 5 _n';he
180 Yayti rainfall - 22.5 inch_
Volume = 22.5 in * DA ! 12 in. per ft. = 12 984 :,uYin fret runoff
Volume = 15.5 in * law.-n OF/12 in./ft = F5111 =ubi;_ feet ovap.
vol-Lime - _?S573 cubic feet

Volume - 7.0 inches / 12 inches per foot * DA
5E. AdditionaI. volume as follows:
TOTAL REQUIRED TEMPORARY FTORAGE
5A. 0 cubic feet
5B•. 33690 cubic fee
5C. 3857= cubic lee"
5D, ?8573 cubic Net
5E. 50990 cubic feet
TOTAL 161826 cubic_ feet
6. SUMMARY
TeTporarti storage
180
days
Rainfall during wetter.; Lerica of storage===>
22.5
inches
Evaporation during storage }period===========>
15.5
inches
25 Year - 24 hour
7.0
inches
1.0
feet
Side
2.5
. 1
Inside top
265.0
feet
Inside top
125.0
feet:
Top of dike
53.80
feet.
Bottom of lagoon elev-ation===---------------
---------------
43.00
fret
Total. required
16182E
cu. ft.
Actual design
222365
cu. ft.
Se5sanal high watertable elevation (SHWT)===>
46.1c
feet.
Stop peari-, illy
146.30
feet:
Most be - or = to the 5HWT elev.====______,
46.30
feet
Most be > or = to min. req. treatment el.=>
49-00
feet
Required minimum treatment volume===========>
0
cu. ft.
Volume at Stop
57414
cu. ft.
?:t rt pumping ele-.=___________________ ___,
.5470.
feet
Most be at bottom of freeboard & 25 =r. rainfall
Actual volume less, 25 yr.- 24 hr. ra n all==;.
1S:792
cu. ft.
Volume at start pumping e l vatio---=W=r==== 0
1 - - - -a2
_u. ft.
Required vniume to be pumpe=----=_=__-__--_->
12, 5?
_u. ft.
Actual volume ume planned to be p'.-imped==_=== ==== 4
125073
c7. ft.
Min. thickness ,:f sail liner when required
1.E
feet
7. DES! GNED BY: APPROVED BY: adz
DATE: DATE:
e' i

i FE7 1 OF
OPERATION AND MAINTENANCE
------------------------------
This 11`:_ n is dRs s :- d for w=, to treatment (permanent t -c ge) anj
190 days of tempoyary szorage. The time required Eon the plannee.
fluid levs! (permanent and temporzry st-rayn) to he reached ma7 vary
due to site conditions, wmather, flushing operations, and . ths amount
of frash water added M the system,
- , i n ed t.ti.mp;_,ranv storage consiats of 180 days storage for:
( _) waste from animal; and 2) excess rainfall ftF_,r evaporation. Also
included is storage for the 25 year - 24 hour storm for the , nt ation .
rho l III cif waste seneratea from given number - al s will b
_air'constant thr. g.- ut_ the f_ n a n 7from year �o year, but excess
rainfall willvary from year to year. The 27Lra
rainfall will not.
be a factor to f`or1sider in am annual pumping _sell. but. this star g,'-�
volume must always, ways _ available,-
r'_ maximum elevation is determined in r'-.=t-.ch design to begin
pumping and this is usually the outlet invert: of pipe(s) from
building (s) . If the outlet pipe i_e n Dt installed at the elevation to
begin pumping, a permanent marker I':usn be installed ,at this elevation
to indicate when 'pumping should begin. An elevation most be established
to stop Pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
a vatio ns for operating convenience as site conditions permit, such
as.
weather, soils, crap, and equipment in order to apply waste without
runoff or leaching.
LW application of waste grater is recognized as an acceptable
method of di-kpos•al. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops,
The following items are to be carried out:
1. It is strongly r;eo n•,^,'..^:-leI-d d -!:h t the treatment lagoon be pre -
charged `o 1/2 its capacity to prevent excessive.odors during
start-up. Pro -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
ov.•=:red with effluent at all times, WbRn p echar ink; is complete,
flush building_ with recycled lagoon liquid. Fresh water s3'isnu!.d not
be used for flushing after initial filling.
2. The attaKedwaste utilizaticn plan shall be Followed. This
re-nomnien ds sampling - n J testing of waste (see attachment"
- - nvp land application.
7. ' n t i:5por-=, vim :_• � ��� J L'.:JU^po ( the
:agnon . -. n f,. _' _ nv e
whon the fluid level ren:hen slevation K.3 . Th!F teTp-rar_,,
540525-alloys.

F
SHEET 2 OF 2
4. The recommended maximum amount to apply per irnigation is
one (1) inch and the recommended maximum application rate A Q.3
inch per hour. Refer to the waste utilization plan for furthpr details.
5. Kkep vegetation on the erNankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by Yndents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to Stable
outlets.
S. Keep a minimum of 25 feet of grass vegetated buffer around
wasts u-ilization fiel.Q adjacent to perennial streams. Waste will
tot b- applied in open ditoheF. DD not pump Within 200 fe-t nf a
residence or within 100 feet oF a 0-17. wox�n stall Se applies in
manner not tQ reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits, the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resourobs, Division of Environ.-
mental Management, has the responsibility for enforcing this law.

SPECIFICATIONS FOR _OYSTaTrPT -,'\I OF WASTE TREATMENT _Aljl}f_K—_
-----------------------------------------------------------
-----------------------
foundation area of the Ia_;7-ron embankment baZIkmt"'it and building pad .'. hall be
cleared of trees, logz, stumpa, roots, brush, boulderp,W and rubbish.
Satisfactory disposition will be ^lade of all debris. The topsail from
the lagoon and pad area should 1' - s tT ip a and stockpiled for use o
.-he dike and •a `r stripping, the foundation h' _h �_k.V , id ;=��� �,r` After _ � 1F_ •b � �:� _ ,. _ _ .,�. .-_�Y�eti� _.f the
lagoon emb,--wil-mr._. and buildinS pad shall be thoroughly loosened pric'�•
to placing the first lift of fill material to `et a good bond.
EXCAVATION AND EARTHF I LL PLACEMENT:
-----------------------------------
The completed excavation ani earthfill shall _ nfono t Qe lines
r
grades, and elevations shown on the plans. Ea„thfil l material shall
be free of material such as sod, roots, frozen soil, stones over
6 inches in diameter, and other objectionable material. To the extent
they are suitable, excavated materials can be used as fill. The fill
shall be brought up in appioxim•ately horizontal layers not to exceed 9
inches in thickness when loose and prior to compaction. Each layer
will he compacted by corTleve coverage with the 'rtalllirg and spreading
_ ;ipment or standard tamping roller or other equivalent method
Compaction will be considere6 adequate when fill material is observed
to consolidate to the point that settlement is not readily detectible.
NOTE THE SPECIAL REQUIFEM?NTS FOR PLACEMENT OF LINERS IN THE LINEP.
SECTION OF THIS SPECIFICATION. The embankment of the: lagoon shall be
installed using the more impervious, ;materials from the requires
_ _: c'vations . C c.ns r__ _ _ _- of fill heights shall include 5 percent for
�t.lement. Dikes oner 15 foot in i7?r,'r}`ht and with an impoundment
:-pachy of 10 a_.''-_oe-- or more fall under the -:,, is-___tion nF the 7-.
- - Safety Lew. The height is - efined as the difference in elevation
--_.-m the constructed he -y', to the ._s=ea t toe of the dike.
Precautions ShellS he taken duping ~instruction to prevent _._ce 5 .v
erosion and sedimentation.
LINER: THE MINI1�RTM REQUIRED THICKNESS SHALL BE 1.6 ft.
_ OTE . LINERS ( PARTIAL 07 FULL) ARE PFV71RED 1TEN THE ATTACHED SOILS
iT.iyr^ r-� ti T -� SO 1 D S OR r^.E UNSUITABLE
l:rp:TER-A- UZI
�� r,.S1I[�A�ION REPORT ,_ � �_.TC'A'TE., ,_, r,_.��T _f�..,-.�. � l�',EI_ ls�ti�_... [�..1
ENCOUNTERED DURING CONSTRUCTION. p TYPICAL
!.YP;L CROSS SECTION OF THE LINER
IS INCLUDED IN THE DESIGN WHEN LINERS ARE REnUIRED Y THE -_ FOILS REPORT.
- - - ter f tns t �l e material are - n _.re they � 1 be - -ar-
_._ _ areas O L_,_ _.� _�.__ _ )- ..-- _-._ _- _ F'=i'_ '„ti _ _-- •- _ _ -.'.
_ _- - en --_I_ ular to the finish gra_, _ . The foundation shall be i , c; -_1=ed

_l lf- `_'Z material shall a--- - - 'a-- p . - wre,-1 h - � - -- - Thr
n'-..ymm water content of the liner 'i=ateria. =l:a, ' s _ optimum moisture
nnzt�= which relates to that - - ' content when
the oil is 1•.n'.v.'1de�q
n the hand :_t will form a hall ' - ich does not -_'-dil_ separate. Water
shall be ailed to borrow an n-p-srary to insure proper maistnne c=ent
r-a. eri . _hall nct b- less than �_%ytimum water content ']bring pla e en .
The maximum G:atEr convent relates to the soil material Feinv too c,;.=t
for efficient use of hauling _ qi_l1�'�ITen and proper Co:::�'.�rtson. Propercompactionofthe line includes plrccitilt n 9 inch lifts and,
... J it -,_`led to at leas,t. 90 -°='rG_.-=ny_ of the maximum A TM DM Dry Unit
t'.
M l _ ;t. of the liner matei i l . When smooth or hard, the previous lift
shall be scarMea .and moistoned as I:le"_='dei :s'=-r pl ---dent of the next
l i f+
la� _.
The single most important factor ,affecting the overall a_'L=mL'a ted perne-
Mility of _ clay liner, other than the type K clay used
_d for the;
'liner, is the efficient construction processing of tcompacted. liner.
The sequence of equipment use and the routing of equipment in an estab-
lished pattern helps a5s11re uniformity 1n the whole placement and
compaction pro ten• For mo& ,_ clay soils, a tamping or sheopsf lost
roller is tho preferable type of compaction equipment.
The soil liner shall be protected from the discharge of waste outlet.
pipes. This can be done �t.
by using some type of energy .?i`iJ .1� 4 -i � or(roc.)_s )
or using flexible ovtlet.son waste pipes .
Alternatives to soil liners are synthetic liners and bentonit-e sealant.
When these are specified, additional construction specifications are
included with this Construction Specification.
CUTOFF TRENCH!
-------------
P, cutoff trench hall to n tro L.P-.:_a undo ;_" the embankment area when
shown on 3 typicel_ crosssection on in the plans. The final depth of the
cutoff trench shall be ete7_i,;intia by observation of t'_-_e foundation
materials.
VEGETATION:
11 exposed e.1laIZi_,menl an! other bare constructed - areas shall be Seeded
to the planned type of vegetation ,as soon as passibin = to _ nn tr=
tide_ according to the seeding specifications. Tapsnii should be pl ce-
on areas of the dike ,and p d to be s eL .a e d . Temporary - _ _ i g or mulch
shall be used if the rCiromn =ll5t=�1 permanent vegetation is out of season
i=lnt.t=-s for sL - :illy, Permanent vegetation Phould beYs_ - _ _.':;;e:d as soon
as possible Krinj the neyt Perin! of =P ro _ c 4--_iiP the .
-------------------------------
when till drains ar.. encountered, the tile will b? 7wroved M a T' .ir-au-,
of in feet beyond the it:t i e toe of slope of the M_ . Me'+_ ] 0
ret_- shall all be i}'���� -
.il i lR aLd c om _ _ - a y;.,_-1. 9000 n. .l_
o A l ouch eti
C, C'L, or CH.

SCS-ENG-538 U. S. DEPARTMENT OF AGRICULTURE
Rev. 5-70 SOIL CONSERVATION SERVICE
SOIL INVESTIGATION TO DETERMINE SUITABILITY OF PROPOSED POND SITE
0 a.s I
Q 4.5 4i7-b
i .. .
■
■■
■
■■■■
��_
■■■■■■■■■■■
■
■■■■
NE■■■.■
■■■
■
■
■
■■■■■■■■■■■■■
■■■
■
■■
■■■N■■■■
■■■■■
■
O�
NNE
mn!1mmmmm
N■■■
■■■
MERE
�
■■■
NN-0-a
IN
■■®
mmm■■mmmmmmm
MEMNON
■■�.■e�■®■��®■....■..■..
■■.■■■■■■■■■
■■
■
■■
■
■■■■■■■
NEON
■■■
ON
•■
...■_■■■
■■■■
MEN
N■o
■i■■
■■■�■■■■■■®■■
■
■■
■■111momm
so
own
I
�
�
I I��
I
i'
f
I
I
I
�I
I
I��
I
I
I
!■I
!��
I
I■'
i!
I
I■I
�
I
+.
!
I
±!
I I
�.I.•
I
I
�.LI..
��
C
i
I
I
�
�■I
!
�
I
I
I
�
I
�
►■i
■■�.
��.
�
�■I
�
���CI
I
�
I.IC
_
■'.�
!
!■�
I
IN
I■a■�

TVVE� MATFRIAL ENCOUNTERED IN DORM,
(Use one of systems below)
UNIFIED CLASSIFICATION
USDA CLASSIFICATION ; +,
GW-Well Prnded Rravel5; gravel. sand mix
g-grave)
GP -Poorly graded prnvels
s-sand
GM -Silty gravels; gravel--nnd-r..lit mix
vfs-very fine sand
CC-Clnyry grnvels; gravel -sand -tiny mix
sl - ;nndy loam
SW -Well graded SnndS; sand -grovel MIX
f41 -fine sandy loam ►.
S>' - Poorly prnded sands
1- lonm
SM - Silty snnd
91= gravelly Ivaco
SC -Clayey ennds; sand -clay mixtures
RI -milt !
ML - Silts; silty. v. fine eanrls; nnndy or clayey silt
nil - silt loam
CL-Cinys of low io medium pinnticity
cl - clay loam I
CII- InorFnnic clays of high pinaticity
slcl-silty tiny loam !
Mil -Elastic silts
scl--Andy clay loam
OL-Organic sills and Silty clays, ln%v plasticity
-tic -silty Clay
Oil - Organic clay-4, medium to high plAsilcity
c - clay
1. Flulirble meterhl for emhenkrnrrnt In nvxilwhle
Yes n No 0-fic to reA.4 hxar eti M• 140rch a"
r+WM*
AEMARR9:
1
i
�
t +�•r, •f ��ti
t Fsplein hnrrrdx rerlydring xPrcinl ettrntinn in drniRn
rs*f"pr. Jtrf.s.irvrl rk.1 -
I ,
CENFRAL REMARKS-
t
25 26 27 2A 29 30 31 32 13 34 35 36 37 36 39 40 41 42 43 44
.46 41 48 49 60 61
►� G-- I-P N t
tu_j-r- oZ�

U. S. Department of Agriculture NC-ENG-34
Soil Conservation Service September 1980
File Code: 210
HAZARD CLASSIFICATION DATA 5.HEET FOR GAMS
Landowner MCounty. L.—I -�
Community or Groin No. Conservation, plan: No.
Estimated Depth of Water to Top of tam S Ft. Length of.FloodrPool = ;= Ft.
Date of Field Hazard Investigation
Evaluation by reach of flood plain downstream to the point of estimated minor effect
from sudden dam failure.
X Elev.'Est. ElevatFion
Kind of
:Improvements: of Breach
Reach: Length: Width: Slope:
Land Use
Improvements
Above :floodwater Above
Flood Plain: Flood Plain
Ft. Ft. %
Ft► Ft.
2
4-e
:
LJ
3
Describe potential for loss
of life and
damage.to existing
or probable future downstream
improvements from a sudden
breach r; r ic" Moto Tr,;._ ; zvon fP_1235_ 1'rPr, ,�o;,'
Hazard Classification of OEM (a}1 b, c) (see HEM -Part 520.21)
Dam Classification (I, II III, IV, V)
By
i
O
Concurred ay_/��—
name) title
NOTE: 1. Instructions on reverse side.
2. Attach additional sheets as needed,
Date 5-- �-c�'
Date / - -? -r

US Department of Agriculture
Soil ranser1£r2 Service
OUT77ITY CALCULATIONS
prepared £e2
1 t;D aw 1-1f3 4' w»
iR
GREENE County, North Carolina
Designer : £«?OM TURNA GE Checker
Date : 06/03/96 Gate
Job Number I1M,
fot Left Right Off -CS
Width
SS
SS
(£t)
71
2,5:1
2,5:1
72.0
71
2.5:1
2.5:1
72.0
71
2.5:1
2.5:1
72.0
71
2,5:1
2,5:1
72.0
� � �
F£CAVA
Ct
Dist
Sta
({t)
0+10
90
I+00
100
2+QO
2+56
56 !
** EXCAVATION ** I ** Zltt **
Area Volume I area Vol,— e
(SgFt) MUMS) i (SgFt) M .M )
|
490.8 1 0.0
1621.6 1 0.0
482.1 k 0.0
3449.8 1 0.0
505.1 | 0.0
4512.61 O.0
519.6 | 0.0

Et
G Vri T -) i HCD
C. u L 0
u
t 10 i -d 0
0 C
—UT L
Tit
-2
T -a';!- No T tL
49/49
00000*0
qs�z U-4 0 0 + Z
-43/49
00000,0
S Z/T L TOG Z\D
0 0 + L- 04 00+T
4J/49
00000*0
00+T Oq OT+
49/43
00000 ' 0
Z/TLT05Z\D
OT+ 04 OT+
C)T+
-ktic -K *. * * * * * *- *-* * ir; v
1',U'iT a�GqlmlFj Of
96/'CO/90 P4 p (i
LIT
CrL

US! Dep, .rtme-nt of A-gric-u t:Li--e
FLAI'NED
(-)UAN- TTY CALr-T_TT jTT'T%?1-1
prep r�d fo;--
G EENE Co -Linty, C:arel zria
fie&igner ELTON TURNAGS. C'he.4:l-,ar
Dare C"-)/03/96
Job Number 2MIM
Top Left Right Off-CL
Width
SS
SS
(ft)
10
3:1
2:5:1
.35.0
10
3:1
2.5:1
35.0
10
'3:1
2.5:1
35.0
10
.3 : T
2 . 5 : 1
15 . 0
10
:3:1
_, 5..1
20.0
10
31
2..5.1
2/0.0
10
3:1
2-5-1,20.0
10
3::1
"5:1
20..0
10
, .1
2.5.1
210.0
20.0
C° L
Ste,
0+00
0+dui
1+95
2+75
DIKE FILL
I * * EXCAVATION
Dist 1 Area. V01-un.�
(ft) I (SgFt) (Ci_I:Yds)
I 0.0
95 1 !-) . 0
1 0..0
100
1 0. C.,
0.0
0.0
o . r
75 I
0,0
4+10
I
i�0
0 #
0.0
4+90
I
0.0
100
5+90
I
0.0
_
0.t�
7+6,0
I
0.
C + 2 0
**
FILL **
Area
vc 11_l n,
(SgFt)
(t_U.Yds)
133.9
44`�.:
121.5
897.5
120.5
1220.3
97.3
- Z Y C . 7
1C}":;.5
17C5.1
124.5
148 3
134.1
1.38 2
�25
11.f:
729.4
1 Q,
J L r G

�T4 Department of 0 i ul tui e
Soil Con ervati n S evict
CPOFS-SEC7157 DATA
prepared - -
om
GREENE Cconty. North Carolina
%ate gn r EL" ,r. rj U NAGE Welker
Date
TT
elr�-.hw Number 2M-VD"!
'k�=**=#�'�'�k.k�='kk x-kX*'k�!�k**=K:k�::tc%k�::k*:k��*.:►.�c:k:l:k�:k*'X-*��k�k�c�**���K������s-k�:k�Ic:k�Ic:k�:Y�:!'�*�:k�**�K�
TEMPLATE DATA:
Beginning Elevation = 53.8
Beginning Station = 0+00
0+00 to 0 0
0+00 to +95
+95 to 1+95
1+95 to 2+75
2+75 to 3+35
3+35 to 4+10
4+10 to 4+90
4+90 to 5+90
5+90 To 6+85
6+85 to 7+60
7+60 to 8+20
SECTION NOWER
Centerline Station 0+00
O TGTNAL DATA:
DIKE FILL
D/3CL10\ ' . 5
0.00000
ft/ft.
i/3CL10\2 . 5
0.00000
f t/ft
D/3CL10\2.5
0.00000
ft/ft
D/3CL10\2.5
0.00000
ft/ft.
D/3CL10\2.5
0.00000
ft/ft
D/3CL10\2.5
0.00000
ft/ft
n/3CL10\2.5
0.00000
ft/ft
D/3CL10\2.5
0.00000
ft./ft
D/3CL10\2.5
0.00000
ft/ft
D/3CL10\ % . 5
0.00000
ft /ft.
D/3CL10\2.5
0.00000
ft/ft
0.0 / 48.4 50.0 48.4 100.0 4 .8
SECTION NUMBER `'
Centerline Station +95
ORIGINAL DATA:
ORIGINAL EATA:
0.0 / 48.9 50.0 / 48.7 100.0 49 . t+
SECT101.7 L.

VIE FILL (continued) 06/02/96
Rear rline Station 2+75
ORIGINAL DATA:
0.0 / 49.4 50.0 49.4 i00.0 Z 49.1
SECTION NUMBER 5
Centerline Station 3w95
ORIGINAL DATA:
W / 49.2 1000 Z 49.0
SECTION NUMBER 6
Centerline Station 6110
O2:012AT DATA:
K-c / 48.6 25.0 Z 4B.6 75.0 19.2
SECTION NUMBER 7
Centerline Station 4+90
ORIGINAL DATA:
0.0 / 4814 40.0 48.4 70.0 48.6
SECTION NUMBER 8
Centerline Station 5+90
ORIGINAL DATA:
C.? / ks.3 50.0 48.3 100.0 48.7
SFCT-C--!I -,-747 DER 9
Conterline Station 6+65
ORIGINAL DATA:
0.0 / 40.7 75.0 W.7
SEW1102 NUMBER 10
Centerline Station ?+&D
ORTMINAL DATA:
0.0 / 48.8 110,0 Z 48,7
page 2

United States Natural NC-CPA-17
(� )� Department of Resources REV. 1, 2-96
Agriculture Conservation
Service
WASTE MANAGEMENT FACILITY SITE EVALUATION
GENERAL, IINFORiiATION
NAME '/ 1 fl % � ' 1) c LOCATION
TELEPHONE
SIZE OPERATION
" �,) L9 , /�� , . ? -Z :! —/
LOCATION DATA
DISTANCE FROM NEAREST RESIDENCE NOT OWNED BY PRODUCER 1 5 o o FT.
DISTANCE FROM NEAREST PUBLIC FACILTrY (school, chur�c etc.)
IS SITE WITHIN lop -YEAR FLOOD PLAIN?
YES _ NO ✓
If yes, MRCS cannot provide assistance.
IS SITE AT LEAST 100 FT. FROM A "BLUE LINE" PERENNIAL STREAM?
YES ✓ NO _
If no, site must be relocated.
IS SITE WITHIN 1 MIU ZONING JURISDICTION OF A MUNICIPAL1 Y?
YES No
If yes, landowner should consult with local zoning board about required
permits. Permits must be obtained prior to design approval
ARE UIILTTIES IN CONSTRUCTION AREA?
YES _ No
If yes, see Part 503 of the National Engineering Manual and follow policy.
(Copies of maps or other reference materials may be attached to site
evaluation.
WETLANDS
WILL SITE INVOLVE CLEARING WOODLAND OR ANY NON-CROPL LND? YES NO ✓
If yes, producer must complete Form NRCS-CPA-38 (Request for Certified
Wetland DeterminatiowDelineation).
WILL ACTION RESULT IN SWA .2BUSTENG? YES NO
W WETLANDS ARE INVOLVED, IT IS THE RESPONSIBILITY OF THE PRODUCER TO CONTACT THE US ARMY CORP OF
ENGINEERS AND THE DIVISION OF ENVIRONLIENTAL MANAGEMENT TO DETER.MENE IF PERMITS ARE REQUIRED.
IF WETLANDS ARE INVOLVED, THE PRODUCER SHOULD NOT CLEAR ANY LAND UNTIL A WETLAND DELINEATION
IS MADE.
MRCS will provide technical assistance in wetlands only under the following conditions. For natural wetland
inclusions less than one acre in size, NRCS will provide assistance only if the functions and values lost are fully
mitigated. For natural wetlands greater than one acre in size, MRCS will provide assistance only after a
rigorous sequencing process to include avoidance, minimization of impacts, and compensatory mitigation is
carried out in that order of preference.
ODOR CONTROL
HAS ODOR CONTROL BEEN DISCUSSED WITH PRODUCER.:
• PREDOMINANT WIND DIRECTION? YES ✓ NO
• ?RECHARGING LAGOON WITH FRESH WATER TO AT LEAST 1/2 YES ✓ NO
OF THE CAPACITY?
• USING GOOD SOUND JUDGMENT IN LAND APPLICATION YES NO
OF WASTE?

N C-CPA-17
REV. 1, 2-96
Page 2
OTHER ENVIRONMENTAL FACTORS
IS ENDANGERED AND/OR THREATENED SPECIES HABITAT PRESENT'?
YES
NO
IS A DESIGNATED ; IATUR L SCENIC AREA INCLUDED IN THE PL1kNN4 ING AREA OR
NO
WILL PLANNED ACTIONS LkIPACT ON AN ADJACENT NATURAL SCENIC AREA?
YES
IS AN ARCHAEOLOGICAL OR HISTORICAL SITE LOCATED IN THE PL.ANNI ED AREA?
YES _
NO
ARE THERE PRLtiiE, UNIQUE, STATE OR LOCALLY IMPORTANT FARLMLANDS IN THE
YES
NO
OPERATD;G UNIT?
WILL THE ACTION RESULT IN SODBUSTING?
YES _
NO
If the answer to any of the above is yes, MRCS will not provide technical
assistance unless agency policy is followed.
WASTE NLANAGENIEPNT
DOES PRODUCER OWN ENOUGH LAND TO PROPERLY LAND APPLY ALL WASTE YES V' NO
INCLUDING SLUDGE, ALTHOUGH SLUDGE MAY ONLY BE APPLIED INFREQUENTLY?
IF NO, DOES PRODUCER HAVE ACCESS TO MORE LAND? YES _1\10
IF LA-N'D IS NOT OWNED BY PRODUCER, CAN PRODUCER GET AGREEMENT ON LAND YES _ NO
ON WHICH TO APPLY WASTE?
(Attach Waste Utilization Plan to site evaluation__)
SOIL LNWMICATION - V_-L D ONLY IF SOIL INVESTIGATION
SHEET ATTACHED
/
IS SOIL SUITABLE FOR LAGOON?
YES ✓
NO
IS A LETTER REQUIRED?
YES
NO
TYPE OF L UNFER TO BE USED--
CLAY
BENTONTIR SYNTHETIC
T CLAY LINER IS TO BE USED, IS SUITABLE CLAY AVAILABLE ON
YES _
NO
SITE?
IF CLAY IS NOT AVAII.ABLE ON SITE, DOES LANDOWNER HAVE
YES _
NO
ACCESS TO CLAY?
✓
IS A CORE TRENCH REQUIRED?
YES
NO
(Attach soil investigation sheet to site evaluation.)
/
IS SUBSURFACE DRAIN TILE PRESENT?
YES _
NO
1/
(If yes, tile must be removed or plugged)
SITE ,APPROVED YES ✓ NO CONDITIONAL
C OM*iENTS
THIS SITE INVESTIGATION IS VALID FOR TWELVEMONTHS FROM THE DATE SHOWN BELOW. IF CONSTRUCTION
HAS NOT BEEN STARTED WITHIN TWELVE MONTHS, ANEW SITE INVESTIGATION WILL BE REQUIRED, u
SIGNATURE �i % i' r.'r DATE
1� Changes in the local or state law or changes in the standard could require a new site investigation.

IV6 Z'96z7�v'l
operatrr:MOSES M)YE County: GREENE
Pa0e:
06010J.
Vistanco io nearest TeFK=nc- (other than owner):
3500.0
feet
1, AVERAGE LIVE WEIGHT TLW)
0 sows (farrow to finish) A 1417 lbs.
-
0 lbs
400 sows (farrow tc feederh x 522 !be.
=
258900 lbs
0 head Vinishing only) X 135 lbs,
0 As
0 sows NarrDw to wean) x 433 lbs.
0
0 head (wean tolbs
Describe other :-
0
Tnial Average Live Weight
209900 AS
2. MINIDTUT4 REQUIRED 7TERTMENT VO-INE OF LAGOON
Volume = 208FOO lbs. ALW x Treatment Volume=)/lb.
ALW
Treatment Volume (CF)/lb. ALW = 1
CF/Ib. ALW
Volume = 208600 cubic ft (includes 0
cu. ft.
add. treat, vol.)
3. STORAGE VOLUME FOR SLUDGE ACCUTULATION
Volume = 0.0 cubic feet
0. TOTAL DESIGNED VOLTU-F=M-
inside top length (feet) ---------------------
586.8
Inside top width (feet)------------------------
55.0
Top of dike elevatiop (font.-----------------
43.70
Bottom of lagoon elevation (feet) ------------
36.20
Freeboard (feet) -----------------------------
i.7
Side slopes (insiie lagDon) ------------------
Total design volume using prismoidal formula
SS/ENDI SS/=2 SSISIDEI SS/SIDE2 1ENGTH
WIDTH
DEPTH
1.0 1.0 i.0 1.0 583.4
51.6
10.8
AREA OF TOP
LENGTH * W7DTF
583.4 51.�- 20103 (AREA OF
TOP)
AREA OF EQTTTT
LEN9TH * 77774
561.E iIFFT CF
po=m�
OF MTDFEjT:
WIP7H
5724
07. fAREA 70P + 14"APFA MITSFOTTON! A7FT
BQ=71
9200
16 R 5 1�
Total 5e6ignad Volume Available
n52720 CU. FT.

A 1 , ,
5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
{ Length * Width ) + Surface area of connecting waste facility
586.8 55.0 0.0
32274.0 square feet
Buildings (roof and lot water) or impervious area
0.0 square feet. Describe this area.
TOTAL DA 32274.0 square feet
Design temporary storage period to be 0 days.
5A. Volume of waste produced
Feces & urine production in gal./day per 135 lb. ALW 1.37
Volume = 208800 lbs. ALW/135 lbs. ALW * 1.37 gal/day 0 days
Volume = 0 gals. or 0.0 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 0 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
0 days evaporation = 0.0 inches
0 days rainfall = 0.0 inches
Volume = 0.0 in * DA / 12 in. per ft. = 0 cubic feet runoff
Volume = 0.0 in * lagoon DA/12 in./ft = 0 cubic feet evap.
Volume = 0 cubic feet

1 A i .
5D. Volume of 25 year - 24 hour storm
Volume = 0.0 inches / 12 inches per foot * DA
Volume = 0 cubic feet
5E. Additional volume as follows:
TOTAL REQUIRED TEMPORARY STORAGE
5A. 0 cubic feet
5B. 0 cubic feet
5C . 0 cubic feet
5D. 0 cubic feet
5E. 0 cubic feet
TOTAL 0 cubic feet
6. SUMMARY
Temporary storage period___ _________________>
0
days
Rainfall during wettest period of storage===>
0.0
inches
Evaporation during storage period=====______>
0.0
inches
25 year - 24 hour rainfall===_______________>
0.0
inches
1.7
feet
Side slopes_________________________________>
1.0
: 1
Inside top length___________________________>
586.8
feet
Inside top width=====_=_____________________>
55.0
feet
Top of dike elevation_______________________>
48.70
feet
Bottom of lagoon elevation=====____=________>
36.20
feet
Total required volume=====__________________>
208800
cu. ft.
Actual design
252730
cu. ft.
Seasonal high watertable elevation (SHWT)===>
46.30
feet
Stop pumping elev.====_________-______=_=_==>
47.00
feet -
Must be > or = to the SHWT elev.====______>
46.30
feet
Must be > or = to min. req. treatment el.=>
42.20
feet
Required minimum treatment volume=====______>
208800
cu. ft.
Volume at stop pumping elevation=====_______>
252730
cu. ft.
Start pumping elev.====_____________________>
47.00
feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall=_>
252730
cu. ft.
Volume at start pumping elevation=====______>
252730
cu. ft.
Required volume to be pumped________________>
0
cu. ft.
Actual volume planned to be pumped=====_____>
0
cu. ft.
Min. thickness of soil liner when required==>
1.6
feet
NNE a-�:� .�e_.� _'_
DATE:
DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS: /�/S f�, c.-r
Coti�.r.� Tyr�f7°r.✓ 71
far /'e�r+.r.�ce S��urys /rleoSn.�e�.pr`�.r

11
dr
�-
�r/Y V 0
C-2;71--

I i ,
i
rnJpJr eleO,, 4745
R
I I ;
it
lil III'ill
i
r� •

44! 1
w- o