NCGNE1296_COMPLETE FILE - HISTORICAL_20180905

STORMWATER DIVISION CODING SHEET
.NCG PERMITS
PERMIT NO.
NCGNE Co
DOC TYPE
[�—RISTORICAL FILE
DOC DATE
n ;�ov� 0
YYYYMMDD

i
4
t..�
Energy, Mineral
and Land Resources
ENVIRONMENTAL OVALITY
August 27, 2018
Fontaine Modification
Attention: Mr. Brad Howard
2718 Salisbury Highway
Statesville, North Carolina 28677
Subject: No Exposure Request — Fontaine Modification.
NCGNE 1296
Iredell, North Carolina
Dear M.r. Howard:
ROY COOPER
Govemor
MICHAEL S. REGAN
Secretary
WILLIAM E. TOBY VINSON JR.
Interim Director
REC' VE
SEA 0 5 2018
NING PIQ
MI
M
0
Enclosed please' find a copy of the report from August 22, 2018 site inspection. No exposure cannot be granted
at this time. The report should be self-explanatory, however, should you }lave any questions concerning this, please
do not hesitate to contact Lily Kay at [phone] or at [e-mail]
Sincerely,
3c-�'
s , V -
Zahid S. Khan, CPM, CPESC, CPSWQ
Regional Engineer
Land Quality Section
Enclosure: Inspection Report
cc: Stormwater Permitting Program, Raleigh Central Office- NCGNE1266
State of North Carolina I Environmental Quality I Energy, Mineral and Land Resources
Mooresville Regional Office 1 610 East Center Ave Ste 301 1 Mooresville, NC 29115

Compliance inspection Report
Permit: NCGNE1296 Effective: Expiration: Owner: Fontaine Modification
SOC: Effective: Expiration: Facility: Fontaine Modification
County: Ired ell 2718 Salisbury Hwy
Region: Mooresville
Statesville NC 28677
Contact Person:" Brad Howard Title: Phone: [phone]
Directions to Facility:
travel east on hwy 70 then turn left on old 70 (salisbury hwy) and facility is on right about 1.5 miles.
System Classifications:
Primary ORC: Certification: Phone:
Secondary ORC(s):
On -Site Representative(s):
Related Permits:
Inspection Date: 0812312018 Entry Time: 12:OOPM Exit Time: 12:30PM
Primary inspector: Lily C Kay Phone: . [phone]
Secondary Inspector(s):
James D Moore Phone:
Reason for Inspection: Other Inspection Type: Technical Assistance
Permit Inspection Type: Stormwater Discharge, No Exposure Certificate
Facility Status: ❑ Compliant Not Compliant
Question Areas:
® Miscellaneous Questions S Misc
(See attachment summary)
Page: 1

Permit: NCGNE1296 Owner - Facility: Fontaine Modification
Inspection Date: 0&231201 a Inspection Type: Technical Assistance Reason for Visit: Other
Inspection Summary:
This inspection was conducted due to the facility's request for a "No Exposure" certification for this industrial stormwater
permit. The request was denied at this time due to vehicle maintenance performance and petroleum staining and storage on
site at the time of inspection. The site must be cleaned and vehicle maintenance on site must cease before a "No
Exposure" certification can be granted. If you have any questions, contact my office at [e-mail] or (704)
235-2137.
Page: 2

permit: NCGNE1296 Owner - Facility: Fontaine Modification '
Inspection Data: 081231201 B Inspection Type : Technical Assistance Reason for Visit: Other
Misc Yes No NA NE
Is the facility compliant? ❑ M ❑ ❑
Comment: Outside vehicle maintenance, oil changing and stained soil observed during the. inspection.
Page: 3

I�%'Gn E/a9 b
Division of Energy, Mineral and Land Resources
Land Quality Section
National Pollutant Discharge Elimination System
NO EXPOSURE CERTIFICATION for Exclusion
Energy, Mineral NCGNE0000
and Land Resources
ENVIRONMENTAL QUALITY
FOR AGENCY USE ONLY
Date Received
Year I Month
Da
Certificate of coveraAe
National Pollutant Discharge Elimination System application for exclusion from a Stormwater Permit based
on NO EXPOSURE:
Submission of this No Exposure Certification constitutes notification that your facility does not require a
permit for stormwater discharges associated with industrial activity in the State of North Carolina because
it qualifies for a no exposure exclusion. A condition of no exposure at an industrial facility means all
industrial materials and activities are protected by a storm resistant shelter (with some exceptions) to
prevent exposure to rain, snow, snowmelt, and/or runoff.
For permitted facilities in Ncrth Carolina, DEMLR must approve your application for No
Exposure Certification before this exclusion is effective. Until you are issued a No
Exposure Certification and your NPDES permit is rescinded, your facility must continue
to abide by the terms and conditions of the current permit.
Industrial materials or activities include, but are not limited to. material handling equipment or activities,
industrial machinery, raw materials, intermediate products, by-products, final products, or waste products.
Material handling activities include the storage, loading and unloading, transportation, or conveyance of
any raw material, intermediate product, final product or waste product A storm resistant shelter is not
required for the following industrial materials and activities: drums, barrels, tanks, and similar containers
that are tightly sealed, provided those containers are not deteriorated and do not leak. Sealed" means
banded or otherwise secured and with locked or non -operational taps or valves; adequately maintained
vehicles used in material handling; and final products, other than products that would be mobilized in
stormwater discharges (e.g., rock salt).
A No Exposure Certification must be provided for each facility qualifying for the no exposure exclusion. In
addition, the exclusion from NPDES permitting is available on a facility -wide basis only —not for individual
outfalls. If any industrial activities or materials are, or will be, exposed to precipitation, the facility is not
eligible for the no exposure exclusion. By signing and submitting this No Exposure Certification form, you
certify that a condition of no exposure exists at this facility or site and are obligated to comply with the
terms and conditions of 40 CFR 122.26(g).
If approved, your conditional No Exposure Exclusion has no expiration date
BUT MUST BE self re -certified at least annually.
Please look for information about re -certification under the No Exposure section on this page:
htt s:llde .nc. ov/about/divisions/ener -mineral-land-resources/ener -mineral-land- ermits/stormwater-
ermitsln des-industrial-sw
For questions, please contact the DEMLR Regional Office for your area. (See page 6)
(Please print or type)
1) Mailing address of owner/operator (address to which all certification correspondence will be mailed):
Name Fontaine Modification
Contact Brad Howard, Director of Operations RECEIVED
Street Address 2718 Salisbury Hwy
City Statesville State NC ZIP Code 28677 AUG 0 6 2018
DENR•LAND QUALITY
Page 1 of 7 STORMti' MER PERMIT71NG
qWI I-NrC.NF I act rmAtzprt Q/?R19nia

NCGNE0000 No Exposure Certification
Telephone No.
704-768-2429 Fax: [phone]
2) Location of facility producing discharge:
Facility Name
Fontaine Modification
Facility Contact
Brad Howard, Director of Operations
Street Address
2718 Salisbury Hwy.
City
Statesville State NC ZIP Code 28677
County
iredell County
Telephone No.
704-768-2429 Fax: [phone]
3) Physical location information:
Please provide a narrative description of how to get to the facility (use street names, state road numbers, and
distance and direction from a roadway intersection). Travel east on Highway 70 then turn Left on Old 70
(Salisbury Hwy.) and facility is on Right about 1.5 miles
(A copy of a map with the facility clearly located on it should be included with the certification application.)
4) Is the facility located on Native American Lands? ❑Yes X No
5) Is this a Federal facility? ❑Yes X No
6) Latitude 35.756515 Longitude-80.787230 (deg., min., seconds)
7) This NPDES No Exposure Exclusion application applies to which of the following:
❑ New or Proposed Facility Date operation is to begin
X Existing Date operation began March 2014
❑ Renewal of existing No Exposure Certification Certification No.: NCGNE
8) Was this facility or site ever covered under an NPDES Stormwater Permit? ❑Yes X No
If yes, what is the NPDES Permit Number? NIA
9) Standard Industrial Classification:
Provide the 4-digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial
activity at this facility
SIC Code: 3713
10) Provide a brief description of the types of industrial activities and products produced at this facility:
After market add -on to new class 7 and class 8 tractor trucks.
11) Does this facility have any Non -Discharge permits (ex: recycle permits)?
X No
❑Yes
If yes, list the permit numbers for all current Non -Discharge permits for this facility:
Page 2of7
Rw1I_Nrr;NF I aat rA%AQA i 419R/901A

NCGNE0000 No Exposure Certification
Exposure Checklists (12. - 14.)
12) Are any of the following materials or activities exposed to precipitation, now or in the foreseeable
future? (Please check either "Yes" or "No.") If you answer "Yes" to any of these items, you are not
eligible for the no exposure exclusion.
a. Using, storing, or cleaning industrial machinery or equipment, and areas where ❑Yes X No ❑NIA
residuals from using, storing or cleaning industrial machinery or equipment
remain and are exposed to stormwater
b. Materials or residuals on the ground or in stormwater inlets from spills/leaks ❑Yes X No ❑NIA
c. Materials or products from past industrial activity ❑Yes X No ❑NIA
d. Material handling equipment (except adequately maintained vehicles) ❑Yes X No ❑NIA
e. Materials or products during loading/unloading or transporting activities ❑Yes X No ❑NIA
f. Materials or products stored outdoors (except final products intended for outside ❑Yes X No ❑NIA
use [e.g., new cars] where exposure to stormwater does not result in the
discharge of pollutants)
g. Materials contained in open, deteriorated or leaking storage drums, barrels, ❑Yes X No ❑N/A
tanks, and similar containers
h. Materials or products handled/stored on roads or railways owned or maintained Dyes X No ❑NIA
by the discharger
i. Waste material (except waste in covered, non -leaking containers [e.g., ❑Yes X No ❑N/A
dumpsters])
j. Application or disposal of process wastewater (unless otherwise permitted) ❑Yes X No ❑N/A
k. Particulate matter or visible deposits of residuals from roof stacks and/or vents ❑Yes X No ❑N/A
not otherwise regulated (i.e., under an air quality control permit) and evident in the
stormwater outflow
I. Empty containers that previously contained materials that are not properly stored ❑Yes X No ❑N/A
(i.e., not closed and stored upside down to prevent precipitation accumulation)
m. For any exterior ASTs, as well as drums, barrels, tanks, and similar containers ❑Yes X No ❑N/A
stored outside, has the facility had any releases in the past three (3) years?
13) Above Ground Storage Tanks (ASTs): If you answer "No" to any of the following items, you are not
eligible for the no exposure exclusion.
a. Are exterior ASTs or piping free of rust, damaged or weathered coating, pits, or ❑Yes ❑No X N/A
deterioration, or evidence of leaks?
b. Is secondary containment provided for all exterior ASTs? If so, is it free of any ❑Yes ❑No X N/A
cracks, holes, or evidence of leaks, and are drain valves maintained locked
shut?
14) Secondary Containment: If you answer "No" to any of the following items, you are not eligible for the
no exposure exclusion.
Page 3of7
cwi i_nerr,NF i aer raviearl Q17RIhf11R

NCGNE0000 No Exposure Certification
a. Is secondary containment provided for single above ground storage containers ❑Yes ❑No X NIA
(including drums, barrels, etc.) with a capacity of more than 660-gallons?
b. Is secondary containment provided for above ground storage containers stored ❑Yes ❑No X NIA
in close proximity to each other with a combined capacity of more than 1,320-
gallons?
c. Is secondary containment provided for Title III Section 313 Superfund ❑Yes ❑No X NIA
Amendments and Reauthorization Act (SARA) water priority chemicals"?
d. Is secondary containment provided for hazardous substances" designated in ❑Yes ❑No X N/A
40 CFR §116?
e. Are release valves on all secondary containment structures locked? ❑Yes []No X NIA
15) Hazardous Waste:
a. Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility? ❑Yes X No ❑N/A
b. Is this facility a Small Quantity Generator (less than 1000 kg. of hazardous ❑Yes X No ❑N/A
waste generated per month) of hazardous waste?
c. Is this facility a Large Quantity Generator (1000 kg. or more of hazardous waste ❑Yes X No ❑NIA
generated per month) of hazardous waste?
If you answered yes to questions b. or c., please provide the following information:
Type(s) of
waste:
vendor:
How is material stored:
Where is material stored:
How many disposal shipments per year:
Name of transport / disposal
Vendor address:
Footnotes to Questions 14) c. & d.
"Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for de minimis amounts of certain substances,
and/or other qualifiers, as described in the exemptions from reporting requirements of Title III SARA 313 in 40 CFR
§372.38.
"Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for amounts less than the Reportable
Quantities of the hazardous substances listed in 40 CFR §117.3.
16) Other information: If you answer "Yes" to any of the following items, you might not be eligible for the
no exposure exclusion. A more in-depth evaluation of the site circumstances may be required.
Page 4of7
Awl i-Nr;r;NF I act rovicM Ql9R/9MA

NCGNE0000 No Exposure Certification
a. Does your facility store used, recycled, or otherwise reclaimed pallets outside? ❑Yes X No ❑NIA
b. Does your facility have coal piles on site?
❑Yes X No ❑NIA
c. Does your facility store other fuel sources outside in piles, such as wood chips,
❑Yes X No ❑NIA
sawdust, etc.?
d. Does your facility have air emissions associated with its industrial activity (e.g.,
❑Yes X No ❑NIA
degreasing operations, plating, painting and metal finishing)? If so, describe the
industrial activity:
e. If you answered yes to d., are those emissions permitted by an Air Quality
❑Yes X No ❑NIA
Permit? Please specify:
f. Please list any other environmental program permits (federal, state, etc.) not
specified earlier in this application (such as Hazardous Waste Permits, etc.):
Permit: Program:
Permit: Program:
Permit: Program:
Permit: Program:
Perm it: Program:
Permit: Program:
Permit: Program:
Page 5of7
swi i.ivrr;NF i act ravi¢ar1 019P/901F

NCGNE0000 No Exposure Certification
17) Certification:
I certify under penalty of law that I have read and understand the eligibility requirements for claiming a condition of "no
exposure" and obtaining an exclusion from NPDES stormwater permitting.
certify under penalty of law that there are no discharges of stormwater contaminated by exposure to industrial activities or
materials from the industrial facility or site identified in this document (except as allowed under 40 CFR 122.26(g)(2)).
I understand that I am obligated to maintain no exposure conditions and complete a Self -Recertification form at least once
each.,ypar, and if requested, provide this certification to the operator of the local municipal separate storm sewer system
(MS4) into which the facility discharges (where applicable). I understand that I must allow the North Carolina Division of
Energy, Mineral, and Land Resources, or MS4 operator where the discharge is into the local MS4, to perform inspections
to confirm the condition of no exposure and to make such inspection reports publicly available upon request. I understand I
must keep a copy of annual re -certifications on file at the facility.
In the event that the site no longer qualifies for a No Exposure Exclusion, I understand that I must obtain coverage under
an NPDES permit prior to any point source discharge of stormwater from the facility. Additionally, I certify under penalty of
law that this document and all attachments were prepared under my direction or supervision in accordance with a system
designed to assure that qualified personnel properly gathered and evaluated the information submitted. Based on my
inquiry of the person or persons who manage the system, or those persons directly responsible for gathering the
information, the information submitted is to the best of my knowledge and belief true, accurate and complete. I am aware
that there are significant penalties for submitting false information, including the possibility of fine and imprisonment for
knowing violations.
I certify that I am familiar with the information contained in this application and that to the best of my knowledge and belief
such information is true, complete, and accurate.
Printed Name of Person Signing:
of Applicant)
(Date Signed)
Please note: This application for the No Exposure Exclusion is subject to approval by the NCDEQ
Regional Office prior to issuance. The Regional Office may inspect your facility for compliance
with no exposure conditions prior to that approval. The Regional Office may also inspect your
facility at any time in the future for compliance with the No Exposure Exclusion.
North Carolina General Statute 143-215.6 B(i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan, or other
document filed or required to be maintained under this Article or a rule implementing this Article; or who knowingly makes a false
statement of a material fact in a rulemaking proceeding or contested case under this Article; or falsifies, tampers with, or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
(Environmental Management] Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine
not to exceed ten thousand dollars ($10,000).
There is currently no fee for a No Exposure Exclusion.
Page 6of7
Rwl l_Nrr.NF 1 am ravicarl QI9Rl901A

NCGNE0000 No Exposure Certification
Final Checklist
This application should include the following items:
X This completed application and all supporting documentation.
X A map with the location of the facility clearly marked.
N/A If the site currently has an NPDES Stormwater Permit, be sure to indicate the permit number in Question B.
Mail the entire package to:
Stormwater Permitting Program
Division of Energy, Mineral and Land Resources
1612 Mail Service Center
Raleigh, North Carolina 27699-1612
Note
The submission of this document does not guarantee the issuance of a No Exposure Exclusion.
For questions, please contact the DEMLR Regional Office for your area.
DEMLR Regional Office Contact_ Information_
Asheville Office ...... [phone]
Fayetteville Office
... [phone]
Mooresville Office
... [phone]
Raleigh Office ........
[phone]
Washington Office
...[phone]
Wilmington Office
... [phone]
Winston-Salem ......
[phone]
Central Office .........[phone]
Page 7 of 7
.qwi i.Nrr,NF: i Pqt rovieorl 419R19 1A

8/3/2018
2718 Salisbury Rd - Google Maps
G©ogle MapS 2718 Salisbury Rd
R-edray't 1kveStR:0ii;
s
S. .'NjR %[}
�.F!!Si3} 2 ` { SiFtfSua[ti 3i CI
.SSi:S[3r:T PC v
S3i FM1 t''11 s i 04 i3�' C;vlt'iV.°Oi
CRSI 1rt Art! $yS,^.r^S
a7
y41'
Q-^ e
,7.
a
Y
�Foni Tr'rlsno;acpps
-
Sa;._:
56ulterr� Sides
�,
i
•
'716 HG4 }
3
k
/yam hi^,tv[�r:ar.
T SFa1niL�.CJ IL'"!I v
c
Care;ulei La��vtrs R�
x�-�
tir,n:gcr 2nt�
Z
,. uG
_r.
-
Google
W
Map data @2018 Google
200 ft r i
https:llwww.google,com/maps/pl@ce/2718+Salisbury+Rd,+Statesville,+NC+286771@35,7565148,-80.7894184,17zldata-!3m1!4b1!4m5!3m4!1so xB853e2c062170abd:Oxc7db71763401116f!8m2!3d35.75... 112