NCGNE0547_COMPLETE FILE - HISTORICAL_20090422

Ap
STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
NCGNE �4-7
DOC TYPE
rid, HISTORICAL FILE
DOC DATE
❑ &D9 D+ a�;k
YYYYMMDD

jph
C®ER
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins
Governor Director
April 22, 2009
Ms. Laura Cummings
UPM RAFLATAC
400 Broadpointe Drive
Fletcher, NC 28732
Subject: No -Exposure Certification NCGNE0547
UPM RAFLATAC, RFID
267 Cane Creek Road, Fletcher, NC
Henderson County
Dear Ms. Cummings:
Dee Freeman
Secretary
The Division has reviewed your submittal of the No -Exposure Certification for Exclusion from NPDES Stormwater
Permitting form. Based on your submittal and signed certification of no exposure at the above. refere n ced facility, the
Division is granting your conditional exclusion from permitting as provided for under 40 CFR 126.22(g), which is
incorporated by reference in North Carolina regulations.
Please note that by our acceptance of your no -exposure certification, you are obligated to maintain no -exposure
conditions at your facility. If conditions change such that your facility can no longer qualify for a do -exposure exclusion,
you are obligated to immediately obtain NPDES permit coverage for your stormwater discharge. Otherwise, the
discharge becomes subject to enforcement as an un-permitted discharge. Your conditional no -exposure exclusion
expires in five years (April 21, 2014), At that time you must re -certify with the Division, or obtain NPDES permit
coverage for any stormwater discharges from your facility.
Your conditional exclusion from permitting does not affect your facility's legal requirements to obtain environmental
permits that may be required under other federal, state, or local regulations or ordinances.
If you have any questions or need further information, please contact Sarah Young at [phone], or at
sarah.young [e-mail].
Sincerely,
e Xd.1
for Coleen H. Sullins
cc: DWQ Asheville Regional Office
Stormwater Permitting Unit - No Exposure Files
Wetlands and Stormwater Branch One 1617 Mail Service Center, Raleigh, North Carofna 27699-1617 NOltt,! lCai-of l lria
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604
Phone: [phone] FAX: [phone] Customer Service: 1-877-623-6748 �/�t �'�"JJ
Internet: www.ncwaterquality.org i/
An Equal Oppodunity S Affirmative Acton Employer

N,
�Zo jSY
FOR AGFr;CY USF ONLY
9I Durc �'d
)DIVlSl017 Of Water Quality / SLII'filCe Water PCOtL'CtlOn Year �wonih onth Dsy
C)
0
NCDENR National Pollutant Discharge Elimination System "tcalcolCovorage
r !Nr I;
11015141
: ,„ uo inP �x...TMert or NO EXPOSURE CERTIFICATION for Exclusion
fr ,R7•+inF,'IT a111: NPTµA+I L1�`iO.'i^..Fr
NCGNE0000
NO EXPOSURE CERTIFICATION Please check here if this is a renewal: ❑ RENEWAL
National Pollutant Discharge Elimination System application for exclusion from a Stormwater Permit
based on NO EXPOSURE:
Submission of this No Exposure Certification constitutes notice that your facility does not require permit
authorization for its stormwater discharges associated with industrial activity in the State of North
Carolina because it qualifies for a no exposure exclusion. A condition of no exposure at an industrial
facility means all industrial materials and activities are protected by a storm resistant shelter (with some
exceptions) to prevent exposure to rain, snow, snowmelt, and/or runoff.
Industrial materials or activities include, but are not limited to: material handling equipment or activities,
industrial machinery, raw materials, intermediate products, by-products, final products, or waste
products. Material handling activities include the storage, loading and unloading, transportation, or
conveyance of any raw material, intermediate product, final product or waste product. A storm resistant
shelter is not required for the following industrial materials and activities: drums, barrels, tanks, and
similar containers that are tightly sealed, provided those containers are not deteriorated and do not leak.
"Sealed" means banded or otherwise secured and with locked or non -operational taps or valves;
adequately maintained vehicles used in material handling; and final products, other than products that
would be mobilized in stormwater discharges (e.g., rock salt).
A No Exposure Certification must be provided for each facility qualifying for the no exposure exclusion.
In addition, the exclusion from NPDES permitting is available on a facility -wide basis only —not for
individual outfalls. If any industrial activities or materials are, or will be, exposed to precipitation, the
facility is not eligible for the no exposure exclusion. By signing and submitting this No Exposure
Certification form, you certify that a condition of no exposure exists at this facility or site and are
obligated to comply with the terms and conditions of 40 CFR 122.26(g).
You must re -apply for the No Exposure Exclusion once every five (5
For questions, please contact the DWO Regional Office for your area. (Seepage 5)
(Please print or type)
1) Mailing address of owner/operator (address to which all certification correspondence will be mailed):
Name LIPM RAPE-A_T_
Contact _L.A U R A C U M M 11SI G S,, P- E-
Street Address _47D o.c A D go t tJ TF_ D iZ .
City E[ ETC f-t E R State jj C ZIP Code Z $_7 3 Z
Telephone No. S Z 6 6 5 I -- 4-? 9 6 Fax: 9 2 S (381 -- b8 5 4
11 2) Location of facility producing discharge:
Facility Name U P M K A F L A TA C., Iv F L D
Facility Contact NI I k E K E E Q
Street Address a G 1 CAW-.E C K E" IC KID
City F L E-T-c4 aP, State IJC=ZIP Code Z 9'7 3 2-
County F+ Ff-� D_!e R S o N
Telephone No. 2-8 6 S I - 6 o 5 4- Fax: 82-, 6 S i- 6 3
Page i of 5
5WU-NE-060508 Last revised 06105/2008
" f ' ?�O%

NCGNE0000 No Exposure Certification
3) Physical location information:
Please provide a narrative description of how to get to the facility (use street names, state road numbers, and
distance and direction from a roadway intersection). rgoM FLETr.wEQ, fJo. ThwN cF_►arert1 HE-A-fl sQu;r-4
014 f+&NDP_2Snj1jVILLC_- ILD bi..5. iS) r-og. 3oz Fr_ -ru rt L EFT om GAw a tPZA&-ic Qoho
(A copy of a map with the facility clearly located on it should be included with the certification application.) rop- 0-9 MILES
✓ 4) Is the facility located on Native American Lands? ❑ Yes No
5) Is this a Federal facility? ❑ Yes D(No
* 6) Latitude N 36° Z (a `(4 Longitude W 62" 2q' 3 Z " (deg., min., seconds)
7) This NPDES No Exposure Exclusion application applies to which of the following:
❑ New or Proposed Facility Date operation is to begin
X Existing Date operation began A U G 1, Zoo S
❑ Renewal of existing No Exposure Certification Certification No.: NCGNE
8) Was this facility or site ever covered under an NPDES Stormwater Permit? ❑ Yes X No
If yes, what is the NPDES Permit Number?
9) Standard Industrial Classification:
Provide the 4 digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial
activity at this facility
SIC Code: (o -7 Ci
10) Provide a brief description of the types of industrial activities and products produced at this facility:
_KFZD TAG A,ND I NLAY MA WVPA-C.TUI—I MG , tPjr- LU 6,
MC Cf+tP Pt_4CEMENT &N0 W e 9 C_ otiVEQ'rtNG
11) Does this facility have any Non -Discharge permits (ex: recycle permits)?
QC No
❑ Yes
If yes, list the permit numbers for all current Non -Discharge permits for this facility:
Exposure Checklists (12. - 14.)
✓ 12) Are any of the following materials or activities exposed to precipitation, now or in the foreseeable
future? (Please check either "Yes" or "No.") If you answer "Yes" to any of these items, you are not
eligible for the no exposure exclusion.
a. Using, storing, or cleaning industrial machinery or equipment, and areas where ❑ Yes X No
residuals from using, storing or cleaning industrial machinery or equipment remain
and are exposed to stormwater
b. Materials or residuals on the ground or in stormwater inlets from spills/leaks ❑ Yes $6 No
c. Materials or products from past industrial activity ❑ Yes XNo
d. Material handling equipment (except adequately maintained vehicles) ❑ Yes CK No
e. Materials or products during loading/unloading or transporting activities ❑ Yes KNo
f. Materials or products stored outdoors (except final products intended for outside ❑ Yes �No
use [e.g., new cars] where exposure to stormwater does not result in the discharge
of pollutants)
Page 2 of 5
SWU•NE-060508 Last revised D6/05/2008

NCGNE0000 No Exposure Certification
g. Materials contained in open, deteriorated or leaking storage drums, barrels, tanks, ❑ Yes YNo
and similar containers
h. Materials or products handled/stored on roads or railways owned or maintained by ❑ Yes X No
the discharger
i. Waste material (except waste in covered, non -leaking containers [e.g., dumpsters]) ❑ Yes >(No
j. Application or disposal of process wastewater (unless otherwise permitted) ❑ Yes X No
k. Particulate matter or visible deposits of residuals from roof stacks and/or vents not ❑ Yes ;KNo
otherwise regulated (i.e., under an air quality control permit) and evident in the
stormwater outflow
I. Empty containers that previously contained materials that are not properly stored ❑ Yes 3KNo
(i.e., not closed and stored upside down to prevent precipitation accumulation)
m. For any exterior ASTs, as well as drums, barrels, tanks, and similar containers ❑ Yes ;KNo
stored outside, has the facility had any releases in the past three (3) years?
13) Above Ground Storage Tanks (ASTs): If you answer "No" to any of the following items, you are not
eligible for the no exposure exclusion.
a. Are exterior ASTs or piping free of rust, damaged or weathered coating, pits, or XYes ❑ No
deterioration, or evidence of leaks? N / A
b. Is secondary containment provided for all exterior ASTs? If so, is it free of any Yes ❑ No
cracks, holes, or evidence of leaks, and are drain valves maintained locked shut?
14) Secondary Containment: If you answer "No" to any of the following items, you are not eligible for the
no exposure exclusion.
a. Is secondary containment provided for single above ground storage containers
(including drums, barrels, etc.) with a capacity of more than 660-gallons?
b. Is secondary containment provided for above ground storage containers stored
in close proximity to each other with a combined capacity of more than 1,320-
gallons?
c. Is secondary containment provided for any amount of Title III Section 313
Superfund Amendments and Reauthorization Act (SARA) water priority
chemicals?
d. Is secondary containment provided for any amount of hazardous substances?
e. Are release valves on all secondary containment structures locked?
NIA Sec a ncca a� Ctsm�' v% &-,,f A;4
j ►1�icl`a �.t �1.a1 fd`.. ,� 1�
15) Hazardous Waste:
j$ Yes ❑ No
XYes ❑ No
;<Yes ❑ No
Yes ❑ No
K Yes ❑ No
Page 3 of 5
AT17111B i! i AIT-TIT.W-4
Last revised 06/05/2008

NCGNE0000 No Exposure Certification
a. Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility?
b. Is this facility a Small Quantity Generator (less than 1000 kg, of hazardous waste
generated per month) of hazardous waste?
c. Is this facility a Large Quantity Generator (1000 kg. or more of hazardous waste
generated per month) of hazardous waste?
If you answered yes to questions b. or c., please provide the following information:
Types) of waste: M 9-'rr-+y � E'1]+-f t K.F_ T -0 4 E_ 4- W
How is material stored: METAL DRuM iN La for -Ai t. m
Where is material stored: I N S1 DE FAc roil V P`itMC ,
How many disposal shipments per year: — t Dkyi iP_n+
Name of transport / disposal vendor: GARB-0 r Ne , crrL
❑ Yes X No
X Yes ❑ No
❑ Yes X No
Vendor address: - , •4 A�
`�- �. `3c�c tad? , AS"i6biz, Nc. x140kF
16) Certification:
'ENNA ETZt-4F_o
+-T r=B wJ AcP
C wV, iPS
Ry
I certify under penalty of law that I have read and understand the eligibility requirements for claiming a condition of "no
exposure" and obtaining an exclusion from NPDES stormwater permitting.
I certify under penalty of law that there are no discharges of stormwater contaminated by exposure to industrial activities
or materials from the industrial facility or site identified in this document (except as allowed under 40 CFR 122.26(g)(2)).
understand that I am obligated to submit a no exposure certification form once every five (5) years to the North Carolina
Division of Water Quality and, if requested, to the operator of the local municipal separate storm sewer system (MS4) into
which the facility discharges (where applicable). I understand that I must allow the North Carolina Division of Water
Quality, or MS4 operator where the discharge is into the local MS4, to perform inspections to confirm the condition of no
exposure and to make such inspection reports publicly available upon request.
In the event that the site no longer qualifies for a No Exposure Exclusion, I understand that I must obtain coverage under
an NPDES permit prior to any point source discharge of stormwater from the facility. Additionally, I certify under penalty
of law that this document and all attachments were prepared under my direction or supervision in accordance with a
system designed to assure that qualified personnel properly gathered and evaluated the information submitted. Based
on my inquiry of the person or persons who manage the system, or those persons directly responsible for gathering the
information, the information submitted is to the best of my knowledge and belief true, accurate and complete. I am aware
that there are significant penalties for submitting false information, including the possibility of fine and imprisonment for
knowing violations.
I certify that I am familiar with the information contained in this application and that to the best of my knowledge and
belief such information is true, complete, and accurate.
Printed Name of Person Signing: M I CH A I- L E E
Title: b P E?_ A-ri o tJ 5 ityl A N A G E V_
(Signature of Applicant) (Date Signed)
Please Rote: This application for the No Exposure Exclusion is subject to approval by the
NCDENR Regional Office prior to issuance. The Regional Office may inspect your facility for
compliance with no exposure conditions prior to that approval. The Regional Office may also
inspect your facility at any time in the future for compliance with the No Exposure Exclusion.
Page 4 of 5
SWU-NE-060508 Last revised 06/05/2008

0000 No Exposure Certification
North Carolina General Statute 143-215.6 B(i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan, or other
document filed or required to be maintained under this Article or a rule implementing this Article; or who knowingly makes a false
statement of a material fact in a rulemaking proceeding or contested case under this Article; or who falsifies, tampers with, or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
[Environmental Management] Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine
not to exceed ten thousand dollars ($10,000).
There is currently no fee for a No Exposure Exclusion.
Final Checklist
This application should include the following items:
❑ This completed application and all supporting documentation.
❑ A map with the location of the facility clearly marked.
❑ If this is a renewal, indicated current NCGNE number in Question 7.
Mail the entire package to:
Stormwater Permitting Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Note
The submission of this document does not guarantee the issuance of a No Exposure Exclusion.
For questions, please contact the DWQ Regional Office for your area.
DWO Regional Office Contact Information:
Asheville Office ......
[phone]
Fayetteville Office ...
[phone]
Mooresville Office ...
[phone]
Raleigh Office ........
[phone]
Washington Office ...(252)
946-6461
Wilmington Office ...
[phone]
Winston-Salem ......
[phone]
Central Office .........(919)
733-5083
Page 5 of 5
SWU-NE-060508 Last revised 06/05/2008

1
Fletcher. N Carolina to 267 Cane Creek Rd. Fletcher, NC 28732 - Google Maps Page 1 of 2
GOO le
s
P
Ma
Start Fletcher, N Carolina
End 267 Cane Creek Rd
Fletcher, NC 28732
Travel 1.0 mi — about 2 mins
Get Google Maps on your phone
AWText the word "GMAPS" to466453
r4,�F� mg Pndg J]�d
125
tiry
.an un1�,�IAI
J
n.;
f�f
�G°`ice n
U p M V XF7 L/4�T�4c-
Z 6 T C AN P- C iZEEK� ay Mamtan g4,
�c A R,
Haape
Creek
i,1i5s G-P Ru v�
-U
016
b
@2008 Gigdgl� data ©2008 NAVTEQ'm - Terms of
llttp://maps.,,00gie.com/maps?f=d&h1=en&geocode=&saddr=fletcher.+nc&daddr=267+Cane... 6/24/08

UPM
July 1, 2008
Stormwater Permitting Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Re: No Exposure Certification Form
UPM Raflatac, RFID
267 Cane Creek Road
Fletcher, NC 28732
Dear Sir:
Please find enclosed a completed No Exposure Certification Form for the UPM Raflatac, RFID
facility located in Fletcher, NC. Please contact me at [phone] if you have any questions.
Sincerely,
Laura P. Cummings, P.E.
Sustainability & Environmental Manager
attachment
cc: Mike Keen, RFID
UPM Raflatac, Inc. Tel. [phone]
400 Broadpuinte Ihivc Toll Frcc H-800-992-3992
Fletcher. NC 28732 Fax +1_828.651-4888
USA Toll Frec Fax r1-800-452-4127
www.uftmraftatac.com