WQ0006245_Final Permit_20200518

ROY COOPER
Governor
MICHAEL S. REGAN
Secretary
S. DANI£L SMITH NORTH CAROLINA
Director Environmental Quality
May 18, 2020
ANDY SMITH — OPERATIONS MANAGER
CITY OF STATESVILLE
POST OFFICE BOX I I I I
STATESVILLE, NORTH CAROLINA 28687-1111
Subject: Permit No. WQ0006245
City of Statesville DCAR
Distribution of Class A
Residuals
Iredell County
Dear Mr. Smith:
In accordance with your permit renewal request received February 14, 2020, and subsequent
additional information received May 12, 2020, we are forwarding herewith Permit No. WQ0006245 dated
May 18, 2020, to the City of Statesville for the continued operation of the subject residuals management
program. Please note that this renewed permit shall become effective on October 1, 2020 (i.e., the day after
the expiration date of the existing permit).
Modifications to the subject permit are as follows: The City of Statesville WTP has been removed
as a residuals source for this permit.
This permit shall be effective from October 1, 2020 through April 30, 2026, shall void Permit No.
WQ0006245 issued April 2, 2015, and shall be subject to the conditions and limitations as specified therein.
The Permittee shall submit a renewal application no later than November 1, 2025.
Please pay particular attention to the monitoring requirements listed in Attachment A for they may
differ from the previous permit issuance. Failure to establish an adequate system for collecting and
maintaining the required operational information shall result in future compliance problems.
Please note that on September 1, 2018, North Carolina Administrative Code Title 15A Subchapter
02T — Waste not Discharged to Surface Waters was readopted. Accordingly, this permit incorporates the
requirements of these rules, therefore, please take the time to review this permit thoroughly.
The Division has removed the following permit conditions since the last permit issuance dated
April 2, 2015:
➢ Old Condition IIL6. — This condition has been replaced by the new Condition IIL6.
➢ Old Condition IIL9. — This condition has been replaced by the new Condition IIL6.
➢ Old Condition VL2. — This condition has been removed because the permit is not voidable.
North Carolina Department of Environmental Quality I Division of Water Resources
512 North Salisbury Street 1 1617 Mail Service Center I Raleigh, North Carolina 27699-1617
N11H fH (:Ai(1!.INA �
0­O'torenwm—talQ"I 919,707.9000

Mr. Andy Smith
May 18, 2020
Page 2 of 2
The following permit conditions are new since the last permit issuance dated April 2, 2015:
➢ Condition IIL4. — The Permittee shall ensure that a copy of this permit and the Division -
approved Operation and Maintenance Plan is available when land applying bulk Class A
residuals.
➢ Condition IIL5. — The Permittee shall ensure that spill control provisions are available when
transporting or land applying bulk Class A residuals.
➢ Condition IIL6. — Class A residuals may be staged at the land application site for up to 30 days
for biological residuals and 60 days for non -biological residuals. Class A residuals shall be
stored or staged in a manner to prevent runoff of leachate and other wastewaters generated.
➢ Condition IIL8.1. — Residual land application may not occur if the land application sites are
located within a WS-1 watershed pursuant to 15A NCAC 02B .0212 or within the Critical Area
of a WS-II, WS-III, or WS-IV watershed.
➢ Condition IIL9. — The Permittee shall notify all third -parry entities receiving bulk Class A
residuals that land application activities occurring on the third-party's property shall meet the
requirements in 15A NCAC 02T .I108(b) and 02T .1109(a)(1).
➢ Condition VL8. — This permit shall not be renewed if the Permittee or any affiliation has not
paid the required annual fee.
If any parts, requirements, or limitations contained in this permit are unacceptable, the Permittee
has the right to request an adjudicatory hearing upon written request within 30 days following receipt of
this permit. This request shall be in the form of a written petition, conforming to Chapter 150B of the North
Carolina General Statutes, and filed with the Office of Administrative Hearings at 6714 Mail Service
Center, Raleigh, NC 27699-6714. Otherwise, this permit shall be final and binding.
If you need additional information concerning this permit, please contact Erick Saunders at (919)
707-3659 or erickson.saunders&ncdenr.gov.
Sincerely,
S. Daniel Smith, Director
Division of Water Resources
cc: Iredell County Health Department (Electronic Copy)
Mooresville Regional Office, Water Quality Regional Operations Section (Electronic Copy)
Laserfiche File (Electronic Copy)
Digital Permit Archive (Electronic Copy)

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENTAL QUALITY
RALEIGH
DISTRIBUTION OF CLASS A RESIDUALS PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina as
amended, and other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
City of Statesville
Iredell County
FOR THE
continued operation of a residuals management program for the City of Statesville and consisting of the
distribution of Class A residuals generated by the approved facilities listed in Attachment A, with no
discharge of wastes to surface waters, pursuant to the application received February 14, 2020, subsequent
additional information received May 12, 2020, and in conformity with other supporting data subsequently
filed and approved by the Department of Environmental Quality and considered a part of this permit. The
disposal of residuals is regulated under Title 40 Code of Federal Regulations Part 503. This permit does
not exempt the Permittee from complying with Federal Regulation 40 CFR Part 503.
This permit shall be effective from October 1, 2020 through April 30, 2026, shall void Permit No.
WQ0006245 issued April 2, 2015, and shall be subject to the following conditions and limitations:
I. SCHEDULES
1. The Permittee shall request renewal of this permit on Division -approved forms no later than November
1, 2025. [15A NCAC 02T .0105(b), 02T .0109]
II. PERFORMANCE STANDARDS
The Permittee shall maintain and operate the subject residuals management program so there is no
discharge to surface waters, nor any contravention of groundwater or surface water standards. In the
event the residuals management program fails to perform satisfactorily, including the creation of
nuisance conditions due to improper operation and maintenance, the Permittee shall immediately cease
distributing residuals, take immediate corrective actions, and contact the Mooresville Regional Office
supervisor. [15A NCAC 02T .0108(b)(1)(A)]
2. This permit shall not relieve the Permittee of their responsibility for damages to groundwater or surface
water resulting from the operation of this residuals management program. [15A NCAC 02T
.0108(b)(1)(A)]
3. Only residuals generated by the facilities listed in Attachment A are approved for distribution in
accordance with this permit. [15A NCAC 02T .1101]
WQ0006245 Version 5.0 Shell Version 200201 Page 1 of 9

4. Pollutant concentrations in distributed residuals shall not exceed the following Ceiling Concentrations
or Monthly Average Concentrations, on a dry weight basis:
Parameter
Ceiling Concentration
Monthly Average
Concentration
img/w
(mg1kg)
Arsenic
75
41
Cadmium
85
39
Copper
4,300
1,500
Lead
840
300
Mercury
57
17
Molybdenum
75
N/A
Nickel
420
420
Selenium
100
100
Zinc
7,500
2,800
[15A NCAC 02T .1105(a), 02T .1105(c)]
5. Class A biological residuals shall meet the pathogen reduction requirements in 15A NCAC 02T
.1106(a). Exemptions to this requirement shall be specified in Attachment A. [15A NCAC 02T
.1106(a), 02T .1106(d)]
6. Class A biological residuals shall meet one of the vector attraction reduction alternatives in 15A NCAC
02T .1107(a). Exemptions to this requirement shall be specified in Attachment A. [15A NCAC 02T
.1107(a), 02T .1107(c)]
7. The facilities and sites herein were permitted per the following setbacks:
a. Setbacks for Class A land application sites are as follows (all distances in feet):
Liquid Cake
Residuals Residuals'
I. Each private or public water supply source:
100
100
ii. Surface waters such as intermittent and perennial streams, perennial
100
25
waterbodies, and wetlands:
iii. Surface water diversions such as ephemeral streams, waterways, and
25
0
ditches:
iv. Groundwater lowering ditches where the bottom of the ditch
25
0
intersects the SHWT:
v. Each well with exception of monitoring wells:
100
100
vi. Bedrock outcrops:
25
0
' Unless otherwise noted in Attachment A, "cake" residuals are those that have greater than 15%
solids by weight and can be stacked without flowing, as well as can be handled, transported
and spread as a solid (e.g., using a backhoe, front end loader, slinger spreader, broadcast
spreader or other equipment designed for handling solid materials) without leaving any
significant liquid fraction behind.
[15A NCAC 02T .1108(b)]
WQ0006245 Version 5.0 Shell Version 200201 Page 2 of 9

b. The out of service sludge drying beds that are currently being used as a residuals storage unit were
originally permitted or modified between February 1, 1993 to August 31, 2006 and the setbacks
are as follows (all distances in feet):
i. Each private or public water supply source: 100
ii. Surface waters: 50
iii. Each well with exception of monitoring wells: 100
iv. Each property line: 50 1
v. Nitrification field: 20
' Setbacks to property lines are not applicable when the Permittee, or the entity from which the
Permittee is leasing, owns both parcels separated by the property line.
[15A NCAC 02H .02190)(5)]
8. Residuals and other sources of Plant Available Nitrogen (PAN) shall not be applied in exceedance of
agronomic rates. Appropriate agronomic rates shall be calculated using expected nitrogen requirements
based on the determined Realistic Yield Expectations (RYE) using any of the following methods:
a. Division's pre -approved site specific historical data for specific crop or soil types by calculating
the mean of the best three yields of the last five consecutive crop harvests for each field.
b. North Carolina Historical Data for specific crop and soil types as provided by North Carolina State
University Department of Soil Science (http://nutrients.soll.ncsu.edl /yields/index.php). A copy
shall be kept on file and reprinted every five years in accordance with Condition IV.6.
c. If the RYE cannot be determined using methods (a) or (b) above, the Permittee may use the RYE
and appropriate nutrient application rates reported in any of the following documents:
i. Crop management plan as outlined by the local Cooperative Extension Office, the North
Carolina Department of Agriculture and Consumer Services, the Natural Resource
Conservation Service, or other agronomist.
ii. Waste Utilization Plan as outlined by the Senate Bill 1217 Interagency Group -Guidance
Document: Chapter 1
(hLtp://www.ncagr.gov/SWC/tech/documents/9th Guidance_ Doc_ 100109.pdf).
iii. Certified Nutrient Management Plan as outlined by the Natural Resources Conservation
Services (MRCS). These plans must meet the USDA-NRCS 590 Nutrient Management
Standards(ftp://fip-fc.sc.egov.usda.gov/NHQ/Tractice-standards/standards/590.pdf�
d. If the RYE and appropriate nutrient application rates cannot be determined, the Permittee shall
contact the Division to determine necessary action.
[15A NCAC 02T . I 109(a)(1)(K)]
9. Prior to distributing Class A residuals that have a sodium adsorption ratio (SAR) of 10 or higher, the
Permittee shall obtain and implement recommendations from at least one of the following: the local
Cooperative Extension Office; the Department of Agriculture and Consumer Services; the Natural
Resource Conservation Service; a North Carolina Licensed Soil Scientist; or an agronomist. The
recommendations shall address the sodium application rate, soil amendments (e.g., gypsum, etc.), or a
mechanism for maintaining site integrity and conditions conducive to crop growth. The Permittee shall
maintain written records of these recommendations and details of their implementation. The Permittee
shall notify third -party entities of the effects of a high SAR content residuals on their receiving sites.
[I5A NCAC 02T .0 1 08(b)(1)(A)]
WQ0006245 Version 5.0 Shell Version 200201 Page 3 of 9

III. OPERATION AND MAINTENANCE REQUIREMENTS
1. The Permittee shall operate and maintain the residuals management program as anon -discharge system.
[15A NCAC 02T .1100]
2. The Permittee shall maintain a Division -approved Operation and Maintenance Plan that shall include:
a. Description of the program, and associated facilities and equipment, in sufficient detail to show
what operations are necessary for the program to function and by whom the functions are to be
conducted;
b. Description of anticipated maintenance of facilities and equipment associated with the program;
c. Include provisions for safety measures, including restriction of access to sites and equipment;
d. Spill control provisions:
I. Response to upsets and bypasses including control, containment, and remediation; and
ii. Contact information for plant personnel, emergency responders, and regulatory agencies;
e. Detailed inspection procedures:
I. Names or titles of personnel responsible for conducting inspections;
ii. Frequency and location of inspections, and procedures to assure that the selected locations and
inspection frequency are representative of the residuals management program; and
iii. Description of record keeping and actions to be taken by the inspector in the event that
noncompliance is observed;
f Detailed sampling and monitoring procedures:
I. Names or titles of personnel responsible for conducting sampling and monitoring;
ii. Description of monitoring procedures including parameters to be monitored; and
iii. Sampling frequency and procedures to assure that representative samples are collected.
Fluctuation in temperature, flow, and other operating conditions can affect the quality of the
residuals gathered during a particular sampling event. The sampling plan shall account for any
foreseen fluctuations in residuals quality and indicate the most limiting times for residuals to
meet pathogen and vector attraction reduction requirements.
[15A NCAC 02T .I I I0(a)]
3. Upon the Water Pollution Control System Operators Certification Commission's (WPCSOCC)
classification of the residuals management program, the Permittee shall designate and employ a
certified operator in responsible charge (ORC), and one or more certified operators as back-up ORCs.
The ORC or their back-up shall visit the facilities in accordance with 15A NCAC 08G 0204 and shall
comply with all other requirement in 15A NCAC 08G 0204. [15A NCAC 02T .0117, 08G .0204]
4. The Permittee shall ensure that a copy of this permit and the Division -approved Operation and
Maintenance Plan is available when land applying bulk Class A residuals. [15A NCAC 02T .1110(b)]
5. The Permittee shall ensure that spill control provisions are available when transporting or land applying
bulk Class A residuals. [15A NCAC 02T .1110(a)(4)]
6. Class A residuals may be staged at the land application site for up to 30 days for biological residuals
and 60 days for non -biological residuals. Class A residuals shall be stored or staged in a manner to
prevent runoff of leachate and other wastewaters generated. [15A NCAC 02T .1110(c), 02T .1110(d)]
7. Adequate measures shall be taken to prevent wind erosion and runoff from the bulk Class A residual
land application sites. [15A NCAC 02T .0108(b)(1)(A)]
WQ0006245 Version 5.0 Shell Version 200201 Page 4 of 9

8. Bulk Class A residuals shall not be land applied under the following conditions:
a. If the residuals are likely to adversely affect a threatened or endangered species listed under section
4 of the Endangered Species Act or its designated critical habitat;
b. If the application causes nuisance conditions;
c. If the land fails to assimilate the bulk residuals or the application causes the contravention of surface
water or groundwater standards;
d. If the land is flooded, frozen, or snow-covered, or is otherwise in a condition such that runoff of
the residuals would occur;
e. Within the 100-year flood elevation, unless the residuals are injected or incorporated within a 24-
hour period following a residuals land application event;
f During precipitation events, or within 24 hours following a rainfall event of 0.5 inches or greater
in a 24-hour period;
g. If the slope of the land is greater than 10% when liquid residuals are surface applied, or if the slope
of the land is greater than 18% when liquid residuals are injected or incorporated;
h. If the land does not have an established vegetative cover crop unless the land is a Division -approved
no -till site, or the residuals are injected, or incorporated within a 24-hour period following the
application of residuals;
i. If the vertical separation of the seasonal high water table and the depth of residuals application is
less than one foot;
j. If the vertical separation of the depth to bedrock and the depth of residuals application is less than
one foot;
k. If the application exceeds agronomic rates; or
1. If the land application sites are located within a WS-I watershed pursuant to 15A NCAC 02B .0212
or within the Critical Area of a WS-II pursuant to Sub -Item (4)(g) of Rule 15A NCAC 02B .0212,
or within the Critical Area of a WS-III or WS-IV watershed pursuant to Sub -Item (4)(h) of Rules
15A NCAC 02B .0215, and .0216.
[15A NCAC 02T. I 109(a)(1), 02T. I 109(b)]
9. The Permittee shall notify all third -party entities receiving bulk Class A residuals that land application
activities occurring on the third-party's property shall meet the requirements in 15A NCAC 02T
.1108(b) and 02T .1109(a)(1) (i.e., Conditions IL7.a. and III.8., respectively). [15A NCAC 02T
.1103(a)(4), 02T .1103(a)(5)]
10. Bagged or other container Class A residuals shall have an affixed label or an information sheet provided
to the person receiving the Class A residuals. The label or information sheet shall contain the following:
a. The name and address of the person who prepared the residuals;
b. A statement that residual land application is prohibited except in accordance with the instructions
on the label or information sheet;
c. A statement that the residuals shall be applied at agronomic rates and recommended rates for its
intended use.
[15A NCAC 02T. I 109(c)]
11. The Permittee shall not distribute bulk Class A residuals to any person or entity known to be applying
residuals contrary to the conditions of this permit. The Permittee shall report to the Mooresville
Regional Office any person or entity known to be applying residuals contrary to the conditions of this
permit. [15A NCAC 02T .0108(b)(1)(A)]
WQ0006245 Version 5.0 Shell Version 200201 Page 5 of 9

IV. MONITORING AND REPORTING REQUIREMENTS
The Permittee shall conduct and report any Division required monitoring necessary to evaluate this
program's impact on groundwater and surface water. [15A NCAC 02T .0108(c)]
2. The residuals from each source generating facility shall be analyzed to demonstrate they are non-
hazardous under the Resource Conservation and Recovery Act (RCRA). Residuals that test or are
classified as a hazardous or toxic waste under 40 CFR Part 261 shall not be land applied. The analyses
(i.e., corrosivity, ignitability, reactivity, and toxicity characteristic leaching procedure (TCLP)) shall be
performed at the frequency specified in Attachment A, and the Permittee shall maintain these results
for five years. Any exemptions from the requirements in this condition shall be specified in Attachment
A. The TCLP analysis shall include the following parameters, and the Federal regulatory level (mg/L)
is in parentheses:
Arsenic (5.0)
1,4-Dichlorobenzene (7.5)
Nitrobenzene (2.0)
Barium (100.0)
1,2-Dichloroethane (0.5)
Pentachlorophenol (100.0)
Benzene (0.5)
1,1-Dichloroethylene (0.7)
Pyridine (5.0)
Cadmium (1.0)
2,4-Dinitrotoluene (0.13)
Selenium (1.0)
Carbon tetrachloride (0.5)
Endrin (0.02)
Silver (5.0)
Chlordane (0.03)
Heptachlor (and its epoxide)
(0.008)
Tetrachloroethylene (0.7)
Chlorobenzene (100.0)
Hexachlorobenzene (0.13)
Toxaphene (0.5)
Chloroform (6.0)
Hexachlorobutadiene (0.5)
Trichloroethylene (0.5)
Chromium (5.0)
Hexachloroethane (3.0)
2,4,5-Trichlorophenol (400.0)
m-Cresol (200.0)
Lead (5.0)
2,4,6-Trichlorophenol (2.0)
o-Cresol (200.0)
Lindane (0.4)
2,4,5-TP (Silvex) (1.0)
p-Cresol (200.0)
Mercury (0.2)
Vinyl chloride (0.2)
Cresol (200.0)
Methoxychlor (10.0)
2,4-D (10.0)
Methyl ethyl ketone (200.0)
[15A NCAC 13A .0102(b), 02T .1101, 02T .1105]
3. The residuals from each source generating facility shall be analyzed at the frequency specified in
Attachment A, and the Permittee shall maintain the results for a minimum of five years. Each analysis
shall include the following parameters:
Aluminum
Mercury
Potassium
Ammonia -Nitrogen
Molybdenum
Selenium
Arsenic
Nickel
Sodium
Cadmium
Nitrate -Nitrite Nitrogen
Sodium Adsorption Ratio
(SAR)
Calcium
Percent Total Solids
TKN
Copper
pH
Zinc
Lead
Phosphorus
Magnesium
Plant Available Nitrogen
(by calculation)
[15A NCAC 02T .1101]
WQ0006245 Version 5.0 Shell Version 200201 Page 6 of 9

4. Residuals shall be monitored for compliance with pathogen and vector attraction reduction
requirements at the frequency specified in Attachment A. The monitoring results shall specify the
stabilization process utilized, and demonstrate compliance with the Class A pathogen reduction
requirements in 15A NCAC 02T .1106(a), and one vector attraction reduction requirement in 15A
NCAC 02T .1107(a) shall be met. Any exemptions from the requirements in this condition shall be
specified in Attachment A. [15A NCAC 02T .1106(a), 02T .1107(a), 02T .1111(c)]
5. Representative samples of residuals that are prepared for distribution shall be collected and analyzed.
[15A NCAC 02T .1I I I(a)]
6. The Permittee shall maintain records for all bulk Class A residual distribution events. These records
shall include the following:
a. Residuals source (as listed in Attachment A);
b. Date of distribution;
c. Name and address of residuals recipient;
d. Volume of residuals distributed to each recipient; and
e. Intended use of residuals.
[15A NCAC 02T .0108(c)]
7. One hard copy and one electronic copy of an annual report shall be submitted on or before March 1st
The annual report shall meet the requirements described in the Instructions for Residuals Application
Annual Reporting Forms. Instructions for reporting and annual report forms are available at
http:Hdeg .nc. gov/about/divisions/water-resources/water-resources-permits/wastewater-branch/non-
discharge-permitting-unit/reportin -fg orms, or can be obtained by contacting the Non -Discharge Branch
directly. The annual report shall be submitted to the following address:
Division of Water Resources
Information Processing Unit
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
[15A NCAC 02T .I I I I(d)]
8. Noncompliance Notification
The Permittee shall report to the Mooresville Regional Office, telephone number [phone],
within 24 hours of first knowledge of the:
a. Any process unit failure (e.g., mechanical, electrical, etc.) rendering the facility incapable of
adequate residual treatment.
b. Any failure resulting in a discharge to surface waters.
c. Any time self -monitoring indicates the program has gone out of compliance with its permit
limitations.
d. Distribution of residuals abnormal in quantity or characteristic.
e. Any discharge from a vehicle or piping system transporting residuals.
Emergencies requiring reporting outside normal business hours shall call the Division's Emergency
Response personnel at telephone number [phone], [phone], or [phone]. All
noncompliance notifications shall file a written report to the Mooresville Regional Office within five
days of first knowledge of the occurrence, and this report shall outline the actions proposed or taken to
ensure the problem does not recur. [15A NCAC 02T .0108(b)(1)(A)]
WQ0006245 Version 5.0 Shell Version 200201 Page 7 of 9

V. INSPECTIONS
1. The Permittee shall perform inspections and maintenance to ensure proper operation of the Permittee's
storage and distribution facilities. [15A NCAC 02T .1110(f)]
2. The Permittee shall inspect the Permittee's residuals processing and storage facilities to prevent
malfunctions, facility deterioration, and operator errors that may result in discharges of wastes to the
environment, threats to human health, or public nuisances. The Permittee shall maintain an inspection
log that includes the date and time of inspection, observations made, and maintenance, repairs, or
corrective actions taken. The Permittee shall maintain this inspection log for a period of five years
from the date of inspection, and this log shall be made available to the Division upon request. [15A
NCAC 02T .0 1 08(b)(1)(A), 02T .I I I0(f)]
Division authorized representatives may, upon presentation of credentials, enter and inspect any
property, premises, or place related to the distribution sites or facilities permitted herein at any
reasonable time for determining compliance with this permit. Division authorized representatives may
inspect or copy records maintained under the terms and conditions of this permit, and may collect
groundwater, surface water, or leachate samples. [G.S. 143-215.3(a)(2)]
VI. GENERAL CONDITIONS
1. Failure to comply with the conditions and limitations contained herein may subject the Permittee to a
Division enforcement action. [G.S. 143-215.6A, 143-215.613, 143-215.6C]
2. This permit is effective only with respect to the nature and volume of wastes described in the permit
application, and Division -approved plans and specifications. [G.S. 143-215.1(d)]
3. Unless specifically requested and approved in this permit, there are no variances to administrative codes
or general statutes governing the construction or operation of the facilities permitted herein. [15A
NCAC 02T .0105(n)]
4. The issuance of this permit does not exempt the Permittee from complying with all statutes, rules,
regulations, or ordinances that other jurisdictional government agencies (e.g., local, state, and federal)
may require. [15A NCAC 02T .0105(c)(6)]
If the permitted residuals program change ownership, or the Permittee changes their name, the
Permittee shall submit a permit modification request on Division -approved forms. The Permittee shall
comply with all terms and conditions of this permit until the permit is transferred to the successor -
owner. [G.S.143-215.1(d3)]
WQ0006245 Version 5.0 Shell Version 200201 Page 8 of 9

6. This permit is subject to revocation or modification upon 60-day notice from the Division Director, in
whole or part for:
a. violation of any terms or conditions of this permit or Administrative Code Title 15A Subchapter
02T;
b. obtaining a permit by misrepresentation or failure to disclose all relevant facts;
c. the Permittee's refusal to allow authorized Department employees upon presentation of credentials:
I. to enter the Permittee's premises where a system is located or where any records are required
to be kept;
ii. to have access to any permit required documents and records;
iii. to inspect any monitoring equipment or method as required in this permit; or
iv. to sample any pollutants;
d. the Permittee's failure to pay the annual fee for administering and compliance monitoring; or
e. a Division determination that the conditions of this permit are in conflict with North Carolina
Administrative Code or General Statutes.
[15A NCAC 02T .0110]
7. Unless the Division Director grants a variance, expansion of the facilities permitted herein shall not
occur if any of the following apply:
a. The Permittee or any parent, subsidiary, or other affiliate of the Permittee has been convicted of
environmental crimes under G.S. 143-215.6B, or under Federal law that would otherwise be
prosecuted under G.S. 143-215.6B, and all appeals of this conviction have been abandoned or
exhausted.
b. The Permittee or any parent, subsidiary, or other affiliate of the Permittee has previously abandoned
a wastewater treatment facility without properly closing the facility.
c. The Permittee or any parent, subsidiary, or other affiliate of the Permittee has not paid a civil
penalty, and all appeals of this penalty have been abandoned or exhausted.
d. The Permittee or any parent, subsidiary, or other affiliate of the Permittee is currently not compliant
with any compliance schedule in a permit, settlement agreement, or order.
e. The Permittee or any parent, subsidiary, or other affiliate of the Permittee has not paid an annual
fee.
[15A NCAC 02T .0120(b), 02T .0120(d)]
8. This permit shall not be renewed if the Permittee or any affiliation has not paid the required annual fee.
[15A NCAC 02T .0120(c)]
Permit issued this the 18"' day of May 2020
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
S. Daniel Smith, Director
Division of Water Resources
By Authority of the Environmental Management Commission
Permit Number WQ0006245
WQ0006245 Version 5.0 Shell Version 200201 Page 9 of 9

THIS PAGE BLANK

ATTACHMENT A — APPROVED RESIDUAL SOURCES
City of Statesville
Residuals Source -Generating Facility
Certification Date: May 18, 2020
Permit Number: WQ0006245 Version: 5.0
Owner
Facility
County
Permit
Biological
MaximumMonitoring
Dry Tons
Frequency for Non-
Monitoring Frequency for Metals
Number
Residuals
hazardous Determination 2
and Nutrients'
per Year'
City of Statesville
Third Creek WWTP
Iredell
NCO020591
Yes
N/A
N/A
N/A
City of Statesville
Fourth Creek WWTP
Iredell
NCO031836
Yes
N/A
N/A
N/A
Total
Class A Residuals Product Generated for Distribution
Monitoring
Monitoring
MonitoringApproved
Permit
Biological
Maximum
Frequency for
Frequency for
Frequency for
Mineralization
Owner
Facility Name
County
Number
Residuals
Dry Tons
Non -hazardous
Metals and
Pathogen &
Rate
Per Year'
Determination 2
Nutrients 3,6
Vector Attraction
Reductions 1,6
City of Statesville
Sta-Lime Processing &
Iredell
WQ0006245
Yes
7,000
Once per permit
See Table Below
See Table Below
0.3
Distribution
cycle
1. Maximum Dry Tons per Year for residuals source is the amount of residuals approved for composting. Maximum Dry Tons per Year for Class A residuals is the amount of residuals product
approved for distribution from the permitted facility.
2. Analyses to demonstrate that residuals are non -hazardous (i.e., TCLP, ignitability, reactivity, and coirosivity) as stipulated under permit Condition IV.2.
3. Testing of metals and nutrients as stipulated under permit Condition IV.3.
4. Analyses of pathogen and vector attraction reductions as stipulated under permit Condition IV A.
5. Monitoring frequencies are based on the actual dry tons applied per year using the table below, unless specified above.
Dry Tons Distributed
short tons per ear
Monitoring Frequency
Established in 40 CFR 503 and 15A NCAC 02T .1111
<319
1/Year
=>319 - <1,650
1/ Quarter 4 times per ear
=>1,650 - <16,500
1/60 Days 6 times per ear
=>16,500
1/month 12 times per ear
6. Sampling of the final Sta-Lime product in lieu of sampling individual sources is allowed provided that residuals from each source are blended to provide a homogenous mixture of the final product.
WQ0006245 Version 5.0 Attachment A Page 1 of 1