WQ0017554_Permit (Issuance)_19991210

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Mr. Bob Boyette, Town Manager
Town of Carthage
Post Office Box 842
Carthage, NC 28327
Dear Mr. Boyette:
,1kTz.18WA
'T 0
NCDENF1
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATTrEF,UiQS1VED
December 10, 1999 D EC 1 4 1999
FAYMEVILLE
REG. OFFICE
Subject: Permit No. WQ0017554
Town of Carthage
Jackson Terrace, Phase II
Wastewater Collection System
Moore County
In accordance with your application received October 12, 1999, attached is Permit No.
WQ0017554, dated December 10, 1999, to the Town of Carthage for the construction and operation of
the subject wastewater collection extension. A variance has been granted for the installation of
approximately 352 linear feet of 6-inch gravity sewer. This variance has been granted because the
proposed site is surrounded by existing 8-inch sewer lines. Please note Permit Conditions 11 and 12
regarding the permitted 6-inch gravity line.
This permit shall be effective from the date of issuance until rescinded and you shall be subject
to the conditions and limitations as specified in the North Carolina Gravity Sewer Design Criteria
adopted February 12, 1996 and the attached permit.
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North
Carolina as amended, and other applicable Laws, Rules, and Regulations, permission is hereby granted
for the construction and operation of approximately 352 linear feet of 6-inch gravity sewer and 170
linear feet of 8-inch gravity sewer to serve eighteen (18) one -bedroom units, four (4) two -bedroom units,
and a three -employee office as part of the Jackson Terrace, Phase H project, and the discharge of 5,355
GPD of collected domestic wastewater into Moore County's existing sewerage system, pursuant to the
application received October 12, 1999, and in conformity with the North Carolina Gravity Sewer Design
Criteria.
The sewage and wastewater collected by this system shall be treated in the Moore County
Wastewater Treatment Facility (NPDES Permit No. NC0037508) prior to being discharged into the
receiving stream.
This permit shall become voidable unless the agreement between the Town of Carthage and
Moore County for the collection and final treatment of wastewater is in full force and effect.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

If any parts, requirements, or limitations contained in this permit are unacceptable, you have the
right to request an adjudicatory hearing upon written request within thirty (30) days following receipt of
this permit. This request must be in the form of a written petition, conforming to Chapter 150B of North
Carolina General Statutes, and filed with the Office of Administrative Hearings, 6714 Mail Service
Center, Raleigh, NC 27699-6714. Unless such demands are made this permit shall be final and binding.
The issuance of this permit does not preclude the Permittee from complying with any and all
statutes, rules, regulations, or ordinances which may be imposed by other government agencies (local,
state, and federal) which have jurisdiction.
If you need additional information concerning this matter, please contact Kristin Miguez at
[phone] extension 524. 7
Sinc ely,
-,4Kerr T. Stevens
cc: Moore County Health Department
Fayetteville Regional Office, Water Quality Section
Jordan-Tew & Associates, P.A.

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
GRAVITY SEWER COLLECTION SYSTEMS PERMIT
This permit shall be effective from the date of issuance until rescinded and shall be subject to the
following specified conditions and limitations:
1. This permit shall become voidable unless the facilities are constructed in accordance with the
conditions of the Division of Water Quality Gravity Sewer Design Criteria adopted February 12,
1996.
2. This permit is effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
3. The facilities must be properly maintained and operated at all times.
4. This permit is not transferable. In the event there is a desire for the facilities to change ownership,
or there is a name change of the Permittee, a formal permit request must be submitted to the
Division of Water Quality (Division) accompanied by an application fee, documentation from the
parties involved, and other supporting materials as may be appropriate. The approval of this request
will be considered on its merits and may or may not be approved.
5. Construction of the gravity sewers shall be scheduled so as not to interrupt service by the existing
utilities nor result in an overflow or bypass discharge of wastewater to the surface waters of the
State.
6. Upon completion of construction and prior to operation of this permitted facility, a certification
and a copy of the record drawings (i.e., as constructed plans) must be received from a professional
engineer certifying that the permitted facility has been installed" in accordance with the Division of
Water Quality Gravity Sewer Design Criteria adopted February 12, 1996, and other supporting
materials. If this project is to be completed in phases and partially certified, you shall retain the
responsibility to track further construction approved under the same permit, and shall provide a final
certificate of completion once the entire project has been completed. A copy of the record
drawings, indicating the facilities constructed in the phase being certified, shall be submitted with
each partial certification. Mail the Certification and one (1) copy of the "Record Drawings" to the
Non -Discharge Permitting Unit,1617 Mail Service Center, Raleigh, NC 27699-1617.
7. A copy of the Record Drawings shall be maintained on file by the Permittee for a minimum of five
years from the date of the completion of construction.
8. Failure to abide by the conditions and limitations contained in this general sewer permit or the
North Carolina Gravity Sewer Design Criteria may subject the Permittee to an enforcement action
by the Division, in accordance with North Carolina General Statute 143-215.6A to 143-215.6C.

9. In the event that the facilities fail to perform satisfactorily, including the creation of nuisance
conditions, the Permittee shall take immediate corrective action, including those as may be required
by this Division, such as the construction of additional or replacement wastewater collection
facilities.
10. Noncompliance Notification:
The Permittee shall report by telephone to the Fayetteville Regional Office, telephone number (9 10)
486-1541, as soon as possible, but in no case more than 24 hours or on the next working day,
following the occurrence or first knowledge of the occurrence of either of the following:
a. Any process unit failure, due to known or unknown reasons, that renders the facility incapable
of adequate wastewater transport, such as mechanical or electrical failures of pumps, line
blockage or breakage, etc.; or
b. Any failure of a sewer line resulting in a by-pass directly to receiving waters without treatment
of all or any portion of the influent to such station or facility.
Persons reporting such occurrences by telephone shall also file a written report in letter form within
five (5) days following first knowledge of the occurrence. This report must outline the actions
taken or proposed to be taken to ensure that the problem does not recur.
11. The permitted 6-inch gravity sewer is to serve only Buildings 7, 8, 9, 10, and 11 of Jackson Terrace,
Phase II.
12. No additional sewer lines may be extended from the permitted 6-inch gravity sewer.
Permit issued this the tenth day of December, 1999
NORTH OLINA E IRONVENTAL MANAGEMENT COMMISSION
/-Kerr T. Stevens, Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ0017554
2

Permit No. WQ0017554
December 10, 1999
ENGINEER'S CERTIFICATION
Partial Final
I, , as a duly registered Professional Engineer in the State of North
Carolina, having been authorized to observe (periodically, weekly, full time) the construction of the
project, , for the
Project Name Location and County
Permittee hereby state that, to the best of my abilities, due care and diligence was used in the observation
of the construction such that the construction was observed to be built within substantial compliance of
this permit, the certificate of coverage, the North Carolina Gravity Sewer Minimum Design Manual, and
other supporting materials.
Signature
Date
Registration No.
The above Engineer's Certification must be completed and submitted to the address below with one (1)
copy of the "Record Drawings" (i.e., as -constructed plans) of the wastewater collection system. This
project shall not be considered complete and allowed to operate until this Engineer's Certification and
the "Record Drawings" plans have been submitted. Any wastewater flow made tributary to the
wastewater collection system prior to completion of this Engineer's Certification shall be considered a
violation of the permit and shall subject the Permittee to appropriate enforcement actions.
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
PERMITS AND ENGINEERING UNIT -
1617 MAIL SERVICE CENTER
RALEIGH, NORTH CAROLINA 27699-1617
3

MEMO TO: State Review Group Division
/J Division of Water Quality
FROM: Ricky Revels R R Fayetteville Regional Office
SUBJECT: Procedure Four (4) "/l October 28, 1999
WQ0017554 Date
Jackson Terrace Phase II
Sewer Extension -Public
Town of Carthage
Moore County
State Review Group Review
Engineer Joni Cardin
Regional Office
Contact Ricky Revels
1) Name of wastewater treatment plant to receive the wastewater:
Moore Co. Regional WWTP
2) WWTP design capacity 6.7000 MGD
3) NPDES Permit No. NC003 508 Expiration Date: 11/30/1999
4) Compliance Information:
Present treatement plant performance for previous 12 months, beginning 1/98 -
12/98 - Calendar Year Average is 5.3887 MGD
(See attached self -monitoring data)
5) Quantity and type of wastewater from proposed sewers:
* 5.355 GPD
domestic _ X industrial other
6) Volume from previously approved projects not yet tributary to WWTP:
-342,330-GPD previously approved flows began with WQ0015947 dated 12/11/98
7) Regional
Recommendations: Approval =* Denial
* Moore Water and Sewer Authority is presently working on a 201 study.
RR/rr
Enclosure

3KEX88/MP
10/27/1999
COMPLIANCE EVALUATION ANALYSIS REPORT
PAGE 1
PERMIT--NC0037508
PIPE--001
REPORT PERIOD:
9801-9812
LOC ---
E
FACILITY--MOORE CO W&SA/MOORE CO WWTP
DESIGN FLOW--
6.7000
CLASS--4
LOCATION --PINE BLUFF
REGION/COUNTY--06 MOORE
50050
00310
00530
00610
31616
50060
00300
TGP3B
MONTH
Q/MGD
BOD
RES/TSS
NH3+NH4-
FEC COLI
CHLORINE
DO
CERI7DPF
LIMIT F
6.7000
F 30.00
F 30.0
NOL
F 200.0
NOL
NOL
NOL
98/01
5.2806
3.23
5.9
.00
18.2
165.789
9.96
1
98/'02
6.1892
2.88
5.7
.00
7.6
203.000
10.14
98/03
6.3870
3.20
5.0
.00
15.3
164.545
10.37
1
LIMIT F
6.7000
F 22.00
F 30.0
17.00
F 200.0
NOL
NOL
NOL
98/04
6.3666
3.35
4.1
.00
10.2
160.000
9.23
98/05
6.0000
3.93
4.7
.00
26.1
173.000
8.39
98/06
5.4466
3.94
4.1
.00
23.3
87.727
8.06
1
98/07
5.1741
4.22
5.0
.00
21.1
149.130
7.82
9F:/08
5.0935
3.89
4.4
.00
28.1
111.428
7.96
98/09
4.8233
6.19
10.0
.00
54.6
155.238
8.16
1
98/10
4.8838
6.51
7.2
.00
33.1
282.954
8.25
LIMIT F
6.7000
F 30.00
F 30.0
NOL
F 200.0
NOL
NOL
NOL
98/11
4.5233
6.80
8.3
.00
9.5
127.777
8.74
98/12
4.4967
5.52
8.4
.12
16.0
127.142
9.46
1
AVERAGE
5.3887
4.47
6.0
.01
21.9
158.977
8.87
1
MAXIMUM
9.8000
11.80
26.0
1.79
4400.0
1145.000
13.60
1
MINIMUM
4.0000
LESSTHAN
LESSTHAN
LESSTHAN
LESSTHAN
LESSTHAN
- 5.60
1
UNIT .
MGD
MG/L
MG/L
MG/L
#/100ML
UG/L
MG/L
PASS/FAI

3KEX88/MP 10/27/1999
COMPLIANCE EVALUATION ANALYSIS REPORT PAGE 2
PERMIT--NC0037508 PIPE--001 REPORT PERIOD: 9801-9812 LOC --- E
FACILITY--MOORE CO W&SA/MOORE CO WWTP DESIGN FLOW-- 6.7000 CLASS--4
LOCATION --PINE BLUFF REGION/COUNTY--06 MOORE
MONTH
LIMIT
98/01
98/02
98/03
LIMIT
98/04
98/05
98/06
00010
00400
00600
00665
00720
01042
01077
01092
TEMP
PH
TOTAL N
PHOS-TOT
CYANIDE
COPPER
SILVER
ZINC
NOL
9.0 6.0
NOL
NOL
NOL
NOL
NOL
NOL
°15.55
7.7-6.8
13.500
1.4000
.0000
8.0000
.0000
21.0000
14.60
7.8-7.3
11.000
1.6500
.0000
9.0000
.0000
21.5000
15.77
7.9-7.1
15.250
1.3700
NOL
9.0 6.0
NOL
NOL
18.47
7.9-7.4
8.130
2.4000
20.95
7.9-7.4
14.250
2.0500
23.90
7.9-7.3
12.760
2.2600
98/07
25.87
7.8-7.1
21.140
2.7000
98/08
26.09
7.8-7.4
15.170
1.9500
LIMIT
98/11
98/12
AVERAGE
MAXIMUM
MINIMUM
UNIT
.0000 8.0000
NOL NOL
.0000 7.5000
25.63
7.9-7.4
17.310
2.0200
22.96
7.9-7.1
14.630
1.5900
NOL
9.0 6.0
NOL
NOL
20.36
7.9-6.8
18.210
1.9700
18 32
7.9-6.9
16.100
2.2300
.0000 19.0000
NOL NOL
.0000 19.5000
0000 11.0000 .0000 26.0000
0000 8.5000
.0000 10.0000
.0000 6.5000
.0000 20.0000
.0000 21.5000
.0000 21.0000
.0000 10.0000 3.0000 25.0000
.0000 7.5000
NOL NOL
.0000 9.5000
.0000 9.0000
.0000 19.0000
NOL NOL
.0000 20.0000
.0000 20.0000
20.70
14.787
1.9658
.0000 8.7083
.2500 21.1250
27.00
7.900 21.140
2.7000
14.0000
6.0000 33.0000
14.00
6.800 8.130
1.3700
6.0000
17.0000
DEG.0
SU MG/L
MG/L
UG/L UG/L
UG/L UG/L