NCG520090_HistoricFile_20200511

PAT MCCRORY
r',,,c,,,o,
DONALD R. VAN DER VAART
Water Resources S. JAY ZIMMERMAN
ENVIRONMENTAL OUAUTY
Uirr•c(nr
June 14, 2016
Mr. David Hoffman
Hoffman Paving&Grading, Inc.
711 Complex PI
Lenoir, NC 28645
Subject: Renewal of coverage/General Permit NCG520000
Mabe Pit
Certificate of Coverage NCG520090
Burke County
Dear Permittee:
The Division hereby renews Certificate of Coverage (CoC) NCG520090 to discharge under General
Permit NCG520000. This CoC is issued pursuant to the requirements of North Carolina General Statue
143-215.1 and the Memorandum of Agreement between North Carolina and the US Environmental
Protection agency dated October 15, 2007 [or as subsequently amended].
If any parts, measurement frequencies or sampling requirements contained in this General Permit
are unacceptable to you, you have the right to request an individual permit by submitting an individual
permit application. Unless such demand is made, the certificate of coverage shall be final and binding.
Please take notice that this Certificate of Coverage is not transferable except after notice to the
Division. The Division may require modification or revocation and reissuance of the certificate of coverage.
Contact the Asheville Regional Office prior to any sale or transfer of the permitted facility.
Regional Office staff will assist you in documenting the transfer of this CoC.
This permit does not affect the legal requirements to obtain any other Federal, State, or Local
governmental permit that may be required.
If you have any questions concerning the requirements of the General Permit, please contact John
Hennessy [919 807-6307 or [e-mail]].
7mcely,
for S.Jay Zimmerman, P.Q.
Director,Division of Water Resources
E NLI.?
cc: Asheville Regional Office Division of Water Resources
NPDES file '
I!
J U N 2 3 2016
,
i
State of North Carolina I Environmental Quality I Water R ourMter Ouality Regional Operations
1617 Mail Service Center I Raleigh,NC 27699-161
919 807 6300 919-807-6389 FAX
https://deq.nc.gov/about/divisions/water-resources/water-resources-permits/wastewater-brancIVnpdes-wastewater-permits

�r5a:
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENTAL QUALITY
DIVISION OF WATER RESOURCES
GENERAL PERMIT NCG520000
CERTIFICATE OF COVERAGE NCG520090
DISCHARGE OF IN-STREAM SAND MINING WASTEWATER, ASSOCIATED STORMWATER
AND SIMILAR DISCHARGES UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and
the Federal Water Pollution Control Act, as amended,
Hoffman Paving & Grading, Inc.
is hereby authorized to discharge instream mining wastewater from the following facility:
Mabe Pit
1000 - 1209 Atioch
Morganton
Burke County
to receiving waters designated as Lower Creek, a class WS-IV stream in subbasin 03-08-31 of the
Catawba River Basin. All discharges shall be in accordance with the effluent limitations,
monitoring requirements, and other conditions set forth in Parts I, II, III and IV hereof.
This certificate of coverage shall become effective June 14, 2016.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day June 14, 2016
for 4Jim-merman, P.G.
Director, Division of Water Resources
By Authority of the Environmental Management Commission

PAT MCCRORY
Governor
DONALD R. VAN DER VAART
Z' Secretary
Water Resources S. JAY ZIMMERMAN
ENMONMENTAL QUALITY
Director
May 19, 2016
David Hoffman
Hoffman Materials
711 Complex Pl.
Lenoir,NC 28645
SUBJECT: Compliance Evaluation Inspection
Mabe Pit
Permit No:NCG520090
Burke County
Dear Mr. Hoffman:
Enclosed please find a copy of the Compliance Evaluation Inspection form from the inspection conducted on
4/20/2016. Present during the inspection were myself,Zan Price,Kevin Mitchell and Tim Fox with the Division
of Water Resources (DWR) and Ginger Clark with Hoffman Materials.
The Mabe pit is inactive; it has not been dredge. If you choose to dredge here, please plan accordingly to the
guidance in the enclosed inspection report. If you choose not to dredge here and wish to rescind the permit,
please follow the instruction that were given to Ginger Clark during the inspection.
Please refer to the enclosed inspection report for additional observations and comments. If you or your staff
have any questions,please call me at 828-296-4500.
Sincerely,
Linda Wiggs
Enviromnental Senior Specialist
Asheville Regional Office
Enc. Inspection Report
cc: MSC 1617-Central Files-Basement
Asheville Files
G:\WR\WQ\Burke\Wastewater\General\Sand Dredges NCG52\Mabe Pit-NCG520090\CEI.04-20-2016.Ltr.docx
State of North Carolina I Environmental Quality 1 Water Resources
2090 U.S.Highway 70 Swannanoa,NC 28778
828 296 4500

/ ALT
FqCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Michael F. Easley, Governor William G. Ross,Jr.,Secretary
Alan W. Klimek, P.E., Director
January 11,2007
David Hoffman
Hoffman Materials
417 Sharon Avenue
Lenoir, NC 28645
Subject: Renewal Notice/General Permit NCG520000
Certificate of Coverage NCG520090
Burke County
Dear Permittee:
You are receiving this notice because your company currently operates a dredging operation covered under the
subject General Permit for the discharge of sand-dredging runoff. NCG520000 will expire on July 31,2007. Federal (40 CFR
122.41)and North Carolina(15A NCAC 2H.0105(e)) regulations require that permit renewal applications be filed at least 180
days prior to expiration of the current permit. To satisfy this requirement,the Division must receive a renewal request
postmarked no later than February 1,2007.
The Certificate of Coverage(CoC)specific to your operation was last issued on October 25,2006. The Division needs
information from you to determine if coverage under NCG520000 is still necessary.
➢ If your property still has a wastewater system like the ones described in the enclosed Technical Bulletin,you must renew the
subject CoC. Complete the enclosed form and submit it to the address on the form.
➢ If you are not sure what type of system your property has,contact Keith Haynes in the NC DENR Asheville Regional Office at
[phone]. That person[or other staff members]can help you determine if you should renew your CoC.
➢ If this site has been shut down and no further dredging will occur,contact me at the address or phone number listed below to
request rescission of the CoC.
Please verify that the provided information is correct,or make corrections on the attached form. Complete the
additional questions,then sign and date the form. The completed form should be submitted to the address listed below the
signature block.
If you have any questions concerning this matter, please contact me at the telephone number or e-mail address listed
below.
Sincerely,
L� C
Charles H.Weaver,Jr I,' L' ,
d"�E,I I _' .0, ,{
NPDES Unit
wt i
cc: Central Files _e...=___
Asheville Regional Office/Keith Haynes
NPDES file .n�e.
1617 Mail Service Center,Raleigh,North Carolina 27699-1617
512 North Salisbury Street,Raleigh,North Carolina 27604 t
Ca
ro'
Phone: [phone],extension 511/FAX [phone]/[e-mail] J(r //�
An Equal Opportunity/Affirmative Action Employer—50%Recycled/10%Post Consumer Paper

Michael F. Easley,Governor
State of North Carolina
I: William G. Ross,Jr.,Secretary
LinDepaent of Environment and Natural Resources
AIan�iAl. limek, P.E., Director
. bivlston of Water Quality
October 25,2006
Mr. David Hoffman
417 Sharon Avenue
Lenoir,North Carolina 28645 < -V F-
Subject: , General Permit�N-o.-NCG520000 ,
Certificate of Coverage NCG520090
Hoffman Materials
Mabe Pit
Burke County
Dear Mr.Hoffman:
General Permit Coverage:In accordance with your application for discharge,the Division is forwarding
herewith the subject Certificate of Coverage to discharge under the subject state-NPDES general permit.
This permit is issued pursuant to the requirements of North Carolina General Statue 143-215.1 and the
Memorandum of Agreement between North Carolina and the US Environmental Protection agency dated
May 9,1994(or as subsequently amended).
The following information is included with your permit package:
■ A copy of the Certificate of Coverage for your treatment facility
• A copy of General Wastewater Discharge Permit NCG520000
■ A copy of a Technical Bulletin for General Sand Mining Discharge Permit NCG520000
If any parts,measurement frequencies or sampling requirements contained in this general permit are
unacceptable to you,you have the right to request an individual permit by submitting an individual
permit application.Unless such demand is made,the certificate of coverage shall be final and binding.
Please take notice that this Certificate of Coverage is not transferable except after notice to the Division of
Water Quality. The Division of Water Quality may require modification or revocation and reissuance of
the certificate of coverage. This permit does not affect the legal requirements to obtain other permits
which may be required by the Division of Water Quality or permits required by the Division of Land
Resources,Coastal Area Management Act or any other Federal or Local governmental permit that may be
required.
NPDES Permit Contact. If you have any questions concerning the requirements of this permit,
please contact Toya Fields at telephone number 919-733-5083,extension 551.
Sincerely,
f
Alan W.Klimek,P.E.
cc: Central Files
NPDES General Permit Files
Asheville Regional Office/Surface Water Protection Section,
Technical Assistance and Certification
1617 Mail Service Center,Raleigh,North Carolina 27699-1617 Telephone[phone] FAX[phone] NlorthCarolina
512 N:Salisbury Street,Raleigh,North Carolina 27604 On the Internet at http://www.ncwaterquality.org Naturally
An Equal Opportunity/Affirmative Action Employer

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
CERTIFICATE OF COVERAGE NCG520000
GENERAL PERMIT NO. NCG520090
TO DISCHARGE SAND DREDGING WASTEWATER AND SIMILAR WASTEWATERS UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1,other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission,and the Federal Water Pollution Control Act,as amended,
Hoffman Materials
is hereby authorized to operate a sand dredging operation with the discharge of runoff water
from a facility located at
Mabe Pit
Antioch Road
Morganton
Burke County
to receiving waters designated as Lower Creek,a WS-IV water,in the Catawba River Basin in
accordance with the effluent limitations,monitoring requirements,and other conditions set forth
in Parts I,II,III and TV of General Permit NCG520000 as attached.
This certificate of coverage shall become effective October 25,2006.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day October 25,2006.
Alan W.Klimek,P.E.,Director
Division of Water Quality
By Authority of the Environmental Management Commission
2

j
4 JM ENET',
�
fs
Wi E3` sxaowb & AH
PDischarge location '
Y k "`g �, ^• � '4'"" ' •y pax �^ k ".�'`y'• � S
k `E'
Y'r '' w ' "
OR
Qy
€ to v
�� Y � r gg
a"
s n f
A
k�:
�'.az. , a o�...•Jkw., 4�i:V. Yslv,m.`,,^�' £ii '�'` ,;'i. .,.... .a f.sui,•`r
Hoffman Materials'- Mabe Pit'— NCG520050.
Facility
Location a^,
USGS-Quad Name:Morganton North
Receiv'ing Stream:Lower Creek Lat.:35°49'30" r
,Stream Class:WS-IV' Long.:81°38'10" N
Subb:asin:Catawba -03 08 31 Not t0 SCALE

United States Environmental Protection Agency Form Approved.
EPA Washington,D.C.20460 OMB No.2040-0057
Water Compliance inspection Report Approval expires 8-31-98
Section A: National Data System Coding (i.e., PCS)
Transaction Code NPDES yr/mo/day Inspection Type Inspector Fac Type
1 I NI 2 15I 31 NCG520090 111 121 06/09/12 117 18I GI 19I SI 201 I
Remarks
21111111111111111111111111111111111111111111111116
Inspection Work Days Facility Self-Monitoring Evaluation Rating B1 QA --------------------------Reserved----------------------
67 I 169 701 I 711 I 721 NJ 73I I 174 751 I I I I I I 180
Section B: Facility Data u_1
Name and Location of Facility Inspected(For Industrial Users discharging to POTW,also include Entry Time/Date Permit Effective Date
POTW name and NPDES permit Number)
Mabe Pit 10:00 AM 06/09/12
1000 - 1209 Atioch Exit Time/Date Permit Expiration Date
Morganton NC 28655 10:30 AM 06/09/12
Name(s)of Onsite Representative(s)/Titles(s)/Phone and Fax Number(s) Other Facility Data
Name,Address of Responsible Official/Title/Phone and Fax Number
Contacted
David Hoffman,417 Sharon Ave Lenoir NC 28645//828-754-5582/8287540188
No
Section C: Areas Evaluated During inspection(Check only those areas evaluated)
Facility Site Review
Section D: Summary of Find in /Comments Attach additional sheets of narrative and checklists as necessary)
(See attachment summary)
Name(s)and Signature(s)of Inspector(s) Agency/Office/Phone and Fax Numbers Date
Larry Frost ARO Wg//828-296-4500 Ext.4658/
Signature of Management Q A Reviewer Agency/Office/Phone and Fax Numbers Date
EPA Form 3560-3(Rev 9-94)Previous editions are obsolete.
Page# 1

NPDES yr/mo/day Inspection Type 1
3I NCG520090 I11 12I 06/09/12 11' 18ICI
Section D: Summary of Finding/Comments(Attach additional sheets of narrative and checklists as necessary)
This inspection was done for the staff report and the facility is not yet built.
Page# 2

SOC PRIORITY PROJECT: Yes No
IF YES, SOC NUMBER
TO: NPDES UNIT
WATER QUALITY SECTION
ATTENTION: LeToya Fields
DATE: September 13, 2006
NPDES STAFF REPORT AND RECOMMENDATION
Burke COUNTY
PERMIT NUMBER NCG520090
PART I - GENERAL INFORMATION
1. Facility and Address: Hoffman Materials
Mabe Pit
Antioch Road
Morganton, North Carolina 28655
Mailing: David Hoffman
417 Sharon Avenue
Lenoir, North Carolina 28645
2. Date of Investigation: 09/12/2006
3. Report Prepared By: Larry Frost
4. Persons Contacted and Telephone Number: David Hoffman
828.754.5582
828.754.0188
5. Directions to Site.- From Morganton, Hwy 64/18 northeast of Morganton, right
on Antioch Road (SR 1501), left just before the first bridge
6. Discharge Point(s), List for all discharge points:
Latitude: N35 degrees 49.555' Longitude: W81 degrees 38.149'
Attach a USGS map extract and indicate treatment facility site and discharge point on map.
U.S.G.S. Quad No. U.S.G.S. Quad Name Morganton
7. Site size and expansion area consistent with application?
XX Yes No If No, explain:
8. Topography (relationship to flood plain included): Site is in the Lower Creek flood plain.
-1-

i
9. Location of nearest dwelling: >1000 feet from the site
10. Receiving stream or affected surface waters: Lower Creek
a. Classification: WS-IV
b. River Basin and Subbasin No.: Catawba River Basin 11-39-(6.5)
C. Describe receiving stream features and pertinent downstream uses: the site is 1
mile upstream of the WS-IV CA
PART 11 - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
1. a. Volume of wastewater to be permitted
No discharge /possible stormwater MGD (Ultimate Design Capacity)
b. What is the current permitted capacity of the Wastewater Treatment facility? N/A
C. Actual treatment capacity of the current facility (current design capacity N/A
d. Date(s) and construction activities allowed by previous Authorizations to Construct
issued in the previous two years: N/A
e. Please provide a description of existing or substantially constructed wastewater
treatment facilities: NONE
f. Please provide a description of proposed wastewater treatment facilities: NONE
g. Possible toxic impacts to surface waters: NONE
h. Pretreatment Program (POTWs only):
in development approved
should be required not needed
2. Residuals handling and utilization/disposal scheme: N/A
a. If residuals are being land applied, please specify DWQ Permit Number
Residuals Contractor
Telephone Number
b. Residuals stabilization: PSRP PFRP OTHER
C. Landfill:
d. Other disposal/utilization scheme (Specify):
3. Treatment plant classification (attach completed rating sheet): N/A
-2-

4. SIC Codes(s): N/A
Primary Secondary
Main Treatment Unit Code
PART III - OTHER PERTINENT INFORMATION
1. Is this facility being constructed with Construction Grant Funds or are any public monies
involved. (municipals only)? N/A
2. Special monitoring or limitations (including toxicity) requests: None
3. Important SOC, JOC, or Compliance Schedule dates: (Please indicate)
Date
Submission of Plans and Specifications
Begin Construction
Complete Construction
4. Alternative Analysis Evaluation: Has the facility evaluated all of the non-discharge options
available. Please provide regional perspective for each option evaluated.
Spray Irrigation:
Connection to Regional Sewer System:
Subsurface:
Other disposal options:
5. Other Special Items:
-3-

PART IV - EVALUATION AND RECOMMENDATIONS
This is a sand dredge operation. The operator uses a track hoe to remove sand from the river
places it on the stream bank and screens it prior to sale. The water from the wet sand drains back
to the river by way of the sandy substrate; there is no discharge point. Stormwater is treated in the
same manner.
Note: The property owner is: Claud Ervin Mabe -
2674 NC18/US64
Morganton, NC 28655
The regional office recommends the issuance of the permit.
Sig ture of Report Preparer
---- is
Water Quality Regional Supervisor
Date
-4-

Page l of l
Send To Printer Back To TerraServer Change to i W7 Print Size Show Grid Lines Change to Portrait
2USGS 10 km NE of Morganton, North Carolina, United States 01 Jul 1986
a ['�a a
"` • MABE PIT SITE
NCG520090 BURKE
44 `l _
333 `
fill
I t � �0
f
AmSp
y4 4 {
07
C 7A,�'
0' 2Km 0' 1Mi
Image courtesy of the U.S. Geological Survey
© 2004 Microsoft Corporation. Terms of Use Privacy Statement
ale://C:\DOCUME—l\LFrost\LOCALS-1\Temp\BOVJ97FS.htm 9/13/2006

Burke Co., NC -- Printable Map Page 1 of 2
Burke Co., NC
MABE PIT SITE
NCG520090 BURKE
elf
q
C
a`
Q
Parcels
recnl: 23060 Map: 13 Page: 12 Blk. Lot: 2 13
PIN: 271600862471 Deed Reference: Bk. 831 Pg. 1709
Parcel Address: 2974 NC 18/US 64 Land Area: 10.00 acres
Parcel Owner: Assessed Value:$33,954
MABE CLAUD ERVIN Building Value: $0
2974 NC 18/Us 64 Land Value: $23,490
MORGANTON NC 28655 Other Value: $10,464
Sales Amount: $0
Sales Date: 9/27/1994
Other Attributes
at point 1218447,766067
Fire Districts: Townships: Watersheds:
Fire: CHESTERFIELD Name: LOWER CREEK River Basin: Catawba
School Districts: Voting Districts: Stream Name: Lake Rhodhiss
Elementary: CHESTERFIELD Precinct: 28 PCA Class: WS-IV P.
Middle: WALTER R.JOHNSON District: Lower Creek Zoning, County:
High: FREEDOM Zoning: G-B
Zoning: AO
DISCLAIMER: The information contained on this page is NOT to be construed or used as a"legal description". Map
information is believed to be accurate but accuracy is not guaranteed. Any errors or omissions should be reported to the
Burke County Geographic Information Systems Division of the Office of Information Technology. In no event will Burke
County be liable for any damages,including loss of data, lost profits, business interruption, loss of business information or
other pecuniary loss that might arise from the use of this map or the information it contains.
http://arcims.webgis.net/nc/Burke/printable.asp?process=id&x2=1218446.61511328&y2=766067.471623... 9/13/2006

■*i
L+J I WLO S S I p 1 1
( CD bq J i
1
\
l O •p �
f 1
CD m I r� .2 lcm
/`• ti N
;�} 7
�:J S m N A,
Wo
p
1 W A
w OCD
lw CMD
50#
\ '4 1 �� g.
W \ S , IUOi p 3 W IW / ^I W 9 (�1 J _ / 81`40'
M �• (/
1- -^- i -� 1- - - I� �IN'9► Q '1.4Ip
h, 1.2 m
1_1 -
il
,on
G
omco w
IO `
Cn
I0)� / O AO
1 1
_ N
41
_ \ 7 I� OD
o
Iry
nNR N 2
�� I� s zs;
I d 0
II ✓ N m
Ui 0 v
(a � 81°35'
M
m .�
ct
1

Michael F.Easley,Governor
O� ��T� State of North Carolina
0_' QG William G.Ross,Jr.,Secretary
Department of Environment and Natural Resources
Alan W.Klimek,P.E.,Director
-- _Division of Water Quality
July 13,2006
Mr.David Hoffman
417 Sharon Avenue
Lenoir,North Carolina 28645
Subject: Application Acknowledgement
General Permit Coverage
COC# NCG520090
Burke County
Dear Mr.Hoffman:
The Division of Water Quality received your application for coverage udder General Permit
NCG520000. The application has been assigned to Toya Fields with the NPDES unit.We are
reviewing your application and will contact you if additional information is needed to process your
application. By copy of this letter,we are also requesting a Staff Report from the Asheville Regional
Office. If you have any questions concerning your application,please contact me at telephone
number(919)733-5083 extension'551([e-mail]).
Sincerely,
eToya Fields
Western Permitting Program
cc: Asheville Regional Office,Surface Water Protection(with application package)
NPDES General PermitTile
�
S r P - 8006
P
k
i ? t
North Carolina Division of Water Quality (919)733-5
1617 Mail Service Center FAX enr.s 733 0719
19
Raleigh,North Carolina 27699-161I On the Internet at http://h2o.enrstate.nc.us/

FOR AGENCY USE ONLY
Date Received
Year Month Do
Division of Water Quality/Water Quality Section
—
Certificate
NC®ENR National Pollutant Discharge Elimination System g Y NoRn CARD m DuxRTM orENVIRONMCNTANONA RA.ResoURcp
NCG520000
NOTICE OF INTENT m
G ��
National Pollutant Discharge Elimination System application for coverage under Ge'n Peri�t �`
NCG520000: In-stream sand mining wastewater, associated stormwater and similar wa wat r All
(Please print or type)
1) Mailing address of ownerloperator: t t�,
Company Name: . I S
Contact Person: �'
Street Address: / HIV
City:,- State: �((' ZIP Code: SG
Telephone No.: 12,9- 7-7 y Fax: �_� 75 G�'hT-.
2) Location of facility producing discharge: --
, earl
Facility Name: to
/ ?
a m
Street Address: z
Contact Person:
City: - 'rlcS�tt�n�Bn State: V 0 ZIP Code:,
County: n
Telephone No.: _ jg' �'SV``"6`�2 Fax: a
C CD
r" �,
� Ya '
3) Permit Contact(complete this section if permit contact is different from facility contact)
Contact Person:
Street Address:
City: State: ZIP Code:
County:
Telephone No.: Fax:
4) Physical location information:
A copy of an USGS quad map or county map with the facility clearly located on the map IS REQUIRED to
be submitted with this application.
Please provide a narrative description of how to get to the facility(use street names,state road numbers,
and distance and direction from a roadway intersection):
5) This NPDES permit application applies to which of the following
3--'K-ew or Proposed ❑ Modification
Please describe the modification:
❑ Renewal
Please specify existing permit number and original issue date::
Page of 4
MU-214-080102

NCG520000 N.0.1.
6) Doe's this facility have any other NPDES(permits, including stormwater general permits?
QF No ❑ Yes
If yes, list the permit numbers for this facility:
7) Description of Discharge:
a) Will stormwater also be discharged? ❑ Yes �No
If yes, does stormwater drain to a settling pond prior to discharge? Yes El No
b) Is the sand washed or rinsed on the bank after removal from the stream? ❑ Yes f"o
c) Is the discharge directly to the receiving water? ❑ Yes �l'No
If no, submit a site map with the pathway to the potential receiving waters clearly marked. This
includes tracing the pathway of the storm sewer to the discharge point; if the storm server is the only
viable means of discharge.
d) Number of discharge points (ditches, pipes, channels, etc. that convey wastewater from the prooE`P,,'
SO si, .
e) Volume of discharge per each discharge point (in GPD):
#1: /q /).. 1t 2; —
f) Please describe the type of process the sand dredging wastewater is being discharged from, be
�Y O Ec np I-iF ^ -
specific. /42 f SS �
g) Is there any treatment being applied to the wastewater before discharge (check the type of t r e a'^n e
in use).
Cl Settling pond ❑ Lagoon ❑Other None
(Please describe "Other")
h) How much of the volume discharged is treated (state in percent)?
i) if any box in item (e) above, other than none, was checked, please include design specii-,cs
design volume, retention time, surface area, etc.) with submittal package. Existing treatment fac.'ine
should be described in detail. Design criteria and/ operational data (including calculations) sho::-"
provided to ensure that the facility can comply with the requirements of the General Permit.
treatment shall be sufficient to meet with1he limits set by the general permits. The trapping: ef:`c!en `
should be greater than 75%. The surface area should be as large as possible to insure sedin,en;at:c
occurs. To secure optimum efficiency the flow length of the basin to the basin width snow:d nave-
ratio of 2:1
Note: Construction of any wastewater treatment facilities requires submission of thr e (3) sets
plans and specifications along with the application, Design of treatment faciii!ies ,r.uSt con--
with requirements of 15A NCAC 2H .0138, If construction applies to this discha ge, 1 _:
the three sets of plans and specifications with this application,
8) Discharge Frequency:
a) The discharge is: ❑ Continuous Intermittent ❑ Seasonal
i) If the discharge is intermittent, describe when the discharge will occur: '1,221. _',��
ii) If seasonal check the monlh(s) the discharge occurs: ❑ Jan. ❑ Feb. ❑ velar _. . .
❑ May ❑ Jun. ❑ Jul. ❑ Aug. ❑ Sept. ❑ Oct. ❑ Nov. ❑ Dec.
Page 2 of 4
SWU-214-080102

v
NCG520000 N.O.I.
b) Please check the days discharrge occurs: _/
C7 Sat. .13 Sun. ITMon. Er/Tue. Wed. H Thu. t 7 Fri.
9) Receiving waters:
a) What is the name of the body or bodies of water (creek,stream, river, lake, etc.) that the facility
wastewater discharges end up in? If the site wastewater discharges to a separate storm sewer
system (4S), name the operator of the 4S (e.g. City of Raleigh).
b) Stream Classification (WS-IV, C, etc.): C 1 n5S
10) Alternatives to Direct Discharge:
Address the feasibility of implementing each of the following non-discharge alternatives
a) Connection to a Regional Sewer Collection System
b) Subsurface disposal (including nitrification field, infiltration gallery, injection wells, etc.)
c) Spray irrigation
The alternatives to discharge analysis should include boring logs and/or other information indicating Mat a
subsurface system is neither feasible nor practical as well as written confirmation indicating that
connection to a POTW is not an option. It should also include a present value of costs analysis as outlined
in the Division's "Guidance For the Evaluation of Wastewater Disposal Alternatives".
11) Additional Application Requirements:
For new or proposed discharges, the following information must be included in triplicate v,ith this
application or it will be returned as incomplete.
a) 7.5 minute series USGS topographic map (or a photocopied portion thereof) with discharge location
clearly indicated.
b) Site map, if the discharge is not directly to a stream, the pathway to the receiving stream must 'ce
clearly indicated. This includes tracing the pathway of a storm sewer to its discharge point.
c) If this application is being submitted by a consulting engineer (or engineering Firm), include
documentation from the applicant showing that the engineer (Or firm) submitting the application has
been designated an authorized Representative of the applicant.
d) Final plans for the treatment system (if applicable). The plans must be signed and sealed by a North
Carolina registered Professional Engineer and stamped-"Final Design-Not released for constructicn".
e) Final specifications for all major treatment components (if applicable). The specifications mus`. 'Se
signed and sealed by a North Carolina registered Professional Engineer and shall include a narr !i,;,e
description of the treatment system to be constructed,
I certify that i, am familiar with the information contained in this application and that to the best cf miv
knowledge and belief such information is true, complete, and accurate.
Printed Name of Person Signing:.__ N0 An
Title: OCU 11r?r
(Signature of Appliea ) (Date Signed)
Page 3 of 4
swu•214-080102

NCG520000 N.O.I. ,
North'Caroli'na General Statute 143.215.6 b (i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application.
record, report, plan or other document filed or required to be maintained under Article 21 or reaula!,;On c
the Environmental Management Commission implementing that Article, or who falsifies, tampers % ith 3-
knowingly renders inaccurate any recording or monitoring device or method required to be operated or
maintained under Article 21 or regulations of the Environmental Management Commission implementing
that Article, shall be guilty of a misdemeanor punishable by a fine not to exceed S10,000, or by
imprisonment not to exceed six months, or by both. (18 U.S.C. Section 1001 provides a punishment by a
fine of not more than $10,000 or imprisonment not more than 5 years, or both,for a similar offense.)
Notice of Intent must be accompanied by a check or money order for S80.00 made payable to:
NCDENR
Mail three (3) copies of the entire package to:
Stormwater and General Permits Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Final Checklist
This application will be returned as incomplete unless all of the following items have been
included:
❑ Check for$80 made payable to NCDENR her l r�
❑ 3 copies of county map or USGS quad sheet with location of facility clearly marked on map
❑ 3 copies of this completed application and all supporting documents
❑ 3 sets of plans and specifications signed and sealed by a North Carolina P.E. (if applicable)
❑ Alternatives analysis including present value of costs for all alternatives
Note
The submission of this document does not guarantee the issuance of an NPDES permit
Page 4 of 4
SWU-214.080102

rn
/V5

,ag Directions from 711 Complex Pl,Lenoir,NC to [1000-1209] Antioch Rd,Morga... Page 1 of 2
711 Complex PI [1000-12091 Antioch Rd
Lenoir, NC 28645-8337, US Morganton, NC 28655, US
Total Est. Time: Total Est. Distance:
19 minutes 10.18 miles
Maneuvers Distance
1: Start out going NORTH on COMPLEX PL 0.3 miles
toward SW LOOP BLVD.
2: Turn LEFT onto MORGANTON BLVD SW / 6.2 miles
US-64 / NC-18 BYP. Continue to follow
US-64.
3: Turn LEFT onto ANTIOCH RD. 3.5 miles
4: End at [1000-1209] Antioch Rd
Morganton, NC 28655, US
Total Est. Time: 19 minutes Total Est. Distance:
10.18 miles
http://www.mapquest.com/directions/main.adp?do=nw&go=l&r=f&aoh=&aot=&aof--&2... 6/23/2006

,Ang Directions from 711 Complex PI,Lenoir,NC to [1000-12091 Antioch Rd,Morga... Page 2 of 2
aid Pl
LaW St C rqe C '
� r AJIgus err s
l- 3-
Linvillt Ct
�? s`
j�>r
Oil Lrt Crinn wit
�h
t
q, T
a 'r>
,
fry
006 htavQuest.111 ". 02006 NAV
All rights reserved Use Subject to License/Copyright
These directions are informational only. No representation is made or warranty given as to their content,road conditions or
route usability or expeditiousness. User assumes all risk of use.MapQuest and its suppliers assume no responsibility for any
loss or delay resulting from such use.
http://www.mapquest.com/directions/main.adp?do=nw&go=1&r=f&aoh=&aot=&aof&2... 6/23/2006

Page 1nf 3
Back
/
~^� Use the print feature in your browser to print this
~^ page.
' ---------------------------------------------------------------------------'
Swnannanoa, NC 28778
to
1100An0och Rd
Morganton, NC 28655-9361
Zd
6-1
go
land 4
Find it in the 2007 Road Atlas
Swannanoe, NC Morganton, NC
° page 74, grid section ° page 74, grid section
L-O, Western North E-3
Carolina map
° page 74, grid section
E-1
Estimated Total Driving Estimated Total Driving
Total Number of Steps:
Time: Distance:
37
1 hour, Z5minutes 52nni|es
Step Directions Distance
1 You are atSvvennanoa,NC.
... ..............................................................................................................................................................................................................................
2 Go SE on Unknown Street for 60 feat < 0.1 miles
... ................................................................ ........................................................... ....... .........................................................................................
3 Bear right < 0.1 Milos
'
---------------------------------------------------------------------------'
4 Bear left onto McBrayerAx < 0.1 miles
-_-------------------------------------------------------------^-------'----�
S Turn left onto Rk/ervvood Rd 0.1 rni|as
- --------------------------------------------------------------------------.
6 Turn right onto Old US 70 2.4 miles
httn://vpvvvv. .cou /rnzc/dirccti ireoti/nuj l=co}or&o n— 9/11/2006

Page 2of3
........................................... .................................................... .......................................................................................
nua onto [>|d U8 70 VV 1.9 miles
�----------------------------------------------------------------------
Turn right onto College St ' « 0.1 nni|as
.' _--------------------------------------------------------------------------.
9 Turn left onto US-70 (State St) 1.3 miles
---------------------------------------------------------------------------'
10 Continue onto US-70 E (State StE) 0.3 rn||es
---------------------------------------------------------------------------'
11 Enter on ramp to I-40 E (US-70 E) 0.4 miles
� ..............................................................................................................................................................................................................................
12 Continue on I-40 E (UB-70 E) 34.4 rni|ea
-'--------------------------------------------------------------------------
13 Bear right onto off-ramp at exit 1OUtoJamestown Rd 0.2 miles
---------------------------------------------------------------------------'
14 Bear left onto Jamestown Rd Z rni|ea
---------------------------------------------------------------------------'
15 Turn right onto US-70 (Carbon City Rd) 0.8 miles
---------------------------------------------------------------------------'
16 Continue onto US-7O (Union St) 0.3 miles
.... ........................................................................................................ ................................................... .................................................................
17 Continue onto BUS US-7O (Union St) 1.2rni|es
---------------------------------------------------------------------------'
18 Continue onto US-O4 E (GUSUS-7O E, Meeting St) 0.3 miles
....
19 Turn right onto NC-18 S (Sterling St) 0.1 miles
---------------------------------------------------------------------------'
30 Turn left onto Concord St 0.2 rni|as
------------------------------------------------------------^--------------'
21 Turn right onto White St < 0.1 miles
.... ........ .....................................................................................................................................................................................................................
22 Turn left onto Valdese Av 1 miles
---------------------------------------------------------------------------'
23 Bear right onto BUS US-70 (Union St) 0.3 miles
���������������....................................................................... ..............................................................................................................
24 Turn left onto Amherst Rd 2.7 miles
---------------------------------------------------------------------------'
25 Bear left onto Huffman Bridge Rd 1.4rni|es
-- ................................................................................................. .......................... ................................ ...........................................................
26 Continue onto Antioch Rd 0.4 nni|ea
.... ..............................................................................................................................................................................................................................
�Ur� . — 0/11/2000
_-, ' � -__-_''--�' - -

Directions Page 3 of 3
are at 1100 Antioch Rd,Morganton,NC
...............................................................................................................................................................................................................
i
Destination: 1100 Antioch Rd
Morganton, NC 28655-9361
AQI
y r4
On
Please note that these driving directions are suggested. No warranty is given as to their content or route
usability. Rand McNally and its suppliers assume no responsibility for any loss or delay resulting from such use.
Please let us know of any errors or omissions you find in our driving directions and maps, especially the names of
towns and streets that we may have been unable to locate for you.
All rights reserved. Use subject to license.
2006 randmcnally.com inc
httj=a://www.randmenally.com/rmc/directions/dirPrintDirections.j sp?ref=dim&col=color&sStartName=&s... 9/11/2006

3 7, 49
Og

VqA
O� �� MichaelState of North Ca olina
0 QG William G.Ross,Jr.,Secretary
Department of Environment and Natural Resources
CO %W:
7 -4 Alan W.Klimek,P.E.,Director
Y Division of Water Quality
July 13,2006
Mr.David Hoffman -
417 Sharon Avenue
Lenoir,North Carolina 28645
Subject: Application Acknowledgement
General Permit Cove_.ge
Burke County
Dear Mr.Hoffman:
The Division of Water Quality received your application for coverage.under General Permit
NCG520000. The application has been assigned to Toya Fields with tl:e NPDES unit.We are
reviewing your application and will contact you if additional information is needed to process your
application. By copy of this letter,we are also requesting a Staff Report from the Asheville Pegional
Office. If you have any questions concerning your application.,pleese contact m:-at telephone.
number [phone],extension 551 (e-mail:[e-mail]).
Sincerely, e
C.e�71 oya Fields
Western Pena;ft T 'err`ra .
cc: Asheville Regional Office,Surface Water Protection(with application package)
NPDES General Permit File
xi Ap Frr�R'.a 1a+N.Ah+Siumalk .ik.. rw.vss�Fa.`flr,}*}�.',x4e� P f
f
r J U L 1 7 2
ASf,ev�� :r,c �r NAI O FIC7
[phone]
North Carolina Division of Water Quality
1617 Mail Service Center (`1 ),733-,0719;
Raleigh,North Carolina 27699-1617 "x.. On the Internet at http://h2o.enr.state.nc.us/`

FOR AGENCY USE ONLY
+ Date Received
• Year Month
f Division of Water Quality/Water Quality Section Da
C rtificate of Covera e
NCDER National Pollutant Discharge Elimination System O a
g Y heck# Amount
E—ROMMEWM0 N.vu Rr.SOURc. .. - .
NCG520000 Permit Assigned to
IT
NOTICE OF INTENT
National Pollutant Discharge Elimination System application for coverage under General Permit
NCG520000: In-stream sand mining wastewater, associated stormwater and similar wastewaters
(Please print or type) S r_ 5 �4 F,
Mailing address of owner/operator: �4
bD
Company Name: �• ,�S
�� Cam.
Contact Person: i 3
Street Address: /7 IvA,
City: State: {' ZIP Code:
Telephone No.: _�2.Q' 7-5-4- Fax:
2) Location of facility producing discharge:
Facility Name: tQ a6e / �
Contact Person:
Street Address:
City: State _ ZIP Code:, 6
County: 11 n e
Telephone No.: �GZ� _�'S�fS"6` 2 Fax:
3) Permit Contact(complete this section if permit contact is different from facility contact)
Contact Person:
Street Address:
City: State: ZIP Code:
County:
Telephone No.: Fax:
4) Physical location information:
A copy of an USGS quad map or county map with the facility clearly located on the map IS REQUIRED to
be submitted with this application.
Please provide a narrative description of how to get to the facility.(use street names, state road numbers,
and distance and direction from a roadway intersection):
5) This NPDES permit application applies to which of the following j P
®-<ew or Proposed ❑ Modification
Please describe the modification: FR r--C E. k
❑ Renewal y.
Pleases specify existing i 101
p y g permit number and original issue date: I, CLJ
Vv
ftU t _` f ICN
Page.1 of a��-vi��� �
SWU-214-080102
w _-�._v ...n ._

NCG520000 N.O.I.
6) Does'this facility have any other NPDES permits, including stormwater general permits?
Q No ❑ Yes
If yes, list the permit numbers for this facility:
7) Description of Discharge: �/
a) Will stormwater also be discharged? O Yes [2 No
If yes, does stormwater drain to a settling pond prior to discharge, ❑ Yes ❑ No
b) Is the sand washed or rinsed on the bank after removal from the stream? ❑ Yes io
c) Is the discharge directly to the receiving water? ❑ Yes E'No
If no, submit a site map with the pathway to the potential receiving waters clearly marked. This
includes tracing the pathway of the storm sewer to the discharge point, if the storm sewer is ;he only
viable means of discharge.
d) Number of discharge points (ditches, pipes, channels, etc. that convey wastewater from the proper y).
A"
e) Volume of discharge per each discharge point (in GPD): rc"
N E .
#2; #3: --
f) Please describe the type of process the sand dredging wastewater is being discharged from, be ,
S n -I. /97_ E(' i sF,1<r I^"
specific. r cY V J
g) Is there any treatment being applied to the wastewater before discharge (check the type of treatmen:
in use).
O Settling pond O Lagoon ❑Other None
(Please describe "Other")
h) How much of the volume discharged is treated (state in percent)?
i) If any box in item (e) above, other than none, was checked, please include design spect;,cs
design volume, retention time, surface area, etc,) with submittal package. Existing treatmen;
should be described in detail. Design criteria and/ operational data (including calculations) s7o:!_'. '
provided to ensure that the facility can comply with the requirements of the Genera: P•crmi!.
treatment shall be sufficient to meet with%`the limits set by the general permits. The trapping
should be greater than 75%, The surface area should be as large as possible to insure secime
occurs. To secure optimum efficiency the flow length of the basin to the basin widt'n s'ncu'.d na.'
ratio of 2:1
Note: Construction of any wastewater treatment facilities requires submission of three (3; se"s
plans and specifications along with the application. Design of treatment facilities ^dust oc~-c
with requirements of 15A NCAC 2H .0138, If construction applies to this discharce, in !
the three sets of plans and specifications with this application.
8) Discharge Frequency:
a) The discharge is: El Continuous Intermittent ElSeasonal
i) If the discharge is intermittent, describe when the discharge will occur: -L),,� ,,
n t pD ,h s oQ-'r SA�, �
77
ii) If seasonal check the month(s) the discharge occurs: ❑ Jan, ❑ Feb. ❑ tvlar. -- .
❑ May ❑ Jun. ❑ Jul. ❑ Aug. ❑ Sept. ❑ Oct. ❑ Nov. ❑ Dec.
Page 2 of 4
SWu•214-080102

NCG520000 N.0.1.
b) Please check the days discharge occurs:
O Sat. .❑ Sun. EfMon, E1 Tue. Wed. ZThu. D/Fri,
9) Receiving waters:
a) What is the name of the body or bodies of water (creek, stream, river, lake, etc.) that the facility
wastewater discharges end up in? If the site wastewater discharges to a separate storm sewer
system (4S), name the operator of the 4S (e.g. City of Raleigh), F/.n r C/-Pe 1�
b) Stream Classification (WS-IV, C, etc.): C l t3,5 l
10) Alternatives to Direct Discharge:
Address the feasibility of implementing each of the following non-discharge alternatives
a) Connection to a Regional Sewer Collection System
b) Subsurface disposal (including nitrification field,infiltration gallery, injection wells, etc.)
c) Spray irrigation
i
The alternatives to discharge analysis should include boring logs and/or other information indicating that a
subsurface system is neither feasible nor practical as well as written confirmation indicatinc Glrlat
connection to a POTW is not an option, It should also include a present value of costs analysis as out!in=d
in the Division's "Guidance For the Evaluation of Wastewater Disposal Alternatives".
11) Additional Application Requ'irements:
For new or proposed discharges, the following information must be included in triplicate v ith this
application or it will be returned as incomplete.
a) 7.5 minute series USGS topographic map (or a photocopied portion thereof) with discharge location
clearly indicated,
b) Site map, if the discharge is not directly to a stream, the pathway to the receiving stream mus! 'oe
clearly indicated. This includes tracing the pathway of a storm sewer to its discharge point.
c) If this application is being submitted by a consulting engineer (or engineering firm), include
documentation from the applicant showing that the engineer (Or firm) submitting the application has
been designated an authorized Representa`ive of the applicant.
d) Final plans for the treatment system (if applicable). The plans must be signed and sealed by a Ncr•.h
Carolina registered Professional Engineer and stamped-"Final Design-Not released for construction".
e) Final specifications for all major treatment components (if applicable). The specifications must tDe
signed and sealed by a North Carolina registered Professional Engineer and shall include an narrative
description of the treatment system to be constructed.
I certify that I. am familiar with the information contained in this application and that to the best of r-
iv
knowledge and belief such information is true, complete, and accurate.
Printed Name of Person Signing:- '^�/;f// NO - yy) �n
Title: OCU nr°r
(Signature ofApplica ) (Date Signed)
Page 3 of 4
SWU-214.080102

NCG520000 N.O.I.
Ncrth'Caroliha General Statute 143-215.6 b (i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application,
record, report, plan or other document filed or required to be maintained under Article 21 or regulations o;
the Environmental Management Commission implementing that Article, or who falsifies, tampers with or
knowingly renders inaccurate any recording or monitoring device or method required to be operated or
maintained under Article 21 or regulations of the Environmental Management Commission implementing
that Article, shall be guilty of a misdemeanor punishable by a fine not to exceed S10,000, or by
imprisonment not to exceed six months, or by both. (18 U.S.C, Section 1001 provides a punishment by a
fine of not more than $10,000 or imprisonment not more than 5 years, or both, fora similar offense.)
Notice of Intent must be accompanied by a check or money order for $80.00 made payable to:
NCDENR
Mail three (3) copies of the entire package to:
Stormwater and General Permits Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Final Checklist
This application will be returned as incomplete unless all of the following items have been
included:
❑ Check for$80 made payable to NCDENR PC �i 7-6�
❑ 3 copies of county map or USGS quad sheet with location of facility clearly marked on map
❑ 3 copies of this completed application and all supporting documents
❑ 3 sets of plans and specifications signed and sealed by a North Carolina P.E. (if applicable)
❑ Alternatives analysis including present value of costs for all alternatives
Note
The submission of this document does not guarantee the issuance of an NPDES permit
Page 4 of 4
SWU-214.080102

Q' �,�'.,�. ,1� dire /��

Driving Directions from 711 Complex Pl,Lenoir,NC to [1000-1209]Antioch Rd,Morga... Page 1 of 2
711 Complex PI [1000-1209] Antioch Rd
Lenoir, NC 28645-8337, US Morganton, NC 28655, US
Total Est. Time. Total Est. Distance.
19 minutes 10.18 miles
Maneuvers Distance
1: Start out going NORTH on COMPLEX PL 0.3 miles
toward SW LOOP BLVD.
2: Turn LEFT onto MORGANTON BLVD SW / 6.2 miles
US-64 / NC-18 BYP. Continue to follow
US-64.
<e> 3: Turn LEFT onto ANTIOCH RD. 3.5 miles
4: End at [1000-1209] Antioch Rd
Morganton, NC 28655, US
Total Est. Time: 19 minutes Total Est. Distance:
10.18 miles
http://www.mapquest.com/directions/main.adp?do=nw&go=l&r=f&aoh=&aot=&aof'--&2... 6/23/2006

Driving Directions from 711 Complex PI,Lenoir,NC to [1000-1209]Antioch Rd,Morga... Page 2 of 2
TI
sck 0���
La t Circle
x
Ir
Pot
'-"Wah far
' _ C L�allle Cf
JI-
�^ s
C�
71
p$e ?tn Crrr.n Ct
�N
} 7 ..
405.
Pie-
q�2006 Manoue,st inc 02006 NAV
All rights reserved. Use Subject to License/Copyright
These directions are informational only. No representation is made or warranty given as to their content,road conditions or
route usability or expeditiousness.User assumes all risk of use. MapQuest and its suppliers assume no responsibility for any
loss or delay resulting from such use.
http://www.mapquest.com/directions/main.adp?do=nw&go=1&r=f&aoh=&aot=&aof--&2... 6/23/2006

/ 1