310514_Waste Utilization Plan_20200406

Murphy -Brown, LLC 4/6/2020
NUTRIENT UTILIZATION PLAN
Grower(s): Murphy -Brown, LLC
Farm Name: 3501-3102; AWS310514
County: Duplin
Permit Capacity:
Farrow to Wean 4719
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Wean to Finish
Feeder to Finish
Gilts
Boars
Storage Structure. -
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
2822 Hwy 24 West
P.O. Sox 856
Warsaw, NC 28398
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown_
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen
Either of these conditions may result in runoff to surface waters which is not allowed
under DWR regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 11

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to mainta"n pH in the optimum range for speck crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, W, tons, etc.):
Capacity Type Waste Produced per Animal Total
4719
Farrow to Wean
3203 gal/yr
15,114,957 gal/yr
Farrow to Feeder
3861 gallyr
gallyr
Farrow to Finish
10478 gallyr
gallyr
Wean to Feeder
191 gallyr
gallyr
Wean to Finish
776 gal/yr
gallyr
Feeder to Finish
927 gallyr
gal/yr
Gilts
1015 gallyr
gallyr
Boars
2959 gallyr
gallyr
Total 15,114,957 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Capacity Type Nitrogen Produced per Animal Total
4719
Farrow to Wean
3.84 lbs/yr
18,121 lbs/yr
Farrow to Feeder
6.95 lbs/yr
lbs/yr
Farrow to Finish
18.86 Ibs/yr
Ibslyr
Wean to Feeder
0.34 lbslyr
Ibslyr
Wean to Finish
1.4 lbs/yr
lbslyr
Feeder to Finish
1.67 Ibs/yr
Ibs/yr
Gilts
1.83 Ibslyr
Ibs/yr
Boars
5,33 Ibs/yr
Ibs/yr
Total 18,121 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 114.05
Total N Required 1st Year: 31837.19
Total N Required 2nd Year: 25432.07
Average Annual Nitrogen Requirement of Crops. 28,634.63
Total Nitrogen Produced by Farm: 18,120.96
Nitrogen Balance for Crops: (10,513.67)
The foilowing table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 11

Reception Area Specifications OPTIONAL: Year 2 of a 2 year crop rotation (INheat/Soyheans)
Tract Field Irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs N/Ac Lbs N Total Ibs N
Acrea e Type Code A I Yield Ibs Ill Residual IAc Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs NIAc Lbs N Total Ibs N
Code Apply Yield Ibs N1Unit Residual !Ac Utilized
Total
Lbs NIAc
Tntal Ibs N
Utilized
70964
1A
6,92
Norfolk
0-
A r-Se t15
35 Q
3.91
136.85
947,002
N
Sept -Apr
60
2.09
1b
110A
763.968
247.25
1710.97
70964
1 B
3.76
Norfolk
O
A r-Se t15
35.0
3.91
136.85
514.556
N
Sept -Apr
60
2.09
15
110.4
415.104
247.25
929 66
70964
2A
6.61
Norfolk
O
A r-Se t15
35.0
3.91
136.85
904.5785
N
Sept -Apr
60
2.09
15
110.4
729.744
247.25
1634 323
70964
2B
3,53
Norfolk
O
A r-Se t15
35.0
3.91
136,85
483,0805
N
Sept -Apr
60
2.09
15
110.4
389.712
247,25
872.7925
70964
3A
6.92
Norfolk
O
A r�Se t15
35,0
3 ^.1
136.85
94T002
N
Sept -Apr
6C
2.09
15
110A
763.968
247,25
1710,97
70964
313
3.53
Norfolk
O
A r-Se t15
35,0
136.85
483.0805
N
Sept -Apr
60
2.09
15
110.4
389.712
247.25
872.7925
70964
4A
7.79
Norfolk
0
Al t15
35.0
3.91
136.85
1066.062
N
Se t-A r
60
1 2.09
15
110.4
860.016
247.25
1926.078
70964
46
3.26
Norfolk
O
Apr -Sept 15
35.0
3.91
136.85
446,131
N
Sept -Apr
6C
2.09
15
110.4
359.904
247,25
806,035
70964
6
2.65
Goldsboro
BIC
Mar -Set
6.5
40,25
261.625
693.3063
K
Sept -Apr
1
50
50
132.5
311.625
825,8063
70964
7
4.47
Goldsboro
BIC
Mar -Sat
6.5
40 5
251.525
1169.464
K
Sept-Alpr
1
50
5C
223.5
311.625
1392.964
70964
8
5.16
AwtryvjlJe
Bic
Mar -Sept
5.5
235.84
1216.934
K
Se t-A r
1
50
50
258
285 84
1474.934
70964
9
6,08
Autry011e
Bic
Mar -Sat
5.5
235.84
1433.907
K
Sept -Apr
1
50
50
304
28584
1737.907
70964
10A
5.32
Autrvville
BIC
Mar -Set
5.5
235.84
1254,669
K
Sept -Apr
1
50
50
266
285.84
1520.869
70964
10B
1.54
Autryvjlle
BIG
Mar -Set
5.5
d- H.:,
235.84
363,1936
K
Sept -Apr
1
50
50
77
285,84
440.1936
-0964
11
2.53
Norfolk
BIG
Mar -Set
65
40,2�'
261.825
661.9113
K
Sept -Apr
1
50
50
126.5
311,625
788,4113
10964
12
5.65
Norfolk
BIC
Mar -Set
6.5
40,25
261.525
1478.181
K
Sept -Apr
1
50
50
282,5
311.625
1760.681
343
13
4,51
Autryville
C
Mar -Set
5.5
49
269.5
1215.445
K
Sept -Apr
1
50
50
225,5
319.5
1440.945
343
14
7.65
Aut isle
C
Mar -Se
5.5
49
269.5
2061.675
K
Sept -Apr
1
50
50
3825
319.5
2444.175
343
15
8.04
Autryville
C
Mar -Set
5,5
49
269.5
1627.78
K
Selpt-Alor
1
50
50
302
319.5
1929.78
343
16
8.81
Autryville
C
Mar -Set
5.5
49
1 269.5
2$74.295
K
Se -Apr
1
50
440,5
319.5
2614.795
343
17
1.67
Goldsboro
O
A r-Se t15
38.0
3,91
148.58
248.1266
0
0
148.58
248.1286
343
18
4.91
Goldsboro
0
A r-Se t15
38.0
3,91
148.58
729.5278
0
0
148.58
729.5278
343
19
4.74
Goldsboro
O
A r-Se t15
38.0
3,91
148,58
704.2692
0
0
148.68
704.2692
Totals: 114.05 23024.18 7692,B28 30716.61
3(b) of 11

Reception Area Specifications OPTIONAL., Year 1 of 2 year crop rotation (Wheat/Soybeans)
Tract Field Irrigated soil 1st Crop Time to 1st Crop 1st Crop Lbs NIAc Lbs N Total Ibs N
Acreage Type Code 8ppjy Yield Ibs NlUnit Residual IAc Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs NIAc Lbs N Total Ibs N
Code Apply Yield Ibs NlUnit Residual IAo Utilized
Total
Lbs NfAc
Total Ibs N
Utilized
u 764
1A
G J.
U
A r-Se tl5
35.0
3.91
136.85
947,002
N
Sept -Apr
8C
2.09
15
110.4
763.968
247.25
1710-97
70964
1B
3.76
0
A r-Se 15
35.0
3.91
136.85
514,556
N
Se t-A r
60
2.09
15
110A
415.104
247,25
929.66
70964
2A
6.61
O
A r•Se t15
35.a
3 91
136.85
904.5785
N
Sept -Apr
60
2.09
15
110.4
729.744
247.25
1634.323
70964
213
3.53
A r-Se t15
350
3.91
136.85
483.0805
N
Sept -Apr
60
2.09
15
110.4
389,712
247.25
872,7925
70964
3A
6.92
Norfolk
A r-Se tl5
36.0
3 91
136.85
947.002
N
Se t-A r
60
2A9
15
110.4
763.968
247.25
1710.97
70964
3B
3.53
Norfolk
A r-Se tl5
35.0
3 91
136.85
483.0805
N
Sept -Apr
60
2.09
15
110.4
389.712
247.25
872,7925
70964
4A
7.79
Norfolk
O
A r-Se tl5
35.0
3.91
136.85
1066,062
N
Sept -Apr
60
2.09
15
110.4
860.018
247.25
1926.078
70964
4B
3.26
NorfoEk
O
Apv-Sept15
35.0
3.91
136.85
446,131
N
Sept -Apr
60
2.09
15
110.4
359.904
247.25
806.035
70964
6
2.65
Goldsboro
BIC
Mar -Set
6.5
40,25
261,625
693.3063
K
Sept -Apr
50
50
132,5
311,625
825.8063
70964
7
4.47
Goldsboro
BIC
Mar -Set
6.5
40,25
261.625
1169,464
K
Sept -Apr
50
50
223,5
311 625
1392.964
70964
8
5.16
AutryOle
BIC
Mar -Set
5.5
42,88
235.84
1216 934
K
Se t-A r
1
50
50
258
285.84
1474.934
70964
9
6.08
Aut We
BIC
Mar -Set
5.5
42,88
236.84
1433,907
K
Sept -Apr
1
50
50
304
285.84
1737.907
70964
10A
5.32
Aut IRIe
BIC
Mar -Set
5.5
42,88
235.84
1254,669
K
Sept -Apr
1
50
50
266
285.84
1520.669
r'954
10B
1.54
Aut IHe
BIC
Mar -Set
5.5
4:21b
235.84
363.1936
K
Se t-A r
1
50
50
77
285.84
440,1936
14
11
2.53
Norfolk
BIC
Mar -Set
6.5
4
261.625
661.9113
K
Sept -Apr
1
50
50
126.5
311,625
788,4113
12
5.65
Norfo k
BIC
Mar -Set
6.5
4
261.625
1478.181
K
Se t-A r
1
50
50
282.5
311.625
1760,681
13
4.51
Aut ille
C
Mar -Se i
5.5
269.5
1215.446
K
Se t-A r
1
50
50
225.5
3195
1440 945
343
14
7.65
Aut ille
C
Mar -Set
5.5
2695
2061.675
K
Se t-A r
1
50
50
382.5
319 5
2444.175
343
6.04
Aut ilie
C
Mar -Set
5.5
269,5
1627.78
K
Sept -Apr
1
50
50
302
319.5
1929.78
343
8.81
Aut ille
C
Mar -Set
5.5
49
269.5
2374.295
K
Sept -Apr
1
50
50
440.5
3%5
2814.795
343
1.67
Goldsboro
D
Febl5-JLine
156 ',1
0,95
15
133.2
222,444
N
Se t-A r
65
2,C9
135.85
226.8695
269.05
449.3135
343
4.91
Goldsboro
D
FeW 5-June
15'
096
15
133.2
654.012
N
Sept -Apr
65
209
135.85
667.0236
269,05
1321.036
4,74
Goldsboro
D
Febl5-June
0,95
15
133.2
531.368
N
Sept -Apr
65
2,09
135.85
843.929
269.05
1275.297
�7otafs: 114.05 22850.08 9230.45 32080.53
3(a) of 11

Reception Area Specifications Year 2 ofa 2 year crop rotation (Corn/WheaflSoydeans)
Tract Field Irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs NlAc Lbs N Total Ibs N
Acreage- Type Code Apply Yield lbs N/Unit Residual lAc Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs NlAc Lbs N Total Ids N
Code Apply Yield Ibs NlUnit Residual lAc Utilized
Total
Lbs NIAc
Total Ibs N
Utilized
3Ei4
1A
6.9�
Norf
Ax-Sezt15
35.0
39'
136,85
947.002
0
0
136,85
947,002
A r-Se t15
s5 0
3.91
13685
514.556
0
0
136.85
514,556
Air-Sept'I6
25.0
39'
136,85
904.5785
0
0
136.85
904.5785
r-st ,tl5
15.0
3 9i
136,85
453,C805
0
0
136.85
483,0805
A r-Sept15
75.G
3,9i1
136-85
947.002
0
0
136.85
947,002
A r-Se t15
��5 C
391
136.85
483,0805
0
0
136.85
483.0605
A r-Sept15
35 0
3.91
136,85
1066.062
0
0
135.85
1066.062
A r-Se t15
a5.0
391
136,85
446,131
0
0
136.85
446.131
Mar -Sept
6 5
40 25
261.625
693.3063
K
Sept -Apr
1
bq
50
132,5
311.625
825,8063
Mar -set
6 5
40 2t;
261.625
1169.464
K
Sept -Apr
1
50
50
223 5
311.625
1392.964
Mar -Seat
=
42.88
235.84
1216.934
K
Sept -Apr
1
50
50
258
285,84
1474.934
h,9ar-Set
1S 5
42 88
235.84
1433.907
K
Sept -Apr
1
'::0
50
304
285.84
1737.907
PAarl t
56
42 88
235,64
1254.669
K
Sept -Apr
1
5�0
50
266
285.84
1520.669
Mar -tee t
5.5
42 85
235,84
383.1936
K
Sept -Apr
G
50
77
285,84
440 1936
Mar -Sept
'G 5
40 25
261.625
661.9113
K
Sept -Apr
1
5L,
50
126,5
311.625
788,4113
Mar -Set
6 5
4025
261.625
1478.181
K
Sept -Apr
50
282.5
311.625
1760.681
Aar -Se pt
5.5
49
269.5
1215.445
K
Sept -Apr
50
225.5
119.5
1440,945
Mar -Sep[
5 5
49
269.5
2061.675
K
Sept -Apr
1
50
50
382.5
319.5
2444,175
hAar-Se pt
5 5
49
269.5
1827.78
K
Sept -Apr
1
50
50
302
319.5
1929.78
Mar Sept
5
49
269.5
2374.295
K
Se t-A r
1
dl
50
440.5
319.5
2814,795
A r-Se:�t15
38.0
3.91
148,58
248.1286
0
0
148,58
248.1286
Apr-Supt1`'i
;�8-0
3B1
14868
729.5278
0
0
148,58
729.5278
A. r-Se �t1 E'
3H 0
3 CO
14858
704.2692
0
0
148,58
704.2692
Totals. 114.05 23024.18 3020.5 26044.68
3
olk
C]
7 P; �ri4
1 B
3.7c
Norfolk
O
2A
6.G1
Norfolk
Q
4
2B
3-53
Norfolk
O
70964
3A
6.92
Norfolk
O
70964
3B
3.53
Norfolk
Q
70984
4A
7.79
Norfolk
b
70964
4B
3.26
Norfolk
O
70964
6
2.65
Goldsboro
B1C
70964
7
4 47
Goldsboro
BIC
i 0964
8
5-16
Aut ville
B!C
/0964
9
8.U8
Aut ville
BlC;
�0964
1UA
5.3,'.?
Autr illy
BIC
OF�64
1 E78
i-54
Aut ille
F3li,
70J64
11
253
Norfolk
B1C
TCiFic4
12
6.t5
Norfolk
B;C
�?�93
13
4 51
Aut ille
C
3-l'3
14
7.C5
Autr ille
C
343
15
6.04
Aut ville
G
'E6
F,'-61
Aut ille
C
17
1.6/
Golcdsbora
O
3a3
1Li
4.91
Goldsboro
O
?43
4-I4
Gold�bora
CJ
(b) of 11

Reception Area Specifications Year 1 of a 2 year crop rotation (Corn/Wheat/Soybeans)
Tract Field Irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs N1Ac Lbs N Total Ibs N
Acreage- Type Code Apply Yield lbs NfUnit Residual !Ac Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs NIAc Lbs N Total Ibe N
Code Apply Yield Ibs N/Unit Residual /Ac Utilized
Total
Lbs NlAc
Total [be N
Utilized
70964
1A
6,92
Norfolk
D
Feb15-June
138,0
0.95
15
116,1
803,412
f;
Sept -Apr
60
209
125.4
867,768
241.5
1671.18
70964
1 B
3.76
Norfclk
D
Feb15-June
138.0
0 95
15
116,1
436.536
] .
Sept -Apr
60
2.09
1254
471.504
241.5
908,04
70964
2A
6.61
Norfolk
D
Feb15-June
138,0
0.95
15
116,1
767,421
N
Sept -Apr
60
2.09
125.4
828.894
241.5
1596,315
70904
2B
3.53
Norfolk
D
Feb15-June
138.0
0.95
15
116,1
409.833
N
Sept -Apr
60
2.09
125.4
442 862
241.5
852.495
70964
3A
6.92
Norfclk
D
Feb15-June
136.0
0,95
15
116 1
803.412
N
Sept -Apr
60
2.09
123.4
867.768
241.5
1671.18
70964
3B
3.53
Norfolk
D
Febl6-June
138.0
0.95
15
116,1
409,833
N
Sept -Apr
60
2.09
125.4
442.862
241.5
852.495
70964
4A
7,79
1 Norfolk
D
jFeb15-June
138.0
1 0.95
15
116,1
904,419
N
Sept -Apr
60
2.09
125.4
976.866
241.5
1881 286
70964
4B
3.26
Norfolk
D
Feb15-June
138.0
0,95
15
116.1
378.488
N
Sept -Apr
60
2.09
125.4
408.804
241-6
787.29
70964
6
2.65
Goldsboro
B/C
Mar -Set
6.5
40.2C,
261.625
693.3063
K
Sept -Apr
1
50
50
132.5
311.625
825.8063
70964
7
4A7
Goldsboro
B/C
Mar -Set
8.5
40.25
261,625
1169.464
K
Sept -Apr
1
50
50
223.5
311.625
1392,964
70964
8
5.16
Aut ille
B/C
Mar -Set
42.88
235.84
1215.934
K
Sept r
1
50
50
258
286.84
1474,934
70964
9
6,08
Aut i]ie
B/C
Mar -Sat
42.8B
235.84
1433.907
K
Sept -Apr
1
50
50
304
285,84
1737.907
70964
10A
532
Aut vide
B/C
Mar -Set
5.5
42.8E
235.84
1254.569
1
Sept -Apr
1
50
50
256
285.84
1520,669
70964
10B
1,54
Autryville
B!C
Mar -Set
5.5
42.8E
235.84
363.1936
K
-9ept-ATDr
1
50
50
77
286.84
440.1936
70964
11
2,53
Norfolk
B/C
Mar -Set
5.5
40.25
261.625
661.9113
K
Se t-A r
1
50
50
126,5
311.625
788.4113
70964
12
5,65
Norfolk
Bic
Mar -Set
6.5
40.25
261.625
1478,181
K
9e t-A r
1
50
50
282.5
311.626
1760,681
343
13
4,51
Autryville
C
Mar -Set
5.5
49
269,5
1215.445
K
Sept -Apr
1
50
50
225.5
319.5
1440.945
343
14
7.65
Autryville
C
Mar -Set
5.5
49
2695
2061.675
K
Sept -Apr
1
50
50
382.5
3%5
2444.175
343
15
6,04
Autryville
C
Mar -Set
5.5
49
269.5
1627.78
K
Sept -Apr
1
50
50
302
3195
1920.78
343
16
8.81
Aut ille
C
Mar -Set
5.5
49
269,5
2374.295
K
Sept -Apr
1
0
50
440.5
319.5
2814,795
343
17
9 t?7
Goldsboro
D
Feb15-June
156.0
0,95
15
133.2
222A44
N
Sept -Apr
65
_..09
135,85
226.8695
269.05
449,3135
343
1 B
-idsboro
D
Feb15-June
156.0
0.95
15
133.2
854.012
N
Sept -Apr
65
209
135.85
667.0235
269.05
1321.036
343
19
414
''oldsboro
D
Feb15-June
156 =!
0.95
15
133.2
631.368
N
Sept -Apr
65
2.09
135,85
643.929
269.05
1275.297
Tofals: 114.05 21971.94 9865.25 31837.19
3{a} of 11

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, W, tons, etc.):
Capacity Type Waste Produced per Animal Total
4719
Farrow to Wean
3203 gal/yr
15,114,957 gal/yr
Farrow to Feeder
3861 gallyr
gallyr
Farrow to Finish
10478 gal/yr
gallyr
Wean to Feeder
191 gallyr
gallyr
Wean to Finish
776 gallyr
gallyr
Feeder to Finish
927 gallyr
gal/yr
Gilts
1015 gallyr
gallyr
Boars
2959 gallyr
gallyr
Total 15,114,957 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Capacity Type Nitrogen Produced per Animal Total
4719
Farrow to Wean
3.84lbs/yr
18,121 Ibs/yr
Farrow to Feeder
6.95 Ibs/yr
Ibslyr
Farrow to Finish
18.86 Ibslyr
Ibslyr
Wean to Feeder
0.34 Ibslyr
Ibslyr
Wean to Finish
1.4 Ibslyr
Ibs/yr
Feeder to Finish
1.67 Ibslyr
Ibslyr
Gilts
1.83 Ibslyr
Ibs/yr
Boars
5.33 Ibslyr
Ibs/yr
Total 18,121 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 114.05
Total N Required 1st Year: 31837.19
Total N Required 2nd Year: 26044.68
Average Annual Nitrogen Requirement of Crops: 28,940.93
Total Nitrogen Produced by Farm: 18,120.96
Nitrogen Balance for Crops: (10,819.97)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of11

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above_
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definitely interfere
with stand of Bermudagrass_ This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Description -Harvested As
A
Barley
Grain Crop
B
Grazed Hybrid Bermudagrass
PasturelGrazed
C
Hybrid Bermudagrass Hay
Hay
B/C
Comb. Hybrid Bermudagrass
Graze/Hay Combination
D
Corn - Grain
Grain Crop
E
Corn -- Silage
Silage
F
Cotton
Cotton Lint
G
Grazed Fescue
PasturelGrazed
H
Fescue Hay
Hay
I
Oats
Grain Crop
J
Rye
Grain Crop
K
Grazed Overseed
Pasture/Grazed (Seeded in Bermudagrass)
L
Overseed Hay
Hay (Seeded in Bermudagrass)
M
Grain Sorghum
Grain Crop
N
Wheat
Grain Crop
O
Soybean
Grain Crop
P
Pine Trees
Pine Trees
S
Small Grain
Grain Crop/ Hay (After Grain Crop)
CC
Cover Crop
Not Harvested; Burned/Disked In
SWG
Swithgrass
Biomass Crop
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of11

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications
PANlyrlanimal Farm Totallyr
4719 Farrow to Wean
0.8 3775.2
Farrow to Feeder
0.96
Farrow to Finish
3.9
Wean to Feeder
0.07
Wean to Finish
0.27
Feeder to Finish
0.34
Gilts
0.39
Boars
0.55
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 3775.2 pounds of plant available nitrogen per year and will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 18876 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 62 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 151.008 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation, The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of11

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
in/hr
* inches
70964
1A
Norfolk
D
0.5
1
70964
1 B
Norfolk
D
0.5
i
70964
2A
Norfolk
D
0.5
1
70964
2B
Norfolk
D
0.5
1
70964
3A
Norfolk
D
0.5
1
70964
3B
Norfolk
D
0.5
1
70964
4A
Norfolk
D
D_5
1
70964
4B
Norfolk
D
0.5
1
70964
6
Goldsboro
BIC
0.4
1
70964
7
Goldsboro
BIC
0.4
1
70964
S
Autryville
BIC
0.6
1
70964
9
Autryville
B/C
0.6
1
70964
10A
Autryville
BIC
0.6
1
70964
10B
Autryville
BIC
0.6
1
70964
11
Norfolk
BIC
0.5
1
70964
12
Norfolk
BIC
0.5
1
343
13
Autryville
C
0.6
1
343
14
Autryville
C
0.6
1
343
15
Autryville
C
0.6
1
343
16
Autryville
C
0.6
1
343
17
Goldsboro
D
0.4
1
343
18
Goldsboro
D
0.4
1
343
19
Goldsboro
D
0.4
1
6of11

Additional Comments:
-his plan revised to show the recalculated wetted acres remaining and added
after the conversion to Farrow -Wean.
OPTIONS:
A cover crop may be planted in any of the row crop fields if desired. This option
allows a maximum application of 30 Ibs Nlac from Sept -April and the amount
applied to the cover crop must be deducted from the following crops starting
PAN rate.
A small grain crop may be planted in any of the row crop fields if desired. This
option allows a maximum application of 100 Ibs Nlac from Sept -April and the
must be harvested as a hav cro
4/6/2020 This revision changes fields 13,14 and 15 from combination hay
and graze to hay only.
7of11

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 3501-3102; AWS310514
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. Ilwe know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWR before the new
animais are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWR upon request.
Name of Facility Owner:
Signature:
Name of Manager (if different from owner):
Signature:
LLC
Date
Date
Name of Technical Specialist:
Toni W. King
Affiliation:
Murphy -Brown, LLC.
Address:
2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone:
[phone]
Signature:
Z-0
Date
8of11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity, allowing
him/her the use of the land for waste application. It is the responsibility of the owner of the
waste production facility to secure an update of the Nutrient Utilization Plan when there is
a change in the operation, increase in the number of animals, method of application,
recieving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
5 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order to control odor and flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9of11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is not
covered with waste to a depth that would inhibit growth. The potential for salt damage from
animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste/nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall not
be applied more than 30 days prior to planting of the crop or forages breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following: The outer
perimeter of the land area onto which waste is applied from a lagoon that is a component of a
swine farm shall be at least 50 feet from any residential property boundary and canal. Animal
waste, other than swine waste from facilities sited on or after October 1, 1995, shall not be applied
closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those owned by the
landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by discharge
or by over -spraying. Animal waste may be applied to prior converted cropland provided the fields
have been approved as a land application site by a "technical specialist". Animal waste shall not be
applied on grassed waterways that discharge directly into water courses, and on other grassed
waterways, waste shall be applied at agronomic rates in a manner that causes no runoff or drift
from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall not be
discharged into the animal waste management system.
10of11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
17 A protective cover of appropriate vegetation will be established an all disturbed areas (lagoon
embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to protect the
vegetation. Vegetation such as trees, shrubs, and other woody species, etc., are limited to areas
where considered appropriate. Lagoon areas should be kept mowed and accessible. Berms and
structures should be inspected regularly for evidence of erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is responsible for
obtaining and implementing a "closure plan" which will eliminate the possibility of an illegal
discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular basis to
prevent breakdowns, leaks and spills. A regular maintenance checklist should be kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct human
consumption. However, if animal waste is used on crops for direct human consumption, it should
only be applied pre -plant with no further applications of animal waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the temporary
storage (pumping volume) of all waste treatment lagoons. Pumping shall be managed to maintain
the liquid level between the markers. A marker will be required to mark the maximum storage
volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually at crop
sites where waste products are applied. Nitrogen shall be the rate -determining nutrient, unless
other restrictions require waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the soil shall be monitored
and alternative crop sites shall be used when these metals approach excessive levels. pH shall be
adjusted and maintained for optimum crop production. Soil and waste analysis records shall be
kept for a minimum of five years. Poultry dry waste application records shall be maintained for a
minimum of three years. Waste application records for all other waste shall be maintained for a
minimum of five years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
11 of 11

3501 & 3102
AWS310514
Scale: 9 "-501'
Hyd # Acres
I 6.92
iB 3,76
2A 6.61
2B 3.53
3A 6.92
3B 3.53
4A 7-79
48 3.26
s 7 5 2.55
$ 1� 7 4.47
8 5.16
a 9 6-08
10A
10A 5-32
103 1.54
11 2.53
12 5.65
13 4-51
tt 14 7-85
15 6.04
' t2 16 8-81
17 1.67
18 4,91
tB 19 4,74
Lagoon Total 114.05
lA 39 4g
2A 3A
4A 3501
Lagoon 3102
' 13
14
15
17
18
19
Specifications: Pulls
Travelers: Ag Rain ST5, Ag Rain E30 &
Cadman 3500 G3
w/Nelson 150 Big Gun Sprinklers
w/1-18' Nozzle 0 60 PSI YOW
300' WD do 225 GPM`
260' Lana Spacing (Pulls 1A--46, 17-18).�4
250' Lane Spacing (Pulls 6--12)
a
Specifications: Solid Sets
° €IA2419 `
Benninger 7025 o�si6sA�`
w/g18 Nozale5 0 50 PSf
135' WD & 16.3 GPM
80'x80' Spacing