The URL can be used to link to this page

Home My WebLink About840015_Compliance Evaluation Inspection_20181004s Water Resources Environmental Quality October 4, 2018 Melvin K. Huneycutt Huneycutt Pig Farms 28376 Millingport Road Albemarle, NC 28001 ROY COOPER Governor MICHAEL S. REGAN Secretary LINDA CULPEPPER Interim Director Re: COMPLIANCE INSPECTION Huneycutt Pig Farms/Facility 84-15 General Permit AWS840015 Stanly County Dear Mr. Huneycutt: On September 26, 2018, staff of the North Carolina Division of Water Resources (DWR), Water Quality Regional Operations Section (WQROS), inspected Huneycutt Pig Farms and the permitted waste disposal system. We wish to thank you for being present and assisting during the inspection. The enclosed report should be self-explanatory; however, should you have any questions concerning this report, please contact Mr. Bealle or me at (704) 663-1699. Sincerely, DocuSigned by: Asww H P4444 F161F 9 Q84AI" Andrew . itnerP.G., Assistant Regional Supervisor Mooresville Regional Office Water Quality Regional Operations Section Division of Water Resources enclosure: Compliance Inspection Report dated September 26, 2018 jb State of North Carolina I Environmental Quality I Water Resources I Water Quality Regional Operations Mooresville Regional Office 1610 East Center Avenue, Suite 3011 Mooresville, North Carolina 28115 704-663-1699 Division of Water Resources ❑ Division of Soil and Water Conservation ❑ Other Agency Facility Number: 840015 Facility Status: Active Permit: AWS840015 ❑ Denied Access Inpsection Type: Compliance Inspection Inactive Or Closed Date: Reason for Visit: Routine County: Stanly Region: Mooresville Date of Visit: 09/26/2018 Entry Time: 03:00 pm Exit Time: 4:30 pm Incident # Farm Name: Huneycutt Pig Farms Owner Email: Owner: Melvin K Huneycutt Phone: 704-982-1976 Mailing Address: 28376 Millingport Rd Albemarle NC 28001 Physical Address: 28376 Millingport Rd Albemarle NC 28001 Facility Status: Compliant ❑ Not Compliant Integrator: N G Purvis Farms Inc Location of Farm: Latitude: 35' 18' 30" Longitude: 80' 22' 30" From intersection of Hwy 73 and SR1134 (Millingport Rd), travel south on Millingport Rd. about 2 miles. Farm is on the left. About 4 miles west of Albemarle. Question Areas: Dischrge & Stream Impacts Waste Col, Stor, & Treat Waste Application Records and Documents Other Issues Certified Operator: Rodney K Huneycutt Operator Certification Number: 16665 Secondary OIC(s): On -Site Representative(s): Name Title Phone 24 hour contact name Rodney K. Huneycutt Phone : 704-982-1976 On -site representative Rodney K. Huneycutt Phone : 704-982-1976 DocuSiq ned by: Primary Inspector: James Bealle Phone: 704-gg6 1gg 9 EEx 118 Inspector Signature: Date: LC2AF677B45D947B... 0/j/2� Secondary Inspector(s): Inspection Summary: 05/17/18 > Waste Analysis > N = 6.09 Lbs/1000 Gallons 12/06/17 > Waste Analysis > N = 7.31 Lbs/1000 Gallons 04/07/17 > Soil Analysis DS page: 1 Permit: AWS840015 Owner - Facility : Melvin K Huneycutt Facility Number: 840015 Inspection Date: 09/26/18 Inpsection Type: Compliance Inspection Reason for Visit: Routine Regulated Operations Swine Design Capacity Current promotions Swine - Feeder to Finish 2,590 0 Swine - Wean to Feeder 800 0 Total Design Capacity: 3,390 Total SSLW: 373,650 Waste Structures Disignated Observed Type Identifier Closed Date Start Date Freeboard Freeboard Lagoon LAGOON1 18.00 30.00 page: 2 Permit: AWS840015 Owner - Facility : Melvin K Huneycutt Facility Number: 840015 Inspection Date: 09/26/18 Inpsection Type: Compliance Inspection Reason for Visit: Routine Discharges & Stream Impacts Yes No Na Ne 1. Is any discharge observed from any part of the operation? ❑ ❑ ❑ Discharge originated at: Structure ❑ Application Field ❑ Other ❑ a. Was conveyance man-made? ❑ ❑ 0 ❑ b. Did discharge reach Waters of the State? (if yes, notify DWQ) ❑ ❑ 0 ❑ c. What is the estimated volume that reached waters of the State (gallons)? d. Does discharge bypass the waste management system? (if yes, notify DWQ) ❑ ❑ ❑ ❑ 2. Is there evidence of a past discharge from any part of the operation? ❑ 0 ❑ ❑ 3. Were there any observable adverse impacts or potential adverse impacts to Waters of the ❑ 0 ❑ ❑ State other than from a discharge? Waste Collection, Storage & Treatment Yes No Na Ne 4. Is storage capacity less than adequate? ❑ 0 ❑ ❑ If yes, is waste level into structural freeboard? ❑ 5. Are there any immediate threats to the integrity of any of the structures observed (Le./ large ❑ 0 ❑ ❑ trees, severe erosion, seepage, etc.)? 6. Are there structures on -site that are not properly addressed and/or managed through a ❑ ❑ ❑ waste management or closure plan? 7. Do any of the structures need maintenance or improvement? ❑ ❑ ❑ 8. Do any of the structures lack adequate markers as required by the permit? (Not applicable ❑ 0 ❑ ❑ to roofed pits, dry stacks and/or wet stacks) 9. Does any part of the waste management system other than the waste structures require ❑ 0 ❑ ❑ maintenance or improvement? Waste Application Yes No Na Ne 10. Are there any required buffers, setbacks, or compliance alternatives that need ❑ 0 ❑ ❑ maintenance or improvement? 11. Is there evidence of incorrect application? ❑ 0 ❑ ❑ If yes, check the appropriate box below. Excessive Ponding? ❑ Hydraulic Overload? ❑ Frozen Ground? ❑ Heavy metals (Cu, Zn, etc)? ❑ PAN? ❑ Is PAN > 10%/10 lbs.? ❑ Total Phosphorus? ❑ Failure to incorporate manure/sludge into bare soil? ❑ Outside of acceptable crop window? ❑ Evidence of wind drift? ❑ Application outside of application area? ❑ page: 3 Permit: AWS840015 Owner - Facility : Melvin K Huneycutt Facility Number: 840015 Inspection Date: 09/26/18 Inpsection Type: Compliance Inspection Reason for Visit: Routine Waste Application Yes No Na Ne Crop Type 1 Corn (Grain) Crop Type 2 Soybean, Wheat Crop Type 3 Timothy, Orchard, & Rye Grass Crop Type 4 Crop Type 5 Crop Type 6 Soil Type 1 Soil Type 2 Soil Type 3 Soil Type 4 Soil Type 5 Soil Type 6 14. Do the receiving crops differ from those designated in the Certified Animal Waste ❑ 0 ❑ ❑ Management Plan(CAWMP)? 15. Does the receiving crop and/or land application site need improvement? ❑ 0 ❑ ❑ 16. Did the facility fail to secure and/or operate per the irrigation design or wettable acre ❑ ❑ ❑ determination? 17. Does the facility lack adequate acreage for land application? ❑ ❑ ❑ 18. Is there a lack of properly operating waste application equipment? ❑ 0 ❑ ❑ Records and Documents Yes No Na Ne 19. Did the facility fail to have Certificate of Coverage and Permit readily available? ❑ 0 ❑ ❑ 20. Does the facility fail to have all components of the CAWMP readily available? ❑ 0 ❑ ❑ If yes, check the appropriate box below. WUP? ❑ Checklists? ❑ Design? ❑ Maps? ❑ Lease Agreements? ❑ Other? ❑ If Other, please specify 21. Does record keeping need improvement? ❑ 0 ❑ ❑ If yes, check the appropriate box below. Waste Application? ❑ Weekly Freeboard? ❑ Waste Analysis? ❑ Soil analysis? ❑ Waste Transfers? ❑ Weather code? ❑ Rainfall? ❑ Stocking? ❑ page: 4 Permit: AWS840015 Owner - Facility : Melvin K Huneycutt Facility Number: 840015 Inspection Date: 09/26/18 Inpsection Type: Compliance Inspection Reason for Visit: Routine Records and Documents Yes No Na Ne Crop yields? ❑ 120 Minute inspections? ❑ Monthly and 1" Rainfall Inspections ❑ Sludge Survey ❑ 22. Did the facility fail to install and maintain a rain gauge? ❑ 0 ❑ ❑ 23. If selected, did the facility fail to install and maintain a rainbreaker on irrigation equipment ❑ ❑ 0 ❑ (NPDES only)? 24. Did the facility fail to calibrate waste application equipment as required by the permit? ❑ 0 ❑ ❑ 25. Is the facility out of compliance with permit conditions related to sludge? If yes, check the ❑ ❑ ❑ appropriate box(es) below: Failure to complete annual sludge survey ❑ Failure to develop a POA for sludge levels ❑ Non -compliant sludge levels in any lagoon ❑ List structure(s) and date of first survey indicating non-compliance: 26. Did the facility fail to provide documentation of an actively certified operator in charge? ❑ ❑ ❑ 27. Did the facility fail to secure a phosphorous loss assessment (PLAT) certification? ❑ ❑ ❑ Other Issues Yes No Na Ne 28. Did the facility fail to properly dispose of dead animals within 24 hours and/or document ❑ 0 ❑ ❑ and report mortality rates that exceed normal rates? 29. At the time of the inspection did the facility pose an odor or air quality concern? If yes, ❑ 0 ❑ ❑ contact a regional Air Quality representative immediately. 30. Did the facility fail to notify regional DWQ of emergency situations as required by Permit? ❑ 0 ❑ ❑ (i.e., discharge, freeboard problems, over -application) 31. Do subsurface tile drains exist at the facility? ❑ 0 ❑ ❑ If yes, check the appropriate box below. Application Field ❑ Lagoon / Storage Pond ❑ Other ❑ If Other, please specify 32. Were any additional problems noted which cause non-compliance of the Permit or ❑ 0 ❑ ❑ CAW M P? 33. Did the Reviewer/Inspector fail to discuss review/inspection with on -site representative? ❑ 0 ❑ ❑ 34. Does the facility require a follow-up visit by same agency? ❑ 0 ❑ ❑ page: 5