The URL can be used to link to this page

Home My WebLink About800043_Compliance Evaluation Inspection_20190114ROY COOPER Governor MICHAEL S. REGAN Secretary LINDA CULPEPPER Director Shelbia C. Foster La -Foster Dairy (Carson Road) 13210 Cool Springs Road Cleveland, NC 27013 Dear Ms. Foster: NORTH CAROLINA Environmental Quality January 14, 2019 Re: COMPLIANCE INSPECTION La -Foster Dairy/Facility 80-43 General Permit AWC800043 Rowan County On December 6, 2018, staff of the North Carolina Division of Water Resources (DWR), Water Quality Regional Operations Section (WQROS), inspected the La -Foster Dairy and the permitted waste disposal system. We wish to thank you for being present and assisting during the inspection. The enclosed report should be self-explanatory; however, should you have any questions concerning this report, please contact Mr. Bealle or me at (704) 663-1699. Sincerely, DocuSigned by: 4. N P F161 FB69A2D84A3... Andrew H. Pitner, P.G., Assistant Regional Supervisor Mooresville Regional Office Water Quality Regional Operations Section Division of Water Resources enclosure: Compliance Inspection Report dated December 6, 2018 jb D Q North Carolina Department of Environmental Quality I Division of Water Resources Mooresville Regional Office 1 610 East Center Avenue, Suite 301 1 Mooresville, North Carolina 28115 NORTH CAROHNA � o.namremor �w.c�giuuei� /`� 704.663.1699 Division of Water Resources ❑ Division of Soil and Water Conservation ❑ Other Agency Facility Number: 800043 Facility Status: Active Permit: AWC800043 ❑ Denied Access Inspection Type: Compliance Inspection Inactive Or Closed Date: Reason for Visit: Routine County: Rowan Region: Mooresville Date of Visit: 12/06/2018 Entry Time: 03:00 pm Exit Time: 5:00 pm Incident #: Farm Name: La -Foster Dairy (Carson Road) Owner Email: Owner: Shelbia C Foster Phone: 704-278-2596 Mailing Address: 13210 Cool Springs Rd Cleveland NC 270139438 Physical Address: 1685 Carson Rd Cleveland NC 270139438 Facility Status: 0 Compliant ❑ Not Compliant Integrator: Location of Farm: Latitude: 35' 46' 48" Longitude: 80' 37' 34" FROM INTERSECTION OF SR 1003 (COOL SPRG RD) AND SR 1970 (CARSON RD), TRAVEL SOUTH ON CARSON RD. FARM ON LEFT ABOUT 300 YARDS. Question Areas: Dischrge & Stream Impacts Waste Col, Stor, & Treat Waste Application Records and Documents Other Issues Certified Operator: Shelbia C Foster Operator Certification Number: 20945 Secondary OIC(s): On -Site Representative(s): Name Title Phone 24 hour contact name Shelbia C. Foster 704-278-2596 On -site representative Shelbia C. Foster 704-278-2596 Primary Inspector: James Bealle Phone: 704-663-1699 Ext.2 L�C2AF6771345ID94713... 1/14/2019 Inspector Signature: Date: Secondary Inspector(s): Inspection Summary: 10/16/18 > Waste Analysis > N = 3.21 Lbs/1000 Gallons 07/17/17 > Waste Analysis > N = 7.33 Lbs/1000 Gallons 07/14/17 > Soil Analysis DS Page 1 of 5 Permit: AWC800043 Owner: Shelbia C Foster Facility Number: 800043 Inspection Date: 12/06/18 Inspection Type: Compliance Inspection Reason for Visit: Routine Regulated Operations Design Capacity Current promotions Cattle Cattle - Milk Cow 500 I 434 Total Design Capacity: 500 Total SSLW: 700,000 Waste Structures Effective Built Closed Designated Observed Type Identifier Date Date Date Freeboard Freeboard Waste Pond CARSON ROAD 07/17/2005 18.00 48.00 Page 2 of 5 Permit: AWC800043 Owner: Shelbia C Foster Facility Number: 800043 Inspection Date: 12/06/18 Inspection Type: Compliance Inspection Reason for Visit: Routine Discharges & Stream Impacts Yes No NA NE 1. Is any discharge observed from any part of the operation? ❑ MEIEI Discharge originated at: Structure ❑ Application Field ❑ Other ❑ a. Was conveyance man-made? ❑ ❑ 0 ❑ b. Did discharge reach Waters of the State? (if yes, notify DWQ) ❑ ❑ 0 ❑ c. What is the estimated volume that reached waters of the State (gallons)? d. Does discharge bypass the waste management system? (if yes, notify DWQ) ❑ ❑ 0 ❑ 2. Is there evidence of a past discharge from any part of the operation? ❑ 0 ❑ ❑ 3. Were there any observable adverse impacts or potential adverse impacts to Waters of the ❑ 0 ❑ ❑ State other than from a discharge? Waste Collection, Storage & Treatment Yes No NA NE 4. Is storage capacity less than adequate? ❑ 0 ❑ ❑ If yes, is waste level into structural freeboard? ❑ 5. Are there any immediate threats to the integrity of any of the structures observed (Le./ large ❑ 0 ❑ ❑ trees, severe erosion, seepage, etc.)? 6. Are there structures on -site that are not properly addressed and/or managed through a ❑ MEI ❑ waste management or closure plan? 7. Do any of the structures need maintenance or improvement? ❑ MEI ❑ 8. Do any of the structures lack adequate markers as required by the permit? (Not applicable ❑ 0 ❑ ❑ to roofed pits, dry stacks and/or wet stacks) 9. Does any part of the waste management system other than the waste structures require ❑ 0 ❑ ❑ maintenance or improvement? Waste Application Yes No NA NE 10. Are there any required buffers, setbacks, or compliance alternatives that need ❑ 0 ❑ ❑ maintenance or improvement? 11. Is there evidence of incorrect application? ❑ 0 ❑ ❑ If yes, check the appropriate box below. Excessive Ponding? ❑ Hydraulic Overload? ❑ Frozen Ground? ❑ Heavy metals (Cu, Zn, etc)? ❑ PAN? ❑ Is PAN > 10%/10 lbs.? ❑ Total Phosphorus? ❑ Failure to incorporate manure/sludge into bare soil? ❑ Outside of acceptable crop window? ❑ Evidence of wind drift? ❑ Application outside of application area? ❑ Crop Type 1 Corn (Silage) Page 3 of 5 Permit: AWC800043 Owner: Shelbia C Foster Inspection Date: 12/06/18 Inspection Type: Compliance Inspection Facility Number: Reason for Visit: 800043 Routine Waste Application Yes No NA NE Crop Type 2 Soybean, Wheat Crop Type 3 Crop Type 4 Crop Type 5 Crop Type 6 Soil Type 1 Soil Type 2 Soil Type 3 Soil Type 4 Soil Type 5 Soil Type 6 14. Do the receiving crops differ from those designated in the Certified Animal Waste ❑ 0 ❑ ❑ Management Plan(CAWMP)? 15. Does the receiving crop and/or land application site need improvement? ❑ 0 ❑ ❑ 16. Did the facility fail to secure and/or operate per the irrigation design or wettable acre ❑ ❑ 0 ❑ determination? 17. Does the facility lack adequate acreage for land application? ❑ 0 ❑ ❑ 18. Is there a lack of properly operating waste application equipment? ❑ 0 ❑ ❑ Records and Documents Yes No NA NE 19. Did the facility fail to have Certificate of Coverage and Permit readily available? ❑ 0 ❑ ❑ 20. Does the facility fail to have all components of the CAWMP readily available? ❑ 0 ❑ ❑ If yes, check the appropriate box below. WUP? ❑ Checklists? ❑ Design? ❑ Maps? ❑ Lease Agreements? ❑ Other? ❑ If Other, please specify 21. Does record keeping need improvement? ❑ ❑ ❑ If yes, check the appropriate box below. Waste Application? ❑ Weekly Freeboard? ❑ Waste Analysis? ❑ Soil analysis? ❑ Waste Transfers? ❑ Weather code? ❑ Rainfall? ❑ Stocking? ❑ Crop yields? ❑ Page 4 of 5 Permit: AWC800043 Owner: Shelbia C Foster Facility Number: Inspection Date: 12/06/18 Inspection Type: Compliance Inspection Reason for Visit: 800043 Routine Records and Documents Yes No NA NE 120 Minute inspections? ❑ Monthly and 1" Rainfall Inspections ❑ Sludge Survey ❑ 22. Did the facility fail to install and maintain a rain gauge? ❑ 0 ❑ ❑ 23. If selected, did the facility fail to install and maintain a rainbreaker on irrigation equipment ❑ ❑ 0 ❑ (NPDES only)? 24. Did the facility fail to calibrate waste application equipment as required by the permit? ❑ 0 ❑ ❑ 25. Is the facility out of compliance with permit conditions related to sludge? If yes, check the ❑ ❑ 0 ❑ appropriate box(es) below: Failure to complete annual sludge survey ❑ Failure to develop a POA for sludge levels ❑ Non -compliant sludge levels in any lagoon ❑ List structure(s) and date of first survey indicating non-compliance: 26. Did the facility fail to provide documentation of an actively certified operator in charge? ❑ ❑ ❑ 27. Did the facility fail to secure a phosphorous loss assessment (PLAT) certification? ❑ ❑ ❑ Other Issues Yes No NA NE 28. Did the facility fail to properly dispose of dead animals within 24 hours and/or document ❑ 0 ❑ ❑ and report mortality rates that exceed normal rates? 29. At the time of the inspection did the facility pose an odor or air quality concern? If yes, ❑ 0 ❑ ❑ contact a regional Air Quality representative immediately. 30. Did the facility fail to notify regional DWQ of emergency situations as required by Permit? ❑ 0 ❑ ❑ (i.e., discharge, freeboard problems, over -application) 31. Do subsurface tile drains exist at the facility? ❑ 0 ❑ ❑ If yes, check the appropriate box below. Application Field ❑ Lagoon / Storage Pond ❑ Other ❑ If Other, please specify 32. Were any additional problems noted which cause non-compliance of the Permit or ❑ 0 ❑ ❑ CAW M P? 33. Did the Reviewer/Inspector fail to discuss review/inspection with on -site representative? ❑ 0 ❑ ❑ 34. Does the facility require a follow-up visit by same agency? ❑ 0 ❑ ❑ Page 5 of 5