NC0028941_AUTHORIZATION TO CONSTRUCT_20051001

NPDES DOCUMENT SCANNINL COVER SHEET
NPDES Permit: NCO028941 ,
Pine Valley WWTP
Document Type: Permit Issuance
Wasteload Allocation
' of to f34S-i•�i—.��Y.i+ : Ni F� : ...tly a.
Aiyutth`orization to Construct
(AtC)
Permit Modification
Speculative Limits
Complete File - Historical
Instream Assessment (F?B)
Environmental Assessment (EA)
Permit
History '
Document Date: October 1, 2005
This document is priated oa reuse paper-igaorc May
coateat oa the reverse aide '

Pine Valley Subdivision
A to C No. 028941 AO
Issued July 8, 2005
Engineer's Certification
I, T ��H2n a '.G as a duly registered Professional Engineer in
the State of North Carolina, having been authorized to observe (periodically/weekly/full time)
the construction of the modifications and improvements to the Pine Valley Subdivision WWTP
located on State Road 1802 in Rowan County for Aqua North Carolina, Inc., hereby state that, to
the best of my abilities, due care and diligence was used in the observation of the following
construction:
Installation of a tablet dechlorination system pursuant to the fast track application
received on July 7, 2005, and in conformity with the Minimum Design Criteria
for Dechlorination Facilities.
I certify that the construction of the above referenced project was observed to be built
within substantial compliance and intent of the approved plans and specifications.
Signature-. L1 Registration No. /c, ¢3 z,
Date G o 2 e J-�
Send to: Construction Grants & Loans44!
DENR/DWQ
1633 Mail Service Center �! . • 10A,
?6�F
Raleigh, NC 27699-1633 / =�2f ' Gif ;:
RECEIVED
OfT u. o z'O:"s
UOSt: •r^ i

�JpF�`NA7-Fq Michael F.Easley.Governor
o' \ William G. Ross rary
\l r North Carolina Department of finvironment and Naturaall Resource's
^( Alan W.Klimek,P.E. Director
Division or Water Quality
July 8, 2005
Mr. Michael Myers
Aqua North Carolina, Inc.
P.O. Box 4889
Cary, North Carolina 27519
SUB.IECT: Authorization to Construct
A to C No. 028941 AO
Pine Valley Subdivision W WTP
Dechlorination Facilities
Rowan County
Dear Mr. Myers:
A fast track application for Authorization to Construct dechlorination facilities was
received on July 7, 2005, by the Division. Authorization is hereby granted for the construction of
modifications to the existing Pine Valley Subdivision W WTP, with discharge of treated
wastewater into Setman Branch in the Yadkin-Pee Dee River Basin.
This authorization results in no increase in design or permitted capacity and is awarded
for the construction of the following specific modifications:
Installation of a tablet dechlorination system pursuant to the fast track application
received on July 7, 2005, and in conformity with the Minimum Design Criteria
for Dechlorination Facilities.
This Authorization to Construct is issued in accordance with Part 111, Paragraph A of
NPDES Permit No. NCO028941 issued April M, 2004, and shall be subject to revocation unless
the wastewater treatment facilities arc constructed in accordance with the conditions and
limitations specified in Permit No. NCO028941.
In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as may
be required by this Division, such as the construction of additional or replacement wastewater
treatment or disposal facilities.
The Mooresville Regional Office, telephone number [phone], shall be notified at
least forty-eight (48) hours in advance of operation of the installed facilities so that an on site
Nor`hCarolina
Xi l turu!!y
North Carolina Division of Water Quality 1617 Nlail Service Cenrcr Raleigh.NC 27699-1617 Phone[phone]: Customer Sen iee
Internet: h2o.encslate.nc.us _12 N.Salisbury St. Raleigh.NC 27604 FAX [phone] 1-377-623-6748
An Equal OpportunitylAffirmarve Acton Employer—5095 Recycledl10%Post Consumer Paper

Mr. Michael Myers
July 8, 2005
Page 2
inspection can be made. Such notification to the regional supervisor shall be made during the
normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding State
Holidays.
Pursuant to 15A NCAC 2H .0140, upon completion of construction and prior to operation of
these permitted facilities, the completed Engineering Certification form attached to this permit shall be
submitted to the address provided on the form.
Upon classification of the facility by the Certification Commission, the Pennittee shall
employ a certified wastewater treatment plant operator to be in responsible charge (ORC) of the
wastewater treatment facilities. The operator must hold a certificate of the type and grade at least
equivalent to or greater than the classification assigned to the wastewater treatment facilities by
the Certification Commission.
The Permittee must also employ a certified back-up operator of the appropriate type and
grade to comply with the conditions of T 15A:8G.0202. The ORC of the facility must visit each
Class I facility at least weekly and each Class 11, III and IV facility at least daily, excluding
weekends and holidays, must property manage the facility, must document daily operation and
maintenance of the facility, and must comply with all other conditions of T 15A:8G.0202.
A copy of the approved plans and specifications shall be maintained on file by the
Permittee for the life of the facility.
During the construction of the proposed additions/modifications, the permittee shall
continue to properly maintain and operate the existing wastewater treatment facilities at all times,
and in such a manner, as necessary to comply with the effluent limits specified in the NPDES
Permit.
You are reminded that it is mandatory for the project to be constricted in accordance
with the North Carolina Sedimentation Pollution Control Act, and, when applicable, the North
Carolina Dam Safety Act. In addition, the specifications must clearly state what the contractor's
responsibilities shall be in complying with these Acts.
Failure to abide by the requirements contained in this Authorization to Construct may
subject the Permittee to an enforcement action by the Division of Water Quality in accordance
with North Carolina General Statute 143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not preclude the Permittee from
complying with any and all statutes, rules, regulations, or ordinances which may be imposed by
other government agencies (local, state, and federal) which have jurisdiction.

Mr. Michael Myers
July 8, 2005
Page 3
If you have any questions or need additional information, please do not hesitate to contact
Cecil G. Madden, Jr., P.E. at telephone number [phone].
Sincerely,
Alan W. Klimek, P.E.
MH/cgm
cc: .I. Thurman Horne, P.E. - Horizon Engineering & Consulting, Inc.
Rowan County Health Department
Mooresville Regional Office, Surface Water Protection Section
Technical Assistance and Certification Unit
Daniel Blaisdell, P.E.
Point Source Branch, NPDES Program
Cecil G. Madden, Jr., P.E.
Mark Hubbard, P.E.
A to C File