NC0050661_Authorization to Construct_20070322 (2)

May 08 06 10:28a McDRVID RSSOCIRTES, IMC. 919-735-7351 P.4
The Town of Macclesfield
Macclesfield WWTP
A to C No.050661 AO
Issued May 3,2006
Engineer's Certification
I, Charles Joyner, -Ir. . PE . as a duly registered professional Engineer in
the State of North Carolina,having been authorized to observe (periodically/weekly/full time)
the construction of the modifications and improvements to the Macclesfield WWTP located on
Fountain Road in Edgecombe County for The Town of Macclesfield,hereby state that, to the
best of my abilities,due care and diligence was used in the observation of the following
construction:
Installation of dechlorination equipment to utilize Calcium Thiosulfate Solution
pursuant to the fast track application received on May 3,2006,and in conformity
with the Minimum Design Criteria for Dechlorination Facilities.
I certify that th 'on of the above referenced project was observed to be built
within substantial nt of the approved plans and specifications.
4 8718
Signature Registration No.
Date 2 2 0 �
Q
Send to: Cons coon Grants&Loans a�0
DENR/DWQ Q, ¢+p 0�Q
1633 Maul Service Center p rq m
Raleigh,NC 27699-1633 S
EAL
,� 1972 Q,
��V1i.LE
tih
• r

�0 NI A TERQ Michael F.Easley,Governor
William G.Ross Jr.,Secretary
r North Carolina Department of Environment and Natural Resources
C Alan W.Klimek,P.E.Director
Division of Water Quality
May 3, 2006
Mr. Mike Keel
Town of Macclesfield
PO Box 185
Macclesfield, NC 27852-0185
SUBJECT: Authorization to Construct
A to C No. 050661 A01
Town of Macclesfield
Macclesfield WWTP
Dechlorination Facilities
Edgecombe County
Dear Mr. Keel:
A fast track application for Authorization to Construct dechlorination facilities was
received on May 3, 2006, by the Division. Authorization is hereby granted for the construction of
modifications to the existing Macclesfield WWTP, with discharge of treated wastewater into
Bynums Mill Creek in the Tar-Pamlico River Basin.
This authorization results in no increase in design or permitted capacity and is awarded
for the construction of the following specific modifications:
Installation of dechlorination equipment to utilize Calcium Thiosulfate Solution
pursuant to the fast track application received on May 3, 2006, and in conformity
with the Minimum Design Criteria for Dechlorination Facilities.
This Authorization to Construct is issued in accordance with Part III, Paragraph A of
NPDES Permit No. NCO050661 issued October 29, 2004, and shall be subject to revocation
unless the wastewater treatment facilities are constructed in accordance with the conditions and
limitations specified in Permit No. NCO050661.
In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as may
be required by this Division, such as the construction of additional or replacement wastewater
treatment or disposal facilities.
The Raleigh Regional Office, telephone number(919) 791-4200, shall be notified at least
forty-eight (48) hours in advance of operation of the installed facilities so that an on site
o`
NhCarolina
NlaurallY
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh,NC 27699-1 6 1 7 Phone[phone] Customer Service
Internet; h2o.enr.state.nc.us 512 N.Salisbury St. Raleigh,NC 27604 FAX [phone] 1-877-623-6748
An Equal Opportunity/Affirmative Action Employer—50%Recycled/10%Post Consumer Paper

Mr. Mike Keel
May 3, 2006
Page 2
inspection can be made. Such notification to the regional supervisor shall be made during the
normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding State
Holidays.
Pursuant to 15A NCAC 2H .0140, upon completion of construction and prior to operation of
these permitted facilities, the completed Engineering Certification form attached to this permit shall be
submitted to the address provided on the form.
Upon classification of the facility by the Certification Commission, the Permittee shall
employ a certified wastewater treatment plant operator to be in responsible charge (ORC) of the
wastewater treatment facilities. The operator must hold a certificate of the type and grade at least
equivalent to or greater than the classification assigned to the wastewater treatment facilities by
the Certification Commission.
The Permittee must also employ a certified back-up operator of the appropriate type and
grade to comply with the conditions of T15A:8G.0202. The ORC of the facility must visit each
Class I facility at least weekly and each Class II, III and IV facility at least daily, excluding
weekends and holidays, must properly manage the facility, must document daily operation and
maintenance of the facility, and must comply with all other conditions of T15A:8G.0202.
A copy of the approved plans and specifications shall be maintained on file by the
Permittee for the life of the facility.
During the construction of the proposed additions/modifications, the permittee shall
continue to properly maintain and operate the existing wastewater treatment facilities at all times,
and in such a manner, as necessary to comply with the effluent limits specified in the NPDES
Permit.
You are reminded that it is mandatory for the project to be constructed in accordance
with the North Carolina Sedimentation Pollution Control Act, and, when applicable, the North
Carolina Dam Safety Act. In addition, the specifications must clearly state what the contractor's
responsibilities shall be in complying with these Acts.
Failure to abide by the requirements contained in this Authorization to Construct may
subject the Permittee to an enforcement action by the Division of Water Quality in accordance
with North Carolina General Statute 143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not preclude the Permittee from
complying with any and all statutes,rules, regulations, or ordinances which may be imposed by
other government agencies (local, state, and federal) which have jurisdiction.

Mr. Mike Keel
May 3, 2006
Page 3
If you have any questions or need additional information, please do not hesitate to contact
Cecil G. Madden, Jr., P.E. at telephone number(919) 715-6203.
Sincerel?mel
r6c Alan , P
MM/cgm
cc: Charles A. Joyner, Jr., P.E., McDavid Associates, Inc.
Edgecombe County Health Department
Raleigh Regional Office, Surface Water Protection Section
Technical Assistance and Certification Unit
Daniel Blaisdell, P.E.
Point Source Branch, NPDES Program
Cecil G. Madden, Jr., P.E.
Michelle McKay
A to C File