NC0020338_AUTHORIZATION TO CONSTRUCT_19910131

d100Rn1L�4
r�
• i
State of North Carolina
Department of Environment, Health and Natural Resources
Division of Environmental Management
512 North Salisbury Street • Raleigh, North Carolina 27611
James G. Martin,Governor George T. Everett,Ph.D.
William W. Cobey,Jr., Secretary Director
January 31, 1991
Mr. Jerry Carlton, Town Manager
Town of Yadkinville
Post Office Drawer 816
Yadkinville,North Carolina 27055
Subject: Permit No. NCO020338
Authorization to Construct
Town of Yadkinville
Wastewater Treatment Facility
Effluent Pump Station and Relocation
of Discharge Point
Yadkin County ,
• Dear Mr. Carlton:
A letter of request for an Authorization to Construct was received December 13, 1990 by
the Division and final plans and specifications for the subject project have been reviewed and found
to be satisfactory. Authorization is hereby granted for the construction of a 2.0 MGD effluent
pump station and force main (to relocate the treatment works discharge point) consisting of a 10
foot by 20 foot by 13 foot wet well with high water alarms, one 700 GPM pump and two 1,400
GPM pumps, approximately 3,495 linear feet of 16-inch ductile iron force main, approximately
195 linear feet of 24-inch gravity effluent line, a discharge point head wall with rip rap outlet
protection, and all associated piping, valves, vents, air release valves, and appurtenances with
discharge of treated wastewater into North Deep Creek,classified Class C waters.
This Authorization to Construct is issued in accordance with Part III paragraph B of
NPDES Permit No. NCO020338 issued February 1, 1991, and shall be subject to revocation .
unless the wastewater treatment facilities are constructed in accordance with the conditions and
limitations specified in Permit No. NC0020338.
The sludge generated from these treatment facilities must be disposed of in accordance with
G.S. 143-215.1 and in a manner approved by the North Carolina Division of Environmental
Management.
No sludge or solids of any kind shall be allowed to accumulate at the bottom of the effluent
pump station wet well or the manhole at the end of the effluent force main.
In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action,including those as may be
• required by this Division, such as the construction of additional or replacement wastewater
treatment or disposal facilities.
Pollution Prevention Pays
P.O.Box 27687,Raleigh,North Carolina 27611-7687 'telephone [phone]
An Equal Opportuniry Affirmative Action Employer

The Winston-Salem Regional Office, phone no. 919/ 761-2351 shall be notified at least
forty-eight (48) hours in advance of operation of the installed facilities so that an in-place
inspection can be made. Such notification to the regional supervisor shall be made during the •
normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding State
Holidays.
Upon completion of construction and prior to operation of this permitted facility, a
certification must be received from a professional engineer certifying that the permitted facility has
been installed in accordance with the NPDES Permit, this Authorization to Construct and the
approved plans and specifications. Mail the Certification to the Permits and Engineering Unit,
P.O. Box 27687, Raleigh, NC 27611.
Construction of the subject facilities shall not allow any bypassing of wastewater from the
treatment facilities, or allow any discharge of effluent other than at the discharge points allowed by
the NPDES Permit.
The Permittee shall employ a certified wastewater treatment plant operator to be in
responsible charge of the wastewater treatment facilities. The operator must hold a certificate of the
grade at least equivalent to the classification assigned to the wastewater treatment facilities by the
Certification Commission.
A copy of the approved plans and specifications shall be maintained on file by the Permittee
for the life of the facility.
Failure to abide by the requirements contained in this Authorization to Construct may
subject the Permittee to an enforcement action by the Division of Environmental Management in
accordance with North Carolina General Statute 143-215.6.
The issuance of this Authorization to Construct does not preclude the Permittee from, .
complying with any and all statutes, rules, regulations, or ordinances which may be imposed by
other government agencies (local, state, and federal) which have jurisdiction.
One (1) set of approved plans and specifications is being forwarded to you. If you have
any questions or need additional information, please contact Mr. John Seymour, telephone
number 919/733-5083.
Sin erely,
eorge T. Eve
cc: Yadkin County Health Department
Winston-Salem Regional Office
Training and Certification Unit
•