NCG200489_COMPLETE FILE - HISTORICAL_20140421

zJAD
STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
/V
DOC TYPE
R- HISTORICAL FILE
❑ MONITORING REPORTS
DOC DATE
❑ J O i y�/ c
YYYYM M DD

STATE OF NORTH CAROLINA —7
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG200000
CERTIFICATE OF COVERAGE No. NCG200489 - CL
i
STORM WATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Sadler Salvage Yard, LLC
is hereby authorized to discharge stormwater from a facility located at
Sadler Salvage Yard
800 J.P. Taylor Rd.
Henderson
Vance County
to receiving waters designated as an UT to Sandy Creek, a class C; NSW:+ water in the Tar -
Pamlico River Basin, in accordance with the effluent limitations, monitoring requirements, and
other conditions set forth in Parts I, 11, III, IV, V, and VI of General Permit No. NCG200000 as
attached.
This certificate of coverage shall become effective December 7, 2012.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day December 7, 2012.
for Charles Wakild, P.E., Director
Division of Water Quality
By the Authority of the Environmental Management Commission

r
NCD-ENR
North Carolina Department of Environment and Natural Resources
Division of Energy, Mineral and Land Resources
Land Quality Section Pat McCrory, Governor
Tracy E. Davis, PE, CPM John E. Skvarla, III, Secretary
Director
March 7. 2014
CERTIFIED MAIL 70121640 0001 9605 7782
RETURN RECEIPT REQUESTED
Mr. Frank Sadler
Sadler's Recycling Center
P. 0. Box 151
Brodnax, Virginia 23902
h\'� '.I 7
i APR 2 1 2014
r
Subject: Sadler's Recycling Center
8001. P. Taylor Road
Henderson, North Carolina 27536
Illegal Discharge/Unpermitted Facility
Vance County
Dear Mr. Sadler:
This letter is being sent to address an illegal discharge that was reported to the Division of Energy, Mineral and
Land Resources (DEMLR) on December 13, 2013. The concern is the lack of an NPDES stormwater permit
and the required monitoring for a facility of this type. A site visit was conducted on December 20, 2013. Dave
Parnell, of the DEMLR Raleigh Regional Office conducted the site visit, after receiving the complaint.
During the site visit, it was observed that a large number of salvaged vehicles were being stored on the site. Mr.
Parnell spoke with an employee by the name of Curtis, who stated that he thought the City of Henderson was
involved with the facility's stormwater program. A business card was received that stated that the facility buys
steel, copper, aluminum and brass. Therefore, it is apparent that a facility such as this, requires a NPDES
Stormwater permit.
Please note that the release of stormwater from an unpermitted used motor vehicle or scrap metal facility is a
violation of the following North Carolina General Statutes:
1628 Mail service Center, Raleigh, North Carolina 27699-1628
Location: 3800 Barrett Drive, Raleigh, North Carolina 27609 One
Phone: 919-791A2001 FAX: [phone] NOrthCarOlina
Internet: pport r-4a nc Affirmative
ActionlE Naturally
An Equal OpponunitylAKrmative Action Employer l�[ FL "

4 -,.
Ar
NC®ENR
North Carolina Department of Environment and Natural Resources
Beverly Eaves Perdue
Governor
Mr. Frank G. Sadler, Jr.
Sadler Salvage Yard, LLC
P.O. Box 151
Brodnax, VA 23920
Dear Mr. Sadler:
Division of Water Quality
Charles Wakild, P.E.
Director
December 7, 2012
Subject: General Permit No. NCG
Sadler Salvage Yard
COC NCG200409
Vance County
Dee Freeman
Secretary _
`11 JJ
LI
In accordance with your application for a discharge permit received on October 30, 2012, we
are forwarding herewith the subject certificate of coverage to discharge under the subject state -
NPDES general permit. This permit is issued pursuant to the requirements of North Carolina General
Statute 143-215.1 and the Memorandum of Agreement between North Carolina and the US
Environmental Protection Agency dated October 15, 2007 (or as subsequently amended).
Please take notice that this certificate of coverage is not transferable except after notice to the
Division of Water Quality. The Division of Water Quality may require modification or revocation and
reissuance of the certificate of coverage.
Per the requirements of the Tar -Pamlico Riparian Buffer Rule, all stormwater drainage to
stream buffers, from portions of this site that have been constructed after January 1, 2000, must be
discharged through a correctly designed level spreader or another device that meets diffuse flow
requirements per 15A NCAC 26.0259. Diffuse Flow requirements are described in Chapter 8 of the
North Carolina Stormwater BMP Manual, available at:
httl?://portal.ncdenr.org/web/wq/ws/su/bmp-manual.
This permit does not affect the legal requirements to obtain other permits which may be
required by the Division of Water Quality or permits required by the Division of Land Resources,
Coastal Area Management Act or any other federal or local governmental permit that may be
required.
If you have any questions concerning this permit, please contact Robert Patterson at
telephone number [phone], or at [e-mail].
Sincerely,
D� cc: Danny Smith - Raleigh Regional Office
/K) Central Files
for Charles Wakild, P.E. Stormwater Permitting Unit Files
Wetlands and Stonnwater Branch
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604
Phone: [phone] FAX: 91 M07-6494
internet: www.ncwaterquallty.org
An Equal Opportunity 1 Affirmative Action Employer
NorthCarcllina
Naturally

NCG200489
Map Scale 124, 000
Sadler Salvage Yard, LLC
Sadler Salvage Yard
Latitude: 360 17' 47" N
Longitude: 78' 24' 09" W
County: Vance
Receiving Stream: UT to Sandy Creek
Stream Index No): 28-78-1-(1)
Stream Class: C; NSW: +
Rivar Racin• Tar - Pamlirn
Facility Location

Compliance Inspection Report
Permit: NCG200489 Effective: 12/07/12 Expiration: 12/31/14 Owner: Sadler Salvage Yard LLC
SOC: Effective: Expiration: Facility: Sadler Salvage Yard
County: Vance 800 JP Taylor Rd
Region: Raleigh
Henderson NC 27537
Contact Person: Frank G Sadler Title: Phone: [phone]
Directions to Facility:
from us north 1 towards henderson nc take us 1 business east/raleigh rd turn right onto j.p. taylor rd destination will be on the left
System Classifications:
Primary ORC: Certification: Phone:
Secondary ORC(s):
On -Site Representative(s):
Related Permits:
Inspection Date: 12/13/2013 Entry Time: 11:00 AM Exit Time: 12:00 PM
Primary Inspector: David R Parnell Phone: [phone]
Secondary Inspector(s):
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Wholesale Trade of Metal Waste and Scrap Stormwater
Discharge COC
Facility Status: ❑ Compliant ❑ Not Compliant
Question Areas:
0 Storm Water
(See attachment summary)
Page: 1

Permit: NC6200489 Owner -Facility: Sadler Salvage Yard LLC
Inspection Date: 12/13/2013 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Inspection Summary:
Following up on a complaint that oily sheered stormwater was leaving this site, Dave Parnell visited the site. Checking
under Sadler's Recycling Center (name on the business card given to Parnell), there was no facility in BIMS by that name
and no one on site this day could give documenation that the facility has a stormwater permit. After calling the facilty and
receiving no documentation of permitting, a letter was issued asking for the facility to be permitted. Parnell made the
decision not to issue an NOV or NOD but in effort to prod them towards compliance. On April 21, 2014 a copy of the
letter was sent to DEMLR and a copy of the permitted in the name of Sadler Salvage Yard dated 12-7-12. drp
Page: 2

00
C r
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Energy, Mineral and Land Resources
Land Quality Section Pat McCrory, Governor
Tracy E. Davis, PE, CPM John E. Skvarla, III, Secretary
Director
January 8, 2014
CERTIFIED MAIL 70121640 0001 9605 7775
RETURN RECEIPT REQUESTED
Mr. Frank Sadler
Sadler's Recycling Center
800 J. P. Taylor Road
Henderson, North Carolina 27536
Subject: Sadler's Recycling Center
Illegal Discharge/Unpermitted Facility
Vance County
Dear Mr. Sadler:
This letter is being sent to address an illegal discharge that was reported to the Division of Energy, Mineral and
Land Resources (DEMLR) on December 13, 2013. The concern is the lack of an NPDES stormwater permit
and the required monitoring for a facility of this type. A site visit was conducted on December 20, 2013. Dave
Parnell, of the DEMLR Raleigh Regional Office conducted the site visit, after receiving the complaint.
During the site visit, it was observed that a large number of salvaged vehicles were being stored on the site. Mr.
Parnell spoke with an employee by the name of Curtis, who stated that he thought the City of Henderson was
involved with the facility's stormwater program. A business card was received that stated that the facility buys
steel, copper, aluminum and brass. Therefore, it is apparent that a facility such as this, requires a NPDES
Stormwater permit.
Please note that the release of storm water from an unpermitted used motor vehicle or scrap metal facility is a
violation of the following North Carolina General Statutes:
1628 Mail service Center, Raleigh, North Carolina 27699-1628
Location: 3800 Barrett Drive, Raleigh, North Carolina 27609 One
Phone: [phone] FAX: [phone] North Caro 1 i na
Internet: hqpppor,portaLncden mativeActionE Naturally
An Equal Opportunity 1 Affirmative Action Employer

Article 21. Water and Air Resources
NCGS 143-21 5.l (a) Activities for Which Permits Required. -No person shall do any of the following things or
carry out any of the following activities unless that person has received a permit from the Commission and has
complied with all conditions set forth in the permit:
Make any outlets into the waters of the State.
To avoid any penalties, please submit the attached Notice of Intent to the Stormwater Permitting Program
within thirty (30) days of the receipt of this correspondence. Contact Dave Parnell of the Regional Office at
919 791-4200 or Ken Pickle of the Stormwater Permitting Program at 919 807-6376 with any questions
pertaining to the permitting process.
Raleigh Regional Office
cc: 'Stormwater Permitting Program Files - with attachment
DEMLR Raleigh Regional Office Files - with attachment
1628 Mail Service Center, Raleigh, North Carolina 27699-1628
Location: 3800 Barrett Drive, Raleigh, North Carolina 27609 One
Phone: [phone] FAX: [phone] North C aro l i n a
Internet: ppo:portaLncrmabve Action
Nat�Nn //y
An Equal Oppoduniry, \ Affirmative Action Employer { !Z`/lI

�� Division of Water Quality
A e
NCDENRNational Pollutant Discharge Elimination System
ExxiROII NGRO D N Dcw.w+xcn� o�
oxx[wr NawY Rcep,wcc
NCG200000
NOTICE OF INTENT
National Pollutant Discharge Elimination System application for coverage under General Permit NCG200000:
STORMWATER DISCHARGES associated with activities classified as:
SIC 5093 Scrap Metal Recycling (except as specified below)
SIC* NIA Like activities deemed by DWQ to be similar in the process and/or the exposure of raw materials,
products, by-products, or waste materials
The following activities are specifically excluded from coverage under this General Permit:
Automobile Wrecking for Scrap (SIC 5093)
Non -Metal Scrap Recycling (SIC 5093)
Used Motor Vehicle Parts (SIC 5015)
* Standard Industrial Classification Code
1) Mailing address of owner/operator: (address to which all permit correspondence will be mailed):
Name
Street Address
City
Telephone No.
E-mail Address
2) Location of facility producing discharge:
Facility Name
Fax:
ZIP Code
Facility Contact
Contact E-mail
Street Address
City State ZIP Code
County
Telephone No. Fax:
3) Physical Location Information:
Narrative description of how to get to the facility (use street names, state road numbers, and distance and direction
from a roadway intersection).
(A copy of a county map or USGS quad sheet with facility clearly located on the map is required to be submitted with
this application)
4) Latitude Longitude (degrees, minutes, seconds)
5) This NPDES Permit Application applies to which of the following :
❑ New or Proposed Facility Date operation is to begin
❑ Existing
6) Standard Industrial Classification:
Provide the 4 digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial activity at
this facility:
SIC Code:
7) Provide a brief description of the types of industrial activities and products produced at this facility:
Page 1 of 3
SWU-235-11.16.09

NCG200000 N.O.I.
8) Discharge points:
How many discharge points (ditches, pipes, channels, etc.) convey stormwater from the property?
Receiving water classification (if known):
9) Receiving waters:
What is the name of the body or bodies of water (creek, stream, river, lake, etc.) that the facility stormwater
discharges end up in?
Receiving water classification (if known):
If the site stormwater discharges to a separate storm sewer system, name the operator of the separate storm sewer
system (e.g. City of Raleigh municipal storm sewer).
10) Does this facility have any other NPDES permits?
❑ No U
❑ Yes
If yes, list the permit numbers for all current N PDES permits for this facility:
11) Does this facility have any Non -Discharge permits (ex: recycle permits)?
❑ No
❑ Yes
If yes, list the permit numbers for all current Non -Discharge permits for this facility:
12) Does this facility employ any best management practices for stormwater control?
❑ No
❑ Yes
If yes, please briefly describe:
13) Does this facility have a Stormwater Pollution Prevention Plan?
❑ No
❑ Yes
If yes, when was it implemented?
14) Are vehicle maintenance activities occurring at this facility?
❑ No
❑ Yes
15) Hazardous Waste:
a) Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility?
iD No
❑ Yes
b) Is this facility a Small Quantity Generator (less than 1000 kg. of hazardous waste generated per month) of
hazardous waste?
❑ No
❑ Yes
c) Is this facility a Large Quantity Generator (1000 kg. or more of hazardous waste generated per month) of
hazardous waste?
❑ No
❑ Yes
d) If you answered yes to questions b. or c., please provide the following information:
Page 2 of 3
SWU-235-11.16.09

NCG200000 N.O.I.
Type(s) of waste:
How is material stored:
Where is material stored:
How many disposal shipments per year:
Name of transport / disposal vendor:_
Vendor address:
16) Certification:
North Carolina General Statute 143-215.6 b (i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan, or other
document filed or required to be maintained under this Article or a rule implementing this Article; or who knowingly makes a false
statement of a material fact in a rulemaking proceeding or contested case under this Article; or who falsifies, tampers with, or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
[Environmental Management] Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine not to
exceed ten thousand dollars ($10,000).
I hereby request coverage under the referenced General Permit. I understand that coverage under this permit will
constitute the permit requirements for the discharge(s) and is enforceable in the same manner as an individual permit.
I certify that I am familiar with the information contained in this application and that to the best of my knowledge and
belief such information is true, complete, and accurate.
Printed Name of Person Signing:
Title:
(Signature of Applicant) (Date Signed)
Final Checklist
This application will be returned as incomplete unless all of the following items have been included:
❑ Check for $100 made payable to NC DENR
❑ This completed application and all supporting documents
❑ Copy of county map or USGS quad sheet with location of
facility clearly marked on map
Mail the entire package to: Stormwater Permitting Unit
Division of Energy, Mineral and Land Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Note
The submission of this document does not guarantee the issuance of an NPDES permit.
For questions, please contact the DWQ Central Office or Regional Office for your area.
DWQ Regional Office Contact Information:
Asheville Office ......
[phone]
Fayetteville Office ...
[phone]
Mooresville Office ...
[phone]
Raleigh Office ........
[phone]
Washington Office ...(252)
946-6481
Wilmington Office ...
[phone]
Winston-Salem ......
[phone]
Central Office .........(919)
807-6300
Page 3 of 3
SWU-235-11.16.09