NCG170172_COMPLETE FILE - HISTORICAL_20101011

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
/v I o -
DOC TYPE
E�HISTORICAL FILE
❑ MONITORING REPORTS
DOC DATE
❑ J b I D r--o I I
YYYYM M D D

Edgerton, Thom
From: Edgerton, Thom
Sent: Monday, October 11, 2010 5:12 PM
To: '[e-mail]'
Subject: DWQ Web Site Infromation and General Notes Regarding the Site Visit
Hello,
The following is the link to the web page which contains the General Permits:
http://portal.ncdenr.org/web/wq/ws/su/npdessw#Application Forms NPDES
I am surprised that the facility's permit does not require analytical monitoring (as does the other permit types at renewal)
unless the operation has on -site vehicle maintenance.
The permit does require yearly reporting to the Regional Office as well as implementation of additional protective
measures (BMP's) upon knowledge that present measures are not adequately protecting water quality.
Also, the permit does not allow for other point source discharges. Therefore, the Boat Builder requires a separate permit.
I will request that NCG170173 be rescinded and that the facility was determined to be in compliance with the conditions of
the permit.
It was nice meeting you today. Please contact me anytime with any questions.
Thanks,
Thom
Thom Edgerton
Environmental Engineer.
NCDENR - DWQ - Surface Water Protection Section
Washington Regional Office
[phone] Phone
[phone] Fax
E-mail correspondence to and from this address may be subject to the North Carolina Public Records law and may be disclosed to third parties.

4
RNA
MOM
North Carolina Department of Environment and Natural Resources
Beverly Eaves Perdue
Governor
Ronald Raynor
National Spinning Company Inc
PO Box 191
Washington, NC 27889-0191
Dear Permittee:
Division of Water Quality
Coleen H. Sullins
Director
August 3, 2009
Dee Freeman
Secretary
Subject: NPDES Stormwater Permit Coverage Renewal
Washington Mill
COC Number NCG170172
Beaufort County
In response to your renewal application for continued coverage under stormwater General Permit NCG170000 the Division of
Water Quality (DWQ) is forwarding herewith the reissued stormwater General Permit. This permit is reissued pursuant to the
requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between the state of North
Carolina and the U.S. Environmental Protection Agency, dated October 15, 2007 (or as subsequently amended.)
The following information is included with your permit package:
• A new Certificate of Coverage
• A copy of stormwater General Permit NCG170000
• A copy of a Technical Bulletin for the General Permit
• Five copies of the Discharge Monitoring Report (DMR) Form
• Five copies of the Qualitative Monitoring Report Form
The General Permit authorizes discharges of stormwater only, and it specifies your obligations with respect to stormwater
discharge controls, management, monitoring, and record keeping. Please review the new permit to familiarize yourself with all the
changes in the reissued permit.
The more significant changes in the General Permit since the your last Certificate of Coverage include the following:
• Permit cover page — Coverage is expanded to include industrial activities similar to the categorically identified industries.
• Part I Section A — This part explains that the No Exposure Exclusion from permitting option may be available to the permittee.
• Part II Section A — Several minor expansions and clarifications of the required content of the Slormwater Pollution Prevention
Plan have been added. Please be sure that your plan is updated to comply with the new requirements.
• Part 11 Section B — Qualitative monitoring must now be conducted during a representative storm event.
• Part 11 Section B — The permittee is required to keep a written record of his response to problems identified by his qualitative
monitoring observations.
• Part II Section C - For facilities with vehicle maintenance activities using more than 55 gallons of new motor oil per month, new
provisions require that discharges from the vehicle maintenance areas be sampled twice per year, and that the sampling
results be compared to new numerical benchmark values. (The previous cutoff concentrations have been eliminated.)
• Part 11 Section C — For facilities with vehicle maintenance activities using more than 55 gallons of new motor oil per month,
new provisions require the permittee to execute Tier One and Tier Two response actions, based on the first benchmark
exceedence (Tier One) and the second consecutive benchmark exceedence (Tier Two). Tier Two requires that the permittee
institute monthly monitoring instead of twice -per -year monitoring, until three consecutive monitoring events show no
benchmark exceedences.
• Part 11 Section C — This part contains a new provision that four exceedences of any particular benchmark will trigger increased
DWQ involvement in the permittee's stormwater management and control actions. DWQ may direct the permittee to apply for
an individual permit, or may direct the implementation or installation of specific stormwater control measures.
Wetlands and Slormwater Branch
1617 Mail Service Center, Raleigh, North Carolina 27699.1617
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604
Phone: 9IM07-63001 FAX: [phone] Customer Service:1-877-623-6748 None Carolina
Internet wwx.ncwaterquatty.org /� // /�
An Equal Opportunity 1 AlfirmMve Action Employer at allif

a
NPDES Stormwater Permit Coverage Renewal
Permit Number NCG170172
August 3, 2009
Page 2
• Part III Section E — Items 1. and 2. require submittal of a new reporting form, the Annual Summary DMR. This annual
summary of only the analytical monitoring results (if any) should be submitted to the local DWQ Regional Office. The Annual
Summary DMR reporting form will be posted on the Stormwater Permitting Unit's website in the near future.
Your coverage under the General Permit is transferable only through the specific action of DWQ.
This permit does not affect the legal requirements to obtain other permits which may be required by DENR, nor does it relieve the
permittee from responsibility for compliance with any other applicable federal, state, or local law, rule, standard, ordinance, order,
judgment, or decree.
If you have any questions regarding this permit package please contact Brian Lowther of the DWQ Stormwater Permitting Unit at
[phone].
Sincerely,
fr Coleen H. Sullins
cc: DWQ Central Files
Stormwater Permitting Unit Files
Washington Regional Office

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG170000
CERTIFICATE OF COVERAGE No. NCG170172
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards
and regulations promulgated and adopted by the North Carolina Environmental Management
Commission, and the Federal Water Pollution Control Act, as amended,
National Spinning Company Inc
is hereby authorized to discharge stormwater from a facility located at
Washington Mill
1481 W 2nd St
Washington
Beaufort County
to receiving waters designated as Washington MSSS and Kennedy Creek, a class C NSW waterbody in
the Tar -Pamlico River Basin in accordance with the effluent limitations, monitoring requirements, and
other conditions set forth in Parts I, Il, III, IV, V, and VI of General Permit No. NCG170000 as attached.
This certificate of coverage shall become effective August 3, 2009.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day August 3, 2009.
for Coleen H. Sullins, Director
Division of Water Quality
By Authority of the Environmental Management Commission

m
LEGEND \
— — PROPERTY BOUNDARY
FENCE LINE
$1 OUTFALL LOCATION / rz r' //-• \\
W � /
llO /y
KENNEDY CREEK #2 BLADDER BAG Q1f �51NLv .% /• \i\\L \\\
ENGINEERING CONTROL \�f OFF r' .A
(SAMPLING OUTFALL) ` J
G
DOCK-2 DOCK -I
KENNEDY LO Ja .
CRcEC IuI DOCK-3
\\+ /
BLADDERt
ENGINEERING \.ONTROI
3
SQUARE FEZ ACRES'•'-
' '\ ARE4 OF PftOPERtt
#4 / DOCK-4 I BOUNDARY 1.545.810 I 35.5
SHEER GATE VALVE3 I
AREA OF 8UILDWGS 682.438 15J
ENGINEERING CONTROL I/ I AREA OF PARKING LOT 230,801 5.3
COMBINED AREA OF
BUILDINGS AND 913,239 Zt0
PARKING LOT
DOCK-5
NENNEOY ! I
_ CREEK
i
- I DOCK-6
DOCK-] N
= � I
_ so zx
SITE LAYOUT
ERM-Southeast. Inc. STORM WATER POLLUTION PREVENTION PLAN 2
aennesa �. Ceor�ia
- NATIONAL SPINNING CO., INC.
W.ASHINGTON, NORTH CAROLINA

a
Permit: NCG 170172 Owner - Facility: National Spinning Company Inc
Inspection Date: 10/11/2010 Inspection Type: Compliance Evaluation Reason for Visit: Other
Inspection Summary:
The WaRO recommends Rescinding NCG170173 as it is a dupilicate Permit and is not necessary. History: On
9/3/09 Travis Smith visited the facility and recommended that permit #: NCG170173 be rescinded due to having duplicate
permits. Also, NCG170173 (duplicate permit) had expired & NCG170172 (this permit) was still active. The rescinding of
permit NCG170173 was never completed and the facility was again billed for Two permits. Upon a discussion with Brian
Lowther, Ronald Raynor, Industrial Engineer/Supply Manager of CARON, a subsidiary of National Spinning, was able to
get the permit tabled in BIMS, as "Fee Waived". Again the facility has been included in the most recent Rescission
Request list dated 9/10/10. On 10/11/10, Samir Dumpor, PE and myself visited the facility with Ronald Raynor. Mr.
Raynor stated that the facility had been merged with CARON approximately 3 years prior. National Spinning is still a legal
owner (when the Permit is renewed in 2014, both names should be listed on the permit). National Spinning had not
requested any changes of the duplicant permits, because prior to approximately 8 years ago the Dye operation and the
Yarn operation were both functioning at full capacity, therefore the company assumed that seperate permits were
required. The operation purchased a modern facility near Winston Salem and relocated the Dye operation. Soon
thereafter the Owner purchased the adjacent existing facility in which their main Yard operation has been relocated. The
present status of this Washington facility consist of a small Yarn operation and some other spaces which have been
leased to others. The boilers, heaters, wastewater treatment and towers have been removed and properly
de-comissioned. All permits have been rescinded except for these (NCG170172 & ...173) and the Air Quality permitting.
All operations are inside except for the truck traffic. Active loading docks are covered with little chance for exposure.
Since there is no vehicle.maintainance onsite, only Qualitative Monoriting is required. —The Facility does have 8 outfall
locations (NCG170172 presently lists NULL Outfalls)"'. The leased space operates with all activity inside without
exposure except for the Pacific Seacraft which may require additional permitting (likely a NE). The operation is inside
although at their main loading dock, at the roll up door (which was open), approximately 8 to 10 - 5 Gallon unlabeled
different color portable liquid holding containers where chained and stored on the loading platform, although under a
canopy. This area looked to present some potential of impact to surface water and was located adjacent to outfall #4.
The boat builder may qualify for NE, but the operation should be addressed. Steve Brodie, a representative of the above
mentioned sail boat building company has emailed following this site visit and stated that when they were moving into the
facility, through discussions with DWQ personnel, the operation was informed that no permitting was required. I will
respond to Mr. Brodie's message as soon as DWQ's direction has been determined. This site visit was unannounced and
the only outside activities were, a few trucks, a few trash containers with lids, a double walled above ground diesel
storage container and a propane storage tank. The outside permitted area (concrete and pavement sections) was clean
and without any noticable evidence of spills. The wastewater treatment areas were de-comissioned years ago and Mr.
Raynor said the areas have never been overtopped by the river or creek. I expect that during the plants history,
permitting and especially permit compliance, was once of much greater significance than is the present facilities operating
conditions. Based on the present activities, the operation is in compliance with the permit conditions and Permit #:
NCG170173 should be rescinded.
Page: 2

F;;i
1
Permit:
NCG170172
SOC:
County:
Beaufort
Region:
Washington
Compliance Inspection Report
Effective: 08/01/09 Expiration: 07/31/14 Owner: National Spinning Company Inc
Effective: Expiration: Facility: Washington Mill
1481 W 2nd St
Contact Person: Ronald Raynor
Directions to Facility:
System Classifications:
Primary ORC:
Secondary ORC(s):
On -Site Representative(s):
Related Permits:
Title:
Inspection Date: 10/11/2010 Entry Time: 01:30 PM
Primary Inspector: Thom Edgerton
Secondary Inspector(s):
Washington NC 27889
Phone: [phone]
Certification:
Exit Time: 03:30 PM
Phone:
Phone: [phone]
Reason for Inspection: Other Inspection Type: Compliance Evaluation
Permit Inspection Type: Textile Mill Products Stormwater Discharge COC
Facility Status: Y Compliant ❑ Not Compliant
Question Areas:
® Storm Water
(See attachment summary)
Page: 1

Michael F. Easky, Govemor
William G. Ross Jr.. Secrera.,
North Carolina Department or Environment and Natural Resources
Alan W. Klimek. P.E. Direeto:
Division of'Aater Qualin
May 25, 2006
Mr. Ronald Raynor
National Spinning Co. Inc. -Dye Plant
P.O. Box 191
Washington, NC 27889
Subject: Stormwater General Permit NCG170000
Operations and Maintenance Reminder
National Spinning Co., Inc.- Dye Plant
COC Number NCG170172
Beaufort County
Dear Permittee:
Our records indicate that you have been issued a Stormwater General Permit and a Certificate of
Coverage for your facility. These permits have specific conditions that must be met in order for you to
be in compliance with your permit. It is your responsibility, as the permit holder, to read and comply
with the conditions contained in the permit.
It is our responsibility, as the issuing authority, to make sure that the operation and maintenance of
your facility complies with the conditions contained in your permit. To assist you in complying with
these conditions, we are attaching a Technical Bulletin specific to your permit requirements. We are
currently in the process of developing our inspection schedule. Therefore, you should have all of
your records up to date as we may be contacting you in the near future to set up an inspection of your
facility.
If you have any questions, please do not hesitate to contact Samir Dumpor, Pat Durrett or myself at
[phone].
Si cerely
Al Hodge, Supervisor
Surface Water Protection Unit
Encl.
CC: WaRO files
North Carolina Division or Water Qualiry Intemn h2e.encsate.nc.us
943 Washingmon Square Mall Phone: 252-946-i481
Washin_ton, NC 27889 FAX [phone]
An 'Equal OpponunitylAHumative Action Employer— 50% Recycledn 0% Post Consumer Paper
NorthCarolina
Natura!!ry

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
j2B y 11d- y�r r�nvr July 28, 1999
WILLY41at RE1 fd6itD5
NATIONAL SPINNING CO., INC.-DYE PLANT
P.O. BOX 191
W.ASIiINGTON. NC 27889
Dear Permittee:
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Reissue - NPDES Stormwater Permit
National Spinning Co.. Inc. -Dye Plant
COC Number NCG 170172
Beaufort County
In response to your renewal application for continued coverage under general permit NCG 170000. the Division of
Water Quality (DWQ) is forwarding herewith the reissued Stormwater general permit. This permit is reissued
pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement
between the state of North Carolina and the U.S. Environmental Protection Agency, dated December 6. 1983.
The following information is included with your permit package:
* A copy of general stormwater permit NCG 170000
* A Stormwater Pollution Prevention Plan (SPPP) Certification Form. Completion of this form is required to
certify that you have developed and implemented the SPPP as per the conditions of the permit. This form
must be completed and returned to the Division within 30 days of receipt of this letter.
DO NOT SEND the SPPP with the signed form.
• Five copies of the Analytical Monitoring form and five copies of the Qualitative Monitoring form
* A copy of a Technical Bulletin for the general permit which outlines changes in the permit, key requirements.
and addresses frequently asked questions
A Certificate of Coverage
Your coverage under this general permit is not transferable except after notice to DWQ. The Division may require
modification or revocation and reissuance of the Certificate of Coverage. This permit does not affect the legal
requirements to obtain other permits which may be required by DENR or relieve the permittee from responsibility
for compliance with any other applicable federal, state, or local law, rule, standard, ordinance, order, judgment, or
decree.
If you have any questions regarding this permit package please contact Bill Mills of the Central Office Stormwater
and General Permits Unit at [phone], ext. 548
Sincerely.
for Kerr T. Stevens
cc: Central Files
Stormwater and General permits Unit Files
Washington Regional Office
[ 2 W � N
AUG - 5 1999
WASHINGTON REGIONAL OFFICE
DWO
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

- I l
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG170000
CERTIFICATE OF COVERAGE No. NCG170172
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
NATIONAL SPINNING CO., INC.-DYE PLANT
is hereby authorized to discharge stormwater from a facility located at
NATIONAL SPINNING CO.. INC.-DYE PLANT
PLYMOUTH ST.
W ASHINGTON
BEAUFORT COUNTY
to receiving waters designated as Washington MSSS and Kennedy Creek in the Tar - Pamlico River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts 1, 11, 111,
IV, V, and VI of General Permit No. NCG170000 as attached.
This certificate of coverage shall become effective August I, 1999.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day July 28, 1999.
for Kerr T. Stevens, Director
Division of Water Quality
By Authority of the Environmental Management Commission

State of North Carolina
Department of Environment,
' Health and Natural Resources
Division of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
June 9, 1995
William Reynolds
National Spinning Co
P.O. Box 191
Washington, NC 27889
RECEIVED
WASHINGTON OFFICE
JUN 13 1995
0.EM.
Subject: General Permit No. NCG 170000
National Spinning Co
COC NCG170172
Beaufort County
Dear William Reynolds:
In accordance with your application for discharge permit received on March 9, 1995, we are forwarding
herewith the subject certificate of coverage to discharge under the subject state - NPDES general permit. This
permit is issued pursuant to the requirements of North Carolina General Statute 143-215 .1 and the
Memorandum of Agreement between North Carolina and the US Environmental Protection agency dated
December 6, 1983.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to request an individual permit by submitting an individual permit
application. Unless such demand is made, this certificate of coverage shall be final and binding.
Please take notice that this certificate of coverage is not transferable except after notice to the Division
of Environmental Management, The Division of Environmental Management may require modification or
revocation and reissuance of the certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be required by the
Division of Environmental Management or permits required by the Division of Land Resources, Coastal
Area Management Act or any other Federal or Local governmental permit that may be required.
If you have any question concerning this permit, please contact MR. BILL MILLS at telephone number
919/733-5083.
Sincerely, iJrigir+a! Si^,gip„c; ,!
Coica.. �..�`i.OSit,'..
A. Preston Howard, Jr. P.E.
cc: _Wshington a. Regional -Office
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50%recycled/ 10%postconsumer paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL RESOURCES
DIVISION OF ENVIRONMENTAL MANAGEMENT
GENERAL PERMIT NO. NCG170000
CERTIFICATE OF COVERAGE NO. NCG170172
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
National Spinning Co., Inc.
is hereby authorized to discharge stormwater from a facility located at
Dye Plant
End of Plymouth Street and West Third Street Extension
Washington
Beaufort County
to receiving waters designated as the City of Washington Storm Sewer System and Kennedy Creek in the Tar -
Pamlico River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Pans I, II, II1
and IV of General Permit No. NCG170000 as attached.
This Certificate of Coverage shall become effective June 9, 1995.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day June 9, 1995.
i riftit�s.
A. Preston Howard, Jr., P.E., Director
Division of Environmental Management
By Authority of the Environmental Management Commission

h,
Dar Yacoo
'Kertoe
Allant,c (C)
Uaybeacons 0
I o
a.
ms . ......... . . . . . .
P
c
q, A ItO-
7
Pilin "4:
.1olling
!Castle
The C astle,,
Piling
(C)
0 Rad�o TD�vei -
--- --(WHEDI-
p
Piling Foul
FF2N N
Grandpe
Ar,a
�Lighl �C)
N L
Solt (C)
Porter
Junction.
0 2. ...
_Radio Toe,, I
(WRRF)
k
pflkq F
pe
7
2
Icovdnitv (L �Vn, I (C)
or c
r
C'Ilk
Ram (C)
—a choco (C)
7
XCI
Eoding (C)
(Cl \%