NCG140265_COMPLETE FILE - HISTORICAL_20161014

STORMWATER DIVISION CODING SHEET
RESCISSIONS.
PERMIT NO.
DOC TYPE
P—COMPLETE FILE - HISTORICAL
DATE OF
RESCISSION
❑ O I (e i ro l g
YYYYMMDD

4 ARGOS,
October 13, 2016
Mr. Cheng Zhang
North Carolina Department of Environmental Quality
3800 Barrett Drive
Raleigh, NC 27609
Dear Mr. Zhang:
OCT 1 4 2016
Nc DENR Raleigh Regional Office
RE: Response to the Multimedia Compliance Evaluation Inspection, COC Number NCG 140265;
Southern Equipment Company — Fuquay Varina - Plant 910; NCG14000 General Permit
This letter is in response to the questions concerning our concrete wash pit at this facility. Below is
the response to the comments and question of the design of the concrete pit.
The wash concrete pit located in the middle of the facility is not a recycling pit. It is simply used to
catch wash water used to wash trucks before they leave for the job and after returning. From time to
time, portions of that water are removed by loader and used to wet down the travel areas on the plant
site to keep fugitive dust down when we are busy. This property does not have any point source
discharge points, so if water did leave the pit because of a 24 hour, 25 year storm event it would
probably not leave property and if it did, it would leave with rain water as sheet flow. Currently, we
do maintain a spill plan and we follow Best Management Practices and perform routine inspections.
This past weekend with the massive amount of rain associated with Hurricane Matthew, it was
identified by our plant personnel that the water did not leave the pit.
With the recognition that the pit water is not used for recycling, that we have a SPCC plan, we
follow BMP's such as using the water to control fugitive dust, and we perform routine inspections,
we are not sure that this is governed by 15A NCAC 02T .1003(a)(2). If that is the case, do we still
need to verify the storage capacity?
I want to thank you for taking the time to inspect our facility and spend time with our Operations
Manager, Jay Watkins. Please contact me with any questions and to let me know if we still need to
provide the storage capacity of the concrete pit. I can be reached at 919-790-1520.
Very truly yours,
Ready Mixed Concrete Company
James A Walters 16*A /i,
James A. Walters
RDU Division Manager

Environmental
Quality
September 6, 2016
Mr. James Walters
Division Manager
Southern Equipment Co. (d.b.a Ready Mixed Concrete Co.)
3610 Bush Street
Raleigh, NC 27609
Dear Pennittee:
nAT VCCRORY
Gcor;�
DO\ALD R. VA\ DER VAART
se�_ra,y
Subject: Multimedia Compliance Inspection
Closed -loop Recycle System
Southern Equipment Co — Fuqua-Varina - Plant # l0
Wake County
It is understood that the subject facility used to have a Certificate of Coverage (COC) No.
NCG 140265 under NPDES Stormwater General Permit NCG 140000. The COC was rescinded on
February 22, 2000, based on the fact that the facility lacked point source discharge of stormwater. It was
verified during this inspection that stormwater leaves the site via sheet flow.
It was also noted that the wash concrete pit located in the middle of the facility collects stormwater
runoff and process wastewater generated in the production area. Pursuit to 15A NCAC 02T .1003(a)(2),
close -loop recycling of rinse water at concrete mixing facilities for concrete mix removal from
equipment is deemed permitted, provided the wastewater is contained within concrete structures, there is
sufficient storage capacity to contain the runoff from a 24-hour, 25-year storm event plus one -foot
freeboard and the facility develops and maintains a spill control plan in the event of a wastewater
release.
Please notify the Division of Water Resources Raleigh Regional Office in writing within 30 days of
receipt of this letter, detailing that the design of concrete pit complies with the above deemed
permitted criteria.
If you have any questions regarding this multimedia inspection, please contact me at [phone] or at
clieng. zhang@ncdenr. gov.
Sincerely,
0
Cheng Zhang
Environmental Senior Specialist
Raleigh Regional Office
cc: DAQ RRO files
RRO Stormwater files
Department of Environmental Quality, Raleigh Regional Office http:11deq.nc.govl
1628 Mail Service Center, Raleigh, NC 27699-1628 Phone: [phone]
Location: 3800 Barretl Drive, Raleigh, NC 27609 Fax: [phone]

Environmental
Quality
Mr. James Walters
Division Manager
Southern Equipment Co.
3610 Bush Street
Raleigh, NC 27609
Dear Permittee:
PAT MCCRORY
Gadr�
DONALD R. VAN DER VAART
Sevetey
September 6, 2016
(d.b.a Ready Mixed Concrete Co.)
Subject: Multimedia Compliance Inspection
Southern Equipment Co — Fuqua-Varina - Plant # 10
Wake County
Department of Environment and Natural Resources staff conducted a multimedia compliance inspection of
Southern Equipment Co — Fuqua-V arina - Plant #10 on August 2, 2016 for permitted and/or other activities
administered by the following Divisions:
Division of Air
Division of Energy,
Division of Water
Division of Waste
Quality(DAQ)
Mineral, and Land
Resources (DWR)
Management (DWM)
Resources EMLR
We hope that you have enjoyed the benefit of our initiative to provide a single inspector capable of handling
multiple areas of environmental compliance at your facility. The results of each applicable inspection area
and any associated response actions or necessary corrective measures are detailed in the Division specific
areas of the attached report. If there are no notes or comments under each Division header, you may assume
compliance with that particular Division's rules and regulations at the time of inspection. Should violations
be noted in the attached report, you may receive separate enforcement related correspondence in addition
to this report.
If you have any questions regarding this multimedia inspection, please contact me at
[e-mail]. Thank you for your cooperation.
cc:
DAQ RRO Files
DEMLR RRO Stormwater Files
Department of Environmental Quality, Raleigh Regional Office hflpaldeq.nagovl
1628 Mail Service Center, Raleigh, NC 27699-1628 Phone: [phone]
Location: 3800 Barrett Drive, Raleigh, NC 27609 Fax: [phone]

ra4' n°
,t f4 f
Environmental
Quality
September 6, 2016
Mr. James Walters
Division Manager
Southern Equipment Co. (d.b.a Ready Mixed Concrete Co.)
3610 Bush Street
Raleigh, NC 27609
Dear Permittee:
PATMCCRORP
ckxey ?
DONALD R. VAN DER VAART
smemr
Subject: Multimedia Compliance Inspection
Closed -loop Recycle System
Southern Equipment Co — Fuqua-Varina - Plant #10
Wake County
It is understood that the subject facility used to have a Certificate of Coverage (COC) No.
NCG140265 under NPDES Stormwater General Permit NCG140000. The COC was rescinded on
February 22, 2000, based on the fact that the facility lacked point source discharge of stormwater. It was
verified during this inspection that stormwater leaves the site via sheet flow.
It was also noted that the wash concrete pit located in the middle of the facility collects stormwater
runoff and process wastewater generated in the production area. Pursuit to 15A NCAC 02T .1003(a)(2),
close -loop recycling of rinse water at concrete mixing facilities for concrete mix removal from
equipment is deemed permitted, provided the wastewater is contained within concrete structures, there is
sufficient storage capacity to contain the runoff from a 24-hour, 25-year storm event plus one -foot
freeboard and the facility develops and maintains a spill control plan in the event of a wastewater
release.
Please notify the Division of Water Resources Raleigh Regional Office in writing within 30 days of
receipt of this letter, detailing that the design of concrete pit complies with the above deemed
permitted criteria.
If you have any questions regarding this multimedia inspection, please contact me at [phone] or at
[e-mail].
Sincerely,
Cheng Zhang
Environmental Senior Specialist
Raleigh Regional Office
cc: DAQ RRO files
RRO Stormwatcr files
Department of Environmental Quality, Raleigh Regional Office http:lldeq.ncgovl
1628 Mail Service Center, Raleigh, NC 27699-1628 Phone: (919) 791A200
Loraton: 3800 Barrett Drive, Raleigh, NC 27609 Fax: [phone]

NORTH CAROLINA DIVISION OF
AIR QUALITY
Inspection Report
Date: 08/26/2016
Facility Data
Southern Equipment Co (dba RMCC) - Fuqua-Varina - Plant #10
1506 Holland Road
Fuquay-Varina, NC 27530
Lat: 35d 34.1990m Long: 78d 46.0960m
SIC: 3273 / Ready -Mixed Concrete
NAICS: 32732 / Ready -Mix Concrete Manufacturing
L_ Contact Data
Facility Contact Authorized Contact ITechnical Contact O
Jay Watkins
Operations Manager
[phone]
Comments:
Inspector's Signature:
Date of Signature:
James Walters Steve Simonsen
Division Manager Environmental Manager
[phone] [phone]
Raleigh Regional Office
Southern Equipment Cc (dba RMCC) - Fuqua-
Varina - Plant 010
NC Facility ID 9200083
County/FIPS: Wake/183
Permit Data
Permit 01913 / Rl l
Issued 3/3/2015
Expires 2/28/2023
Classification Small
Permit Status Active
Current Permit Application(s) Rescission
Request
SIP
Program Applicability
Data
Inspection Date 08/02/2016
Inspector's Name Cheng Zhang
Operating Status Operating
Compliance Code Compliance - inspection
Action Code FCE
On -Site Inspection Result Compliance
Loral ACIUal C1111351UM
UI avnor
a
TSP
S02
NOX
VOC
CO
PM10
*HAP
2013
0.2200
---
---
---
---
0.1000
0.0613
2009
0.1700
---
---
---
---
0.0800
0.0476
'ive Year Violation History: None
Date Letter Type Rule Violated
'erformed Stack Tests since last FCE: None
Date Test Results Test Method(s)
* Highest HAP Emitted
Violation Resolution Date
Source(s) Tested
1) DIRECTIONS TO FACILITY: Southern Equipment Company, Plant 10 is located near the intersection of
Holland and North Holland Roads in Fuquay-Varina, North Carolina, Wake County. From the RRO take U.S. 401
South to Fuquay-Varina. At the traffic light take a left onto NC-55/NC-42. Proceed approximately 2 miles and turn
right onto Holland Road. Travel approximately one mile on Holland Road and the facility will be located on the left.

(Q) FACILITY DESCRIPTION: Facility is a concrete batch plant. Note: Include a hard hat, blaze orange safety
vest, earplugs and safety glasses for personal protective equipment.
(III) INSPECTION SUMMARY: On August 2, 2016,1 (Chong Zhang) met with Mr. Jay Watkins, Operations
Manager, to conduct a compliance inspection. Initially, we reviewed the conditions of the facility's logbook and
current air permit, and then a tour of the facility's permitted equipment was conducted. On the day of the
inspection, the facility was not in operation.
(IV) PERMITTED EMISSIONS SOURCES: _
Emission Emission Source Control Control System
Source ID Descnphon System ID Description
truck mix concrete batch plant (loll cubic yards per hour maximum
ES SIL 02 silo with two compartments (one 100 ton
compartment for cement and one 48 ton
compartment for flyash)
i
ES-SIL-Ol storage bin with one 12 ton compartment for
CD-FF-01 bagfilter (1,433 square feet
cement and one 9 ton compartment for flyash of filter area)
ES-WB-01 cement / flyash weigh batcher
ES-TLl itruck loadout operation
ES-WB-02 , sand / aggregate weigh batcher N
***All the above emission sources were observed during the inspection. The plant was not in operation. ***
(V) SPECIFIC PERMIT CONDITIONS:
A.1. Any air emission sources or control devices authorized to construct and operate above must be operated
and maintained in accordance with Subchapter 2D .0202, 2D .0515, 2D .0521, 2D .0535, 2D .0540, 2D .0611, and
2D ..1806.
***IN COMPLIANCE - The facility appears to be in compliance with all applicable state and federal regulations.
A.2. 2D .0202, PERMIT RENEWAL AND EMISSION INVENTORY REQUIREMENT — At least 90 days
prior to the expiration date of this permit, the Permittee shall request permit renewal by letter. The renewal request
(with AA application form) should be submitted to the Regional Supervisor, DAQ. Also, at least 90 days prior to
the expiration date of this permit, the Permittee shall submit the air pollution emission inventory report (with
Certification Sheet) and shall document air pollutants emitted for the 2021 calendar year.
***IN COMPLIANCE — During the inspection, Mr. Watkins was reminded that the permit expires April 30, 2023,
and the emission inventory due will be for the 2021 calendar year. ***
A.3. 2D .0515, PARTICULATE CONTROL REQUIREMENT - particulate matter emissions from the emission
sources shall not exceed allowable emission rates.
***IN COMPLIANCE - Emissions calculations verified in permit review. ***
A.4. 2D .0521, CONTROL OF VISIBLE EMISSIONS - Visible emissions from the permitted items at the
facility shall not exceed 20% opacity.
***IN COMPLIANCE —The facility was not in operation on the day of the inspection. No visible emissions. ***

A.S. 2D .0535, NOTIFICATION REQUIREMENT - the Permittee of a source of excess emissions that last for
more than four hours and that results from a malfunction, a breakdown of process or control equipment or any other
abnormal conditions, shall notify NCDAQ of any such occurrence by 9:00 a.m.
***IN COMPLIANCE — No excess emissions have been noted or reported regarding this facility. ***
A.6. 2D .0540, FUGITNE DUST CONTROL REOUIREMENT - The Permittee shall not cause or allow
fugitive dust emissions to contribute to substantive complaints or excess visible emissions beyond the property
boundary.
***rN COMPLIANCE — No fugitive dust emissions were observed on the day of the inspection. ***
A.7. 2D .0611, FABRIC FILTER REQUIREMENTS including cartridge filters baghouses, and other dry filter
Particulate collection devices. The permittee is to maintain and inspect the bagfilters, and record the results of these
activities in a logbook.
***IN COMPLIANCE — The facility has a complete and up to date air quality logbook that contains weekly,
monthly and annual bagfilter maintenance records. All requirements for this stipulation have been satisfied. Most
recent bagfilter inspection was dated July 29, 2016. ***
A.B. 2D .1806, CONTROL AND PROHIBITION OF ODOROUS EMISSIONS - The Permittee shall not
operate the facility without implementing management practices or installing and operating odor control equipment
sufficient to prevent odorous emissions from the facility from causing or contributing to objectionable odors beyond
the facility's boundary.
***IN COMPLIANCE - No odors detected during the inspection. **
(VI) INSIGNIFICANT/EXEMPT SOURCES: None.
(VII) 112R APPLICABILITY: This regulation does not apply to this facility.
(VIIT) COMPLIANCE HISTORY: The facility has not been issued any Notices of Violation or Notices of
Deficiencies within the last five years.
(IX) STACK TEST HISTORY: There are no stack tests in the database.
(X) CONCLUSIONS/RECOMMENDATIONS: At the time of the inspection, the facility appeared to be in
compliance. It is also recommended that the facility be re -inspected in two years.

State of North Carolina
Department of Environmert.ft
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
C
February 22, 2000
LYMAN AUSTIN
READY MIXED CONCRETE CO-FV # 10
3610 BUSH STREET
RALEIGH NC 27609
Dear LYMAN AUSTIN:
E N R
Subject: Rescission of NPDES Permit
Permit No. NCG 140265
READY MIXED CONCRETE CO-FV #10
WAKE County
Reference is made to your request for rescission of the suhiect NPDES Permit.
Stafl'of the Raleigh Regional Office have confirmed that this Permit is no longer
required. Therefore; in accordance with your request, NPDES Permit No. NCG 140265
is rescinded, effective immediately.
If in the future you wish to again discharge stormwater to the State's surface waters,
you must first apply for and receive a new NPDES Permit. Operating a facility without
a valid NPDES Permit will subject the responsible party to a civil penalty of up to
$10,000 per day.
If it would be helpful to discuss this matter further, I would suggest that you contact
the Water Quality staff, Raleigh Regional Office at [phone].
Sincerel ,
Kerr T. Stevens
cc: Wake County Health Department
Raleigh - Water Quality Regional Supervisor - w/attachments
Point Source Branch — Bradley Bennett
Operator Training and Certification
Point Source Compliance - Robert Farmer - w/attachments
Mr. Roosevelt Childress, EPA
Central Files - w/attachments
Fran McPherson, DWQ Budget Office
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50 % recycled/ 10 % post -consumer paper

January 11, 2000
MEMORANDUM
TO: RobertFarmer
FROM: Robin Simpson Q S
THROUGH: Randy Jones
U
SUBJECT: Rccission of NPDES Permit No. NCG140265
After a site visit to the Ready Mixed Concrete Co. in Fuquay-Varina, it was determined
that all stormwater that leaves the site is sheet flow. Therefore, I recommend recission
of the stormwater general permit NCG140265.
If you have any questions, please contact me at [phone].
cc: Ken Schuster
I, I
DF.'.
a W,.... „. -IITY

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
October 4, 1999
LYMAN AUSTIN
READY MIXED CONCRETE CO-FV #10
3610 BUSH STREET
RALEIGH NC 27609
Dear LYNTAN AUSTIN:
AA
`��
D E N R
Subject: Acknowledgement of Rescission Request
READY MIXED CONCRETE CO-FV # 10
NPDES Permit No. NCG 140265
WAKE County
This is to acknowledge receipt of your request that NPDES Permit No. NCG 140265
be rescinded. Your request indicated that this permit is no longer needed.
By copy of this letter, I am requesting confirmation from our Raleigh Regional
Office that this permit is no longer needed. After verification by the Regional Office that
the permit is no longer needed, NPDES Permit No. NCG 140265 will be rescinded.
If there is a need for any additional information or clarification, please do not hesitate
to contact Robert Farmer at [phone]. ext. 531.
Sinccrcly,
� CZ
E. Shannon Langley, Supervis
Point Source Compliance/ Enforcement Unit
cc: Raleigh Water Quality Regional Supervisor - w/attachments
Point Source Branch - Bradley Bennett - w/attachments
Point Source Branch - Robert Farmer - w/attachments
Central Files- w/attachments
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50 % recycled/ 10 % post -consumer paper

(p READY MIXED CONCRETE COMPANY
3610 Bush Street, Raleigh, NC 27609 P.O. Box 27326, Raleigh, NC 27611
n I Telephone [phone] _
�.. Fax [phone]i
Guaranteed Strength Y3 (T
August 11, 1999
Mr. Bradley Bennett
North Carolina Department of Environment and Natural Resources
Division of Water Quality/ Water Quality Section
1617 Mail Service Center
Raleigh, NC 27699-1617
Subject: REQUEST "f0 RESCIND GENERAL PERMIT NO. NCG 140000
READY MIXED CONCRETE COMPANY
1506 HOLLAND ROAD
COC NCGI40265
Dear Mr. Bennett:
Ready Mixed Concrete Company requests that General Permit No. NCG140000
( COC NCG140265) for the above referenced facility be rescinded. Based on the fact
that all stormwater from the site leaves the site as sheet Flow and there are not point -
source discharges, it is our understanding that a general permit is not necessary. If you
have any questions, please feel free to contact Lyman Austin at [phone] ext.132.
Sincerely,
Ready Mixed Concretzpany
h�an Austin
FD
AUG f 3 M9
ENR - WATER DUALITY
POINT SOURCE BRANCH
Member National Iifadv Ah,ed Concrete Association

NPDES FACILITY AND PERMIT DATA 09/30/99 13:10:14
UPDATE OPTION TRXID 5NU KEY NCG140265
PERSONAL DATA FACILITY APPLYING FOR PERMIT REGION
_
rACILITY NAME>.READY MIXED CONCRETE CO-FV *** COUNTY> WAKE
05
ADDRESS: MAILING (REQUIRED) LOCATION (REQUIRED)
STREET: 3610 BUSH STREET STREET: 1506 HOLLAND ROAD
CITY: RALEIGH ST NC ZIP 27609 CITY: FUQUAY VARINA ST NO ZIP
27526
TELEPHONE [phone] DATE FEE PAID: O1/26/99 AMOUNT: 80.00
STATE CONTACT> ENGLAND PERSON IN CHARGE LYMAN AUSTIN
1=2ROPOSED,2=EXIST,3=CLOSED 2 1=MAJOR,2=MINOR 2 1=MUN,2=NON-MUN 2
LAT: 3534100 LONG: 07846050 N=NEW,M=MODIFICATION,R=REISSUE> R
DATE APP RCVD O1/26/99 WASTELOAD REQS
DATE STAFF REP REQS 02/09/99 WASTELOAD RCVD
DATE STAFF REP RCVD 02/09/99 SCH TO ISSUE
DATE TO P NOTICE / / DATE DRAFT PREPARED 02/10/99
DATE OT AG CON REQS / / DATE DENIED
DATE OT AG CON RCVD / / DATE RETURNED
DATE TO EPA / / DATE ISSUED O8/01/99 ASSIGN/CHANGE
PERMIT
DATE FROM EPA / / EXPIRATION DATE 07/31/04
FEE CODE ( 0 ) 1=(>10MGD),2=(>lMGD),3=(>O.lMGD),4=(<O.1MGD),S=SF,6=(GP25,64,79),
7=(GP49,73)8=(GP76)9=(GP13,34,30,52)0=(NOFEE) DIS/C 73 CONSILL
( )
COMMENTS: REQUEST TO RESCIND TO RF 9/28/99
MESSAGE: *** DATA MODIFIED SUCCESSFULLY ***
T

t
January 11, 2000
MEMORANDUM
TO: Robert Farmer
FROM: Robin Simpson is
THROUGH: Randy Jones
SUBJECT: Recission ofNPDES Permit No. NCG140265
After a site visit to the Ready Mixed Concrete Co. in Fuquay-Varina, it was determined
that all stormwater that leaves the site is sheet flow. Therefore, 1 recommend recission
of the stormwater general permit NCG140265.
If you have any questions, please contact me at [phone].
cc: Ken Schuster

Guaranteed
READY MIXED CONCRETE COMPANY
3610 Bush Street, Raleigh, NC 27609 P.O. Box 27326, Raleigh, NC 27611
Telephone [phone]
Fax [phone]`
YT i;(tri!/'
August 11, 1999
Mr. Bradley Bennett
North Carolina Department of Environment and Natural Resources
Division of Water Quality/ Water Quality Section
1617 Mail Service Center
Raleigh, NC 27699-1617
Subject: REQUEST TO RESCIND GENERAL PERMIT NO. NCG140000
READY MIXED CONCRETE COMPANY
1506 HOLLAND ROAD
COC NCG 140265
Dear Mr. Bennett:
Ready Mixed Concrete Company requests that General Permit No. NCG140000
( COC NCG140265) for the above referenced facility be rescinded. Based on the fact
that all stormwater from the site leaves the site as sheet flow and there are not point -
source discharges, it is our understanding that a general permit is not necessary. If you
have any questions, please feel free to contact Lyman Austin at [phone] ext.132.
Sincerely,
Ready Mixed Concrete mpany
an Austin
AUG 13 1999
DENR - WATER QUALITY
POINT SOURCE BRANCH
Member National Ready Mixed Concrete Association

NPDES FACILITY AND PERMIT DATA 09/30/99 13:10:14
UPDATE OPTION TRXID 5NU KEY NCG140265
PERSONAL DATA FACILITY APPLYING FOR PERMIT REGION
-ACILITY NAME> READY MIXED CONCRETE CO-FV *** COUNTY> WAKE 05
ADDRESS: MAILING (REQUIRED) LOCATION (REQUIRED)
STREET: 3610 BUSH STREET STREET: 1506 HOLLAND ROAD
CITY: RALEIGH ST NC ZIP 27609 CITY: FUQUAY VARINA ST NC ZIP 27526
TELEPHONE [phone] DATE FEE PAID: 01/26/99 AMOUNT: 80.00
STATE CONTACT> ENGLAND PERSON IN CHARGE LYMAN AUSTIN
1=PROPOSED,2=EXIST,3=CLOSED 2 1=MAJOR,2=MINOR 2 1=MUN,2=NON-MUN 2
LAT: 3534100 LONG: 07846050 N=NEW,M=MODIFICATION,R=REISSUE> R
DATE APP RCVD 01/26/99 WASTELOAD REQS
DATE STAFF REP REQS 02/09/99 WASTELOAD RCVD
DATE STAFF REP RCVD 02/09/99 SCH TO ISSUE
DATE TO P NOTICE / / DATE DRAFT PREPARED 02/10/99
DATE OT AG COM REQS / / DATE DENIED
DATE OT AG COM RCVD / / DATE RETURNED
DATE TO EPA / / DATE ISSUED 08/01/99 ASSIGN/CHANGE PERMIT
DATE FROM EPA / / EXPIRATION DATE 07/31/04
FEE CODE ( 0 ) 1=(>10MGD),2=(>lMGD),3=(>O.1MGD),4=(<O.1MGD),5=SF,6=(GP25,64,79),
7=(GP49,73)8=(GP76)9=(GP13,34,30,52)0=(NOFEE) DIS/C 73 CONBILL ( )
COMMENTS: REQUEST TO RESCIND TO RF 9/28/99
MESSAGE: *** DATA MODIFIED SUCCESSFULLY ***

'State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
LYMAN AUSTIN
READY MIXED CONCRET CO- F-V #10
3610 BUSH STREET
RALEIGH, N.C. 27609
Dear Permittee:
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
July 26, 1999
- Subject: Reissue - NPDES Stormwater Permit
Ready Mixed Concret Cc- F-V #10
COC Number ncg 140265
Wake County
In response to your renewal application for continued coverage under general permit NCG140000, the Division of
Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This permit is reissued
pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement
between the state of North Carolina and the U.S. Environmental Protection Agency, dated December 6, 1983.
The following information is included with your permit package:
* A copy of general Stormwater permit NCG 140000
* A Stormwater Pollution Prevention Plan (SPPP) Certification Form. Completion of this form is required to
certify that you have developed and implemented the SPPP as per the conditions of the permit. This form
must be completed and returned to the Division within 30 days of receipt of this letter.
DO NOT SEND the SPPP with the signed form.
* Five copies of the Analytical Monitoring form and five copies of the Qualitative Monitoring form
* A copy of a Technical Bulletin for the general permit which outlines changes in the permit, key requirements,
and addresses frequently asked questions
* A Certificate of Coverage
Your coverage under this general permit is not transferable except after notice to DWQ. The Division may require
modification or revocation and reissuance of the Certificate of Coverage. This permit does not affect the legal
requirements to obtain other permits which may be required by DENR or relieve the permittee from responsibility
for compliance with any other applicable federal, state, or local law, rule, standard, ordinance, order, judgment, or
decree.
If you have any questions regarding this permit package please contact Darren England of the Central Office
Stormwater and General Permits Unit at [phone], ext. 545
Sincerely,
for Kerr T. Stevens
cc: Central Files
Stormwater and General permits Unit -Files
Raleigh Regional Office
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG140000
CERTIFICATE OF COVERAGE No. NCG140265
STORMWATER AND PROCESS WASTEWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
READY MIXED CONCRET CO- F-V #10
is hereby authorized to operate a process wastewater treatment system, and is hereby authorized to discharge process
wastewater and stormwater from a facility located at
READY MIXED CONCRET CO- F-V #10
1506 HOLLAND ROAD
FUQUAY VARINA
WAKE COUNTY
to receiving waters designated as a UT to Partins Pond in the Neuse River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I. II. III,
IV, V, and VI of General Permit No. NCG140000 as attached.
This certificate of coverage shall become effective August I, 1999.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day July 26, 1999.
for Kerr T. Stevens, Director
Division of Water Quality
By Authority of the Environmental Management Commission

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
JOHN N. HOLDING, JR.
THOMAS CONCRETE OF CAROLINA, INC.
P.O. BOX 12544
RALEIGH, N.C. 27605
Dear Permittee:
A1�
jLA
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
July 26, 1999
Subject: Reissue - NPDES Stormwater Permit
Thomas Concrete of Carolina. Inc.
COC Number nce140266
wake County
In response to your renewal application for continued coverage under general permit NCG140000, the Division of
Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This permit is reissued
pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement
between the state of North Carolina and the U.S. Environmental Protection Agency, dated December 6, 1983.
The following information is included with your permit package:
* A copy of general Stormwater permit NCG140000
* A Stormwater Pollution Prevention Plan (SPPP) Certification Form. Completion of this form is required to
certify that you have developed and implemented the SPPP as per the conditions of the permit. This form
must be completed and returned to the Division within 30 days of receipt of this letter.
DO NOT SEND the SPPP with the signed form.
* Five copies of the Analytical Monitoring form and five copies of the Qualitative Monitoring form
* A copy of a Technical Bulletin for the general permit which outlines changes in the permit, key requirements,
and addresses frequently asked questions
* A Certificate of Coverage
Your coverage under this general permit is not transferable except after notice to DWQ. The Division may require
modification or revocation and reissuance of the Certificate of Coverage. This permit does not affect the legal
requirements to obtain other permits which may be required by DENR or relieve the permittee from responsibility
for compliance with any other applicable federal, state, or local law, rule, standard, ordinance, order, judgment, or
decree.
If you have any questions regarding this permit package please contact Darren England of the Central Office
Stormwater and General Permits Unit at [phone], ext. 545
Sincerely,
b_.'e .!
for Kerr T. Stevens
cc: Central Files
Stormwater and General permits Unit Files
Raleigh Resional Office
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50 % recycled/ 10 % post -consumer paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG140000
CERTIFICATE OF COVERAGE No. NCG140266
STORMWATER AND PROCESS WASTEWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and -adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
THOMAS CONCRETE OF CAROLINA, INC.
is hereby authorized to operate a process wastewater treatment system, and is hereby authorized to discharge process
wastewater and stormwater from a facility located at
THOMAS CONCRETE OF CAROLINA, INC.
220INTERNATIONAL DRIVE
MORRIS VILLE
WAKE COUNTY
to receiving waters designated as a UT of Crabtree Creek in the Neuse River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts 1, II, III,
IV, V, and VI of General Permit No. NCG140000 as attached.
This certificate of coverage shall become effective August I, 1999.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day July 26, 1999.
for Kerr T. Stevens, Director
Division of Water Quality
By Authority of the Environmental Management Commission

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
Mr. Lyman Austin
Ready Mixed Concrete Co-FV #10
3610 Bush Street
Raleigh, North Carolina 27609
Dear Mr. Holding:
AJA
NCDENR
February 16,1999
Subject: General Permit No.NCG140000
Ready Mixed Concrete Co-FV #10
COC NCG140265
Wake County
In accordance with your application for discharge permit received on January 1, 1999 we are forwarding
herewith the subject certificate of coverage to discharge under the subject state - NPDES general permit. This
permit is issued pursuant to the requirements of North Carolina General Statute 143-215 .l and the Memorandum
of Agreement between North Carolina and the US Environmental Protection agency dated December 6, 1983.
If any parts, measurement frequencies or sampling requirements contained in this permit are unacceptable
to you, you have the right to request an individual permit by submitting an individual permit application. Unless
such demand is made, this certificate of coverage shall be final and binding.
Please take notice that this certificate of coverage is not transferable except after notice to the Division of
Water Quality. The Division of Water Quality may require modification or revocation and reissuance of the
certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be required by the
Division of Water Quality or permits required by the Division of Land Resources, Coastal Area Management Act
or any other Federal or Local governmental permit that may be required.
If you have any questions concerning this permit, please contact Darren England at telephone number
919/733-5083 ext.545.
cc: Raleigh Regional -Office
Sincerely,
ORIGINAL SIGNED BY
WILLIAM C. MILLS
A. Preston Howard, Jr., P. E.
FFR I � IOC'
P.O. Box 29535, Raleigh, North Carolina 27626-0535
An Equal Opportunity Affirmative Action Employer
Telephone [phone] FAX [phone]
50% recycled/ 10% post -consumer paper

4b a
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG 140000
CERTIFICATE OF COVERAGE No. NCGI
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
Ready Mixed Concrete Co-FV #10
is hereby authorized to discharge stormwater from a facility located at
Readyy Mixed Concrete Co-FV #10
I506 Holland Road
Fuquay Varina, NC
Wake County
to receiving waters designated as an unnamed tributary Partins Pond in the Neuse River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts 1, 11, III
and IV of General Permit No. NCG 140000 as attached.
This Certificate of Coverage shall become effective February 16, 1999.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day February 16, 1999.
0pjGINAL SIGNED BY
WLLIAM C. MILLS
A. Preston Howard, Jr., P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

Facility Location Map
SGS Topographic Map
7.5 Minute Series
L/Y.
pduay� -a
T
i A
o a
J-0
Tra)i e
V
rrr
Facility:
Map ID CZ3 St
Latitude: 3 Y
Longitude: _.Y� <z t;