NCG020855_COMPLETE FILE - HISTORICAL_20151230

pZo
STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
/v U& U a b
DOC TYPE
C( HISTORICAL FILE
❑ MONITORING REPORTS
DOC DATE
❑ a U ) 5 1 a 3 U
YYYYM M D D

December 30 , 2015
Energy, Mineral
and Land Resources
ENVIRONMENTAL QUALITY
R M Hayes Construction Co Inc
Attn: Raymond Hayes
1646 B Strickland's Crossroads Rd
Four Oaks, NC 27524
PAT MCCRORY
DONALD R. VAN DER VAART
Subject: NPDES Stormwater Permit Coverage Renewal COC #NCG020855
Dear Permittee:
s, , „-m"
TRACY DAVIS
PirNlur
For coverage under NPDES General Permit NCG020000, the Division of Energy. Mineral and Land
Resources (DEMLR) is forwarding herewith the reissued Certificate of Coverage and
Stormwater/Wastewater General Permit. This permit is reissued pursuant to the requirements of North
Carolina General Statute 143-215.1 and the Memorandum of Agreement between the state of North
Carolina and the U.S. Environmental Protection Agency, dated October 15, 2007 (or as subsequently
amended.) The following information is included with your permit package:
• New Certificate of Coverage
• Stormwater/Wastewater General Permit
• Technical Bulletin for the General Permit
• Discharge Monitoring Report (DMR) Forms
• Annual Discharge Monitoring Report Forms
• Qualitative Monitoring Report Forms
The General Permit authorizes discharges of stormwater and/or wastewater (as applicable to your site),
and it specifies your obligations with respect to discharge controls, management, monitoring and record
keeping. Please review the new permit to familiarize yourself with all changes in the reissued permit.
Significant changes to the General Permit are outlined in the Technical Bulletin.
Your coverage under the General Permit is transferable only through the specific action of DEMLR. This
permit does not affect the legal requirements to obtain other permits which may be required by the N.C.
Department of Environmental Quality, nor does it relieve the permittee from responsibility for
compliance with any other applicable federal, state, or local law, rule, standard, ordinance, order,
judgment or decree.
If you have any questions regarding this permit package please contact the DEMLR Stormwater
Permitting Program at 919-707-9220.
Sincerely,
69sJ/ i/ �F',ryYrt�
for Tracy E. Davis, P.E., C.P.M
Cc: Stormwater Permitting Files
Slate or Nona Carolina I liavironmemal Quality I lEacrgy, A7 incral and land Reaoumes
1612 Mail Service Center 1 512 North Salisbury Street I Raleigh, NC 27699-1612
919 707 9200 T

North Carolina
Divisio
Tracy E. Davis, PE, CPM
Director
n
r�
NCDENR
Department of Environment and Natural Resources
of Energy, Mineral, and Land Resources
Land Quality Section
Mr. R. M. raves
R. Mi. Hayes Construction, Inc.
1646 Stricklands Crossroads Rd.
Pour Oaks, NC 27524
Dear Mr. Hayes:
Pat McCrory, Governor
John E. Skvarla, III, Secretary
January 23, 2014
Subject: General Permit No, NCG020000
Stone Creek Sand & Gravel Mine
COC NCG020055
Johnston County
In accordance with your application for a discharge permit received on October 7,
2013, we are forwarding herewith the subject certificate of coverage to discharge under the
subject state - NPDES general permit. This permit is issued pursuant to the requirements
of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between
North Carolina and the US Environmental Protection Agency dated October 15, 2007 (or as
subsequently amended).
This certificate of coverage is not transferable. If the facility changes ownership or is
closed, the Division of Energy Mineral & Land Resources may require modification,
revocation or reissuance of the certificate of coverage.
Per the requirements of the Neuse Riparian Buffer Rule, aii storaiwater drainage to
stream buffers, from portions of this site that have been constructed after July 22, 1997,
must be discharged through a correctly designed level spreader or another device that
meets diffuse Flow requirements per 15A NCAC 2B .0233. Diffuse Flow requirements are
described in Chapter 8 of the North Carolina Stormwatei "MP Manual, available at:
nttp:f/poEtaJ,r_�<Je_trar5� ✓eb/lc/bnIp-manual.
This permit does not affect the leg
al obligation to obtain other permits which may
be required by the Divisionof Energy, Mining, and Land Resources, or any other federal,
state, or local authorities.
1612 Mail Service Center, Raleigh, North Carolina 27699-1612 • Telephone [phone] / FAX: [phone]
512 North Salisbury Street, Raleigh, North Carolina 27604 - Internet: http://poital.ncdenr.org/web/ir/land-quality
An Equal Opportunity 1 Affirmative Action Employer — 50% Recycled 110% Post Consumer Paper

V 4
If you have any questions concerning this permit, please contact Larry Wade PE at
telephone number [phone].
Sincerely,
for Tracy F, 11a.vis; P.F.
cc: Raleigh Regional Office
Central Files
Stormwater Permitting Program Files
1612 Mail Service Center, Raleigh, North Carolina 27699-1612 • Telephone [phone] / FAX: [phone]
512 North Salisbury Street, Raleigh, North Carolina 27604 • Internet: http://portal.ricdenr.org/web/Ir/land-quality
An Equal'Opportunity 1 Affirmative Action Employer — 50% Recycled 110% Post Consumer Paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF ENERGY, MINERAL, AND LAND RESOURCES
GENERAL PERMIT NO. NCG020000
CERTIFICATE OF COVERAGE No. NCG020855
STORN1WATr..R nl"'MARGES
NATIONAL POLLIITANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
R. M. Hayes Construction, Inc.
is hereby authorized to discharge stormwater from a facility located at
Stone Creek Sand & Gravel Mine
7499 U. S. Hwy 70 S
Four Oaks
Johnston County
to receiving waters designated as Mill Creek, a class WS I-IV;NSW water in the Neuse River
Basin, in accordance with the effluent limitations, monitoring requirements, and other
conditions set forth in Parts I,11, 111, IV, V, and VI of General Permit No. NCG020000 as
attached.
This certificate of coverage shall become effective January 23, 2014.
This Certi:'. ate of Gaverage S!:all remain: in effect for the duration of tl:e General Permit.
Signed this day January 23, 2014.
for Tracy E. Davis, P.E., Director
Division of Energy, Mineral, and Land Resources
By the Authority of the Environmental Management Commission

NCGi 20855
Map Scale 1:24, 000
R. M. Hayes Construction, Inc.
Stone Creek Sand & Gravel Mine
Latitude: 350 19' 52" N
Longitude: -780 21' 39" W
County: Johnston
Receiving Stream: Mill Creek
Stream Class: WSI-IV;NSW
Sub -basin: 03-04-04 (Neuse River Basin)
Facility Location

Central Files: APS SWP
01 /23/14
Permit Number NCG020855
Permit Tracking Slip
Program Category
Status Project Type
NPDES SW
Active New Project
Permit Type
Version Permit Classification
Mining Activities Stormwater Discharge COC
1.00 COC
Primary Reviewer
larry.wade
Coastal SW Rule
Permitted Flow
Facility Name
Stone Creek Sand & Gravel Mine
{ Permit Contact Affiliation
RECE V G®
J AN 2 3 Z014
CEpWQES
IBOG
Major/Minor Region
Minor Raleigh
Location Address County
7499 US Hwy 701 S Johnston
Four Oaks NC 27524 Facility Contact Affiliation
Raymond M. Hayes
1646 B Strickland's Crossroads Rd
Four Oaks NC 27524
Owner Name
R M Hayes Construction Co inc
Scheduled
Orig Issue App Received Draft Initiated Issuance
01/23/14 10/07/13 01/22/14
egulated Activities
Mining activities - stormwater discharges
Outfall 100
Waterbody Name
Mill Creek
Owner Type
Non -Government
Owner Affiliation
Raymond M. Hayes
1646 B Strickland's Crossroads Rd
Four Oaks NC 27524
Public Notice Issue Effective Expiration
01/23/14 01/23/14 12/31/14
Requested/Received Events
RO staff report received - MGi�t fdaO r.
RO staff report requested 17/13
Stream Index Number Current Class Subbasin
27-52-(8.5) WS-IV;NSW 03-04-04

r
NC®ENR
North Carolina Department of Environment and Natural Resources
Division of Energy, Mineral, and Land Resources
Land Quality Section
Tracy E. Davis, PE, CPM
Director
January 23, 2014
Mr. R. M. Haves
R. M. Hayes Construction, Inc.
1646 Stricklands Crossroads Rd.
Four Oaks, NC 27524
Pat McCrory, Governor
John E. Skvarla, III, Secretary
Subject: General Permit No. NCG020000
Stone Creek Sand & Gravel Mine
CDC NCG020855
Johnston County
Dear Mr. Hayes:
In accordance with your application for a discharge permit received on October 7,
2013, we are forwarding herewith the subject certificate of coverage to discharge under the
subject state - NPDES general permit. This permit is issued pursuant to the requirements
of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between
North Carolina and the US Environmental Protection Agency dated October 15, 2007 (or as
subsequently amended).
This certificate of coverage is not transferable. If the facility changes ownership or is
closed, the Division of Energy Mineral & Land Resources may require modification,
revocation or reissuance of thecertificate of coverage.
Per the requirements of the Neuse Riparian: Buffer Rule, a sto: inwater drainage to
stream buffers, from portions of this site that have been constructed after July 22, 1997,
must be discharged through a correctly designed level spreader or another device that
meets diffuse flow requirements per 15A NCAC 2B .0233. Diffuse flow requirements are
described In Chapter B of Cite North Carolina Stormwater BMP Manual, availabie at:
ftG.:f ic;:rla.rcacrtl_.:�rg�wl�lr/imp mnn; J.
This permit deer not affect the legal obligation to obtain other permits which may
be required by the Division of Energy, Miring, and Land Resources, or any other federal,
state, or local authorities.
1612 Mail Service Center, Raleigh, North Carolina 27699-1612 • Telephone [phone] FAX: [phone]
512 North Salisbury Street, Raleigh, North Carolina 27604 • Internet: http://poital.ncdenr.org/web/Ir/land-quality
An Equal Opportunity \ Affirmative Action Employer - 50% Recycled \ 10% Post Consumer Paper

If you have any questions concerning this permit, please contact Larry Wade PE at
telephone number (919) 807-637S.
Sincerely,
for Tracy E. Davis, P.E.
cc: Raleigh Regional Office
Central Files
Stormwater Permitting Program Files
1612 Mail Service Center, Raleigh, North Carolina 27699-1612 • Telephone [phone] / FAX: [phone]
512 North Salisbury Street, Raleigh, North Carolina 27604 • Internet: http://portal.ncdenr.org/web/ir/land-quality
An Equal Opportunity 1 Affirmative Action Employer — 50% Recycled 110% Post Consumer Paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF ENERGY, MINERAL, AND LAND RESOURCES
GENERAL PERMIT NO. NCG020000
CERTIFICATE OF COVERAGE No. NCG020855
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
R. M. Hayes Construction, Inc.
is hereby authorized to discharge stormwater from a facility located at
Stone Creek Sand & Gravel Mine
7499 U. S. Hwy 70 S
Four Oaks
Johnston County
to receiving waters designated as Mill Creek, a class WS I-IV;NSW water in the Neuse River
Basin, in accordance with the effluent limitations, monitoring requirements, and other
conditions set forth in Parts I, 11, 111, IV, V, and VI of General Permit No. NCG020000 as
attached.
This certificate of coverage shall become effective January 23, 2014.
This Certific Ce of Coverage shall rernain in effect for the d : atim: of the General Permit.
Signed this day January 23, 2014.
for Tracy E. Davis, P.E., Director
Division of Energy, Mineral, and Land Resources
By the Authority of the Environmental Management Commission

NCG02 855
0
` Map Scale 1:24, 000
R. M. Hayes Construction, Inc.
Stone Creek Sand & Gravel Mine
Latitude: 350 19' 52" N
Longitude: -780 21' 39" W
County: Johnston
Receiving Stream: Mill Creek
Stream Class: WSI-IV;NSW
Sub -basin: 03-04-04 (Neuse River Basin)
1Q -
Facility Location

Division of Water Quality / Surface Water Protection
NC®ENR National Pollutant Discharge Elimination System
Nonni U Dvnrxort on
EnvinOxn[xi u0 NMnLL RpWFCC9
NCG020000
NOTICE OF INTENT
FOR AGENCY USF ONLY
Dme Recened
Year
Month
I0
r1
'1
Certificate of Coverage
NC )0fa
Check N
1 Amonnt
23
too
Permit Assigned to
National Pollutant Discharge Elimination System application for coverage under General Permit
NCG020000:
STORMWATER DISCHARGES associated with activities classified as:
SIC (Standard Industrial Classification) Code - 14XX Mineral Mining Industry (except as specified below)
The following activities are also included:
Active or inactive mining operations (including borrow pits —except for NCDOT borrow pits) that discharge
stormwater contaminated with or that has come in contact with, any overburden, raw material, intermediate
products, finished products, byproducts or waste products located on the site of such operations;
Stormwater from vehicle maintenance activities at mining operations,
Overflow from facilities that recycle process wastewater; and/or
Mine dewatering (wastewater)
The following activities are specifically excluded from coverage under this General Permit:
Stormwater discharges associated with peat mining, coal mining, and metal mining,
Stormwater discharges from mining operations which are intermixed on site with stormwater from asphalt
operations and/or concrete operations,
Stormwater discharges associated with oil and gas extraction operations; and
Stormwater discharges associated with tourist gem mines
NCDOT borrow pits are covered under NCS000150
The following discharges are covered by NPDES general permit NCG520000 instead of NCG020000:
Point source discharges of stormwater and wastewater from in -stream sand mining operations (i.e., sand
dredging or dipping operations).
Please contact the NPDES Wastewater Point -Source Group for more information on coverage under this
Please print or tvne all entries in this aoolication form
1) Mailing address of owner/operator (official address to which all permit correspondence will be mailed):
Legal Owner Name R.M. Haves Construction Inc.
(Attach the most recent Annual Report to the NC Secretary of State showing the current legal name of the corporation or entity.
Alternatively this permit can be given to an individual or government authority. This name must be the same name as appears on the
Division of Land Resources' Mining Permit.)
Signee's Name (as signed for in permit signature at bottom) R.M. Haves
Street Address 1646 Stricklands Crossroads Rd.
City Four Oaks State NC_ ZIP Code 27524
Telephone No. 919-934-0106 Email
Alternate Contact Name
Alternate Contact Telephone (if different)
Email (if different)
ISV�U V L5
OCT - 7 2013
Page 1 of 8
SWU-NCG02-NOI

NCG020000 N.O.I.
2) Location of facility producing discharge:
Facility Name Stone Creek Sand & Gravel Mine
Facility Street Address 7499 US Hwy 701 S.
Facility City Four Oaks State NC ZIP Code 27524
Facility County Johnston
Facility Contact R.M. Haves
Telephone No. 919-934-0106 Fax:
Contact E-mail
3) Physical Location Information:
Please provide a narrative description of how to get to the facility (use street names, state road numbers, and
distance and direction from a roadway intersection). From 1-95, take HWY701 South. The mine is on the
right about 10 miles from the intersection.
4) Latitude 35* 19' 52" Longitude 78* 21' 39" (degrees, minutes,
seconds)
Permits:
5) This NPDES Permit Application applies to which of the following:
❑ New or Proposed Facility Date operation is to begin:
X Existing Date began mining: 2006
6) Standard Industrial Classification:
Provide the 4 digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial
activity at this facility l yya
SIC Code: 0 0 1 4
7) Provide a narrative description of the types of minerals mined at this facility: Fill dirt, sand, and gravel.
8) Is this mine an inactive mine site?
X No
❑ Yes If yes, do you posses an "Inactive Renewal" from DEMLR and notified the DWQ Regional Office or
have you certified to the DWQ that the site has been stabilized? ❑ No ❑ Yes
9) Does this facility already have a valid Mining Permit from the Division of Energy, Mineral and Land Resources
(DEMLR) [formerly DLR]?
❑ No
X Yes
If No, please indicate the status of the Mining Permit application:
If yes, please provide the Mining Permit number: 51-45 Please also
provide a copy of your DEMLR Mining Permit with this DWQ application.
Note: DWQ cannot issue a COC for the NCG020000 General Permit until a Mining Permit is issued or
renewed by the DEMLR.
10) Does this facility have any other NPDES permits?
X No
❑ Yes If yes, list the permit numbers for all current NPDES permits for this facility:
Page 2 of 8
SWU-NCG02-NOI Last revised 9/5/2012
t

NCG020000 N.O.I.
11) Are you applying for a mining permit in the same location as a previously permitted mine?
X No
❑ Yes If yes, specify permit number and name if known:
12) Does this facility have any Non -Discharge permits (ex: recycle permits)?
X No
❑ Yes If yes, list the permit numbers for all current Non -Discharge permits for this facility:
13) Does total area of this mine site include ready -mix and asphalt areas?
X No
❑ Yes
If yes, do they have DWQ stormwater permits (if owned by the same company)? ❑ No
(provide permit number )
If not owned by the same company, who is the owner?
14) Will this mining operation precede development activities at this site?
X No
❑ Yes
❑ Yes
15) Is this mine located within one of the 20 Coastal Counties and will it add more than 10,000 ft2 of impervious
surface?
X No
❑ Yes If yes, you may be required to apply for an additional state stormwater permit. Check with your
local Regional Office. See contact information and checklist below.
16) Is this mine located the Neuse, Tar -Pamlico, or Catawba River Basins, or the Randleman or Jordan
Water supply Watersheds?
❑ No
X Yes If yes, what size stream buffers are included on site? No stream is within 1500' of mining area
Please show buffers in site plans.
If yes, please include information and plans showing diffuse flow through buffers as required.
Discharge Points, Receiving Waters & Wetlands:
17) Receiving waters:
What is the name of the body or bodies of water (creek, stream, river, lake, etc.) that the facility stormwater
and/or wastewater discharges end up in? Mill Creek
If the site stormwater discharges to a separate storm sewer system, name the operator of the separate storm
sewer system (e.g. City of Raleigh municipal storm sewer). N/A
Receiving water classification (if known)
Note: Discharge of industrial wastewater to receiving waters classified as WS-II to WS-V, or SA, must
be approved by the Div. of Water Resources, or Div. of Marine Fisheries. If DWR or DMF does
not approve, coverage under NCG020000 cannot be granted. No new discharges of wastewater
are permitted in receiving waters classified as WS-1 or freshwater ORW. Wastewater
discharges to Saltwater ORW will not be approved under the NCG02 General Permit.
18) If your facility has wastewater discharges and they are to HWQ and/or PNA waters (Primary Nursery Areas)
waters, what is the proposed flow rate? (See
http://www.ncdmf.net/maps/FNA maps/index.html, for map)
Page 3 of 8
SWU-NCG02-NOI Last revised 9/5/2012

NCG020000 N.O.I.
19) Discharge Points:
Number of discharge points (ditches, pipes, channels, etc. that convey discharges from the property):
Onsite: Stormwater: 5 Mine dewatering: 0 Process Wastewater Overflow: 0
Offsite: Stormwater: 0 Mine dewatering: 0 Process Wastewater Overflow: 0
Discharge points should be clearly marked on the submitted site plan.
Please provide short narrative description of discharges: Stormwater runoff through sediment basins. Only
three basins will be discharging at any given time.
a) Is your mine dewatering and discharging? (Answer only if you are dewatering)
X No
❑ Yes If yes, where to? _ Surface Waters and/or Wetlands (on -site or off -site)
_ Other (on -site or off -site) Describe:
b) Are you dewatering but not discharging? (Answer only if you are dewatering)
INNER
❑ Yes If Yes, please explain how you are dewatering, and where that water will be directed:
20) Will mining operations require dewatering near wetlands or impact any stream, groundwater, or wetlands?
X No
❑ Yes
Note: Wetlands must be CLEARLY DELINEATED on the site plan. Mine dewatering activities that have
the potential to drain wetlands or otherwise impact surface water or groundwater MUST develop and
implement a Pumping Operation and Monitoring (O&M) Plan that has been approved by the
Division.
For sites that may drain wetlands — approval of a Pumping O&M plan may be required prior to
coverage under this general permit. The Pumping O&M Plan should be submitted to the
appropriate Regional Office and must be approved prior to operation.
The plan shall include, but is not limited to: (1) Groundwater monitoring strategies to demonstrate the
effect of pumping and to establish any pumping regime necessary to reduce impacts, and (2) Detailed
plans to maintain surrounding hydrology and respective monitoring to demonstrate compliance. See
checklist at end of document. Contact your local Regional Office for questions specific to your mine.
21) If you are dewatering, are there wetlands or surface waters within 400' of the mine pit perimeter?
❑ No
❑ Yes If yes, what distance are they from the mine pit perimeter?
22) Have you been required to obtain a 4041401 Certification permits?
X No
❑ Yes If yes, please briefly describe below (include information such a required mitigation, BMPs, setbacks,
and/or O&M plans for on or off -site wetlands or other pertinent information). Attach other sheets as necessary:
Page 4 of 8
SWU-NCG02-NOI Last revised 9/5/2012

NCG020000 N.O.I.
23) Have you been required to obtain a wetland delineation certified by the US Army Corps of Engineers?
X No ❑ Yes If yes, please attach to application submission.
Stormwater BMPs:
24) Does this facility employ any best management practices for stormwater control?
❑ No X Yes If yes, please briefly describe: Retention and Wet Detention Basins for
stormwater runoff.
25) Does this facility have a Stormwater Pollution Prevention Plan?
X No ❑ Yes
If yes, when was it implemented?
26) Will vehicle maintenance activities occur at this facility?
X No ❑ Yes
Wastewater Treatment Facilities:
27) Will mine dewatering discharges occur?
X No
❑ Yes
28) Will discharges of overflows from process wastewater treatment systems occur?
X No
❑ Yes If yes,
a. Does this facility employ chemical additives to flocculate suspended solids? ❑ No ❑ Yes
If yes, please state the name, manufacturer and the quantity of average daily usage of the chemical additive
Note: Please see our website for a list of evaluated polyacrylamide (PAMS) products for use in North Carolina:
http://portal.ncdenr.org/web/wq/ws/su/npdessw
b. Does this facility overflow only during rainfall events exceeding the 10-yr, 24-hr rainfall event?
❑ No ❑ Yes
29) Are wastewater treatment facilities (including recycle systems) planned in the 100-year flood plain?
X No
❑ Yes
30) Is your facility washing mined materials?
❑ No
X Yes If Yes, are you discharging this water? No there will be a re -circulation system
Page 5 of 8
SWU-NCG02-NOI Last revised 9/5/2012

NCG020000 N.O.I.
Other:
31) Hazardous Waste:
a) Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility?
X No ❑ Yes
b) Is this facility a Small Quantity Generator (less than 1000 kg. of hazardous waste generated per month) of
hazardous waste?
X No ❑ Yes
c) Is this facility a Large Quantity Generator (1000 kg. or more of hazardous waste generated per month) of
hazardous waste?
X No ❑ Yes
d) If you answered yes to questions b. or c., please provide the following information:
Type(s) of waste:
How is material stored: _
Where is material stored:
How many disposal shipments per year:
Name of transport / disposal vendor:
Vendor address:
32) Is your facility providing appropriate secondary containment for bulk storage of liquid materials? See permit
text for secondary containment requirements.
X No
❑ Yes
33) Does your site have an active landfill within the mining permit boundary?
X No
❑ Yes If yes, specify type: ❑ LCID ❑ Other:
Final Checklist:
This application will be returned as incomplete unless all of the following items have been included and
initialed for. Please show that the following required information has been included by initialing in each
space below.
Fee of $100 made payable to NCDENR.
Completed application and all supporting documents.
Copy of the valid approved mining permit (MP) for the facility or indication of MP application status.
Copy of a county map or other general location map that shows the mining site and nearest major roads.
Copy of USGS topographic map showing the mining site and surrounding areas, or other map that clearly
shows site location in relation to nearby streams, wetlands, and other waters, etc.
2 copies of large-scale (minimum 24" x 36") site plan with topographical lines with all outfalls, applicable
buffers and wetlands clearly delineated, and 100-year flood plain line if applicable.
A copy of your DEMLR mining permit.
A copy of your US Army Corps -approved wetland delineation if you marked "yes' to question 23 above.
A line drawing of the water flow through the facility. A pictorial description of the nature and amount of any
sources of water and any collection and treatment measures.
_ If mine site is in one of the 20 Coastal Counties:
• Applicant has checked with the appropriate regional office to verify the need for a Coastal State
Stormwater permit. Regional Office Contact:
Page 6 of 8
SWU-NCG02-NOI Last revised 9/5/2012

NCG020000 N.O.I.
Applicant has included a detailed list of impervious surface areas and percentages, sub -drainage
areas and total drainage area.
If the mine is dewatering and near wetlands, or may otherwise impact surface waters or groundwater,
include the following and contact your local regional office about a Pumping O&M Plan (see below
for contact information). You may be required to provide an approved Pumping O&M plan priorto
NCG02 issuance.
_2 copies of detailed Full Size Plans (at least 24" x 36") delineating areas on the plans and listing
acreage (including: wetlands, ditches, well -placements, pits, borrow areas, overburden storage,
stormwater controls/BMPs, vehicle maintenance areas, settling basins, product process (such as
screening, stockpiles, waste piles), total drainage area, impervious surface percentages (if state sw
programs apply), applicable buffers, and access and/or haul roads).
_Pump dewatering size and information on its specifications.
_Well information (design, depths, maintenance).
_Physical monitoring for the wetlands areas.
_Settling pond sizing information, if applicable.
_Level spreader design, if applicable.
_Details about dewatering method.
_Cone of influence calculations.
_Description of measures to prevent erosion and flooding.
_Description & information about 401/404 permits that have been obtained.
_Copy of US Army Corps of Engineers wetland delineations or approved wetland delineation (if
applicable).
_I have contacted my local regional office about a Pumping O&M Plan.
Regional Office Contact: Date contacted:
-OR-
X I will not any impact nearby wetlands, surface waters or groundwater by dewatering.
Certification: North Carolina General Statute 143-215.6 b (i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan, or other
document fled or required to be maintained under this Article or a rule implementing this Article; or who knowingly makes a false
statement of a material fact in a rulemaking proceeding or contested case under this Article; or who falsifies, tampers with, or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
[Environmental Management] Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine not to
exceed ten thousand dollars ($10,000).
33) Signatory Requirements (per 40 CFR 122.22)
All applications, reports, or information submitted to the Director shall be signed and certified.
a. All notices of intent to be covered under this General Permit shall be signed as follows:
(1) For a corporation: by a responsible corporate officer. For the purpose of this permit, a responsible corporate officer means: (a) a president,
secretary, treasurer or vice president of the corporation in charge of a principal business function, or any other person who performs similar
policy or decision making functions for the corporation, or (b) the manager of one or more manufacturing production or operating facilities
employing more than 250 persons or having gross annual sales or expenditures exceeding 25 million (in second quarter 1980 dollars), if
authority to sign documents has been assigned or delegated to the manager in accordance with corporate procedures.
(2) For a partnership or sole proprietorship: by a general partner or the proprietor, respectively; or
(3) For a municipality, state, federal, or other public agency: by either a principal executive officer or ranking elected official.
I hereby request coverage under the referenced General Permit. I understand that coverage under this permit will
constitute the permit requirements for the discharge(s) and is enforceable in the same manner as an individual
permit.
I agree to abide by the following as a part of coverage under this General Permit:
1. 1 agree to abide by the approved Mining Permit for this mining activity. (A copy of the valid
mining permit must be attached to this request.
Page 7 of 8
SWU-NCG02-NOI Last revised 9/5/2012

NCG020000 N.O.I.
2. 1 agree to not discharge any sanitary wastewater from this mining activity except under the
provisions of another NPDES permit specifically issued therefore.
3. 1 agree that bulk storage of petroleum products and other chemicals shall have adequate
protection so as to contain all spills on the site.
4. 1 agree that solid wastes will be disposed of in accordance with N.C. statutes and rules
governing solid waste disposal.
5. 1 agree that maintenance activities for vehicles and heavy equipment will be performed so as to
not result in contamination of the surface or ground waters.
I agree to abide by the provisions as listed above and recognize that the provisions are to be considered as
enforceable requirements of the General Permit.
I certify that I am familiar with the information contained in this application and that to the best of my knowledge
and belief such information is true, complete, and accurate.
Printed Name of Person Signing: R.M. Haves
Title: President
i 2V 4 /L 9-2--7- aC'U
(Signature of Applica (Date Signed)
Notice of Intent must be accompanied by a check or money order for $100.00 made payable to NCDENR.
Mail the entire package to:
Stormwater and General Permits Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Note
The submission of this document does not guarantee the issuance of an NPDES permit.
For questions, please contact the DWQ Regional Office for your area.
DWQ Regional Office Contact Information:
Asheville Office ......
[phone]
Fayetteville Office ...
[phone]
Mooresville Office ...
[phone]
Raleigh Office ........
[phone]
Washington Office ...(252)
946-6481
Wilmington Office ...
[phone]
Winston-Salem ......
[phone]
Central Office .........(919)
807-6300
Page 8 of 8
SWU-NCG02-NOI Last revised 9/5/2012

Scale: 1 "=1 500' (Approx.)

1187 I O 1194
8 0
1136
1°° o �Q Bentonville
143
Battlefield
e M 0
p 1185 !
1190 0
r
mds B Minle A ea r 1189 J 118f;
e I'Harper
1144 ;a Pre d
1 Mine Aaea
v
Overshot _ 88 Q
r-�
P d 'e f 1r
` 1137 , /1
r 1135
1135
rg 1136
` s a 1132 /
8 .61 I
1 .6 / u
1 1136 e1138 f 1008
.`� 11 2 1� ` s.
Ca
13°9' 113(
-:1
'fi 1136
32� P 11R� 1122
Scale: V=4000' (Approx.)

PAYTOTHE NCDENR $ '*100.00
ORDER OF
One Hundred and 00/100,,,,,,,,,,,,,,,,,,,,,,,,,»..,,.,.......,.,.,,,.,,......,,..,.,»,..,..,..,,.,,.....,.....,..,..,
DOLLARS
A TAMPER RESISTANT TONER AREA

Wade, Larry
From:
Parnell, David
Sent:
Friday, November 08, 2013 10:15 AM
To:
Wade, Larry
Subject:
Stormwater Permits
Larry
It is permissible with RRO — DEMLR — DLR — Stormwater, to go forward with approval of the following facility's
permits:
• NCG020855 - R. M. Hayes Const — Stone Creek Sand and Gravel Mine
• NCG140431 - Morgan Corp Roxboro Pugmill
• NCG020854—General Shale, Colon Mine
Thanks,
Dave Parnell
Environmental Senior Specialist
North Carolina Department of Environment & Natural Resources
Division of Energy, Minerals, and Land Resources
Raleigh Regional Office
3800 Barrett Drive
Raleigh, NC 27609
0: [phone]
F: [phone]
E-mail correspondence to and from this address may be subject to the North Carolina Public Records Law
and may be disclosed to third parties.
1

Wade, Larry
From: Wade, Larry
Sent: Thursday, October 17, 2013 1:34 PM
To: Parnell, David
Subject: NCG020855 R. M. Hayes Const. - Stone Creek Sand & Gravel Mine
Attachments: Hayes NOI.pdf
Hello David,
Find attached the N01 for the subject facility. I am sending you a map through courier.
Please review these documents and let me know If you have any concerns, prior to issuing a permit for this facility.
If I do not receive a response from you within 30 days from the date of this email, I will proceed with issuing the permit
contingent upon central office review and approval.
If you have any questions, or require additional information please let me know.
Thanks,
Larry W. Wade PE Telephone: [phone]
Fax: [phone]
Stormwater Permitting Program
North Carolina Department of Environment & Natural Resources
Division of Energy Mineral and Land Resources
1612 Mail Service
9425
Raleigh, NC 27699-1612
Physical Address - 512 N. Salisbury St. Room
Raleigh, NC 27604
************************This is a government E-mail address****************************
*********E-mails sent and received from this address can be disclosed to third parties************

Division of Water Quality / Surface Water Protection
A"FA
NC®ENu/
R National Pollutant Discharge Elimination System
No— Ww—Dwu .ev of
'.vR N En u0 NU Rn R[CWn<e]
NCG020000
NOTICE OF INTENT
FOR AGENCY USE ONLY
Date Received
Year
Month
Day
IO
I h
Certificate
of Coverage
2043
Check
Amount
1 ]3
lop
Permit Assigned to
National Pollutant Discharge Elimination System application for coverage under General Permit
NCG020000:
STORMWATER DISCHARGES associated with activities classified as:
SIC (Standard Industrial Classification) Code - 14XX Mineral Mining Industry (except as specified below)
The following activities are also included:
Active or inactive mining operations (including borrow pits —except for NCDOT borrow pits) that discharge
stormwater contaminated with or that has come in contact with, any overburden, raw material, intermediate
products, finished products, byproducts of waste products iocated on tile site of such operations;
Stormwater from vehicle maintenance activities at mining operations;
Overflow from facilities that recycle process wastewater; and/or
Mine dewatering (wastewater)
The following activities are specifically excluded from coverage under this General Permit:
Stormwater discharges associated with peat mining, coal mining, and metal mining;
Stgrmv✓ater discharges from mining operations which are intermixed on site with stormwater from asphalt
operations and/or concrete operations;
Stormwater discharges associated with oil and gas extraction operations; and
Stormwater discharges associated with tourist gem mines
NCDOT borrow pits are covered under NCS000150
The following discharges are covered by NPDES general permit NCG520000 instead of NCG020000:
Point source discharges of stormwater and wastewater from in -stream sand mining operations (i.e., sand
dredging or dipping operations).
Please contact the NPDES Wastewater Point -Source Group for more information on coverage under this
Please print or tvpe all entries in this application form
1) Mailing address of owner/operator (official address to which all permit correspondence will be mailedl:
Legal Owner Name R.M. Haves Construction, Inc.
(Attach, the most recent Annual Report to the NC Secretary of State showing the current legal name of the corporation or entity.
Alternatively this permit can be given to an individual or government authority. This name must be the same name as appears on the
Division of Land Resources' Mining Permit.)
Signee's Name (as signed for in permit signature at bottom) R.M. Haves
Street Address 1646 Stricklands Crossroads Rd.
City Four Oaks State NC _ ZIP Code 27524
Telephone No. 919-934-0106 Email
Alternate Contact Name
Alternate Contact Telephone (if different)
Email (if different)
cc r NO
OCT - 12013
Page 1 of 8
SWU-NCG02-NOI --"—"-Cos `f'rev"'eJise-gt/2012

NCG020000 N.O.I.
2) Location of facility producing discharge:
Facility Name Stone Creek Sand & Gravel Mine
Facility Street Address 7499 US Hwy 701 S.
Facility City Four Oaks State NC ZIP Code 27524
Facility County Johnston
Facility Contact R.M. Haves
Telephone No. 919-934-0106 Fax:
Contact E-mai!
3) Physical Location !nformati^n:
Please provide a narrative de.scriotion of how to get to the facility (use street names, state road numbers, and
distance and direction from a roadway intersection). From 1-95, take HWY701 South. The mine is on the
right, about 10 miles from the Intersection.
4) Latitude 35" 19' S2" Longitude 78' 21' 39" (degrees, minutes,
seconds)
Permits:
5) This NPDES Permit Application applies to which of the following:
❑ New or Proposed Facility Date operation is to begin:
X Existing Date began mining: 2006
6) Standard Industrial Classification:
Provide the 4 digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial
activity at this facility l 4ya
SIC Code: 0 0 1 4
7) Provide a narrative description of the types of minerals mined at this facility: Fill dirt, sand, and gravel.
8) Is this mine an inactive mine site?
:LC
❑ Yes If yes, do you posses an "Inactive Renewal" from DEMLR and notified the DWQ Regional Office or
have you certified to the DWQ that the site has been stabilized? ❑ No ❑ Yes
9) Does this facility already have a valid Mining Permit from the Division of Energy, Mineral and Land Resources
(DEMLR) [formerly DLR]?
❑ No
X Yes
If No, please indicate the status of the Mining Permit application:
If yes, please provide the Mining Permit number: 51-45
provide a copy of your DEMLR Mining Permit with this DWQ application.
Please also
Note: DWQ cannot issue a CDC for the NCG020000 General Permit until a Mining Permit is issued,or
renewed by the DEMLR.
10) Does this facility have any other NPDES permits?
X No
❑ Yes If yes, list the permit numbers for all current NPDES permits for this facility:
Page 2 of 8
SWU-NCG02-NOI Last revised 9/5/2012

NCG020000 N.0.1.
11) Are you applying for a mining permit in the same location as a previously permitted mine?
X No
❑ Yes If yes, specify permit number and name if known:
12) Does this facility have any Non -Discharge permits (ex: recycle permits)?
X No
❑ Yes If yes, list the permit numbers for all current Non -Discharge permiis for this facility:
13) Does total area of this mine site include ready -mix and asphalt areas?
X No
❑ Yes
If ves, do thev have DWO stormwater permits (if owned by the same company)? f.] No
(provide permit number )
If not owned by the same company, who is the owner?
14) Will this mining operation precede development activities at this site?
X No
❑ Yes
❑ Yes
15) Is this mine located within one of the 20 Coastal Counties and will it add more than 10,000 ftZ of impervious
surface?
X No
❑ Yes If yes, you may be required to apply for an additional state slormwater permit. Check with your
local Regional Office. See contact information and checklist below.
16) Is this mine located the Neuse, Tar -Pamlico, or Catawba River Basins, or the Randleman or Jordan
Water supply Watersheds?
❑ No
X Yes If yes, what size stream buffers are included on site? No stream is within 1500' of minina area
Please show buffers in site plans.
If yes, please include information and plans showing diffuse flow through buffers as required.
Discharge Points, Receiving Waters Sr Wetlands:
17) Receiving waters:
What is the name of the body or bodies of water (creek, stream, river, lake, etc.) that the facility stormwater
and/or wastewater discharges end up in? Mill Creek
If the site stormwater discharges to a separate storm sewer system, name the operator of the separate storm
sewer system (e.g. City of Raleigh municipal storm sewer). N/A
Receiving water classification (if known) WSI-IV:NSW
Note: Discharge of industrial wastewater to receiving waters classified as WS-II to WS-V, or SA, must
be approved by the Div. of Water Resources, or Div. of Marine Fisheries. If DWR or DMF does
not approve, coverage under NCG020000 cannot be granted. No new discharges of wastewater
are permitted in receiving waters classified as WS-1 or freshwater DIRK Wastewater
discharges to Saltwater ORW will not be approved under the NCG02 General Permit.
18) If your facility has wastewater discharges and they are to HWQ and/or PNA waters (Primary Nursery Areas)
waters, what is the proposed flow rate? (See
http://www,ncdmm=.net/mps/index.html, for map)
Page 3 of 8
SWU-NCG02-NOI Last revised 9/5/2012

NCG020000 N.O.I.
19) Discharge Points:
Number of discharge points (ditches, pipes, channels, etc. that convey discharges from the property):
Onsite: Stormwater: 5 Mine dewatering: 0 Process Wastewater Overflow: 0
Offsite: Stormwater: 0 Mine dewatering: 0 Process Wastewater Overflow: 0
Discharge points should be clearly marked on the submitted site plan.
Please provide short narrative description of discharges: Stormwater runoff through sediment basins. On!v
three basins will be discharging at anyg ven tare.
a) Is your mine dewatering and discharging? (Anwar o„ly if you are dewatering)
X No
❑ Yes If yes, where to? _ Surface Waters and/or Wetlands (on -site or off -site)
Other (on -site or off -site) Describe:
b) Are you dewatering but not discharging? (Answer only if you are dewatering)
❑ No
❑ Yes If Yes, please explain how you are dewatering, and where that water will be directed:
20) Will mining operations require dewatering near wetlands or impact any stream, groundwater, or wetlands?
X No
❑ Yes
Note: Wetlands must be CLEARLY DELINEATED on the site plan. Mine dewatering activities that have
the potential to drain wetlands or otherwise impact surface water or groundwater MUST develop and
implement a Pumping Operation and Monitoring (0&M) Plan that has been approved by the
Division.
For sites that may drain wetlands — approval of a Pumping O&M plan may be required prior to
coverage under this general permit. The Pumping O&M Plan should be submitted to the
appropriate Regional Office and must be approved prior to operation.
The plan shall include, but is not limited to: (1) Groundwater monitoring strategies to demonstrate the
effect of pumping and to establish any pumping regime necessary to reduce impacts, and (2) Detailed
plans to maintain surrounding hydrology and respective monitoring to demonstrate compliance. See
checklist at end of document. Contact your local Regional Office for questions specific to your mine.
21) If you are dewatering, are there wetlands or surface waters within 400' of the mine pit perimeter?
❑ No
❑ Yes If yes, what distance are they from the mine pit perimeter? feet.
22) Have you been required to obtain a 404/401 Certification permits?
0U1.
❑ Yes If yes, please briefly des6ribe below (include information such a required mitigation, BMPs, setbacks,
and/or O&M plans for on or off -site wetlands or other pertinent information). Attach other sheets as necessary:
Page 4 of 8
SWU-NCG02-NOI Last revised 9/5I2012

NCG020000 N.O.I.
23) Have you been required to obtain a wetland delineation certified by the US Army Corps of Engineers?
X No ❑ Yes If yes, please attach to application submission.
Stormwater BMPs:
24) Does this facility employ any best management practices for stormwater control?
I_1 No X Yes If yes, please briefly describe: Retention and Wet Detention Basins for
stormwater runoff.
25; Poes this facility have a Stormwater Poilution Prevention Tian-,
X Nc ❑ Yes
If yes, when was it implemented?
26) Will vehicle maintenance activities occur at this facility?
X No ❑ Yes
Wastewater Treatment Facilities:
27) Will mine dewatering discharges occur?
X No
❑ Yes
28) Will discharges of overflows from process wastewater treatment systems occur?
X No
❑ Yes If yes,
a. Does this facility employ chemical additives to flocculate suspended solids? ❑ No ❑ Yes
If yes, please state the name, manufacturer and the quantity of average daily usage of the chemical additive
Note: Please see our website for a list of evaluated polyacrylamide (PAMS) products for use in North Carolina:
b. Does this facility overflow only during rainfall events exceeding the 10-yr, 24-hr rainfall event?
❑ No ❑ Yes
29) Are wastewater treatment facilities (including recycle systems) planned in the 100-year flood plain?
X No
❑ Yes
30) Is your facility washing mined materials?
❑ No
X Yes If Yes, are you discharging this water? No there will be a re -circulation system
Page 5 of 8
SWU-NCG02-NOI Last revised 9/5/2012

NCG020000 N.O.I.
Other:
31) Hazardous Waste:
a) Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility?
X No ❑ Yes
b) Is this facility a Small Quantity Generator (less than 4000 kg. of hazardous waste generated per month) of
hazardous waste?
X No ❑ Yes
cj IS tl"Iis facility a Large Quantity KO. Or mare Of ..^.aZ3:2:OL'S waste generated per mcnrh, of
hazardous waste?
X No ❑ Yes
d) If you answered yes to questions b. or c., please provide the following information:
Tyke(,) of waste:
How is material stored: _
Where is material stored:
How many disposal shipments per year:
Name of transport / disposal vendor: _
Vendor address:
32) Is your facility providing appropriate secondary containment for bulk storage of liquid materials? See permit
text for secondary containment requirements.
X No
❑ Yes
33) Does your site have an active landfill within the mining permit boundary?
X No
❑ Yes If yes, specify type: ❑ LCID ❑ Other:
Final Checklist:
This application will be returned as incomplete unless all of the following items have been included and
initialed for. Please show that the following required information has been included by initialing in each
space below.
Fee of $100 made payable to NCDENR.
Completed application and all supporting documents.
Copy of the valid approved mining permit (MP) for the facility or indication of MP application status.
Copy of a county map or other general location map that shows the mining site and nearest major roads.
Copy of USGS topographic map showing the mining site and surrounding areas, or other map that clearly
shows site location in relation to nearby streams, wetlands, and other waters, etc.
2 copies of large-scale (minimum 24" x 36") site plan with topographical lines with all outfalls, applicable
buffers and wetlands clearly delineated, and 100-year flood plain line if applicable.
_ A copy of your DEMLR mining permit.
A copy of your US Army Corps -approved wetland delineation if you marked "yes" to question 23 above.
A line drawing of the water flow through the facility. A pictorial description of the nature and amount of any
sources of water and any collection and treatment measures.
_ If mine site is in one of the 20 Coastal Counties:
• Applicant has checked with the appropriate regional office to verify the need for a Coastal State
Stormwater permit. Regional Office Contact:
Page 6 of 8
SWU-NCG02-NOI Last revised 9/5/2012

NCG020000 N.O.I.
• Applicant has included a detailed list of impervious surface areas and percentages, sub -drainage
areas and total drainage area.
_ If the mine is dewatering and near wetlands, or may otherwise impact surface waters or groundwater,
include the following and contact your local regional office about a Pumping O&M Plan (see below
for contact information). You may be required to provide an approved Pumping O&M plan priorto
NCG02 issuance.
_2 copies of detailed Full Size P!ans (at !east 24" x 36") delineating areas on the plans and listing
ac.aaaa Qndudcg: wetlands, ditches, well -placements, pits, borrow areas, over storage,
stormwater controls/BMPs, vehicle maintenance areas, settling basins, product process (such as
screening. stuck,:Aes, waste plies), total drainage aiva, impervious surface uercantaaes (if state sw
p:-3gran15 app;c aGp lGatiiB buffers, and access aiid/or liFul roads).
_Pump dewatering size and information on its specifications.
—Well information (design, depths, maintenance).
---__Physical monitoring for the wetlands areas.
_Settling pond sizing information, if applicable.
_Level spreader design, if applicable.
_Details about dewatering method.
Cone of influence calculations.
_Description of measures to prevent erosion and flooding.
_Description & information about 401/404 permits that have been obtained.
_Copy of US Army Corps of Engineers wetland delineations or approved wetland. delineation (if
applicable).
_I have contacted my local regional office about a Pumping O&M Plan.
Regional Office Contact. Date contacted:
-OR-
X I will not any impact nearby wetlands, surface waters or groundwater by dewatering.
Certification: North Carolina General Statute 143-215.6 b (i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan, or other
document filed or required to be maintained under this Article or a rule implementing this Article; or who knowingly makes a false
statement of a material fact in a rulemakirg proceeding or contested case under this Article; orwho falsifies, tampers with, or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
[Environmental Management] Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine not to
exceed ten thousand dollars ($10,000).
33) Signatory Requirements (per 40 CFR 122.22)
All applications, reports, or information submitted to the Director shall be signed and certified.
a. All notices of intent to be covered under this General Permit shall be signed as follows:
(1) For a corporation: by a responsible corporate officer. For the purpose of this permit, a responsible corporate officer means: (a) a president,
secretary, treasurer or vice president of the corporation in charge of a principal business function, or any other person who performs similar
policy or decision making functions for the corporation, or (b) the manager of one or more manufacturing production or operating facilities
employing more than 250 persons or having gross annual sales or expenditures exceeding 25 million (in serond quarter 1980 dollars), if
authority to sign documents has been assigned or delegated to the manager in accordance with corporate procedures.
(2) For a partnership or sole proprietorship: by a general partner or the proprietor, respectively; or
(3) For a municipality, state, federal, or other public agency: by either a principal executive officer or ranking elected official.
I hereby request coverage under the referenced General Permit. I understand that coverage under this permit will
constitute the permit requirements for the discharge(s) and is enforceable in the same manner as an individual
permit.
I agree to abide by the following as a part of coverage under this General Permit:
1. I agree to abide by the approved Mining Permit, for this mining activity. (A copy of the valid
mining permit must be attached to this request.
Page 7 of 8
SWU-NCG02-N01 Last revised 9/5/2012

NCG020000 N.O.I.
2. 1 agree to not discharge any sanitary wastewater from this mining activity except under the
provisions of another NPDES permit specifically issued therefore.
3. 1 agree that bulk storage of petroleum products and other chemicals shall have adequate
protection so as to contain all spills on the site.
4. 1 agree that solid wastes will be disposed of in accordance with N.C. statutes and rules
governing solid waste disposal.
5. 1 agree that maintenance activities for vehicles and heavy equipment wiil be performed so as to
not result in contamination of the surface or ground waters.
I agree'o abide by the piuvlsions as fisted above and recognize ti fat the provisions are to be Considered as
enforceablo requircmentc of tho General Permit.
I certify that 1 arr familiar with the information contained in this application and that to the best of my knowledge
and belief such information is true, complete, and accurate.
Printed Name of Person Signing: R M Haves
Title: President
Y 7 - z (i3
(Signature ofApplica (Date Signed)
Notice of Intent must be accompanied by a check or money order for $100.00 made payable to NCDENR.
Mail the entire package to:
Stormwater and General Permits Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Note
The submission of this document does not guarantee the issuance of an NPDES permit.
For questions, please contact the DWQ Regional Office for your area.
DWQ Regional Office Contact Information:
Asheville Office ......
[phone]
Fayetteville Office ...
[phone]
Mooresville Office ...
[phone]
Raleigh Office ........
[phone]
Washington Office ...(252)
946-6481
Wilmington Office ...
[phone]
Winston-Salem ......
[phone]
Central Office .........
[phone]
Page 8 of 8
SWU-NCG02-NOI Last revised 9/5/2012

Scale: 1 '=1500' (Approx.)

1187 w 1
�4 O 1194
o i 4'a 1
-6
® a 1136'
1•
1143 °� o Bentonville
� f� Bottlefield
y 1190
t �t
`
i B Active 1189 r / 11188
Ids Mine Ar'ea�Q , .8
.B ` 'Harper
n�
v 4 ;k j er 1
1144 ,4 Pro d
Min e Ada ry ,4�I
a �JYAnhot . 88 Q ` b
�— \- 1137 ? �{
1135
1135
rg i 138
1132
1 8
1136 �1138 1�2
IOUs
1133 ) 113(
- I .S A . 1132 1122 ]�-
Scale: 1 "=4000' (Approx.)

PnYTOTHE �1CDEfJti *'100.UU
ORDER OF
r•..._ nn*�xxs:xxaxvw++a+xxr++x*+xa+++axx+++xx+xxxmxxr+sxrxw+x�.eo+xxwxxw+.x+x+x:rxxxrx.x+.+x+.x...+xx.*a x.
One nu Kl eii �;,d ,«/10o
n-._U C3 C3F"- ••U7]-MU 7U.�.7•• u'•�r �v JJ.J '� -

Wade, Larry
From: Parnell, David
Sent: Friday, November 08, 2013 10:15 AM
To: Wade, Larry
Subject: Stormwater Permits
Larry,
It is permissible with Mho — DEMLR — DLR — Stormwater, to go forward oral) approval of the following facilitv's
permit:;:
o NCG0200055 - R. PA. t-layes Const - Stone Creek Sand and Gravel P lira
a NCG140431 - Morgan Corp Roxboro Pugmill
Y NCG020854 — General Shale, Colon Mine
shanks,
Dave Parnell
Environmental Senior Specialist
North Carolina Department of Environment & Natural Resources
Division of Energy, Minerals, and Land Resources
Raleigh Reainnai Office
3800 Barrett Drive
Raleigh, INC 27609
0: (919) 791-420C
F: (9191 571-4718
E-mail correspondence to and from this address may be subject to the North Carolina Public Records Law
and may be disclosed to third parties.

Wade, Larry
From: Wade, Larry
Sent: Thursday, October 17, 2013 1:34 PM
To: Parnell, David
Subject: NCG020855 R. M. Hayes Const. - Stone Creek Sand & Gravel Mine
Attachments: Hayes NOI.pdf
Hello David,
Find attached the NO! for the subject facility. I am sending you a map through courier.
Please review these documents and let me know If you have any concerns, prior to issuing a permit for this facility.
If I do not receive a response from you within 30 days from the date of this email, I will proceed with issuing the permit
contingent upon central office review and approval.
If you gave any questions, ur require additional information please let me know.
Thanks,
Larry W. Wade PE Telephone: [phone]
Fax: [phone]
Stormwater Permitting Program
North Carolina Department of Environment & Natural Resources
Division of Energy Mineral and Land Resources
1612 Mail Service Physical Address - 512 N. Salisbury St. Room
942S
Raleigh, INC 27699-1612 Raleigh, NC 27604
is a government E-mail address****************************
*********E-mails sent and received from this address can be disclosed to third parties************

.. �-a f�.- Y. 1`a la .. I':_ - .. _ 11. ....._ -_., l� ....�it _-� _ .. ..e ♦ .21.[4-
GENERAL PROJECT INFORMATION
The Stone Creek Sand & Gravel Mine (Permit No. 51-45) is located approximately 10
miles south of Smithfield on Hwy 701 in Johnston County. Currently approximately
10.09 acres of land is within the mine permit boundary with 8.7 acres to be disturbed
within the next 10 years. The proposed modification will add 21.5 acres to the permitted
acreage, with 18.9 acres to be disturbed within the next 10 years. The mine areas are
connected by an existing road with an easement agreement.
Total land disturbance within the next 10-years will be 27.6 acres and includes the access
road within the easement agreement. Total permitted land area will be 31.59 acres. The
proposed mine expansion area will use wet detention ponds for erosion control runoff.
The existing mining operation uses front end loaders to excavate for fill dirt, sand, and
gravel. The proposed mine expansion area will be conducted in a similar fashion. Mined
material may be washed and screened periodically at the mine. A recirculation system
will be installed for use in the screening process. There will be no structures except the
screen at the proposed plant area.
Water usage will be approximately 400 gallon Is per minute (0.89 cfs). The water will be
pumped to the recirculation system from the wet detention pond for makeup water. The
recirculation system will not discharge to the wet detention pond.
HydroCAD was used to evaluate the runoff volumes and peak flow rates for a 1-inch
rainfall, as well as the 10-year and 25-year rain events. Erosion control for the proposed
mining area will consist of wet detention basins with perimeter berms to divert the
stormwater runoff to the basins.
The proposed basins will have corrugated metal riser pipes with two (2) holes (2"
diameter) drilled in each riser to slowly drain the basin when the water level goes above
normal pool. A trash rack which covers the top of the riser m well as the 2" holes is
provided for each riser. The system will allow the water to slowly drain out of the
structure for a rainfall event greater than I -inch. The CMP riser pipe inverts will be
placed 6" above the drilled holes. Based on the pipe elevations, watersheds, and basin
storage data, the maximum rainfall depth before the CMP risers begin to discharge is
2.24" for Basin 4 and 2.12" for Basin 5. The basins can pass the 25-year rain event with
one foot of freeboard.
The recirculation system is designed to settle the 0.017 millimeter particle size. Both basins
will have a surface area of 2,000 sf. An 8" Schedule 40 PVC pipe will connect the two
basins.
Upon completion of mining, two (2) lakes will be formed. Basin 3 will be formed into an
approximately 0.9 acre lake. Basin 5 will be an approximately 3.0 acre lake. The
perimeter berms will be removed. Along the perimeter of the mine, ground will be cut to
3:1 (H: V) or flatter slopes. AM areas will be sloped for positive sheet water flow to the
lakes.
Shed
Existing I
Exist.
r
PUMP
RE -CIRCULATION BASIN DETAILS (NTS)
TYPICAL CROSS-SECTION
PLAN VIEW
5' MIN.
50' 50,
�� PUMP
JT BASIN/
POND
SCREEN
Over Land
Flow
40'
')SLOPE
CLEAR WATER BASIN SETTLEMENT BASIN
Minimum Recirculation Basin System Requirements
Volume Retention Time Surface Area
Clear Pond 10,000 fta 187 min. 2000 ft2
Settlement Basin 10,000 fta 187 min. 2000 ft2
Recirculation Basin Construction Specifications
1. Basin system shall be constructed according to the dimensions on the approved plans.
2. Soil backfill for construction of the berths shall be compacted to at least 95 % of the
materials standard Proctor maximum dry density as detemined by ASTM D-698.
3. The basin perimeter and embankment slopes shall be vegitatied as per the approved
plans within 15 days of construction.
Watershed Information
Watershed
No.
Total Area
Acres
fI Exposed Ground
(Acres)
Impervious Surface
(Acres) _ _
% Impervous
Surtace
possible Pollutants
1 a
3.58
3.58
0
0.00%
I Soil particulate
1 b
10.9
8.09
0
0,00%
Soil particulate
2
5.01 !
2.19
0
0.00%
Soil particulate
3a
21.5 !
8.7
0
i 0.00%
Soil particulate
3b
45.4
10.2
0
0.00%
Soil particulate
(1) Exposed ground acreage will vary over time due to mining and reclamation activities.
Note: Only three discharge points will be actively discharging at any point in time.
Discharge Point 1 b will not begin discharging until Discharge Point 1 a has been
removed. This is also true for Discharge Pants 3a and 3b.
LEGEND
Property Line
-- Adjacent Property Line
- - - - Mine Permit Limits
- - 10-Yr Limits of Disturbance
Buffer Limits
Streams
Building
120 Topographic Lines
Soil/Gravel Road (Existing)
Tree Line
PROPOSED BASIN DETAILS (BASINS 4 & 5)
51-I
Il�
{CUTOFF
TRENCH)
SEDIMENT BASIN SCHED
1
�nITI�S�y�
7
Vicinity Map
(NTS)
See Outlet Protection Details
�r
Total Wooded' Grass Disturbed' Q10 Q10 Q25
Q25
Re aired
q
(1)
Provided
Re�aired
sed'Imem
Provided
Sediment Storage,
Maximum
Watershed;
(ac)
Weighted
�t Inflow Outflow
(ac) Cx
Inflow
Outflow
Area
Area
Storage
volume
Volume
Adjacent
Berm Heigh
Basm'I
(ac)�
--
- -
ac
( ) (cfs) (cfs)
--
(cfs )
cfs
( )
(sfl
.. {I
(s8
{�
- -- (� �'
_ f
4
21.5
3.0
9.8 8.7 69 55.11 5.87
78.13
6.37
23,973
37,819
1115 660
37,819 1
7.5' 11
5
45.4
8 1
27.1 10.2
73 58.28 22.81
! 82.63
25.41
25,352
83,740
18,360
83,740
6.75'
(1) Required Surface Area is based on Q10"435
Outlet Pipe
PROPOSED PRIMARY SPILLWAY DETAILS (BASINS 4 & 5)
Cross -Section (NTS)
Drain Valve
Trash Rack +
Top of Riser ) 4 in.
r
6 in.� �-" Bin.
Normal Pool , • �
f
.
Basin 4: 24" Dia. CMP Riser
Basin 5: 36" Dia. CMP Rise£
3 ft. (2) 2 inch holes
6" CMP
C DETAILS
of Berm
Water Level for
25-Yr Rain Event
1 Embankment
Basin 4: 8" Dia. CMP
Basin 5: 24" Dia. CMP
Note: Embed Riser Pipe and Valve Stem Support into Concrete
3000 psi Concrete at 28 days
NOTE: 0.46 CUBIC YARDS OF CONCRETE REQUIRED FOR BASIN 4
1.04 CUBIC YARDS OF CONCRETE REQUIRED FOR BASIN 5
Basin 4: 3' � � �' 0 1
Basin 5: 6' 0 C J G
0 0
1� `' , L) C
r � o �<
C) % 5" C q Basin 4: 11'
dnw Basin 4: r6�
C ) Basin 5: 16'
o � � Era 5:`43:55 ,
`\ \ 0 V
Basin 4: 10'
Basin 5: 14'
BASIN OUTLET DETAILS (BASIN 1-3)
Cross -Section (NTS)
5 FT
2 -
MIN/Front View (NTS)
�
\ 1' FREEBOARD
i.ri II \ of'I
7.0�7 �i � i �° f 79 min
�2:1SIDE
3F7 it�g, 3' S=g ° j r SLOPEMAX
�� So
FILTEIDE SLOPE
FABRIC
-3 FT
1
Try �
,.�" lard, ,<_ 5t •;� I i
2 C ENGINEERING & ENVIRONMENTAL DATE:
SCIENCE COMPANY 09/27)
3008 Anderson Drive DRAWN:
Raleigh, NC 27609
[phone] RW
Stormwater Plan REVISED:
Scale: V= 100' _-Altuttn..- _ _ _ _ -
f • 1,
i
I 11
1 f' ' 1 i.1•. •,

GENERAL PROJECT INFORMATION
The Stone Creek Sand & Gravel Mine (Pemut No. 51-45) is located approximately 10
miles south of Smithfield on Hwy 701 in Johnston County. Currently approximately
10.09 acres of land is within the mine permit boundary with 8.7 acres to be disturbed
within the next 10 years. The proposed modification will add 21.5 acres to the permitted
acreage, with 18.9 acres to be disturbed within the next 10 years. The mine areas are
connected by an existing road with an easement agreement.
Total land disturbance within the next 10-years will be 27.6 acres and includes the access
road within the easement agreement. Total permitted land area will be 31.59 acres. The
proposed mine expansion area will use wet detention ponds for erosion control runoff.
The existing mining operation uses front end loaders to excavate for fill dirt, sand, and
gravel. The proposed mine expansion area will be conducted in a similar fashion. Mined
material may be washed and screened periodically ar the mine. A recirculation system
will be installed for use in the screening process. There will he no structures except the
screen at the proposed plant area.
Water usage will be approximately 400 gallon s per minute (0.89 cfs). The water will be
pumped to the recirculation system from the wet detention pond for makeup water. The
recirculation system will not discharge to the wet detention pond.
HydroCAD was used to evaluate the runoff volumes and peak flow rates for a 1-inch
rainfall, as well as the 10-year and 25 -year rain events. Erosion control for the proposed
mining area will consist of wet detention basins with perimeter berms to divert the
stormwater runoff to the basins.
The proposed basins will have corrugated meta) riser pipes with two (2) holes (2"
diameter) drilled in each riser to slowly drain the basin when the water level goes above
normal pool. A trash rack which covers the top of the riser as well as the 2" holes is
provided for each riser. The system will allow the water to slowly drain out of the
structure for a rainfall event greater than 1 -inch. The CMP riser pipe inverts will be
placed 6" above the drilled holes . Based on the pipe elevations, watershed s, and basin
storage data, the maximum rainfall depth before the CMP risers begin to discharge is
2.24" for Basin 4 and 2.12" for Basin 5. The basins can pass the 25-year rain event with
one foot of freeboard.
The recirculation system is designed to settle the 0.017 millimeter particle size. Both basins
will have a surface area of 2,000 sf An 8" Schedule 40 PVC pipe will connect the two
basins.
Upon completion of mining, two (2) lakes will be formed. Basin 3 will be formed into an
approximately 0.9 acre lake. Basin 5 will be an approximately 3.0 acre lake. The
perimeter berms will be removed. Along the perimeter of the mine, ground will be cut to
3:1 (H:V) or flatter slopes. All areas will be sloped for positive sheet water flow to the
lakes.
�X�Sti�n�
PUMP
50,
RE -CIRCULATION BASIN DETAILS (NTS)
IJF-@\V/I�rirj
4o,
ENT BAS
1
50'
Over Land
Flow
TYPICAL CROSS-SECTION
5' MIN.
) SLOPE
CLEAR WATER BASIN SETTLEMENT BASIN
Minimum Recirculation Basin System Requirements
Volume Retention Time Surface Area
Clear Pond 10,000 fta 187 min. 2000 ft2
Settlement Basin 10,000 fta 187 min. 2000 ft2
Recirculation Basin Construction Specifications
1. Basin system shall be constructed according to the dimensions on the approved plans.
2. Soil backfill for construction of the berms shall be compacted to at least 95 % of the
materials standard Proctor maximum dry density as detemined by ASTM D-698.
3. The basin perimeter and embankment slopes shall be vegitafied as per the approved
plans within 15 days of construction.
Watershed Information
Watershed
Total Area i11 Exposed Ground
Impervious Surface % Impervious
Possible Pollutants
No.
1 ai
Acres Acrea
3.58 3.58
Acres) Surface
0 0.00% 1
Soil particulate
1 b
10.9 li 8.09
0 0.00%
Soil particulate
2
5.01 li 2.19
0
0.00%
I Soil particulate
3a
21.5 8.7
0
0.00%
Soil particulate
3b
45.4 10.2
0
0,00%
Soil particulate
(1) Exposed ground acreage will vary over time due to mining and reclamation activities.
Note: Only three discharge points will be actively discharging at any point in time.
Discharge Point 1 b will not begin discharging until Discharge Point 1 a has been
removed. This is also true for Discharge Points 3a and 3b.
LEGEND
Property Line
- Adjacent Property Line
- - - - Mine Permit Limits
- 10-Yr Limits of Disturbance
Buffer Limits
Streams
Building
lzo
Topographic Lines
Soil/Gravel Road (Existing)
Tree Line
PROPOSED BASIN DETAILS (BASINS 4 & 5)
5'--- -
1,
5' 2
{CUTOFF
TRENCH}
SEDIMENT BASIN SCHEDULE
Vicinity Map
(NTS)
See Outlet Protection Details
i
Basin
Total Wooded Grass Disturbed
Watershed
(ac) ac) (ac)
(
CN
Q10 Q10
Inflow
Q10
utflowl
Q25
Inflow
Q25
Outflo
(1)
Required
Area
Provided
Area
Req�^ Provided
sediment sediment storage
stoage volume
volume
Maximum
Adjacent
Berm Height ;
(ac)
(cfs)
(cfs)
(�)
(cfs)
(s0
(sf)
m + (�
y4
4
21.5 3.0 9.8 8.7�6955.11
---
5.87
78.13
-
6.37
23,973
37,819
� 15,669 37,
7.5'
5
45.4 8.1 27.1 10.2 -
58.28
22.81
82.63
25.41
25,352
83,740 _I 18,360 83,740
76 5
(1) Required Surface Area is based on Q10*435
PROPOSED PRIMARY SPILLWAY DETAILS (BASINS 4 & 5)
Cross -Section (NTS)
Shed \! j � ..-,/ ��., �
Drain Valve Water Level for
26-Yr Rain Event 1T
Trash Rack i
TOP of Riser 4 in.
6in� Normal Poor Bin �1 Embankment
Existing Drive
Basin 4: 24"36" 1 CMP Riser 2
L Basin 5: 36' Dla. CMP Ri
i J - a fl (2) 2 inch holes
1, / Basin 4: 18" Dia. CMP
Basin 5: 24" Dia. CMP
k Note: Embed Riser Pipe and Valve Stem Support into Concrete
\ _ 6" CMP Drain aipe� PP
_.i � 3000 psi Concrete at 28 days
N, NOTE: 0.46 CUBIC YARDS OF CONCRETE REQUIRED FOR BASIN 4
1.04 CUBIC YARDS OF CONCRETE REQUIRED FOR BASIN 5
EXigt�
Outlet Pipe
F
Scale: V= 100'
OUTLET PROTECTION DETAILS BASIN OUTLET DETAILS (BASIN 1-3)
Basin 4: 3' 1
Basin 5: 6' ��' 0 �✓ 0
I-) C
n " 5 I� i \- C C Basin 4: 11'
(-)drr ate: Basin 4:6",
s-. Basin 5: 16'
&a in :13:5�) 1
CD
1
Basin 4: 10' _
Basin 5: 14'
Cross -Section (NTS)
5 FT
24"
MIN
3 FT
FILTER
FABRIC
Front View (NTS)
1'FREEBOARO
2:1 SIDE
SLOPE MAX
1:1 SIDE SLOPE
MAX
' ^9.'➢:: r:,.:: L �,�:.' 1:: -:,. .... cim ... :. -.-..; r. :-nr :..-...-..r ".. :-...- -- ..-rT.(.aP'�ir. n; c=tutu i _. o.F., m: �..i