NCG020124_MONITORING INFO_20140226

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
DOC TYPE
El HISTORICAL FILE
[MONITORING REPORTS
DOC DATE
❑ a o t
YYYYMMDD

N 10 . 0,
February 26, 2014
Manager
NCDENR Raleigh Regional Office
Division of Water Resources
3800 Barrett Drive
Raleigh, NC 27609
❑mO
❑❑❑
❑ J� ❑ Hanson
HEIDELBERGCEMENTGroup
Hanson Aggregates Southeast, LLC
South Region
North Carolina Territory Office
2101 Gateway Centre Blvd, Suite 100
Morrisville, NC 27560-9626
Tel [phone]
Fax [phone]
www.lianson.com
RE: Hanson Aggregates — Princeton Quarry
NPDES General Permit COC No. NCG020124
Benchmark Exceedance: Stormwater Samples for 2nd 6-Month Period 2013
Dear Manager:
Hanson Aggregates is notifying the Department that during the 2"d 6-month period 2013, SDO-1
Outfall stormwater samples collected on 07/02/13 resulted in concentrations for TSS above the
Benchmark stated in the General Permit. The measured concentration was 113.Omg/L with a
Benchmark of 100.Omg/L. Hanson has worked hard to minimize TSS and Turbidity
concentrations at SDO-1, and as a result, have normally experienced TSS concentrations
around the 10mg1L mark and Turbidity levels around 10 NTU. The 133mg/L TSS sample was
collected on 07/02/13, and there were large amounts of rainfall occurring in that time period.
The check dam is in good condition, and the basin does not need cleaning. The exceedance
was just over the Benchmark, and the Turbidity samples were less than 50NTU.
Attached is the Benchmark Exceedance Form with monitoring results and the exceedance
highlighted in yellow. Hanson will continue to maintain its erosion control structures and keep
suspended solids at a minimum.
Should you have any questions or need additional information, please call me: [phone],
or reach me by email: Jack.Garve hanson.com .
Sincerely,
J k Garvey
Environmental Manager
cc: Toby Lee, NC Operations Manager
Jesse Bizzeil, Plant Manager

I,
�zr
I TIER 2 or BENCHMARK EXCEEDENCE D1V R - STORMWATER I
II SEND TO YOUR LOCAL REGIONAL OFFICE* II
STORMWATER DISCHARGE OUTFALLS (SDO)
GENERAL PERMIT NO. NCG020000 (MINING)
* Use this form if you have EXCEEDED BENCHMARKS for any parameter or are in Tier 2 Monitoring. Send sample results to DWQ Regional Office within .30 days of receipt
f rcmr Icrb.
CERTIFICATE OF COVERAGE NO. NCG02 i SAMPLE COLLECTION PERIOD: 1 ❑ 2
MONTHLY: ❑ MONTH
PERSON COLLECTING SAMPLESyFACILITY NAME:
ORATORY _ ^COUNTY_�LCERTIFIED LAB�.
tart rr u� Lab# '5-3rla PHONE NO. (`ItR )3�so-1`i�(c
Part A: Stormwater Monitoring Re uirements
Outfall
No.
Date Sample
Collected
(mo/dd/vr OR
NO FLOW)t
In Tier 2
Monthly
Monitoring"'
(y/n) g'
# of Months
in Tier 2
z Sampling
Total Flow
(MG)
Total Suspended
Solids
(mg/1)
4
Turbidity
(NTU)
Settleable
Solids (mil)
Total
Rainfall
(in)
Event
Duration
(minutes)
-
-
-
-
-
1001-4
See Footnote"'
0.1
i If "NO FLOW" or "NO DISCHARGE. Enter "NO FLOW" or "NO DISCHARGE" for each out€all here and the Date Range.
Per NCG02: Tier 2 Monthly sampling shall be done until 3 consecutive samples are below the benchmark or within the benchmark range
a If a value is in excess of the benchmark, or outside the benchmark range (for pH). you must implement the Tier 1 or Tier 2 responses in the General Permit.
4TSS benchmark values are 100 mg/l except in ORW. HWQ, trout, and PNA waters where they are 50 mg/l.
The discharge shall not cause an instantaneous measurement of the turbidity of the receiving water to exceed: 10 NTU for freshwater streams, lakes. and reservoirs designated as trout
waters: 25 NTU for all lakes and reservoirs, and all salt waters: 50 NTU for all other streams and surface waters. Turbidity may be monitored at the Stormwater Discharge Outfall.
Alternatively, the permittee may choose to monitor turbidity in the receiving water. directly upstream and downstream of the SDO.
Permit Date: I/1/2010-12/31/2014 Last Revised 0 1 -2 1 -11
Page 1 of 2

Part B: Vehicle Maintenance Activity Monitoring Requirements for facilities using > 55 gal of new motor oil/month on average
Outfall
No.
Date Sample
Collected
(mo/ddlyr OR
NO FLOW}
In Tier 2
Monthly
�
Monitoring.
{y/n)
# of
Months in
Tier 2
$ampling2
New Motor Oil
Usage
(gal/month)
Total Flow
(MG)
TPH using
method I664A
SGT-HEM ( )
Total Suspended
Solids
)
pH
(Standard
Units
Total
Rainfall
(in)
Event
Duration
(nunutes
-
15
140
6-9
HAS YOUR FACILITY HAD 4 OR MORE BENCHMARK EXCEENDENCES AT YES ❑ NO;K
ANY ONE OUTFALL (ALL SDOs INCLUDING VEHICLE MAINTENANCE)?
HAVE YOU CONTACTED THE REGION? YES ❑ NO)'ie
WHO AT THE REGION HAVE YOU SPOKEN WITH?
USE THIS FORM IF YOU HAVE EXCEEDED BENCHMARKS FOR ANY PARAMETERS.
SEND THIS DMR TO YOUR LOCAL DWO REGIONAL OFFICE WITHIN 30 DAYS OF RECEIPT OF SAMPLE RESULTS FROM THE LAB:
Asheville Regional Office (ARO)
Roger Edwards, Surface Water Protection
Supervisor
2090 US Highway 70
Swannanoa. NC 28778
COURIER 12-59-01
Phone: [phone]
Fax: [phone]
Fayetteville Regional Office (FRO)
Belinda Henson, Surface Water Protection
Supervisor
225 Green Street
Systel Building Suite 714
Fayetteville, NC 28301-5043
COURIER 14-56-25
Phone: (9I0) 433-3300
Fax: [phone]
Mooresville Regional Office (MRO)
Rob Krebs. Surface Water Protection
Supervisor
610 East Center Avenue, Suite 301
Mooresville, NC 28115
COURIER 09-08-06
Phone: [phone]
Fax: [phone]
Raleigh Regional Office (RRO)
Danny Smith', Surface Water Protection
Supervisor
3800 Barrett Drive
Raleigh, NC 27609
COURIER 52-01-00
Phone: [phone]
Fax: [phone]
Washington Regional Office (WaRO)
Al Hodge. Surface Water Protection
Supervisor
943 Washington Square Mall
Washington, NC 27889
COURIER 16-04-01
Phone: [phone]
Fax: [phone] or [phone]
Wilmington Regional Office (WRO)
Rick Shiver, Surface Water Protection
Supervisor
127 Cardinal Drive Extension
Wilmington, NC 28405-2845
COURIER 04-16-33
Phone: [phone]
Fax: [phone]
Winston-Salem Regional Office (WSRO)
Steve Tedder. Surface Water Protection
Supervisor
585 Waughtown Street
Winston-Salem, NC 27107
COURIER 13-15-01
Phone: [phone]
Fax: [phone]
YOU MUST SIGN THIS CERTIFICATION FOR ANY INFORMATION REPORTED:
"I certify, under penalty of law, that this document and all attachments were prepared under my direction or supervision in accordance with a system designed to
assure that qualified personnel properly gather and evaluate the information submitted. Based on my inquiry of the person or persons who manage the system, or
those persons directly responsible for gathering the information, the information submitted is, to the best of my knowledge and belief, true, accurate, and complete.
I am aware that there are significant penalties for submitting false information, including the possibility of fines and imprisonment for knowing violations."
(Signature of Permittee)
Permit Date: 1 / 1 /2010-12/31 /2014
C' f aE;
(Date)
Last Revised 01-21-11
Page 2 of 2

if
t 7 7014
February 26, 2014
Manager
NCDENR Raleigh Regional Office
Division of Water Resources
3800 Barrett Drive
Raleigh, NC 27609
000
❑❑❑
0 0 ° Hans®n
HEIDELBERGMAENTGroup
Hanson Aggregates Southeast, LLC
South Region
North Carolina Territory Office
2101 Gateway Centre Blvd, Suite 100
Morrisville, NC 27560-9626
Tel [phone]
Fax [phone]
www.hanson.com
RE: Hanson Aggregates — Princeton Quarry
NPDES General Permit COC No. NCG020124
Benchmark Exceedance: Stormwater Samples for 2n' 6-Month Period 2013
Dear Manager:
Hanson Aggregates is notifying the Department that during the 2"d 6-month period 2013, SDO-1
Outfall stormwater samples collected on 07/02/13 resulted in concentrations for TSS above the
Benchmark stated in the General Permit. The measured concentration was 113.Omg/L with a
Benchmark of 100.Omg/L. Hanson has worked hard to minimize TSS and Turbidity
concentrations at SDO-1, and as a result, have normally experienced TSS concentrations
around the 1 Omg/L mark and Turbidity levels around 10 NTU. The 133mg/L TSS sample was
collected on 07/02/13, and there were large amounts of rainfall occurring in that time period.
The check dam is in good condition, and the basin does not need cleaning. The exceedance
was just over the Benchmark, and the Turbidity samples were less than 50NTU.
Attached is the Benchmark Exceedance Form with monitoring results and the exceedance
highlighted in yellow. Hanson will continue to maintain its erosion control structures and keep
suspended solids at a minimum.
Should you have any questions or need additional information, please call me: [phone],
or reach me by email: Jack. GarveyCci)_hanson.com .
Sincerely,
J k Garvey
Environmental Manager
cc: Toby Lee, NC Operations Manager
Jesse Bizzell, Plant Manager

I TIER 2 or BENCHMARK EXCEEDENCE DMR - STORMWATER
SEND TO YOUR LOCAL REGIONAL OFFICE*
STORMWA TER DISCHARGE OUTFALLS (SDO)
GENERAL PERMIT NO. NCG020000 (MINING)
* Use this form if you have EXCEEDED BENCHMARKS for any parameter or are in Tier 2 Monitoring. Send sample results to DWQ Regional Office within 30 days of receipt
from lab.
CERTIFICATE OF COVERAGE NO. NCG02 a`\ SAMPLE COLLECTION PERIOD: 1 ❑ 2
MONTHLY: ❑ MONTH
PERSON COLLECTING SAMPLES Jnr✓te J �� r� _ FACILITY NAME: Q r15on A� Clec,� S —tom^ i�nCc�n Quar t'V
CERTIFIED LABORATORY tP c l k;\ Lab # W Ar co �-) COUNTY �c� h n S�ta✓1
4 s re Lab # 5 39 P, PHONE NO. (9 r R ) 3-10- D,7 `i !o
Part A: Stormwater Nlonitorin2 Reauirements
Outfall
No.
Date Sample
Collected
(mo/dd/yr OR
NO FLOW)
In Tier 2
Monthly
Monitoring?
(y/n)
# of Months
in Tier 2
Sampling2
Total Flow
(MG)
Total Suspended
Solids
(mg/l)
a
Turbidity
(NTU)
Settleable
Solids (m]A)
Total
Rainfall
(in)
Event
Duration
(minutes)
-
-
-
-
-
100 •
See Footnote-5
0.1
1 13
'� DNSire`s.
< D.
t913 •J
3 [o C>
t If "NO FLOW" or "NO DISCHARGE. Enter "NO FLOW" or "NO DISCHARGE" for each outfail here and the Date Range.
Per NCG02: Tier 2 Monthly sampling shall be done until 3 consecutive samples are below the benchmark or within the benchmark range
` If a value is in excess of the benchmark. or outside the benchmark range (for pH), you must implement the Tier 1 or Tier 2 responses in the General Permit.
4TSS benchmark values are 100 mg/l except in ORW. HWQ. trout. and PNA waters where they are 50 mgA.
5 The discharge shall not cause an instantaneous measurement of the turbidity of the receiving water to exceed: 10 NTU for freshwater streams, lakes, and reservoirs designated as trout
waters: 25 NTU for all lakes and reservoirs, and all salt waters: 50 NTU for all other streams and surface waters. Turbidity may be monitored at the Stormwater Discharge Out€all.
Altemativelv. the permittee rnav choose to monitor turbidity in the receiving water. directly upstream and downstream of the SDO.
Permit Date: l/l/2010-1213112014 Last Revised 0 1 -21 -11
Page I of 2

t
�b' I n o✓1 � v a r� y N CU ©� ©� ��--�.
N$
Part B: Vehicle Maintenance Activity MonitoringRe uirements for facilities using > 55 gal of new motor oil/month on average
Outfall
No.
Date Sample
Collected
(mo/dd/yr OR
NO FLOW)'
In Tier 2
Monthly
Monitoring?
(y/n)
# of
Months in
Tier 2
Sampling2
New Motor Oil
Usage
( at/month)
Total Flow
(MG)
TPH using
method I664A
SGT-HEM ( )
Total Suspended
Solids
( )
pH
(Standard
Units)
Total
Rainfall
(in)
Event
Duration
(minutes)
-
-
15
100 m
G-9
5OD- I
Lo to ��
--�
55
�'�
5, D
d ?
HAS YOUR FACILITY HAD 4 OR MORE BENCHMARK EYCEENDENCES AT YES ❑ NOX
ANY ONE OUTFALL (ALL SDOs INCLUDING VEHICLE MAINTENANCE)?
HAVE YOU CONTACTED THE REGION? YES ❑ NO'X
WHO AT THE REGION HAVE YOU SPOKEN WITH:'
USE THIS FORM IF YOU HAVE EXCEEDED BENCHMARKS FOR ANY PARAMETERS.
SEND THIS DMR TO YOUR LOCAL DWO REGIONAL OFFICE WITHIN 30 DAYS OF RECEIPT OF SAMPLE RESULTS FROM THE LAB:
Asheville Regional Office (ARO)
Roger Edwards, Surface Water Protection
Supervisor
2090 US Highway 70
Swannanoa, NC 28778
COURIER 12-59-01
Phone: [phone]
Fax: [phone]
Fayetteville Regional Office (FRO)
Belinda Henson, Surface Water Protection
Supervisor
225 Green Street
Systel Building Suite 714
Fayetteville, NC 28301-5043
COURIER 14-56-25
Phone: [phone]
Fax: [phone]
Mooresville Regional Office (MRO)
Rob Krebs. Surface Water Protection
Supervisor
610 East Center Avenue, Suite 301
Mooresville, NC 28115
COURIER 09-08-06
Phone: [phone]
Fax: [phone]
Raleigh Regional Office (RRO)
Danny Smith, Surface Water Protection
Supervisor
3800 Barrett Drive
Raleigh, NC 27609
COURIER 52-01-00
Phone: [phone]
Fax: [phone]
Washington Regional Office (WaRO)
Al Hodge, Surface Water Protection
Supervisor
943 Washington Square Mall
Washington, NC 27889
COURIER 16-04-01
Phone: [phone]
Fax: [phone] or [phone]
Wilmington Regional Office (WRO)
Rick Shiver, Surface Water Protection
Supervisor
127 Cardinal Drive Extension
Wilmington, NC 28405-2845
COURIER 04-16-33
Phone: [phone]
Fax: [phone]
Winston-Salem Regional Office (WSRO)
Steve Tedder, Surface Water Protection
Supervisor
585 Waughtown Street
Winston-Salem, NC 27107
COURIER 13-15-01
Phone: [phone]
Fax: [phone]
YOU MUST SIGN THIS CERTIFICATIONFOR ANY INFORMATION REPORTED:
"I certify, under penalty of law, that this document and all attachments were prepared under my direction or supervision in accordance with a system designed to
assure that qualified personnel properly gather and evaluate the information submitted. Based on my inquiry of the person or persons who manage the system, or
those persons directly responsible for gathering the information, the information submitted is, to the best of my knowledge and belief, true, accurate, and complete.
I am aware that there are significant penalties for submitting false information, including the possibility of fines and imprisonment for knowing violations."
(Signature of Permittee)
Permit Date: I/l/2010-12/31/2014
C)sx1aE; �o
(Date)
Last Revised 01-21-I1
Page 2 of 2

cacr
®m®
"Hanson
Hanson Brick
P.O. Box 368
1410 Forest Acres Circle
Pleasant Garden, NC 27313
Tel: [phone]
Fax: [phone]
www.hansonbrick.com
March 8, 2011
Manager
NCDENR Raleigh Regional Office
Division of Water Resources
3800 Barrett Drive
Raleigh, NC 27609
RE: 2010 Benchmark Exceedence DMRs
Hanson Aggregates — Rocky Mount Quarry
Hanson Aggregates — Rougemont Quarry
Hanson Aggregates --- Neverson Quarry
Hanson Aggregates — Princeton Quarry
Dear Manager:
Please find the attached 2010 Benchmark Exceedence DMRs for the above referenced facilities
located in the Raleigh Region. Should you have any questions or need additional information,
please call me: [phone].
Sincerely,
Jack Garvey
Environmental Manage
cc: Jerry Bass, Rocky Mount Quarry
Jim Hilton, Rougemont Quarry
John Wakefield, Neverson Quarry
Jesse Bizzell, Princeton Quarry
i0.4;')' q 2911

w - - TIER 2 or BENCHMARK EXCEEDENCE DMR - STORMWATER
SEND TO YOUR LOCAL REGIONAL OFFICE
STORMWATER DISCHARGE OUTFALLS ' (SDO)
GENERAL. PERMIT NO. NCG020000 (MINING)
*Use this form if you have EXCEEDED BENCHMARKS far any parameter or are in Tier 2 Monitoring. Send sample results to DiF'Q Regional Office within 30 days of receipt
from lab.
CERTIFICATE OF COVERAGE NO. NCG02 (D 1 a, ±
FACILITY NAME:
PERSON COLLECTING SAMPLES 1'h'L l,'n t•-c w%w-r
CERTIFIED LABORATORY —rr ; -fe�5 } Lab # W v11 a 6 r1 _
ti+ Lab # DW 3 n'73 1
Part A: Stormwater Monitoring Reauirements
SAMPLE COLLECTION PERIOD, 1 ❑ 2 ❑
.OR MONTHLY: ❑ MONTH
COUNTY 3-- 1 n 3i--n
PHONE NO. { `i 19)
TOTAL RAINFALL: 4). a a.,a L.,'Z!$__ INCHES
EVENT DURATION: e O •z. a , 1.,o MINUTES
Outfall No.
Date Sample
Collected
mo/dd/ r ORMonitoring?
'( y ,)1
NO FLO�i
In Tier 2
Monthly
{ /n
# of Months in
Tier 2
Sampling'
Total Flow
(MG)
Total Suspended
(mid)
Turbidity
(NTU)
Settleable Solids
-
-
-
-
-
()01.4See
Footnote3,50.1
to3A LI)
Q Ca E)
Cam. 3
Stain-.�.
o rc�
a�a,o
lay
�
moo.
Q
' If "NO FLOW" or "NO DISCHARGE, Enter "NO FLOW" or "NO DISCHARGE" for each outfall here and the Date Range.
' Per NCG02: Tier 2 Monthly sampling shall be done until 3 consecutive samples are below the benchmark or within the benchmark range
3 If a value is in excess of the benchmark, or outside the benchmark range (for pH), you must implement the Tier 1 or Tier 2 responses in the General Permit.
' TSS benchmark values are 100 mg/l except in ORW, HWQ, trout, and PNA waters where they are 50 mgh.
s The discharge shall not cause an instantaneous measurement of the turbidity of the receiving water to exceed: 10 NTU for freshwater streams, lakes, and reservoirs designated as trout
waters; 25 NTU for all lakes and reservoirs, and all salt waters; 50 NTU for all other streams and surface waters. Turbidity may be monitored at the Stormwater Discharge Outfall.
Alternatively, the permittee may choose to monitor turbidity in the receiving water, directly upstream and downstream of the SDO.
Permit Date: 1/1/2010-12/31/2014 Last Revised 01-19-10
Page 1 of 2

Part B: Vehicle Maintenance ActiviO, Monitoring Requirements for facilities using > 55 gal of new motor oftontfl on average
No.
ONo.
Date Sample
Collected
(moldd/yr OR
NO FLON�)t
In tier 2
Monthly
'-vlonfioring?
(y/n).
# of Tier hs
m Tier 22
Sampling
New Motor Oil
Usage
(gal/month)
Total Flory
(MG)
TPH using
method 1664A
SGT--HEVf
m Il
Total Suspended
Solids,
mg/l
PH,
Standard
Units
-
-
is
1:00
6-9
O
I �`lccl 7�e
roleu.v.
r� r�r o n
I�
Call �er� : 5a�
]ir r
HAS YOUR FACILITY HAD 4 OR MORE BENCHMARK EXCEENDENCES AT YES ❑ NO
ANY ONE OUTFALL (ALL SDOs INCLUDING VEHICLE MAINTENANCE)?
HAVE YOU CONTACTED THE REGION? YES Z NO ❑
WHO AT THE REGION HAVE YOU SPOKEN WITH? an43e r 12R0 IJWQ vim,
USE THIS FORM IF YOU HA VE EXCEEDED BENCHMARKS FOR ANY PARAMETERS.
SEND THIS DMR TO YOUR LOCAL DJVO REGIONAL OFFICE WITHL'Y.30 DAYS OF RECEIPT OF SAMPLE RESULTS FROM THE LAB:
Asheville Regional Office (ARO)
Mooresville Regional Office (MRO)
Washington Regional Office (WaRO)
Winston-Salem Regional Office (WSRO)
Roger Edwards, Surface Water Protection
Rob Krebs, Surface Water Protection
Al Hodge, Surface Water Protection
Steve Tedder, Surface Water Protection
Supervisor.
Supervisor
Supervisor
Supervisor
2090 US Highway 70
610 East Center Avenue, Suite 301
943 Washington Square Mall
585 Waughtown Street
Swannanoa; NC 28778
Mooresville, NC 28115
Washington, NC 27889
Winston-Salem, NC 27107
COURIER 12-59-01
COURIER 09-08-06
COURIER 16-04-01
COURIER 13-1'5-01
Phone: [phone]
Phone: [phone]
Phone: [phone]
Phone: [phone]
Fax: [phone]
Fax: [phone]
Fax: [phone] or [phone]
Fax: [phone]
Fayetteville Regional Office (FRO) Raleigh Regional Office (RRO) Wilmington Regional Office (WRO)
Belinda Henson, Surface Water Protection Danny Smith, Surface Water Protection Rick Shiver, Surface Water Protection
Supervisor Supervisor Supervisor
225 Green Street 3800 Barrett Drive l27 Cardinal Drive Extension
Systel Building Suite 714 Raleigh, NC 27609 Wilmington, NC 28405-2845
Fayetteville, NC 28301-5043 COURIER 52-01-00 COURIER 04-16-33
COURIER 14-56-25 Phone: [phone] Phone: [phone]
Phone: [phone] Fax: [phone] Fax: [phone]
Fax: [phone]
YOU MUST SIGN THIS CERTIFICA TION FOR ANY LVFORMATION REPORTED:
"I certify,'under penalty of lam, that this document and all attachments were prepared under my direction or supervision in accordance with a system designed to
assure that qualified personnel properly gather and evaluate the information submitted. Based on my inquiry of the person or persons who manage the system, or
those persons directly responsible for gathering the information, the information submitted is, to the best of my knowledge and belief, true, accurate, and complete.
I am aware that there are significant penalties for submitting false information, including the possibility of fines and imprisonment for knowing violations."
3 !i
(Sign t re of Perml tee). (Date)
Permit Date: 1/l/2010-12/31/2014. Last Revised 01-19-10
Page 2 of 2

October 29, 2010
MEN
ONE
"' Hanson
Hanson Brick
P.O. Box 368
1410 Forest Acres Circle
Pleasant Garden, NC 27313
Tel; [phone]
Fax: [phone]
www.hansonbrick.com
RECEIVED
Manager
NCDENR Raleigh Regional Office NOV - ] 2010
Division of Water Resources
3800 Barrett Drive NC DENR
Raleigh, NC 27609 Raleigh Regional Office
RE: Hanson Aggregates — Princeton Quarry
NPDES General Permit COC No. NCG020124
Benchmark Exceedance: Stormwater Samples for 2nd 6-Month Period 2010
Dear Manager:
Hanson Aggregates is notifying the Department that during the 2nd 6-month period 2010, SDO-1
Outfall stormwater samples collected on 9/29/10 resulted in concentrations for TSS and
Turbidity above the Benchmarks stated in the newly issued General Permit. The Princeton
Quarry had already taken actions stated in Tier One for Benchmark exceedances from the 18t 6-
month period on 6/3110. Tier One steps were implemented, and improvement showed for
Setteable Solids and Turbidity in the second consecutive set of samples. However, the TSS and
Turbidity results exceeded the Benchmarks for the second consecutive sampling, and Hanson
must follow the actions found under Tier Two in the new General Permit. Sample results were
received on 10/11/10, and the environmental manager notified the plant manager and corporate
lab manager of the Tier Two actions that must be taken, including a stormwater management
inspection. Results from inspections and correspondence with those familiar with the site will be
maintained in the SWPPP.
Resulting from the Vt 6-month sampling, Tier One steps included the repair of a burst pipe
transferring process water to the closed loop series of sediment basins. The repair ensured only
stormwater was entering the conveyance leading to the SDO-1 outfall. During the 2nd 6-month
sampling, Setteable. Solid results were satisfactory, and Turbidity was reduced. Heavy rain
contributed to the exceedances as did some areas in the ditch that contains areas that need
stabilizing. Turbidity needs improving; however, it needs to be sampled upstream and
downstream of the outfall to demonstrate that the discharge does not elevate the Turbidity of the
receiving stream.
Hanson will clean and stabilize areas that could potentially elevate TSS and Turbidity. Check
dams will be installed as necessary within the ditch leading to the outfall. Turbidity will be
sampled upstream and downstream of the outfall. We have contracted a landscaper to create
and maintain pathways leading to potential upstream and downstream sampling points. Hanson
also will experiment with the use of "Floc Logs" to reduce TSS and Turbidity.

The above corrections should bring the levels down to the Benchmarks stated in the permit. Per
Tier Two Steps, Item #6 under Tier One instructions states to include monitoring results for that
sampling period. Since there was not a Tier One form included in the newly issued General
Permit, I have recorded the sample results on the old DMR form. Attached are sample results
and a Qualitative Monitoring Report conducted at the time of sampling. Monthly monitoring will
start in November-2010, and monthly monitoring reports will be submitted to the Raleigh
Regional Office DWQ. Records will be maintained in the SWPPP.
Should you have any questions or need additional information, please call me: [phone].
Sincerely,
Ja Garvey
Environmental Manager
cc: David Morgan, Morrisville, NC
Jesse Bizzell, Princeton Quarry

STORMWATER DISCHARGE MONITORING REPORT (DMR)
Please Mail Original And One Copy To Mailing Address Below
GENERAL PERMIT NO. NCG020000
Part A: Facility Information nd 1
Samples Collected In Calendar Year: � O 10 (all samples shall be reported within 30 days following monitoring period) _
Certificate Of Coverage No. NCG02_C31 a� County of Facility V-►
Facility Name d .n r _?c c4r 0, ar c Y Name of Laboratory ' L--, "+e_6
Facility Contact $; Lab Certification # we6`) c-'DW:59.131
Facility Contact Phone No. (91 ct )�q:5 A. -A I
Part B: Land Disturbance and Process Area Monitoring Requirements
.f" - i'
G ; •-•--'i.�`�.i$:F`.'-n
_
j ; �•
-A '.•.: SJ±
Date
. w"
.J+: ;33.'.+�!Wu
50050
la'�'�..
.? Yh^iWP;'G�M
00530
r {'t
4-i'.b.Y.,r.J_
W016�
.1.- rc±a�au-n.,:'xr.�rn
%0 545
'a- _ _ ed' .eC
"h�� {
O�utfall�:
'Receinng Streamer
e
Sample
z�-•..;-
-
•sfTota]
z N.[ otal- iyw,��
a-t�a
:,iryo;;�s_FName
�'x'?�a ~.= �* .;Colette,
;,�
Flu
.. _ t
Suspended
Turbidity,
Sohds
:-N-
j �S dA�� e+i
, :,3 v+:.
�`�`. oe
41�—MOMG''
.���•:-
�'
•�`5�a..l�l'�'x.
NdM�m,S.,US�R
61
0+LIa�vr
aUlq
I aG
I ac.
I
Part D: Storm Event Characteristics
Total Event Precipitation (inches): . c'� T
Event Duration (hours): a Q
Part E: Cert fcation
Part C: Vehicle Maintenance Monitoring Requirements
' s
t
t_0
04 ao,#.
=.Rece�vzn .Stream'
� -
.an
r0530
N;
Ssm Ie
`��"`iz�T_o'ta]
, ;
:Outfall�f
.g
k'
w'>.�
=4IS1amc
spende`
FP
0, f
x
ohd
ds-
'
�.r'�'
mo/ddl r
MG;
m.
umt
Total Event Precipitation (inches):
Event Duration (hours):
(if a separate storm event is sampled)
"I certify, under penalty of law, that this document and all attachments were prepared under my direction or supervision in accordance with a
system designed to assure that qualified personnel properly gather and evaluate the information submitted. Based on my inquiry of the person
or persons who manage the system, or those persons directly responsible for gathering the information, the information submitted is, to the best
of my knowledge and belief, true, accurate, and complete. 1 am aware that there are significant penalties for submitting false information,
including the possibility of fines and imprisonment for knowing violations."
m�/ag/Io
(Signature of ermitt (Date)
Part F: Mailing Address
Attn: Central Files, DENR, N.C. Division of Water Quality, 1617 Mail Service Center, Raleigh, NC 27699-1617
SWU-243-012005

o Page 1 of 1
I�QOTEST
Laboratory Report
Lob Location R' Lob 1L
C' Lob LOcotion 'W'
NCNUW Cert.#: 067 NCIDW Cert.#: 37731 NClVIIW Cert.#: 103DW Cert.#: 37733 NC1WW Cert.#: 075 NCIDW Cert.#: 37721
6701 Conference Dr, Raleigh, NC 27607 6300 Ramada Dr, Suitmmons, NC 27012 6624 Gordon Rd, Unit G, Wilmirgton, NC 28411
Ph: [phone] Fax: [phone] Ph: (336) 766-784336) 766-2514 Ph: [phone] Fax: [phone]
Project No.:
Project ID: PRINCETON QUARRY
--- Prepared for ---
JACK GARVEY
HANSON AGGREGATES
PO Box 368
PLEASANT GARDEN, NC 27313
No. Sample ID
001 SDO 01
Report Date: 10/5/2010
Date Received: 9/3012010
Work Order #: 1009-02398
Cust. Code: HA2746
Cust. P.O.#:
Date Sampled Time Sampled Matrix Sample Type Condition
912912010 15:31 GW Grab 4 +1- 2 deg C
'bla11V zed
Test Performed
Method
Results
Lab Loc
Time Qualifier
Settleable Solids
EPA 160.5
<0A rnUL
R 9130110
16:30
Total Suspended Solids
SM 2540D
126 mg/L
R 1014110
6:53
Turbidity
180.1
126 NTU
R 9/30/10
16:15
Reviewed by:
for Tritest, Inc.

TRITEST
Chain of Custody
6701 Conference Drive, Raleigh, NC 27607
ph: [phone], fax: [phone]
NCWW Cert#67, NCDW Cert#37731
6624 Gordon Road, Unit G, Wilmington, NC 28411
ph: [phone], tax: [phone]
NCWW Cert#75, NCDW Cert#37721
Cl 6300 Ramada Dr., Suite C2, Clemmons, NC 27012
ph: [phone], tax: [phone]
NCWW Cert#103, NCDW Cert#37733
Report Results To:
Company: (�ga^3dirkk
Address: `M'UtC,� &
Attn: _Sct•�V_�i`,
Phone:. �o .3p�j° r / Ne 7-
Fax: -7,3� - VA , I,�43 e-
Sampled by (signature): -IJ
Bill To:
Tritest W.O. # % 06 S-v23�V
Project Reference:
` tnGL40� c�dV&-t
Project Number:
Purchase Order #:
❑ Standard Report Delivery
❑ Rush Report Delivery (w/surcharge)
"Rush projects are subject to prior approval by
the laboratory
Requested Due Date:
Sample Description
Compomieor
Grab
Start Date
End Date
Matrix
vdw, ow, SW
Gw, soil ego
Analyses Requested
TrItrast
Sample#
Start Time
End Time
to
ztsgPlo
� �Spl�'daJ �.,�.1S�csPrr�1�d.goJ,ds
t.t
Relinquished by (signature)
n,
Re a ed signature)
Date
�a
Time
Relinquished by (signature)
eceived by (signature)
Date
Time
Relinquished by (signature)
Received by (signature)
Date
Time
�R'ecce�ipt Conditions (Lab Use Only)
t:y4t2°C ❑ Temp: °C
R Chlorine:
❑ Absent ❑ Present ❑ nla
Acid preserv. <2?
❑ Yes ❑ No 0 nla
Base preserv, >12?
11 Yes 0 No ❑ nla

go
U U3co' TE5T
SAMPLE
PRESERVATION CHECK -IN SHEET
WO #:
0 j` 02 3 Fe?
Checked in by:
106—
Date:
[} -_2
Time:
Temp:
CfQ C�
Route:
CD
TTS
TTPU
USM
FEDX
I GC
UPS
Sample
No.
Analysis Requested
Sample
Type
Comp!
Grab
Container
Chlorine
Preservative
None
HCL
H2SO4
IIN03
NaOH
Thio
OTHER
C /4
G
Pos 1 an
Nt
HCL
H2SO4
HNO3
NaOH
Thio
OTHER
G
Pas / ne
Noe
HCL
H2SO4
HNO3
NaOH
Thio,
OTHER
Pos / n g
No ie
HCL
H2SO4
HNO3
NaOH
Thio
OTHER
C 1 G
PIG
Pos I neg
No ie
FICL
H2SO4
HNO3
NaOH
Thio
OTHER
C / G
PIG
Pos I neg
None
HCL
H2SO4
HNO3
NaOFi
Thio
OTHER
C 1 G
P / G
Pos / neg
None
HCL
H2SO4
FIN03
NaOH
Thio
OTHER
C / G
P / G
Pos 1 neg
None
HCL
H2SO4
HNO3
Na0H
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
HNO3
NaOH
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
HNO3
Na0H
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
FIN03
Na0H
Thio
OTHER
C 1 G
PIG
Pos / neg
None
HCL
1-12SO4
HNO3
NaOH
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
HNO3
NaOH
Thio
OTHER
C / G
P / G
Pos I neg
None
HCL
H2SO4
HNO3
NaOH
Thio
OTHER
C / G
P / G
Pos / neg
None
FICL
H2SO4
HNO3
NaOH
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
HNO3
NaOH
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
FIN03
NaOH
Thio
OTHER
C / G
P 1 G
Pos 1 neg
None
HCL
1-12SO4
FIN03
NaOH
Thio
OTHER
C / G
PIG
Pos I neg
None
HCL
H2SO4
FIN03
NaOH
Thio
OTHER
C / G
P 1 G
Pos / neg
None
HCL
1-12SO4
HNO3
NaOH
Thio
OTHER
C / G
P / G
Pos / neg
None
FICL
1-12SO4
HNO3
NaOH
Thio
OTHER
COMMENTS:

a
amn
000
'"'Hanson
NEI0ELBEMCEMENTGmup
HANSON AGGREGATES North Carolina
Lab Sample Profile & Discharge Monitorinq Sheet
QC Lab Collection Sites (Crabtree, Raleigh, Neverson, main quarry office)
Sample Information
Site Name: Princeton
SDO #01
Discharge Point: (SDO) x (NPDES)
Name of Collector: PhzCp Lawler
Date Sample Collected: 29-Sep-lo Time Sample Collected: 3:31 PM
Container Used: x 11 plastic 11 amber glass w/preservative (o&g only)
Flow: From Weir
From CMP
height of water
L = 36" (L=length of weir)
/2" 38.2 cfs; 1' 108 cfs: 1 'r4" 197 cfs
2" 302 cfs; 2 '/2 " 422 cfs
3" 552 efs: 3'/2" 695 cfs
round pipe
28 in. E)
Analytical Information:
pipe diameter 60 in.
Date Analysis Performed; 29-Sep-10 Time Analysis Performed
Analysis Performed by: _ Thifip Lawler Sample Temp:
pH (N.S.U.)(performed wrin 15 minutes of sample col
3:31 PM
oC
Flow estimate: 1s5a9s.15 gpm
Lab; Date Sample Received by Lab:
Date Lab Analysis Performed:
TSS: I mg/1 Oil & Grease: _ mg/l
Check Buffer 7.00 pH: x Temperature: oC Time:

a,
Quarry:
Princeton
Sample Station:
SDO #01
SDO:
x
NDPES:
Name:
(Philip Lawler
Date:
9129110
Time:
3:31 PM
Plastic:
x
Amber:
Sample
Temperature
pH Readings
Check Buffer
7.00 pH
Time:
Temperature:
x
H = Height of water; D = Diameter of pipe (in feet)
HID = column "B"
Read Column "C" adjacent to pipe "B"
"C" x "D"2 =Filled area, "A" (sq.ft)
"A" x Average Velocity Volumeter flow (CFS)
CFS x 448.153 = Gallons per minute (GPM)
GPM x 1440 = Gallons per day (GPD)
COMMENTS:
aRo
Ursa
000 Hanson
HE1D ELBERGCEMEMTGroup
Average Velocity 49.5
Inches
Height = "H" 28.0
Diameter = "D" 60
HID
0.46667
Column "C"
0.3527
"C., x "D"2 = "A"
8.8175
"A" x Velocity = CFS
436.4663
CFS x 448.83 = GPM
196899.147
GPM x 1440 = GPD
282094772
Feet
2.3333
5.0000
25.0000

r
Calibration Record
ph Meter: YSI Model 60 pH meter
Serial Number: 06,12393 AD
Date: Wednesday, September 29, 2010
Name
❑U❑
1300
HEIDEiB KOCEMENTGroup
Method 4500 H + B
Time:
Calibration:
Step #1: pH 7.00 buffer calibration reading 7.00 temp 24.4 °C
pH stable at .01 for 10 seconds; decimal stopped flashing) X yes no
Step #2: pH 4.01 buffer calibration reading 4.01 temp 23.4 °C
pH stable at .01 for 10 seconds; decimal stopped flashing) X yes no
Step #2: pH 10.01 buffer calibration reading 10.03 temp 22.7 °C
pH stable at .01 for 10 seconds; decimal stopped flashing) X yes no
Check Buffer pH 7.00: 7.01 temp 24.5 °C Time: 2:50

4.
Stormwater Discharge Outfall (SDO)
Qualitative Monitoring Report
For guidance on filling out this form, please visit: http:11h2o.enr.state.nc.us/su/Forms_Documents.htm#miscforms
Permit No.: NICI 1_I�ITI_I I_I or Certificate of Coverage No.: NIC/G10FZ/0f 1 1211
Facility Name:
County: 73�kn n _ Phone No. 911 7S6 4-Zzj
Inspector: t-)h;.1, P iyt
Date of Inspection: _ z4 5 10
Time of Inspection: s ti
Total Event Precipitation (inches): 4 1n ek
Was this a Representative Storm Event? (See information below) [� Yes ❑ No
Please check your permit to verify if Qualitative Moniroring must be performed during a representative
storm event (requirements vary),
A "Representative Storm Event" is a storm event that measures greater than 0.1 inches of rainfall and that
is preceded by at least 72 hours (3 days) in which no storm event measuring greater than 0.1 inches has
occurred. A single storm event may contain up to 10 consecutive hours of no precipitation.
By this signature, I certify that this report is accurate and complete to the best of my knowledge:
(Signature of Permittee or Designee)
1. Outfall Description:
Outfall No. SPO'6 01 Structure (pipe, ditch, etc.) ro f--
Receiving Stream: L Le- —"'! �" _
Describe the industrial activities that occur within the outfall drainage area: M, n i nl�__
2. Color: Describe the color of the discharge using basic colors (red, brown, blue, etc.) and tint
(light, medium, dark) as descriptors: _ b"q cG)-.ram
3. Odor: Describe any distinct odors that the discharge may have (i.e., smells strongly of oil, weak
chlorine odor, etc.): ti c> 0C)o C
Page l of 2
S WU-242-112608

4. Clarity: Choose the number which best describes the clarity of the discharge, where I is clear
and 5 is very cloudy:
1 2 3 4
5. Floating Solids: Choose the number which best describes the amount of floating solids in the
stormwater discharge, where I is no solids and 5 is the surface covered with floating solids:
1 2 G 4 5
6. Suspended Solids: Choose the number which best describes the amount of suspended solids in
the stormwater discharge, where 1 is no solids and 5 is extremely muddy:
1 2f 4 5
7. Is there any foam in the stormwater discharge? Yes Nam,,
8. Is there an oil sheen in the stormwater discharge? Yes No ,
9. Is there evidence of erosion or deposition at the outfall? Yes
10. Other Obvious Indicators of Stormwater Pollution:
List and describe
Note: Low clarity, high solids, and/or the presence of foam, oil sheen, or erosion/deposition may be
indicative of pollutant exposure. These conditions warrant further investigation.
Page 2 of 2
SwU-242-112608

!E!
MEN
8"Hanson
Hanson Brick
P.O. Box 368
1410 Forest Acres Circle
Pleasant Garden, NC 27313
Tel: [phone]
Fax: [phone]
www.hansonbrick.com
July 30, 2010
Manager
NCDENR Raleigh Regional Office AUG
Division of Water Resources
3800 Barrett Drive
Raleigh, NC 27609
RE: Hanson Aggregates — Princeton Quarry
NPDES General Permit COC No. NCG020124
Benchmark Exceedance: Stormwater Samples for 1516-Month Period 2010
Dear Manager:
Hanson Aggregates is notifying the Department that during the 15t 6-month period 2010, SDO-1
Outfall stormwater samples collected on 6/3/10 resulted in concentrations for TSS, Setteable
Solids, and Turbidity above the Benchmarks stated in the newly issued General Permit. The
Plant Manager and I conducted a stormwater management inspection on 6/22110, and our initial
findings indicated process water was entering the stormwater ditch leading to the outfall. On
7/21/10, the Plant Manager found that the process water return line to the closed loop series of
sediment basins had burst. The piping was repaired, and only stormwater is entering the ditch
leading to the SDO-1 Outfall. The Tier One Steps were followed, and the results of the
inspection have been placed in the SWPPP book.
The above corrections should bring the levels down to the Benchmarks stated in the permit.
Item #6 under Tier One instructions states to include monitoring results for that sampling period.
Since there was not a Tier One form included in the newly issued General Permit, I have
recorded the sample results on the old DMR form. Attached are sample results and a
Qualitative Monitoring Report conducted at the time of sampling.
Should you have any questions or need additional information, please call me: [phone]
Sincerely,
Jack Garvey
Environmental Manager
cc: David Morgan, Morrisville, NC
Jesse Bizzell, Princeton Quarry

STORM`VATER DISCHARGE MONITORING REPORT (DMR)
Please Mail Original And One Copy To Mailing Address Below
GENERAL PERMIT NO. NCG020000
Part A: Facility Information
Samples Collected In Calendar Year: jStHc�� c-01 D (all samples shall be reported within 30 days following monitoring period) Certificate Of Coverage No. NCG02 p 1 —A County of Facility .J_ ,V)n 5+0 r%
Facility Name Name of Laboratory
Facility Contact z;z.L--l Lab Certification # W C 6`71 o- ia0--57731
Facility Contact Phone No. 3 1)� ]
Part S: Land Disturbance and Process Area Monitoring Requirements
D.-
Receiving Stream
cs
'Outtall
� .�,;� �1.= „ �
� � u
,�;fotal
:Total
� ���5 ��
�:. •emu
eSettleable,
No
,
Suspended
Turbidity
�`
•Flows;
'��;
uySolids.t
dr
7` a
y-. rt -7:
^3yr-
-i: ., L
�... ,�.ro r
•tip as
A'_NTFJs,,7:,a�:
ml/l
"s
L:-H-It R'j vef
DEL
O, 3
Part D: Storm Event Characteristics
Total Event Precipitation (inches): I`-_ -a
Event Duration (hours): I
Part E: Certification
Part C: Vehicle Maintenance Monitoring Requirements
T
_
Date �50050
00556
00530
400400-
Sarri le
and`
To ter
ai;
p Receiviri :Stream"
f
ame
C ollectc 3
<a .:�.
' Suspende a
pH
_ �:
:Flow
Grease
solids
�-
T
4 °'
- MG
114.
in f
unit_
.�
.nio/dd/ r�
sm
. ll
L, i,44tc yer
G /3 /id
3.57
C, S-
] 16
11M
Total Event Precipitation (inches):
Event Duration (hours):
(if a separate storm event is sampled)
"I certify, under penalty of law, that this document and all attachments were prepared under my direction or supervision in accordance with a
system designed to assure that qualified personnel properly gather and evaluate the information submitted. Based on my inquiry of the person
or persons who manage the system, or those persons directly responsible for gathering the information, the information submitted is, to the best
of my knowledge and belief, true, accurate, and complete. I am aware that there are significant penalties for submitting false information,
including the possibility of fines and imprisonment for knowing violations."
, l9 A
(Signat� of Perm' ee) ` (Date)
Part F: evfailingAddress
Attn: Central Files, DENR, N.C. Division of Water Quality, 1617 Mail Service Center, Raleigh, NC 27699-1617
SWU-243-012005

o Page 1 of 1
7MIEST
Laboratory Report
lob locollon R' Lob location 'C' Lab Location 'W'
NC/WW Cert.#: 067 NC/DW Cert.#: 37731 NCNVW Cert.#: 103 NC/DW Cert.#: 37733 NC/WW Cert.#: 075 NCIDW Cert.#: 37721
6701 Conference Dr, Raleigh, NC 27607 6300 Ramada Or, Suite C2, Clemmons, NC 27012 6624 Gordon Rd, unit G, Wilmington, NC 28411
Ph: [phone] Fax: [phone] Ph: [phone] Fax: [phone] Ph: [phone] Fax: [phone]
Project No.:
Project ID: PRINCETON QUARRY
--- Prepared for ---
JACK GARVEY
HANSON AGGREGATES
PO Box 368
PLEASANT GARDEN, NC 27313
Report Date: 6/15/2010
Date Received: 6/412010
Work Order #: 1006-00291
Cust. Code: HA2746
Cust. P.O.#:
No. Sample ID
Date Sampled
Time Sampled Matrix
Sample Type
Condition
001 SDO-01
6/3/2010
16:35 GW
Grab
4 +1- 2 deg C
Test Performed
Method
Results
- - - - zed
Lab Loc aI�
--------
Time Qualifier
Oil & Grease
EPA 1664A
6.5 mg/L
R 6/11110
12:00
Settleable Solids
EPA 160.5
0.3 mLIL
R 614110
12:25
Total Suspended Solids
SM 2540D
110 mg1L
R 618110
13:00
Turbidity
EPA 180.1
260 NTU
R 614110
15:40
Reviewed by:
for Tritest, Inc.

TRITEST
Chain of Custody
J 6701 Conference Drive, Raleigh, NC 27607
ph: [phone], fax: [phone]
NCWW Cert#67, NCDW Cert#37731
CJ 6624 Gordon Road, Unit G, Wilmington, NC 28411
ph: [phone], fax: [phone]
NCWW Cert#75, NCDW Cert#37721
❑ 6300 Ramada Dr., Suite C2, Clemmons, NC 27012
ph: [phone], tax: [phone]
NCWW Cert#103, NCDW Cert#37733
Report Results
To:
Company: fp �3aJ 1.�g5r��
Address: t•0• soy, �
��d�� rJG Z�.313
Attn: T c w �*-6
Phone: 3316• 3qg• l2(,2
Fax: 31" 398 • /ZS'Z
Sampled by (signature):
Bill To:
-5A-MP—
Tritest W.O. # ��I�—
Project Reference:
i�rr UC94a. 4awm•
Project Number:
Purchase Order #:
❑ Standard Report Delivery
❑ Rush Report Delivery (w/surcharge)
"Rush projects are subject to prior approval by
the laboratory
Requested Due Date:
Sample Description
composgour
Gran
Start Date
End Date
Matrix
ww, ow, sw
GVJ,Soii.etc-
Analyses Requested
Tritest
sample#
Start Time
End Time
SDo• O �
G
3�'rD
3TUIw10
r'
o; (4Groae-, salads,
�sp�loi�o[ .salads. T�b►d{�y
jb�s
ld3s
Reli h/ecl by(signature)Received
l-
by (signal
re)
Date
6. 0f
Time
Z
Relinquished by (signature)
Received by (signature)
Date
Time
Relinquished by (signature)
Received by (signature)
Date
Time
Receipt Conditions (Lab Use Only)
RAIt2°C ❑ Temp: °C
. Chlorine:
i7 Absent ❑ Present Q nla
Acid preserv. <2?
0 Yes D No ❑ nla
Base preserv, >12?
11 Yes ❑ No 0 n/a

•
u I�oTEST
SAMPLE
PRESERVATION CHECK -IN SHEET
w0#:
4 (
uv
Checked in by;
Date:
, CO
Time
Temp:
es_
Route:
D
TTS I TTPU I
USM I
FEDX
I GC
UPS
Sample
No.
Analysis Requested
Sample
Type
Comp!
Crab
Container
Chlorine
Preservative
None
HCL
H2SO4
HNO3
NaOH
Thio
OTHER
rW
C l
I G
Pos / n g
No te
HCL
H2SO4
HNO3
NaOH
Thio
OTHER
f
kL 1
C/ G
J/G
Pos I rg
N e
HCL
H2SO4
FIN03
NaOH
Thio
OTHER
1
C /
/ G
Pos / r eg
Ndne
HCL
H2SO4
HNO3
NaOH
Thio
OTHER
v
C 1
P 1
Pos / eg
None
HCL
H2S 4
HNO3
NaOH
'Thio
OTHER
C /
P 1 G
Pos / neg
None
HCL
H2SO4
HNO3
NaOH
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
HNO3
NaOH
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
HNO3
Na0H
Thio
OTHER
C / G
P / G
Pos / neg
None
1-ICL
H2SO4
HNO3
NaOH
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
HNO3
NaOH
Thio
OTHER
C / G
P / G
Pos 1 neg
None
HCL
H2SO4
FIN03
NaOH
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
HNO3
Na0H
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
HNO3
NaOH
Thio
OTHER
C 1 G
P / G
Pos / neg
None
HCL
H2SO4
1-1NO3
Na01-1
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
HNO3
NaOH
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
HNO3
NaOI-1
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
FIN03
NaOF1
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
HNO3
NaOI-I
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
FIN03
NaOi-1
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
1-12SO4
HNO3
NaOI1
Thio
OTHER
C 1 G
P / G
Pos I neg
None
HCL
H2SO4
HNO3
Na01-1
Thio
OTHER
COMMENTS:

mom
MMM
.'.Manson
araDELIBMGCEMEHTGroup
HANSON AGGREGATES, North Carolina
Lab Sample Profile & Discharge Monitoring Sheet
QC Lab Collection Sites (Crabtree, Raleigh, Neversons main quarry office)
Sample Information
Site Name: Princeton
SDO #01
Discharge Point: (SDO) x (NPDES)
Name of Collector: ThilipLawler
Date Sample Collected: 3-.gun-10 Time Sample Collected: 4:35 tans
Container Used: x 11 plastic x 11 amber glass w/preservative (o&g only)
L = 36" (L=length of weir)
%" 38.2 cfs: 1 " 108 cfs; 1 '%" 197 cfs
2" 302 cfs; 2 '/2 " 422 cfs
Flow: From Weir 10 3" 552 cfs; 3 %" 695 cfs
round pipe
From CMP
height of water 5 in.
Analytical Information:
pipe diameter 72 in.
Date Analysis Performed: 3-Jun-10 Time Analysis Performed:
Analysis Performed by: 'Philip Lawfer Sample Temp:
PH (N.S, U.)(periormed wlin 15 minutes of sample col
Flow estimate: 2481.85
Lab; Date Sample Received by Lab:
Date Lab Analysis Performed:
7.43
4:35 PM
28.7 oC
gpm
TSS: mg/I Oil & Grease: m /1
Check Buffer 7.00 pH: x Temperature: 34.3 oC Time: 4:35 PM

Calibration Record
ph Meter: YSI Model 60 pH meter
Serial Number: 06G2324 AD
Date: Monday, June 30, 2008
Name
mom
MMm
... Hanson
ifEtDELBERGCEMEHTGroup
Method 4500 H + B
Time: 1205
Calibration:
Step #1: pH 7.00 buffer calibration reading 6.99 temp 31 °C
pH stable at .01 for 10 seconds; decimal stopped flashing) X yes no
Step #2: pH 4.01 buffer calibration reading 4.01 temp 29.6 °C
pH stable at .01 for 10 seconds; decimal stopped flashing) X yes no
Step #2: pH 10.01 buffer calibration reading 9.94 temp 29.9 °C
pH stable at .01 for 10 seconds; decimal stopped flashing) X yes no
Check Buffer pH 7.00: 6.98 temp 34.3 °C Time: 16:35

wRAja
Stormwater Discharge Outfall (SDO)
Qualitative Monitoring Report
Forguidance on filling out this form, please visit: httg.-/fh2o.enr.state.iic.us/su/Forins Documents.htm#miscforms
Permit No.: N/C10121C/ l 12141 1 or Certificate of Coverage No.: NIC/GI I_I 1 lil—1
Facility Name: �ri„�,�o _�„�►l,uw !*(_��
County: 3—ot,,,,�©r. PhoneNo. 1 • 93 • 4ZL!
Inspector: m . r-a�t�—
Date of Inspection: A OZ
Time of Inspection: 14 3$
Total Event Precipitation (inches):
Z
Was this a Representative Storm Event? (See information below) © Yes ❑ No
Please check your permit to verify if Qualitative Monitoring must be performed during a representative
storm event (requirements vary).
A "Representative Storm Event" is a storm event that measures greater than 0.1 inches of rainfall and that
is preceded by at least 72 hours (3 days) in which no storm event measuring greater than 0.1 inches has
occurred. A single storm event may contain up to 10 consecutive hours of no precipitation.
By this signature, I certify that this report is accurate and complete to the best of my knowledge:
(Signature of Permittee or Designee)
1. Outfall Description:
Outfall No. Stay • ct Structure (pipe, ditch, etc.) >r
Receiving Stream: U n 1rna�a n irri kp_y �r ! j.
Describe the industrial activities that occur within the outfall drainage area:
A e! i RI..---
2. Color: Describe the color of the discharge using basic colors (red, brown, blue, etc.) and tint
(light, medium, dark) as descriptors: �q,A_ I i
3. Odor: Describe any distinct odors that the discharge may have (i.e., smells strongly of oil, weak
chlorine odor, etc.): ►ton C
Page I of 2
5 WU-242-112608

4. Clarity: Choose the number which best describes the clarity of the discharge, where 1 is clear
and 5 is very cloudy:
1 2 4 5
5. Floating Solids: Choose the number which best describes the amount of floating solids in the
stormwater discharge, where I is no solids and 5 is the surface covered with floating solids:
1 CZ 3 4 5
6.. Suspended Solids: Choose the number which best describes the amount of suspended solids in
the stormwater discharge, where I is no solids and 5 is extremely muddy:
1 3 4 5
7. Is there any foam in the stormwater discharge? Yes No
8. Is there an oil sheen in the stormwater discharge? Yes No
9. Is there evidence of erosion or deposition at the outfall? Yes No
10. Other Obvious Indicators of Stormwater Pollution:
List and describe
Note: Low clarity, high solids, and/or the presence of foam, oil sheen, or erosion/deposition maybe
indicative of pollutant exposure. These conditions warrant further investigation.
Page 2 of 2
SWU-242-112608

mom
ago
0IN"Hanson
Hanson Brick
P.O. Box 368
1410 Forest Acres Circle
Pleasant Garden, NC 27313
Tel: [phone]
Fax: [phone]
www.hansonbrick.com
July 30, 2010
Manager
NCDENR Raleigh Regional Office
Division of Water Resources
3800 Barrett Drive
Raleigh, NC 27609
RE: Hanson Aggregates — Princeton Quarry
NPDES General Permit COC No. NCG020124
Benchmark Exceedance: Stormwater Samples for 1516-Month Period 2010
Dear Manager:
Hanson Aggregates is notifying the Department that during the 1st 6-month period 2010, SDO-1
Outfall stormwater samples collected on 613/10 resulted in concentrations for TSS, Setteable
Solids, and Turbidity above the Benchmarks stated in the newly issued General Permit. The
Plant Manager and I conducted a stormwater management inspection on 6/22/10, and our initial
findings indicated process water was entering the stormwater ditch leading to the outfall. On
7/21/10, the Plant Manager found that the process water return line to the closed loop series of
sediment basins had burst. The piping was repaired, and only stormwater is entering the ditch
leading to the SDO-1 Outfall. The Tier One Steps were followed, and the results of the
inspection have been placed in the SWPPP book.
The above corrections should bring the levels down to the Benchmarks stated in the permit.
Item #6 under Tier One instructions states to include monitoring results for that sampling period.
Since there was not a Tier One form included in the newly issued General Permit, I have
recorded the sample results on the old DMR form. Attached are sample results and a
Qualitative Monitoring Report conducted at the time of sampling.
Should you have any questions or need additional information, please call me: [phone],
Sincerely,
Jack Garvey
Environmental Manager
cc: David Morgan, Morrisville, NC
Jesse Bizzell, Princeton Quarry

STORNIWATER DISCHARGE NIONITORING REPORT (DAIR)
Please Mail Original And One Copy To Mailing Address Below
GENERAL PERMIT NO. NCG020000
Part .4: Facility Information
Samples Collected In Calendar Year: 1"H M �_01 (all samples shall be reported within 30 days following monitoring period) _
Certificate Of Coverage No. NCG02 Q l County of Facility ti� c�i�� t,+o a�
Facility Name d., r tr `� G.�o,. Cuctrr Name of Laboratory
Facility Contact -J-t Y Lab Certification #
Facility Contact Phone No. Ll 1
Par! B: Land Disturbance and Process Area Monitoring Requirements
'�:% � °�
is.
;t
s1-
s5Q050
�u 0053D:
DOD75 r
;,00545
;.Date -
:Sam
Recervin Stream
'
xSettleablc
-°Name
Eollecte,i
,r.'
:Sus ended-,,'p.u�bid�ty
�}
wTSolLds
"`
x,
{, F,3a.�. '.. nw
t`+d�,;.=
°,: Sobds.?`
;:a.::
:iQddlvr;
�nVlz .L
i-:4 �e (1Z� vef
SEC
E`.3
Part D: Storm Event Characteristics
Total Event Precipitation (inches): Q , I
Event Duration (hours): I
Part E. Certification
Part C.• Vehicle Maintenance Monitorinz Requirements
>Sample`g
Total
Oifand
Total w
Outfall ;.
ReccM60tream i'
x ro
r
ColleeteV
Flow
Grease
,Suspende j
,pli
d .:.
' d solids r
_'whit
w' .c
;• a
molddlvr
YiG,_'.
_!m /l:
_m Il'-
;
Total Event Precipitation (inches):
Event Duration (hours):
(if a separate storm event is sampled)
"I certify, under penalty of law, that this document and all attachments were prepared under my direction or supervision in accordance with a
system designed to assure that qualified personnel properly gather and evaluate the information submitted. Based on my inquiry of the person
or persons who manage the system, or those persons directly responsible for gathering the information, the information submitted is, to the best
of my knowledge and belief, true, accurate, and complete. i am aware that there are significant penalties for submitting false information,
including the possibility of fines and imprisonment for knowing violations."
/ 1
(Signature of Perini ee) (Date)
Part F.• lyfa ding A ddress
Attn: Central Files, DENR, N.C. Division of Water Quality, 1617 Mail Service Center, Raleigh, NC 27699-1617
SWU-243-012005

C Page 1 of 1
75,610TEST
Laboratory Report
!a6 lOCal10R Ploci location 'C' Laa Localior, 'W'
NC/WW CertA 067 NCIDW Cert.#: 37731 NCIWW Cert.#: 103 NCIDW Cert.#: 37733 NCIWW Cert.#: 075 NCIDW Cert.#: 37721
6701 Conference Dr, Raleigh, NC 27607 6300 Ramada Dr, Suite C2, Clemmons, INC 27012 6624 Gordon Rd, Unit G, Wilmington, NC 28411
Ph: [phone] Fax: [phone] Ph: [phone] Fax: [phone] Ph: [phone] Fax: [phone]
Project No.:
Project ID: PRINCETON QUARRY
--- Prepared for ---
JACK GARVEY
HANSON AGGREGATES
PO Box 368
PLEASANT GARDEN, NC 27313
Report Date: 611512010
Date Received: 614/2010
Work Order #: 1006-00291
Cust. Code: HA2746
Cust. P.O.#:
No. Sample ID Date Sampled Time Sampled Matrix Sample Type, Condition
001 SDO-01 6/3/2010 16:35 GW Grab 4 +1- 2 deg C
Test Performed
Method
Results
------------ INN, zed ----
Lab Loc Time - --
Qualifier
Oil & Grease
EPA 1664A
6.5 mglL
R
6/11110
12:00
Settleable Solids
EPA 160.5
0.3 mLIL
1?
614110
12:25
Total Suspended Solids
SM 2540D
110 ini
R
618110
13:00
Turbidity
EPA 180.1
260 NTU
11
614110
15:40
Reviewed by:
for Tritest, Inc.

fig
Chain of Custody
'J 6701 Conference Drive, Raleigh INC 27607
ph: [phone]. lax: [phone]
NCWW Cert#57, NCDW Cert#37731
6624 Gordon Road, Unit G. Wilmington, NC 28411
ph: [phone], lax: [phone]
NCWW Geri#75. NCDW Cert#37721
6300 Ramada Dr.. Suite C2. Clemmons, NC 27012
ph: [phone], fax: [phone]
NCWW Cert#1D3, NCDW Cert#37733
Report Results To:
_
Company:o�t`13o�
A -
Address: ?0. 1?0K
--ZS
easw.l+ C-xWd
� d c, Z-;-313
Attw
Phone: 33(,- 3qe-
l 2(pz
Fax: 33E+c- 398 •
/ Z,SZ
Sampled by (signature): -
Bill To:
-5A-✓ ?-
Tritest W.O.
Project Reference:
?r] za4o,) ors y
Project Number:
Purchase Order #;
L Standard Report Delivery
❑ Rush Report Delivery (wlsurcharge)
"Rush projects are subject to prior approval by
the laboralory
Requested Due Dale:
Sample Description
corn .lee,
_
Gran
Start Date
End Date
Matrix
ww. Dw, Sw
Gw. sod. etc
Analyses Requested
Tritest
Sam IeA
Start Time
End Time
,q)6• 4
G
3s "1 D
3 TZ .. 10
Gw
%/rl,/
SusP��ofa�f -W-ds. W"'044y
/s(,3s
/b35-
Reli t ;hed by (signature)
..�nl(�)✓t
Received by (signat Ire)
Date
6 -o (o
Time
2
Relinquished by (signature)
Received by (signature)
Date
Time
Relinquished by (signature)
Received by (signature)
Date
Time
Receipt Condilions (Lab Use Only)
+2°C n Temp: °C
R . Chlorine:
❑ Absent ❑ Present l l nla
Acid preserv. <2?
❑ Yes ❑ No r! nla
Base preserv. >12?
13 Yes El No n n/a

oTEST
SAMPLE
PRESERVATION CHECK -IN SIIF:LLT
wog:
d , - c1
Chcckcd in by:
Date:
;-f!�
Time
Temp:
�—
Route:
CV
ITS
I 'ITPU I
USM
FEDX
GC
UPS
Sample
No.
Analysis Requested
Sample
We
Camp/
Crab
Container
Chlorine
Preservative
None
IICL
112SO4
IIN03
NaOH
Thio
Q']'}IGR
t
C /
1 / G
Pos / n g
No Ie
14CL
142SO4
HNO3
NaOI-I
Thio
OTHER
Ls-)l
C / G
1 I G
Pos / °g
N ie
IICL
H2SO4
IIN03
Na01I
Thio
OTI 17-R
C /
/ G
Pos / t eg
N ie
1-1CL
142SO4
HNO3
Na011
Thio
OTHER
_\
CJ
C /
P I
Pos II eg
None
IICL
1-I2S 4
I-IN03
NaOH
Thio
OTHIiR
C /
P / G
Pos / neg
None
HCL
1-12SO4
I-IN03
Na01-I
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
IIN03
NaOH
Thio
OTH1IR
C / G
P / G
Pos / neg
None
HCL
H2SO4
FIN03
NaOH
"Thio
OTHER
C / G
P / G
Pos / neg
None
IICL
1.12SO4
IIN03
NaOli
Thio
OTHER
C / G
P / G
Pos / neg
None
14CL
1-12SO4
HNO3
Na0I1
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
H2SO4
HNO3
Na01-I
Thio
OTHER
C / G
P / G
Pos / neg
None
FICL
1-12SO4
HNO3
Na01I
Thio
OTHER
C / G
P / G
Pos / neg
None
IICL
1I2SO4
I-IN03
Na01-I
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
1-12SO4
1-1NO3
NaOli
Thio
OTHER
C / G
P / G
Pos / neg
None
IICL
1-12SO4
I IN03
NaOH
Thio
OTHER
C / G
P / G
Pos / neg
None
HCL
I-12SO4
HNO3
Na0I1
Thio
OTI I FR
C / G
I' / G
Pos / neg
None
HCL
142SO4
HNO3
NaOH
-Thio
OTHER
C / G
P / G
Pos / neg
None
IICL
1-12SO4
HNO3
Na01-i
Thio
OTl-IER
C / G
P / G
Pos / neg
None
HCL
1-12SO4
IIN03
NaOI-i
Thio
OTI I ER
C / G
P / G
Pos / neg
None
1-ICL
1-12SO4
I-IN03
Na0I1
"Thio
OTHER
C / G
P / G
Pos / neg
None
I iCL
1-I2SO4
I-IN03
Na011
Thio
O"l l I ER
COMM3 NTS:

mom
MOM
HER3EI.BERGC£MENTGnoup
HANSON AGGREGATES, North Carolina
Lab Sample Profile _& Discharge Monitoring Sheet
QC Lab Collection Sites_Crabtree, Raleigh, Neverson, main quarry office
Sample information
Site Name: Princeton SDO #01
Discharge Point: (SDO) x (NPDES)
Name of Collector. ThiCp La-wCer
Date Sample Collected: 3-Jun-10 jime Sample Collected: 4:35 PM
Container Used: x 11 plastic x 11 amber glass wlpreservative (o&g only)
Flow: From Weir
From CMP
height of water
Analytical Information:
L = 36" (L=length of weir)
'/2" 38.2 cfs: 1" 108 cfs; 1 %" 197 cfs
2" 302 cfs; 2 M! " 422 cfs
3" 552 cfs; 3 Yz" 695 cfs
round pipe
in.
pipe diameter
Date Analysis Performed: 3-Jun-10 Time Analysis Performed:
Analysis Performed by: Pfidip LawCer Sample Temp:
pH (N.S. U.)(performed wfn 15 minutes of sample col
Flow estimate: 2481.85
Lab; Date Sample Received by Lab:
Date Lab Analysis Performed:
72 in.
4:35 PM
28.7 oC
7.43
9pm
TSS: mg/I Oil & Grease: mg/l
Check Buffer 7.00 pH: x Temperature: 34.3 oC Time: 4:35 PM

Calibration Record
OEM
totals
... Hanson
H E! 0 EL B E RG CEM E IfF Gajup
ph Meter: YSi Model 60 pH _meter Method 4500 H + B
Serial Number: 06G2324 AD
Date: Monday, June 30, 2008 Time: 1205
Name:
Calibration:
Step #1: pH 7.00 buffer calibration reading 6.99 temp 31 °C
pH stable at .01 for 10 seconds; decimal stopped flashing) X yes no
Step #2: pH 4.01 buffer calibration reading 4.01 temp 29.6 °C
pH stable at .01 for 10 seconds; decimal stopped flashing) X yes no
Step #2: pH 10.01 buffer calibration reading 9.94 temp 29.9 °C
pH stable at .01 for 10 seconds; decimal stopped flashing) X yes no
Check Buffer pH 7,00: 6M temp 34.3 °C Time: 16:35

* %ATE
Stormwater Discharge Outfall (SDO)
Qualitative Monitoring Report .
Forguidance on filling out this form, please visit: htt:lth2o,enr.state.nc.us/su/F'orms Doc umentskm#miscforms
Permit No.. NICIO/ 210,I 1 I zlQl�l or Certificate of Coverage No.: N/CIGI 1�1�1 I_I 1
Facility Name: r1 rr n LG {-a a
County: TaL,_n �op Piione No. q19 • 936- 4ZLl
Inspector: �PW I; t°--
Date of Inspection: 3
Time of Inspection: 1436
Total Event Precipitation (inches):
4
Was this a Representative Storm Event? (See information below) © Yes ❑ No
Please check your permit to verify if Qualitative Monitoring must be performed during a representative
storm event (requirements vary).
A "Representative Storm Event" is a storm event that measures greater than 0.1 inches of rainfall and that
is preceded by at least 72 hours (3 days) in which no storm event measuring greater than 0.1 inches has
occurred. A single storm event may contain up to 10 consecutive hours of no precipitation.
By this signature, I certify that this report is accurate and complete to the best of my knowledge:
(Signature of Permittee or Designee)
1. Outfall Description:
Outfall No. Stan • of Structure (pipe, ditch, etc.) If -
Receiving Stream tin kAeuz n �-r'6
Describe the industrial activities that occur within the outfall drainage area:
M ,*n in
2. Color: Describe the color of the discharge using basic colors (red, brawn, blue, etc.) and tint
(light, medium, dark) as descriptors: —9 l ig h
3. Odor: Describe any distinct odors that the discharge may have (i.e., smells strongly of oil, weak
chlorine odor, etc.):
Page 1 of 2
SwU-242-112608

4. Clarity: Choose the number which best describes the clarity of the discharge, where 1 is clear
and 5 is very cloudy:
1 2 4 5
5. Floating Solids: Choose the number which best describes the amount of floating solids in the
stormwater discharge, where 1 is no solids and 5 is the surface covered with floating solids:
1 5 3 4 5
6., Suspended Solids: Choose the number which best describes the amount of suspended solids in
the stormwater discharge, where 1 is no solids and 5 is extremely muddy:
I 3 4 5
7. Is there any foam in the stormwater discharge? Yes No
S. Is there an oil sheen in the stormwater discharge? Yes No
9. Is there evidence of erosion or deposition at the outfall? Yes No
1:0. Other Obvious Indicators of Storrnwater Pollution:
List and describe
Note: Low clarity, high solids, and/or the presence of foam, oil sheen, or erosionldeposition maybe
indicative of pollutant exposure. These conditions warrant further investigation.
Page 2of2
5 WU-242- l 12608