NCG020086_COMPLETE FILE - HISTORICAL_20131219

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
/V l9�
DOC TYPE
q�HISTORICAIFILE
0 MONITORING REPORTS
DOC DATE
❑ a e i 3 � a��
YYYYMMDD

R ��
+Mja
NCDENR .
North Carolina Department of Environment and
Division of Energy, Mineral and Land
Land Quality Section
Tracy E- Davis, PE, CPM
Director
December 19, 2013
Mr. Nuwan Wijesuriya
Environmental Engineer
P. O. Box 30013
Raleigh, NC 27622-0013
Natural Resources
Resources
Subject: Compliance Evaluation Inspection
Stormwater Permit NCG020086
Pat McCrory, Governor
John E. Skvarla, III, Secretary
Martin Marietta Materials, Inc. - Garner Quarry
Wake County
Dear Mr. Wijesuriya:
On November 25, 2013, I, Joe Dupree, of the Raleigh Regional Office, along with Ashley Rodgers, PE -
and Chris Pullinger, also of the Raleigh Regional Office, carried out a stormwater compliance evaluation
inspection (CEI) for the above permit. The availability of Mr. Nuwan Wijesuriya and Mr. Charles
Horton to assist me, was appreciated as it facilitated the inspection. A synopsis of the inspection is
discussed below:
1. The Stormwater Pollution Prevention Plan (SPPP) was available during the inspection. The
SPPP was reviewed and updated annually during this permit cycle. All components of the plan
were evaluated during the CEI, and the plan was found to be complete,and being put into active
use.
2. The Stormwater Discharge Outfalls (SDO) were inspected during the inspection. The SDO
appear to be adequately capturing all of the stormwater corning from the production area.
3. Qualitative monitoring results were reviewed during the CEI. Qualitative monitoring results
were available and up to date, and within benchmarks.
4. It appears that the current permit will expire on December 31, 2014. An application for renewal
of your permit is required to be received a minimum ol'six months prior to its expiration,
One
NorthCarolina
Naturally
North Carolina Division of Water Quality Raleigh Regional Office Surface Water Protection Phone [phone] Customer Service
Internet: www.ncwaterquality.org 1628 Mail Service Center Raleigh, NC 27699-1628 FAX [phone] B77-623.67,48
An Equal Opportunity/Affirmative Action Employer — 50% Recycled110% Post Consumer Paper

' Martin Marietta - Garner Quarry Compliance Evaluation Inspection Page 2 ol'2
It is apparent that the Stormwater Program is being carried out for the Martin Marietta Materials Inc. —
Garner Quarry facility. If there are any questions or comments about this inspection, please contact me
at 919-791-4208 or tnailto:joe.dupree numcdenr.gov.
Sincerely,
oe Dupree
Environmental Senior Specialist
Raleigh Regional Office
cc: RROISWP Files
Central Office Files
Enclosure: Inspection checklist for Martin Marietta Materials Inc. Garner Quarry, dated Nov. 25, 2013

8
Compliance Inspection Report
Permit: NCG020086 Effective: 01/01/10 Expiration: 12/31/14 Owner: Martin Marietta Materials Inc
SOC: Effective: Expiration: Facility: Martin Marietta -Garner
County: Wake 1111 E Garner Rd
Region: Raleigh
Garner NC 27529
Contact Person: Steve Whitt Title: Phone: [phone]
Directions to Facility:
System Classifications:
Primary ORC:
Secondary ORC(s):
On -Site Representative(s):
Related Permits:
Inspection Date: 11125/2013
Primary Inspector: Joe A Dupree
Secondary Inspector(s):
Certification:
Entry Time: 09:30 AM Exit Time: 10:30 AM
Phone:
Phone:
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Mining Activities Stormwater Discharge COC
Facility Status: ■ Compliant ❑ Not Compliant
Question Areas:
0 Storm Water
(See attachment summary)
Page: 1

Permit: NCG020086 Owner - Facility: Martin Marietta Materials Inc
Inspection Date: 11/25/2013 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Inspection Summary:
Page: 2

Permit: NCG020086 Owner - Facility: Martin Marietta Materials Inc
Inspection Date: 11/25/2013 Inspection Type: Compliance Evaluation
Reason for Visit:
Routine
Stormwater Pollution Prevention Plan
Yes No
NA NE
Does the site have a Stormwater Pollution Prevention Plan?
■ ❑
❑ ❑
# Does the Plan include a General Location (USES) map?
■ ❑
❑ ❑
# Does the Plan include a "Narrative Description of Practices"?
■ ❑
❑ ❑
# Does the Plan include a detailed site map including outfall locations and drainage areas?
■ ❑
❑ ❑
# Does the Plan include a list of significant spills occurring during the past 3 years?
■ ❑
❑ ❑
# Has the facility evaluated feasible alternatives to current practices?
■ ❑
❑ ❑
# Does the facility provide all necessary secondary containment?
■ ❑
❑ ❑
# Does the Plan include a 13MP summary?
■0
❑ ❑
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
■ ❑
❑ ❑
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
■ ❑
❑ ❑
# Does the facility provide and document Employee Training?
■ ❑
❑ ❑
# Does the Plan include a list of Responsibie Party(s)?
■ ❑
❑ ❑
# Is the Plan reviewed and updated annually?
■ ❑
❑ ❑
# Does the Plan include a Stormwater Facility Inspection Program?
0 ❑
❑ ❑
Has the Stormwater Pollution Prevention Plan been implemented?
■ ❑
❑ ❑
Comment:
Qualitative Monitoring
Yes No
NA NE
'Has the facility conducted.its Qualitative Monitoring semi-annually?
■ ❑
❑ ❑
Comment:
Analytical Monitoring
Yes No
NA NE
Has the facility conducted its Analytical monitoring?
■ ❑
❑ ❑
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas?
❑ ❑
■ ❑
Comment:
Permit and Outfalls
Yes No
NA NE
# Is a copy of the Permit and the Certificate of Coverage available at the site?
■ ❑
❑ ❑
# Were all outfalls observed during the inspection?
®❑
❑ ❑
# If the facility has representative outfall status, is it properly documented by the Division?
130
■ ❑
# Has the facility evaluated all illicit (non stormwater) discharges?
130
■ ❑
Comment:
Page: 3

wArFAQG
r
Ms. Nuwan Wijesuriya
Environmental Engineer
Martin Marietta Materials
P.O. Box 30013
Raleigh, NC 27622-0013
Subject: Use of Flocculant
Michael F. Easley, Governor
William G. Ross Jr„ Secretary
North Carolina Department of Environment and Natural Resources
August 24, 2006
NPDES Permit No. NCG020086
Wake County
Dear Ms. Wijesuriya:
Alan W. Klimek, RE, Director
Division of Water Quality
A(R ? 5 ,
r
A jr_ 7 5 2006
In response to your letter of August 10, 2006, regarding approval of the use of a flocculant
in the closed loop recycle system at the Martin Marietta Garner Quarry, you have
permission from the Division to use the specified flocculant Chemtreat P-8282L. Use of
the flocculant should be in full compliance with the conditions of NC DWQ General
Permit No. NCG020000. This includes the provision that your recycle ponds must have
sufficient size to contain the accumulation of water from a 25-year, 24-hr storm event.
Please note that Section 12 of the MSDS Ecological Information did not identify the
parameter of the toxicity data for the daphnia and fathead minnow listings.
Communications with ChemTreat, Inc. clarified that the numbers were LC50 tests and
provided us with a corrected sheet.
If you have any specific questions about the above information, please contact Boyd
DeVane. He can be reached at 919-733-5083 ext. 559 or at [e-mail].
Sincerely,
1
Bradley Bennett, Supervisor
Stormwater Permitting Unit
Cc: Chad Coburn, RRO
Stormwater Unit Files
Connie Brower
No` Carolina
�tura!!�
Wetlands and Stormwater Branch 1617 Mail Service Center Raleigh, NC 27699-1617 Phone [phone]
Internet h2o.enr.statemc.us 512 N. Salisbury St. Raleigh, NC 27604 FAX [phone]
An Equal OpportuniV/A9firmative Action Employer — 50% Recycled110°% Post Consumer Paper

Michael F, Easley, Governor
William G. Ross Jr., secretary
North Carolina Department of Environment and Natural Resources
Alan W, Klimek, P,E, Director
Division of Water Quality
August 24, 2006
Ms. Nuwan Wijesuriya
Environmental Engineer
Martin Marietta Materials
P.O. Box 30013
Raleigh, NC 27622-0013 -
Subject: Use of Flocculant
NPDES Permit No. NCG020086
Wake County
Dear Ms. Wijesuriya:
In response to your letter of August 10, 2006, regarding approval of the use of a flocculant
in the closed loop recycle system at the Martin Marietta Garner Quarry, you have
permission from the Division to use the specified flocculant Chemtreat P-8282L. Use of
the flocculant should be in full compliance with the conditions of NC DWQ General
Permit No. NCG020000. This includes the provision that your recycle ponds must have
sufficient size to contain the accumulation of water from a 25-year, 24-hr storm event.
Please note that Section 12 of the MSDS Ecological Information did not identify the
parameter of the toxicity data for the daphnia and fathead minnow listings.
Communications with ChemTreat, Inc. clarified that the numbers were LC50 tests and
provided us with a corrected sheet.
If you have any specific questions about the above information, please contact Boyd
DeVane. He can be reached at 919-733-5083 ext: 559 or at [e-mail].
Sincerely,
-&4&,4,�
Bradley Bennett, Supervisor
Stormwater Permitting Unit
Cc: Chad Coburn, RRO
Stormwater Unit Files
Connie Brower
Onc
North Carolina
Nalmrn!ll,J
Wetlands and Stormwater Branch 1617 Mail Service Center Raleigh, NC 27699-1617 Phone [phone]
Internet: h2o.enr.state.nc.vs 512 N. SalisburySt, Raleigh, NC 27604 FAX [phone]
An Equal Opportunity/Affirmative Action Employer — 50% Recycled110°% Post Consumer Paper

11 r ,
Martin Marietta Materials
P. O. Box 30013
Raleigh, North Carolina 27622-0013
Telephone [phone]
CERTIFIED MAIL — RETURN RECEIPT REQUESTED
August 10, 2006
Mr. Bradley Bennett
Stormwater & General Permits Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, NC 27699-1617
Subject:
u Z
Authorization to use Flocculant in a Closed Loop Recycle System
Martin Marietta Materials, Inc. — Garner Quarry
NPDES Permit No. NCG020086
Dear Mr. Bennett
We wish to seek authorization to utilize flocculant (Chemtreat P-828211) at Martin Marietta
Materials, Inc., Garner Quarry in their closed loop plant process water recycle system. As such,
please find attached a copy of the Material Data Safety Sheet (MSDS) for the Iocculant. As you
can see from Section 15 of the MSDS, this product does not fall under SARA Title III Section
313 Toxic Chemicals reporting requirement.
As mentioned above, the plant process water settling ponds are completely closed loop and have
been designed to operate with two feet of freeboard. It is our understanding from reviewing
Permit NCG020000 and the Technical Bulletin that the approval for flocculent use was only
applicable to use in treatment facilities that have the potential to discharge. As stated, this
flocculent will be used in a closed loop system. This type of system is exempt from Elie
Authorization to Construct requirements for the same reason that we assumed flocculent use was
exempt. All of the water contained in these systems remains on site and effluent limitations are
not an issue. The Technical Bulletin definition of Treatment Facility also reinforces this by
stating that these facilities are used to meet effluent limitations.
I trust this will satisfy the Part 11, Section B(7) requirement of the NPDES General Permit. Should
you require more information please get in touch with this office.
Sincerely,
Nuwan Wijesuriya
Lnviromnental Engineer
CC: Chad Coburn, NCDWQ

Chemireatjnc.
MATERIAL SAFETY DATA SHEET
Section 1. ChemicaI Product and Company Identification
Product Name: P-8282L
Manufacturer's Name: ChemTreat, Inc.
Emergency Telephone Number: [phone]
Address (Corporate Headquarters) 4461 Cox Road, Glen Allen, VA 23060
Telephone Number for Information: [phone]
Date of MSDS: March 6, 2006
Section 2. CornpositioWHazardous Ingredients
Component CAS Registry # Wt. I%
Aluminum cl-ilorhydrate 12042-91-0 45 - 50
Ferric chloride
7705-08-0 0 -10
Section 3. Hazards Identification
Emergency Overview: Dark brown opaque liquid; mild odor; not flammable.
Potential Health Effects:
Eyes: Overexposure may cause discoloration of eye tissue, irritation and discomfort, tearing and
blurring of vision, or eye corrosion with corneal or conjunctival ulceration.
Skin: May cause irritation with discomfort or rash, burns, or ulceration.
Inhalation: May cause irritation of upper respiratory tract, with coughing.
Ingestion: May cause corrosive damage to the GI tract. Repeated ingestion of sub -lethal doses may
lead to excessive deposition in the tissues accompanied by pancreatic and liver damage.
Chronic Effects/Carcinogenicity: None of the components of this material are listed as a carcinogen
by IARC, NTP, OSHA, or ACGIH..
Section 4. First Aid Measures
Inhalation: Remove victim to fresh air. If not breathing, give artificial respiration, preferably mouth-
to-mouth. If breathing is difficult, give oxygen. Get immediate medical attention.
Eyes: Hold eyes open and rinse slowly and gentle with water for 15 - 20 minutes. Remove contact
lenses, if present, after the first 5 ininutes, then continue rinsing eye. Get immediate medical
attention.
Skin: Take off contaminated clothing. Rinse skin immediately with plenty of soap and water for 15 -
20 minutes. Get immediate medical attention.
Ingestion: Do not induce vomiting. Give large quantities of water, then an antacid. Never give
anything by mouth to an unconscious person. Call a physician.
ChemTreat, Inc.
P-8282L
Page 1

Section 5. Fire Fighting Measures
Flammable Properties: Not flammable.
Suitable Extinguishing Media: Use extinguishing media appropriate for surrounding fires.
Fire & Explosion Hazards: Possible formation of hazardous chlorine compounds.
Protective Equipment: Wear full protective clothing including a positive -pressure, NIOSH-approved,
self-contained breathing apparatus.
Section 6. Accidental Release Measures
Small Spill: Construct temporary dikes of dirt, sand, or any readily available inert material to
prevent spreading of the material. Wearing appropriate personal protective equipment, move the
leaking container to a containment area, or plug the leak. Neutralize the lime or other base, then
absorb on inert material. Shovel up and dispose of according to local, state and federal regulations.
Large Spill: Construct temporary dikes of dirt, sand, or any readily available inert material to
prevent spreading of the product. Wearing appropriate personal protective equipment, close or cap
valves and/or block or plug hole in Ieaking container and transfer to another container for proper
disposal.
Section 7. Handling and Storage
Store in closed or covered containers when not in use, in cool, dry areas with adequate ventilation.
Do not store near heat or open flames. Exercise caution when handling product. Wash with soap and
water before eating, drinking, smoking, or using toilet facilities.
Section 8. Exposure ControlsjPersonal Protection
Use protective equipment in accordance with 29 CFR 1910, Subpart 1. Good general ventilation
should be sufficient to control airborne levels. Wear chemical splash goggles or safety glasses with
full -face shield. Wear rubber gloves. Wash theirs after each use and replace as necessary. If conditions
warrant, wear impervious protective clothing such as boots, aprons, and coveralls to prevent skin
contact. Maintain eyewash fountain and quick -drench facilities in work area.
Section 9. Physical and Chemical Properties
Appearance: Dark brown opaque Physical state: Liquid
Boiling Point: >230T Solubility in Water: Complete
Evaporation Rate: N/D Specific Gravity: —1.357
Freezing Point: N/ D Vapor Density: N/D
Melting Point: N/A Vapor Pressure: N/D
Molecular Weight: N/D Viscosity: N/D
Odor: Mild % VOCs: N/ D
pH: —2.9 Flash Point: Not flammable
Section 10. Stability and Reactivity
Chemical Stability: Stable at normal temperatures and conditions.
C]ei]7Treat, lnc.
P-8282L
Page 2

Incompatibility: Rapidly corrodes most metals (titanium is one exception); may generate flammable,
potentially explosive hydrogen gas. Avoid contact with nylon, aluminum/aluminum alloys, carbon
steel, stainless steel, and copper or copper alloys.
Hazardous Decomposition Products: None known.
Hazardous Polymerization: Will not occur.
Section 11. Toxicological Information
No information furnished
Section 12. Ecological Information
Fathead minnow: 574 mg/L
Ceriodaphnia dubia: 1464 mg/L
Section 13. Disposal Considerations
Dispose of in accordance with applicable federal, state and local laws.
Section 14. Transport Information (not meant to be all inclusive)
D.O.T. Shipping Name: Corrosive liquid, acidic, inorganic, n.o.s. (Ferric Chloride)
Hazard Class: 8 (corrosive); UN3264; PG III
Section 15. Regulatorlj Information (Not iwant to be all inclusive - selected regulation represented)
TSCA'Status: All ingredients listed
CERCLA Reportable Quantity: Ferric chloride (7705-08-0)1000 lbs.
SARA Title III:
Section 302 Extremely Hazardous Substances: None
Section 313 Toxic Chemicals: None
CALIFORNIA PROPOSITION 65: None known
Section 16. Other 111forination
HMIS Hazard Rating:
Health: 2 FlammabiIity: 0 Physical Hazard: 0 PPE: X (see note)
Note: PPE rating depends on circumstances of use. See Section 8 for recommended PPE.
SARA Hazard Categories - Section 311/312
Acute - Y Chronic - Y Fire - No Reactive - No Sudden Release - No
Prepared by: ChemTreat Regulatory Affairs
Alfhongh the imfnrruation and recnnrn+endalions sel forth herein Mereinnfler "hrfornmtion") arr presentee) in good failh and fir-lier><d to Iv mrreet as of the date lrrrrof, ChrrnTreal, fit('. rnake5 no representations as to the
rmnpickness or arcurary thereof. Information is 5upphed lrpom the evtrdition that the persons rerrivillg same will make their mmnr d te/orinalion as to its snitabilily for their parposrs jrriar to rise. In no Qtlnf mill CheajTrrat,
hic. be respmuifNe for damages of any natwe whals wr rrsulfitlg frow the rue or reliance mporr irrfmmnatimt.
NO REPRESENTATION OR WARRANTIES, EITHER EXPREss OR lA1pmm OF MERCHANTABILM', FITNESS FOR A PARTICULAR PURPOSE, OR OF AN}' OTHER NATURE ARE MADE
HEREUNDER l M4 RESPECT TO 1,VFORAIATION OR THE PRODUCT TO I1MCH INFORMATION REFERS.
ChemTreat, Inc.
P-8282L
Page 3

T t.
ChemTrea#,inc,
MATERIAL SAFETY DATA SHEET
Section 1. Chemical Product and Company Identification
Product Name: P-8282L
Manufacturer's Name: ChemTreat, Inc.
Emergency Telephone Number: [phone]
Address (Corporate Headquarters) 4461 Cox Road, Glen Allen, VA 23060
Telephone Number for Information: [phone]
Date of MSDS: March 6, 2006
Section 2. Composition/Hazardous Ingredients
Component CAS Registry # wt.
Aluminum chlorhydrate 12042-91-0 45 - 50
Ferric chloride
7705-08-0 0 -10
Section 3. Hazards Identification
Emergency Overview: Dark brown opaque liquid; mild odor; not flammable.
Potential Health Effects:
Eyes: Overexposure may cause discoloration of eye tissue, irritation and discomfort, tearing and
blurring of vision, or eye corrosion with corneal or conjunctival ulceration.
Skin: May cause irritation with discomfort or rash, burns, or ulceration.
Inhalation: May cause irritation of upper respiratory tract, with coughing.
Ingestion: May cause corrosive damage to the GI tract. Repeated ingestion of sub -lethal doses may
lead to excessive deposition in the tissues accompanied by pancreatic and liver damage.
Chronic Effects/Carcinogenicity: None of the components of this material are listed as a carcinogen
by IARC, NTP, OSHA, or ACGIH.
Section 4. First Aid Measures
Inhalation: Remove victim to fresh air. If not breathing, give artificial respiration, preferably mouth-
to-mouth. If breathing is difficult, give oxygen. Get immediate medical attention.
Eyes: Hold eyes open and rinse slowly and gently with water for 15 - 20 minutes. Remove contact
lenses, if present, after the first 5 minutes, then continue rinsing eye. Get immediate medical
attention.
Skin: Take off contaminated clothing. Rinse skin immediately with plenty of soap and water for 15 -
20 minutes. Get immediate medical attention.
Ingestion: Do not induce vomiting. Give large quantities of water, then an antacid. Never give
anything by mouth to an unconscious person. Call a physician.
ChemTreat, Inc.
P-8282L
Page 1

Section 5. Fire Fighting Measures
Flammable Properties: Not flammable.
Suitable Extinguishing Media: Use extinguishing media appropriate for surrounding fires.
Fire & Explosion Hazards: Possible formation of hazardous chlorine compounds.
Protective Equipment: Wear full protective clothing including a positive -pressure, NIOSH-approved,
self-contained breathing apparatus.
Section F. Accidental Release Measures
Small Spill: Construct temporary dikes of dirt, sand, or any readily available inert material to
prevent spreading of the material. Wearing appropriate personal protective equipment, move the
leaking container to a containment area, or plug the leak. Neutralize the lime or other base, then
absorb on inert material. Shovel up and dispose of according to local, state and federal regulations.
Large Spill: Construct temporary dikes of dirt, sand, or any readily available inert material to
prevent spreading of the product. Wearing appropriate personal protective equipment, close or cap
valves and/or block or plug hole in Ieaking container and transfer to another container for proper
disposal.
Section 7. Handling and Storage
Store in closed or covered containers when not in use, in cool, dry areas with adequate ventilation.
Do not store near heat or open flames. Exercise caution when handling product. Wash with soap and
water before eating, drinking, smoking, or using toilet facilities.
Section 8. Exposure Controls/Personal Protection
Use protective equipment in accordance with 29 CFR 1910, Subpart I. Good general ventilation
should be sufficient to control airborne levels. Wear chemical splash goggles or safety glasses with
full -face shield. Wear rubber gloves. Wash them after each use and replace as necessary. If conditions
warrant, wear impervious protective clothing such as boots, aprons, and coveralls to prevent skin
contact. Maintain eyewash fountain and quick -drench facilities in work area.
Section 9. Physical and Chemical Properties
Appearance: Dark brown opaque Physical state: Liquid
Boiling Point: >230°F Solubility in Water: Complete
Evaporation Rate: N/D Specific Gravity: —1.357
Freezing Point: N/D Vapor Density: N/D
Melting Point: N/A Vapor Pressure: N/D
Molecular Weight: N/D Viscosity: N/D
Odor: Mild % VOCs: N/D
pH: —2.9 Flash Point: Not flammable
Section 10. Stability and Reactivity
Chemical Stability: Stable at normal temperatures and conditions.
ChemTreat, Inc.
P-8282L
Page 2

Incompatibility: Rapidly corrodes most metals (titanium is one exception); may generate flammable,
potentially explosive hydrogen gas. Avoid contact with nylon, aluminum/aluminum alloys, carbon
steel, stainless steel, and copper or copper alloys.
Hazardous Decomposition Products: None known.
Hazardous Polymerization, Will not occur.
Section 11. Toxicological Information
No information furnished
Section 12. Ecological Information
Fathead minnow: 96h LC50 = 574 mg/L 0. OS X 57yrn91l..
Ceriodaphnia dubia: 48h LC50 =1464 mg/L
Section 13. Disposal Considerations
Dispose of in accordance with applicable federal, state and local laws.
Section 14. Transport Information (not meant to be all inclusive)
D.O.T. Shipping Name: Corrosive liquid, acidic, inorganic, n.o.s. (Ferric Chloride)
Hazard Class: 8 (corrosive); UN3264; PG III
Section 15. Regulatory Inf ormatton (Not meant to be all inclusive - selected regulation represented)
TSCA Status: All ingredients listed
CERCLA Reportable Quantity: Ferric chloride (7705-08-0)1000 lbs.
SARA Title III:
Section 302 Extremely Hazardous Substances: None
Section 313 Toxic Chemicals: None
CALIFORNIA PROPOSITION 65. None known
Section 16. Other Information
HMIS Hazard Rating:
Health: 2 Flammability: 0 Physical Hazard: 0 PPE: X (see note)
Note: PPE rating depends on circumstances of use. See Section 8 for recommended PPE.
SARA Hazard Categories - Section 311/312
Acute - Y Chronic - Y Fire - No Reactive - No Sudden Release - No
Prepared by: ChemTreat Regulatory Affairs
Although the iaformalion and recommendations sef forth herein (hereinafter "Infomralion") are presented in good faith and believed to be correct as of the dale hereof, ChemTreat, Inc. makes no rrpresenfalions as to the
completeness or accuracy thereof. information is supplied upon the condition flwt flu persans rereiaing same wili make their own determination as to its suitability for their purposes Prior to use. In no event will ChanTreal,
Inc. br responsible for damages of any nature whatsoeon resulting front the use or reliance upon informaGan,
NO REPRESENTATION OR WARRANTIES, EITHER EXPRESS OR IMPLIED, OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE, OR OF ANY OTHER NATURE ARE MADE
HEREUNDER WITH RESPEC' TO INFORMATION OR THE PROD UCT TO WHICH INFORMATION REFERS.
ChemTreat, Inc.
P-8282L
Page 3

Martin Marietta Materials
P. O. Box 30013
Raieigh, North Carolina 27622-0013
Telephone [phone]
CERTIFIED iVIAIL - RETURN RECEIPT REQUESTED
August 10, 2006 - -
Mr. Bradley Bennett AUG I 120
Stormwater & General Permits Unit
Division of Water Quality
1617 Mail Service Center ,
Raleigh, NC 27699-1617
Subject: Authorization to use Flocculant in a Closed Loop Recycle System
Martin Marietta Materials, Inc. - Garner Quarry
NPDES Permit No. NCG020086
Dear Mr. Bennett
We wish to seek authorization to utilize flocculant (Chemtreat P-8282L) at Martin Marietta
Materials, Inc., Garner Quarry in their closed loop plant process water recycle system. As such,
please find attached a copy of the Material Data Safety Sheet (MSDS) for the flocculant. As you
can see from Section 15 of the MSDS, this product does not fall under SARA Title III Section
313 Toxic Chemicals reporting requirement.
As mentioned above, the plant process water settling ponds are completely closed loop and have
been designed to operate with two feet of freeboard. It is our understanding from reviewing
Permit NCG020000 and the Technical Bulletin that the approval for flocculent use was only
applicable to use in treatment facilities that have the potential to discharge. As stated, this
flocculent will be used in a closed loop system. This type of system is exempt from the
Authorization to Construct requirements for the same reason that we assumed flocculent use was
exempt. All of the water contained in these systems remains on site and effluent limitations are
not an issue. The Technical Bulletin definition of Treatment Facility also reinforces this by
stating that these facilities are used to meet effluent limitations.
i trust this will satisfy the Part 11, Section B(7) requirement of the NPDES General Permit. Should
you require more information please get in touch with this office.
Sincerely,
Nuwan Wi}esuriya
Environmental Engineer
CC: Chad Coburn, NCDWQ

August 1, 2006
Donald M. Moe
Martin Marietta Materials Inc.
P.O. Box 30013
Raleigh, NC 27622-0013
Stormwater Compliance Evaluation Inspection
Garner Quarry
NPDES Permit No. NCG020086
Wake County
Dear Mr. Moe,
Michael F. Easley, Govemor
William G. Ross, Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E., Director
Division of Water Quality
Mr. Chad Coburn of the Division of Water Quality, Raleigh Regional Office, conducted an compliance evaluation inspection of the
Garner Quarry for coverage under the NPDES permit NCG020086 on July 28, 2006. Mr. Nuwan Wijesuriya, Mr. Chubby Horton,
and Ms. Jennifer Sjaardema represented Martin Marietta Materials Inc. during the inspection and their assistance was greatly
appreciated. Findings during the inspection are as follows:
1) The Stormwater Best Management Practices (BMP's) Plan for the site was reviewed and found to be in excellent order.
A general location map and site map identifying all SDO's, a copy of the general permit, records of spills, training
rosters, emergency contact information, and records of in house site inspections, were on file.
2) Qualitative monitoring is being performed according to the permit, and records are kept on site in accordance to the
permit requirements. Analytical monitoring is being performed according to the permit, and laboratory records kept at
the company's central office in Raleigh were made available to the inspectors upon request. Monitoring records are kept
on site as well.
3) Part 11, Section B (7) of the permit states that no chemical floceulants shall be used in the treatment facility without
written authorization from the Division of Water Quality. There is no record of written authorization for the use of the
chemical flocculants in the file. Please send a request for authorization to:
Bradley Bennett
Stormwater & General Permits Unit
Division of Water quality
1617 Mail Service Center
Raleigh NC 27699-1617
If you have any questions concerning the inspection, please call Mr. Chad Coburn [phone] or you can email at
chad.coburn a ncniail.net,
Sincerely,
Chad Coburn
Environmental Technician
Cc: Central Files
RRO/SWP files
Nuwan Wijesuriya, same address
NorthCarolina
Aatura!!y
North Carolina Division of Water Quality Raleigh Regional Office Surface Water Protection Phone [phone] Customer Service
Internet: h2o,enrstate.nc.us 1628 Mail Service Center Raleigh, NC 27699-1628 FAX [phone]

'1 r- , r"--r r -- .
United States Environmental Protection Agencyf, }'
�.
Form Approved.
_ ��.
EPA Washington, D.C. 20460
OMB No. 2040-0057
Water Qom liance Ins�R�
Approval expires 8-31-98
Section A: National Data System Coding (i.e., PCS)
Transaction Code NPDES yr/mo/day Inspection Type Inspector Fac Type
1 I rtl 2 15I 31 NCG020086 Ill 121 06/07/28 117 18I c 1 19I ct 20I
1 -! —I
Remarks
211 J l J1 I _1 L l I I I I I I I I _L I I_ III I" I I __I I I" I f_ I I I_J I I _I I I L 1 16 LInspection
Work Days Facility Self -Monitoring Evaluation Rating 131 QA----- -------- -- ------ --- Reserved --------- —---- ------
67I 169 7111 I 711 I 72 I N I 73I I 174 751 I I 1 I 1 I 180
Section B: Facility Data
Name and Location of Facility Inspected (For Industrial Users discharging to POTW, also include
Entry Time/Date
Permit Effective Date
POTW name and NPDES permit Number)
02,30 PM 06/07/28
05/01/19
Martin Marietta -Garner
Exit Time/Date
Permit Expiration Date
1111 E Garner Rd
Garner INC 27529
04:30 PM 06/07/29
09/12/31
Name(s) of Onsite Representative(s)/Titles(syPhone and Fax Number(s)
Other Facility Data
Name, Address of Responsible Offcialrritle/Phone and Fax Number
Contacted
Steve Whitt, PO Box 30013 Raleigh NC 27622//919-781-4550/9195104739
No
Section C: Areas Evaluated During Inspection (Check only those areas evaluated)
Permit 0 Storm Water
Section D: Sul of Finding/Comments Attach additional sheets of narrative and checklists as necessa
(See attachment summary)
Name(s) and Signature(s) of Inspector(s) AgencylOffice/Phone and Fax Numbers Date
Chad Coburn RRO WQ//919-791-4200/
6�j /� �
8/l AD
Signature of Management Q A Reviewer Agency/Office/Phone and Fax Numbers Date
EPA Form 3560-3 (Rev 9-94) Previous editions are obsolete.
Page # 1

i'
Permit: NCG020086
Inspection Date: 07/28/2006
Owner - Facility: Martin Marietta -Garner
Inspection Type: Compliance Evaluation
Permit
(If the present permit expires in 6 months or less). Has the permittee submitted a new application?
Is the facility as described in the permit?
# Are there any special conditions for the permit?
Is access to the plant site restricted to the general public?
Is the inspector granted access to all areas for inspection?
Comment:
Yes No NA NE
❑❑■❑
■❑❑❑
❑ ■ ❑ ❑
■ ❑ ❑ ❑
s❑00
Page # 3

t o�oF w a rFRQG
bwa)—I
February 7, 2005
Donald M Moe
Martin Marietta Materials Inc
PO Box 30013
Raleigh, NC 276220013
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
Subject: . NPDES Stormwater Permit Coverage Renewal
Martin Marietta -Garner
COC Number NCG020086
Wake County
Dear Permittee:
In response to your renewal application for continued coverage under general permit NCG020000 the Division of Water
Quality (DWQ) is forwarding herewith the reissued stormwater general permit. Please review the new permit to familiarize
yourself with the changes in the reissued permit. The general permit authorizes discharges of stormwater and some types of
wastewater. You must meet the provisions of the permit for the types of discharges present at your facility. This permit is
reissued pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement
between the state of North Carolina and the U.S. Environmental Protection Agency, dated December 6, 1983.
The following information is included with your permit package:
• A new Certificate of Coverage
• A copy of General Stormwater Permit NCG020000
• A copy of a Technical Bulletin for the general permit
• Five copies of Discharge Monitoring Report (DMR) Forms - wastewater and stormwater
• Five copies of Qualitative Monitoring Report Form
Your coverage under this general permit is not transferable except after notice to DWQ. The Division may require modification
or revocation and reissuance of the Certificate of Coverage. This permit does not affect the legal requirements to obtain other
permits which may be required by DENR or relieve the permitfee from responsibility for compliance with any other applicable
federal, state, or local law, rule, standard, ordinance, order, judgment, or decree.
If you have any questions regarding this permit package please contact Aisha Lau of the Central Office Stormwater Permitting
Unit at [phone], ext.578.
Sincerely,
for Alan W. Klimek, P.E,
cc: Central Files
Stormwater & General Permits Unit Files
Raleigh Regional Office
One
NorthCarolina
Naturally
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 Phone [phone] Customer Service
Intemet: h2o.enr.state.nc.uslsulstormwater.html 512 N. Salisbury St. Raleigh, NC 27604 FAX [phone]
An Equal Opportunity/Affirmative Action Employer— 50% Recycledl10% Post Consumer Paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG020000
CERTIFICATE OF COVERAGE No. NCG020086
STORMWATER AND PROCESS WASTEWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and
the Federal Water Pollution Control Act, as amended,
Martin Marietta Materials Inc
is hereby authorized to discharge stormwater and to operate treatment systems and discharges associated
with mine dewatering wastewater and process wastewater from a facility located at
Martin Marietta -Garner
1111 E Garner Rd
Garner
Wake County
to receiving waters designated as Big Branch, a class C;NSW stream in the Neuse River Basin in
accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II,
III, IV, V, and VI of General Permit No. NCG020000 as attached.
This certificate of coverage shall become effective February 7, 2005.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day February 7, 2005
for Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

i
State of North Carolina
Department of Environment Y?�VAI
and Natural Resources f
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary NCDENR
Kerr T. Stevens, Director NORTH CAROLINA DEPARTMENT OF ��
ENVIRONMENT AND NATURAL RESOIJRCE5"\', r
December 17, 1999
ROBERTT WINCHESTER
MARTIN MARIETTA - GARNER LP
P. O. BOX 30013
RALEIGH, NC 27622
Subject: Reissue - NPDES Stormwater Permit
Martin Marietta - Garner L!
COC Number NCG020086
Wake County
Dear Permittee:
In response to your renewal application for continued coverage under general permit NCG020000, the Division of
Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This permit is reissued
pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement
between the state of North Carolina and the U.S. Environmental Protection Agency, dated December 6, 1983.
The following information is included with your permit package:
* A copy of general stormwater permit NCG020000
* Five copies of the Analytical Monitoring form and five copies of the Qualitative Monitoring form
* A copy of a Technical Bulletin on this permit which outlines permit components and
addresses frequently asked questions
* A Certificate of Coverage for your facility
* DWQ fee schedule
Your coverage under this general permit is not transferable except after notice to DWQ. The Division may require
modification or revocation and reissuance of the Certificate of Coverage. This permit does not affect the legal
requirements to obtain other permits which may be required by DENR or relieve the permittee from responsibility
for compliance with any other applicable federal, state, or local law rule, standard, ordinance, order, judgment, or
decree.
Please note that in 1998 Senate Bill 1366 established changes to the permit fee structure for DWQ permits effective
January 1, 1999, This change requires that you pay an annual fee to assure continued coverage under this permit.
You will be invoiced for this fee beginning next year. A copy of the current fee schedule is included with this letter.
If you have any questions regarding this permit package please contact Tony Evans of the Central Office Stormwater
and General Permits Unit at [phone], ext. 584
Sincerely,
for Kerr T. Stevens
Director, Division of Water Quality
cc: Central Files
Raleigh Regional Office ;
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG020000
CERTIFICATE OF COVERAGE No. NCG020086
STORMWATER AND PROCESS WASTEWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
MARTIN MARIETTA
is hereby authorized to discharge stormwater and to operate or continue operation of treatment systems and
discharges associated with mine dewatering and process wastewater from a facility located at
MARTIN MARIETTA - GARNER
I I I E. GARNER ROAD
GARNER
WAKE COUNTY
to receiving waters designated as Big Branch in the Neuse River Basin in accordance with the effluent limitations,
monitoring requirements, and other conditions set forth in Parts I, II, II1, IV, V, and V1 of General Permit No.
NCG020000 as attached.
This certificate of coverage shall become effective December 17, 1999.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day December 17, 1999.
for Kerr T. Stevens, Director
Division of Water Quality
By Authority of the Environmental Management Commission

aLnk■ i �'
i
Mr, D. Glenn Williams
KPMG LLP
303 Peachtree Street, Suite 2000
Atlanta, Georgia 30309
wiru idea r. r-dsiey, tivvemor
William G. Ross Jr., Secretary
North Carolina Departm*Env':ronment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quatity
March 21, 2003
Subject: Tax Certification
_._. �—._-_-------------._._..--.-----_-..--Martin-Marietta-Materials,-Inc.---------------------__.___---___ _-•
Garner Quarry
`Wastewater Treatment/Collection Facilities
Certificate of Approval No. TCS-RH-157
Wake County
Dear Mr. Williams:
Transmitted herewith are two (2) copies of the Tax Certification (TCS-RJ-I-157) covering the Martin
Marietta Materials, Inc. Garner Quarry wastewater treatment and disposal facilities. These facilities are
authorized by Division of Water Quality Permit No. NCG020086.
Martin Marietta Materials, Inc. may use this Certification to obtain tax benefits in accordance with the
appropriate North Carolina General Statutes [NCGS 105-275(8)]. The Division of Water Quality Raleigh
Regional Office has confirmed the construction of these wastewater treatment/disposal facilities. The
applicable items/facilities are identified in the attached table: Garner Quarry Tax Certification Items.
Please be advised, however, that this Office has not attempted to judge property tax values. The inclusion
of the "Acquisition Date" and "Cost" in the table is only to assist in identification and is compiled from
the information provided to the Division of Water Quality by Martin Marietta Materials, Inc.
If you have any questions regarding this matter, please contact Mr. Randy Jones, of my staff, or me at
919/571-4700.
Sincerely,
Kenneth Schuster, P.E.
Regional Water Quality Supervisor
Attachment
file: h:ltaxcertV=ariettagarner,let
NCl?
Raleigh Regional Office Telephone [phone]
Water Quality Section Fax [phone]
1628 Mail Semite Center Customer Service: 1-800-623-774B
Raleigh, NG 27699-1628 An Equal Opportunity Action Employer

W
0 0
Garner Quarry Tax Certification Items
(The Acquisition Date and Cost Are Included for Identification Purposes Only
From Information Submitted by Martin Marietta Materials, Inc.)
Description
Acquisition Date
Cost
28078 Sand Screws
1/01/94
$55,474.86
28080 Pumps- Vertical
8/1/96
$6077.30
28081 Pumps -Vertical
8/1/96
$4481.65
9/1/96
.$16;334:38
28085 Pumps
1/l/94
$2927.30
28086 Pumps
8/ 1 /95
$9812.73
28110 Piping
1/l/94
$15,480.77
28117 Piping
8/1/96
$27,202.87
28251 Pumps
8/1/96
$4057.90
28278 Settling Cell
8/1/96
$39,275.76
28279 Settling Cell
8/1/96
$39,275.75
28280 Land
8/1/96
$39,275.75
28281 Land -Water
8/1/96
$37,965.05
Tax Certification
Martin Marietta Materials, Inc.
Page 2

NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
RALEIGH, NORTH CAROLINA
TAX CERTIFICATION
(Franchise/Privilege; Amortization; Property)
In accordance with the provisions of the General Statutes of Forth Carolina (G.S. 105-275 (8)), this
document is to certify that:
MARTIN MARIETTA MATERIALS, INC.
WAKE COUNTY
has been issued Permit No. NCG020086 from the Division of Water Quality which
authorizes Martin Marietta Materials, Inc. to own and operate wastewater
treatment/disposal facilities which serve the Garner Quarry, in Wake County.
The Environmental Management Commission (EMC) and the Department of
Environment and Natural Resources have found that the facilities referenced above:
a. have been constructed and placed into operation; and
b. comply with the requirements of the EMC; and
C. are being operated in accordance with the terms and
conditions of the applicable permit (referenced above); and
d. have as its primary, rather than incidental purpose, the
reduction of pollution resulting from the operation of the
facility that it serves.
Tax Certification
Martin Marietta Materials, Inc.
Page 3

f
Issued at Raleigh, North Carolina this the 21st day of March, 2003.
By the direction of the North Carolina Environmental Management Commission and the
North Carolina Department of Environment and Natural Resources.
Kenneth Schuster, .P.E.
Regional Water Quality Supervisor
Raleigh Regional Office
TCS-RH-157
file: hAtaxcertlmmariettagarner.let

A r avucnaw r. tasley, t;ovemor
�F Fig William G. Ross Jr., Secretary
`O� QG North Carolina Departrof Environment and Natural Resources
I, Alan W. Klimek, P.E. Director
Division of Water Quality
P `r
March 21, 2003
Mr. Emmett Curl, Revenue Collector
County of Wake
Post Office Box 2331
Raleigh, N. C. 27602
Subject: Tax Certification
Martin Marietta Materials, Inc.
Garner Quarry
Wastewater Treatment/Collection Facilities
Certificate of Approval No. TCS-RH-157
Wake County
Dear Mr. Curl:
Transmitted herewith are two (2) copies of the Tax Certification (TCS-RH-157) covering the Martin
Marietta Materials, Inc. Garner Quarry wastewater treatment and disposal facilities. These facilities are
authorized by Division of Water Quality Permit No. NCG020086.
Martin Marietta Materials, Inc. may use this Certification to obtain tax benefits in accordance with the
appropriate North Carolina General Statutes [NCGS 105-275(8)]. The Division of Water Quality Raleigh
Regional Office has confirmed the construction of these wastewater treatment/disposal facilities. The
applicable items/facilities are identified in the attached table: Garner Quarry Tax Certification Items.
Please be advised, however, that this Office has not attempted to judge property tax values. The inclusion
of the "Acquisition Date" and "Cost" in the table is only to assist in identification and is compiled from
the information provided to the Division of Water Quality by Martin Marietta Materials, Inc.
If you have any questions regarding this matter, please contact Mr. Randy Jones, of my staff, or me at
919/571-4700.
Sincerely,
Kenneth Schuster, P.E.
Regional Water Quality Supervisor
Attachment
file: hAtaxcertlmmariettagarner.tax
saw
NCD
Raleigh Regional Office Telephone [phone]
Water Quality Section Fax [phone]
1628 Mail Service Center Customer Service: 1-800-623-7748
Raleigh, NC 27699-1628 An Equal Opportunity Action Employer

.x
r
Garner Quarry Tax Certification Items
(The Acquisition Date and Cost Are Included for Identification Purposes Only
From Information Submitted by Martin Marietta Materials, Inc.)
Description
Acquisition Date
Cost
28078 Sand Screws
1/01/94
$55,474.86
28080 Pumps- Vertical
8/1/96
$6077.30
28081 Pumps -Vertical
8/1/96
$4481.65
28082 Pump
9/1/96
$16,334.38
28085 Pumps
1 / 1 /94
$2927.30
28086 Pumps
8/ 1 /95
$9812.73
28110 Piping
1/1/94
$15,480.77
28117 Piping
8/1/96
$27,202.87
28251 Pumps
8/1/96
$4057.90
28278 Settling Cell
8/1/96
$39,275.76
28279 Settling Cell
8/l/96
$39,275.75
28280 Land
8/1/96
$39,275.75
28281 Land -Water
8/1/96
$37,965.05
Tax Certification
Martin Marietta Materials, Inc.
Page 2

NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
RALEIGH, NORTH CAROLINA
TAX CERTIFICATION
(Franchise/Privilege; Amortization; Property)
In accordance with the provisions of the General Statutes of North Carolina (G_S. 105-275 (8)), this
document is to certify that:
MARTIN MARIETTA MATERIALS, INC.
WAKE COUNTY
has been issued Permit No. NCG020086 from the Division of Water Quality which
authorizes Martin Marietta Materials, Inc. to own and operate wastewater
treatment/disposal facilities which serve the Garner Quarry, in Wake County.
The Environmental Management Commission (EMC) and the Department of
Environment and Natural Resources have found that the facilities referenced above:
a. have been constructed and placed into operation; and
b. comply with the requirements of the EMC; and
C. -are being operated in accordance with the terms and
conditions of the applicable permit (referenced above); and
d. have as its primary, rather than incidental purpose, the
reduction of pollution resulting from the operation of the
facility that it serves.
Tax Certification
Martin Marietta Materials, Inc.
Page 3

0 - 0
Issued at Raleigh, North Carolina this the 21 st day of March, 2003.
By the direction of the North Carolina Environmental Management Commission and the
North Carolina Department of Environment and Natural Resources,
Kenneth Schuster, P.E.
Regional Water Quality Supervisor
Raleigh Regional Office
TCS-RH-157
file: hataxcertlmmariettagarner.tax

6
Martin Mariettagregates
P.O. Box 30013
Raleigh, North Carolina 27622-0013
Telephone: [phone]
September 10, 1996
Mr. Jay Zimmerman, Supervisor
NC Dept. of Environment, Health and Natural Resources
Division of Water Quality
3800 Barrett Drive
Raleigh, NC 27609
sllt icct: Martin Marietta Aggregates
Raleigh Regional Office
Dear Mr. Zimmerman:
U!_ SAP j 3
RAtEICHREGIO,VA
_ 1. OFFICE
In accordance with the conditions of General Permit No. NCG020000, this letter is to serve as written
notification as to Martin Marietta's intentions in the aftermath of Hurricane Fran which occurred on
September 5, 1996.
Due to high sustained winds and extensive rainfall amounts, a number of the Martin Marietta Aggregate
facilities regulated by the Raleigh Regional Office experienced major pit flooding, electrical failure and
structural damage. In order to return to normal operating conditions, emergency measures are being
implemented to remove stormwater which has accumulated within the respective pits. During the
dewatering process, discharge flow amounts may be significantly higher than normally reported. An
explanation as to the specifics of the storm will be included on the Discharge Monitoring Report (DMR)
for each facility where a permit exceedance is experienced.
Thank you for your cooperation regarding this unfortunate upset. Should you have any questions, or
should any additional information be required, please contact this office at 919/781-4550.
Very truly yu:ars,
Mitch Scott
Environmental Engineer
cc: Don Moe
Horace Willson

;y
I
State of North Cana
Depanm nt of Environment,
Healt Natural Resources
Div' ironmental Management
�a s B Hun- , , Governor
ona%8A)B. w , Secretary
A. Preston Hdw? , Jr., P.E., Director
March 8, 1995
#Aarietta Aggregates
. Box 30013
ii!h. NC 27622
Dear Mr. Whitt:
k ".4
[DEHNR
Subject: Re -Authorization to Construct
Garner Quarry
NCG020086
Wake County
In accordance with your request for an amendment to the Authorization to Construct
issued January 6, 1995, received in our office as per your letter of February 8, 1995,
approval is hereby granted. It is our understanding that the original design measurements
of the settling cells were based on an approximation of the areas available. Per your letter,
a recent survey of the areas revealed that there is room enough to increase capacity of
storage of the cells by lengthening the cells. It is also our understanding that these changes
would have no effect on the pipe sizes, flow rates, weir sizes or the pump sizes, but would
increase the efficiency to collect more fines.
This Authorization to Construct is issued in accordance with Part III, Paragraph 2
of NPDES General Permit No. NCG020000, Certificate of Coverage NCG020086, and
shall be subject to revocation unless the wastewater treatment facilities are constructed in
accordance with the conditions and limitations specified in the General Permit.
In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as
may be required by this Division, such as the construction of additional or replacement
wastewater treatment or disposal facilities.
The Raleigh Regional Office, telephone number [phone], shall be notified at
least forty-eight (48) hours in advance of operation of the installed facilities so that an in -
place inspection can be made. Such notification to the regional supervisor shall be made
during the normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday,
excluding State Holidays.
A copy of the approved plans and specifications shall be maintained on file by the
Permittee for the life of the facility.
Failure to abide by the requirements contained in this Authorization to Construct
may subject the Permittee to an enforcement action by the Division of Environmental
Management in accordance with North Carolina General Statute 143-215.6A to 143-
215.6C.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Page 2
NCG020086
March 8, 1995
The issuance of this Authorization to Construct does not preclude the Permittee from
complying with any and all statutes, rules, regulations, or ordinances which may be
required by the Division of Environmental Management or permits required by the Division
of Land Resources, the Coastal Area Management Act or any Federal or Local other
governmental permit that may be required.
If you have any questions concerning this matter, please contact Steve Ulmer at
[phone].
Sincerely,
Prestondiward, Jr., P.E.
cc: Raleigh Regional Office✓
Central Files
Permits and Engineering Unit

State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
MR STEVE WHIT=
MARTIN MARIETTA
PO BOX 30013
RALEIGH, NORTH CAROLINA 27622
Dear MR WHITT:
,I'q- -,�, 7 -9,,,e)
A 4
��r08
s
�EHNR
September 20, 1994
SEP 2 6
DEHNR RALEIGH REGIONAL Gfi lAl
Subject: Application No. ACG020086
Garner Quarry
Authorization To Construct
Wake County
The Division's Permits and Engineering Unit acknowledges receipt of your permit application and
supporting materials on September 12, 1994. This application has been assigned the number listed
above. PLEASE REFER TO THE ABOVE WATER QUALITY NUMBER WHEN MAKING
INQUIRES ON THIS PROJECT.
Your project has been assigned to Steve Ulmer for a detailed engineering review. Should there be any
questions concerning your project, the reviewer will contact you with an additional information letter.
Be aware that the Division's regional office, copied below, must provide recommendations from the
Regional Supervisor or a Procedure Four Evaluation for this project, prior to final action by the
Division.
If you have any questions, please contact Steve Ulmer at [phone].
cc: Raleigh Regional Office
Sincerely, _
ado
Carolyn McCaskill
Supervisor, State Engineering Review Group
Pollution Prevention Pays
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone]
An Equal Opportunity Affirmative Action Employer

�G

1
i�5a7i+
State of North Carolina
Department of Environment, Health and Natural Resources
Division of Environmental NL- agetnent
512 North Salisbury Street • Raleigh, North Carolina 27604
James B. Hunt, Jr., Governor
February 26, 1993
Horace Willson
P O Box 30013
Raleigh, NC 27622
Jonathan B. Howes, Secretary
Subject: General Permit No. NCG020WO .
Martin Marietta Aggregates,,
Garner Quarry
COC NCG020086 '
Wake County,
Dear Willson:
In accordance withyour application for discharge_ permit.received on December 15, 1992 we
are forwarding herewith the subject certificate of coverage to discharge under the subject state -
NPDES general permit. Issuance of this certificate of coverage.supercedes the individual NPDES
permit No. NC00002780. This permit. is issued pursuant to the requirements of North Carolina
General Statute 143-215 .1 and the' Memorandum of Agreement between North Carolina and the
US Environmental Protection agency dated December 6, 1983. • •
If any parts, measurement frequencies or sampling requirements contained M this .permit are
unacceptable to you, you have the right to request an individual permit by submitting an individual,
permit application. Unless such demand is made, this certificate of coverage shall be final and
binding.
Please take notice that this certificate of coverage is not transferable except after notice to the
Division of Environmental Management. The Divsion of Environmental Management may require
modification or revocation and reissuance of the certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be
required by the Division of Environmental Management or permits required by the Division of
Land Resource's, Coastal Area Management Act or any other Federal or Local governmental
permit that may be required.
Pollution Prevention Pays P
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] �d
An Equal Opportunity .i,(fumativeAction Employer
. rtl FS

If you have'any.quesuonsfnconcerning this permit, please contact Ms. Susan Robson at telephone
number 919/733-5083.
S, e ely,
eston , 7r.
Acting Director
cc:
Raleigh Regional Office

STATE OF NORTH CAROLINA.'­.
DEPARTMENT OF ENVIRONMENT, HEALTI-L A10NATURAL RESOURCES
DMSION OF ENVIRONMENTAL MANAGEMENT
STORMWATER, MINE DEWATERING, AND/OR OVERFLOW FROM
PROCESS WATER RECYCLE SYSTEMS DISCHARGES
11214VI&I 11 Krallem, b" I t -11-10 1 SUM 0 11 JEW61114 0.
I
In compliance with the provision of North Carolina General Statute ' 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
Martin Marietta Aggregates
is hereby authorized to continue operation of a treatment system for mine de -watering and closed loop recycling and
discharge treated wastewater and stormwater from a'facility. located at
Garner 7­
NCSR 1004
Wake County
to receiving waters designated as an unnamed tributary to Big Branch Creek in the Neuse River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts 1, 11, 1U
and IV of General Permit No. NCGO20000 as attached.
This certificate of coverage shall become effective February 26, 1993
This Certificate of Coverage shall remain in effect for the duration of the General PermiL
Signed this day February 26,1993
0
Nk-.-Flfeston HowardJr., P.E., Acting Director
Division of Environmental Management
By Authority of the Environmental Management Commission

SOC PRIORITY PRO J ECIV Y e s,___ N.o
-'If 'Yes; soc
;To
Permits and Erigineering'rUzzif
Water Quality Sectiori'
Attention: �Re�xeiv EngincerlS�`s'"V�s°
Date' ! Z- . 1;
NPDES STAFF REPORT AND RECOMMENDATION
County b)aAe
Permit No. NCOo o 2790 (04_Aew0`QQ
PART I - GENERAL INFORMATION
1. Facility and Address:
P. 0 73du 3 0o i3
2.
3.
4.
5.
6.
7_
2a(eL�k-,fJ.C. 'z7�Z2-
Date of Investigation:
Report Prepared. by:ab 1?��
Persons Contacted and Telephone,, Number: dla�
Directions to Site: o�J s 2 r o o �J ( S c �� 3 ecc �. C I/-n) Qk
Discharge Point(s), List for all discharge points:
Latitude: 35 � 1 2, 40 , Longitude: 7 &,"q r a
Attach a USGS map extract and indicate treatment facility site and discharge
point on map.
U.S.G.S. Quad No. ez-- tJ U.S.G.S. Quad Name �,9�,��2
Site and expansion area consistent with application ?
Yes --_No If No, explain:
8. Topography (relationship to flood plain included): FaCAJI'� P-ocG`��,�
(moov R
6 :::

0
9 Location of 'nearest dwelling:
�10. Receiving stream or affected surface waters: U I T 4,o -9I5�-
a. Classification: (_1 ~ '� S Ck)
b. River Basin and Subbasin No.: 03 ' 04'• o
C. Describe receiving stream features id pertinent
downstream uses: 3� 5ZC--
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
I. a. Volume of Wastewater to be' -permitted: a,u-J- c MGD(Ultimate Design
Capacity)
b. What is the current permitted capacity of the Waste Water Treatment
facility?`� �s p
C. Actual treatment capacity of the .current facility (current design
capacity)?s_, -, c,I.a
d. Date(s) and construction activities allowed by previous Authorizations
to Construct issued in the previous two years: Aj6.J
e. Please provide a description of existing or substantially constructs
wastewater trey e t facilities: P7.,, a-
�%,LC-C�ss ,W
f. Please provide a description of proposed wastewater treatment
facilities: Nut"-.
g. Possible toxic impacts to surface waters: 0 -
h. Pretreatment Program (POTWs only):
in development approved
should be required not neededW-
2. Residuals handling and utilization/disposal scheme: r 1/,4
a. If residuals are being land applied, please specify DEM permit no.
NPDES Permit Staff Report
Version 10/92
Page 2 :..

C;
Residua=ls Cont.ractor,.,'
-__--_
'Telephone NoXf
b:
•Residuals stabilization: -PSRP
C.
Landfill:
-PFRP'
Other,
d. . Other disposal/utilization scheme (Specify):
3. "Treatment plant classification (attach completed rating sheet):
4. SIC Code(s):. I q- 9 Z .
Wastewater. -Code(s) of actual wastewater, not particular facilities .i.e.., non -
contact cooling water discharge from a metal plating company would be 14,
not 56.
Primary Secondary
Main Treatment 'knit Code: 5 o o 0
PART III. OTHER PERTINENT INFORMATION.
is Is this facility bein"constructed with Construction Grant Funds or are any
public monies involved. (municipals only)? /\)14
2. ' Special inonitoring or limitations (including toxicity) requests: �J�#
3. Important SOC, JOC or Compliance Schedule dates: (Please indicate)
Date
Submission of Plans and Specifications
Begin Construction
Complete Construction
4. Alternative Analysis Evaluation: Has the facility evaluated all of the non -
discharge options available. Please provide regional perspective for each
option evaluated.
Spray Irrigation: h4 ltico—tJW
Connection to Regional Sewer System: m�bd
Subsurface: KJ6�_ (L" 4
NPDES Permit Staff Report
Version 10/92
l
P, Y

�tl er d Oos' lI,opticns:
5 �? Other SpeczaliItems: �[
P"TIV - EVALUATION AND RECOMM NDAT ON5,-, • '
use
Signature of report pr arer
Water Quality Regional Supervisor
t/ti 2 ,, 72
Date
NPDPS Permit Staff Report
Version 10/92

N�A
.'v \4
M,
I I NJ A
Cb

f •'J.. - X �rh P,e'io- ia. " s dr SiA71
• �t i" 'a.. ^ Y �� Via. 7^ :s 't - ,�• c P h' ^ '%J.x ,i, � r
zY
Sfate of North'. 'Caroli'ria
c: ..
16epartmenf -of Environmteent, Health and Nar,:aI Resources
Division of Environmental Management
512 North Salisbury Street Raleigh; North -Carolina 27604
James G. Martin, Governor A. Preston Howard, Jr„ P.E.
William W. Cobey, Jr., Secretary Acting Director
December 18, 1992
Horace Willson
Martin Marietta Aggregates
P. 0. Box 30013
Raleigh, NC 27622
Dear Mr. Willson
Subject: NPDES Permit Application
NPDES Permit No.NC0002780
Garner Quarry
Wake County
This is to acknowledge receipt of the following documents on December 15, 1992:
Application' Form
Engineering Proposal (for proposed control
Request for permit renewal,
Application Processing Fee"of $400.00,
Engineering Economics Alternatives Analysis,
Local Government Signoff,
Source Reduction and Recycling,
facilities),
lnterbasin Transfer,
4 Other Request for coverage under a general permit is being considered.,
The items checked below are needed before review can begin:
Application Form ,
Engineering proposal (see attachment),
Application Processing Fee of
Delegation of Authority (see attached)
Biocide Sheet (see attached)
Engineering Economics Alternatives Analysis,
Local Government Signoff,
Source Reduction and Recycling,
interbasin Transfer,
Other
Pnffutinn Prpv.&.tA. Ji__

�,�,'y'- 'art t 4*��: . f G"I � `•.- , 1=;, . y
,..r
li' .,• '.ai
..- •' N f r .
.� tit
Tf':the�yapplzcation as not-,, made "complete
within thirtyy�,.(30) . days, it
will be;,
returned to you:, arid',may� ,be resubmitted
when complete
this•.application has�tbeen :'assigned
4 Susan
.to
(919/73'3--5083) ;-of. our Permits -Unit for
Robson'
review., ou wae —.-advised
comments' reconuiendaticns, questions• or
'of
other information necessary
o any
for the
review the application.
I am, by copy of this letter, requesting that our Regional Office
Supervisor prepare a staff report and recommendations regarding this
discharge. If you have any questions regarding this applications,
please contact the review person listed above.
CC: Raleigh Regional Office
�Sincerely,
Coleen H. Sullins, P.E.
Z
V.,+ g
'i1

Ni?DES FACILITY,' RND PERMIT DATA
UPDATE OPTION TRX•I D:.= 5NU KEY:: NC0002786,: - '
'ERSONRL: DATA FRC I L I TY' A PLY,j NG FOR,. PERMIT �r W REGION
FACILITY NRME>.MARTIN MARIETTA=GARNER,'QUARRY" COUNTY> WAKE 05
ADDRESS: MAILING -(REQUIRED)'°, LOCATION•(REQUIRED)
STREET: P 0 BOX 30fl 13 • *' _`:�: ' STREET•::; P 0 BOX, 37
CITY: RALEIGH ST�+NC ZIP 27622 CITY.:' GARNER ST NC ZIP 27529
TELEPHONE [phone] DATE'FEE PAID:­12/15/92 AMOUNT: 400.00
STATE CONTACT> ROBSON PERSON.IN CHARGE HORACE S WILLSON
1=PROPOSED,2=EXIST,3=CLOSED 2 1=MA30R,2=MINOR 2 1=MUN,2=NON-MUN 2
LAT: 3592190 LONG: 07833590 N=NEW,M=MODIFICATION,R=REISSUE> R
DATE APP RCVD 12/15/92 WASTELOAD REQS rV/(,z
DATE STAFF REP REQS ! l-/ lV cz- WASTELOAD . RCVD 7-1
DATE STAFF REP RCVD / / SCH TO ISSUE
DATE TO P NOTICE / / DATE DRAFT PREPARED
DATE OT AG COM REQS / / DATE DENIED
DATE OT AG CON RCVD / / DATE RETURNED
DATE TO EPA / / DATE ISSUED / / ASSIGN/CHANGE PERMIT
DATE FROM EPA / / EXPIRATION DATE 06/30/93
=EE CODE C 3) 1= 0 10MGD),2=(>iMGD),3=00.SMGD),Q=(<O.1MGD),5=SF,6=(GP25,64,79),
7=(GP99,73)8=(GP76)9=(GP13,3,4,30,52)0=(NOFEE) DIS/C �11 93 CONBILL C )
"OMMENTS: 01
MESSAGE;* DATA MODIFIED SUCCESSFULLY

AND PERMIT DATA
UPDATE"`.;" OPTION :'--'.-'TRXID_',:5NU_" 'KEY NC0002780
ERSONRL!'.',', 1T6ACi LiTY."MPLY FOR PERMIT
A; ' ' REGION'
EGI
ON
FkI�IT,Y;,,NAME?;_MARTIN MARIEVA-GARNER Cou�f�Y,�,-­WAkE05 ADDRE8S:-," MAILING CkEbUIRED) LOCATION, (REQUIRED9.,-,
�Q A A �'p 6 STREET:' ROCk, 0 RRY, �O D
STREE,T,-z� --BOX 30013,
T,�,. 'i"'RALEIGH ST"NC'ZIP 27622 CITY,: TY,: GARNER`', CST NC ZIP 27622
TELEPHONE [phone],50' DATE FEE PAID: 02i�/'88 AMOUNT: 150 . 00;
STATE CONTACT> HARRIS.,.". PERSON IN CHARGE STEPHEN 'P. ZELNAK,JR
I=PROPOSED,2=EXIST,3=CLOSED -2 1=MAJOR,2=MINOR 2 1-MUN,2=NON-MUN 2
LAT: 35,12190 LONG: 07833590 N=NEW,M=MODIFICATION,R=REISSUE> R
DATE APP RCVD 02/29/88 WASTELOAD REQS 02/29/88
DATE STAFF REP REQS 03/01/88 WASTELOAD RCVD 02/29/88
DATE STAFF REP RCVD O-q / 13/86 SCH TO ISSUE CE)/ 16/88
DATE TO P NOTICE 05/02/88 DATE DRAFT PREPARED 01/13/88
DATE OT.AG COM REQS / / DATE DENIED
DATE OT AG COM RCVD. / / DATE RETURNED
DATE TO EPA / / DRTE ISSUED 06/16/88 ASSIGN/CHANGE PERMIT
DATE FROM EPA / / EXPIRATION DATE 06/30/93-
:EE CODE ( 3 ) 1=(>10MGD),2=(>lMGD),-3=(>O.lMGD),A=C<0.1,MGD),'5=SF.C)=(GP25,6,1,79),
7=(GP49,73)8=(GP76)9=(GP13,34,30,52)0=(NOFEE) DIS/C 11 q3 CONBILL
"ONMENTS: EFFECTIVE 07/01/88
MESSAGE;** ENTER DATA FOR UPDATE
�W

POST OFFICE BOX 30013
RALEIGH,NORTH CAROLINA 27622.0013
TELEPHONE [phone]
December 11, 1992
North Carolina Division of Environmental Management
Water Quality Section, NPDES Group
P. O. Box-29535
Raleigh, NC 27626-0535
`Y
Subject: General NPDES Permit Renewals
Notice of Intent
Martin Marietta Aggregates
I.
Dear Sir and/or Madam:
c
Enclosed please find four completed Notice of Intent (NOT)application: forms requesting coverage:
under General NPDES Permit No- NCG020000 for Martin Marietta's Garner; Hickory, Fountain and -,-
Lemon Springs Quarries. Attached to each NOI is its appropriate USGS topo sheet. Also included
is check #99-017886 in the amount of $1,600 to cover the application fee for each of these sites.
Please contact this office if any additional information is needed regarding this matter.
Sincerely,
110�
Mitch Scott
Environmental Engineer
MS/oe
Enclosure
cc: H. S. Willson
_ 51 Wa ey4

6d Z70L-D
OR AGENCY•USE ONLY . - E0..._—
r r
NMI WWA,2)zW1W1X�_
r•
•
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTE
NOTICE OF INTENT REQUESTING COVERAGE UNDER THE
MINING ACTIVITIES GENERAL NPDES PERMIT NCG020000
Complete this Notice of Intent (NOI) and mail 1. to the following address
North Carolina Division of Environmental Management
Water Quality Section, NPDES Group,
P.O. Box 29535
Raleigh, North Carolina, 27626-0535
The NOI must be accompanied with a.general permit filing fee of $400.00. The check should be
made out to the North Carolina- Department. of, Environment.. Health, and Natural. Resources.,
rI _ ' i
•• CCi: C2+
CRY:i a.
r • i Si
Facility Location, Informafion:
Name: u `�
Address: CC). Px &37
City: ,.(r-6,&tF PZ) _ stater zip: Z75��t
County: l-�A�Phone LQlq)77Z-3Sco3
Physical Location Information:
(Street address, state road number, distance and direction from roadway Intersection, &ad
attach a copy of a county map or USGS quad with the location of. the facility marked on the map.)
II I I t . 4A� ?}KIPS V-P. . �'Jz tj_:� s-r at' L-4,,P, P,
[Agency use only: Latitude Longitude
179
WWI ik4
NOI 02 PAGE 1

.1 �i .1 `1• l
Type>of miderals mined' at' This facility:
Siandaid. Iridiistrial'Classitication. (SIC CODE=):1473 (far activity for which the facility 'is
primaiily :'engaged)
This .is an ,�< existing facility or a _. proposed facility.
If proposed, date operation is to begin
Discharges are to I�►Jr�l�[�[E `'f ���1T�`i T ELT ^ 13
(name of receiving waters or, if to a separate
storm sewer system, name of the separate storm sewer system)
A. Does this facility have any NPDES Permits? yes —no If yes, NPDES No. 0Z760
B. Are vehicle maintenance activities occurring on site? )( yes ._no
C. Are mine dewateririg discharges occur(ng? )C yes _no
D. Are discharges of:overflows from process was tewater'treatment'systems'.occurring?-Tyes7Cno.
If yes, 'complete the: following ,on the wastewater treatment',system• ,
1.-Please describe the type`oif'process used-fo'treat`and/or recycle the -process"
wastewater. Give design specifics (i.e. design volume, retention'.time, -surf ate. -area,
etc.). Existing treatment facilities should be described in detail and design criteria or
operational' data should be provided (including calculations)�to ensure that the facility
can comply with requirements of the General Permit.
NOTE: Construction of any wastewater treatment facilities' require'-submiss.lon' of !three (3)
sets of plans and specifications along with their application.` -Design -of treatment
facilities must comply with requirements 15A NCAC 2H '.0138. If construction of
wastewater treatment facilities applies to the discharge of process wastewater,
include three sets. -of plans and .specifications with this application.
2. Does this facility employ chemical additives to flocculate suspended solids? _yes 7�no
If yes, please -state the name, manufacturer and the quantity of average daily usage of
the chemical additive.
3. Does this facility overflow only during rainfall events exceeding the 10-year, 24-hour
rainfall event? --yes _no
E. Does this facility' employ any best management practices for stormwater control? )Lyes no
If yes,�please describe
i1.1Si iQG4 Inr-ltJ1_IA�:1/G 1.4riN,�1c H1K11W, o,G-i nG
NOI 02 PAGE 2

F. Number"of discharge' points . "}
Mine Dewatering ,L mwater ;
Process Wastewater Overflows k2
Please' provide short` narrative.descelpii6n of discharges Hide OEScwl�P�E is u� �,rry
4, "'.
.
.. A. i' � .. �Ai I..1Gr1/. rJ.'2,% n✓,. LZ..'2'•is n._-,.. k �a". &.,..lA �,_II A.17 lJ�
��s�ati,� -� > ,►� Eef LO'O ©NirWLY s-Te4 PP�p AV A s E �F �►�L �r
I hereby request coverage under the referenced General Permit. I understand that coverage
under• this permit'will constitute the permit requirements for the discharge(s) and is
enforceable in the same manner as an individual permit.
I agree to abide by the following as a part of coverage under this General Permit:
1. 1 agree to abide by the approved Mining Permit for this mining activity. ('A copy of the valid mining
permit must be attached to this request.
2. 1 agree to not. discharge any sanitary wastewater from this mining activity except under the 7
provisigns of another NPDES- permit specifically issued therefore.
3. 1 agree that bulk storage of petroleum products and other chemicals shall have adequate protection so
as to contain all spills on the site..
4. 1. agree that' solid wastes will be. disposed. of in accordance'. with N.C. statutes -and rules governing,
solid waste disposal. .
5. 1 agree that maintenance activities'for vehicles -and heavy -equipment will 'be. performed so as to not
result in contamination of the surface. or. ,ground waters.
I agree to abide by the' provisions as listed above and recognize that the provisions -are to be considered
as enforceable requirements of the General Permit. .
I certify that I. am familiar with the information contained in the application and. that to the best of my
knowledge and belief such information is true, complete, and accurate.
signature
name of person signing above (printed or typed)
� 2
da e
North .Carolina General Statute 143-215.6B (1) provides .that: Any person who knowingly
makes any false statement, representation, or certification in any application, record, report,
plan or other document filed or required to be maintained under Article 21 or regulations of the
Environmental 'Management .Commission implementing that Article, or who falsifies, tampers
with or knowingly renders inaccurate any. recording or monitoring device or method required to
.be operated or maintained under Article 21 or regulations of the. Environmental Management
Commission implementing that Article, shall be guilty -of a misdemeanor punishable by a fine
not to exceed $10,000, or by imprisonment not to'exceed six months, or by both. (18 U.S.C.-
Section 1001' provides a punishment 'by a fine of not more than $10,000.or imppsonm'en ,n .%�F.
more than 5 ,years, or both, -for similar offense.) ' TM
Mrl,T r) pnr�

illiard'
l j • ��e=sy /,'�\ I 111 . 1 .1 (. �J \
Ij r n1kNr
�
y � 7 � � `•fir' -y� .'�i-:\ �. l '�7 i I �
Joy A'
II pe
-tea,. .,� h;: v',� �•; ._ -. `_/jt<L---,. � �:-- :�...: �. . I �l , II i! . '%_-..'J 1:1 .I'iJ'.�I
f�lll'` `� �-ai�� � � r392, '�.- •-n'- �o � , .l _ � �. .LL- - u, � � u � a"if n^�lM::
;• II{� .- ��yil�•r w tic. .\ �I�, ,�.� '.•� '. �' �. fi'=�,� 41 � � ��.
a ler-Co
.Hi Sc !'
Ki
y job
a .q'• ( e�� 5 -. � rir_ '���1� ., �� Ir . Jam! � ,-_'7 r_.� �ap`�1. •..�$^
yp �Ji 1• _ i� �\� _ {<.� Nis='^. �ji1`!`'�. II �� �/'IS• �•, ?3'
� r� ; ^� .�fi�r:' - I � `�c a400v,. c„�. II '� • � ti f � O l
'� `; � .�Y;¢"-`.�•`'a�y r�J 7'� -r." S.�' � ;!' 1 L� %� �•tiJ /�•• � i�-!1 u•L..
r • .�ti, •C . y = I ��P�r. ��.�d�'i' '�y: �/'.' /"l •. _-I`l1 �I I `\\� ~ u ��
�' 1.. •u I\ �l �, 1, il$O Cem V ` ,��� { Ji
J] .i i �� ~ ' •y 3 _ r9�, /' �r_ � 'l.-' 5
ter
a
UT
C2m
z o r1 Tot_Se- �— IJ `I-�e-/o, L - OJ T �,
360 }}
>> I � . �� .:� �--_, �.'� , • -'�� l� <:-ram (,�fj�f �Al. tit. � �, i

ME'M
O
�-���DATE: 2 z
To: N SUBJFCT: A C C7QZ 20 �a
N IL
PC
oaa'i y�
�L
Eo�y "P-C'a 'Z>Ac�-_T4
l Ty, s -[I>
TIf-e
ftpp rrPrz r
.SC)
77,�4 7
-n_-FE DES-A-y
1
r Kf Pn-IDVO IAlc-1
IWt S 7-b
- 4 g/V d- . '
_o From: ��V� �.�f LM E1� - �
11
r`
� North Carolina Department of Environment,
Health, and Natural Resources Primed on Recycled Paper

'Martin Marie Aggregates
•
P.O. Box 30013
Raleigh, North Carolina 27622
Telephone: [phone]
September 6, 1994
Ms. Coleen Sullins, P.E.
Water Quality Permits and Engineering Unit
N.C. Division of Environmental Management
P.O. Box 29535
Raleigh, N.C. 27626-0535
Subject: Request For Authorization to Construct
Closed Circuit Settling Cell System
Martin Marietta Aggregates - Garner Quarry
Dear Ms. Sullins:
Enclosed please find duplicate copies of the design drawings for a new closed loop
settling cell system at our Garner Quarry located in Wake County. This system will replace
the current system that has been in operation at the site for many years. This new system
will consist of 4 ponds that receive wash water from the plant. Fines from the water will
settle out in the system and the clean water is pumped back to the wash plant. This site is
currently covered by Certificate of Coverage # NCG020086 issued under General Permit
# NCG020000. This general permit covers the operation and maintenance of the present
closed loop system. As required the construction details have been sealed by a Professional
Engineer.
As stated on the details, this system will have the required 2 foot of freeboard and all of the
surface runoff will be directed away from the system. All of the required slopes will be
seeded upon completion and erosion control will be provided where needed.
Also included is a check in the amount of $200.00 to cover the permit processing fee.
Please get in touch with this office if any additional information is needed on this matter.
Sincerely,
I �� � Gam✓
Steve Whitt �-
Environmental Engineer UkL
cc: Mark Morgan UO3)
Mike � "-
BradyY
—2 JAA

5�R�9p� Nc• �� �r
S '
Ali
ro
CA
14
FAI
�N
�di
na
--A lift, 1
EEC GEL
LU,
-
�G' g
_ I kj
r
i 1 ~ Martin Marietta Aggregates
—rx-o.l✓E : 1 �� � Zoos
Garner Quarry
j Closed Loop Settling Cell Sy
Sheet: k of (o
j Date: 9/6/94
� 1

r�
•
PLa4T
SuvA -r=
�Pun P
To
1,500 Ca Prl
� Op, - •. f i, �
; LESS/�� �•'�
i a SEAL ►
i 125
, Q;
i5o Lx 4:W x IZ�� -
12 6mr SF�aaoaR-�
�ET'rLlrl� GEt,t. �
rr
A
rip F�OH P4 oIIT
�Sco GPM
e
12 � cnP
N 20 ,��� uIER
x
4
x
J
_q
a
J
w
v
v
1r
W
�
a
r
i
A
Martin Marietta Aggregates
Garner Quarry
Closed Loop Settling Cell System
Sheet: 2 of 6
Date: 9/6/9

0 0

•
SETTL.IrJfa Vie-4 A —A
Nor T[a hc.a�.E
,1 , , ,i 1 41 . i 11 .I
'7007 w -v L.-A V �jOO
4!d'f�R ELE� 2
lZ D� 1 1}-O 1 1 Z=0 r
lJoTES p I1) W-L S,tP,Fta.G>r �2kiWoFF WILL_ 13E. G)VE ,TSP FRoh
TEE GEL�trS.
ZK Rp •%
i ESS p��2) �� ExrST�NCa SLaB�aRa.Of; �iALrL� BE KEr1c�rE0 oN�
�QQ SEAL ; PEEP+-nGEp B--( c�,H I MPEAH w,.BL.E.
1250? 1 3� Z` of FP,EE,ecaPV-Sr_io.►--L- BE 116JNTZ�,NEP 6T L,A-L, TrlE�
Martin Marietta Aggregates
Garner Quarry
Closed Loop Settling Cell System
Sheet: 3of(o
Date: 9/6/94

n
U
E
5ET-rLIrl(:�3 GEL-L, GROSS- SEGTiaNL).L_ VE�-,J 0-F3
30-0'
Z } _
F-L e-VnTi o hl
E.bT To L. E-
1� �L.l. S�yRF4GE RUNOFF WILL- EaE
2) ��� Ex15T�N�a SU aR[a0E -6do.LL- BE eEriOvE.O 6-1140 REPLaGEA
3� z` aF oT v,LL- Tir�Es
Martin Marietta Aggregates
Garner Quarry
Closed Loop Settling Cell System
Sheet:4of to
-Date: 9/6/94

a •
. PP-
1 A k E- bF;,
' , L E�i ... 7b p C�� �'/t[ �-^o.• i; �v u o is Lda /o ar ! 1-�- is Z4 /-;5
t 4�i
Ir-
N • ., ry
AIL
O�/. 4.r
4� ` S�crt C vr3 �qC- pATc F 0 n 3/�•�4ofT h I �, t'LLN�`�tf I�ah Li��/4`CEN v l�l/Eil�
%N L Aqp
Y :. .J•i :a r.
0 SS
� 1A r,!�
—� Martin Marietta Aggregates
r•��r;� (Z ��k v s1 UJ i n Garner Quarry
FOA S Emu ue, GEi,L Closed Loop Settling Cell System
�+ Sheet:5of eo
r
Date: 9/6/94

,
,
--�c. /44 ..
SS
ra
'k
.2'.ox2l--o
k
0
E
Martin Marietta Aggregates
Garner Quarry
Closed Loop Settling Cell System
Sheet: &of &
Date: 9/6/94
Martin Marietta Aggregates
Garner Quarry
Closed Loop Settling Cell System
Sheet: &of &
Date: 9/6/94

•
State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
MR SIEVE WWII'
MARTIN MARIETTA
PO BOX 30013
RALEIGH, NORTH CAROLINA 27622
Dear MR WWII:
A1LF.X;WA
4
%meow,,,
IDEHNF=1
September 20, 1994
Subject: Application No. ACGO20086
Garner Quarry
Authorization To Construct
Wake County
The Division's Permits and Engineering Unit acknowledges receipt of your permit application and
supporting materials on September 12, 1994. This application has been assigned the number listed
above. PLEASE REFER TO THE ABOVE WATER QUALITY NUMBER WHEN MAK NG
INOUIRES ON TH[S PROJECT.
Your project has been assigned to Steve Ulmer for a detailed engineering review. Should there be any
questions concerning your project, the reviewer will contact you with an additional information letter.
Be aware that the Division's regional office, copied below, must provide recommendations from the
Regional Supervisor or a Procedure Four Evaluation for this project, prior to final action by the
Division.
If you have any questions, please contact Steve Ulmer at [phone].
cc: Raleigh Regional Office
Sincerely,
ado i-K
Carolyn McCaskill
Supervisor, State Engineering Review Group
Pollution Prevention Pays
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone]
An Equal Opportunity Affirmative Action Employer

ILE COPY
JOC PRIORITY PROJECT: Yes NoF
If Yes, JOC No.
To: Permits and Engineering Unit
Water Quality Section
Attention: Steve Ulmer
AUTHORIZATION TO CONSTRUCT
NPDES GENERAL PERMIT
REPORT AND RECOMMENDATIONS
Date: December 13, _1994
County: Wake
Permit No. NCG020086
PART I - GENERAL INFORMATION
1. Facility Name and Current-.Address:Martin Marietta
Garner Quarry
P.O. Box 30013
Raleigh, NC 27622
2. Date of most recent NPDES Staff Report (attach copy):
January 22, 1993
3. Changes since previous action on NPDES Permit: The
January, 1993 permit was for an individual permit,
NC0002780. This permit was replaced by a General Permit,
NCG020086.
t
4. Verify Discharge Point(s) on plans with current NPDES
Permit. List for all discharge points:
Latitude: 35042`40" Longitude: 78034/10/1
Attach a USGS map extract and indicate treatment facility
site and discharge point on map.
U.S.G.S. Quad No. E24NE U.S.G.S. Quad Name Garner
5. Treatment plant classification (attach completed rating
sheet) :Class I (too cv00%y)
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
1. Existing treatment facility
a. What is the current permitted capacity of the
facility? variable
b. Date(s) and construction activities allowed by
previous Authorizations to Construct issued in
the previous two (2) years:none

•
c. What is the actual treatment capacity of the
current facility (design volume)? variable
d. Please provide a description of existing or
substantially constructed wastewater
treatment facilities:Four settling ponds for pit
dewatering
2. Please provide a description of proposed wastewater
treatment facilities: propose to abandon existing
settling cel 1 F and construct a new four ( 4 ) cell settling
pond system.
3. Residuals handling and utilization/disposal scheme:
solids are dredged
PART III - EVALUATION AND RECOMMENDATION
The RRO has reviewed the plans for the proposed
treatment system upgrade at the Martin -Marietta Garner Quarry.
The proposal is to replace the existing four settling cell
system with a new enlarged four settling cell system to treat
the pit dewatering water. The old cells will be abandoned and
filled with borrow material. This system is closed loop
(recycle, no discharge) but is covered under NCG020086.
The RRO recommends issuance of the A to C.
r
Signature of Report Preparer
W er Quality onal Supervisor
Date
H:\ACO20086:SR

i$C:
'-:, III :zI _ �'-'\\l` :I�_`•.- J.
l (r 4ji r ink •5��i �%� �.�\�• � `' � , ,.1 �1 ` � �1 1 � �,.
CT
\'wli .! mil. 38G eeoa, .0�� -7,�y '�z i�/�•11 '�7�.`, l`� ''�•
:4,H ape
Aj
Er Co odb
�
'�i ,., 5+ :,��� �• 'max r' =.:ice'• .Y• ,
�� it r' •; J- + / .' / �. ��' '� 1 �� ,. ',.�f,,, ` � _. x i ti,� • "� ;'� �a� L' � '
• '�' 'y0 � L�f .f °r,. _ n -:,�.r �j1..: ; 1 ill _ .. 9P9 . - � Q~,� 5
inkLP
M %
+•� - '.- G � , +..,,. _ /( i-. /ems' t' . q i
� n
r 1 l 1 ter
.-i. -; _ � � .: ../• l �I`'� � �' { a9 ear' �` \���1/'y\1 / 1' � �^ a;l.
yn eem
11a r.
IE a4 N E Gar net' ��

DEC-12-1994 15: 27 FROM DEM WATER QUALITY S'7r. T 1 Off TO RRO P . 02i05
SOC PRIORITY PROJEC* Yes-__No_v_
If Yes, SOC No.
To: Permits and Engineering Unit
Water Quality Section
Attention; jBeyfezug��,''`.^f�°bso�
Date 1-- 27-'''-4
NPDES STAFF REPORT AND RECOMMENDATION
County Qa%e
Permit No. NCO06 2,29,o
PART 1 - GENERAL INFORMATION
r.�
1. Facility and Address: %�-
p. o . T3du 13
tJ . C . 2-7 z2
2. Date of Investigation:
3. Report Prepared.by: RA
4. Persons Contacted and Telephone Number: a Lc1t��so.J
�550
S. Directions to Site: o ,1 S 2 r o o �( 5� s Qo �.� �. �' 19/-A) RIL
7.
Discharge Point(s), List for all discharge points:
D / r Latitude: 35 `fz �+4 Longitude: '7_ K6.-s' ro
Attach a -USGS map extract and indicate treatment facility site and discharge
point on map.
U.S.C.S. Quad No. fz-1- 4 U.S.G.S. Quad Name e,4 x ov a-e-
Sitesize and expansion area consistent with application ?
Yes No If No, explain:
S. Topography (relationship to flood plain included): Pac.,.Q_�

DEC-12-1994 15:28 FROM DEM WATER QUALITY SECTION TO RRO P.03/05
9. Location of nearest dwelling: 'Noun. ,.,.rflA.,� 400�4-
10. Receiving stream or affected surface waters: UT -fv -9,5 TAa,kc-L
a. Classification:. '�— - t� 5 u1
b. River Basin and Subbasin No.: 03 ' 04-' o C. Describe receiving stream featuresZid pertinent
downstream uses: �� ��-� 'S a --
PART II - DESCRIMON OF DISCHARGE AND TREA,TMFNT WORKS
1. a. Volume of Wastewater to be permitted: MGD(Ultimate Design
Capacity)
b. What is the current permitted capacity of the Waste Water Treatment
facility?�
c. Actual treatment capacity of the current facility (current design
.
capacity)?S—'- G 4e1K
d. Date(s) and construction activities allowed by previous Authorizations
to Construct issued in the previous two years: Mod �.
e. Please provide a description of existing or substantially construcle
waste ater treaftnerkt facilities: jf��� pnas
. J,�.etrsS w ` J Z-y , 'rant- ,
f. Please provide a description of proposed wastewater treatment
facilities:
g. Possible toxic impacts to surface waters: tj j,F
h. Pretreatment Program (POTWs only):
in development approved
should be required not needed___
2. Residuals handling and utilization/disposal scherne: 01A
a. If residuals are being land applied, please specify DIEM permit no.
NPDE$ Permit Staff Report
Version Id/92
Page 2
Y

DEC-12-1994 15:28 FROM DEM WATER QUALITY SECTION TO RRO P.04i05
.i
Residuals Contractor ............. ..........
Telephone ' No. -------------------^-------------------
b. Residuals stabilization: PSRP PFRP Other
c. Landfill:
d. Other disposal/utilization scheme (Specify):
3. Treatment plant classification (attach completed rating sheet)::Z
4. SIC Code(s): f Lf 9 2-
.
Wastewater Code(s) of actual wastewater, not particular facilities i.e.., non -
contact cooling water discharge from a metal plating company would be 14,
not 56.
Primary ±Ej Secondary
Main Treatment Unit Code: S o o o
PART III. - OTHER PERTINENT INFORMATION
1. Is this facility being constructed with Construction Grant Funds or are any
public monies involved_ (municipals only)? /�JA
2. Special inonitoring or limitations (including toxicity) requests: &)tA
3. Important SOC, JOC or Compliance Schedule dates: (Please indicate)
Date
Submission of Plans and Specifications
Begin Construction
Complete Construction
4. Alternative Analysis Evaluation: Has the facility evaluated all of the non -
discharge options available. Please provide regional perspective for each
option evaluated.
Spray Irrigation: hA a c"
Connection to Regional Sewer System: r J rt-ec4W
Subsurface:
MIN.
NPDF-S Permit Staff Report
Version 10/92
Page 3 3 1�S9a

DEC-12—d994 15:2B FROM DEN WATER QUALITY SECTION TO
RRO P.05/05
Other disposal opticns:
5: , Other Special Items: 44- .
PART IV - EVALU TION AND RECOMM NDAT' ONS
f _4
r
Signature of report pr arer
Water Quality Regional Supervisor
Date
NPDES Permit Staff Report
Version 10/92
Page 4
TOTAL P.05