HomeMy WebLinkAboutNC0003417_SOC_20200129 DUKif E James Wells
Vice President
ENERGY Environmental,Health and Safety
Programs&Environmental Sciences
526 South Church Street
Charlotte,NC 28202
(980)373-9646
January 29, 2020 RECE�VED
Via Overnight Mail FEB 0 4 1010
Linda Culpepper NCDEQIDWR/NPDES
Director of Water Resources
North Carolina Department of Environmental Quality
1617 Mail Service Center
Raleigh, NC 27699-1617
Bob Sledge
Division of Water Resources
North Carolina Department of Environmental Quality
1617 Mail Service Center
Raleigh, NC 27699-1617
Subject: Report Under Special Order by Consent—EMC SOC WQ S 18-006
Duke Energy Progress, LLC— H.F. Lee Energy Complex
NPDES Permit NC0003417
Quarterly Progress Report for 4th Quarter 2019
Dear Ms. Culpepper and Mr. Sledge:
On behalf of Duke Energy Progress, LLC (DEP), I am submitting to you the H.F. Lee Energy
Complex Progress Report summarizing the work and activities undertaken with respect to closure
of coal ash surface impoundments as required Special Order by Consent (SOC), SOC No. S 18-
006 Section 2.b.3).
As required by the SOC, I certify under penalty of law that this document and all attachments were
prepared under my direction or supervision in accordance with a system designed to assure that
qualified personnel properly gather and evaluate the information submitted. Based on my inquiry
of the person or persons who manage the system, or those persons directly responsible for
gathering the information, the information submitted is, to the best of my knowledge and belief,
true, accurate, and complete. I am aware that there are significant penalties for submitting false
information, including the possibility of fine and imprisonment for knowing violations.
Ms. Culpepper and Mr. Sledge
January 29, 2020
Page 2
Please direct any questions concerning the H.F. Lee Energy Complex SOC No. S 18-006 to Lori
Tollie at (336) 854-4916.
Sincerel ,
James ells
Vice President, Environment, Health & Safety
Programs and Environmental Sciences
Duke Energy
CC: Richard Baker, Duke Energy
Lori Tollie, Duke Energy
Robert Howard, Duke Energy
George Hamrick, Duke Energy
Paul Draovitch, Duke Energy
Matt Hanchey, Duke Energy
Randy Hart, Duke Energy
r • I
NPDES PERMIT NC0003417
SPECIAL ORDER BY CONSENT EMC SOC WQ 518-006
QUARTERLY EXCAVATION PROGRESS REPORT
HF LEE PLANT
JANUARY 29, 2020
Background and Summary
On January 10,2019, Duke Energy Progress, LLC(DEP)and the North Carolina Environmental Management
Commission entered into a Special Order by Consent— EMC SOC WQ S18-006 (SOC) applicable to the HF
Lee Plant (HF Lee). This report is submitted in accordance with Section 2.b.3) of the SOC. In compliance
with Section 2,b.3), this report summarizes the work and activities undertaken with respect to decanting
and dewatering work and closure of coal ash surface impoundments at HF Lee. The quarterly reports are
due no later than the last day of January, April,July, and October for the duration of the SOC.
The HF Lee Plant is located in Goldsboro, NC (Wayne County) along the Neuse River. The Plant began
commercial operation in 1951. The plant's three coal-fired units were retired in September 2012 and
replaced by four oil-fueled combustion turbine units in October 2012. In December 2012, the HF Lee
Combined Cycle Plant was brought on-line, which applies two sources of energy, combustion and steam
turbines, to convert natural gas to electricity. The Coal Combustion Residuals (CCR) basins associated
with the historical coal-fired energy generation are also located on the site.
The HF Lee Plant has four, regulated CCR basins on site and a Lay of the Land Area (LOLA). The ash basins
cover approximately 307 acres, with a current ash inventory of approximately 6.3 million tons of ash, as
of November 2019. The basins are referred to as:
• Basin 1 or 1950 Inactive CCR Basin (State ID WAYNE-031)
• Basin 2 or 1955 Inactive CCR Basin (State ID WAYNE-032)
• Basin 3 or 1962 Inactive CCR Basin (State ID WAYNE-033)
• Active Basin or 1982 CCR Basin (State ID WAYNE-022)
• Lay of Land Area (LOLA)
The HF Lee site was announced as an ash beneficiation site on December 13, 2016. Ash excavation,
beneficiation, and closure of the HF Lee Ash Basins has not yet begun. Construction, startup, and
performance testing is scheduled to be completed in Q4 2020.
Decanting and Dewatering Status
Prior to the Special Order by Consent, Duke Energy commenced decanting of the HF Lee Active Ash Basin
on November 27, 2017. Decanting was completed on November 2, 2018. Duke Energy has performed
periodic maintenance decanting since that time to maintain the ash basin in a decanted state. Dewatering
of the Active Ash Basin began on July 16, 2019 and will continue throughout beneficial reuse and closure.
HF Lee: 1