NCGNE1308_COMPLETE FILE - HISTORICAL_20181121

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO. NCGNE 13iD(�
DOC TYPE [j( HISTORICAL FILE
a�0/ ti r I a- I
DOC DATE ❑
YYYYMMDD

i
STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
/V L&
DOC TYPE
!l HISTORICAL FILE
F I MONITORING REPORTS
DOC DATE
-I
YYYYM MDD

ROY COOPER NORTH CAROLINA
Governor Environmental Quality
MICHAEL S. REGAN
Secretary
WILLIAM E. (TOBY) ViNSON, JR.
Interim Director
November 21, 2018
Infiltrator Water Technologies
Attention: Ishbak Saldana
1030 Corporate Center Drive
Salisbury, North Carolina 28146
Subject: No Exposure Certification NCGNE1308
Infiltrator Water Technologies
Rowan County
Dear Mr. Saldana:
The Division of Energy, Mineral and Land Resources (DEMLR) has reviewed your submittal of
the No Exposure Certification for Exclusion from NPDES Stormwater Permitting form. Based
on your submittal and signed certification of no exposure at the above referenced facility as well
as observations made during a site visit conducted by Mooresville Regional Office staff on
November 19, 2018, the Division is granting your conditional exclusion from permitting as
provided for under 40 CFR 122.26(g), which is incorporated by reference in North Carolina
regulations.
Please note that by our acceptance of your No Exposure Certification, you are obligated to
maintain no exposure conditions at your facility. If conditions change such that your facility can
no longer qualify for the No Exposure Certification, you are obligated to immediately obtain
NPDES permit coverage for your stormwater discharge. Otherwise, the discharge becomes
subject to enforcement as an un-permitted discharge. You must self re -certify annually using the
enclosed form, or obtain NPDES permit coverage for any stormwater discharges from your
facility. The annual self re -certification does not need to be submitted to DEMLR unless
requested.
Your conditional exclusion from permitting does not affect your facility's legal requirements to
obtain environmental permits that may be required under other federal, state, or local regulations
or ordinances.
North Carolina Department of Environmental Qualiry 1 Division of Energy, mineral and Land Resources
Mooresville Regional Office f 610 East Center Avenue, Suite 301 1 Mooresvile, North Carolina 28115
704,663.1699

Infiltrator Water Technologies
No Exposure Certification
November 21, 2018
Page 2 of 2
If you have any questions or need further information, please contact Mr. James Moore at (704)
235-2138.
Sincerely,
d
Zahid Khan, CPM, CPESC, CPSWQ
Regional Engineer
Enclosure
cc: MRO — DEMLR, Stormwater Files (w/o enclosure)
Raleigh Stormwater Permitting Program, No Exposure Files (w/o enclosure)

Mao
i;
Environmental
Quality
Division of Energy, Mineral and Land Resources
Land Quality Section
National Pollutant Discharge Elimination System
NO EXPOSURE CERTIFICATION for Exclusion
NCGNE0000
FOR AGENCY USE ONLY
Date Received
Year March De
Certificate of Coverage
)Zoe
OCT
rj 0 2018
DENR-LAND QUALI
National Pollutant Discharge Elimination System application for exclusion fromraO& t p sed
on NO EXPOSURE:
Submission of this No Exposure Certification constitutes notification that your facility does not require a
permit for stormwater discharges associated with industrial activity in the State of North Carolina because
it qualifies for a no exposure exclusion. A condition of no exposure at an industrial facility means all
industrial materials and activities are protected by a storm resistant shelter (with some exceptions) to
prevent exposure to rain, snow, snowmelt, and/or runoff.
For permitted facilities in North Carolina, DEMLR must approve your application for No
Exposure Certification before this exclusion is effective. Until you are issued a No
Exposure Certification and your NPDES permit is rescinded, your facility must continue
to abide by the terms and conditions of the current permit.
industrial materials or activities include, but are not limited to: material handling equipment or activities,
industrial machinery, raw materials, intermediate products, by-products, final products, or waste products.
Material handling activities Include the storage, loading and unloading, transportation, or conveyance of
any raw material, intermediate product, final product or waste product- A storm resistant shelter is not
required for the following industrial materials and activities: drums, barrels, tanks, and similar containers
that are tightly sealed, provided those containers are not deteriorated and do not leak. "Sealed" means
banded or otherwise secured and with locked or non -operational taps or valves; adequately maintained
vehicles used in material handling; and final products, other than products that would be mobilized in
stormwater discharges (e.g., rock salt).
A No Exposure Certification must be provided for each facility qualifying for the no exposure exclusion. In
addition, the exclusion from NPDES permitting is available on a facility -wide basis only —not for individual
outfalls. if any industrial activities or materials are, or will be, exposed to precipitation, the facility is not
eligible for the no exposure exclusion. By signing and submitting this No Exposure Certification form, you
certify that a condition of no exposure exists at this facility or site and are obligated to comply with the
terms and conditions of 40 CFR 122.26(g).
If approved, your conditional No Exposure Exclusion has no expiration date
BUT MUST BE self re -certified at least annually.
Please look for information about re -certification under the No Exposure section on this page:
httDs:lldea. nc.aovlaboutldivisionslenerov-mineral-land-resourceslenerov-mineral-land-permits/storrnwater-
permitslnpdes-industrial-sw
For questions, please contact the DEMLR Regional Office for your area. (See page 6)
(Please print or type)
1) Mailing address of owner/operator (address to which all certification correspondence will be mailed?:
Name
Contact
Street Address
City
Telephone No.
Infiltrator Water Technologies
Ishbak Saldarra
1 D30 Corporate Center Drive
Salisbury State NC
704 633-5198 Fax: 704
Page 1 of 7
ZIP Code 28146
738-2266
SWU-NCGNE Last revised 9/28/2016

NCGNE0000 No Exposure Certification
2) Location of facility producing discharge:
Facility Name Infiltrator Water Technologies
Facility Contact Ishbak Saldana
Street Address 1030 Corporate Center Drive
City saiisbury State NC ZIP Code 28146
County Rowan
Telephone No. 704 633-5198 Fax: [phone]
3) Physical location information:
Please provide a narrative description of how to get to the facility (use street names, state road numbers, and
distance and direction from a roadway intersection). Go North on 1-85 to the Julian Road Exit for Salisbury. Turn right onto Julian
and proceed 750 ft then turn right onto Summit Park Drive. Proceed almost 0.4 miles and tum left onto Corporate Ctr Dr_ the site is <0.2 miles on rt.
(A copy of a map with the facility clearly located on it should be included with the certification application.)
4) Is the facility located on Native American Lands? El Yes 0 No
5) Is this a Federal facility? El Yes 0 No
6) Latitude 35 deg 37' 23.88" Longitude -80 deg 29' 14.75" (deg., min., seconds)
7) This NPDES No Exposure Exclusion application applies to which of the following:
0 New or Proposed Facility Date operation is to begin
El Existing Date operation began 2010
0 Renewal of existing No Exposure Certification Certification No.: NCGNE
8) Was this facility or site ever covered under an NPDES Stormwater Permit? 0 Yes CI No
If yes, what is the NPDES Permit Number?
9) Standard Industrial Classification:
Provide the 4-digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial
activity at this facility
SIC Code: 3 0 8 6
10) Provide a brief description of the types of industrial activities and products produced at this facility:
The facility extrudes HD Dolvethvlene into drain hoe and is readv for sale. Also makes a
a pipe product augmenting the same pipinq w/nettinct surrounding it WEPS bead. _
11) Does this facility have any Non -Discharge permits (ex: recycle permits)?
C3 No
❑ Yes
If yes, list the permit numbers for all current Non -Discharge permits for this facility:
Page 2 of 7
SWU-NCGNE Last revised 9/28/2016

NCGNE0000 No Exposure Certification
Exposure Checklists (12. - 14.)
12) Are any of the following materials or activities exposed to precipitation, now or in the foreseeable
future? (Please check either "Yes" or "No.") If you answer "Yes" to any of these items, you are not
eligible for the no exposure exclusion.
a. Using, storing, or cleaning industrial machinery or equipment, and areas where ❑ Yes 0 No El NIA
residuals from using, storing or cleaning industrial machinery or equipment
remain and are exposed to stormwater
b. Materials or residuals on the ground or in stormwater inlets from spills/leaks
c. Materials or products from past industrial activity
d. Material handling equipment (except adequately maintained vehicles)
e. Materials or products during loading/unloading or transporting activities
f. Materials or products stored outdoors (except final products intended for outside
use [e.g., new cars] where exposure to stormwater does not result in the
discharge of pollutants)
g. Materials contained in open, deteriorated or leaking storage drums, barrels,
tanks, and similar containers
h. Materials or products handled/stored on roads or railways owned or maintained
by the discharger
i. Waste material (except waste in covered, non -leaking containers [e.g.,
dumpsters])
j. Application or disposal of process wastewater (unless otherwise permitted)
© Yes
EI No
0 NIA
p Yes
p No
❑ NIA
❑ Yes
17 No
0 NIA
❑ Yes
© No
0 NIA
© Yes
0 No
❑ NIA
❑ Yes El No O N/A
❑ Yes 3 No ❑ NIA
❑ Yes El No 0 NIA
O Yes 0 No I] NIA
k. Particulate matter or visible deposits of residuals from roof stacks and/or vents 0 Yes El No E3 NIA
not otherwise regulated (i.e., under an air quality control permit) and evident in the
stormwater outflow
1. Empty containers that previously contained materials that are not properly stored ❑ Yes (p No p N/A
(i.e., not closed and stored upside down to prevent precipitation accumulation)
m. For any exterior ASTs, as well as drums, barrels, tanks, and similar containers ❑ Yes 0 No El NIA
stored outside, has the facility had any releases in the past three (3) years?
13) Above Ground Storage Tanks (ASTs): If you answer "No" to any of the following items, you are not
eligible for the no exposure exclusion.
a. Are exterior ASTs or piping free of rust, damaged or weathered coating, pits, or ❑ Yes ❑ No El N/A
deterioration, or evidence of leaks?
b. Is secondary containment provided for all exterior ASTs? If so, is it free of any ❑ Yes ❑ No a NIA
cracks, holes, or evidence of leaks, and are drain valves maintained locked
shut?
14) Secondary Containment: If you answer "No" to any of the following items, you are not eligible for the
no exposure exclusion.
Page 3 of 7
SWU-NCGNE Last revised 9/28/2016

NCGNE0000 No Exposure Certification
a. Is secondary containment provided for single above ground storage containers 13 Yes t3 No © NIA
(including drums, barrels, etc.) with a capacity of more than 660-gallons?
b. Is secondary containment provided for above ground storage containers stored E3 Yes ❑ No 0 NIA
in close proximity to each other with a combined capacity of more than 1,320-
gailons?
c. Is secondary containment provided for Title III Section 313 Superfund pYes 0 No Il NIA
Amendments and Reauthorization Act (SARA) water priority chemicals'?
d. Is secondary containment provided for hazardous substances" designated in [:]Yes © No CI NIA
40 CFR §116?
e. Are release valves on all secondary containment structures locked? © Yes 0 No p NIA
15) Hazardous Waste:
a. Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility? pYes 13 No 0 NIA
b. Is this facility a Small Quantity Generator (less than 1000 kg. of hazardous 0 Yes 0 No 0 NIA
waste generated per month) of hazardous waste?
c. Is this facility a Large Quantity Generator (1000 kg. or more of hazardous waste 0 Yes 0 No p NIA
generated per month) of hazardous waste?
If you answered yes to questions b. or c., please provide the following information:
Type(s) of
waste:
How is material stored:
Where is material stored:
How many disposal shipments per year:
Name of transport / disposal
vendor:
Vendor address:
Footnotes to Questions 14) C. & d.
"Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for de minimis amounts of certain substances,
and/or other qualifiers, as described in the exemptions from reporting requirements of Title ill SARA 313 in 40 CFR
§372.38.
"Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for amounts less than the Reportable
Quantities of the hazardous substances listed in 40 CFR §117.3.
16) Other information: If you answer "Yes" to any of the following items, you might not be eligible for the
no exposure exclusion. A more in-depth evaluation of the site circumstances may be required.
Page 4 of 7
SWU-NCGNE Last revised 9/2812016

NCGNEOOOO No Exposure Certification
a. Does your facility store used, recycled, or otherwise reclaimed pallets outside? 0 Yes IM No ❑ NIA
b. Does your facility have coal piles on site? ❑ Yes 0 No 0 NIA
c. Does your facility store other fuel sources outside in piles, such as wood chips, i0 Yes 0 No 0 NIA
sawdust, etc.?
d. Does your facility have air emissions associated with its industrial activity (e.g., El Yes 0 No 0 NIA
degreasing operations, plating, painting and metal finishing)? If so, describe the
industrial activity: Pipe Mfg and Polystyrene bead expansion and final assembly
e. If you answered yes to d., are those emissions permitted by an Air Quality 0 Yes 0 No ❑ NIA
Permit? Please specify: 1024Ro1
f. Please list any other environmental program permits (federal, state, etc.) not
specified earlier in this application (such as Hazardous Waste Permits, etc.):
Permit:
Program:
Permit:
Program:
Permit:
Program:
Permit:
Program:
Permit:
Program:
Permit:
Program:
Permit:
Program:
Page 5 of 7
SWU-NCGNE Last revised 912812016

NCGNE0000 No Exposure Certification
17) Certification:
I certify under penalty of law that I have read and understand the eligibility requirements for claiming a condition of "no
exposure" and obtaining an exclusion from NPDES stormwater permitting.
I certify under penalty of law that there are no discharges of stormwater contaminated by exposure to industrial activities or
materials from the industrial facility or site identified in this document (except as allowed under 40 CFR 122.26(g)(2)).
I understand that I am obligated to maintain no exposure conditions and complete a Self -Recertification form at least once
each year, and if requested, provide this certification to the operator of the local municipal separate storm sewer system
(MS4) into which the facility discharges (where applicable). I understand that I must allow the North Carolina Division of
Energy, Mineral, and Land Resources, or MS4 operator where the discharge is into the local MS4, to perform inspections
to confirm the condition of no exposure and to make such inspection reports publicly available upon request. 1 understand I
must keep a copy of annual re -certifications on file at the facility.
In the event that the site no longer qualifies for a No Exposure Exclusion, I understand that I must obtain coverage under
an NPDES permit prior to any point source discharge of stormwater from the facility. Additionally, 1 certify under penalty of
law that this document and all attachments were prepared under my direction or supervision in accordance with a system
designed to assure that qualified personnel properly gathered and evaluated the information submitted. Based on my
inquiry of the person or persons who manage the system, or those persons directly responsible for gathering the
information, the information submitted is to the best of my knowledge and belief true, accurate and complete. I am aware
that there are significant penalties for submitting false information, including the possibility of fine and imprisonment for
knowing violations.
I certify that I am familiar with the information contained in this application and that to the best of my knowledge and belief
such information is true, complete, and accurate. RCE{1 ED
Printed Name of Person Signing: rshbak saidana
Title: FZFlow Operations Manager
(Signature of Applicant)
(Date Signed)
OCT 3o 2018
DENR-LAND QUALITY
STORMWAT8R PERMITTING
Please note: This application for the No Exposure Exclusion is subject to approval by the NCDEQ
Regional Office prior to issuance. The Regional Office may inspect your facility for compliance
with no exposure conditions prior to that approval. The Regional Office may also inspect your
facility at any time in the future for compliance with the No Exposure Exclusion.
North Carolina General Statute 143-215.6 B([) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan, or other
document filed or required to be maintained under this Article or a rule implementing this Article; of who knowingly makes a false
statement of a material fad in a rulemaking proceeding or contested case under this Article; or who falsifies, tampers with, or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
[Environmental Management) Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine
not to exceed ten thousand dollars ($10,000).
There is currently no fee for a No Exposure Exclusion.
Page 6 of 7
SWU-NCGNE Last revised 9/28/2016

Raleigh, NC to 1030 Corporals Center Dr Google Mips
Page: 1 0l'4
Google Maps Raleigh, NC to 1030 Corporate Center Drive 128 miles, 2 h 10 Min
Dr
c�IR
:Ito
G
50 � V -� ." ,µw.r. .m.it U , nu ✓nan r41lnr
C1
C u.,.t.. o«., ate. r.a ii• s,.r;,..r.a r 1 tDn L}
`I
�' J uw�owi � i f t� � ...s.r' _:aM Cf• � ^a y - �.ti� �z�roml. . � o, n ' .. Inca
ili
Cr-
U �)
.C� 1 ,.. try r -rara • �u', !7 'w., �r.w n««�.' rry saa.rr..� I r7-
a � � i..e,:o sow w��e.� t~�t.'' Glnrloun t•. 49 �, � + v L7 . a�ok.
tv • o.li,wa«k ca.. m w �,aa„ nar r _ w varonrdil: , nr r.a r
{
.. „1
IP" - rW "."_' S
Map data 0201 8 Google 10 rni
Raleigh
North Carolina
Get on 1-440 W from E Edenton St and Hillsborough St
14 man (3.8 mi)
t 1. Head north on S Wilmington St toward New Bern
PI
a1 2. Turn left onto E Edenton St
fw 3. Use any lane to turn slightly right onto
Hillsborough St
0.1 mi
- 0.5 mi
05mi
4. At the traffic circle, take the 1 st exit and stay on
Hillsborough St
05m1
5. At the traffic circle, take the 2nd exit and stay on
Hillsborough St
0.6 mi
https:Hwww.googIc.com/maps/d1r/Raleigh,+NC/1030-PCorpo rate+Center+Dr,+Saiisbur�T,... 10/29/201 h

Raleigh, NC to 1.0 30 Corporate Center Dr - Google Maps,
I'agc 2 of 4
6. At the traffic circle, continue straight to stay on
Hillsborough St
Pass by Zaxby's Chicken Fingers & Buffalo Wings (on
the left)
0.2 mi
7. At the traffic circle, continue straight to stay on
Hillsborough St
- 02rni
*1 8. Turn left onto Hillsborough St/Shepherd St
- 72 ft
f 9. Twin right onto Hillsborough St
_ 1.0 mi
10. Turn right to merge onto 1-440 W
0.2 mi
Follow 1-440 W and US-1 S to US-64 W in Cary. Take exit
98B from US-1 S
7 min (7.1 mi)
R 11. Merge onto 1-440 W
2.7 mi
49 12. Keep left to continue on US-1 S
4.1 mi
13. Take exit 98B for US 64 W toward
Pittsboro/Asheboro
0.4 mi
Get on US-421 N in Matthews
40 min (37.8 mi)
t 14. Continue onto US-64 W
37.5 mi
R 15. Turn right to merge onto US-421 N
04mi
Follow US-421 N and 1-85 S to Julian Rd in Litaker. Take exit
74 from 1-85 S
1 h 8 min (78.7 mi)
16. Merge onto US-421 N
17. Take exit 197 to merge onto 1-85 S toward
Winston - Salem/Charlotte
littps://\V\V\V.google.coiii/ma1)s/ciii-/Raleigh,-t-NC/1030+Coi-I)or�Etc-i-Ccntei-+Dr,-t-Sitl i sbuI'y;... 10/29/2018

Raleigh, NC to 1030 Corporate Centel- Dr - Goode Maps
1'abe o['d
18. Keep left at the fork to stay on 1-85 S
_.. - 24m1
41 19. Keep left to stay on 1-85 S
44.7 m'F
20. Take exit 74 for Julian Rd
0.2 rni
Continue on Julian Rd. Take Summit Park Dr to Corporate
Center Dr
2 min (M mi)
I'' 21. Turn right onto Julian Rd
0.4 mi
r* 22. Turn right onto Summit Park Dr
O's mi
*1 23. Turn left onto Corporate Center Dr
0.2 mi
1030 Corporate Center Dr
Salisbury, NC 28146
These directions are for planning purposes only.
You may find that, construction projects, traffic,
weather, or other events may cause conditions to
differ from the map results, and you should plan
your route accordingly. You must obey all signs or
notices regarding your route
ilttps://\VWIA'.goot;lC.Com/maps/clii-/Raleigi),+NC/1030 f Corl�oratC+Centers Dr,� Salisbury ,.. 10/29/2018

.r
a

NCGNE0000 No Exposure Certification
Final Checklist
This application should include the following items:
This completed application and all supporting documentation.
U!� A map with the location of the facility clearly marked.
❑ If the site currently has an NPOES Stormwater Permit, be sure to indicate the permit number in Question 8.
Mail the entire package to:
DEMLR - Stormwater Program
Dept. of Environmental Quality
1612 Mail Service Center
Raleigh, North Carolina 27699-1612
Note
The submission of this document does not guarantee the issuance of a No Exposure Exclusion.
For questions, please contact the DEMLR Regional ice for your area.
DEMLR Regional Office Contact Information:
Winton -Salem (�
Asheville Office .-... [phone]
Fayetteville Office ... [phone]
Mooresville Office ... [phone] ,� •o
Raleigh Office ........ [phone] /[il►eniile Mvoresriiie
Washington Office ... [phone]
Wilmington Office ... [phone]
Winston-Salem ...... [phone]
Central Office ......... [phone] 1,
Page 7 of 7
SWU-NCGNE last revised W28i2016