NCGNE1215_COMPLETE FILE - HISTORICAL_20170828

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
NCGNE Ia
DOC TYPE
HISTORICAL FILE
DOC DATE
O �o
YYYYM M D D

Energy, Mineral
and Land Resources
ENVIRONMENTAL QUALITY
August 28, 2017
Hamer Fischbein
Attention: Mr. Greg Janis, Operations Manager
151 Walker Road
Statesville, NC 28625
Subject: No Exposure Certification NCGNE1215
Hamer Fischbein Statesville Plant
Iredell County
Dear Mr. Janis:
ROY COOPER
Governor
MICHAEL S. REGAN
Secretary
TRACY DAVIS
Direcmr
The Division of Energy, Mineral and Land Resources (DEMLR) has reviewed your submittal of the No
Exposure Certification for Exclusion from NPDES Stormwater Permitting form. Based on your submittal and
signed certification of no exposure at the above referenced facility as well as observations made during a site
visit conducted by Mooresville Regional Office staff on July 19, 2017, the Division is granting your conditional
exclusion from permitting as provided for under 40 CFR 122.26(g), which is incorporated by reference in
North Carolina regulations. This exclusion allows for the storage of just new wooden pallets outside.
Please note that by our acceptance of your No Exposure Certification, you are obligated to maintain no
exposure conditions at your facility. If conditions change such that your facility can no longer qualify for the
No Exposure Certification, you are obligated to immediately obtain NPDES permit coverage for your
stormwater discharge. Otherwise, the discharge becomes subject to enforcement as an un-permitted
discharge. You must self re -certify annually using the enclosed form, or obtain NPDES permit coverage for
any stormwater discharges from your facility. The annual self re -certification does not need to be submitted
to DEMLR unless requested.
Your conditional exclusion from permitting does not affect your facility's legal requirements to obtain
environmental permits that may be required under other federal, state, or local regulations or ordinances.
If you have any questions or need further information, please contact Mr. James Moore at [phone].
Sincerely,
Zahid Khan, CPM, CPESC, CPSWQ
Regional Engineer
Enclosure
cc: MRO — DEMLR, Stormwater Files (w/o enclosure)
Raleigh Stormwater Permitting Program, No Exposure Files (w/o enclosure)
State of Noah Carolina I Environmental Quality I Energy, Mineral and Land Resources
Mooresville Regional Office I610 East Center Avenue I Moores%ille, NC 28113
704fi63-1699

Permit: NCGNE1215
SOC:
County: Iredell
Region: Mooresville
Contact Person: Greg Janis
Compliance Inspection Report
Effective: Expiration: Owner: Hamer Fischbein
Effective: Expiration: Facility: Hamer Fischbein
151 Walker Rd
Statesville NC 28625
Title: Phone: [phone]
Directions to Facility:
take exit 148 off interstate 40, n on nc 90/64, right on 90, right on comscope drive, left on walker,
System Classifications:
Primary ORC: Certification:
Secondary ORCIsI:
On -Site Representativelsl:
Related Permits:
Inspection Date: 07/19/2017 Entry Time: 02:50PM Exit Time: 03:20PM
Primary Inspector: James D Moore
Secondary Inspector(s):
Phone:
Phone:
Mary L Hays
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Stormwaler Discharge, No Exposure Certificate
Facility Status: ® Compliant Not Compliant
Question Areas:
® Miscellaneous Questions ® Misc
(See attachment summary)
Page: 1

Permit: NCGNE1215 (Tuner - Facility: Hamer Fischbein
Inspection Date: 07/19/2017 Inspection Type : Compliance Evaluation Reason for Vsit: Routine
Inspection Summary:
Scap metal stored in covered metal containers.General waste stored in small covered dumpsters. Used and new pallets
stored outside. Met with Greg Janis (site manager) and discussed relocating used pallets indoors and that we would advise
on new pallets in August. Also the potential for stormwater impacts from the dock area is small.
Page: 2

ate�) �1_.
-I � z?-\ � 1-
A
NCDENR
Division of Energy, Mineral and Land Resources
Land Quality Section
National Pollutant Discharge Elimination System
NO EXPOSURE CERTIFICATIONgr�Cusion NCGNE0000
FOR AGENCY USE ONLY
D.c Rccv,. d
Year Momh
W
.
National Pollutant Discharge Elimination System application forJUN extlus of n from7a Stormwater Permit based
on NO EXPOSURE: DENR-LAND QUALITY
STORMWATER PERMITTING
Submission of this No Exposure Certification constitutes notification that your facility does
permit for stormwater discharges associated with industrial activity in the State of North Ca
it qualifies for a no exposure exclusion. A condition of no exposure at an industrial facility
industrial materials and activities are protected by a storm resistant shelter (with some exct
prevent exposure to rain, snow, snowmelt, and/or runoff.
For permitted facilities in North Carolina, DEMLR must approve your application for�o
ExposureCertification before this exclusion is effective. Until you are issued a N's
Exposure Certification and your NPDES permit is rescinded, your facility must conftue
to abide by the terms and conditions of the current permit.
Industrial materials or activities include, but are not limited to: material handling equipment or activities,
industrial machinery, raw materials, intermediate products, by-products, final products, or waste products.
Material handling activities include the storage, loading and unloading, transportation, or conveyance of
any raw material, intermediate product, final product or waste product. A storm resistant shelter is not
required for the following industrial materials and activities: drums, barrels, tanks, and similar containers
that are tightly sealed, provided those containers are not deteriorated and do not leak. "Sealed" means
banded or otherwise secured and with locked or non -operational taps or valves; adequately maintained
vehicles used in material handling; and final products, other than products that would be mobilized in
stormwater discharges (e.g., rock salt).
A No Exposure Certification must be provided for each facility qualifying for the no exposure exclusion. In
addition, the exclusion from NPDES permitting is available on a facility -wide basis only —not for individual
outfalls. If any industrial activities or materials are, or will be, exposed to precipitation, the facility is not
eligible for the no exposure exclusion. By signing and submitting this No Exposure Certification form, you
certify that a condition of no exposure exists at this facility or site and are obligated to comply with the
terms and conditions of 40 CFR 122.26(g).
If approved, your conditional no -exposure exclusion must be self re -certified at least annually
Please see information here'
fFor questions, please contact the DEMLR Regional Office for your area. (See page 6)
(Please print or type)
1) Mailing address of ownerloperator (address to which all certification correspondence will be mailed):
Name
Contact
Street Address
City
Telephone No.
State A,IC ZIP Code 2:r623'
Fax: Z"'0'rf312 " 3303
S`IP,U- ov, -Yl C 9-,C of Sfit�
Page 1 of 7
Ma
SWU-NCGNE
Last revised 5/5/2015

NCGNE0000 No Exposure Certification
2) Location of facility producing discharge:
Facility Name
Facility Contact
Street Address
City
County
Telephone No.
3) Physical location information:
Please provide a narrative description of how to get to the facility (use street names, state road numbers, and
distance and direction from a roadway intersection). J�Cc �X! r ilB oFF /-0kSi f irL Vp 01
o) Aid 16f 'tl6N>— dU 4o Zf4rFr Caµd'cJQ�D/L Leer ov Lj'1&g6Z
(A copy of a map with the facility clearly located on it should be included with the certification application.)
4) Is the facility located on Native American Lands? ❑ Yes -No
5) Is this a Federal facility? ❑Yes ANo Q�j3�g') �XU.�.3
6) Latitude ff <yS i• SW/longitude V� .f L �.Y ,Yr i�(deg., min., seconds)
7) This NPDES No Exposure Exclusion application applies to which of the following:
❑ New or Proposed Facility Date operation is to begin
.A Existing Date operation began
❑ Renewal of existing No Exposure Certification Certification No.: NCGNE
8) Was this facility or site ever covered under an NPDES Stormwater Permit? ❑ Yes No
If yes, what is the NPDES Permit Number?
9) Standard Industrial Classification:
Provide the 4 digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial
activity at this facility
SIC Code: 3 5 6, J-
10)
11) Does this facility have any Non -Discharge permits (ex: recycle permits)?
_XNo
❑ Yes
If yes, list the permit numbers for all current Non -Discharge permits for this facility:
Page 2 of 7
SWU-NCGNE Last revisetl 5l52015

NCGNE0000 No Exposure Certification
Exposure Checklists (12. - 14.)
12) Are any of the following materials or activities exposed to precipitation, now or in the foreseeable
future? (Please check either "Yes" or "No.") If you answer "Yes" to any of these items, you are not
eligible for the no exposure exclusion.
a. Using, storing, or cleaning industrial machinery or equipment, and areas where ❑ Yes *o ❑ N/A
residuals from using, storing or cleaning industrial machinery or equipment remain
and are exposed to stormwater
b. Materials or residuals on the ground or in stormwater inlets from spills/leaks ❑ Yes )KNo ❑ N/A
c. Materials or products from past industrial activity
❑ Yes *No
❑ N/A
d. Material handling equipment (except adequately maintained vehicles)
❑ Yes *No
❑ N/A
e. Materials or products during loading/unloading or transporting activities
❑ Yes *No
❑ N/A
f. Materials or products stored outdoors (except final products intended for outside
❑ Yes T No
❑ N/A
use (e.g., new cars] where exposure to stormwater does not result in the discharge
of pollutants)
g. Materials contained in open, deteriorated or leaking storage drums, barrels, tanks,
❑ Yes No
❑ N/A
and similar containers
h. Materials or products handled/stored on roads or railways owned or maintained by
❑ Yes -q,No
❑ N/A
the discharger
i. Waste material (except waste in covered, non -leaking containers [e.g., dumpsters])
❑ Yes •19'No
❑ N/A
j. Application or disposal of process wastewater (unless otherwise permitted)
❑ Yes IkNo
❑ N/A
k. Particulate matter or visible deposits of residuals from roof stacks and/or vents not
❑ Yes *No
❑ N/A
otherwise regulated (i.e., under an air quality control permit) and evident in the
stormwater outflow
I. Empty containers that previously contained materials that are not properly stored
❑ Yes -:No
❑ N/A
(i.e., not closed and stored upside down to prevent precipitation accumulation)
m. For any exterior ASTs, as well as drums, barrels, tanks, and similar containers
❑ Yes 4 No
❑ N/A
stored outside, has the facility had any releases in the past three (3) years?
13) Above Ground Storage Tanks (ASTs): If you answer "No" to any of the following items, you are not
eligible for the no exposure exclusion.
a. Are exterior ASTs or piping free of rust, damaged or weathered coating, pits, or
deterioration, or evidence of leaks?
b. Is secondary containment provided for all exterior ASTs? If so, is it free of any
cracks, holes, or evidence of leaks, and are drain valves maintained locked shut?
O Yes ❑ No X'N/A
O Yes ❑ No .XN/A
Page 3 of 7
SVVU-NGGNE
Last revised 51512015

Vi
NCGNE0000 No Exposure Certification
14) Secondary Containment: If you answer "No" to any of the following items, you are not eligible for the
no exposure exclusion.
a. Is secondary containment provided for single above ground storage containers
(including drums, barrels, etc.) with a capacity of more than 660-gallons?
b. Is secondary containment provided for above ground storage containers stored
in close proximity to each other with a combined capacity of more than 1,320-
gallons?
c. Is secondary containment provided for Title III Section 313 Superfund
Amendments and Reauthorization Act (SARA) water priority chemicals'?
d. Is secondary containment provided for hazardous substances" designated in 40
CFR §116?
e. Are release valves on all secondary containment structures locked?
15) Hazardous Waste:
a. Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility?
b. Is this facility a Small Quantity Generator (less than 1000 kg. of hazardous waste
generated per month) of hazardous waste?
c. Is this facility a Large Quantity Generator (1000 kg. or more of hazardous waste
generated per month) of hazardous waste?
If you answered yes to questions b. or c., please provide the following information:
Type(s) of waste:
How is material stored: _
Where is material stored:
How many disposal shipments per year:
Name of transport / disposal vendor: _
Vendor address:
Footnotes to Questions 14) c. & d.
❑ Yes []No N/A
❑ Yes ❑ No tN/A
❑ Yes []No N/A
❑ Yes ❑ No ON/A
❑ Yes ❑ No ,y N/A
❑ Yes ;ONO a N/A
❑ Yes -Po ❑ N/A
❑ Yes :t'K ❑ N/A
'Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for de minimis amounts of certain substances,
and/or other qualifiers, as described in the exemptions from reporting requirements of Title III SARA 313 in 40 CFR
§372.38.
"Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for amounts less than the Reportable Quantities
of the hazardous substances listed in 40 CFR §117.3.
SWU-NCGNE
Page 4 of 7
Last revised 5/5/2015

NCGNE0000 No Exposure Certification
16) Other information: If you answer "Yes" to any of the following items, you might not be eligible for the
no exposure exclusion. A more in-depth evaluation of the site circumstances may be required.
a. Does your facility star us , recycled, or otherwise reclaimed pallets outside? 11 Yes ❑ No ❑ N/A
b. Does your facility have coal piles on site? ❑ Yes *No ❑ N/A
c. Does your facility store other fuel sources outside in piles, such as wood chips, O Yes f No ❑ N/A
sawdust, etc.?
d. Does your facility have air emissions associated with its industrial activity (e.g., LI Yes ❑ No Cl NIA
degreasing operations, plating, painting and metal finishing)? If so, describe the
industrial activity:
e. If you answered yes to d., are those emissions permitted by an Air Quality Permit? ❑ Yes ❑ No ❑ N/A
Please specify:
I. Please list any other environmental program permits (federal, state, etc.) not
specified earlier in this application (such as Hazardous Waste Permits, etc.):
Permit: `fo/U Program: Sih /ate 24TC/. wA w4r6P� Pr.�4aM
Permit: Program:
Permit: Program:
Permit: Program:
Permit: Program:
Permit: Program:
Permit: Program:
Page 5 of 7
SWU-NCGNE Last revised 5/512015

NCGNE0000 No Exposure Certification
17) Certification:
I certify under penalty of law that I have read and understand the eligibility requirements for claiming a condition of "no
exposure" and obtaining an exclusion from NPDES stormwater permitting.
I certify under penalty of law that there are no discharges of stormwater contaminated by exposure to industrial activities
or materials from the industrial facility or site identified in this document (except as allowed under 40 CFR 122.26(g)(2)).
I understand that I am obligated to submit a no exposure certification form once every five (5) years to the North Carolina
Division of Water Quality and, if requested, to the operator of the local municipal separate storm sewar system (MS4) into
which the facility discharges (where applicable). I understand that I must allow the North Carolina Division of Water
Quality, or MS4 operator where the discharge is into the local MS4, to perform inspections to confirm the condition of no
exposure and to make such inspection reports publicly available upon request.
In the event that the site no longer qualifies for a No Exposure Exclusion, I understand that I must obtain coverage under
an NPDES permit prior to any point source discharge of stormwater from the facility. Additionally, I certify under penalty of
law that this document and all attachments were prepared under my direction or supervision in accordance with a system
designed to assure that qualified personnel properly gathered and evaluated the information submitted. Based on my
inquiry of the person or persons who manage the system, or those persons directly responsible for gathering the
information, the information submitted is to the best of my knowledge and belief true, accurate and complete. I am aware
that there are significant penalties for submitting false information, including the possibility of fine and imprisonment for
knowing violations.
I certify that I am familiar with the information contained in this application and that to the best of my knowledge and belief
such information is true, complete, and accurate.
Printed Name of Person Signing: GR-za6 Jft�"y t s
Title: Ot rca-ACT/or3S 1-t^P-Jf}6e7L
(Signa:t of pl' t) (Date Signed)
Please note: This application for the No Exposure Exclusion is subject to approval by the
NCDENR Regional Office prior to issuance. The Regional Office may inspect your facility for
compliance with no exposure conditions prior to that approval. The Regional Office may also
inspect your facility at any time in the future for compliance with the No Exposure Exclusion,
North Carolina General Statute 143-215.6 B(i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan, or other
document filed or required t0 be maintained under this Article or a rule Implementing this Article; or who knowingly makes a false
statement of a material fact in a rulemaking proceeding or contested case under this Article: or who falsifies, tampers with, or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
[Environmental Management] Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine
not to exceed ten thousand dollars ($10,000).
There is currently no fee for a No Exposure Exclusion.
Page 5 of 7
SWU-NCGNE � Last rcvisetl 5/5120I5

NCGNE0000 No Exposure Certification
Final Checklist
This application should include the following items:
❑ This completed application and all supporting documentation.
❑ A map with the location of the facility clearly marked.
❑ If the site currently has an NPDES Stormwater Permit, be sure to indicate the permit number in Question 8.
Mail the entire package to:
Stormwater Permitting Unit Program
Division of Energy, Mineral and Land Resources
1612 Mail Service Center
Raleigh, North Carolina 27699-1612
Note
The submission of this document does not guarantee the issuance of a No Exposure Exclusion.
For questions, please contact the DEMLR Regional Office for your area.
DEMLR Regional Office Contact Information:
Asheville Office ......
[phone]
Fayetteville Office ...
[phone]
Mooresville Office ...
[phone]
Raleigh Office ........
[phone]
Washington Office ...(252)
946-6481
Wilmington Office ...
[phone]
Winston-Salem ......
[phone]
Central Office .........(919)
607-6300
Page 7 of 7 C
Last revised 5I5/2015
SWU-NCGNE

151 Walker Rd - Google Maps
Page I of 2
Google Maps 151 Walker Rd
Statesville, NC Mal:
_r I on uti10.-
� Y
o,
151 Walker Rd
Statesville, NC 28625
At this location
Fischbein Co
. •-SaIr4Na'sLaO -.. -
�Iu�p
wi.n r.
•.vk,�•e.l rvE ri F.
Google
Map data 02017 Google 200 ft,
https://www.googlc.corrVmaps/place/ 15 I+Walker+Rd,+Statesville,+NC+28625/@ 15.9035... 5/31 /2017

�x—x—x—x—x—x—x—x—x—x—x—x—x—x—x—x—x--x—x—x—x—I SITE MAP CODE GUIDE CONTD
i v O I B ®i 24-55 Gallon Drum W/Pump
overflow L//,` 25-Conex Storage
e Boxes (No PPM)
W/Rip Rap 26-Stormwater Retention Pond #2
Q"-- � MEP 27-Mobile Oil Vac Unit
28-Oil/Grease Distribution Drums
i OF-1* � ® C-� —+e \' 1 (On Spill Pallet)
29-Hose Reel
6
i
5 e—%—x—x—x—%—%—X—x—x—x—%—%—%�
t US i --_--_______A
B 6 ©1 ] 11
POV
1 ]
2
POV
I �--
MEP I 1 i 3SA �-
x—x—x—x—x—
XP/�y' /
POV j I ----- Overflo
_%,
i W R0
u " I Adminiatrntion a9 e
Building
Bldg
1300
L11230JT T p
—� Bldg 1300 ti
Center
ente 800 Man Center m C� u
Westover Street
Reeldentiol
SITE MAP CODE GUIDE 5-Hoz-Waste Storage Bldg 10-Curbed/Covered POL Storage Shed 15-Vehicle Wash Rack-Covered/Curved 19-Stormwater Retention Pond #1
1-MSDS Location 6-Spill Response Kit/Supplies 11-Battery Room 16-Oil/Water Separator (Wash Rack) 20-Used Grease Drum
2-HAZMAT Storage Locker 7-Oil Filter Press 12-Parts Washing Solvent Vat 17-Eye Wash Station 21-Storage Bldg (No PPM)
3-POL Storage Room 8-Used Oil Tank AST 13-Corrosive Material Cabinet 18-Secondary Containment Unit- 22-Exposed Tires -
4-Spill Response Kit W/Overpack 9-Used Antifreeze Tank 14-Flommable Storage Cabinets New Oil Drums 23-LoadingRam
EL EN ENVIRONMENTAL sS ENTERPRISE GROUP, INC.
1345 Stormwater Run-off -'a— Grassy Swale Asphalt NOUN CHARIESTON. SOUTH CAROUNA 29405
FIGURE
Security Fence —x— Rip Rap ® Concrete 0
US ARMY RESERVE CENTER (NC007/100)
Storm Sewer ----- Trench Drain Grass SWP3 - SITE MAP
Storm Drain ® Building Q CHARLOTTE NC
DATE PREPARED BY: DRAWN BY: REV
Headwall ) Unregulated Outfall 'k 09-22-01 M. MOLTZEN J.I. BROWNLEE A
Manhole Q SCALE NnNE DWG NUMBER
SITE MAP CHARLOTTE NC SHEET 1 OE 1