NCGNE1031_COMPLETE FILE - HISTORICAL_20141030

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
NCGNE
DOC TYPE
HISTORICAL FILE
DOC DATE
❑
YYYYMMDD

AT
NC®EN
North Carolina Department of Environment and Natural Resources
Pat McCrory
Governor
Curtiss-Wright
Attention: Mr. Phillip Felkel
3120 Northwest Boulevard
Gastonia, NC 28052
Dear Mr. Felkel:
October 30, 2014
John E. Skvarla, III
Secretary
RECEIVED
DENR-LAND QUALITY
STQRMWATER PERMITTING
Subject: No -Exposure Certification NCGNE1031
Curtiss-Wright
3120 Northwest Boulevard
Gastonia, North Carolina
Gaston County
The Division has reviewed your submittal of the No -Exposure Certification form for
Exclusion from NPDES Stormwater Permitting. Based on your submittal and signed
certification of no exposure at the above referenced facility, and the inspection dated October
29, 2014, the Division is granting your conditional exclusion from permitting as provided for
under 40 CFR 122.26(g), which is incorporated by reference in North Carolina regulations.
Please note that by our acceptance of your no -exposure certification, you are
obligated to maintain no -exposure conditions at your facility. If conditions change such
that your facility can no longer qualify for a No -Exposure exclusion, you are obligated to
immediately obtain NPDES permit coverage for your stormwater discharge. Otherwise,
the discharge becomes subject to enforcement as an unpermitted discharge.
You must self re -certify your No -Exposure status annually using the included form
or obtain NPDES permit coverage for any stormwater discharges from your facility. The
annual self re -certification does not need to be submitted to DEMLR unless requested.
Division of Energy, Mineral, and Land Resources
Land Quality Section - Mooresville Regional Office
'610 East Center Avenue, Suite 301, Mooresville, North Carolina 28115
Telephone: [phone] FAX: [phone] • Internet: http:llportal.ncdenr.org/web/Ir/land-quality
An Equal Opportunity 1 Affirmative Action Employer-- 50% Recycled 110% Post Consumer Paper

Your conditional exclusion from permitting does not affect your facility's legal
requirements to obtain environmental permits that may be required under other federal, state,
or local regulations or ordinances.
If you have any questions or need further information, please contact Mr. Samar Bou-
Ghazale at [phone].
�.. Sincerely,
Zahid S. Khan, CPM, CPESC, CPSWQ
Regional Engineer
Land Quality Section
Enclosure: Inspection Report
cc: Bradley Bennett, Stormwater Permitting Program, No- Exposure Files NCGNE1031

Compliance Inspection Report
Permit: NCGNE1031 Effective: Expiration: Owner: Curtiss-Wright Controls Inc
SOC: Effective: Expiration: Facility: Curtiss-Wright Controls, Inc
County: Gaston 3120 Northwest Blvd
Region: Mooresville
Gastonia NC 28052
Contact Person: Phillip Felkel Title: Phone: [phone]
Directions to Facility:,
From exit 14 on 1-85, travel east on Hwy 274 (Bessemer City Road). Left on NW Blvd. Facility is on left.
System Classifications:
Primary ORC: Certification: Phone:
Secondary ORC(s):
On -Site Representative(s):
Related Permits:
Inspection Date: 10/29/2014 Entry Time: 11:30AM Exit Time: 11:45AM
Primary Inspector: Samar E Bou Ghazale Phone: [phone] Ext.2199
Secondary Inspector(s):
Reason for Inspection: Other Inspection Type: Compliance Evaluation
Permit Inspection Type: Stormwater Discharge, No Exposure Certificate
Facility Status: ® Compliant Not Compliant
Question Areas:
JW Miscellaneous Questions ® Misc
(See attachment summary)
Page: 1

'r
permit: NCGNE1031 Owner - Facility: Curtiss-Wright Controls Inc
Inspection Date: 10/2912014 Inspection Type : Compliance Evaluation Reason for Visit: Other
Inspection Summary:
Based on Mooresville Regional Office inspection on 10/2912014, Curtiss-Wright do qualify for a no -exposure certification.

E l D 5 / -'
��
Actuation Systems
RECEIVED Sensors & Controls Division
3120 Northwest Boulevard
OCT 10 2014 T: 704.869.46 0 1SF n704. 69.23326
www,curtissw6ght.com
DENL-LAND.QuALITY
STORMWATER PERMITTING
Stormwater Permitting Program
Division of Energy, Mineral and Land Resources DIVISION OF LAND RESOURCES
1612 Mail Service Center 'AND QUALITY SECTION
Raleigh, North Carolina 27699-1612 Octoberr3!s201:4)
Subject: No Exposure Certification OCT 15 2014
Curtiss-Wright Controls, Inc.
3120 Northwest Boulevard L)Ltliniiv;c,ti, yr civvthUNMEN1
Gastonia, Gaston County, North Carolina AND NATURAL RESOURCES
Dear Sir/Madam:
Please find enclosed a National Pollutant Discharge Elimination System
(NPDES) application for exclusion from a Stormwater Permit based on No
Exposure for our facility located at 3120 Northwest Boulevard in Gastonia, North
Carolina.
The facility requests No Exposure Certification on the basis that the facility does
not have or anticipate any future exposures of industrial activities to stormwater.
The facility understands that a self -recertification of the No Exposure Exclusion is
required annually, and that if conditions at the facility require a change in status,
appropriate measures will be pursued to remain in compliance (e.g. obtaining
NPDES storm water permit coverage).
If you have any questions or require additional information, please contact me by
phone at 704.481.2211 or by email at [e-mail].
Yours sincerely,
Phillip Felkel
Facilities Manager
PCF2014.014
Enclosures --No Exposure Certification application

A� Division of Energy, Mineral, and Land Resources
NCDENRNational Pollutant Discharge Elimination System
LK.�rsh Cu.ouwr. Do—'.-T Z NO EXPOSURE CERTIFICATION for Exclusion
Ex.nac ME*'T ll.o N1•IN.1L Rt50.n+C[5
NCGNE0000
FOR AGENCY USE ONLY
flats RLYeivod
Year
A44111[h
Daj'
Ccni6cutc of Cuvrn r.
NO EXPOSURE CERTIFICATION
National Pollutant Discharge Elimination System application for exclusion from a Stormwater Permit based
on NO EXPOSURE.
Submission of this No Exposure Certification constitutes notification that your facility does not require a
permit for stormwater discharges associated with industrial activity In the State of North Carolina because
it qualifies for a no exposure exclusion. A condition of no exposure at an industrial facility means all
industrial materials and activities are protected by a storm resistant shelter (with some exceptions) to
prevent exposure to rain, snow, snowmelt, andlor runoff.
For permitted facilities in North Carolina, DEMLR must approve your application for No
Exposure Certification before this exclusion is effective. Until you are issued a No
Exposure Certification and your NPDES permit is rescinded, your facility must continue
to abide by the terms and conditions of the current permit.
Industrial materials or activities Include, but are not limited to: material handling equipment or activities,
industrial machinery, raw materials, intermediate products, by-products, final products, or waste products.
Material handling activities include the storage, loading and unloading, transportation, or conveyance of
any raw material, intermediate product, final product or waste product. A storm resistant shelter is not
required for the following Industrial materials and activities: drums, barrels, tanks, and similar containers
that are tightly sealed, provided those containers are not deteriorated and do not leak. "Sealed" means
banded or otherwise secured and with locked or non -operational taps or valves; adequately maintained
vehicles used in material handling; and final products, other than products that would be mobilized in
stormwater discharges (e.g., rock salt).
A No Exposure Certification must be provided for each facility qualifying for the no exposure exclusion. In
addition, the exclusion from NPDES permitting is available on a facility -wide basis only —not for individual
ouffalls. If any industrial activities or materials are, or will be, exposed to precipitation, the facility is not
eligible for the no exposure exclusion. By signing and submitting this No Exposure Certification form, you
certify that a condition of no exposure exists at this facility or site and are obligated to comply with the
terms and conditions of 40 CFR 122.26(g).
Y
For questions, please contact the DEMLR Regional Office for your area. (See page 6)
(Please print or type)
1) Mailing address of ownerloperator (address to which all certification correspondence will be mailed):
Name V43RAG'wr
Contact _ P�41uaP +-eL_>L,eL
Street Address o u sXa4&jGS 40m>
City State fjc- ZIP Code 7$1,52
Telephone No.01�l�l - LZl l Fax: 04 LIS[ - 2,� 6Z
Email PFI-=L_V_G�_6) GJ4"ASSW a4E T- (A1M
Page 1 of 7
SW U-N E-21 Fe52014

NCGNE0000 No Exposure Certification
2) Location of facility producing discharge:
Facility Name C.0a--nee, a-%%A+-r UkrMb1-S 4 1sQC..
Facility Contact
Facility Street Address 3tzo Not tW �S'� u 1 Arzr�
City Nxs-"P'31A State K)C ZIP Code zao52-
County %�S-i-O N
Telephone No. 10y yal -zZ11 Fax: -70'1 `iat - z 2-4'7
Email Cj 12n, %W -16tf-T. wwt
3) Physical location information:
Please provide a narrative description of how to get to the facility (use street names, state road numbers, and
distance and direction from a roadway intersection)- 4 1 -9 G-L
ON `- t Crr' "A+> t-e4:`r O3. "Lkl_Vp, FAC_ u l OX3 l-1cF 1
(A copy of a map with the facility clearly located on it should be included with the certification application.)
4) Is the facility located on Native American Lands? ❑ Yes %No
5) Is this a Federal facility? ❑ Yes � No
6) Latitude 35.7_163y . Longitude - St. zt803 (deg., min., seconds)
7) This NPDES No Exposure Exclusion application applies to which of the following:
❑ New or Proposed Facility
Existing
Date operation is to begin
Date operation began 10100
Cl Renewal of existing No Exposure Certification No.: NCGNE
8) Was this facility or site ever covered under an NPDES Stormwater Permit? ❑ Yes X No
If yes, what is the NPDES Permit Number?,
9) Standard Industrial Classification:
Provide the 4 digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial
activity at this facility
SIC Code: 3 -7 Z
10) Provide a brief description of the types of industrial activities and products produced at this facility:
iz;�i FA rt- z Mc- 57vQ s+ , AI mr--Av7-r 'Ovr_y u A" !z- Gov, a.-t,� .a ;
11) Does this facility have any Non -Discharge permits (ex: recycle permits)?
� No
❑ Yes
If yes, list the permit numbers for all current Non -Discharge permits for this facility:
Page 2 of 7
SW U-NE-21 F6b2014

NCGNE0000 No Exposure Certification
Exposure Checklists (12 - 14.)
12) Are any of the following materials or activities exposed to precipitation, now or in the foreseeable
future? (Please check either "Yes" or "No.") If you answer "Yes" to any of these items, you are not
eligible for the no exposure exclusion.
a. Using, storing, or cleaning industrial machinery or equipment, and areas where ❑ Yes � No
residuals from using, storing or cleaning industrial machinery or equipment remain
and are exposed to stormwater
b. Materials or residuals on the ground or in stormwater inlets from spills/leaks ❑ Yes �4 No
c. Materials or products from past industrial activity
Cl Yes
No
d. Material handling equipment (except adequately maintained vehicles)
❑ Yes
I;Q No
e. Materials or products during loading/unloading or transporting activities
❑ Yes
ll No
f. Materials or products stored outdoors (except final products intended for outside
❑ Yes
No
use [e.g., new cars] where exposure to stormwater does not result in the discharge
of pollutants)
g. Materials contained in open, deteriorated or leaking storage drums, barrels, tanks,
u Yes
No
and similar containers
h. Materials or products handled/stored on roads or railways owned or maintained by
❑ Yes
€�( No
the discharger
i. Waste material (except waste in covered, non -leaking containers [e.g., dumpsters])
❑ Yes
No
i. Application or disposal of process wastewater (unless otherwise permitted)
❑ Yes
No
k. Particulate matter or visible deposits of residuals from roof stacks and/or vents not
❑ Yes �( No
otherwise regulated (i.e., under an air quality control permit) and evident in the
stormwater outflow
1. Empty containers that previously contained materials that are not properly stored
❑ Yes �(No
(i.e., not closed and stored upside down to prevent precipitation accumulation)
m- For any exterior ASTs, as well as drums, barrels, tanks, and similar containers
❑ Yes �A No
stored outside, has the facility had any releases in the past three (3) years?
13) Above Ground Storage Tanks (ASTs): If you answer "No" to any of the following items, you are not
eligible for the no exposure exclusion.
a. Are exterior A51"s and piping free of rust, damaged or weathered coating, pits, or ❑ Yes ❑ No �(N/A
deterioration, or evidence of teaks?
b. Is secondary containment provided for all exterior ASTs? if so, is it free of any ❑ Yes C No � N/A
cracks, holes, or evidence of leaks, and are drain valves maintained locked shut?
Page 3 of 7
SW U-ICE-21 Feb201 a

NCGNEOOOO No Exposure Certification
14) Secondary Containment: If you answer "No" to any of the following items, you are not eligible for the
no exposure exclusion.
a. Is secondary containment provided for all single above ground storage
0 Yes ❑ No � NIA
containers (including drums, barrels, etc.) with a capacity of more than 660-
gallons?
b. Is secondary containment provided for above ground storage containers stored
Yes ❑ No ❑ NIA
in close proximity to each other with a combined capacity of more than 1,320-
gallons?
c. Is secondary containment provided for Title III Section 313 Superfund
❑ Yes ❑ No tXN/A
Amendments and Reauthorization Act (SARA) water priority chemicals"?
d. Is secondary containment provided for hazardous substances- designated in 40
Yes ❑ No ❑ N/A
CFR §116?
e. Are release valves on all secondary containment structures locked?
[]Yes ❑ No �( N/A
15) Hazardous Waste:
a. Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility? ❑ Yes V No
b, Is #his facility a Small Quantity Generator (less than 1000 kg. of hazardous waste XYes ❑ No
generated per month) of hazardous waste?
c. Is this facility a Large Quantity Generator (1000 kg. or more of hazardous waste ❑ Yes X No
generated per month) of hazardous waste?
It you answered yes to questions b. or c., please provide the following information.
Type(s) of waste: _So4t�stL%Qotg Fne,M PA �.rt��]fs,+AtAttt,r+,r s(y at IT rSUos-na(,r s tgiO+9M--4
How is material stored: CS -rc--S pti kM
Where is material stared: _6tz,r 9A� -T izre++w �ur� Pa,n�srzoom co&n4iid-tcorrAAvA
How many disposal shipments per year:ym. r (1)-
Name of transport / disposal vendor: *t>etr-O&E 7rAA"5!ruGr, u4j qRVR-TAGC
Vendor address: 7got W , +MO is szx r H lMtfl-lA1JArPQu� ins (oZ3t
Footnotes to Questions 14) c. & d.
'Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for de minimis amounts of certain substances,
and/or other qualifiers, as described in the exemptions from reporting requirements of Title III SARA 313 in 40 CFR
§372.38.
"Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for amounts less than the Reportable Quantities
of the hazardous substances listed in 40 CFR §117.3.
Page 4 of 7
5 W U-N E-21 Feb2014

NCGNE0000 No Exposure Certification
16) Other information: If you answer "Yes" to any of the following items, you might not be eligible for the
no exposure exclusion. A more in-depth evaluation of the site circumstances may be required.
a. Does your facility store used, recycled, or otherwise reclaimed pallets outside? Cl Yes [ 00
b. Does your facility have coal piles on site?
❑ Yes �f No
c. Does your facility store other fuel sources outside in piles, such as wood chips, ❑ Yes V No
sawdust, etc.?
d. Does your facility have air emissions associated with its industrial activity (e.g., j.Yes ❑ No
degreasing operations, plating, painting and metal finishing)? It so, describe the
industrial activity: (alm- ij&', Wor- perm As%NG _
e. It you answered yes to d., are those emissions permitted by an Air Quality Permit? ❑ Yes X No ❑ NIA
Please specify: _ON gPA&&JT 9,00-M) , Vh{M9l--GQF c - _AL4- g�&?Ts,apt-aw,1nvU.
f. Please list any other environmental program permits (federal, state, etc.) not
specified earlier in this application (such as Hazardous Waste Permits, etc.):
Permit: NONE
Program:
Permit:
Program:
Permit:
Program:
Permit:
Program:
Permit: Program:
Permit: Program:
Permit:
Program:
Page 5 of 7
5WU-NE-21Feb2014

NCGNEOOOO No Exposure Certification
17) Certification:
I certify under penalty of law that I have read and understand the eligibility requirements for claiming a condition of "no
exposure" and obtaining an exclusion from NPDES stormwater permitting.
I certify under penalty of law that there are no discharges of stormwater contaminated by exposure to industrial activities
or materials from the industrial facility or site identified in this document (except as allowed under 40 CFR 122.26(g)(2)).
I understand that I am obligated to annually self re -certify No Exposure and, if requested, submit the re -certification to
DEMLR or the operator of the local municipal separate storm sewer system (MS4) into which the facility discharges (where
applicable), I understand that I must allow the North Carolina Division of Energy, Mineral, and Land resources (DEMLR),
or MS4 operator where the discharge is into the local MS4, to perform inspections to confirm the condition of no exposure
and to make such inspection reports publicly available upon request.
In the event that the site no longer qualifies for a No Exposure Exclusion, I Understand that I must obtain coverage under
an NPDES permit grior to any point source discharge of stormwater from the facility-. Additionally, I certify Lander penalty of
law that this document and all attachments were prepared under my direction or supervision in accordance with a system
designed to assure that qualified personnel properly gathered and evaluated the information submitted. Based on my
inquiry of the person or persons who manage the system, or those persons directly responsible for gathering the
information: the information submitted is to the best of my knowledge and belief true, accurate and complete. I am aware
that there are significant penalties for submitting false information, including the possibility of fine and imprisonment for
knowing violations.
I certify that I am familiar with the information contained in this application and that to the best of my knowledge and belief
such information is true, complete, and accurate.
Printed Name of Person Signing:.I p n �!'+�el0Wo 14
(Signature of Applicant)
1a o-2114
(bate Signed)
Please note: This application for the No Exposure Exclusion is subject to approval by the
NCOENR Regional Office prior to issuance. The Regional Office may inspect your facility for
compliance with no exposure conditions prior to that approval. The Regional Office may also
inspect your facility at any time in the future for compliance with the No Exposure Exclusion.
North Carolina General Statute 143-215.6 B(i) provides that:
Any person who knowingly makes any false statement, represematlun, or certification In any application, record, report, plan, or other
document filed or required [o be maintained under this Article or a rule implementing this Article; or who knowingly makes a false
statement of a material fact in a rulemaking proceeding or contested case under this Article; or who falsifies, tampers with, or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
[Environmental Management] Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine
not to exceed ten thousand dollars ($10,000).
There is currently no fee for a No Exposure Exclusion.
Page 6 of 7
SWU-NE-21 Feb2014

NCGNE0000 No Exposure Certification
Final Checklist
This application should include the following items:
This completed application and all supporting documentation.
A reap with the location of the facility clearly marked.
It the site currently has an NPDES Stormwater Permit, be sure to indicate the permit number in Question S.
Mall the entire package to:
Stormwater Permitting Program
Division of Energy, Mineral, and Land Resources
1612 Mail Service Center
Raleigh, North Carolina 27699-1512
Note
The submission of this document does not guarantee the issuance of a No Exposure Exclusion.
For questions, please contact the DEMLR Regional Office for your area.
DEMI_R Renal Off ic_e_Conjact Information:
Asheville Office ...... [phone]
Fayetteville Office ... [phone]
Mooresville Office ... [phone]
Raleigh Office ........ [phone]
Washington Office ...[phone]
Wilmington Office ... [phone]
Winston-Salem ...... [phone]
Central Office ......... [phone]
Page 7 of 7
S W li-N E-21 Feb2014

6 b -kit 5
.
l . f/1��1Y s, � - � Gaston Park r, �
,S11W+n S, Q -
• Cv N
` z�s Gearon Cauege N ELF]
�'d.[l.Khlg101I hY 1
^ vUr `•ur71 iaaa //" tl
u� x.Q a b r.:•
. 1r5, T: S
4a r l
Adn4in lake rark l
Aaak-lake
jo
Ffvrr pal;
rar
$40huC Feuch'l;Wy/ 7z
2:a
1 - ti \tom 133a m�SP EkEMirS��II:ArIt<vr'Pa<TGh}
Aad
•E)Curtiw-Wright Contnft
rrS// 7: re
FI�
t �tq W- z. Izle 171i•. ,
1
1iI S -Tj?t
130T 'AW
` d•r` IT[ /, �4 buy
�y � Rangy:n i
"
G -A 5 T 0 N I A
y 1331 waP.lman SUPevCenrnn z 1l�,ytjyer�+nn Are.�ndfeW 3atksoa k't,"N l;," W2rd Fue E
Is 19 ' ya{•kggsl SivN - W Intl Avc.--
j Ta die a W 51n ire g
2ra L
\ m
„4 c
• O 0
O
o®©o E ,
O ENVIRONMENTAL
0• e •
Consulting. Engineered for Results.
1440 Blueberry Lane
Charlotte, NC 28226
www.aerisenviro.com
Site Location Ma p
DATE:
September 2014
SCALE:
Curtiss-Wright Controls, Inc.
Approx. 1 in = 2,000ft.
DRAWING NO.
Gastonia, North Carolina
Figure 1

{
GTTalm Park
]7t
r
4
P�hul Rauch hwy
^'•!
� y5
a
SeP
•
L.rrtAse-WrlgifS Controls
tl Rll
.A �l` � l IlSI
� IIYI• �
._
}aSI.,Q`ih�r
aec
C4 A,r
IY iJ�rrd'.tnr
{�Tli
-
a
�.
-
• F E
YI S,r Irl. qyr
Sv .fir �
1f11
''VA"nsupoeente"* y
A,t And," Jarkor Hxl
7{
Jt
71 .�
Id'NY
'�Zk
W Inr; Mr
r
��n
r",d+e'er
4lT`
Ji i• -
C 44
�..
''aG di. C:('11 is-:L f
00 ;:;.•AERIS
ENVIRONMENTAL
Consulting. Engineered for Results.
1440 Blueberry Lane
Chariotter NC 28226
www.aerisenviro.com
Site Location Marl
F'
DATE:
September 2014
SCALE:
Curtiss-Wright Controls, Inc.
Approx. 1 in = 2,000 ft.
DRAWING NO.
Gastonia, North Carolina
Figure 1