NCGNE0685_COMPLETE FILE - HISTORICAL_20100604

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO. /VCch16 OLogl;
DOC TYPE
DOC DATE
2� HISTORICAL FILE
❑ MONITORING REPORTS
❑ avuL bLO y+
YYYYM M DD

ALI,
•Ir
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins
Governor Director
June 4, 2010
Mr. Robert K. Jayne
Kenan Transport, LLC
100 Europa Drive, Suite 320
Chapel Hill, NC 27517
Subject: No -Exposure Certification NCGNE0685
3201 Highway 421 North
New Hanover County
Dear Mr. Jayne:
Bee Freeman
Secretary
The Division has reviewed your submittal of the No -Exposure Certification for Exclusion from NPDES
Stormwater Permitting form. Based on your submittal and signed certification of no exposure at the above
referenced facility, the Division is granting your conditional exclusion from permitting as provided for under 40
CFR 126.22(g), which is incorporated by reference in North Carolina regulations.
Please note that by our acceptance of your no -exposure certification, you are obligated to maintain no -exposure
conditions at your facility. If conditions change such that your facility can no longer qualify for a no -exposure
exclusion, you are obligated to immediately obtain NPDES permit coverage for your stormwater discharge.
Otherwise, the discharge becomes subject to enforcement as an un-permitted discharge. Your conditional no-
-exposure exclusion expires in five years (June, 2015). At that time you must re -certify with the Division, or obtain
NPDES permit coverage for any stormwater discharges from your facility.
Your conditional exclusion from permitting does not affect your facility's legal requirements to obtain
environmental permits that may be required under other federal, state, or local regulations or ordinances. If you
have any questions or need further information, please contact Linda Willis at [phone].
Sincerely,
for Coleen H. Sullins
cc: WRO NCG140000 New Hanover w/original att
Central Office, Stormwater Permitting Unit, No -Exposure Files Attn: Bradley Bennett w/att
Central Office, Fran McPherson -Budget Office wo/att
Gregg Pittman 3201 Highway 421 North, Wilmington, NC 28401 Watt
File: WQ Data/NPDES/No Exposure/New Hanover
Wetlands and Stomtwater Branch
1617 Mail Service Center, Ratei h, Noah Carolina 27699-1617
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604
Phone: [phone] FAX: [phone] Customer Service: 1-877-623-6748
Internet: www.ncwalerqual4.org
An Equal Opportunity i Affirmative Action Employer
Nne
orthCar.o ina
Naturally

A 0
Lw'! - wAA
�A�
NCDENR
V�iH !iaap..w1 t.F F.Y1M[Vr pF
MAR 2 4 2010
Division of Water Quality / Surface WHU' an
National Pollutant Discharge Elimination System
NO EXPOSURE CERTIFICATION for Exclusion
NCGNE0000
NO EXPOSURE CERTIFICATION
F
CY USE ONLY
ate Rtceived
Year
I Mortth
Du
Certificate of Coverage
Please check here if this isaa f
National Pollutant Discharge Elimination System application for exclusion from a
on NO EXPOSURE:
f: E RENEW,41=�\
i permit based r f
Submission of this No Exposure Certification constitutes notification that your facility does n equire a`
permit for stormwater discharges associated with industrial activity in the State of North Carolina NCB
it qualifies for a no exposure exclusion. A condition of no exposure at an industrial facility means
industrial materials and activities are protected by a storm resistant shelter (with some exceptions) to
prevent exposure to rain, snow, snowmelt, and/or runoff.
For permitted facilities in North Carolina, DWQ must approve your application for No
Exposure Certification before this exclusion is effective. Until you are issued a No
Exposure Certification and your NPDES permit is rescinded, your facility must continue
to abide by the terms and conditions of the current permit.
Industrial materials or activities include, but are not limited to: material handling equipment or activities,
industrial machinery, raw materials, intermediate products, by-products, final products, or waste products.
Material handling activities include the storage, loading and unloading, transportation, or conveyance of
any raw material, intermediate product, final product or waste product. A storm resistant shelter is not
required for the following industrial materials and activities: drums, barrels, tanks, and similar containers
that are tightly sealed, provided those containers are not deteriorated and do not leak. "Sealed" means
banded or otherwise secured and with locked or non -operational taps or valves; adequately maintained
vehicles used in material handling; and final products, other than products that would be mobilized in
stormwater discharges (e.g., rock salt).
A No Exposure Certification must be provided for each facility qualifying for the no exposure exclusion. In
addition, the exclusion from NPDES permitting is available on a facility -wide basis only —not for individual
outfalls. If any industrial activities or materials are, or will be, exposed to precipitation, the facility is not
eligible for the no exposure exclusion. By signing and submitting this No Exposure Certification form, you
certify that a condition of no exposure exists at this facility or site and are obligated to comply with the
terms and conditions of 40 CFR 122.26(g).
You are required to reapply for the No Exposure Exclusion once every five (5) years.
For questions, please contact the DWQ Regional Office for your area. (See page 6)
(Please Print or type)
1) Mailing address of owner/operator (address to which all certification correspondence will be mailed):
Name ir61q Al �iL/.I Nsd/Li L L C
Contact Iry b C-A- i e. .F.Ae6V
Street Address t u n Ck RC> RA f7rt,.i<-
City C f_jAPC k H LL State .NL ZIP Code 2751-7
Telephone No. t q Q& 7 - r 2.2r1 Fax: C1 1 11 9 Z9 - 52V/5'
Page 1 of 7
S W U-NE-021309
Last revised 2/13/2009

r-
cam.
r c
tis �,

NCGNE0000 No Exposure Certification
2) Location of facility producing discharge:
Facility Name f�_C- N A.y ZA N s Py4*r LL e-
Facility Contact d 96 C Pr r /n A ti
Street Address J..;�0 / /-1iGj/41AS" Sia i NOArH
City W i z_M i i. Tv N T State N G ZIP Code - 8 }z o /
County ak) A(4vC4L.
Telephone No. 1/ 0 76 Z- 3377 Fax: 9 0 76 2 -- G 21
3) Physical location information:
Please provide a narrative description of how to get to the facility (use street names, state road numbers, and
-distap ce and direction from a roadway intersection). 1✓ l�J�'4 M'4; �/1I.;Y Y22Z
NOd-k AA,*/LoXrAA 11tj 4 M r 4e r e&9Jrs R •N _A';i44 -
(A copy of a map with the facility clearly located on it should be included with the certification application.)
4) Is the facility located on Native American Lands? ❑ Yes j No
5) Is this a Federal facility? ❑ Yes O(No
6) Latitude .344'17" 3" Longitude -770 , 7` S7`r (deg., min., seconds)
7) This NPDES No Exposure Exclusion application applies to which of the following:
❑ New or Proposed Facility Date operation is to begin
;K Existing Date operation began /9 g 7
❑ Renewal of existing No Exposure Certification Certification No.: NCGNE
8) Was this facility or site ever covered under an NPDES Stormwater Permit? ❑ Yes No
If yes, what is the NPDES Permit Number?
9) Standard Industrial Classification:
Provide the 4 digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial
activity at this facility
SIC Code: _127 1 3
10) Provide a brief description of the types of industrial activities and products produced at this facility:
11) Does this facility have any Non -Discharge permits (ex: recycle permits)?
KNo
C] Yes
If yes, list the permit numbers for all current Non -Discharge permits for this facility:
Page 2 of 7
SWU-NE-021309 Last revised 211312009

NCGNE0000 No Exposure Certification
Exposure Checklists (12. - 14.)
12) Are any of the following materials or activities exposed to precipitation, now or in the foreseeable
future? (Please check either "Yes" or "No.") If you answer "Yes" to any of these items, you are not
eligible for the no exposure exclusion.
a. Using, storing, or cleaning industrial machinery or equipment, and areas where ❑ Yes X No ❑ N/A
residuals from using, storing or cleaning industrial machinery or equipment remain
and are exposed to stormwater
b. Materials or residuals on the ground or in stormwater inlets from spills/leaks ❑ Yes X No ❑ NIA
c. Materials or products from past industrial activity
❑ Yes
9 No
❑ N/A
d. Material handling equipment (except adequately maintained vehicles)
❑ Yes
KNo
❑ NIA
e. Materials or products during loading/unloading or transporting activities
❑ Yes
X No
Cl N/A
f. Materials or products stored outdoors (except final products intended for outside ❑ Yes ;KNo ❑ N/A
use [e.g., new cars] where exposure to stormwater does not result in the discharge
of pollutants)
g. Materials contained in open, deteriorated or leaking storage drums, barrels, tanks, ❑ Yes X No ❑ N/A
and similar containers
h. Materials or products handled/stored on roads or railways owned or maintained by ❑ Yes Y No © N/A
the discharger
i. Waste material (except waste in covered, non -leaking containers [e.g., dumpsters]) ❑ Yes X No ❑ NIA
j. Application or disposal of process wastewater (unless otherwise permitted) ❑ Yes O(No ❑ N/A
k. Particulate matter or visible deposits of residuals from roof stacks and/or vents not
❑ Yes No ❑ NIA
otherwise regulated (i.e., under an air quality control permit) and evident in the
stormwater outflow
I. Empty containers that previously contained materials that are not properly stored
❑ Yes No ❑ N/A
(i.e., not closed and stored upside down to prevent precipitation accumulation)
m. For any exterior ASTs, as well as drums, barrels, tanks, and similar containers
❑ Yes KNo ❑ N/A
stored outside, has the facility had any releases in the past three (3) years?
13) Above Ground Storage Tanks (ASTs): If you answer "No" to any of the following items, you are not
eligible for the no exposure exclusion.
a. Are exterior ASTs or piping free of rust, damaged or weathered coating, pits, or ❑ Yes ❑ No b(NIA
deterioration, or evidence of leaks?
b. Is secondary containment provided for all exterior ASTs? If so, is it free of any ❑ Yes ❑ No XNIA
cracks, holes, or evidence of leaks, and are drain valves maintained locked shut?
Page 3 of 7
SWU-NE-021309 Last revised 211312009

NCGNE0000 No Exposure Certification
14) Secondary Containment: If you answer "No" to any of the following items, you are not eligible for the
no exposure exclusion.
a. Is secondary containment provided for single above ground storage containers
(including drums, barrels, etc.) with a capacity of more than 660-gallons?
b. Is secondary containment provided for above ground storage containers stored
in close proximity to each other with a combined capacity of more than 1,320-
gallons?
c. Is secondary containment provided for Title III Section 313 Superfund
Amendments and Reauthorization Act (SARA) water priority. chemicals'?
d. Is secondary containment provided for hazardous substances— designated in 40
CFR §116?
e. Are release valves on all secondary containment structures locked?
15) Hazardous Waste,
a. Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility?
❑ Yes ❑ No )(N/A
❑ Yes ❑ No )(N/A
❑ Yes ❑ No X NIA
❑ Yes ❑ No ;& N/A
❑ Yes ❑ No XN/A
❑ Yes X No ❑ N/A
b. Is this facility a Small Quantity Generator (less than 1000 kg. of hazardous waste P(Yes ❑ No ❑ N/A
generated per month) of hazardous waste? S6T ldsGD
c. Is this facility a Large Quantity Generator (1000 kg. or more of hazardous waste ❑ Yes O<No ❑ NIA
generated per month) of hazardous waste?
If you answered yes to questions b. or c., please provide the following information:
Type(s) of waste: /Vo WA-S l e ON S i h F
How is material stored: JVIA
Where is material stored:
Now many disposal shipments per year:
Name of transport / disposal vendor:
Vendor address: AJIi4
Footnotes to Questions 14) c. & d.
*Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for de minimis amounts of certain substances,
and/or other qualifiers, as described in the exemptions from reporting requirements of Title III SARA 313 in 40 CFR
§ 372.38.
"Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for amounts less than the Reportable Quantities
of the hazardous substances listed in 40 CFR §117.3.
Page 4 of 7
5WU-NE-021309 Last revised 211312009

NCGNE0000 No Exposure Certification
16) Other information: If you answer "Yes" to any of the following items, you might not be eligible for the
no exposure exclusion. A more in-depth evaluation of the site circumstances may be required.
a. Does your facility store used, recycled, or otherwise reclaimed pallets outside? ❑ Yes X No ❑ NIA
b. Does your facility have coal piles on site? ❑ Yes Q( No ❑ NIA
c. Does your facility store other fuel sources outside in piles, such as wood chips, ❑ Yes X No ❑ NIA
sawdust, etc.?
d. Does your facility have air emissions associated with its industrial activity (e.g., ❑ Yes KNo ❑ NIA
degreasing operations, plating, painting and metal finishing)? If so, describe the
industrial activity:
e. If you answered yes to d., are those emissions permitted by an Air Quality Permit? ❑ Yes ❑ No ),N/A
Please specify:
f. Please list any other environmental program permits (federal, state, etc.) not
specified earlier in this application (such as Hazardous Waste Permits, etc.):
Permit: Program:
Permit: Program:
Permit: Program:
Permit: Program:
Permit: Program:
Permit: Program:
Permit: Program:
Page 5 of 7
SWU-NE-021309 Last revised 211312009

NCGNE0000 No Exposure Certification
17) Certification:
I certify under penalty of law that I have read and understand the eligibility requirements for claiming a condition of "no
exposure" and obtaining an exclusion from NPDES stormwater permitting.
I certify under penalty of law that there are no discharges of stormwater contaminated by exposure to industrial activities
or materials from the industrial facility or site identified in this document (except as allowed under 40 CER 122.26(g)(2)).
I understand that I am obligated to submit a no exposure certification form once every five 5 ears to the North Carolina
Division of Water Duality and, if requested, to the operator of the local municipal separate storm sewer system (MS4) into
which the facility discharges (where applicable). I understand that I must allow the North Carolina Division of Water
Quality, or MS4 operator where the discharge is into the local MS4, to perform inspections to confirm the condition of no
exposure and to make such inspection reports publicly available upon request.
In the event that the site no longer qualifies for a No Exposure Exclusion, I understand that I must obtain coverage under
an NPDES permit prior to any point source discharge of stormwater from the facility. Additionally, I certify under penalty of
law that this document and all attachments were prepared under my direction or supervision in accordance with a system
designed to assure that qualified personnel properly gathered and evaluated the information submitted. Based on my
inquiry of the person or persons who manage the system, or those persons directly responsible for gathering the
information, the information submitted is to the best of my knowledge and belief true, accurate and complete. I am aware
that there are significant penalties for submitting false information, including the possibility of fine and imprisonment for
knowing violations.
certify that I am familiar with the information contained in this application and that to the best of my knowledge and belief
such information is true, complete, and accurate_
Printed Name of Person Signing: /Z. �CR' K • SAKN 4
Title: S"V t L& S
(Signature of Appli t) (Date Signed)
Please note: This application for the No Exposure Exclusion is subject to approval by the
NCDENR Regional Office prior to issuance. The Regional Office may inspect your facility for
compliance with no exposure conditions prior to that approval. The Regional Office may also
inspect your facility at any time in the future for compliance with the No Exposure Exclusion.
North Carolina General Statute 143-215.6 B(i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan, or other
document filed or required to be maintained under this Article or a rule implementing this Article; or who knowingly makes a false
statement of a material fact in a rulemaking proceeding or contested case under this Article; or who falsifies, tampers with, or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
[Environmental Management] Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine
not to exceed ten thousand dollars ($10,000).
There is currently no fee for a No Exposure Exclusion.
Page 6 of 7
S W U-N E-021309
Last revised 2l1312009

(w

f
Map of 3201 Us Highway 421 N, Wilmington, NC 28401-9013 - Bing Maps
Page 1 of 1
Print this page in a more readable format: Click print next to the upper-rigtN corner of the map.
z `V
421 A
O V E R �4.
a
S%,
utra
117
3201 Us Highway 421 N, Wilmington, NC 28401-9013
Fat' O�W; d
��
Sokitter Acres
j
-* j1331
N c4ur"
C
Coundl -_--_
(3
N O R T
HI
http://www,bing-com/maps/defaWt.aspx?wip=2&v=2&rtp &FORM=MSNNAV 1/25/2010

Map of 3201 Us Highway 421 N, Wilmington, NC 28401-9013 - Bing Maps Page 1 of !
Pnnt this page in a more readable format: Cock Prfnt next to the tapper-igfht comer of the map.
3201 Us Highway 421 N, Wilmington, NC 28401-9013
http://www.bi ng.com/maps/default.aspx?wip=2&v=2&rtp=—&FORM=MSNNAV 1 /25/2010