NCG170353_COMPLETE FILE - HISTORICAL_20090209

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT N0.
IV '�� � � O J ✓ 3
DOC TYPE
HISTORICAL FILE �
❑ MONITORING REPORTS
DOC DATE
❑ `�.
YYYYMM D

ff�'ia
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Paves Perdue Coleeo H. Sullins
Governor Director
February 9, 2009
Parkdale America
Attn: Mr. Randall Ferguson, Corporate Eng.
400 Cannalt Street
Thomasville, NC 27360
Subject: Compliance Evaluation Inspections
Certificates.of Coverage* NCG170353, NCG170354 & NCG500274
-Parkdale Mills, Inc.
Davidson County
Dear Mr. Ferguson:
Dee Freeman
Secretary
Jenifer Carter of the Winston-Salem Regional Office performed compliance. Evaluation
Inspections at Parkdale Mills facilities located on Carmalt Street in Thomasville (Plant 6) and -Mill Street
in Lexington (Plant 3), North Carolina on: February 111, 2009. Mark Dobbins and Laura .Grubb were
present for the inspection at Plant 6. -Shane Hamrick, Tommy Wright, Cathy Greene and Lester Sain were
present for the inspection at Plant 3. The purpose of the inspections was to review compliance with the
National Pollutant Discharge Elimination System (NPDES) General stormwater and wastewater permits.
The following are the findings from the subject inspections:
NICGI70353 (Plant 6) & NCGI70354 (Plant 3)
o Stoirnwater Pollution Prevention Plans'(SPPP) has been developed and properly implemented.
* Qualitative monitoring has been conducted and recorded in accordance with permit requirements.
• Analytical monitoring is not required since no vehicle maintenance is performed on either site.
* There were no residuals from spiIIs or leaks observed on the ground, nor in or near surface waters.
• There was no evidence of use of, or cleaning of industrial machinery or equipment outdoors.
At Plant 3, qualitative monitoring is conducted at each stormdrain. Only those stormdrains conveying
the stornwater off of the property are required to be monitored. Since many of thorn are
interconnected, you may be able to cut down of the number of monitoring locations.
NCG500274 (Plant 3)
• It was determined that this facility does not have any discharges listed in this permit, as all related
discharges are discharged to the municipal sewer system, not the storm sewer system. You may
request to have this permit rescinded.
North Carolina Division of Water (duality, Winston-Salem Regional Office
Location: 5d5 Waughtown St Winston-Salem, North Caroflna 27107
Phone: [phone]COO l FAX: [phone] Ct6tomer Service: 1-877-623-6748
Intemet mr..nmaterquality.org
eontinued on reverse...
One
NorthCarolina
)Vatumlly
An Equal 0ppx nily %A€ rrMa; ve Anion Eniployer

The Division greatly appreciates the efforts of Parlcdale Mill's staff to maintain compliance. Should you
have any questions, please contact 7enifer Carter at [phone].
Sincerely,
l✓ r
Steve W. Tedder
Surface Water Regional Supervisor
Winston-Salem Regional Office
Division of Water Quality
CC.' Mark Dobbins, Plant Mgr. (same address as above)
Shane Hamrick, Plant Mgr. (Parkdale Mills, Inc — Plant 3; 100 Mill St., Lexington, NC 27295)
WSRO Files
SWP -- Central Files
NPS ACO Unit

��
NC®ENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Michael E. Easley, Govemor William G. Ross, Jr., Secretary
Alan W. Klimek, P.E., Director
August 4, 2004
Randall Ferguson
Parkdale America
100 Mill St
Lexington, NC 27295
Subject: NPDES Stormwater Permit Coverage Renewal
Parkdale Mills Incorporated -Plant 6
COC Number NCG t 70353
Davidson County
Dear Permittee:
In response to your renewal application for continued coverage under general permit NCG170000 the Division of
Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This permit is reissued
pursuant to the requirements of North Carolina General Statute 143-215.I and the Memorandum of Agreement
between the state of North Carolina and the U.S. Environmental Protection Agency, dated December 6, 1983.
The following information is included with your permit package:
• A new Certificate of Coverage
• A copy of General Stormwater Permit NCG 170000
• A copy of a discharge monitoring report form
• 5 copies of the qualitative monitoring report form
Your coverage under this general permit is not transferable except after notice to DWQ. The Division may require
modification or revocation and reissuance of the Certificate of Coverage_ This permit does not affect the legal
requirements to obtain other permits which may be required by the Department of Environment and Natural
Resources, or relieve the permittee from responsibility for compliance with any other applicable federal, state, or
local law, rule, standard, ordinance, order, judgment, or decree.
If you have any questions regarding this permit package please contact of the Central Office Stormwater Permitting
Unit at [phone], ext. .
Sincerely,
for Alan W. Klimek, P.E.
cc: Central Files
Stormwater Permittinj Unit
Winston-Salem Regional Office
Surface Water Protection Section
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
512 N. Salisbury St,, Raleigh, North Carolina 27604
Phone: [phone] FAX [phone] / Internet: http:llh2o,enr.state,nc.us/su/storrnwater.html
An Equal Opportunity/Affirmative Action Employer — 50% Recycled/10% Post Consumer Paper
NorthCarolina
Naturally

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG170000
CERTIFICATE OF COVERAGE No. NCG170353
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission,
and the Federal Water Pollution Control Act, as amended,
Parkdale America
is hereby authorized to discharge stormwater from a facility located at
Parkdale Mills Incorporated -Plant 6
400 Carmalt St
Thomasville
Davidson County
to receiving waters designated as a UT of Hunts Fork, a class C stream, in the Yadkin - Pee Dee River
Basin in accordance with the effluent limitations, monitoring requirements, and other conditions set forth
in Parts I, I1, I II, I V, V, and VI of General Permit No. NCG 170000 as attached.
This Certificate of Coverage shall become effective August 1, 2004.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day August 1, 2004.
for Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management
Commission

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
RANDALL FERGUSON
PARKDALE INC-PLANT 6 & 7
P.O. DRAWER 1787
GASTONIA, NC 28053
Dear Permittee:
1�•
�� _.
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
July 28, 1999
Subject: Reissue - NPDES Stormwater Permit
Parkdale Inc -Plant 6 & 7
COC Number NCG 170353
Davidson County
In response to your renewal application for continued coverage under general permit NCG170000, the Division of
Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This permit is reissued
pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement
between the state of North Carolina and the U.S. Environmental Protection Agency, dated December 6, 1983,
The following information is included with your permit package:
* A copy of general Stormwater permit NCG170000
* A Stormwater Pollution Prevention Plan (SPPP) Certification Form. Completion of this form is required to
certify that you have developed and implemented the SPPP as per the conditions of the permit. This form
must be completed and returned to the Division within 30 days of receipt of this letter.
DO NOT SEND the SPPP with the signed form.
* Five copies of the Analytical Monitoring form and five copies of the Qualitative Monitoring form
* A copy of a Technical Bulletin for the general permit which outlines changes in the permit, key requirements,
and addresses frequently asked questions
* A Certificate of Coverage
Your coverage under this general permit is not transferable except after notice to DWQ. The Division may require
modification or revocation and reissuance of the Certificate of Coverage. This permit does not affect the legal
requirements to obtain other permits which may be required by DENR or relieve the permittee from responsibility
for compliance with any other applicable federal, state, or local law, rule, standard, ordinance, order, judgment, or
decree.
If you have any questions regarding this permit package please contact Bill Mills of the Central Office Stormwater
and General Permits Unit at [phone], ext. 548
Sincerely,
for Kerr T. Stevens
cc: Central Files
Stormwater and General permits Unit Files
Winston-Salem Regional Office
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG170000
CERTIFICATE OF COVERAGE No. NCG170353
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1. other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
PARKDALE INC-PLANT 6 & 7
is hereby authorized to discharge stormwater from a facility located at
PARKDALE INC-PLANT 6 & 7
400 CARMALT STREET
THOMASVILLE
DAVIDSON COUNTY
to receiving waters designated as a UT of Hunts Fort: in the Yadkin - Pee Dee River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts 1, 11. 111.
IV, V. and V1 of General Permit No. NCG170000 as attached.
This certificate of coverage shall become effective August 1, 1999.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day July 28, 1999.
/Se,nt
for Kerr T. Stevens, Director
Division of Water Quality
By Authority of the Environmental Management Commission

Sate of North Carolina
Department of Environment,
Health and Natural Resources
Division of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
June 7, 1996
Randall Ferguson
Parkdale Inc-Plt 6 & 7
P.O. Drawer 1787
Gastonia, NC 28053
I ffl1.V*WA
C)EHNR
Subject: General Permit No. NCG170000
Parkdale Inc-Plt 6 & 7
COC NCG 170353
Davidson County
Dear Randall Ferguson:
In accordance with your application for discharge permit received on March 29, 1996, we are
forwarding herewith the subject certificate of coverage to discharge under the subject state - NPDES general
permit. This permit is issued pursuant to the requirements of North Carolina General Statute 143-215 .1 and
the Memorandum of Agreement between North Carolina and the US Environmental Protection agency dated
December 6, 1983.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to request an individual permit by submitting an individual permit
application. Unless such demand is made, this certificate of coverage shall be final and binding.
Please take notice that this certificate of coverage is not transferable except after notice to the Division
of Environmental Management. The Division of Environmental Management may require modification or
revocation and reissuance of the certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be required by the
Division of Environmental Management or permits required by the Division of Land Resources, Coastal
Area Management Act or any other Federal or Local governmental permit that may be required.
If you have any question concerning this permit, please contact MR. BILL MILLS at telephone number
919/733-5083.
Sincerely, ORGINIA1_ SIGNED BY
EIPADLI f 31_N1iylr <T
A. Preston Howard, Jr. P.E.
cc: Winston-Salem Regional Office
EPA
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

-T
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL RESOURCES
DIVISION OF ENVIRONMENTAL MANAGEMENT
GENERAL PERMIT NO. NCG170000
CERTIFICATE OF COVERAGE NO. NCG170353
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
Parkdale Mills, Inc.
is hereby authorized to discharge stormwater from a facility located at
Parkdale
Plants #6 and #7
400 Carmalt Street
Thomasville
Davidson County
to receiving waters designated as an unnamed tributary to Hunts Fork in the Yadkin - Pee Dee River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts 1, 1I, III
and IV of General Permit No. NCG 170000 as attached.
This Certificate of Coverage shall become effective June 7, 1996.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day June 7, 1996.
SlGNED 13Y
� .EY SENNtT
A. Preston Howard, Jr., P.E., Director
Division of Environmental Management
By Authority of the Environmental Management Commission

LS _ j 'c •+, - .Bc,/ ��1' ;,S �� i. +.J•-�'' fl iv 97.
J : r� •." >�,% ,1 ' a U - �: % y _ ,-k, , n\,fin
Ir a L.v OO CI�, .i Ate_'• i/' 1 - I i• � +f �'. ���,� '-�I� � y _ _; f�• � !/ ! ,i U 71.-,5
I lR-' ,f• WWW Y �- =^'.}i V _ .I r';%•��' r! / J �• •�' "' ' t_ d' _-;l
..r .�• -3. ` L, rr � �� % •I ,'p� Jam` ,�_�_� ,:.t- ' t jj
r 'Tel
' �,��7�I{, �. -,_ 1 ;"1. �' - ! _ ') Ir�. •�', J`. f_ "'- "`E� � !r i ,F hy..—.� •�� .li; !` 7)
. � l�-y `�� /�. �i i� -- •7 _ _ - � ' . �'l. " r' : _ _ •'JM _ • p�lesaanr C+'V�* �
lip
40
it
1 !•itVIP
==`F z�hf��= - :� moo• rl�F -:
ine .-Ctr1:�/IrT'� `"[r�'1i� S'HelghtsIlk
NY
'. i• /~ .,'-•.''\- ` ail -'�w '
���'1t,1 - S _ ]:- �• _ �=_ ' `[S.:' * `` � I.- •� - �o • ,-�. Imo` � �Brr1 •�s
l 1; ,�Ce .'=tRa ia•To ers, `1o."C�1 . u _ -, ` _ .. egg - ; ���.1, •� /� . 4•.�.
Vr-
1 • �` ;.. "` .1 . �"=: • �� '%•47
'� i'c7. >I �v�r�. 75 _'.. I!\__�'1Pdrk �'Ci l�,�/.`\ili I�l �� I_ s� 5��.= �. 'H'' r��A� '•-�` ��/�'
{° `-il_ - -'�' r•y '� i L�', t f7M �.i..
sm
• •/1 �1�, _ C [i $t J �_.. - ' ern
w • , � 'l erg: r �f ? JJ � ^. rr• _��f /�` '.;� '''�_ . . `l� - 'r � "�::I• „i�!y�l : �J �„ ,. �i
`.bCem,.' a •._t -�/ IIIII! :[�v� �•�'f' - ` G
J t]] � .. iilf L _ r' �',,. <•� ss •�tit.FG � �S -' �'� �• ,l3rL'" � :'t.
%•'►
wry .r,.. �:* s�o-�`� Doti
• M s,� i' . owts t o I u : / M { 1! I a` _ �� 14t N
i+;{�.�
� f �I�l i t
I �'{ v 1 LJr` ;�.• ' '''' r:' �. U t�-: is •.I� I , {{
AV u _ •1, <�,ti'=_, a 4 , _�.
c.`--_° Doak :^ �•' c s-, _ J; r� 1 I a -.
' `_ dye -
ry
esp;•� of
,�r. •' loni� GPR �'r1 L��j �lribertY'i�r II. � • � 1 .(�
:��•,. �•' C r � \11^ •�' � �� ' 1 �I ;� �r 5014• �� 'J���'T�:—�•�'Cj_ ~ `'a'•�'.l �•
�'- .> • .' J .F- _ :�`�� ��� r'- Y/ Y•.�_ >�'.`i Y-; ��' �iIF',�M�I �• Jyi , s _ _ 1 0
* IL
.R .Yt-�: A�/,hH79••{.•y� •:7:-� ' :� .� IlY 2 /�
�. %� S� 1`' �. - ti N r �p r `4 1!�.f�: �i"'�•~--lj:r•` :r• •il- o � i r,
A7o�,•, [ . ~ � `,� t � -- ' : I .� �.^. 4i��31i . i ' !li i .1-. �.4 Jj I, „ ... - f _
581 562 5' 583 1 FAIR Ga0y= 1.5 nrl. 584 - (FAIR GROVE) ' 585 $86
495. 1 SE
SCALE 1:24000
1 � o
eY
MN 1D00 0 1000 2000 3000 4000 sxCI 6000 7000 FEET
phs GN
1 5 0 1 KILOMETER
1076MILS L CONTOUR INTERVAL 10 FEET
10 MILS NATIONAL GEODETIC VERTICAL DATUM OF 1929
UTM GRID AND 1987 MAGNETIC NORTH
OECONATION AT CENTER OF SHEET THIS MAP COMPLIES WITH NATIONAL MAP ACCURACY STANDARDS
FOR SALE BY U. S. GEOLOGICAL SURVEY
DENVER, COLORADO 80225. OR RESTON, VIRGINIA 22092

FACILITY
COUNTY Z) Ao id so-n
NPDES N G C1 t r7' 0 353
MAP # -big N E
DSN FLOW � I A
SUB BASIN
LATTITU D E
o3-ol- 07
35�5�z�3a
LONGITUDE 0 S ` (`d' "
RECEWING STREAM L --T- +a ; Ltivt� Far k.
S T RE►Wl CLASS
DISCHARGE CLASS :54-orm
EXPIRATION DATE ( 0-7/31/9,7