NCG170225_COMPLETE FILE - HISTORICAL_20070403

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
/V p q,,6
DOC TYPE
❑ HISTORICAL FILE
❑ MONITORING REPORTS
DOC DATE
❑ aw7 04 D 3
YYYYM M D D

WATER4
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Mark E Hawes
1620 Highland Avenue NE
Hickory, NC 28601
Dear Mr Hawes:
SURFACE WATER PROTECTION
April 3, 2007
Alan W. Klimek, P.E. Director
Division of Water Quality
Asheville Regional.Office
F,,
R
SUBJECT: March 21, 2007
Compliance Evaluation Inspection
Shuford Yarns LLC
Shuford Yarns Inc - Dudley Shoals
Permit No: NCG170225
Caldwell County
Enclosed please find a copy of the Compliance Evaluation Inspection form from
the inspection conducted on March 21 2007. The facility was found to be in compliance
with permit NCG170225.
Please refer to the enclosed inspection report for additional observations and
comments. If you or your staff have any questions, please call me at [phone].
Sincerely, S
&
Starr Silvis
Environmental Engineer
Enclosure
cc: Danny Smith—NPS-ACO
Central Files
Asheville Files
2090 U.S. Highway 70, Swannanoa, NC 28778 Telephone: [phone] Fax: [phone] Customer Service 1 877 623-6748
%onhCaro tin a
Natura!!J

Permit: NCG170225
SOC:
County: Caldw0
Region: Asheville
Compliance Inspection Report
Effective: 08/01/04 Expiration: 07/31/09
Effective: Expiration:
Contact Person: Mark E Hawes
Directions to Facility:
Primary ORC:
Secondary ORC(s):
On -Site Representative(s):
24 hour contact name
Related Permits:
Inspection Date: 03/21/2007
Primary Inspector: Starr Silvis
Secondary Inspector(s):
Mark E Hawes
Entry Time: 11:00 AM
Certification
Owner: Shuford Yarns LLC
Facility: Shuford Yarns Inc - Dudley Shoals
Rt 1
Granite Falls NC 28630
Phone: [phone]
Exit Time: 11:45 AM
Phone:
Phone: [phone]
Phone: [phone]
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Textile Mill Products Stormwater Discharge COC
Facility Status: ® Compliant ❑ Not Compliant
Question Areas:
® Storm Water
(See attachment summary)
Page: 1

Permit: NCG170225 Owner - Facility: Shuford Yarns LLC
Inspection Date: 03/21/2007 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Inspection Summary:
The facility has 5 outfalls. All required monitoring is being conducted and recorded as required by the permit. All outfalls
were observed during the inspection. Ron Davis, Steven Driver, Steve Shuffler, Jerry Eplin and Mark Hawes assisted
during the inspection.
Stormwater Pollution Prevention Plan Yes No NA NE
Does the site have a Stormwater Pollution Prevention Plan?
®
n
n n
# Does the Plan include a.General Location (USGS) map?
®
Cl
❑
n
# Does the Plan include a "Narrative Description of Practices'?
®
n
n
n
# Does the Plan include a detailed site map including outfall locations and drainage areas?
m
n
n
n
# Does the Plan include a list of significant spills occurring during the past 3 years?
®
❑
n
n
# Has the facility evaluated feasible alternatives to current practices?
®
❑
❑
❑
# Does the facility provide all necessary secondary containment?
S
Cl
n
n
# Does the Plan include a BMP summary?
Y
n
n
n
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
®
n
n
n
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
®
n
n
n
# Does the facility provide and document Employee Training?
®
n
n
n
# Does the Plan include a list of Responsible Party(s)?
®
n
n
n
# Is the Plan reviewed and updated annually?
®❑
n
n
# Does the Plan include a Stormwater Facility inspection Program?
o
n
❑
n
Has the Stormwater Pollution Prevention Plan been implemented?
Ie
n
n
n
Comment:
Qualitative Monitoring
..,.. ....... I—- •_-_.._................ -
Yes
No
NA
NE
Has the facility conducted its Qualitative Monitoring semi-annually?
■
n
n
n
Comment:
Permit and Outfalls
_................................1._....... _
Yes
No
NA
NE
# Is a copy of the Permit and the Certificate of Coverage available at the site?
a
n
n
n
# Were all outfalls observed during the inspection?
®
n
n
n
# 1f the facility has representative outfall status, is it properly documented by the Division?
n
n
®
❑
# Has the facility evaluated all illicit (non stormwater) discharges?
■
❑
n
n
Comment:
Page: 2

_' of 1N ATF p
�O G
r
>_
0 'C
4
August 18, 2006
Mr. Allen Barwick
Shuford Yarns, LLC
1985 Tate Blvd. SE, Box 54
Hickory, NC 28602
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
Subject: NPDES General Permit NCG170000
Certificate of Coverage NCG170225
Shuford Yarns, LLC
Formerly Shuford Mills, LLC
Caldwell County
Dear Mr. Rivers:
Division personnel have reviewed and approved your request to transfer coverage under the General Permit,
received on June 28, 2006.
Please find enclosed the revised Certificate of Coverage. The terms and conditions contained in the General
Permit remain unchanged and in full effect. This revised Certificate of Coverage is issued under the requirements of
North Carolina General Statutes 143-215.1 and the Memorandum of Agreement between North Carolina and the U.S.
Environmental Protection Agency. .
If you have any questions, please contact the Stormwater Permitting Unit at [phone], extension 502.
Sincerely, >�v
MIGINAL 431GN1 t~ r
§'CEO mc,
Alan W. Klimek P. E.
cc: DWQ Central Files
Ashebilie Regional Office, Water Quality Section. i
Stormwater Permitting Unit
f
005 l
WAECTION
No Carolina
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 Phone [phone] Customer Service
Internet: h2o.enr.statemc.us 512 N. Salisbury St. Raleigh, NC 27604 FAX [phone]
An Equal Opportunity/Affirmative Action Employer— 50% Recycled110% Post Consumer Paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG170000
CERTIFICATE OF COVERAGE No. NCG17022S
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
SHUFORD YARNS, LLC
is hereby authorized to discharge stormwater from a facility located at
SHUFORD YARNS, LLC
RT 1
GRANITE FALLS
CALDWELL COUNTY
to receiving waters designated as the Upper Little River in the Catawba River Basin in accordance with the effluent
limitations, monitoring requirements, and other conditions set forth in Parts 1, II, I11, IV, V, and VI of General Permit
No. NCG170000 as attached.
This certificate of coverage shall become effective August 18, 2006.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day August 18, 2006.
ORIGINAL SIGNED By
KEN PICK;
Alan W. Klimek, Director
Division of Water Quality
By Authority of the Environmental Management Commission

UNITED STATES
DEPARTMENT OF THE INTERIOR
GEOLOGICAL SURVEY
'30" 467000mE. I ,+fi8 j+69 20, ;+70 l 1+7t
300
it
` / ,.` I• ,
�'. 1 j 1� � / � • i } \1IF..:,r51.1: I tl !� %-��� 1 •J /,li r � \ U `�� __ - t l ` ,, `'�1 ����,,..
1740, r1 '� / ;� �/ fix; �' �,'� ! .41 �` "�i2i���✓.�-r
II /,,_ ii � %. 4/ ��•\ y �ll� 41• 11`'�,� 1� - %`�j+]r7-��\'mac '•.
200
j/r�l� J���'7�, � ��I:,J!�rN �' �J -/ .IJ�`���—a ��r�r�ti,5 •�� +�-':� —•'� ��� -
�./,l�
•� 17G 1} �1 yip ��J 4 1 / F, � )' =_r _ter =Sc, 'r �.:�e. 1'�-.i' L-d
vi
Budlea' Sh ills
1 - `.% / '! . ` �� �•; i ''�_ � �% I rV �-,L..� � � � � 1 .-"���(lC` � F . `I� \ , ,�I' �� f snx
J•; �1 /r,. Y�! /� ;f lip J� /. r!�/ ' t��J.a731 �\ �� i� t `l 1 17
..��� 1 ti' 1 .' ii, � \ � �I ` �. //^ �\(—' r 1'` � i� • f ' � / \ ��� �' �, . p ��l}.4 fill/
....
`i'`_(,r��� �`.\� /� ✓ ��� ! ��i `�;��\ 1. \• I} ; '��� r�j.5
If
If
Nil
IN
7 r-. �� �^� _ r�� ��/[...J✓I J ]7� ,� �, Sri �� � �1 �l� ;� .
�vr
!I '. "Betra'Mil1sY� �4•' ° 11 I �� . , ; �� // 11 ! r' I�� _ • "�
1L
rr
+ 1 9
c'` �t �� �) ��~ ,"II_� •G� � \H ll r� _' ��G,,- •,'rt7�1 I '✓ �' ... L/.' ' i�� 1 -
`-�� n � n ��'�"�i t) fir;'• ��; i��•

Michael F. Easley, Governor
o�oF w A r�9Q�
Mr. Allen Barwick
Shuford Yarns, Inc.
1985 Tate Blvd. SE, Box 54
Hickory, NC 28602
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
Subject: Permit name or ownership change request
Permit NCG170218 and NCG170225
Your request for a permit name change or ownership change received on CON06, is being
returned due to:
❑ Permit Name/Ownership Change Form is missing.
❑ Permit Name/Ownership Change Form is incomplete.
❑ Permit Name/Ownership Change Form signatures missing.
G(Missing legal document of the transfer of ownership (such as a contract or a deed).
❑ Other �I eas e 34
S'don QS t7D�'Sc �P Sa
Please return the information so we can continue processing your request. If you have any
additional questions, please contact Sarah Young at [phone] extension 502. Our mailing
address is as follows: Wetlands and Stormwater Branch
1617 Mail Service
Raleigh, NC 27699-1617
D Q Stormwater Permitting Unit
Cc:
i7WQ Central Files
SPU
N� Carolina
Nahtmlly
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 Phone [phone] Customer Service
Internet: h2o.enr.state.nc.us 512 N. Salisbury St. Raleigh, NC 27604 FAX [phone].623-6748
An Equal Opportunity/Affirmative Action Employer — 50% Recycledl10% Post Consumer Paper

State of North Carolina
Department of Environment
and Natural Resources.
Division of Water Quality
Michael F. Easley, Governor
William G. Ross,.Jr., Secretary
Alan W. Klimek, P.E., Director
71
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RE50URCES
PERMIT NAME/OWNERSHIP CHANGE FORM
I. CURRENT PERMIT INFORMATION:
Permit Number: NCG170225
1, Permit holder's name: Shuford Mills, LLC — Dudley Shoals
2. Permit's signing official's name and title: David Rivers
(Person legally responsible for permit)
Director of Manufacturing
T' (Title)
3. Mailing address: PO Box 2228 City: Hickory
State: North Carolina Zip Code: 28603-2228 Phone'. (828) 322,2131
E-mail address: cpdavis(cDshufordmills .com & cdavis _shurtape.com
II. NEW OWNER/NAME INFORMATION:
1. This request for a name change is a result of:
`X__a. Change in ownership of property/company
b. Name change only
c. Other (please explain
2. New owner's name (name to be put on permit):
Shuford Yarns, LLC
3. New owner's or signing official's name and title: Allen Barwick
(Person legally responsible for permit)
President
(Title)
4. Mailing address: 1985 Tate Blvd SE Box 54 City: Hickory
State: NC Zip Code: 28602 Phone:( 828 ) 304-8365
E-mail address: abarwick shufordmills.com & abarwick shurta e.com
1617 Dail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled 110% post -consumer paper

PERMIT NAME 1 OWNERSHIP CHANGE FORM
THIS APPLICATION PACKAGE WILL NOT BE ACCEPTED BY THE DIVISION OF WATER QUALITY UNLESS
ALL OF THE APPLICABLE ITEMS LISTED BELOW ARE INCLUDED WITH THE SUBMITTAL.
REQUIRED ITEMS:
1. This completed application form
2. Legal documentation of the transfer of ownership (such as a contract, deed, articles of
incorporation)
For changes of ownership, this form must be completed and signed by both the current permit
holder and the new owner of the facility.
For name change only, the current permit holder must complete and sign the Applicant's
Certification.
Current Permittee's Certification:
I, David Rivers , attest that this application for
name/ownership change has been reviewed and is accurate and complete to the best of my
knowledge. I understand that if all required parts of this application are not completed and that
if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature: ���.-✓ Date: O 6 23 0 6
Applicant's Certification:
I, Allen Barwick , attest that this application
for a name/ownership change has been reviewed and is accurate and complete to the best of
my knowledge. I understand that if all required parts of this application are not completed and
that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature: / Date: -3 1?d b t
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING
INFORMATION & MATERIALS, SHOULD BE SENT TO THE FOLLOWING ADDDRESS:
NC DENR 1 DWQ / Point Source Branch
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Version 8101

lillf[llilllll[111[111111111II11111111�1111I1[11111[1111[[111[flll[Illl�lf 111
Recorded: 06/30/20060atDoc ID: 11065577003TVo0&.00053 PM
Fee Amt; $770.00 Page 1 of 3
Excise Tax: $$750.00
Workflow# 655732
Caldwell, county. NC
WAYNE L RASH Register of Deeds
Bx 1501 PG579-581
NORTH CAROLINA GENE RAL WARRANTY DEED
THIS INSTRUMENT WAS PREPARED BY-
ELOISE D. BRADSHAW
P TRICK, HARPER & DIXON L.LT
O. Box 218, Hickory, NC 28603
REVENUE $ 750.00
NORTH CAROLINA
CATAWBA COUNTY
THIS DEED made tivs� day of Rune, 2006, by and between Shuford Mills, LLC, a North
Carolina limited liability company, Grantor and Shuford Yarns, LLC, a North Carolina limited
liability company, 1985 Tate Boulevard SE, Box 54, Hickory, NC 28601, Grantee.
The designation Grantor and Grantee as used herein shall include said parties, their heirs, successors,
and assigns, and shall include singular, plural, masculine, feminine or neuter as required by context.
WITNESSETH, that the Grantor, for a valuable consideration paid by the Grantee., the receipt of
which is hereby aclaiowledged. has and by these presents does grant, bargain, sell and convey unto
the Orantee in fee simple, all that certain lot or parcel of land situate in Caldwell County, North
Carolina and more particularly described as follows:
See Exhibit A
TO HAVE AND TO HOLD_ the aforesaid lot or parcel of land and all privileges and appurtenances
thereto belonging to the Grantee in fee simple.
And the Grantor covenants with the Grantee, that the Grantor is seized of the premises in fee simple,
has the right to convey the same in fee simple, that title is marketable and free and clear of all

.J1
encumbrances, and that the Grantor will warrant and defend the title against the lawful claims of all
persons whomsoever except for the exceptions hereinafter stated. Title to the property hereinabove
described is subject to the following exceptions:
All easements, restrictions, and rights -of -way of record.
IN WITNESS WHEREOF, the Grantor has caused this instrument to be signed in its
corporate name by its duly authorized officer the day and year first above written.
Shuford Mills, LLC
By:
C. Hunt SbdfoAd, Jr anager
North Carolina
Catawba Count),
I certify that the following persons) personally appeared before me this day, each
acknowledging to the that he or she voluntarily signed the foregoing document.for the -purpose stated
therein and in the capacity indicated: C. Huni Shuford, Ji:, Manager
Date:J-u-
ne- .3
My Commission Expires: 101 y o
.`9 "54933G„oL.,.���.
D.
,.r., C0U0.�,
7
pll"L4;
otary
51®iSe D.-radshG,w
Notary's printed or typed name

Exhibit A
Caldwell County
All that certain tract or parcel of land situated in Lovelady Township, Caldwell County, North
Carolina and more particularly described as follows:
Begiru- ing at a new Y inch rebar set in the northern margin of the right of way of Burns Road, the
southeast corner of Tract 8 as described in deed dated December 4, 1996 from Valdese Weavers, Inc.
to Shuford Mills, Inc. as recorded in Book 1179 at Page 485, Caldwell County Registry; proceeding
thence with the eastern line of Shuford Mills, Inc., the following courses and distances: North 17'
52' 07" East 2.18 feet to an existing'/2 inch rod, North 17' 52' 07" East 231.15 feet to an. existing `/
inch pipe, and North 17' 57' 53" East 412.59 feet to an existing'/ inch pipe in the line, now or
formerly, of Shuford Development, Inc. under deed recorded in Book 1175 at Page 1851, Caldwell
County Registry; thence with the line of Shuford Development, Inc., the following courses and
distances: South 84' 06' 14" East 434.94 feet to an existing % inch pipe, South 83` 04' 21" East
214.00 feet to an existing % inch rod, and South 83' 04' 21" East 29.04 feet to a point (Northing
778,257.964, Easting 1,298,153 240) in the approximate centerline of the Upper Little River, said
point being located South 85' 55' 14" West 1036.66 feet from NCGS horizontal monument
"Dudley"(NAD 83, Northing 778,257.964, Easting 1,298,153.240); thence with the approximate
centerline of the Upper Little River, the following courses and distances: South 39° 48' 07" East
154.29 feet to a point; South 36' 12' 12" West 172.24 feet to a point; South 26' 04' 01" West 127.10
feet to a point, South 08' 54' 01" West 126.12 feet to a point, South 07' 48' 22" East 116.73 feet to
apoint, and South 43' 06' 31" East 110.92 feet to a point; thence South 66° 53' 40" West 171.06 feet
to a new !/:! inch rebar in the northern margin of the right of way of Burns Road; thence with the
northern margin of the right of way of Burns Road, the following courses and distances: North 39°
58' 41" West 57.95 feet to a new'/a inch rebar, North 57' 52' 41" West 67.72 feet to a new inch
rebar, North 80` 47' 30" West 95.14 feet to a new inch rebar, South 86' 57' 42" West 33.93 feet .
to a point, South 86' 57' 42" West 41.83 feet to a new inch rebar, North 04' 32' 47" East 5.93 feet
to a new % inch rebar, North 84' 26' 14" West 34.32 feet to a point, North 82' 3T 14" West 41.16
feet to a point, North 78' 32' 34" West 86.78 feet to a MAG nail set, North 74' 01' 03" West 72.98
feet to a paint, North 71 ° 39' 51" West 64.48 feet to a point, North 70' 52' 40" West 55.17 feet to a
point, North 71 ° 15' 37" West 48.05 feet to a point.. North 72' 42' 56" West 47.73 feet to a point, and
North 74' 46' 43" West 30.69 feet to the Beginning, and containing 12.83 acres, more or less, as
shown on plat of survey entitled "A Boundary Survey for Shuford Yarns, LLC" prepared by J. Mike
Honeycutt, NCPLS and dated June 22, 2006.
Document if?85971

Michael F. Easley, Governor
7
>
August 18, 2006
Mr. Allen Barwick
Shuford Yarns, LLC
1985 Tate Blvd. SE, Box 54
Hickory, NC 28602
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
Subject: NPDES General Permit NCG170000
Certificate of Coverage NCG170225
Shuford Yarns, LLC
Formerly Shuford Mills, LLC
Caldwell County
Dear Mr. Rivers:
Division personnel have reviewed and approved your request to transfer coverage under the General Permit,
received on]une 28, 2006.
Please find enclosed the revised Certificate of Coverage. The terms and conditions contained in the General
Permit remain unchanged and in full effect. This revised Certificate of Coverage is issued under the requirements of
North Carolina General Statutes 143-215.1 and the Memorandum of Agreement between North Carolina and the U.S.
Environmental Protection Agency. .
If you have any questions, please contact the Stormwater Permitting Unit at [phone], extension 502.
Sincerely,
ORIGINAL SIGNED BY
KEN PIC-Kt_E
Alan W. Klimek P. E.
cc: DWQ Central Files
Asheville Regional Office, Water Quality Section
Stormwater Permitting Unit
. . C. - .
N Carolina
Nafturally
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 Phone [phone] Customer Service
Internet h2o.enr.state,nc.us 512 N. Salisbury St. Raleigh, NC 27604 FAX [phone]
An Equal OpportunitylAfflrmaWe Action Employer— 50°% Recycled110°% Post Consumer Paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG170000
CERTIFICATE OF COVERAGE No. NCG170225
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
SHUFORD YARNS, LLC
is hereby authorized to discharge stormwater from a facility located at
SHUFORD YARNS, LLC
RT 1
GRANITE FALLS
CALDWELL COUNTY
to receiving waters designated as the Upper Little River in the Catawba River Basin in accordance with the effluent
limitations, monitoring requirements, and other conditions set forth in Parts I, II, III, IV, V, and VI of General Permit
No. NCG170000 as attached.
This certificate of coverage shall become effective August 18, 2006.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day August 18, 2006.
ORIGINAL SIGNED By
XEN •�^FQ.'�
Alan W. Klimek, Director
Division of Water Quality
By Authority of the Environmental Management Commission

UNITED STATES
DEPARTMENT OF THE INTERIOR
GEOLOGICAL SURVEY
'30" +67000m. E. ; i +66 1+69 20' j +70
'`�{ 4 .•' "i736 ��i i' Z f;..� �' ��_—'•�-�� 5+1 ,� -, tl ��f �% �� , ! Irr/ / �` •� ) / - .
V��� ��,r � ,��: lam. ��•M1 �� �p�`�-� `�.'trr'� l � r , •.�\`:Q r a / c
110i
ji
it
_ l 1 ' O 9- � ii -'r f ,., ! � •F �11� "�� � , ' .'. is
/ .,ter, ✓ \ '��� jai /100�`1
i � :5 17i1','`r l/, /l�ll 1 ~`—' '�15�`~f�•� `'•� }5 ' �' .�,��'�� ( f �' '�' 'r,J " r�i� �Q�` •/ r / �..� � ;`r.� C �)-:
t'. a f3 `i /, � /r r 1 /� %_ \ '. . / � 1J�1 ll � � i � tl�,.-! a� ..' •- t
�/.1 R11 „11 � ' l s=§ Vic✓ / - � ..r' '✓, ,•,\� .�`,~ r
,y / • � � � J 'S 1 ,'\ \�-f���� v 11 /��; _j \ �_vl r:lj ';f
Du Viet' 5h ajs
^.•i �� �`-' •^`; � i r �K�` �C� C f ---\ `� 1 f �1 1 4, �. ,d f ��:� 1�
._-.�� � C\i'� � ��.�• �y`i r' � , l; 1J1..51J,i'3 \J%\ � `� \ u• �1,�•- •
•ter �`n ���/�\, ,� 1 ,,``'\ r, r�✓�� �'1�• �Jl� �� �` j � �-�,, V/• ��� : Q ` ,r o (� �"-,-...
`�_:.:V� / � � . ,',f �✓,' ;_ ,/%'+kJ
1 5\. cs.�--_ �h% ,: ��--,71r �'f j !� l�}`- i; ' • f� /'�1 •, y.� / -' �'` 1 C� �e� � : u l 1`- � � �
S e;
.. � r,�� ff�5 -� /f.�I ��;� �� -17d4 \i � � lr_•i I r � � ��� ' �\ �l� . .� .
if + �Pet;a'�1Is�'; �!l�r n1 { .� \'� �l/ '�I��-� r �� `•..`+
45
cc
lit •� 1. / .!'

DtO� W A 7-FRQIV .
�3
r
March 31;'2006
Shuford Mills Inc
PO Box 2228
Hickory, NC 28603-2228
Subject: General Stormwater Permit Inspections
Shuford Mills Inc - Dudley Shoals
Permit No. NCG170225
Caldwell County
Dear Sir or Madam:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
Your facility holds a general permit from the North Carolina Division of Water Quality to
discharge stormwater associated with industrial activities performed at your facility. Please be
advised that the Asheville Regional Office will be performing NPDES stormwater inspections
sometime in the near future.
If this office has not previously inspected your facility, you should be prepared to demonstrate
compliance with all terms and conditions included in the permit. Specifically, we will be
evaluating the following: your stormwater pollution prevention plan, stormwater outfall
locations, qualitative and analytical monitoring data and any other activities required by your
permit. Please note that any data reported to the State must be analyzed by a facility that has a
North Carolina laboratory certification, either as a full laboratory or as a facility certified to
perform on -site field testing. If you have any questions regarding the generation of your
facility's data, please feel free to call Gary Francies at [phone].
Copies of the general permits and accompanying documents can be accessed from the following
webpage: http://tit)ialiv.nctiv(itergzialits,.org/,sulFt)rnis_Docun?ents.hlrai#stormwaterGP.
If you have any questions, please contact me in the Asheville Regional Office at [phone].
CC' NPS Compliance & Assistance Oversight Unit
SWP-Central Files
ARO Files
Sincerely,
kx�_� p_ ..__
Roy Davis
Environmental Engineer
NorthCaroiina
,NaftirallU
North Carolina Division of Water Quality 2090 U.S. Hwy 70
Internet: httpJAunvw.ncwaterquality.orgl
An Equal Opportunity/Affirmative Action Employer
Swannanna, NC 28778 Phone [phone] Fax [phone]

e
NtDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
August 4, 2004
Mark E Hawes
Shuford Mills Inc
PO Box 2228
Hickory, NC 286032228
William G, Ross, Jr., Secretary
Alan W, Klimek, P.E., Director
Subject: NPDES Stormwater Permit Coverage Renewal
Shuford Mills Inc - Dudley Shoals
COC Number NCG 170225
Caldwell County
Dear Permittee:
In response to your renewal application for continued coverage under general permit NCG 170000 the Division of
Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This permit is reissued
pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement
between the state of North Carolina and the U.S. Environmental Protection Agency, dated December 6, 1983.
The following information is included with your permit package:
• A new Certificate of Coverage
• A copy of General Stormwater Permit NCG 170000
• A copy of a discharge monitoring report form
• 5 copies of the qualitative monitoring report form
Your coverage under this general permit is not transferable except after notice to DWQ. The Division may require
modification or revocation and reissuance of the Certificate of Coverage. This permit does not affect the legal
requirements to obtain other permits which may be required by the Department of Environment and Natural
Resources, or relieve the permittee from responsibility for compliance with any other applicable federal, state, or
local law, rule, standard, ordinance, order, judgment, or decree.
If you have any questions regarding this permit package please contact of the Central Office Stormwater Permitting
Unit at [phone], ext. .
Sincerely,
for Alan W. Klimek, P-E.
cc: Central Files
Stormwater Permitting Unit
Asheville Regional Office
Surface Water Protection Section
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
512 N. Salisbury St., Raleigh, North Carolina 27604
Phone: [phone] FAX [phone] / Intemet: http://h2o.enr.state.nc.us/su/siormwater,html
NorthCarolina
;Vaturally
An Equal OpportunitylAffirmative Action Employer — 50% Recycled110% Post Consumer Paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG170000
CERTIFICATE OF COVERAGE No. NCG170225
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission,
and the Federal Water Pollution Control Act, as amended,
Shuford Mills Inc
is hereby authorized to discharge stormwater from a facility located at
Shuford Mills Inc - Dudley Shoals
Rt 1
Granite Falls
Caldwell County
to receiving waters designated as the Upper Little River, a class C stream, in the Catawba River Basin in
accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts
I, I1, I1I, IV, V, and VI of General Permit No. NCG170000 as attached.
This Certificate of Coverage shall become effective August I, 2004.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day August 1, 2004.
for Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management
Commission

State of North Carolina
Department of Environment
and Natural Resources
Asheville Regional Office
Nlichael F. Easley, Governor
William G. Ross, Jr., Secretary
Alan W. Klimek, P.E., Director
Coleen H. Sullins, Deputy Director
Division of Water Quality
WATER QUALITY SECTION
April 7, 2004
MEMORANDUM
TO: Bradley Bennett
Stormwater & General Permits Unit
Charles Weaver
NPDES Unit
FROM: Jim Rei
ARO
SUBJECT: Contact information
Shuford Mills, Inc.
Mr. Mark Hawes (Director of Environment and Safety for Shuford Mills,
Inc.) contacted this office and advised that the company failed to make
timely application for renewal of Stormwater COCs due to DWQ's having
mailed renewal notices to nonexistent people. Mr. Hawes stated that NOIs
had been faxed this date and had also been sent by overnight service for
delivery tomorrow morning -
In order to avoid future mishaps, Mr. Hawes requested that all DWQ's
contact information be updated to reflect him as owner and contact for
Shuford Mills, Inc.'s facilities. I attempted to make the requested
changes in BIMS, but apparently do not have authorization to change the
items in BIMS.
Consequently, would you please change "affiliations" in BIMS for your
respective program areas for the following permits? Mr. Hawes
information precedes the list of permits held by Shuford Mills, Inc.
2090 U.S. llighway 70, Swannanoa, North Carolina 28778 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Bradley Bennett
Charles Weaver
April 7, 2004
Page 2
Mr. Mark Hawes, P.E.
Director of Environment and Safely
PO Box 1530
Hickory NC 28603-1530
Telephone [phone]
Fax [phone]
NCG170219
NCG170225
NCG170218
NCG170220
NCG170222
NCG170221
NCG500321
NCO035211
Your assistance with this matter is appreciated.
additional information is required.
Xc: Mark Hawes
Please contact me if
2090 U.S. Highway 70, Swannanoa, North Carolina 28778 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50%> recycled/10% post -consumer paper

'2
�f6tate of North Caroling
Department of Envirom,gent
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
July 28. 1999
TOM GUTHRIE
SHUFORD MILLS INC.-DUDLEY SHOALS PLANT
P.O. BOX 2228
HICKORY. NC 28603
Dear Permittee:
4 •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Reissue - NPDES Stormwater Permit
Shuford Mills Inc. -Dudley Shoals Plant
COC Number NCG170225
Caldwell County
L. iesponse to your renewal application for continued coverage under general permit NCG170000, the Division of
Water Quality (DWQ) is forwarding herewith the reissued Stormwater general permit. This permit is reissued
pursuant to the requirements of North Carolina General Statute 143-215A and the Memorandum of Agreement
between the state of North Carolina and the U.S. Environmental Protection Agency, dated December 6, 1983.
The following information is included with your pennit package:
* A copy of general stormwater permit NCG170000
A Stormwater Pollution Prevention Plan (SPPP) Certification Form. Completion of this form is required to
certify that you have developed and implemented the SPPP as per the conditions of the permit. This form
must be completed and returned to the Division within 30 days of receipt of this letter.
DO NOT SEND the SPPP with the signed form.
* Five copies of the Analytical Monitoring form and five copies of the Qualitative Monitoring form
* A cop), of a Technical Bulletin for the general permit which outlines changes in the permit, key requirements.
and addresses frequently asked questions
A Certificate of Coverage
Your coverage under this general permit is not transferable except after notice to DWQ. The Division may require
modification or revocation and reissuance of the Certificate of Coverage. This permit does not affect the legal
requirements to obtain other permits which may be required by DENR or relieve the permittee from responsibility
for compliance with any other applicable federal, state, or local law, rule, standard, ordinance, order, judgment, or
decree.
If you have any questions regarding this permit package please contact Bill Mills of the Central Office Stormwater
and General Permits Unit at [phone], ext. 548
Sincerely,
for Kerr T. Stevens
cc: Central Files
Stormwater and General permits Unit Files
Asheville Regional Office
r
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

"ATE OF NORTH CAROLINA
DEPARTMENT L_ ENVIRONMENT AND NATURAL t,—SOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG170000
CERTIFICATE OF COVERAGE No. NCG170225
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of.North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
SHUFORD MILLS INC.-DUDLEY SHOALS PLANT
is hereby authorized to discharge stormwater from a facility located at
SHUFORD MILLS INC.-DUDLEY SHOALS PLANT
RT 1
GRANITE FALLS
CALDWELL COUNTY
to receiving waters designated as the Upper Little River in the Catawba River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts 1, 1I, III,
IV, V, and VI of General Permit No. NCG170000 as attached.
This certificate of coverage shall become effective August 1, 1999.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day July 28. 1999.
for Kerr T. Stevens, Director
Division of Water Quality
By Authority of the Environmental Management Commission

~State .of North Carolina
D�Wartment of Environment,
Health and Natural Resources
Division of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
June 9, 1995
W H Little Jr
Shuford Mills Inc.
P.O. Box 2228
Hickory, NC 28603
Subject: General Permit No. NCG170000
Shuford Mills Inc.
COC NCG 170225
Caldwell County
Dear W H Little Jr :
-In accordance with your_apphcation for discharge permit received on March 9, 1995, we are forwarding
herewith the subject -certificate of coverage to discharge under the subject state - NPDES general permit -This -
permit is issued pursuant to the requirements of North Carolina General Statute 143-215 .1 and the
Memorandum of Agreement between North Carolina and the US Environmental Protection agency dated
December 6, 1983.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to request an individual permit by submitting an individual permit
application. Unless such demand is made, this certificate of coverage shall be final and binding.
Please take notice that this certificate of coverage is not transferable except after notice to the Division
of Environmental Management. The Division of Environmental Management may require modification or
revocation and reissuance of the certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be required by the
Division of Environmental Management or permits required by the Division of Land Resources, Coastal
Area Management Act or any other Federal or Local governmental permit that may be required.
If you have any question concerning this permit, please contact MR. BILL MILLS at telephone number
919/733-5083.
Sincerely, Original Signed By
Coieen H. ua
A. Preston Howard, Jr. P.E.
cc: Asheville Regional Office
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL RESOURCES
. DIVISION OF ENVIRONMENTAL MANAGEMENT
GENERAL PERMIT NO. NC_G170000
CERTIFICATE OF COVERAGE NO. NCG170225
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
Shuford Mills, Inc.
is hereby authorized to discharge stormwater from a facility located at
Dudley Shoals Plant
Rt. 1
Granite Falls
Caldwell County
to receiving waters designated as Upper Little River in the Catawba River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, III
and IV of General Permit No. NCG170000 as attached.
This Certificate of Coverage shall become effective June 9, 1995.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day June 9, 1995.
Origlna!s=;�'' i'�
Coleen R Mta,111...
A. Preston Howard, Jr., P.E., Director
Division of Environmental Management
By Authority of the Environmental Management Commission

UNITED STATES
DEPARTMENT OF THE INTERIOR
GEOLOGICAL SURVEY
° 22' 30" �67000m,�. 1 1 i 468 1469 20' 1 470 { 1171
�0 l 1 \ r� f/�'1 V ��~/� �,�—✓...r� J,\tt,1�l`\ v���, —�— V� { `� �,� iJi (,n \L
,� �.' / � `1'f�: i � � ��' f/ -f •_� � r;'r-i- ���' . 1u 1�yy �f' �� � � r r1� yO �� �" ' f, r`
,1fQ'r � (jljf1!/J•(/�� / /.� 1 '� jIIII s''� ill II-• f��Jf 1I � f�i'�, 1' _ '. ��^ ,,...`,\1`�^� �' , , �1�1G•_. 1' C''
_ r / ;-\�! j?jl` �O ;" ;� J-II; , / � %�!-'./i.� `'r' � l�j, 1 •1�• �1` 7� ,� �`-�L7 � : 1. I; �= s � J -�i is
�.�!:1�� �,t z.L�'\ �jc%= Q
A���i/
(�, �' 111 � � (�-=a�•.i�� tJ�ir� `o - �r � tl li�s-r�`;c�-�J•/� i, +•�\�r; ter_
� \ � . - I /1 L, � ( � . ✓� _ Ili•' r
_!ti�:'Du'dle}• Sh als J Jp; �- �- � � �� �- -� ,r �� � 'J fi �J }/� _
cz-
7 /
FIA
1968
- - 'ti^-�� ,✓, /ram_,--J � /f/ � � � I � r ��f v l � 1 } l (,� 1\.:� � �• -usl
•.\, --',,� t�� / '/ � �f r i,) f y 1 IsaacCree Ch ,
--- 13)66
%
M.
.' ' OSS f i � �/ ��i7t � �-•_J � i.� ��^� � \. 1 Imo` �' ` � � 1
L
I 1 - % - _
1 4 i -'11n •—.— '`'t _ ���J I ',iLc
1 , f �� j��-i
ul

FACILITY 5 k t& lM-X�AL
COUNTY
NPDES
DSN FLOW 1i//-
SUB BASIN D3-og" 31
LAITTITUDE 360
L0NuITUDE
RECLI'VING STREAM tKPffr
STR�; F-..,l CLASS G
011SCi !ARGE CLASS "rywo Aip-,L
EXPIRATION DATE D 7F 31-91

FACILITY /)y / L � .5 'UvCI 4" r__�cIhc c, k
COUNTY CLASS _
MAILING ADDRESS �� t .% = t
RESPONSIBLE
OFFICIAL._ ,
.j
TELEPHONE NO.
WHERE LOCATED
�r
NPDES PERMIT NUMBER NC Doi j S24
STATE FEDERAL
DATE ISSUED
EXPIRATION DATE
STREAM: NAME
CLASS
7410
SUB -BASIN
Shurtapeo
Mark Hawes, P.E.
DIRECTOR OF ENVIRONMENT AND SAFETY
SHURTAPE TECHNOLOGIES, INC.
P.O. Box 1530
HICKORY. NC 28603-1530 USA
Tel, 828.325.5428
Fa- 828.325.5387
[e-mail]] Mal
CERT. NUMBER
CECIL L. CLINE
DIRECTOR OF MAINTENANCE
SHUFORD MILLS, INC.
P.O. BOX 2228 CELLULAR: 828.381.1637
HICKORY, NC 28603 PAGER: 828.314.%476
OFFICE: [phone] EXT, 2316 FAX: B28.328.8603
Shuford Mills, Inc.
%
RON DAVIS
PROCESS ENG NEER
SHUFORD WILLS, INC. PHONE: [phone]
P.O. BOX 2228 EXT. 3245
HICKORY, NC 28603-2228 FAX: [phone]