NCG140309_COMPLETE FILE - HISTORICAL_20150422

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
//
DOC TYPE
1�- HISTORICAL FILE
❑ MONITORING REPORTS
DOC DATE
❑ �(�� ,�j C�¢ 22-
YYYYM M DD

PIMA
i�l
NCDENR
North.Carolina Department of Environment and Natural Resources
Pat McCrory
Governor
April 22, 2015
Southern Concrete Materials,' Inc.
ATTN: Mr. Jeff Lamm
80 Pond Road
Asheville, North Carolina 28806
Southern Concrete Materials, Inc.
ATTN: Mr. Jeff Lamm
PO Box 5395
Asheville, North Carolina 28813
Donald R, van der Vaart
Secretary
SUBJECT: NPDES Stormwater Permit Compliance Inspection
Southern Concrete Materials, Inc. -- 80 Pond Road
General Permit No: NCG140000; COC No: NCG140309
Buncombe County
Dear Mr.' Lamm:
In -,response to a complaint about stormwater runoff from your facility, and an inspection
of noncompliance on March 2, 2015, NCDENR-Land Quality Section staff conducted a
follow-up si#e inspection on April 8, 2015. The primary goal of this inspection was to
evaluate compliance with the conditions of the NCG140000 General Permit, and to
discuss any actions that have been or could -be taken to assure compliance with your
permit NCG140309.
At the time of this inspection the facility was found to be in compliance with your permit.
Please refer to the enclosed Compliance Inspection Report for additional comments,
observations, and recommendations made during the inspection. There are some
matters that require your attention to keep the site in compliance.
1. You were provided an Authorization to Construct a wastewater collection system
and we encourage you to proceed with these plans. You indicated that a closed -
loop recycle system is planned for this facility in the near future. Note that to be
defined as a truly closed -loop system with no monitoring requirements; the
system will have to meet the requirements of 15A NCAC 02T .1003 "Permitting
by Regulation." This requires that there is sufficient storage capacity to contain
the runoff from a 24-hour, 25-year storm event plus one foot freeboard; and that
the facility develops and maintains a spill control plan in the event of a
Division of Energy, Mineral, and Land Resources — Land Quality Section
Asheville Regional Office, 2090 US Highway 70, Swannanoa, North Carolina, 28778-8211
Telephone [phone] Fax [phone] ne
http://portal.ncdgnr.org/web/Inland-qualms l , opf Carolina
An Equal Opportunity / Affirmative Action Employer Vaturally

Mr. Jeff Lamm
April 22, 2015
Page 2 of 2
wastewater release. Please contact Ms. Beverly Price of the Division of Water
Resources, Asheville Region at [phone] if you have any questions or
need more. information regarding the "27' requirements for this system. Please
provide our office a schedule for installation of this system.
2. Develop a routine maintenance schedule for keeping accumulated silt off of
Pond Road and out of the drainage ditch in front of your facility.
During this follow-up compliance inspection it was determined that the settling basins
and its outflow channel had been maintained, seeded and matted; a secondary berm
had been provided near the road to direct stormwater flows to the settling basins; and
monthly sampling of the stormwater and wastewater outfall has been initiated.
Please retain and append this letter to your Stormwater Pollution Prevention Plan
(SPPP) or permit. If you have any questions or comments concerning this letter, please
contact Darlene Kucken or me at (828) 2964500.
Sincerely,
/,-,. 4.
Laura Herbert, PE
Regional Engineer
Enclosure (April 8, 2015 Inspection Report)
ec: Bethany Georgoulias, RCO
Landon Davidson, ARO - DWR
Carl Solesbee ([e-mail] )

Permit: NCG140309
SOC:
County: Buncombe
Region: Asheville
Contact Person: Jeff Lamm
Directions to Facility:
System Classifications:
Primary ORC:
Secondary ORC(s):
On -Site Representative(s):
Related Permits:
Compliance Insuectlon Report
Effective: 07/01/11 Expiration: 06/30/16. Owner: Southern Concrete Materials Inc
Effective: Expiration: Facility: Southern Concrete Materials -Asheville
80 Pond Rd
Asheville NC 28808
Title: Phone: [phone]
.Certification:
Phone:
Inspection Date; 04/08/2015 Entry Time: 10:OQAM • Exit Tlme: 12:10PM
Primary Inspector: Darlene J Kucken Phone:
Secondary Inspector(a):
Reason for Inspection: Follow-up Inspection Type: Compliance Evaluation
Permit Inspection Type: Ready Mix Concrete Stormwater/Wastewater Discharge COC
Facility Status: Compliant ❑ Not Compliant
Question Areas:
Storm Water
(See attachment summary)
Page: 1

permit: NCG140309 Owner - Facility: Southern Concrete Matarlats Inc
Inspection Data: 0410W015 Inspection Type : Compliance Evaluation Reason for Melt: Follow-up
Inspection Summary:
This inspection was conducted as a follow-up inspection to the March 2, 2015 stormwater permit compliance Inspection.
The site was found to be in noncompliance during that inspection primarily due to the lack of maintenance of the settling
basins, the need for additional bean protection near the front of the site to direct stormwater flow to the settling basins, and
failure to provide quarterly monitoring of the wastewater discharge componenet of the site. During this follow-up inspection,
it was noted that these Issues were addressed.
The facil€ty was asked to provide a maintenance plan for keeping silt off of Pond Road by scraping current deposition from
the road and ditch, and then providing regular maintenance with a vacuum sweeper. It was noted that both SCM and other
entities contribute to the deposited silt along Pond Road and that when the road is repaired by DOT the ditchline needs to
be reworked to provide for better positive flow and drainage.
Page: 2

permit: NCG140309 Owner- Facility, Southem Concrete Materials Inc
Inspection Date: 04/0812015 Inspection Type : Compiiance Evaluation Reason for Visit: Follow-up
Stormwater Pollution PreventlonPlan
Does the site have a Stormwater Pollution Prevention Plan?
# Does the Plan include a General Location (USGS) map?
# Does the Plan Include a "Narrative Description of Practices"?
# Does the Plan Indude a detailed site map including outfall locations and drainage areas?
# Does the Plan Include a list of significant spills occurring during the past 3 years?
# Has the facility evaluated feasible alternatives to current practices?
# Does the facility provide all necessary secondary containment?
# Does the Plan Include a BMP summary?
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
# Does the Plan Include a Preventative Maintenance and Good Housekeeping Plan?
# Does the facility provide and document Employee Training?
# Does the Plan include a list of Responsible Party(s)?
# Is the Pion reviewed and updated annually?
# Does the Plan Include a Stormwater Facility Inspection Program?
Has the Stormwater Pollution Prevention Plan been implemented?
Comment: Settling basins were cleaned out and seeding and matting provided.
(Qualitative Monitoring
Has the facility conducted Its Qualitative Monitoring semi-annually?
Comment:
Analytical Monitoring
Has the facility conducted its Analytical monitoring?
Yee No NA NE
®❑ ❑ ❑
❑ ❑ ❑
❑❑M❑
❑❑❑
❑❑❑
❑ ❑ ❑
❑1❑ ❑
❑❑❑
M❑❑❑
■❑❑i1
■❑❑❑
❑❑❑
❑ ❑ ❑
ree No NA NE
■ ❑❑❑
Yes No NA NE
❑ ❑ ❑
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas? ❑ ❑ ELJ
Comment: The first of monthly analytical monitoring was provided for the wastewater component of the
facility, Monthly monitodna is required for six months and then monitodng will bg guarterltilf_
parameters are not exceeded.
Permlt and Outfalls Yes No NA NE
# Is a copy of the Permit and the Certificate of Coverage available at the site? . ❑ ❑ ❑
# Were all outfalls observed during the inspection? N ❑ ❑ ❑
# If the facility has representative outfall status, is it property documented by the Division? ❑ ❑ E ❑
# Has the facility evaluated all illicit (non Stormwater) discharges? ❑ ❑ ❑
Comment:
Page: 3

ATA
NWENR
North Carolina Department of Environment and Natural Resources
Pat McCrory Donald R. van der Vaart
Governor Secretary
March 9, 2015
CERTIFIED MAIL — 7014 0510 0000 4466 6907
CERTIFIED MAIL -- 7014 0510 0000 4466 6891
RETURN RECEIPT REQUESTED
Southern Concrete Materials, .Inc.
ATTN: Mr. Jeff Lamm
80 Pond Road
Asheville, North Carolina 28806
Southern Concrete Materials, Inc.
ATTN: Mr. Jeff Lamm
PO Box 5395
Asheville, North Carolina 28813
SUBJECT: NPDES Stormwater Permit compliance Inspection
Southern Concrete Materials, Inc. — 80 Pond Road
General Permit No: NCG140000; COC No: NCG140309
Buncombe County.
Dear Mr. Lamm:
In response to a complaint about sormwater runoff from your facility, NCDENR-Land
Quality Section staff conducted a site Inspection on March 2, 2015., The primary goal of
this inspection was to evaluate compliance with the conditions of the NCG140000
General Permit, and to discuss any actions that have been or could be taken to assure
compliance with your permit NCG140309.
At the time of this inspection the facility was found to be in non-compliance with your
permit. There are several issues that need to be addressed. Please refer to the
enclosed Compliance Inspection Report for additional comments, observations, and
recommendations made during the inspection. In addition, there are some matters that
require your immediate attention to bring the site into compliance.
1. You must immediately clean out and maintain your stormwatertwastewater
settling basins to make them fully functional, as well as providing maintenance of
the ditched channel outlet from these basins. Current lack of maintenance has
contributed to stream bank erosion due to excessive outflows from these basins.
Division of Energy, Mineral, and Land Resources — Land Quality Section
Asheville Regional Office, 2090 US Highway 70, Swannanoe, North Carolina, 28778-8211
Telephone [phone] Fax [phone] rie
h :! Rortal.nedenr,omtwet>nriland-Qualltv W Ca o �' a
An Equal Opportunity 1 Affirmative Action Employer Q�iQIl�

Mr. Jeff Lamm
March 9, 2015
Page 2 of 2
2. There is an area at the front comer of the property near the road that you are
directed to provide a berm or some other means of redirecting stormwater flows
to the settling basins. Currently this area is flowing to the outer berm and is
contributing to stream bank erosion.
3. You were provided an Authorization to Construct a wastewater collection system
and we encourage you to proceed with these plans. You indicated that a closed -
loop recycle system is planned for this facility in the' near future. Note that to be
defined as a truly closed -loop system with no monitoring requirements, the
system will have to meet the requirements of 15A NCAC 02T .1003 "Permitting
by Regulation." This requires that there is sufficient storage capacity to contain
the runoff from a 24-hour,. 25-year storm event plus one foot freeboard; and that
the facility develops and maintains a spill control plan in the event of a
wastewater release. Please_ contact Ms. Beverly Price of the Division of Water
Resources, Asheville Region at [phone] if you have any questions or
need more information regarding the "2T" requirements for this system. Please
provide our office a schedule for installation of this system.
4. Given that you currently have co -mingled wastewater and stormwater, you are
required to conduct quarterly wastewater monitoring of the outfall(s) of these
materials per your permit. Since your analytical sampling has not been
conducted at this frequency, your permit triggers you to now conduct monthly
sampling for a period of at least six months and report these results to this office
pursuant to Part IV, Section D of Permit No. NCG140000.
A follow-up compliance inspection will be conducted in approximately 30 days to assure
the settling basins and its outflow channel have been maintained; a secondary berm
has been provided near the road; and monthly sampling of the stormwater and
wastewater outfall has been initiated.
Please retain and append this letter to your Stormwater Pollution Prevention Plan
(SPPP) or permit. if you have any questions or comments concerning this letter, please
contact Darlene Kucken or me at [phone].
Sincerely,
eatra
4fa
llft�
Herbert, PE
Regional Engineer
Enclosure (March 2, 2015 Inspection Report)
ea Bethany Georgoulias, RCO
Landon Davidson, ARO - DWR
Carl Solesbee ([e-mail] )

Permit: NCG140309
SOC:
County: Buncombe
Region: Ashevtlie
Contact Person: Jeff Lamm
Directions to Facility:
System Clessi lcationa:
Primary ORC:
Secondary ORC(s):
On -Site Representative(s):
Related Permits:
Compliance Inspection Report
Effective: 07/01/11 Explratlon: 05/30/16 Owner : Southern Concrete Materials Inc
Effective: Explmtlon: Facility: Southern Concrete Materials -Asheville
80 Pond Rd
Inspection Date: 03102/2015
Primary Inspector. Darlene J Kucken
Secondary tnapector(s):
Asheville NC 2UN
title: Phone: [phone]
Certification: Phone:
EntryTime: 10:00AM Exit Time: 11:30AM
Phone:
Laura C Herber Phone:
Reason for Inspection: Routine Inepection Type: Compllance Evaluation
Permit Inspection Type: Ready Mix Concrete StommaterNVastewater Discharge COC
Facility Status: Compliant Not Compliant
Question Areas:
Storm Water
(See attachment summary)
Page: 1

Permit NC014030n Owner - Feclftty: Strutllern Conaete Materiels lnc
lnspeadon Dets: 0310 OIS Inspedlon Type: Compliance Evaluation Reason for Malt: Routine
Inspection Summary:
1. The SWPPP is reasonably good, however more consistent updates and organization might be helpful.
2. The settling basins are clearly In need of malntenance and repairs. Because they no longer function at full holding
capacity, overflows are more frequent than they need to be and overflows are contributing to streambank erosion.
3. The area currently storing some sandy materials near the front of the property needs to have a berm or some other
measure installed to force stormwater flows from this area to the settling basins. Currently, flows from this area are
contributing to the streambank erosion because they bypass the settling basin.
4. An Authority to Construct a wastewater collection system was provided in July 2009. This system has not been built.
Therefore, the facility currently has co -mingled stormwater and wastewater going to the earthen pits and detention basins.
The co -mingled flows of truck wash water plus rainfall are regutated under the wastewater portion of the permit (see Part IV,
Section D). Therefore, quarterly monitoring is required. Quarterly monitoring has not been conducted. Under Part IV,
Section D, page 10, the lack of quarterly monitoring triggers monthly monitoring for a period of six months.
5. pH buffers were expired; pH buffers need to be kept current
7. There is no vehicle maintenance on site; however there is one 10,000 gallon doub"alled diesel tank on site. We
recommend providing a spill kit at the diesel tank in case of any leaks or spills.
Page: 2

perMit N00140309 owner • Facility:5outhem Concrete Materiele Inc
Inspection Data: 031=015 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Storrnwater PgIlUtlon Prevention Plan
Does the site have a Stormwster Pollution Prevention Plan?
# Does the Plan include a General Location (USGS) map?
# Does the Plan indUde a 'Narrative Description of Practices?
# Does the Plan Include a detailed site map including outfall locations and drainage areas?
# Does the Plan include a list of significant spills occurring during the past 3 years?
# Has the facility evaluated feasible altematives to current practices?
# Does the faciiity, provide all necessary secondary containment?
# Does the Plan Include a 8MP summary?
# Does the Plan Include a Spill Prevention and Response Plan (SPRP)?
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
# Does the facility provide end document Employee Training?
# Does the Plan include a list of Responsible Party(s)?
# Is the Plan reviewed and updated annually?
# Does the Plan include a Slormwatar Facility Inspection Program?
Has the Stormwater Pollution Prevention Plan been Implemented?
7�s NA N E
0❑❑❑
B ❑ ❑ ❑
®❑ ❑ ❑
* ❑ 1111
❑ ❑ 0 ❑
®❑Ell]
®❑❑❑
®❑ ❑ ❑
M ❑ ❑ ❑
®❑❑❑
®❑❑❑
®❑❑❑
®❑ ❑ ❑
❑M❑❑
Comment: Setdino basins have n t been maintained: lack of maintenance results in excessive overflows
which are eroding the streambank.
Qualitative Monitoring
Has the facility conducted its Qualitative Monitoring semi-annualty?
Yes No NA NE
®❑❑❑
Comment: Although qualitative monitgrinn has been conducted, maintenance on existing settling basins has
not been undertaken.
Anatytical Monitoring Yee No NA NE
Has the facility conducted its Analytical monitoring? ❑ ®❑ ❑
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas? ❑ ❑ 0 ❑
Comment: The facility has been conductino its analytical monitorincl Der the stormwater permit, however.
uarteriy monitoring of the wastewater component of the facility has not been undertaken.
Permit and O tfa ! Yes No Na N
# Is a copy of the Permit and the Certificate of Coverage available at the site? ® ❑ ❑ ❑
# Were all outfalls observed during the inspection? ®❑ ❑ ❑
At It the facility has representative outfall status, is it properly documented by the Division? ❑ ❑ ❑
# Has the facility evaluated all illicit (non storrawater) discharges? ❑ ❑ N ❑
Comment: There is one outfall at the facility: the basins associated with this outfall have nlatbeen
maintained.
Page; 3

North Carolina
Beverly Eaves Perdue
Governor
j ( Mr. Jeff Lamm
h Southern Concrete Materials
POB 5395
Asheville, NC 28813
At 5404<
'=�A
114
NENR
Department of Environment and Natural Resources---------'.7
Division of Water Quality
Coleen H. Sullins 'Dee -,Freeman
fr
Director Flilu
E � lYl E Secretary
July 22, 2009 2 2009
WATER QUALITY SECTION
SNEVILLE REGIONAL OFFICE
Subject: Authorization td'Coiistr6et"`���.�' __'
4Southern Concrete Materials — Pond Rd
COC No. NCG140309
Buncombe County
Dear Mr. Lamm:
By this letter DWQ is issuing an Authorization to Construct (ATC) wastewater
collection, treatment, and recycle facilities at your plant located at 80 Pond Road in
Asheville, North Carolina.
You are authorized to construct and install the facilities as described in your narrative
and calculations submitted, and as shown on the approved drawings attached to this letter;
including the specific elements:
A truck rinse and drum and chute washout pad;
Three, 20'x 56'x 6' deep settling chambers to receive truck rinse water, washout
waters, any incidental aggregate storage drainage, pit sludge drainage, and
stormwater generated from the small contributing drainage area;
1 • A pit sludge drying area;
0� • A carbon dioxide pH correction system;
• A pump and necessary piping to both return treated wastewater to the mix, and to
�9 reuse treated wastewater for truck rinse and drum and chute washout;
4 • A runoff diversion structure in front of pits #2 and #3;
• And all incidental mechanical, electrical, and structural construction and equipment
installation necessary to accomplish a wastewater collection, treatment, and recycle
system functioning as implied by the approved submittal package.
We are issuing this ATC based on your specific, stated design basis that the facilities
will not discharge wastewaters at the design storm (i.e. the 25-year, 24-hour rainfall). We
note that your current COC #NCG140309 authorizes only the discharge of stormwaters, not
wastewaters.
This ATC does not affect the legal requirements to obtain other permits which may
be required by the Division of Water Quality or permits required by the Division of Land
Resources, Coastal Area Management Act or any other federal or local governmental permit
that may be required,
Please notify DWQ's Asheville Regional Office, telephone number [phone], at
least forty-eight (48) hours in advance of operation of the installed facilities so that an in -
place inspection can be made. Such notification to the regional supervisor shall be made
Wetlands and aiormwater Branch One
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Noi.- Ci1CQlin a
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604
Phone: [phone] S FAX: [phone] Customer Service: 1-877-623-6748 /,/� u!'a�`�/
Internet: www,ncwaterquality.org v i/
An Equal Opponunity 1, Affirmative Action Employer

,Mr. Jeff Lamm
Southern Concrete Materials
NCG140309
July 22, 2009
OF' '64,
during the normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday,
excluding State Holidays.
Upon completion of construction and prior to operation of this authorized facility, a
certification must be received from the designing professional engineer certifying
that the wastewater collection, treatment, and recycle facility has been installed in
accordance with the NPDES Permit, this Authorization to Construct, and the
approved plans and specifications. Please mail the certification (attached) to the
Stormwater Permitting Unit, 1617 Mail Service Center, Raleigh, NC 27699-1617.
Please note that any future construction, installation, or modification of wastewater
treatment facilities (including process wastewater recycle systems) will require an additional
Authorization to Construct (ATC) .prior to construction per 15A NCAC 2H .0138 & .0139. You
must submit, in triplicate, plans/specifications and design calculations, stamped and sealed
by a professional engineer, with a letter requesting an ATC to the Stormwater Permitting
Unit, 1617 Mail Service Center, Raleigh, NC .27699-1617.]
Please note that we are returning your check for $100, since the permit processing
and annual administering and compliance monitoring fees are strictly associated with
coverage under the General Permit, NCG140000 which you already have. There is no
additional fee for the ATC.
One (1) set of approved plans and specifications is being forwarded to you. Please
maintain a copy of the approved plans and specifications on file for the life of the facility. if
you have any questions concerning this permit or Authorization to Construct, please contact
Ken Pickle at telephone number [phone].
Sincerely,
� PCZA,
for Coleen H. Sullins
cc: Asheville Regional Office, w/ 1 set approved submittal
DWQ Central Files, NCG140309
Stormwater Permitting Unit Files, NCG140309, w/ 1 set approved submittal
Enclosures: 1 set approved submittal
Southern Concrete Materials check #11694 for $100

Mr. Jeff Lamm
Southern Concrete Materials
NCG140309
July 22, 2009
Engineer's Certification fCOC No. NCG140309)
as a duly registered Professional Engineer in the
State of North Carolina, having been authorized to observe (periodically, weekly, full time)
the construction of the project: wastewater additions at Southern Concrete Materials, 80
Pond Road, Asheville, NC, for the permittee hereby state that, to the best of my abilities,
due care and diligence was used in the observation of the following installations:
• Construction of a process wastewater collection, treatment, and recycle system at the
Southern Concrete Materials Pond Road plant in Asheville, NC.
I certify that the construction of the above referenced project was observed to be built
within substantial compliance and intent of the approved plans and specifications.
Signature
Date
Registration No.
Mail this Certification to: Stormwater Permitting Unit
NC Division of Water Quality
1617 Mail Service Center
Raleigh, NC 27699-1617,

October 30, 2008
Mr. Ken Pickle, Environmental E
NC DENR — Stormwater Permitting
1617 Mail Service Center
Raleigh, North Carolina 27669-161
Re: Permit Application for Authorization -to -Construct (A to C) a Proposed
Process / Stormwater Recycling System for Pond Road Concrete Plant
Southern Concrete Materials
80 Pond Road
Asheville, North Carolina 28806
CPEES Project No. 1114-004
NPDES General Permit No.: NCG140000
Certificate of Coverage: NCG 140309
Dear Mr. Pickles:
Southern Concrete Materials (SCM) is pleased to submit the attached Authorization -to -Construct
(A to C) permit request report along with construction drawings for the Proposed Process /
Stormwater Recycling System for Southern Concrete Materials — Pond Road Concrete Plant
located in Asheville, North Carolina; The A to C Report includes:
4 '• NC DENR NPDES General Permit .Application­NCG140000;
• Check for $100 made payable to NC DENR;
• Site map showing the delineation of drainage area contributing to the process
wastewater;
+ Site layout map showing the proposed location of the process 1 stormwater recycling
system;
• 25 yr 24-hr stormwater runoff calculations;
• Detailed design, construction drawings along with construction specifications for the
proposed process and stormwater recycling system;
• Site Location Map;
• NC Certified laboratory supplied analytical results for stormwater samples collected at
similar plant;
• Manufacturer supplied literature for the proposed Carbon Dioxide System for pN
adjustment.

r Y .
i
SCM sincerely appreciates your cooperation and progress of this project. Please call me at 828-
253-6421 or Mr. Chuck Pakala of CPEES at 704-541-4042 if you have any questions or
comments on this permit request.
Respectfully submitted,
`;
Jeff Lamm
EH&S Manager
Attachments: A to C Permit Application Package

Mr. James Combest
Southern Concrete Materials
PO Box 5395
Asheville, NC 28813
Michael F. Easley, Governor
William G. Ross Jr„ Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
September 22, 2006
Subject: NPDES General Permit NCG140000
Certificate of Coverage NCG140309
Southern Concrete Materials
Formerly Hyder Concrete, Inc.
Buncombe County
Dear Mr. Combest:
Division personnel have reviewed and approved your request to transfer coverage under the General Permit,
received on September 6, 2006.
Please find enclosed the revised Certificate of Coverage. The terms and conditions contained in the General
Permit remain unchanged and in full effect. This revised Certificate of Coverage is issued under the requirements of
North Carolina General Statutes 143-215.1 and the Memorandum of Agreement between North Carolina and the U.S.
Environmental Protection Agency.
If you have any questions, please contact the Stormwater Permitting Unit at [phone], extension 502.
Sincerely,
ORIGINAL SIGNED BY
KEN PICKLE
Alan W. Klimek P. E.
cc: DWQ Central files
Asheville Regional Office, Water Quality Section
Sforrnwaret Permitting Unit,
No Carolina
�turally
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 Phone [phone] Customer Service
Internet: h2o.enr.state.mus 512 N. Salisbury St. Raleigh, NC 27604 FAX [phone]
An Equal Opportunity/Affirmative Action Employer — 50% Recycled110% Post Consumer Paper

I
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG140000
CERTIFICATE OF COVERAGE No. NCG140309
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
SOUTHERN CONCRETE MATERIALS
is hereby authorized to discharge stormwater from a facility located at
SOUTHERN CONCRETE MATERIALS-ASHEVILLE
80 POND ROAD
ASHEVILLE
BUNCOMBE COUNTY
to receiving waters designated as Hominy Creek, a class C waters, in the French Broad River Basin in accordance
with the effluent limitations, monitoring requirements, and other conditions set forth in Parts 1, II, III, IV, V, and VI
of General Permit No. NCG I40000 as attached.
This certificate of coverage shall become effective September 22, 2006.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day September 22, 2006. ORIGINAL SIGNED gy
KEN PICKLE
Alan W. Klimek, Director
Division of Water Quality
By Authority of the Environmental Management Commission

copyrngnt (c) 1997, maptecn, Inc.

ova �%-Drl
' • Division of Water
Quality !Wafer Quality Section
NGDENRNational Pollutant Discharge Elimination System cteck#Arnirt
C �NCG140000 R3'=`r A�4wIzd w
NQiICE OF INTEW
National Pdlutart DischanI Binination System apptication for coveraW eair_ier Coal Pert -tit
N03140000:
(Please print or type)
1) Mailing address of om-oer/operator:
Nart-6 Hyder Concrete Company
Street Actress 2 Country Spring Drive
aty Asheville Stye
Tdeoxxr e �b. 828/ 254-7333 F x
2) Location of facility producing discharge:
Facility N; Hyder Concrete C
Facility Gatact Brownie Hyder
Street Address 80 Pond Road
aty Asheville
County Buncombe
Tel ephone No. Fa)c
strial CEassifrcation Coder/
MAY -) 2CW
NCIZ!p;7Fs3(28t80'4.►.
828/ 281-3604 .-...
A6&ess to which all pemvt corresponderce vtiil be rrzJl-2rd
3) Pl-ryslcal Location tnfornotion:
Gn
See NC Zip Code 28804
Please prcide a narrative description d how to get to the facility (use street na -es' stale road nuTbers, anc
distanceand cir�ticnfrornaroIir>fc ion). Exi-L 140 south onto Brevard Road , .5
turn right onto Pond Road - Site is on le-ft, east side of I-26.
(A ocpy or a county rrep or L3SGS quad sheet with fatality dearly IioCat0d an the rrx is requred to to sut rYitted with this milt cn)
4) This [P'DES PI Application applies to Mich of the foilaI
a N--w or Proposed Facility Date operation is to begin
❑ Exsting
March 2001
Provide tt-e 4 digit Starxard indt..rstlial Classification Code (SIC Code) that describes the prirrrary irKilstrid
activity of this facility
SC Code: . 3 2 7 3
6) Provide a brief description of the types of industrial activities and products prockxs ed at this facility
(Include a site process diag•arn with this submittal):
Produce Readv Mix Concrete - See attached site plan.

Hyder Concrece Company, 80 Pond Road, Asheville, NC
NCG140000 N-0.1.
7) Discharge points/ Fiecdving vzders:
t-bw n-ay discharge points (ditches, pipes, channels, etc.) convey stomw Eder frcrn the properV? `
VU-%ai is the name of the body or bodes of water (creek, scream river, lake, etc) that the facility stornwnater
discharges end up in? Hominy Creek
If the site stormter dsdhar ges to a separate storm sewer system name the operator of the separate storm
sevver system (e.g. City of Raleigh m rhicipal storm sesAer).
Receiving water classification (if knov\n): C Tr
at las
be approved by U-k-- UC Dept- of Errvircinirrer" Healtfi If DEH does not Mprove, awe -age
under NM 40000 cannot be granted. No new cE scf-orges of process vv3stev�oter are pern-itted
in receiving viaters classified as VVS4 or freshwater ORW
8) Does this facHity have any other NFUES permits?
1I r1b
❑ Yes
If yes, list the pen -nit run -hers for all a.rrent NPDES permits for this facility. _
9) Does this facility have any Non -Discharge perrrrits (e)c recycle permfts)?
a r"b
❑ Yes
If yes, list the peaTit rxsrtx)ss for all current Ncn-Disd-urge pm its for this facility.
10) Does this facility erTpioy arty best manaagen-e-rt Practices for stom water control?
K$ r�.b
❑ yes
If yes, Terse briefly d ec ibe:
11) Does this facility have a Storrruuater Pollution Prevention Plan?
JUF\b
❑ Yes
If yes, v t)e vas it irrpierre"ed?
12) Are vehicle maintenance activities occuring at this facility?
ET`Nb
❑ Yes
13) Are discharges occurring from any of the following process wastewater generating activities?
Vehi d e and ec ppn-rat dean ng ❑{ Yes ❑ I\b
V1ttting c( raw material stockpiles El: Yes Cl rib
M)dng drum clearing -
E}. Yes ❑ f\b
If yes to any of the above, please describe the type crf process used to treaf aracYor recycle the pr ooess
v,astewafer. Give design specifics (i.e. design vdurrv, retention time, surface area, etc). [Use separate
sheet(s)]
Note: C xisb rction of any wastewater treatrner rt facilities require su#xrission of three (3) sets
of plans and specifications along with this aappiicatiorti Design of ftxoh E tt facilities
rrtist corrrply with regtrirernents 15A NCAC 2H .0138.

HYDER CONCRETE COMPANY 80 POND ROAD ASHEVrLLE, NC 1/22/2001
13}
All discharges occurring from vehicle and equipment washing, raw material stockpile
wetting, and mixing drum cleaning will be routed to the retention ponds. See attached
Erosion Control Plan and Erosion Control Drawing.

Hyder. Concrete Company, 80 Pond Road, Asheville, NC
NCG140000 N.O.I.
14) Does tale facility use a recycle systenY?
U fib
❑ Yes
If yes, does the system overflow only during rainfall events exceeding the 10-yr, 24^hr rainfall event? ❑ Yes ❑ Nc
• • •- • . r. • �r • . • •.• r • ••• �ru •
a) is this fad Iity a F-iazardous Waste Treatment, Storage, or Dspy Fad Iity?
U fib
❑ Yes
b) Is tfis fad Iity a Eck r l CLontity Generator (less than 1000 kg of hazardous waste generated per calendar
year) of hazardous vjaste?
rib
❑ Yes
c) Is this facility a Large Qontity Generator (1000 kg or more of hazardous vvaste generated per calendar
year) of hazardous vvaste?
U fib
❑ Yes
d) If you ansmered yes to questions b. ore., please provide the fdlor�Ang information:
Types) of veste:
i a,v is material stored-.
W-e—e is material stored
Ho v marry disposal ship -rents per year:
f"hrr e of trarisport / disposal Vendor:_
Vendor address.-
16) Certification:
North Carolina Genf Statute 143-21a6 b (i) p-wides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record, report,
plan or other document filed or required to be maintained under Article 21 of regulations of the Environmental
Management Commission inOernen6ng that Article, or wino falsifies, tampers with or knowingly renders inaccurate any
recording or morwtoring device or med)od required to be operated or maintained under Article 21 or regulations of the
Envirormentaf Management C mrnission implementing that Artide, shall be guilty of a misdemeanor punishable by a
fine rrot to exceed $10,00 , or by imprisonrnent not to exceed six months, or by both. (18 U.S.C. section 5001 provides
a punishment by a fine of not more than $10,000 or imprisonment not more than 5 years, or both, for a similar offense.)
I hereby repic st coverage under the referenced General Perm t I wand tt>at coverage Lr der this pern'i t
will o_-stitute the pa rit recuirements for the discharge(s) and is enforceable in the same manr>er as an
i r d, id-d perz7i t.
certify that i am familiar with the infotmaiion contained in this apoicaficn and that to the best of my k noWedge
and belief st tcfz infca-nattion is true, oorrplete, and acaurate.
Printed Names of Person Sging: Brownie Hyder
Title: Owner
(SgWure OfAp iiCal t)
(Gate SDF-

r
v
State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Kerr T. Stevens, Director
April 6, 2001
Ms. Brownie Hyder
Hvdcr Concrete Company
2 Country Spring Drive
Asheville, NC 28804
lkf:?W,A
IT 0 0
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: General Permit No. NCG140000
Hyder Concrete, Company
COC NCG 140309.
Buncombe County
Dear Ms. Hyder:
In accordance with your application for a discharge permit received on Febraary 6,,2001--
we are forwarding herewith the subject certificate'of coverage to-discharge.underthe stafiject state
NPDES'general;permit: This permit is issued pursuant to the iequiremerits of North Carolina ; '
General'Statute 143-215-.•Land the Memorandum of.Agreerr►enf betw666 North Car'olira andtthe'
US Environmental Protection agency dated Deceiriber 6,`-1983.
If any parts;measitrement frequencies or s'ampIing requirements contained iri this permit
are unacceptable to you, you have the right to request an individual permit by submitting,an
individual permit application., Unless such demand is made,'this certificate of coverage shall be
final and binding.
Please take notice that this certificate of coverage is not transferable except after notice to
the Division of Water Quality. The Division of Water Quality may require modification or
revocation and reissuance of the certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be
required by the Division of Water Quality or permits required by the Division of Land
Resources, Coastal Area Management Act or ariy1other~17ederal or Local governmental permit
that may be required. I,` ' ,i
If you have any questions concerning this permit, please contact Aisha Lau at telephone
number [phone] ext. 578.
cc: Asheville Regional Office
Central Files
Stormwater and General Permits Unit Files
1617 Mail Service Center, Raleigh, NC 27699-1617
An Equal Opportunity Affirmative Action Employer
Sincer'e�I ...,
G�i�-e1 "r��S ,
Kerr T. Stevens
Telephone [phone] FAX [phone]
50% recycled/ 10% post -consumer Iwaper

,>J
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG140000
CERTIFICATE OF COVERAGE No. NCG140309
STORMWATER AND PROCESS WASTEWATER DISCHARGES
NATIONAL POLLUTANT -DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management. Commission, and.the ;
Federal Water.Pollution Control Act, as amended,
f
Hyder Concrete Company
's �4 Cs hereby authorized to diklharge;stbrmwater.and treated wash , a,A from -a facility located -at
s:+
'id j .Hyde�:COncrele Company l
r � x 80 Poi d H6ad :
Asheville ti c �: �k k
!i f� a r i Buncomhe'County
C% r
'=to,receiving"waters design5ted'as Hominy Creek`Class'C' waters in the French Broad River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts 1, II,1I1,
IV, V, and VI of General Permit No. NCG140000 as attached.
This certificate of coverage shall become effective April 6, 2001,
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day April 6, 2001-
Kerr T. Stevens, Director
Division of Water Quality
By Authority of the Environmental Management Commission

I Me 01—
DA ArwI
MOW—
W;
Ile
IV
r4t
L6
our p um
Copyright (C) 1997, Maptech, Inc.

0
Markers
Name: NCG140309 - Hyder Concrete Company
Short Name: 140309
Coordinates: 0350 32' 43.1" N, 082' 36' 11.2" W 04
Comment: County: Buncombe, Map #: E8SE, Subbasin: 03-%-02, Receiving Stream: Hominy
Creek, Class: C.