NCG140156_COMPLETE FILE - HISTORICAL_20180815

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
IV U& 14 0
DOC TYPE
XHISTORICAL FILE
❑ MONITORING REPORTS
DOC DATE
❑ %D b 0� Ce�
YYYYM M D D

ROY COOPER
Governor
y_a MICHAEL S. REGAN
,.a
Secretary
WILLIAM E. VINSON, JR
Energy, Mineral
and Land Resources Interim Director
ENVIRONMENTAL QUALITY
August 15, 2018
Southern Concrete Materials
Attention: Jeff Lamm
Post Office Box 5395
Asheville, North Carolina 28813
Subject: Compliance Evaluation Inspection
Permit: NCO140156
Buncombe County, North Carolina
Dear Mr. Lamm:
Enclosed please find a copy of the Compliance Evaluation Inspection Report for the inspection I conducted at
the subject facility on August 8, 2018.
The report should be self-explanatory; however, should you have any questions concerning this report,
please do not hesitate to contact me at [phone] or by email at [e-mail].
Enclosure: Inspection Report
Since ,
Isaiah Ree , CEPSCI, S4CECI
Environmental Specialist
Land Quality Section
State of North Carolina I Environmental Quality I Energy, Mineral and Land Resources
2090 US 70 highway I Swannanoa, NC 28778-8211
828 296 4500 T

Compliance Ins ection Report
Permit: NCG140156 Effective: 08/01/17 Expiration: 06/30/22 Owner : Southern Concrete Materials
SOC: Effective: Expiration: Facility: Southern Concrete Mai-Ashevill
County: Buncombe 35 Meadow Rd
Region: Asheville
Asheville NC 28813
Contact Person: .lames F Combest. Title: Phone: [phone]
Directions to Facility: - — - - --
System Classifications:
Primary ORC:
Secondary ORC(s):
On -Site Representative(s):
Related Permits:
Inspection Date: 08/08/2018
Primary Inspector: Isaiah L Reed
Secondary Inspector(s):
Certification:
Phone:
EntryTime: 10:00AM Exit Time: 11:00AM
Phone: [phone]
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Ready Mix Concrete StormwaterNVastewater Discharge CoC
Facility Status: ❑ Compliant ® Not Compliant
Question Areas:
® Storm Water
(See attachment summary)
Page: 1

Permit: NCG140156 Owner -Facility: Southern Concrete Materials
Inspection Date: 08/08/2018 Inspection Type : Compliance Evaluation Reason for Visit: Routine
Inspection Summary:
On August 8, 2018 thiws facility was inspected for compliance. I met with Jeff Lamm on site. Durin gthe inspection, the
following items were noted.
1) Secondary containment was not provided in all areas where containers stored in close proximity to each other had a total
capacity greater than 1320 gallons. These containers shall be moved to an area which provides secondary containment.
2) The area next to the stilling basin should be evaluated for the potential to over flow during rain events. During an inspection
of the adjacent facility, it was observed that this area was overflowing.
Please contact this office with any questions. 828-296-4614
Page: 2

Permit: NOG140156 Owner. Facility: Southern Concrete Materials
Inspection Date: 0810812018 Inspection Type : Compliance Evaluation Reason for Visit: Routine
Stormwater Pollution Prevention Plan
Does the site have a Stormwater Pollution Prevention Plan?
# Does the Plan include a General Location (USGS) map?
# Does the Plan include a "Narrative Description of Practices"?
.# Does the.Plan include a detailed site map including. outfall locations and drainage areas?
# Does the Plan include a list of significant spills occurring during the past 3 years?
# Has the facility evaluated feasible alternatives to current practices?
# Does the facility provide all necessary secondary containment?
# Does the Plan include a BMP summary?
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
# Does the facility provide and document Employee Training?
# Does the Plan include a list of Responsible Party(s)?
# Is the Plan reviewed and updated annually?
# Does the Plan include a Stormwater Facility Inspection Program?
Has the Stormwater Pollution Prevention Plan been implemented?
Comment: See summary for further information.
Qualitative Monitorinq
Has the facility conducted its Qualitative Monitoring semi-annually?
Comment:
Analytical Monitoring
Has the facility conducted its Analytical monitoring?
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas?
Comment:
Permit and Outfalls
# Is a copy of the Permit and the Certificate of Coverage available at the site?
# Were all outfalls observed during the inspection?
# If the facility has representative outfall status, is it properly documented by the Division?
# Has the facility evaluated all illicit (non stormwater) discharges?
Comment:
Yes No NA NE
® ❑ ❑ ❑
® ❑ ❑ ❑
® ❑ ❑ ❑
® ❑ ❑ ❑
® ❑ ❑ ❑
® ❑ ❑ ❑
BE ❑ ❑ ❑
® ❑ ❑ ❑
® ❑ ❑ ❑
❑ ® ❑ ❑
® ❑ ❑ ❑
® ❑ ❑ ❑
® ❑ ❑ ❑
® ❑ ❑ ❑
® ❑ ❑ ❑
Yes No NA NE
® ❑ ❑ ❑
Yes No NA NE
® ❑ ❑ ❑
®❑ ❑ ❑
Yes No NA NE
® ❑ ❑ ❑
® ❑ ❑ ❑
❑ ❑ ® ❑
B ❑ ❑ ❑
Page: 3

Compliance Inspection Report
Permit: NCG140156 Effective: 08/01/17 Expiration: 06/30/22 Owner : Southern Concrete Materials
SOC: Effective: Expiration: Facility: Southern Concrete Mai-Ashevill
County: Buncombe 35 Meadow Rd
Region: Asheville
Asheville NC 28813
Contact Person: James F Combest Title: Phone: [phone]
Directions to Facility:
System Classifications:
Primary ORC:
Secondary ORC(s):
On -Site Representative(s):
Related Permits:
Inspection Date: 08108/2018
Primary Inspector: Isaiah L Reed
Secondary Inspector(s):
Certification:
Phone:
EntryTlme: 10:OOAM Exit Time: 11:OOAM
Phone: [phone]
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit inspection Type: Ready Mix Concrete Stormwater/Wastewater Discharge COC
Facility Status: ❑ Compliant Not Compliant
Question Areas:
■ Storm Water
(See attachment summary)
Page: 1

Permit: NCG140156 Owner - Facility: Southern Concrete Materials
Inspection Date: 08108/2018 Inspection Type : Compliance Evaluation Reason for Visit: Routine
Inspection Summary:
On August 8, 2018 thiws facility was inspected for compliance. I met with ,Jeff Lamm on site. Durin gthe inspection, the
following items were noted.
1) Secondary containment was not provided in all areas where containers stored in close proximity to each other had a total
capacity greater than 1320 gallons. These containers shall be moved to an area which provides secondary containment.
2) The area next to the stilling basin should be evaluated for the potential to over flow during rain events. During an inspection
of the adjacent facility, it was observed that this area was overflowing.
Please contact this office with any questions. 828-296-4614
Page: 2

Permit: NCG140156 Owner -Facility: Southern Concrete Materials
Inspection Date: 08/0812018 Inspection Type : Compliance Evaluation
Reason for Visit: Routine
Stormwater Pollution Prevention Plan
Yes No NA NE
Does the site have a Stormwater Pollution Prevention Plan?
0 ❑ ❑ ❑
# Does the Plan include a General Location (USGS) map?
i ❑ ❑ ❑
# Does the Plan include a "Narrative Description of Practices"?
® ❑ ❑ ❑
# Does the Plan include a detailed site map including outfall locations and drainage areas?
® ❑ ❑ ❑
# Does the Plan include a list of significant spills occurring during the past 3 years?
■ ❑ ❑ ❑
# Has the facility evaluated feasible alternatives to current practices?
® ❑ ❑ ❑
# Does the facility provide all necessary secondary containment?
® ❑ ❑ ❑
# Does the Plan include a BMP summary?
0 ❑ ❑ ❑
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
0 ❑ ❑ ❑
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
❑ ■ ❑ ❑
# Does the facility provide and document Employee Training?
❑ ❑ ❑
# Does the Plan include a list of Responsible Party(s)?
® ❑ ❑ ❑
# Is the Plan reviewed and updated annually?
® ❑ ❑ ❑
# Does the Plan include a Stormwater Facility Inspection Program?
E ❑ ❑ ❑
Has the Stormwater Pollution Prevention Plan been implemented?
® ❑ ❑ ❑
Comment: See summary_ for further information
Qualitative Monitoring Yes No NA NE
Has the facility conducted its Qualitative Monitoring semi-annually? ® ❑ ❑ ❑
Comment:
Analytical Monitorin
Yes No NA NE
Has the facility conducted its Analytical monitoring? ® ❑ ❑ ❑
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas? ® ❑ ❑ ❑
Comment:
Permit and Outfalls Yes No NA NE
# is a copy of the Permit and the Certificate of Coverage available at the site? ❑ ❑ ❑
# Were all outfalls observed during the inspection? ® ❑ ❑ ❑
# If the facility has representative outfall status, is it properly documented by the Division? ❑ ❑ ® ❑
# Has the facility evaluated all illicit (non stormwater) discharges? ■ ❑ ❑ ❑
Comment:
Page: 3

North Carolina Department of
HLE
SURFACE WATER PROTECTION
February 27, 2006
Mr. James F. Combest
Southern Concrete Materials, Inc.
Post Office Box 5395
Asheville, North Carolinas 28813
Michael F. Easley, Governor
William G. Ross Jr., Secretary
rnment and Natural Resources
Alan W. KRmek, P.E. Director
Division of Water Quality
Asheville Regional Office
SUBJECT: Compliance Evaluation Inspection
Storm Water Management System
Southern Concrete Materials
Permit No: NCG140156
Buncombe County
Dear Mr. Combest:
Attached is the report resulting from my February 24, 2006 Compliance Evaluation
Inspection of the wash water/storm water management system serving Southern
Concrete Materials' (SCM) Asheville Plant. I found the plant to be in compliance with the
documents and record keeping requirements of the permit. The system allows the use of
treated wash and storm water in the mix. When necessary to discharge, effluent pH is first
adjusted. The facility was found to be in Compliance with permit NCG140156.
Should you or anyone working with SCM have need to discuss this inspection
please do not hesitate to call me at 8238-296-4659.
Sincerely,
1 '-w
Roy M. Davis
Environmental; Engineer
Enclosure
cc: Jeff Lamm
Charlie Watson
NPS Unit
NCG 140156CoverLetter,06
ont
NovhCarolsna
�1 at�rrall�
2090 U.S. Highway 70, Swannanoa, NC 28778 Telephone: [phone] Fax: [phone] Customer Service 1 877 623-6748

c7m
United Sates Environmental Protection Agency
Form Approved.
EPA Washington, D.C. 20466
OMB No. 2040-0057
Water Com Iiance Inspection Report
Approval expires 8-31-98
Section A: National Data System Coding (i.e., PCS)
Transaction Code NPDES y0molday Inspection Type Inspector Fac Type
1 1 1,1 2 1_1 31 IiC, -i 10 :+ 111 121 1 ?ci,`.'r; 24 1 17 181-• 1 191 S1 20I 1
Remarks
211_11111111111111111111111111111111111111111111116
Inspection Work Days Facility Self -Monitoring Evaluation Rating B1 QA --------------------------- Reserved ------------------_---
671 169 701w1 711 1 721� 1 73 J ( ] 74 75 80
�J
Section B: Facility Data
Name and Location of Facility Inspected (For Industrial Users discharging to POTW, also include
Entry Time/Date
Permit Effective Date
POTW name and NPDES permit Number)
�.r.:11G AM 06 02: 2.1
04102 0
Snuth,-r_^.
Exit TimelDate
Permit Expiration Date
35 eacd. y, Ro
shov.iZle Pr 2rs9
lei:OG bl 06102,2d
r'o% %31
Name(s) of Onsite Representative (s)[Titles(s)lPhone and Fax Number(s)
Other Facility Data
Name. Address of Responsible OfficiaVTitle/Phone and Fax Number
Contacted
a roes F Co-d,?S t-,?0 Po.i -. :.5 eA T:1-e,i_1. le tic 28g13i/A25-253- 421 8 S25.13024
Section C: Areas Evaluated During Inspection (Check only those areas evaluated)
Facility Site Review
Section D: Summaa of Finding/Comments Attach additional sheets of narrative and checklists as necessary)
(See attachment summary)
Name(s) and Signature(s) of Inspector(s) Agency/Office/Phone and Fax Numbers Date
.-'.0 c //22B_2y6_95i.t. Fy:C.4,5!'/
Signature of Management Q A Reviewer. Agency/Office/Phone and Fax Numbers ate
y
Z/X---a
EPA Form 3560-3 (Rev 9 94) Previous editions are obsolete -
Page # 1

NPDES yrlmolday Inspection Type 1
3 11 12 17 18
taco 0,-156 Jr:i(r�. �..�
Section D: Summary of Finding/Comments (Attach additional sheets of narrative and checklists as necessary)
SCM's Asheville Plant is served by a very reliable storm water/wash water management system. Treated
storm waterlwash water is generally used in the mix. Effluent pH adjustment occurs when it becomes
necessary to discharge.
Page # 2

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
.lames B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
1 � •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVRONMENT AND NATURAL RESOURCES
July 26, 1999
JAMES F COMBEST
SOUTHERN CONCRETE MATERIALS INC
P O BOX 5395
A_ SHEVILLE, NC 28813
- Subject: Reissue - NPDES Stormwater Permit
Southern Concrete Materials Inc
COC Number NCG 140156
Dear Permittee: Buncombe -County
In response to your renewal application for continued coverage under general permit NCG140000, the Division of
Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This permit is reissued
pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement
between the state of North Carolina and the U.S. Environmental Protection Agency, dated December 6, 1983.
The following information is included with your permit package:
* A copy of general stormwater permit NCG140000
* A Stormwater Pollution Prevention Plan (SPPP) Certification Form. Completion of this form is required to
certify that you have developed and implemented the SPPP as per the conditions of the permit. This form
must be completed and returned to the Division within 30 days of receipt of this letter.
DO NOT SEND the SPPP with the signed form.
* Five copies of the Analytical Monitoring form and five copies of the Qualitative Monitoring form
* A copy of a Technical Bulletin for the general permit which outlines changes in the permit, key requirements,
and addresses frequently asked questions
* A Certificate of Coverage
Your coverage under this general permit is not transferable except after notice to DWQ. The Division may require
modification or revocation and reissuance of the Certificate of Coverage. This permit does not affect the legal
requirements to obtain other permits which may be required by DENR or relieve the permittee from responsibility
for compliance with any other applicable federal, state, or local law, rule, standard, ordinance, order, judgment. or
decree.
If you have any questions regarding this permit package please contact Tony Evans of the Central Office Stormwater
and General Permits Unit at [phone], ext. 584
Sincerely,
for Kerr T. Stevens
cc: Central Files
Stormwater and General permits Unit Files
Asheville Regional Office
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCGI40000
CERTIFICATE OF COVERAGE No. NCG140156
STORTMWATER AND PROCESS WASTEWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELINIINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amend-ed,
SOUTHERN CONCRETE MATERIALS INC
is hereby authorized to operate a process wastewater treatment system, and is hereby authorized to discharge process
wastewater and stormwater from a facility located at
SOUTHERN CONCRETE MATERIALS INC
35 MEADOW ROAD
ASHEVILLE
BUNCOMBE COUNTY
to receiving waters designated as the Swannanoa River in the French Broad River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, III,
IV, V, and VI of General Permit No. NCG140000 as attached.
This certificate of coverage shall become effective August 1, 1999.
This Certificate of Coverabe shall remain in effect for the duration of the General Permit.
Signed this day July 26, 1999.
for Kerr T. Stevens, Director
Division of Water Quality
By Authority of the Environmental Management Commission

4)C,
CIP
. t
�I

Southern Conaete Materials
BlItmore Plant (#10) - Asheville, North Carolina
Pollution Prevention Plan
Southern Concrete Materials
Certification
I certify under penalty of law that, based on my inquiry of the person or persons
directly responsible for gathering the information, the information submitted is, to the
best of my knowledge and belief, true, accurate, and complete. I am aware that there
are significant penalties for submitting false information, including the possibility of fines
and imprisonment for knowing violations.
Signature: C- , Tel: [phone]
-°'�me: Jeff Lamm Date: 8-31-01
Title: Environmental Manager
N

Page 1 of I
M rip)
P' ....'
w w w. M APQU EST. COM
< Back I
~fn �CarrFby St r4� �� ` 11
� TahkiaastrsOr—� � 5��,.
Print__ OPbons
f r0alton
x�/�� 'T41V1'IC1C>�df �
t i l ';f"Nl -_ _ _�JCErfflWorth� ti�
s{ Q f = r�6-`� 1--
edoOa o
p
CaIC1t1A811Do
Rd"
St ' C i
l� ea. V,_Ze i � c c Z�dr. �rrYial..
- - •4---^i�..
All Rights Reserved. Use Subject to_ LicenselCopyright
• I
1
p is informational only. No representation is made or warranty given as to its content. User assumes alf risk of use. MapQuest and its suppliers assume no
sibility for any loss or delay resulting from such use.
V://www.mapquest.conVcgi-bin/ia find?link=btwn%2Ftwn-map�rint&uid=udm4o214m2are5zd%3At2( 09/04/2001

Southern ConaEte Materials
Biltmwie Plant (#10) - ASheville, North Carolina
Pollution Prevention Plan
Spill Prevention and Response Plan
The Spill Prevention and Response Plan (SPRP) for this Plant includes many of the Best
Management Practices identified in Section II of this Manual. Specific practices include:
• The adoption of good housekeeping practices.
• The performance of regular visual inspections.
• The recycle and reuse of process materials.
• Secondary containment of bulk liquid storage tanks.
• Conducting monthly materials inventories.
• Making sure that the lids remain on all containers not in use.
• Maintaining Material Safety Data Sheets (MSDS) for all hazardous
chemicals and fuels stored and used on site.
The Pollution Plan Team Leader and Team Member(s) identified on page ii-2 of this
Manual are responsible for implementing and maintaining this SPRP. The Team Leader
is responsible for keeping this Plant's "Emergency Telephone List" current. A copy of
this list is illustrated at the end of this Appendix.
The spill response required is dependent upon the location, substance, and quantity of
spill which has occurred. The Plant Team should review the materials inventory
'� ,;trated in Appendix B.1 and assess the spill potential for the products listed. For
,.-zardous materials, the following procedures shall be followed:
Hazardous Material Spill and Containment Procedure
A. Identify the chemical for proper action.
B. Check MSDS for emergency instructions involving exposure,
treatment, and cleanup.
C. Contain chemical that was spilled to prevent contamination of other areas
or groundwater. Containment may include: a dirt dike; or sand (or other
spill control sorbents) to absorb the spill.

Southem Concrete materials
Blltmore Plant (*10) - Asheville, North Carolina
Pollution Prevention Plan
D. Reportable spills must be communicated to the proper federal, state and/or
local officials. Provide the following:
1. Name, address and telephone number of person reporting the spill.
2. Company name and location.
3. Location of the spill.
4. Name of the material spilled.
5. The quantity of material spilled
6. The cause and source of the spill
7. Name of the body of water involved or nearest body of water to the
spill.
8. The action which has been taken to contain the spill and clean it up.
E. Clean up the chemical and dispose of the waste as approved by the
applicable federal, state and/or local regulatory departments.
'"�te - This condensed Spill Prevention and Response Plan is not intended
replace any required Plans, including but not limited to:
• Spill Prevention, Control and Countermeasures Plan
• Hazardous Waste Contingency Plan
• Emergency Preparedness and Prevention Plan

State of North Carolina
Department of Environment,
Hp� it',�and-Natural Resources
'Diision of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
March 24, 1995
James F Combest
Soutehrn Concrete M_ aterials
P O Box 5395
Asheville, NC 28813 {�
1 LT
• •
EF�M�AR 2
8 .9q�
WATER (�Ljua;A S._e;,514
�iSHEVii[.[ I�E�I10i`:fit
Subject: General Permit No. NCG 14
Soutehrn Concrete Materials
COC NCG 140 t 56
Buncombe County
Dear James F Combest :
In accordance with your application for a stormwater discharge permit received on December 2, 1994, we
are forwarding herewith the subject certificate of coverage to discharge under the subject'state - NPDES general
permit. This perrnit is issued pursuant to the requirements of North Carolina General Statute 143-215 .l and the
Memorandum of Agreement between North -Carolina and the US Environmental Protection agency dated
December 6, 1983.
The stormwater permit you are receiving, NCG 140000, does 'not permit wasting concrete, dumping excess
concrete, directly into storm sewer outfalls or into waters of the state. Any facility which -either dumps excess
concrete or washes excess concrete into storm sewers or waters of the state will be operating in direct violation to
both the terms of this permit and the North Carolina General Statutes. Such a discharge shall be considered an
illegal discharge and may subject the owner to enforcement actions in accordance with North Carolina'General
Statutes 143-215.6A
If any parts, measurement frequencies or sampling requirements contained in this permit are unacceptable to
you, you have the right to request an individual permit by submitting an individual permit application. Unless
such demand is made, this certificate of coverage shall be final and binding.
Please take notice that this certificate of coverage is not transferable except after notice to.the Division -of
Environmental Management. The Division of Envirorunental Management may require modification or revocation
and reissuance of the certificate of coverage.
This permit does not affect the legal requirements to obtain other permits .which maybe required by the
Division of Environmental Management or permits required by the Division of Land Resources,, Coastal Area
Management Act or any other Federal or Local governmental permit that may be rcquired.
If you have any question concerning this permit, please contact MR. ANTONCO.'EVANS at telephone
number 919/733-5083, extension 584,
cc: Asheville Regional- Office
Mr. Roosevelt Childress, EPA
Sincerely, Original Sigrte:; 8u
Cotes n P-i: sui- —
A. Preston Howard, :r"r.-P.E.
P.O. Box 29535, Raleigh, North Carolina 27626-0535
An Faual OaDortu'nitV Affirmative Action.5-molover
Telephone [phone] FAX [phone]
Sr3aG.rars�n;br{! 1n*/ r,-et_nnnc, m nnnnr

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL -RESOURCES.
DIVISION"OF ENVIRONMENTAL MANAGEMENT
GENERAL PERMIT NO. NCG1.40000
CERTIFICATE . OF COVERAGE No. NCG140156
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the -North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amendecL,
Southern Concrete Materials
is hereby authorized to discharge stormwater from a facility located at
Southern Concrete Materials
35 Meadow Road
Asheville, NC
Buncombe County
to receiving waters designated as Swannanoa River in the French Broad River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I, 11, III
and IV of General Permit No. NCG 140000 as attached
This certificate of coverage shall become effective March 24, 1995,
This Certificate'of Coverage shall remain in effect for the duration of the -General Permit
Signed this day March 24, 1995.
A. Preston Howard, Jr., P.E., Director
Division of Environmental Management
mission
By Authority of the Environmental Management Com

March 15, 1995
Carolyn McCaskill, Supervisor
State Engineering Review Group
NC DEHNR
PO Box 29535
Raleigh, NC 28726-0535
Re: Permit No. WQ0004037
Southern Concrete Materials - B
Buncombe County
Dear Ms. McCaskill:
Enclosed please find a copy of your January 19,1995 letter
to Jeff Lamm, Geoligist together with a copy of Southern
Concrete's November 28, 1994 NOz for its Meadow Road plant.
Please allow this NOI to replace Permit WQ0004037. This
facility will be covered under General Permit 140000.
If additional information is required, please contact me at
this office (800-288-6421).
Sincerely, --
SOUTHERN CONCRETE MATERIALS, INC.
Pam Ho
Assistant
/ph
cc: Max Haner
Asheville Regional Office
35 Meadow Road/P.O. Box 5395/Asheville, NC 28813/704-253-6421 AC
Sirfnon l n,-afinnc QAru nn Alnrfh rarnlina _ tl

u
State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
.]EFF LAMM, GEOLOGIST
SOUTHERN CONCRETE MATERIALS-B
PO BOX 5395
ASHEVILLE, NC 28813
Dear Permittee:
C)EHNF=?L
January 19, 1995 "
SUBJECT: PERMIT NO. WQ0004037
SOUTHERN CONCRETE MATERIALS-B
BUNCOMBE COUNTY
Our files indicate that the subject permit issued on 11/19/90
— expires on 10/31/95. We have not received a request for renewal from
— you as of this date.
A renewal request shall consist of a letter requesting renewal and
completion of the enclosed application, submitted in triplicate. A
processing fee must be submitted with the request. Please find attached
a copy of the 15 NCAC 2H .0205(c) regulations. The processing fee for
your facility is based on the design or permitted— flow,- whichever is
appropriate, listed in the first four categories of --facilities. Sludge
renewals are based on total acres of land permitted. If the facility
covered by this permit contains some type of treatment works, a
narrative descripton of the sludge management plan that is in effect at
the facility must be submitted with the application for renewal.
The Environmental Management Commission adopted revised rules on
October 1, 1990 (attached), requiring the payment of an annual fee for
mast. -permitted facilities. You will .be billed separately=for -that fee
(if Applicable), after your permit is approved.
Please be Ladvised that this permit must not be allowed -to-expire.
If the renewal request is not received within 180. days - prior to the
permit's expiration date as required by 15 NCAC 2H .0211,7--.you -will be
assessed an automatic civil penalty. This civil penalty. by North
P.O. Box 29535, Raleigh, [North Carolina 2762640535 Telephone [phone] FAX [phone],,._'

Page 2
Carolina General Statute may be as much as $10,000 per day. If a permit
renewal request is not received 180 days before permit expiration, a
civil penalty of at least $250 will be assessed. Larger penalties may
be assessed depending on how late the request is made. In addition, any'
permit renewal request received after the permits expiration date will
be considered as a new application and will be required to pay the
higher permit application fee. -
The letter requesting renewal, along with a completed Non -Discharge
Permit application and appropriate standard fee, should be sent to:
Permits and Engineering Unit
Division of Environmental Management
P. 0. Box 29535
Raleigh, North Carolina 27626-0535
The check should be made payable to the North Carolina Department of
Environment, Health, and Natural Resources (DEHNR).
If you should have any questions or need any additional information
regarding this matter, please contact me at [phone].
Sincerely, ,
zolyn McCaskill,, -Supervisor --
State Engineering Review Group
cc: Asheville Regional Office
Permits and Engineering Unit
Central Files

J.
Nt
FOR -AGENCY USE ONLY
DATE RECEIVED
YEAR I -MONTH I DAY
CERTMCATE OF COVERAGE
DATE ISSUED
YEAR MONTH DAY
NATIONAL POLLUTANT DISCRARGE ELIMINATION SYSTEM
NOTICE OF INTENT REQUESTING COVERAGE UNDER
GENERAL PERMIT NO. NCG140000
STORMWATER DISCHARGES associated with activities classified as Ready Mixed Concrete
[Standard Industrial Classification Code (SIC) 3273].
Complete this Notice of Intent (NOI) and mail to the following address:
North Carolina Division of Environmental Management
Water Quality Section, NPDES Group
P.O. Box 29535
Raleigh, North Carolina 27626-0535
The NOI must be accompanied with a general permit filing fee of S400.00 and a copy of a county
map or USGS quad with the location of the facility clearly marked on the map. The check should
be made out to the forth Carolina Department of Environm nt, Health, and Natural Resources.
Portable ready mixed concrete facilities may begin operation upon submittal of a Notice of Intent
(NOI) and implementation of a stormwater pollution prevention plan. Portable plants are defined
as a temporary plant installation for the purpose of dedicating at least 7590 of all materials to a
specific job or a plant which continuously occupies a site fora period of six months or less. New
permanent installations are required to submit a NOI 90 days prior —to -beginning- industrial
activities.
I. - General Facility Information
1. Answer the following`questions by indicating the appropriate response (yes or no)
with•a check -mark in'th�e space provided to the right of each question:_
a. Does this facility have any NPDES Permits? __ - _yes x no
77,
b. Docs.this facility have any Nori-Discharge permits (ex: recycle permits)?.: ;. yes _rio
`-c:`Are vehicle maintenanm activities occumng on sits. � '_ : _ z' 'es ^,-no:
d. Are any best management practices'employed. for stormwater control? ,_yes _no:
e. Is this an existing facility? cs--L-no
f. Is this facility a Hazardous Warta Treatment, Storage, or Disposal -facility? . -.,_yes x no
�g.Is this facility a Small Generator of Hazardous Waste? - -- - - - y,_yes X2 no
h.. Does. this facility use molds to produce cast concrete products? ,.:. -..; _ .ryes X no. -
2_. ,. List the permit numbers for all current NPDES and Non -Discharge permits for this facility.
`wQ000403T
NOI 14 Page 1 of 3 Pages. _

Provide a brief narrative description of the types of industrial activities and products
manufactured at this facility:
Production of ready mixed concrete
V. Cemfication _.
I hereby request coverage under the referenced General Permit. I understand that coverage under
this permit will constitute the permit requirements for the discharge(s) and is enforceable in the
..same manner as an individual permit.
I 9f�at I am familiar withh�nnation contained in the application and that to the best of
r f y know edge and beliefAuc f on is eLcomplete, and accurate.
11-28-94
Signa re date
,lam s F. Combest President
print or type name of person signing above title
North Carolina General Statute 143-215.5(B)(2) provides that: Any person who knowingly makes
any false statement, representation, or certification in any application, record, report, plan or other
document files or required to be maintained under Article 21 or regulations of the Environmental
Management Commission implementing that Article, or who falsifies, tampers with or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or
maintained under Article 21 or regulations of the Environmental Management Commission
implementing that Article, shall be guilty of a misdemeanor punishable by a fine not to exceed
S10,000, or by imprisonment not to exceed six months, or by both. (18 U.S.C. Section 1001
provides'a punishment by a fine of not more than $10,000 or imprisonment not more than 5 years,
or both, for similar offense.) - -- - -
NOI 14 Page 3 of 3 Pages

azz
o
rj1!I�ilIN
;rI.11�1 13
111LLMSS774�TT �� `h`}r•'• � �` {
rlj i
- u
ter.,•"�`s
t`�'\
t � \�\'�
_o h 1i' � ` ``? —`_ II � �� v ` � .... � ,\��`j7`/��/�• � /i fry � .
rrj%�/ '=;.�1 \� .' �,•
J11� i

touthern
Concrete
Nlc�ter�c�ls .
Mr. Max Haner
DEHNR
Interchange Building
59 Woodfin Place
Asheville, NC 28801
Dear Mr. Haner:
April 15, 1994
In response to your letter dated April 12, 1994, pertaining to
the complaint filed by Marc Pruett, the following information is
submitted.
The driver Mr. Pruett observed at the Carolina Tractor site
was indeed washing off his truck. After completing a concrete pour
there are certain steps the driver must follow prior to departing
the job site. The hopper and internal blades of the mixer must be
washed off. This wash water is collected inside the mixing drum.
The next step is to wash off the four sections of chute (about 12
linear feet) to prevent the concrete residue from setting up
enroute to plant. The entire procedure requires about 25 gallons
of water. Should more extensive washing be required, the driver
(usually after the last trip of the day) would return to the plant
and flush out the mixer in the reclaimer area where the water would
be collected for future use.
Drivers have been thoroughly briefed on using good judgment
when selecting a "washdown` site for their vehicles. This will be
emphasize again during our next safety meeting and will be a
special point of interest for all future meetings.
Should you require additional information, please contact me
at your convenience.
Thank you for your co-operation.
Verb uJly yours ,
SOUTHE CO 7CR ERIALS, INC.
ames F. Combest
President
��1 JFC : ph
Uw
35 Meadow Road/P.O. Box 53951Asheville, NC 28813/704-253-6421 r
Sixteen Locations Serving North Carolina
Printed on Recycled Paper

� _
� � 'i
t
N
r

State of North �_ ,rolina
Department of Environment,
Health and n-7-- urces m o
Division of Environmental Management
.lames B. Hunt, Jr., Governor MW
Jonathan B. Howes, Secretary
Nann B. Guthrie, Regional Manager
Asheville Regional Office
WATER QUALITY SECTION
April 12, 1994
Mr. James Combest, President
Southern Concrete Materials
Post Office Box 5395
Asheville, North Carolina 28813
Subject: Transmittal of Complaint
of Concrete Washwater Disposal
Southern Concrete Materials
Buncombe County
Dear Mr. Combest:
Please find attached results of an inspection conducted by
"a Buncombe County Erosion Control Officer at Carolina Tractor in
Buncombe County in which the inspector observed what appears to be
an improper disposal of washwater from a Southern Concrete
Materials truck. Accounts of this observation as related in
paragraph 9 of the report indicate that on the afternoon of March
29, 1994, this washwater was. allowed to enter Hominy Creek,
surface waters of North Carolina, in a manner unapproved by this
Agency. I would request that you look into this matter and advise
me of your findings (and any warranted corrective action) on or
before April 29, 1994.
Thank you for your cooperation. Should you wish to discuss
this letter in more detail, please contact me at this office;
telephone [phone].
Yo s truly,
`
ax 2�Haner
Environmental Chemist
Attachment
xc: Marc R. Pruett
Forrest R. Westall
ti
Interchange Building, 59 Woodfin Place, Asheville, N.C. 28801 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 1096 post -consumer paper

5
'.OUNTY OF BUNCL _BE
Departrner,.r M ..
Erosion Control Office
46 Valley Street
Asheville, NC 28801
[phone]
Project Name: rA o I"A 717_64_1- 09m. . ' _ Permit No.: E- oZZ4.
Person(s) Financially Responsible: _I1g1=,?
Project Location:
1. Pictures: Yes[] No-k Number Prints o Slides o Video[]
2. Weather & Soil Conditions: GLGA-L_I G o0t.'6tVi73't _
3. Is site currently under Notice of Violat on? Y [] Now - - ^-
4. Is site in compliance with the North Carolina Sedimentation Pollution Control Act of 1973 (N.C.G.S. 113A-50) and
Buncombe County Ordinance No. 20172? Yes [] No;R If no, check violations below.
5. [1 No approved plan [G.S. 1I3A-57(4) and 15A N.C.A.C. 4B.0007(c), B.C. Ordinance -Section 6]
Failure to follow approved plan [G.S. 113A-61.1, B.C. Ordinance -Section 21(b)]
to [] Failure to submit revised plan [G.S. 113A-54.1(b) and 15A N.C.A.C. 413.0018(a), B.C. Ordinance -Section 19(d)]
Z Failure to provide adequate ground cover [G:S. 113A-57(3) and 15A N.C.A.C. 4B.0007(b) or
0 15A N.C.A.C. 413.0024(e), B.C. Ordinance -Section 8(c)]
�-+ :R Insufficient measures to retain sediment on site [G.S. 113A-57(3), B.C. Ordinance -Section 8(c)]
a[] Failure to take all reasonable measures [15A N.C.A.C. 4B.0005, B.C. Ordinance -Section 6(b)]
0 [1 Inadequate buffer zone [G.S. 113A-57(1), B.C. Ordinance -Section 8(a)]
> R, Graded slopes and fills too steep [G.S. 113A-57(2) or 15A N.C.A.C. 4B.0024(d), B.C. Ordinance -Section 8(b)]
0 Unprotected exposed slopes [G.S. 113A-57(2), B.C. Ordinance -Section 8(b)] _
Failure to maintain erosion control measures [15A N.C.A.C. 4B.0013, B.C. Ordinance -Section 14]
[] Other (Describe)
6.
W
Has off -site' sedime_n_tat_ion occurred since last_ inspection?-_J�Yes�_'- []. No--
9 -
Degree::-Sliht [] Moderate - [] Severe - Remarks:--
Copy of inspection report to be sent to person(s) responsible: 'Yes [] No ._
Copy to: 1 p _ Repo -file only `+-
s
tL o Date sent•
51 WcoaFru: •rLAcr., 4v6., t4-.-Z'1.e801
8. Corrective action(s) needed:._ __ _ td -" G
-- - -- SaME btsltLs�t�D!'.41`�.P�r�•1 U�.4tA�—NAPI�u�tD-
a -��_AF_W
• -
Comments:
nXlWR-F&j]iY.;4.1'lh .tom =t ` nR_,G_rtUr_A: A
"'IL ' kR F A
10:. DEADLINETOR• CORRECTIVE ACTIONS:_ ' g
Others present:
y Othe
1
-- =-,�-- .Date'.of �irispectiori: �'i 8 r - : --
7tJTH �I;NI' .
R . WA•:5���
i -t-H-��B14�t►J •

f
County of Buncombe
PLANNING AND DEVELOPMENT
46 VALLEY STREET
ASHEVILLE, N.C. 28801
[phone]
Jon E. Creighton Director
April 4, 1994
Mr. Forrest Westall
Regional Water Quality Supervisor
Water Quality Section, DEHNR
59 Woodfin Place
Asheville, NC 28801
Dear Mr. Westall:
Commissioners
Gene Rainey, Chairman
Patsy Keever
C. Thomas Sobol
David W. Young
William H. Stanley
Enclosed is a copy of a recent inspection report on the "Carolina Tractor site"
which details conditions on the site from an inspection I made on March 29, 1994.
This may not be a situation we need to look at further, but I did want to pass this
information on to you. "Section 9" refers to the item I wanted to bring to your
attention. Feel free to call if you have any questions about this matter.
Sincerely,
Marc R. Pruett
Erosion Control Technician
MRP/cws
cc: Michael A. Brookshire, Erosion Control Officer
Jon E. Creighton, Planning Director
Enclosure
APR - 5199A

Southern
Concrete
Materials
January 13, 1993
ME
Forest Westall
Regional Water Quality Supervisor
NC Department of Environment, Health & Natural Resources
59 Woodfin Place
Asheville, NC 28801
Re: Tax Certification
Dear Mr. Westall:
Please allow this letter to serve as a request for the issuance of
tax certifications for various locations (list to follow).
It is my understanding you require the listing of the facility, name
and address of the tax official to whom a copy of certification should be
sent and the name of our company official to whom a copy is to be sent.
Please direct certifications to my attention at Southern Concrete
Materials, Inc. The facilities in question are:
Water Quality Permit #WQ0004817
Haywood County Tax Supervisor
Haywood County Courthouse
Waynesville, NC 28786
Water Quality Permit #WQ0004818
Robert Baird, Tax Assessor
Henderson County
400 h Main Street
Hendersonville, NC 28739
Water Quality Permit #WQ0004037
Buncombe County Tax Supervisor
Buncombe County Courthouse
Asheville, NC 28801
If you would have any questions, please feel free to contact this
office.
Sincerely,
SOUTHERN CONCRETE MATERIALS,
Pam Hoffm
/ph
INC.
Printetl pn Recycled Paper
N
35 Meadow Road/P.O. Box 5395/Asheville, NC 28813/704-253-6421
Sixteen Locations Serving North Carolina

�� � �
�r��:� �"
�v�,�a {

4 'T •.. � ; i . .. 1�� C. / �� .. T � r tra.�✓e. -r a ck•�-�a� _"" - i �•.
f r t f r
f Ip
l< cl) C. C �i V r rr • f- f 1
(t� f�dattJas �' b Zr�Cs4�q W)J, /�:°14c
f BSc S r
W4
s/sped dog so frd.-1
A }r;o5� '�',� 5 5r�,rr�v
Ro
OL—
kJ
0-2
ed; 41'VAA G� 1 N .
L'ps�
At h�q��' Azuess Hoff
• Yti
• ULI& a•( n e
��, AA a ut��� �uSo �2 � � Vry.i :r�:C• � Q � �,�`.3 ! _.. . , _ r c e
�VG:q�%D} fir•, _ ".._, '... Tv1r0 �� 5�1_�v�'12Yc�� u�N�P
+ r .� «. ". ♦ .:en .. m%ems ^± +,s• :.y� r ��rr•�1Cr r �? r-r�rd*'i`i`v fy.. Y srrx� 3• a Lk •.5 r ^.r

.4i,i�i�l.ili; ''p'7't� ;.I,il1�.` �i.�li1{J. ..�r....{ '1y c'' � 1"�`i�r. ,:1A;fy?'l��l .7�•� ••�!;/.i'�••_�1,ei =! �1^;1.i^• .•Jl�r.? .,il;r."�f.r:l.�-.
' ! �.. '" �l � . • - ' ` � � jam,` li � �I I it � �J
{�.t,,i1'v' ,.�.. ;J '• i.,> �^''1`�-:i-,lrt � .. G(ff .... �. � j. r .�� lT.�' �ji9� 4� '
�'755,AI
� '• 4 - ; H" t. �. �� �'!"/.1. ' Imo., �,�r' /F"
_77.
.,.,...._tom",.-. - _...�..._ -... � . E`� .. '� . __.� � '�; P F�P, : '• -�
�• 4 I _ - .� --A '-A i.f
9 li�ir, o� r ZI
Z.
SJ
':'JLAJ.
If
.t.�:�,��1 r�l^i1 ;t'I1�. k; �c3 �:�7� r�'fZ' 1� �l �' {z,� .s __ / '•'C jI
,il

dr�4
State of 1\'orth C ir'o1i11It
Dela.'.1—Hn m of Environrl>lent, HC',fltll and ttN'attlr-al I CSOLlrccS
Division of Environrrtentnl ,ti,lasrragcmcnt
512 Nor0i Salisbury Strect • Raleigh, `onh Carol inn 27611
James G. Nlarrin, Govcrno: Gcorgc T, Evercu, Ph.]),
Williano W. Cobex, Jr., Director
� . 1991,
oS
Subject: Retul-n of Incarlplete Applica on
County
Dear
In accordance, v..-iih Division policy, we must hereby return as incomplete the attached
applications materials -ecei1991. It lacks the following items:
Three s�-_ of plans and specifications signed and sealed by a professional engineer.
Cornple;ei and signed application form.
Gravi[y _eve,er or pump station checklist (copy enclosed).
Letter of :lost,- acceptance.
Operatioa�-11 A_reemtnt for private sewers serving Multi -family dwellings.
r ..
Permit __=oliryion lee of
SubsLli c's °.raiio;]ISO11 SCientiSt'S I'eport for SUI"faCe, and -SUbSUdace waste
dispoS- pcn-1[s, Including loading rate calculations.
Waste.'.r.alyses and Toxicity Characteristic Leaching Procedure (TCLP) Analysis.
.2 Land G" Ier's .� trreement for sludge disposal applications.
"
r'v ci :mac c/✓�i�i� Q ",� J� r�' /
After you have obtaiiicd the checked items, you may resubmit your application for review.
Please submit all the iier]S returned to yod and the checked items together. Should you have any
questions, please contact \9r. Randy Jones or myself at [phone].
Sincerely,
. Z4-
RECEIVED
water Quality Section
�7 Carolyn D. McCi- a kill, Supervisor
✓�� State Engineering Review Group FEB — 7 1901
cc: � Regional Office
SERG File
Pollution Prevention Pays ps�y;llg Regional, of#�e
I'.0. Rn 27637, Raleigh, North Carolina 2761 1-76V Telephone [phone] Aghe,�fle, liorth Cardim
- n Equal Opportunity Affirmative Action Employer

TO:' PERMITS AND ENGIi.. _.::RING UNIT.
r WATER QUALITY SECTION
DATE: September 26, 1990
NON -DISCHARGE STAFF REPORT. AND RECOMMENDATION
COUNTY Buncombe County
PERMIT NUMBER WQ004037
(Renewal. of Permit No.3912R2)
PART I - GENERAL INFORMATION
I. Facility and Location: Southern Concrete Materials
35 Meadow Road
Asheville, North Carolina 28813
Mailing Address: Mr. Jeff Lamm
Post Office Box 425
Swannanoa, North Carolina 28778
2. Date of Investigation: July 25, 1990
3. Report Prepared By: Max L. Ha.ner.
4. Persons Contacted and Telephone Number.: Jim Combest
704 253-6421
5. Directions to Site: Existing facility is located at 35
Meadow Road near the Biltmore Section of Asheville, N.C.
6. Size (land available for expansion and upgrading): Adequate
7. Topography (relationship to 1.00 yer+r. flood plain included) :
Not in Flood Plain
Attach a U.S..G.S. map extract and indicate facility site,
U . S . G . S . Quad No. U . S . O . S . Quad Name Asheville
8. Location of nearest dwelling and water supply well: >1000 Ft
9. Watershed Stream Basin Informat.inn: Nearest Stream- Swannanoa Rivr
a. Watershed Classification: c 1_as�: "C"
b. River Basin and Subbasin tlo.: Fi:ench Broad River--040302
C. Distance to surface water from disposal system:300 ft (est)

PART II -- DESCRIPTION OF D.TSCHARCE ATM TR.F:ATMFNT WORKS
1. Type of wastewater,' sludge or contaminated soil:
2
3.
n7, I)OInesti c
1001% Tncbi:rtl J.al
a. Volume: MGT) (Design Capacity)
b. Types and quantities Of ;.nd1?st_r.ia1 wastewater. Concrete
truck ;rashwater
C. Prevalent toxic constituents in wastewater: None
d. Pretreatment Program (POTWs only): N/A
in development approved
should be required not needed
Production rates (industrial di.schar.cies only) in pounds per day:
N/A
a. Highest month in the past 1.2 months-
b. Highest year in the past 5 years-
lbs/day
lbs/day
Description of industrial process (.for industries only) and
applicable CFR Part and Subpart:
4. Type of treatment (specify whether proposed or existing):
Existing treatment system consists of three basins
used to
settle and recycle washwater from -oncrete trucks.
Washwater
contains inorganic solids washed (roitn concrete trucks. Basins
operated such that solids are l-einov(-A in First and second
basin.
Third basin used for recycle.
5. Sludge handling and disposal scheme: Sol -ids removed
and dryed
on site with drainage re-enteri.nci ^ysi,ein_
6. Treatment plant classification: [.ess than 5 points;
no rating
(include rating sheet, if. appropri.nte). N/A
7. SIC Code(s): 3273
Wastewater Code(s): Primary: 71P Secondary:

PART III - OTHER PEt— INENT INFORMATTON
1. Is this facility being const ri,r.ts(I with Construction Grant funds
(municipals only)?
2. Special monitoring requests:
3. Other:
PART IV - EVALUATION AND RECOMMENDATIONS
The non discharge and recycle system operates properly. It is
recommended that the Permit he ,-e,ss„Ad as appropriate.
v
Si.gnattiire of Report Preparer
s�tAr etyR-,gional Supervisor
T)a t:a

1 I jLLk:j LA L UL: It
171
kx
k
irrnoun
10
V FA[, Vlfw
BMA
---- -------- ---- R 0 AAJfQ 1993
-------------- as
I e A ----------
--fRtre-1 so
—2,000
eel
-4 A, NATi
r
v
co
U2
M m I
tf
-tea
Ferry p,
\\ f -_ \ :/ 9 i r r .I,\_- ..lr �,` �`I�r; 1l_ "P�� ;l4/.1\�,.�. I`.f i
S�-
N
b
L
A
-"Silo
The Lagoon
I in Lone e
ti
Res
"'Ord,
Long 12 4ak,!
B:
k—f I Pood

TTZ
5
State of North Carolina
Department of Environment, Health, and Natural Resources
Division of Environmental Management
512 North Salisbury Street O Raleigh, North Carolina 27611
James G. Martin, Governor George T. Everett, Ph.D.
William W. Cobey, Jr., Secretary Date: i 1 ! ' 19 Director
I
ham;_-Ftfr - sfm
I �cr 4 2-5-
Dear
SUBJECT: Application No. WQ �i�) �} _q
r��f �'��� 1. �.� !j'�f[ � r. r �I -� l r'' %; ♦ ✓'��
i t ICi (f 5_� II t.Ri r){il)r, f ( 3pA
The Division's Permits and Engineering Unit acknowledges receipt of your permit" application and supporting
materials on t� 1r�) �� 1 19 �/ . This application has been assigned the number shown above. Please
refer to this number when making inquiries on thi project.
Your project has been assigned to f 7G','1i�7�1`CL�'C.1 for a detailed engineering
review. A technical acknowledgement will be forthcoming. If this acknowledgement is not -received within thirty (30)
days, please contact the engineer listed above.
Be aware that the Division`s regional office, copied below, must provide recommendations from the Regional Super-
visor or a Procedure Four Evaluation for this project, prior to final action by the Division.
If you have any questions, please call the review engineer listed above at [phone].
Sincerely
r 7 {
L'��
Donald Safrit, P.E.
)Supervisor, Permits and Engineering
CC: I-aIt-U1-0,11t4 Regional Supervisor RECEIVED
�...-� Water Quality Sectiun
SEP 1 0' 1990
1 Pollution Prevention Pays
\J ,Asheville Regional, Office
P.O. Box 27687, Raleigh, North Carolina 27611-7687 Telephone [phone] Asheville, North Carolina
An Equal Opportunity Affirmative Action Employer

qw.
rt6 Carotin• Department of E► .nment, Health; and-Naitiral Resources DEM USE ONLY
•' Environmental Management Commission
Permit Number:
J(
- [,lOaJ3 7
NON -DISCHARGE PERMIT APPLICATION
County: Buncombe
`1n accordance with NC General Statutes Chapter 143, Article 21
Applit:aetl(tiamVlof board, individual, or others):
Application Date:
- o�l -90
Projeet!jha)we of(city;EOUlzige;ttovi lEsanitary district, establishment):
FOR:
Brief
n1i5rCo8ouPee basins. Concrete trucks rinse
❑ Non -Discharge Treatment/Disposal Facilities
out concrete into first which has spillway to
❑ Pretreatment Facilities
second basin. Material settles out here. Water
❑ Sewer Collection System (private)
is pumped from Mere to third basin for holding.
Solid material is periodically cleaned out of
❑ irxtenaion of Sewer Systems (public)
second basin. Water is pumped out of third
❑ Sludge Disposal
into trucks to start cycle again
❑ Spray Irrigation
NATURE OF WASTEWATER:.
❑KDomestic Sewage
❑ Sludge/Industrial Waste
Estimated Completion Date: in operation
❑ Other Waste
From (sewers, pretreatment plant):
Serving (ci y, inatituiion, Industry) -
I boi,ttl it k:onclr tt~ IVILILeri is
I r
Into (name of treatment plant):
Average LR'pjIsFLG&II9p7s4Sewage or Waste Flow:
I
At (location of plant):
(NPDES No.)
NC 00
Name and Complete
Address of Engineering Firm:
Zip Code:
Telephone No.
Applicant assures that proposed works will be constructed, supervised, operated and maintained in accordance
with approved plans and specifications or approved changes thereto.
tfefr Lamm Mailing
P. O. Box 425
Print Nami;:-^I-dSt Address:'
v
�
Swannanoa, N.C. 28778
Title: </7
Zip Code:
� `
a 7b4 ra} � �QV�:S 41i
Signature:
Telephone No.
1
INSTRUCTIONS:
I. Fill-in All Spaces. If not applicable, enter N/A_
2.Secure appropriate signature (mayor/city manager for municipality, chairman for sanitary district board, owner/proper official of
corporation, or legally constituted board or commission in charge of proposed works). A letter of authorization is required from
proper official if design engineer or other agent signs application.
3.Submit to Division of Environmental Management, Permits and Engineering Unit, P.O. Box 27687, Raleigh, NC 27611 the original.
and ALL carbon copies of the application, 3 sets of finalized plans, specifications and other supporting data as required by Co --
mission Rules. and permit fee. Plans and specifications must be signed and sealed by a registered North Carolina engineer.
FOR ASSISTANCE, CALL THE STATE CENTRAL OFFICE [phone]. PERMITS & ENGINEERING UNIT, OR:,
Asheville [phone]
Fayetteville [phone]
Mooresville [phone]
Winston-Salem. [phone]
59 Woodfin Place
Suite 714 Wachovia Bldg.
919 North Main Street
8025 North Point Boulevard
Asheville, NC 28801
Fayetteville, NC 28301
Mooresville, NC 28115
Suite 100
Winston-Salem, NC 27106
Raleigh [phone]
Washington [phone]
Wilmington [phone]
3800 Barrrett Drive
1424 Carolina Avenue
7225 Wrightsville Avenue
P.O. Box 27687
P.O. Box 1507
Wilmington, NC 28403
Raleigh,,NC 27611
Washington, NC 27889
t v
$

Y

N
August 20, 1990
Permits and Engineering Unit
Division of Environmental Management
P. O. Box 27687
Raleigh, N. C. 27611-7687
Subject: Permit No. 3912 RT
Southern Concrete Materials
Buncombe County
Dear Sirs:
At this time, we are requesting renewal for the
above referenced permit. I have enclosed a completed
Non -Discharge Permit Application and a check for the
standard fee of $100.00 for simple renewal.
Respectfully submitted,
l�/r1�
Jeff Lamm
JL/jm
=
35 Meadow Road/P.O. Box 5395/Asheville, NC 28$13/704-253-6421 :A c1t`
12 Plants & Over 100 Trucks Serving North Carolina "L

A�
V. Or M
01
August 3, 1990
Mr. Max L. Haner
Environmental Chemist
NC. Department of Environment, Health,
and Natural Resources
Water Quality Section
59 Woodfin Place
Asheville, NC 2BB01
Re: Non -Discharge Permit 3912R2
Compliance Evaluation Inspection
Dear Mr. Haner:
We are in receipt of your letter dated August 2, 1990 with
reference to your inspection conducted July 25, 1990.
Low volume discharge (trickle) was observed. The line from
the which the discharge was observed has been sealed.
If you have any questions, please feel free to call.
JFC:ph
Ver truly yours,
SOUTHE CONC ATERIALS, INC.
-G��•�
amen F . Comb -mot
Vice -President
RECEIVED
Water Quality section
AUG 0 - 1990
,Asheville Regional,.pffice
Asheville, North Carolina
35 Meadow Road/P.O. Box 5395/Asheville, NC 28813/704-253-6421 I .A�C);;
12 Plants & Over 100 Trucks Serving North Carolina 0,:?

State of North Carolina
Department of Environment, Health, and Natural Resources
Asheville Regional Office
James G. Martin, Governor
William W. Cobey, Jr., Secretary DIVISION OF ENVIRONMENTAL MANAGEMENT
WATER QUALITY SECTION
August 2, 1990
Mr. Jim Combest
Southern Concrete Materials
Post Office Box 5395
Asheville, North Carolina 28813
Ann B, Orr
Regional Manager
Subject: Compliance Evaluation Inspection
Status: In Compliance
Wastewater Treatment System
Southern Concrete Materials
Non -Discharge Permit 3912R2
Buncombe County, North Carolina
Dear Mr. Combest:
The Compliance Evaluation Inspecti n that I conducted July 25,
1990, indicated that the wastewater- treatment and recycle system
serving Southern Concrete Materials generally has been operating as
designed with exception of an observed low volume discharge (trickle)
from the system's overflow line to surface waters of North Carolina. I
realize that this overflow line is in place for use during emergency
situations, however, since the permit does not provide for a discharge,
it is recommended that this line be sealed or otherwise altered to
prevent passive use and subsequent unpermitted discharge_ The system
appears to have been receiving proper maintenance. Marginal compliance
with permit no 3912R2 is noted as result of this inspection -
Should you have questions or wish to discuss this letter in more
detail, please do not hesitate to contact me.
Your try ly,
Ma L . at
Environmental. Chemist
xc: Forrest R. Westall
Interchafi� Kiildinp 51) WogKlfin Place, Adievillu. N.C. 25801 • Teleph piw 714-225i-6?08
:1n I rival Orin rtunikv A Tirm;ricr At_iuIII FTi 1i711 A :I

RECEIVED
Water Quality Section
JUN 2 2 1990
Asheville RegionakOffice
Asheville, Forth Carolina
June 19, 1.990
ANTHONY J. SCAVONE
SOUTHERN CONCRETE MATERIALS
P. 0. BOX 5395
ASHEVILLE, NC 28813
SUBJECT: PERMIT NO. 3912R2
SOUTHERN CONCRETE MATERIALS
BUNCOMBE COUNTY
Bear Permittee:
Our files indicate that the subject permit issued oir 3/1.8/86 expires on
3/31/91. We have not received a request for renewal from you as of this date.
A renewal request shall consist of a letter requesting .renewal and completion of
the enclosed application, submitted in triplicate. A processing fee must be submitted
with the request. Please find attached a copy of the 15 NCAC 211 .0205(c) regulations.
The processing fee for your facility is based on the design or permitted flow,
whichever is appropriate, listed in the first four. categories of facilities. Sludge
renewals are based on total acres of land permitted. If the facility covered by this
permit contains some type of treatment works, a narrative descripton of the sludge
management plan that is in effect at the facility must be submitted with the
application for renewal.
The Environmental Management Commission adopted rifles on August 1, 1988,
requiring the payment of an annual fee fot most permitte-d facilities (attached
regulations). You will be billed separately for that fec (i.r applicable), after your
permit is approved.
Please be advised that this permit must riot be allowed to expire. If the renewal
request is not received within 180 days prior to the pe.r:mi.t's expiration date as
required by 15 NCAC 211 .0211, you will be assessed an automatic civil penalty. This
civil penalty by North Carolina General Statute may be as much as $1.0,000 per day. If
a permit renewal request is not received 1.80 days before permit expiration, a civil
penalty of at least $300 will be assessed. Larger penalties may be assessed depending
on how late the request is made. In addit.i.on, any per-mi.t .renewal request received
after the permit's expiration date will be considered as a new application and will be
required to pay the higher permit application fee.

Page 2
The letter requesting renewal, along with a completed Non -Discharge Permit
application and appropriate standard fee, should be sent- to:
Permits and Engineering Unit
Division of Environmental Management
P. 0. Box 27687
Raleigh, North Carolina 27611.-7687
The check should be made payable to the North Carolina Department of Environment,
Health, and Natural Resources (DEHNR).
if you should have any questions or need any addit:i.onal, information regarding this
matter, please contact me at [phone].
Sincerely,
c.�_O'(Y� IC_
Carolyn McCaskill, Supervisor
State Engineering Review Group
cc: -Asheville=Regi'onal`0ffi e
Permits and Engineering Unit
Central Files

f
i
�
I

•i
I
�.
��
��
i'
i
i
,1.
�,
i
,�
i
f
.. � �, r •.
� � �
�' ��' 1. 5'� -� c
,!
1
i f
a
r
.
c .��
_ ,v � �a
(. � `
y

?Z

k.
I

� RflPfl
M a�t;ce
e \'
o1�te�o�c 1 o,�t,ce
' 0 a
eciaimer & pits
plant
. -Iolo -, . f"
�OR4o��
Ntmore Plar
5awt�crn Concrcte Materi.ls
Ro, �30x 5395
A55 eville NC 2881'
�7ate: b/ 17/ O� i i7rawn [3u: JeF('L�

Jeff Lamm
P.O. Box 5395
Asheville, NC 28813
Ph: 828-253-6421
Fax: [phone]
%AIATC- A/VL9RR_Fd71