NC0048305_Fact Sheet_20190822

FACT SHEET FOR EXPEDITED PERMIT RENEWALS
This form must be completed by Permit Writers for all expedited permits which do not require full Fact
Sheets. Expedited permits are generally simple 100% domestics (e.g., schools, mobile home parks, etc)
that can be administratively renewed with minor changes, but can include facilities with more complex
issues (Special Conditions, 303(d) listed water, toxicity testing, instream monitoring, compliance
concerns).
Basic Information for Expedited Permit Renewals
Permit Writer / Date
Sydney Carpenter 8/22/2019
Permit Number
NCO048305
Facility Name / Facility Class
Carolina Yarn Processors / PC-1
Basin Name / Sub -basin number
Broad River Basin / 03-08-06
Receiving Stream / HUC
Little Creek / 030501051201
Stream Classification / Stream Segment
C / Index: 9-55-1-11.5
Does permit need Daily Max NH3
limits?
No
Does permit need TRC
limits/language?
N/A
Does permit have toxicity testing?
No
Does permit have Special Conditions?
No
Does permit have instream monitoring?
Yes, for Turbidity.
Is the stream impaired (on 303(d) list)?
No
Any obvious compliance concerns?
Multiple problems with TSS since 2013 renewal.
Enforcement case in 2015, NOVs in 2018, 2016, 2014, and
NOD in 2014.
Any permit mods since last permit?
No
New expiration date
7/31/2023
Facility Overview:
Carolina Yarn Processors applies conventional water treatment technology to non -process
contact wastewater. Facility discharges to surface waters for 6 hours max twice per year (Outfall
001), 4 hours once per year or as needed (Outfall 002), and on average 4 hours monthly or as
needed (Outfall 003). Total discharge averages 3,528 gal/month (Combined Outfalls 001, 002,
003).
Compliance History:
• Enforcement case in 2015 regarding TSS limit violations
• Multiple NOVs from 2013-2018, all for TSS limit violations.
Reasonable Potential Analysis (RPA) — Renewal Summary:
• Permit application does not state if Iron sulfate or ferrous sulfate has the potential to be
discharged. An RPA for Outfall 003 was performed using the old freshwater standard
of 1 mg/L for Iron. Per the 2007-2014 Triennial Review, Iron no longer has a WQS and
as only four values exceeded 1 mg/L out of the past 4 '/2 years of Iron DMR data, the
permit writer has removed monitoring for Iron from the effluent table.

• Outfalls 001 & 002 discharged yearly. The Iron values for these two outfalls have not
exceeded the old freshwater standard of 1 mg/L and Iron no longer has a recommended
limit, therefore the permit writer has removed Iron from the effluent table, per 2007-
2014 Triennial Review.
• Per "Assistance with BPJ on WTP renewals" 2012 Memo, Aluminum does not require
an RPA. Renewal application states Aluminum chloride (polymer) is added in Primary
Basin and has potential to be discharged from all three outfalls. Therefore, Aluminum
monitoring will stay in renewal permit with the same monitoring frequency as the
previous permit renewal.
Changes from previous permit to draft:
• Added regulatory citations
• Added facility grade.
• Updated receiving stream information. Previously known as UT to N Pacolet River, but
has been updated to Little Creek and confirmed with ARO.
• Updated eDMR language in Footnote 1 in Section A. (1).
• Removed Iron parameter in A. (1) Effluent table for Outfalls 001 & 002 and in A. (2)
Effluent table for Outfall 003. Iron does not have a recommended limit and was
monitoring only in previous permit. All reported values in previous four and a half years
are < 1 mg/L for Outfalls 001 & 002, and only four values exceeded 1 mg/L for Outfall
003.
• Updated electronic reporting language in Section A. (3).
Changes from draft to final:
• No changes.
Comments received on draft permit:
• No comments received.

Wafer Resources
ENVIRONMENTAL QUALITY
January 31, 2018
David Moore
Fendrich Industries Inc
PO Box 1579
Tryon, NC 28782-1579
Subject: Permit Renewal
Application No. NCO048305
Carolina Yarn Processors
Polk County
Dear Applicant:
ROY COOPER
G"erraor
NUCHAEL S- REGAN
secrete.
LLNDA CULPEPPER
Ixterim Directa*
The Water Quality Permitting Section acknowledges the January 30, 2018 receipt of your permit renewal application and
supporting documentation. Your application will be assigned to a permit writer within the Section's NPDES WW
permitting branch. Per G.S. 15OB-3 your current permit does not expire until permit decision on the application is made.
Continuation of the current permit is contingent on timely and sufficient application for renewal of the current permit.
The permit writer will contact you if additional information is required to complete your permit renewal. Please respond
in a timely manner to requests for additional information necessary to allow a complete review of the application and
renewal of the permit.
Information regarding the status of your renewal application can be found online using the Department of Environmental
Quality's Environmental Application Tracker at:
https://deq.nc.ciov/permits-regulations/permit-guidance/environmental-application-tracker
If you have any additional questions about the permit, please contact the primary reviewer of the application using the
links available within the Application Tracker.
Sincerely,
Wren Thedford
Administrative Assistant
Water Quality Permitting Section
cc: Central Files w/application(ARO)
ec: WQPS Laserfiche File w/application
State of North Carolina I Environmental Quality I Water Resources
1617 Mail Service Center I Raleigh, North Carolina 27699-1617
919-807-6300

Carolina Yarn Processors
Division of Fendrich Industries, Inc.
250 Scriven Road
P.O. Box 1579
Tryon, NC 28782
Phone: [phone]
Mr. Wren Thedford
NC DENR/DWR/NPDES Unit
1617 Mail Service Center
Raleigh, NC 27699-1617
Dear Mr. Thedford:
January 25, 2018
RECEIVE®!®ENR/DWR
JAN 3 0 2018
Water Resources
Permitting Section
This letter is to request renewal of our NPDES Permit number NCO048305 which
will expire on July 31, 2018.
Enclosed is the completed application form.
Sincerely,
David M. Moore
President
Fendrich Industries, Inc.

NPDES PERMIT APPLICATION — SHORT FORM C — Minor Industrial
Minor industrial, manufacturing and commercial facilities.
Mail the complete application to:
N. C. Department of Environment and Natural Resources
Division of Water Quality / NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
NPDES Permit Number INCO048305
Please print or type.
1. Contact Information:
RECE9VE[3tC)ENR1DW
Owner Name Fendrich Industries, Inc. JAN 3 ® 2918
Facility Name CAROLINA YARN PROCESSORS Water Ftesaurces
Mailing Address PO BOX 1579 PerMI
UMY
City TRYON
State / Zip Code NORTH CAROLINA 28782
Telephone Number 828-859-5891
Fax Number 828-859-9024
e-mail Address [e-mail]
2. Location of facility producing discharge:
Check here if same as above ❑
Street Address or State Road 250 SCRIVEN ROAD
City TRYON
State / Zip Code NORTH CAROLINA 28782
County POLK
L
3. Operator Information:
Name of the firm, consultant or other entity that operates the facility. (Note that this is not refemng to the
Operator in Responsible Charge or ORC)
Name CAROLINA YARN PROCESSORS
Mailing Address PO BOX 1579
City TRYON
State / Zip Code NORTH CAROLINA 28782
Telephone Number 828-859-5891
Fax Number 828-859-9024
4. Ownership Status:
Federal ❑ State ❑ Private XX Public ❑
Page 1 of 5 C-MI 10/08

NPDES PERMIT APPLICATION - SHORT FORM C - Minor Industrial
Minor industrial, manufacturing and commercial facilities.
5. Standard Industrial Classification (SIC) code(s): 2284
6. Number of employees: 50
7. Describe the treatment system List all installed waste treatment components with capacities,
describe the processes that generate wastewaters. If the space provided is not sufficient attach a
separate sheet of paper with the system description.
PLEASE SEE ATTACHED PAGE
8. Is facility covered under federal effluent limitation guidelines? No X® Yes ❑
If yes, specify the category?
9. Principal product(s) produced: Bleached & dyed yarn and cloth, print cloth
Principal raw material(s) consumed: Process natural & synthetic yarn and cloth
Briefly describe the manufacturing process(es):
Wet processing of cotton and synthetic yarns: Bleach and dye for companies who weave fabric.
Wind yarn onto dye tubes, dye, dry dyed yarn, wind onto cones, pack and ship.
Bleach and dye or print cloth, both 100% cotton and 50/50 poly/cotton blend; put on rolls and ship.
Page 2 of 5 C-MI 10/08

Carolina Yarn Processors
Division of Fendrich Industries, Inc. January 22, 2018
250 Scriven Road
P.O. Box 1579
Tryon, NC 28782
Phone: [phone]
WATER TREATMENT SYSTEM
Primary and Secondary Sedimentation Basins
Polymer Feed System
Flow Equalization
Sand Filter Beds
Filtration System
Primary Sedimentation Basin
Water from our pond is channeled to the Primary Basin (145,000-gallon capacity) where
polymer and caustic are added to clear turbidity and control PH.
Sand Filter Beds
Sediment and solids build up in the Primary Basin which requires emptying and cleaning basin
no more than twice annually. Contents are washed to a flow equalization chamber and then piped
to the Sand Beds. Sediment is filtered as water passes through the sand and then the water is
discharged to the stream. Outfall #001
Secondary Sedimentation Basin
Water from the Primary Basin is piped to the Secondary Basin (92,000-gallon capacity) where
remaining turbidity settles. As sediment builds up, the basin is cleaned and discharged to the
stream annually. Outfall #002
Filtration System
Water from the Secondary Basin is piped to Filter Tanks (8,000-gallon capacity) and then piped
into the plant for use in yarn and fabric dyeing equipment. The filters are backwashed and
discharged to the stream as needed. Outfall #003

NPDES PERMIT APPLICATION - SHORT FORM C - Minor Industrial
Minor industrial, manufacturing and commercial facilities.
10. Amount of principal product produced or raw material consumed
List spectlic amounts consumed and/or units of roduction over the last three ears
Product Produced or Raw Material
Consumed
AVERAGE
Product Produced or Raw Material
Consumed
PEAK
per Day
3,950 lbs (250 days/yr)
4,540 lbs
per Month
82,284 lbs
94,600 lbs
per Year
987,415 lbs
1,135,200 lbs
11. Frequency of discharge: Continuous ❑ Intermittent X®
If intermittent:
Days per week discharge occurs: 1 Duration: #001: 6 hours max twice per year
#002: 4 hours once per year
#003: 4 hours average monthly
12. Types of wastewater discharged to surface waters only
Discharge
Flow
(GALLONS PER DAY)
Sanitary - monthly average
N/A
Utility water, etc. - monthly average
N/A
Process water - monthly average
N/A
Stormwater - monthly average
37,000 gallons average
Other - monthly average
Explain:
Water from outfalls #001, #002, #003
3,528 gallons average
Monthly Average
total discharge (all types)
40,528 gallons average
13. Number of separate discharge points: 3 Outfall Identification number(s) 001, 002, 003
14. Name of receiving stream(s) (Provide a map showing the exact location of each outfall, including
latitude and longitude):
Unnamed tributary to the North Pacolet River in the Broad River Basin: MAP ATTACHED
Page 3 of 5 C-MI 10/08

FCI�OIi�r'#�1f'
Ch
W � a „^� ,r� "• "•� •"r - 4 �'" ,fit ..a _
NC Hwy 108 '1
y • •• v� 5 ;1 �/��►.yjy{(/���� ij �''� :". '�1 * ice-- �� . _'"�}' '"
-, • V�/ R • lid • a.� /.- �� 15115.
'� `, b`� �. • v`d . r iti�
�� , ��' �4 ;,,�=° ,' •� • r UT to North `Pacolet ♦t ? '
�. 4s, " "`�• a `its ,r'�` Rivet
• �� f ;-�, .r,' ♦ (flows east)
00
fi^. � r"1 ��. • s�w, �f t' +r '�a — , s • . 1, �t'c ` 9 " `s •
� a C ScilvenRoad.a •���t r
``�, ` Itf"_ �;:,�.,;�',,`�..,,..• Outfalls 002 and 003 (flow-E)
__� �— w • �., e Lat 35, 13 'a 05"
Approximate Facility • �i '' •��` }� Long $2; 14' 09"
Boundary • "--.. �,.� � l �-�'r1 -�..
�• ti
01
• � i r,----...._ ��, '-� •�`1t yam..✓ ; ��,,�� 1� s �`-r � • �'t� . `,�� ..--�. �° + :'��" • Outfall 001 C� •F Iw
�_.
. . • ,� j : . :!� �;'!� . ►f (flows I , + i ;�i ; ��.V
,� f"� = `��,,,_,,._.�.�.� .�'"_,�" � {� � `r �- "�r 1��� -�''; —= � ,,,tip • ram`=--"• « -
'fir •-�. i ♦ *' � ! • _/`" � s • + •i
s �NC Hwy 176
i ■�.� • •f" 11 Sao♦{ems. l 'tf�`—..._51` �j��`: �� ♦ 4 1 ��`�r✓`
41
•\ • t t r l � • •� i f r � �Ile
,•i a • f ► / A M1 t i [�
%
-fir
r `Y. � * • �v, `• ' ,�.�.���'• €1. • :�.-, r__�';,z;,�la ic_ .t � ;t3:1�.•.l t�C �, � 5
Fendrich Inds -tries, Inc.
Carolina Yarn 'Processors, Trion
State Grid/Quad (il ONW / Landrum, SG Sub-13as111 03-08-06
Pet mrtted Flow not limited Stream Class C
RccervmQ Stream. UI to North Pacolet Rner Stt cam Sef ment 9-5'5-1-(10)
UtamacceMigui BtoadRivci,Bat tm IIUC 03050105
Facility
Location
not to scale
North NPDES Peimrt NC0048305
� Polk County

NPDES PERMIT APPLICATION - SHORT FORM C - Minor Industrial
Minor industrial, manufacturing and commercial facilities.
15. Effluent Data [for new or proposed discharges]
Provide data for the parameters listed. Temperature and pH shall be grab samples, for all other parameters 24-hour
composite sampling shall be used If more than one analysts is reported, report daily maximum and monthly average.
If only one analysts is reported, report as daily maximum.
NOTE: Permittees requesting renewal should complete the table ONLY for the parameters
currently monitored. Summarize the past 3 years of effluent data.
Parameter
Daily
Maximum
Monthly
Average
Units of
Measurement
Biochemical Oxygen Demand (BOD5)
Chemical Oxygen Demand (COD)
Total Organic Carbon
Total Suspended Solids
9.6
6.4
Mg/L
Ammonia as N
Temperature (Summer)
Temperature (Winter)
pH
7.5
7.0
Fecal Coliform (If sanitary waste is
present)
Total Residual Chlorine (if chlorme is
used)
16. List all permits, construction approvals and/or applications (check all that apply and provide permit
numbers or check none tf not applicable):
Type Permit Number Type Permit Number
Hazardous Waste (RCRA) NESHAPS (CAA)
UIC (SDWA) Ocean Dumping (MPRSA)
NPDES NCO048305 Dredge or fill (Section 404 or CWA)
PSD (CAA) Other
Non -attainment program (CAA)
17. List any chemicals that may be discharged (Please list and explain source and potential
amounts.)
Polymer (CAS#7446-70-0) and Caustic (CAS# 1310-73-2) are added to water in the Primary Basin.
By the time the diluted solution goes through the system and the sand beds, the amount that
could make it to the stream would only be a trace if any.
Page 4 of 5 C-MI 10108

NPDES PERMIT APPLICATION - SHORT FORM C - Minor Industrial
Minor industrial, manufacturing and commercial facilities.
18. Is this facility located on Indian country? (check one)
Yes ❑ No XX
19. Applicant Certification
I certify that I am familiar with the information contained in the application and that to the
best of my knowledge and belief such information is true, complete, and accurate.
David M. Moore President
Printed name of Person Signing Title
/M , 1/2,C/2 b IS
Signature of Applicant Date
North Carolina General Statute 143-215.6 (b)(2) provides that Any person who knowingly makes any false
statement representation, or certification in any application, record, report, plan, or other document files or
required to be maintained under Article 21 or regulations of the Environmental Management Commission
implementing that Article, or who falsifies, tampers with, or knowingly renders inaccurate any recording or
monitoring device or method required to be operated or maintained under Article 21 or regulations of the
Environmental Management Commission implementing that Article, shall be guilty of a misdemeanor punishable
by a fine not to exceed $25,000, or by imprisonment not to exceed six months, or by both. (18 U.S.C. Section
1001 provides a punishment by a fine of not more than $25,000 or imprisonment not more than 5 years, or both,
for a similar offense.)
Page 5 of 5 C-MI 10/08

Carolina Yarn Processors
Division of Fendrich Industries, Inc. January 25, 2018
250 Scriven Road
P.O. Box 1579
Tryon, NC 28782
Phone: [phone]
Mr. Wren Thedford
NC DENR/DWR/NPDES Unit
1617 Mail Service Center
Raleigh, NC 27699-1617
Dear Mr. Thedford:
Regarding management of our sludge or solids, sedimentation from the primary
sedimentation basin is discharged to the sand beds. Solids are separated as the
water passes through the sand beds before being discharged to the stream.
On -site storage occurs before the solids are loaded and disposed of at the county
landfill. The primary basin requires being emptied and cleaned a maximum of
twice per year. Sedimentation may be discharged many times to the sand beds
before disposal is required.
Sincerely,
David M. Moore
President
Fendrich Industries, Inc.

Freshwater RPA - 95% Probability/95% Confidence Using Metal Translators
MAXIMUM DATA POINTS = 58
REQUIRED DATA ENTRY
Table 1. Project Information
]CHECK IF HQW OR ORW WQS
Facility Name
Par01
Carolina Yarn Processors
WWTP/WTP Class
PC-1
Par02
NPDES Permit
NCO048305
Par03
Outfall
001
Par04
Flow, Qw (1
0.050
Par05
Receiving Stream
Little Creek
Par06■
HUC Number
03050105
Par07
Stream Class
C
0.00
Paro8
Par09
Par10
]Apply WS Hardness WQC
7Q10s (cfs)
7Q10w (cfs)
0.00
Par11
311 (cfs)
0.00
Par12
QA (cfs)
0.00
Par13
1Q10s (cfs)
Par14
Par15
0.00
Effluent Hardness
NO EFFLUENT HARDNESS DATA
-----------------------------------
Upstream Hardness
NO UPSTREAM HARDNESS DATA
I Par16
- _
Combined Hardness Chronic
- - -- -
DATA INCOMPLETE
I Par17
-- —
Combined Hardness Acute
----- ---------- ----
-- DATA INCOMPLETE ------I
I
Par18
I Par19
Par20
Data Source(s)
❑CHECK TO APPLY MODEL
Par21
Par22
Par23
Par24
Table 2. Parameters of Concern
Name WQS Type Chronic Modifier Acute i Units
Arsenic
Aquactic Life
C
150
FW
340
ug/L
Arsenic
Human Health
Water Supply
C
10
Hi
N/A
ug/L
Beryllium
Aquatic Life
NC
6.5
FW
65
ug/L
Cadmium
Aquatic Life
NC
NO DATA
FW
NO DATA
ug/L
Chlorides
Aquatic Life
NC
230
FW
Chlorinated Phenolic Compounds
Water supply
NC
1
A
ug/L
Total Phenolic Compounds
Aquatic Life
NC
300
A
ug/L
Chromium III
Aquatic Life
NC
NO DATA
FW
NO DATA
ug/L
Chromium VI
Aquatic Life
NC
11
FW
16
pg/L
Chromium, Total
Aquatic Life
NC
N/A
FW
N/A
pg/L
Copper
Aquatic Life
NC
NO DATA
FW
NO DATA
ug/L
Cyanide
Aquatic Life
NC
5
FW
22
10
ug/L
Fluoride
Aquatic Life
NC
1,800
FW
ug/L
Lead
Aquatic Life
NC
NO DATA
FW
NO DATA
ug/L
Mercury
Aquatic Life
NC
12
FW
0.5
ng/L
Molybdenum
Human Health
NC
2000
HH
ug/L
Nickel
Aquatic Life
NC
NO DATA
FW
NO DATA
pg/L
Nickel
Water Supply
INC
25.0000
WS
N/A
pg/L
Selenium
Aquatic Life
INC
5
FW
56
ug/L
Silver
Aquatic Life
NC
0.06
FW
NO DATA
ug/L
Zinc
Aquatic Life
NC
NO DATA
FW
NO DATA
ug/L
Iron
Aquatic Life
NC
1
FW
mg/L
NCO048305 RPA 2019 001, input
3/27/2019

Carolina Yarn Processors -
NC0048305 Freshwater RPA - 95% Probability/95% Confidence Using Metal Translators
MAXIMUM
Qw (MGD) =
0.0500
1Q10S (cfs) =
0.00
7Q10S (cfs) =
0.00
7Q10W (cfs) =
0.00
30Q2 (cfs) =
0.00
Avg. Stream Flow, QA (cfs) =
0.00
Receiving Stream:
Little Creek HUC 03050105
DATA POINTS = 58
WWTP/WTP Class: PC-1
IWC% @ 1Q10S =
100
IWC% @ 7Q10S =
100
IWC% @ 7Q10W =
100
1WC% @ 30Q2 =
100
IW%C @ QA =
100
Stream Class:
C
Outfall 001
Qw = 0.05 MGD
COMBINED HARDNESS (me/L)
NO DATA
NO DATA
PARAMETER
NC STANDARDS OR EPA CRITERIA
REASONABLE POTENTIAL RESULTS
RECOMMENDED ACTION
TYPE
a
Applied
Chronic Acute
n # Det. Max Pred Cw Allowable Cw
Standard
Acute: NO WQS
Iron
NC
1 FW
mg ; L
2 2
3.79000
Note: n <_ 9
C.V. (default)
Chronic: 1.00000
RP for Limited Dataset (n<8 samples) - no WQS, so
Limited data set
No value > Allowable Cw
no monitoring required.
Acute:
0 0
N/A
—
-Chronic: ----------
--------------------------
Acute:
0 0
N/A
_ __________
Chronic:
Acute:
0 0
N/A
_ __________
Chronic:
_
NCO048305 RPA 2019 001, rpa
Page 1 of 1 3/27/2019

REASONABLE POTENTIAL ANALYSIS
Par22
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
Iron
Date Data BDL=1/2DL
5/21/2015 1 1
7/5/2016 0.5 0.5
Use"PASTE SPECIAL
Values" then "COPY"
. Maximum data
points = 58
Results
Std Dev.
0.3536
Mean
0.7500
C.V. (default)
0.6000
n
2
Mult Factor = 3.79
Max. Value 1.000000 mg/L
Max. Fred Cw 3.790000 mg/L
-1-
NCO048305 RPA 2019 001, data
3/27/2019

Freshwater RPA - 95% Probability/95% Confidence Using Metal Translators
MAXIMUM DATA POINTS = 58
REQUIRED DATA ENTRY
Table 1. Project Information
]CHECK IF HQW OR ORW WQS
Facility Name
Par01
Carolina Yarn Processors
WWTP/WTP Class
PC-1
Par02
NPDES Permit
NCO048305
Par03
Outfall
002
Par04
Flow, Qw (1
0.050
Par05
Receiving Stream
Little Creek
Par06■
HUC Number
03050105
Par07
Stream Class
C
0.00
Paro8
Par09
Par10
]Apply WS Hardness WQC
7Q10s (cfs)
7Q10w (cfs)
0.00
Par11
311 (cfs)
0.00
Par12
QA (cfs)
0.00
Par13
1Q10s (cfs)
Par14
Par15
0.00
Effluent Hardness
NO EFFLUENT HARDNESS DATA
-----------------------------------
Upstream Hardness
NO UPSTREAM HARDNESS DATA
I Par16
- _
Combined Hardness Chronic
- - -- -
DATA INCOMPLETE
I Par17
-- —
Combined Hardness Acute
----- ---------- ----
-- DATA INCOMPLETE ------I
I
Par18
I Par19
Par20
Data Source(s)
❑CHECK TO APPLY MODEL
Par21
Par22
Par23
Par24
Table 2. Parameters of Concern
Name WQS Type Chronic Modifier Acute i Units
Arsenic
Aquactic Life
C
150
FW
340
ug/L
Arsenic
Human Health
Water Supply
C
10
Hi
N/A
ug/L
Beryllium
Aquatic Life
NC
6.5
FW
65
ug/L
Cadmium
Aquatic Life
NC
NO DATA
FW
NO DATA
ug/L
Chlorides
Aquatic Life
NC
230
FW
Chlorinated Phenolic Compounds
Water supply
NC
1
A
ug/L
Total Phenolic Compounds
Aquatic Life
NC
300
A
ug/L
Chromium III
Aquatic Life
NC
NO DATA
FW
NO DATA
ug/L
Chromium VI
Aquatic Life
NC
11
FW
16
pg/L
Chromium, Total
Aquatic Life
NC
N/A
FW
N/A
pg/L
Copper
Aquatic Life
NC
NO DATA
FW
NO DATA
ug/L
Cyanide
Aquatic Life
NC
5
FW
22
10
ug/L
Fluoride
Aquatic Life
NC
1,800
FW
ug/L
Lead
Aquatic Life
NC
NO DATA
FW
NO DATA
ug/L
Mercury
Aquatic Life
NC
12
FW
0.5
ng/L
Molybdenum
Human Health
NC
2000
HH
ug/L
Nickel
Aquatic Life
NC
NO DATA
FW
NO DATA
pg/L
Nickel
Water Supply
INC
25.0000
WS
N/A
pg/L
Selenium
Aquatic Life
INC
5
FW
56
ug/L
Silver
Aquatic Life
NC
0.06
FW
NO DATA
ug/L
Zinc
Aquatic Life
NC
NO DATA
FW
NO DATA
ug/L
Iron
Aquatic Life
NC
1
FW
mg/L
NCO048305 RPA 2019 002, input
3/27/2019

Carolina Yarn Processors -
NC0048305 Freshwater RPA - 95% Probability/95% Confidence Using Metal Translators
MAXIMUM
Qw (MGD) =
0.0500
1Q10S (cfs) =
0.00
7Q10S (cfs) =
0.00
7Q10W (cfs) =
0.00
30Q2 (cfs) =
0.00
Avg. Stream Flow, QA (cfs) =
0.00
Receiving Stream:
Little Creek HUC 03050105
DATA POINTS = 58
WWTP/WTP Class: PC-1
IWC% @ 1Q10S =
100
IWC% @ 7Q10S =
100
IWC% @ 7Q10W =
100
1WC% @ 30Q2 =
100
IW%C @ QA =
100
Stream Class:
C
Outfall 002
Qw = 0.05 MGD
COMBINED HARDNESS (me/L)
NO DATA
NO DATA
PARAMETER
NC STANDARDS OR EPA CRITERIA
REASONABLE POTENTIAL RESULTS
RECOMMENDED ACTION
TYPE
a
Applied
Chronic Acute
n # Det. Max Pred Cw Allowable Cw
Standard
Acute: NO WQS
Iron
NC
1 FW
mg
2 2
1.97080
Note: n <_ 9
C.V. (default)
Chronic: 1.00000
RP for Limited Dataset (n<8 samples) - no WQS, so
Limited data set
No value > Allowable Cw
no monitoring required.
Acute:
0 0
N/A
—
-Chronic: ----------
--------------------------
Acute:
0 0
N/A
_ __________
Chronic:
Acute:
0 0
N/A
_ __________
Chronic:
_
NCO048305 RPA 2019 002, rpa
Page 3 of 3 3/27/2019

REASONABLE POTENTIAL ANALYSIS
Par22
Use"PASTE SPECIAL
Iron Values" then "COPY"
. Maximum data
points = 58
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
Date Data BDL=1/2DL
5/21 /2015 0.52 0.52
7/5/2016 0.05 0.05
Results
Std Dev.
0.3323
Mean
0.2850
C.V. (default)
0.6000
n
2
Mult Factor = 3.79
Max. Value 0.520000 mg/L
Max. Fred Cw 1.970800 mg/L
-1-
NCO048305 RPA 2019 002, data
3/27/2019

Freshwater RPA - 95% Probability/95% Confidence Using Metal Translators
MAXIMUM DATA POINTS = 58
REQUIRED DATA ENTRY
Table 1. Project Information
]CHECK IF HQW OR ORW WQS
Facility Name
Par01
Carolina Yarn Processors
WWTP/WTP Class
PC-1
Par02
NPDES Permit
NCO048305
Par03
Outfall
003
Par04
Flow, Qw (1
0.171
Par05
Receiving Stream
Little Creek
Par06■
HUC Number
03050105
Par07
Stream Class
C
0.00
Paro8
Par09
Par10
]Apply WS Hardness WQC
7Q10s (cfs)
7Q10w (cfs)
0.00
Par11
311 (cfs)
0.00
Par12
QA (cfs)
0.00
Par13
1Q10s (cfs)
Par14
Par15
0.00
Effluent Hardness
NO EFFLUENT HARDNESS DATA
-----------------------------------
Upstream Hardness
NO UPSTREAM HARDNESS DATA
I Par16
- _
Combined Hardness Chronic
- - -- -
DATA INCOMPLETE
I Par17
-- —
Combined Hardness Acute
----- ---------- ----
-- DATA INCOMPLETE ------I
I
Par18
I Par19
Par20
Data Source(s)
❑CHECK TO APPLY MODEL
Par21
Par22
Par23
Par24
Table 2. Parameters of Concern
Name WQS Type Chronic Modifier Acute i Units
Arsenic
Aquactic Life
C
150
FW
340
ug/L
Arsenic
Human Health
Water Supply
C
10
Hi
N/A
ug/L
Beryllium
Aquatic Life
NC
6.5
FW
65
ug/L
Cadmium
Aquatic Life
NC
NO DATA
FW
NO DATA
ug/L
Chlorides
Aquatic Life
NC
230
FW
Chlorinated Phenolic Compounds
Water supply
NC
1
A
ug/L
Total Phenolic Compounds
Aquatic Life
NC
300
A
ug/L
Chromium III
Aquatic Life
NC
NO DATA
FW
NO DATA
ug/L
Chromium VI
Aquatic Life
NC
11
FW
16
pg/L
Chromium, Total
Aquatic Life
NC
N/A
FW
N/A
pg/L
Copper
Aquatic Life
NC
NO DATA
FW
NO DATA
ug/L
Cyanide
Aquatic Life
NC
5
FW
22
10
ug/L
Fluoride
Aquatic Life
NC
1,800
FW
ug/L
Lead
Aquatic Life
NC
NO DATA
FW
NO DATA
ug/L
Mercury
Aquatic Life
NC
12
FW
0.5
ng/L
Molybdenum
Human Health
NC
2000
HH
ug/L
Nickel
Aquatic Life
NC
NO DATA
FW
NO DATA
pg/L
Nickel
Water Supply
INC
25.0000
WS
N/A
pg/L
Selenium
Aquatic Life
INC
5
FW
56
ug/L
Silver
Aquatic Life
NC
0.06
FW
NO DATA
ug/L
Zinc
Aquatic Life
NC
NO DATA
FW
NO DATA
ug/L
Iron
Aquatic Life
NC
1
FW
mg/L
NCO048305 RPA 2019 003, input
3/27/2019

Carolina Yarn Processors -
NC0048305 Freshwater RPA - 95% Probability/95% Confidence Using Metal Translators
MAXIMUM
Qw (MGD) =
0.1710
1Q10S (cfs) =
0.00
7Q10S (cfs) =
0.00
7Q10W (cfs) =
0.00
30Q2 (cfs) =
0.00
Avg. Stream Flow, QA (cfs) =
0.00
Receiving Stream:
Little Creek HUC 03050105
DATA POINTS = 58
WWTP/WTP Class: PC-1
IWC% @ 1Q10S =
100
IWC% @ 7Q10S =
100
IWC% @ 7Q10W =
100
1WC% @ 30Q2 =
100
IW%C @ QA =
100
Stream Class:
C
Outfall 003
Qw = 0.171 MGD
COMBINED HARDNESS (me/L)
NO DATA
NO DATA
PARAMETER
NC STANDARDS OR EPA CRITERIA
REASONABLE POTENTIAL RESULTS
RECOMMENDED ACTION
TYPE
a
Applied
Chronic Acute
n # Det. Max Pred Cw Allowable Cw
Standard
Acute: NO WQS
Iron
NC
1 FW
mg/L
38 32
6.51700
_ _ _ _ _ _
Chronic: 1.00000
_ _ _ _ _ _ _ _ _ _ _ _ _ _
RP shown - However, Iron no longer has a WQS
4 values > Allowable Cw
Removing monitoring from permit.
Acute:
0 0
N/A
—
-Chronic: ----------
--------------------------
Acute:
0 0
N/A
_ __________
Chronic:
Acute:
0 0
N/A
_ __________
Chronic:
_
NCO048305 RPA 2019 003, rpa
Page 1 of 1 3/27/2019

REASONABLE POTENTIAL ANALYSIS
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
Use "PASTE SPECIAL
Iron
Values" then "COPY"
. Maximum data
points = 58
Date Data
BDL=1/2DL
Results
9/2/2014
0.066
0.066
Std Dev.
0.9968
9/9/2014
0.2
0.2
Mean
0.4401
9/16/2014
0.088
0.088
C.V.
2.2650
9/23/2014 <
0.05
0.025
n
38
9/30/2014
0.41
0.41
10/7/2014 <
0.05
0.025
Mult Factor =
1.33
10/14/2014 <
0.05
0.025
Max. Value
4.900000 mg/L
10/21/2014
0.1
0.1
Max. Pred Cw
6.517000 mg/L
10/28/2014
0.12
0.12
11/4/2014
0.68
0.68
11/11/2014
0.13
0.13
11/18/2014 <
0.05
0.025
11/25/2014
0.27
0.27
12/2/2014
3.8
3.8
12/9/2014
0.053
0.053
12/16/2014
1.4
1.4
12/30/2014
0.057
0.057
1/6/2015
0.17
0.17
1/13/2015
1.2
1.2
1/20/2015
0.052
0.052
1/27/2015 <
0.05
0.025
2/3/2015
0.054
0.054
4/14/2015
0.1
0.1
7/14/2015 <
0.005
0.0025
10/6/2015
4.9
4.9
1/5/2016
0.37
0.37
4/5/2016
0.054
0.054
7/12/2016
0.67
0.67
10/4/2016
0.063
0.063
1/10/2017
0.073
0.073
4/4/2017
0.15
0.15
7/11/2017
0.05
0.05
10/3/2017
0.062
0.062
1/9/2018
0.85
0.85
4/3/2018
0.24
0.24
7/12/2018
0.05
0.05
10/9/2018
0.013
0.013
1/8/2019
0.1
0.1
-1-
NCO048305 RPA 2019 003, data
3/27/2019

Publisher's Certificate of Publication
STATE OF NORTH CAROLINA
PUBLIC NOTICE
COUNTY OF POLK
North Carolina
Environmental
Management Commission/
Kevin Powell, being duly sworn, says:
NPDES Unit
That he is General Manager of theTryon Daily Bulle-
1617 Mail Service Center
tin, a daily newspaper of general circulation, printed
Raleigh, NC 27699-1617
and published in Tryon, Polk County, North Carolina-
Notice of Intent to Issue a NP-
that the publication, a copy of which is attached
The Northwater Carolina PermitEnvi-
hereto, was published in the said newspaper on the
ronmental Management
following dates:
Commissionpropastewateoses
s
issue tewater
`
discharge permit to the per-
06/25/19
sons) listed below. Written
comments regarding the pro-
posed permit will be accepted
until 30 days after the pub -
That said newspaper was regularly issued and
9 Y
date of this notice. The
Director of the NC Division
circulated on those dates.
of Water
of water Resources (DWR)
may hold a public hearing
The sum charged by the Newspaper for said publi-
should there be a significant
cation does not exceed the lowest rate aid b
P Y com-
degree of public interest.
Please mail comments and/
mercial customers for an advertisement of similar
or information requests to
size and frequency in the same newspaper in which
DWR at the above address.
the public notice appeared.
Interested persons may visit
the DWR at 512 N. Salisbury
There are no agreements between the Tryon Daily
Street, Raleigh, NC to review
information on file. Additional
Bulletin and the officer or attorney charged with the
information on NPDES per -
duty of placing the attached legal advertising no-
mits and this notice may be
tices wherebyan advantage, gain or profit accrued
Y 9 9 P
found .g our out/diiwebsitv hens/
deq.nc.gov/sbout/divisions/
to said officer or attorney.
water-resources/water-re-
so urces-permits/wastewa-
SIGNED:
ter-branch/npdes-wastewa-
ter/public-notices,or byy callingg
[phone]. Fendrich
Industries, Inc., Polk Coun-
ty, applied to renew NPDES
Permit NC0048305/Carolina
Yam Processors WTP. Facil-
ity discharges to Little Creek/
Broad River Basin.
Daily Bulletin:
Kevin Powell, General Manager
June
FENDRICH INDUSTRIES
Subscribed and sworn to before me this
25th Day of June, 2019
i
Mary Jo Eskridge, Notary Public
State of Alabama at Large
My commission expires 03-05-2022
Account # 144932
Ad # 834689
NCDENR&DWQ&POINT SEARCH BRANCH
1617 MAIL SERVICE CENTER
RALEIGH NC 27699