NCG030125_COMPLETE FILE - HISTORICAL_20140616

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
Iv cc; co 3
DOC TYPE
HISTORICAL FILE
❑ MONITORING REPORTS
DOC DATE
❑ 00I q D � I (/
YYYYMMDD

ATtA
IBC® NR
North Carolina Department of Environment and Natural Resources
Pak McCrory John E. Skvarla, III
Governor Secretary
July 16, 2014
Norandal USA
Attn: Ms Ann Evans, EH&S Specialist
1709 Jake Alexander Blvd South
Salisbury, North Carolina 28145
Subject: Compliance Assistance
Stormwater Permit # NCG030127
Norandal USA
Iredell County
Dear Ms. Evans:
The subject site was inspected on July 15, 2014 as requested by your company for
compliance assistance regarding the exceedances of Copper and Zinc. Ms. Christine Brenk,
Consultant with Kleinfelder Company, was present at the meeting and toured this site with you
and me. As noted during our investigation there were a lot of pipes and metals (some rusted)
stored in an old parking lot to the right of the building and occupy approximately at least one.
quarter of an acre that discharges to Stormwater Outfall 1. At the receiving deck we noted a
stormwater inlet with patches of oil. This -inlet is connected under the building to Stormwater
Outfa113.' Also, we noted above Stormwater Outfall # 3 a waste container that is rusted with
holes at the bottom and will leak during any storm event. Also, we noted around the buildings
several areas with a lot of rusted metals and oil stain on the ground.
Please note that -you could apply for relief from monthly monitoring once you are in tier
3 with 4 consecutive samples above the benchmark. In order to obtain a relief from monthly
monitoring, all of the questionable areas need to be investigated in order to determine the
source of zinc and copper at the facility.
Division of Energy, Mineral, and Land Resources
Land Quality Section - Mooresville Regional office
610 East Center Avenue, Suite 301, Mooresville, North Carolina 28115
Telephone: [phone] FAX: [phone] • Internet: http:llportal.nodenr.org/webArAand-quality
An Equal Opportunity I Affirmative Action Employer - 50% Recycled 110% Post Consumer Paper

Please retain and append this letter to your Stormwater Pollution Prevention Plan
(SPPP) or permit. If you have any questions or comments concerning this letter, please
contact Samar Bou-Ghazale or myselfat 704-663-1699
Sincerely,
Zahid S. Khan, CPM, CPESC, CPSWQ
Regional Engineer
Land Quality Section
Enclosure: Inspection Report
cc: Bathany Georgoulias-Stormwater Permitting Program (via e-mail)
MRO-Land Quality Section, Stormwater Files-NCG030127

......��
NCDEE R
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Charles Wakild, P. E.
Governor Director
December 4, 2012
Gary Barnes
Frit Car & Equip Co
PO Box 569
Bridgeton, NC 28519
Dee Freeman
Secretary
Subject: NPDES Stormwater Permit Coverage Renewal
Frit Car Incorporated
COC Number NCG030125
Craven County
Dear Permittee:
In response to your renewal application for continued coverage under stormwater General Permit NCG030000
the Division of Water Quality (DWQ) is forwarding herewith the reissued General Permit. This permit is
reissued pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of
Agreement between the state of North Carolina and the U.S. Environmental Protection Agency, dated October
15, 2007 (or as subsequently amended).
The following information is included with your permit package:
• A new Certificate of Coverage (COC)
• A copy of General Permit NCG030000
• A copy of the Technical Bulletin for the General Permit
• Two copies of the Discharge Monitoring Report (DMR) Form
• Two copies of the Qualitative Monitoring Report Form
The General Permit authorizes discharges of stormwater, and it specifies your obligations for discharge
controls, management, monitoring, and record keeping. Please review the new permit to familiarize yourself
with all the changes in the reissued permit. Your facility has six (6) months from the time of receipt of the
permit to update your current SPPP to reflect all new permit requirements.
The first sample period of your permit begins January 1, 2013. Your facility must sample a "measureable
storm event" beginning during the periods beginning January 1 and July 1 of every year (or, if applicable,
report "No Flow," as outlined in Part III, Section E). Also, please note that Tier 3 Actions in Part 11 of your
permit are triggered by benchmark exceedances on four occasions beginning on the effective date of this
permit and do not count prior exceedances.
The more significant changes in the General Permit since your last COC was issued are noted either in the
Draft Permit Fact Sheet that accompanied the public notice (http://Portal'ncdenr,org/web/wc[/ws/su/current-
notices), or in the Response to Comments / Summary of Changes and Technical Bulletin documents that are
posted on the Stormwater Permitting Unit's website with the new General Permit. Please visit
http://portal.ncdenr.orgjweb/wq/ws/sulnpdessw (click on 'General Permits' tab) to review that information
for your specific General Permit carefully.
1617 Mail Service Center, Raleigh, North Carolina 27699.1617
Location: 512 N. Salisbury St. Ralegh, North Carolina 27604
Phone: [phone] FAX: 91H07.6492
Intemet: www.ncwaterguality.org
An E,, ual Opportunity 4 Affirmative A • lion Employer
NorthCarolina
Naturally

i
Gary Barnes
December 4, 2012
Page 2 of 2
Some of the changes include:
Part II:
• Section A: The Stormwater Pollution Prevention Plan (SPPP) section, if applicable, has been updated
to the most current language of our permits. Additional conditions for specific industry sectors have
been added to the SPPP requirements in some cases.
• Sections B, C: Failure to perform analytical stormwater monitoring may result in the Division requiring
that the permittee begin a monthly sampling scheme.
• Sections B, C: A lower TSS benchmark of 50 mg/I for HQW, ORW, PNA and Tr Waters applies to these
more sensitive waters.
• Sections B, C: The monitoring parameter Oil & Grease (O&G) has been replaced by the parameter
Total Petroleum Hydrocarbons (TPH) for vehicle maintenance areas, and in some cases, other
analytical monitoring requirements.
• Sections 9, C, D: Inability to sample due to adverse weather must be recorded in the SPPP, or in
separate on -site records if your General Permit does not require an SPPP. Adverse weather is defined
in the "Definitions" section of the permit.
• Sections B, C: The term "Representative Storm Event" has been replaced by "Measurable Storm
Event." A measurable storm event is defined in the permit.
• Section D. If the permittee fails to respond effectively to problems identified by qualitative
monitoring, DWQ may require the permittee to perform corrective action.
Please review Parts III and IV to understand the Standard Conditions of your new NPDES General Permit,
including Compliance and Liability, Reporting, Monitoring and Records requirements; Operation and
Maintenance obligations; and Definitions. Please note that all samples analyzed in accordance with the terms
of this permit must be submitted to the Division on Discharge Monitoring Report (DMR) forms available on
the Stormwater Permitting Unit's website above. DMR forms must be delivered to the Division no later than
30 days from the date the facility receives the sampling results from the laboratory. Also note that existing
permittees do not need to submit a renewal request prior to expiration unless directed by the Division.
Your coverage under the General Permit is transferable only through the specific action of DWQ. This permit
does not affect the legal requirements to obtain other permits which may be required by DENR, nor does it
relieve the permittee from responsibility for compliance with any other applicable federal, state, or local law,
rule, standard, ordinance, order, judgment, or decree. if you have any questions regarding this permit
package, please contact the Division's Stormwater Permitting Unit at [phone].
Sincerely,
for Charles Wakild, P.E.
cc: DWQ Central Files
Stormwater Permitting Unit Flies
Washington Regional Office

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NC6030000
CERTIFICATE OF COVERAGE No. NCG030125
STORMWATER
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Frit Car & Equip Co
is hereby authorized to discharge stormwater from a facility located at:
Frit Car Incorporated
Hwy 17N
Bridgeton
Craven County
to receiving waters designated as Mills Branch, a class SC;Sw,NSW waterbody in the Neuse
River Basin in accordance with the effluent limitations, monitoring requirements, and other
conditions set forth in Parts 1, I1, III, and IV of General Permit No. NCG030000 as attached.
This certificate of coverage shall become effective December 4, 2012.
This Certificate of Coverage shall remain in effect for the duration of the General Permit
Signed this 4th day of December, 2012.
for Charles Wakild, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission
to

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, RE., Director
Division of Water Quality
August 23, 2002
AMY MADSEN
FRIT CAR INCORPORATED
PO BOX 1340
BREWTON, AL 36427
SubJect: NPDES Stormwater Permit Renewal
FRIT CAR INCORPORATED
COC Number NCG030125
Craven County
Dear Permittee:
In response to your renewal application for continued coverage under general permit NCG030000, the Division of
Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This permit is reissued
pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement
between the state of North Carolina and the U.S. Environmental Protection Agency, dated December 6, 1981
The following information is included with your permit package:
* A new Certificate of Coverage
* A copy of General Stormwater Permit NCG030000
* A copy of the Analytical Monitoring Form (DMR)
* A copy of a Technical Bulletin for the general permit
Your coverage under this general permit is not transferable except after notice to DWQ. The Division may require
modification or revocation and reissuance of the Certificate of Coverage. This permit does not affect the legal
requirements to obtain other permits which may be required by DENR or relieve the permittee from responsibility
for compliance with any other applicable federal, state, or local law, rule, standard, ordinance, order, judgment, or
decree.
If you have any questions regarding this permit package please contact Bill Mills of the Central Office Stormwater
and General Permits Unit at [phone], ext. 548
Sincerely,
Bradley Bennett, Supervisor
Stormwater and General Permits Unit
cc: Central Files
Stormwater & General Permits Unit Files
Washington Regional Office
N. C. Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 [phone]
®�GDE NNIt
Customer Service
1-800-623-7748

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG030000
CERTIFICATE OF COVERAGE No. NCG030125
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
FRIT CAR INC
is hereby authorized to discharge stormwater from a facility located at
FRIT CAR INCORPORATED
I-iWY 17 NORTH
BRIDGETON
CRAVEN COUNTY
to receiving waters designated as a UT to the Neuse River, a class C NSW stream, in the Neuse River Basin in
accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I, 1I,1II,
IV, V, and VI of General Permit No. NCG030000 as attached.
This certificate of coverage shall become effective September I, 2002.
This Certificate of Coverage shall remain in effect For the duration of the General Permit.
Signed this day August 23, 2002.
for Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

o�bN
WAr�9Q�
a--)rW "1
0 11� 1<
DARRELL MATTHEWS
FRIT CAR INCORPORATED
PO BOX 569
BRIDGETON, NC 28519
Dear Permittee:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Gregory J. Thorpe, Ph.D.
Acting Director
Division of Water Quality
December 27, 2001
Subject: NPDES Stormwater Permit Renewal
FRIT CAR INCORPORATED
COC Number NCG030125
Craven County
Your facility is currently covered for stormwater discharge under General Permit NCG030000. This permit expires
on August 31, 2002, The Division staff is currently in the process of rewriting this permit and is scheduled to have
the permit reissued by late summer of 2002. Once the permit is reissued, your facility would be eligible for
continued coverage under the reissued permit.
In order to assure your continued coverage under the general permit, you must apply to the Division of Water
Quality (DWQ) for renewal of your permit coverage. To make this renewal process easier, we are informing you in
advance that your permit will be expiring. Enclosed you will find a General Permit Coverage Renewal
Application Form. The application must be completed and returned by March 4, 2002 in order to assure continued
coverage under the general permit.
Failure to request renewal within this time period may result in a civil assessment of at least $250.00. Larger
penalties may be assessed depending on the delinquency of the request. Discharge of stormwater from your facility
without coverage under a valid stormwater NPDES permit would constitute a violation of NCGS 143-215. l and
could result in assessments of civil penalties of up to $10,000 per day.
Please note that recent federal legislation has extended the "no exposure exclusion" to all operators of industrial
facilities in any of the I l categories of "storm water discharges associated with industrial activity," (except
construction activities). If you feel your facility can certify a condition of "no exposure", i.e. the facilty industrial
materials and operations are not exposed to stormwater, you can apply for the no exposure exclusion, For additional
information contact the Central Office Stormwater Staff member listed below or check the Stormwater & General
Permits Unit Web Site at http://h2o.enr.stato.ne.us/su/stormwater.htinI
If the subject stormwater discharge to waters of the state has been terminated, please complete the enclosed
Rescission Request Form. Mailing instructions are listed on the bottom ol'the form. You will be notified when the
rescission process has been completed.
If you have any questions regarding the permit renewal procedures please contact Robert Tankard of the
Washington Regional Office at 252-946-6491 or Bill Mills of the Central Office Stormwater Unit at (919)
733-5083, ext. 548
Sincerely,-`�
Bradley Bennett, Supervisor
Stormwater and General Permits Unit
cc: Central Files
Washington Regional Office
TA
NCDENR
N. C. Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 [phone] Customer Service
1- 800.623.7748

State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Water Quality 4 •
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary I G F'NJ F1
A. Preston Howard, Jr., P.E., Director
September 24, 1997
MR. DARRELL MATTHEWS
FRIT CAR INC
PO BOX 569 HIGHWAY 17 NORTH
BRIDGETON, NC 28519
Subject: Reissued Stormwater General Permit for Certificate of Coverage No. NCG030125
Craven County
Dear Permittee:
In response to your renewal application for continued coverage under the subject permit, the Division
of Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This permit
is reissued pursuant to the requirements of North Carolina General Statute 143-215 .1 and the
Memorandum of Agreement between North Carolina and the US Environmental Protection agency
dated December 6, 1983.
The following information is included with your permit package:
■ A copy of the stormwater general permit.
■ A Stormwater Pollution Prevention PIan Certification Form. This form certifies that you have
developed and implemented the Stormwater Pollution Prevention Plan (SPPP) required in your
permit. This form must be completed and returned to the Division within 30 days of receipt of
this letter. DO NOT send the SPPP with the signed form.
■ Five copies of Analytical Monitoring forms.
■ Five copies of Qualitative Monitoring forms.
■ A copy of a Technical Bulletin on the stormwater program with outlines program components
and addresses frequently asked questions.
■ A corrected Certificate of Coverage if you indicated a name or address change on the Renewal
Form returned to the Division.
Your certificate of coverage is not transferable except after notice to DWQ. The Division of Water
Quality may require modification or revocation and reissuance of the certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be required by
DWQ or permits required by the Division of Land Resources, Division of Air Quality, Coastal Area
Management Act or any other Federal or Local governmental permits that may be required.
If you have any questions concerning this permit or other attached documents, please contact the
Stormwater Group at telephone number [phone]
Sincerely,
for
A. Preston Howard, Jr., P. E.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, 'Secretary
A. Preston Howard, Jr., P.E., Director
May 28, 1993
Mr. Darrell Matthews
Frit Car, Inc.
P0Box 569
Bridgeton, NC 28519
LT!?FA
Ar4jron
E:)EHNFl
Subject: General Permit No, NCG030000
Frit Car, Inc.
COC NCG030125
Craven County
Dear Mr. Matthews:
In accordance with your application for discharge permit received on October . 2, 1992, we are
forwarding herewith the subject certificate of coverage to discharge under the subject state - NPDES general
permit. This permit is issued pursuant to the requirements of North Carolina General Statute 143-215 .1 and the
Memorandum of Agreement between North Carolina and the US Environmental Protection agency dated
December 6, 1983.
If any pans, measurement frequencies or sampling requirements contained in -this permit are
unacceptable to you, you have the right to request an individual permit by submitting an individual permit
application. Unless such demand is made, this certificate of coverage shall be final and binding.
Please take notice that this certificate of coverage is not transferable except after notice to the Division
of Environmental Management. The Division of Environmental Management may require modification or
revocation and reissuance of the certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be required by the
Division of Environmental Management or permits required by the Division of Land Resources, Coastal Area
Management Act or any other Federal or Local governmental permit that may be required.
If you have any questions concerning this permit, please contact Mr. Steve Ulmer at telephone number 919n33-
5083.
cc:
Sincerely,
Original Signed BY
Coleen H. Sullins
A. Preston Howard, Jr., P. E.
Washington Regional Office
P.O. Box 29535, Raleigh, Forth Carolina 27626.0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL RESOURCES
DIVISION OF ENVIRONMENTAL MANAGEMENT
STORMWATER DISCHARGES
In compliance with the provision of North Carolina General Statute 143-215,1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
Frit Car, Inc.
is hereby authorized to discharge stormwater from a facility located at
Frit Car, Inc.
US Highway 17 North, approximately three (3) miles north of Bridgeton
Bridgeton
Craven County
to receiving waters designated as the Neuse River in the Neuse River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, III
and IV of General Permit No. NCG0300M as attached.
This Cenificate of Coverage shall become effective May 28, 1993.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day May 28, 1993.
Original Signed By
Coleen H. Sullins
A. Preston Howard, Jr., P.E., Director
Division of Environmental Management
By Authority of the Environmental Management Commission

XX
Ce
LA
//`5
1
j7
. �'..._
'o
11
wes Corti `
Antioch:
Chum
lc
\ts ��;em�Forest
i5Ir
Strip
u
16
BR
M
'� �
,4
�•,lSi} � •\
!1
i���
• � �'
_�,y��si, .:.
3�e
�_`�
.`
�.\
l,l
`\
� i�-
i �•
E.� ��1�'
V
If N
if It
�
1
14
_. \ \tom
.~_ _ �\
a`� •
�
'�:
�--�
�
5
��a;% •�a`;
=H•
I _� �,..
• ! f (_f --fir �
+`(pmN
rs _ \ e
3e91
Wildlife
Land
�uiFark
IfilS
f\�jr1
���
CD
` ties ��•
Boat
\,,\ Ramp
` 1
\
�. r..
� rCem�S,`.� � 2 •..
�`
ell
l�!
• ���
Dicker os
�•`\�/
3590
fryFerry
f... \ \\
7�_
3 y_
�- per/ y
r,.
adio i4wer _
\
�y ����
o
_ 0-1.

FACILITY F CA, 1N�
COUNTY C Vaw
NPDES
Q C)5D �25
MAP
DSN FLOW N /Ar
SUE BASIN
!ATTITUDE
LONGITUDE
RECEIVING STREAk
S
STREAM CLASS
DISCHARGE CLASS
EXPIRATION DATE
03 - o4- - l o
c N Q AM�i7 77z_4 Fc {7WyZ�/ TD
C_ k45 h/
S'T orz M W A7EIZ-
n8-3/-q-�
9