HomeMy WebLinkAboutNC0072125_Draft Permit_20191016 ROY COOPER
Un, inn
MICHAEL S. REGAN
4. / LINDA CULPEPPER
NORTH CAROLINA
Environmental Quality
October 16,2019
Ms.Rochelle Small-Toney
City of Rocky Mount
331 S Franklin St
Rocky Mount,N.C. 27804
Subject: DRAFT NPDES PERMIT NC0072125
Tar River WTP
Grade 1 PC WPCS [15A NCAC 08G.0306]
Nash County
Dear Ms. Small-Toney:
Enclosed with this letter is a copy of the draft permit for your facility. Please review the draft very carefully
to ensure thorough understanding of the conditions and requirements it contains. Your permit is among
several in the Tar Pamlico River Basin that the Division has targeted for expedited renewal.
This draft contains the following changes from the existing permit:
• HUC and Stream Index#were added to outfall description on supplement to cover page
• Iron monitoring requirements were removed from the effluent characteristics table. There is no longer an
action level standard for iron.
• Manganese monitoring requirements were removed from the effluent characteristics table.
• Turbidity monitoring requirements were reduced from weekly to 2/month.
• The language in section A.(3.) has been updated to be consistent with the finalization of federal
requirements for electronic reporting.
• A previous footnote citing the need to sample metals concurrent with WET testing has been removed—this
is no longer required.
• Regulatory citations for permit requirements have been added throughout the permit.
With this notification,the Division will solicit public comment on this draft permit by publishing a notice
in newspapers having circulation in the general Nash County area,per EPA requirements. Please provide
your comments, if any,to me no later than 30 days after receiving this draft permit.
Following the 30-day public comment period, the Division will review all pertinent comments and take
appropriate action prior to issuing a final permit. If you have questions concerning the draft,please contact
me via email at [emily.delduco@ncdenr.gov] or call 919-707-9125.
Sincerely,
Emily DelDuco
Environmental Specialist II
NPDES Program
cc: NPDES files
ec: WSS Aquatic Toxicity/Cindy Moore
PWS/Allen Hardy
North Carolina Department of Environmental Quality I Division of Water Resources
1617 Mail Service Center I Raleigh,North Carolina 27699-1617
919-707-9125
NPDES Permit NC0072125
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENTAL QUALITY
DIVISION OF WATER RESOURCES
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
(NPDES)
In compliance with the provisions of North Carolina General Statute 143-215.1, other lawful standards
and regulations promulgated and adopted by the North Carolina Environmental Management
Commission, and the Federal Wat ution Control Act, as amended,the
City of Rocky Mount
is hereby authorized to discharge treated wastewater from a facility known as
Tar River Water Treatment Plant (WTP)
4489 Leaston Road, Rocky Mount
Nash County
to receiving waters designated as the Tar River, within the Tar-Pamilco River Basin, in accordance with
effluent limitations,monitoring requirements, and other applicable conditions set forth in Parts I, II, III,
and IV hereof.
The permit shall become effective
This permit and the authorization to discharge shall expire at midnight on October 31, 2024.
Signed this day
Linda Culpepper,Director
Division of Water Resources
By Authority of the Environmental Management Commission
Page 1of7
NPDES Permit NC0072125
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility,whether for operation or discharge are hereby revoked,and as of this
issuance,any previously issued permit bearing this number is no longer effective.Therefore,the exclusive authority to operate
and discharge from this facility arises under the permit conditions,requirements,terms,and provisions described herein.
City of Rocky Mount
is hereby authorized to:
1. continue to operate a conventional technology water treatment plant [coagulation, flocculation,
sedimentation, and filtration] with discharge of wastewaters from media filter backwash and
sedimentation basins with a design potable flowrate of 12 MGD and a current maximum monthly
average wastewater discharge of 0.63 MGD. This facility is located at the Tar River WTP (Rocky
Mount,Nash County), with water and wastewater treatment which includes the following
components;
• flash mixer/contact structure [18,300 gallons]
• two (2) 0.9 MG flocculators & sedimentation basins
• six(6) sand and anthracite filters
• two (2) 1.0 MG clearwells
• two(2) 0.27 MG Trac Vac Basins
• dechlorination equipment
• chemical usage consists of
o ferric sulfate
o fluoride
o chloramines
o sodium hydroxide
o calcium hydroxide
o polymer
o gaseous chlorine(stored in liquid state in "ton" containers)
o calcium thiosulfate
o silica polyphosphate
2. discharge from said treatment works via Outfall 001 at a location specified on the attached map,
into Tar River [HUC: 030201010606; Stream Segment 28-(64.5)], currently a Class WS-IV;NSW
waterbody within Subbasin 03-03-02 of the Tar-Pamilco River Basin.
Page 2 of 7
NPDES Permit NC0072125
PART I
A. (1.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
[15A NCAC 02B.0400 et seq., 02B.0500 et seq.]
Grade 1 Physical Chemical WPCS [15A NCAC 08G .0306]
During the period beginning on the effective date of this permit and lasting until expiration, the
Permittee is authorized to discharge filter backwash via Outfall 001. Such discharges shall be limited
and monitored' by the Permittee as specified below:
LIMITS MONITORING REQUIREMENTS '
EFFLUENT
CHARACTERISTICS Monthly Daily Measurement Sample Sample
[EDMR CODES]
Average Maximum Frequency Type Location
Flow(MGD) 50050 Continuous Recording Effluent
Total Suspended Solids (TSS) (mg/L) C0530 30.0 mg/L 45.0 mg/L Weekly Grab Effluent
Turbidity(NTU) 00070 2/Month Grab Effluent
Total Residual Chlorine(TRC)2 (pg/L) 50060 28 pg/L Weekly Grab Effluent
pH (su) 00400 Not<6.0 or>9.0 Weekly Grab Effluent
standard units
Total Fluoride (mg/L) 00951 Quarterly Grab Effluent
Ammonia Nitrogen (NH3 as N) (mg/L) C0610 Quarterly Grab Effluent
Total Phosphorous (TP) (mg/L) C0665 Quarterly Grab Effluent
Total Nitrogen (TN) (mg/L) C0600 Quarterly Grab Effluent
Chronic WET Testing 3 TGP3B Quarterly Grab Effluent
Footnotes:
1. The permittee shall submit discharge monitoring reports electronically using NC DWR's eDMR
system. See Special Condition A. (3).
2. The Division shall consider TRC effluent values reported below 50 µg/L to be compliant with
the permit. However, the Permittee shall continue to record and submit all values reported by a
North Carolina-certified laboratory method (including field certified), even if these values fall
below 50µg/L.
3. Whole Effluent Toxicity(WET) testing- testing of Ceriodaphnia dubia shall be performed as 7-day
pass/fail test at 6% effluent concentration, during January, April,July and October [See A. (2.)].
Samples shall be taken at the outfall but prior to mixing with the receiving waters.
There shall be no discharge of floating solids or foam in other than trace amounts.
Page 3 of 7
NPDES Permit NC0072125
A. (2.) CHRONIC TOXICITY PASS/FAIL MONITORING (QUARTERLY)
[15A NCAC 02B.0200]
The permittee shall conduct quarterly chronic toxicity tests using test procedures outlined in the"North
Carolina Ceriodaphnia Chronic Effluent Bioassay Procedure,"Revised December 2010, or subsequent
versions.
The effluent concentration defined as treatment two in the procedure document is 6%. The testing shall
be performed as a Ceriodaphnia dubia 7-day pass/fail test. The tests will be performed during the
months of January,April,July and October. These months signify the first month of each three
month toxicity testing quarter assigned to the facility. Effluent sampling for this testing must be
obtained during representative effluent discharge and shall be performed at the NPDES permitted final
effluent discharge below all treatment processes.
All toxicity testing results required as part of this permit condition will be entered on the Effluent
Discharge Monitoring Form (MR-1) for the month in which it was performed,using the parameter code
TGP3B. Additionally, DWR Form AT-1 (original) is to be sent to the following address:
Attention: North Carolina Division of Water Resources
Environmental Sciences Section
1621 Mail Service Center
Raleigh,N.C. 27699-1621
Completed Aquatic Toxicity Test Forms shall be filed with the Environmental Sciences Section no later
than 30 days after the end of the reporting period for which the report is made.
Test data shall be complete and accurate and include all supporting chemical/physical measurements
performed in association with the toxicity tests, as well as all dose/response data. Total residual chlorine
of the effluent toxicity sample must be measured and reported if chlorine is employed for disinfection of
the waste stream.
Should there be no discharge of flow from the facility during a month in which toxicity monitoring is
required,the permittee will complete the information located at the top of the aquatic toxicity(AT)test
form indicating the facility name,permit number,pipe number, county, and the month/year of the report
with the notation of"No Flow"in the comment area of the form. The report shall be submitted to the
Environmental Sciences Section at the address cited above.
Should the permittee fail to monitor during a month in which toxicity monitoring is required, then
monthly monitoring will begin immediately. Upon submission of a valid test, this monthly test
requirement will revert to quarterly in the months specified above.
Should any test data from this monitoring requirement or tests performed by the North Carolina Division
of Water Resources indicate potential impacts to the receiving stream,this permit may be re-opened and
modified to include alternate monitoring requirements or limits.
If the Permittee monitors any pollutant more frequently then required by this permit, the results of such
monitoring shall be included in the calculation&reporting of the data submitted on the DMR& all AT
Forms submitted.
Page 4 of 7
NPDES Permit NC0072125
NOTE: Failure to achieve test conditions as specified in the cited document, such as minimum control
organism survival,minimum control organism reproduction, and appropriate environmental controls,
shall constitute an invalid test and will require immediate follow-up testing to be completed no later
than the last day of the month following the month of the initial monitoring.
A. (3.) ELECTRONIC REPORTING OF DISCHARGE MONITORING REPORTS
[G.S. 143-215.1(B)]
Federal regulations require electronic submittal of all discharge monitoring reports (DMRs) and program
reports. The final NPDES Electronic Reporting Rule was adopted and became effective on December
21, 2015.
NOTE: This special condition supplements or supersedes the following sections within Part II of this
permit(Standard Conditions for NPDES Permits):
• Section B. (11.) Signatory Requirements
• Section D. (2.) Reporting
• Section D. (6.) Records Retention
• Section E. (5.) Monitoring Reports
1. Reporting Requirements (Supersedes Section D. (2.) and Section E. (5.) (a)1
The permittee shall report discharge monitoring data electronically using the NC DWR's Electronic
Discharge Monitoring Report (eDMR) internet application.
Monitoring results obtained during the previous month(s) shall be summarized for each month and
submitted electronically using eDMR. The eDMR system allows permitted facilities to enter
monitoring data and submit DMRs electronically using the internet. Until such time that the state's
eDMR application is compliant with EPA's Cross-Media Electronic Reporting Regulation
(CROMERR),permittees will be required to submit all discharge monitoring data to the state
electronically using eDMR and will be required to complete the eDMR submission by printing,
signing, and submitting one signed original and a copy of the computer printed eDMR to the
following address:
NC DEQ/Division of Water Resources/ Water Quality Permitting Section
ATTENTION: Central Files
1617 Mail Service Center
Raleigh,North Carolina 27699-1617
If a permittee is unable to use the eDMR system due to a demonstrated hardship or due to the facility
being physically located in an area where less than 10 percent of the households have broadband
access,then a temporary waiver from the NPDES electronic reporting requirements may be granted
and discharge monitoring data may be submitted on paper DMR forms(MR 1, 1.1, 2, 3)or
alternative forms approved by the Director. Duplicate signed copies shall be submitted to the
mailing address above. See"How to Request a Waiver from Electronic Reporting"section below.
Regardless of the submission method,the first DMR is due on the last day of the month following
the issuance of the permit or in the case of a new facility, on the last day of the month following the
commencement of discharge.
Page 5 of 7
NPDES Permit NC0072125
Starting on December 21,2020,the permittee must electronically report the following compliance
monitoring data and reports,when applicable:
• Sewer Overflow/Bypass Event Reports;
• Pretreatment Program Annual Reports; and
• Clean Water Act(CWA) Section 316(b) Annual Reports.
The permittee may seek an electronic reporting waiver from the Division(see"How to Request a
Waiver from Electronic Reporting" section below).
2. Electronic Submissions
In accordance with 40 CFR 122.41(1)(9),the permittee must identify the initial recipient at the time
of each electronic submission. The permittee should use the EPA's website resources to identify the
initial recipient for the electronic submission.
Initial recipient of electronic NPDES information from NPDES-regulated facilities means the entity
(EPA or the state authorized by EPA to implement the NPDES program)that is the designated entity
for receiving electronic NPDES data [see 40 CFR 127.2(b)].
EPA plans to establish a website that will also link to the appropriate electronic reporting tool for
each type of electronic submission and for each state. Instructions on how to access and use the
appropriate electronic reporting tool will be available as well. Information on EPA's NPDES
Electronic Reporting Rule is found at: http://www2.epa.gov/compliance/final-national-pollutant-
discharge-elimination-system-npdes-electronic-reporting-rule.
Electronic submissions must start by the dates listed in the"Reporting Requirements" section above.
3. How to Request a Waiver from Electronic Reporting
The permittee may seek a temporary electronic reporting waiver from the Division. To obtain an
electronic reporting waiver, a permittee must first submit an electronic reporting waiver request to
the Division. Requests for temporary electronic reporting waivers must be submitted in writing to
the Division for written approval at least sixty(60) days prior to the date the facility would be
required under this permit to begin submitting monitoring data and reports. The duration of a
temporary waiver shall not exceed 5 years and shall thereupon expire. At such time,monitoring data
and reports shall be submitted electronically to the Division unless the permittee re-applies for and is
granted a new temporary electronic reporting waiver by the Division. Approved electronic reporting
waivers are not transferrable. Only permittees with an approved reporting waiver request may
submit monitoring data and reports on paper to the Division for the period that the approved
reporting waiver request is effective.
Information on eDMR and the application for a temporary electronic reporting waiver are found on
the following web page:
http://deq.nc.gov/about/divisions/water-resources/edmr
Page 6 of 7
NPDES Permit NC0072125
4. Signatory Requirements [Supplements Section B. (11.) (b) and Supersedes Section B. (11.)
(d)1
All eDMRs submitted to the permit issuing authority shall be signed by a person described in Part II,
Section B. (11.)(a) or by a duly authorized representative of that person as described in Part II,
Section B. (11.)(b). A person, and not a position, must be delegated signatory authority for eDMR
reporting purposes.
For eDMR submissions, the person signing and submitting the DMR must obtain an eDMR user
account and login credentials to access the eDMR system. For more information on North
Carolina's eDMR system, registering for eDMR and obtaining an eDMR user account, please visit
the following web page:
http://deq.nc.gov/about/divisions/water-resources/edmr
Certification. Any person submitting an electronic DMR using the state's eDMR system shall make
the following certification [40 CFR 122.22]. NO OTHER STATEMENTS OF CERTIFICATION
WILL BE ACCEPTED:
"I certify, under penalty of law, that this document and all attachments were prepared under my
direction or supervision in accordance with a system designed to assure that qualified personnel
properly gather and evaluate the information submitted. Based on my inquiry of the person or
persons who manage the system, or those persons directly responsible for gathering the information,
the information submitted is, to the best of my knowledge and belief true, accurate, and complete. I
am aware that there are significant penalties for submitting false information, including the
possibility of fines and imprisonment for knowing violations."
5. Records Retention [Supplements Section D. (6.)l
The permittee shall retain records of all Discharge Monitoring Reports, including eDMR
submissions. These records or copies shall be maintained for a period of at least 3 years from the
date of the report. This period may be extended by request of the Director at any time [40 CFR
122.41].
Page 7 of 7
f l " • rrn ., �\ r rap -
I/ \ll s
_ ''I ' _./ fi p. \ J/ c h �'
Sra r �
1 l /• -.. y9� j;�t3 -. • ++�4sOi1tSL1T� ..
it West Mount Dr - .�-s"`k -;; i / - `�, •• • - '
•
�_�( (NCSR 1717) • :" '% r / • -- : '�` . ,(1 est Ma
Rr!Ste 'i '
i t — \ j ii (1717 y�i
I Sc) /• \� li �4��
/ '--- Approximate 0 <<i 1 r \i t1
Facility Boundary ` ( _ �� , % ! p . o
fD `-�
VS
t<s
\ / t.i : i ' %Am� /na/ oa 11 ��+s
/ -rr • 110,1110 -, --vr,,,,, 1 . ./ , - , Ac..=....,...is.... a arm amp==‘",:,...-
:• ° r.67 "fir \ a _ _ �,�'O \, .. _
\Y Oa ,��__ _ - FIIBIstion/� 1_ar: ` i '
O /67 ' ()Trim
mt r, ,*plot
_ • r \._. 1 '' `��S r�
/
r a k •' J 'f j( i
i76• j �' - , r 1 l •
lJf • 1lI • r 1 '' ('; !
\ \ t
, - -s1 1" f �,,(1- - R j V E R. 9,,' ,,-",...ii �. '` 'k\ \•- ) r
-sk
—) / _ ` :/ },��\ ✓ ` ,/' * --� -t- 14 .-- to ink
�_ / It , ' ; .11 Tar River --s ro ,"-
9- , e a [flows east] �. .r„
Tar River Mills 6s -- -'�, �'I i ,/ _ .. _ - / -_'t, p /. `
j _. 1 ,3 I ` • c.
Dam `` S , �//„0.--/, ;•�,7•b , ' Outfall 001 -,
/�,, �� �' a�°� it
: g _,/ s (flows east) IP -
•„ \
1 11. .CP )_. e �i I` -----Y f u
II
1 ui��
)" _,)/)Stic)
I7t5 ` Y IIJfiak
�\ .iio�� 1 t i �f
:, i ‘r \ \ _ , . .. . 1 )2 L.
{ -- �- ;. �0 _ .0 NC Hwy 97j.\.,,,, -•• an ,\ A.
- ______ --,_. le. ...- .i )) CA(t.7-\ ...... \'‘..-\----7-------:-. --- ..,,L.' ,,,_ „.../...-
a i' o rn , -- 7 e -.'" '\ ,. _
H ! g—c - IJ sue'r ' µ L *1`{ } . i _Y n
` - r
City of Rocky Mount-Tar River
Facility �,�} '!; ,rff� --
Water Treatment Plant (WTP) . viki .II`f-Atz•Nr
4489 Leaston Road, Rocky Mount 27802 Location a, � inv '.
Receiving Stream: Tar River Stream Segment: 28-(64.5) Scale 1:24,000 ,eA'
Drainage BasinBasin: Tar-Pamlico River Basin Sub-Basin: 03-03-02
Latitude: 35°54'02" Longitude: 77°52'59" NPDES Permit NC0072125
Stream Class: WS-IV;NSW HUC: 03020101 North
State Grid/USGS Quad: D27NW/Nashville,NC Nash County