The URL can be used to link to this page

Home My WebLink About43F_WeeksLCID_PTCCell2_PTOCell1&2_DIN24422_20150602 Facility Permit No: 43F-LCID-2010 Weeks Sandpit No. 2 June 2, 2015 Document ID No. 24422 Page 1 of 9 North Carolina Department of Environment and Natural Resources Division of Waste Management Pat McCrory Donald R. van der Vaart Governor Secretary 1646 Mail Service Center, Raleigh, North Carolina 27699-1646 Phone: 919-707-8200 \ Internet: http://portal.ncdenr.org/web/wm/sw An Equal Opportunity / Affirmative Action Employer STATE OF NORTH CAROLINA DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES DIVISION OF WASTE MANAGEMENT SOLID WASTE SECTION LAND CLEARING AND INERT DEBRIS (LCID) LANDFILL PERMIT NO. 43F-LCID-2010 WEEKS SANDPIT NO. 2 is hereby issued a PERMIT TO CONSTRUCT WEEKS SANDPIT NO. 2 CELL 2 and PERMIT TO OPERATE WEEKS SANDPIT NO. 2 CELL 1 and 2 Located at 20710 N.C. Highway 24/27 near Cameron, Harnett County, North Carolina in accordance with Article 9, Chapter 130A, of the General Statutes of North Carolina and all rules promulgated thereunder and subject to the conditions set forth in this permit. The legal description of the site is identified on the deeds recorded for this property listed in Attachment No. 1 of this permit. Edward F. Mussler, III, P.E., Permitting Branch Supervisor Permitting Branch Solid Waste Section Facility Permit No: 43F-LCID-2010 Weeks Sandpit No. 2 June 2, 2015 Document ID No. 24422 Page 2 of 9 ATTACHMENT 1 PART I: PERMITTING HISTORY Permit Date Date of Original Issue Permit to Construct/Operate Phase 1 (DIN 9740) February 19, 2010 Administrative Correction of Permit Number March 15, 2010 Permit to Construct Cell 2 Permit to Operate Cell 1 and 2 (DIN 24422) June 2, 2015 PART II: LIST OF DOCUMENTS FOR THE APPROVED PLAN 1. Application for LCID Landfill Permit. Prepared by: RWK, PA, Garner, NC. Prepared for: Weeks Sandpit No. 2, Broadway, NC. March 12, 2009, (DIN 9728) revised February 8 and 11, 2010 (DINs 9729 and 9731) 2. 2013 Permit Renewal & Modification. Prepared by: C.T. Clayton, Sr., P.E., Inc. for: Weeks Sandpit No. 2, Broadway, NC. November 6, 2013 (DIN 20206) PART III: PROPERTIES APPROVED FOR THE SOLID WASTE FACILITY PIN Book Page Acreage Grantor Grantee 9565-38-1737.000 1837 940-944 70.54 Joseph S. Weeks J.S. Weeks Sand, Inc. 9566-20-9752.000 1837 940-944 43.20 Joseph S. Weeks J.S. Weeks Sand, Inc. 9565-39-3022.000 1837 940-944 1.14 Joseph S. Weeks J.S. Weeks Sand, Inc. 9565-38-2888.000 1837 940-944 0.69 Joseph S. Weeks J.S. Weeks Sand, Inc. Total Site Acreage: 115.57 Note: Deed book reference is from Harnett County, NC Register of Deeds office. Facility Permit No: 43F-LCID-2010 Weeks Sandpit No. 2 June 2, 2015 Document ID No. 24422 Page 3 of 9 PART IV: GENERAL PERMIT CONDITIONS 1. This permit is issued by the North Carolina Department of Environment and Natural Resources, Division of Waste Management, Solid Waste Section (Section). In accordance with North Carolina Solid Waste Management Rule 15A NCAC 13B .0201(e), a land clearing and inert debris solid waste management facility permit may be combined in two parts: a Permit to Construct and a Permit to Operate. a. The Permit to Construct shall expire September 17, 2020. The Permit to Construct conditions are contained in Attachment 2 of this permit. b. The Permit to Operate shall expire September 17, 2020. The Permit to Operate conditions are contained in Attachment 3 of this permit. 2. The persons to whom this permit is issued ("permittee") are the owners and operators of the solid waste management facility. 3. The Permit to Construct and Operate for this facility, dated March 15, 2010, was recorded by the Harnett County Register of Deeds on March 29, 2010 in Book 2727 on Pages 103-114 (DIN 10255). 4. When this property is sold, leased, conveyed, or transferred in any manner, the deed or other instrument of transfer must contain in the deed description section, in no smaller type than that used in the body of the deed or instrument, a statement that the property has been used as a land clearing and inert debris landfill and a reference by book and page to the recordation of the permit. 5. By beginning construction or receiving waste at this facility the permittee shall be considered to have accepted the terms and conditions of this permit. 6. Construction and operation of this solid waste management facility must be in accordance with the Solid Waste Management Rules, 15A NCAC 13B, Article 9 of Chapter 130A of the North Carolina General Statutes (NCGS 130A-290, et seq.), the conditions contained in this permit; and the approved plan. Should the approved plan and the rules conflict, the Solid Waste Management Rules shall take precedence unless specifically addressed by permit condition. Facility Permit No: 43F-LCID-2010 Weeks Sandpit No. 2 June 2, 2015 Document ID No. 24422 Page 4 of 9 7. The permit is issued based on the documents submitted in support of the application for permitting the facility including those identified in Attachment 1, "List of Documents for Approved Plan," and which constitute the approved plan for the facility. Where discrepancies exist, the most recent submittals and the Conditions of Permit shall govern. 8. This permit may be transferred only with the approval of the Section, through the issuance of a new or substantially amended permit in accordance with applicable statutes and rules. In accordance with NCGS 130A-295.2(g), the permittee must notify the Section thirty (30) days prior to any significant change in the identity or business structure of either the owner or the operator, including but not limited to, a proposed transfer of ownership of the facility or a change in the parent company of the owner or operator of the facility. 9. The permittee is responsible for obtaining all permits and approvals necessary for the development of this project including approval from appropriate agencies for sedimentation and erosion control, and a General or Individual National Pollutant Discharge Elimination System (NPDES) Stormwater Discharge Permit, if applicable. Issuance of this permit does not remove the permittee's responsibilities for compliance with any other local, state or federal rule, regulation or statute. - End of Section - Facility Permit No: 43F-LCID-2010 Weeks Sandpit No. 2 June 2, 2015 Document ID No. 24422 Page 5 of 9 ATTACHMENT 2 CONDITIONS OF PERMIT TO CONSTRUCT PART I: FACILITY SPECIFIC CONDITIONS 1. Pursuant to the NC Solid Waste Management Rules (Rule) 15A NCAC 13B .0201(c) and (e), this permit approves construction of Cell 2 of the Weeks Sandpit No. 2. 2. The landfill is permitted for a total gross capacity of 489,418 cubic yards. Gross capacity is the measured volume between the bottom of waste and the top of final cover. Development of the landfill is approved as summarized below: Area Acreage Capacity Status (cubic yards) Cell 1 7.25 202,239 Permitted & Constructed Cell 2 5.59 202,239 Permitted Cell 3 2.35 84,940 Proposed Totals 15.19 489,418 *Applications must be submitted to the Department for review and approval prior to the Construction and Operation of Cell 3. 3. The following are required prior to receiving solid waste in a new cell: a. Written certification from a Registered Professional Engineer must be submitted to the Section certifying that the waste disposal unit(s) has been constructed in accordance with the approved plans. b. A sign must be posted at the entrance as required by the NC Solid Waste Management Rules Operational Requirements, 15A NCAC 13B .0566(16). c. The disposal unit boundary must be accurately identified with permanent markers. d. A site inspection and pre-operative meeting must be conducted by a representative of the Section. The permittee must notify the Section’s Environmental Senior Specialist and make arrangements for the site inspection and pre-operative meeting. e. After completion of the requirements in subparagraphs a. through d. above, the Section Environmental Senior Specialist shall notify the Permitting Branch Supervisor by letter or email that the pre-operative requirements have been Facility Permit No: 43F-LCID-2010 Weeks Sandpit No. 2 June 2, 2015 Document ID No. 24422 Page 6 of 9 met and that the unit(s) may commence receiving waste. The permittee will be copied on the notification and may begin receiving waste at that time. EROSION AND SEDIMENTATION CONTROL REQUIREMENTS 4. All earth disturbing activities must be conducted in accordance with the Sedimentation Pollution Control Act of 1973 (15 NCAC 4) and consistent with any other local, state or federal requirements. 5. Facility construction, operations or practices must not cause or result in a discharge of pollution, dredged material, and/or fill material into waters of the state in violation of the requirements under Sections 401 and 404 of the Clean Water Act, as amended. 6. Modifications to the approved sedimentation and erosion control activities require approval by the North Carolina Land Quality Section. The permittee must notify the Section of any sedimentation and erosion control plan modifications. - End of Section - Facility Permit No: 43F-LCID-2010 Weeks Sandpit No. 2 June 2, 2015 Document ID No. 24422 Page 7 of 9 ATTACHMENT 3 CONDITIONS OF PERMIT TO OPERATE PART I: FACILITY SPECIFIC CONDITIONS 1. This Permit to Operate expires September 17, 2020. Pursuant to 15A NCAC 13B .0201(g), no later than March 17, 2020, the owner or operator must submit a request to the Section for permit review and must submit updated facility plans meeting the requirements of Rule 0.565 and .0566. 2. This facility must conform to the operational requirements of the NC Solid Waste Management Rules, 15A NCAC 13B .0566, and to the operational plan required by 15A NCAC 13B .0565(4). 3. This Permit to Operate authorizes the operation of Cell 1 and 2 at the LCID Landfill when the Permittee has complied with the conditions contained in Attachment 2. Cell 3 is not permitted for operation under this permit, but may be permitted to operate when construction is certified in accordance with the approved plan referenced in Attachment 1, Part II, of this permit and approved by the Division. 4. This facility is permitted to receive land clearing waste; yard trash; untreated and unpainted wood; uncontaminated soil; inert debris such as unpainted rock, brick, concrete, and concrete block; and asphalt in accordance with NCGS 130-294(m). 5. This facility is permitted to receive waste generated within Harnett County, Wake County, Johnston County, Cumberland County, Sampson County, Moore County and Lee County. Proposed changes to the service area must be submitted to the Section for review prior to any changes in accordance with Condition No. 9 of this Attachment 6. The permanent markers that accurately delineate the waste disposal boundary must be maintained. 7. Excavation, grading and fill material side slopes must not exceed a ratio of three horizontal feet to one vertical feet (3:1). 8. Open burning of land clearing waste is prohibited. If a fire occurs, the permittee must provide oral notification to the Section within 24 hours of the occurrence followed by a written report of the details of the fire within 10 working days of the occurrence. The report must include the cause, the location(s) on the premises, the dimensions and Facility Permit No: 43F-LCID-2010 Weeks Sandpit No. 2 June 2, 2015 Document ID No. 24422 Page 8 of 9 volume of material involved, a description of emergency response activities with results, and a description of mitigation measures implemented to reduce or eliminate conditions leading to the fire. Other conditions may be required based on the severity or nature of the fire. 9. Revisions to the design or operation of the facility or changes to the facility service area must be submitted to the Section for review and approval prior to the implementation of any changes. Revisions or changes that require modification to the permit will be subject to the appropriate permitting fee. 10. Amendments or revisions to the NC General Statutes or to the NC Solid Waste Management Rules or any violation of ground water standards may necessitate modification of the approved design or operation plans, waste acceptance requirements or may require closure of the facility. Cover Material Requirements 11. Solid waste must be covered with 1 foot of suitable soil cover at least once per month or when the active area reaches 1 acre in size, whichever occurs first, or more often when necessary to prevent the site from becoming a nuisance or to mitigate conditions associated with fire, windblown materials, vectors or excessive water infiltration. 12. The facility must maintain a supply of cover material adequate to cover the working face in case of an emergency or fire, at all times. 13. Vegetative ground cover sufficient to control erosion must be established within 30 (thirty) working days upon completion of any phase of LCID landfill development or as addressed in the approved Sedimentation and Erosion Control permit. 14. Within 120 calendar days after completion of the final disposal operations, the disposal area must be closed and covered with a minimum of 1 foot of suitable soil cover sloped to allow surface water runoff in a controlled manner. However, for ditches with depths greater than 6 inches and widths less than 3 feet located on the landfill, at least 2 feet of soil is required between the bottom elevation of the ditches and the waste mass. Drainage Control and Water Protection Requirements 15. All required sedimentation and erosion control measures must be installed and maintained to mitigate excessive on-site erosion and to prevent silt from leaving the site of the landfill unit during the service life of the facility. Facility Permit No: 43F-LCID-2010 Weeks Sandpit No. 2 June 2, 2015 Document ID No. 24422 Page 9 of 9 16. Ground water quality at this facility is subject to the classification and remedial action provisions of 15 NCAC 2L. 17. Solid waste must be placed a minimum of four feet above the seasonal high water table. 18. Solid waste must not be disposed in standing water. Surface water must be diverted away from the operational area and must not be impounded over or in waste. 19. Leachate must be properly managed on site using best management practices. - End of Permit Conditions -