5106_INSP_20221118

NORTH CARnLINAD_E Q��
o.n.mm.m m c.wm..rem.i a.i�
FACILITY COMPLIANCE INSPECTION REPORT
Division of Waste Management
Solid Waste Section
UNIT TYPE:
Lined
LCID
YW
Transfer
Compost
SLAS
COUNTY: JOHNSTON
MSWLF
PERMIT NO.: 5106-TP-2019
Closed
HHW
White
Incin
T&P
X
FIRM
MSWLF
goods
FILE TYPE: COMPLIANCE
CDLF
TireT&P
Tire
Industrial
DEMO
SDTF
Collection
Monofill
Landfill
Date of Site Inspection: November 18, 2022
FACILITY NAME AND ADDRESS:
West Farms Wood Products
1683 Barefoot Road
Newton Grove, NC 28366
GPS COORDINATES: Lat.: 35.300748'
Date of Last Inspection: February 8, 2022
Long.:-78.397089'
FACILITY CONTACT NAME AND PHONE NUMBER:
Name: Ryan Conrad
Phone: [phone]
Email address: [e-mail]
FACILITY CONTACT ADDRESS:
Blackwood Associates, LLC
Mr. Ryan Conrad
699 West Dillman Road
Bloomington, IN 47401
PARTICIPANTS:
Amanda Thompson, NCDEQ, Solid Waste Section
Ryan Davis, West Farms Wood Products
STATUS OF PERMIT:
Permit to Operate (PTO) issued August 2, 2019. Permit to Operate shall expire on August 2, 2024. Permit renewal must
be submitted to the Section no later than April 2, 2024.
A revised Permit to Operate Application was submitted to the Section on February 5, 2021.
PURPOSE OF SITE VISIT:
Comprehensive Inspection
STATUS OF PAST NOTED VIOLATIONS:
A. March 11, 2019 Permit to Operate Application, Site Design (Page 4, Paragraph 1), "The West Farms Wood
Produces wood material treatment and processing facility is in the east central portion of the site and occupies
about 6.0 acres (see Total Property Layout & Staging Area — Drawing 2)."
PARTIALLY RESOLVED: A new permit application has been submitted to Donna Wilson, Permitting Engineer,
for review. This violation will be resolved once the new permit application with site plan has been reviewed and
approved.
OBSERVED VIOLATIONS:
None.
Pagel of 3

NORTH CARnLINAD_E Q��
o.n.mm.m m c.w.mmen.i a.i�
FACILITY COMPLIANCE INSPECTION REPORT
Division of Waste Management
Solid Waste Section
The item(s) listed above were observed by Section staff and require action on behalf of the facility in order to come into or maintain compliance
with the Statutes, Rules, and/or other regulatory requirements applicable to this facility. Be advised that pursuant to N.C.G.S. 130A-22, an
administrative penalty of up to $15,000 per day may be assessed for each violation of the Solid Waste Laws, Regulations, Conditions of a Permit,
or Order under Article 9 of Chapter 130A of the N.C. General Statutes. Further, the facility and/or all responsible parties may also be subject to
enforcement actions including penalties, injunction from operation of a solid waste management facility or a solid waste collection service and any
such further relief as may be necessary to achieve compliance with the North Carolina Solid Waste Management Act and Rules.
ADDITIONAL COMMENTS
1. The facility is fenced and is secured by a locking gate when it is not open for operations.
2. The correct signage is located at the entrance of the facility.
3. Operating hours are 7:OOAM to 5:OOPM, Monday through Friday and 7:OOAM to 12:OOPM, Saturday.
4. The facility is permitted to store up to 2,000 tons of treated wood on -site at any one time based on a demonstrated
financial responsibility of $200,000.
5. The waste stream was identified to be relatively clean. Continue to remove and properly dispose of any unacceptable
waste, as it is observed.
6. The area had been graded to shed water away from the wood stockpiles.
7. Grinding and incineration were not taking place during this inspection. Mr. Davis stated that the white wood had
been ground by a third party and sent to another facility for mulching and composting. The electrical poles are still
being ground and sent to the landfill to be utilized as road base. Mr. Davis also stated that the stockpiles of wood
had been moved to the flattened area to the west of the carbonizer, to reduce the possibility of accidental ignition
of the wood stockpiles.
8. The previously identified biochar pile has been removed from the facility.
9. Digital photographs were taken during the inspection.
Please contact me if you have any questions or concerns regarding this inspection report.
Amanda Digitally signed by Amanda
Thompson
Thompson Date: 2022.11.2113:40:58-05'00'
Phone: [phone]
Amanda Thompson
Environmental Senior Specialist
Regional Representative
Sent on: November 21, 2022 X Email Hand delivery US Mail Certified No.
Copies: Drew Hammonds, Eastern District Supervisor— Solid Waste Section
Donna Wilson, Permitting Engineer — Solid Waste Section
Page 2 of 3

NORTH CARnLINAD_E Q��
o.n.mm.m m c.w.mmen.i a.i�
FACILITY COMPLIANCE INSPECTION REPORT
Division of Waste Management
Solid Waste Section
2022.
View of the clean wood stockpile near the center of the
General view of the facility.
General view of the facility.
Page 3 of 3