NCG140390_COMPLETE FILE - HISTORICAL_20170801

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO,
Jv �� L/O 3 0
DOC TYPE
� HISTORICAL FILE
❑ MONITORING REPORTS
DOC DATE
❑
YYYYMMDD

Energy, Mineral &
Lund Resources
ENVIRONMENTAL QUALITY
August 1, 2017
Hildreth Ready Mix LLC
Attn: Karl Hildreth
PO Box 1098
Wadesboro, NC 28170
ROY COOPER
Governor
MICHAEL S. REGAN
5errrtctry
TRACY DAVIS
171 ector
Subject: NPDES Stormwater Permit Coverage Renewal COC #NCG140390
Dear Permittee:
For coverage under Stormwater General Permit NCG140000, the Division of Energy,
Mineral, and Land Resources (DEMLR) is forwarding herewith the reissued Certificate of
Coverage (COC). This permit is reissued pursuant to the requirements of North Carolina
General Statute 143-215.1 and the Memorandum of Agreement between the state of North
Carolina and the U.S. Environmental Protection Agency, dated October .l5, 2007 (or as
subsequently amended.) A new Certificate of Coverage (COC) is included with this
letter.
You must print a copy of the new NCG140000 General Permit from our website here:
http.//deq.nc.goy/about/divisionsI- _... _....
permits /stormwater- e=-_mits.Jnpdes-industrial-sw. In addition to the full permit, the 2017
print package on the website includes revised Discharge Monitoring Report (DMR) forms,
Annual Discharge Monitoring Report forms, and Qualitative Monitoring Report Forms.
The General Permit authorizes discharges of stormwater and wastewater (if applicable),
and it specifies your obligations with respect to discharge controls, management,
monitoring, and record keeping. Please review the new permit to familiarize yourself with
all changes in the reissued permit. Significant changes to the General Permit are
outlined in the Technical Bulletin, which is also available on the website above. Your
facility has six months from receipt of the permit to update your Stormwater Pollution
Prevention Plan (SPPP) to reflect any new permit requirements.
--5 'Nothing Compares..---. -
5State of North Carolina I Environmental Quality I F"rtergy, hllncral and land Resources
512 N. Salisbury Street i 1612 Mail Service Center I Raleigh, North Carolina 27699•lbl2
9197079200

/ :
How does the new General Permit affect Tier Status?
The first sample period of your permit begins August 1, 2017. Tier 3 actions in Part IV of
your permit are triggered by benchmark exceedances on four occasions beginning on the
effective date of this permit and do not count prior exceedances. Likewise, Tier 2 actions
are triggered by two consecutive benchmark exceedances beginning on the effective date
of this permit and do not count prior exceedances. However if your facility is already in
Tier 2 (monitoring stormwater discharges monthly) or Tier 3, you must continue Monthly
monitoring until relieved through conditions of the permit or by DEMLR staff approval.
When does electronic DMR reporting start?
We are setting up our database with final permit parameters and the outfalls that
permittees submitted on-line. All NCG14 Permittees will receive notification when our
eDMR system is ready for these permittees to register and begin reporting
monitoring data electronically. If you have any questions about the status, please
contact Bethany Georgoulias at [phone] or Robert Patterson at [phone]. If
you did not submit outfall information already, we have included a form for you to return
to us. (Note: NO FORM IS ATTACHED if we already have your outfall information.)
Your coverage under the General Permit is transferable only through the specific action of
DEMLR. This permit does not affect the legal requirements to obtain other permits which
may be required by the N.C. Department of Environmental Quality (DEQ), nor does it
relieve the permittee from responsibility for compliance with any other applicable federal,
state, or local law, rule, standard, ordinance, order, judgment, or decree.
If you have any questions regarding this permit package please contact the DEMLR
Stormwater Permitting Program at [phone].
cc: Stormwater Program files
Sincerely,
Fox
for Tracy E. Davis, P.E., C.P.M.
-,"Nothing Compares,.. � -_
State of North e uolina I Environmental Quality ! Energy, Mineral end Land Resources
512 N. Salisbury Street 1 1612 Mail Service Center I Raleiyl+, North Carolina 27699-1a12
919 707 9200

5
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENTAL QUALITY
DIVISION OF ENERGY, MINERAL, AND LAND RESOURCES
STORMWATER AND WASTEWATER DISCHARGES
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Hildreth Ready Mix LLC
is hereby authorized to operate approved wastewater treatment system(s) and discharge
stormwater and/or wastewater, as approved in the original permit/application or
subsequent permit modification, from a facility located at:
4
Hildreth Redi-Mix and Septic Services
City Pond Rd
Wadesboro
Anson County
to receiving waters designated as North Fork Jones Creek (City Pond), class WS-II;HQW,CA
waters in the Yadkin River Basin, in accordance with the effluent limitations, monitoring
requirements, and other conditions set forth in Parts I,1I, I[[, IV, and V of General Permit
No. NCG140000 as attached.
This Certificate of Coverage (COC) shall become effective August 1, 2017.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day August 1, 2017.
7-060o U�'fof
for Tracy E. Davis, P.E., CPM
Director, Division of Energy, Mineral, and Land Resources
By the Authority of the Environmental Management Commission

Hildreth Ready Mix, LLC
PO BOX 1098
Wadesboro, NC 28170
704-694-2034
Fax: [phone]
We here at Hildreth Readymix are writing do to the Notice of
Violation. The reason that our company is not in compliance is
due to staff turnovers and some paperwork had been misplaced.
We have had several people to come and go throughout the
company and now that we are finally trying to get back on track.
Now since after the inspection I'm aware of the process that
must be taking to get Hildreth Readymix once again Compliant.
I know now to keep records of all papers, procedures, and
records. I now know that this have to be done and submitted
every quarter. We thank you for your patience and deeply
apologize for being late.
v
Sincerely,
Hildreth Readymix, LLC
i JUN 1'6
2017
J
;

Energy, Mfrleral
and Land Resources
ENWRONMENTAL QUALITY
May 23, 2017
CERTIFIED MAIL: 7012 3050 0001 9398 7065
RETURN RECEIPT REQUESTED
Hildreth Ready Mix, LLC
Attn: Karl Hildreth
PO Box 1098
Wadesboro, NC 28170
ROY COOPER
Governor
MICHAEL S. REGAN
Secretary
TRACY DAVIS
Director
Subject: NOTICE OF VIOLATION (NOV-2017-PC-0285)
NPDES General Permit NCG140000
Hildreth Redi-Mix and Septic Services, Certificate of Coverage NCG140390
Anson County
Dear Mr. Hildreth:
On April 18, 2017, Joshua Harris with the Division of Air Quality (DAQ) and Mike Lawyer with the Division of
Energy, Mineral and Land Resources (DEMLR), conducted a Multimedia Compliance Inspection for the
Hildreth Redi-Mix and Septic Services facility located on City Pond Road in Wadesboro, Anson County,
North Carolina. A copy of the Compliance Inspection Report is enclosed for your review. The subject facility
is covered by NPDES General Permit NCG140000 under Certificate of Coverage NCG140390. Permit
coverage authorizes the discharge of stormwater and process wastewater, excluding discharge from the
wetting of raw material stockpiles, from the facility to receiving waters designated as North Fork Jones
Creek, a Class WS-11;HQW,CA waterbody in the Yadkin -Pee Dee River Basin.
As a result of the site inspection, the following permit conditions violations are noted:
1) Stormwater Pollution Prevention Plan (SPPP)
A Stormwater Pollution Prevention Plan (SPPP) has not been developed, recorded, or properly implemented.
Secondary containment is not provided around bulk storage of liquid materials in accordance with permit
requirements.
2) Qualitative Monitoring
Qualitative monitoring has not been conducted and/or recorded in accordance with permit requirements.
3) Analytical Monitoring
Analytical monitoring has not been conducted and/or recorded in accordance with permit requirements.
Other Observations:
Please refer to the enclosed Compliance Inspection Report for additional comments and observations made
during the inspection.
Requested Response:
You are asked to respond to this office, in writing, within 30 calendar days from receipt of this notice. Your
written response should include a reasonable explanation as to why the aforementioned violations have,
occurred as well as a Plan of Action to prevent these violations from recurring.
State of North Carolina I Environmental Quality I Energy, Mineral and Land Resources
Fayetteville Regional Office 1 225 Green Street, Suite 714 1 Fayetteville, NC 2M1
910.433.3300

Thank you for your attention to this matter. This office requires that the violations, as detailed above, be
properly resolved. These violations and any future violations are subject to a civil penalty
assessment of up to $25,000 per day for each violation. Should you have any questions regarding these
matters, please contact Mike Lawyer or myself at [phone].
Sincerely,
T mothy L. LaBounty, PE
Regional Engineer
DEMLR
TVml
Enclosure
ec: Laura Alexander, Administrative Assistant - DEMLR, Stormwater Permitting Program
cc: FRO — DEMLR, Stormwater Files-NCG140390
►n (Domestic
o
co
t7'
rn Postage $
Er,
Certified Fee
Poslmnrk
0 C3 Return Receipt Fee
t7 (Endorsement Required) Here
C3
Rostricled Delivery Fan
C:1 (Endorsement Required)
Ln
C3 Total Postage & Fees 1 $
M
ni Sent To A!%C0/eAFrAP�t' s4/,r/C� LG
ra . ..-•------ �-'-4ni-�- !•-•�r.'+1 r=........... ---................ '---
a S`freef, Apf. a.;
M1 or PO Box No. , ,Q �r]
City, Ste re, ZIF44
PS Form :f1 August 2006
• •COMPLETE
i
THIS SECTIONON DEUVERy
■ Complete Items 1, 2, and 3. Also complete
I A. Signature
Item 4 if Restricted Delivery Is desired.
■ Print your name and address on the reverse
Agent
ALP &U1#Addresses
so that we can return the card to you.
■ Attach this card to the back of the mallplece,
Aec Ivad b y (Prints of DelIve
or on the front if space permits.
,pate
1. Article Addressed to:
D. Is delivery address different from Item 1? Cl Yes
If YES, enter delivery address below: ❑ No
HILDRETI-I READY MIX, LLC
ATTN: KARL HILDRETH
P.Q. BOX 1098
WADESBORO, NC 28170
3. Service 1pe
X Certified Maim ❑ priority Mall Express'"
❑ Registered AfRetum Receipt for Mercherufse
❑ insured Mali ❑ collect on Delivery 1
4. Restricted Dalivery? (Extra Fee) ❑ Yes
2. Articlar Number 7012 3050
(Monster from service iaben
0001 9398 7065
PS Form 3811, July 2013 Domestic Return Receipt

Permit; NCG140390
SOC: .
county: Anson
Region: Fayetteville
f
-0-nuance Inspection Report
Effective: 07/01/16 Expiration: 06/30/17 Owner; Hildreth Redi-Mix
i
Effoctive: Expiratlon: Facility: Hildreth Redi-MIx'and Septic Sgrvices
City Pond Rd
Contact Person: Karl Hildreth Title:
Directions to Facility:
System classiflcabotm:
Primary ORC: Certification:
Secondary ORC(s):
On -Site Repreeentative(a):
Related Permits:
Wadasboro NC 28170
Phone. [phone]
Inspection Date: 04/18/2017 Entry Time 12:05PM It Time: 01:35PM
Primary Inspector: Joshua Harris c .y�•� -- Phone: [phone]
Secondary Inspector(s):
Mike Lawyer Phone :[phone] Ext.72
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Ready Mix Concrete StormwaterMastewater Discharge COG
Facility. Status: ❑ Compliant Not Compliant
Question Areas:
Storm Water
(See attachment summary)
Phone:
Page: 1

t
Permit: NCG140390 Owner -Facility-. Hlldreth_Red I -Mix
Inspection Date: 0414&201-7.: Inspection Type: Compliance Evaluation Reason for Visit: Routine i
i
Inspection Summary:
On 18 April 2017, Mike Lawyer FRO DEMLR, and I, Joshua Harris, FRO DAQ, met Karl Hildreth, Owner, and conducted
multimedia inspection at Hildreth Ready Mix, LLC in Wadesboro, Anson County. -There were no records available at the
time of the inspection, Mr. Hildreth was later able to provide a detailed site map, but was not able to produce any other
records.
This will be referred to DEMLR for follow-up.
Page: 2

Permit; NC13140390 Owner • Faamy: Rldrath Redi-Mix l
Impecaon pate.- D4I1612017 ... Inepse!!on Type., Compliance Evaluation Region for Vhft Routine
I
Starnwitter PgIIwtWrLE_ra_ventIon Plan
Does the site have a Stormwater Pollution Prevention Plan?
# Does iha Plan Include a General Evocation (USGS) map?
Al Does the Plan Include a "Narrative Description of Practices'?
# Does the Plan Include a detailed site map Including outfall locations and drainage areas?
# Does the Plan Include a list of significant spills occurring during the'past.3 years?
# Has the facUty evaluated feasible alternatives to currant practical?
# Does the facility provide all necessary secondary containment?
# Does the Plan Include a BMP summary?
# Does the Plan Include a Spill Prevention and Response Plan (SPRP)?
# Dees the Plan Include a Preventative Maintenance and Good Housekeeping Plan?
# Does the facility provide and document Employee Training? U U U ■
# Does the Plan Include a list of Responsible PartAs)? 110 ❑ ■
# Is the Plan reviewed and updated annually? ❑ ❑ ❑ ■
# Does the Plan Include a 3tormwater Facility Inspection Program?. ❑ ❑ ❑ ■
Has the Stormwater Pollution Prevention Plan been implemented? ❑ ■ ❑ ❑
Comment: With ft exception of a detailed site map, the facility was not able to aroduge any -records. Thera -
Is no secondary contalnrnent_around_add mixtures.
Qualitative manitorina
Has the facility conducted Its Qualitafave Monitoring semi-annually?
Comment: No regards available.
Analytical Monitorina
Has the facility conducted Its Analytical monitoring?
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas?
Comment: No records available
Perrnit and outfalla
# Is a copy of the Permit and the Certificate of Coverage available at the site?
# Were all outfails observed during the Inspection?
Al If the facility has representative outfall status, is It property documented by the Division?
# Has the facility evaluated all illicit (non stormwater) discharges?
Comment: No records available.
Yee No N& ME
❑■❑❑
❑ ❑ S ❑
Yes Na NA NE
❑■❑❑
■ ❑ ❑ ❑
❑ ❑ ■ ❑
❑❑❑■
Page: 3

,, 1
K
y
..
Environmental
Quality
ROY COOPER
Govemor
MICHAEL S. REGAN
sEcngwy
16 May 2017
HILDRETH READY MIX, LLC
AnN: KARL HILDRETH, OWNER
P.O. BOX 1098
WADESBORO, NC 28170
Subject: Multimedia Compliance Inspection
Hildreth Ready Mix, LLC
Anson County
Dear Perrnittee:
Department of Environmental Quality staff from the Fayetteville Regional Office conducted a
multimedia compliance inspection of Hildreth Ready Mix, LLC on 18 April 2017 for permitted
activities administered by the following Divisions:
Division of Air Division of Energy,
Quality (DAQ) Mineral, and Land
Resources (DEMLR)
The results of each applicable inspection area and any associated response actions or necessary
corrective measures are detailed in the Division speeific areas of the attached report(s). Should
violations be noted in the attached report(s), you may receive separate enforcement related
correspondence in addition to the report(s).
If you have any questions regarding this multimedia inspection or the results of each program
inspection, please contact the Fayetteville Regional Office at [phone] and ask to speak
with the appropriate Division staff. Thank you for your cooperation.
encl: Air Quality Inspection Report
Storrnwater Inspection Report
cc: (w/attachments)
Trent Allen, FRO
DAQ FRO Files
DEMLR FRO Files
State of North Carolina � Department of pavitonmental Quality
Fayetteville Regional Office 1 225 Green Street, Suite 714 1 Fayetteville, HC 28301
910-433-3300

NORTH CAROLINA DIVISION OF
AIR QUALITY.
Inspection Report
Date: 05/03/2017
Facility Data
Hildreth Ready Mix, LLC
878 City Pond Road - SR 1142
Wadesboro, NC 28170
Lat. 34d 55A974m Longs BOd 5.9570m
SIC: 3273 / Ready -Mixed Concrete
NAICS: 32732 / Ready -Mix Concrete Manufacturing
Contact Data
Facility Contact Authorized Contact
Karl Hildreth Karl•Hildreth
Owner Owner
(704}694-2034 [phone]
Technical Contact
Karl Hildreth
Owner
[phone]
Hildreth Ready Mix, LLC
NC Facility ID 0400045
County/FIPS: Anson/007
Permit Data
Permit 08715 / 003
Issued 7/30/2013 -
Expires 6/302018
Classification Small
Permit Status Active
Current Permit Applications) None
SIP
Program Applicability
Compliance Data
Comments"
Inspection Date 04/18/2017
Inspector's Name Joshua L, Harris
Inspector's Signature:-�� Operating Status Operating
Compliance Code Compliance - inspection
Action Code FCE
Date of Signature: os�2rv,7 On -Site Inspection Result Compliance
Tnfnl enh�al emivainna in Tf1NRNF.Ar2.
TSP
S02
NUX
-•VOC
CO
PM10 '
*HAP"
2012
0.7200
---
.--
-..
.--
0.2200
0.0610
2007
0.9240
---
---
---
---
0.2410
0.0700
Five Year Violation Hlitorv:
Date Letter WWI Rule VioJat&
03/2V2017 NOV Permit Late Report (excluding ACC)
Permed Stack Tests since last FCE: None
Date Test Results Test Metbad(sl
* Hiahest HAP Emitted
Violation Resolution Date
03/13017
Source(s) Tested
L DIRECTIONS TO SITE: In Wadesboro, take Hwy 742 south for 3.5 miles to City Pond Road and turn
right. Hildreth Ready Mix is approximately 2 miles on the right. I£ no one is at the plant, take Hildreth
Road, which is just past plant, up to the office on the right.

II, SAFETY: Standard PRO safety gear is required. The inspector should be mindful of vehicular and
heavy equipment traffic.
III. FACILITY/PROCESS DESCRIPTION: Hildreth Ready Mix is a small concrete batch plant. Cement
is stored in silos and mixed with aggregate and sand (both stockpiled on site), all of which is mixed with
water inside a cement truck. The loadout and silos are controlled by a central dust collector. A second,
unused bagfilter, which was previously used as a dedicated control for one of the silos is still in place, but.
it no longer operating. To produce the septic tanks, cement is poured into 1,000-gallon, 1,200-gallon, or
1,500-gallon molds and allowed to cure for 28-30 days. The molds are removed and septic tanks are
delivered and installed on site. Although septic tanks Are still produced on site, most of Mr. Hildreth's
business now is delivering concrete from his batch plant, which is operated on an "as needed" basis.
The facility requested to have the air quality permit rescinded on 01 July 2016 under the newly adopted
2Q .0102(d) exemption. The facility's permit was rescinded on 19 July 201 b. The rescission request was
an apparent error, and the facility subsequently requested to have the permit reinstated. The facility's air
permit was reinstated on 13 September 2016.
Throughputs:
gratin hours 0900-1700 Monday -Friday wl occasional Saturday
Employees 7 including drivers
Production (cu yd) 2016: 4,147
2015: 7,972.5
2014: 6,000
2013: 2,000
2012: 3,397
IV. INSPECTION SUMMARY: On 18 Apri12017, Mike Lawyer, FRO DF,MI,R, and I, Joshua Harris FRO
DAQ, arrived on site to conduct a multimedia inspection of Hildreth Ready Mix, LLC. While. entering
the property, we briefly observed 4 silo being loaded, and noted intermittent visible emissions around *e.
connections at ^-5% opacity. These emissions dissipated before reaching the property boundary, and no
other visible emissions were noted, and the facility was otherwise not operating during the inspection. At
the Admin Office, we met Karl liildreth, Owner, and Chanel Little, Secretary. Mr. Hildreth verified the
FacFindet information, and requested that Ms. Little be listed as the invoice contact.
We reviewed the facility's records, which, while messy, appeared to be complete. Mr. Hildreth described
his methods for maintaining the bagfilter, which appears -to be sufficient. Mr. Hildreth stated that he has
not had to change any bags in nearly a decade, and no visible emissions concerns were noted during
previous inspections in which the facility was observed operating.
V. PERMITTED EMISSION SOURCES:
A. One cement mixing weigh hopper and loading operation, and
Not operating
H. Silos for cement and Elyash storage.
Cement loading briefly observed with 0% opacity at bagJilter exhaust Light visible emissions,
—5% opacity, were noted at the connections. No fugitive dust was visible past the property
boundary.

' c f
VI. APPLICABLE AIR QUALITY REGULATIONS:
A. 15A NCAC 2D .0202 — PERMIT RENEWAL AND EMISSION INVENTORY
REQUIREMENT - The permittee shall submit an application for renewal of the facility's permit no
later than; 90 days prior to expiration, and shall include documentation of air pollutants emitted for the
2017 calendar year.
APPEARED INQOMPLIANCE: We reminded Mr. Hildreth of this requiremen4 and reminded hint
that his permit will be expiring next year on 30 June 2018. Previously, the facility's emission
inventories, and applications for renewal have been received on time. The facility will be deemed in
non-compliance # the emission inventory and renewal application are not received by 01 April 2018
B. 15A NCAC 2D .0515 —PARTICULATES FROM MISC. INDUSTRIAL PROCESSES —
Particulate emissions shall not exceed allowable emission rates as calculated by the. foliowitig
equations:
E = 4.10 * (P) ° 6'. for P :5 30,tonslhr, or
E = 55 * (P) ° 11- 40 for P >30 tons/hr
9AMARBD IN COMPLIANCE; These calculations were made when the facility was permitted,
and the previous permit reviews indicated that that facility, when controls are properly maintained
and operated -would not exceed these limits. The facility's particulate emissions are controlled by
bagJllters. Each bagfilter appeared to have regular maintenance conducted, and there were no dust
accumulations near their exhaust points which would indicate an operational problem.
C. 15A NCAC 2D .0521— CONTROL OF VISIBLE EMISSIONS— Visible omissions shall not
exceed 20% opacity.
APPEARED 12V COMPLIANCE_ The facility was not operating at the time of the, inspection,
though we did observe a silo load as we entered, during which light visible emissions, �-S% opacity,
were noted around the connections. Mr. Hildreth stated that he does not see visible emissions while
the plant is operating, outside of occasional fugitive emissions at loadout, and that he hasn't received
any recent dust complaints.- DAQ has not received any recent complaints pertaining to this facility.
D. 15A NCAC 2D .0535 — NOTIFICATION REQUIREMENT— Notify, DAQ in the event of excess
emissions lasting longer than 4 hours resulting from malfunctions, breakdowns, or abnormal
conditions.
,APPEARED &V COMPLIANCL- There are no indications of any excess emissions which would
require a not (cation by the facility. We reminded Mr. Hildreth of the notification requirement,
There have been no recent complaints received by the facility or DAQ.

E. 15A NCAC 2D .0540 —PARTICULATES FROM FUGITNE DUST EMISSION SOURCES —
liugitive dust emissions shall not contribute to substantive complaints, or excessive dust emissions
across the property boundary.
APPEARED IN COMPLIANCE: No fugitive dust concerns at the property boundaries were noted
during the inspection, though the facility is located just off the street. The facility was not operating
at the time of the inspection, but we were able to briefly observe a silo load. Brief, light visible
emissions were noted at the connections, and no dust was visible past the property boundary. There
have been dust complaints in the past associated with the truck loadout, but none have been received
by DAQ in the past two years.
F. 15A NCAC 2D .0511— FABRIC FILTER REQUIREMENT —Particulate emissions controlled by
fabric filters; actnual internal inspections; record keeping.
APPEARED IN COMPLIANCE: Mr. Hildreth performs the maintenance himself, and described his
method for cleaning and inspecting the bagfilter. Mr. Hildreth stated that he removes the bags,
inspects them for damage, rinses them; and lets them dry before reinstalling them. He uses a pump
truck to pump out any collected cement, then he sprays the slurry onto his lawn, which he claims
helps the grass grow. Mr. Hildreth's production log has an entry on 28 January 2017, which states
simply that the baelter was cleaned.
G. 15A NCAC 2D .1104 —TOXIC AIR POLLUTANT CONTROL REQUIREMENTS —Arsenic
emissions shall not exceed the AAL. Concrete production limit based on distance to property
boundary (35,000 cubic yards at 75 feat), which shall be marked. Monthly recordkceping,
Notification of changes. Annual reporting. .
APPEARED IN COMPLIANCE: The nearest property boundary is marked and has been verified at
—75 feet which limits the facility to 35, 000 cubic yards of production annually. Mr. Hildreth keeps a
running log of concrete produced each day, and there is a spreadsheet available which shows the
monthly and annual totals; the facility produced 4,147 cubic yards in 2016 A. IBldreth stated that
there have been -no.-changes to the facility, and we reminded him of the notiflcation.requirement. The
annual report was received late, on 13 March 2017, and a Notice of Violation was issued on 21
March 2017. The violation was immediately resolved since the report was received
H. 15A NCAC 2Q .0310 — GENERAL PERMIT CRITERIA — The facility must meet the following
criteria to qualify for a general permit: 1) No emissions sources operated other than those listed; 2)
facility not subject to regulations other than those covered by the general permit; 3) facility is located
in dne of the listed counties; 4) maximum hourly throughput does not exceed 138 cubic yards per
hour; and 5) the facility does not exceed the maximum annual production rate based on distance to the
property line (35,000 cubic yards at 75 feet).
APP IN PLIANCE• The facility appears to qualify for a general permit. No other
emission sources other than those listed were noted, and the facility does not appear to be subject to
any regulations, State or Federal, other than those listed in the general permit The facility is located
in Anson County, which is listed in the permit and covered by generalized modeling. The facility's
maximum throughput is 100 cubic yards per hour, which is much less than the maximum permitted
throughput, and the annual throughput, 4,147 cubic yards in 2016, is also much less than the 35, 000-
cubic yard limit,

i
'I. 15A NCAC 2Q .0711- TOXIC AIR POLLUTANT EMISSION LIMITATIONS —Emissions of
toxic air'pollutants shall not exceed the listed limitations without first obtaining a permit and
demonstrating compliance with 2D .1100.
APPEARED IN COMPLIANCE: The listed TPERs are based on a maximum production rate of
1-50, 000 cuhic yards per year. The facility's annual throughput was much Jess than this limit,
therefore compliance is indicated.
VII. INSIGNIFICANT ACTIVITIES:
VUL NON-COMPLIANCE HISTORY SINCE 2010;
03/21/17
NOV issued for late annual reporting.
03/28/16
NOD issued for late annual reporting.
05/28/10
NOV issued for late annual reporting.
IX. RISK MANAGEMENT (112r): This facility does not store any 112(r) subject materials above threshold
quantities. Therefore, it is not required to maintain a written Risk Management Plan (P-W).
X. CONCLUSION AND RECOMMENDATIONS:
- Hildreth Ready Mix, LLC, appeared to be IN COMPLIANCE with their current air permit.
PINK SHEET ADDITIONS:
- None.
/jlh

Perm it: N CG 140390
SOC: .
County: Anson
Region: Fayetteville
Comallance Inspection Report
Effective: 07/01/16 Expiration: 06/30/17 Owner, Hildreth Redi-Mix
I
Effective: Expiration: Facility: Hildrath Redi-Mixand Septic Services
City Pond Rd
I
Wadesboro NC 28170
Contact Person: Karl Hildreth Title: Phone: [phone]
i
Directions to Facility:
System -Class Ifications:
Primary ORC: Certification: Phone:
Secondary ORC(s): ##
On -Site Representative(s):
Related Permits:
Inspection Date: 04/18/2017 Entry Time 12:05PM It Time: 01:35PM
Primary Inspector: Joshua Harris :)�Phone: [phone]
Secondary Inapector(s):
Mike Lawyer Phone :91 OA33-3300 Ext.72
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Peltnit Inspection Type: Ready Mix Concrete StormwaterMlastewater Discharge COC
Facillty. Status: ❑ Compliant E Not Complient
Question Areas:
Storm Water
(See attachment Summary)
Page: 1

Permit: NCG140390 Owner - Facility: Hlldreth Redl-Mix
Inspection bate:. 04148/2017: Inspection typo: Compliance Evaluation Reason for Wall: Routine
Inspection Summary:
On 18 April 2017, Mike Lawyer FRO DEMLR, and I, Joshua Hams, FRO DAQ, met Karl Hildreth, Owner, and conducted;
multimedia inspection at Hildreth Ready Mix, LLC in Wadesboro, Anson County.. There were no records available at the
time of the inspection. Mr. Hildreth was later able to provide a detailed site map, but was not able to produce any other
records.
This will be referred to DEMLR for follow-up.
page: 2
I

pert; NCOU0380 Owner • Fecioty: HNdrsth RedkMlx
Inspection pate- O4111812017 •- Inspection 7yps : ComPllanoe Evaluation Ronson for Visit: Routino
8IgaMff ter PPRIlution Prevention Plan
Yes No NA NE
Does the site have a Stormwater Pollution Prevention Plan?
❑ ❑ ❑
# Does the Plan include a General Location (USGS) map?
❑ ❑ ❑
# Does the Plan Include a'Narrative Description of Practices'?
❑ ❑ ❑
# Does the Plan Include a detailed site map Including outlall locatlons and drainage areas?
❑ ❑ ❑
# Does the Plan Include a list of significant spills occurring during the past.3 years?
❑ ❑ ❑
# Has the'fadlity evaluated feasible alternatives to current practices?
❑ ❑ ❑
# Does the facility provide all necessary secondary containment?
❑ ❑ ❑
# Does the Plan Include a BMP summary?
❑ ❑ ❑
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
❑ ❑ ❑
# Does the Plan Include a Preventative Maintenance and Good Housekeeping Plan?
❑ ❑ ❑
# Does the facility provide and document Employee Training?
❑ ❑ ❑
Al Does the Plan include a list of Responsible Party(s)?
❑ ❑ ❑
# Is the Plan reviewed and updated annually?
❑ ❑ ❑ N
# Does the Plan Include a Stamrwater Facility Inspection Program?
❑ ❑ ❑
Has the Stormwater Pollution Prevention Plan been Implemented?
❑E ❑ ❑
Comment: With the exception of a detailed site map, j3e faciti4Y was -not able to produce any, records.
Thefm .
Is no secondary containment round add mixtures.
Qualltattyo Manitaring YWas No NA NE
Has the facility conducted its Qualitative Monitoring semi-annuapyl;' ❑0 ❑ ❑
Comment: No records avallable.
Analytical Monitoring ENE
Has the facility conducted its Analytical monitoring? 1101313
# Has the faollity conducted ills Analytical monitoring from Vehicle Maintenance areas? ❑ ❑ ■ ❑
Comment: No records_availab�
Permit and Outfalls Yes No Mh Ng
# Is a copy of the Permit and the Certificate of Coverage available at the site? ❑ 0 ❑ ❑
# Were all outfalls observed during the Inspection? E ❑ ❑ ❑
# If the facility has representative outfall status, Is it properly documented by the Division? ❑ ❑ M ❑
# Has the facility eve luated all illicit (non stormwater) discharges? ❑ ❑ ❑
Comment: No records available.
Page: 3

if
Fnergy, Min rral &
Land Resources
ENVIRONMENTAI,_ QQ At IlY
April 7, 2017
Karl Hildreth
Hildreth Redi-Mix
PO Box 1098
Wadesboro, NC 28170
ROY COOPER
Govel-nor
MICHAEL S. REGAN
,So.,retary
TRACY DAVIS
DIrcaor
Subject: NPDES General Permit Renewal and Electronic Reporting Requirements
Hildreth Redi-Mix and Septic Services
NPDES Permit Certificate of Coverage (COC) Number: NCG140390
Dear NPDES Permittee:
The NCG140000 General Permit expires on June 30, 2017. Our records indicate that your annual fees
are up to date; therefore, your coverage will be automatically renewed unless you submit a rescission
request for this permit. If you no longer need this permit, a rescission form can be found on our website
(http://goo. I BcgDP4).
The new General Permit NCG140000 is scheduled for public notice in May 2017. At that time, the
proposed general permit will be available for public comment on our website. This notice process
should conclude in June, so that the new general permit can be issued effective July 1, 2017. Upon
issuance of the final general permit, your coverage will be renewed, and we will send you a new
Certificate of Coverage (COC) with the new effective and expiration dates.
In conjunction with this renewal process, two items require your action no later than May 31, 2017:
(1) You must review your permit contact information and notify us of any changes.
(2) You must submit outfall information on-line for this site in preparation for electronic data
monitoring report (eDMR) requirements.
Permit Contact Information
Please review the permit contact information enclosed. Ensure that Owner Affiliation and Permit
Contact are accurate, and that e-mail addresses are provided wherever possible. Your new COC will be
mailed to both of these contacts once the General Permit is renewed.
- 55>^Nothing Compares....�,�
SSlatr of Nurth Carolina I Environinmial Quality I Fncrgv. Minrtral Wuxi lajid Rrsriun-es
51L N. Salisbury Strcrt I 1612 Mall Servia:e Center I Ralctgh, Nort h C;urnl€na 176nt)-1612
919 707 9200

0
To update contact information for your permit: You may simply e-mail us changes to contact
information, unless there is a chanee to the Owner Affiliation. Because owner Affiliation is the person
legally responsible for the permit, we require a hard copy of the signed Owner Affiliation Change Form
(enclosed) to make this change. (A change in company Name or Ownership requires a different form, so
please contact us if necessary.) Changes to other contacts can be e-mailed to Laura Alexander at
[e-mail].
Submitting Outfa!! Information for E-Reporting
The U.S. Environmental Protection Agency (EPA) finalized the National Pollutant Discharge Elimination
System (NPDES) Electronic Reporting Rule in December 2015. The rule requires NPDES regulated
facilities to report certain information electronically, instead of filing written paper reports. EPA is
phasing in the requirements of the rule over a 5-year period. The first phase requires regulated entities
to submit Data Monitoring Reports (DMRs) electronically starting on December 21, 2016.
While that deadline has passed, EPA is aware that NC is working on expanding the State's eDMR System
(currently available to NPDES Wastewater Permit -holders) to include Stormwater Program DMR
reporting. As soon as eDMR is available for your permit, we will notify you. In the meantime, we must
collect information about the discharge outfalis at your facility to prepare the system to flow data to
EPA as the new federal rule mandates.
To submit outfall information to DEQ: You must go to the following website and enter the
discharge outfall number, type of discharge, receiving water information, representative outfall status
information, and other details no later than May 31, 2017. The website will walk you through all steps.
The website is: http5J/deg.nc.gov/about/stormwater-program/stormwater-outfall-collection
The reissued general permit will include new electronic reporting requirements. For more information
on EPA's NPDES Electronic Reporting Rule, visit http://www2.epa.gov/compliance/final-national-
pollutant-discharge-elimination-system-npdes-electronic-reporting-rule. For more information on
electronic reporting to NC DEMLR, visit http://deg.nc,gov/about/divisions/enerey-mineral-land-
resources/stormwater/erepo rting-rule or contact Bethany Georgoulias at [phone] or via email at
[e-mail].
Sincerely,
geda7 �m^pa&e
Bethany Georgoulias,
DEMLR Stormwater Program
Cc: Stormwater Program Permit File
Fayetteville Regional Office / DEMLR Stormwater Program
--:>^Nothing Compares_.,.,
State of North Carolina I EnvirowneFTW1 Quality I Energy, Mineral and Land Resourr, cs
512 N. Sahbury Street 11612 Mail Servic.c Center I Raleigh, Nnrl h Carolina 27699.1612
919 707 9200

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES - DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG140000
TO DISCHARGE STORMWATER AND/OR PROCESS WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
Coverage under this General Permit is applicable to all owners or operators of establishments
classified as primarily engaged in ready -mixed concrete [Standard Industrial Classification
Code (SIC) 3273] and like activities deemed by DWQ to be similar in the process and/or the
exposure of raw materials, products, by-products, or waste materials.
Discharges covered under this permit are:
• Stormwater point source discharges (including discharges from on -site vehicle
maintenance areas), and
• Authorized process wastewater discharges.
The following activities are specifically excluded from_coveraae under this
General Permit:
• Disposal of wastewater not specifically designated in this permit.
• Disposal of any concrete directly into stormwater conveyances, storm sewer outfalls,
wetlands, and/or into any waters of the state.
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission and the Federal Water Pollution Control Act, as amended, this permit
is hereby issued to all owners or operators, hereafter permittees, which are covered by this
permit as evidenced by receipt of a Certificate of Coverage by the Environmental Management
Commission to allow the discharge of stormwater and process wastewater to the surface waters
of North Carolina or separate storm sewer systems conveying stormwater to surface waters in
accordance with the terms and conditions set forth herein.
The General Permit shall become effective on July 1, 2016.
The General Permit shall expire at midnight on June 30, 2017.
Signed this day June 30, 2016.
Original Signed by Toby Vinson
for Tracy E. Davis, P.E., CPM, Director
Division of Energy, Mineral, and Land Resources
By the Authority of the Environmental Management Commission

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES - DIVISION OF WATER
QUALITY
GENERAL PERMIT NO. NCG140000
TO DISCHARGE STORMWATERAND/OR PROCESS WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
Coverage under this General Permit is applicable to all owners or operators of
establishments classified as primarily engaged in ready -mixed concrete [Standard
Industrial Classification Code (SIG) 3273] and like activities deemed by DWQ to be
similar in the process and/or the exposure of raw materials, products, by-products, or
waste materials.
December fl, 2011:
In response to Section 9 of Session Law 2011-
394, NCDWQ will not implement some of the Authorization to Construct requirements in
the current version of the permit. DWQ will revise the printed text of the General Permit to
be consistent at the next scheduled renewal period. Specifically:
a. Note that permit requirements in Part II, Section A, numbers 1-5, and Part I1, Section
B, number 1 are no longer valid per NC Session Law 2011-394.
b. However, note that Part II, Section A, number 6, and Part 1I, Section B, numbers 2-10
are unaffected by this Session Law.
C. Your facility must notify the appropriate DWQ Regional Office at least 72 hours in
advance of operation of your wastewater treatment facility.
d. Other DWQ supporting documentation (other than the permit) will be amended to
reflect these changes.

PAT MCCRORY
ffournmar
DONALD R. VAN DBR VAART
Energy, Mfneml 'TRACY-DAVIS
and Und Resources -
6M 1RONMtrNTALQLMUTY ZWTMr
September 28, 2015
CERTIFIED iNAIL:.7009 3410:0001' 8831223Q
RETURN RECEIPT REQUESTED -
Hiidreth Redl-Mix
Attn: Karl Hildreth
PO Sax 1088
Wadeaboro, .NC 28170
Subl»ct: NOTICE Olrr-VIOLATION'(NQV.-2,018-PC-0484)
NPDES.Gertaral'Permlt MC0140000
Hildreth Ftedl4Nlx and Septic Services, Certificate of Cove e C E.403
Anson County'-
Dear Mr. Hildreth:
On September S, 2016, Joshua_Hards with the Division of Air Quality (DAQ) and Mike Dwyer with the
Division of Energy, Mineral and Land Resources (DEMLR), conducted a Multimedia Compliance Inspection
for the Hildreth Redi-Mix and Sepik Services facility located on City Pond Read in Wadesboro, Anson
County, North Carolina. A copyof'the Compliance Inspection Report Is enclosed for your review. The sub W
facility is covered by NPDES General Permit NC6,140000 under Cerlfficate of Coverage NCG140390. Permit
coverage authorizes the discharge of stormwater and process wastewater, excluding discharge from the
wetting of raw material stockpiles, from the facility to receiving waters designated as North Fork Jones
Creek, a Class WS-II;HQW,CA waterbody in the Yadldn-Pee Dad River Basin.
As a result of the site Inspection, the following permit conditions violations are noted:
1) jWm water Pollution PdaMga Elan (SPPP)
A Stormwater Pollution Prevention Plan, (SPPP) has not been developed, recorded, or properly Implemented.
Secondary containment Is not provided around bulk storage of liquid materials In accordance with permit
requirements.
2) QualftWIX2 Monftarlog
Qualitative monitoring has not been conducted and recorded In accordance with permit requirements.
i 3) &yh4lcal-Monftgrino
Analytical monitoring has not been conducted and recorded In accordance whit permit requirements.
Other Qbmwationa:
Please refer to the enclosed Compliance Inspection Report for additional comments and observations made
during the Inspection.
meammea a
You are asked to respond to this office, in wrEting, within 30 calendar days from receipt of this notice, Your
written response should include a reasonable explanation as to why the aforementioned v olatlons have
occurred as well as a Plan of Action to prevent these vfolatlons from rkiming.
S= of Nm& Cualim I llovhoammtal Qudky I lie a, Mb =4 wd Land Rummoea
AgEema" RoOmW offlm 1 2" Om" steer, Subs 714 I Fi pWvah. NC =I
9104&$-3300

}
Thank you :for your attention to.this matter. This office requires that the violations, as d lled, sbove;. b '•,•
properly rwolved. These vlalattone and any..future violations are subject to. a dull peftelty. ;'
essesernem of up to $",000 per day for each Vlolatlom Should you have any questions n 6dingAhese
matters, pleasebontact Mike Lawyer or myself at, [phone].
Sincerely,
.
Th 6ffi V. lw ,,.Pt
Regional Engineer
©EMLR
TLhi,
Enclosure
ec: Bradley Bennett, Program Manager — DEMLR, Stormwater. I ermitting Program
Laura Alexander, Administrative Assistant — DEMLH 5totmwe}er Permitting Program .
cc: kO D ML.R, Starmwater!Flles-NCG1'40390

Pmnit-NC0140380' EHacWetV 60111A , .:.:...:,. O6,WI.•..,•.:,.::7 ti",.:.,
t optraflon:. ;'., klidrath ke610bc
80C: 61ffeaave: Elgllratloe: Fpcipgr. FOIdI+eVl Redl�Mlx and Septloeryloea '
City Pond Rd,
County: Anson
fieglon: Fayrettevdue
1NadeesbOra 281i`0:
CorhaetPerson:. Karl Mdrefh Tlde: Pfions:` .704$@4-2034
Directions to Faclllgr
System Classifications:
Primary ORC: CerltRoatlon: Phone:
Secondary ORCM.,
OA41 to Reprosentid (s):
On -a be representative Kid Hildtath ' r04404-2034
Related Peftb:
tnapewonDate: 0910S12018 EntryTtrtro: i1:i0AM E:dtTirne. 12.40PM
PrdYmry inspector. Joshua Harris Phone: [phone]M
Secondary lrrtpectorlel: .
Mike l-ewY�j PFione :91Q-493�3300tPt�'
Reason for Inspection: Routine tnspaption Type: Compliance Evaluation
PermR lnspacnon Type: • Ready Mix Concrete Stam waterMsetswatnr Discharge CQC -
Pae0lty status: (] Compliant Not Compilard
4uestio n Ames:
Stun Wafer
(See attachment summary)
Page: 1

1
a
0
P"ll NCQ/40W Q-Fagelgl:H)d!a7!.Red�W
rnspecumD* oBIbeJ2ole heikeintYP+:{;dmp :2yakiidtih. RoamnforVlst Radne
Inspection Surnm'ary,
f { On 08 September 2418, Mike Lawyer FRO DEMI R, arsd I, Joshua Harris, FIZO bAq, conducted a multimedia Irrspectl6n et
1 H ureth Ready mx LLC In Waoasbono, Anson County. There were no neoards awftle it the tt 9 of tfre Inspe6ti0 j, fir..
111 H109M requested time to pivvlde the required records. Mr. Lawyer granted his,requast, and neyulried.the documents tp be
eubmlibed no laterthan 19 September 201 S. A oopy of the faculty's appl+cation for a *m wwaW peimlt was reciWd on ie
September201$,bwtnoother-6W" ibentationwaslaoelved,
This wwID be rsbmr d to DI_NILR fqr follow-up:

penA NU"44360- Oww.FaolIIfaI:HlldrodtRO"bc
hupoodon Dame: DBIeMMS tngjWon roe: 06inPllanaa EvAfu3 m Reawn (wVWb Roulne
NmbdlW n ,.
Has the Willy conducted Its Analytical mani6oMV?
# Has the faclllfy conducted its Analytical monitoring from Vehlpie Malnienance areas?
Comment Fadlity had no records on slte_atthOAme of the.insoector
0In a copy of the Pwm8 and the Cavil late of CoveMa avallable at tha site?
# Wom an outfalls observed during the kxpedlon?
# If the faaft lies reprosentatm oulfall statue, Is R properly documented.by the Melon?
# Has the fedlity eaeluetad all V&S (non stdrmwater) dlsohames?
Comment ' i~adlKv hgg ao records ort mat the UM} of The insoectlon.
Has the fad *i aorrduoted Its CWWttadve Monitoring seml•annually?
Comment Facility had no records on sly. ttme of the his
jkEMMdjMr Pollution Prer►arttlon Plan
Doan the efts haves Stornwiater Polluilorl Prever ft Plan?
# Doee the Plan fnolude a General t oosdon (USGS) map?
0 Does fife Plan Wude a %wrallvs DesWptfon of Pradlcse?
4 Does the. Plan Include a detailed aite map Including WWI locadons and drainage areas?
# Does the Plan lrrotude a Rat of signIfloard spilts oomw tg during the past 3 years?
# Has fhe faoill(jr sveluated tleaslble altemativea to cumsnt predyoes?
# Does the foolnly provide an,necessery secondary oontwMment.?
# Does the Plan include a BMP summery?
# Does th3 Plan Irdude a Spill Plevedon and Response Plan (SPRP)?
# Does the Plant Include a Prevmttadve Main6artartce and Good Housekeeping Plan?
# Does the facer provide and document F{nplayes Tminhg?
# Does the Plan include a Rat of Responelbte Pariy(s)?
# is the Plan Wivioed and updated annually?
# Does the Plan Include a SUm%vater Fadllgl inspectlon Proomn?
Has the St mmuier Pollution Prevention Plan been Imptemsnted?
Comment.
xuNq NA Nfl
❑ Q ❑
Yes No NA M&
❑ •M ❑ ❑
❑ ❑ ❑N
❑❑❑■
❑❑❑M.
❑i❑l7
❑ 1113
❑ J❑■
111300
❑❑13M.
❑❑❑•■
Page: 3

PAT MCCRORY
Governor
DONALD R. VAN DER VAART
Energy, Mineral
and Land Resources
ENVIRONMENTAL QUALITY
September 26, 2016
CERTIFIED MAIL: 7009 3410 0001 6831 2230
RETURN RECEIPT REQUESTED
Hildreth Redi-Mix
Attn: Karl Hildreth
PO Sox 1098
Wadesboro, NC 28170
Subject: NOTICE OF VIOLATION (NOV-2016-PC-0484)
NPDES General Permit NCG140000
Hildreth Redl-Mix and Septic Services, Certificate of Coverage NCG140390
Anson County
Dear Mr. Hildreth:
Secretory
TRACY DAVIS
Director
On September 8, 2016, Joshua Harris with the Division of Air Quality (DAQ) and Mike Lawyer with the
Division of Energy, Mineral and Land Resources (DEMLR), conducted a Multimedia Compliance Inspection
for the Hildreth Redi-Mix and Septic Services facility located on City Pond Road in Wadesboro, Anson
County, North Carolina. A copy,of the Compliance inspection Report is enclosed for your review. The subject
facility is covered by NPDES General Permit NCG140000 under Certificate of Coverage NCG140390. Permit
coverage authorizes the discharge of stormwater and process wastewater, excluding discharge from the
wetting of raw material stockpiles, from the facility to receiving waters designated as North Fork Jones
Creek, a Class WS-II;HQW,CA waterbody in the Yadkin -Pee Dee River Basin.
As a result of the site inspection, the following permit conditions violations are noted:
1) Stormwater Pollution Prevention Plan (SPPP)
A Stormwater Pollution Prevention Plan (SPPP) has not been developed, recorded, or properly implemented.
Secondary containment is not provided around bulk storage of liquid materials in accordance with permit
requirements.
2) Qualitative Monitoring
Qualitative monitoring has not been conducted and recorded in accordance with permit requirements.
3) Analytical Monitoring
Analytical monitoring has not been conducted and recorded in accordance with permit requirements.
Other Observations:
Please refer to the enclosed Compliance Inspection Report for additional comments and observations made
during the inspection.
Requested Response:
You are asked to respond to this office, in writing, within 30 calendar days from receipt of this notice. Your
written response should include a reasonable explanation as to why the aforementioned violations have
occurred as well as a Plan of Action to prevent these violations from recurring.
State of North Carolina I Environmental Quality I Energy, Mineral and land Resources
Fayetteville Regional Office 1 225 Green Street, Suite 714 1 Fayetteville, NC 28301
910.433-3300

Thank you for your attention to this matter. This office requires that the violations, as detailed above, be
properly resolved. These violations and any future violations are subject to a civil penalty
assessment of up to $25,000 per day for each violation. Should you have any questions regarding these
matters, please contact Mike Lawyer or myself at [phone].
Sincerely,
L45el
Timothy L. Lagy,PE
Regional Engineer
DEMLR
TVmI
Enclosure
ec: Bradley Bennett, Program Manager— DEMLR, Stormwater Permitting Program
Laura Alexander, Administrative Assistant — DEMLR, Stormwater Permitting Program
cc: FRO — DEMLR, Stormwater Files-NCG140390 U.S. Postal Service,.
m
ru
ru
m
r-i
1Q
O
C3
r�
rn
FFICI � i
.Ai L US-8
Postage $
Certified Foe
Return Receipt Fee
(Endorsement Requlred)
Restricted Delivery Fee
(Endorsement Required)
Total Postage & Fees g
Postmark
Here
9- 2 ?-/,C
PS Foun 3800. August 2006 Sue fleverse for lusiructious
• Complete Items 1, 2, and 3. Also complete A. Signature
Item 4 if Restricted Delivery is desired. '0 Agent
• Print your name and address on the reverse XUjCL+�
❑ Addressee
so that we can return the card to you. B. Received by (P a gN:e C. Date of Delivery
• Attach this card to the back of the maiipiece, g—� ^l6
or on the front if space permits,
1. Article Addressed to; D. Is delivery address different from item t? ❑ Yes
If YES, enter delivery address below: IP No
HII.,DR1 11-1 RLDW `., .
A FIN: K A K L 1-111
P.O. BOX 1098
WADESBORJ, Nt Zoi ri)
3. Service Type
XCertlfled Mall* 0 Priority Mall Express'"
❑ Registered ;Veturn Receipt for Merchandise
13 Insured Mail © Collect on Delivery
4. Restricted Dellvery? (Extra Fee) ❑ Yes
2. Artlele Number 7009 3 416 0001 6831 2230
(transfer from service fabeO —�-�—
PS Form 3811, July 2013 Domestic Return Receipt l

Compliance lnspection Report
Permit: NCG140390 Effective: 07101/16 Expiration: ' 06/30/17 Owner: Hildreth Redi-Mix
SOC: Effective: Expiration: Facility: Hiidreth Redi-Mix and Septic Services
County: Anson City Pond Rd.
Region: Fayetteville
Wadesboro NC 28170
Contact Person: Karl Hildreth Title: Phone: [phone]
Directions to Facility:
System Classificattons:
Primary ORC: Certification: Phone:
Secondary ORC(s):
On -Site Representative(s):
On -site representative Karl Hildreth 704-694-2034
Related Permits:
Inspection Date: 09/0812016 EntryTime: 11:10AM Exit Tlme: 12140PM
Primary Inspector: Joshua Harris Phone: [phone]
Secondary Inspector(s):
Mike Lawyed Phone :[phone]i}.Ekt�`19-'
Reason for inspection: Routine Inspection Type: Compliance Evaluation
Permit inspection Type: Ready Mix Concrete Stormwater/Wastewater Discharge COC
Facility Status: Compliant Not Compliant
Question Areas:
Storm Water
(See attachment summary)
Page: 1

permit: NCG140390 Owner - Facility: Hildreth Redi-MiK
Inspection Date: 09I08M18 Inspection type : Compliance Evaluation Reason for Visit: Routine
Inspection Summary:
On 08 September 2016, Mike Lawyer FRO DEMLR, and i, Joshua Harris, FRO DAQ, conducted a multimedia inspection at
Hildreth Ready Mix, LLC in Wadesboro, Anson County. There were no records available at the time of the inspection. Mr.
Hildreth requested time to provide the required records. Mr. Lawyer granted his request, and required the documents to'be
submitted no later than 16 September 2016. A copy of the facility's application for a stormwater permit was received on 16
September 2016, but no other documentation was received.
This will be referred to DEMLR for follow-up.
Page: 2

Permit: NCG140390 Owner - Facility:HlldrethRedl-Mix
Inspection Date: 0910812016 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Analytical Monitorin
Has the facility conducted its Analytical monitoring?
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas?
Comment: Facility had no records on site at the time of the inspection.
Permit and Outfalls
# Is a copy of the Permit and the Certificate of Coverage available at the site?
# Were all outfalls observed during the inspection?
# if the facility has representative outfall status, is it properly documented by the Division?
# Has the facility evaluated all illicit (non sormwater) discharges?
Comment: Faciflly had no records on site at the time of the inspection.
Qualitative Monitoring
Has the facility conducted its Qualitative Monitoring semi-annually?
Comment: Facile had_ no records on site at the time of the inspection.
Stormwater Pollution Prevention Plan
Does the site have a Stormwater Pollution Prevention Plan?
# Does the Plan Include a General Location (USGS) map?
# Does the Plan include a "Narrative Description of Practices"?
# Does the Plan include a detailed site map including outfall locations and drainage areas?
# Does the Plan include a list of significant spills occurring during the past 3 years?
# Has the facility evaluated feasible alternatives to current practices?
# Does the facility provide all. necessary secondary containment?
# Does the Plan include a BMP summary?
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
# Does the facility provide and document Employee Training?
# Does the Plan include a list of Responsible Party(s)?
# Is the Plan reviewed and updated annually?
# Does the Plan include a Stormwater Facility Inspection Program?
Has the Stormwater Pollution Prevention Plan been implemented?
Comment: Facili had no records on site at the time of the ins ectibn.
Yes No NA NE
❑ ❑ ❑
❑ ❑ ❑
Yes No NA NE
❑ ❑ ❑.0
❑❑CIE
❑❑❑®
Yee No NA NE
❑❑❑E.
Yes No _NAB
❑❑❑■
❑❑❑■
❑❑❑■
❑ ®❑ ❑
❑ ❑ ❑
❑❑❑■
❑ ❑ ❑ N
❑❑❑®
❑❑[In
❑❑[IN
❑❑❑®
❑❑❑®
Page: 3

PAT MCCRORY
Governor
DONALD R. VAN DER VAART
Environmental
Quality
19 September 2016
HILDRETH READY MIX, LLC
ATTN: KARL HILDRETH, OWNER
P.O. BOX 1098
WADESBORO, NC 28170
Subject: Multimedia Compliance Inspection
Hildreth Ready Mix, LLC
Anson County
Dear Permittee:
Department of Environmental Quality staff from the Fayetteville Regional Office conducted a
multimedia compliance inspection of Hildreth Ready Mix, LLC on 08 September 2016 for
permitted activities administered by the following Divisions:
Division of Air Division of Energy,
Quality (DAQ) Mineral, and Land
Resources (DEMLR)
The results of each applicable inspection area and any associated response actions or necessary
corrective measures are detailed in the Division specific areas of the attached reports. Should
violations be noted in the attached reports, you may receive separate enforcement related
correspondence in addition to the reports.
Secretary
If you have any questions regarding this multimedia inspection or the results of each program _-- --'--
inspection, please contact the Fayetteville Regional Office at [phone] and ask to speak
with the appropriate Division staff. Thank you for your cooperation.
encl: Air Quality Inspection Report
Stormwater Inspection Report
cc: (w/attachments)
Trent Allen, FRO
DAQ FRO Files
DEMLR FRO Files
SEQ 2 3 2016
r t34r1(C _n
State of North Carolina I Department of Environmental Quality
Fayetteville Regional Office 1 225 Green Street, Suite 714 1 Fayetteville, NC 29301
910-433-3300

NORTH CAROLINA DIVISION OF
AIR QUALITY
Inspection Report
Date: 09/ 13/2016
Facility Data
Hildreth Ready Mix, LLC
878 City Pond Road - SR 1142
Wadesboro, NC 29170
Lat: 34d 55.4970m Long: 80d 5.9570m
SIC. 3273 / Ready -Mixed Concrete
NAICS: 32732 / Ready -Mix Concrete Manufacturing
Contact Data
Facility Contact Authorized Contact Technical Contact
Kati Hildreth Karl Hildreth Karl Hildreth
Owner Owner Owner
[phone] [phone] [phone]
Comments:
Inspector's Signature: —�
Date of Signature: 091s/ao.4.
Fayetteville Regional Office
iiildreth Ready Mix, LLC
NC Facility ID 0400045
County/FIPS: Anson/007
Permit Data
Permit
Issued
Expires
Classification
Permit Status
Current Permit Application(s) None
Program Applicability
SIP
Compliance Data
Inspection Date 09/08/2016
Inspector's Name Joshua L. Harris
Operating Status Operating
Compliance Code Compliance - inspection
Action Code FCE
On -Site Inspection Result Compliance
l Tntal Actnai emivcinns in TONS/VRAR! l
TSP
S02
NOX
VOC
CO
PM10
*HAP
2012
0.7200
---
0.2200
0,0610
2007
0.8240
---
---
---
•--
0.2410
0.0700
Five Year Violation History: None
Date Letter Tyne Rule Violated
Performed Stack Tests since last FCE: None
Date Test Results Test Method(s)
* Highest HAP Emitted (i
Violation Resolution Date
Sources Tested

1. DIRECTIONS TO SITE: In Wadesboro, take Hwy 742 south for-3.5 miles to City Pond Road and turn
right. Hildreth Ready Mix is approximately 2 miles on the right. If no one is at the plant, take Hildreth
Road, which is just past plant, up to the office on the right.
II. SAFETY: Standard FRO safety gear is required. The inspector should be mindful of vehicular and
heavy equipment traffic.
III. FACILITY/PROCESS DESCRIPTION: Hildreth Ready Mix is a small concrete batch plant. Cement
is stored in a silos and mixed with aggregate and sand (both stockpiled on site), all of which is mixed with
water inside a cement truck. The loadout, and two of the three silos are controlled by a central dust
collector, one of these two silos has its own baghfilter in series with the central dust collector; the third
silo is controlled by a single, dedicated bagfilter. To produce the septic tanks, cement is poured into
1,000-gallon,1,200-gallon, or 1,500-gallon molds and allowed to cure for 28-30 days. The molds are
removed and septic tanks are delivered and installed on site. Although septic tanks are still produced on
site, most of Mr. Flildreth's business now is delivering concrete from his batch plant, which is operated on
an "as needed" basis.
The facility requested to have the air quality permit rescinded on 01 July 2016 under the newly adopted
2Q .0102(d) exemption. The facility's permit was rescinded on 19 July 2016. The rescission request was
granted based on calculations which assume the facility's emission sources are controlled by bagfilters
which are properly maintained and operated.
Operating hours 0800-1700 Monday=Friday w/
occasional Saturday
Emolovees 5 including drivers
Production (cu yd) 2015. 7,972.5
2014: 6,000
2013: 2,000
2012: 3,397
2011: 3,272
IV. INSPECTION SUMMARY: On 08 September 2016, Mike Lawyer, FRO DEMLP, and I, Joshua Harris
FRO DAQ, arrived on site to conduct a multimedia inspection of Hildreth Ready Mix, LLC. We met
Karl Hildreth, Owner, and Chanel Little, Secretary, in the facility's office. Mr. Hildreth verified the
FacFinder information, and noted no changes. We began discussing the current process DAQ is using
regarding inspections for facilities which have rescinded their air permits, and Mr. Hildreth stated that he
did not want to rescind his permit. I informed him that the permit was already rescinded, and that a letter
requesting rescission was received. We were able to locate copies of the original request documents, for
registration and rescission, that were submitted to DAQ. Mr. Hildreth reiterated that he did not want to
rescind the permit, and would like to have the permit reissued.
After the rescission discussion, we attempted to locate the facility's production records and the
maintenance records for the bagfilters. Ms. Little was able to provide the requested production records,
but W. Hildreth stated that he does not keep records of maintenance conducted on the bag houses. He
stated that every two months, be removes the bags, washes them, cleans out the bag house, and reinstalls
the bags. I reminded Mr. Hildreth that when his permit is reinstated, he will be required to keep records
for inspections and maintenance performed on the facility's bagfilters. Mr. Hildreth stated that he
understood and would start keeping those records. We then toured the batch plant.

16
The facility was not operating at the time, but Mr. Hildreth pointed out how each source is controlled, and
pointed out each emission point. We asked if there are any visible dust emissions while the plant is
operating, and Mr. Hildreth stated that some dust will come out of the enclosure during loadout, but that
there is never any dust visible at the baghouse exhausts. ' After touring other parts of the property for the
stormwater inspection, we departed.
V. EQUIPMENT ON SITE:
A. One weigh hopper and loadout operation;
B. Three silos for cement storage; and
C. Sand and Aggregate stockpiles and handling equipment.
VI. APPLICABLE AIR QUALITY REGULATIONS:
A. 15A NCAC 2D .0515 — PARTICULATES FROM MISC. INDUSTRIAL PROCESSES —
Particulate emissions shall not exceed allowable emission rates as calculated by the following
equations:
E = 4.10 * (P) "7 for P c 30 tons/hr, or
E = 55 * (P)'-" - 40 for P >30 tons/hr
APPEARED INCOMPLIANCE: These calculations were made when the facility was permitted,
and the previous permit reviews indicated that that facility, when controls are properly maintained
and operated, would not exceed these limits. The facility's particulate emissions are controlled by
hagf lters. Each bagfilter appeared to have regular maintenance conducted, and there were no dust
accumulations near their exhaust points which would indicate an operational problem.
B. 15A NCAC 2D .0521— CONTROL OF VISIBLE EMISSIONS — Visible emissions shall not
exceed 20% opacity.
APPEARED INCOMPLIANCE: The facility was not operating at the time of the inspection. Mr.
Hildreth stated that he does not see visible emissions while the plant is operating, outside of
occasional fugitive emissions at loadout and that he hasn't received any recent dust complaints.
DAQ has not received any recent complaints pertaining to this facility.
C. 15A NCAC 2D .0535 —NOTIFICATION REQUIREMENT —Notify DAQ in the event of excess
emissions lasting longer than 4 hours resulting from malfunctions, breakdowns, or abnormal
conditions.
APPEARED IN COMPLL4NCE: There are no indications of any excess emissions which would
require a notification by the facility. Mr. Hildreth eagerly pointed out that there are no dust
accumulations near the baghouse exhausts. There have been no recent complaints received by the
facility or DAQ.

D. 15A NCAC 2D .0540 —PARTICULATES FROM FUGITIVE DUST EMISSION SOURCES —
Fugitive dust emissions shall not contribute to substantive complaints, or excessive dust emissions
across the property boundary.
APPEARED I1V COMPLIANCE: No fugitive dust concerns at the property boundaries were noted
during the inspection, though the facility is located just off of the street. The facility was not
operating at the time of the inspection, and we did not observe a truck loadout. There have been dust
complaints in the past associated with the truck loadout, but none have been received by DAQ in the
past year. Mr. Hildreth stated that he has received past dust complaints which prompted him to
upgrade his dust collection system. The system was observed in operation during the previous
inspection, and visible emissions at the loadout were noted to be —10% opacity at that time.
VII. NON-COMPLIANCE HISTORY SINCE 2010:
03/28/16 NOD issued for late annual reporting.
05/28/10 NOV issued for late annual reporting.
VIII. RISK MANAGEMENT (112r): This facility does not use or store any 112(r) subject materials above
threshold limits. Therefore, it is not required to maintain a written Risk Management Plan (RMP).
IX. CONCLUSION AND RECOMMENDATIONS:
Hildreth Ready Mix, LLC. appeared to be IN. COMPLIANCE with applicable air quality
regulations on the date of inspection.
PINK SHEET ADDITIONS:
- None.
/j lh

Compliance Insuection Report
Permit: NCG140390 Effective: 07/01/16 Expiration: 06/30/17 Owner: Hildreth Redi-Mix
SOC: Effective: Expiration: Facility: Hildreth Red'+ -Mix and Septic Services
County: Anson City Pond Rd
Region: Fayetteville
Wadeshoro NC 28170
Contact Person: Karl Hildreth Title: Phone: [phone]
Directions to Facility:
System Classifications:
Primary ORC: Certification: Phone:
Secondary ORC(s):
On -Site Representative(s):
On -site representative Karl Hildreth 704-694-2034
Related Permits:
Inspection Date: 09108/2016 Entry Tlme: 11:10AM Exit Time: 12:40PM
Primary Inspector: Joshua HarrisPhone: 910-433-3367
Secondary inspector(s):
Mike Lawyer,�� Phone :[phone]
Reason for Inspection: Routine ���� Inspection Type: Compliance Evaluation
Permit Inspection Type: Ready Mix Concrete Stormwater/Wastewater Discharge COC
Facility Status: [] Compliant Not Compliant
Question Areas:
■ Storm Water
(See attachment summary)
Page: 1

J
Permit: NOG140390 Owner - Facility; Wdreih Red i-Mix
Inspection Date: 012108/2016 Inspection Type : Compliance Evaluation Reason for Visit: Routine
Inspection Summary:
On 08 September 2016, Mike Lawyer FRO DEMLR, and I, Joshua Harris, FRO DAG, conducted a multimedia inspection at
Hildreth Ready Mix, LLC in Wadesboro, Anson County. There were no records available at the time of the inspection. Mr.
Hildreth requested time to provide the required records. Mr. Lawyer granted his request, and required the documents to be
submitted no later than 16 September 2016, A copy of the facility's application for a stormwater permit was received on 16
September 2016, but no other documentation was received.
This will be referred to DEMLR for follow-up.
Page: 2

A
Permit: NGG140390 Owner - Facility:HildrethRedi-Mix
Inspection Date: 09108/2016 Inspection Type : Compliance Evaluation Reason for Veit Routine
Analytical Monitorinn Yes No_NA NE
Has the facility conducted its Analytical monitoring? ❑ ❑ ❑
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas? ❑ ❑ ❑
Comment: Facility had no records on site at the time of the inspection.
Permit and Outfalls )Leg No NA NE
# Is a copy of the Permit and the Certificate of Coverage available at the site? ❑ ❑ ❑
# Were all outfalls observed during the inspection? ❑ ❑ ❑
# If the facility has representative outfall status, is it properly documented by the Division? ❑ ❑ ❑
# Has the facility evaluated all illicit (non stormwater) discharges? ❑ ❑ ❑ ■
Comment: Facility had no records on site at the time of the inspection.
Qualitative Monitoring Yes No NA NE
Has the facility conducted its Qualitative Monitoring semi-annually? ❑ ❑ ❑ �.
Comment: Facility had no records on site at the time of the inspection_
Stormwater Pollution Prevention Plan
Yes No NA_Nt:
Does the site have a Stormwater Pollution Prevention Plan?
❑ N ❑ ❑
# Does the Plan include a General Location (USGS) map?
❑ ❑ ❑ 0
# Does the Plan include a "Narrative Description of Practices'?
❑ ❑ ❑ 0
# Does the Plan include a detailed site map including outfall locations and drainage areas?
❑ ❑ ❑
# Does the Plan include a list of significant spills occurring during the past 3 years?
❑ ❑ ❑
# Has the facility evaluated feasible alternatives to current practices?
❑ ❑ ❑
# Does the facility provide all, necessary secondary containment?
❑ 0 ❑ ❑
# Does the Plan include a BMP summary?
❑ ❑ ❑
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
❑ ❑ ❑
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
❑ ❑ ❑
# Does the facility provide and document Employee Training?
❑ ❑ ❑
# Does the Plan include a list of Responsible Party(s)?
❑ ❑ ❑ N
# Is the Plan reviewed and updated annually?
❑ ❑ ❑ E
# Does the Plan include a Stormwater Facility Inspection Program?
❑ ❑ ❑
Has the Stormwater Pollution Prevention Plan been implemented?
❑ ❑ ❑
Comment: Facility had no records on site at the time of the inspection.
Page: 3

Energy, Mineral
and Land Resources
ENVIRONMENTAL OUALITY
May 31, 20t6
Hildreth Redi-Mix
Attn: Karl Hildreth,
PO Box 1098
Wadesboro, NC 28170
Subject: NPDES Industrial Stormwater Permit Renewal
Certificate of Coverage No. NCG140390
Hildreth Redi-Mix and Septic Services
Dear Permittee:
PAT MCCRORY
Governor
DONALD R. VAN DER VAART
Secretary
TRACY DAVIS
Director
Your NPDES stormwater permit will expire on 6/30/2016. The N.C. Division of Energy, Mineral and
Land Resources (DEMLR) will renew your permit unless you no longer require coverage. We are writing
to update you on the status of your renewal Certificate of Coverage (COC).
The Division plans to reissue this General Permit "as is" for another year before revising the permit. We
published public notice of this action earlier this month, with a comment period ending on June 15, 2016.
The public notice on our Public Notices and Hearings Calendar can be found with a begin date of
05/01/2016: http:l/deq.iic.gov/news/cvents/public-notices-hearings. We will not issue you a new
renewal COC until the General Permit is revised next year.
However, we do need to know whether you intend to renew coverage under this General Permit.
Your renewal request will be honored next year once the new permit is issued and COCs are distributed,
and so it is important that you submit your renewal request and verify the contact information for your
permit per the instructions below.
To begin the renewal process, please review the enclosed summary of permit contact information.
Then follow these steps to ensure we have accurate information:
1. Visit our website at www.swpermits.ne to enter your renewal request and contact
information into the web form there. Please do this no later than ,June 30, 2016.
2. Please be sure to enter a valid e-mail address for the Permit Contact. This is how we will
communicate updates throughout the renewal process.
3. As you fill out the form, indicate what contacts should be updated or corrected. Note:
a. Changes to Owner Affiliation (Person Legally Responsible for Permit) require that a signed
form be submitted to us for the permit record. Please visit our website to find the appropriate
form, dependent on whether or not a Name/Ownership Change has occurred
(http;l/elect.ne.„ov/about/divisions/energy-mineral-Ian-resourceslener y-minerai-land-
permi is/stormwaler-nermits/npdes-i ndustri al-sw).
b, Owner Contact, Facility Contact, Permit Contact, and Permit Billing Contact changes
can simply be e-mailed (stormwater@ncdelango_v), faxed to [phone], or mailed back
to us with changes noted.
State of North Carolina I Environmental Quality I Energy, Mineral and Land Resources
1612 Mail Service Center 1 512 N. Salisbury St. I Raleigh, NC 27699
919 707 9200 T

4. Please confirm a correct e-mail address for the Permit Contact. It is important! This is also
the a -mail address that will receive the electronic confirmation upon submittal.
5, After you submit the survey, the confirmation page will direct you to a map link. On that map,
you can search for your permit COC number to locate your facility. Click on the permit
location point and review the information in the pop-up box window. Please let us know if
anything is incorrect.
6. If you have any questions, or you wish to request a paper renewal package instead of receiving
your COC electronically next year, please contact us at ,[e-mail] or by calling
[phone].
We ask that you submit your renewal request no later than June 30, 2016. This will allow us to
communicate to all permittees ahead of final permit actions this year and next year.
What's next? Please check our website for updates (www,swpermits..aoy). We will also communicate
updates by e-mail, including when a revised General Permit is proposed for issuance. Next year, when
NC DEQ has renewed the General Permit and your new COC is ready, we will direct you to this same on-
line map to print the documents for your records. We will contact you by e-mail to let you know the new
permit is ready, or if you requested a paper package, we will mail you that package instead. We
encourage all permittees to provide an e-mail address for the most efficient communication time.
What about the new Electronic Reporting Requirements? This past December, the new NPDES
Electronic Reporting Rule became effective. This rule will phase in requirements for permittees to report
outfall monitoring data and other information over a five-year period. By December 2016, permittees
must begin submitting data monitoring reports (DMRs) electronically either to the state or to EPA
directly. NC DEMLR is working with the Division of Water Resources (DWR) to implement a system to
receive DMR data electronically from our permittees, In the coming months, we will need to collect
information about the outfall locations at your facility. As we develop a process for complying with the
new federal requirement, we will contact you with more guidance.
Discharge of stormwater without coverage under a valid Stormwater NPDES permit constitutes a
violation of N.C. General Statute 143-215.1 and may result in the assessment of civil penalties of up to
$25,000 per day. Please follow these steps as soon as possible to ensure a timely renewal.
If you have questions, please contact Stormwater Permitting Program staff at [phone].
Sincerely,
t5
Bradley Bennett, Supervisor
Stormwater Permitting Program
Division of Energy, Mineral and Land Resources, NCDEQ
cc: Central Files
Stormwater Program Files
State of North Carolina I Environmental Quality I Energy, Mineral and Land Resources
1612 Mail Service Center 1 512 N. Salisbury St. I Raleigh, NC 27699
919 707 9200 T

v1
DENR--FRCS
A A
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue
Governor
Karl Hildreth
Hildreth Septic Tanks
PO Box 579
Wadesboro, NC 28170
Dear Permittee:
Charles Wakild, R E,
Director
November 20, 2012
NOV 2 6 2012
DWQ
Dee Freeman
Secretary
Subject: NPDES Stormwater Permit Coverage Renewal
Hildreth Spetic Tanks
COC Number NCG070159
Anson County
In response to your renewal application for continued coverage under Stormwater General Permit
NCG070159 received October 1, 2012, the Division of Water Quality (DWQ) is forwarding herewith the
reissued Certificate of Coverage and stormwater General Permit. This permit is reissued pursuant to the
requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between
the state of North Carolina and the U.S. Environmental Protection Agency, dated October 15, 2007 (or as
subsequently amended.)
The following information is included with your permit package:
• A new Certificate of Coverage
+ A copy of the stormwater General Permit
• A copy of it Technical Bulletin for the General Permit
• Copies of the Discharge Monitoring Report (DMR) Form
• Copies of the Annual Discharge Monitoring Report Form (if applicable)
• Copies of the Qualitative Monitoring Report Form
The General Permit authorizes discharges of stormwater only, and it specifies your obligations with
respect to stormwater discharge controls, management, monitoring, and record keeping. Please review
the new permit to familiarize yourself with all changes in the reissued permit. Significant changes to the
General Permit are outlined in the attached Technical Bulletin.
Your coverage under the General Permit is transferable only through the specific action of DWQ.
This permit does not affect the legal requirements to obtain other permits which may be required by
DENR, nor does it relieve the permittee from responsibility for compliance with any other applicable
federal, state, or local law, rule, standard, ordinance, order, judgment, or decree.
1617 M0 Service Center, Raleigh, North Carolina 27699.1617
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604-
Phone: 9IM07-63001 FAX: [phone] Customer Servlce:1-877-623.6748
Internet: W0,9materauaiity.ora One
An Equel opportunity 1 AMrmative Action Employer North Caro 1 i n a
Naturally

If you have any questions regarding this permit package please contact the DWQ Stormwater Permitting
Unit at 919-807-6300.
Sincerely,
ORIGINAL SIGNED B)
KEN PICKLE
for Charles Wakild, P.E.
cc: DWQ Central Files
Stormwater Permitting Unit Files
Fayetteville Regional Office, Surface Water Protection Section Supervisor

4
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCGO70000
CERTIFICATE OF COVERAGE No. NCG070.159
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
H ildreth Septic Tanks
is hereby authorized to discharge stormwater from a facility located at:
Hildreth Septic Tanks
Sr 1142
Wadesboro
Fayetteville County
to receiving waters designated as North Folk .tones Creek, a class C waterbody in the
Yadkin -Pee Dee River Basin in accordance with the effluent limitations, monitoring
requirements, and other conditions set forth in Parts I, II, I1I, IV, V, and VI of the Genera!
Permit as attached.
This certificate of coverage shall become effective November 20, 2012.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day November 20, 2012.
ORIGINAL SIGNED M
KEN PICKLE
for Charles Wakild, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

NCDE V%
North Carolina Department of Environment and
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins
Governor Director
April 3, 2009
Mr. Karl Hildreth
Hildreth Redi-Mix & Septic Services
PO Box 1098
Wadesboro, North Carolina 28170
Natural Resources
DWQ
Subject: General Permit No. NCG140000
Dee Freeman
Secretary
Hildreth Redi-Mix & Septic Services
(Wadesboro Plant) '
COC No. NCG140390
Anson County
Dear Mr. Hildreth:
In accordance with your application for a discharge permit received on February 5, 2009,
we are forwarding herewith the subject certificate of coverage (COC) to discharge under the
subject state — NPDES general permit. This permit is issued pursuant to the requirements of
North Carolina General Statute 143-215.1 and the Memorandum of Agreement between North
Carolina and the US Environmental Protection Agency dated October 15, 2007 (or as
subsequently amended).
Please note that this COC contains a special additional requirement limiting total
suspended solids (TSS) in any process wastewater discharge to no greater than 20 mg/L. This
additional limitation is consistent with North Carolina environmental rules found in
15A NCAC 02B.0224(b)(ii), the water quality standards applicable to High Quality Waters
(HQW). In. accordance with the information presented in your application, your facility
discharges to waters classified as HQW, and the cited rule applies to site discharges of
commingled stormwater and process wastewater from the proposed wastewater recycle
system.
This COC does not allow discharge from the irrigation of raw material stockpiles,
which'is defined as a wastewater, from this site. This stipulation is a result of the information
presented in the application and gathered during technical review of your process operations at
this plant.
Please note that your facility drains to an area where there' are threatened and
.endangered species. The Single -flowered Sandwort (Minuartia uniflora) is an endangered
species that has been identified near your facility and the Piedmont Quillwort
Wetlands and Stormwater Branch 1�T
1617 Mail Service Center, Raleigh, North Carolina 27699.1617 1� �118
O Carolina
Location: 512 N. Salisbury 5t. Raleigh, North Carolina 27604 � �ul'N� r��
Phone: [phone] FAX: [phone] Customer Service: 1.877-623.6746 a `
Internet: www.ncwaterquality.org
An Equal opportunity 1 Affirmative Action Employer

Mr. Karl Hildreth
iildreth Redi-Mix & Septic Services
NCGl40390
April 3, 2009
(Isoetes piedmontana) is a threatened species that has been identified near your facility. Failure to
abide by your stormwater permit may constitute violation of the Threatened and Endangered
Species Act.
This certificate of coverage is not transferable except after notice to the Division of Water
Quality. The Division of Water Quality may require modification or revocation and reissuance
of the certificate of coverage. This permit does not affect the legal requirements to obtain other
permits which may be required by the Division of Water Quality or permits required by the
Division of Land Resources, Coastal Area Management Act or any other federal or local
governmental permit that may be required. .
Note that any future construction, installation, or modification of wastewater treatment
facilities (including process wastewater recycle systems) will require an Authorization to
Construct (ATC) prior to construction per 15A NCAC 2H .0138 & .0139. You must submit, in
triplicate, plans/specifications and design calculations, stamped and sealed by a professional
engineer, with a letter requesting an ATC to the Stormwater Permitting Unit,1617 Mail Service
Center, Raleigh, NC 27699-1617.1
Earlier this month the Division of Water Quality extended the expiration date of General
Permit No. NCG140000 for an additional two years. This discharge permit shall expire on July
31, 2011. if you have any questions concerning this permit, please contact Cory Larsen at
telephone number [phone].
Sincerely,
ORIGINAL SIGNED BY
KEN PICKLE
for Coleen H. Sullins
cc: Fayetteville Regional Office, Mike Lawyer
Central Files
Stormwater Permitting Unit Files
encl.

4
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG140000
CERTIFICATE OF COVERAGE No. NCG140390
STORMWATER AND PROCESS WASTEWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Hildreth Redi-Mix & Septic Services
is hereby authorized to operate a process wastewater recycle system and to discharge stormwater
and process wastewater, excluding discharge from the wetting of 'raw material stockpiles, from a
facility located at
Hildreth Redi-Mix & Septic Services (Wadesboro Plant)
City Pond Road
Wadesboro
Anson County
to receiving waters designated as North Fork Jones Creek, a class WS-II; HWQ, Critical Area
water in the Yadkin Pee Dee River Basin, in accordance with the effluent limitations, monitoring
requirements, and other conditions set forth in Parts I, II, III, IV, V, and VI of General Permit -No.
NCG140000 as attached. Additionally, discharges from the process wastewater recycle system
are further limited to containing no more than 20 mg/L of Total Suspended Solids.
This certificate of coverage shall become effective April 3, 2009.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this 3`a day of April, 2009.
ORIGINAL SIGNED BY
KEN PICKLE
for Coleen H. Sullins., Director
Division of Water Quality
By the Authority of the Environmental Management Commission

LOCA1 A ION MAP:
X4
7 1 1.
X1. 2
ON
NCG140390
NV 7
S
lvb,o Scale 1-20,000
I reth'Re(
31
J, ew 6'
A
4
Hildreth Red! -Mix and Septic Services
Latitude: 350 55' 30" N
Longibide: 800 05'57" W
County: Anson
Receiving Stream: North Fork ]ones Creek
Stream Class; WS-II; HQW, Critical Area
Sub -basin: 03-07-17 (Yadkin Pee Dee River Basin)
Facility Location

Re: Hildreth Redi-Mix & Septic Services -- NCG 140390 Page 1 of 2
Re: Hildreth Red! -Mix & Septic Services -- NCG140390
Cory Larsen [[e-mail]]
Sent: Friday, March 20, 2009 3:26 PM
To: Mike Lawyer [Mike,[e-mail])
Cc: Debra Benoy [[e-mail]]; Belinda Henson [[e-mail]]; Julie Ventaloro
[Jul [e-mail]); James,[e-mail]
Mil ke , ^—
Julie spoke with Anson county today and they actually don't have or
aren't implementing a WS Watershed Protection program. So, she's going
to visit them and help them get up to speed. As far as this facility is
concerned though, we are back to where we were. I suppose I'm OK with
issuing as are you it sounds so I will wait to hear back from DEH unless
you think otherwise.
Cory
Mike Lawyer wrote:
> Cory,
> I had never realized that the facility was in a WS-II;HQW watershed.
> The receiving stream was apparently reclassified sometime after 2003
> because their previous permit coverage under NCG070000 has stream
> classified as C waters. Should we check with the local government to
> make sure that they have reviewed and approved the project for
> compliance with their Water Supply Watershed Protection Ordinance?
> Beyond that, I say go ahead with issuance.
> Mike
> Cory Larsen wrote:
>> Mike,
>> I've processed the NOI from the subject facility in Anson County and
>> I believe you guys are familiar with them. They will recycle
>> process/wash water and have the ability to hold the 25yr-24hr storm
>> so I expect under this NCG14 (SW/WW) permit they will primarily
>> discharge stormwater and possibly sometimes wastewater.
>> The receiving water is North Fork Jones Creek (WS-II; HQW, critical
>> area). I've attached the NOT, site plan, and topo map. Should I go
>> ahead and issue?
>> Debra,
>> Any concerns on DEH's end on this facility? I'll move ahead within
>> 30 days if no response. Thanks to you both. --
>> Cory Larsen Environmental Engineer NCDENR I DWQ I Stormwater
>> Permitting Unit 1617 Mail Service Center, Raleigh, NC 27699-1617 512
>> N. Salisbury St, Raleigh, NC 27604 Phone: [phone] Fax: (919)
>> B07-6494
>> E-mail correspondence to and from this address may be subject to the
>> North Carolina Public Records Law and may be disclosed to third parties,
https://niail.nc.gov/owa/?ae=Item&t=[PM.Note&id=RgAAAAC7uSFCOgIVQZdPwg0u%... 4/13/2009

k
�, + Re: Hildreth Redi-Mix & Septic Services -- NCG 140390 Page 2 of 2
Cory Larsen
Environmental Engineer
NCDENR I DWQ I Stormwater Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
512 N. Salisbury St, Raleigh, NC 27604
Phone: [phone]
Fax: [phone]
E-mail correspondence to and from this address may be subject to the North Carolina
Public Records Law and may be disclosed to third,parties.
https://mail.nc.gov/owa/?ac=Item&t=I PM.Note&id=RgAAAAC7uSPCOgI VQZdllwg0u%... 4/ 13/2009

Re: Hildreth Redi-Mix & Septic Services -- NCG140390
Subject: Re: Hildreth Redi-Mix & Septic Services -- NCG140390
From: Mike Lawyer <[e-mail]>
Date: Thu, 19 Mar 2009 15:22:39 -0400
To: Cory Larsen <[e-mail]>
CC: Debra Benoy <Debra.Benoy@ne mail.net>, Belinda Henson <[e-mail]>
Cory,
I had never realized that the facility was in a WS-II;HQW watershed_ The receiving stream was apparently
reclassified sometime after 2003 because their previous permit coverage under NCG070000 has stream classified as C
waters. Should we check with the local government to make sure that they have reviewed and approved the project for
compliance with their Water Supply Watershed Protection Ordinance? Beyond that, I say go ahead with issuance.
Mike
Cory Larsen wrote:
[ Mike,
I've processed the NOI from the subject facility in Anson County and I believe you guys are familiar with them.
They will recycle process/wash water and have the ability to hold the 25yr-24hr storm so I expect under this
NCG14 (SW/WW) permit they will primarily discharge stormwater and possibly sometimes wastewater.
The receiving water is North Fork Jones Creek (WS-II; HQW, critical area). I've attached the NOI, site plan, and
topo map. Should I go ahead and issue?
Debra,
Any concerns on DEH's end on this facility? I'll move ahead within 30 days if no response. Thanks to you both.
Cory Larsen Environmental Engineer NCDENR I DWQ I Stormwater Permitting Unit 1617 Mail Service Center, Raleigh,
NC 27699-1617 512 N. Salisbury St, Raleigh, NC 27604 Phone: [phone] Fax: [phone]
E-mail correspondence to and from this address may be subject to the North Carolina Public Records Law and may be
disclosed to third parties.
lM'f
Michael Lawyer
Environmental Specialist
NCDENR-Division of Water Quality
Surface Water Protection Section
Fayetteville Regional Office
Direct: [phone]
Main: [phone]
Fax: [phone]
1 of 2 3/20/2009 9:36 AM

4�
r
CCDEElR
North Carolina Department of Environment and Natural Resources -
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor director DWV®—Fry
Mr. Karl Hildreth
February 11, 2009 FES 13 28J9
-
P.O. Box 1098 DWQ
Wadesboro, North Carolina 28170
Subject: NPDES Stormwater General Permit
NCG140000 Application—
Hildreth Redi-Mix & Septic Services
Application Return (Return #1207)
Anson County
Dear Mr. Hildreth:
On February 5, 2009, the Division of Water Quality received your Notice of Intent (NOI)
requesting coverage and an Authorization to Operate (ATO) under general stormwater and
wastewater permit NCG140000. After preliminary review, the Stormwater Permitting Unit
(SPU) has determined the submitted application materials are incomplete. The deficiencies are
explained below to help you resubmit a complete application.
NOI Application Fee: The submitted application did not include a check for $100 made
out to NCDENR (first item of checklist on Page 5). This is the primary reason for the
return of this application.
The cover letter from Mr. Dennis states that he "understood that the fee amount of $100
was submitted August 15, 2008." However, the fee payment to which he refers was
payment of the annual fee invoice for General Permit NCG070159. That payment was
separate from, and cannot be applied towards, the fee required for an NOI application for
General Permit NCG 140000. Enclosed is the letter from the Fayetteville Regional Office
dated September 10, 2008 that also references that payment and explains why it is
necessary to submit an NOI application for NCG 140000. Please resubmit your
application for this plant with the appropriate payment of $100.
— Other items of additional information will be helpful to provide for the DWQ staff member who
will be assigned to review your re -submittal. Those items continue on the next page:
Wetlands and Stormwater Branch
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
Location: 612 N. Salisbury St, Raleigh, North Carolina 27604 OnePhone:919-807-63001FAX:[phone]CustomerService:1-877-623-6748
rqualit.org Internet wwnwateNO Carolna
� I/
An Equal opportunity 1 Aflirmative Actlon Empluyer atm`yaS `y

Mr. Karl Hildreth
Hildreth Redi-Mix & Septic Services (Wadesboro)
NCG140000 Application Return
February 11, 2009
2. Design Calculations and Basis for Recycle System: The application included
demonstration that the recycle basin is large enough to contain the 25-year, 24-hour rain
event, as well as room for solids accumulation, freeboard, and assumptions about truck
wash inputs. However, there is no water balance provided for the recycle system. How
much water will be used in the concrete mixers on a daily basis? The plans note that the
wet well pump will activate when water is 0.5 ft deep, but that does not demonstrate that
the 6000-gal tank shown on the plans is sufficient to contain any accumulated water after
several days' time. A water balance should show all Inputs - Outputs = No
Accumulation. (In other words, please provide assumptions regarding what will be
drawn out on a daily basis to show the system can maintain freeboard). It would be
advisable to address how rainwater that enters the system in a large event could be used
in the process (or properly disposed of) within a reasonable time frame so that capacity is
restored before subsequent rains.
3. Site Plans: A more detailed view of the recycle system itself would be helpful. The
plans do note a bottom elevation of 460', but spot elevations at 465' at the rim of the
system are different from the 463.85' noted in the calculations (or is this a demonstration
that the walls are tall enough?). It is also unclear whether this system is a sloped, earthen
pit or constructed concrete basin with vertical walls.
The plans indicate where grab samples are to be taken at two locations. However, a
stormwater or wastewater discharge point is not noted at the end of the `Prop. Grass Line
Swale' in the center of the property. This swale appears to drain any stormwater that
would fall on aggregate piles. According to the application, the aggregate piles are not
irrigated. [However, please remember that should water stored in the tank from the
recycle system ever be used to spray those aggregate piles down, any discharges coming
from those piles would be wastewater and will have to be treated to meet effluent limits.
We note in this submittal that you are not proposing any pH adjustment, which would be
unacceptable if the system were not a non -discharging, closed -loop recycle system.]
Please indicate whether this is a stormwater discharge point and ensure that the
application accurately reflects any plans to irrigate piles, even if very infrequent.
The return of this application does not affect the legal requirements to obtain other
permits which may be required by the Division of Water Quality or permits required by the
Division of Land Resources, Coastal Area Management Act or any other federal or local
governmental permit or approval that may be required.
J

:. Mr. Karl Hildreth
Hildreth Redi-Mix & Septic Services (Wadesboro)
NCG140000 Application Return
February 11, 2009
The NOI application and all attached materials are being returned to you with this letter.
If you have any questions concerning this matter, please contact Bethany Georgoulias at (919)
807-6372. Please resubmit your application with the appropriate fee and any other necessary
changes to the attention of the Stormwater Permitting Unit.
Sincerely,
far Coleen H. Zljfins
cc: Fayetteville Regional Office/ Mike Lawyer
James M. Dennis/ SEPI Engineering Group Inc./ 7506 E. Independence Blvd., Suite 122/
Charlotte, NC 28227
Stormwater Permitting Unit Files
enclosure

P. o. Box 725
Wadesboro, North Carolina 28170
February 18, 2009
Subject: DWQ Letter of Feb. 1 l , 2009 — Hildreth Redi-Mix & Septic Services -
(Return #1207)
Memo. To: C H. Sullins
From: James is
The subject letter was received February 16, 2009. We are resubmitting the application
with the appropriate payment of $100 (Check Attached). We answered, on a separate
sheet, your concerns in items 2 & 3 of the subject letter.
Enclosure/attachment.
ZJ
540
,,,,1��4-'s "7�n o u-el 'ro b�: i d '� ; � tom- y.�- ►,�
c-rre,s4. bra► �I�--�-�-; . 7q s s lc 6 z
e" ct ?A42. -Y � � " � p �
I ' AviVi 1
rlao Swt , � 1
W
�r
o{
Yiu�' S �y
L�Ad
PIR
ai.73

1
���rr� n)a AGIiN(,f UST, ONLY
Mr DaxI e 'red
Yeor Mrxrh tr.
� Division of Water Quality J Surface Water Protection
c. c: �,-,-
NCDENR National Pollutant Dirchar a Elimination S yslow
Chexk � Amxun
,w i.�arrlrrv,.swU _)
NCG140000 '� • ""' °
nr
NOTICE OF INTENT
National Pollutant Discharge Elimination System application for coverage under General a mlt Rai
NCG140000: 9
STORMWATER AND PROCESS WASTEWATER DISCHARGES associated with activltlos ci P31 i-i'
SIC (Standard Industrial Classiticatlon) Code - 3273 Ready Mixed Concrete o
For liM plant sites that will discharge or recycle process wastewater (oven if commingled
sformwater): This NOI is also an APPLICATION FOR 6ulhorizatlon to Construct (ATC) was -
treatment facilities. ATC requests must be submitted at least 90 days prior to construCtior
Forox0l plant sites discharging or recycling process wastewater (even if commingred wilt)
srormwater): This NOI is also an APPLICATION FOR APIUriz—ationso continue to oomrate wastewater
treatment facilities in place. Construction, modification, or installation of any new treatment components
at an existing site requires an ATC.
Treauuen[ facilities used to lrcat or reeycle process wastewater (including stnrmwater Bivll' Str1IClureS
treating process wastewater flows commingled will) stnnmwotcr} require an ATC prior to conslruclion
per 15A NCAC 211 .0139. •the authorization to Coasiruct nr continue to operate will he issued al the
Same lime as 1heCerlificatc of Coverage (COC) for the NCG14 permit. D sign of trcaunent facilities
must comply with requirements of 15A NCAC 211,0138 8c .0139.
Construction of wastewater treatment facilities (this Includes recycle systems) at now a existing plant
sites requires submission of three (3) sets of plans and specifications signed and sealed by a
Professional Engineer (P.E.) or qualified stall" along with this application. A copy of the design
calcutallons should be Included. Please see questions 14 a 15.
For questions, please contact the OWO Regional Office for your area. (See page 5)
(Please print or type)
I Mailing address of ownerloperator (addrels to which fill pormil corresl2orideracewill bg mallaill.
Name _f. 1-111-6Q. -'r13 ... ..
Street Address _ o
City slateZIP Code 2,51-7-
Telephone No. Fax: A
2) Location of facility producing discharge: / n
Facility Name �1tr .rK�l^Ynrk�4 Sgzdi +fir k- rryW�
Facility Contact
Street Address _ C1VyOD Ra"Co
City ku State M- ZIP Code _A!I'l0
County'"
Telephone No. 7U (_ GrZ 7.0 3 Fax:LH
Page 1 0l 5
;Ae per 15A NCAC 211 .0100
'Unless boatmant raalibes are designed, Constmded, and put into operation by alrployeas inlemal Lc the company who are qualified to
perform such wo+h for their respect- oompanina in accadarim wilb General Statutes, 119G25 i7), plans and specirirations must be signed
and sealed by a P.E.
SWUM-1171406
Last revised 7lt41es

Ir
NCG140000 N.O.I.
3) Physical location information:
Please provide a narrative description of how to got to the totality (use street names, state road numbers, and
distance and direction from a roadway intersections. iAV_O AC ii.r7, lrxf 4v_n. caD r r rNA—__
(A -py pj a fDllnhl MPer OSGS qued 9h Bel wilh 1..,iiq 60AOY bested on the m-p is g mgWrOd pwl oI this spplimtfne.)
4) Latitude N b4-°ss 3r0 Longitude _W Xh a y 57 r" (deg, In, soc)
5) This NPDES Permit Application applies to which of the following:
C1 New or Proposed Facility Date operation is to begin
Existing
6) Standard Industrial Classification:
Pravide the 4 digit Standard Industrial Classification Code (SIC Gode) that describes the primary industrial
activity at this facility
SIC Cade: 3 ?_
7) Provide a brief description of the types of industrial activities and products produced at this facility:
(include a site diagram showing the process areas present at this lacHity.)
8) Discharge points I Receiving waters.
How many discharge points (ditches, pipes, channels, etc.} convey slormwator and/or wastewater from the
property? UNe Air door r.- Je" Fd eck ef-tc _
What is the name of the body or b,*s of ater (creek, stream, river, lake, etc,) that the tacllity, siormwater
and/or wastewater discharges end rij� fm };C.R�.t�.- rJ� l t rSf> tJrm L w2�1`r 5 -
It the site stormwater discharges to a separate storm sewer system, name the operator of the separate storm
sewer system (e.g. City at Raiegh municipal Storm sewer).
Receiving water classification (it known): Lbl i rad'r-- r_, c _7r • tf a , P a C,4
WY IKK
Note: Discharge of process wastewater to receiving waters classified as WS-II to WS-V or SA must
be approved by the N.C. Dept. of Environmental Health, It DEH does not approve, coverage
under NCGI40000 cannot be granted. No rtew discharges of process wastewater are
permitted in receiving waters classified as WS-i or freshwater ORW.
9) Does this facility have any other NPDES permits?
T, l i*,,. rit l.i (</>Cl LI r/ 47M5 Fit yror,bw`/ ��..1�•n r I'rt�r7
No -r IS,Jwne^1-•.'*v-n
O Yes f-- - ri az ' r ,
If yes, list the permit numbers for all current NPDES permits for this tacAty:
10) Does this facility have any Non -Discharge permits (ex: recycle permits)?
I'No
0 Yes
It yes, list the permit numbers for all current Non -Discharge permits for this facility: _
1 t) Does this facility employ any best management practices for slormweter control?
XNo
0 Yes
II yes, please briefly describe:
Page 2 of 5
SWU.229-071409
L. Sl revised W140)GS

NCG140000 N.O.I.
12) Does this facility have a Storrnwater Pollution Prevention Plan?
IK No
❑ Yes
If yes, when was it implemented?
13) Are vehicle maintenance activities occurring or planned at this fatuity?
No
Yes
wastewater _rmrojim_entOeslrrn lnfarr faffon
14) Are discharges occurring or planned from any of the following process wastewater generating activities?
Vehicle and equipment cleaning 0 Yes Z( No
Wetting of raw material stockpiles 0 Yes K No
Mixing drum cleaning X Yes ❑ No
If yes to any of the above, please describe the type of process used to treat andlor recycle the process
wastewater. 50rS r.r r11ru
TaFor a sufficient application, you must provide design specilics (e.g., design volume, retention time, surface
area, etc.) and calculations to damonstraw Comp Vance with permit effluent Ilmits (pH — 6-9 GU. Total
Suspended Solids (TSS) — 30 mgn, and Settleable Solids (SS) — 5 mill.) [Use separate sheet(s)).
If gl1 these discharges are recycled, please refer to Question 15,
Ear pin_niff_that mcvcteand_/ordlschar_e-prixesswastewater:
When applying for this permit, you are also applying for an authorization to construct (now
treatment facilities) or authorization to continue to operate (existing treatment facilities) as
part of the N01. For nQ!y sites. you must submit three (3) sets of design plans and
Specifications with this application rind provide supporting calculaflons that predict
compliance of fMal discharge with permit limits. For frlristfn_q_j s, applicants should submit
throe (3) sets of plans and specs for facilities as -built and provide as many design details as
possible, or submit a detailed diagram of treatment systems In place that Includes Information
such as tank volumes, dimensfons, retention (line, piping, settling basin details, etc.
Please note. If new treatment systems are planned for an existing site, an ATC will be requirod
prior to construction of those facilities. Planslspecalcalculatlons prepared by a P.E. and the
request for an ATC may, be submitted with this NOI, or separately of a later data DINO may
requasf the status of yourplans for requesting an ATC upon issuance of the CDC. _ __ _ _
15) Does the facility use or plan tg use a recycle system?
0 No
KYes
It yes, what size storm event is the system designed to hold before ovOlowing? (for example, 10-yr, 24-hr)
4 J year, 24-hr rainfall event
For a recycle system freoardiess of when it ovedlowsl, please provide plans, calculations, and design
specifics (e.g., throughput assumplionstwaler balance, design volume, retention time, surface aroa, amount of
`___1geboard in des'Rn storm event, etc.). [Use separate sheets}[.
For a sufficient application, the information must demonstrate compliance of final discharge with permit
effluent limits (pH — 6-9 SU. Total Suspended Solids (TSS) — 30 mgll, and Settleable Solids (SS) — 5 mill), o
must demonstrate that the recycle system has sufficient capacity to contain runoff tram a 25-year, 24-hr
rainfall event plus one foot of freeboard under design operating conditions.
Page 3 of 5
SWU-2240714e8 last revised 704rMa

NCG140000 N.O.I.
16) Are wastewater treatment facilities (including recycle systems) planned in the 100 year flood plain?
XNo ❑ Yes It so, include information to demonstrate protection from flooding. (Minimum design
requirements for treatment works include protection from the 100•yoar flood, per 15A NCAG 2H .0219.)
17) Hazardous Waste;
a) Is this facility a Hazardous Waste Treatment, Storage, or disposal Facility?
KNo
Cl Yes
b) is this facility a Small Quantity Generator (loss than 1000 kg, of hazardous waste generated pot month) of
hazardous waste?
❑ No
kYes
c) Is this facility a Large Quantity Generator (1000 kg, or more of hazardous waste generated per month) of
hazaidous waste?
X No
❑ Yes
di If you answered yes to questions b. or c please provide the loltowing information: /
Type(s) of waste: i
How is material stored: j rviu vr�L}�/ �i;, Y c�+— An r cru I. ref
Where is material stored: Urj -`A R
How many disposal shipments per year: VAK1>3
Name of transport I disposal vendor: H it. a ffNl� SLV nc_ S y`S�
Vendor address;.tax
18) Certification:
Norlh Carolina General Statute 143-215.6 B(I) provides that:
Anv Person who knowingly maces any Iaise statement, topresenlalion. or certtication in any application, record, report, plan, er other
document filed or required to be maintained under ttis Artida or a rule implementing this Anido; or who krtordngly makes a false
statement of a material fact In a rulsmaking proceeding or contested case under this Anicio; or who falsities, tampers with, or knamr oh,
renders inaccurate any recording or monftorfng device or method required to he operated or maintained under this A1ble or rules of Iho
jiiw mental rdanagemenrl Commission implementing 1h's Article shall he guitry of a Gass 2 misdemeanor which may include a line
m110 exceed ten thousand 6M" (St0,000).
I hereby request coverage under the relorenced General Permit. I understand that coverage under this permit
will constitute the permit requirements for the discharge(s) and is enlorceablo In the same manner as an
individual permit.
I certify that I am familiar with the information contained in this appiication and that to the best of my
knowledge and belief such information is true, complete, and accurate.
Printed Name of Per on Signing: Kn tZL (� +�Di2L3tt
Title:�WJffl— y00G—ryhiT1'��
- K,x f�c.L G>N�r Ol Zt 0`%
(Signature olAPpiicanQ Pale Signed)
I
Notice of Intent must be accompanied by a check or money order for $100.00 made payable to:
NCDENR
Page 4 of 5
SWIb229-071408 Last revised 7041200/1

NCG140000 N.O.t.
Finol Checklist
This application will be returned as incomplete unless all of the following Items have been included:
❑ Check for $100 made payable to NCDENR. i.
This completed application and all supporting documentation (including design details and calculations for
treatment systems).
❑ If an Erosion & Sedimentation Control (EBSC) Plan is required from Division of Land Resources (DLR)
�L or local designee: documentation verifying applicant has developed and Submitted that Plan to the governing
agency (required per 15A NCAC 02H .0138).
G) For now sites (or sites that will install new treatment facilities): Three (3) copies of plans and
specifications for wastewater treatment facilities (includingl,recycle systems), signed and sealed by a
Proiessional Engineer or qualified staff meeting requirements of G.S. 89C-25 (7),
f For existing sltes: three (3) copies of plans and specilications for wastewater treatment facilities (including
recycle systems) as built, stamped and sealed by a PrDiespional Engineor, or (only if plans not available) a
detailed diagram of treatment systems in place that includes inlormalion such as tank volumes, dimensions,
retention time, piping, settling basin details, etc. I
I� A site map showing, at a minimum, (existing or proposed);
(a) outline of drainage areas, (b) slormwaterlwastewatar trI"atmant structures, (c) location of
stormwaterlwastowaler oulfalls (corresponding to which drainage areas), (d) runoff conveyance structures,
(e) areas where materials are stored, (1) impervious areas and (g) site properly lines.
A county map or USGS quad sheet with location of facility, loarly marked.
Mail the entire package to:
Siormwafer Permitting Unit
Division of Water Ouality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
ti4Is
The submission of this document does not guarantee the issuance of an NPQE5 permit.
For questions, please contact the DWO Regional Office for your area.
i
DW1Q_Retllonal_Office Contact Information:
Asheville Office ...... (82B) 2964500
Fayetteville Office
... [phone]
Mooresville Office
... [phone]
Raleigh Office ........
[phone]
Washington Office
...(252) 946-WI
Wilmington Office
... [phone]
Winston-Salem ......
[phone]
Central Office .........(919)
807-6300
Page 5 of 5
S W U-229-011400 last revised 70 412006

1 0
fC yZ kk r tr� v
A
1
Cools
tG
vur LavM
mm
mmmm
'� m
�m
4F���
g
o��
Z
Q�R�
x
11
It
1T
L
J
u
w

TopaZone - USGS Wadesboro (NC) Topo Map Page I of I
7-1
1. J
0 V,
. 0
7
M*
0 0.1 0.2 0.1 0.4 0.5 kn
0 0.09 0. IB 0.27 0.35 0.45 M
I
UTM 17 582524E 3864657N (NAD27)
USGS Wadesboro (NC) Quadrangle
Mz-7.556
Projection is UTM Zone 17 NAD83 Datum
G-O, 5 17
htIpJ/Www.tOpOzone coniipdnt.asp?lat=34.9228&lon=-80,09653&s=24&symshow--ri&laye 5/2/2007

eSEPI
ENGINEERING GROUP
7506 E. Independence Blvd,
Suite 122
Charlotte, NC 28227
Tel [phone]
Fox 704.714.4885
sepiengineering.com
February 3, 2009
Belinda S. Henson
Regional Supervisor
Surface Water Protection Section
North Carolina Division of Water Quality
225 Green Street, Suite 714
Fayetteville, North Carolina 28301
Subject: Nov-2008-OP-0041 Dated 8-21-08
Hildreth Septic Tanks (Wadesboro Plant)
Dear Ms. Henson,
'.t'E �q �
k�J U
DWQ
Your letter of January 22, 2009 request that NCG 140000 Permit be submit to DWQ
Stormwater permitting Unit within fifteen (15) calendar days from receipt. This is to
advise the NCG 140000 was mailed on February 3, 2009. It is understood that the fee
amount of $100 was submitted August 15, 2008.
9ame
'rely,
s M. Dennis
SEPI Engineering Group Inc.
7506 E. Independence Blvd. Ste. 122
Charlotte, NC 28227
704-714-4880
Fax [phone]
Cc: Hildreth Septic Tanks
DWQ Stormwater Permitting Unit
File

0r' SEPI
�! ENGINEERING GROUP
7505 E. Independence Blvd.
Suite 122
Charlotte, NC 28227
Tel [phone]
Fax [phone]
sepiengineering.com
January 29, 2009
Belinda S. Henson
Regional Supervisor
Surface Water Protection Section
North Carolina Division of Water Quality
225 Green Street Suite 714
Fayetteville, NC 28301
Subject: NOTICE OF CONTINUING VIOLATION
RECOMMENDATION FOR ENFORCEMENT
NOV-2008-OP-0041 dated 8-21-08
Hildreth Septic Tanks (Wadesboro Plant)
Anson County
Ms. Henson,
�-aI
a r . .
IVY.
D R—FRO
FEB a 2 Baas
DWQ
This is to acknowledge your letter dated January 22, 2009 and to let you and DWQ know
that the matter is being attended to with all possible haste. We have been in
communication with Ms. Jones and the Permitting Unit in Raleigh and have consciously
applied much effort to resolving the issues with this project and location. We ask that the
DWQ be patient as we make every effort to comply in a timely manner and to assemble
all information needed to complete the submission of DWQ forms.
•.---T k you,
3ames M. Dennis PE, PLS, CPESC
SEPI Engineering Group Inc.
7506 E. Independence Blvd. Ste.122
Charlotte, NC 28227
704-714-4880
Fax [phone]

4b., i vi r
UNITED STATES_
POSTAL SERVKE•
Track & Confirm
Search Results
LabellReceipt Number: 7006 2150 0005 2109 8136
Status: Delivered
Your item was delivered at 9:48 am on January 29, 2009 in
WADESBORO, NC 28170. A proof of delivery record may be available
through your local Post Office for a fee.
Additional information for this item is stored in files offline.
Aaxrouo 0Whe Dorrtrrs> 0 Rw= to IUSPS.cam Homo s
Home I Help I Sign_in
Track & Confirm F4Q$
Track S Confirm
Enter Label/Receipt Number.
Qoa
Ito r'a0 Cuslomer_Servicq Forms Gov't Services Careers Frivac..y_Polii y Terms nf_Use HusiOes.s_Custorner GolAway
CopyrightGO2010 USPS. All Rights Reserved, No FEAR Act EEO Data FOIA 19 ly'r.V3-AQj lr^'n•,!i r5ssrr�ogl awn,
http://trkcnfrm I.smi.usps.com/PTSintemetWeb/InterLabellnquiry.do 10/5/2010

/ A
Division of Water Quality 1 Surface Water Protection
NCDENRNational Pollutant Discharge Elimination System
�f. � D c,
F'yVIRQKMIhT ,wn NiE1AW . Rrao��ra 1�
1�i C�l(� 1 A
1�FO00Q
NOTICE OF INTENT
I Certificate of Coveraee i
National Pollutant Discharge Elimination System application for coverage under General Permit
NCG 140000:
STORMWATER AND PROCESS WASTEWATER DISCHARGES associated with activities classified as:
SIC (Standard Industrial Classification) Code - 3273 Ready Mixed Concrete
For new plant sites that will discharge or recycle process wastewater (even H commingled with
stormwater): This NOI is also an APPLICATION FOR Authorization to Construct (ATC) wastewater
treatment facilities. ATC requests must be submitted at least 90 days prior to construction'.
For existing plant sites discharging or recycling process wastewater (even tf commingled with
stormwater): This NOI is also an APPLICATION FOR Authorization to continue to operate wastewater
treatment facilities in place. Construction, modification, or installation of any new treatment components
at an existing site requires an ATC.
Treatment facilities used to treat or recycle process wastewater (including stormwater BMP structures
treating process wastewater flows commingled with stormwater) require an ATC prior_to_construction
per 15A NCAC 2H .0138. The authorization to construct or continue to operate will be issued at the
same time as the Certificate of Coverage (COC) for the NCG14 permit. Design of treatment facilities
must comply with requirements of 15A NCAC 2H .0138 & .0139.
Construction of wastewater treatment facilities (this includes recycle systems) at new or existing plant
sites requires submission of three (3) sets of plans and specifications signed and sealed by a
Professional Engineer (P.E.) or qualified staff2 along with this application. A copy of the design
calculations should be included. Please see questions 14 & 15.
W, I For questions, please contact the DWO Regional Office for your area. (See page 5)
(Please print or type)
1) Mailing address of owner/operator (address to which all permit correspondence will be mailed):
Name
Street Address
City
Telephone No.
L
W P, -%. State ZIP Code 'Z81-7�
�7- C)3 — IW4 - �}- Fax: A
2) Location of facility Droducing discharge:
Facility Name
Facility Contact
Street Address
City
County
Telephone No.
I�11 L.D9j-jjA ?'-M t - M O x xiMe, GE�?vr�q-g (G,jA>ot} � RAu
a.a State 94- ZIP Code ZB 00
~'6�
�o4 -2. o3 4 Fax:
Page 1 of 5
�As per 15A NCAC 2N .0106
2Unless treatment facilities are designed, constructed, and put into operation by employees internal to the company who are qualified to
perform such work for their respective companies in accordance with General Statutes, 89C-25 (7), plans and specifications must be signed
and sealed by a P.E.
SWU-229-07140& Last revised 711V08

NCG140000 N.O.I.
3) Physical location information:
Please provide a narrative description of how to get to the
distance and direction from a roadway intersection). J J
4Z
1(use street names, state road numbers, and
C W,a,/, 10 50.,w+ av- od,
,v Po a KD . &va: MiLe EDAM i_err.
(A copy of a county map or USGS quad sheet with facility clearly located on the map is a required part of this application.)
t
4) Latitude N J4-SS �)O Longitude -14 SODS 57 11 (deg, min, sec)
5) This NPDES Permit Application applies to which of the following:
❑ New or Proposed Facility Date operation is to begin
Existing
6) Standard Industrial Classification:
Provide the 4 digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial
activity at this facility
SIC Code:
.3 L - -
7) Provide a brief description of the types of industrial activities and products produced at this facility:
(include a site diagram showing the process areas present at this facility.)
'TRAPS' C>-r C_
S) Discharge points / Receiving waters:
How many discharge points (ditches, pipes, channels, etc.) convey stormwater and/or wastewater from the
property? OMEE
What is the name of the body or bodies of water (creek, stream, river, lake, etc.) that the facility stormwater
and/or wastewater discharges end up in? ..ln,str3 C , hi+✓ t, A-.,m Omit_, "r- LcevWce 5 tw
If the site stormwater discharges to a separate storm sewer system, name the operator of the separate storm
sewer system (e.g. City of Raleigh municipal storm sewer).
Receiving water classification (if known): Har Kt�k�
Note: Discharge of process wastewater to receiving waters classified as WS-II to WS•V or SA must
be approved by the N.C. Dept. of Environmental Health. If DEH does not approve, coverage
under NCG140000 cannot be granted. No new discharges of process wastewater are
permitted in receiving waters classified as WS-I or freshwater ORW.
9) Does this facility have any other NPDES permits?
YINo Tr i s rAtf Li rl WM,i p� v1Or's`1� '�=1t_m 1 r1tYJ
CI Yes I
If yes, list the permit numbers for all current NPDES permits for this facility:
10) Does this facility have any Non -Discharge permits (ex: recycle permits)?
X.,No
❑ Yes
If yes, list the permit numbers for all current Non -Discharge permits for this facility:
11) Does this facility employ any best management practices for stormwater control?
XNo
❑ Yes
If yes, please briefly describe:
Page 2 of 5
SWU-229-071408 Last revised 7/14/2008

NCG140000 N.O.I.
12) Does this facility have a Stormwater Pollution Prevention Plan?
�I No
❑ Yes
If yes, when was it implemented?
13) Are vehicle maintenance activities occurring or planned at this facility?
R No
❑ Yes
Wastewater Treatment Design Information
14) Are discharges occurring or planned from any of the following process wastewater generating activities?
Vehicle and equipment cleaning ❑ Yes 9 No
Wetting of raw material stockpiles ❑ Yes 2� No
Mixing drum cleaning )K Yes ❑ No
If yes to any of the above, please describe the type of process used to treat and/or recycle the process
wastewater. j� S[-t ISr n i n ,p 1 uA,X, `7, j "iY�1 k_�, -
' For a sufficient application, you must provide design specifics (e.g., design volume, retention time, surface
area, etc.) and calculations to demonstrate compliance with permit effluent limits (pH — 6-9 SU, Total
Suspended Solids (TSS) — 30 mg/I, and Settleable Solids (SS) — 5 ml/I.) [Use separate sheet(s)],
if all these discharges are recycled, please refer to Question 15,
For Plants that recycle and/or dlschar a rocess wastewater:
When applying for this permit, you are also applying for an authorization to construct (new
treatment facilities) or authorization to continue to operate (existing treatment facilities) as
part of the NOL For new sites, you must submit three (3) sets of design plans and
specifications with this application pnnd provide supporting calculations that predict
compliance of final discharge with permit limits. For existing sites, applicants should submit
three (3) sets of plans and specs for facilities as -built and provide as many design details as
possible, or submit a detailed diagram of treatment systems In place that Includes Information
such as tank volumes, dimensions, retention time, piping, settling basin details, etc.
Please note: If new treatment s s ems are 121anned for an existing site, an ATC will be required
prior to construction of those facilities. Plans/specs/calculations prepared by a P.E. and the
request for an ATC may be submitted with this NOI, or separately at a later date.' DWO may
request the status of your plans for requesting an ATC upon Issuance of the COC.
15) Does the facility use or plan to use a recycle system?
❑ No
Yes
if yes, what size storm event is the system designed to hold before overflowing? (for example, 10-yr, 24-hr)
2. J year, 24-hr rainfall event
For a recycle system (regardless of when it overflows), please provide plans, calculations, and design
specifics (e.g., throughput assumptions/water balance, design volume, retention time, surface area, amount of
freeboard in design storm event, etc.). [Use separate sheet(s)].
W'7 For a sufficient application, the information must demonstrate compliance of final discharge with permit
effluent limits (pH — 6-9 SU, Total Suspended Solids (TSS) — 30 mg/l, and Settleable Solids (SS) — 5 mi/1), or
must demonstrate that the recycle system has sufficient capacity to contain runoff from a 25-year, 24-hr
rainfall event plus one foot of freeboard under design operating conditions.
Page 3 of 5
5WU-229-071408 Last revised 7/14/2008

NCG140000 N.O.I.
16) Are wastewater treatment facilities (including recycle systems) planned in the 100-year flood plain?
ANo ❑ Yes If so, include information to demonstrate protection from flooding. (Minimum design
requirements for treatment works include protection from the 100-year flood, per 15A NCAC 2H .0219.)
17) Hazardous Waste:
a) Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility?
K—No
Yes
b) Is this facility a Small Quantity Generator (less than 1000 kg. of hazardous waste generated per month) of
hazardous waste?
❑ No
K Yes
c) Is this facility a Large Quantity Generator (1000 kg. or more of hazardous waste generated per month) of
hazardous waste?
D( No
❑ Yes
d) If you answered yes to questions b. or c., please provide the following information: /
Type(s) of waste: _ �KUt�fi L-
&nCJZ 'G6er^6t-- c;�H�T W�IXr3L. Ame wgirk�lCC)»�sr��ykovj
How is material stored: A.* Giorn Ic.t+ 1.9 ctmi'y%±0 CF_ �
Where is material stored: Uij
How many disposal shipments per year: VAKti�
Name of transport / disposal vendor: kfILObF71J, SG7Frit.S S?Efc
Vendor address: r049 WAaCr�Th�i — -ZTI ?�
18) Certification:
North Carolina General Statute 143-215.6 B(i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan, or other
document filed or required to be maintained under this Article or a rule implementing this Article: or who knowingly makes a false
statement of a material fact in a rulemaking proceeding or contested case under this Article; or who falsifies, tampers with, or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
[Environmental Management] Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine
not to exceed ten thousand dollars ($10,000).
I hereby request coverage under the referenced General Permit. I understand that coverage under this permit
will constitute the permit requirements for the discharge(s) and is enforceable in the same manner as an
individual permit.
I certify that I am familiar with the information contained in this application and that to the best of my
knowledge and belief such information is true, complete, and accurate.
Printed Name of Per on Signing: Al2,L tLfl49U
Title: -6 W 14Gk- O Pt'ZArn
(Signature of Applicant) (Date Signed)
Notice of Intent must be accompanied by a check or money order for $100.00 made payable to:
NCDENR
Page 4 of 5
SWU-229-071408 Last revised 7/14/2008

4
NCG1'40000 N.O.I.
Final Checklist
This application will be returned as Incomplete unless all of the following items have been included:
❑ Check for $100 made payable to NCDENR.
l� This completed application and all supporting documentation (including design details and calculations for
treatment systems).
❑ It an Erosion & Sedimentation Control (E&SC) Plan is required from Division of Land Resources (DLR)
or local designee: documentation verifying applicant has developed and submitted that Plan to the governing
agency (required per 15A NCAC 02H .0138).
❑ For new sites (or sites that will Install new treatment facilities): Three (3) copies of plans and
specifications for wastewater treatment facilities (including recycle systems), signed and sealed by a
Professional Engineer or qualified staff meeting requirements of G.S. 89C-25 (7).
' For existing sites: three (3) copies of plans and specifications for wastewater treatment facilities (including
recycle systems) as built, stamped and sealed by a Professional Engineer, or (only if plans not available) a
detailed diagram of treatment systems in place that includes information such as tank volumes, dimensions,
retention time, piping, settling basin details, etc.
A site map showing, at a minimum, (existing or proposed):
(a) outline of drainage areas, (b) stormwaterlwastewater treatment structures, (c) location of
stormwaterlwastewater outfails (corresponding to which drainage areas), (d) runoff conveyance structures,
(e) areas where materials are stored, (f) impervious areas, and (g) site property lines.
A county map or USGS quad sheet with location of facility clearly marked.
Mail the entire package to:
Stormwater Permitting Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Nole
The submission of this document does not guarantee the issuance of an NPDES permit.
For questions, please contact the DWO Regional Office for your area.
DWGI—Regional Office Contact Information:
Asheville Office ......
[phone]
Fayetteville Office ...
[phone]
Mooresville Office ...
[phone]
Raleigh Office ........
[phone]
Washington Office ...(252)
946-6481
Wilmington Office ...
[phone]
Winston-Salem ......
[phone]
Central Office .........(919)
807-6300
Page 5 of 5
SWU-229-071408 Last revised 7/14/2008

'r 4 Division of Water Quality 1 Surface Water Protection
NCDENRNational Pollutant Discharge Elimination System
�1C.TH C D�MLw a.
FM~—f" AW, N&u . Rrso.Acra NCG 140000
NOTICE OF INTENT
FOR AGENCY USE ONLY
Dam Received
Year Month Da
Certificate of Coveta e
Check N Amount
Permit Assigned to
National Pollutant Discharge Elimination System application for coverage under General Permit
NCG140000:
STORMWATER AND PROCESS WASTEWATER DISCHARGES associated with activities classified as:
SIC (Standard Industrial Classification) Code - 3273 Ready Mixed Concrete
For new plant sites that will discharge or recycle process wastewater (even N commingled with
stormwater): This NOI is also an APPLICATION FOR Authorization to Construct (ATC) wastewater
treatment facilities. ATC requests must be submitted at least 90 days prior to construction'.
For existing plant sites discharging or recycling process wastewater (even if commingled with
stormwater): This NO[ is also an APPLICATION FOR Authorization to continue too erate wastewater
treatment facilities in place. Construction, modification, or Installation of any new treatment components
at an existing site requires an ATC.
Treatment facilities used to treat or recycle process wastewater (including stormwater BMP structures
treating process wastewater flows commingled with stormwater) require an ATC prior to construction
per 15A NCAC 2H .0138. The authorization to construct or continue to operate will be issued at the
same time as the Certificate of Coverage (COC) for the NCG14 permit. Design of treatment facilities
must comply with requirements of 15A NCAC 2H .0138 & .0139.
Construction of wastewater treatment facilities (this includes recycle systems) at new or existing plant
sites requires submission of three'(3) sets of plans and specifications signed and sealed by a
Professional Engineer (P.E.) or qualified staff2 along with this application. A copy of the design
calculations should be included. Please see questions 14 & 15.
Val For questions, please contact the VWQ Regional Office for your area. (See page 5)
(Please print or type)
1) Mailing address of owner/operator (address to which all permit corres ondence will be mailed :
Name
Street Address
City
Telephone No.
9+ G�r�F -7-o + Fax:
2) Location of facility producing discharge:
Facility Name
Facility Contact
Street Address
City
County
Telephone No.
rt.00 State 144" ZIPCode Z'80o
Toy 62 4 w2•o3 Fax:
'As per 15A NCAC 2H .0106 Page 1 of 5
2Unless treatment facilities are designed, constructed, and put into operation by employees internal to the company who are qualified to
perform such work for their respective companies in accordance with General Statutes, 89C-25 (7), plans and specifications must be signed
and sealed by a P.E.
SWU-229-071408 fast revised 7/14108

NC,G140000 N.O.I.
3) Physical location information:
Please provide a narrative description of how to get to the facility (use street names, state road numbers, and
distance and direction from a roadway intersection). TAge NC jj::tjL„I&„ tr+ cu'r Or
4z /L, N P..e IZA . 0,;z
(A copy of a county map or USGS quad sheet with facility clearly located on the map is a required part of this applicalion.)
4) Latitude �J4-a55 �0O Longitude fob v 5 57 (deg, min, sec)
5) This NPDES Permit Application applies to which of the following:
❑ New or Proposed Facility Date operation is to begin
)1! Existing
6) Standard Industrial Classification:
Provide the 4 digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial
activity at this facility
SIC Code:.3 Z. '1 ­3
7) Provide a brief description of the types of industrial activities and products produced at this facility:
(Include a site diagram showing the process areas present at this facility.)
'T S C>_1r.
8) Discharge points 1 Receiving waters:
How many discharge points (ditches, pipes, channels, etc.) convey stormwater and/or wastewater from the
property? ONE!
What is the name of the body or bodies of water (creek, stream, river, lake, etc.) that the facility stormwater
and/or wastewater discharges end up in? �CR.eac . Kc, Of' m Omf�%_— "1 a Ueywce 5 +p;-
If the site stormwater discharges to a separate storm sewer system, name the operator of the separate storm
sewer system (e.g. City of Raleigh municipal storm sewer).
Receiving water classification (if known): -Nor Kak.-YN
Note: Discharge of process wastewater to receiving waters classified as WS-II to WS-V or SA must
be approved by the N.C. Dept. of Environmental Health. If DEH does not approve, coverage
under NCG140000 cannot be granted. No new discharges of process wastewater are
permitted in receiving waters classified as WS-1 or freshwater ORW.
9) Does this facility have any other NPDES permits?
Qes�'No jT I S-I►s>ac�`� �a c T� rk i. FAci L1 r/ WADS �n��+ovs��/r1Lvn , nN?
❑ Yes r.,.►� P�kT .
It yes, list the permit numbers for all current NPDES permits for this facility:
10) Does this facility have any Non -Discharge permits (ex: recycle permits)?
L,No
❑ Yes
If yes, list the permit numbers for all current Non -Discharge permits for this facility:
11) Does this facility employ any best management practices for stormwater control?
XNo
❑ Yes
If yes, please briefly describe:
Page 2 of 5
SWU-229-071408 Last revised 7/14/2008

NCG140000 N.O.I.
12) Does this facility have a Stormwater Pollution Prevention Plan?
No
❑ Yes
If yes, when was it implemented?
13) Are vehicle maintenance activities occurring or planned at this facility?
R Na
❑ Yes
Wastewater Treatment Deslan Information
14) Are discharges occurring or planned from any of the following process wastewater generating activities?
Vehicle and equipment cleaning ❑ Yes I?( No
Wetting of raw material stockpiles ❑ Yes 91 No
Mixing drum cleaning X Yes ❑ No
If yes to any of the above, please describe the type of process used to treat and/or recycle the process
wastewater. � lam ! ,ff7.0 f,A,r, -;" D%E� -
For a sufficient application, you must provide design specifics (e.g., design volume, retention time, surface
area, etc.) and calculations to demonstrate compliance with permit effluent limits (pH -- 6-9 SU, Total
Suspended Solids (TSS) — 30 mg/I, and Settleable Solids (SS) — 5 ml/I.) [Use separate sheet(s)].
If all these discharges are recycled, please refer to Question 15.
For plants that recycle and/or discharge process wastewater:
When applying for this permit, you are also applying for an authorization to construct (new
treatment facilities) or authorization to continue to operate (existing treatment facilities) as
part of the NOI. For new sites you must submit three (3) sets of design plans and
specifications with this application and provide supporting calculations that predict
compliance of final discharge with permit limits. For existing sites, applicants should submit
three (3) sets of plans and specs for facilities as -built and provide as many design details as
possible, or submit a detailed diagram of treatment systems In place that Includes Information
such as tank volumes, dimensions, retention time, piping, settling basin details, etc.
Please note: If new treatment systems are glanned for an existing slte, an ATC will be required
prior to construction of those facilities. Plans/specs/calculations prepared by a P.E. and the
request for an ATC may be submitted with this NOI, or separately at a later date. DWQ may
request the status of your plans for requesting an ATC upon Issuance of the COC.
15) Does the facility use or plan to use a recycle system?
❑ No
KYes
If yes, what size storm event is the system designed to hold before overflowing? (for example, 10-yr, 24-hr)
'Z 5 year, 24-hr rainfall event
For a recycle system {regardless of when it overflows), please provide plans, calculations, and design
specifics (e.g., throughput assumptions/water balance, design volume, retention time, surface area, amount of
freeboard in design storm event, etc.). [Use separate sheet(s)].
For a sufficient application, the information must demonstrate compliance of final discharge with permit
effluent limits (pH — 6-9 SU, Total Suspended Solids (TSS) — 30 mg/I, and Settleable Solids (SS) — 5 ml/1), or
must demonstrate that the recycle system has sufficient capacity to contain runoff from a 25-year, 24-hr
rainfall event plus one foot of freeboard under design operating conditions.
Page 3of5
SWU-229-071408 Last revised 7/14/2008

N(ZG140000 N.O.I.
16) Are wastewater treatment facilities (including recycle systems) planned in the 100-year flood plain?
XNo ❑ Yes If so, include information to demonstrate protection from flooding. (Minimum design
requirements for treatment works include protection from the 100-year flood, per 15A NCAC 2H .0219.)
17) Hazardous Waste:
a) Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility?
KNo
❑ Yes
b) Is this facility a Small Quantity Generator (less than 1000 kg. of hazardous waste generated per month) of
hazardous waste?
❑ No
K Yes
c) Is this facility a Large Quantity Generator (1000 kg
hazardous waste?
XNo
❑ Yes
or more of hazardous waste generated per month) of
d) If you answered yes t{o�questions b. or c., please provide the following information: /
Type(s) of waste: KuUb fi �2�" QpwC�-� �, -r, y,nl�( A&c w45rf� lC�n�i�4, Rpv j
How is material stored: 5 Tv CAL u I t�� +.0' G-►u>.% JC4,— I rt,,,.� f N Twos
Where is material stored: 00 57,6
How many disposal shipments per year: VA
Name of transport / disposal vendor: 11,41LE
Vendor address: P.0.Oox 10g9—OkN
18) Certification:
North Carolina General Statute 143-215.6 B(i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan, or other
document filed or required to be maintained under this Article or a rule implementing this Article; or who knowingly makes a false
statement of a material fact in a rulemaking proceeding or contested case under this Article; or who falsifies, tampers with, or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
[Environmental Management] Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine
not to exceed ten thousand dollars ($10,000).
I hereby request coverage under the referenced General Permit. I understand that coverage under this permit
will constitute the permit requirements for the discharge(s) and is enforceable in the same manner as an
individual permit.
I certify that I am familiar with the information contained in this application and that to the best of my
knowledge and belief such information is true, complete, and accurate.
Printed Name of PE
Title: 6W dEl--
on Signing: I�fA>IZt-- �� tLbtZ
(Signature of Applicant) (Date Signed) .
Notice of Intent must be accompanied by a check or money order for $100.00 made payable to:
NCDENR
Page 4 of 5
SWU-229-071408 Last revised 7/14/2008

NQG140000 N.O.I.
Final Checklist
This application will be returned as Incomplete unless all of the following items have been included:
❑ Check for $100 made payable to NCDENR.
This completed application and all supporting documentation (including design details and calculations for
treatment systems).
❑ If an Erosion & Sedimentation Control (E&SC) plan is required from Division of Land Resources (DLR)
or local designee: documentation verifying applicant has developed and submitted that Plan to the governing
agency (required per 15A NCAC 02H .0138).
❑ For new sites (or sites that will install new treatment facilities): Three (3) copies of plans and
specifications for wastewater treatment facilities (including recycle systems), signed and sealed by a
Professional Engineer or qualified staff meeting requirements of G.S. 89C-25 (7).
For existing sites: three (3) copies of plans and specifications for wastewater treatment facilities (including
recycle systems) as built, stamped and sealed by a Professional Engineer, or (only if plans not available) a
detailed diagram of treatment systems in place that includes information such as tank volumes, dimensions,
' retention time, piping, settling basin details, etc.
U/A site map showing, at a minimum, (existing or proposed):
(a) outline of drainage areas, (b) stormwater/wastewater treatment structures, (c) location of
stormwaterlwastewater outfalls (corresponding to which drainage areas), (d) runoff conveyance structures,
(e) areas where materials are stored, (f) impervious areas, and (g) site property lines.
A county map or USGS quad sheet with location of facility clearly marked.
Mail the entire package to:
Stormwater Permitting Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Note
The submission of this document does not guarantee the issuance of an NPDES permit.
For questions, please contact the D WO Regional Office for your area.
DW9 Regional Office Contact Information:
Asheville Office ......
[phone]
Fayetteville Office ...
[phone]
Mooresville Office ...
[phone]
Raleigh Office ........
[phone]
Washington Office ...(252)
946-6481
Wilmington Office ...
[phone]
Winston-Salem ......
[phone]
Central Office .........[phone]
Page 5 of 5
SWU-229-071408 Last revised 7/14/2008

O�0� W TF�QG Deverly l?Ies Perdue, Governor
Dee Freeman, Secretary
rNorth Carolina Department of Environment and Natural Resources
Q Colcen H. Sullins, Director
Division of Water Quality
January 22, 2009
CERTIFIED MAIL: 7006 2150 0005 2109 8136
RETURN RECEIPT REQUESTED
Karl Hildreth
Hildreth Septic Tanks
PO Box 1098
Wadesboro, NC 28170
SUBJECT: NOTICE, OF CONTINUING VIOLATION
RECOMMENDATION FOR ENFORCEMENT
NOV-2008-OP-0041 dated 8-21-08
Hildreth Septic Tanks (Wadesboro Plant)
Anson County
Dear Mr. Hildreth:
On August 21, 2008, DWQ issued Notice of Violation NOV-2008-OP-0041 for your continued
operation of the Wadesboro ready -mix concrete facility without coverage under the NCG140000 permit,
which constitutes violations•of North Carolina General Statute § 143-215. In another letter dated June 5,
2006, which you received on June 7, 2006 according to the Certified Mail Return Receipt, DWQ
requested that a Notice of Intent (NOI) application form be completed and submitted for review by the
DWQ Stormwater Permitting Unit within thirty days from receipt of the letter.
DWQ Central Office spoke with your consulting Engineer, James Dennis of SEPI Engineering
on January 15, 2009, At that time, Mr. Dennis indicated that the surveying of the site was completed and
the paperwork had been turned into him.
As of the date of this letter, a DWQ file review indicates that your coverage under the
NCG070000 permit is still expired and the Division of Water Quality has still not received an NOI
for coverage under the NCG140000 permit. We request that a Notice of Intent (NOI) application form
be completed and submitted for review by the DWQ Stormwater Permitting Unit within fifteen (15)
calendar days from receipt of the letter. If this information is not received within 15 calendar
days, DWQ may proceed with the enforcement recommendation and assess civil penalties.
This office requires that the violations, as detailed above, be properly resolved. These
violations and any future violations are subject to a civil penalty assessment of up to $25,000 per
day for each violation. Should you. have any questions regarding these matters, please contact Mike
Lawyer at the Fayetteville Regional Office at [phone] or Jennifer Jones with the Stormwater
Permitting Unit in Raleigh at [phone]. one
No-thCarolina
Nat t"irraNY
Not -Ili Carolina Division of Water Quality 225 Green Street -Suite 714 Fayetteville, NC 28301 Phone [phone] Customer Service
Internet: w%vw.ncwateruuality,orFax [phone] 1-877-623-6748
An Equal OpportunityWfirmative Action Employer — 50% Recycledl10% Post Consumer Paper

Sincerely,
Belinda S. Henson
Regional Supervisor
SLll-faC:C Water Protection Section
cc: FRO -Surface Water Protection
Stormwater Permitting Unit Files
NPS Assistance & Compliance Oversight Unit
DWQ Central Files
lames M. Dennis, PE, PLS, CPESC-SEPI Engineering
7503 E. Independence Blvd., Suite 122
Charlotte, NC 28227
M.
:2AIal.1In► FI\ •
m
r-9 lour :b;
cc
P9 Postage $
ri l
Certified Fee
Ln
0 Return Receipt Fee
Postmark
0 (Endorsement Required) Here
© Restricted De!lvery Fae
(Endorsement Requlmc)
O
Lill
rrq Total Postage A coax
ru Karl1-lildreth
enr o
Hildreth Septic 'funks
C Strse(Apt ivo.,
© or PO Box110. P.O. Box 1098
r` airy,""stale:z`;a- Wadesboro, NC 28170
:�r

SeSEPI
ENG[NEERING GROUP
7506 E. Independence Blvd.
Suite 122
Charlotte, NC 28227
Tel [phone]
Fax 704,714.4885
sepiengineering.com
October 13, 2008
Belinda S. Henson
Regional Supervisor
Surface Water Protection Section
225 Green Street, Suite 714
Fayetteville, NC 28301
DENR--FRO
OCT 16 2008
DWQ
Reference: DWQ Letter of September 10, 2008 (November 2008-OP-0041)
Hildreth Ready -Mix &.Septic Services
Dear Ms, -Henson,
As previously advised by email October 2, 2008 , SEPT Engineering Group was
employed by Hildreth to work on the application. There was a surveyor hired, by
Hildreth, to provide site plans to SEPI Engineering Group. I received a call from the
surveyor October 13, 2008, advising the field work was completed October 10, 2008,
and paper work (site plans) should be complete by October 17, 2008. This brings you up
to date as of October 13, 2008.
erel y,
James M. Dennis, PE,.. PLS, CPESC
Manager
Cc: Hildreth Concrete Products
File

F UvFs�<
�Q 9Q i Miehaal F. Easley, Governor
�Q _P +William CU. Ross Jr., Secretary
r North Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
September 10, 2008
CERTIFIED MAIL: 7006 2150 0005 2109 7993
RETURN RECEIPT REQUESTED
Karl Hildreth
Hildreth Septic Tanks
PO Box 1098
Wadesboro, NC 28170
Subject: Response to NOTICE OF VIOLATION (NOV-2008-OP-0041) and
RECOMMENDATION FOR ENFORCEMENT
Hildreth Ready -Mix & Septic Services (Wadesboro Plant)
Anson County
Dear Mr. Hildreth:
The Fayetteville Regional Office is in receipt of your response to the Notice of Violation and
Recommendation for Enforcement that we issued on August 21, 2008 for failure to obtain coverage under the
NCG140000 general stormwater permit for ready -mixed concrete facilities. In your letter you explain that a check
in the amount of $100.00 was submitted on August 15, 2008. Please be advised that submitting the appropriate
fee does not automatically renew permit coverage once the respective general permit has expired, To renew
coverage, a renewal application must be submitted along with the appropriate fee requesting that coverage
continue. Regardless, your facility can no longer be covered under the NCG070000 general permit due to the
change in facility operations, which was confirmed during Mr. Lawyer's site visit over two years ago. To clarify, the
violation you have committed is operating a ready -mixed concrete facility without proper permit coverage under
the NCG140000 permit.
In order to resolve this violation, you must submit a Notice of Intent (NOI) application form for coverage
under the NCG140000 general permit to the Stormwater Permitting Unit in Raleigh as you have done for your
new ready -mixed concrete facility in Richmond County. As a courtesy, we have enclosed a copy of the NOI
application to be completed and submitted within 30 calendar days from receipt of this letter.
Sincerely,
J3C.P 'J.
Belinda S. Henson
Regional Supervisor
Surface Water Protection Section
BSH: MLlml
Enclosure
cc: FRO -Surface Water Protection (w/o enclosure)
Stormwater Permitting Unit (w/o enclosure)
NPS Assistance & Compliance Oversight Unit (w/o enclosure)
Water Quality Central Files (w/o enclosure)
NoCthCarolina
AWimal!y
North Carolina Division of Water Quality 225 Green Street -Suite 714 Fayetteville, NC 28301 Phone [phone] Customer Service
Internet: www,newaterquality.ore Fax [phone].623-6748
An Equal DpportunilylAff+rmative Action Employer— 50% Recycledl10% Post Consumer Paper

Y
(uomesuc mart unry; no insurance coverage rrovraeal
For delivery Information visit our website at www.uaps.eomro
I
Ln a Retum Receipt Fee Postmark
O
(Endorsement Required) Here
t'3 Restricted Dellvery Fee
(Endorsement Required)
Ln Total Postage
Karl Hildreth
ru enr - 1-lildreth Septic Tan]<s
srr��r,aato-; 1'.Q. BOX 109$
or PO Box NOL
�` cirysisia;zrP. Wadesboro, NC 28170
...See. Reverso toi Instructions

C'ovuptlm, Name 1jlLT31:2-EiT�t R6ADY MIX E�T-lC SARV��~✓��.
P,0, P-1D.X 10 L?
IVED
IOVED
Phone Number 704-694.2034 0 S 7Fax Number 70"W1664
e-mail mrhiidrei gwindstream,notI)ENR—FAYEif1r LLEA1.OFRCI
FAX `rfiAkjSMi'TTAL'L
To: Division of Water Qualify
Fram::Kart Hiidretit Gate Sent 9/5/2006
CC: Ms. Belinda Henson
And Mr,tawyer
Phone: Number of Pages:4
Fax:
■ complete items 1, 2, and $- Also complete
Item 4 If Restricted Delivery Is desired.
■ Print your name'and address on the reverse
so that we can return the card to you.
■ Attach this card to the back of the mallplece,
or on the front if space permits.
1. Article Addressed to:
Karl 1-lildreth
Hildreth Septic "ranks
P.O. BOX 1098
Wadesboro, NC 28170
A. $Ignature
X ern
Addressee
Date o
WtDell-s-(IveATMW
- ory
D. Is delivery address different from Item t? ❑ Yes
If YES, enter delivery address below: ❑ No
3. Service Type
0 Certlfled Mail ❑ Express Mail
❑ Registered ❑ Return Reoelpt for Merchandise
❑ Insured Mall ❑ c.o.D.
4. Restricted Delivery? (Sxtra Fee) ❑ Yes
2. Article Number .
(Ttensfdr fmm service mbar) I-- 7 0 0.k 2150 a 0 0 5 :121r 119 7 9 9 3 11 i i
PS Form 3811, February 2004 T Domestic Return Receipt 102595-02-M-1540
E

• F t
{� \N T Michael F. Easley, Govctnar
wiiliam G. Ross 7r., Secretary
. I , North Carolina 13epattment of Environment and Natursl Resources
rrrr bAvS � x: ! ~C Coleen H. Sullins. Director
Division of Water Quality
August 21, 2008
CERTIFIED MAIL: 7001 2510 0006 9498 7704
RETURN RECEIPT REQUESTED
Karl Hildreth
Hildreth Septic Tanks
PO Box 1098
Wadesboro, NC 28170
Subject: NOTICE OF VIOLATION (NOV-2008-OP-0041) and
RECOMMENDATION FOR ENFORCEMENT
Hildreth Septic Tanks (Wadesboro Plant)
Anson County
Dear Mr, Hildreth:
On June 2, 2006, Mike Lawyer from the Fayetteville Regional Office of the Division of Water Quality
(DWQ) conducted a site visit at the Hildreth Septic Tank facility located on SR 1142 in Wadesboro, Anson
County, NC in response to a complaint that he received from a neighboring property owner. As a result of Mr.
Lawyer's site visit, it was determined that your facility needed to obtain coverage under the NCG140000 General
Stormwater Permit for Ready -Mix Concrete facilities to replace coverage you had at the time under the
NCG070000 General Stormwater Permit for Stone, Clay, Glass and Concrete Products. A letter dated ,tune 5,
2006, which you received on June 7, 2006 according to the Certified Mail Return Receipt, requested that a Notice
of Intent (NOI) application form be completed and submitted for review by the DWQ Stormwater Permitting Unit
within thirty days from receipt of that letter. As of the date of this letter, DWO file review indicates that your
coverage under the NCG070000 permit has expired and the Division of Water Quality has not received an NOI for
coverage under the NCG140000 permit.
Your continued operation of the Wadesboro ready -mix concrete facility without coverage under
the NCG140000 permit constitutes violations of North Carolina General Statute §143.215.1.
You are required to respond to this offlee within thirty (30) calendar days from receipt of this letter. Your
response should include a Plan of Action to address the aforementioned violations within a reasonable amount of
time. This Office is considering sending a recommendation for enforcement to the Director of the Division of
Water Quality regarding these issues. Your above -mentioned response to this correspondence will be considered
in this process. This office requires that the violations, as detailed above, be properly resolved. These
violations and any future violations are subject to a civil penalty assessment of up to $25,000 per day for
-----. �act>�ulolat�d�o�t.hav nv_q ti rsgarriiru.i1 � , please r tact Mr -Law myself•...__ __ .....
[phone].
Sincerely,
Belinda S. Henson
Regional Supervisor
Surface Water Protection Section.
BSH: MLIml
cc: FRO -Surface Water Protection
Stormwater Permitting Unit Nne
pithcarolina
NPS Assistance & Compliance Oversight Unit Aattlydlly
Water QMality Central Has
North Carolina Division of Water Quality 225 Green Street -Suite 714 Fayetteville, NC 28301 Phone [phone] Customer Service
Internet: www.ncwatertgualia.ora Fax (910)4B"707 1-877-623-6748
An Equal opportunttylAtA"Wve ACtlon Employer— 50% Recyoledll0% Poet consumer Paper

NORTH CAROLINA DEPARTMENT OF
ENWRONMENT AND NATURAL RESOURCES
2 0 Q 8 P R 0 0 6 7 6 3
INVOICE
Annuli Permit Fee
This annual fee is required by the North Carolina Administrative Code. It covers the administrative costs associated with your
pemit. It is required of any person bolding a permit for any time during the annual fee period, regardless of the facility's operating
status. Failure to pay the Re by the due date will subject the permit to revocation, Operating without a valid permit is a violation
and is subject to a $10,000 per day fine. If the permit is revoked and you later decide a permit is needed, you must reapply, with the
understanding the permit request may be denied due to changes in enviroamcntal, regulatory, or modeling conditions.
Permit lumber: NCG070159
Anson County
Karl Hlldreth
Hlldreth Septic Tanks
PO Box 579
Wadesbnro, NC 28170
Annual Fee Period; 2006.06-01 to 2009-05-31
Invaite Date: 07/22/08
Due .Date, 08/21/08
Annual Fee: $100,00
Notes:
1. A $25.00 proecssing fee will be charged for returned checks in accordance with the North Carolina General Statute 25.3.512. r
2. Non -Payment of this fee by the payment due date will initiate the permit revocation process.
3. Remit payment to: 0'
NCDENR - Division of Water Quality'
1617 Mail Service Center ( �
Raleigh, NC 27699-1617
d. Should yev have any questions regarding this invoice, please comtact the Annual Administering and Compliance Fee Coordinator at
919-733-5083 extension 210

9/S/2008
Hildreth Septic Tank & Ready Mix
PO Box 1098
Wadesboro, N.C. 28170
Wadesboro Plant
To whom it may concern:
We received the notice for Annual Permit Fee about the.end of July 2008, mailed a check
for $100.00 dollars on 8/15/2008, check # 2202 on Anson Bank in Wadesboro. There
very well could have been a letter prior to this August 21,2008 certified Mail. There are
several people that get the mail and T never saw any paper. We try to honor all
regulations because to operate oar business is very, very important to us. Please fax what
we need to have in order to comply of let me know where Z can go online to get the
papers for your requirements.
Our Fax # [phone].
Thank you.
Karl Mldreth owner

of W A rF9
DWa7
--I
O �
August 21, 2008
CERTIFIED MAIL: 7001 2510 0006 9498 7704
RETURN RECEIPT REQUESTED
Karl Hildreth
Hildreth Septic Tanks
PO Box 1098
Wadesboro, NC 28170
Michael F. Easley, Govemor
William G. RossJr., Secretary
North Carolina Department of Environment and Natural Resources
Subject: NOTICE OF VIOLATION (NOV-2008-OP-0041) and
RECOMMENDATION FOR ENFORCEMENT
Hildreth Septic Tanks (Wadesboro Plant)
Anson County
Dear Mr. Hildreth:
Coleen H. Sullins, Director
Division of Rater Quality
On June 2, 2006, Mike Lawyer from the Fayetteville Regional Office of the Division of Water Quality
(DWQ) conducted a site visit at the Hildreth Septic Tank facility located on SR 1142 in Wadesboro, Anson
County, NC in response to a complaint that he received from a neighboring property owner. As a result of Mr.
Lawyer's site visit, it was determined that your facility needed to obtain coverage under the NCG140000 General
Stormwater Permit for Ready -Mix Concrete facilities to replace coverage you had at the time under the
NCG070000 General Stormwater Permit for Stone, Clay, Glass and Concrete Products. A letter dated June 5,
2006, which you received on June 7, 2006 according to the Certified Mail Return Receipt, requested that a Notice
of Intent (NOI) application form be completed and submitted for review by the DWQ Stormwater Permitting Unit
within thirty days from receipt of that letter. As of the date of this letter, DWO file review indicates that your
coverage under the NCG070000 permit has expired and the Division of Water Quality has not received an N01 for
coverage under the NCG140000 permit.
Your continued operation of the Wadesboro ready -mix concrete facility without coverage under
the NCG140000 permit constitutes violations of North Carolina General Statute §143-215.1.
You are required to respond to this office within thirty (30) calendar days from receipt of this letter. Your
response should include a Plan of Action to address the aforementioned violations within a reasonable amount of
time. This Office is considering sending a recommendation for enforcement to the Director of the Division of
Water Quality regarding these issues. Your above -mentioned response to this correspondence will be considered
in this process. This office requires that the violations, as detailed above, be properly resolved. These
violations and any future violations are subject to a civil penalty assessment of up to $25,000 per day for
each violation. Should you have any questions regarding these matters, please contact Mr. Lawyer or myself at
[phone].
Sincerely,
at;O�D J %M4zrz)
Belinda S. Henson
Regional Supervisor
Surface Water Protection Section
cc: FRO -Surface Water Protection
Stormwater Permitting Unit No`hcaroIIna
NPS Assistance & Compliance Oversight Unit Naturally
Water Quality Central Files
North Carolina Division of Water Quality 225 Green Street -Suite 714 Fayetteville, NC 28301 Phone [phone] Customer Service
Internet: www.ncwateraualitv.orP Fax [phone].623-6748
An Equal Opportunity/Affirmative Action Employer — 50% Recycled110% Post Consumer Paper

i C3 I
CO Postage $
Cr
tr 0' Certified Fee
Postmark
Return Receipt Fee Here
(Endorsement Required)
M Restricted Delivery Fee
C3 (Endorsement Required)
�
Total Postagel Karl 1-Iildl eth
�
senfr4 I-Iildreth Septic Tanks
1' . O. Box 1098
C3 or Pp Box Mo.
O C;'ry;'Srare;iiP+ Wadesboro, NC 28170
N
■ Complete Items 1, 2, and 3. Also complete A
Item 4 If Restricted Dellvery is desired.
■ Print your name and address on the reverse,
so that we can return the card to you.
■ Attach this card to the back of the mallplece,
or on the front If space permits.
-, Is delivery address different from item
If YES, enter delivery address below:
1. Article Addressed to:
Karl 1-Iddreth
I iildreth Septic Tanks
P.O. Box 1098
Wadesboro, NC 28170
"Add
gent
❑ Addre:
I I C. Date of Dell
❑ Yes
❑ No
3. Service'lype
❑ Certified Mali o Express Mail
❑ Registered ❑ Return Receipt for Merchandise
❑ Insured Mall ❑ C.Q.D.
4. Restricted Delivery? Pfha Fee} ❑ Yee
2. Article Number _._
( milerfmmeervloe►aW 7001 2510 0006 9498 7704
Ps Form 3811, February 2004 Domestic Return Receipt 1=95-02-M-1540

RECEIVED A PHONE MESSAGE FROM:
MR. SHANNON HILDERETH. MR. HILDERETH HAD THE FOLLOWING COMPLAINTS:
1. AN ABOVE GROUND FUEL TANK IS LEAKING INTO THE CEMETARY NEXT TO
THE FUEL TANK.
2. A CONCRETE PLANT EXISTS ON THE SAME SITE. CONCRETE TRUCKS ARE
WASHED. THE WATER GOES INTO A POND THAT DUMPS INTO THE CITY POND.
ANSON CO GETS ITS WATER FROM THE CITY POND.
3. HOUSE DEMOLITION DEBRIS IS DUMPED BEHIND THE OWNER'S RESIDENCE.
RESIDENCE IS ON THE SAME SITE AS THE FUEL TANK AND THE CONCRETE
PLANT.
LOCATION: WADESBORO, ANSON COUNTY
OWNER: CARL HILDERETH
SHANNON HILDERETH
PHONE: [phone]
CELL: 704-695-2529
�,5-) C4 pet',J
a (d6�6/e w;da 1mr7v)

g 4 �F W A r�R . Michael F. Easley, Governor
t,
O�4 QG .
William G. Ross in, Secretary
North Carolina Department of Environment and Natural Resources
(� Alan W. Klimek, P.E. Director
Division of Water Quality
June 5, 2006
CERTIFIED MAIL: 7001 2510 0006 9500 5902
RETURN RECEIPT REQUESTED
Karl Hildreth
Hildreth Septic Tanks & Ready -Mix Concrete
PO Box 1098
Wadesboro, NC 281,70
SUBJECT: Application for Stormwater Permit for Ready -Mixed Concrete Facilities
Dear Mr. Hildreth:
Thank you for meeting with me this past Friday and discussing the issues between you and your
neighbors. As 1 said during our discussion, ready -mixed concrete facilities such as yours are required to
obtain coverage under General Permit NCG140000.to allow stormwater and process wastewater to
discharge from the property. Enclosed with this letter is a Notice of Intent form for you to complete and
return to our Stormwater Permitting Unit in Raleigh, whose address is included on the application. You
have thirty days from receipt of this letter to submit the application in order to avoid a Notice of
Violation for operating without a permit. Once they receive your application they will review the
information that you have provided, contact.you if additional information is needed, request comments
from the Fayetteville Regional Office and then probably issue a Certificate of Coverage. We also
discussed whether or not you should keep coverage under the permit for stone, clay, glass and concrete
products. I have been informed that this will not be necessary. For businesses with multiple activities,
the permit coverage -requirement is based on which activity generates the majority of income.
Therefore, you will need to send a letter to Raleigh concerning your business changes and asking that
the other permit be rescinded. 1 would suggest sending this letter along with your application for
coverage under the NCG 140000 permit.
l have also enclosed my business card with the Division's website written at the bottom. 1
encourage you to visit our website and click on Norms and Documents under the Stormwater Runoff and
Nonpoint Source Pollution section so that you can become familiar with the permit and all of its
requirements. If you need any assistance with this, completing the Notice of Intent or anything else,
please feel free to call me at 910-486-1541,
Sincere ly,
Michael Lawyer
Environmental Technician
Erlclosures (2)
One
Npr hCarohna
Ndurally
North C'aroiina Division of Water Quality 225 Green Street, Suite 714 Fayetteville, NC 28301-5043 Phone [phone] Customer Service
Internet: Fax [phone]
An Equal OpportunitylAliirmative Action Employer — 501% Recycied110% Post Consumer Paper

J
�� Division of Water Quality / Surface Water Protection
NCDENRNational Pollutant Discharge Elimination System
NO.�tI CARG IN4 Q* Y TM[M q/
Ewvlrvowa[nr who tlRu.rl R[wuncla
NCG140000
NO—TICE OF INTENT
National Pollutant Discharge Elimination System application for coverage under General Permit
NCG 140000:
STORMWATER AND PROCESS WASTEWATER DISCHARGES associated with activities classified
SIC (Standard Industrial Classification) Code - 3273 Ready Mixed Concrete
For new plant sites that will discharge or recycle process wastewater (even if commingled with
stormwater): This NOI is also an APPLICATION FOR Authorization to Construct (ATC) wastewater
treatment facilities. ATC requests must be submitted at least 90 days prior to construction'.
For existin plant sites discharging or recycling process wastewater (even if commingled with
stormwater): This NOl is also an APPLICATION FOR AuthQrizatlon to corlirinuQto operate wastewater
treatment facilities in place. Construction, modification, or installation of any new treatment components
at an existing site requires an ATC.
Treatment facilities used to treat or recycle process wastewater (including stormwater BMP structures
treating process wastewater flows commingled with stormwater) require an ATC prior to construction
per 15A NCAC 214 .0138. The authorization to construct or continue to operate will he issued at the
same time as the Certificate of Coverage (COC) for the NCG14 permit. Design of treatment facilities
must comply with requirements of 15A NCAC 2H .0138 & .0139.
Construction of wastewater treatment facilities (this includes recycle systems) at new or existing punt
sites requires submission of three (3) sets of plans and specifications signed and sealed by a
Professional Engineer (P.E.) or qualified staff' along with this application. A copy of the•design
calculations should be included. Please see questions 14 & 15.
For questions, please contact the DWQ Regional Office for your area. (See page 5)
(Please print or type)
1) Mailing address of owner/operator address to which all permit correspondence will be mailed):
Name
Street Address
City
Telephone No.
2) Location of facility producing discharge:
Facility Name
Facility Contact
Street Address
City
County
Telephone No.
Page 1 of 5
State
Fax:
ZIP Code
State ZIP Code
Fax:
'As per 15A NCAC 2H ,0106
`Unless treatment facilities are designed, constructed, and put into operation by employees snternal to the company who are qualifiedlto
perform such work for their respective companies in accordance with General Statutes, 89C-25 (7), plans and specifications must be signed
and sealed by a P.E.
SWU-229-101905 Last revised 10119/2005

r
i
NCG140000 N.4.1.
3) Physical location information:
Please provide a narrative description of how to get to the facility (use street names, state road numbers, and
distance and direction from a roadway intersection).
to copy of a county map or USGS quad sheet with facility clearly located on the map is a required part of this application.)
4) Latitude Longitude (deg, min, sec)
5) This NPDES Permit Application applies to which of the following:
❑ New or Proposed Facility Date operation is to begin
❑ txisting
6) Standard Industrial Classification:
Provide the 4 digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial
activity at this facility
SIC Code:
7) Provide a brief description of the types of industrial activities and products produced at this facility:
(Include a site diagram showing the process areas present at this facility.)
8) Discharge points 1 Receiving waters:
How many discharge points (ditches, pipes, channels, etc.) convey stormwater and/or wastewater from the
property?
What is the name of the body or bodies of water (creek, stream, river, lake, etc.) that the facility stormwater
and/or wastewater discharges end up in?
If the site stormwater discharges to a separate storm sewer system, name the operator of the separate storm
sewer system (e.g. City of Raleigh municipal storm sewer).
Receiving water classification (if known):
Note: Discharge of process wastewater to receiving waters classified as WS-II to WS-V or SA must
be approved by the N.C. Dept. of Environmental Health. If DEH does not approve, coverage
under NCG140M cannot be granted. None discharges of process wastewater are permitted
in receiving waters classified as WS-I or freshwater ORW.
9) Does this facility have any other NPDES permits?
❑ No
❑ Yes
It yes, list the permit numbers for all current NPDES permits for this facility:
10), Does this facility have any Non -Discharge permits (ex: recycle permits)?
❑ No
❑ Yes
If yes, list the permit numbers for all current Non -Discharge permits for this facility:
11) Does this facility employ any best management practices for stormwater control?
❑ No
❑ Yes
If yes, please briefly describe:
Page 2 of 5
SWU-229-101905 Last revised 10/19/2005

NCG140000 N.O.I.
i.
12) Does this facility have a Stormwater Pollution Prevention Plan?
❑ No
❑ Yes
If yes, when was it implemented?
13) Are vehicle maintenance activities occurring or planned at this facility?
❑ No
❑ Yes
Wastewater, Treatment Desi n Information
14) Are discharges occurring or planned from any of the following process wastewater generating a
Vehicle and equipment cleaning ❑ Yes ❑ No
Wetting of raw material stockpiles ❑ Yes ❑ No
Mixing drum cleaning
❑ Yes ❑ No
If yes to any of the above, please describe the type of process used to treat and/or recycle the process
wastewater.
For a sufficient application, you must provide design specifics (e.g., design volume, retention time, su
area, etc.) and calculations to demonstrate compliance with permit effluent limits (pH - 6-9 SU, Total
Suspended Solids (TSS) - 30 mg/I, and Settleable Solids (SS) - 5 min.) [Use separate sheet(s)].
If all these discharges are recycled, please refer to Question 15.
For plants that rec cle and/or dischar a pLocess was!@Ngter:
When applying for this permit, you are also applying for an authorization to construct (new
treatment facilities) or authorization to continue to operate (existing treatment facilities) as
part of the NOL For new sites, you must submit three (3) sets of design plans and
specifications with this application and provide supporting calculations that predict
compliance of final discharge with permit limits. For gxJstina sites, applicants should submit
three (3) sets of plans and specs for facilities as -built and provide as many design details as
possible, or submit a detailed diagram of treatment systems in place that includes information
such as tank volumes, dimensions, retention time, piping, settling basin details, etc.
Please note: if new treatment systems are planned for an existing site, an ATC will be required
prior to construction of those facilities. Plans/specs/calculations prepared by a P.E. and the
request for an ATC may be submitted with this NOI, or separately at a later date. DWQ may
request the status of your plans for requesting an ATC upon Issuance of the COC.
15) Does the facility use or plan to use a recycle system?
❑ No
❑ Yes
If yes, what size storm event is the system designed to hold before overflowing? (for example, 10-yr, 24-hr)
year, 24-hr rainfall event
For a recycle system (regardless of when it overflows), please provide plans, calculations, and design specifics
(e.g., throughput assumptions/water balance, design volume, retention time, surface area, amount of
freeboard in design storm event, etc.). [Use separate sheet(s)].
V- For a sufficient application, the information must demonstrate compliance of final discharge with permit effluent
limits (pH - 6-9 SU, Total Suspended Solids (TSS) - 30 mg/l, and Settleable Solids (SS) - 5 mill), or must
demonstrate that the recycle system has sufficient capacity to contain runoff from a 25-year, 24-hr rainfall
event plus one foot of freeboard under design operating conditions.
Page 3 of 5
SWU-229-101905 Last revised 1011

—.
4 NCG140000 N.O.I.
16) Are wastewater treatment facilities (including recycle systems) planned in the 100-year flood plain?
❑ No ❑ Yes If so, include information to demonstrate protection from flooding. (Minimum design
requirements for treatment works include protection from the 100-year flood, per 15A NCAC 2H .0219.)
17) Hazardous Waste:
a) Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility?
❑ No
❑ Yes
b) Is this facility a Small Quantity Generator (less than 1000 kg. of hazardous waste generated per month) of
• hazardous waste?
❑ No 5
❑ Yes
c) Is this facility a Large Quantity Generator (1000 kg. or more of hazardous waste generated per month) of
hazardous waste?
❑ No
❑ Yes
d) If you answered yes to questions b. or c., please provide the following information:
Type(s) of waste:
How is material stored:
Where is material stored:
Flow many disposal shipments per year:
Name of transport / disposal vendor:.
Vendor address:
18) Certification:
North Carolina General Statute 143-215.6 B(i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan, or other
document filed or required to be maintained under this Article or a rule implementing this Article; or who knowingly makes a false
statement of a material fact in a rulemaking proceeding or contested case under this Article; or who falsifies, tampers with, or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
[Environmental Management] Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine
not to exceed ten thousand dollars ($10,000).
I hereby request coverage under the referenced General Permit. I understand that coverage under this permit
will constitute the permit requirements for the discharge(s) and is enforceable in the same manner as an
individual permit.
I certify that i am familiar with the information contained in this application and that to the best of my knowledge
and belief such information is true, complete, and accurate.
Printed Name of Person Signing:
Title:
(Signature of Applicant)
(Date Signed)
Notice of Intent must be accompanied by a check or money order for $80.00 made payable to:
NCDENR
Page 4 of 5
SWU-229-101905 Last revised 10/19/2005

4- •
NCG140000 N.0.1.
Final Checklist
This application will be returned as incomplete unless all of the following items have been Included:
❑ Check for $80 made payable to NCDENR.
❑ This completed application and all supporting documentation (including design details and calculations for
treatment systems).
❑ If an Erosion & Sedimentation Control (E&SC) Plan is required from Division of Land Resources (DLR)
or local designee: documentation verifying applicant has developed and submitted that Plan to the governing
agency (required per 15A NCAC 02H .0138),
❑ For new sites (or sites that will Install new treatment facilities): Three (3) copies of plans and
specifications for wastewater treatment facilities (including recycle systems), signed and sealed by a
Professional Engineer or qualified staff meeting requirements of G. S. 89C-25 (7). ,
❑ For existing sites: three (3) copies of plans and specifications for'wa'stewater. treatm'ent,faciiities (including
recycle systems) wilt, stamped and sealed by a Professional Engineer, or (only if plans not availalI le) a
detailed diagram of treatment systems in place that includes information such as tank volumes, dimensions,
retention timo, piping, settling basin details, ate.
❑ A site map showing, at a minimum, (existing or proposed):
(a) outline of drainage areas, (b) stormwaterlwastewater treatment structures, (c) location of
stormwaterlwastewater outfalls (corresponding to which drainage areas), (d) runoff conveyance structures,
(e) areas where materials are stored, (f) impervious areas, and (g) site property lines.
❑ A county map or USGS quad sheet with location of facility clearly marked.
Mail the entire package to:
Stormwater Permitting Unit
Division of Water Duality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Note
The submission of this document does not guarantee the issuance of an NPDES permit.
J For questions, please contact the DWO Regional Office for your area. I j
DVV.Q Regional Qffice Contact Information:
Asheville Office ......
[phone]
Fayetteville Office ...
[phone]
Mooresville Office...
[phone]
Raleigh Office ........
[phone]
Washington Office ...(252)
946-6481
Wilmington Office ...
[phone]
Winston-Salem ......
[phone]
Central Office .........(919)
733-5083
Page 5 of 5
T �"
S W U-229.101905
Last revised 10'19/2005

Karl Hildreth
Hildreth Septic Tanks
P O Box.Wr /09S
Wadesboro, NC 28170
ZJ? (e
ear Permittee:
Michael F. Easley, Governor
William 4. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
April 28, 2003
Alan W. Klimek, P.E. Director
Division of Water Quality
ink r
i APR 3 0 2003
i
Subject: NPDES Stormwater` Permit Renewal
Hildreth Septic Tanks
COC Number NCG070159
Anson County
In response to your renewal application for continued coverage under general permit NCG070000, the
Division of Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This
permit is reissued pursuant to the requirements of North Carolina General Statute 143-215.1 and the
Memorandum of Agreement between the state of North Carolina and the U.S. Environmental Protection
Agency, dated December 6, 1983.
The following information is included with your permit package:
• A new Certificate of Coverage
• A copy of General Stormwater Permit NCG070000
• A copy of the Analytical Monitoring Form (DMR)
• A copy of the Qualitativei Monitoring Form
• A copy of a Technical Bulletin for the general permit
Your coverage under this general permit is not transferable except after notice to DWQ. The Division
may require modification or revocation and reissuance of the Certificate of Coverage. This permit does
not affect the legal requirements to obtain other permits which may be required by the Department of
Environment and Natural Resources, or relieve the permittee from responsibility for compliance with any
other applicable federal, state, or local law, rule, standard, ordinance, order, judgment, or decree.
It you have any questions regarding this permit package please contact Mack Wiggins of the Central
Office Stormwater and General Permits Unit at [phone], ext. 542.
Sincerely,
Bradley Bennett, Supervisor
Stormwater and General Permits Unit
cc: Central Files
Stormwater & General Permits Unit Files
Fayetteville Regional Office
N. C. Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 [phone]
ARMA
Rate
Customer Service
1 800 623-7748

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG070000
CERTIFICATE OF COVERAGE No. NCG070159
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended, I
Hildreth Septic Tanks
is hereby authorized to discharge stormwater from a facility located at
Hildreth Septic Tanks
/ 574'.
Wadesboro h
Anson County
to receiving waters designated as the North Fork Jones Creek, a class C stream, in the Yadkin -
Pee Dee River Basin in accordance with the effluent limitations, monitoring requirements, and
other conditions set forth in Parts I, II, III, IV, V, and VI of General Permit No. NCG070000 as
attached.
This certificate of coverage shall become effective May 1, 2003.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day April 28, 2003.
for Alan W. Klimek, P.E., Director
Division of Water Duality
By Authority of the Environmental Management Commission

�0F WATEA4
�Q G
� r
0lii;�Zwillw `c
KARL HILDRETH
HILDRETH SEPTIC TANKS
P O BOX 579
WADESBORO, NC 28170
Dear Permittee:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E., Director
Division of Water Quality
September 4, 2002 I
SFP 1 0
I
Subject: NPDES Stormwater Permit Coverage Renewal
Hildreth Septic Tanks
COC Number NCG070159
Anson County
Your facility is currently covered for stormwater discharge under General Permit NCG070000. This permit expires
on March 31, 2003. The Division staff is currently in the process of rewriting this permit and is scheduled to have
the permit reissued by early spring of 2003. Once the permit is reissued, your facility would he eligible for
continued coverage under the reissued permit.
In order to assure your continued coverage under the general permit, you must apply to the Division of Water
Quality (DWQ) for renewal of your permit coverage. To make this renewal process easier, we are informing you in
advance that your permit coverage will be expiring. Enclosed you will find a Permit Coverage Renewal
Application Form. The application must be completed and returned by October 2, 2002 in order to assure
continued coverage under the general permit. Due to staff and budget constraints, letters confirming our receipt of
the completed application will not be sent.
Failure to request renewal within the time period specified, may result in a civil assessment of at least $250.00.
Larger penalties may be assessed depending on the delinquency of the request. Discharge of stormwater from your
facility without coverage under a valid stormwater NPDES permit would constitute a violation of NCGS 143-215.1
and could result in assessments of civil penalties of up to $10,000 per day.
Please note that recent federal legislation has extended the "no exposure exclusion" to all operators of industrial
facilities in any of the I l categories of "storm water discharges associated with industrial activity," (except
construction activities). If you feel your facility can certify a condition of "no exposure", i.e. the facility industrial
materials and operations are not exposed to stormwater, you can apply for the no exposure exclusion. For additional
information contact the Central Office Stormwater Staff member listed below or check the Stormwater & General
Permits Unit Web Site at http://h2o.enr.state.nc.us/su/stormwater.htinI
If the subject stormwater discharge to waters of the state has been terminated, please complete the enclosed
Rescission Request Form. Mailing instructions are listed on the bottom of the form. You will be notified when the
rescission process has been completed.
If you have any questions regarding the permit renewal procedures please contact Ricky Revels of the Fayetteville
Regional Office at 910-486-1541 or Mack Wiggins of the Central Office Stormwater Unit at [phone], ext.
542
Bradley Bennett, Supervisor
Stormwater and General Permits Unit
cc: Central Files
Stormwater and General Permits Unit Files
Fayetteville Regional Office ®VA
NCDENR
N. C. Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 [phone] Customer Service
1- 800-623.7748

r'7
CI
ff-
m
M
Postage
S
.43
Ln
Cr�
CortNled Fee
(� O
�[
Postmark
-0
Return Receipt Fee
(Endorsement Required)
!
c
Here
t7
Cl
Restricted Delivery Fee
©
(Endorsement Required)
Total Postage S. Fees
s 4 •
(�
1""
Sent To
/�
----••----------------
C3
©
Street, Apt. Na,; f�D1/_.lt�_�-/�
No or PO Box .
O
117�hC
.Eiry.st _i ...1P...
+14 r
(VV76
■ Complete Items 1, 2, and 3. Also complete A.
item 4 if Restricted Delivery Is desired. x
■ Print your name and address on the reverse
so that we can return the card to you. g
■ Attach this card to the back of the mailpleae,
or on the front if space permits.
1. Article
(6�Addressed
`to:
POai�a to48
ad"bw, nC a8,70
Number
� srarrrawawtwvrce �_
I PS Form ruary 200 rr
Agent
Received by (Printed Name) C. Date f De1I ery
r, A �4� e �-- �%
Is delivery address different from item 17 ❑ Yes
It YES, enter delivery address below: ❑ No
-3. Service Type
Certified Mail ❑ Express Mall
Registered 0 Return Receipt for Merchandise
❑ Insured Mall ❑ C.D.D.
RzigroVfi WXOWFee1 ❑ Yea
a lb t 1 Ubt�j W:9>1'tJI
Domestic Return Recelpt 102595-1V4*1UD

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
Mr. Karl Hildreth
Hildreth Septic Tanks
Post Office Box 579
Wadesboro, North Carolina 28170
Dear Mr. Hildreth:
RECEIVE
JUN 1 4 1999 � � i�
FAYETTEVI�� �
REG. OFFICNCDENR
June 11, 1999
Subject: General Permit No, NCG070000
Hildreth Septic Tanks
COC NCG070159
Anson County
In accordance with your application for discharge permit received on February 11, 1999, we are
forwarding herewith the subject certificate of coverage to discharge under the subject state - NPDES general
permit. This permit is issued pursuant to the requirements of North Carolina General Statute 143-215 .1 and the
Memorandum of Agreement between North Carolina and the US Environmental Protection agency dated
December 6, 1983.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to request an individual permit by submitting an individual permit
application. Unless such demand is made, this certificate of coverage shall be final and binding.
Please take notice that this certificate of coverage is not transferable except after notice to the Division of
Water Quality. The Division of Water Quality may require modification or revocation and reissuance of the
certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be required by the
Division of Water Quality or permits required by the Division of Land Resources, Coastal Area Management Act
or any other Federal or Local governmental permit that may be required.
If you have any questions concerning this permit, please contact Aisha Lau at telephone number
919/733-5083 ext. 578.
Sincerely,
ORIGINAL SIGNED BY
WILLIAM C. MILLS
Kerr T. Stevens
cc: [Fayetteyille_RegianalOffice]e.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG070000
CERTIFICATE OF COVERAGE No. NCG070159
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
Karl Hildreth
is hereby authorized to discharge stormwater from a facility located at
Hildreth Septic Tanks
SR 1142
Wadesboro
Anson County
to receiving waters designated as North Fork Jones Creek, a class C stream in the Yadkin River Basin in accordance
with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, III, IV, V, and VI
of General Permit No. NCCY070000 as attached.
This Certificate of Coverage shall become effective June 11, 1999.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day June 11, 1999.
ORIGINAL SIGNED BY
WILLIAM C. MILLS
Kerr T. Stevens, Director
Division of Water Quality
By Authority of the Environmental Management Commission

r
4a
00
,
J,
'l
.
Igoe
SOO
F=77\
7%
400
343
to
-17•
L
�p
-.x
f AA_
L142
'50
0
121
'Ir
Gat
wood S�tps'
Ch
AD—.
Bethel
500
Ch
7N
'1129'
4
rm,
Z__
Ala.
00