NCG030041_COMPLETE FILE - HISTORICAL_20090319 (2)

STbRMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
/V C& 03 b-o y
DOC TYPE
HISTORICAL FILE
❑ MONITORING REPORTS
DOC DATE
❑ ao-05 6 3 I g
WYYMMDD

,
NCDENR
North Carolina Department of Environment and
Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins
Governor Director
March 19, 2009
MAR 2 4 2009
Mr. Mike Sperati
t ;
Crown -Kinston
F �• .'y 1. .:^,
2000 Dobbs Farm Road
Kinston, NC 28501
Dear Mr. Sperati:
Dee Freeman
Secretary
Subject: NPDES General Permit NCG030000
Certificate of Coverage NCG030041
Crown -Kinston
Formerly Kinston Neuse Corporation
Lcnoir County
On October 29, 2008, Division personnel received your'request to revise your storrnwater permit Certificate of Coverage
to accurately include you new company name.
Please find enclosed the revised Certificate of Coverage, The terms and conditions contained in the General Permit
remain unchanged and in full effect. This revised Certificate of Coverage is issued under the requirements of North
Carolina General Statutes 143-215.1 and the Memorandum of Agreement between North Carolina and the U.S.
Environmental Protection Agency.
If you have any questions, please contact the Stormwater Permitting Unit at [phone].
Sincerely, 0
Coleen H. Sullins
cc: DWQ Central Files
Washington Regional Office
Stormwater Permitting Unit
Wetlands and Stormwaler Branch
1617 Mart Service Center, Raleigh, North Carolina 27699-1617
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604
Phone: [phone] FAX: [phone] Customer Service: 1-877-623-6748
Internet: www.ncwaterquality.org
An Equal Opporlunlly 1 Affirmative Action Employer
NorthCarolina
;Vaturallty

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG030000
CERTIFICATE OF COVERAGE No. NCG030041
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
CROWN-KINSTON
is hereby authorized to discharge storinwater from a facility located at
CRO WN-KINSTON
2000 DOBBS FARM ROAD
KINSTON
LENOIR COUNTY
to receiving waters designated as Briery Run, a class C SW NSW stream, in the Neuse River Basin in accordance
With the efftucnt limitations, monitoring reduireinents, and other conditions set ibrth in Parts I, 11, 111, IV, V, and VI
of General Permit No. NCG030000.
This certificate of coverage shall become effective March 19, 2009
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day March 19, 2009
for Coleen H. Sullins, Director
Division of Water Quality
I3y Authority of the Environmental Management Commission

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
of WArF9
�O� QG
Coleen H..Sullins, Director
Division of Water Quality
Chuck Wakild, P.E.,Deputy Director
Water Quality
December 19, 2007
Tonja Hardin, Environmental Administrator
Crown - Kinston Neuse Corporation
44 S Washington Street
New Bremen OH 45869
SUBJECT: November 29, 2007 Stormwater Inspection
Kinston Neuse Corporation
Permit No: NCG030041
Lenoir County
Dear Ms. Hardin:
Enclosed please find a copy of the Stormwater Inspection form from the inspection conducted by
me on November 29 2007. The facility was found to be in Compliance with permit NCG030041.
Please refer to the enclosed inspection report for additional observations and comments. If you or
your staff have any questions, please call me at 252-948-3918.
Sincerely,
Kristin. C. Ja man
Wastewater Treatment Plant Consultant
cc: John Hennessy -- NPS-ACO Unit
Central Files
Washington Files
NoNr hCarolina
aturally
North Carolina Division of Water Quality Washington Regional Office Phone [phone] Customer Service
Internet: www.ncwaterquality.org 943 Washington Square Mail, Washington, NC 27889 FAX [phone]
An Equal Opportunity/Affirmative Action Employer — 50% Recycled110% Past Consumer Paper

Permit: NCG030041
SOC:
County: Lenoir
Region: Washington
Compliance Inspection Report
Effective: 09/01/02 Expiration: 06/31/07 Owner: Kinston Neuse Corporation
Effective: Expiration: Facility: Kinston Neuse Corporation
2000 Dobbs Farm Rd
Contact Person: JiM--MeRM ic,�/a FI/12 D1� Title:
Directions to Facility:
System Classifications:
Kinston NC 28504
Phone: [phone]
Primary ORC: Certification: Phone:
Secondary ORC(s):
On -Site Representative(s):
Related Permits:
Inspection Date: 1112912007 Entry Time: 10:00 AM Exlt Time: 11:00 AM
Primary Inspector: Kristin C Jarman Phone: [phone]
Secondary Inspector(s): Ext.
Reason for Inspection: Routine Inspection Type: Stormwater
Permit Inspection Type: Metal Fabrication Stormwater Discharge COC
Facility Status: ® Compliant Q Not Compliant
Question Areas:
Storm Water
(See attachment summary)
Page: 1

Permit: NCG030041 Owner - Facility: Kinston Neuse Corporation
Inspection Date: 11/29/2007 Inspection Type: Stormwater Reason for Visit: Routine
Inspection Summary:
The facility is compliant with permit NCG030041. A USGS map will be added to the file. The facility has received its new
permit.
Page: 2

Permit: NCG030041 owner - Facility: Kinston Neuse Corporation
Inspection Date: 11/29/2007 Inspection Type: Stormwater
Reason for Via It: Routine
Stormwater Pollution Prevention Plan
Yes No NA NE
Does the site have a Stormwater Pollution Prevention Plan?
■ ❑ ❑ ❑
# Does the Plan include a General Location (USGS) map?
❑ ■ ❑ ❑
# Does the Plan include a "Narrative Description of Practices"?
■ ❑ ❑ ❑
# Does the Plan include a detailed site map including outfall locations and drainage areas?
■ ❑ ❑ ❑
# Does the Plan include a list of significant spills occurring during the past 3 years?
■ ❑ ❑ ❑
# Has the facility evaluated feasible alternatives to current practices?
■ ❑ ❑ ❑
# Does the facility provide all necessary secondary containment?
■ ❑ ❑ ❑
# Does the Plan include a BMP summary?
■ ❑ ❑ ❑
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
e ❑ ❑ ❑
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
■ ❑ ❑ ❑
# Does the facility provide and document Employee Training?
■ ❑ Cl ❑
# Does the Plan include a list of Responsible Party(s)?
■ ❑ ❑ ❑
# Is the Plan reviewed and updated annually?
■ ❑ ❑ ❑
# Does the Plan include a Stormwater Facility Inspection Program?
®❑ ❑ ❑
Has the Stormwater Pollution Prevention Plan been implemented?
■ ❑ ❑ ❑
Comment: Will get USGS map
Qualitative Monitoring
Yes
No
NA
NE
Has the facility conducted its Qualitative Monitoring semi-annually?
®❑
❑
Cl
Comment:
Analytical Monitoring
Yes
No
NA
NE
Has the facility conducted its Analytical monitoring?
®❑
❑
❑
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas?
❑
❑
IN
Cl
Comment:
Permit and Outfalls
Yes
No
NA
NE
# Is a copy of the Permit and the Certificate of Coverage available at the site?
®❑
❑
❑
# Were all outfalls observed during the inspection?
a
G
❑
❑
# If the facility has representative outfall status, is it properly documented by the Division?
❑
❑
v
❑
# Has the facility evaluated all illicit (non stormwater) discharges?
®❑
130
Comment:
Page: 3

o��� w A rE9Q
G
> ~�
May 23, 2006
Mr. Sam Phillips
Kinston Neuse Corporation
2000 Dobbs Farm Road
Kinston, NC 28501
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
Subject: Stormwater General Permit NCG030000
Operations and Maintenance Reminder
Kinston Neuse Corporation
COC Number NCG030041
Lenoir County
Dear Permittee:
Our records indicate that you have been issued a Stormwater General Permit and a Certificate
of Coverage for your facility. These permits have specific conditions that must be met in order for you
to be in compliance with your permit. It is your responsibility, as the permit holder, to read and
comply with the conditions contained in the permit.
It is our responsibility, as the issuing authority, to make sure that the operation and
maintenance of your facility complies with the conditions contained in your permit. To assist you in
complying with these conditions, we are attaching a Technical Bulletin specific to your permit
requirements. We are currently in the process of developing our inspection schedule. Therefore, you
should have all of your records up to date as we may be contacting you in the near future to set up
an inspection of your facility.
If you have any questions, please do not hesitate to contact Samir Dumpor, Pat Durrett or
myself at [phone].
Sincerely
Al Hodge, Supervisor
Surface Water Protection Unit
Encl.
CC: WaRO files
North Carolina Division of Water Quality lntemet: h2o.enr.state.nc.us
943 Washington Square Mall Phone: [phone]
Washington, NC 27889 FAX [phone]
An Equal Opportunity/Affirmative Action Emplcyer— 50% Recycledl10% Post Consumer Paper
NorthCarohna
Naturail'ff

SAM PHILLIPS
KINSTON NEUSE CORPORATION
2000 DOBBS FARM ROAD
KINSTON, NC 28501
Dear Permittee:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.faEE., Directtor'
Dif11air @�orD
August 23, 2002 AUG 2 9 2002
DWQ-WARO
Subject: NPDES Stormwater Permit Renewal
KINSTON NEUSE CORPORATION
COC Number NCG030041
Lenoir County
In response to your renewal application for continued coverage under general permit NCG030000, the Division of
Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This permit is reissued
pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement
between the state of North Carolina and the U.S. Environmental Protection Agency, dated December 6, 1983,
The following information is included with your permit package:
* A new Certificate of Coverage
* A copy of General Stormwater Permit NCG030000
* A copy of the Analytical Monitoring Form (DMR)
* A copy of a Technical Bulletin for the general permit
Your coverage under this general permit is not transferable except after notice to DWQ. The Division may require
modification or revocation and reissuance of the Certificate of Coverage. This permit does not affect the legal
requirements to obtain Dther permits which may be required by DENR or relieve the permittee from responsibility
for compliance with any other applicable federal, state, or local law, rule, standard, ordinance, order, judgment, or
decree.
If you have any questions regarding this permit package please contact Bill Mills of the Central Office Stormwater
and General Permits Unit at [phone], ext. 548
Sincerely,
Bradley Bennett, Supervisor
Stormwater and General Permits Unit
cc: Central Files
Stormwater & General Permits Unit riles
Washington Regional Office
N. C. Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 [phone]
e�,A
NCDENR
Customer Service
1-800.623-7748

BRIAN DUFFY
KINSTON NEUSE CORPORATION
424 WEST MONROE ST
NEW BREMEN, OH 45869
Dear Permittee:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Gregory J. Thorpe, Ph.D.
Acting Director
RECEIVED, Sion of Water Quality
December 27, 2001
ERR - 4 2002
DWQ-WARO
Subject: NPDES Stormwater Permit Renewal
KINSTON NEUSE CORPORATION
COC Number NCG030041
Lcnoir County
Your facility is currently covered for storrnwater discharge under General Permit NCG030000. This permit expires
on August 31, 2002. The Division staff is currently in the process of rewriting this permit and is scheduled to have
the permit reissued by late summer of 2002. Once the permit is reissued, your facility would be eligible for
continued coverage under the reissued permit.
In order to assure your continued coverage under the general permit, you must apply to the Division of Water
Quality (DWQ) for renewal of your permit coverage. To make this renewal process easier, we arc infirrming you in
advance that your permit will be expiring. Enclosed you will find a General Permit Coverage Renewal
Application Form. The application must be completed and returned by March 4, 2002 in order to assure continued
coverage under the general permit.
Failure to request renewal within this time period may result in a civil assessment of at least $250.00. Larger
penalties maybe assessed depending on the delinquency of the request. Discharge of storrnwater from your facility
without coverage under a valid storrnwater NPDES permit would constitute a violation of NCGS 143-215.1 and
could result in assessments of civil penalties of up to $10,000 per day.
Please note that recent Icderal legislation has extended the "no exposure exclusion" to all operators of industrial
facilities in any of the I I categories of' "storm water discharges associated with industrial activity," (except
construction activities). If you feel your lacility can certify a condition of "no exposure", i.e. the facilty industrial
materials and operations are not exposed to storrnwater, you can apply for the no exposure exclusion. For additional
information contact the Central Office Stormwater Staff member listed below or check the Stormwater & General
Permits Unit Web Site at htip:Hh2o.enr.state.nc.us/su/stormwater.hun]
If the subject storrnwater discharge to waters of the state has been terininatcd, plcasc complete the enclosed
Rescission Request Form. Mailing instructions are listed on the bottom ol'the form. You will he notified when the
rescission process has been completed.
if you have any questions regarding the permit renewal procedures please contact Robert Tankard of the
Washington Regional Office at 252-946-6481 or Bill Mills of the Central Office Stormwater Unit at (919)
733-5083, ext. 548
Sincerely,
Bradley Bennett. Supervisor
Stormwater and General Permits Unit
cc: Central Filcs
Washington Regional Office
iAr
RUNNR
N. C. Division of Water Quality 1617 Malt Service Center Raleigh, NC 27699-1617 [phone] Customer Service
1-800-623-7748

--State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
Mr. Brian Duffy
Kinston Neuse Corp.
424 West Monroe Street
New Bremen, OH 45869
Dear Mr. Duffy:
�_w VIC
E):EHNR
1"• SFf NGTONEOFFiCc
March 4,1994 MAR 10 1994
D. E 1%1.
Subject: General Permit No. NCG030000
Kinston Neuse Corporation
COC NCG030041
Lenior County
In accordance with your application for discharge permit received on Spetember 9, 1992, we are
forwarding herewith the subject certificate of coverage to discharge under the subject state - NPDES general
permit. This permit is issued pursuant to the requirements of North Carolina General Statute 143-215 .1 and the
Memorandum of Agreement between North Carolina and the US Environmental Protection agency dated
December 6, 1983.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to request an individual permit by submitting an individual permit
application. Unless such demand is made, this certificate of coverage shall be final and binding.
Please take notice that this certificate of coverage is not transferable except after notice to the Division
of Environmental Management. The Division of Environmental Management may require modification or
revocation and reissuance of the certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be required by the
Division of Environmental Management or permits required by the Division of Land Resources, Coastal Area
Management Act or any other Federal or Local governmental permit that may be required.
If you have any questions concerning this permit, please contact Mr. Bill Mills at telephone number 919/733-
5083.
Since
rely,tlared RY
4.(lrigil � i�5U11it1�
, oieei,
A. Preston Howard, Jr., P. E.
r—__W
cc: Washington Regional Office
P.O. Box 29535, Raleigh, forth Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL. RESOURCES
DIVISION OF ENVIRONMENTAL MANAGEMENT
STORMWATER DISCHARGES
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
Kinston Neuse Corporation - Crown Equipment Company
is hereby authorized to discharge stormwater from a facility located at
Kinston Neuse Corporation
2000 Dobbs Farm Road
Kinston
Lenoir County
to receiving waters designated as Briery Run in the Neuse River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, I11
and IV of General Permit No. NCG030000 as attached.
This certificate of coverage shall become effective March 4, 1994
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day March 4 , 1994
Original Signed By
Coleen H. Sullins
A. Preston Howard, Jr., P.E.
Division of Environmental Management
By Authority of the Environmental Management Commission

COUNTY
iqPDE'a
DSN-_-,--W
3 C4 05
Un -4- TV i U D E 35 0 1'6 1 40'k
DE.
MuU.;, STREAM:
T11 110 1A SS;
r L rnLCC{l
- -- - - - - - - - -