820445_CORRESPONDENCE_20171231

NUH I H UAHULINA
Department of Environmental Qual

A,
jr4VA
NCDENR
North Carolina Department of Environment and Natural Resources
Beverly Eaves Perdue
Governor
Norman Naylor
Norshan Farm (Sow)
3628 Bud Johnson Road
Clinton, NC 28328
Dear Norman Naylor:
Division of Water Quality
Charles Wakild, P. E.
Director
February 8, 2012
DENR-FRO
FEB 0 9 2012
DWO
Dee Freeman
. Secretary
Subject: Sludge Survey Testing Dates
Certificate of Coverage No. AWS820445
Norshan Farm (Sow)
Animal Waste Management System
Sampson County
The Division of Water Quality (Division) received your sludge survey information on January
31, 20I2. With the survey results, you requested an extension of the sludge survey requirement
for the lagoon at the Norshan Farm (Sow) facility. Due to the amount of treatment volume
available, and the rate of sludge accumulation for the lagoon, DWQ feels that an extension is not
appropriate at this time for the lagoon.
The next sludge survey for the lagoon at this facility should be performed before December 31,
2012. Thank you for your attention to this matter. Please call me at [phone] if you have
any questions.
Sincerely,
Al�d
Miressa D. Garoma
Animal Feeding Operations Unit
cc: Fayetteville Regional Office, Aquifer Protection Section
Permit File AWS820445
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604
Phone: [phone] FAX: 91U07-64921 Customer Service: 1-877-623.6748
Internet: www ngwaterguality.2M
An Equal Opper[Mly ! A�imative Action Employer
One
NorthCat-olina
Nahmallf

September 7, 2007
Norman Naylor
Norshan Farm
3628 Bud Johnson Road
Clinton, North Carolina, 28428
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
DENR-FAYETlb
Coleen H. Sullins, Director
Division of Water Quality
Subject, Certificate of Coverage No. AWS820445
Norshan Farm
Animal Waste Management System
Sampson County
Dear Mr. Naylor. -
In accordance with your application requesting a change in operation type from a 1200 farrow to feeder
farm to a 1446 Farrow to wean farm received on August 8, 2007, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Norman Naylor, authorizing the operation of the subject animal
waste collection, treatment, storage and land application system in accordance with General Permit
AWG100000. The issuance of this COC supercedes and terminates your previous COC Number
AWS820445 dated October 1, 2004, which expires September 30, 2009. This change of operation type
does not result in an increase in the steady state live weight.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Norshan farm, located in Sampson County, with an animal capacity of no
greater than an annual average of )446 Farrow to Wean swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP)_ ' If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows.
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Pursuant to this COC, you are authorized and required to operate the system in conformity with the
conditions and limitations as specified in the General Permit, the facility's CAWMP, and this COC. An
adequate system for collecting and maintaining the required monitoring data and operational information
must be established for this facility. Any increase in waste production greater than the certified design
capacity or increase in number of animals authorized by this COC (as provided above) will require a
modification to the CAWMP and this COC and must be completed prior to actual increase in either
wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Enclosed for your convenience is
a package containing the new and revised forms used for record keeping and reporting. Plea
careful attention to the record keeping and monitoring conditions in this permit.
No Carolina
,Xatura!!ry
Aquifer Protection section 1636 Mail Service Center
Internet: www.newatgrauaiity or_ Location: 2728 Capital Boulevard
An Equal OpportunitylAffirrnative Action Employer— 50% Reryded110% Post Consumer Paper
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh, NC 27604 Fax l: [phone]
Fax 2: [phone]
Customer Service: [phone]

If your Waste Utilization Plan has. been developed based on site -specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this.permit convey any property rights in either real or personal property.
;ter
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 02T .01 I I (c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Per 15A NCAC 02T .1306, any containment basin, such as a lagoon or waste storage structure, shall
continue to be subject to the conditions and requirements of the facility's permit until closed to NRCS
standards and the permit is rescinded by the Division.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at
[phone].
Sincerely,
for Coleen H. Sullins
Enclosures (General Permit AWG 100000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Sampson County Health Department
Sampson County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files
Permit File AWS820445

�3-z -,J)4 5-
Murphy-Brown, LLG
7/26/2007
NUTRIENT UTILIZATION PLAN
Grower(s): Norman Naylor
Farm Name: NorShan Sow Farm
Farm Capacity
Farrow to Wean
144i
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish
Storage Structure:
Anaerobic
Storage Period:
>180 days
Application Method:
Irrigation
2822 Hwy 24 West
P.O_ Box 856
Warsaw, NC 28398
RECEIVED
DENR - FAYETiEV€LLE REGIONAL DFRGE
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer valve of the waste and to ensure that it is applied In an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8 RECEIVED / Di~NR 1 DVJQ
AQUIP�7R PROT;C.rin^; SFCTION
HP 17 2000

This plan is based on the waste appiicat€ m method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same..
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flerdbla so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH In the optimum range for specific crop production.
This waste utilization plan, If carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Manageinent Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc):
Type Waste Produced per Animal Total
1446 Farrow to Wean
3212 gatlyr
4,64 .552 gal/yr
Famaw to Feeder
4015 gallyr
gavyr
Famm to Finish
10565 gallyr
gallyr
Wean to Feeder
223 WiNr
gatlyr
Feeder do Finish
986 gdy
gavyr
Total JI8M4,55
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Capacity Type Produced per Antmal Tend
1446
Farrow to Wean
5.4 Ibstyr
7,808 ibslyr
Farrow to Feeder
6.5 Ibslyr
lbstyr
Farrow to Finish
26 Ibslyr
Ibslyr
Weary to Feeder
0.48 lbstyr
Ibslyr
Feeder to Finish
2.3balyr
Total 7,808 IhWV
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste In a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 40.19
Total N Required 1st Year: 7938.885
Total N Required 2nd Year. 0
Average Annual Nitrogen Requirement of Crops: 7,938.89
Total Nitrogen Produced by Farm: 7,808.40
Nitrogen Balance for Crops: (130.48)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this fadiity. This chart describes the size.
W1 characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, Is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading mayYesult if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier_ You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to Interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two Inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized I unit yield
A
Barley
1.6 lbs N 1 bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N / ton
C
Hybrid Sermudagrass - Hay
50 lbs N 1 ton
D
Corn - Grain
1.25 lbs N 1 bushel
E
Com - Silage
12 lbs N / ton
F
Cotton
0.12 lbs N / lbs lint
G
Fescue - Grazed
50 lbs N 1 ton
H
Fescue - Hay
50 lbs N ! ton
I
Oats
1.3 lbs N / bushel
J
Rye
2.4 lbs; N / bushel
K
Small Grain - Grazed
50 lbs, N 1 acre
L
Small Grain - Hay
50 lbs N I acre
M
Grain Sorghum
2.6 lbs N / cwt
N
Wheat
2A Ibs_N I bushel
O
Soybean
4.0 lbs N / bushel
P
Pine Trees
40 ibs N I acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 8

�311110rl:1J:jRIM- f[it]U
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications P !animal Farm Totaltyr
1446 Farrow to Wean 0.84 1214.64
Farrow to Feeder 1
Farrow to Finish 4A
Wear! to Feeder 0.072
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 1214.64 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 6073.2 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 20 acreas of land. If you apply the sludge
to com at a rate of 125 pounds per acre, you will need 48.5856 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the Intake rate of the soil at the time of Irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and Irrigation designer to ensure that an Irrigation system Is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
"This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months_ In no Instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown In the tables may make this plan invalid.
Cali your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
_ Tract
Hydrant
Type
Crop
... Whir
` Inches
T10681 .
1
Rains
B
0A
1
T10681
2
Rains
B
0.4
1
Ti 0681
3
Rains
B
Q.4
1
T10681
4
Rains
G
0.4
1
T10681
5
Rains
G
0.4
1
T10681
6
Rains
G
0.4
1
T10681
7
Rains
G
0.4
1
T10681
8
Rains
T10681
9
Rams
T10661
10
Rains
T10681
11
Noodingtor
T10681
12
Rains
Q 0.4
Q 0.4
Q 0.4
Q 0.4
G 0.4
6 of 8

Additional Comments:
There have been no crop or acreage changes to this Oan. i did update the
crap rates according to the Nutrient Management for NC website. This plan
changes the type of facility from a farrow to feeder to farrow to wean.
MMI-I

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: NorShan Sow Farm
Owner: Norman Naylor
Manager:
Owner/Manager Agreement:
Ilwe understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal.waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
l/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature:
Norman Nor
6
Name of Manager (if different from owner):
Signature:
Date
Date
Name of Technical Specialist: Toni W. Kin
Affiliation: Murphy -Brown,' L.1.C.
Address: 284ttwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
Signature: �JLJ 1/1,rZ
Date
8of8

North Carolina Cooperative Extension Service
Facility No.: 82-445
Farm Name: Norshan Sow Farm
Subject: WUP Update
Tech. Spec.: Danny Bailey
The waste utilization plan is being updated based on effective wetted acres. The farm
owner installed underground irrigation pipe.
Owner Signature Tech. SfiL Slgnatur
Date Date
D/ �'Jq) C'f Y
North Carolina State University and North
race, color, creed, national origin, religion,
tion. North Carolina State University. North
gardless of
A orienta-
g.

�'
NI
�IJ
1
1
~
fL
1-
t;
_S cJ
.�
ul
r-i
-v �
'\ I : � �,\�
H
r

'1'i�LSLi� 1 : l�� ItL;`;
U4�I1L'U
L11' ]'1wDUCE'R
oQssi.�,v
sue
K
t- ; -,4 y
r
I"7LLli
;;01L TYPE 1. CLA"S--
lRUP
1:1L.LU
�.�UC;
All Id
COMM II
1'L1?
ACRE!,
UL'I•L1T13-14JAIG PHASE
.ODE
tic
Ac
j
1
�
l
1
1
l
I I I I I I I I

A. ,
Animal NVaste .-ppficarion X' indows
For Common Crops Which Receive A. nimal '-A'asi.e
Thest: apciiaarian windows in_iL6!; 30 d73'S prior tc• pianzin ' and ryr-- rnup
End.30 days be;on; harvAs:.
B�, udag:a;s Begin• hIlp—rch l nd Se al= nber 3G'�'
Small Grails Btair_+ GciobL I st End Miarc i j I s,
JsrPrswhd in Pt-rm- uda2m--s
Corr;
Cor on
Cucumbers — Direci zcrosumplicn
OT P-DCt�Ssarlg
�2 seasons)
Sm, all Gale
B-zgin Feb-umj; _5&' end .iunt 30r}t
Begin h4arci•: I "I End A zwk I
Begin hdarcl-, I"' (I Doi % a ;,laming)
Begin A p--n1 I " End May 3, i
•Be it my I' End Augur 3ist
Bazin Scpvzmber l't End March 3 151
Peanuts
Begin April IS'
End Sepifmbe; 30"
Soighummo
Begins March 1 So
Ind E zwo 37 s`
n_ Cram
Sudan via),
L
V
S�tcear�
Begin April IS`
End SWater Or l�'}`
TDba_cC — PlUt C U70
NO MwTh I S'h
end Junk 30'`'
_-Bu1-la:-
B�Zin May 15"'
End Augm I,ch
-tscue
End _f,_it` 3 1st
•rar-_ aw__ do was me Awr. +=a: i:= vat. r•._.::_i vatu-_ SL31
ile =aie ca!t ;Eiivas and i1 :u' _ a!iaw a pr:i--:i-)n nmrc :..::r.:ititc _,;. s : ria: !,} p?sa.[u_�ur a's:ir _ L3 :t::m ': a: irss.. 'sLn 30
T-_rrj , j- li,nd
N dL rin_, Jan: axle Jul ncr nh- .: ir. D_ c:ar zr.F ;an::an'
!�iL'r7i71L3E �: '_ pttYt:Si pow . III ;h N PAlC,i AI so, SI1 o M6 aI:; 1 IU' nll in a: i1S i19. still on: t; JST 4 www ma's^.=—

Farm Name: NORS) iAN Sow Farm
Facility No.: 82-445
Subject: Wildlife Buffer (wettable acreAVUP)
Tech. Spec. Danny Bailey
North Carolina Cooperative Extension Service
RECEIVED
APR 19 2005
©ENR-FAYUMMLLE REGIONALMCE
Facility No. 82-445 is participating in a wildlife buffer program. A thirty foot native
species buffer extends parallel with field codes P7 and P11. A thirty foot buffer also
extend across the irrigation start end of field codes P4, P5, P6 and P7. See the new
wettable acreage below_
Field Old Wettable New Wettable
Code Acres Acre__,,..
P4 3.815 3.655
P5 3.685 3.541
P6 4.046 3.902
P7 5.075 4.388
P 1 I 6.003 5.349
Total acreage reduction due to wildlife buffer is 1.789 acres. See revised WUP following
for nitrogen balance on the farm.
wner's Sibnatur Te pec. Signa
Wo, I.—
Los— ��;Ee'Z'0,7
date Date
North Carolina State University and North Carolina A&T State University commit themselves to positive action to secure equal opportunity regardless of
race, color, creed, national origin, religion, sex, age, or disability. In addition, the two Universities welcome all persons without regard to sexual orienta-
tion. North Carolina State University, North Carolina A&T State University, U.S. Department of Agricuiture. and local governments cooperating.

2—
fi
xn
ct Al
ni)
`'OlL TYPE 1,
E, Lit)
DETEM-111411W 1.11111SC
C:VDL
Im 11
u V. 1)
PEk Ac
Ac
AF7
io
794
to
lair
AIL.
FP
q .32-1
Fp
Fp
/ 68
3.t,sf PV
3.ry/ Sys
F P
L—
FR, P007Af4t4=-

�r
�=
a Lu
Q
J
i J
1 I i
1
f- * ,:1 K
ul
sm
%L I N�
1
s
s
V
�
a
0

Animal 'Waste .kpplication Windows
For Common Crops 'Which Receive Animal Waste
ThPs= aaplicarior, windows inclsstit 30 darts prior to planrinc- and ;rtenup of Bcrrrmudam s.
End 30 days before harvest.
Bermud3t°r ss B-z ri Iti�Ch 1st End September 30'h
Small Grain Begin Octobtr l s' End March a I S'
Overseeded in Bermudaarass
Corn
cation
CucurnbUrs — Direct consumption
— For Processirz
(2 seasons)
_ S m al l Grair,
P e.anuis
Begin February 15 End June 30'''
Begin March 15t' End August 15'
Begin March 151(1 DO /o at planting)
Bain April I" End May 315'
Begin July 1S' End August 315t
Begin September 15, End March 315`
Begin April 15L End September 30t'
Sarum/ Begin March 15'h End August 31 s'
Sudan Grass Kay,
Sovbeans Begin April I' End September L')
T©bacco — Flue Cured Begin March 15" End June 30'I'
—-Burleti Begin May 1 >'h End August.) >"
Fescue- 'De, -in A Remus: l51 End July 315'-
s ra>` snrnom rtpr=s ;ZS s :t.eAiric htniLsc. Pias)Lin * at)e Jt u� cstin t nt.E ti:uv gross rite sraer: and !tort vcar t0 ,.dual t'alLa>a sitnli refit cL
SiEc ip:'=ific' C(r)ir�itiUnS arc i77 nU t:.s_ 311ow nnpli•:.:1ia.^. more Phan eidlrr a l juvr prit)r L1 �I�telin�_+inr:;a::iri_ Hu ran:_: or ICSS litUn Sri ciM'S_
b:fnr ltai: cSL Sc. Gka_rai P^remit for tirn(1 C MPS
I.InLtLITalnS ^ Jiniii Ir aPpii-=ion dLLrin•+ Jun. and Juh. i an nitrnLu: in 17=C-mnc-and january
PiCarton? C'aaslnl PJnin - limit h appli-nition during' Junc ane Juh': nr nilmnrn in ri_r and Jan durtiu-, s_•+crc u•intcra.

AffA.illi,
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor
Mr. Norman Naylor
Norshan Farm
3628 Bud Johnson Rd.
Clinton, NC 28328
Dear Mr. Naylor:
Director
May 5, 2009
Secretary
RECEIVED
W-Y87209
W-FAYEi'[E Uf RMONALOfHCF
Subject: Additional Information Request
Application No. AWS820445
Norshan Farm
Sampson _County
The Animal Feeding Operation Unit of Division of Water Quality's Aquifer Protection Section has
completed a preliminary review of your renewal permit application package. Additional information is
required before we may continue our review. Please address the following items within 30 (thirty) days
of receipt of this letter:
Missing Waste Utilization Plan:
You were requested to submit two copies of your facility's Waste Utilization Plan (WUP) or,
Nutrient Management Plan (NMP). Our records shows copies of the waste plan are incomplete in
your permit application we received. Please submit missing copies of your current WUP or NNW to
my attention at the Mail Service Center address given on at the bottom of the first page of this
letter.
A blank copy of the Animal Waste Management Plan Certification can be downloaded from the following
web link:
h ://h2.o.enr.state.nc.us/a s/afouldocuments/Anima[WasteMana2ementSvstemCenificationForm09l8O6.doc
Please be aware that you are responsible for meeting all requirements set forth in North Carolina rules and
regulations. Any oversights that occurred in the review of the subject application package are still the
responsibility of the applicant. In addition, any omissions made in responding to the above items shall
result in future requests for additional information.
Please reference the subject application number when providing the requested information. All revised
and/or additional documentation shall be signed, sealed and dated, with two (2)copies submitted to my
attention at the address below. Please note that failure to provide this additional information on or before
the above requested date may result in your application being returned as incomplete.
Aquifer Protection Section 1636 Mail Service Center
Internet: rev .ncwaterqu i .org Location: 2728 Capital Boulevard
An Equal Opportunity/Affirmative Action Employer- 50°/6 Recyded110% Posl Consumer Paper
1+10a Carolina
Adw-a(ly
Raleigh, NC 27699-1636 "T'clephone: [phone]
Raleigh, TIC 27604 Fax 1: [phone]
Fax 2: [phone]
Customer Service. [phone]

Failure to request renewal of your coverage under a general permit within the time period specified may
result in a civil penalty. Operation of your facility without coverage under a valid general permit would
constitute a violation of NCGS 143-215.1 and could result in assessments of civil penalties of up to
$25,000 per day.
If you have any questions regarding this letter, please feel free to contact me at [phone].
Sincerely,
J
Larry W. Wade PE
Environmental Engineer I
Animal Feeding Operations Unit
cc: Fayetteville Regional Office, Aquifer Protection Section
Sampson County Soil and Water Conservation District
Murphy Brown, LLC (P O Box 856, Warsaw NC 28398)
APS Files- AWS820445

. 4 /
4L 41 j'-
TYPE
L
Ul~.l U)?j J. 111 jhL; ki N, ILIL)
C i%c
TI HE-
kJA i ova
?4111. 51
Aga, IJ
7- J 70
'70 Z Z
7
OV
FO
:j— -
�O�h der d6 P,4.,r
IPJA
/
L�l
10 1 1 1
—.—AL
TUTAU)
RECEIVED
UAR 25 2M9
ON-FAYEMaf RRMI fRrF
REGENED I DENR I DWQ
Aquifer
protection Section
MAR 10 2009

i-
4
I
w
3
Q

oFWAr�� � Co��
Q Michael F. Easley, Governor
y William G. Ross Jr„ Secretary
co
r North Carolina Department of Environment and Natural Resources
p Y Coleen Sullins, Director
Division of Water Quality
December 17, 2008
Norman Naylor
Naylor Swine 1 & 2 & Norshan Farm
3628 Bud Johnson Rd
Clinton NC 28428
82-0316 & 82-0445
Dear Mr. Naylor,
Enclosed are copies of the specific Certificate of Coverages for your farms. This is
nothing new but we could not find the copy for one farm when I inspected on December 10.
Since I'm a bit confused as to which farm COC was missing, I am sending you both.
Please place the missing one in the notebook with the other farm information and the permit,
and you can throw out the duplicate. If you need a copy of the current state swine permit, it can
be downloaded from our website at.hftp://h2o.enr.state.nc.us/aps/afou/afou home.htm or I can
mail you a copy. Renewal information for the new 2009 permit should be in the mail by February
and the application will be due back in Raleigh in April 2009. However, the current permit is in
effect through September 30, 2009.
3333.
Please let me know if you need anything else. My phone and voice mail are at (910) 433-
Sincerely,
Joan Schneier
Environmental Specialist
Division of Water Quality
Fayetteville Regional Office
NorthCarolina
A74(ra!!y
North Carolina DWQlAquifer Prutection Section 225 Green St,/ Suite 714 Fayetteville, NC 28301 Phone [phone]
FAX [phone] Internet: h2o.enr.state.nc.us Customer Service 1-877-621-0-18
An Equal Opportunity/Affirmative Action Employer - 50% Recycled110% Post Consumer Paper

t- Nk
0� waLLXLUT�
r�Rp�
? 4
Michael F. Easley
Governor
Wrdliam G. Ross Jr.. Secretary
Department of Environment and Natural Resources
O 'C Wan W. Kfmsk. P.E. Director
Division of Water Quafity
April 28, 2003
Mr. Norman Naylor
3628 Bud Johnson Road
Clinton, NC 28328
MAY — 5 2003
SUBJECT: Retraction of Notice of Violation
Naylor Swine Farm
Farm # 82- 45
Sampson County
Dear Mr. Naylor:
On April 17, 2003, you were sent a Notice of Violation for having high freeboard in your
lagoon. Because there was a misunderstanding as to reading the freeboard marker and you
actually had more than nineteen inches, this Notice of Violation is hereby retracted and has been
removed from your file.
We apologize for any inconvenience this has caused you. If you have any questions, please
call Steve Lewis at 733-5083, ext. 539.
Sincerely,
Zan W. Klimek, P.E.
or
cc: Facility File — Non -Discharge Compliance/Enforcement Unit
ffifa
yetteville-Regional_Office
V*A
NCDENR
Customer Ssrylce: Mailing Address: Telephone [phone] Location:
1.877-623-6748 1617 Mail Service Center Fax [phone] N. Salisbury St.
Raleigh, North Carolina 27699.1617 State Courier k52-01-01 Raleigh, NC 27699-1617
An Equal Opportunity/Affirmative Action Employer
50% recycled / 10°/, post -consumer paper
httpJ/h2o. enr.state. nc. us

O�0F W A r4s;,
Y
r
Michael F. Easley
Governor
William G. Ross Jr., Secretary
Department of Environment and Natural Resources
p Alan W. Klimek, P.E. Director
Division of Water Quality
April 16, 2003
CERTIFIED MAIL
RETURN. RECEIPT REQUESTED
Norman Naylor
3628 Bud Johnson Road
Clinton NC 28328
SUBJECT: Notice of Violation
Request for Information
Inadequate Freeboard
Naylor Swine
#82-445
Sampson County
Dear Sir or Madam:
,t: s
rPR 2 3 2003
a
On March 6, 2003, a representative of your animal operation informed the Division of
Water Quality (DWQ) that there was inadequate freeboard in the lagoon(s) serving this facility.
This lack of adequate freeboard is in non-compliance with the Certificate of Coverage
issued to this facility on June 11, 1999. In addition to this Notice of Violation (NOV), this non-
compliance is subject to an appropriate enforcement action by DWQ. This action can consist of
one or more of the following: a civil or criminal enforcement action; an injunction; and/or a
requirement to apply for coverage under an individual permit. The action chosen will be based
on complete evaluation of all factors that resulted in the inadequate freeboard; the actions taken
to restore the needed freeboard; and the actions being proposed to prevent the problem from
reoccurring.
To assist us in our review, please provide the Fayetteville Regional Office with an
evaluation of the reasons for the freeboard violation(s) and a strategy to prevent future freeboard
violation(s). This evaluation and strategy must include but is not limited to the following:
Current Freeboard level(s)
Freeboard level records in the lagoon(s) for the past 12 months up to the date of submittal
Spraying records for the past 12 months up to the date of submittal
aNR
Customer Service. Mailing Address: Telephone (919) 733-SD83 Location:
1-877-623-6748 1617 Mail Service Center Fax [phone] N. Salisbury St.
Raleigh, North Carolina 27699-1617 State Courier #52-01-01 Raleigh, NC 27699-1617
An Equal Opportunity/Affirmative Action Employer
50% recycled 110% post -consumer paper
h t tpJlh2o. enr. sta te. nc. us

.0 1
Inadequate Freeboard
Page 2
Rainfall records for the past 12 months for this site up to the date of submittal (if
available)
Cropping system and PAN specified in the CAWMP. If the cropping system was not in
compliance with the facility's CAWMP, provide details of the cropping system in place
for the past 12 months.
A summary of actions taken to restore the needed freeboard in the lagoon(s) including but
not limited to removal of animals from the site, delay of restocking of animals, pumping
and hauling waste to another site (specify site), securing additional irrigation equipment,
and securing additional spray sites.
A description of water conservation measures in use at the facility and the date(s)
installed.
If the lagoon level(s) are still in violation of the facility's CAWMP and Permit, provide
an updated Plan of Action as to how the facility will return to compliance_
Provide a detailed description of the actions taken or proposed to be taken to insure that
there are no further freeboard violations at this facility.
This information must be received by the Fayetteville Regional Office at the following
address no later than 10 days following receipt of this letter.
Division of Water Quality
225 Green Street, Suite 714
Fayetteville, NC 28301-5043
Once this information is received and evaluated by the DWQ staff, a determination will
be made as to the appropriate compliance/enforcement actions to be taken. Each case will be
evaluated on its own merit. The efforts by the owner/producer to notify DWQ of the problem,
efforts made to resolve the problem once identified, and efforts proposed to prevent future
problems will be positive factors in this determination.
Nothing in this letter should be taken as removing from you either the responsibility or
liability for this non-compliance or future cases of non-compliance. If you have any questions
regarding this letter, please do not hesitate to contact our Fayetteville Regional Office Staff at
[phone].
Sincerely,
Alan W. Klimek, P.E.
Director
cc: Fayetteville Regional Office
Non -Discharge Compliance/Enforcement Unit
Central Files

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Norman Naylor
Naylor Swine
3628 Bud Johnson Road
Clinton NC 28328
Dear Norman Naylor:
NCDENR
ENVIRONMENT AND NATURAL Rr-SQUFRCES
December 30, 1999
RECE�
, _ A. `i 5 2000
FAY` i t'EViLLE
REG. OFFICE
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 82-445
Sampson County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites_ This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRR1, IRR2, DRY1, DRY2, DRY3, SLUR1, SLUR',
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerel
1
Kerr T_ Stevens, Director
Division of Water Quality
cc: Fayetteville Regional Office
Sampson County Soil and Water Conservation District
Facility File
16I7 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

1.
State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Govemor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
Norman Naylor
Naylor Swine
3628 Bud Johnson Rd
Clinton NC 28328
Dear Norman Wayne Naylor:
A74
f
NCDENR
NORTH CAROUNA DEPARTMENT OF
ENVIRONMENT ATlD NATURAL RESOURCES
June 11, 1999 RECEIVED
JUN 1 6 1999
FAYETTEVILLE
AEG. OFFICE
Subject: Certificate of Coverage No. AWS820445
Naylor Swine
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your application received on June 5, 1998, we are forwarding this Certificate
of Coverage (COC) issued to Norman Naylor, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG 100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the Naylor Swine, located in Sampson County, with an animal
capacity of no greater than 1200 Farrow to Feeder and the application to land as specified in the
Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS
143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] . FAX [phone]
An Equal Opportunity Affirmative Action Employer 5D% recycled/ i o% post -consumer paper

Certificate of Coverage AWS820445
Naylor Swine
Page 2
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact Sonya Avant at [phone] ext. 571.
cc: (Certificate of Coverage only for all cc's)
Sampson County Health Department
Fayetteville Regional Office, Water Quality Section
Sampson County Soil and Water Conservation District
Permit File
NDPU Files

State of North Carolina
Department of Environment and Natural Resources
Division of Water Quality
Non -Discharge Permit .Application Form
(THIS FORM M,4 Y BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Existing Liquid Animal Waste Operations
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections which are appropriate. if a
Question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
t. GENERAL., INFORMATION:
1.1 Facility Name: Naylor Swine
1.2 Print Land Owner's name: Norman N for R E D E i V E D
1.3 Mailing address: 3628 Bud Johnson Rd 1tifH i E� =" r
City, State: Clinton NC = - - zip: 29328 JUN 5 1998
Tekphone Number (include area code): 910-564-6551
raI Lc:«+J ia
1.4 Cnts' wbere facility is located: Sampson
ou
1.5 Facility L acation (Directions from nearest major highway. Please include SR numbers for state roads. Plus include a
copy of a county road map with the location of the farm identified): Sow farm .3 mile E. of intersection of 1006 and 242
Piney Green Church on SR 1332 Parker Metnorial Rd. intersection is 5 miles N_ of Salemburg- Topping houses an SR
1338 Rabbit SL -2 mile W. of SR 13251SR 1337 ()ocation of Nemng Vol- Fire Dept. l3oildin S. an faun
L6 print Farm Manager's mine (if diflereat fiom Land Owner): Shannon Naylor
1.7 Lessee's / Integrator`s dame (if applicable,- please circle which type is listed):
1.9 Date Facility Originally Began Operation: 01/01/82
1.9 Date(s) of Facility Expansions) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: 82 (county number)- 445 (facility number)-
22 Cpemon Descrcpt o Swine operation
Farrow to Fender
12W Cerfified Design Capacity
Is the above information correct"? yes; F_7 no. If no, correct below using the design capacity of tlae-fiwility '
The "No. of Animals" should be Lhe maximum numT�Fr_fnr which the wake management structures were designed -
Type of Swine
Wean io Feeder
Feeder to Finish
Farrow to Wears (# sow)
Farrow to Feeder (# sow)
Farrow to Finish (fi sow)
No. of Aaunals Type of Poultry No. of Animals Type of Cattle No, of Animals
Other Type of Livestock on the farm:
Layer
Non -Layer
Turkey
FORM: AWO-G-E It28/98 Page 1 of 4 82 - 445
Dairy
Beef
No. of Animals:

13 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
systom): 59 Required Acreage (as listed in the AWMP): 49
2.4 Are subsurface drains preset within 1 W of any of the application fields? or NO (please circle one)
2.5 Are subsurface drains present in the vicWV or under the lagoon(s)? S or � (please circle one)
2.6 Does this facility meet all applicable siting requirements? (Swine Farm Siting Ad, NRCS Standard, etc.) (Swine Only)
or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited?
What was the date that this faciWs land application areas were sited? 3 %lf •S '��
3: REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by suing your initials in the spare provided next to each
item _
--Y . _ - -
AARlicants Initials
3.f O�ie con> feted ands' on
p cgned giant and one copy of the application for General Permit - Animal
Waste Operations;
}
/
-
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;tj
33 Two copies of the entire Certified Animal Waste Managernent Plan (CAWMP). If the facility
does not have a CAWMP, it crust be compkied prior to submittal of a general pemit
application for animal waste operas" ms.
(,.1
The CAWMP must include the following cotuponents-
3.3. l Tie Waste Utilization flan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced aW utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e-g. irrigation,
injection, etc.)
3.33 A map of every field used for land application_
3.3.4 The soil series present on every land application field.
3.3,5 The crops grown on every land lication field.
3-3.6 The Realistic Yield Expectation RYF-) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.39 The required MRCS Standard specifications.
3.3.1 a A site schematic. .
3.3.11 Emergency Action Plan.
3.3.12 insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3-3.14 Mortality Control Checklist with the selected method rioted. .
3.115 Lagoon/storage pond opacity documentation (design, calculatims, etc.)
If your C.AWMP includes components not shown on this list, such as an irrigation design,
or site evaluation, please include the additional components with your submittal.
FORM-. AWO-G-E JaW98 Page 2 of 4 82 - 445

Facility Number: 92 - 445
Facility Name: Naylor Swine
4. . APPLIC S CERTIFICATION:
I, " -r A+ !+v e (Land Owner's name listed in question l .2), attest that
this application for GC y 1.,t/1 Sc.. ;i,— _ _ (Facility name listed in question 1.1)
has been reviewed by me and is dc6tirate and complete W the best o my knowledge. 1 undamand that if all required }ants of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will re5 mett to me as Wcomplete
SigUtdrrre Date r -
5. ; A+IANAGER'S CERTIFICATION: (complete only if different frmn the Land Owner)
(Manager's name listed in question 1.6), attest that this
application for � (Facility name listed.ia 4ues#ion l:l;
. has fneen revievwed � rrraaard-Es acctrraoe ae[d comp to o my ow ge. I tlncb:rct�rur that if al! required � ofthis
agpfiratian are nvt cvnipleted anti tliat if all required supporting informahan and atia.chments are oat included, #Iris application
parlcagc wilt be returned as in�camptete.
Sigma Date
THE COMPLETT:D APPLJCA�10N PACKAGE, INCLUDING ALL SUPPORTING lNMRMATIDN AND MATERIALS,
SHOULD RE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGM NORTH CAROLINA 2762"535
TELEPHONE NUMBER: (919) 733-SM
FAX NUMBER: [phone]
FORM: AWO-G-E 1I2 M : Page 3 of 4 82 - 445

State of North Carolina
Department of Environment and Natural Resources
Division of Water Quality
Non -Discharge Permit Application Form
MHIS FORM MAY BE PHO719COPIED FOR USE AS AN ORIGINAL) -
General Permit - Existing Liquid Animal Waste Operations
The following guesdons have been completed utilizing information on file with the Division. Please
mizw the information for eompletene_4s and make any corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not have
any question unanswered.
1. GENERAL INFORMATION:
I Facility Name: Naylorirne—
S ;
12 Print Land Owner's name: Norman Naylor-
13 Mailing address: 3628 Bud ,lohwon Rd
City, state: Clinton NC _ _ - _ - Zip: 29323
Telephone Number (include area code): 910-564-6551
1.4 County where facility is located: Sampson
1.5 Facility Location (Directions frorn nearest major highway. Please include SR numbers for state roads. Pkase include a
copy of a county road map with the loom of the farm identified): Saw farm 3 mile F. of intemcctkm of 1006 and 242
Piney Green Churcb on SR 1332 Perksr Memorial Rd. intersection is S miles N. of Salem j9pEjM lrrrtises on SR
1339 Rabbit St..2 mile W. of SR 1325/SR 1337 (location of'1-3errm�r, Vol. Fire Dept. Building) S. on farce
1-6 Print: Farm Managers name (if different From Land Owner): Shannon Naylor
1.7 Lessee's / integrator's name (if applicable; please circle which type is list.
1-8 Date Facility Origisially Began Operation: 01/01/12
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: _ 82 (cwmty number); 445 (facility number).
2-2 Operatiorn Descrtpttou: Swint opnmdon
4l• row to Feeder
1200-- Certified Design Capacity
Is the above information correct? yes; no. If no, correct below using the design capacity of rite facility
The ''No- of Animals" should be the maxunum num i ot which the wrier management structures wert designed.
1y2t of Swine No. of Animals 1)?e of Poultry No. of Animals Terre of -Cattle No. of Animals
Wean to Feeder Layer Dairy
Feeder to Finish Non -Layer Beef
Farrow to Wean (# saw) Turkey
Farrow to Feeder (# saw)
Farrow to Finish (# sow)
Other Type of Livestock on the farm:
AUG 10 1998
FORM. AWO-G-E 1PZ M Page i of 4 82 - �gnkER QUALITY SECTION
1ischarcge Compliance En#.

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): _ 59 Required Acreage (as listed in the A WMP): 49
2.4 Are subsurface drains present within 100' of any of the application fields? or NO (please circle one)
2.5 Are subsurface drains present in the vicinity or under the lagoon(s)? S or V (please circle one)
2.6 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
\S or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? IF CP,
What was the date that this facility's land application areas were sited? 3' 7..-
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
Applicants Initials
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied; A, L � 4)
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). -If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications_
3.3.10 A site schematic.
3.3.1 1 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
33.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.)
If your CAWMP includes components not shown on this list, such as an irrigation design,
or site evaluation, please include the additional components with your submittal.
FORM: AWO-G-E 1/28/98 Page 2 of 4 92 - 445

Facility Number. 82 - 445
Facility Name.- Naylor Swine
4. APPLICANT'S CERTIFICATION:
I,
c
(Land Owner's name listed in question 1.2), attest that
this application for A )C Uf a,, „,cJ t ` rr.! + (Facility name listed in question L I )
has been reviewed by me and is urate and complete to the best of my owledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will bglreturned to me as incomplete. _ / l
5. MANAGER'S CER
application for
has been reviewed
application are not
package will bc-Fp
Signature
only if different from the Land Owner)
A,& , Ala Vi/0-V (Manager's name listed in question 1.6), attest that this
JQ/Q,//ey yam, (Facility name listed in question 1.1)
me and is accuffla and complete to the best of my knowledge. I understand that if all required parts of this
npleted and that if all Auired supporting information and attachments are not included, this application
ed as incomplete. // A
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS -
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 1/28/98 Page 3 of 4 82 - 445

� -i-_ IB• tY u B � "` ri � 't • _ u" 1 ,� nn.. .c- ::� w • '
1-- `, • r 1 y, � ;' ... w ,. r .
m T� 1•r B IIr•J Irr 'r M 'y' Y'Yw , •Ir• �`
rn' 1 � \ L •rP
I,Ywt` ` •' 1•I't0/ p Ilr, ,� � Iwr •Irr•
Y �pn•wlt•f {• `
r[ U[ `iy �!� Fn IVY � , ♦JP p®� 1
1 � 1.1. i � wr• 111, • \ y ur• emu" YP r`tn rm
Yir w44 • r t0 -
1 � 1 ' �, ,� tl ♦ . F� l o lgll, 1 • are `'� t •� rm
_ �ul� pptu,.m \ tq ♦ . r •f tyy9 . G y � • na un ° q" Iw.
.w. Y' B .�♦ 1 r M' � rw,, � , are n., 11+. � .. r 'I^+'w I
rw ! � y • eu� . nn r r .I na � ` �i Iy .
`rh ` ` Imp • n ntt 9 1(•� 1..�' .�.w Y ; ••� �_
�I. nr,a o, .YI ,[ -' wK yxx• ..Imp l 'rx B
i reu p m^` [ _ r r'^I .jy rw. 9 41 ♦ � I • �- LL'n•rr ♦' a �w� c rp� L•, � Ir
pYj1 :- �{ !' nllb t1t• Y nr / p•iN® :.• i�py I jay B ,� - � �. r+r S•'w 3
Iwr P �L 111� ° 1 Y rtr, (-Y.-._fll I11•. • r._Q. �Jm�r '.• .r a•p
4
n •T 40F , uu °•� ut' wu • yo a .n, $ r ��1�•t•� d m tum k I ...{wt - r� pl���..
° � . r •(r Irr ,.
S�.d � (wr •'Wn 4
9 a 6 r1� 1.. rrlr .. a4 �Ii� ` r�•�^' '�j° r `44ir• �...] `0♦ 4y+ u.r •�'j u �f .
•e {w� •w � I .rll •1 � .��• y ^ yw4 va. ♦ a n 1 a Y w ., r 1
up Y Iw �� ml' vn•.nYI rrl m• �l.0 .r.v{ r To�10j • p`,r, w0µ ♦ r `ua �A IF
Y C y ..r•y . atp, ' { ♦ r' i •nu C I 'w ,.r rn. Y y rf� • , (
1• ♦w. ar ♦� p • atwl � Iwr
m � ray � '♦ ° Ili 4'bY„al r f�aA �/ � ' •ICm •'. � �S a ,• va
4 [ Irl l
wl�. F(•oi •Yu quo®, uar"•� 1 '•w � �`��...I x1 �w •.. a � .up' • / rm •4i
la, ai �r' � i y�J uu P ''-�{tu crls B n•ae •.. l.r 1.., a �.
r h{Z. � p{� �. w r,[r �� u1q' ` Yu p. « � �19� uO� � • �'L/ a��`� tug ray � q 111 r � - I'., r �^n° rw. •I wi
°" ' mw - { lot® Pp `• .rm I 4' nl \ w•, y.p.r• :.
m�rti—a•- ��e� Y�''�i � i wr••rY. ,�u1♦ t•a C,` i f`♦r p t. �� •� m'•
a
txv+] - ' wu C o �¢ . nli C t" � r wr.,• ra `�i •u
;i •% ,fll rya � ( Wpt� t11� 'i tr O r �la `/(II.. { Iin
I .i W wp Yt
0 l \ l
1 - �.• i ... f { ♦ r•pr��.,xwq wry F • lug
1NI13 ♦/wn , n pRY u�' " ` m. vO�/' J 111 .C� '>� � °I w " !� / o
. ♦ ♦ •.r tut :•m.r `_w•�
(� p • O� I•r �,� .I�.r•w �♦ rl oylR !' • ` �yj.,� ; w
A .w� F,� ao./Y�.. •Pov..o.]1 J I •.�1� I �Pr�
`� {M t` Flrr• �� mlllw0 � i iiii° • O I♦ iq e w /f r ,e O r �• I r'°, , r ' I rF
°0 �' a 1 dt owFq ro. wnxo• 1'1, [
t , ( u _ •4 ,1 o d,� . ' a0 r ..1 r.r ! Q � . '•��p.ry.^ [ • 'rn.-
kk
�/ ' •{� n„ r r riy9J " 5 em a 6ry .v, ��m q � � ... 1 r \
a •vat w'°r••'quwt'• �, � . (r`�.\
�. fw -� � .� 4 eu� I•n rt��� 1i 1 .w•tr� :.I�n �• nY r. {� r 4 + «� � �i, �• y�m� aura of °
� ✓1�, Inn _.-, `Ln P ,.u.o6 .� nF ..I LF � ,.a i
-e
.... 1• ,ds 9,,�. ..••! n P °r [ •w\At{ r w� \ II rw 1 �' (a'll,

1
00G%C), 4
a■ v� : all
C a a a 0 C> C� 0 C
C)■ C_: C G0a a01
GSGC-O'00G� vV,
s00a0C:C CC.— 0
COGGC S•G Gi
C ©[-C'- C. C: a t
C O rG C 0 0 C
C ®[`C C C•a
C0CC � a0C.0`.�4
C ®0 ;� C'
(Division of Water Quality
MEMO From:... eta Date: .7)aKI 99
To: E L2 Subject:
spoy.a L'0t4-k
J\.bvr'� A"kcf , Bnk�n mat 4"t vowu
,&"r, 'V. a"V�
NCDENR
North Carolina Department of Environment and Natural Resources
PO Box 29535, Raleigh, North Carolina 27626-05351 Phone: [phone]

KLUEIVED
Animal Waste Management Plan Certification
(Please type or print all information that does not require a signature) LJC 124 1997
Name of Farm: X>ft -f IV o �Facility No: YX -4J
Owner(s) Name: 66 - /r%v /o Phone No:
Mailing Address: ��_� �l d •l'.�.s •.� '4o .q c, C l:.v �o.� _ �/ C' . .�t fr 3 1 _
Farm Location: Fourteen Digit Hydrologic Unit:_ O 3 03yo e G o j"o c) sF d
Latitude and Longitude/U SOS %,� 1lJ�g 27 ��' County: SAS4so.-, _
Please attach a copy of a county road map with location identified and describe below (Be specific: road
names, directions, milepost, etc.): jjxr — . li t I
TP le-V" /cf Aw.00' 7..C.✓ /a let/sFt a'5koMa"ae- /fV.
IVAel A� A�Vdw- c i-A..sI-1% :Af i* A.7 e .J i,/er�..� 7I '�e�_ Ta..e.. 1 �•�t J Pa— &rL
Type of Swine
• Wean to Feeder
• Feeder to Finish
❑ Farrow to Wean
7 Farrow to Feeder
• Farrow to Finish
No. of Animals Type of Poultry
D Uyer
❑ Pullets
/Z?04
No. of Animals
Type of Cattle
❑ Dairy
❑ Beef
No. of Animals
Other Type of livestock: Number of Animals:
Acreage Available for Application: Required Acreage: Z7� _
Number o agoons Storage Ponds: Total Capacity,: �9.T 5 633 [ er—Ee Vubic Feet (fi3)
Are subsurface drains present on the farm: YES or IQ?) (please circle one)
Owner / Manager Agreement
i (we) verify that all the above information is Correct and will be updated upon changing. I (we) understand the operation and
maintenance procedures established in the approved animal waste management plan for the farm named above and win
implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and
storage system or construction of new facilities will require a new certification to be submitted to the Division of
Environmental Management before the new animals are stocked I (we) understand that there must be no discharge of animal
waste from the storage or application system to surface waters of the state either directly through a man-made conveyance or
from a storm event less severe than the 25-year, 24-hour storm and there must not be run-off from the application of animal
waste. I (we) understand that run-off of pollutants from lounging and heavy use arras must be minimized using technical
standards developed by the Natural Resources Conservation Service. The approved plan will be filed at the farm and at the
office of the local Soil and Water Conservation District. I (we) know that any modification must be approved by a technical
specialist and submitted to the Soil and Water Conservation District prior to implementation. A change in land ownership
requires written notification to DEM or a new certification (if the approved plan is changed) within 60 days of a title transfer.
Name of Land Owner: OV6 RA -AN W -,• ,rE ykr�
Signature: f ,,� 4wI/ f L_!_ Date:_
Name of Manager(if different from owner):
Signature: Date:
AWC -- April 24, 1996 1

Technical Specialist Certification
I. As a technical specialist designated by the North Carolina Soil and Water Conservation Commission
pursuant to 15A NCAC 6F .0005, I certify that the animal waste management system for the farm
named above has an animal waste management plan that meets or exceeds standards and specifications
of the Division of Environmental Management (DEM) as specified in 15A NCAC 2H.0217 and the
USDA -Natural Resources Conservation Service (NRCS) and/or the North Carolina Soil and Water
Conservation Commission pursuant to 15A NCAC 2H.0217 and 15A NCAC 6F .0001,0005. The
following elements are included in the plan as applicable. While each category designates a technical
specialist who may sign each certification (SD, SI, WUP, RC, 1), the technical specialist should only
certify parts for which they are technically competent.
IL Certification of Design
A) Collection_ Serge. Treatment Svstem
Check tg appropriate box
R— Existing _facili , without retrofit (SD or WUP)
Storage volume is adequate for operation capacity; storage capability consistent with
waste utilization requirements.
ZI Ng_w. expanded or retrofitted facility. (SD)
Animal waste storage and treatment structures, such as but not limited to collection systems,
lagoons and ponds, have been designed to meet or exceed the minimum standards and
specifications.
Name of Technical Specialist (Please Print):,
Affiliation:
Address(A
Lncy): 3 6 5 �Peez.- . A .Al, C ..2,tix Phone No.: Sie - S92. - 71
B) Land Al2plication Site (WUP)
The plan provides for minimum separations (buffers); adequate amount of land for waste
utilization; chosen crop is suitable for waste management; hydraulic and nutrient loading rates.
Name of Technical Specialist (Please Print): tz
Affiliation: C!EQ eE, 'c 0'
Address
C) Runoff QQntrols from Exterior Lpts.
Check the appropriate box
Mr ac'li without exte '0 1 (SD or WUP or RC)
This facility does not contain any exterior lots.
No. o �b
U Facility with exterior lots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas have been
designed in accordance with technical standards developed by NRCS.
Name of Technical Specialist (Please Print): •/*ggEZ
Affiliation: C`a� ,¢ :,J
Address �� 5 �.�,�� �P�✓ �1:�� _ .t/.c. ems- �z,�Phone No. 9� -:Sys - Z../
Signs Date:
AWC -- April 24,1996 2

D) Application and Handling Eguinment
Check thhe appropriate box
Mr 1'rxistine facility with existing waste a pication equipment (WUP or I)
Animal waste application equipment specified in the plan has been either field calibrated or
evaluated in accordance with existing design charts and tables and is able to apply waste as
necessary to accommodate the waste management plan: (existing application equipment can
cover the area required by the plan at rates not to exceed either the specified hydraulic or
nutrient loading rates, a schedule for tithing of applications has been established; required
buffers can be maintained and calibration and adjustment guidance are contained as part of the
plan).
U New or expanded facility; or existing facility without existing waste appication egviiment (I)
Animal waste application equipment specified in the plan has been designed to apply waste as
necessary to accommodate the waste management plan; (proposed application equipment can
cover the area required by the plan at rates not to exceed either the specified hydraulic or
nutrient loading rates; a schedule for timing of applications has been established; required
buffers can be maintained; calibration and adjustment guidance are contained as part of the
plan).
Name of Technical Specialist (Please Print):_ '/•�y
Affiliation: ad .Q4 c= c T.s�S; �J S�`�i•'e t
Address(A Phone No.: 9io - $ 9.2 - 7/ G /
Siettature: Date -
III. Certification of Installation
A) Collection. StgEage. Treatment Tnstallaton
New. exp n ed or retrofitted facility (SI)
Animal waste storage and treatment structures, such as but not lirrrited to lagoons and ponds,
have been installed in accordance with the approved plan to meet or exceed the minimum
standards and specifications.
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation:
Address(Agency): Phone No.:
Signature: Date:
AWC -- April 24, 1996 3

B} Land Applicalign Sile (WUP)
Check the appropriate box
Mr The cropping system is in place on all land as specified in the animal waste management plan.
❑ Conditional Approval: all required land as specified in the plan is cleared for planting; the
cropping system as speed in the waste utilization plan has not been established and the
owner has committed to establish the vegetation as specified in the plan by
(month/day/year); the proposed cover crop is appropriate for compliance with the waste
utilization plan.
❑ Also check this box if appropriate
if the cropping system as specified in the plan can not be established on newly cleared
land within 30 days of this certification, the owner has committed to establish an interim
crop.for erosion control;
Name of Technical Specialist (Please Print):__
Affiliation: C'ao4Eieori,, t✓ �arT�.�.s%�.-� s��t✓: cE�
Address(A .3 � ! el _ C/, f,-- tl r. Phone No.:
Signatur Date:
This following signature block is only to be used when the box for conditional approval in M. B
above has been checked. -
I (we) certify that I (we) have committed to establish the cropping system as specified in my (our) waste
utilization plan, and if appropriate to establish the interim crop for erosion control,. and will submit to
DEM a verification of completion from a Technical Specialist within 15 calendar days following the date
specified in the conditional certification.- I (we) realize that failure to submit this verification is a
violation of the waste management plan and will subject me (us) to an enforcement action from DEM.
Name of Land Owner:
Signature: Date:
Name of Manager(if different from owner):
Signature: Date:
C) Runoff Controls from Exterior Lots (RC)
Facility with exterior lots
Methods to minimize the run off of pollutants from lounging and heavy use areas have been
installed as specified in the plan.
For facilities without exterior lots, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation:
Address (Agency): Phone No.:
Signature: Date:
AWC -- April 24, 1996 4

D) Application and Handling EaL1iVmg13t Installation (WUP or I)
Check the appropriate block
l7 Animal waste application and handling equipment specified in the plan is on site and ready
for use; calibration and adjustment materials have been provided to the owners and are
contained as part of the plan.
❑ Animal waste application and handling equipment specified in the plan has not been
installed but the owner has proposed leasing or third party application and has provided a
signed contract; equipment specified in the contract agrees with the requirements of the
plan; required buffers can be maintained; calibration and adjustment guidance have been
provided to the owners and are contained as part of the plan.
a Conditional approvalAnimal waste application and handling equipment specified in the
plan has been purchased and will be on site and installed by
(month/day/year); there is adequate storage to hold the waste until the equipment is installed
and until the waste can be land applied in accordance with the cropping system contained
in the plan; and calibration and adjustment guidance have been provided to the owners and
art contained as part of the plan.
Name of Technical Specialist (Please Print):
Affiliation:Cc? o eeG��•
a/. CA " A-J - r: Phone No.: 910 - 5:P.2 - 7/ 6 /
Signatu _ �3 �--- _ _ Date:
The following signature block is only to be used when the box for conditional approval in III D
above has been checked.
I (we) certify that I (we) have committed to purchase the animal waste application and handling
equipment as specified in my (our) waste management plan and will submit to DEM a verification of
delivery and installation from a Technical Specialist within 15 calendar days following the date specified
in the conditional certification. I (we) realize that failure to submit this verification is a violation of the
waste management plan and will subject me (us) to an enforcement action from DEM.
Name of Land Owner:
Signature: Date:
Name of Manager(if different from owner):
Signature: Date:
Please return the completed form to the Division of Environmental Management at the
following address:
Department of Environment, health, and Natural Resources
Division Of Environmental Management
Water Quality Section, Compliance Group
P.O. Box 29535
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a copy in
your files with your Animal Waste Management Plan.
AWC -- April 24,1996
5

U i� � ^ro Mom•%' " '.� „» C`«..... � ,,., law\ 1 ,r.
..v rur ' •`�9 • 1 ,.1, �,... D N�
+,.WY Y " ♦4 :..• /x . .M rr a. •, � �, Ilr ,ua r
�. ,N Y,.cr, ♦ C) '�rror� �' D,u, ,u., x�r ru' ,• ,• u � d '
\AI, rw •.... ,., 6 ,e,•n~w« �r. ht •-� e AV,
nl.♦ �,...
•I t • Lp1 a>r,' �!v\P y D r•� r L? r 'C 'ru• rY •,o .ul� 1'^ - --jp. b hrf �'Y �'�ial,
sm Ilr r -G... J'i .ILV �D�,lu r 1 •I ►ru �w B ,u• r I' 1., �.»
rx • Ya � r � r) � 0, . a K � 'r ..r., ' rro� .e P `a:n s b I �wl
YI , I ra♦ .. xM,•, rul .► r ow e _ ` rlai• , rn. ,rl Z rnr �" : �.•.. ! (. x•• 11 J ro G
4 ti°"rin� x ! !�'1'•"1d' � ♦'.w D v'. � � ¢ ...e � �e6y 16 ••'
• I^ C.✓+n r._a,o o Irk
Bep �f .ter
/ '.°' ro•r .f � x lord ^'C '-� CkINfON •
Y,1 •J �• ,l '�M• r•r .,I wrl .! IY •1 \ rQl.11lll
x „ . w...r � 9D • m '♦�
,ua r¢oq �'.� Y � • ,r. o I ur) � [r„lV � ae r 1 � .
»Y rw 'Y '' ' JC ,Iq • ,l)r u, S• 1 , ,w �•' q �r ,1
•. hi, 1 _ �� .1. ar¢� ' G�,.��.�► rur \j � ,)Y J u Ywl ! B yg` � 8° ,w r�
' r '!• a uw riw) r J • qr � rM oW rm /' i I S r " yn
..... .,) ra ,c 0 ,.w' r• C Yfl°atO ea„♦ t ,r '..•,;, ,mm 6 • ..
�� •I •bl4 �• � G+r,, w,1•11 ♦ au"b Q4 ur I c D�,ul u.� +A ,,w `t ,Om � ur. `w � , -4.4r
q uv � w, 1 y• MNI\R „r ,m D'' Cd un nn •r., ,
r .t ,n, !•^'r »i IYr.,,,•n ro jj m 'In +!n s `,w
to Cw o ,Ir
� 1 rr�♦� � �. � , uH y • 9 " -. ,r` :1 d^4'R uu ♦ � �. q w
yq✓ mwfM.y �/ ,ru �,'»l• ••Ir ^ 1 I �uq1 �n.w R' rr� ! ♦ rr
ss< ® \ .m' ! .. �m rwq• •,.l I• . un , /wd.. , Ow alp
• i »' wr'w 3^•,r b 'Or �� ' boy\�� Ur.. ! 'n u), �- ,w ` ,wl _
� o,• �e r. .w•¢'♦ 1 f �Iw u,� ,IY .. rnr - 9 nu j
• n ,h �' Gw. �i r,u �- ,. ir• •J yL o O qY w% yu •� � I
�' � r»r, N ,r � r �• �• " rN D � ',qY ,Y� ••t.r�„Y , ,w ,G1¢6
.., wl •- ALLO ',, rr 0�, •y'p .wet • ' . ' _ lq
IM. ,• /1.'rry w �r�•. .rN OR)I tr V +� �' Y 1• ♦ ill•.00 . ,1M rlll .h „Il � � l.t d
./ r Il fr r I ,w ' Inl' lr -O • 1. \✓ b.
Il ' i rr1 ; xli r< .. _ e. ..D � +.m ,. rhx •.) nu , •ll' � � m ' t r �i � ``Q (n •.r � Y•� 1 3 e ,:il"T •� . .m, � 1 n »vw. �. rlr ,» t •r, \
\, E• `.q,�� c' rq »» '•4r+ ,.q �i»o-.wc!w" t'1. .1 ` I.
1 O x ! 1• ."/..n' rr uu yu •+,w `. ,n ee ♦ .m ,y. r•1 •,m 1 .rs0
`��+ a r..�y i r.n yI �' n r,u • xrr rl r � \ ,rl rwml ,i r,i e
4 •� �r.'. 1. ' qM 1 ♦ `1� �• , � • •w• n», I , • �O5t Wa0 ,l
- / i, � ` fir` �ri¢n¢ o b • 1

•
•
•
r. Mole Farm Nutrient Management
'I Plan Summary
WUP/Rp-quired Specifications
BIMP' S For Handling Swine Manure
Emergency Action Plan
Insect Control
Odor Cceitrol
mortality
Provisions for Cabbrati-on
Of Nutrient Application LquipMent
Waste Application records

4, r. � .4eA Iwr� 1t[i 'P a wpi�• rr � � I .�y� r « �^ 1
�r-
t [ °a r 2.Ir• I' 1 •. w mr ar.� ♦R' r... ..I� •AA fw� a
w(` � rraar <. /, y,� In oM.w Mth} r foi iron .Efj• n., r`[' o �.., ` '.
«p yl/d rt n, • •' •, h E Ivi "pb t • upy�, pi t rwi � a 4.' l �' _
wu rar Y a �t1 ••f a •'KA R'`, • ! uJ �m' In�r 'Yr.p r�
abp • ! "� •«u i ah / 4 i _ '1 In . YO `, a• I .
op
' ` • wdAll
rG Iwi � � a .f / °"�ng om°L .� •.•M", rs.'y � s'' �e.' ,�1P 1..�
a`lrir P ] [ \ � ,`t[tr °I' flti «lr • tC. er� O •' r[.. � �. ' J .Nr. n. ��lir ��, . rP 111E � Y [. i - O 1 ��•.
'. o- Isar y .«. " � ♦. � � , wo d bu a.. �' 7 o[ar �n' ,< �, na (�, " - ,,"da 'r' 4 w +wr w.♦ ruC
wr �, B .nr � p .� w �, •wn pd ua •.
ap i d. iwr� '^t °q.:'.�.r < « � .a� �♦n •„ ` rT� � P P� �aO
♦� «ai 01 1 C o-u .''� w � �' 1i' a I +r.1 a r w•r �•eLlr ]Y�, rv.e' P
4. Q® rw. nl �� �a 1 [ 4, _ .uiF PIr.� enrn Iw• a �p
,C, o-ar rw.w, a °f Iy'� +[af],w C�A � � �^rw� 7ucm ,;;: ,r +�. P i• +.
. �+t + .rar A ua� ' + mr� � E• r, . a. P p S Ira t. a Y.
'�-- a •� •M '�qaa.' , • � ' nt.-trt, °I f._�nr\' f..rM O u1��. <ft. wa ,.
�i ]m, rail << : war rm . r � �' ,.. �.. `` . ni ` •,:
'gym „ , w ♦ [I r a In,. • : I r n {'
" war 9 , i + . a, a[n Ld - � a.. , w•r a
[, as yrrr ,e _ ry B`8
] _ z, ', u • .rc. C n n. «I, .�. a: . � �P ' rr •,ram >� e.r
.°Iwy ;� . rflr wii� ,R. • is � I �✓~:
wLP t1 . J P � ♦} ...` «ar _ ,., . w w �. a�i"� i.r..1 ...r
, ua. ^-, ' r Y rnr C E I ♦ .�.u.] �n .o.r � tur W.
' "IIi rl@ r>�' p . ode a r , ^■.. ! a.. ,' _
NO1NI1� �: «awl ao q1 sir
Y Z ♦ \ �iw (Lr' •t1._ °l I w' Y.1 w•, l ,M.r ,
46
C ? 't,°,rG! L, •i;' 7A [ ♦ TIiT• ' a ' ..0 1 t 1� ^ ♦� ... u 1
' C r _ Pa1F10� d n r. • G 'g', . W • ` Ir.. �' •.' r •Ln.
'If
� .r • •a �. '°. `� ' ' i • ... � ,. s pp , � . ro w r... ."'r.n mom.
_ taw.., j�;p Oar w ' % � ' •C7 n aub . •'�?�6.. lNa ' r
r •.�wA P.Ia� arr �'� �� �.. w.enw.,^a^+9 � � .<
� Y e «.r l ���, rw' L '4 °j ,!� •', a .r Iwr � ur�I �w� �•rf „_ *o P P'!.'a�
I! y o,� ' "s,>4° 2 2 ?c , �� w w . � ior' ` . � 1 _'tr•.'w, w .
•ds }.T ... ' .. + ,.,P ♦ ° a Crl ,I, r.ww 1 :/..r +Oran°

EkMrr A-8
Waste Utilization Plan Agreement
Name of Farm /t/e ,E w7,PA/ 6tJ A S Nrr -,C�v Iai[z--
OwnerNanager Agreement
Uwe understand and will follow and implement the specifications and the operation and maintenance procedures
established in the approved waste utilization. plan for the farm named above. I (we) know that any expansion to the
existing design capacity of the waste treatment and storage facilities will require a new certification to be submitted
to the Division of Environmental Management (DEM) before the new animals are stocked. I (we) also understand
that there must be no discharge of waste nutrients form this systems to surface waters of the state from a storm
event less severe than the 25-year, 24-hour storm. the approved plan will be filed on -site at the farm office and at
the office of the local Soil and Water Conservation District and will be available for review by DEM upon request.
I (we) understand that I must own or have access to irrigation or other equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be available at the appropriate pumping time such
that no discharge occurs from the lagoon in a 25-year, 24-hour storm event. I also certify that the waste will be
applied on the land according to this plan at the appropriate times and at rates that no runoff occurs.
Name of Facility Owner (Please Print):
7.7.0,U wA n/ r Al-f
I* Signature
Name of Manager ( if different than owner)
Date
Signature _ Date
Person Who Prepared Waste Utilization Plan: s G
Affiliation oca it iu r EkT. S ,Phone No.Sr.2
Address /r /t-a�....I�J /Pt✓
Signatu Date
•
MRCS, NC
RJNE, 1996

About Your Waste Utilization Plan (WUP)
• I. Whole Farm Nutrient Management Plan Summary:
This is an assessment of the plan for the entire farm. it
includes the priority nutrient that the plan is being
developed for as well as indicating if other nutrients are
being tracked. The summary addresses soil erosion, necessary
storage availability and if there is a need for daily
spreading of waste.
•

Whole -Farm Nutrient Management Plan Summary
Producer's name: U
Idress:_ - cl Jo /i - s ,.._j �c! -
C /'.Y ibN .V•
Telephone: `/o -__�-r<; 5f -,
ASCS Tract #: _ i / a'i�/
Farm location: 7a.-r // TC : s!�z / eZv_.,.-,1._ oT_--., ' i,*—A-4
—DENy —�� _ 44.�—'"-K. .3 r- A 7 -.: /
,o f C• .tom .lp �ItE.
%s�f ,✓ ,c , 5 L r c. ,J hlo .�. <.rc a 77` �p %u,G LC 7ef
Type of operation:re�t a-.�,.-,u��[..��. ���.c.�7�o,.. o.� .es5dr ��t..T' � �.-.•f� .
Assessment of Plan for Entire Farm
circle one
® Is the farm in a critical watershed area? yes no
® Have water quality problems been identified in the watershed? yes
If yes, what are they?
Does the plan consider these problems?
yes
no
N
Are any erosion problems apparent on the farm?
yes
CV
If yes, have the eroded areas been considered usable acres?
yes
no
For what priority nutrient is the whole -farm plan being written?
N P,Os Other
cries with field
®
Will nutrient sources other than commercial fertilizer be used on the farm?
ye
no
If no, skip to last item and signature section.
■
Is enough land available on farm to use all of the primary nutrient that is
produced?
n0
If no, have alternate plans been included for the ­xcess nutrients?
yes
no
®
Is daily spreading of nutrients necessary?
yes
®
Is land available for daily spreading?
yes
no
0
Have plans been made to track the potential buildup --f nutrients other than
the priority nutrient?
(!p
no
■
Does this site/farm need additional storage facilities for best use of the
nutrients, both agronomically and environmentally?
yes
<0
If yes, is the submitting party making plans for necessary storage?
yes
no
■ Based on the facts and representation of the submit.'-g party, will this plan
comply with technical requirements for proper nutrient management? ye no
Submitted by:_j\,9"_� f1 Date: . J t_- /,F 7
\ 1aaAlua nlj
.)aration assistance by: F--�--.-
N.C. Cooperative Extension Service
1-2

II. Total Waste/Nutrients Generated (per year)
0 This section includes the total volume of waste generated
(gallons or tons) as well as the total pounds of nutrients
generated. Values may be derived from tables of estimated
waste production or from actual waste records generated by the
farm. Particular attention should be noted in Table 2
under section (Included in WUP Yes/No). The total waste
generated on the farm may or may not be included in the Waste
Utilization Plan (WUP). If the answer is no in this section,
there is not adequate acreage available on site to utilize
this portion of the waste. This portion of the waste will
therefore have to be utilized by some other means when
necessary.
11
Note that the N (nitrogen) generated and having a yes answer
in Table 2 will appear on the Field Summary in Section III of
this plan under the column (Total lbs. Nitrogen).
The amount of sludge shown in Table D is for a one year period and is based
on an application method shcxm in Table C. The sludge should be tested
before land application.
0

11.,.. Zbtal Waste/Nutrients Generated (per Year)
A. Percent collected of produced / o o.
B. Design time of temporary storage.
4� Type storage Time (Day(s))
Liquid / w
0
C. Waste Generated (per Year).
Table 1
L� JCL
633 e- 7''t
Type
Prod.
Unit
*
# of
Animals
**
FbrM of
aste
Generated
Volume of Waste
Generated
Gals. qbns
Appli_,
Method
Plant A%enable
Waste 'Anal sis Values
animal Unit
s.. 1QOQ. Gals. 'ibn
Tables
Actual
Tables
Actual
N
P
K 1
Zn
Cu
N
P
K
Zn
jCu
��ertof
A AIf4-4I C-
Z-.*
-O�
,c!
S/NDG
//Z Fcas
51
/•34
3. 3
Salloffjo..0171
D. Nutrients Generated/Used (per Year)
Table 2
Form
of
Waste
Included
1n
WUP
Yes/No
Total Plant Available Nutrients (lbs.)
N P K Zn Cu
.SL4DG�
.cla
3Y
117/
2
* Cne time capacity
** Liquid, Slurry, Dry, stockpiled, Composted. Etc.

III. Field Summary/Application Calendar
The Field Summary Sheet is the most important part of the
Waste Utilization Plan for the farm. Significant columns for
the operator include the (1) Nutrients Rectuired column
(lbs./ac.), (2) PA Plant Available Applied from by -products -
and (3) Applied From •Fertilizer (lbs./ac.)._ When the (1)
Nitrogen Requirement (lbs./ac.) of the crop is satisfied with
the waste application, other nutrients in the waste are also
supplied to the crop. If the waste does not contain enough of
these other nutrients, then column #(3) will show the balance
being supplied from Fertilizer (lbs./ac.). Nutrient excesses
are shown in red under (6) Net Nutrient Balance. This column
is used to estimate the buildup of nutrients on the site.
• The Ap
plication Calendar following the Field Summary Sheet
indicates the months that waste can be applied to each crop
type. It may also include the relative uptake of nitrogen
during the growing season for the crop.
•

Relative Growth Rate
of Forage Species by Month (Piedmont & Coastal Plain)'
Crop
January
Febrtary
March
April
May
Jane
July
Augmt
September
October
November
December
Relative
Growth
1©� Fescue
L
L
M
H
H
L
L
M
M
M
L
L
too
Orchardgrass
L
L
M
H
H
L
L
M
M
M
N
L
100
Kentuck bluegrass
N
L
M
H
H
L
L
M
M
M
N
N
65
Rascuegrass
L
L
M
H
H
M
L
L
L
M
M
L
65
Hybrid Bermudagrass
N
N
N
L
M
H
H
M
M
L
N
N
100
Switchgrass
N
N
L
M
H
H
H
M
L
L
N
N
70
Flacidgrass
N
N
L
M
H
H
H
M
L
L-
L
N
a5
Gamagrass
N
N
N
M
H
H
-H
M
L
L
N
N
t0o
Caucasian Sfuestem
N
N
N
L
M
H
H
H
M
L
N
N
70
8at�iagrass'
N
---
N
-- N ----
N
--- N
L
M
H
H
---
M
-- M----
L
-- M----
L
- --_
N
-_ N _-
N
-- N ----
70
---85----
ScrghunVsudan Hybrid
N
N
N
N
M
H
H
M
M
L
N
N
100
Crabgrass
N
N
N
N
L
H
H
H
M
L
N
N
70
Italian Ryegrass
L
L
M
H
M
N
N
N
L
L
L
L
100
Smal Grain
(winter rye)
L
L
H
H
L
N
N
N
L
M
M
L
100
` For species adapted to the mountains, the growth rate is generally delayed 2 to 4 weeks in the spring and stops 2 to 4 weeks earlier in the fall.
L = low growth rate; M = medium growth rate; H = high growth rate
3 Not adapted except in piedmont and mountains.
' Not adapted in most of piedmont or mountains.
' Relative to other species in the same section in the table. 6uqzutad Oe? Eg0-3iG-U0N
g661 S W.
Novas
a3/111"a038�M
LM

ie CORN AND GRAIN SORGHUM
Nitrogen and Phosphorous Application Calendar
November /December: Applications of lime should be made, if called for by soil test recommendations.
0
March/April: Applications of potash and phosphorus and other nutrients should be applied according to soil test
recommendations_ Application of mobile nutrients such as nitrogen and sulfur should not be made too far
in advance of planting.
April: At -planting apply nitrogen and phosphorous in a starter fertilizer in a 1:1 to 1:3 NT ratio. Nitrogen rates may vary
from 10 to 30 pounds/acre in a 2" x 2" band and phosphorous rates may vary from 15 to 60 pounds/acre. Potash
may also be included in starter fertilizers. If nitrogen and potash are applied together and do not exceed 80
lbs./acre total (N+K,O) in a 2" x 2" band. Starters may also be applied on the soil surface, 2" to the side of the seed
furrow in sandy soils or placed directly into a subsoiler track. Applications of liquids should prevented from
adhering to the subsoil shank . Use of splatter guards or angled drop lines away from the shank can help. Small
amounts of diluted 10-34-0 may be also used in the seed furrow only in organic soils. Application of fertilizers with
the seed are not generally recommended because of seedling damage. Growers interested in this option should
experiment with it on a small bases. Past experience shows that hybrids vary in their susceptibility to salt damage
from in -furrow placement of starters.
April: Some nitrogen solution may be applied as a herbicide carrier. states should be as low as possible, particularly when
abundant prior crop residues are on the soil surface- Nitrogen in the starter plus that used to carry herbicides should
amount to 1/4 to 12 of predicted nitrogen needs depending upon the one's ability to get back into the field following
heavy rains. If nitrogen is not known to enhance the activity of the herbicide use water instead.
It should be remembered that starter and sidedress operations offer excellent opportunities to economically combine
nitrogen and sulfur applications to supply sulfur that may be needed on sandy soils. Starter fertilizers are especially
efficient vehicles for sulfur applications (3-10 lbs./acre sulfate sulfur).
Early May: Nitrogen sidedressings for corn should contain 1/2 to 3/4 of total N, depending upon soil texture and the
potential for getting back into fields following extended rainfall- Final rates for corn should be determined
by assessing the crop's condition at sidedressing time. One to 1.25 pounds of nitrogen per anticipated
bushel of grain for corn is recommended, with yield goals being realistic and achievable. The higher rate
should be used under high yield conditions such as where irrigation is used.ln no -till corn where residues
are abundant, it is preferable to dribble sidedress nitrogen rather than broadcast spray, unless a weed
problem demands that the nitrogen be used to increase the effectiveness of the herbicide. The best
sidedressing time is about 4 weeks after planting when corn is 12 inches tall and roots are meeting in the
row middles_ Where possible, close -to -the -row placement (6 inches to the side) will improve nitrogen use
efficiency.
Grain sorghum plantings require 90-100 lbs./acre of nitrogen ( 2 to 2.5 lbs N/cwt)_ In absence of a soil test
use approximately 25-50 lbs./acre of phosphorous and 60-80 lbs./acre of K,O/acre. Sidedressing nitrogen
works well with grain sorghum but timing must be made earlier than corn because sorghum develops faster
than corn, i.e., it is easy to be late with grain sorghum sidedressings. Starter fertilizers also work well for
sorghum but care must be taken not to place nitrogen or potash too closely to the seed -
Early .tune: Irrigators applying nitrogen through their systems may want to make a "just -before -tasseling nitrogen
application of 30-50 lbs./acre. This application is advisable if intensive rains are believed to have leached
substantial nitrogen or if local experience has shown a response to nitrogen at this late stage of growth. No
additional nitrogen should be applied if silks have turned brown. The preferable tune for the last nitrogen
ampliation is a week before tasseling which is usually around June 1. It is important to remember that
postemergence herbicides like Banvel, Bvik and 2,4-D should not be applied too close to tasseling.
Fertilization with By -Products
NCSU Nutrient Management Manual North Carolina Cooperative Extension Service
4-23 _ , -

•
•
E
When fertilizing corn and grain sorghum with by-product materials high in inorganic or readily available
N, comments given above for commercial N management are applicable. For sources low in inorganic N,
the slower release properties will provide some additional protection against leaching.
When applying by-product materials, timing should be as close to planting time as possible. Guidelines to
meet the plant requirements are as stated in the above section for commercial nitrogen. Often, however, it
may be difficult to meet these timing criteria. Some general suggestions are offered if this occurs.
By-product fertilizer sources should not be applied more than a month before planting unless soil and site
conditions prevent leaching, denitrificaton and runoff. Materials high in organic nitrogen and low in nitrate
or ammonium are less likely to leach before planting. Availability of nitrogen from organic sources are
dependent on microbial release_ Because of this weather can greatly affect the amount of nitrogen released.
Tissue analysis is an excellent tool to help fine tune these systems and take much of the guess work out of
N uptake.
Other Nutrients
If by-product utilization is to be based on a nutrient other than nitrogen and soil tests call for no additional
nutrients, additional nutrients can still be supplied providing the application rates do not exceed plant
removal rates. Removal rates are based on the portion of the crop physically removed from the site. The
values obtained below were taken from Nutrient Removal Rates by Crops in Norrh Carolina, SoilFacts AG-
439-16 can be used as a guideline.
Corn and Grain Sorghum Phosphate and Potash Removal Rates
yield P,O, K,O
unit
--lbs/bu or Ton - -
Corn (grain) bu 0.35 0.27
Com' (silage)
tons
3.60
8.30
Sorghum (grain)
bu
0.42
0.25
(stover)
tons
6.67
31.67
For a 120 bushel corn crop (120 X .35) 42 lbs of PZOS and (120 X .27) 32.4 lbs of K.O are removed per
acre.
'Com silage values were missing in the nutrient removal fact sheet and added here from "Plant Food
Uptake for Southern Crops" PPi . Values close to these were found in Tisdale and Nelson's Soil Fertility
and Fertilizers Text.
It should be emphasized that application of nutrients other than N should be based on the soil test
recommendations and not removal rates when ever possible.
NCSU Nutrient Management Manual
North Carolina Cooperative Extension Service

�I
Small Grain — Nutrient Management Notes
Nitrogen application rates should be based on a realistic yield potential for each specific
field (Table 1). Reduce the total amount of nitrogen topdressing if small grains follow a
legume crop like peanuts or soybeans (Table 2).
Table 4.5. Nitrogen application rates for small grains
Crop lb N/RYE'
Wheat (grain) 1.7 to 2.4 lbs N/bu
Barley (grain) 1.4 to 1.6 lbs N/bu
Rye (grain) 1.7 to 2A lbs N/bu
Triticale (grain) 1.4 to 1.6 lbs N/bu
Oats (grain) 1.0 to 1.3 lbs N/bu
Small grain (hay2) 50 to 60 lbs N/dry ton
' RYE = Realistic Yield Expectation
Reduce N rate by 50 percent when grazing.
Dry matter production and nitrogen needs for small grains is fairly slow in the fall and
early winter months. Therefore, a moderate amount of nitrogen (15-30 lb N/acre) is all
that is needed for establishing a timely -planted crop.
Topdressing with nitrogen is a very important practice for profitable small grain
production. It can often mean the difference between a high yield and a low one.
Nitrogen is crucial because it promotes tillering, ensures a large number of heads,
increases the number of kernel per head, and increases the weight per kernel_ All lead to
increased yields. Topdressing should be done by Feeke's growth stage 5. This stage of
growth generally occurs by mid -March.
Split applications of nitrogen at topdressing have, in some cases, reduced severity of
diseases and lodging and have increased yields. Apply one half of the nitrogen at growth
stage 3 and the remaining half at growth stage 5. These growth stages coincide
approximately with mid -February and mid -March. The success of this practice has not
been consistent and depends heavily on varietal response, soil type and weather. Split
applications are more likely to be effective in the coastal plains on sandy soils than in the
piedmont on heavy clay soils. On most North Carolina piedmont and mountain soils, all
of the nitrogen may be applied in the fall without great loss from leaching. It also
decreases the possibility of having to delay topdressing because of bad weather that can
cause poor traction for the application equipment. However, applying all of the nitrogen
in the fall can increase the possibility of cold damage resulting from excessive growth
and succulent plants. It can also result in the early onset of insect and disease problems.
0
Other Nutrients

Nutrients other than nitrogen should be added at rates based on soil test
recommendations. If soil test levels are high (P-I >60, K-I >70), no additional fertilizer
will be recommended.
Sulfur deficiencies can occur on small grains, especially on the deep sandy soils in the
Coastal Plains that are low in organic matter and with the clay below 15 inches. Sulfur
deficiencies can also be induced when nitrogen application rates are high and sulfur
levels marginal. This induced deficiency is caused by an imbalance between N and S in
the plant tissue. The ideal plant tissue ratio of N:S for small grain is 16:1 or less. Visual
S deficiencies are often found when this ratio exceeds 20:1. Use of a sulfur fertilizer will
usually prevent this from occurring. Application rates of sulfur are generally from 20 to
25 lb/acre.
PH
Small grains grow best in mineral soils at a pH of 5.8 to 6.2_ Target pH for
mineral -organic soils is 5.5 and for organic soils 5.0.
Using By -Products
Nitrogen
When fertilizing small grains with by-product materials high in inorganic N or readily
available N, comments given above for commercial N management are applicable. For
sources low in inorganic N, the slower release properties will provide some additional
protection against leaching.
. When applying by-product materials, timing should be as close to planting time as
possible. Guidelines to meet the plant requirements are as stated in the above section for
commercial nitrogen. Often, however, it may be difficult to meet these timing criteria.
Some general suggestions are offered if this occurs.
By-product fertilizer sources should not be applied more than a month before planting
unless soil and site conditions prevent leaching, denitrification and runoff.
Nitrogen applications should not be applied after the boot stage which occurs in mid to
late April for most small grains. Applications after this stage of growth are too late for
efficient plant uptake and therefore could be a potential pollutant source.
Research results in NC with poultry litter have shown that the availability coefficients
for surface applied litter at topdressing time are not accurate. it is felt that a large portion
of the nitrogen is volatilized and thus lost to the crop. It is unknown, at this time, if
similar results would be obtained if other by-products are surface applied on small
grains. Although, it seems possible especially for solid and semi -solid materials. The
best management option at this time may be to apply litter and other materials preplant
incorporated. Then, take tissue samples prior to topdressing. Other research in NC has
shown tissue sampling at topdressing to be a reliable tool in determining if additional
nitrogen is needed.
Other Nutrients
If by-product utilization is to be based on a nutrient other than nitrogen and soil tests call
for no additional nutrients, additional nutrients can still be supplied providing the
. application rates do not exceed plant removal rates. Removal rates are based on the
portion of the crop physically removed from the site. The following values obtained
NCSU Nutrient Management Manual North Carolina Cooperative Extension Service
4-26

IV. Field Maps/Soil Sample/Waste Analysis
1
9 This section includes acres, tract numbers, field numbers,
buffers, etc. It may also include a soil series, a USGS map,
and a soil sample code map. Following the map section are
recent soil and waste analysis reports.
141
•

�� �_w r';r: i��L"_},.C.i�. ;.W?-..v--a i ,�� t a�w iw�;!�"� � -� • 1'i ; r _ __ _ r .C' � .,
"t� C j r,� � _ ��; r ler _'J - i+u • r. a �. '��r, e-'. : r � ' � � •`• ^• -•y M"t fIF r 'e
r r � '%<)j i 1„ . i j 1 ds�i+ }.r ( y ;� _ �: s+- +°; � _ a � F � • �:� • r `�„a � , j !j� 4 i. t� Y -�.A 1 •a S
` �` �^� ��� �, �}�r � 8 _c�� d� !S` '� ' `i'.c J� � °' - '3Qr 4 ' , o : 4� x ' p+ r � .S i �Y' � 4t u'n' � e k '"ei• ..-.,^ i e y
ti,iyx9'-�''`.� ��' •�Ye �3 \g ',.} '••t}�P" .o. i, t`� id, r wr I '!'
• ..1:,cla ,(� i S:,-,�J ,.% E. 1'�. A � �0 y_.'��'So �" b:. � y F` r%" ,�T :'q '�1'i r, � • Cs,-t 4+Y
•� .s:�. ^. n, .�� ��� .0 i £. •'a a � _ u:. Ir `'�. S" �`. �.-G.r Lr'•'•, i y ,L � t'�.�l
.
r'�;Ij--j�1i�.,Ps ''L�.'C'yyr`.s, "'(fin �g s•? t+,1'"w"' ^.�q ti, an "�' "'� `"'F.•0� ',. vs•e."r A'�r irk•-i'b'" '�.S*;. �F;: rf�,r�':-, Y^„"•ilif -s :.
�. {j-'fl 'Ga i.,'w a &' r'rG" •' r'7�,�sy .�- - - 1 � r� -rt` i_ .1} ,� rr t,• .a• •.T)
S � � � - � s �•�.t �.r(] 4 r' �• n � : y a •• •� }i' .. •r. - 'fF •' •c t'l-� s r f _Far
��
.: L �" ! G v� �• ^' L7 '� ad p ,! t u. �•: +:, 4 cr 3 �r o ! t r i r, M y r' V �. �'�i�
Z} ,A.q�y . w \y° ( ;• Id- DI+ J. C." a r ` ,r 1i yy osl� a' 1 i' k. :Y• - _i f r rt Y
�..,...�� a - _ f,� r f °!' a 1 !4�{p/y,4-fit' '•'• ,y 3a`
r' '7� r ��p F.Y�r+ �\ � '� _ � - Zp..F D : �` � 3 �1 � �yi.• [� `4- '� ��}1�) S `.i I , ,�,L C1 •
:��11'��: A' .•;2 � ��.•��'d '�G;tt',1 ;.sy �]+� � J:.. r� ,y f r0 9. • . d- k„ ' Y� FA•••� �t�,S � ,yy.� _ " +' 7F. 4�" 5� YW- r �' w ,•� .+r . +/ y •�1 _ F �
- .: ° �+' ' �'``t}' "P .r �'�.� ,`•aj'�O .^t+' +A` ° ti.' v • i• si,.q t�''ij:., ynFn : �.ti-�.� s ��,.xw .j,��;'. �..
Ztrl. -.r, .� k�-.ih's-�.. ^ -f.y .+ �L"� , ti; ..'7 1"r �. i • i••S . , " `". Cat ` {'�` T , �i` __ er:-.iw•ix`' w� w,: t.+ _
�' � n � 1. "!"� � r 7 sSf' -1 , �y�a • . r ; 6� r: .Rd. � A. � I'�>i � p, w r >4�'. • r ' ,,.'�
IL
1l,r k r- �l„t^'�, 1>w�C. ,.•{n YL, Iq. • y0 �``" °' r.'k ,,,``�V° •' t 7"9 s� tea. r: ,nq,,! _
d . . r ��• ,�_ � 4i ..+' ... r'Ss i. _ s•. � -,1 �. r/°1�� ��� Y.'a. -•..M1 }} �,. �ry 1 „� �i - � .. -
,1 •' '� 5,(.. a ' � �:► .+i r'A d , � � ^ , 'b� r O � ,1 i Pq c �>� $.1- - • _ 4rH��>r' t. .+' .7 o� _'-�ch1,�
!'� A "Of b
-� � �f �� � 2 �x 1i- • "• yea' r �;+- •'R`
{ ^K Rw i -y �XYi? 3-3;1 '' ,! �}ej a " •A. 1 r, *X"' r# .'' r,R -'.'L � y..•. .n ' ° 't�i
r�" `� � -4S. T JI� 4.'� 'I • ;a,. � r .. d c� r` t n a9t,,��`C �'' 1� qr�. '���� � r•'t ��. w 4Y ^�
.. +f'a, �"!i"A' • r Y s , r . ' � . �i 9 �,,.„ {, i 1 I 'A "y C ` v � � - ,' T M, s _ ar' , J , 111 i, ' r.� V ,y y. .!1 ,+ •a.-•: i
vu., �' '''3,. Y.'-A�+ -6' -,r: i r'.: �. •! . .'r," a .•_ . ^ `".a-^„"T !'. a. 'M'�i " -'!;y i 'rr
rt
,-.�'1 `�9 jk7:Jy�hi r. ., L-C%'��:^o.�:N•!- .'7�,', +�r ��''.'fr;:�S� ,1'�y/,�k'Y4.'AA:r`'ii-rT,S-'-. �ys..�g`C+T7..+'A�•i'ie,'H'�e,�tui,.�.�`4, �„°ra.. w.�yrl.y�. ar,;• ��r��'b � 'R �'rri•r', ,'�5,3p.1'z7'i'l�I+lr s1 D. .:�r.:x4r? �a ' L:1p}"+--Y,.'�6 , �- 8'0 Z',• 4•ffiq' {bf�E.+:.wy,,�.s'pp!'�rara�`p-:f„��t:r•�ati,. ° te_ rr�=`!•�',{ ,1�`y«a4! ' ' ���r� r'p-�n' {,;ri,}r,+!}.� F,'ti�k';, zr., d.r.tAJ ^+�,w^5[1i�.�•aL�'._' e� r. .�rm<- .,F..*•x+,.fra".at''{9�'�,':`'+.,'�y,i"ix'j?, ' +�•:•,yr,_t#1(`.
�'�4r
•`rY�. 'Iw
,•'r='t- +�fipr
M'7
� *�..y'� y�,�'•'.-'"yi- 1fp "Jp+ � �� `9 ` s'` `4i.B: `a�:[ v+r -�'.e 1 +,4 r.-''j/�t«� 1 • T�•' �'L •`�± ! F � \ # M
..`�, rr.� �v, �.�,�`o,�, �y b yk,•^y.+�� +"l+h. i�.1 �`'�Yt4+�yP'r �l I a� ..,..�� ��y�� .i•�^'�;,i` �9. ;,t .a "d
'�•. r J�� �r n,`i�t ..}•l,��, `, ��yar � kt . :�✓-, � ,� life ::�}
�*'t�#t' r7Q '`tiripp f 1r�•..' 9{fT1,'.'•+�•"T_"'�que: '�tyri��'F.�. �'•- c �, ,4�� tc;ts xw,; .a".l�C`.,.. :<�y �. .SS+ rc3}ice �- �, ' Z�"tySi6"Y..r,C.y"t,..'.0 f4� "tr.,rf .,y'�.rite F7 a � •f3 'd`'n(�.C.LiI :4,�}{.� -�"i'. ��,r `pn°•+' - .:i4:n_-c 7lQ2yq.a 0 'rr. -D , n}Ln�J'1'' • ao•p.. au . t,LL'l•7 O ' a`�r avy1,.'f tW. �n �f-4.i•i, •fYA +�,i + 1l �.k'}.r ..i -.jY-AIe',,+..is�'� }_'...e• , _ Yr�,�y�+ c -..,�i-. � �" r' 4. ijs,}' gB { Yl P
�f-
•sb'C6: r•�1Dif+ L
..
W
'�,`"� ,.�� R p s�r •�'t� �'�,r �`� „ F�. '}+Q�'. ,. ,.re}��,`�,4:. � o-,.ar: a ,Q � �'�,I * �: � 1 '�4j p,Ya �; r'rn•+�,�;*, .i n ""{�
4�, p I�, �.�"+�. � N��Sp�•I�K�, '�.. �'� a• ..w
r• s �• S, . {� !`ctt a r\ y a r�?.`a' fir : r ,c:' , y'., ;j�c.. �, �. \ 1•i.�1: + . g 7C=} ..{,�( =i 3�.,,
r • F � � I
'X�� r t i'e�y yNrt, r �1��,� r -a ��` t 4r." .4 �'��, ,', a . �'} a. '�t3, �, t� 1 �r ��j ��'� `� � it: ae y . � T�t t � �•
;.r- rKti . 3`° ? _ '�, 1.'.q„ •wY ''", Y6'/•-rvy F �'" ' �'W s 7,.- gFrr,.t - . v j'"='�raf sr'� _ .+ h �'w`�.L+'+ :., -^� '.$•, _ ,+
'�c, aY✓w,# ¢Q ` te� a -Ci.l '., _ 'r��Q/�/." 'qr . • i,, r .i .4, 7. jj �� L 'i, . r.7} 1'1'1;�� `1. z'S•d'N9 .r • I$'1'+i `, JE''.•^}'.... °'Cy'-
{��,p' i '"•Iq" ;'
•,r i- ,�.k�T'. i. ' µ" . ..1 ,) � _ i ,.. I,-r " i/ter r'..'�r'' � i •,Y', a ' � 1.�,b�!�r�� �r' '', �''�•3 L � � e y�� Y :'' t � fir.: s"3. i�.�W r t . R
i, Ia�e
.� fjr'rr� i-` •"}, _ �1 ,-�( ":�+`3ct } ar -Y �._ .Nf J y,�,r }' �+�., �7 ry •+'•' ..��,- r t L •... 4 7k:hk,
-;
���h'''iii _11✓s, .7P -'Fi'w ��_ i ,J,;Y^',wiv+i. 1 �,w. �. _ s"wi �•+�J` .-t y- {F��r'
rw ' ."5"ys fi•, z.,9i "�,�'� fir' nth'
$� ������Ni'1"a„ja tQ='g1...F 1p-'a:S >',`-h 7 '�"'� n `�'�.`,� s. tr .y ,+•,:y_ �� > .ee _ •
•, i'� � �a a ,ft�`• - � ,v.: _ 4'� - ��,y . � �� � . �. r r' . � s - �;, a 'Ae` «`l.q�,R�
s� °� .t _ C ✓ 'c 's•i:• ' x'. i t'^ G r' +. ..'y,. '� .& t ° +,. ,�` ,p t'ygRt! �'
NNI,
�'r• 1 r'�' `� y'.+`a +r r +�` 41Kr` a;"s p `k�
- s' � -} ♦ ` rI�' r ;,yf'',.- , �!� ` ice• � +W c�.., ��''j�i. G'. o� � Y� 11 + w {�
y'' � •.�„� a �'v� 4 N a S , :,•1L ,�.. y •� �'' .1 � /"�' � �1.
'•e f�69y' k Irf "s ..�i _.1 ��• �'t" - i . w-•�,..ti t ` c:� 4As!°l'. 5 r, T! .Sn"`." ...4 -
• i-5 !",.' #a ` Y` �=•� �r11,s '-.
.. I ' �,,.y,.�l Jida. � i � � q,, .,�,` G _ � ri.'• 9 � � ... { ,� � ' r p 'r'+ :., � �;�� � s .4< '^ti '
�,"YR �1'3:+d 1. � 7 _r ' G prf3''', � �+ 5&Fti'•• '� B+ 4 � it ;7 •fa'�j. j' �* t.,
1 -� + St ;r J. '7'`�. r7 ' p•• .r,��(1y� �A `�� :Jr7" +r ♦ f�� ' •r^ ti�{ '' - J,�'. G ya. r M ��j�1•
's i+•: �": `*r�} @ , f•'�+.'r1
.. •r�•r ' a�^ '4 ,, -'.3 Fes_ fay+ t CR! bH-0 } °r "y 8, �? _ ,� �,h ` "•...F
y' r ii.�a y S 4,r '• , T} ,,'� _ ,. - '•t a ti !1' b, • • "4 Ir f,
n 'r ,�w� � ' : � ! . � r ,"� �' S ,'..� 4 , CI: s�i " •� .:-'7'r" � `�' � r :d- n. M.,$+�.
�`�� •,�cF Tl�Y� z S ' s.. '. F'.`S;, ro"F �3tsrS• Y '.'�° �r p ram" r �+ �,1"'x-J" ,w r .�' "'�,�w'�''P� •.n �, + ti,'1•� r � d ,�' �"'Y•ui
' "$ „ r he xi r �eLTN �'` .'r'h 5 1MC�, r ,� � � ° 4rt �` n < +'bi ` y •+:; a , H, 1 r+r � r' ' ` �F...
.. �`A-; •.!, E,.,�• � ,1. � , , y a �' 'ry. p�j 4a�� � r. � � ti'k - - , �• ��" - 47. ' _ t•'7"1".rL+fP' �Q1.,c .,,� �t 'S. �;, j 1. 'siM1!, . i Y
'� T '�'•t r7c,Si- \ .uY �, s .i1->•rr.- r ry+^�° . ' y}�.` ,'.'+ � b
r
yy '`!'• E'er 4r ,Ir/a4T i' re' .- I� �r 1 t a t•
i
�r5 .... ^� rl�. i e�,a., _ °N 4 f ,d, �, '� ^', 8 9 r '? � b `? �`�', • �" `3"-• . < i C n �a '�„�` j �' � �,�n
J tT n t - o , '• i 3s• ,, ,�' '.' s .,}, �."f: a �''- b1�X,�.~� �. �-a, .y ,.�i•F : _,���� �s ''e �.
. � � ' • ,��!}} '.y.r y�� � �yp ' . _. - � , - � °?, 7�� G :t � `� , °a '4 r .'�i�' 'ti .,.� � `:r's 9 �,,. - �"� ori�yCSC?. �' _ .t'.
V^ ,y o , a , yr 't fi .. �M v4, v �`. R a y •� ' ,,,*
.�Y ,A �� . 'kati Ja. .y �� ' C,. .'�, a _ is ,1� psi. a-t;,' 1 - fq �.. rc ty ^:!r S•9e e ' r'.
Of
:"'4� i �,y -s'�� �, .fit:' . ,,• + o �i 1 O , 3 -
•. S ''� a' fi F1�Yj�^Jk ' n'd d�p�+'F 4�.� '+�� a •'` - o t -S• i' � o ' 4 ° ^:'�'- -•'� 4' :9�. � 'a{�q��v�t..y���s.,"s'• `. `� �y ��i r y �,,.
y, �.."" j f" - - r i r . 4 ° 0. `s rr� r " . h - . +' L .. ; �' W'i"-.tb.', �• , t idwd
r+ �~ `! ',� s - `• _ `• ' ��$',`:., a � 'ore - M +r y , � ..Y}�S�s� � �. 'Trr.v � `.�rif ,VFd"i,/.• ��

lj st.. - ., .... .. •• :�'' (:•-:�.: , :"..tom;;};.
Sol L CONSERVATION SEAMCE
RV
di •'
: t� �_ ���• { -ram
-a
:f
•� 7�,, � try, _ f - ^ _ `��•\
M `1
.t � '� �� Wry::, '.;-'i7`� V�,?��r:iVV:�� ��'�• '+�.a'
Ke
!�Jiff•.,` � G��tLa®-
� ,+t�:.d..�:'r . r.• ;tin.-':••
� YAP. a hl. !. Ty.r, C 1 .r- � 1 •�'� d e � _ �?I
.F ��j,3 2vL•x; ;; �'!''��...-+ T 3ts'c �rV .�� y.� �Kj, �F�.1f•t1,��.
•i�JG .t;�7.0 4 ��pr,.. �.,. s� '°4y + „�LL � �# � "•,� '•; rt i� 1 r
�`r;•� 3 T ss '`Z I Ft
f1Y� + ' � . � Vw J = L• _ ♦r;d•ir �1 � r�+iL� .
r1IRr _

V. Field Data Sheets:
• The field data sheets include a variety of significant
information useful for managing each particular field, Envi-
ronmental Hazards or Concerns, Field Leaching Potential,
Highly Erodible Land, and Plant Available Nitroaen Required
(lbs./ac.) by the crop are significant. Note that the
nitrogen required by the crop is indicated here and on the
Field Summary Sheet in Section III of the Waste Utilization
Plan.
0

Field Data Sheet
Field ID -�' l Total Crop Acres ._ / o? . 3 Acres Useable for
/ Blosolld Application / 2—
Soil Series G✓ i ., q y,�
Environmental Hazards or Concerns Is field classed as HEL7 Application Equipment
❑ sinkholes ❑ No 13 Broadcast
11 surface water ❑ Yes 13 Banded Applications
© Field leaching potential --- ❑ Low ❑ High ❑ Starter Fertilizer Rig
E3 Manure Spreader
Nutrient Sources
Irrigation Equipment
❑
Injection
❑
Commercial Fertilizer`
❑
None
❑
Fertigation
❑
Animal Manures
❑
Traveller
❑
Sewage Sludge
❑
Portable
Tillage System
❑
Septage
❑
Center Pivot
❑
Conventional
❑
Other By -Product
❑
Solid Set
❑
Reduced Till
❑
Lateral Move
0
No-TiU
Crops
Previous Crop
Predicted Crop Rotation Sequence N Residue Credit
(if double -cropped. list spring crop fit Realistic Yield(s) Expected Plant Avallabl N Requlred froPrevious Crop
Year (1) i3FR RtJ (ia•zE) 5f . Z / �r i" %P m
Year (2) -
Year (3)
Soil Test Results;
Date of Soil Sampling Soil Class: © Mineral 13 Mineral/Organic ❑ Organic
pti CEC P-1 K-1 Ca% Mg% Mn-1 Zn-I Cu-I
Nutrient Recommendations:
Lime: N: ,SCe,Above _ P205: K20: ,_._, Mg: - S: Mn: Zn: Cu:
BuFgluuscl a61E4os'Ci-uo1+1
[f using only commercial fertilizer, go to section 6.
96619 Nnr
,, NOU035A1)W'10; 11vM

Field Data Sheet
Field !D_� _ _ Total Crop Acres R. o ! Acres Useable for
Soil Series Blosolld Application '7. G
/CiQ%Ns
Environmental Hazards or Concerns Is field classed as HEL? Application Equipment
❑ sink holes ❑ No ❑ Bsoadcast
❑ surface water ❑ YeS 0 Banded Applications
❑ Field leaching potential — o Low d High ❑ Starter Fertilizer Rig
❑ Manure Spreader
Nutrient Sources
Irrigation Equipment
❑
Injection
❑
Commercial Fenilizer'
Q
None
tz
Fertigation
❑
Animal Manures
17
Traveller
17
Sewage Sludge
❑
Portable
Tillage System
❑
Septage
❑
Center Pivot
❑
Conventional
❑
Other By -Product
❑
Solid Set
❑
Reduced rill
❑
Lateral Move
11
No Till
Crops
Previous Crop
Predicted Crop Rotation Sequence
(if double -cropped, list spring crop first) Realistic Yleld(s) Expected
Year (i) Et ewtF- Kj;X.42ar .3. ? 7-
Year (2) ~ "s rbtG 4.a ` "
Year (3) _`ks eA c lr efa 41;
Soil Test Results:
Date of Soil Sampling
pH CEC P-t
Plant Available N Required
. _ 1 4 E
//
N Residue Credit
from Previous Crop
Soil Class: ❑ Mineral 0 MineralJOrganic 13 Organic
K-I Ca% Mg% Mn-I Zn-I Cu-I
Nutrient Recommendations:
Lime: N: See Above . P205:._ - _ K20: Mg: S: Mn:— Zn: Cu:
[f using only commercial fertilizer, go to section 5.

Field Data Sheet
j iDGr2-
Field ID
Soil Series-
Environmental Hazards or Concerns
❑ sink holes
❑ surface water
Total Crop Acres 1- J l C
is field classed as HEL?
❑ No
❑ Yes
Field leaching potential — ❑ Low
Acres Useable for
Blosolid Application 31)
Application Equipment
13 Broadcast
❑ Banded Applications
❑ High ❑ Starter Fertilizer Rig
13 Manure Spreader
Nutrient Sources
Irrigation Equipment
©
Injection
❑
Commercial Fertilizer`
❑
None
0
Fertigation
©
Animal Manures
©
Traveller
a
Sewage Sludge
❑
Portable
Tillage System
a
Septage
❑
Center Pivot
o'
Conventional
o
Other By -Product
❑
Solid Set
la
Reduced Till
❑
Lateral Move
❑
No -Till
Crops
Previous Crop '
Predicted Crop N Residue Credit
(if double -cropped, list spring crop first) j Realistic Yield(s) Expected Plant Available N Required from Previous Crop
s / 3 ir'y �PE� u c F
�.+ l ,N� .2Q ��3/xcw r i /%I✓irq
sn3P 9z
RA.Q e x Y C 5, /A*E d 7o ^e >' w /,7 O
Sol[ Test Results:
Date of Soil Sampling Soil Class: ❑ Mineral 0 Mineral/Organic o Organic
PH. CEC P-I K-1 Ca% Mg% Mn-1 Zn-1 Cu-I
Nutrient Recommendations:
Lime: N: Sec Alboye P205: K20: Mg: S: Mn: Zn: Cu:
If using only commcrcial fertilizer, go to section 6,
A
..a

1 .Z
WASTE UTILIZATION PLAN
•
REQUIRED S.?ECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
S. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
B. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
isa manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 9

A i
WASTE UTILIZATION PLAN
0
REQUIRED SPECIFICATIONS
10. Waste nutrients. shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 10

WASTE UTILIZATION PLAN
•
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
• 22. Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
•
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 11

Material Handling & Best Management Practices
for Swine Manure
& Wastewater
Collection:
❑
pit recharge
❑
hand wash/hand scrape
❑
flush
❑
mechanical scrape
❑
exhaust air plenum
❑
tractor scrape
❑
lift station
❑
other
❑
other
❑
other
Storage:
❑
manure underfloor pit
❑
retention pond
❑
manure abovegrourid tank
❑
lagoon temporary storage
❑
manure earthen basin
❑
lagoon sludge storage
❑
compost shed
❑
mortality container for rendering Cbiogas
storage tank
pickup
❑
other
❑
other
Treatment:
❑
biological additive
❑
solids composting
❑
solids separation
❑
sludge drying
❑
anaerobic lagoon
❑
lot rotation
❑
lagoon cover
❑
stream fencing
❑
anaerobic digester
❑
riparian filter
❑
mechanically aerated lagoon
❑
mortality composting
aeration cell
❑
mortality pit disposal
❑
constructed wetland
❑
mortality burial
❑
exhaust air biofiltration
❑
mortality incineration
❑
other
❑
other
Use: ❑ fertilizer (field crops, pasture/hay, turfgrass, trees)
❑ biogas fuel (space heat, water heating, cogeneration)
❑ organic compost (lawn, garden, horticulture, landscaping)
❑ animal by --product feedstuff
❑ other
❑ other
Application Equipment.
❑
tractor scraper
❑
manure spreader
❑
irrigation pump
❑
mechanical scraper
❑
compost turner
❑
irrigation dry hydrant
❑
front-end loader
❑
biogas hot-water boiler
❑
irrigation (permanent,
❑
mechanical solids separator
❑
biogas cogenerator
solid -set, portable,
❑
flush pump
❑
biogas scrubber
traveller, center pivot,
❑
flush tank/valve/controller
❑
biogas compressor
lateral move)
❑
agitator/sludge pump
❑
aeratoriblower
❑
incinerator
❑
sludge/solids dryer
❑
lift pump
❑
other
❑
other
❑
other
•
10-S

Important Considerations
when Managing Nutrients to Protect Water Quality
Animal Manures & By -Products
l • t Da ■Remember that the producer is responsible for any pollution caused by improper management of
nutrients.
■ To avoid runoff, apply irrigated or liquid materials at levels less than the infiltration rate of the
soil. Infiltration rates vary with the degree of soil saturation and should be taken into account
when applying nutrients from liquid sources.
■ To avoid groundwater contamination, apply no more liquid than the amount necessary to fill the
soil profile within the crop rooting depth to field capacity.
■ To properly design and implement a nutrient management system, have manure and by-products
analyzed. If a sample cannot be taken before land application use the best available information
for that material. Then during land application or loading, take a representative sample of the
material and have it analyzed. After results are received, reassess the nutrient management plan
and make any necessary changes.
■ To maximize nutrient uptake for plant growth and development and to reduce the potential for
pollution, apply nitrogen from fertilizers or by-products less than 30 days before planting.
■ Develop field borders. which serve as a nutrient trap if field runoff occurs.
■ If a by-product has a calcium carbonate equivalent. be sure to assess the lime effect at calculated
. application rates for the primary nutrient. Many products with calcium carbonate need to be
treated as a primary lime source rather than a primary nutrient source.
■ Store nutrient or lime sources that can't be applied at the appropriate time for plant use properly
to prevent groundwater or surface water contamination.
■ Locate temporary and permanent storage structures a minimum of 100 feet from perennial waters
as indicated on the most recent version of U.S.G.S. 1:2400 (7.5 minute) scale maps.
Don't: ■ Don't apply manure or by-products at rates greater than agronomic rates.
■ Don't spread manure or by-products on soils designated as highly erodible (HEL) unless treated to
nlcct soil loSS or "T' (value that is considered to be an acceptable field loss tonslaclyr), or unless
the application is parl of a treatment program such as soil amendment.
■ Don't apply manures and by-products on soils with high runoff potential or steep slopes.
■ Don't apply nutrients to soils that are water saturated, frozen or snow covered. These conditions
promote runoff and may contribute to surface water contamination.
■ Don't apply nutrients before a storm. Greatest nutrient runoff occurs when significant rain falls
within 24 hours after application.
• ■ Don't apply nutrients near surface waters &.- wells.
10-1.1

ENIER GEN CY ACTION : PLAN
PHD\-EN-UMBERS
DVvQ 2-/4,1},F4—/Sy/ -4 r'FR Nits. V/t-'731— 3sys
EMERGENCY INIA.VAGIHM-E T SYSTEM .Cf 2 r RyfG
SWCD .S"fL - 17 f L 3
NRCS _f:fi-7 14 3
This plan wi]i be implemented in the event that wastes from your operation are leaking.
overflowing, or running off site. You should not wait anti] wastes reach surace waters or
leave your property to consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location for
all employees at the facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to be.­rri to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. CalI a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application sates for the fields wher-- runoff occurred.
C. Leak.ase from the waste pipes and sptinMers-action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge_
d. Repair all leaks Fa-ior to resianin-c pumps.
D: 1-1-2kace from flush systems. houses. solid separator: -action include:
a. Stop rec•:cie pump.
r. Stop irri^nation pump.
Mjk} sure no sip, non oc--,j
.:. Stop -ail floxv-z UI tilt ; u-h sx-ztems. or s.:iid separators.

C. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks- possible action:
a. Dig a small sump or ditch away from the embankment to catch all seepage.
put in a submersible pomp, and pump back to lagoon.
b. If holes are caused by burrowing animals. trap or remove animals and fill
holes and compact with a clay ripe soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
1 Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was re!eased and for what duration?
c_ Anv damage noted, such as employee injury, fish kills, or propeny damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f.- Could a future rain event cause the spill to reach surface waters?Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality)
regional office. Phone - - . After hours, emergency number: 919-t3-3942.
Your phone call should include: your name, facility, telephone number, the details
of the incident from item ? above, the exact location of the facility, the location or
direction of movement of the spill, weather and wind conditions. The corrective
measures that have been under taken, and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local ELMS Phone numbs: -
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number - - , local SWCD office phone number
and local MRCS office for advice/technical assistance phone number - -
4: If none of the above works call 911 or the Sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off -site
damage.
a. Contractors `ame;- i r'+
h. Contractors Aidres;-- --1 a G��►w � � !i)C- ���
c. Ccrtrac:ars phon 6 x

5: Contact the technical specialist who certified the lagoon (MRCS, Consulting
Engine-zr. etc.)
a. lame: l7A��Y 3A•' Lt '�
b. Phone: 9_io_ - SF f- - ?--
7: Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage. repair the system. and reassess the waste management plan to
keep problems with re?ease of wastes from happening again_

ti
Swine Farm Waste Management Odor Control Checklist
Sourct: Cause - flMPS to Mi1111ufi
ize 0(1411' Site specie Pr_iclives
1'alllll�l�a�1 • Swine f111idlicIiolt 0 Vegetative or woDded bidMrs;
M--aecommended best nlanagelucul practices;
124--bood judgment and comirson sense
Animal hucly surfaces 0 Dirly niantlre-covered aninialls gt-'(fry floors
I'lnc+r taulaccs9 Wet Iritututc-cuverecl Monts Sloiled Iloors. --
11 -Waterers located over slnited floors;
Feeders tit high civil of solid floors;
fa--Sc—rapt: manure hniklup from floors,
rl llntlerfluor ventilation fur drying
Hallow C111kc1iuu pil, . thine; R'l"requeul manure reninval by Ilush, ph techarge,
• Paiiial ndcruhial cleconyiusikoll or scrape;
n l lndedloor ventilation
Venlil.cli-t 11al st I',cns 0 Vcrlalik gases; ilo lu.liutcnanc:e;__--
Ihest R-Ilflicieui air movemcul
114100r sulf;lLes • Dust washdown humcco groups of animals; �—
fl Izeetl tlllllitives;
r1 Ccutler cowers;
rl l'cell delivery tlowllsputtt UXtcuclels lli Icccler
covers
Flusll WAS
• Agitatinn ofrecyclell lagaorl
0
Flush lank covers;
iicloicl while: rinks :lie filling
C1
Extend rill lines to near button] tcl,la elks with
anti -siphon VC1115
Flush atllcys
0 Agitation during waslewmer
(7
I Inderfloor flltsh'willl untlerlloor vent ila loll `
cnnvcyance
Pit 14cll.11y poilits
• Agilaliun of recycled lagoon
n
I:xlend tcchargc lines In hear all' Mils
liquid while flits are f illitig
With anti -siphon VC111S
-
l.ili al:cliuos
ftilwinu during stluip tank
f-1
Shop hulk. covers
filling atlitl drowllown
Oolsiclk draiin cullecliun • Agitation during wastewater f-1 flux covers
Dr 1t1i1Clioli boxes C011veyallce
AAl()(. - November 11, 1996, Page 7

Source Curse RMI's to Miniluize Odor Site Specific Practices
End of drainpipes ui • Agitalion during wastewater Cl Extend discharge point of pipes mitlerucatli
lagoon conveyance lagoon liquid level
Lagoon surruces Volatile gas Clllissiolls; roper lagoon liquid capacity;
• Biological mixing; C1 C ecI lagoon startup procedures;
• Agitation ([YMilli num surface area-lo-volmlle ratio;
CI Minimum agitation when.pumping;
Cl Mechanical aeration;
Proven biological additives
�IIIibatiun sprinkler 0 I sigh pressluC agilatioll; Irrigalt on dry days wills little or tin wines;
oodles 0 Wind drift Qinimwn recommended operating pressure;
'amp intake near lagoon liquid surface;
Slulagi; lallk or basin
cur t'"Ge
Cl Pllinp from second -stage lagoon
• Partial Microbial deconlposition; ❑ Bottom or midlevel loading;
• Mixing white filling; ❑ Tank covers;
• Agitation when emplying n Basin surface foals orsoiws;
Cl
Proven biological additives or oxidants
Sculiog busiii surface 0
Partial miciollial decomposition;
Cl
Extend drainpipe outlets underneath liquid
•
Mixing while: filling;;
level;
■
Agitation when emptying
C1
Remove settled solids regularly
Mamire, slurry or s,Imlge •
Agitalion when spicading ,
❑
Soil injeelion nrslarry/sludges; T
spreader oullels .
Volatile gas emissions
❑
Wash residual manure from spreader after use;
C1
Proven biological additivus or oxidants
Uncovered inalime,
Volatile gas emissions while
❑
Soil hijeciion ol'shirry/shidges
slurry or sludge all field
drying
M
Soil incorpnration within 49 hrs.;
suiiaeia
❑ Spread in thin unirirrm layers fur rapid drying;
❑ Proven biological additives or oxidants
Dead au 111111s • Carcuss decomposition W Proper disposition oFearcasscs
t)cad allillral di:;jjtnal • Carcass decomposition ❑ Colnplele: cowrlllg oI cal -cams ill bill hil pits;
pill n 'Proper location/consirtiction (Wilisposal Ails
Inciucialuls • Iilcollil}ICIC Colllbnstion ❑ Secondary stud: burners
A1v OC - November 11, 1996, time 4

soul ce Cause AMPS to Minimize Odor - - Site Specific i'ruclices
Standing wilcr arumul • Improper drainage; 0 Grade and landscape such that water drains
facilities . Microbial decomposilion of away from facilities
organic matter
Manure tracked onto • Poorly maintained access roads Fann access road maintenance
public rungs I'i om farm
access
Adhlitional Infurmation :
Swine Manure ManagemmW ; 0200 Itulc/i"iMP Packet
Swin4 Prodaction fanm Potential Odor Sources and Remedies ; I'BA1i Fact Sheet
Swine h(MILIC6011 facility Man,rre Management: Pit Itecilarbe - Lagoon Treatment ; FBAC 128-99
Swine PrncLlctumr facility k1anure Managemenl: Underfloor fDish - Lagoon Treatment ; FBAC 129-88
Lagoon Design and Ma+,abemma for I.iVestDCk Manure Treatment and Storage ; I:13AE 103-83
Calibration of htanury and Wastewaler Application Equipment ; EBAF Fact Sheet
Coutrulling Odors from S%vinc Buildings ; PII I-33
l'ovlrmimc:ntal Assurance I'rotru m ; NI'PC Mammal
Optim" 10r Rlaiwgimg Odor; a report tram the Swine Odor Task force
Nuisance Cimccrrrs in Animal Manure Management: Odors and flies ; V110107, 1995 Conference Proceedings
6u!1 WJ9d r,6:e'���f1�°�
g6g1 W
Available From :
NCS11, Cnnnly lixterrsion Center
NCSII - IIAI:
NCSI I - IIAI:
NCS11- IIAI:
NCSII - IIAI:
NCSIJ - IIAI:
NCSI I - Swine Extension
NC fork Prudncers Assoc
NCSIJ Agri Conummicatinns
Flovitla Court alive Eixtensiocr
AAIi 1C - Novi mbar 11. 1996, P.ct;c 5

..1
Insect Control Checklist for Animal Operations
Source Cause - BMPs fit Gltrtt'o) lusccls Silt: Slicci(w Pr'�rclices
_ Liquid Sysletus _ ._.,......_._� _
f}uslr gullets Accuumlatioti of solids Cl Flush system is designed and operated
I � '
sufficiently to remove accumulated solids from
gtruers as designed.
M Remove bridging of accumulalcd solids ;it
d'•chargc _
I.agonus and Pits Crusled Solids Maintain lagoons, sellling basins and I)its wlrer4
pest breeding is apparent to minbitiie Ilse
crusting of solids to a depth of no utore than 6 -
B inches over more than 30% of surface.
^ I-xc"bivc Vct;clalive • I)t;cuyillg vegelatiun Maintain vegetative control almig hanks of-
iruwih lagoons and other impoundments to prevent
accumulation of decaying vegetative tstallu
along wakes edge on impoitodincrtt`s perimeter.
_ Dry Systems _
a
0 Feed SpilhlLc l)esigu, (1pra'iilc ruin mMintaiu I'r:e:(l sysl4rtts
htinl:ers and irovighs) it) minimize the
accurnitlaliun of decaying wastage.
R"6vaii tip spillage un a routine basis (r .g., 7 - 10
day interval (luring; summer; 15-30 clay iumeivaI
tluring winter).
feet) Stmage Accumulations of feed residues R, Reduce moisture accuulnlation within and
around imutediate perinicier of teed stunt;(
areas by itistiriub drainage away frruri silt;
and/or prnvi(ling adc(luate cnnlairtnu:nl (u.g,,
coverer! hin Cur brewei's grain mid simiLtr hil;lt
moisture grant In-oducts).
n Inspect liir Enid rCniove or break up acruntul�tic+t
solids In filler strips aruuud feed slorage;is
needed.
AN11C' - November 1 1,4996, Page 1
L. 4

Sunrcx Cause BMPs to Control Insects Site Spcclfic 1'rrclices
Animal I folding Areas Aminikilations of animal wastes 0 Eliminate low areas Ihal trap moisture along
and feed wastage fences and ollier locations where waste
accumulales and disturbance by animals is
minimal.
C3 Maintain fence rows and Filler strips arannd
animal holding areas to mii;imize
acemmilations of wastes (i.e., inspect for and
remove or break up aec[rmulaled solids as
needed).
Di A1amure Ilandling Accumulalions of animal wasle;s el
Syslcros
n
Remove spillage on a routine basis (c.g., 7 . 10
clay interval during summer; 15-30 day interval
during winter) wlrere manure is loaded for land
application or disposal.
Provide for adequate drainage around manure:
stockpiles.
0 Inspect for and remove or break up accunmlaled
wastes in filter strips around stockpiles acid
manure handling areas as needed.
For more information eolslact lire Cooperative Emension Service, Department of Entomology. Box 7613, With Carolina Stale: l tuiversily,
Italcigh, NC, 27695-7613.
AMIC - Novefnlmr 11, 1996, Page 2

Mortality N1anacement Methods
(check which method(s) are being implemented)
:J Burial three feet beneath the surface of the around within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water. T
Rende:ine at a rendering plant licensed under G.S. 106-168.7
Z) Complete incineration
❑ In the case of dead poultry only, piacing in a disposal pit of a size and design
approved by the Department of Agriculture T
Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endaueriu
human or animal health. (Written approval of the State Vve narian must b-ee
attached)

I
Land ownerlOperator Name: T //0 :,-; . � � � � ., ..�:- ,t�i'.,/, `� � _ G^ttci.�r ,5�•'..� �s r,_�
Telephone: E; o — r- � V - ,,
TABLE I - Field Specifica.iOrs '
Field
Nurnberg
Approximate
Maximum
Useable Six*
of NeW
(acres)
Soil Type
Slope
(;;}
Cror+(s}
MaKimUm
Appilcation
Rate'E
(Inlhr)
Maximurn
Application
per Irrigation
cyale4
(Inches)
Comments
s O �
3
:.v
�/'—,y
�" .�/v l++E� i S • <w
3
iL
«A / C
'Table to be completed In its entirety by Field Office personnel and forwarded to the irrigation systain designer.
'See attached map provided by the Field Office for field location(s).
'Total field acreage minus required buffer areas,
4Refer to N. C. Irrigation Guide, Field Office Technical Guide, Section 11 G. Mutt application must not exceed lite agronomic rates for the soil end crop used.
Irrigation Paramelers i USDA-NP.CS
October loss Morti Csrollna

A.
instantaneous
� m
•
l ab
Comparison of avcra a and
l g
a fic. t
pp
e f r a
rat s a
gun nozzle
g
with v
variable
orifice
openings.
(Prepared by lames C. Barker).
Sprinkler
Nelson
Nelson Nelson Nelson
Nelson
Nelson
Nelson
150T
150T
150T
150T
150T
150T
150T
Nozzle diameter, in
0.7
0.8
0.9
1.0
1.1
1.2
1.3
Nozzle pressure, psi
80
so
80
80
80
so
80
Nozzle flow, gpm
128
165
210
260
315
380
445
Wetted diameter, ft
290
310
335
355
375
395
410
Full wetted area, acres
360o arc
1.52
1.73
2.02
2.27
2.54
2.81
3.03
15o arc
0.06
0.07
0.08
0.09
0.11
0.12
0.13
Effective wetted area, acres
75% spacing: 360o are
1.09
1.24
1.45
1.63
1.82
2.01
2.17
320o arc
0.97
1.10
1.29
1.45
1.tit
1.79
1.93
15o arc
0.045
0.05
0.06
0.07
0.08
0.08
0.09
60% spacing: 360o arc
0.70
0.79
0.93
1.04
1.16
1.29
1.39
15o arc
0.029
0.033
0.039
0.043
0.048
0.05
0.06
Volumetric application, ac-in/hr
0.28
0.36
0.46
0.57
0.70
0.84
0.98
Average application rate, in/hr
one sprinkler only
0.19
0.21
0.23
0.25
0.27
0.30
0.32
two sprinklers @ 75% spacing 320o arc
0.29
0.33
0.36
0.40
0.43
0.47
0.51
two sprinklers @ 60% spacing 360o arc
0.41
0.46
0.50
0.55
0.60
0.65
0.71
Instantaneous application rate, in/hr
one sprinkler only
4.5
5.0
5.5
6.1
6.6
7.2
7.8
two sprinklers @ 75% spacing 15o arc
6.2
7.0
7.7
8.5
9.2
10.0
10.9
two sprinklers @ 60% spacing 15o arc
9.,F
11.0
12.0
13.2
14.4
15.6
17.0

0 0 0
Table 1. Comparison of average and instantaneous application rates for several sprinkler and gun nozzles used to irrigate
waste%vater.
(Prepared by James C.
Barker).
Sprinkler _ W
- Y - - ^ - ^
- y Rainbird^ 5enninger
Rain6ird^
Nelson Nelson-
"Nelson
70 7025
80
100T
150T
200T
Nozzle diameter,
in
0.25 9/32
0.5
0.75
1.0
1.5
Nozzle pressure,
psi
50 60
70
70
80
90
Nozzle flow, gpm
12.9 17.8
'57.5
136
260
625
Wetted diameter,
ft
124 142
189
283
355
485
Full wetted area, acres
360o arc
0.28
150 arc
0.012
Effective wetted area, acres
75% spacing: 3600 arc
0.20
320o arc
0.18
15o arc
0.008
60% spacing: 360o arc
0.13
15o arc
0.005
i olumet.ric application, ac--in/hr
0.03
Average application rate, in/hr
one sprinkler only
0.10
two sprinklers @ 751 spacing
320o arc
0.16
two sprinklers @ 60$ spacing
360o arc
0.22
Instantaneous application rate,
in/hr
one sprinkler only
2.5
two sprinklers @ 75% spacing
15o arc
3.4
two sprinklers 0 60% spacing
15o arc
5.4
0.36
0.64
1.44
2,27
4.24
0.015
0.027
0.06
0.09
0.18
0.26
0.46
1.03
1.63
3.04
0.23
0.41
0.92
1.45
2.70
0.011
0.019
0.043
0.07
0.13
0.17
0.30
0.66
1.04
1.94
0.007
0.012
0.03
0.04
0.08
0.04
0.13
0.30
0.57
1.38
0.11
0.20
0.21
0.25
0.33
0.17
0.31
0.33
0.40
0.45
0.24
0.43
0.45
0,.55
0.71
2.6
4.7
5.0
6.1
7,6
3.6
6.6
7.0
8.5
10.9
5.7
10.3
10.9
13.2
17.1

calculating Application Volume and Travel Time
For A Traveler
• 1. To calculate the travel speed it takes a traveler to apply a
certain application volume, use the formula below:
Travel speed (in/min) =
19.26 X GPM
Lane spacing (ft) x depth of application (in)
Example: Calculate the travel speed needed to apply one inch
of water using a 200 R Ring Nozzle @90 psi. with a
oriface opening of (1.4611).
From Big Gun Table
GPM - 405
Dia. = 415'
First we must calculate the lane spacing for a traveler. This
is calculated at approximately 75% of the wetted diameter of
the gun.
Lane spacing = .75 x 415'
Lane spacing = 311.25' or approximately 300'
Travel speed (in/min) = 19.26 x 405
. 300' x 1"
Travel speed (in/min) = 7800
300
Travel speed (in/min) = 26 inches/minute
or 2.16 feet/minute
2. To calculate application volume if you know travel speed, use
the formula below:
Depth of application =
19.26 x GPM
Lane spacing (ft) x Travel speed (in/min)
If we use the travel speed above of 26 inches/minute and a lane
spacing of 300' and GPM - 405 then
Depth of application = 19.26 x 405
300' x 26
Depth of application = 7800
7800 or 1"
•

BIG GUN° PERFORMANCE TABLES U.S. UNITS
100 SERIES BIG GUNS -- 24° TRAJECTORY"
100 T TAPER BORE NOZZLES
NOzzs
Nozzle
wozzle Nozzle
vozzre I Nozzle
NoWe mzVe
Noz: a NoUle
' 5'
"°
'3
35"
a"
?5" 3 -
! 0-
�S I
.
pm
CIA
GPM
CIA
GPM
1PM
]IA
GPM
:)IA GPM.cDtA
-GPM
=1A GP-,
:)IA GPM
:IA 3PM :::A
40 1
47
191'
S7
202•
ea
213' 76
z22' + 91
23W 103
247
116
250' 1311
259' 152
262 "•"_... .r
,300'
i0
S0
?^5'
3a
Z'5-
-s
7Z5 97
235'
100
245' 1 :;5
256'
'30
-55' 150
27,' 165
290' 204
80 I
55
215' (
69
Z2r I
81
240' ! 96
2W170
260' 1120
_ 277 I
143
2W r 164
266' [ 102
2W!.224 =3115�
70
50
225'
75
238'
9B
'a:.' 103
263,
120
275' 1 136
283'
155
295' !77
202' 197
3':' 243 330, ,
60 I
64
235' I
79
24a' {
. 94
2W 1110
273•
I 125
285' ! 146
.2W !
165
3W E 109
314' E 210
325' ! . s5S,___�.asap_j
'C
is
245'
33
255'
100
_'_' !17
783'
135
295- i 1.55
305,
175
315' 201
325' 223
335274 352' 1
100 [
72
255' I
87
268' r
100
2130' 1 123
293'
1143
- 305' [.10
316• !
185
325' j 212
335' ! 235
34W 20 »`:' W=
' 3
-5
295'
92
Z78'
"' '29
303'
•So
315' -7f
324'
195
335' i 222
344' 1 247
355' 304 380' 1
'AyallaOle dnty W11h
1'100 i1 SR100.
100 R RING NOZZLES
100 DN DIFFUSER NOZZLES
71 11NG I 77 Al'.G 91 RING 36 RING
1
39 RING
I
.93 RING
36 RING
1-5 ON 3.60N
�
.7.' 314 I
3-8DN
• GPM ]IA I GPM :-i GPM OIA G?M O!A �
aPM DIA
GPM 31A
GPM DIA
11 GPM DrA GPM OIA
GPM DIA I
:iP41 OtA
' :f} I °6y2:6 '8 ?'2 ?'. 2i' 't13�224 1
•18 235 1
134 238
'Fz 52 242
'I 45 t5s I 56 168
91 'H2 I
!1$ 19E
i 15p:�... 14.,220 Wr--st 22s�[010L1:: M1'SZ241=
'
a.3
' SC 41 23` =$ 7:3 '"0 245 '25 250 :
•a1 2'0 1
154 275 i
-93 290
'4 i
'+0 '00
'i3 2tE
30 1 ?s 255 _55 -27 2-5 '-15 "SS
163 300
tB9 305 1
2 11 3t5
'I - - -
99 265 _�>�>�.-275 �r��:..C.s
_
• '00 i :05 2`^ t2s _80 '42 295 -62 = I
'92 120
212 325
236 335
I
_ _
I'tT0~ r-ti4 275 `! 'y70`•290"�j"�1i4 .3R5 r`170 375 '
"'-19{. 325
` `
— — _—
' "ne Czamefer y tn:cw •s aoaroalmatew s°- <ess'o1 :15e 2t= _ eV.0" an91e, 55+ Bess nor IV
150 SERIES BIG GUNS - 240 TRAJECTORY"
150 T TAPER SORE NOZZLES
Nozzle
':ante
Nozzie
.Nozzle
NOzzie
Ndtzle
NOzzte ,
-
3"
3'
1 0" i
I I-
it
2•
: T
=51,
.GPM D1A
Sp1A
DIA
GPM
71A
GPM
DIA. 1
3?M
-IA
GPM
DtA,
GPM
]IA
50 I
100 250' I
130
270'
i 1e5
290'
205
310'
255
330'
3W
W. I
350
380'
- i0
110 255'
1.13
285'
I82
305'
225
325'
275
345'
330
365'
365
180'
70 !
120 M. [
155
300'
i 197
320'
[, 245
_
.... i..i40
295
360• [
3SIr [
415
395'
60
!213 290'
155
310'
210
335'
260
355' I
315
375'
380
345'
=-5
a10' '
90 [
133 31W !
175
32W
! 223
345•
�.-;
_
=..'3W �
'�i.S
3W [
e0S
110' [
47S
_
42S'-� •. j
r� I .00
-13 310'
'S5
]30'
235
355'
_
290
375'
355
sC0'
425
1N0
°00
i40' '
v, ! 110 I
150 320' [
195
340•
I 247
365•
"j" 3as
=__3esr ` {
3m
410• j
"S
430'
I
._ _
'!7 330-
?CA
350'
258
375'
320
395'
365
i2C'
165
440'
S15
150'
.'20
150 R RING
NOZZLES
.Ping
Pi—,
Ring
Ring
Ring
Ring
Amt;
!
35'
97-
1.DO'
i
1.16"
5,26"
1
1 34"
OSI. I
GPY ]IA.
GPM
DIA.
GPM
DIA
GPM
DiA
GPM
OIA
GPM
:)IA.
GPM
]SA,
i 50
100 245' 7
130
268'
I 1e5
M.
205
_. 300'
255
320'
300
335'
-w
350'
60 '
110 250'
143
Za01
ie2
300'
225
375'
275
335
330
350'
3e5
365'
70
120 270' j
155
290'
! 19T
310'
I 245
3:i0' [
295
350' [
355
365'
! 415
.3a0'_-_wl
a0
1129 2B0'
155
300'
2:0
32C'
250
3Q,
215
360' i
3B0
390,
- Aa5
IRS'
90 I
135 290' [
175
310-
! 223
330•
j_ 275
350- [
335
370' =
A05
390'
j 475
r405'­_:!
' 100 i
'43 3C0'
:45
32C
235
340'
290
360'
$5
383'
-25
400'
S00
415.
' It0 [
150 310' !
195
330'
247
350
-.. I 305
370' {
370
390' I
445
410'
[ -3iJ'
_
• 425'...•_.I
'20
3',5'
204
33!
258
360'
220
380'
B5
:CO'
-65
40'
i45
435"
"'x 0lameier OF ;nrow'f ao0roslmalelr 317 :ess Ior me 2"
:'alectcry anote.
200 SERIES BIG GUNS -- 270 TRAJECTORY"
200 T TAPER SORE NOZZLES
NOzzio
Nozzle
NoI:_'e
Npzile I
Nozzle
Nozzle
I NOW
'
1,1"
:,2
1 3' I
14,
• 5'
I 1.$
GaM DIA
GPM DIA,
OPM ='A.
GPM 71A
GPM PIA,
I GPM DIA.
I GPM PIA.
So. _-250 345'
295 .355'
.. a30_...375' ._
-...365 390'
44S .410'
_.
-0 I
270 260,
I 310 ISO,
355 235"
4t5 4f0'
480 430'
555 a50'
i $30 465'
.290 375'
L _ x1a 39s•."L�,3at3'."_
,41f3' -
..L445 430' - !
s1s _ 4a0 :
4.'.::590 -fro
.:;1- -_ SIM 4as
• 90
310 290'
350 at0'
405 125' I
175 445' 1
545 465'
625 495'
715 505
_
I 1M .,r
. 775 _, -. 400 ..�.r�'.'-77�-
_-
420'.i
,�25- f40' �.� .� 460 . �.
' 675 : 66tt ':j 300' `. lSi "-.'r�20
- 110 1
240 z10'
1 390 430'
any 150' I
525 470' !
605 495-
I 695 515,
1 790 535•
_
SD5' ;-
r.: i25 � _ S30'
- - 825 550'
- 130
310 -25'
425 4a5-
485 -55' 1.
565 -85'
555 515'
755 540'
I 960 560'
NOzIIa 140211e
1.75' 1 19"
GPM DIA. GPM Dik
525 -. 477 627c -
! 755 is$, 390 515'
855 535' IGO$ 555-
900 L mt0stswom
• 9A5 565' E 1110 590'
M': -, 5110" :. =:t1lV✓Q�eed�
7025 590' 1210 020'
200 R RING NOZZLES
t '.• Rmg
s '�- Rmg
1 'S- Pmg
i ' 1' Ring
i 10" Rmg
I -�" Ring I
2' Ring
1193' actuap
11.29' actuall
}5-L I GPM ]IA-
11 46' actuall
GPM DIA.
1156' actual)
GPM GtA.
1166 actuan
I GPM D1A. 1
ft.74' aCiUal1
GPM DIA.
;183 atitrall I
I GPM DIA, I
GPM OIA
' 30230__. _32Y._z,;
-
455'
30 25C 310'
330 370,
385 390' n45 410'
515 425'
585 440'
595
.70.=-��.:.270.355•.' r►J�SS11..:�465'.,:� '-4425'
-='C--630 "'
�•
. 90 I 290 370' I
380 s00'
145 420' l 515 4s0'
590A55'
�70'
I 675 I BO5 490'
100 I 325 390'
i--i10.-'•34C
A25 -15'
-455:.....r$06•�
Soo aa5• 1 575 455- f
660 480'
1 7c§ 500'
-
900 520'
am
120 1 355 410, +
155 445'
545 165' 630 a85' I
725 Soo,
.7DP...��y3
925 $20'
985 545'
130 - 3ro_"'Ei�
se1!•" + �s7D'"�' 655T '
75 '"`505
" few
L>13 <-
Tne diameter dt wow .s addrox.maiety 2% +ais for the 241 ••alaclory angle. 5% toss for the 21• sratectdry angle,
The BIG GUN= DerrormanC• Cal& has "n obtained
under weal test Conanlons and may to aarasely affected by wind. Door
nydrau',C ?rtlranco conditions
or Diner factors.
Nelson Ifrtgalydn Carodralmn nuues no reamsernation regarding broom condition.
uniformity. or
a0oticanon rails

Sequence Sheet For Liguid Waste Irri at'o
•
n
�J
I. Use soil sample report for nutrient recommendations and liming.
Example: Recommended in lbs./ac.
* N P205_ O Zn Cu Lime
20-40 '22:0-240,- 0 $ .7 Ton
2. Use Waste Analysis Report for nutrient availability and rate.
gxaxnRle: lbs. available/1.000 gallons (PA - Plant Available)
N P205 K_ 20 Z n Cu
2.5. 1.4 3.4 .02 .01
3. Calculate the amount of waste needed in gallons to supply a
certain nitrogen loading rate in lbs./acre.
Example: Calculate the gallons of waste needed to supply
40 lbs. of nitrogen/acre from the waste analysis
in item .# 2 above.
Gallons = lbs. nitrogen needed x 1000
lbs. nitrogen/1000 gallons
Gallons = 40 x 1000
2.5
Gallons = 16,000
4. Convert the gallons of waste needed per acre into acre inches.
Example: Use answer from item 1 3 above. (Given: one acre inch.'
Equals 27,154 gallons)
Acre Inches 16,00U
27,154
Acre Inches = .59
Nitrogen rate on soil report is a generic recommendation by crop
type. Suggested rate obtained from Waste Utilization Plan (WUP)
or technical specialist is dependent on crop type, soil type and
realistic yield expectation.

mmm

m
mm
mmm
m

sprinkler flow rate, gpm = from manMacturers data sheet based on sprinkler operating pressure and nozzle diameter
irrigation volume, gallons - no. of sprinklers operating x sprinkler flow rate, gpm x irrigation time, mins
irrigation area, acres = no. of sprinklers operating x sprinkler spacing width, ft x length, ft 43560
liquid nutrients applied, Ibs/ac = liquid nutrient analysis, Ibs/1000 gallons 1000 x irrigation volume, gallons
irrigation area, acres
% x 83.5 = Ibs/1000 gallons
ppm x .00835 = Ibs/1000 gallons
Ibs/1DD0 gallons x 27.154 = Ibs/acre-inch
IF

•
FoRNI lair l
Farm Owner
Irrigation Operator
I+n 1•iL11enl lit e.^uit'll 1•I:11kl,;
IIIw;rlroar 1`% nl•c kin 11rl�lt,wril I- It-M.;
Facility Number
Irn ation Time
Tract # Field Lagoon Date Crop Type Field Size Start Time End Time Total Number of
mm/dd/ r acres Minutes —Sprinklers O eratin

•
FORM IRR-2
Tract #
Field Size (acres) = (A)
Farm Owner
Owner's Address
Owner's Phone #
Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Field #
Facility Number
Irrigation Operator
Irrigation Operator's
Address
Operator's Phone #
From Waste Utilization Plan
Crop Type Recommended PAN Loading
(Ibracre) a (a)
r11 M r31 (4) r51 181 M r81 rAl fin% ..e.
Da;e
Irrigation
Waste Analysis PAN'
(W1000 gaq
PAN Applied
(lbtacra)
to) • (9)
1000
Nitrogen Balance
pb/acr4)
(M - 00)
Slert Tana
End Tkne
Total
MimAes
A of S Hiders
C{peretir►D
Flow Role
(gallmin)
Total Velurne
{gallons)
{B) ■ ts) • [4)
Volume
per Acm
{gavocre)
Z-
A
Crop Cycle Totals 1,
Owner's Signature
Certilied Operator (Print)
Operator's Signature
Operator's Certification No.
l NCDA Waste Anaylysis or Equivalent or NRCS Estimate, Technical Guide Section 633.
Enter the value received by subtracting column (10) from (8) Continue subtracting column (10) Irom column (11) following each irrigation event

AA
,13
76 p
4-
7-0,0
7.
.1 A
—re,
F"ACTICE MEETS UAW
()ERTIFfICATION MADE I)
J49
AND SPECIFICATION&

/ccntrol.
OPERATION AND MAINTENANCE PLAN
agoon is designed for waste treatment with minimum odor
The time required for the planned fluid level to be
reached may vary due to soil conditions,flushing operations, and
the amount of fresh water added to the system.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent runoff from the field or damage
to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see Attachment S)
before land application.
3. Begin pump -out of the lagoon when fluid level reaches eleva-
tion 50.3 as marked by permanent markers. Stop pump -out when
the fluid level reaches elevation 48.3 or before fluid depth is
less than 6 feet deep (this prevents the loss of favorable
bacteria) .
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.4
inch per hour.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand_
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
B. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

AGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
685.0 171.0 117135.0 square feet
Buildings (roof and lot water)
Length * Width =
0.0 0.0 0.0 square feet
TOTAL DA 117135.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume = 626400 Lbs. 55LW * CF of Waste/Lb./Day * 180 days
Volume = 152971 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
160 days excess rainfall - 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 68328.8 cubic feet

►ne naylor County: SA2PSON
nearest residence (other than owner):
STEADY STATE LIVE WEIGHT
Date: 03/18/92
2000.0 feet
IT 0 sows
(farrow to finish)
x 1417
lbs.
= 0
lbs
1200 sows
(farrow to feeder)
x 522
lbs.
= 626400
The
head
(finishing only)
x 135
lbs.
a 0
lbs
sows
(farrow to wean)
x 433
lbs.
0
The
0 head
(wean to feeder)
x 30
lbs.
0
lbs
TOTAL STEADY STATE LIVE WEIGHT (SSLW) = 626400 lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 626400 lbs. SSLW x Treatment Volume(CF)/lb. SSLW
Treatment Volume(CF)/lb. SSLW= 1 CF/lb. SSLW
Volume = 626400 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet ; "Owner requests no sludge storage.
Sludge will be removed as needed."
4. TOTAL DESIGN VOLUME
Inside top length 685.0 feet ; Inside top width 171.0 feet
Top of dike at elevation 52.0 feet
Freeboard 1.0 feet ; Side slopes 2.5 : 1 (Inside lagoon)
Total design lagoon liquid level at elevation 51.0 feet
Bottom of lagoon elevation 41.0 feet
Seasonal high water table elevation 42.0 feet
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
2.5 2.5 2.5 2.5 680.0 166.0 10.0
AREA OF TOP
LENGTH * WIDTH =
680.0 166.0
AREA OF BOTTOM
LENGTH * WIDTH =
630.0 116.0
112880.0 (AREA OF TOP)
73080.0 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
655.0 141.0 369420.0 (AREA OF MIDSECTION * 4)
CU. FT. = KAREA TOP + (4*AREA MIDSECTION) + AREA BOTTRMO * DEPTH/6
112880.0 369420.0 73080.0 1.7
VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 925633 CU. FT.

i year - 24 hour storm
Volume = 7.0 inches / 12 inches per foot * DA
Volume s 68328.8 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
152971
cubic
feet
5B.
0
cubic
feet
5C.
68329
cubic
feet
5D.
68329
cubic
feet
TOTAL 289628 cubic feet
6. SUMMARY
Total required volume 916028 cubic feet
Total design volume avail. 925633 cubic feet
Min. req. treatment volume plus sludge accumulation 626400 cubic feet
At elev. 48.3 feet ; Volume is 636112 cubic feet (end pumping)
Total design volume less 25yr-24hr storm is 857305 cubic feet
At elev. 50.3 feet ; Volume is 847651 cubic feet (start pumping)
Seasonal high water table elevation 42.0 feet
7. DESIGNED BYAPPROVED BY:
DATE:�r ��•�--i� ��l— DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN

OPE LATION & MAIN'i ENANCE PLAN
rroYer lac;1cn liquid rnanagemen, shcOuid `e ayear-round prfafitJ. it is BSpP.,_ia:ly
important to marlatre levels >o :F,at da not ha%e problems dU~.,g extenred ra riy a-:d
v.,et Opri[7r�5.
zxi' u q stor2c? capadiy 5i"ko'-dd be available the lagoon sor pT, ivd5 whe'i � :he
rece't in. crop IS dormant (such as v.'Inteiiiine for bermudagrass) or when there are
exterloed rainy spells such as The thunderstorm season it the Summertime. This means
ilia; at the 'f-St 51-nS 41 oiZnt g-O'Alh in the later win`er✓,Rariv spring, Irritation, according td
a i'ar.m, waste-nanagernert pear, should be done W„arla'.'er ;pie Tana is dry e,10L!ah :o
receive lagoo,- ilou*d. This iNlli mare s:Ura?e apace in the lagoon for future wet
pericds. .1r, ti^.e late summer/early faah b.he lagoon should be purnped ootrn to the low
marker (see Figure 2-1) to aliow for , inter storage. tvFry effort should be made to
maintain th,e lagoon close to the minimum liquid ievel as !or.- as the weather and %va_Sie
utilization plan ailow it.
;�=lttr:g U^tll `.lie 12goon has reached its miiaximurn sto.a�2 capaci before stZ.i:tls? :.
1-rigate Csoe= not leave hooch. i.^.' S'a:irr� oXC?5> 1\'fit?- dl ri 1� ��t'?f dFd v�'pt?-17d5.
oVe''low from the lagoon for any ro�;_c on =Xe;i a 77-+'=cr 2A-hour storm is a vin, 'a:Ion or
state lay`' and subject tc penalty actin-;.
Ti,e routine-nainterhance of a lagoon involves the following:
Maintenance of a Vegetative, cove, toi' the dam.
reSCUe Or C0r7-im0:1 bermudagrass are the most common vegetative
covers. The vegetation should be fertilized each year, if needed, to
maintain a vigorous stand. The arnourli of ;e-t'ihzer applied should b4
based on a soils tes'., bui in the event that it is not practical to obtain
a soils test each year, the lagoon embankment and surrounding areas
should be fertilized with 800 pounds per ac-e of 10-10-10, or
equivalent.
Brush, and trees or the embarkment r L-.;t be controk-2d. This rna'. be
dor..,e by moxving, spraying, grazing, chopp- ' -, Or a Ca'lI . ctlOil "i
these practices. T' is si ouldbe done at least once a year arid
possibly tlrvice in Years th-,t weather con&tion.5 are tavoraJl2 for
heavy vegetative crow,l1_
N07E if vegetation is controlled by spraying, the he-bicide must not be allowed to enter
the lagoon water. Such Chemicals could alarm the bacteria in the lagoon that ere treating
I
he w2;Ee.
Malntena,,ce inspections of the entire lagoon, should bi mace du-i,ng tl-e initial filling of
t`-te lagoon and at least monthly and aster major rainfall and storr-) events. Iteril; to he
checked should include, as a minirrl'arr, t1he follo,.%'ing:
Waste Inlet does, Recycling Pipes, and Overflow PlPes—look for:
1 . separation of Joints
2. cracks or breaksRFIC"CEIVED
3. accumulation of salts or rrirlera!s �'P�, � . overall coriditi�!-i of pipes 0, 19q
WATER QUALITY- Shy 11=i,r-1

Lagoon surface---l(.0, foi :
i. undesirable vegetative grooh
�. floating or lod'ged debris
Embanknient---look for:
1 . settlement, cracking, or "jug" holes
?. sid? 51ope 5tabiliiy---sii^nps or �; ses
3, wet or damp area_ on the back s;ope
4, erosion due to lack o{ vegetation or as a res,;,t of wave action
K. rodent da:r.ase
Larger lago0r!s may be subject to liner damage d: ;e to vwavec,'iC.; cause-3 by strong
':rincs. These
hese waves can erode the lagoon sidewalfs, thereby wea'Fenip" t'le lagoon darr..
A good stand of vegetation will reduce the potentia' dar-age caused by wave :.coon. if
'wave action causes serious damage to a lagoon sidewall, baffles in ►;;q'agoon may be
:5p'd to reduce the wave irnp2cts.
env oI the5a features could lead to erosion and w'eakenR-^c o tie damn. tr v o u r Ia;Don has
any of these features, you should call an appro-hate exper, rami::ac wit`) desKh art
C'? S;riJCttG^ of wage lagoons. You may need M pr^vide a temporary fix iir there is a throat
of a v-aste discharge. However, a permanent 5olu,ion should b-- revsewed by the
technical expert. Any digging Into a lagoon dam with heavy equiprn�-nt is a serious
underaking w;t:i potentially serious consequences and should not oe cor.d+:!.-�tzed unless
recommended by an appropriate technical expert.
Transfer Pumps --check for proper operation of:
1 . recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusu:-flq loud or grinding
noise, or a large amount or vibration, may indicate that the pump is in r:fed or repair or
rep'acernent.
NOTE: Pumping systems should be inspecte� and operated frequently enough so that you
are not completely "su-prised" by equipment faifure. You should Narform your pt,rrping
system. rnairfter:anee at a time wren your lagoon is at its low level. T.-:Is will allow some
sa_e!y lime vic_; id rnajor repair be requ;red. Having a nearfv ful! ;agoon is riot the t;.rne
tc think about switching, repairing , or bcrrox%!i�:g pumps. Probably, if your lagoon is full,
your neighbcr`s lagoon is full also. you Should consider mainta:rwi iz an inventory of Spare
part3 or pumps.
Surface water diversion features are designed to carry 211 surface
drainage wa}ers (suck as rainfall runoff, roof drainage, gutter out=ets,
and parking lot runoff) away iromt your lagoon and c'ner waste
treatment or storage structures. T Fe only waver Char. should be
coming from your lagoon is that -which comes frorr yo,:r flushing
rwas7ing1 system pipes and the rain.a`.f chat hits the �aaoon directly.
YOU Should in-spect your system for -he fo,l���irla:
1. adeq:jate vegetation
2. diveer5ion cap?city
I., -i6ze berm r.e-I-ht

identified problems should be comer;tied promptly. It is a-'vi5able to i7spect your system
during or immediately iollowing a heavy rain. If technicii assiytanc{_ is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is predicted, and then
record the level again 4 to 6 hours artier the rain rassurmes there is no Dumping). This wIII
give ,you an idea of how much your 1220C:n level rise tivith a czrtai-, rainfall arnount
{you must also be recordin5 your rainfall for this to work;. Knowing tnis should help in
planning irrigatici q applications and storage. If your lagoon rises excessively, you may .
have an inflow problem from a sul ace water diversion o- t')ere may be seepage Ii,to illy
lagoon from the surround;n; land.
Lagoon Operation
Startup:
i . imrnediately aver construuion establish a '.orrip-ste :o:l cover on b2, e soil
surfaces to avoid eresior.
�. FJ1; ,"haw lagoo:Z design volume a, least hat'' ..j:l of wafer be, -Ore
was`.e load-ng begins, takir?o rare. not ro erode ll.n.ing or bank slopes.
Drainpipes into the lagoon should have a flexible pipe extender on the
end of the pipe to discharge near the bottom of the la;aon during initial
filling or another means of slowing the incoming water to avoid erosion of
the lining.
;. When possible, begin loading new lagoons in the spring to maximize
bacterial establishment (due to warmer weather).
S. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 ,percent of the full lagoon
liquid volume. T' is seeding should aCcoU at least tA!o weeks prior to the
addition of wastewater.
6. Maintain a periodic check ,n the lagoon hquid pH. ;f the pH falls below
7.0, add agricultu-21 lim-2 at the rate cf 1 pound per '000 cubic feet of
lagoon liquid volume u-,,till t`le pH rises above 7.0. Oot;rnurri lagoon llc:Jd
pH is between 7.3 and 8.0.
7. A dark color, licit cf bubbling, arc excessive odor si_nais ir;adpquate
biological activity. Con5ul?anon with a tecn.iical specia`ist is recomMe"IC!e`�
if these conditions o_c-ur for perim2s, espec'all y during the 'rearm
s�asor..
Loading:
The more frequently and regular y t^at wa]inwzter is aCced to a lagoc-n, t� e bet'er !.he
lagoon wlil function. Flush sy.te.is t ,Izt 1tiaSn wasie Into 'he lagoon several tirn?s dally are
O�l:l7t� ;i for treatme^t. Pit recharge systems. In which cne or more nuildinES are drained
and recharged eaczl clay, al'o wo..-: v ell.

Management:
Pfanic:e water consl.rvation--m:nimize building +eater usage and
,pillage from Leaking watererc, broken pipes and wandown through
proper mamlenar'Ice ar,d waver cons+erva,ion.
'vlinirr ize teed vvasiage anj spi-Ilage by keeping feeders a_-�jU5'ed. Tnis
vti i k ri— e the amo'ura of solids erttering tr''_' la_ccn
Mal. 'air, lagoon ill JiO leviO beVwe2^ the F-rrnane-^t 5-Orage level an
the fL!!l temparary 5"C'rage level.
i'la:e visible r;,arkers or stakes on the !aeoon bank to show ti-e
rn'Mumurn liquid. level and the.maxirnum liquid iever (Fig'_:re 2-1 ).
_a='t irrigating ai the earliest possible Gate in the spring based on
r:'Jtne,-It n?quiremen*; and soli moisturethat to N �a 50 that :� .:.. : �
will be maxim zed for the sur` mer blunders:orm. SEasz,-. SI^tilcri`',
ir'iaa:e in the late 3.;rr;M-2reear v Tai, to provide max;m.urri la--oor,
stc,rage ror the wi:.ter
The lagoon hquid level ..-'hind never be closer than 1 toot to the icwest
point of the darn or en.�_-ankrnent.
Do not puma the lagoon liquid level lower that the permanent storage
level un!es5 you are removing sludge.
Locain Moat pump intaFe5 approximately 18 inches undern,ea-h the liquid
s::;zace and as far away frorn the drainpipe inlets a= possible.
Prevent additions of wedding materials, long -stern -med forage or vegetation,
moluad feed, pl -tic syringes, or other foreign rnateria!s into the lagoon.
Frequently remove solids from catch basins at end of conf.-nement houses or
Yti'fi?reVEr they e.'e ir;;,alled.
ti;aint2in and varrr,:w c2ntroi near lagoon e4-es
Do riot a!iIc ' trees or ;arge_ bus`"eS to gro%v or. le2r'O . -3,m or emhankrne~ot.
ReMove sludge iron_ the laQoo either VV,`)en the slL:dge storage capacity !S
toil Or lJetOre lE ?ills ]Q �!?rcant Gt the Pe.m-anen' _,'.! a� volume.
±� animal produc:ion is fo be tQrmina'ed, jr e ownEr is respo':sib,e for
obtalnino a,-d Implementing 2 C!c5ure p.zn to ?!Ir ir'ct? the po-5lbility 01 a
Pollutanz d:3charge.
Sludge Removal:
Rate oi lag,con sludge hu:idup can be rQr�:'uced b'�:

to
m
al
rk
�I•
•�1
� ui�
t1' ..
it
_tiiil
���ii
�`U
C) al
.r o,
�-
lu
... .�• t�
1„
a,
6i,.17
�U ,tt
441
r.p
to 1.
Ci
cu
,Vvia
,V
-
till
,hf
ell
3;
U...
W rb
•�
ri (1, c .
n n Ic
ao
'�
Za
cii X-
L
ci
ri y �u
'1? =i ��
et)
ni
^'
:) toIV
0 �u
C. ua
��
w ts,
ra
`� F: �u
`r
ti
t0 0
c_ -
� 1 OF
c�
t3
bil
ru
:7 C.-�� i!
a►,
CIO
cz
�D 11,
uiti
_.l 01 7 u,
T two

r�
Waste Utilization Plan Agreement
10.40,11:11
1.20�N€��
Name of Farm o 7,.vAl 4,f -Se✓
Owner/Manager Agreement
k2- 0���
Uwe understand and will follow and implement the specifications and the operation and maintenance procedures
established in the approved waste utilization plan for the farm named above. I (we) know that any expansion to the
existing design capacity of the waste treatment and storage facilities will require a new certification to be submitted
to the Division of Envirpnmental Management (DENT) before the new animals are stocked. I (we) also understand
that there must be no discharge of waste nutrients form this systems to surface waters of the state from a storm
event less severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm office and at
the office of the local Soil and Water Conservation District and will be available for review by DEM upon request.
I (we) understand that I trust own or have access to irrigation or other equipment, to land apply the animal waste
described in this waste utilization plan_ This equipment must be available at the appropriate pumping time such
that no discharge occurs from the lagoon in a 25-year, 24-hour storm event. l also certify that the waste will be
applied on the land according to this plan at the appropriate times and at rates that no runoff occurs.
Name of Facility Owner (Please Print):
Signatur - Date d 2 Z
Name of Manager ( if different than owner)
Signature - tJ Date D Z Z-
Person Who Prepared Waste Utilization Plan:
Affiliation Co eq 4LIze 'jz Erg% s .Phone No. 9i a .54.2- 71 L /
Address
Signatu Date 7
NRCS, NC
JUNE. 1996
l

TO: Sonya L. Avant
SUBJECT: Nitrogen Rate On Small Grain Overseed
PERMIT APPLICATION #: 82-0445
In regards to the 901bs. N/Acre in Mr. Naylor's plan, I hope the following
explanation is appropriate. Having worked with the Cooperative Extension Service for 25
years and evaluated rye overseeds on bermuda grass, I recognize that a 50 lb. nitrogen rate
will not produce -a crop suitable for hay or grazing. However, I wanted to comply with
NRCS technical recommendation of the 50 lb. rate. At the second guidance compliance
meeting at James Sprunt Community College, I asked if it would be appropriate to
subtract part of the nitrogen from the bermuda grass requirement, and add this portion to
the rye overseed, so that a suitable crop could be grown. The answer I was given was yes,
as long as the total nitrogen rate did not exceed what the NRCS computer program
generated.
The NRCS computer program has a inadequacy in subtracting a nitrogen rate in a
double crop situation and adding this back to a following crop. I refer you to an enclosed
paper out of an NCSU forage production guide that I was using at the time. Note that
2500 to 5000 pounds of dry matter yiel&per acre were obtained during cool season for
winter rye or Italian rye grass. The reduction in yield of coastal bermuda grass as a result
of overseeding varied from 1200 to 2500 pounds per acre. Therefore, I subtracted a
calculated portion of nitrogen from the bermuda grass due to this reduction in yield of
bermuda and added this to the rye overseed in order to produce 3000 pounds of dry
matter yield at a 60 lb. PAN/ton. NRCS`s computer program calculates the nitrogen on
Bermuda as though it were a single season crop with no yield reduction as a result of an
overseed. If you use NRCS's computer program to determine a nitrogen rate on a
wagram soil type, you will find that their total nitrogen rate is the same as I have included
in Mr. Naylor's plan. Mr. Naylor's plan certainly reflects more closely the plant's actual
nitrogen requirement.
Thank you for your attention to this matter.
Respectfully,
LD-,- 14j4--,A)
Dan Bailey
Technical Specialist
November 15, 1998

i
+' OVERSEEDING BERMUDAGRASS
WfRYE, RYEGRASS
Overseeding. The grazing season can be lengthened by overseeding
bermudagrass with a winter annual grass such as rye and ryegrass
(Fig. 10) or a legume such as crimson Glover. In recent studies, dry
matter yields of 2,500 to 5,000 pounds per acre have been obtained
during the cool season from winter rye or Italian ryegrass, depending
on the management systcm. The higher yields were obtained when
the »inter annuals were cut for.hay. The reductions in yield of
Coastal as a result of overseeding, varied from 1,200 to 2,500 pounds.
Higher net yields were obtained from utilizing rye rather than rye-
(;rass. Some problems are yet to be resolved in overseeding bermuda-
grass, but the practice is desirable under certain conditions. In areas
«•here bermudagrass is the only pasture species available, 25 to 50
percent of the acreage may be overseeded with winter annuals in or-
der to provide supplemental grazing during periods when bermuda is
dormant (Fig. 11).
Two bushels of rye per acre planted in October and fertilized with a
complete fertilizer is suggested at the present time. When over -
seeding bermudagrass hay fields with winter annuals, it is important
that the bermuda be clipped to a stubble height of 3 inches or less.
Bermuda that has been used primarily for pasture will tend to have a
th:ckcr sod than under hay management. Therefore. grazing to a
height of I Lo 2 inches is advisable prior to overseeding.
Overseeding may be accomplished by using a sod -seeder -or a grain
drill, if the grass has been grazed to an inch or less and soil conditions
permit proper penetration of the seeding implement. In other cases a
light dislcing'may be required prior to seeding with a grain drill or
broadcast sc--der.

Operator:wayne naylor County: SAMPSON Date: 03/18/92
Distance to nearest residence (other than owner): 2000.0 feet
1. STEADY STATE LIVE WEIGHT
0 sows
(farrow to finish)
x
1417
lbs.
W 0
The
1200 sows
(farrow to feeder)
x
522
lbs.
626400
lbs
head
(finishing only)
x
135
lbs.
a 0
lbs
sows
(farrow to wean)
x
433
lbs.
0
lbs
0 head
(wean to feeder)
x
30
lbs.
g 0
The
TOTAL STEADY STATE LIVE WEIGHT (SSLW) - 626400 lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume - 626400 lbs. SSLW x Treatment Volume(CF)/lb. SSLW
Treatment Volume(CF)/lb. SSLW- 1 CF/lb. SSLW
Volume - 626400 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume 0.0 cubic feet ; "Owner requests no sludge storage.
Sludge will be removed as needed."
4. TOTAL DESIGN VOLUME
Inside tap length 685.0 feet ; Inside top width 171.0 feet
Top of dike at elevation 52.0 feet
Freeboard 1.0 feet ; Side slopes 2.5 : 1 (Inside lagoon)
Total design lagoon liquid level at elevation 51.0 feet
Bottom of lagoon elevation 41.0 feet
Seasonal high water table elevation 4 :0 feet
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
2.5 2.5 2.5 2.5 680.0 166.0 10.0
AREA OF TOP
LENGTH * WIDTH =
680.0 166.0
AREA OF BOTTOM
LENGTH * WIDTH =
630.0 116.0
AREA OF MIDSECTION
LENGTH * WIDTH * 4
655.0 141.0
112880.0 (AREA OF TOP)
73080.0 (AREA OF BOTTOM)
R;F(C"tF
1 1999
WATER QUA3 l i Y SECTION
Non -Discharge Compliance '`nf.
369420.0 (AREA OF MIDSECTION * 4)
CU. FT. _ AAREA TOP + (4*AREA MIDSECTION) + AREA BOTTOMO * DEPTH/6
112880.0 369420.0 73080.0 1.7
VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL - 925633 CU. FT.

.ri� - . �C11KKLlLL J_wyw�+!
s•
t
5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
-68610 __7135.0 square feet
1 19,0 ! 1
Buildings (roof and lot water)
Length * Width -
0.0 0.0 0.0 square feet
TOTAL DA 117135.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume = 626400 Lbs. SSLW * CF of Waste/Lb./Day * 180 days
Volume = • 152971 cubic feet
5H. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day *
Volume = 0.0 cubic feet
180 days storage/7.48 gallons
per CF
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 7.0 inches
Volume - 7.0 in * DA / 12 inches per foot
Volume - 68328.8 cubic feet

5D. Volume of 25 year - 24 hour storm
Volume = 7.0 inches / 12 inches per foot * DA
Volume = 68328.8 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 152971 cubic feet
5B. 0 cubic feet
5C. G'39.20 68329 cubic feet
5D. 698Z0 6832 cubic feet
Z926tI
TOTAL 289628 cubic feet
6. SUMMARY
419OI I
Total required volume 916G2 cubic feet
94+-6 24Z
Total design volume avail. 925933 cubic feet
Min. req. treatment volume plus sludge accumulation 626400 cubic feet
At elev. 48.3 feet ; Volume is 636112 cubic feet (end pumping)
Total design volume less 25yr-24hr storm is 857305 cubic feet
At elev. 50.3 feet ; Volume is 847651 cubic feet (start pumping)
Seasonal high water tab a elevation 4;%0 feet
7. DESIGNED BY: APPROVED BY:
DATE: 3 S DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLANE
R