300003_PERMITTING_20171231

4�VA
NCDENR
North Carolina Department of Environment and Natural Resources
Pat McCrory
Governor
Henry L Walker
Henry Walker Farm
1493 Godbey Rd
Mocksville, NC 27028
Dear Henry L Walker:
John E. Skvarla, III
Secretary
October 1, 2014
Subject: Certificate of Coverage No. AWC300003
Henry Walker Farm
Cattle Waste Collection, Treatment,
Storage and Application System
Davie County
In accordance with your renewal request, we are hereby forwarding to you this Certificate of Coverage
(COC) issued to Henry L Walker, authorizing the operation of the subject animal waste management
system in accordance with General Permit AWG200000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for Henry Walker Farm, located in Davie County, with an animal capacity of no greater
than the following annual averages:
Dairy Calf: Dry Cow: Beef Brood Cow:
Dairy Heifer: Beef Stocker Calf: Other:
Milk Cow: Beef Feeder: 300
This COC shall be effective from the date of issuance until September 30, 2019, and shall hereby void
Certificate of Coverage Number AWC300003 that was previously issued to this facility. Pursuant to this
COC, you are authorized and required to operate the system in conformity with the conditions and
limitations as specified in the General Permit, the facility's CAWMP, and this COC. An adequate system
for collecting and maintaining the required monitoring data and operational information must be
established for this facility. Any increase in waste production greater than the certified design capacity or
increase in number of animals authorized by this COC (as provided above) will require a modification to
the CAWMP and this COC and must be completed prior to actual increase in either wastewater flow or
number of animals.
Please read this COC and the enclosed State General Permit carefully. Please pay careful attention to the
record keeping and monitoring conditions -in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record keeping forms.
If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
1636 Mail Service Center, Raleigh, North Carolina 27699-1636
Phone: 9IM07-6464 1 Internet: http:/Jwmv.ncdenr.gov/
An Equal opportunity % Affirmative Action Employer — Made in part by recycled paper

I
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per NRCS standards a 100-foot separation shall be maintained between water supply wells and any
lagoon, storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition II.22 of -the -Genera I -Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Greenville/Spartanburg, SC
National Weather Service office at [phone], or by visiting their website at:
http://www.weather.gQK/gsp/
This facility is located in a county covered by our Winston-Salem Regional Office. The Regional Office
staff may be reached at 919-807-6464. If you need additional information concerning this COC or the
General Permit, piease contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
for Thomas A. Reeder
Director, Division of Water Resources
Enclosure (General Permit AWG200000)
cc: (Certificate of Coverage only for all ccs)
Winston-Salem Regional Office, Water Quality Regional Operations Section
Davie County Health Department
Davie County Soil and Water Conservation District
WQROS Central Files (Permit No. AWC300003)
AFO Notebooks

Beverly Eaves Perdue
Governor
CDENR
North Carolina Department of Environment and
Division of Vtilater Quality
RECEIVED
N.C. Dapk of EHR Dee Freeman
OCT 1 4 2009 } Secretary
Winston-Salem
Re9lonal Office
Henry L Walker
Henry Walker Farm
1493 Godbey Rd
Mocksville, NC 27028
Dear Henry L Walker:
Coleen H. Sullins
Director
October 1, 2009
Natural Resources
Subject: Certificate of Coverage No. AWC300003
Henry Walker Farm
Cattle Waste Collection, Treatment,
Storage and Application System
Davie County
In accordance with your renewal request, we are hereby forwarding to you this Certificate of Coverage
(COC) issued to Henry L Walker, authorizing the operation of the subject animal waste management
system in accordance with General Permit AWG200000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the Henry Walker Farm, located in Davie County, with an animal capacity of no
greater than the following annual averages:
Dairy Calf: Dry Cow: Beef Brood Cow:
Dairy Heifer: Beef Stocker Calf- Other:
Milk Cow: Beef Feeder: 300
The COC shall be effective from the date of issuance until September 30, 2014, and shall hereby void
Certificate of Coverage Number AWC300003 that was previously issued to this facility. Pursuant to this
COC, you are authorized and required to operate the system in conformity with the conditions and
limitations as specified in the General Permit, the facility's CAWMP, and this COC. An adequate system
for collecting and maintaining the required monitoring data and operational information must be
established for this facility. Any increase in waste production greater than the certified design capacity or
increase in number of animals authorized by this COC (as provided above) will require a modification to
the CAWMP and this COC and must be completed prior to actual increase in either wastewater flow or
number of animals.
Please carefully read this COC and the enclosed State General Permit. Please pay careful attention to the
record keeping and monitoring conditions in this permit. _Record keeping forms are unchanged with this
General Permit. Please continue to use the same record keeper forms.
1636 Mail Service Center, Raleigh, North Carolina 27699-1636
Location: 2728 Capital Blvd., Raleigh, North Caroiina 27604 one
Phone: [phone] FAX: [phone]B 1 Customer Service. 1-877-623-674 Nbhh Ci' ro l i na
Internet www.ncwatern.uality.org 1ntJlJ'�7fI
An Eoual Opporlunizy l Atbrmabve Action Employer Naturally si+'ys ` ally

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per.15A NCAC 2T .0105(h) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penaltie_s,_criminal.penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, then an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Unit for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition II.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Greenville/Spartanburg, SC
National Weather Service office at [phone], or by visiting their website at:
www.erh.noaa.aov/er/aW/
This facility is located in a county covered by our Winston-Salem Regional Office, The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at
[phone].
Sincerely,
for Coleen H. Sullins
Enclosure (General Permit AWG200000)
cc: (Certificate of Coverage only for all ces)
Winston-Salem Regional Office, Aquifer Protection Section
Davie County Health Department
Davie County Soil and Water Conservation District
APS Central Files (Permit No. AWC300003)
AFO Notebooks

W
Nutrient Management Plan For Animal Waste Utilization
03-27- 2009
This plan has been prepared for:
Walker Farms
Henry Walker
1493 Godhey Road
Mocksville, NC 27028
336-492-5556
This plan has been developed by:
Frankie Singleton
Daive SWCD
180 South Main Street
Room 313
Mocksville, NC 27028
336- 751-5011
Developer Signature
Type of Plan: Nitrogen Only with Manure Only
RECEIVED
N.G. Dept. of ENR
APR 0 6 2009
Winston-Salem
Regional Office
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance procedures
established in this nutrient management plan which includes an animal waste utilization plan for
the farm named above. I have read and understand the Required Specifications concerning animal
waste management that are included with this plan.
Z- :I /
L7 0
Signature (o er) D e
Signature (manager or producer) Date
This plan meets the minimum standards and specifications of the U.S. Department of Agriculture -
Natural Resources Conservation Service or the standard of practices adopted by the Soil and Water
Conservation Commission.
l
Plan Approved By: 3 a
'technical Specialist Si Date
----- -- -- --------------------- --- ---------------------------- ---------
530962 Database Version 3.1 Date Printed: 03-27-2009 Cover Page 1
RECEIVED 1 DENR I DWQ
Aquifer Protection Section
MAR 312009

Nutrients applied in accordance with this plan will be supplied from the following
source(s):
Commercial Fertilizer is not included in this plan.
Ul
Beef Liquid Slurry waste generated 487,500 gals/year by a 300 animal Beef (Feeder)
Liquid Manure Slurry operation. This production facility has waste storage capacities of
approximately 0 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
439
Incorporated
608
Injected
688
Irrigated
389
Max. Avail.
PAN (lbs) *
Actual PAN
Applied (Ibs)
PAN Surplus/
Deficit (lbs)
Actual Volume
Applied (Gallons)
Volume Surplus/
Deficit (Gallons)
Year 1 A
389
738
-349
925,550
438,050
U2 Beef Surface Scraped waste generated 690.00 tons/year by a 300 animal Beef (Feeder)
[Paved Surface Scraped Manure o ration.
Estimated Pounds of Plant Available Nitrogen Generated
Broadcast
6512
Incorporated
8992
Injected
N/A
Irrigated
NIA
Max. Avail.
PAN (lbs) *
Actual PAN
Applied (Ibs)
PAN Surplus/
Deficit (lbs)
Actual Quantity
Applied (Tons)
Surplus/Deficit
(Tons)
Year I
6,512
9155
-2,643
970.10
-280.10
This plan includes a User Defined Source to determine the total pounds of PAN in lieu
of NRCS Standard values. Refer to North Carolina Cooperative Extension Service publication AG-439-42
entitled "Soil Facts: Use of On -Farm Records for Modifying a Certified Animal Waste Management Plan" for
guidance on using on -farm records to develop a User Defined Source.
---------------------------------------------------------------------------------
Note: In source ID. S means standazd source. U means user defined source.
* Max. Available PAN is calculated on the basis of the actual application method(s) identified in the plan for this source.
305121 Database Version 3.1 Date Printed: 03-27-2009 Source Page Page 1 of 1

The table shown below provides a summary of the crops or rotations included in this plan for each field. Realistic Yield estimates .
are also provided for each crop in the plan. In addition, the Leaching Index for each field is shown, where available.
Planned Crops Summary
Tract
Field
Total
Acres
Useable
Acres
Leaching
Index (L1)
Soil Series
Crop Sequence
RYE
274
1-1
3.10
3.10
15.0
Appling
Fescue Pasture
5.2 Tons
274
1-2
3.10
3.10
15.0
Appling
Fescue Pasture
5.2 Tons
274
1-3
2.20
2.20
15.0
Cecil
Fescue Pasture
4.8 Tons
274
1-4
2.80
2.80
15.0
Cecil
Fescue Pasture
4.8 Tons
274
IA
300
3.00
15.0
Aonling
Fescue Pasture
5.2 Tons
274
IB
I2,00
12.00
15.0
Wedowee
Fescue Pasture
3.0Tons
274
2
23,00
23.00
15.0
Cecil
Fescue Pasture
4.6 Tons
433
1
21.00
21.00
NIA
Appling
Fescue Hay
5.4 Tons
9822
lA
16.00
16.00
NIA
Appling
FcscuePasture
5.1 Tans
PLAN TOTALS: 86.20 86.20
LI
Potential Leaching
Technical Guidance
Low potential to contribute to soluble
None
< 2
nutrient leaching below the root zone.
ZModerate
potential to contribute to soluble
Nutrient Management (590) should be planned.
leaching below the root zone.
r 10nutrient
High potential to contribute to soluble
Nutrient Management (590) should be planned. Other conservation practices that improve the soils
nutrient leaching below the root zone.
available water holding capacity and improve nutrient use efficiency should be considered
> 10
Examples are Cover Crops (340) to scavenge nutrients, Sod -Based Rotations (328), Long -Term
No -Till (778), and edge -of -field practices such as Filter Strips (393) and Riparian Forest Buffers
(391).
305121 Database Version 3.1 Date Printed 3/27/2009
PCS Page Page 1 of l
NOTE: Symbol * means user entered data.

The Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of cropland needed to use
the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient requirements, and proper timing of applications to
maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplied by manure or other by-products,
commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field in order to supply the indicated quantity
of nitrogen from each source is also included. A balance of the total manure produced and the total manure applied is included in the table to ensure that the plan adequately provides
for the utilization of the manure generated by the operation.
Waste Utilization Table
Year 1
Tract
Field
Source
ID
Soil Series
Total
Acres
Use,
Acres
Crop
RYE
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
(Ibs/A)
Comm.
Fert.
Nutrient
Applied
(lbs1A)
Res.
(IbslA)
Applic.
Method
Manure
PA
NutrientA
pplied
(lbs/A)
Liquid
ManuraA
pplied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
N
N
1000
gal/A
Tons
1000 gals
tons
274
1.1
U1
Appling
3.10
3.10
Fescue Pasture
5.2 Tons
8/1-7/31
173
0
0
Irrig.
1S
18.81
0.00
58.32
0.00
274
1-1
U2
Appling
3.10
3.10
Fescue Pasture
5.2 Tons
811-7/31
173
0
0
Broad.
75
0.00
7.95
0.00
24.64
274
1-2
Ul
Appling
3.10
3.10
Fescue Pasture
5.2 Tons
8/1-7/31
173
0
0
Irrig.
15
18.81
0.00
58.32
0.00
274
1-2
U2
Appling
3.10
3.10
Fescue Pasture
5.2 Tons
8/1-7/31
173
0
0
Broad.
75
0.00
7.95
0.00
24.64
274
1-3
Ul
Cecil
2.20
2.20
Fescue Pasture
4.8 Tons
8/1-7/31
160
0
0
Irrig,
15
18.81
0.00
41.39
0.06
274
1-3
U2
Cecil
2.20
2.20
Fescue Pasture
4.8 Tons
8/1-7/31
160
0
0
Broad.
75
0.00
7.95
0.00
17.48
274
1-4
Ul
Cecil
2.80
2.80
Fescue Pasture
4.8 Tons
8/1-7/31
1.60
0
0
Irrig.
15
18.81
0.00
52,67
0.e0
274
14
U2
Cecil
2.80
2.80
Fescue Pasture
4,8 Tons
8/1-7/31
160
0
0
Broad.
1 75
0.001
7.95
0.00
22.25
274
IA
Ul
Appling
3.00
3.00
Fescue Pasture
5.2 Tons
8/1-7/31
173
0
0
Irrig,
15
18.81
0.00
56.44
0.00
274
lA
U2
Appling
3.00
3.00
Fescue Pasture
5.2 Tons
8/1-7/31
173
0
0
Broad.
75
0.00
T95
0.00
23.84
274
IB
Ul
Wedowee
12.00
12.00
Fescue Pasture
3.0Tons
8/1-7/31
100
0
0
Irrig.
15
18.81
0.00
225.74
0.00
274
1B
U2
Wedowee
12.00
12.00
Fescue Pasture
3.0 Tons
8/1-7/31
100
0
0
Broad.
60
0.00
6.36
0.00
76,29
274
2
Ul
Cecil
23.00
23.00
Fescue Pasture
4.6Tons
8/1-7/31
153
0
0
Irrig
IS
18.811
OMI
432.68
0.00
274
2
U2
Cecil
23.00
23.00
Fescue Pasture
4.6 Tons
WI-7131
153
0
0
Broad.
100
0.00
10.60
0.00
243.72
433
1
U2
Appling
21.00
211.00
Fescue Hay
5.4 Tons
811-7/31
240
0
0
Broad.
150
0.00
15,89
0.00
333.79
9822
IA
U2
Appling
16.00
16,00
Fescue Pasture
5A Tons
8/1-7/31
170
0
0
Broad.
120
0.00
12.72
0.00
203.45
305121 Database Version 3.1 Date Printed: 3/27/2009 WUT Page Page I of 2

Waste Utilization Table
Year 1
Nitrogen
Comm,
Res.
Manure
Liquid
Solid
Liquid
Solid
PA
Fert.
(lbs/A)
PA
ManureA
Manure
Manure
Manure
Nutrient
Nutrient
NuIrientA
pplied
Applied
Applied
Applied
Req'd
Applied
pplied
(acre)
(acre)
(Field)
(Field)
(lbs/A)
(lbs/A)
(lbs/A)
Source
Total
Ilse.
Applic.
Applic.
1000
Tract
Field
1D
Soil Series
Acres
Acres
Crop
RYE
Period
N
N
N
Method
N
11al1A
Tons
1000 gals
tons
Total Applied, 1000 gallons
925.55
Total Produced, 1000 gallons
488.19
Balance, 1000 gallons
-437.36
Total Applied, tons
;, ,"' ,; .'
970.10
Total Produced, tons
"" r' • =_
0.00
Balance, tons
""s'
-970.10
Notes: 1, In the tract column, --- symbol means leased, otherwise, owned. 2. Symbol * means user entered data.
305121 Database Version 3.1 Date Printed: 3/27/2009 WUT Page Page 2 of

The Irrigation Application Factors for each field in this plan are shown in the following table. Infiltration rate varies with soils. If
applying waste nutrients through an irrigation system, you must apply at a rate that will not result in runoff. This table provides the
maximum application rate per hour that may be applied to each field selected to receive wastewater. It also lists the maximum
application amount that each field may receive in any one application event.
Irrigation Application Factors
Tract
Field
Soil Series
Application Rate
(inches/hour)
Application Amount
(inches)
274
1-1
Appling
0.45
1.0
274
1-2
Appling
0.45
1.0
274
1-3
Cecil
0.40
1.0
274
14
Cecil
0.40
1.0
274
1A
Appling
0.45
1.0
274
iB
Wedowee
0.45
1.0
274
2
Cecil
0.40
1.0
305121 Database Version 3.1 Date Printed 3/27/2009 IAF Page Page 1 of 1
NOTE: Symbol " means user entered data

17. A protective cover of appropriate vegetation will be established on all disturbed
areas (lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as
necessary, to protect the vegetation. Vegetation such as trees, shrubs, and other
woody species, etc., are limited to areas where considered appropriate. Lagoon
areas should be kept mowed and accessible. Berms and structures should be
inspected regularly for evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate
the possibility of an illegal discharge, pollution, and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a
regular basis to prevent breakdowns, leaks, and spills. A regular maintenance
checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops
for direct human consumption. However, if animal waste is used on crops for
direct human consumption, it should only be applied pre -plant with no further
applications of animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom elevations of
the temporary storage (pumping volume) of all waste treatment lagoons.
Pumping shall be managed to maintain the liquid level between the markers. A
marker will be required to mark the maximum storage volume for waste storage
ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the
rate -determining nutrient, unless other restrictions require waste to be applied
based on other nutrients, resulting in a lower application rate than a nitrogen
based rate. Zinc and copper levels in the soils shall be monitored and alternative
crop sites shall be used when these metals approach excessive levels. pH shall be
adjusted and maintained for optimum crop production. Soil and waste analysis
records shall be kept for a minimum of five years. Poultry dry waste application
records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for five (5)
years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
305121 Database Version 3.1 Date Printed: 3/27/2009 Specification Page 3

8. Animal waste shall not be applied to saturated soils, during rainfall events, or
when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that
the crop is not covered with waste to a depth that would inhibit growth. The
potential for salt damage from animal waste should also be considered.
10. Nutrients from waste shall not be applied in fall or winter for spring planted
crops on soils with a high potential for leaching. Waste/nutrient loading rates on
these soils should be held to a minimum and a suitable winter cover crop planted
to take up released nutrients. Waste shall not be applied more than 30 days prior
to planting of the crop or forages breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the
following: The outer perimeter of the land area onto which waste is applied from
a lagoon that is a component of a swine farm shall be at least 50 feet from any
residential property boundary and canal. Animal waste, other than swine waste
from facilities sited on or after October 1, 1995, shall not be applied closer that 25
feet to perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than
those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public
right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or
wetlands by a discharge or by over -spraying. Animal waste may be applied to
prior converted cropland provided the fields have been approved as a land
application site by a "technical specialist". Animal waste shall not be applied on
grassed waterways that discharge directly into water courses, and on other
grassed waterways, waste shall be applied at agronomic rates in a manner that
causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks,
etc., shall not be discharged into the animal waste management system.
305121 Database Version 3.1 Date Printed: 3/27/2009 Specification Page 2

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during operation
or land application. Any discharge of waste that reaches surface water is
prohibited.
2. There must be documentation in the design folder that the producer either owns
or has an agreement for use of adequate land on which to properly apply the
waste. If the producer does not own adequate land to properly dispose of the
waste, he/she shall provide evidence of an agreement with a landowner, who is
within a reasonable proximity, allowing him/her the use of the land for waste
application. It is the responsibility of the owner of the waste production facility to
secure an update of the Nutrient Management Plan when there is a change in the
operation, increase in the number of animals, method of application, receiving
crop type, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for
realistic crop yields based upon soil type, available moisture, historical data,
climatic conditions, and level of management, unless there are regulations that
restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year.
Waste may be applied to land eroding at more than 5 tons per acre per year but
less than 10 tons per acre per year provided grass filter strips are installed where
runoff leaves the field (see USDA, NRCS Field Office Technical Guide Standard
393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste application.
Waste should not be applied when there is danger of drift from the land
application field.
6. When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to
conservation tilled crops or grassland, the waste may be broadcast provided the
application does not occur during a season prone to flooding (see "Weather and
Climate in North Carolina" for guidance).
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such
that runoff does not occur offsite or to surface waters and in a method which does
not cause drift from the site during application. No ponding should occur in order
to control odor and flies.
------------------------------------------------------------------------------------
305121 Database Version 3.1 Date Printed: 3/27/2009 Specification Page 1

Crop Notes
The following crop note applies to field(s): 1-1, 1-2, 1-3, 1-4, 1A, 1B, 2
Fescue: Piedmont
Adaptation: Well -adapted.
In the Piedmont, tall fescue can be planted Aug. 20 to Oct. 10 (best) and Feb. 15 to Mar. 20. For
pure -stand broadcast seedings use 20 to 30 lb/ac., for drilled use 15 to 20 lb/ac. seed. Use certified seed to
avoid introducing weeds or annual ryegrass. Plant seed 0.25" to 0.5" deep for pure stands, 0.25" in
mixture with clovers. Soil test for preplant and maintenance lime, phosphorus, and potassium
recommendations. Apply 40 to 60 lb/ac nitrogen at planting for pure stands only. Do not apply N for
mixtures with clovers but use proper legume inoculation techniques. Apply 150 to 200 Ib/ac. N to
pure -stand fescue for hay production; reduce N rates by 25% for grazing. Apply N Feb. 1 to Mar. 20 and
Aug. 20 to Sept. 30, with equal amounts in each window. Refer to NCSU Technical Bulletin 305
Production and Utilization of Pastures and Forages in North Carolina for additional information or
consult your regional agronomist or extension agent for assistance.
The following crop note applies to field(s): 1
Fescue: Piedmont
Adaptation: Well -adapted.
In the Piedmont, tall fescue can be planted Aug. 20 to Oct. 10 (best) and Feb. 15 to Mar. 20. For
pure -stand broadcast seedings use 20 to 30 lb/ac., for drilled use 15 to 20 lb/ac. seed. Use certified seed to
avoid introducing weeds or annual ryegrass. Plant seed 0.25" to 0.5" deep for pure stands, 0.25" in
mixture with clovers. Soil test'for preplant and maintenance lime, phosphorus, and potassium
recommendations. Apply 40 to 60 lb/ac nitrogen at planting for pure stands only. Do not apply N for
mixtures with clovers but use proper legume inoculation techniques. Apply 150 to 200 lb/ac. N to
pure -stand fescue for hay production; reduce N rates by 25% to 50% for grazing. Apply N Feb. 1 to Mar.
20 and Aug. 20 to Sept. 30, with equal amounts in each window. Refer to NCSU Technical Bulletin 305
Production and Utilization of Pastures and Forages in North Carolina for additional information or
consult your regional agronomist or extension agent for assistance.
-----------------------------------------------------------------------------------
3o5121 Database Version 3.1 Date Printed: 03-27-2009 Crop Note Page Page 1 of 1

Reprogramming of the laboratory -Information -management system that makes this report possible Is being funded
through a grant from the North Carolina Tobacco Trust Fund Commission.
Thank you for using agronomic services to manage nutrients and ,safeguard environmental quality.
- Steve Troxler, Commissioner of Agriculture

..,.:.. ..- ..,...- f, -:; .. '.. „..i .. .. r, .: l u -_ .,a.. ,_: ... ..w. iW.n ,+. ar r.: -. �;.;9.v .3, .,..�,. „�. r.:. �- 1';�:v7 1 ",,W L' '�f'k5^. •b .JP.; 1iY' '1 f'•'b:- Xrv��
NCDA&CS n , o
gtnic'A
:�,:� , .♦ Grower, Walker, Henry Copies To:
Mocksville, NC 27028
Ys� . L k ail Soii Test Report Farm: 274
01/26/2009 SERVING N.C. RESIDENTS FOR OVER 60 YEARS Davie County
Agronomist Comments iz $
. •""••Y' -!k--::.,. i ...n. i.. :, ,�. -
Field,lniormatian _
[f :r,..7^l �.
.. .. " � E
w
lied>l:ime
.. - ... .. ,�J i-A ` ,e-�ry - Ke:.-,,
w N..R �..... .:.. t' ,? ��°; f:y r•.'':' xr ... � S^ ..,�i.5i" •..,3'.' 7 �i �yW�.y�t' ,�,i.',..
-k i' d , - alt..° �RF 4.i:,`,.E ":`' m' - rw.t'"5i£ai+' .i Y +'4[,li<', ,t-a<�.h"4
Recnmrnendationa ' 1 t.RI 1?w N '1
.,.......,._ ._..............r:;APP_._
.,...._.
r. rr - 2 r •��
.., ,_._.-. - ,-sEr�# s._,_4 ...tit:r,; "IV"�_
Sample No. Last Crop
Mo Yr T/A
Crop or Year Lime N P205 K20 Mg S Cu Zn B Mn See Note
F2
1st Crop: Fes/OG/I'im,M 0 120-200 2040 0 0 0 0 0 .0 0 12
2nd Crop: - Fes/OG/fim,M 0 120-200 20-40 0 0 0 0 0 .0 0 12
Test Results
Soil Class HM% W/V CEC BS% Ac pH P-1 K-1 Ca% Mg% Mn-1 Ma-AI(1) Mn-AI(2) Zn-I Zn-AI Cu-1 S-1 SS-1 NO3-N NH4-N Na
MIN 0.22 1,08 10.5 89.0 1.2 6.2 48 128 55.0 28.0 470 296 296 213 213 125 34 0.1
,':, 3.:.
Fieid lnformatlon
'A lied Lime
...::,1✓Y-ti:;k
,5,�.�',:
�Recontmendations,. �
v s
"Y�
;¢kr „�,,,...,. v....-:.�u..._..,�.n...L,..:.....ki."��_t�r��9...�1 ...'�'�t.bi...r�.,... I.a',H,.�sr-. sMN,.�',�o. ,. Yi �.i:,J�:W1�:.xA�.,t.1t•N h -.1e �' .."i.+!r��d�.Y'L�rM:S .,,.,..v11i..hv.+x . §:!'l _�..r ., .1. 'u �l. ��. .7LL., 1:: ..� hl rx
Sample No. Last Crop
Mo Yr T/A
Crop or Year Lime N P205 K20 Mg S Cu Zn B Mn See Note
FIB
1st Crop: Fes/OG/71m,M 0 120.200 10.30 0 0 0 0 0 .0 0 12
2nd Crop: Fes /OG/ Irn,M 0 120.200 10.30 0 0 0 0 0 .0 0 - 12
Test Results
Soli Class HM% W/V CEC BS% Ac PH P-I K-1 Cab Mg% Mn-I Mn-AI(1) Mn-AI(2) Zn-1 Zn-AI Cu-1 S-1 SS-1 NO3-N NH4-N Na
MIN 0.22 1.11 10.5 90.0 1.1 6.2 52 107 57.0 28.0 378 241 241 270 270 95 31 0.1
e., „tt
, .!.n.0
ld,,,
r�me
ln:.:i a..,.t.•. orsMn.
.d�
M,
,A .L... im_.i.,:.e
S.: •�'h anr.,wi.f
i,:: ,?sru.
�kFF-SS„.rs:.,'„a'.ij�`^. ..:,,-rtes?a f. 'k'1�, .,
''�.TiF,t,;,^.'•l'u.Te. u}i
ik,� r+rt � 5
„� +tr , ':A:
µ, r,"w<'i�e
•vatnf
,.1..-:...
.e�.,.
'XtiRe.commen
a..... rFe. ri
�,i4c,
,�,.. _..:t...
r ., ro.,�:..y�t r �rY-�.^,.. :c,.
),� dt';,,'-
.+_..,.r .,�'^%p'- .l,i.we.. v....::
�`kY
(, .,w
!.i.Y`..�" ].f.�x.�z,v;_�stfi y':' ary.�:�.' �i
r k'('C$��'9,r�,.fi'-.•4
.SeS' ..1��
nSt.r ,
.. >+',+��,f�:I,tl.t yr .1,��rx
.n.n,..:._, __ :.�,.."...,'''.H..R�..'. J'....�,ik+'.u.,S..,.»f.eAk.. ,`KAbJ.+f, b'.E,-.
Sample No, Last Crop
Mo Yr T/A
Crop or Year Lime N P205 K20 Mg S Cu Zn B Mn See Note
FIA
1st Crop: Fes/OG/r1m,M 0 120.200 50-70 0 0 0 0 0 .0 0 12
2nd Crop: Fes/OG/71m,M 0 120-200 50.70 0 0 0 0 0 .0 0 12
Test Results
Soil Class HM% W/V CEC BS% Ac pH P-1 K-1 Ca% Mg% Mn-I Mn-AI(1) Mn-AI(2) Zn-I Zn-AI Cu-1 S-1 SS-1 NO3-N NH4-N Na
MIN 0.22 1.08 9.9 92.0 0.8 6,3 34 119 58.0 28.0 346 220 220 120 120 90 40 0.1
'+._.,.-.
t # ;e i k i,;%:
Field`Iniormation
x
..
Lime:.
-T• ..x"CC' _ ,;;J..
,�f", Y!'a k�f ^w, #rs- b..,�.. r, yt.
'Re mm n q , a ;-
r a-._ ....... is Win''
.Applied
r.3 ,'
CO E (i$tiOnS �E �« _:r3rwr� 3 :.A �k f1 .�a a:'
?_, �L �' .><„.,
Sample No. Last Crop
Mo Yr T/A
Crop or Year Lime N P205 K20 Mg S Cu Zn B Mn See Note
Ist Crap: Fes/OG/rim,M 0 120-200 110-130 60-80 0 15-20 0 0 .0 pH$ 12
2nd Crop: Fes/OG/fim,M 0 120-200 110-130 60-80 0 15-20 0 0 .0 pI1$ 12
Test Results
Soil Class HM% W/V CEC BS% Ac pH P-1 K-1 Ca% Mg% Mn-I Mn-AI(1) Mn-AI(2) Zu-1 Za-AI Cu-1 S-I SS -I NO3-N NH4-N Na
MIN 0.22 1.14 14.3 94.0 0.9 6.5 11 32 62.0 31.0 269 171 171 50 50 80 21 0.1

:'._:: - ... :.i.:, .. :..-:,., ':i '- ,.... ........., ..,....... :... ..... r''-. - ;: ' r.m. . — — :•.. -:2 . 1 wrA: y-.. .fie.
•._..";?l i,"a l,q.�il..i. @Yl{L. * r, rxi '.� .., - ., •+i;YZlf,., ri""." �}...1
NCDA&C mic Divisio I �Y , ite:.www on i"Mfrg''Growerr`" gr; " x r Rio 22 �s �' m,P 2
P6one:,(9 9}733.2b55 Web s om.1,,�� ice Hoary Ite o t 553��
;� Y,, .Qcagr.g�!y/agr � :;; 4,� � .� ��
:,,f' tk
°.�l�leld"W6'tnatiou f�� w,+,
4..r it7_.:4'
A lied:Lime:i
F.';'FdTr .�:7. L.,. ✓ ...sJrj ,�ti'FY' �i�iT'�,r.s'�rty. yS' `�'r .. 'P.'ri':-1 �:� ..: g. t-. r..r ,�..M..._.°F ,y�. -%,
` Recominendatians
,:
Sample No. Last Crop
Mo Yr VA
Crop or Year Lime N Pa05 K?O Mg S Cu Zn B Ma See Note
112 1-D
1st Crap: Fes/OG/fIm,M 0 120-200 80-100 60-80 0 15-20 0 0 .0 pH$ 12
2nd Crop: Fes/0G/i'im,M 0 120.200 80-100 60-80 0 15-20 0 0 .0 pH$ 12
Test Results
Soil Class HM% W/V CBC BS% Ac pH P-1 ICI Ca% Mg% Mn-1 Mn-A!(1) Mn-AI(2) Zn-1 Zn-Al Cu4 S-1 SS-1 NW-N AWN Na
MIN 0.22 1,15 12.1 93.0 0.8 6.5 20 36 59.0 33.0 158 lo4 104 35 35 80 18 0.1
-..1,- „1., ,�Y'
k i . .- �.d_`•.:"'
Field information'Iced
� ': i'
Lime:::Recammendationa':
. r - ...x-- �.e •�v. :s
.741f. W r1', .i'°Y1-r. e Y.. •sl: '�,':
....::•• ha-+�•T �, �'•- Sl�ri�',�. � ;i. ' �s?' .Y' 3� 'iT
", � Pam.
" 1".�p 1 A*,.
�i*a-r
....._ ...,_
!"
.w_ ..._.
��
s,�.
.. _ ...._ �}��,y a xr3s > ��i
Lr1 .ra-•s: 1 .-+&'.'JaYk"i .D44.. zG k+e'`ia
Sample No. Lust Crop
Mo Yr T/A
Crop or Year Lime N PzOi K?O Mg S Cu Zn B Mn See Note
113 1-7
1st Crap: Fes/0G/r1m,M 1.4T 120-200 120-140 60-80 0 0 0 0 .0 0 12
2nd Crop: Fes/OG/rim,M 0 120-200 120.140 60-80 0 0 0 0 .0 0 12
Test Results
Soil Class HM% W/V CBC BS% Ac p H P-1 K 1 Ca% Mg% Mn-I Mn-AI(1) Mn-AI(2) Zn-I Zn-AI C04 S-1 SS -I NO3-N NH9-N Na
MIN 0.36 1.12 8.9 73.0 2.4 5.2 5 34 50.0 21.0 203 139 139 28 28 55 26 0.1
o rt h Carolina Reprogramming of the laboratory -Information -management system that makes this report possible is being funded
;• ti through a grant from the north Carolina Tobacco Trust Fund Commission.
Thank you for using agronomic services to manage nutrients and safeguard environmental quality.
- Steve Troxter, Commissioner of Agriculture
i III �;11.0 �•,1 Ti Ii-,i Fe iul rl&I III Ili N%is III

OF W A TF9 Michael F. Easley, Governor
Q William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
r Alan W. Klimek, P. E., Director
o �
Division of Water Quality
October 1, 2004 NJ OCT EHN
Henry L. Walker 0 1 2DO4
Henry Walker Farm Whist
1493 Godbey Road RegiOr I'sf
Mocksville NC 27028 office
1C@
Subject: Certificate of Coverage No. AWC300003
Henry Walker Farm
Cattle Waste Collection, Treatment,
Storage and Application System
Davie County
Dear Henry L. Walker:
On June 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on April 17, 2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Henry L.
Walker, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG200000. The issuance of this COC
supercedes and terminates your previous COC Number AWC300003 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Henry Walker Farm, located in Davie County, with an animal capacity of no
greater than an annual average of 300 Non -Dairy cattle and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this permit.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
Aquifer Protection Section -- Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, North Carolina 27699-1638 One
NorthCarolina
Phone: [phone] FAX: [phone] / Internet: h2o.enr.state. nc.us NatimallyAn Equal Opportunity/Affirmative Action Employer — 50% Recycled110% Post Consumer Paper

The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 21-1.0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Winston-Salem Regional Office. The Regional Office
Water Quality Staff may be reached at (336) 7714600. If you need additional information concerning
this COC or the General Permit, please contact J.R. Joshi at [phone].
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG200000)
cc: (Certificate of Coverage only for all cc's)
Winston-Salem Regional Office, Aquifer Protection Section
Davie County Health Department
Davie County Soil and Water Conservation District
Permit File AWC300003
APS Central Files

WA TF > Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
j r Alan W. Klimek, P. E., Director
Division of Water Quality
QC: pp 11r_
May 1, 2003 N.sC. Dept. Csf.F--HNR
Henry L. Walker MAY i 9 2003
Henry Walker Farm
1493 Godbey Road Winsttl l"-Sa jem
Mocksville NC 27028 Regionals Office
Subject: Certificate of Coverage No. AWC300003
Henry Walker Farm
Cattle Waste Collection, Treatment,
Storage and Application System
Davie County
Dear Henry L. Walker:
On April 28, 2003,. the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the Cattle Waste Operation General
Permit AWG200000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on April 17, 2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Henry L.
Walker, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG200000. The issuance of this COC
supercedes and terminates your previous COC Number AWC300003 which expired on April 30. 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste. from the Henry Walker Farm, located in Davie County, with an animal capacity of no
greater than an annual average of 300 Non -Dairy cattle and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until October 1,.2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required- monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
NN DENR
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Customer Service Center
An Equal Opportunity Action Employer
Internet httpJ/h2o.enr.state.nc.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/10% post -consumer paper

Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon.or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at Ieast 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county -covered by our Winston-Salem Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Sue Homewood at [phone] ext. 502.
Sincerely,
(/
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG200000)
cc: (Certificate of Coverage only for all cc's)
Winston-Salem Regional Office, Water Quality Section
Davie County Health Department
Davie County Soil and Water Conservation District
Permit File AWC300003
NDPU Files

. . .
� ^ ,
coo
Location: 1493 8odbe}~ Rd.
Mocksvi!|e WC 27028
Telephone: [phone]
Type Operation: Existing Beef Feeder -. 6 month
Number of A n i ma ;s: 300. ea 0O head `'--- -
WATER QUALITY SECTION
(Desi8n Capacity)
/\pR 1 7 2003
STORAGE STRUCTURE: Waste Storage Structure
APPLICATION METHOD: Broadcast Nor� -QiscUarp' erMW-
The waste from your anima| fac:( illy must be |and' app| ie� at a
specifi8d rate prevent po||utiori of surface wa-�er and/or
Sroundwater. The |ant nutrjents in the animai waste shou|d be use�
to reduce the ammunt of commercia� f e r t i � izer required for the crops
in the fie}ds where the was'e }s to be app|ied.
This waste uti(ization p|an uses nitrogen as the |imiting nutrient.
Waste shou|d be ana|yzerj before each app}icat|on cyc|e. Annua| so:1>
tests are st1-on3]y encoura3ed so that aI p|aotnatrients can be
baiayced for real }stic yie|ds of the crop to be grown.
Severa| factors are \mportant in imp|ement\ng your waste ut:!|\zaton
p}art in order to maximize the ferti|i7er va!ue of the waste and to
ensure that it is aPp|ied in an environmentally safe manner:
1. Always apply waste bas8d on the ner_;ds of the crop to be
grown an the nutrient content of the waste. Do not app|y
more nitro3en than the crop can uti|�ze.
2. Soii types are important as they have different infi|ation
rates, |eachin8 potent|a|s, caon exchange capacities, and
avai|ab|e water ho|din3 capacities.
3.Moe cha|I not be app/ied to� �and ero��nS at |ess
than 5 tons per acre Per year. Was-l-,e may be app||ed to |and
erodinS at 5 or more tons per acre annuay|y, but >ess than
10 tons per acre per year providing that adequate fi�ter .
str\ps are estab|}shed.
4. Do not app|y waste oo sa-11urat, ed soi|s, uhen �t is rainin8,
or when the surface is frozen. Either of these c�:codis
may resuit in ruoff to surfaCe waters which is not a|{owed
under DEM reSu|ations.

6 1
JJ��ii�y��T NIAI l�.i GTr 1 iT-r T'�- TT-0 i�! PC
,a I-1
i•[iH S !'i llL 1r'.i 1•RJ i 4 5J E 1 � 1 i� i 1 �_rl 'i Y- L1ti-�!
nir=7^i rrr�rrr�rr P7A�P7r�1J'rr�rP�J'1P71xPfPi TPx Ir'71�ilPrfiipippip riTPr!?Pri71'�f�7P�1"fifArftl!Y!'1�rA7r'�P?t�1Pri'rid!'7�?P?�Y(�h7�+7���,r'�f'i�r�yrxnr
5. µi i rsd con d it i on si"lira I d a I Si:' be ct_rns i det-- ed to a vo 1 ,, di i ft an'1
downw i r1d od'e; I•" pr"c,b 1 eirhs •.
T++ rfla::Iinl e t1€e +�Ii1e s :I €I tr iArhus t h Cr"r ri Frr-1:1r €14»t€1-11-h
and to reduce tine r+otent i a l for In I I ut i --n, tlhe was to shc.t11 r,
be al-rp i i e t+i a - r-r_rw i ng ci'-oi-i or a,£;rp l- i eia not more than0
days Pr I ctr" to p i art t I rtg a cr-oF, or for"ages great. i rh'` !JGrmancy.
In ject i ng the waste r:+r" rj I sa:: i ng w i I I conserve nutr i en€ s and
red-uce _-dcir p r o b I erns,
Tit i s P I an 1 s based :+n ti-te waste a.pp I i cat i on me vh od s1"1r:+wrt abiivI- . I f
you choose to ci"ha.n'ge rr.,e ttSods i ri the f u't ure, you need to rev i se V:€ i s
plan. Nutrient 1e'erels ft_rr- different appI icat i+:+rh methoids at-e not the
same.
T CI+W Lest i rn ate 1I a c r e5 rteede'-1 to ar.,p I y t1-he an i ma I wa s t e i' S uaSe . on
ty#rical rlutr-ien1 cc.ntent for- t;ii=_ type :If faci 1 ity. .Acreage
re yu i r-ements should be based on the waste ana. l ys i s 1-e�rrlr- t from om you -
waste management facility. in some rases you may want 11-o hcvve Fi l ant
..nu 1 yw i s madie, which cou l c all +:+w additional waste to `re app 1 i ed.
1=`r-oV i s i Gns shall be made for the at -ea r-ece i `+ i ng waste to be f 1 e;: i it I e
cc as 'to al:cr;+{imLi+_ia' e c"sar131rig waste anaiysia conterht any_ crE,p type.
L. i me- must i?e app l i ed to rfla i i-sta i n pH i n the _apt 1 mum r-ar€ e 'fir_+r" s�tec I f i c
c r r_' F'
This waste u t i l I ,w at i C+ri plan, If carried out, meets the requ i ramen t'"s
fOr- compliance with 1' <A NCAC: H .=i 17 adopted by t1"he En',° i r"+:inrrhenta l
llar€awe.11 f Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
: C) Ikea Z. _ tirria waste itea.+�.rjft Z. - i;f"ii!5
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
hear, .•; i =S ii�1: Il�au`VFa," - f)._r£_> I }�i'ir'ea'r
AiI? l y i rt g th e 3.tr+=rVe a.iri n l,$n t f 41-as t e € 5 a li I 3 y iII Sl"Iirll l r� 1` I a t € rrl e c3.riii
i:aVo a ri r(r r:+I::I' Eat G. F 1!1 i -rMC, t t4r ;7. +i.: 1 y ? e eLS'{ �' E r: t I il7c'. i ; rna.rhr€»'r' .
The f l to -wins act -ease w i 1 1 bs-' iheei:Ied f i-er- waste a. - I eatI +-n Grased on tii *
cr"+:rp k, J iris L "e?rwrs, il.r i ' tyFit= a.rlr_f s irfa.ce a.pp l i cat i on .
-+n; ;•r r.; 9•�r•rt•r ;; n3 i, ,.9yn�:.rrtr�n�ifA ,ah; };;�F 7`77P.
.. :: 1: :1 It rr ., '!i• 1

1,3
of
elplz 6tv'r
.! IAX
16
wc

sz�

rDavie County, North Carolina 95
TABLE S.--LAND CAPABILITY AND YIELDS PER ACRE OF CROPS AND PASTURE
(Yields are those that can be expected under a high level of management. Absence of a yield indicates that the
soil is not suited to the crop or the crop generally is not grown an the soil)
I
Map symbol and I
I
Land I
I I
I I
I I
I I
I I
! I
soil name Icapabilityl
Corn
(Corn silagel
soybeans
I Tobacco I
Wheat
I Grass- I
Pasture
I
I
1 I
I I
!legume hay !
I
I
Bu
_..
I Tons I
Bu
�
I Lba I
�
Bu
I Tons I
AUM*
I
AaA------------- 1,
E
iIw 1
125
I I
1 25 !
45
I I
I 2,800 1
55
I I
1 ---. 1
11.5
Altavista
f
ApB-------------I
I
IIe 1
95
I I
I 19 1
30 1
I E
2,500 1
45
I 1
1 4.6 1
6.0
Appling I
1
I I
I k
I I
I
ArA------------- I
I
VIw !
---
I I
I --- I
--- I
r I
--- I
---
I I
I --- !
6.0
Armenia I
I
I !
I I
I I
BuB------------- I
V1W I
---
I --- I
--- I
--- I
---
I --- I
3.0
Buncombe 1
I
I I
I
!
I r
I
CeB2------------ I
r
IIIe 1
115
I I
I 23 1
1
35 1
I
2,200 1
45
I I
1 4.5 1
7.5
Cecil I
I
I I
I
I
I -~ I
I
I
1 I
I
I
I E�
ChA------------- I
IVM 1
130
I 26 1
30 1
2,000 I
30
1 5.4 I
9.0
Chewacla
f
EnB------------- I
!
IIIe r
110
I I
1 --- I
I
30 I
I
--- I
40
r I
1 5.1 I
9.5
Enon 1
I
I I
I
I
I I
I
EnC------------- I
r
IVe 1
85
I r
1 17 1
I
25 I
!
--- I
---
I I
I 4.8 1
8.0
Enon I
E
I !
I
I
I I
I
Esc ------------- I
I
VIs I
---
I I
I --- I
I
--- i
I
--- I
---
I
I --- I
4.5
Enon I
1
I 1
I
I
I
!
can -------------I
I
VIa I
---
I I
I --- !
I
--- I
!
--- I
---
I I
I --- I
7.5
Gaston
GnB2------------!
I
IIIe 1
130
I I
1 25 I
I
35 I
I
--- I
50
I I
I 5.5 1
8.3
Gaston
GnC2------------I
IVe 1
115
1 23 I
25
40
1 5.0 1
7.6
Gaston I
1
1 I
I
I
I I
I
GrB-------------1
I
its I
75
I I
I --- I
!
--- I
I
2,000 1
35
I I
I 4.6 1
6.0
Granville I
I
I r
I
I
1 I
Ira-------------J
IIe 1
110
1 22 1
-- I
--- I
30
1 3.6 1
8.0
Iredell
I
MaB-------------1
I
IIe 1
120
! [
I 24 1
I
35 1
!
--- I
45
I 1
1 4.8 1
8.5
Masada I
I
! !
!
I
I !
1
MdB------------- I
I
Ile 1
95
I I
1 --- !
I
30 1
!
2,600 1
40
1 I
I 5.1 1
8.0
Mayor r
I
I E
I
I
1 I
I
!
MdC-------------I
I
IVe 1
75
I I
I --- E
E
25 I
!
--- r
30
I
I 4.2 1
7.0
Mayodan I
I
I I
I
I
r I
I
E
MdD------------- I
I
VIe 1
__-
I I
I '-- 1
I
--- I
I
--- 1
---
I
I -- I
6.0
Mayodan 1
I
I I
I
!
I I
KdE-------------I
VIIe 1
---
I --- I
--- I
--- !
---
! --- I
6.0
Mayor I
I
I
r
! I
I I
I
I
I
I
! I
! I
See footnote at and of table.

96 Soil Survey
TABLE S.--LAND CAPABILITY AND YIELDS PER ACRE OF CROPS AND PASTURE --Continued
I
Map symbol and I
I
land I
I I
I I
I I
I I
I I
I I
soil name Icapabilityl
Corn
!Corn silage!
Soybeans
I Tobacco I
Wheat
I Grass- I
Pasture
I
I
I E
I I
Ilegume hay I
I
I
Bu
I Tons J
Bu
I Lbs I
Bu
I Tons I
AUM*
i
MnB2------------ I
I
IIIe 1
85
I I
1 --- 1
I
25 i
I
2,400 1
35
I I
1 4.2 1
7.0
Mayo+ !
I
I
I
I I
E
f
I
I I
MnC2------------ I
IVe 1
75
I I
I --- J
20 1
I
2,100 l
30
I I
l 3.6 J
6.0
Mayodan I
f
[ I
I
1
I 1
MrB2------------J
I
IIIe l
115
I I
I 23 l
I
30 l
I
1,800 J
45
1 !
I 4.4 J
7.3
Mecklenburg I
E
I
I
I I
I
I
I
I I
MrC2------------j
IVe l
100
I I
l 20 l
--- I
I
--- I
35
I I
I --- I
6.5
Mecklenburg I
I
E I
I
I
I
I I
I
MsB-------------I
1
IIe 1
95
! I
i 19 J
25 1
I
--- I
40
I I
J 3.6 J
6.0
Mocksville I
1
! E
I
I
I I
Mac-------------J
IVe 1
70
I --- !J
20 1
--- 1
35
1 3.3 1
5.5
Mocksville J
I
I 1
I
1
I 1
1
MsD-------------1
I
VIIe I
---
I 1
I --- !
I
--- I
I
--- I
---
f [
I --- 1
5.0
Mocksville f
I
I I
I
I
! I
I
PaD-------------I
I
vlie I
---
I I
I --- I
I
--- 1
I
--- I
---
I 1
I --- I
5.0
Pacolet I
I
I I
1
I
I I
I
PcB2------------1
I
IIIe i
105
I I
1 21 1.
I
30 J
I
2,200 I
AS
I I
I 3.9 l
6.5
Pacolet I
I
1 I
I
I
I I
PCC2------------1
IVe l
95
J 19 l
25 I
1,900 !
35
I 3.6 J
6.0
Pacolet I
1
I I
I
{
I I
�
Pt--------------!
VIIIs---
Pits
I
Rnc------------- I
I
rve I
---
E !
I --- !
I
--- !
I
--- I
---
I I
I --- I
4.0
Rion
RnD-------------I
vile I
---
I --- I
--- !
--- I
---
I --- {
3.0
Rion I
I
1 !
!
I
I I
I
RvA-------------J
I
IVw l
140
I I
l 28 J
!
40 J
I
2,200 I
---
I I
I 4.8 !
8.0
Riverview
I
RwA-------------1
I
IVw l
100
! I
J 18 l
I
35 1
E
--- 1
40
I !
1 2.5 I
8.0
Roanoke
I
SeB-------------1
I
IIe 1
100
I I
J 20 l
1
25 I
I
--- I
---
I I
I 3.3 1
5.5
Sedgefield I
I
I
! I
I
I
I
I I
I
Ud--------------1
VIIIe 1
---
i I
1 --- I
--- I'
I
--- I
---
! --- I
---
Udorthents I
{
1 I
I
I
I I
I
Ur ------ -------- I
I
VII13 E
---
f I
I -- I
I
--- I
I
--- I
---
i --- I
---
Urban land 1
I
I I
I
I
{ I
I
WeB------------- 1
I
IIe 1
95
I I
1 19 1
i
30 !
I
2,000 i
35
E
1 3.6 1
6.0
Wedowee l
E
I I
I
I
E !
WeC-------------1
IVe I
85
I 17 l
--- 1
--` I
---
I 3.3 !
5.5
Wedowee 1
• 1
I
1
I I
I I
!
!
I
I
! 1
1 f
* Animal unit month: The amount of forage or feed required to feed one animal unit (one cow, one horse, one
mule, five sheep, or five goats) for 30 days.

r
TABLE is ACRES OWNED BY PRODUCER `
-------------------------------------------------------------------------------
TRACT �FIELD| �OIL TYPE � C�A�S-
�CROP |YIELD| L8S |COMM N| ** |* LBS
|
| DETERMINING PHASE
!CODE | 1 AW N | PER |ACRES; AW N
|PER AC| AC | | USEID
G�
|
|
|APPLY| | \RESID.| | APP _
L[���
|
|
|METH � ~, | °~ | N 1 | TIME`��
274
|1a
|ApD
|FP |4.6 1 |0 |3.0 |60Q
______
----
___---------------------
__---- ______________------ _____________
274
|1u
|WeC
|FP |3.3 |�+�� |0 |z2.0 �����/40 G;
-------------------------------------------------------------------------------
274
|1-1
1Ap8
/J
H040 |3.1 10 -&, �����,,7�
| !
/s-odn��
_�-�______��_��_____�______-_____________-��___-�_�_________-���_�*���������-
�'�
.^_�
.*P�
... . .'" .��'� .�� . .� .`�=
|
|
|B 1 |/��.�� | |
_____________________________________________________________________________��
274
|�-3
�CeB2
|FP |4.5 |�f�' |26 |2.2
|
|
|B | |/Lo,
------
-----------
274
------------------------
|1-4
--------------------------------------
1Ce82
|FP 14.5 140" |26 |2.S |xa'"Z TWO
|
|
|B | |/4�'^7� | ;1-10-1
274
|2
|COB*,-'
|FP 14.5 10?i _|0 i23 \44444 8/'as-
-_____________________________________________________________________________
0 61
15
|
|END
| | | | 1 |
--------------
~
�/�/��
'
_______________________________________________
��c�uc�] L� ��oL �L- �J ' ~� �—��'�����
-
\��
TOTAL: ]l
r7.9!�
~
- indicates
that this field is
0e5nS overseeded (i.e. interp|anted) or
winter annuals fo|iow summer
annuals.
40TE:
The
applicator is cautKned
that P and K may be over applied while
meeting the N requirements.
In the future, rego|at|ons may require
farmers
in some parts of North
Carolina to have a nutrient mana8emect
plan that addresses all nutr!ents.
Ttis plan only addresses nitrogen.
� ` ~—~ 7� ��
. 1-��o ,' <lu��ow� � ^ »v°�� ' ~ .`
�V
'
'U ' '
1040,01-y

'ATION PLAN
TABLE 'Z: ACRES WlTH N8T.�ARIZE'D AGRt�EMEn1T OR ONIG'TERM LE-S—
(Agr2mment wiauJacent |anuowners mus� be attached.>
(Requ�red on�y if ooera�or �oes not own adequate
See requ|red specification Z.>
TRACT |FIELD| SOTY9iH: & C; YIELD| LBS
| | DETER�INI�8 P��SE |CODE | | AW N PER :ACRES| 4W N
|PER AC: | AC | | USED
| | |APPLYESID.| | APPLIC
| | |METH N | | TI'ME
| |END | | | | | |
-------------------------------------------------------------------------------
T�TA�|0
~ Indicates d
that this fie�d is bein9 oversee�ed (i.�. interpian�e) or w|nte
- annuas fo'|ow summer annua}s'
** *crea9e fi8ures may ezcee� to�a| acrea3e in fietds �ue to oversee�ip9.
* !bs A!A� s tota| require� nitro5en |ess
any commercia| nitro3eN,) supp|ieo.
Tho fj owin7|e8end exp|a�ns the crop coa use� iu ta�|es 1 and 2 a"ove:
------------------------------------------------------------------------------
CR[)P CODE | CROP | UtITS |PE� UNIT|
| | | |
FP | F�SCUE PASTRE
TOTALS FROM T��LES 1 AND 2--
A C IF,%" E S D |
TA8LE 1 | �9.3 | `�� 753/��,9/� |
TA�LE Z | 0 | 0 |

r I
A P, —1 Ma -A J--' A 2, T 1 - T I I I Z'
U , I L I Z.A T I C_ INI F` L A
il.,jf: f4MMM�!,qft j. M P-. Pitt- P.?. v'I pi ,.I pthp-jf-m. ?p1m 1
t pl, � �iv YM
E! Al,
- - - _ - - - - - -- - -- - - - - - - -
1 . , k .. �
1 V U. Z 'tir i.i 1 M 'cl W cl S C� N' F_ 0 -5 U C E-
pl-f 1 17
'it Tf

r . i
yy�►pi�i I �iyy,r���.i !-]AST i lTsi I"?A chi 1i
/'[3L 1 Y'1FtL iNJ•'lv7 YELF i 1 L 1 �l'1T i s 14 F _}x` IN
1'r:�rrr�r�rr�rrrr�rr5rr?;n,,�rrrPrf�r^r!'!�,"r�rrr�r�rrrr�rrrrrf^r,%rrrrr,�rrtrr=�r�rr�rrrrrrr:`�1'rfrl`r:"�P71�rr'rPr��"rl'r1`r,'�!'i`,''rl`?!'rPr:'�?1'71'r;'":'�rPrn7�'�i rPr:'rl'r
i i i s r, u rn ill
e r in u .y t t I"h a n ij r" e g 1 t a. I t '.' (:} i ni i i r" dl e r s =f f u I i y u t i i i z
the an iri"ia.I wasta iu pi--s_lduceH}.
Acres shown r rh each of the pr2ced i ri4 tali I es are cons i dered to tie the usat+ 1 e
-&€-res e-c I ud i r',�7 ?' E+z t.i i I'"eiy suffers, f i l ter Str i T,s a.1 i1nj d i tches, Csd.1 area.3
Uriatile to be irri dated, and ;+erimeteir areas not reCeivirig f u 1 1 cippi iCatior€
rates due to elqui Pment I iimi tat i ons. Actual total acres in the f i e I ids
listed may, and most I i ke iy w l I tie, rno-re tear: the acres shown i rh the
talc I es.
See attach-ed map show i rig the f i e I ds to be used for" the Cit i 1 i iact i on _ f
ariirrial waste.
1'O Ur- 'f'ac 1 1 i ty i s ides i dried =60.00 days of ternporacy storage an," the
temporary storage must he removed on the average of once every 2.00 months.
Tn no: i n!--) t.ince 5i€ou I d tiie ''V'i»i i urne of the waste be store d, i rh .your str-artur-e
Lie w i tI-h i ni the 25 yeas cu4 Its"iur sto.r-rn sti_sr"age crr s_ the f s_ii_it s`sf freet' bard e.,-`.cCll~;t
thhe event ,if tie+ Year h;:-Lir 5t+irrri.
It is the res ons i i_i i l i ty i_if the pr od-lueer and waste app I i Cati:r to ensure
that -the spreader equipment is operated properly ti_i apPly tiie cclrre.Ct rates
to tI-}e aCre5 shs:wn l n Tail i e5 1 a.nd 2» -ai i ur e ti_i iI_1_i I tale r"eC iinrne n i�ei�
rates and ofrnourits of nitro -en tolf=fwri i r€ the tab l e w ina''y' mal-re this i splan
i nhva l i d .
C z:)- l I your iter Fhn i C a l s,iec i a l i st after You receive the waste analysis report
f or ass ;! sta.r€ce i ri deter"rn i Ti i rig the anii:iurit of waste per acre and "%ie j.iri"sG'ieh"
alp1:s I i Cat i ur€ rate Pr i or to app 1 y I na tha haste.
NARRATIVE OF OPERATION
T h i s }.+!cute ut i I i'e.at i e_Sri p I an i t€vc. I v e s the 2Lpp I i f_at i liri cif bc, th dr"'y
waste scraj_ed fr i--1 n tale l i„it and I i q u j iJ wa. t-e fri-,m th'ie waste
storaSe i++3ii_l. Lot r-i,ln off capt- ured i n tihe waJs+sty_!?'"aL, 'i.-l7. i s 6
r:i is a p I.., l i e d i=s y i r" r- i Salt; i o n u u I"' i e i d: f �► V Ll i` 7. .I. t w I I I ti ? a p F., l I e S_
a C 0 r d I ri:3 tci t N e - attached i r r i gat i on system i es l gn Est innate+.
n i t r c,9en fr-rlmn th i s was:,a i s act_ o united cir.. i n Tat- -, 1 e _ i.1r-1dC,r th'€e
CG:nmer-C i a i N or rRes i dual N per acre column. ACtua 1 ni i tr _io2n
app i i (:: a.t i is n r-a.t,os in ay i:ePd ts_s i_ie a.di€..'. wtFed after a wa.s ve a,ria.1 ys i s ; s
Comp I eted.
' Sri?:rcf1 i'r>i a, �. n� . Y r t' h7;;:+ y :� +.;^ -., i:, '�f „rntri7H lJh sti3 z„Yn n �, 4Y aH aH it YA a x .:_x_xJ.: z_=
+r. :::'.Arr�. r,ir;.:�rr+.:r rrt : .r r r'.r �r•,r• ir•r;:,

NC - c av;c Nertrtl Wolokcr - gecr Fecdlot nias ��191, ��s wr
Y'/G54t `'orole Rc?,ci - 4-,�O;j tjos�-_ F vduce� 1
r
qtS,ie ara4po+C� �VG[ume -SIraaG
r J
.�, 11 Ts'? gib, 4
yc 7.4-8 a�I/Luft -
/ 6 a, 750 2//Cx
e v e-17 60 Jr Y's
Cafide vv,'1! he ccr7,ecd os, -fAc Fced/a
�L+erC'�vr-f , 'thC Q 0"ounf O-� :!ct-4 {Mott(c) 6c
1 (n�T750 J4f 2 SD d I fows
o du415 X bo days
PCt►vT ,4V �� ! rjzaG�tl PAN
7�ric,�c arm ro rtad..r.! _a✓a�/a(,�C rga s...- �- pIo „t a.va.lQ6..le.
' r y
WaS-4e anti 3e5 A,2rn da�r D �ra�v-rr5 ,.whir . Marrv.
sc+-Q(ed a cry �oulcd a�d ���-�yc ����5 -ar,— eat,y
a ly 1�9u�cl �as/e eurcl . ru n'o4e- h y.c Sown /eve/s off
f�[rrt AV �'f a� �e n r'fi��-c.n LI AJ +0 h c c PLO �x.'�Q er.
1. Ih PAr! rimer IG�O, q u/lrs�� r C occ�Cr- _ 7o- l rchc e CL-'T,�
or' avara%a C-rN aced -�o Gc�cr2yG rve� h4 of I4400 /. s
,T�`� G� r'! i 1 � C C W ♦ � r �`{-�'p A Y� r rkl Q. f �i "t/1vt. s � � � N !] �� 5. �! �e 5 5
i c r c. $I 44-f-1'r -e e f� . ,�3- r4--' .. �a' c f 'kl c Q
1L�s
4-S f z ~cC ci f G f' Tit ar. 0'Yt, 't� " d V'/ S+-
F91 ��0 callc� s . �+ !b P,4al/arr5
CaY-11G are Carr �• i�ed
d V1�� `l'-✓' � i�J�r� "C f r'��:�i �S ;^10-i►C� ��� , +� t�� � . � a l � �. � t:. %'JJ � �
yr� r
r! a f ',5 ' � ,6 r, o ;.r 1C} fa e G`j�!e. `.•-J �� e-/er r+" � rr � ���✓�) Y' ��r� �ri f
leJe�s,
GS-r= '-rorO�4 ;�V�_f :...r! r;c C2j�TZ,(t•..-7

Hepirt
,a�.>� �;�ra�: jJ'�G�- F.�vr`c1 ji1JaS� ��u�'a • 2 2
���,►( be C(ur' TIC ;nlgrn�fer r��,t�n5/ SGme a� `Fh15
�1�l� �� lo�� f'TJ e/ �Jovafi•� , �LV� if�r� `�?e ��cl
",It pmbo'b" ll Qneed 4o ke Co-ptreel Pero ad-,c,11.

WASTE UT I L I ZAT ION, PLAN
REQUIRED SPECIFICATIONS
+�4rtllrlai wawtM shalt rl,';t r"=ach Silr'Fa,-e water-5 t'f the state 6,'Y
! tJI"s k_!ff, rift, fit ct rs Tn a+ae CC=riveya,nces, d I reCt a-p , l i cat i Uri, or
direct i scharge kjur r rig ; +erau i on 4r !Grid aj+ i 1 i cat i C,n . Any
d i schar'ae of waste w-i i ch reaches surface rater is r,roh i b i ted.
There must De dc-curnentat i on i rs the design f C[ 1 der t iat- tl!e
;_+rc-Jucer either owns kip- has an agreement f,_kr Use of ade+.;ti!a,te
land ,)rt which to Properly apply the waste. If the pr,,,yuc er" does
not own adequate I a.r'i,j tk) r,rCLper i y d i 5p ose of was we, he/she sha l l
+ r" C, 1 +� e a c+», r` y [+ a r l a j r" e e rri e rl t w i F+ a i art t= +=+ w rl �' r" w ii 4 is w I t' it ! rt a
reasonable proximity, a i lowing him/her the Use of the land for
waste sa.pp i i cat i ,)r=. It 15 the r espons i b i l i ty of the owner of the
facility to secure an update of the Waste LA i I i zat i on Plan whert
there 15 a Ch:8Lrlge in the oper-at i on, increase i rt t`ie nUTTttker ctf
animals, rneth[),J of utilization, _[r" available Iarid .
: . JarslTrlai ,ta+3tW 511ii �, aY, `i ied t+»+ :'t)e tg but rtiet e`:CC�,j, the
nt , fir"+:? eF, needs fi,r rc-a i i i;t i c c r oi e'1 .15 ba ed k)n SO i i ty'r,e,
avai Iab3e Tfs+?istUi'ey iti 5t':,I'"i Cai datay C I lrrlrt-#C C,-<ri iti�+rlS, 3it,'
I eve I :kf mana,3err,ent, un i ess there are read i at i +)r:s that restrict
t ile rate _-,f anp I i cat i ort fo r ether nutr i entS.
4. fart i ma i w a ste s h & I I he app I i e d t:-k 1 and erod i n l ss:s tha.n 5 tnns.
Per acre Per Year. Waste may be app 1 i ed to I and that i 5 a, "Ols i `k
at L +_,r more t4,rsS, but. less than 1 ' toris per acre l_+er" year
pr ov i d i rt j Orass f i 1 ter strips are 1 rista 1 1 eaJ S.dher e rl3nof f l e-ave5
the f e l d. !See FOTG ,Standard F7 i i ter" Str" i p
r. C1ij,_krS can bC' rekjuCed by :'n ieC c'F, iri the wa.S't~,a ,.+4' d; s`t i r;3 afti:'r
vast, e al p i i Cat i 4rs PLAa.ste Sitou l d r,ot t,e arp l i ed when there i'3
dail'aer »,f ,fir i ft #r,-arll the , irrigation fie : d .
L, ihll"ten an i TTIa 1 waste I a ts_+ 1,e app l i 2d Ori a.CI-eS SUb feet t,3
f l oodi i ri y i- w i i I he - 5„, I I i ricort»,c.rated on c,_>rive t 1 C1rta1 1 y t i Ied
croi-, l :3,r1d . When a.pp i I e= to con52rv3 4 I on t I 1 l ed CropS or -
grass 1 and y the waste may be br oadcast- pro-,, i +.ied t1t2aT: i c-ai, i rt
does not k+cc ur dur i rt _� a. eason I„1 rorie tC! f I ood i r-S . (Sep "Vleatsler
a rid C I i m a t e i rt N+)r' h r:arr, l 1 r.a'+ fr,r 9 u i dance. )
t'. Liquid l as-te sha l 1 be i?pP I i ed at rates not to e,XE: ?ed t: !e so i I
i rlf r 1 -tra.t i c-i-I i--ate SUCK '::flat rurioFf does not 0 C C U r CFf f S i Ge C, tC+
surface waters and i rt a. miethod wh i C'l-I does not CaucSe drift from
the site -Jul"ins ai:q- 1 i cad". i on . No poind i nj s'lloU 1 d occur i rt +; order
t[7 ck)ntrC, i o,_or" i r" f I i e a.
An I iila.i waste sha I I not `,e _app i 1 ed to satura.tc'd '-s,i i I S, kJur i rt'`'
I'ai rif a 1 1 events '»[r" Wiles; the SUrfat-e I S - r ,) Z Prt.
An 1 if,*a I >t- r t- { i-` a w I 3C L I 'E' = I' i i i ( r i_ �, i r4 UC
c, i i !I a. r! n e ! " "'hat tt e C i - ,) F! is rl o 't: C , :+ E r" e e j W 4 4" 't t_3 7 j e P u Il t l"i 3 u
1 d ! I lb. t Y, k?'t1 �; I-i z 1, I e ;+ i i t e r1 't, i a i f: i r- s a I t ,j -L � a.i{ta•�..r � � r C,Tfi ai ! i rfla. t
waSA.iw Si1,1u1d alst=, itG' c ons.'sdere d.
P--=%rF= 7

t, A WAS s'E UT I LIiATI NN PLAN
REQU I i{ED SPECIFICATIONS
10. baste nutr I enter 5ha 1 l not ire app l 1 ens in fa i i. or winter for
cr,r- rl0 p I anted Cr ,_-Aps'- cirl 5,;, i t 5 wi t1-s a h i 31-1 pr"_ tart a fur
I each I rig. Waste nutr 1 ent 1 C,ad 1 r€S rates on tinet"se "so i '€ a 5YIou 1 :j tie
ile l! tii a. CR 's rl l i'R i1 rR an, a 5u i ta€:, I e w l rite cover cr"I_,[r rn, l an ted to
take up re i eased n}?tr '1 ent w. Wa5te 51` a i not tie apsil i 1 el� rRirre
'Ohan :=1() days nr i or to tF, I ant i n-3 of the c rop or fi:iragas break i n:3
:,r-rRancy.
11 . Any r€ew swi ne far i I i t"yf s i teat c-n r_rr after Cictc-ber 1, 1';?;='5 sha I I
cOmpIy wit`I the f o I IowinLj: The outer" P er ii.meter of tale Iand area.
C.ntCr wh i ch waste i e app:i I i ed from a. l a,grron that is a comp:,cinent CIF
a sw i ne farm sha l I be at least Ott_) feet from any residential
property boundary and from any perennial strew m or river (other
t h a n. a4: i rr i gat l r,n d i 'sc♦-s tir- cana.1 . An i ma t waste iz,ther- than
swine waste from fa.ci I ities sited on or after October 1, 1'.fl�5)�
si"Ia1 I n it be app I i ed c I,-,ser" than 25 feet to perenri 1 a waiver-s.
(See Standard M9'3 -- F i l ter Strips).
12„ An i ma 1 waste 5I-1a I I nci . be amp I i ed , I orser" Char, .I.()S) f e'et tri
1'3'. An ) rrsa. i -4asta srja I I ni_.t Lie aF,p I i ed c l iser titan ',_. )0 f eset rI f
dwe I I i n3s other ti-ian tt-li:, ,e iit,,)ned by tul-le 1 andowner a
14. V.Ia _,',e S!-.,- i I 1`ie a�`r, ? i :�r� i ri a. rnar,ner nCit t i reach C,tLier- property
tv
and pub t i c r iq 1€ lr_of -ways
1 _I. Animal waste sila.l I r:ot be CI j sc Barged I ritCl slur"face watPr5,
i:J r-�. I r1 a;e!nlays; CI :`" iw e'er 1 ai-IdS i_Iy a I 1 aC ri ar-�3e or itiiy i=,VG'Y-"'c, I.i r-e7.y I r13.
An iriia1 waste may be a ir; I i ed tr, irr i or converteiJ crC,le I FLnd prov
i;led
tIney have been a.I_,prii`ved a s a I a,rli:t al--jp l i ca.t = tin s i to Miy a.
rtechn i ca. i sp?ec i a i i s tli An i mal waste sha.I i not be a�,sp 1 i ed on
r-as'sed water"ways ti€sat d i sG+iar" ne5 d i rest t y i rlt'an water r o1-1rses
a rld 04I i-11r ii w r Jr as s eal wa at e r w a y{5, to a5 ue s i Ia I I Ya. I:,p e d a 1
a,"rclr!or€aic rates irl a man net- tilat causes :'ICr rLin off ar Y"I'^t from
o
1:_ . D0rnest i s.. ?...r€d i niMI..,;st. 1 c4I Waste f rnrr) Wass -,ij::iw r l f-A
5I"1 _Iwer-s, tli lets, s i nk-s, etc, , hat i ricit Lie d i sc1"lar 3ed I rill= i lie
FA i rRa. I waste manaSefrant s--.,stem.
.I. .. A ,rI=itecisI�,�i= cc,ver- -0f aF,I_,r-0Rh-Sate vet - eta. I1:1rl WI � I ite
IF,
ES :ci�i t i 511ed on a l l d i sts?r�r:_d a ea s ( l a3iion e:R�iarir;rr€er'€'i.S,-ierM7, ,
it„le r"ur€5, ?'Ico) Areas sha.13 be fenced, a5 necessary, tc,
der rl`a c t: trite "Vi seta,t i r,n Vejetca-.' i ii{: SU.l a= trGeZ,, 1.5 rUL'5, wilt:=
,:,Hier" wi_ iii-4v spec it es, 2t= . , ar"e l rn i tcdi o areas where c:' nC _, i dJer"ta,_I
a.pprcipr i zate . 1_a_?iii_in areas d be i' e.nt mowed and access I b 1 ,a„
wit r-r, ra.i1 D i'a" i.jC4-; -e c.11l:lu t r7 i7e i ri E,ac t e d r"'e,-4u I ar" I v for - e`d i rieriCe
_ff er-fES i t-er', l 2aI•.:C31 ­r I =rfi tJr- ?r»'.

`
-WASTE UTAILIZATION PLA% M
REQUIRED SPECIFICA-11ONS
18. If anima| pro�uct�on at the faci| ity is to be suspended or
terminated, the owner is responsible for obtaining and
imp|emen�inS a "c|osure pyan" which wi|| e|iminate the
possty of an i||ega| discharge, po||utios and erosion.
V9. Waste hand1'fn8 structures, p}pinG, pumps, reels, etc., slhou|d
be inspected on a re8u|ar basis to prevent breakdowns, |eaks*
andspi| �s. A re8u�ar maintenance check| ist shou|d be kept on
site.
20. Anima| waste can Le used in a rotation tpat inc|udes vegetab|es
and other crops for L,'irect human consumption. Howsver, if
anima� waste is used on cropa for direct human consumption \t
shou|d on{y be app(ied prep!ant with no further appt,icat' ions of
anima! waste during the crop season.
21. H�3b\y vis\b|e markers sha{\ be >nsta\}ed to mark the top and
bottom e|evat>one of the temporary stora8e (pumpin3 vo|ume) of
a�I waste treatment |agonns. Pumpin8 sha| | be mana8ed to
maintain the | iquid | eve } between the markers. A marker wi��
be required to mark the maximum stora8e va|ume for waste
stora8e ponds.
22. Waste sha|| be tested wit1-1in 60 days of uti |izat|on a.nd soi>
tested at |east annua|�y at crop sites where waste
products are app|ieNitro8en sha|| be the - rate - determinin8
e|ement. Zinc and copper |eve|s in the 5o\ |s sha|| be
monitored and a|ternative crop sites shall be used when th�,s
meta{s aptroroach excess\ve |eve|s. pH sha|i be adJusted for
optimum crop production and ma|ntaioed. Soi| and waste
aria |ysis records sha|| be kept for five years. P�u|try dry
waste app|ication records sha 1| be maintained for three (3)
years. Waste app|ication records for a|| other waste shai{ be
maintained for five (5) years.
23. Dead anima>s wi || be disposed of in a manner th�t meets Nart�
Cara|ina requ|ations'
`
Pa:ze: 9

s'Y Fri 11 lAL '^4 AL SS TM E -! U iT lice.
j:'?I'71�i!'7Pi f'? PjMt'i
�i 7ils�olu 1 Tay, 21 zcoo
Name of Farmi; +� EvlSta� 2. �tG r /� 2r3aa
Owner/Manager Agreement
I (we) Under tant3 a,rr+- w i i I follow arf:j implernerit t,e spec i f I ca.t r!FrS
art! to operation and mai I`I'�er€ar€Ce Srf-i+i e+€LSh-PS Si.3 G t 5�`s4'+ i I"€ !`,he
a,€ proveiJ an i r€a. 1 waste Ut 1 I i wat I c,r€ p I ar€ fiiilr tine f arrrr rirtfCe.' above. I
5 Y.r I•:. I�!.!w tIf a., arty expa.ns I on toti"i e ex 1 s J i ng des ! w € € c ap ac I lr f !, I-) e
waste treatrpent and storaoe system or coris ur uc u I oll of new
f aC i I I ties w i I I require a r'Iew CeI' t l' i Ca.t i on t+:r be submitted ti-. the
North Carol I rfa D I v i s !or, !f Criv i rcrn?t7ent%H. I Mari a�,ne..mpnt tNCDEi`r) bef ire
UhP new ra,nima.i s at-2 Stnk_I•�e+J. (yJe) a.IS:-, urI}12i` ta.ri i tlhr7i tiler
r;Ust IM!€_+ rI!-+ d i=c';-Ia.rge .0i" ar, i rlla i waste !_aril t..'i 15 ='yS t y11r fare
wc`l.S 1Ft-s _!F the =i,3 !te f h"om a st!ri`m Pverit Rs:: : overe snanL,
'y e a I' p .:`.'1' €-€ .+ u r :S L .-r r rFi T f e :f. I"r i-r i" �! L' e. d r! I a rf w I I •.`.! e ? l i e +J r-, rs - 1 t o c€. t
' I ! _ farm r=! .0 ':'• I [= Fa arid c'#. ? the !'! e C F' :r I -I e i +:! C 3. I ;::i :„s 1 i -a i I d W 3. t e r
!-.ri5erVat I C+rr r1 I{ r = aI"I rJ i i i U2 ava i I at- I e T'+t r"ev I ew by N!-.DEM
Name of Fac i I. tx Qwner : Henry Walker
Si'Ieas� -r� ir.,U r
Signatures---'�"�,�-�L; -- -� �r C ��� Date:
Name of Manager- ( is different from owner)., --
Signature: -----------
Date -.
1 v r: e 7/J5 jdAJZ-
L
same -
Name of Person Preparing Plan-. R-2itse ;r?rrt)Fredr i ck Y . Alexander
Aff i i i at i orc.NRCS Phone No. 33,6-751-5011
Addr-ass ;A ?:�cyi •3�am -7i_ tsounty Office Bldg. 180 ` . Main St,
Flo c les-v i i; e NC .270 8
Signature: _ _-- _ _---_ __ ___-----
P�Vj$LLB-st.c�-
iiti �YhY.hi"�i "Hfi7 "i ::'1 '^4H Ai f. rv-Ar AH.*+A.+..".=k:F-A�t a.+a....-_a-n�n_c___.._"_._.., a_.�..+•v •_._��h-:f' .: hi :.i h•f :.. a✓a. n.. a-._.-a-._.�.+... a_v...

Tab Le' BEET PAVED SURFACE SCRAPED MANURE FERTI,__ER NUTRIENTS '
as=saxaaayzsaa3aaaasaxnaxaaa==saaxas=aaax3rsaa�=a=s�s3=aasaga3a:aaaa3xaxeassaasa:sasaxaaxaas=xx=xp=nsa==xa_aa�_a=a�aaxxaa_x=:
Type Animal AnimaL Live Manure Total Plant Plante Totat Plant AvaiL
of Age Weight Storage Scraped Nutrient Nutrient Nutrients Nut rieni
Production Capacity, " Manure,*" AvaitabiLity broade
'it ------------ --- Coefficients -----------
init final mean tons/ tbs.
ft3/ head broadc-Lst heac
head capacity/ tbs/ tbs/ capaci;•.
months ------- tbs ------ capacity year ton ton
------------------ -----------------
Stocker 5 - 10 425 675 550 28 3.1 N .42 14 5.8
P205 .70 9.3 6.5 Zc
X20 .70 13 8.9 c_
Feeder 10 - 15 600 1000 800 41 4.6 N .42 -14 5.8 2-
P205 .70 9.3
K20 .70 i 3 , .
Brood cow 10Oo 1000 1000 51 6.1 N .42 14 5.8
PZ05 .70 9.3 6.5
K20 .TO 13 8.9 54
* References: Depts of Biological and Agricultural Engineering, Animal Science; North Carolina State University; Jan 1990
Agronomic Division, North Carolina Department of Agriculture
• 3-month accumulation of manure and bedding with liquid drainage.
'^ Manure collected within 1 week.
"••-Broadcast: surface spread manure uncovered for 1 month or longer.
Table 7C. LAND APPLICATION OF BEEF PAVED SURFACE SCR"ED MANURE
-
Type Rate- Manure Application Rate " Minimum Land Area for Manure AppLicati-
` Limiting ------------------broadcast------------------ -------------------- broadcast-------------
oduction Nutrient ----------------Lbs/acre/Year---------------------------------- Lbs/acre/year
N 50 100 150 2c0 250 300 350 400 50 100 150 200 7-50 300 350 40C
P205 20 40 60 RO 100 120 140 160 20 40 60 80 100 - 120 140 160
K20 SO 100 150 200 250 300 350 400 50 100 150 200 250 300 350 4o0
----------------t;rs /acre/Year------------------------------acres/head capacity ----------_-.
Stocker N 8-6 17 25 34 43 51 60 68 .37 .18 .12 .092 .073 .061 .052 .046
PZC5 3.1 6.2 9.2 12 15 18 22 25 1.0 .51 .34 .25 .20 .17 .15 .13
K20 5.6 11 17 23 28 34 39 45 .56 ..3 .19 .14 .11 .093 .080 .070
Feeder N 8.6 17 ' 26 34 43 51 60 68 .5.3 .Z7 .18 .13 .11 .089 .076 .067
PZ05 3.1 6.2 9.2 12 15 18 22 Z5 1.5 .7+ .49 .37 .30 .25 .21 .19
Kz0 5.6 11 17 c3 28 34 39 45 .81 .41 .27 .20 .16 .i4 .12 .10
Brood caw N 8.6 17 26 34 43 51 60 68 .71 ._6 .24 .13 .14, .12 .10 .029
PZC5 3.1 6.2 9.2 '2 15 18 22 25 2.0 .94 .66 .•9 .40 .33 .23 .25
K20 5.6 11 17 e3 28 34 39 45 1.1 _5j;. .36 .27 .22 13 .15 i=
References: Depts of Biological 3'Agricai=-.:raL Engineering,'SoiL Science, -Crop Sc::rce; Nor_, Carolina St univ; ,an 1990
'• 4 fertiLization rate should be consistent with realistic crop yield.
N Leac.%ing and wenitrification and P2C5 say: immobiLization unaccounted for.
3d

Attachment
North Car„lina AgricuIttcral Extension Service 1of 3
Agri -Waste Management
Biological and Agricultural Engineering North Carolina State University
LIVESTOCK WASTE SAMPLING, ANALYSIS AND CALCULATION
OF LAND APPLICATION BATES
.lames C. Barker*
I. SAMPLE COLLECTION
A. Semi -Solid Lot Manure
i. Scraped directly from lot into spreader
a. From loaded spreader, collect about 2 lbs of manure from
different locations using nonmetallic collectors. ,
ii. From storage
a. Collect about 2 lbs of manure from under the surface crust
avoiding bedding materials and using nonmetallic collectors.
B. Liquid Manure Slurry
L. Under -slotted -floor pit L -
a. Extend a 1/20 nonmetallic conduit open on,both ends into
manure to pit floor.
b. Seal upper end of conduit (e.g., by placing a thumb over end
of conduit) trapping manure that has entered lower end, remove
and empty slurry into plastic bucket or nonmetallic container.
c. Take subsamples from 5 or more locations or at least 1 quart.
d. Mix and add about 3/4 pint to nonmetallic sample container.
ii. Exterior storage basin or tank
a. Make sure manure has been well minced with a liquid manure
chopper-agi :ator pump or propeller agitator.
b. Take subsamr les from about 5 pit locations, from agitator pump
or from manure spreader and place in a plastic bucket.
* Professor and Extension Specialist. Biological and Ag_icultural Engineering
Department, North Carol;^a State Universit'f. Raleigh. .1C.

Attachment? +
2 of 3
- 2 -
C. Mix and add 3/4 pint to a nonmetallic sample container.
C. Lagoon Liquid
L. Collect about 3/4 pint of recycled lagoon liquid from inflow pipe
to flush tanks in a nonmetallic sample container.
ii. From lagoon
a. Place a small bottle (1/2 pint or less) on end of 10-15' pole.
b. Extend bottle 10-15' away from bank edge.
c. Brush away floating scum or debris.
d. Submerge bottle_ within 1'' of liquid surface.
e. Empty into a plastic bucket, repeat about 5 times around
lagoon, mix, -and add 3/4 pint to nonmetallic sample container.
D. Broiler or Turkey Litter
i. House litter
a. Visually inspect litter for areas of varying quality, e.g.,
areas around feeders and waterers, and estimate percent of
floor surface in each area.
b. Take about 5 litter subsamples at locations proportionate to
item a. E.g., if 20% of litter of similar visual quality is
around feeders and waterers, take 1 subsample there and the
other 4 subsamples from remainder of floor -surface.
c. At each location, collect litter from a 6" by 6" area down to
'earth floor and place in a plastic bucket_
d. After 5 subsamples have been added to the bucket, mix, and add
about 2-3 lbs litter to a nonmetallic sarsple container such as
a 1-gallon freezer bag and seal.
ii. From stockpile
a. Take subsa=ples from about 5 locations at least 18" into pile.
b. Mix, add 2-3 lbs to nonmetallic sample container and seal.

- 3 -
II. SAMPLE PREPARATION AND TRANSFER
Attachment
3 of '3
A. Place sample into an expandable container that can be sealed. Rinse
residues from container with clean water but do not use disinfectants,
soaps, or treat in any other way.
B. Pack sample in ice, refrigerate, freeze, or transfer to lab quickly.
C. Hand -delivery is most reliable way of sample transfer.
D. If mailed, protect sample container with packing material such as
newspaper, box or package with wrapping paper, and tape.
E. Commercial sample containers and mailers are also available. Contacts:
i. AAL Eastern Agricultural Lab, Inc. iii. Polyfoam Packers Corp.
7621 Whitepine Road 2320 S. Foster Avenue
Richmond, VA 23237 Wheeling, IL 60090
Ph: [phone] Ph: [phone]
ii. Fisher Scientific Co. iv. NASCO
3315 Winton Road 901 Janesville Avenue
Raleigh, NC 27604 Fort Atkinson, VI 53538
Ph: [phone] Ph: [phone]
F. Private analytical labs are available, but sample analyses are costly.
G. The NCDA provides this service for North Carolina residents.
i. Address: North Carolina Department of Agriculture
Agronomic Division
Plant/Vaste/Solution. Advisory Section
Blue Ridge Road Center
P.O. Box 27647
Raleigh, NC 27611
Ph: [phone]
Attn: Dr. Ray Campbell..
ii. Forward $4 along with the sample.
iii. Include the following identification information with sample:
a. Livestock s;ecies (dairy, swine, turkey, etc.)
b. Livestock usage (swine -nursery, finishing; turkey -breeders,
brooderhouse, grower, number flocks grown on litter; etc.)
c. Waste type (dairy -lot scraped manure, liquid slurry; swine -pit
slurry, lagoon liquid, sludge; broiler -house litter, stockpile
iv. Routine analyses performed on -all samples: N, P. K, Ca. Mg. Na.
S, Fe. Mn. Zn, Cu. B
v. Additional, analyses performed upon request: DM, Mo. Cd, Ni, Pb

CALIBRATION OF MANURE SPREADERS
Elective utilization of manure is not possible if you do not know flow mucia is being spread over- a
given area. Calibration of your spreader is a simple and elective way of improving utilization of
nutneats m manure more effectively. Oniv by knowing d-.e application rate of sour spreader can you
correctly apply manure to correspond to your crop ne_ds and prevent water a ,-, ity problems through
the ove. application of animal manure.
Applicators can apply manure, at varying rates and patterns, depending on forward travel and/or
PTO speed, Qear box sestinas, gate openings. operating pressures. spread widths and overia4s.
Calibration defines the combination of sestinas and travel speed needed to apply manure. bedding
or wastewater at a desired rate and to ensure uniform application.
Spreader Capacity
Liquid spreader capacities are normally rated by the manufacturer in gallons. Multiply by 0.0042
to get tons. .
Solid and semi -solid spreaders are rated by the manufacturer either in bushels or cubic feet
(multiply bushels by 1.24 to get cubic feet). Most spreaders have two rating capacities: (1) struck
or level full, and (2) heaped. Calibration of solid manure spreaders based on its capacity
(volume) is difficult to estimate accurately because the density of solid and semi -solid manures
are quite variable. Density is the weight of the manure per volume of manure ( pounds per cubic
foot). Manure density varies depending on the type and amount of bedding used as well as its
storage method. Therefore, if you estimate spreader application rates as the volume of the
manure the spreader holds you are overlooking the fact that some manure weighs more than other
manure. This can cause a significant error when calculating manure application rates.
Since manures and litters have diferent densities, an on -farm test should be done. To determine
the load (tons) of a manure spreader:
1. Neigh an empty 5-gallon bucket.
2. Fill the bucket levei full with the material to be spread. Do not pack the material in the
bucket but ensure that it settles similar to a loaded spreader.
Weigh the bucket again. Subtract the empty bucket weight horn this weight to calculate
the weight of the contents.
'.. ytultiply weight of contents by 1.5 to calculate pounds per cubic feet, density.

5. 'Multipiv the manure density by the cubic feet capacity of the spreader and divide by 2000
to get the tons of material in a spreader load.
webszhC of : gal manUM X 1.5 X soreace- c_caci[v (Z.' )
Spreader load (tonsl s ,OOQ
Solid and Semi -Solid 'Manure Spreaders
In order to calibrate a spreader for solid manure (20 percent or more solids), the-tr'oilov.nQ
materials are needed.
1. Bucket
?. Plastic sheet, tarp or old bedsheet. An even size, 3 feet by 8 fee:, 10 feet by 10 _eel_. or 11 feet
by. 12 feet, will make calculations easier.
3. Scales
Calibration method.•
1. Locate a large and reasonably smooth, flat area where manure can be applied.
2. Spread the plastic sheet, tarp or bed sheet smoothly and evenly on the ground.
�. fill the spreader with manure to the normal one. level_ Drive the spreader at the
normal application speed toward the sheet spread on the ground, allowing the manure to
begin Ieaving the spreader at an even, normal rate.
4. Drive over the sheet at the normal application speed and sertings while continuing to
apply manure. If a rear discharge spreader is used, three passes should be made: first
drive directly over the center of the sheet, the other -two on opposite sides of the center at
the normal spreader spacing overlap.
S. Weigh the empty bucket and plastic sheet, tarp, or blanket.
6. Collect all manure spread on the sheet and place it into the bucket.
7. Weieh bucket and manure and subtract the weight of the empty bucket and ground sheet_
This will give you the pounds of manure applied to the sheet.
3. Repeat the procedure three tarries to get a reliabie avezaee.
9. De= nine the average :weight of the three manure analications.
OPUA? '"= . I997— ): _-?

10. Calculate the application rate using the following formula or Table 5-3:
Application ;ace (cons -ace) =
lb manure collected x 21.73
sbee: length (ft) x sheet width (a,)
11. Repeat the procedure at differe:ic speeds and/or spreader settings until the desired
application rate is achieved.
Example:
What is the application rate (tons per acre) if you collect 3.o pounds of a anure on a 10-foot by
10-foot taro during a calibration run?
Application rate (corw4cm) = 3.5 lb manure x 21.73 - 1.35 consiacre
10 ft. x la ft
Table 5-3. Calibration of Solid tilanure Spreaders
Pounds of Manure
Tons of Manure Applied/Acre
Applied to Shea
Size of Ground Sant
8.xT
10'x 10'
12'x 12'
1
0.34
0?22
0.15
2
0.63
0.44
0.30
3
1.02
0.65
0.45
4
1.36
0.37
0.61
5
1.70
1.09
0.76
6
2.04
1.31
0.91
7
2.38
1.32
1.06
3
2.72
1.74
121
9
3.06
1.96
1.36
10
3.40
2A S
1.51
15
5.10
3.27
2.27
20
6.31
4.36
3A3-
Many times it may be necessary to adjust the rate in which waste is applied from the way it is
normally spread. Changes in application rate can easily be done by incressina or decreasing the
spud in which the waste is being applied. In order to perform these calculations, the spreader
load (tons), duration of application (minutes), and the average width (feet) of a normal
application needs to be known. T'ue aicclicstion rate and travel speed can be found using the
following equations:
Application rate (tonsiacre) - spreader load (tons) x 49:
time (min) x width (ft) x travel stead (mph)
Travel sped (mph)screaade. load (tons) x 495
time (min) x width (Pt) x appiicadcn race :.:cavacr-,)

{` Example:
What speed should you run if you wish to apply .4 tons of manure per acre with a 3-ton spreader?
Your spreader appiication ,-vidt_h is =4 feet and your surea.der empties in o minutes.
Trave! s„,:--d (mpn) - 3 tans x 493 = 3.1 :rza
6 ruin x 30 ti x 4 tonsacra
Spreader Pattern Lniforrnity
To determine the uniformity of spread and the amount of overlap needed. place a Iine of small
pans or trays equally- spaced (2 to 4 feet) across the spreader path. The pans should be a
minimum of 12 inches by 12 inches (or 15 inches in diameter), but no more than 24 inches by
24 inches; and 2 inches to 4 inches deep. flake one spreading pass directly over the center pan.
Weigh the contents caught in each pan or pour_ the contents into equally sized glass cylinders or
clear plastic tubes and compare the amount in each.
The effective spread width can be found by locating the point on either side of the path center
where manure contents caught in the containers is half of what it is in the center. The distance
between these points is the effective spreader width. The outer fringes of the coverage area
beyond these points should be overlapped on the next path to ensure a uniform rate over the
entire field. "Flat -top," "pyramid," or "oval" patterns are most desirable and give the most
uniform application. "lVl," "W... "steeple," or "topside" patterns are not satisfactory and one or
more of the spreader adjustments should be made.
t
LPL\t?—'•1=rcr..�. l�G�—, _,

IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name: Henry L. Walker
Address: 1493 Go ey P.a.
MocksvilTe, NC 27028
Telephone: — • --
TABLE I - Field Specifications
County: Davie
Date: January 21, 2000
EX1-HB1T D-I
Fields
Number
Appro:lmate
Masintwu
Useable Size
ofFleld2
(acres)
Soli Tye
Slope
(%)
Crop(s)
Mail mum
Application
1180
(inlhr)
Maximum
Application
per Irrigation
Cycle3
(Inches)
Comments
1-1
3.1
A B
2-8
Fescue Pasture
.4
1.0
1-2
3.2
ApB
2-8
Fescue Pasture
.4
1.0
1-3
2.2
CeB2
2-8
Fescue Pasture
.4
1.0
1-
2.8
CeB2
2-8
Fescue Pasture
.4
1.0
ISee attached map.
21'otal field acreage minus required bulrer areas.
3Refer to N. C. Irrigation Guide, Field Office Tectmical Guide, Section 11 G. Atmual application must not exceed the agronomic rates for the soil and crop used.
NRCS, NC
TUNE, 1996

Landowner/Operator Name:
Address:
Telephone:
TABLE I - Field Specifications
IRRIGATION SYSTEM DESIGN PARAMETERS
t f.
f'{e>'lrl k)a Gv County: dim
W Z7028, Date:
70q- 492- 5G,L6
0.141,Iti is i
Fleldl
Number
Approximate
Maximum
Useable Size
ofField2
(acres)
Sull Type
Slope
(%)
Crop(s)
Maxlniwn
Application
Rate3
On/hr)
Maximwn
Application
per Irrigallon
Cycle3
(inches)
Continents
Ll• 0
3162-
a' F%a1
1160
CcCr SQ,�d clay %a 2 �9os/o
lSee altached map.
2"rol:il field acreage niinus required butter areas.
3Refer to H. C. Irrigation Guide, Field Office Technical Guide, Section 11 G. Annual application must not exceed the agronomic rates for the soil and crop used.
NRCS, NC
JUNE, 1996
Ste_

TABLE 2 - Traveling Irrigation Gun Settings ' Henry Walker Beef Operation, Davie Co. NC
Malce, Model and Type of Equipment. Kifco E27A w/ 820 of 2.7" ID PE Tube, Nelson SR100 Gun w/ .8 Taper Nozzle
Field Nor
and
Hydrant Noe
Travel
Speed
(fthliin)
Precip.
Rate
(inAir)
Application
Depth per
cycle
(ft)
Travel Lane
Effective Effective
Width Length
(ft) (ft)
Wetted
Diameter
(feel)
EQUIPMENT SETTINGS
Nozzle Operating Operating Arc
Diameter Pressure Pressure Pattern
(inches) t Gun (psi) PReel(psi) degrees)
COMMENTS
1 -1
3.51
.33
.33
208
644
295
.8
70
106
300
3.1 acs.
1 -2
351
.33
.33
208
675
295
.8
70
106
300
3.2 acs.
1 -3
351
.33
.33
208
467
295
.8
70
106
300
2.2 acs.
1 -4
351
.33
.33
208
57.9
295
8
70
106
300
2.8acs.
r See attached map provided by the Field Office for field locations(s).
Show separate entries for each hydrant location in each field.

G44
F
secJ 1 ► - S j�a�, -
�4 X, 133, ?5 oZs��4 -A 4:��5G ovtlqc-
�f) . I a c-s
1,,3-A - G/
G T;
208 f
7,5 14LO, 4-100 :yj�: -f 43
3. '�"G cz

2{ _ 908 "
i
�,o C.s
579'
a - e acs

DJOA)
_ S �d- 1 �5 two %v r
pi GL
1. 8j,f� �/ oo-f7+ x - -4
�0-,3p5-1
14, J6 -r+ _

0
'7C,�� � C�u•�
i
9 0-11

TABLE 4 - Irrigation System Specifications
Traveling
Irrigation Gun
Solid Set
Irrigation
Flow Rate. of Sprinkler (gpm)
155
Operating Pressure at Pump (psi)
130
Design Precipitation Rate (inlhr)
i .33
Hose Length (feet)
8201
XXXXXX"
Type of Speed Compensation
Mech .
XXXKXXxx
Pump Type (PTO, En;Ene, Eteciric)
I PTO
Pump Power Requirement (hp)
4 30$
.
f
i
TABLE 5 - Thrust Block Specifications'
Ue511y11Cf 111dy hIVVIUe UHWIL L]IUL K Ut.tdrlb U11 bt:PdldlC JIICCt.
THRUST BLOCK
LOCATiO,`i I AREA (sq. R.)
40' Bend
Dead End
Tee 1
1See USDA•NRCS Fi_Id OfGee Technical Guide, Section IV, Practice Code 430-DD.
L
Irrigation Parameters USDA -MRCS
October 1995 paged North Carolina

IRRIGATION SYSTEM DESIGNER
Name: ito t
Company Gra-Mac Dist ibutin Company
Address: 2310 NC ffLqy 801 N Mocksville NC 27028
Phone: [phone]
REQUIRED DOCUMENTATION
The following details of design and materials must accompany all irrigation designs:
1. A scale drawing of the proposed irrigation system which includes hydrant locations, travel lanes, pipeline routes, thrust block
locations and buffer : reas where applicable.
2. Assumptions and computations for determining total dynamic head and horsepower requirements.
3. Computations used to determine all mainline and lateral pipe sizes.
4. Sources and/or calculations used for determining application rates.
S. Computations used to determine the size of thrust blocks and illustrations of all thrust block configurations required in the system
6. Manufacturer's specifications for the irrigation pump, traveler and sprinkler(s).
7. Manufacturer's specifications for the irrigation pipe and/or USDA-NRCS standard for Irrigation Watez- Conveyance,
N.C. Field Office Technical .Guide, Section IV, Practice Code 430-DD.
8. The information required by this form are the minimum requirements. It is the responsibility of the
designer to consider all relevant factors at a particular site and address them as appropriate.
Irrigation pipes should not be.installed in lagoon or storage pond embankments without the approval
of the designer.
NOTE: A buffer strip 25 feet wide or wider must be maintained between the limits of the irrigation system and all perennial
streams and surface waters per DEHNR-DENT Code Section 15A NCAC 2B .0200 - Waste Not Discharged to Surface
Waters.
Irrigation Parameters USDA44RCS
October 1995 -Page-5 North Carolina

Narrative of Irrigation System Operation
Describe the operation of the -system in the space provided below or on a similar sheet most convinient to the designer/supplier.
Include procedures such as start-up, shut -down, winterization and regular maintenance of all equipment.
1?xwBrr D-6
NRCS, NC
JUNE, 1996

GRA-MAC DffSTfflBUUNG COMPANY
Design — Sales — Service
COMPLETE IRRIGATION SYSTEMS
TELEPHONE: ADVANCE EXCHANGE
1910Y 995-3232
` 19101 998-3800
NC TOLL FREE 1.600-422-3560
Specifications Sheet
HenryWalicer
2310 NC HWY. 801 N
MOCKSVILLE. N. C, 27026
1. Acres under traveler coverage is ± 15.5 acres.
2. Traveler is a Kifco E27A with 820` of 2.7" ID PE Tube and a Nelson SR100 Gun.
3. Nelson SR100 Gun performance with a .8 Taper nozzle is 155 GPM, 295' Diameter
@ 70 PSI.
4. Travel lane spacing is ± 208'.
5. Pressure loss in 820' of 2.7" ID PE hose is 36 PSI.
6. Friction loss in ± 1000' of 4" kluninum Pipe is .8 PSI/100' or 8 PSI total.
7. Pressure requirements are as follows:
Gun 70 PSI
820' of 2.7" ID PE hose 36 PSI
1000' of 4" Aluminum pipe 8 PSI
Elevation ± 30' 13 PSI
Misc. 3 PSI
130 PSI or 300 Head Feet
3. Application Rate is as follows:
96.3 X GPM 360
3.14 X .9 (radius) 2 X ARC
96.3 X 155 X 360 _ .33 In/Hr
3.14 X .9 147.5 2 300
9. Travel Speed is as follows:
19.26 X GPM
Lane Space X App. Rate
19.26 X 155 ' $
208 X .33 = 42.1 In/Min
3. C-
�3151 Ft/Min
210 Ft/Hr

r
GRAd1"SLAG DISTRIBUTING (COMPANY
Design — Sales — Service
COMPLETE IRRIGATION SYSTEMS
TELEPHONE: ADVANCE EXCHANGE
i9i0) 998.3232
[phone]
NC TOLL FREE 1-800.422-3560
Specifications Sheet
Henry Walker
Page
2310 NC HWY. BO1 N
MOCKSVILLE, N. C. 27028
10. Pump is a Kifco NT120S 540 PTO Slurry pump. Pump horsepower requirement for
155 GPM @ 130 PSI is ± 30 BHP. We would recorunend at least a 60 HP tractor
to operate this pump.
11. Pump maximwns are 150 PSI and 550 GPM.
12. Conditions will exist when waste water irrigation should not be performed.
These include when soils are frozen or saturated after rainfall and when
there is excessive winds, ± 10 mph. Length of time after rainfall events
will depend on drying conditions.

Glf A -MAC DISTMBUTING COMPANY
Design — Sales -- Service
COMPLETE IRRIGATION SYSTEMS
TELEPHONE: ADVANCE EXCHANGE 2310 NC HWY, 801 N
(9M 998-3232 MOCKSVILLE. N. C. 27028
1910) 998-3800
NC TOLL FREE 1.800-422.3560
Operations Sheet
HenEy Walker
System Start --Up
1. Position pump and place suction hose in the lagoon.
2. Attach aluminum pipe to pump.
3. Attach traveler to aluminum pipe at one of designed pull locations and
slowly pull out traveler hose.
4. Make sure pump discharge valve is tightly closed.
5. Prime pump. When engaging PTO, gradually open pump discharge valve.
6. Engage tractor PTO -and allow to idle until all air is out of system lines.
7. Raise tractor engine speed until designed pump pressure is met.Open valve fully.
8. Start traveler engine and engage hose -rewind to proper speed setting.
9. Observe the system to make sure that it is operating properly.
System Shut -Down
1. Traveler engine will stop at the end of the travel.pull.
2. Lower the tractor engine speed to idle.
3. Close pump discharge valve slightly.
4. Stop tractor PTO.
5. Close pump discharge valve fully.
6. Move traveler to next designed location or to storage area.
Winterization
1. Be sure to DRAIN both PUMP and TRAVELER.
Maintenance
1. Follow all maintenance_ manuals supplied with the'system.. 2. Replace any worn or damaged parts as soon as possible.
3. Have an emergency plan in place in case of system or equipment failure.

BIG GUN° PELFORMANCE TALES U.S. UNITS
100 SERIES BIG GUNS - 240 TRAJECTORY**
100 T 1APER BORE NOZZLES
ozzla
Nozzle
Nozzle
Nozzle
Nozzle
Nozzle
Nozzle
Nozzle
Nozzle
Nozzle
5•
55"
.6'
.65"
.7"
.75'
115"
9•
1A'
Z
GPM D7A,
GAM DIA.
GPM DIA.
GPM DIA.
GPM DIA.
GPM DIA.
GPM DIA.
GPM DIA.
GPM DIA.
GPM DIA.
i
r
3ra:21�'i
z
9_. rr."
�e7:1 .
q,:,sz
xg
50
50 205,
64 215'
74 225'
87 235'
100 245'
115 256'
130 265'
150 273'
165 280'
204 300'
r
+
,no,
60 225'
75 238'
88 250'
103 263'�
120 275'
136 283'
177 302'
197 310'
243
12
- _ 4,
83 258'
t -1
1,�8 28„`t
'.� - �S'
;3., :i11'rt
g
201 326'
72 93a
w-
223 y335
R ' •
._r
"274 382''
• t Z2'
90
68 245'
100 270'
117 283'
135 295"
143 - 3 5
155 306'
�183 t¢ ti:
175 315'
� , 3 .'
100
S5
8-t 88
10012=
W ' N33
110
76 265'
92 278'
11l 290'
129 303'
150 315,
171 324'
195 335'
222 344'
247 355'
304 380'
Avaaame omy wan r•1 uu C amluu.
100 R RING NOZZLES
100 DN DIFFUSER NOZZLES
PSI
.71 RING
GPM DIA
.77 RING
GPM DIA
.81 RING
GPM DIA
.86 RING
GPM DIA
.89 RING
GPM DIA
.93 RING
GPM DIA
.96 RING
GPM DIA
0.5 ON
GPM DIA
0.6 DIN
I GPM DIA
0.7 ON
I GPM DIA
0.8 DN
I GPM DIA
40
-
66 2Q8
78 212
91 215
103 224
116 235
134 238
152 242
Z.11 a
45 154
sa yes
66 168
91 182
118 196
-
60
81 235
96 240
110 245
YI 4p
125 260
�129f2-5-CM
54 2s
141 270
164 275
183 280
— —
— —
110 200r'
143 216
70
80
94 255 y
111 265
127 275
145 285
290 -
r163 300
a- 9 r3✓€.295a�
e- 18�
-
,•!�•- -
169 305
211 315
— —
— —
— —
2Z5
t34?2
8
�73 zQ2Q1
782 320
'315
212 325
236 335
100
705 270
124 280
142 295
162 305
-
-
-
r,�,J
7. 0' i27 „E..
A..1 _0}� 0-, _
49
1IQk,;, i
194Alf325*,,;
• 222,,335�
.246.1.345�'!
3 '; ,.--•Y-
-
i ne ararmerer or rnrow is apprmrrmarery o sass for me z1" iraleaory angle, ere toss Tor in-
150 SERIES BIG GUNS - 24° TRAJECTORY**
150 T TAPER BORE NOZZLES
P.S.I.
Nozzle
.7'
GPM DIA.
Nozzle
-8"
GPM DIA.
Nozzle
.9'
GPM DtA.
Nozzle
1.0'
GPM DIA.
Nozzle
1.1'
GPM DIA.
Nozzle
1.2'
GPM DIA.
Nozzle
- 1.3'
GPM DIA.
_
143 285,
1�t50is8'L�2Q6'
182 305,
' �39"
225 325'
5�L` 330
275 345'
`
330 365'
�.;,.
385 380'
60
110 265'
80
128 290,
165 310'
^
260 355'
315 375'
. �3.5tw �p?'�
355 400'
�T_g10-,.
380 395'
?,�Ab�i1�a'�'
425 420'
GT�45j
210 335'
445 410'
47 -
S00 "0'
§t7
100
'
143 ,310'
185 330'
�:
- '��'!
235 355'
,, 2Z5`a"!C.�"'-�• 363:
290 375'
dl
120
�al6.14.2�
157 330'
1.f.Q
204 350'
T s3& ,
258 375'
3a.. a5'aar
320 395'
.r< "y460'
385 420'
465 440'
545
150 R RING NOZZLES
Ring
Ring
Ring
Ring
Ring
Ring
Ring
.861
W.
1.08"
1.18'
1,26"
1.34'
1.419
P.S.I.
GPM DIA.
GPM DIA.
GPM DIA.
GPM DIA.
GPM DIA,
GPM DIA.
GPM DIA,
r
t
ftiga "� �.
S.iit32q
300�L3r15
60
110 260'
143 280'
182 300,
' 225 315'
245'NoS `
275 335'
�9- - 5 , O
330 350'
385 365'
NOS '
l
128 280'F
315 360'
+
.
380 380'
•e'i9
80
165 300'
210 320'
260 340'
22581 -dC'
445 395'
1
'ri
J4
100
143 300'
185 320•
235 340'
290 360'
355 380'
7a9o►
425 400•
500 415'
4�.15'
oa7p -
�4Aa
n� 4f5
120
157 315'
204 335'
259 360'
320 380'
385 40D'
465 420'
545 435'
'The diameter or throw is approximately 34t less Tor the 21" trajectory angle.
200 SERIES BIG GUNS - 270 TRAJECTORY**
200 T TAPER BORE NOZZLES
Nozzle
Nozzle
Nozzle
Nozzle
Nozzle
Nozzle
Nozzle
Nozzle
Nozzle
1.05'
1.1'
1.2'
1.3"
1.4"
1.6"
1.61
1.75'
19"
P.S.I.
GPM DIA.
GPM DIA,
GPM DIA.
GPM DIA.
GPM DIA.
GPM DIAn.�-w,tt
GPM DIA.
GPM DIA,
EMS
MOMS=
7 r
_ it '
8 'Y.
1 rt'-.5
!mil 1r` Y-iFu-
7rlGPM wDIIA�..
�.'�bi65 �app'A.+.a�.
ff--R�Qal
9
70
270 360'
310 380'
355 395'
415 410'
480 430'
555 45D'
630 465'
755 495'
890 515,
a1�1�
'dap
-"
' 7U�
9 .7'?L-'M`
M-677I' L WL' [
EMKST533M`F
90
310 390'
350 410'
405 425'
475 445'
545 465'
625 485'
715 505,
855 535,
1005 555'
l-61
'-"�'
7A
2 - 0'
S 460'
7.55MR-AM,
5$ p-0 M
"755 ' ZO'
xx T993-0-5A
605 495'
110 j
340 410'
1 390 430' 1
445 450'
525 470'
695 515,
w725�530
790 535'
u$A 825 G!Ko
945 565'
1110 590'
L60 ffA r
123:1 .
5 0'
465' 460
545 480°
�G30y, a505
85 -
13D
370 425
425 445
485 465'
565 485'
655 515'
755 540'
860 560'
1025 590'
1210 620'
K@TeN;1[;1T,11c1V1e)*A11*y
P.S.I.
1 y4" Ring
(1.29' actual)
GPM DIA.
1 35' Ring
(1.46' actuary
GPM DIA.
1 'h" Ring
(1.56' actual)
GPM DIA,
1 %" Ring
(1.66' actual)
GPM DIA.
1 i4° Ring
(1,74' actuaq
GPM DIA.
1 7/6" Ring
(1.83' actual)
GPM DIA.
2' Ring
{1.93' actual)
GPM DIA,
�&0&0=00MI3
60
r
250 340'
M&PQffi=WiL2M
0150.t, 70., `
385 390,
=00i=:�EOMff`
445 410'
r q7� : 3. Q=bWgMi20'
515 425'
'' 1+
695 455'
330 370'
585 440'
Tut
80
=vIQIMMi kM.
290 370'
M
300 400'
az '4 r. CfS=
445 420'
"s48Q 7425' �?
515 440'
''`-�•55r4,40=
590 455'
' WM6 M T59
675 470'
805 490'
9Q;kr
100
�a��_x 3i o wFi
1 325 390'
�40 5s rdSa
_ 4 5'F a351't aL4
545t1<? 3 455 r "
575 465'
N --T-1 47U n e�
660 480'
725 500
�is'F75S�=^+; OS',r
x Z1 S 1.48 .'
I -, 855x.. a50
900 520'
425 425'
Soo 445'
755 500'
630 485'
825 520'
:.;a Wi 680 ,; 525C.�b.'.'T
985 545'
-, :; 1025'. 3,":.s5S(is =�
120
355 410'
1 465 445
545 465
4•w13I1nf
.:1 70, s'41501, ;S
T ' ,_485- ..q:i..
" �:�ty565�"c,' 70 -.• ,;.n
.,yt:-,655 =`4 OY+7,,.--
'The diameter of throw is approximately 2% less for the 24" trajectory angle, 5% less for trio 2 1 - trajectory angle.
The BIG G11W performance data has been obtained under ideal lost conditions and may be adversely affected by wind, poor hydraulic entrance conditions or other factors.
Nefsan Irrigation Corporation makos no representation regarding droplet condition, uniformity, or application rate.

4, .
Kifco Slurry Pumps
Models NT120S and FRT94135
Pump Models:
NT120S: Single stage, closed impeller centrifugal pump with a mechanical seal and
integral gearbox. The wide design impeller is capable of passing a maximum 3/4" solid.
Three gearbox ratios are available, they are for the following input speeds: 540rpm,
1000rpm & 2000rpm. The 2000rpm pump is built to run direct from an engine and it
rotates in the opposite direction to the PTO pumps.
FRT94/35: Single stage, open impeller centrifugal pump with a mechanical seal and
integral gearbox. The pump will pump most animal waste slurries except long fibrous
material which must first be run through a chopper. The pump includes a stationary knife
which will slice through materials that ball up at the eye of the impeller. The pump is
very aggressive with the material being pumped. It is made from spheroidal graphite
(SG) iron which is twice as strong and four times tougher than regular iron. The gearbox
ratios are the same as those listed for the NT120S above.
PTO Models are mounted on a two wheeled heavy duty cart, the large diameter wheels
are 6.70 x 15 and run on ball -bearing hubs. Pumps mounted on carts are available with
the PTO drive shaft only or fully fitted as described below:
Unfitted Pumps include:
Fitted Pumps as above plus:
Bare Pump
Pump Cart
PTO Drive Shaft
Discharge Fitting
Heavy-duty Discharge Valve
Suction Fitting c/w Check Valve
Priming Pump c/w Easy Flush Line
Pressure Gauge
Gauge Protector
Fully fitted models have a 4" NPT discharge and a 6" Bauer style quick connector
on the suction.

• I 1 0
250
200
PSI
150
100
750
100
HP
50
0
50 100 150 200 250 300 350 400 450 500 550 600 650
GPM
Performance and HP at full speed and full impeller dia. --
(Input speeds = 540, 1000, 2000 depending on the gearbox ratio)
Increasing the speed on the engine driven pump to 2200rpm will
increase the pressure by 40 psi. Contact your local dealer or Kifco
for details of horsepower and performance changes.
300
250
PSI 200
150
100
200
150
HP
100
50
0
NT120S Pump Performance
9
FRT94/53 Pump Performance
A
50 100 150 200 250 300 350 400 450 500 550 600 650
GPM
Curve A = Performance and HP at full speed and full impeller dia.
(input speeds = 640, 1000, 2000 depending on the gearbox ratio)
Curve B = Performance and HP at 90% of full speed or at full speed with trimmed impeller.
[Aft I
GItA MAC DISTRIBlJTING CO.
2310 Nc HM 801 N
600 S. Schrader Ave., P.O. Box 367, Havana, IL 62644 MO (910) 998 3232028
Phone [phone] Fax [phone]
2ec:_sa ct =mLing prec., 7 r vements. photos N martins in o3leafet may no: be iden;caY tp curent dodumn. he aertarmanu inlomtaaon in the leallWs rased on less conductm umer a parz"w se; at..nci:w s. A=j `.e!d
_er-"aree rav vary imr -,:s cno npn ram an vannna nrrm­­ -4 — '­ w - , nten­ ­rtAMer„ ­ nMm lx• , Cry.irf+Me 3.'n --.1. e' �—^ . . '

State of North Carolirlo
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
HENRY L. WALKER
HENRY WALKER FARM
1493 GODBEY ROAD
MOCKSVILLE, NC 27028
Dear Henry Walker:
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONME.hQ; AN�NATURAL RESOURCES
March 23, 2000 N.C. Dep . of EHNR
MAR 3 0 2000
Winston --Salem
x9egional Office
Subject: Certificate of Coverage No. AWC300003
Henry Walker Farm
Cattle Waste Collection, Treatment,
Storage and Application System
Davie County
In accordance with your application received on June 16, 1999, we are forwarding this
Certificate of Coverage (COC) issued to Henry L. Walker, authorizing the operation of the subject
animal waste collection, treatment, storage and land application system in accordance with General
Permit AWG200000. This approval shall consist of the operation of this system including, but not
limited to, the management of animal waste from the Henry Walker Farm Farm, located in Davie
County, with an animal capacity of no greater than 300 Beef feeder calves and the application to land as
specified in the Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP , and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the
General Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance
with NCGS 143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive
relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
P.O. Sox 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

' 1
jr
Certificate of Coverage A00003
I Henry Walker Farm
`Page 2
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an'' non -discharge permit by contacting the engineer listed below for
inf6flnati6n on this�'process.- Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Winston-Salem Regional Office. The Regional Office Water
Quality Staff may be'Yeached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact Susan Cauley at [phone] ext. 546.
Sincerely,
"Ci5 Kerr T. Stevens
cc: (Certificate of Coverage only for all cc's)
DavieCounty Health Department
Winston-Salem Regional Office, Water Quality Section
Davie County Soil and Water Conservation District
Permit File
NDPU Files

State of North Carolina yr��•�.
Department of Environment and Naturatesources =`Y•�
Division of Water Quality
Non -Discharge Permit Application Form r
(THIS FORM MAYBE PHOTOCOPIED FOR USE AS AN ORIGINAL)-',,_ '
General Permit - Existing Animal Waste O.pe-r-ations.,� '
The following questions have been completed utilizing information o I I
le i'th� 9I"As On. Please
review the information for completeness and make any correction
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered. MAR 3 0 2000
]. GENERAL INFORMATION: Winston-Salem
1.1 Facility Name: HenryWalker Farm Regional Office.
1.2 Print Land Owner's name: Henry L. Walker
1.3 Mailing address: 1493 Godbey Road
City, State: Mocksville NC Zip: 27028
Telephone Number (include area code): [phone]
1.4 County where facility is located: Davie
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): 64 W. from Mocksville left on Godbey Rd. I st brick
house after crossing concrete bride over Hunting Creek
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed):
L8 Date Facility Originally Began Operation: 01/01/67 /
1.9 Date(s) of Facility Expansion(s) (if applicable): 1J / ,I
2. OPERATION INFORMATION:
2.1 Facility No.: _30_ (county number); _3 (facility number).
2.2 Operation Description: Cattle operation
I ))airy
300- Certified Design Capacity
Is the above information correct? 121
yes; no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number for which the waste management structures were designed.
Type of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle No. of Animals
0 Wean to Feeder 0 Layer 0 Dairy
0 Feeder to Finish 0 Non -Layer 0 Beef
0 Farrow to Wean (# sow) 0 Turkey
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals:
FORM: AWO-G-E 5/28/98 Page I of 4 30 - 3

•
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 49.5 ; required Acreage (as listed in the AWMP): 29.0
2.4 Number of lagoons/ storage ponds (circle which is applicable): I
2.5 Are subsurface drains present within 100' of any of the application fields? YES or (NO) (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or INO) (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, MRCS Standards, etc.) (Swine Only)
YES or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited?
What was the date that this facility's land application areas were sited?
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components. Some of these components may not
have been required at the time the facility was certified but should be added to the
CAWX[P far permitting purposes:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 , The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
33.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
Applicants Initials
/-/ L tJ
if L J
FORM: AWO-G-E 5/28/98 Page 2 of 4 30 - 3

r
Facility Number: 30 - 3
Facility Name: Henry Walker Farm
4. APPLICANT'S CERTIFICATION:
[, (Land Owner's name Eisted'in, estion 1.2), attest that
this application foriytc� Li �GY (Facility name listed in question 1.1)
has been reviewed by meiffid is acct%te and complete to the best of my knowledge. 1 understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included. this application
package will be returned to me as incomplete.
Signature
5. MANAGER'S
M
Date zz
TIFICATION: (complete only if different from the Land Owner)
(Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX -NUMBER: [phone]
FORM: AWO-G-E 5/28/98 Page 3 of 4 30 - 3

Ct47-16 Al 1\4
c 0 u N -T y
um
tal
ML
-1100
13
ME
Lou -.3:,
I.w Ina.
Ml
tj
ul. c— lQ* J=
9 LLM
Ion;
%jId
IJ
WIS. 10 10-1
up
lm
im
i W
DOLE.
7-
10
t 1st fo P, n,
W
T­
%Y C,
AS
WATER
'JUP]
Nan -Discharge Perri
lung

r' AttachraenL
North CIRlina Agriculturcrl E. nsion Service 1of $
Agri -Waste Management
Biological and Agricultural Engineering North Carolina State University
LIVESTOCK WASTE SAMPLING. ANALYSIS AND CALCULATION
OF LAND APPLICATION SATES
James C. Barker*
I. SAXPLE COLLECTION
A. Semi -Solid Lot Manure
i. Scraped directly from lot into spreader
a. From loaded spreader, collect about 2 lbs of manure from
different locations using nonmetallic collectors.
ii. From storage
a. Collect about 2 lbs of manure from under the surface crust
avoiding bedding materials and using nonmetallic collectors.
B. Uquid Manure Slurry
L. Under -slotted -floor pit
a. Extend a 1/20 nonmetallic conduit open on both ends into
manure to pit floor.
b. Seal upper and of conduit (e.g.. by placing a thumb over end
of conduit) trapping manure that has entered lower and, remove
and empty slurry into plastic bucket or nonmetallic container.
c. Take subsamples fzom 5 or more locations or at least 1 quart.
d. Iiix and add about 3/4 pint to nonmetallic sample container.
ii. Exterior storage basin or tank
a. Make sure ma -sure has been well mixed with a liquid manure
chopper -agitator pump or propeller agitator.
b. Take subsamp'_es from about 5 pit locations. from agitator pump
or from ma::__e spreader and place in a plastic bucket.
* Professor and Extension Specialist. Biological and Agricultural Engineering
Department. North Carol; a State Universit•, Raleigh, NC.

Attachment .
2 of 3
2 -
c. Mix and add 3/4 pint to a nonmetallic sample container.
C. Lagoon Liquid
1. Collect about 3/4 pint of recycled lagoon liquid from inflow pipe
to flush tanks in a nonmetallic sample container.
ii. From lagoon
a. Place a small bottle (1/2 pint or less) on end of 10-15, pole.
b. Extend bottle 10-15' away from bank edge.
c. Brush away floating scum or debris.
d. Submerge bottle. within 1' of liquid surface.
e. Empty' into a plastic bucket, repeat about 5 times around
lagoon, mix, -and add 3/4 pint to nonmetallic sample container.
D. Broiler or Turkey Litter
L. House litter
a. Visually inspect litter for areas of varying quality, e.g..
areas around feeders and waterers, and estimate percent of
floor surface in each area.
b. Take about 5 litter subsamples at locations proportionate to
item a. E.g., if 20% of litter of similar visual quality is
around feeders and waterers. take 1 subsample there and the
other 4 subsamples from remainder of floor' surface.
c. At each location, collect litter from a 60 by 6" area down to
'earth floor and place in a plastic bucket.
d. After 5.subsamplas have been added to the bucket, mix, and add
about 2-3 lb s litter to a nonmetallic sample container such as
a 1-gallon freezer bag and seal.
ii. From stockpile
a. Take subsamples from about 5 locations a = least 18" into pile.
b. Mix, add 2-3 lbs to nonmetallic sample container and seal.

' � r
-3-
II. SAMPLE PREPARATION AND TRANSFER
Attachment
3 of 3
A. Place sample into an expandable container that can be sealed. Rinse
residues from container with clean water but do not use disinfectants,
soaps, or treat in any other way.
B. Pack sample in ice, refrigerate, freeze, or transfer to lab quickly.
C. Hand -delivery is most reliable way of sample transfer.
D. If mailed, protect sample container with packing material such as
newspaper, box or package with wrapping paper, and tape.
E. Commercial sample containers and mailers are also available. Contacts:
i. AhL Eastern Agricultural Lab.
7621 Qhitepine goad
Richmond. VA 23237
Ph: [phone]
ii. Fisher Scientific Co.
3315 Winton Road
Raleigh, NC 27604
Ph: [phone]
Inc. iii. Polyfoam Packers Corp.
2320 S. Foster Avenue
Wheeling, IL 60090
Ph: [phone]
iv. NASCO
901 Janesville Avenue
Fort Atkinson, WI 53538
Ph: [phone]
F. Private analytical labs are available. but sample analyses are costly.
G. The NCDA provides this service for North Carolina residents.
i. Address: North Carolina Department of Agriculture
Agronomic Division
Plant/Vaste/Solution Advisory Section
Blue Ridge Road Center
P.O. Box 27647
Raleigh, NC 27611
Ph: [phone]
Attn: Dr. Ray Campbell—
ii. Forward $4 along with the sample.
iii. Include the following identification information with sample:
a. Livestock srecies (dairy, swine, turkey, etc.)
b. Livestock usage (swine. -nursery, finishing; turkey -breeders,
brooderhouse, grower, number flocks grown on litter; etc.)
c. Waste type (daisy -lot scraped manure, liquid slurry; swine -pit
slurry, lagoon liquid, sludge; broiler -house litter, stockpile
iv. Routine analyses performed on all samples: N, P, R, Ca. Mg, Na.
S, Fe. tin, Zn, Cu, B
v. Additional analyses performed upon request: DM. Mo, Cd, Ni, Pb

CALIBRATION OF MANURE SPREADERS
EZecdve utilization of manure is not possible if you do not know how muc:t is being spread over a
given area. Calibration of vour spreader is a simple and effective way of improving utikiz3tion of
nutrients in manure more effectively. Or& by know-ina &.a application mEe ofyour spreade., can you
correctly apply manum to correspond to your crop needs and pmvent ovate. Quality probierns throuzh
the over application of animal manure.
Applicators can apply manure, at varying rates and patterns, depending on fonvard travel and/or
PTO speed. gear box sestinas, ¢ate openings. operating pressures. spread widths and ove:fans.
Calibration defines the combinanon or settings and navel speed needed to apply manure, beddinc
or wastewater at a desired rate and to ensure uniform application. V
Spreader Capacity
Liquid spreader capacities are normally rated by the manufacturer in gallons. 'Multiply by 0.0042
to get tons.
Solid and semi -solid spreaders are rated by the manufacturer either in bushels or cubic feet
(multiply bushels by 1.24 to get cubic feet). Most spreaders have two rating capacities: (I) struck
or level full, and (2) heaped. Calibration of solid manure spreaders based on its capacity
(volume) is difficult to estimate accurately because the density of solid and semi -solid manures ._
are quite variable. Density is the weight of the manure per volume of manure ( pounds per cubic
foot). Manure density varies depending on the type and amount of bedding used as well as its
storage method. Therefore, if you estimate spreader application rates as the volume of the
manure the spreader holds you are overlooking the fact that some manure weighs more than other
manure. This can cause a significant error when calculating manure application rates.
Since manures and litters have different de.Zsities, an on -farm test should be done. To determine
the load (tons) of a manure spreader:
I. Weigh an empty S-gallon bucket.
2. Fill the bucket level full with the material to be spread. Do not pack the mate. -,;al in the
bucket but ensure that it sertles similar to a loaded spreader.
Wei;h the bucket again. Subtract the empty bucket weigh=.:morn this weight to calculate
the weig n of the contents.
s. 'Multiply,,veigat or contents by IS to calculate pounds per cubic fee:, density.
LPL:.1P—..1=r_a . . t"•o- �-

5. tiluitiply the manure density by the cubic feet capacity of the spreader and divide by 2000
to set the tons of material in a spreader load.
weiThE of 5 zai manure x 1.5 x c_^ C.ry
Spreader load (teas)
=000
Solid and Semi -Solid Manure Spreaders
In order to ca[ibrate a spreader for solid manure (20 p,e;cent or more solids), the oilo« nQ
materials are needed:
1. Bucket
2. Plastic sheet, tarp or old bedshee:.:kn even size. 8 feet by 3 feet, 10 tee,. by 10 _-et% or 12 feet
by 12 feet, will make calculations easier. ,
3. Scales
Calibration method:
1. Locate a large and reasonably smooth,, flat area where manure can be applied.
2. Spread the plastic sheet, tam or bed sheet smoothly and evenly on the ground.
.3. Fill the spreader with manure to the normal operating IeveL Drive the spreader at the
normal application speed toward the sheet spread on the ground. allowing the manure to
begin leaving the spreader at an even, normal rate. Y
4. Drive over the sheet at the normal application speed and settings while continuing to
apply manure. If a rear discharge spreader is used, three passes should be made: first_
drive directly over the center of the sheet, the other two on opposite sides or The center at
the normal spreader spacing overlap.
5. Neigh the empty bucket and plastic sheet, tarp, or blaake-
6. Collect all manure spread on the sheet and glace it into the bucket.
7. Neigh bucket and manure and suctract the weiazht of the emt:rr bucket and around sheet.
This will give you the pounds of manure applied to the she_:.
3. Repeat the procedure three tirt;es to get a reliable average.
9. De: --. —nine the average weight of the three manure apolicador_s.

10. Calculate the application rate using the following forrnula or Table 5-3:
Application rate (tonvacr_)
1b manure collected x 31.73
shee: length (ft) x shr_t %vidth ( )
11. Repeat the procedure at different speeds and/or spreader se:tin_es until the desired
application rate is achieved.
Example -
What is the application rate (tons per are) if you collect 3.e pounds or _.nanure on a 10-foot by
10-foot tarp during a calibration run? +
Application rate (tonsvacme) m 3.: lb maloft. x . x loft x 21.73 a 1.31 tonsracm
Table 5-3. Calibration of Solid Manure Spreaders
Pounds of Manure
Tons of Manure Applied/Acre
Applied to Sheet
Size of Ground Sites
S.x3.
10•x 10'
12'x 12'
1
0.34
022
US
?
0.63
0.44
0.30
3
1.02
0.65
0.45
4
1.36
0.3'7
0.61
5
1.70
1.09
0.76
6
2.04
1.31
0.91
7
2.38
1.52
I.06
3
2.72
1.74
1-21
9
3.06
1.96
1.36
10
3.40
2.13
1.51
15
5.10
3.27
2.27
20
6.31
4.36
3.03 -
tilany times it may be necessary to adjust the rate in which waste is applied from the way it is
normally spread. Changes in application rate can easily be done by inc..3sing or decreasing the
speed in which the waste is being applied. In order to perform these calculations, the spreader
load (tons), duration of application (minutes), and the average width (feet) of a normal
application needs to be known- The application rate and travel steed c= be found using the
following equations:
Application race (tensiicre) = spreader load (tons} x Mgr
time (min) x width (ft) x travel (mph)
sode. !oad (tons) x 49J
Tavel speed (mph) = nx applicadcn rate:I-c;=ac.e)
time {thin) x width (ft)

Example:
What speed should you run if you wish to apply 4 tons of manure per acre with a 3-ton spreader?
Your spreader application widt_`: is 20 feet and your spreader emucies in 6 minutes.
Trave! s..e`d (mph)
Spreader Pattern tiniforrniry
3 tons x 495
6 ruin x 30 ft x ; tons-ac:_-
..1 . zh
To determine the uniformity of spread and the amount of overlap needed, place a line of srnall
pans or trays equally spaced (2 to 4 feet) across the spreader path. The pans should've a
minimum of 12 inches by 12 inches (or 15 inches in diameter), but no more than 241 inches by
24 inches; and ? inches to 4 inches deep. Make one spreading pass directly over the center pan.
Weigh the contents caught in each pan or pour_ the contents into equally sized glass cylinders or
clear plastic tubes and compare the amount in each. _ r
T'ne effective spread width can be found by locating the point on either side of the path center
where manure contents caught in the containers is half of what it is in the center. The distance
between these points is the effective spreader width. The outer fringes of the coverage area
beyond these points should be overlapped on the next path to ensure a uniform rate over the
entire field. "Flat -top," "pyramid," or "oval' patterns are most desirable and give the most
r' uniform application. "Li," " W." "steeple," or "lopside" parterns are not satisfactory and one or
more of the spreader adjustments should be made.

landowner/Operator Name:
Address:
Telephone:
TABLE 1 - Field Specifications
IRRIGATION SYSTEM DESIGN PARAMETERS
r7eYlr w G County: �IQi/iG
oeksv� 2 D�$ Date:
MGMIT D-1
Fleldl
Number
Approilnnale
6ia11111wn
Useable Site
ofField2
(acres)
Solt Type
Slope
(%)
Crop(s)
Maxlnnunt
Appllcatlon
Rnte3
(In/!!h'+r)
Maulrnwn
Appticatlon
per IrrlgalIon
tYcle3
(inches)
Conunents
�.0
3i 2-
217-
S a ire-
•Tb
1,60
CcCi 5q c/QV loget,2257s/o
1See atluched map.
21,011,1 field acreage minus required huller areas.
311efer to 14. C. Irrigation Guide, Field Office Technical Guide, Section 11 G, Annual application must not exceed the apronomic rates for the soil and crop used.
P�
NRCS, NC
TUNE, 1996

TABLE 2 - Traveling Irrigation Gun Settings Henry Walker Beef Operation, Davie Co. NC
Make, Model and Type of Equipment: Kifco E27A w/ 820 of 2.7" 11) PE Tube, Nelson TSRl00 Gun Nv/ .8 Taper- Nozzle
Field No'
and
Hydrant No'
Travel
speed
(ft/ntin)
Precip.
lute
(in/hr)
Application
Depth Per
cycle
(ft)(ft)
Travel Lane
Effective Effective
Width Length
(ft)
Wetted
Diameter
((eel)
EQUIPMENT SETTINGS
Nozzle Operating Operating Arc
Diameter Pressure Pressure Pattern
(inches) r ,Gun (Psi) (Psi) (degrees)
COMMENTS
1 -1
3.51
.33
.33
208
644
295
.8
70
106
300
3.1 acs.
1 -2
351
.33
.33
208
675
295
.8
70
106
300
3.2 acs.
1 -3
351
.33
.33
208
467
295
.8
70
106
300
2.2 acs.
1 -4
351
.33
.33
208
579
295
.8
70
106
300
2.8acs.
' See attached snap provided by the Field Office for field locations(s).
Show separate entries for each hydrant location in each field.

S8S9s
:�) . I a C-s
,9A
C-�ec-t ►�--� ,C.emy�
r-
/33, 95 oZ� ; q-3�5G ofetlq
G Iro It + (,-?, SS' x 4NO,
208
Co 75 4- 0, 40 0 :y �� --L 41

Vv ��, � Y1 it e✓'qbo
46I 1 # Z> = 908 '
1
elllq(-
5791
-57 ' X dV / - �pZV, 2r-S�Cjtlf f
v
3 ac,s

•
fir' t Q�'or� !�r{�►f'd�-,
Gi f c,U 1 atQj 4+304 koz -Fo r 7ri Qi p2 , 7 ./) 610 -4 k I
h4 7Z (n-AC) /,
t, gsz
o, 5 ,so _ 7- .E�t
3/,1S Ps
VCk to
c{ j oss/ao b �55 6PM ; A Ff ioo �4
i/i00-f 7+ x8 = I4S- G
(�2),3ps(

i
Co.
`��ep9
[; ds CdSZ, f,
/eu + 30'
'70y2si Cd Gun
a (311,
S
/3 •45��
30O 16-R
300, /sf� h-eocl cr
I Z9.4 Psi

TABLE 4 - Irrigation System Specifications
Traveling
Irrigation Gun
Solid Set
Irrigation
Flow Rate of Sprinkler (gpm)
155
operating Pressure at Pump (psi)
130
Design Precipitation Rate (irtlhr)
.33
Hose Length (feet)
820 -
XX7UCXXXX
Type of Speed Compensation
Mech .
XX. "XX
Pump Type (PTO, En=lne, Eieclric)
I PT0
Pump Power Requirement (hp)
+ 3OMP
-
i
I
TABLE 5 - Thrust Block Specifications'
Uestytter may YlUVIUe trltusL WIUUK Ueldiis vet acpdtdte srteet.
THRUST BLOCK
LOCATIOU AREA (sq. ft.)
90' Bend I ~
Dead End
Tee
iSee USDA -MRCS Field Office Technical Guide, Sed-+on IV, Practice Cade 430-DD.
A
•
W,
Irrigation Parameters USDA -MRCS
October 1995 page-4 North Carolina

IRRIGATION SYSTEM DESIGNER
Name: Rotmie Wall
Company:.,, Gra--Mac Distributing Co n
Address: 2310 NC ffEy 801 N Mocksvzlle NC 2702
Phone: [phone]
W
REQUIRED DOCUMENTATION
The following details of design and materials must accompany all irrigation designs:
1. A scale drawing of the proposed irrigation system which includes hydrant locations, travel lanes, pipeline routes, thrust block
locations and buffet areas where applicable.
2. Assumptions and computations for determining total dynamic head and horsepower requirements.
-. Computations used to determine all mainline and lateral pipe sizes.
4. Sources'and/or calculations used for determining application rates,
5. Computations used to determine the size of thrust blocks and illustrations of all thrust block configurations required in the system.
6. Manufacturer's specifications for the irrigation pump, traveler and sprinkler(s).
7. Manufacturer's specifications for the irrigation pipe and/or USDA-NRCS standard for Irrigation Water Conveyance, �.
N.C. Field Office Technical .Guide, Section 1V, Practice Code 430-DD.
The information required by this form are the minimum requirements, It is the responsibility of the
designer to consider all relevant factors at a particular site and address them as appropriate.
9. Irrigation pipes should not be installed in lagoon or storage pond embankments without the approval
of the designer.
NOTE: A buffer strip W2_ feet wide or wider must be maintained between the limits of the irrigation system and all perennial
streams and surface waters per DEHNR-DEM Code Section 15A NCAC 2B .0200 - Waste Not Discharged to Surface
Nvatei•s.
Irrigation Parameters USDA -MRCS
October 1995 page 5 North Carolina

Narrative of Irrigation System Operation
Describe the operation of the system in the space provided below or on a similar sheet most convinient to the designer/supplier.
Include procedures such as start-up, shut -down, winterization and regular maintenance of all equipment.
NRCS, NC
JUNE, 1996

TELEPHONE: ADVANCE EXCHANGE
19101 998-3232
19101 998.3800
NC TOLL FREE 1-800-422-3560
R A �USt ,tom D1fSTMBMNG
,r-- * AT
Design — Sales — Service
COMPLETE IRRIGATION SYSTEMS
Specifications Sheet
Henry Walker
2310 NC HWY, 601 N
MOCKSVILLE, N. C. 27026
1. Acres under traveler coverage is ± 15.5 acres.
2. Traveler is a Kifco E27A with 820' of 2.7" ID PE Tube and a Nelson SR100 Gun.
3. Nelson SR100 Gun performance with a .8 Taper nozzle is 155 GPM, 295' Diameter
@ 70 PSI.
4. Travel lane spacing is ± 208'.
5. Pressure loss in 820' of 2.7" ID PE hose is 36 PSI.
6. Friction loss in ± 1000' of 4" Al.iuninum Pipe is .8 PSI/100' or 8 PSI total.
7. Pressure requirements are as follows:
Gun 70 PSI
820' of 2.7" ID PE hose 36 PSI
1000' of 4" Aluminum pipe 8 PSI
Elevation ± 30' 13 PSI
Misc. 3 PSI
130 PSI or 300 Head Feet
3. Application Rate is as follows:
96.3 X GPM X 360
3.14 X .9 (radius) 2 ARC
96.3 X 155 X 360 = .33 In/llr
3.14 X .9 147.5 300
9. Travel Speed is as follows:
19.26 X GPM
Lane Space X App. Rate
19.26 X 155 's
208 X .33 = 42.1 In/Min
3, ro 1
= 3,51 Ft/Min
v -7
= 210 Ft/Hr

GRA-MAC DISTRIBUTING COMPANY
Design — Sales — Service
COMPLETE IRRIGATION SYSTEMS
TELEPHONE: ADVANCE EXCHANGE 2310 NC HWY. 801 N
(9101 996-3232 MOCKSVILLE, N. C. 27028
[phone]
NC TOLL FREE 1-800.422-3560
Specifications Sheet
Henry Walker
Page 2
10. Pump is a Kifco NT120S 540 PTO Slurry pump. Pump horsepower requirement for
155 GPM @ 130 PST is ± 30 BHP. We would recorunend at least a 60 HP tractor
to operate this pump.
11. Pump maximums are 150 PSI and 550 GPM.
12. Conditions will exist when waste water irrigation should not be performed.
These include when soils are frozen or saturated after rainfall and when
there is excessive winds, ± 10 mph. Length of time after rainfall events
will depend on drying conditions.

GRAB AC DISTRIBUTRNG C MPANY
Design — Sales — Service
COMPLETE IRRIGATION SYSTEMS
TELEPHONE: ADVANCE EXCHANGE 2310 NC HWY. 801 N
[phone] MOCKSVILLE, N. C. 27028
[phone]
NC TOLL FREE 1-800-422.3560
Operations Sheet
Henry Walker
System Start -Up
1. Position pump and place suction hose in the lagoon.
2. Attach aluminum pipe to pump.
3. Attach traveler to aluminum pipe at one of designed pull locations and
slowly pull out traveler hose.
4. Make sure pump discharge valve is tightly closed.
5. Prime pump. When engaging PTO, gradually open pump discharge valve.
6. Engage tractor PTO and allow to idle until all air is out of system lines.
7. Raise tractor engine speed until designed pump pressure is met.Open valve fully.
8. Start traveler engine and engage hose rewind to proper speed setting.
9. Observe the system to make sure that it is operating properly.
System Shut -Down
1. Traveler engine will stop at the end of the travel pull.
2. Lower the tractor engine speed to idle.
3. Close pump discharge valve slightly.
4. Stop tractor PTO.
5. Close pump discharge valve fully.
6. Move traveler to next designed location or to storage area.
Winterization
1. Be sure to DRAIN both PUMP and TRAVELER.
Maintenance
1. Fallow all maintenance manuals supplied with the system.
2. Replace any worn or damaged parts as soon as possible.
3. Have an emergency plan in place in case of system or equipment failure.

BIG GUN° P10.FORMANCE TA& .ES U.S. UNITS
100 SERIES BIG GUNS - 24° TRAJECTORY"
100 T TAPER BORE NOZZ EL S�
PS.I.LPM
Ozzie
'5'
D
Nozzle
'55'
GPM DIA,
Nozzle
.6"
GPM DIA.
Nozzle
.65'
GPM DNA.
Nozzle I
.7-
GPM DIA,
Nozzle
,75'
GPM DIA.
Nozzle
GPM " DIA.
Nozzle
.85'
GPM DIA.
Nozzle
.9"
GPM OIA.
Nozzle
1.0"
GPM DIA.
5o
L
�711
.
�90
Yi00:
Ir
I 50 205'
8
115 256'
204 300'
64 215'
74 225'
88 250'
87 235'
-
100 245'
=1
130 265'
150 273'
165 280'
60 225'
68 245'
76 265'
7$ 238'
177 302'
18
,326'
197" 310'
243 338'
103 263'
120 275'
135 295'
1 150 3i5' 1
i36 283
..�.1-$:y:
t55 306•
171 324•
mz
117 283'
1 129 303'
83 258'
92 278' 1
100 270'
111 290'
17$ 315'
1 195 335'
201
1 222 344'
223 335'
274 362'
1 247 355'
304 380'
Available only with F100 i4 SRi00,
100 R RING NOZZLES
100 DN DIFFUSER NOZZLES
P$i
.71 RING
GPM DIA
.77 RING
GPM DIA
.81 RING
GPM DIA
.86 RING
GPM DIA
.89 RING
GPM DIA
.93 RING
GPM DIA
.96 RING
GPM DIA
0.5 ON
GPM DIA
0.6 ON
GPM DIA
0.7 ON
GPM DIA
0.8 DN
GPM DNA i
.%a30Xr�Fiir'M4
40
" 'S0 �`.
60
,71i
80
too
• ai
:"r
66 208
'. `,r&711Z!;3 M
81 235
•'`%esizasr
94 255
105 270
f +
78 212
r=BBB--
91 215
Yi;`
103 224
ZZ�aS.-240=5
118 235
Z;t29.i2.50:M:
.22
134 238
t�°u.150 255rs
.�Y14
3WHERM
118 196 1
152242
45 154
MRM Issm
66 168
_.Gz7;Li"lZ9.i 11
- -
91 102
a"�00.«�i0.�a
�.�I67.Al O--
a�).W-M9(Lifa
itq 200
0�
ta3 216 '
96 240
''<'1 t2S'0'
111 265
124 280
f
110 245
T*'s' ls-�":.26aa
127 275
�'r2g5+
142 295
�.%222
125 260
sl" s: z�s::�
145 285
:5;15428$ii
162 305
141 270
? :�a2 z9a t
163 300
t"r�_� 173w3f0.`u;r"
182 320
164 275
zrn�zes,�
169 305
y�20iy 315aic
212 325
183 280
Y� aye` oa
211 315
��._ � �.z
''•..._., .�
s.,,.."''224:4325
236 335
¢
_::ir1.x==
-:.•_
-
-- -
-
-The diameter of throw is approximately 3% less Ior the 21' trajectory angle, $Aa less for 18•
150 SERIES BIG GUNS '--- 240 TRAJECTORY*"
150 T TAPER BORE NOZZLES
P.S.I.
Nozzle
.7"
GPM QIA.
Nozzle
.8'
GPM DIA.
Nozzle
.9'
GPM DIA.
Nozzle
1.0"
GPM��r��� DIA.
Nozzle
i.1'
GPM ❑IA.
Nozzle
1.2'
GPM OIA.
Nozzle
1.3"
GPM OIA.
60
a070b
80
111s.80"
100
TiFior
120
110 265'
'
128 290'
F L,�
143 310,
157 330'
'1
Qi.i87ty3•i
225 325'
=2
!M
275 345'
r
330 365'
385 380'
143 285'
182 305'
r :
165 310-
- 32d
185 330,
MMESKIW
204 350'
315 375'
380 395',
445 410'
947,
500 aa0'
'a
545 460'
210 335'
'.,v_223 =:;.�n:
260 355'
i27,5r
290 375'
im
320 395'
335��,=,,,e.390
355 400'r
'': c3l�'10
385 420'
75M4b=%$,..
425 420'
235 355'
47. ,''v
256 375'
4.'�"�t�a::.4...:;s:.
465 440'
150 R RING NOZZLES
P $.I.
Ring
.86"
GPM DIA,
Ring
.97"
GPM DIA.
Ring
1.08"
GPM OIA.
Ring
1.18'
GPM DIA.
Ring
1.26"
GPM DIA.
Ring
1.34"
GPM DIA,
Ring
1,41'
GPM OfA.
182 300'
r
�1�
225 315,
-2 33
275 335'
330 350'
385 365'
60
8o
110 260'
2zu 10
128 280'
��i
143 280'
165 300'
- t
210 320'
�
250 340,
315 369
( 380 380,x
445 395'
;120
143 300'
185 320'
235 340'290
360,
355 380'
7d=y�3
425 400'
500 415'
5�.5
385 400'
157 315'
204 335'
258 360'
320 380'
i 465 420'
545 435'
"The diameter of throw is approximately 3% less for the 21' trajectory angle.
200 SERIES BIG GUNS - 270 TRAJECTORY"
200 T TAPER BORE NOZZLES
NFie
Nozzle
Nozzle
Nozzle
Nozzle
NOZZIe
Nozzle
Nozzle
Nozzle
1.05"
1.1"
1.2"
1�"
1.4•
1S'
I L6"
t 75'
1.9"
P.S.I.
GPM DIA,
GPM OW
GPM DIA,
GPM DIA.
GPM DIA.
GPM DIA. -
GPM DIA.
GPM DNA.
GPM DIA,
f`
391
"'E451�ad10'S:::.
480 430.
i5; 43O s:
555 450'
s:[x58�.}ai.]n.4$c
630 a65'
U
755 495'
F. (jyj 4�
70
If�a22700r.�36_0'
310 360'
355 395'
410'
890 515,
'`f8dZPM996•
c375t'=
-
WWO
YY415 _
>i-y.4$0 `7
ibUU�j�.g:-4!Z¢�.5
m590 470:
UZ75=- t ;�s
... ... T!w
'�95
90
310 390,
475 445
545 465'
625 485'
115 5a5'
855 535'
1 1005 555'
350 410'
405 425
i(b'i
=325t4'Xi4'405'"rs
�37 c 42B�
_
'-!440
j� 500 460.a,:
i�5Y5$�"=480
• 860 Ot] ;-,.I
r ..Z55 520'W`T ,
x.�900.�?Q'e'�.
1U4--�?Q40��.`+7.��;,
110
340 410'
390 430'
445 450,
525 470'
605 495'
595 515'
90 535'
945 565'
1110590'
25� 530
25 SfiO
��7
M. e 4'
� Sy 5$
1]60 5r"r'
60
130
370 425'
425 445'
485 465'
565 485'
655 515'
755 540'
660 560'
1025 590'
1210 620'
200 R RING NOZZLES
t '/,' Ring
1 %- Ring
1 '�" Ring
t +A' Ring
1 3/41 Ring I 1 r1.' Ring
2' Ring
(1.29" actual)
(1.46' actual)
(1.56" aCual)
(1.66" actual)
(1.74" actual) (1.83" actual)
(1.93' actual)
PS I.
GPM DIA.
GPM DIA.
GPM DIA.
GPM OIA. I GPM DIA-
GPM 01A.
ME=4r '
.y� yG�PM �y �OIA,
+•vy1:,4.)Q µ�yidt•
4] r. .'.ram•.-�!�'+
-. i.:
60
250 340'
330 370'
385 390'
445 410,
515 425' 1 585 440'
695 455'
�;.70
rw�r.�t�i0�
_
•3.,i'"'tA�•�
t~., ••4t5'=��5:f��'
�480; ;1� _125'.�"_',.''.'.
� �T555'�'��440630�t.'. 455 ':r�.•"r'i
�659
290 370'
380 400'
80
445 420'
515 440'
590 455' 1 675 470'
005 490'
8:90w
>l�r310 ►3' 38�'
1
?ir"�405- .Y� 4f5
75d�»ei3s;,»�
'� Sd r rya a55'.y'.:.
._825» � a70
�rSo . -
500 445'
900 520'
100
325 390'
425 425'
575 465'
660 480' ! 755 500'
11013X440Q7
ri.t
625�5r'�180'
t20
"'130".
355 410,
�1�?i3% 15�' ST
465 445'
, r ..
545 465'
�� �86 -.470
630 485'
�'.Sra,:656 r4gQ�1-J
725 500' 825 520'
: .Z.755 - X, 505'.--s:�660'cTr 525:
_98_5 545'
:`115 5" t7-;M .t. '
'The d+arrlater of throw is approximately 2% less lar the 24° trajectory a ale, $% less for the 211 trajectory angle.
The BIG GUN' performance data has been obtained under idear ,esi conditions and may be adversely allected by wind, poor n craulic entrance conC40n5 or other taclam.
Nelson Irrigation Corporation maics no reprosentation regarding droplet cond4i0n, unitormtly, or application rate.

3. 3. 1 d
ANIMAL WASTE UTILIZATION PLAN
rrrrrrrrrrrrMrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrirrrrrrrrrrrrrrrrrrrrrrrrrrrr�rrrrrrrrrrrrrrrrrrrrr�rrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrr�r
Producer: Henry Walker
Location: 14513 Godbey Rd.
Mocksville NC 270Z8
Telephone: [phone]
Type Operation; Existing Beef Feeder - 6 month
Number of Animals: 300.00 head
(Desi3n capacity)
STORAGE STRUCTURE: Waste Storage Structure
APPLICATION METHOD: Broadcast
The waste f rom your an i rria I f ac i : i ty must be I and apt+ I i e c-j at a
spec i f i ell rate to prevent -+a I I ut i ors +�f surface water- and/or
groundwater. The Plant nutrients i rh the an i rna l waste should i+e used
to reduce the arnount of commercial fertilizer- required for the crops
i rh the fields where the waste is to be ap-p l i ed .
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste sil hu l d be ana: ywed before each apP i i Cat i ern cyc I e. Annua I so i l
tests are strongly encoura3ed s+_, that al I p l ari 4' nutrients cash be
ba `s ariced for real i st i c y i e i rs of the crop, to be grown.
Several factors are i mpiortarit in i rn-+ I efrient i n3 y+_Sur- waste ut i I i zat i pan
rr I aft 1 r, r i�eY' t:+ ma ; i m i 2:e the fertilizer t i l i per value of the waste and to
ensure that it is applied in an environmentally safe manner:
1 . Always apply waste based orr the needs of t`re crop, to be
3rr+wn and the,nutrient content of t1he waste. Do not apply
more rh i trogen than the crop cars ut I I i ze.
Soli I types are i mr :irtan t as h =y ii -ve J i f f erent i rhf i t prat I F:Sn
rates l e.-.c sin poterh a I s, cat i :Sr: —xc ihrLn e '_'ar+aC if t i es y ar,=
availa'I-,le water `!S,+lairh3 caPa.cities.
: N.:,r na l l'� Saaste 5 ra: I rf= t +e apri I i ed t�.' I ai- u r r' ;[ i rrr at i e5S
than 5 tons Per acre per year. haste may be appi I i ed to !and
eroding at �� or more tins per acre arhnuG, l 11y, Lout 1 ess than
10 terns per acre per year providing that adequate f i I ter-
str- i ps are estatr l i s1he+.
4. D+_+ riot a.pp I y waste on saturated GS'j i: s r w,,¢ri i t i s ra i n i nj,
or- wherh the surface i s fro.-erh. Either of these cor, i t i ons
may reS11I t i n run0ff to Surface_ waters wh i Crh ! S not al :owe-J
under DELI re3u l at i ons .

ANIMAL WASTE UTILIZAT;ON PLAN
rrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrr
5. Wind cc,nd i t i on5 should also be considered to avoid drift and
dr„rwnwi nd o.-J rr- problems.
To maximize the value of the nutrients for- crop production
and to reduce the potential for po I l ut i on, tile waste shou l d
be app l i ed to a ;3row i nq Crcrp 1:1r- app l i e d not more than
days pr i crr to p 1 ant i ri-3 a crop or- f ora3es breaking C"ormar,cy.
Injecting the waste or d i slk. i ng will conserve nutr- i ents and
reduce odor Problems.
This r1lar, is based on the waste app 1 i cation meth .,d shown above. If
you choose to Change methods irs the future, yc+u rieev to revise this
p I an Nutt- i ent 1 eve I s far d i ff erent app 1 i ca.t i on methods are not the
same,
The est i mated ac res needed to app 1 y the an i rna I waste is Erased on
typ i cal nutr- i ent content for th i s type of facility. Acreage
requirements should be based on the waste analysis report f ram your -
waste management fac i I i ty. In some cases you may want to have plant
analysis made, which coufd allow additional waste to be applied.
Provisions sha 1 l be made for the area receiving waste to be f I ex i b i e
scr as to accornmodia-te charig i ng waste ar:a fys i s content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utiIization plan, if carried out, meets the requirements
for compliance with 15A NCAC ZH .0217 adofrted by the Environmental
Ma.nagefnent Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, torts, etc.)
hea " t4n5 WaSte/head/yea: - -() trrrs5
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
heal; ;-..FI I trs 'AN/s,ear�/year - 4{=}fir ; bs. 1✓AN/year
Ap , 1 y i ng t-1R af» ove amr-,urst ,-f Wa5 t? 3 5 a b i .jib , vcrU S h o u 1 d F' 1 an t i fne a.rli
have ar1rrr0 .ri-- i ate e,-'id : 'ir+ent to app 1 y the waste i rr a t i me 1 y manner" .
The f ei. I i ow i rig acreage w i 1 I be needed for waste app i i ca t i on t,ase=* '.Sn rile
cre p to trP >'orajri, o i 1 type arr,� surface aFrrr I i Cat i +_rrl.
r'r err°rr°r {'rr'rr°rr°r�^r('r; rrrPrPr ^r,�rrr,�rr^f r�rr�rr�r� rr�r?�r�� ^, �,r°r,''r+^rPrr°rr°r err°T"r,°rrr,°r?rr°rrlrr'1Prr°r,°r,^7r°rr''?•'h�rrr "�.^7 ^7 °"??D1?7,°r,^rr^rPrPi Ar,�1,"� ��

v-1

Davie County, North Carolina •
rl
95
TABLE S.--LAND CAPABILITY AND YIELDS PER ACRE OF CROPS AND PASTURE
(Yields are those that can be expected under a high level of management. Absence of a yield indicates that the
soil is not suited to the crop or the crop generally is not grown on the soil)
I
Map symbol and I
I
Land I
I I
I I
I
I
I
I
I r
r I
soil name Icapabilityl
Corn
ICorn silage!
Soybeans I
Tobacco I
Wheat
I Grass- I
Pasture
I
I
I I
I
I
Ilegume hay I
I
I
Bu
r Tons I
Bu I
Lbs I
Bu
I Tons I
AUM*
I
AaA------------- I
IIw 1
125
r 25 1
45 1
2,800 1
55
1 `--, I
11.5
Altavista I
I
I I
I
I
I I
I
ApB------------- I
I
IIe 1
95
I I
1 19 1
I
30
I
1 2,500 1
45
i I
1 4.6 1
6.0
Appling
I
I
ArA-------------I
r
VIr [
---
I
i --- 1
I
---
I
I --- !
---
I I
i --- I
6.0
Armenia I
I
I 1
I
I
I I
I
BuB------------- I
I
Vr I
---
I I
I --- I
---
I I
I --- I
---
1 I
I --- I
3.0
Buncombe 1
I
I I
I
I
I 1
I
CeB2------------ I
I
IIIe 1
115
1 I
1 23 1
35 1
r I
2,200 1
45
I f
1 4_.55 1
7.5
Cecil 1
I
I I
I
I
I I
ChA------------- I
IV* 1
130
1 26 1
30 1
2,000 1
30
1 5.4 1
9.0
Chevacla I
I
I I
I I
I I
I
EnB------------- I
I
IIIe I
110
I I
1 --- I
1
30 I
k
--- I
40
I f
1 5.1 1
8.5
Enon !
I
1 I
I I
I I
I
EnC------------- I
i
IVe 1
85
I I
[ 17 )
I
25
I
1 --- I
---
I I
I 4.8 1
8.0
Enon I
I
1 [
I I
I !
I
E3C------------- I
1
VIs 1
---
I I
I --- I
!
---
I
I --- I
---
I I
I --- I
4.5
Enon
GAD ------------- I
VIa 1
---
I --- 1
---
I --- I
---
I --- I
7.5
Gaston 1
I
I I
I I
I I
I
GnB2------------ 1
I
IIIe 1
130
I I
1 25 1
35
I I
1 --- 1
50
I I
1 5.5 1
8.3
Gaston I
I
I I
i
I
I I
I
GnC2------------ I
I
IVe 1
115
r I
1 23 1
25
I I
1 --- 1
40
I I
1 5.0 1
7.6
Gaston [
1
I I
I I
I I
I
GrB------------- 1
I
I12 I
75
I I
1 --- I
--- 1
I 1
2,000 1
35
I I
1 4.6 1
6.0
Granville t
I
I I
r I
I I
I
IrB-------------I
I
IIe 1
110
I I
1 22 1
---
I !
I --- I
30
1 I
1 3.6 1
8.0
Iredell
MaB-------------I
IIe 1
120
1 24 1
35
1 --- 1
45
1 4.8 1
8.5
Masada 1
I
I I
I I
I I
I
MdB------------- 1
I
1Ie [
95
I I
1 --- I
30
I r
1 2,600 1
40
1 )
1 5.1 1
8.0
Mayen !
I
I I
I !
1 I
I i
I
MdC------------- 1
I
IVa [
75
I I
[ --- I
25
I i
I --- I
30
1 4.2 1
7.0
Mayodan I
I
t I
I r
1 1
Mdn------------- I
VIe t
---
I --- I
---
I --- 1
---
I --- I
6.0
Mayor I
I
I I
I 1
1 I
I
MdE------------- I
1
VIIe I
---
I I
I --- I
---
1 I
I --- 1
---
I !
I --- I
6.0
Bayou
I
I
I r
I I
I i
See footnote at end of table.

96 Soil Survey
TABLE S.--LAND CAPABILITY AND YIELDS PER ACRE OT CROPS AND PASTURE --Continued
I
map symbol and I
I
Land I
I I
I i
I I
I I
I
I
I
I
soil name Icapabilityl
Corn
ICorn silagel
Soybeans
I Tobacco I
Wheat
I Grass-
I Pasture
I
I
I !
I I
Ilegume hay
I
f
I
Bu
I Tons !
Bu
I Lba I
Bu
I Tons
I AUK*
f
MnB2------------ 1
I
IIIe 1
85
I I
1 --- I
25
I I
1 2,400 1
35
I
1 4.2
I
1 7.0
Mayodan
MnC2------------1
Iva I
75
1 --- I
20
l 2,100 1
30
1 3.6
1 6.0
Kayodan I
I
I
I
I I
I I
I I
I
I
MrB2------------1
IIIe I
115
( 23 1
30
I I
1 1,800 1
45
I
1 4.4
I
1 7.3
Mecklenburg I
I
I
I
! I
I I
I I
I
1
MrC2------------
Iva 1
100
1 20 I
---
I I
I --- I
35
I
1 ---
1
1 6.5
Mecklenburg I
I
I I
I I
I
I
MsB-------------1
IIe l
95
1 19 1
25
I --- i
40
1 3.6
1 6.0
Mocksvills I
E
1 I
I I
I
I
!
Mac-------------1
I
Iva 1
70
I I
I --- I
20
I I
I --- 1
35
I
I 3.3
I
I 5.5
Mocksville
I
MBD-------------1
I
VIie I
---
I 1
I --- I
---
I I
i --- I
---
I
I ---
I
I 5.0
Mocksville I
I
I I
f I
I
I
I
PaD-------------I
I
v11e 1
---
I I
I --- I
---
1 I
1 --- I
---
I
I ---
I
I 5.0
Pacolet I
I
! I
1 I
I
I
I
PcB2------------1
I
IIIe l
105
! I
1 21 I
30
I I
I 2,200 I
45
I
I 3.9
I
I 6.5
Pacolet r
I
! E
I I
I
I
r
PcC2------------1
I
Iva I
95
I I
1 19 1
25
I I
1 11900 l
35
I
1 3.6
I
1 6.0
Pacolet f
I
I I
I I
f
I
Pt--------------f
vllis---
Pits
f
RnC------------- I
I
IVe 1
---
1 I
i --- I
---
I I
I --- I
---
f
i ---
l
! 4.0
Rion E
I
I I
I I
1
I
E
RnD-------------I
1
vIle 1
---
I I
I --- I
---
I I
! --- I
---
1
I ---
I
I 3.0
Rion
RvA-------------1
iVw 1
140
1 28 I
40
! 2,200 1
---
1 4.8
1 8.0
Riverview I
I
I I
! I
I
I
RwA----- -------- 1
Ivw 1
100
I 16 I
35
1 --- f
40
1 2.5
1 B.0
Roanoke
I
I I
I 1
I
I
I
Sea ------------- I
I
IIe 1
100
I I
1 20 1
25
I 1
1 --- 1
---
I
1 3.3
I
1 5.5
Sedgefield I
I
I
I
I 1
I i
I I
I 1
I
I
I
I
Ud--------------1
VIIIe---
Udorthents
i
Ur--------------1
I
VIIIs---
I i
I I
f
I
Urban land f
I
I 1
I I
1
I
I
weB------------- I
I
IIe I
95
I I
I 19 I
30
I I
1 2,000 1
35
I
1 3.6
I
I 6.0
Wedowee 1
I
I I
I I
!
I
1
weC------------- I
I
Iva 1
85
I I
1 17 1
---
I I
i --- I
---
i
1 3.3
I
1 5.5
Wedowee
* Animal unit month: The amount of forage or food required to food one animal unit (one cow, one horse, one
mule, five sheep, or five goats) for 30 days.

ANIMA WASTE UTILxe'_ATISN FLAN
trrrtrrrrrtirr�rrrtrrrrrrftrrrrrtrrrtrrrrrtrtftrrrrrtrrrtirrrrrirrrrrrrrrrrrtrrirrrrrrtrrrrrrrtfrrrrrrtrtrtrtrtrrrrrr"rrrtrtrrrrrrrrrrrtrtrrf
TABLE 1: ACRES OWNED BY PRODUCER
F
D SOIL TYPE' CLASS-
:i-1-1r'
-{-
t r
i rS
i�
!
1 [;s
;_-rRA(ht
I
[� I r fa I -� r
! E I E 'I�i 1 N' J. �N 1 i- 1 i 'i E
DETER
i-
1 F:I.-'__ F
1
I
�A -A I'1
s u -
1 1' _I�
r.1— r-• I It� I
.L•I�.I_.S 1 I N
F=F;('_
AC!Lam)
�.: �_,
f
1
1
! Iy1! _ ! IWi
}
I
I N.
I
I
i
1 T--:
i
f
I NI [V , FEE: t
1
F� C'
i= _
i .k r�� :`I
i E>
i 1 .:.. s 3
1
TC
1_I
i
i
i
I
i NI--; V q F E:"" 7
-A r! A«�
t F Fs
14.rR
k � t 3 �}
� ate. t.:a
1 �_ 1.
f �.-� • � r::. . 4
I-
t
NOV, := IE S r
yyr�
-a...-. «....----.__ _----..--...-..r .---••
AC•1
r
--
5
_-_--..--
1 A++ _
-------- _
I �� }i�
—--
i f�a
_
_ _
-
S .»��_ •
r
—_7 A ________
1 J. —
1 Ce E: ____�._,____ _--------_.-_...---.-----------...
i I F '
1 `'l . C
--...»..-.-.....-----.
1 1'-�'�f
k a:_r_a
.__—__—.....—....,..,...a_I..-,
! 2, . r._
"!
f 3,7
N
1 * r `-'
+ FF
! T . 5
' 1 91:7
f �i-.ly.
i — • _
F 557 �
1
1
i
1 NOV,
---------------------
.AND
i
3
;
D
— 4 -1 !J { t_ !• G �I ' it i-I i"] -pI e 4 ': 7 !_= e n - r v P r j e a fJ P I l . _ n I rI Y- '' 1 .L _2I�
W I pr carIrtj_Ii =. FtS i i i:iw Surr,rrler ai!nua. i S.
T a z I_I r- 15 C itL IS % I ; , �: I, j i 13 v 'a a. rl I j M ;l Y e !_k ; J p «- a. i I r f I e t w r; I e
rneFtIrIS L!e i,a requirements. Trf s_se future, ' e,-Du=:31 1_IrIS' may ,- i-lei:= e
}"a-r mer s I r, ssorloe !-Ia -ts CI-F Nor-Car-r1 i I-Ia t.;! riAVe 3 i11.: _ i e'j : rn.a n.3.gf?r(1 II}
t;rat a.i I re vp 5 7, I r±utr"ice n T'F;i5 riI-irl =,-. Care p s r;i'_r i.
Arr�7rti7r^7�ar A7�'rr'Xr'�rti r's1 r7�••7 r�7r�7e"ft r:^7r"fir°fr^,y��r^rf�rr�1 r°i r°7'rrrt? r^Y ^7P; ,"� 07 h�r'T r'7rf,^7 "77°i i 7 �' 1°71�Y r`r rny1Y� rs* e.;st t1r�i.�+ n7r^%r'?rri�7tfr�7r^7t jr^rA�t7 A7?; rnr

ANIMAL WASTE UTILIZATION FLAN
rrrrr� �rrrrrrrrr.^rrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrriririrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrr rrrrrr
TABLE 2 : ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(.Algr-eemFan`..• with a0 la.Cent ia.ncowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
----__----.-__-__"--__.---.,-„... --„„,,.----..-__-____-----...___.__.__...._...._..._......-,.,,_,__---__----.- ,.-»- ___._._ _._-----__--
-1 RACT !FIELD! SOIL 1"`{PE _. CLASS- !CROP , { I t LD 1 I_BS ;COMM\ 1 ** 1* I_ B
1 � I 1. L-... 1 I
1 I7°E : t= RM 4 N T NG , HAE !CODE 1 1 A!W N 1 PER ;ACRES! AEI \,!
1or
1
1 I 1 I-1 r1 Y! k -' - s \ 1 v r_. 4.' 1 T
1 A !- i 1_. T 1 1 F {�1 I .. {v��, .» �1 rt 5 A I- 17' =_ A ��
I I 1 'ii� H 1 1 i N I ! ?" I IME
i 1 i 1 i I
END
-.—-......—..-._-.—.._------------------------------------------- --
-1 OTAL K)
.. Indicates that; th I s 'Fie l d is being overseeded (i . e . inter p i anted) 1_Ir win,
annuals follow summer- annuals.
Acreage figures may exceed total acreage in f i e l d due to over seeding
I` s Ali N (animal waste n i rr_I .e`S) equals total r_ u `. r ea nitrogen less
any commercial nitrogen (COMM N) sui_1p i i ed .
The fG i i F_rw i ng legend e;;rl l ins the crop codes used in tables 1 and ._ anovEl.
--- ---- ---._..._--_---.__-.---------E-----�-�---------�------�-,----------------------A----------.-----------
__ �� �; =il- - _''' � � ,7 r � t=iZ u; .._
I I I
- ---- - - _ w.......-._-___.....-------..»..--,_-».----..-_.__----------------------------------------
, I 1
FP 1 FESCUE PASTURE TONS 1 50 i
! I 1 ,
TOTALS FROM TABLES 3 AND
3
TABLE 1 I ^T' rt 1 *. 6... :_! a t... I
i 1
A 1=_: L i rw t_. 1 6
I 1
^r1^r,^rryrrrlSir{7^rrrrr?'rrl r^ri'rl^7r^rrrrirryrrrrrr7r^rrr,^rr^rrrrrl^rrrrr hrrrr?r^� .�; r^rrr:^?,^�l^r,^rrrl�r,^rrr r""� P]r''r°7r"','T 1 P7f'ir.+l^i ,'� r'%r'?rrr°rP1 Prr°rrrr'r'"Pl r°T

*I
•
ANIMAL WASTE UTILIZATION PLAN
1'Y^ir7Pfr^r!'7l'rrirrMPfrrrrriril'fPiP7!'rr'i Piri P7rfPfPil"f!'?PrPjl'f!'iPf!'7Pr1'7 P1PiPrPIPrAr,^7 f 7T fPfPfPf PiPfIY1l'7PiPji'jPfP7P1Pr�rnrnj ni �f nr ^rprPj!'rr^r
BALANCE -6075.2
•f *
n

ANIMAL WASTE UTILIZATION PLAN
Pf!'fMMPfMM!']rf A7MPfPfPfMPf MMPfMPfP7PfPf!'f!'fl'f�"fPyPfP1A1PfMMMPfPfP1MMMP1 P1 PrAfPf!'fPf!'fMl'f1'f!'f PfP1P1A1 P1PyP1P]PfPf1'71'1A1P1PfPf
This number- roust be 1 ess than ar- equal tucs 0 in or Jet- to fully ut i 1 i ze
the an i rna 1 waste N prriduc ed.
Acres shl.-,Wn i n each of th e preceding tat, I es are cr-rrs i dered try be the usable
acres exc I ud i ng r-equ i red buffers, f i I ter- str i ps al ,,rig d ii tches, odd are -as
unable to be irrigated, and perimeter meter areas rrr-t rece i v i ng f u l I app € i cab i oR
rates due to equipment I imitations. Actual total acres in the fields
listed may, an."i most I i ke iy wi 1 1 be, rnc-r-e than the acres shown in the
tables.
See attached map showing the f i e I ds to tie used f cor the ut i I i zat i on of
animal waste.
Your faciIity is des i3ned for- 60.00 days of temporary storage and the
temporary storage must be removed on the average of once every 2.00 months.
In no i nstance shou I r the vo I urne of the waste tie stored i n your str-actur-e
be wi th i n the ZF year 2:4 hour storm storage or one foot of fr-eeboar-d e-cept
i rr the event of the 25 year '::'4 hour storm.
It is the responsibility of the producer and waste applicator" to ensure
that the spreader equipment is operated properly to apply the correct rates
to the acres shown i n Tate I es 1 and Fa i i ure to app I the recommended
rates and amounts of n i tr, oger, shown i n the tab I es may make th i s p I an
invalid.
Gall your technical specialist after you receive the waste analysis report
f„r- ass i stance i rr deterrn i III Fig the arnourrt .--if waste per acre and thre prcaper-
aprr l i Cat i orr rate prior to applying the waste.
NARRATIVE OF OPERATION
This waste ut i I i zat i cin plan involves the app I i cat i r,r, of both, dry
waste scraped fr].Lrn the I of and I i qui d waste from the waste
st irage pond. Lot runoff captured i rr the waste storage pond is to
tie appl ied by irrigation to Fields i-f-f-krcA 1-4. It wi l 1 tie appal ied
according to the attached irrigation systern design. Est irnated
nitrogen from this waste is accciunted for in Table 1 under- the
C-r,mmer-c i al N or Residual N per acre co I urnn. Actual nitrogen
app l i cat i r,n rates may need to be a juste d after a waste aria 1 y_s i s. i s
completed. - -
J'rP1PfPf!'7PrA?1'?1'7f1P1Ay1'1r7P��1P1P,r?n�r�nrrYnrrrrrm:M1+7;+r�rnrtnrrr�rp7^7ryr�nynr�rrwny,.,nY.....�•+; f, MM/.Y/.Y,.,,Y.Y.Y.Y........-.�.�.,...v._

NC- - G civ�e _ Nertr y Walker - Derr Feedlot Ws e iwyl- ��sr�er►r
rA �-r9 qlv `TS4rc,(� J� 96
W05-4 ``r'orolc Rcrci - L-1 {LI C! (IJOSA-- HrVdvicec 1 7,
L�r�: ��F'ST� PKoruc�Er YFA ,.
Wq t le f't ro P0,P? V6 dew w e t (40
7S 8 yi, 44- Y T `�O 1/ca•ff = I ba y ?50 gallcrs
� vcrl �G o+/S
Cafife vv,'11 hc. Cor�;rcd a;, fhc reedl64 i 2�:P �^►Nar��y
rloeik.) COCA year cNoveMLer Aj�'-'., /
TG+erC�vr-�i`thG O.Mounf o-� V.;SfG f 0awced k-'CuQ Ac:
1 laa 75o all�►s�f �- ASS 2 So -- aflorrs ---- --- --
(� o c�a•�, x 60 days
Al
crc ar,c no r«c!r'�y _Ora%l�le_,9u•�s.__ plant �va•Ja�le..._�. _�;
-._.,.._._ __ n vt�, e.r.�J__ . � n..._. beefYc'�i�rC_- wa t �--__ i ►� . �? r�... S: '{v�'� ori� � w..i� +� �-r� _..., s
iVae,& a.na L s es P"M _
Gc a r o ere crss __+�hc. n�aK v►�c. �is_� _.....� .
Sra 2d anc7 G h0u.f[r� Gt Mt�'a C crnC�S .._4 rS C 'fury
r y �-
Ord I +•9o,d wosfe circa r-v rr ot- S c w n - I e ve-A - o
1 d art R va �'1 a�- le r) "F"y -c +i (AAN �+-a h c _ c� �!O Mp,oQ a 1
1. Ih PAd pe-r, coo allays , ourcc — Torrm . i3-rrs cAe�7c -
..�►-� `�i,�5 sf�iafio7, Cattle. keCam»A ed _ 'OD /Z5_
or1 a,rcra c%J �� arcd � �� a✓Grays rv_���,-�. af- f�D.o 1,6s .
Q �l•lf CdN.%• �'�J�'Firj G�Nr rN/�<<j J/'1e{ !��'1!7''Q .�r�,g� ���+�•
rfl a •1 Lc r c- n &<4rr, e m 4� - a r< . kc f •r c Cep � rt it .� `f-hc via sic
S ra c paxd. ."� iS i-Faso-rraY/a Afw 4toit
it ,�1�s 'iCcrllot 6tvpri�+ r�• r1 w�sr� �.o,•sr�e
K 'CI
6 !b 12'4nr1l00o al1c-xs. f ,
` F91 0.471"0001
d u v' pry �� � r��-�G.s w �,lG ca�l� a �e c�-r►�.�cd .
a v� C e iJa.rC r'.-ra a sd r s U. Y c Fp r - �' • ` ��a S �C
0 n Q L`� S' 5 6 h o la Ia e C�IC`7* � �� C r �' n aC rt .4 r,'ewq
'�1/5D C�u r,.r �Lr� � � x /+.,rc-��ns rj� ter; Cp_�r`l� � r2 •^��` t..J.+�,►��r.,r?
`r%^� �'�+/GS*C bra �C ;�=7� =f !I �C 2�7'.c r• ,-7 l> r'urt071
f

rJas c S;�ar�q a narG�- +� v•d GtJos fc �r�u cep 2 z
W�"LG] w�'If e h2�Qfi',�e!el^I��ollu d. .1+rrc� •s
w+t1 be Some oo `-Als
Abe /0 4 e V A p ora-f,'O.Y1 , 9":) we �e,r `{fie P C-rd
r.')I pvb�loly Si.n need -v he ep.plred Per+od'u11�„

WASTE UTILIZATION PLAN
MP1P11'1 P1P1P1P1P1 PfP1 P117'P1P1Px1'1Pxf7P1P117MMP7ArPtPrP1!'7P1 h11'1MPJP1 P1PrPtA1P11'1MP1P1 Pl P117P1Pr!'1!'1 PfP11''lP1PrMi'1 A1M!'rMP1h117A1
REQUIRED SPECIFICATIONS
1. Animal waste shaII not reach, surface waters of the state by
runoff drift, manmade conveyances, direct application, or -
direct discharge during operation or ;and application. Any
discharge of waste which reaches surface water- is prohibited.
�.. There must be documer,tat i din i n the d�Es i grs f o l der thrat 41
producer- either owns or has an agreement fair- use of adequate
land on wh i r_h to properly apply the waste. If the producer does
not .rwn adequate land to propder I y dispose of waste, he/she sha l l
provide a copy of art agreement with a landowner who is w i thr i rr a
reasonable proximity, a l ; d,dw i n3 {-rim/l-ter the use of the land fc,r-
waste app 1 i cat i on. It is the responsibility of the owner of the
fac i I i ty to secure an update of the Waste Ut i l i zat i on F' l arr when
there is a change i rr tine operation, increase i n the number- or
animals, methods of ut i l i zat i din, or available land.
3. Animal waste shaII be applied to meet, but not exceed, the
nitrogen needs for real i st i c crop yields based on so i I type,
available moisture, historical data, climatic conditions, and
level of management, unless there ar-e regulations that restrict
the rate of appiicatian for other nutrients.
4. An i ma l waste sha I I be app I i ed to I and erad i rig I ess than; tans
per acre per year. 'Taste may be app; i ed to I arid that i s erod i rig
at F or more tons, but less than 10 tens per acre per year -
providing grass filter strips are installed where rurroff leaves
the f i e 1 d. (See FCITG Standard 9_c -Fi I ter- Str i Pd)
5. Cidors can be reduced by injecting the waste or disl•::in3 after
waste application. Waste should not be applied when there is
danger of drift
_lrift from the irrigation field.
6. When animal waste is to be app l i ed on acres subject to
flooding, it will be soil incorporated on conventionally t i l€ ed;
Crrydp l and. When app l i ed to conservation t i i led crops or
grassland, the waste rrray be brrtaGCaSt pr0V i d e d thde arFr € i C at r Orr
does not occur" during a Season prOne to f l rigid i rr3. (See ''Weather
ands C; irnate in North Carolina" for guidance.)
7. Liquid waste shall be app I i ed 'at rates not to exceed the so i t
i of i l tr-at i on rate such, that runoff does not occur- offsite or- to
surface waters and i n a method which dries not cause drift from
the site during app I i cat i crn. No sh,<<u l d occur in {order
to control ,dor- d_ir flies.
Arr i rna I waste sh,a i I not be ai_dp'> i ed tc, saturated 5o i- 1 s., dur--i no
r ai nfal I events, -4r-when the- sur face is frrdzen.
9. Animal waste shraI I be ap'rl i e d din actively Sr-rowirig crops irr such
a rnar,r,er that th,e crdip i s n,:dt covered wi th waste to a depth that
wou I d i nh i b i t growth . The patent i a€ f or sat t darnage f rorn art i rna i
dsaste sl-,cdu I d a I sdi be cons i dered.

WASTE UTILIZATION PLAN
F1 F1 MMMFI F1F7F1F1F1F1 F1MF1FrF1 F7MFrF1F1FrPiF1Fi'F7F1 F1 F1F1 MMF1 F1 F1MMF1Fi`F�P1P1 F1 MF1 F1 F1 F1FY!'1 F1 F1 F1 FT MMMMFI FIMMFI MMF7
REQUIRED SPECIFICATIONS
10. Waste nutr i ents sera l I not be app I i ed i r, fa I i or wi nter for
spr- i rig p I anted c rcips ort so i I s w i th a h i gh pc,tent i a l for -
I each i ng. Waste nutrient I oad i rrg rates on these sc, i is should be
held to a m i n i rnurn and a suitable winter cover- crop op, planted to
take up re l eased nut.- i ents. Waste Sera I not be app ed more
than, '::C? days pr i or to r I ant i ng r:,f the c r::,r f orages break i ng
d c, r mancy.
11. Any new swine faci I ity site, c,rr or after IWictr,t,er 1, 1`=�'p5 shal I
comp,Iy wi th the f,_, I I o w i ng: The c,uter per imeter- of the I and area.
OntO which waste i s aprp, I i ed from a I agoor, that is a comporient of
a swine farm shaII be at least 50 feet from any residential
property boundary and from any perennial stream or river- (c,ther
than an irrigation ditch or canal . Animal waste ether- than
swine waste from facilities sited on or after Lctrrtrer 1, 1995),
F) ,
shal I not be app l i ed closer than 25 feet to perennial waters.
(See Standard 392: - F i l ter Strips).
12. Animal waste sha l I not be app I i ed closer than 1i-)0 feet to
wells.
1:. Animal waste shalI not be applied closer than 200 feet of
dweIl1ngs other than those owned by the Iandowner.
14. Waste shall be applied in a manner- not to reach other property
and puts I i c r- i ght- r,f -ways .
15. Animal waste shall not be discharged into surface waters,
dra i r,ageways, or wet I ands by a d i schar ge or by over -spray i ng.
An i ma I waste may be app I l ed to pr i ,_,r c oriver-ted crop i and i ded
they have been approved as a Iand app Iicat ion site by a
"technical specialist". Animal waste s„aII not be applied c{n
grassed waterways that d i scharSes d i sect 1y i r,tcrn water- c,--,ur-ses,
and or-r other- grassed waterways, waste sha I I be apFF 1 i ed at
agronomic rates in a manner- that causes no run _rff c r drift f rr3rr,
the Site.
1Dornest: c and i ndust r i a l waste from wasFsdowr, fa i 1 i t i es,
showers, t�7 i I ets, s i nk:s, etc . , s h a I I nrlt be d i scharged i nto the
ar, i ma l waste management system.
17. A protective cover of appropriate vegetation w i l I be
ems tag., 1 i 5lied on a! l d i Stur bejj areas (lagoon ernt,ant-ments, terms,
pipe runs, etc .) . Areas shall be fenced, as necessary, t,.,
F,rotec the 'Ve3etat i _r.$ Vegetation such as trees, shrubs, and
other- woody species, etc . , are l i m i ted to areas when-e Consi-dered
apprrrpr i alte. Lai_,=ln areas sirr_ri1'l d �,e l.'.e jt mowedi and accessible.
Berms and structures shou i d be inspected re3u l ar- l y fc,r- evidence
of eras i r,rr, l eaka.?e or c1 i schar fie.

WASTE UTILIZATION PLAN
rrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrMrr
REQUIRED SPECIFICATIONS
18. If ar, i rnaI product i or, at the f a c i I i ty is to be suspended or
term i nated, the owner- is respor,5 i b l e for- ,:jbta in i ng and
implementing a "closure plan" which will eliminate the
pass i b i I i ty of an it legal discharge, pot I ut i pan and erasion.
1'?. Waste hand I i ng structures, r0 p i ng, purnrps, reels, etc . , should
be Inspected on a regu i ar" basis to prevent br'eaF;downs, l eak.s,
and sp i I I s . A resu l ar ma i ntenance checl-.: 1 i st shou I d tie kept on
Site.
Z-0. An i rna l waste can be used i r, a rotat i or, that i ric I udes vegetab I es
and gather- craps fd i rect human corisumpt i i--n. However, i f
an i ma I waste i s used cir, crows for d i rect human consumpt i pn i t
shou I d -gin I y be app I i ed prep I ant w i th no further app i i c at i ons of
an imaI waste dur- i rig the crop season.
: 1 . Highly visible markers sha I I be instal led to mark the top and
bottom elevations of the temporary storage ( pumping volume) of
at I waste treatment l agooris. Pumping sha I I be managed to
maintain the Iiquid level between the markers. A marker wiII
he requ i red to marl:: the max i rnurn storage vo I ume for- waste
storage ponds.
Z2. Waste sha I I tie tested w i th i n 6.0 days of ut i I i zat i on and so i I
sha I I be tested at least annually at crop sites where waste
products are app I i ed . Nitrogen sha l I tie tI e rate - determining
element. Zinc and copper- levels in the su i l s sha i t be
monitored and alternative crG;i sites sha l l tie used when tiles
metals approach excessive levels. PH shall tIe adjusted for
opt imum cr op product i Can and ma ntai ned. S. i: and waste
analysis recrirds steal I he kept f-,r five years. Pout try drY
waste app I i cat i or, retards shall be ma i nta i ned f cir three (3 )
years. Waste app 1 i cat i _in records for- a I I other" waste sha I I be
rnairota ined for five (5) years.
?. Dead an i rna I s w i i I be d i sposeld of i r, a manner- that meets Nurth
Carc' I i na requ i a} i oris .
oa 1a, 9

ANIMAL WASTE UTILIZATION PLAN
PiArP11'�P1P1 P1f7P1A7PrP1l'�('1P]P1P71'1J`iPrPfPyJ'7P�Pr,°i<M!'1!'1PrA�P�P7M1'rJ'7!'?P�1'irPTP1l'1!'ri7P1!'71'i`Pr!'rP�PyP�PTI"1P1Pr�'�!'T P7P1 P�A1l'i<I'7!'t17A!
W iSTE UT I L I ZIT I UN 1='IL'0kiV hGRI-II-M1=:tVT
Name of Farm:
Owner/Manager Agreement
I (we ) ur„)erstand and w i l l fo I l ow ar;d i rnp I ernent the spec i f i cat i C,r,s
and the riper -at i on arid ma i ntenance procedures esta`, I i shed i n the
approved an i ma i waste ut i I i zat i or, Ti I an for the far rn narned above. T.
(we) know that any expansion to the existing design capacity of the
waste treatment and storage sy5tern or construction of new
facilities will require a new certification to be submitted to the
Nort`, Carolina Division of Environmental Martaaement (NC:DEM) before
the new animals are stocked. I (we) also understand tl-iat tl-,ere
must be no discharge of animal waste fr„rn this system to surface
wasters of the state from a storm event less severe than the ;_F_
year r 2"4--hour- storm. The approved p I art will be filed ran -site at
the farm office and at the office r,f the local Soil and Water
Conservation D i str- i ct and will be available for review toy NC:DEM
upon reiluest.
Name of Facility Owner: Henry Walker
(Please arint)
Signature: =_��_ Date:Name of of Manager(If different from owner) -9AM�
Signature; Date:
Name of Person Preparing Plan: (Please print)Fredrick Y. Alexander
Affiliation:NRCS Phone No. 336-751-5011
Address (Agency): Room 313 County Office Bldg. 180 S. Main St.
Mocksville NC 2TO28
Signature: __ ____. _ _'._� _._..--_----- Date: __

TablBEEF PAVED SURFACE SCRAPED MANURE
asaasasaaasa><sawaa;asaaaaaaasaaaaaa�ta a
Type Animal Animal Live
of Age Weight
Production
lit-------- -----
4ER NUTRIENTS '
------------ ------------ ---­­�axaaa:atraa__
Manure Total Plant Plant Total Plant AvaiL-'_:
Storage Scraped nutrient Nutrient Nutrients Nutrient
Capacity,TM manure, •'' Availability b adc
Coefficients -----------
snit final mean
tons/
tts
ft3/
head
broadcast
ya_,
head
capacity/
" "
lbs/
lbs/
capaci-
months-------ibs ------ capacity year
ton
tcrt
Stocker 5 - 10 425 675 550 28
3.1
N
.42
14
5.8
P205
.70
9.3
6.5
2_
K20
.70
13
8.9
Feeder 10 15 600 1000 800 41
4.6
N
.:2
-14
5.3
-
P205
.70
9.3
K20
.70
i3-
y
9rood cow 1000 1000 1000 51
6.1
N
42
14
5.3
_
P205
.70
9.3
6.5
_
KZO
.70
13
8.9
' References: Depts of Biological and Agricultural
Engineering, Animal
Science;
North Carolina State
University;
Jan 1990
Agronomic Division, North Carolina Department
of Agriculture
3-month accumulation of manure and bedding with
liquid drainage.
'^ Manure collected within 1 week.
-Broadcast: surface spread manure uncovered for
1 month or longer.
Table 7C. LAND APPLICATION OF BEEF PAVED SURFACE SCRAPSO !MANURE '
��-a���-�.a,-_-�-_�aA�aasa�==�aa��
��==asa���ar�=3sar•--�-�__===�.
Type
Rate-
Manure Application Rate
"
Minimum
Land Area for
Manure
Applicati•
`
Limiting
------------------broadcast------------------
--------------------
broadcast------------
oduction
Nutrient
----------------
llss/acre/Year----------------
------------------
lbs/acre/year
-----------
init
N
50
100
150
2=0 250 300
350
400
50
100
150
200
Z50
300
350
4C`_'
P2O5
20
40
60
30 100 120
140
160
20
43
60
80
100
1Z0
140
16C
GO
50
100
150
200 250 300
350
400
50
1CO
150
200
250
300
350
40:
----------------taa-s.'ac.^i:/Year---------------
---------------acres/head
capacity
-------------
Stocker
n
8.6
17
26
_1%4 43 51
60
68
.37
.18
.12
.09Z
.073
.06;
.052
.04c
P205
3.1
6.2
9.2
12 15 18
22
25
1.0
.51
.34
.25
.20
.17
.15
._
K2O
5.6
11
17
23 28 34
39
45
.56
._3
.19
.14
.11
.093
.080
.0 :
Feeder N
8.6
17
26
34
43
51
60
68
P205
3.1
6.2
9.2
1.2
15
18
22
25
KZO
5.6
11
17
23
28
34
39
45
.53 .27 .18 .13 .11 .089 .076 .06
1.5 .74 .49 .37 .30 .25 .21
.31 .27 .20 .16 ;4 .12
3rood cow N 8.6 17 26 34 43 51 60 6a .71 _36 .24 .18 .14 .12 .10 ^2=
P205 3.1 6.2 9.2 '2 15 18 22 25 2.0 .'39 .33 _23
K20 5.6 11 77 =T 23 34 39 45 1.1 _ .36 .27 .22 .13 .15 -
' References: Oepts of 3ialogical 33 Agricul:•_ral Engineering, Sail Science, Crep Sc:erce; Horn Carolina St ;;rtiv; :art
'� H fertilization rate should tse consistent *izh realistic crop yield.
N leaching and denitrification and P2C5 sac: irrmadilizatian unacccunted for_

Kifco Slurry Pumps
Models NT120S and FRT94/35
Pump Models:
NT120S: Single stage, closed impeller centrifugal pump with a mechanical seal and
integral gearbox. The wide design impeller is capable of passing a maximum 3/4" solid.
Three gearbox ratios are available, they are for the following input speeds: 540rpm,
1000rpm & 2000rpm. The 2000rpm pump is built to run direct from an engine and it
rotates in the opposite direction to the PTO pumps.
FRT94/35: Single stage, open impeller centrifugal pump with a mechanical seal and
integral gearbox. The pump will pump most animal waste slurries except long fibrous
material which must first be run through a chopper. The pump includes a stationary knife
which will slice through materials that ball up at the eye of the impeller. The pump is
very aggressive with the material being pumped. It is made from spheroidal graphite
(SG) iron which is twice as strong and four times tougher than regular iron. The gearbox
ratios are the same as those listed for the NT120S above.
PTO Models are mounted on a two wheeled heavy duty cart, the large diameter wheels
are 6.70 x 15 and run on ball -bearing hubs. Pumps mounted on carts are available with
the PTO drive shaft only or fully fitted as described below:
Unfitted Pumps include:
Fitted Pumps as above plus:
Bare Pump
Pump Cart
PTO Drive Shaft
Discharge Fitting
Heavy-duty Discharge Valve
Suction Fitting c/w Check Valve
Priming Pump c/w Easy Flush Line
Pressure Gauge
Gauge Protector
Fully fitted models have a 4" NPT discharge and a 6" Bauer style quick connector
on the suction.

250
200
PSI
150
100
150
100
HP
50
0
50 100 150 200 250 300 350 400 450 500 550 600 650
GPM
Performance and HP at full speed and full impeller dia.
(Input speeds = 540, 1000, 2000 depending on the gearbox ratio)
Increasing the speed on the engine driven pump to 2200rpm will
increase the pressure by 40 psi. Contact your local dealer or Kifco
for details of horsepower and performance changes.
PSI
HP
NT120S Pump Performance
9
EMENMEM MEMO
No
EMMEEMMEMMOMM
EMI rrrrM MOMM
MEMMEMEM
50 100 150 200 250 300 350 400 450 500 550 600 650
GPM
Curve A = Performance and HP at full speed and full impeller dia.
(Input speeds = 540, 1000, 2000 depending on the gearbox ratio)
Curve 8 = Performance and HP at 90% of full speed or at full speed with trimmed impeller.
I
600 S. Schrader Ave., P.O. Box 367, Havana, IL 62644
Phone [phone] Fax [phone] �.
°Baw d r.1'.enecr+g proaelC ---r VW M amms of rt mm in L" lea'H may nat ]@ -1eq= a aarens arme-an. i`d M=zmante rf rmamn ,m :3:earei is =w n •ems c mL caa _-•+eer a :arac w m of r_: c .w s. A=3J • ed
.yr-.-Marxe ra my nm -s n2 cecermxq 3n Vanaau ue_-;Wcas cr Wro. ;::)Co. ea-rr.-r..ai; agen ert arc corer -uwrs. '20cumers ana mixes art s__ el:'. ^=Ca.
GK5502K5?

0 0) 3--3- 11
EMERGENCY ACTION PLAN
FACILITY: HENRY WALKER
LOCATION: 1493 GODBEY RD.
MOCKSVILLE, NC DAVIE COUNTY
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ)
336-7714600
EMERGENCY MANAGEMENT SERVICES (EMS)
336-751-0879
DAVIE SOIL AND WATER CONSERVATION DISTRICT (SWCD)
336-751-5011
NATURAL RESOURCES CONSERVATION SERVICES (NRCS)
336-751-5011
DAVIE COUNTY COOPERATIVE EXTENSION SERVICE (CES)
335-751-6297
This plan will be implemented in the event that waste from your operation is leaking,
overflowing, or running off site. You should not wait until waste reaches surface
waters or leave your property to consider that you have a problem. You should make
every effort to ensure that this does not happen. This plan should be posted in an
accessible location for all employees at the facility. The following are some action
items you should take.

1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Waste Storage Pond overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the pond immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering pond.
B. Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and pumps -actions include:
a. Stop pump.
b. Close valves to eliminate further discharge.
c. Repair all leaks prior to restarting pumps.
D. Leakage from base or sidewall of storage pond. Often this is seepage as
opposed to flowing leaks - possible action:
a. Dig a small sump or ditch away from the embankment to catch all seepage,
put in submersible pump, and pump back to storage pond.
b. if holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the sidewalls and storage
pond bottom as soon as possible.

2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. ' Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ (Division of Water Quality)
regional office: Phone [phone]. After hours, emergency number: 919-
733-3942. Your phone call should include: your name, facility, telephone
number, the details of the incident from item 2 above, the exact location of the
facility, the location or direction of movement of the spill, weather and wind
conditions. The corrective measures that have been under taken, and the
seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS phone number
336-751-0879.
c. Instruct EMS to contact local Health Department.
d. Contact CES. phone number 336-751-6297; local SWCD office phone number
336-751-5011; and local NRCS office for advice/technical assistance phone
number 336-751-5011.
4. If none of the above works call 911 or Sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair of problem to minimize off -
site damage
a. Contractors Name:_
b. Contractors Address:
c. Contractors Phone:
6. Contact the technical specialist who certified the waste storage pond(NRCS,
Consulting Engineer, etc.)
a. Name: Fred Alexander, NRCS District Conservationist
b. Phone Number: 336-751-5011
7. Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.

t'Z
.- ;'
Insect Control Checklist for Animal Operations -�
Source
Cause
0611's to Control I115CCIS Sitc Specific PI nclicrs
_
Liquid Systems —_
—
1'111511 0111cls
• Accun 1ihilim of solids i
d Plush system Is designed and opernled
sufficiently to remove accumulnted solids from
gultcrs ms dCslgncd.
Ci itemove bridging oraccuuurlaled solids at
discliurgo
Lagoons and Mils
C111SIC(l Solids
O Mainlain lagoons, scllling basins and piss where
pest breedlug Is apparent to nlinhielm the
crusting arson ds .to a depth orno more ihnn G -
8 inches over more than 30% orsurrnce.
limmivc Vcgclalivc
• Dceaying vcgetuliml
O Mnintnin vegolallvo cotnlrul nluitg banks of
U1ulvlh
lagoons and other Impoundnncnls to prevcul
nccuinulaliou of decaylrig vegetative molter
along waler's edge on Impoundinciit's perimcicr.
U
FccJcis Fr111 Spillabc 0 Desigrr, operate and ntaininin reed systenis (e.g.,
bunkers and troughs) to minimize the
accumulnlign.ol'. "y1ng wastage.
0 Clean up spllingo ona routine basis (e.g., 7 - 10
day interval' during iumriicr; 1S-30 dny interval
during'whller)ifrh'rtirr�;
Red Slur age Accimm uiiuns ul' I'ecd icsiducs ❑ ItCdilCb I1lblslllrb accumulationIv1111h1 and
around ltnntcdints perimalor a reed slorago
areas by inatiring�drahtage away rrom silo
and/or providing adequate comainment (e.g.,
covered,biw. ror brewer's grain mud similnr high
moisture grain products).
O Inspect rar and reinovc or breakup accumulated
solids in filter! strips around reed storage ns
.7
0..
CN
r
AM IC - November 11. 1996, I'age I

S. -
�SI IIrCC .11UsC
111111's to Control insects Siic Spfcilic I'1':ICIIfCi
AIi1111S11 I lulding AIcas ACCUIIIul-Mium ut animal wrisles ❑
Efli 1innte low areas (lint trap) moislutc along
chit Iced %vailage
fences and other locations where waste
accumulates and disturbance by animals is
Iminimml.
❑
Maintain rence rows and filler strips around
nnimal holding areas to minimirc
aCCullluialions orwasles (i,c., inspect for and
remove or break up accumulatcd solids as
uceded)•
Ili y Mmim e I Icuulling Accunnlbliuus ul'uni nal wasles ❑
Remove spillago un a roulinc basis (e.g., 7 - 10
Syslrlus
day lidervni during sunmicr I S-30 day interval
during whller) where manure is loarlgd rur Imlll
npplicaliun or disposal.
0
Provido for adcqunto drainage around manure
atuckpiics; , � ° .... •
0
, Inspect ror and remove or break up accumulated
wastes In tiller strips around stockpiles and
umitire handling areas ns needed.
I -or luaic inliulualiau cunlact the coopeladve I-XICII51un Service, Uepurlulcul of Entomology, Box 7613, Nullh Cm•ulinn Stale Univelsity,
Raleigh, NC, 27695-7613. A}�
ANIII

3. 3. 13
Beef Farip Waste Management Odor Control Checklist
Source _ Cause I,lf1'll's to Aliniutlze Odor Si1c Specific I'raclices
Fauustcatl B re4. In uductiun ❑ Vegetative or wooded buffers
Cl
Recommended best management praclices
❑
Good judgmelil and common sense
Paved lugs or barn alley • Wet nmmlrc-covcled stirtilces ❑
Scrnpe or flush daily
sill faces O
Promoie drying with proper ventilation
f_1
itutlline checks nud maiulemtuce on walcici
hydrants, pipes, clock Minks
bedded ;IIC;IS Ui Ille ❑
Promule drying with proper venliialion --_ -
• I'tu lial nliCtnbi,ll dccumpusiliorl
Replace wet or manure -covered bedding
AI;Inu1c trey stacks • I',Illial microbial decumposhion
Provide liquid drninage for stored mannic
Slur;lgc foul( ur basin
• I'm till microbial decomposition ;
❑
Hollom or mid -level loading
Sill I"aCC
• Mixing while 1111ilig ; l
O
'Tank covers - ; :: ! .
• Agilalinn when emptying
❑
Bashi surfncc mats orsolids;
❑
Miaintize lot runofTand liquid addiliuns
❑
Agitate only prior to manure removal
Cl
Proven biological addilivcs or oxidants
Scaling basin surlilces
1'attial microbial derumpositioll
O
Liquid drainage firom scllled solids w
• Mixing while tilling
❑
Remove solids regularly
• Agilatiutl when emptying
C]
Mimmc, slurry ur sludge •
Agiluliun when splcadiiig
❑
Soil injection ofslurry/sludges
spreader uullcls .
Vullllile gas emissions,
Cl
Wash residual ltlimure rrom spreader af>ler use
CJ
Proven biological additives or oxidants
Uncovered mamlre, 0
Vulalilegas emissions while
❑
Soil injection ofslurry/sludges
shifty or sludge art field
drying
❑
Soil incorporation within 48 firs
sill lhces
❑
Spread in Ihin uniform layers far rapid drying
❑
Proven biological additives or oxidants
I'1nS11 tanks aAgilativa
_
ofiecycled lagoon
❑
flush tank covers; W
Iiyuid while ranks arc filling
❑
Extend fill lines to near bottom of tanks with
(-
i11111-5ir111011 VCIIIS
Outside dlaiii collecliun •
Agitalion duthig wasiewaler
❑
Box covers
01 jullctioll boxes
collveyallce
W
AA-"- ' - Novembei 11, 1996, Cal v I

w
-1
Source
Cause
AMPS to Minimize Odor Site Specific Practices
Lill sladuns
0 Agitation during sump lank
0
Sump lank covers .
filling acid dlawdo► n
End of di ainpipes at
• Agilaliuri daring wastewater
C3
Exlend discharge poiIlt of pipes nnderticath
lagoon
couvey;llicc
lagoon liquid level '
Lagoon surfaces
0 Volatile gas emission;
I
0
Proper lagoon liquid.capacity;
• Biological Illiaing;
0
Correct lagoon startup procedures;
• Agitalion
0
Mhliiiium`snrface'area-lo-volume ratio;
0
Miniiiluilis ogiiiiiioii�wlicll pumping;
0
Mcclianical aeration;
0
Proven biological additives
III igatiou spl inkler •. I ligh Inessnre agilsltioll;
0 Irrignie oa dry days with little or no wind;
norzles Wind drill
0 Minimluilftccbiliniended operating procedure;
01 PUMP intake near lagoon liquid surface;
0 Pump, froilrsecond-slagc lagoon;
0 FIIISIr residiiai'manure from pipes nt end of
slurry/sludge pumpings
Dead anillials • Cal cass decomposition
0 Proper disposition of carcasses
Standing water around • lulproper drainage;
0 Grnde and landscape such flint water drains
lircililies . Miciubial elecornposition of
a►vay from facilities
organic mailer
Mod liacked onto public • Pool ly maiulained access roads
0 Farm access road maintenance
1Uad5 liunr farm Ilcccss
Addiliunal Infunnnlion :
Available Front
Cattle Manore Management ; 02U0 ROOM' Packet
NCSU, County Exlerlsiurl C.CIrICr
Daily Educaliuiial Unit Maome Managenici l System - Lake Wheeler Road Field Laboratory; EBAB209-_95
NCSU - BAE
I.agoon Design and Management for Livestock Manure Ttentment and Storage; EBAE 103-83
NCSU - DAE
Mauagernenl of Dairy Wastewaler ; EBAE 106-83
NCSU - 13AE
Calibration of Manure and Wasicwaler Application Equipment ;
EBAE Fact Slieel
NCSU - BAE
Nuisasice Concerns in Annual Manure Management: Odors and flies
; 11110107, 1995 Conference Proceedings
Florida Cooperative Exlension
A61ii1' - MnvrIIIIWI I I, 1996. V:we 7

Nlortality Management AvIethocls
(check which methods) are bein`, implemented)
=E Burial three feet beneath the surface of the around within ?4 hours after
knowledge of the death. The burial must be at least 300 feet from anv flowing
scream or public body of water.
J Rendering at a rendering plant Iicensed under G.S. 106-163.-
❑ Complete incineration
J In the case of dead poultry only. placing in a disposal pit of a size and design
approved by the Depatunent of Agriculture
L! Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value Nithout endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
DZQCmber ES. [996

J.3.15
BEEF CATTLE FEEDLOT WASTE STORAGE STRUCTURES
OWNER: Henry Walker
300 COWS - 800lbs. ave weight
USDA-NRCS
DAVIE COUNTY, NC
SOLID MANURE - Drystack
300 cows X 60 days X .45 ft3/day/cow X 100% confinement = 8,100 ft3
WASTE STORAGE POND
1. LIQUID MANURE
300 cows X 60 days X .29 ft3/day/cow X 100% confinement =
5,220 ft3
2. RUNOFF FROM OPEN LOT AREA - 23,100 sq.ft.
Average Annual Rainfall = 46 in. X 16.4% of year(60 days)=7.54 in.
7.54 in. X 75% runoff = 5.66 in.
5.66 in. X 23,100 sq.ft. X 1 ft./12 in. = 10,895 ft3
3. RUNOFF FROM SILO AREA - 14,300 sq.ft.
7.54 in. X 50% runoff = 3.77 in.
3.77 in. X 14,300 sq.ft. X 1 ft./12 in. = 4,493 ft3
4. RAINFALL MINUS EVAPORATION ON STRUCTURE
105 ft. X 73 ft b 7,665 sq.ft.
7,665 sq.ft. X in./day(rainfall exceeding evaporation) X
60 days X 1 ft. /12 in. _ ( 20 �j S) -1,150 -ft3
TOTAL LIQUID VOLUME REQUIRED ` 21,758 ft3
a �(, 703 -F
ADDITIONS TO TOTAL LIOUID VOLUME
1. 25 YEAR STORM ON OPEN AREA - 37,400 ft2 area
Using a Curve Number 98 for open areas, and
With 25 year 1 day storm of 5.7 inches, Runoff = 5.46 in.
37,400 ft2 X 5.46 in. runoff X 1 ft./12 in. = 17,017 ft3
17,017 ft3 / 7665 sq.ft. surface area = 2.2 ft.
2. 25 YEAR STORM ON STRUCTURE - 5.7 inches
Use = .5 ft.
3. EMERGENCY SPILLWAY -
25 year 1 day storm = 5.7 inches = Q = 10 cfs
Discharge = q = 0.5 cfs/ft. ESW STAGE = .5 ft.
Bottom width = Q/q = 10/.5 = 20 ft.
4. FREEBOARD - = 1.0 ft.
4.2 ft.

Beef Paved Surface Scraped Manure Land Application Spreadsheet
This spreadsheet uses values from existing NCSU/NCDA data bases to calculate the fertilizer nutrients, application
rates and land areas needed for agronomic usage of soil incorporated beef paved surface scraped manure. Values in
cells I25-K53 represent inputs which need to be entered to use this spreadsheet. Values in cells D25-F53 are typical
values which may be used if more specific information is not available. If actual manure nutrient analyses are used,
then a corresponding change in manure volumes should also be entered. Application rates and land areas are
calculated for a range of ferdli7ation rates. Actual fertilization rates based on crop yield may be entered into ceiLs I61.
163 with the results calculated in columns C and K in Table C. The spreadsheet also computes herd live weight
equivalents, manure storage capacities, and estimated annual manure volumes to be land applied.
f
Typical
Actual
f
]------------------
----------
y-------
f
f Stockr
Feedr 3r=ed
Stockr
Feedr
9r"d
]
f
Cow
Cow
]
f ----per
hd cap--
----per
hd
cap--
f----------------------------------------------------------------------------------------------------------------
f Animat live weight: initial: 425
600 1000
425
600
1000
f
tbs f
f final: 675
1000 1000
675
1000
1000
tbs f
] average: 550
800 1000
550
.100
'1000
lbs ]
] Groups per year: 2
2 1
2
2
1
groups/year ]
Days per group:
Manure accumulation:
Manure density:
Manure storage period:
152 152 365
18 27 33
60 60 60
91 91 91
152
152
365
✓
18
27
33
;L7 zr
V/
6
60
60
60
91
91
91
days/group
�u FT- Per clay
�If Tj lbs/head/day
lbs/ft3
days
Manure total nutrient analysis:
Tot H:
14
14
14
14
14
14
lbs/tan
HH3H:
31
31
31
31
31
31
% tot H or tkn
P205:
9.3
9.3
9.3
9.3
9.3
9.3
lbs/tan
KZO:
13
13
13
13
13
13
lbs/ton
Organic H mineralization rate .50 .50 .50
.50 .50 .50
] Plant nutrient availability coefficients: (from application method box)
f H: .58 .58 .58 .58 .58 .58
f P205: .75 .75 .75 .75 .75 .75
] K20: .75 .75 .75 .75 .75 .75
]
1
f ] Application method: HH3H-------4------- PSK
f f soil incorp: .75 .58 .58 .58 .75
f ] broadcast: .25 .42 .42 -1.2 .70
] L
f Crop fertilization rate: H:
f P205:
f K20:
Scroll down for results.
] X x 20 = lbs/ton ]
] mg/kg (,-pm) x 0.002 = lbs/ton ]
-PEER � -D y lbs/ac/yr f
lbs/ac/yr f
u R /N r --��
lbs/ac/yr f
1o`ff1l�
L}-5 CO.FT. SOLIA-� -.

359-4e�. Rev. April 1991
��"���%� '� `L[Jl.i►..Jt� . �r,.L,s.�,.- r�--y� e �C�'y � �''�-' n`h-�-r..e.[i1,,� �-.-
Waste Pro
The values for waste production and the characteristics of
fresh livestock manure given in Table 1 are from the North
Carolina Agricultural Extension Service and should be used
except for specific situations which deviate from normal. It
should be noted that the amount of nutrients available for
crops is different from the amount produced._ See Waste
Utilization {633) for plant available nutrients.
TABLE 1. LIVESTOCK FRESH MANURE CHARACTERISTICS
Average
Feces
& Urine
Nitrogen
Animal
Production
Total
Ammonia
Phosphorus
Potassium
.N
NH3N
P205
K 2 0
(lb)
(dal/day)
(tons/err)
(lbs/ton)
Dairy
1400
14.6
21.9
10.5
1.8
5.0
8.2
Beef
800
5.53
7.9•
11.9
3.0
7.3
8.8
Veal
200
1.49
2.0
8.6
4.0
4.9
11.0
Swine
135
1.37
1.9
12.4
6.8
9.6
8.3
Sheep
60
0.28
0.4
20.8
6.2
9.9
19.4
Goat
140
0.69
1.1
21.8
6.5
12.1
17.7
Horse
1000
5.95
9.2
12.0
2.4
6.5
12.0
Rabbit
10
0.08
0.06
23.0
6.9
20.6
10.8
Layer
4
0.03
0.05
26.2
6.6
21.1
11.4
Broiler
2
0.25
0.03
26.0
6.5
16.3
11.2
Turkey
15
0.08
0.12
26.7
3.4
22.5
12.3
Duck
3
0.04
0.05
27.8
5.3
22.5
15.6
r7�'1� 4Q� aa•'
as S 5 .3
TA/CUv4, 7.�
7. 48 gal rU F+
, /
-7Z4 C 'r` G'.t FeCZS f 11 Y+ q
--9 -sty

iDepartment
of
Agriculture
Soil Conservation
Service
RUNOFF
COMPUTATION
SHEET
prepared for
H _ Wet 1Rer
in
Rowan
County, North
Carolina
Designer
: DRR
Checker
Date
: 02/28/96
Date S
*******************************************************************************
WS P
Watershed Slope =
4.0 % Drainage
Area =
1.0 acres Curve Number
= 98
Watershed Length =
250 ft.
Tc =
0.04 hr. Rainfall
Type = II
Frequency
24-hr rainfall
Runoff
Peak discharge
Ia/P
1 - yr.
3.0
in. 2.77
in. 5 cfs.
0.01
2 - yr.
3.5
in. 3.27
in. 6 cfs.
0.01
5 - yr.
4.4
in. 4.16
in. 8 cfs.
0.01
10 - yr.
5.1
in. 4.86
in. 9 cfs.
0.01
25 - yr.
5.7
in. 5.46
in. 10
0.01
50 - yr.
6.5
in. 6.26
in. 12 cfs.
0.01
100 - yr.
7.2
in. 6.96
in. 13 cfs.
0.01
Drainage curves Qa
= 0.3 cfs.
Qc = 0.0
cfs.
Qb
= 0.1 cfs.
Qd = 0.0
cfs.

;15Zf,
f✓L S f' t' C r- j`� C Al! r
U. S. DEPARTMENT OF AGRICULTURE NC-ENG-12
Soil Conservation Service . �Q f — Rev. 6/82
EARTHWORK COMPUTATION SHEET
EARTH EMBANKMENT
Name M � \ , • ,,`
Address
Embankment: Top Width _ Side Slopes CC-rt\ e 1,AI N 1)
"-- 1( rr, Imo^
STATION
FILL
HEIGHT
( Feet)
END AREA
(Sq. Ft.)
SUM OF
END AREAS
(Sq. Ft.)
DISTANCE
( Feet)
DOUBLE
VOLUME
(Cu. Ft. )
f i�
�
�
•r`
ry
r',7`
r �
�7a
-7 5
5
17 6-75
45
L�
5 4 3�
I. Double Volume of Fill t 2 a L `fr 4 Cu. Ft. 45 U i!
2. Volume of embankment fill (line 1 f 27) Cu. Yds.
3. Allowance for settlement (5 or LOY of line 2) = Cu. Yds.
4. Total cubic 3 r
yards (line 2 +line 3) Cu. Yds. i.
Computed by.Tate

A-. $ 1-3 u r
U. S. DEPARTMENT OF AGRICULTURE 15- X C 14 V /f7-4 Al NC-ENG-12
Soil Conservation Service Rev. 6/82
EARTHWORK COMPUTATION SHEET
EARTH EMBANKMENT
Name IV P- 6- L lK
Address
Embankment: Top Width ID Side Slopes 5
S ., r / ►.
STATION
FILL
HEIGHT
( Feet)
END AREA
(Sq. Ft. 1
SUM OF
END AREAS
4 Sq. Ft. 1
DISTANCE
( Feet)
DOUBLE
VOLUME
(Cu. Ft. )
71
a 5
1 CL A -7
$
�
I e'P,
25
-7 5 5 0
L4
to 4 f `F~
O
•2q tits
5a,
3
l 2 S
1. Double Volume of Fill t 2 - 4T 4 2q 5 Cu. Ft.
/ `T
2. Volume of embankment fill (line 1 t 27) = I /D�- S Cu. Yds. 14 5 0(,1.
3. Allowance for settlement (S or 10% of line 2) Cu. Yds.
4. Total cubic yards (line 2 + line 3) 3 Cu. Yds. rrLL
Computed by Date

. ,:,-k-u
F'` E 1 5 4
U. S. DEPARTMENT OF AGRICULTURE
Soil Conservation Service PL,4NNCO
NC-ENG-12
Rev 6/82
EARTHWORK COMPUTATION SHEET
EARTH EMBANKMENT
Name u �� ./, W 14 L K� ��-
Address '-} 3 d In oC KS /L I .2 7D ;Z
Embankment: Top Width 1_Q Side Slopes
STATION
FILL.
HEIGHT
( Feet)
END AREA
(Sq. Ft.)
SUM OF
END AREAS
(Sq. Ft.)
DISTANCE
( Feet)
DOUBLE
VOLUME
(Cu. Ft. )
foo
�
Q
13
zo8
.a
�3
5
/
silo
3 o
q zo
30
6720
3 0
880
'8
434
3
50
700
so
300
o
as
3oo
34
Q co
+,47
1
2 5
+.
5
�.
4
I. Double Volume of Fill + 2 a 3 2 3 -2, -')- Cu. Ft.
2. Volume of embankment fill (line 1 t 27) - Ilq -7 Cu. Yds.
3. Allowance for settlement (5 or.10y of line 2) _ 1 �-O Cu. Yds.
4. Total cubic yards (line 2 + line 3) _ 13 17_ Cu. Yds.
// Computed by Date

U. S. DEPARTMENT OV AGRICULTUR
Soil, Conservation Service
NC-ENG-4O
Rev. 7/91
PLAN OF EXCAVATED WASTE STORAGE PIT
NAME: _ H EE N P, )Z k Q _. Date:
county: V AV 1 'E-
Address:
LENGTH
CC�3Yr-c� cf�/
810E SLOPE,�_TO 1 //
w /
dmoo~ ; 9 �• B AVE. TOP ELEV. f�/ r2b/ S
w i/ ,__——_M10 SECTIQM ly7 r ��/� G-� elc✓. /Ol.
d /
i o
AYf. BOTTOM ELEV.
LLENGTH 3LO
�1
(See beck for volume calculations)
Use of facil 't ; aCr G2�.�'f 3
Capacity: 2a - Gallons Ft3
Soil Type:
Bench Mark Description
Bottom
Normal Liguid Level
Storage for normal Precip.
Maximum Liquid Level
25 yr. Storm Storage
Crest ESW
Max.Flow Depth
Freeboard
Top of Dam
SO4lARY_
Elev.
Elev.'
(+) ---- Ft.
Elev.=•-
(+) -t- Ft.
Elev.9.5
Ft.
Elev.. _� 01
`�. I 1S gm Area -. f IS
t-
l-+

VOLUME OF A TRAPEZOIDAL PIT
One equation for calculating the volume of a trapezoidal pit is:
13 1 sAu
Volume - d epth [(area of top) + (area of bottom) + (4 * area
6 .2 3 -7.2 3 Ft3
of midsection)]
Another equation for determining the volume of a trapezoidal
excavated pit with:gphstant side slopes is:
V=wdL+Zd2(4/3 Zd -w -L)
where:
V = total volume
of the
pit in ft3.
w = width of the
pit at
top -in feet.
d = depth of the
pit at
top in feet.
L = length of the pit at top in feet.
Z = side slope
for 2 to 1
useIZ-7ig2
for 21/2 to
1 use
Z = 21r2
NOTE:
Dimensions used must be constructible. Always check for narrow,
deep pits. For correct results the following must -be true.
w must be greater than 2Zd
L must be greater than 2Zd

16,O)OM n-CRAGE PON&
To P W r OTN
►0 , _,Jll
I Di,D ToP of PAM ELE
NjAX. dAt"�ATrr�1G t.G�I/t`L ECEV, 46•? t r--r11 yatdo e
r-- G DRY----� 9 s
h�oev r ut S+ 7
�Q 3 r yds
r r Scara�Cr+'wi [��
f y
CUT OFF TIT�� t7cp-w tv be d e-fc.-., %rigid
t-y �!%dfh de�crzds on
-rVPlGAL EMBhrJe-Nc-j�.rr- Cr20S4S SEL77DrJ
Tb
`�_ M AxcAMvSA oPt�c t.
nJ Sv�L �Lt'u 9l
A/
1.
s
E-rkbaKe-Me,4 -
C)(C-ava4c!4 l vv r ! o [r C: v
wI DT14 Porup 114)
-r-VPIC-At- PocG-. C-AO55 5 e2TZD�1 LErJG'ri� ' F:
1
i r,
j%� c�s� �qu,d l�o�c;► G1,t�`rC� : 5�"� 3 �G� IL14�C, Lcvel�
Y i 9 2244 °I /
GENETZAL T NEo94%+ArV4
- CHEoK Fops U►aDE7Z�PO��VD U`fZ(�TlEi
B EFO{�� TJ � riV:•�!N( GO ni 5� ({ GTE o Rl
`IMF t °S f `AAI 15 VAL, c C F67K 0NE`-Y&--Ae4
ZF Ct)fJ57lZUC.T74onl r 5 No-r s•-i4rTF-C
W cT rl%J THsiT-r: titc� RE-EYawRrnwv
AnrG A ree-o%m4 of r7Ez,-rCN W1LG-
16E N ECESS .- tY
*-f s �u.1�s ;n red
q` s-1e-qs
f-�ENL-4- L, WACEIS rAFM
• ✓ r- CC'uwy, f NC
TYPE of oPaZA-rTcn/_ [3eelc Ford&-t,
ANIMAL. Nunn3E7z: 300
GAS iamco by: FVA P44-
A FPFotrSF 9Y :
r,P•-rE : G

fr 3. 3. { Vp
Cil"'ERAT I ON 'MAINTENANCEFLAN I IR WA* STORAGE POND
171WNER: HENRY L. 'AALk:ER PHONE: m ,6 -4';,._
14 9'3. God6L.ey R d.
Mrlc:::sv i 1 1 e, NC_: Z7ts2,
The purpose of th i s p' i an I s to pil- =1V I +1C gi1 i de 1 i roes for Carry i ri 1 r-lut
,,I e rout i ne rota I n %enaric e work needed 4+1 'tee p � t l`f I S w a } Ne i 4 =1 r a',3 F+ _, rid
oiler a4 i rig as F, I arine,J. Pou'L i r,e ma i ri Lenanc e i 5 c+_+n= i d e r eIJ to be nor ma 1
good care of the pond.
T`le r clut i ne mai r:ter,ance r_+f t`[ i s waste s' ara;3e 11�r€+_ i r,vo lves t le
f ,., i I ! + w { r,
i Ma i n,ta i rf I n'a tiie 1 r r�LI I G I eve i of waste 1 rr t-1e �:e i-ct �»+f? �,, +_,r l,� a%
t,e I law t`,e Max imurn I_Iperat l Fig Leve I . The Iax mum C,p 2:-at i r[;3
L e v e l i s tir tle marr::e,_, =y a h i gh I y v i s i tl 1 e mar er- t pC'st or c, t1`fer-
su i tat:, 1 e means ) .
Ma i rota ] ri I ri 9 C+=+d Ve;3etat I Ve G+=+Vet" onthe emt+arr::;rnerlt an r[ tri. e
emergency sp, i 1 1 way to prreverit er ,s i on Ta l I Fescue i s be i Fig
estab i i shed on thhese areas, and annual fort i I i z a t i c,n sifr+u I d bE-
done to maintain a v i ;3c}rous stand of Vege tat i cFn . Re -seed i n;3
shuLi I d be dor€e as neede,J tc, rr[a i r,ta i ri an adegLiate stanIJ .
� . Weed-, t,rUSLl, ar€Ij trees 5_+rr rite ernbarr�.:merlt an,�a aFl i l l',Fa'y� s`[�tu 111
be ct:fntrn I I ed by mow i r[ , Spray i rio, chc,pp i rig or a comb i nat i cln
of all three. This w i 1 1 need tc� be done at I east +_ rtce a year -
and posy i t, I y mere of ter, i n years favc+rat+ 1 e to heavy Syr owth .
'Y. Livestock should riot be a i I r,we,4, t'_1 9 r a z e the e m b an kfl e rSt ar€d
sp I I Tway excel,{ T'or very short ,Jurat i C,ris 4 ' aid in control it}'
v?getat i ve cover They should r€+ t t+R a; l , wet; +r€ these areas
at al I when ground are wet andJ soft.
5. Fer[r I rig shr,u; id be ma i rita l ned around the waste sti=,r-aoe t,:1
+reVer,t I t Vestr+Ci: frrrrn f a l I r rl i+3" 5 i r F+�+ 1 ng i r[t+=+ t,`le +crr,+c. .rf.t
w i I l a! Sohe I pi prevent 'riumar[s from Sail n'i Fig access
1' I a i ri t a rI a n C e
inspections
of
this
waste
5 t _+ r j, `3 a
`f +-I ! r 1"�''
� �i �i rj I iJ LI "" j n 1J•- J Li1
d,ur in� lie
i€fitial fi I l
in3,
at,
least
arinua! ly',
and'
of Y_--,- r-�� rS4ai 1_Ir
3- c� i m a v e ri to
. y! 4r e f 1=1 I , I_I
w i 1 F 'v
a r a
areas
which s h
+.,I u� d
_I e e i1 ml. ? C(.
rni rlimum
1. F'r=,rr 1 Are;+ - i i11- L f [Ir
-a U n d e s i rat, I e v e 9 9 t a t i ve ;3r1:1w th
t,) F I rlat i r,3 ai-id I c„ Jged debr- i s
E:7rnbank• meat _ I oo -: fc�r"
a) SettIeu,er,t, rrar- r€3, =,r- `, +les
st+ipje instabi 1ty - wlurnps i:,r ':+uIoes
C) Wr:t vr" darnp areas c,rf the baCz•'. 5 i .,r.,
d ) E7r+=1s I c,n due to 1 FL f ve:3e"at 1or€ c'r" wave act 1 inn
e) R1c,dertt damage

Emergency SpiIIway
3) S h o u e ci,eck.ed after every major storm. If it fur,ctic.r,5
i t sh _�u l -1 ; e checked to see if any repair- is nee-jed if
reseed i nS i s neeA_,ed.
4. Waste Inlet Pipes
a) C:on -j i t i on e--,f p i F,es -- Se par at i -tr, ii f ,jo i r, tt.5 y" L r ac E, Gr brer,.rCS
Fa i I i rig support posts � p i er-s, car Grad I eS
c i G4 i i ect i or, r_,r dr =ire i r, i e t boxes wi, i cl-, d i rec t waste i r,to pond
5. Fencing
a) General cr,ndit1i+n of hos'15 and wire; repair and re :ace ar,y
dama;aed areas.
In the e-ver,t that a ma i ntenance i r,spect i ort reveal 5 that waste from
your - s " o r a 3 e porid air" + '; `ler" FIart .-Jf Y;: qUr L,LT'er-at i 4ri i S QVeP-f i -w i ng,
l eak i rj�3, or running :.f f site, the EMERGENCY ACTION PLAIN prepare_, Por
your operation should be activated.

0 +
ANIMAL WASTE UTILIZATION PLAN
�rrrrtrrrrrrrrrrrrrrrrrrrrrrrrrr�rrrMrrrrrrrrrrMrlrirrPlA?rrrrrrrrrrrrrrrrrrrrrrlrPrPrl7lrPrPrPfMI'11'r�"1P117hi�?l7PrPiP7P1P7T lTrP1,^rrr,^rrr
�rV/5(0tj Ta11. ,2 2-000 cs rrcad�
Producer: Henry Walker
Location: 1493 Godbey Rd
Mocksville NC 27028
Telephone: [phone]
Type Operation: Existing Beef Feeder - 6 month
Number of Animals: 300.00 bead
(Desigii CaparIty)
STORAGE STRUCTURE: Waste Storage Structure
APPLICATION METHOD: Broadcast
The was t's• frori? y,o ur- iI'-Fr1a I f3C i i I ty MUst be I ape+ i i a,::; at a.
5�re c i f i e=3 rate t+-, pr e v ent F+ l l ut i t rh of surf ace water arhdi,_+r
4rcojrfdw ester . The plant. nutrients in the a.ri i roa l waste should be used
to r-E?dluce the amount. ++f Cr}Primer-C i a1 fer-t i l i zer required for the crop+ _
in the fields where the waste is to be app l i ed
This waste ut i i i zat i c_ n plan uses nitrogen as the i i m i t'€ ng r,"tr- i ent.
iR1a5'i:e cyihr-ru and; yz+ed before each app I i cat i on cyc 1 e. Annual so i 1
tests are strono i y encoura3ed so that al 1 1 an-, nlltr I exits cash ire
t a i anCed fe-,r- r ea i i St i s y I e 1 r5 r_,f tihe crc,p tfr ire gr ow.n .
Se -Vera I f a c urirs aria' i mportant i n i rfip I efrient I rig ywur" Waste Ut i I i a.t i on
r` i an i n or der" tc rna;�; s rrt? ,'-_t file feet i l i er value :_ef t`ie waste arh,� to
ensure tCi3t I t is app i i ed Jr, an env i r+_,nmenta l l y safe manner:
1. A I ways apply waste based rri the deeds = the Crf,p to be
3rr_+wn and the nutr- i erht content of the waste. Do nrI t app 1y
mere nitrogen t€3ri tl1e crcrp can ut i l i ze,
cio i t>�pes a.r-e i rfip ,rt�.nt, a.s t,-,ey i -ave d i f ` t�rarit i of i - i ,-'rl
rat=sy iedc siri'c p-teilt aIs, cat orh e.,,c iA.ri7e r-;.kprfcitIE?sr ant`
a V a i I &b e water- ihO!JJ '13 c apac l t o es .
i�IorrrialIy waste Si1alI rtnt ie ci I lec' �r_e tar€,s e,'irrtirl3 a ;es5
Man 5 tons per- acre per year. Waste may tie anr, I i ed to I a.ndl
er od i r,S at !r or more Loris per acre anriva i i y, but less than
10 tons per acre per year- providing that adequate f i l ter
strips are estair l i stied.
i. Do ncL u app I y waste oin Saturated So i i s, w,-en I t i s r-a i n l no,
rrr rl t`€e =ur-facF is Fr,_r7.ein Eitt:er- -,t t�'iese ccin,itir_rrhs
--nay resi n t i ri r'unr�ff t r slirfaCe waters wi! i c`s I c5 n+-{t a I nw7ed
under DELI re.hl3t
"M 76�r6�,Ah? Ai A� h� !I,my Ai "y h7 Al nK

r
ANIMAL WASTE UTILIZATION PLAN
A1!'1 A7A�A1 PrM1'll'1 P7P7MP7Pf P1ArArP1 P1 P1P�r"YP7P11'1!'1 P�?'7P1 PrP]!'1 Pl Pl P71'1 P1 PyPl Pr17f'�P1 P1 Pl!`X P7PIP1 MP?I`7P11'rP7P1P1 P1P1 A�P71'lT 1 Pl M!'rP1P1P1!'1
5. �'A I nd conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for p =. i i ut i oil, the waste should
be app l i e to a growing crop or appiied not more than 30
days prior to p l ant, i ng a crop or forages breaking dormancy.
Injecting the waste or disking wilt conserve nutrients and
reduce odor problems.
This plan is based on the waste app l i cat I on method shown above. If
you choose to change methods in the future, you need' t�_ revise ts�15
plan. Nutrient l eve I s ft_tr- different app I i cat i can methods are not the
same .
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to .have plant
analysis made, wiNich could allow additional waste to 5e app led.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate chancing waste analysis content and crop type.
Lime must be applied to maintainpH in t Li e optimum range f t=i r specific
crop production.
TI'h i s' waste ut i l i at i ern p I an, if carried out, meets the requirements
for compliance with 15A NC:AC. 2H .0'a17 adopted _ty the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
300 ;head x Z.3 tens waste/head/year = 690 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (RAN) PRODUCED PER YEAR
000 head ., 13.5 i bs PAN/head/year = 4050 ; b s . PAN/year
Applying the above amount of waste is a big job- You should plan time and
have appropriate equipment to apply the waste in a timely manner.
The f _r i l ow I ng acreage w i i l be needed for waste app 5 c at i on gases; on the
crop to be grown, so i l type and surface app l i cation.
:1.1 1. 17.11 n; .,y �K n r �,ey!.+ ") Ay ^y?•jpy "y n7 �Y,^'?Y

Y"M-;w��' pia ~►^•'r�.:.`'-. �`r1.h�I 'F�ir�Y'+il'•�.T' - �_.-i.• ,: �. -
-~�� ::'�: � i:.`,.•a.�. L a fsL':: �•.. - :ate �-..�i�,y �, �._• •'�;.:'� - .ti:'..rl+`•.c. ..�Cei._ �ltr.s:,. Ls :� ".r1�4' .7;'•' ~1�•5';.,.�. i. �`y.
y. •4;. LTA �_ • ��y nCs:Y.+ ,r.;..<.'� _, � -
� , t?a�.�t� i . 'y-;jr."��..:• ��� ♦ �iJ_�.nia'a3 �- •�„" �1��.;.^.:-'� '+�.•��O*r�•_;y'� • �; `; r�r' -i..�:';•
,r, �. ;�fti;.: ti :�.:' � r far.• -
"a;":: "Ole
•• .,>. �.'!. ,`' � Y-ra - r�uL'rat..L-E' �. ti'>�: ':. �'�' ai"'. �'P "�.�a` �'� 'i;�•: ,. �t,s'.
d, "`a J }'
A ".�`�•'7iiJr, �' r .1 _ .r r `'tJ Ji �� - e.��Y t..jy iM �
r !'
.: a b; ;� � - � � r .�'.�r'. r'J- �,•; � •r+ y, i'"'"3...,r � c.: , -. x
IZ
t !'�� v,y ' :'1'f 4• {.'��Z r �ai-%ta'+�.j �; �i�'..� Y}• �1 - i � -.� � �1! . -s 4
s

�.. - .-::' �.r � -, f "-w• � �' ��iiii'''' � ?��-ram. �.�_ .:
. � � �., `� :��s� !�►''� yr. .1 {Ri } _ ;..
~ILL"'� Yet rf1i�'•i Z
+° 1. ` :, � • �;:; `:� � ;�t ��?, d� ,��~ ,
�� _.�:� _ � - `' '.�:.,.,�� �.:'� - - : . �-'''��y� � is •. �.`•r e' , .���
:{" _ l �''_ � „ ' - ! �' `�'Y- i/t'� '. -r ✓ � T '. ?�I tom'' .[' i-,
_•r_ .-'�^ •�� _. Y� S�"..R�t �,�-• •, Y• y, .� �_ �,y_f A • - _i. bpi 'ti.
y' J, : l yltfl '� I•' .. F i ri s �3
t• :' �:'' K fr,, - '.c. t' ri. a _ .a`•,,.` F'i •.`l S: Y� �1-'S

Davie County, North Carolina
TABLE S -LADiD CAPABILITY AND YIELDS PER ACRE OF CROPS AND PAS?QR8
(Yields are those that can be expected under a high level of management. Absence of a yield indicates that the
soil is not suited to the crop or the crop generally is not grown on the soil)
I
Map symbol and I
I
Land I
I I
I I
I
I
f
I
I I
I I
soil name Icapsbilityl
Corn
(Corn ailagel
Soybeans I
Tobacco I
Wheat
I Grass- I
Pasture
I
I
I I
I
I
Ilegume hay
I
I
Su
I Tons I
Bu I
Lba I
Bu
I Tons I
AQM*
AaA------------- I
IIw 1
125
1 25 1
45 I
2,800 1
55
! ---_ 1
11"5
Altavista I
(
I I
!
I
1 I
I
ApB------------- I
I
IIe 1
95
I I
1 19 1
I
30 I
i
2,500 1
45
I I
1 4.6 I
6"0
Appling
I
I
ArA------------- I
r
VIw 1
---
I I
I --- I
!
--- 1
I
--- I
---
1
I --- I
6.0
Armenia f
I
f I
I
!
I I
I
sus ------------- I
I
Vw 1
---
I I
I --- 1
I
--- i
I
--- 1
---
! I
f --- 1
3.0
Buncombe I
I
I I
I
{
I I
r
Ces2------------ I
I
IIIe 1
115
I I
1 23 1
35 1
I I
2,200 1
45
I I
1 4�5 1
7.5
Cecil I
I
I I
I
1
I I
ChA------------- I
IV1w 1
130
1 26 1
30 1
2,000 1
30
1 5.4 I
9.0
Chewacla I
I
I I
{ I
I 1
!
EnB------------- I
I
IIIe l
110
1 I
1 --- I
30
I I
I --- I
40
I I
1 5.1 I
8.5
Enon I
I
I I
I I
I I
I
EnC------------- I
I
IVa 1
85
I I
1 17 1
25
I 1
I --- I
---
f f
I 4.8 1
8.0
Enon I
I
I I
I I
I I
I
Esc ------------- 1
I
VIs 1
__-
I I
I --- I
---
I E
I --- i
---
{ I
I --- I
4.5
Enon I
I
I I
I I
I I
I
Gan ------------- I
I
Vie I
---
I I
f --- I
---
I I
1 --- !
---
{ !
I --- I
7.5
Gaston l
I
I I
I I
I I
I
Gns2------------ I
I
IIIe 1
130
I I
1 25 1
35
I I
1 --- 1
50
1 1
1 5.5 1
8.3
Gaston I
I
I I
I I
I I
I
GnC2------------ I
I
Iva 1
115
I I
1 23 1
25
I I
1 --- 1
40
I I
1 5.0 1
7.6
Gaston I
I
I I
I I
I I
1
GrB------------- I
I
IIe 1
75
I I
1 --- I
---
I I
I 2,000 1
35
I I
1 4.6 1
6.0
Granville I
f
1 I
I I
1 I
I
IrB------------- I
I
Ile I
110
I !
1 22 1
---
I I
I --- I
30
I
I 3.6 !
8"0
Iredell I
I
! I
I I
I I
I
I
Mas------------- 1
I
IIe 1
120
I 1
I 24 1
35
I I
I --- I
45
1
I 4.8 1
8.5
Masada I
I
{ I
1 I
I I
MdB------------- I
IIe 1
95
1 --- 1
30
1 2,600 1
40
I 5.1 1
8.0
Mayodan f
I
I I
I I
I I
I !
I
MdC------------- I
!
IVa 1
75
I !
1 --- E
25
! I
1 --- 1
30
1 4.2 1
7.0
Mayodan !
I
I I
I I
I I
I
i
Mdn-------------I
I
Via {
---
1 I
I --- I
---
I I
I --- 1
---
I
I --- I
6.0
Mayodan E
I
I I
I 1
r !
1
MdE------------- I
I
Vlie 1
---
k I
I --- I
---
I I
! --- I
---
I
I --- 1
6.0
Mayodan !
I
I
I
1 1
I I
I I
I I
I !
I I
See footnote at and of table.

96 Soil Survey
TABLE S.--LAND CAPABILITY AND YI&MS PER ACRE OF CROPS AND PASTURE --Continued
I
Map symbol and I
I
Land I
I I
I I
I
I
I
I
I I
I I
soil name !capability!
Corn
Korn silage!
Soybeans I
Tobacco I
wheat
I Grass- I
Pasture
I
I
I !
I
I
Ilegume hay I
I
I
Bu
I Tons I
Bu 1
Lbs I
Bu
I Tons I
AUM*
I
MnB2------------ I
t
IIIe f
85
I I
1 --- !
I
25 1
I
2,400 !
35
I t
1 4.2 I
7.0
Mayodan I
I
I
I I
I I
{
I
I I
I
MnC2------------ I
Ive !
75
I --- 1
I
20 1
I
2,100 1
30
I
1 3.6 1
6.0
Mayodan E
t
[ I
I
I
I I
E
MrB2------------ I
!
IIIe 1
115
1 I
1 23 1
I
30 1
k
1,800 1
45
I I
I 4.4 j
7.3
Mecklenburg I
I
I
I k
! I
I
I
I
I
1 1
E I
KrC2------------ I
I
Iva 1
100
1 20 1
--- I
--- 1
35
1 --- 1
6.5
Mecklenburg I
1
I I
I
I
I
I I
I
I
MsB------------- 1
I
IIe I
95
I I
1 19 1
25 1
I
--- 1
40
I
1 3.6 1
6.0
Mocksville !
I
I I
I
I
I {
I
Mac ------------- I
I
Ive 1
70
1 I
1 --- 1
I
20 1
I
--- 1
35
t 1
1 3.3 1
5.5
Mocksville I
l
I I
I
I
I I
I
MsD-------------I
f
vile I
---
I I
I --- I
I
---
I
l --- I
---
I I
I --- I
5.0
Mocksville I
I
I I
I I
I I
t
PaD-------------k
I
vlle I
---
I I
t _ _ I
---
I I
I --- k
---
I I
I --- I
5.0
Pacolet I
I
{ t
I t
I I
I
PcB2------------I
{
IIIe j
105
E I
1 21 1
30
I I
I 2,200 I
45
I !
I 3.9 j
6.5
Pacolet I
I
I I
I I
I I
I
PcC2------------ I
I
Ive 1
95
I I
1 19 1
25
l I
( 1,900 1
35
I I
1 3.6 1
6.0
Pacolet
� l
Pt--------------]
I
VIIIs---
I I
I I
I I
Pits I
I
k !
I I
1
!
I
RnC-------------I
I
Ive I
---
I I
I --- I
---
I 1
I --- I
---
I
I ---
I
I 4.0
Rion I
I
I I
1 I
I
I
I
RnD-------------I
I
vIIe I
___
I I
I --- I
---
I I
I --- I
---
I
I ---
I
I 3.0
Rion I
I
I l
I I
I
I
I
RvA-------------j
I
Ivx 1
140
I I
l 28 1
40
I I
1 2,200 1
---
I
I 4.8
I
1 8.0
Riverview f
I
I I
I k
I
I
i
RwA-------------!
I
Ivw 1
100
k I
I 18 1
35
I I
1 --- 1
40
I
1 2.5
I
1 8.0
Roanoke
I
I I
l I
I
I
I
SeB------------- 1
I
IIe 1
100
I I
1 20 1
25
I I
1 --- I
---
I
{ 3.3
I
1 5.5
Sedgefield I
1
I
I
I 1
1 1
I !
I !
1
I
I
I
Ud--------------1
Vllie---
Udorthents I
k
I I
t I
I
I
I
I
Ur --------------I
{
VIIIa---
I I
I I
1
Urban land I
I
I I
I I
I
I
I
Wes ------------- I
i
11e 1
95
I I
1 19 1
30
I I
1 2,000 1
35
I
1 3.6 -1
I
6.0
Wedowee I
I
I I
I I
I
I
I
WeC-------------I
I
Ive 1
85
I I
1 17 1
---
I I
l --- I
---
I
1 3.3
I
1 5.5
Wedowee I
I
I
I
I I
I I
I I
I I
I
I
!
1
* Animal unit month: The amount of forage or feed required to feed one animal unit (one cow, one horse, one
mule, five sheep, or five goats) for 30 days.

ANIMAL WAS i E UT I L i .-:ZAi I LAN PLAN
rrrrrrrrrrrirrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrririririrrrrrrrrrrrrrrrirrrrrrrrrrrrrrrrrrrrrrrrrirrrrrrrrrrri;^ir�rrirrrirrrrri fwl j,
TABLE 1: ACRES OWNED BY PRODUCER
TRACT ; - .Lr i`
-_ ----=-----CLASS--�_-_;_C
R,_`
-3 rv•_•�,.
1
.�.`- �_.__`..____
;..
L. 1 1
'A.
.
!
I
us
1
�I
1
1
t 1_!
5 ! l i2,5
�..-
.L i I
-- ---- .
i L,�4l' lY------ ---- _..-i 7
1
3 I
-.,_ -- --....------A - 1 ---- — _ ---—._---._.__..._._._._
F 1
r I
' 'la3 75
V
--r,
V
FIR
, : -
I
1J
1
! Er I
;I
--------- --------- _ _ - '--------------------- --_...__.
Yi'e1d5 y 2590 '{ Pasf7j.re L—�►-.2400 ,._ T
r
Wi _. r 7L D F1'.1ui = }3:r; i :=1ri 5u►r:,frlEi __-.-!ldc. -,
T I I Z a __ F� L3L _ I,! �S f_ I_ I : *, <� u - a F a rt d L:" c
�fl 4e t i f l 'y IL!Y _ l3 £ ffl P_ r! � i i I t i, G
-"hers :'I soon@ [,arty _IaS"} . rlaL -'RVe y -, _.`r I fir,
a -i ,r
ATr°rrr,n;ro7?yrrrirnrrrr°irt7'•7i 7rii 7i��r7 °r,°rrir"if'ir7rni F�!,�"T�ir; r°y;p+�`rr°7hY �7r'�7r7?7'7{nrr 7^iryr'•y:-7rorf�;:�rre'-:ir7i r:o• •.r:°ir�Yr;rtirl��:orr�7�si f•7Ai!•7F ?r� Y

,
ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with aojacent |anoowners must te aztached')
(Required only if operator does not own adequate land.
See requires specification 2.)
| � DETERMINING PKASK ;CODE | | AW N 1 ?ER VCqES| AW �
| � | | ;PER AC; AC | 1 USED
| or t | --------
!APPLY; | /RESID.| 1 APPLIC
| | |METH | | ' N | TIME
| :END | | | \ | |
_______________________________________________________________________________
TQTAL|0
~ Indicates that this field is being overseede, (i.e. interP|anteo) or wip-
annua|s fo||ow summer annuats,
�* Acreage figures may exceed total acreage in fields due to overseed/n3.
* |bs AW W (anima| waste nitrogen) equals total required nitrogen less
any commercial nitrogen (COMM N) supplies.
The fo||awinS |2Send explains the crop coces useo in tanies 1 ano 2 aMove:
______________________________________________________________________________
1 CROP CODE | CROP | UNITS [PER UNIT!
| | | | |
___________ __________________________________________ ____________ ________
| Fp FESCUE PASTURE | TONS | 50 |
------------------------------------------ |------------ I________|
TOTALS FROM TABLES 1 AND 2
_______----- ____________________
� �CRES | LBS A� � USE� |
|______________|
TABLE 1 | �9'3 | +f54*09 7�/uL�� |
°_"°~ |
TATl-E 2 | 0 ) 0 |

• (e 4
ANIMAL. WASTE UTILIZATiUN PLAN
rrririrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrrr^rrirrrirrrrrrrirrri fi,rrrrrrrirrrrrrrrrrrrrrrrr^irrrrrrrrrrryrrri pirr^rrrrrrrrrrrrrrirrrrrrrr ^lplplplpl
--------------------
*.ry. Tni-.; ;-iuii1i=?Y" TA1.!5t u !e:55 ti,aF1 ,,Y aqua: -, :1 i=:'deY- _
rr'?Prr^rn?ri% TrrP?i'iPfrrrTr^lr'rrrr°r!'?,°yhr-„-7;^rhr;.:;orRr?�rrpir^r,,,;r^rr^r�rr.r,i..,�yi+fhrP7PrA?Pr' ?i°"?�,'1:flf,^Y,^;e77r Yrr^;''?fh?,°7i'•!;''?,hYrll°?;^ll°r,°r

ANIMAL WASTE UTILIZATION PLAN
Pf AfrlPfPfPf!'fPi/7A1MPfP1PfP11'1PfMPrP1PrP1P11'11'7MP1r'fP1Pfl'fPfhfAfPlP1P1!'11'71'7PrAf/'fPfl'yMPTAfPff7PfPrPf!'f!'tPf PfPfPrf'1!'1MPyP11"!!'1Pfl'1f'rPf
This number- must be less than or equal to U in order to fully ut i I i ze
the animal waste N produced.
Acres shown in each of the preced i nS tables are c ons 0ered to be the usable
acres excluding required buffers, f i I ter strips along ditches, odd areas
unable to be irrigated, and perimeter areas not rece i v i i-rg full application
rates due to equipment limitations. Actual total acres in the Fields
listed may, and most likely will be, more than the acres shown in the
tables.
Ses attached map showing the fields to be used for the ut I i i zat i on of
animal waste.
Your facility is designed for 60.00 days of temporary storage and the
temporary storage must be removed on the average of once every 2.00 months.
In no instance should the volume of the waste be stored in your strar_ture
be within the 25 year 24 hour storm storage or one foot of freeboard except
in the event of the 25 year 24 hour- storm.
it i 5 the respons i b i l i ty of the producer and waste applicator to ensure
that the spreader equipment is operated properly to apply the correct rates
to the acres shown in Tables 1 and w. Failure to apply the recommended
rates and amounts of nitrogen shown in the tables may make this plan
invalid.
Call your technical specialist after you receive the waste analysis report
for assistance in determining the amount of waste per acre and the proper"
app I i cation rate pr i car- to applying the waste.
NARRATIVE OF OPERATION
This waste ut i l i zat i on plan i nvo i ves the application of both dry
waste scraped from the lot and liquid waste from the waste
storage pond. Lot runoff captured in the waste storage pond is to
be applied by irrigation to Fields j-r-f-jrtA 1-4. It will be applied
according to the attached irrigation system design. Estimated
nitrogen from this waste is accounted for in Table 1 under the
Commercial N or Residual N per acre column. Actual n ? troSer,
app I i cation rates may need to be adjusted after a waste analysis is
completed.
�1PfPfPf1'yrrflfrf7PyPfA1P1A7Air1AlPyntr*p7rlrrrrrYrY.y�:ni^r.�Yrrnrrr/+7rY�1.^,r�:*Yn7r7>,�hY�,nYn� ., .,.iHn.,,,n.,.,.., ,......-...,_.......�..

�C - 'civic
r/a5�e `�roragC �cr'c� - L,yv,� (�lo5f� E-•o�ucer� 1 .1
WG{51e. 7orOgG �Or�C� `/6�G�rr�e
7S ? ��,� 7. 4 f�r/cu.ft - 16d2, '750 9Qll�rs
e v e-7 60 Cl a �/5
Ca41e- N/r 1! he Ccr;.rcd GY' fhe reed to * -/' a2 ? kc) w OA--
(D nv?arikp eacA � ecil CIYOreM6Gtr 'fi�u ��+`�).
`rG+er C{�rfi+ `7Fi^iG r7Q �+nour,t o� k/GSk f -oduGe4 F/ou(C) A
760 �rlcx X 1 8 S 2 so
(o o Cia�I, 60 days 1
w �
7�a c ane no +'dad.,.!y _a✓a�724 unes. 1;r Qva-15
bee�F/c.e_
iNjQS,fe a-na Lrs e, PrVM CIQ %r O �R fiotits jJhe.r_*-- Ma
SC-0 2d Q rtQ Gar jl 0 u �r� Q �fc� �i'�-+-a cJ C "CIS - a 1^e
on jyy 1+9�+d ;�asfe c�►+d r-u off- l� roc S own l e fe-/s . o .. -
Id, a va •'1 a1./e r» ,4"Y-c rl Cp�^� h e- C-�IO roxle1.
,i. lh PAn! 17er lGoo qqal/cnr5 ourrC - TDr^.+�y 13�,r�hcEle�>�C�=T,
I
�� T�'+r5 s�'1�TiafiO)t eQ IG ke;r Car► r,gcd r,-e! A Foo
ora a vcrage- caw ared -{� ✓cr4yc rver�fr- of I #Da /If .
1c-, a i7I 4 e e H*Lt CA K W *J 6 k4i el /n , r�$ . It's. 5,
/ Ili a. rj t,c r G n r t4r r 'e ri 'h$ . •x w . Er- "k, c p� p +u rt r� rr rr `th r-
pm Id, ,r4- iS 4;,2
I r `4- +'s T ti 10 f 6 f v ari �. i�'J a} ►� " /''
PA /OGLE q al/ar+s = ,2 3 I 3 P,,4N
G�urr�y �� � r►-r�-�G.s w�,IG Ca�l� o. � ccyr�'.�cd.
�II fs�+1�'
C hduld b e CiC7i� �`J ClCTLrrr' rr� �� i✓I r;,-4r,'"+
l e V,
�!5 � �j u r + y �y+ � � + x /�, � Crt :' � s W 6, � r; Cp ��1 � i r2 •* � -� �..� L. rc�

6 46
Heery �A!ke r
ua S1%G
rJa;k s{aro� e
wr'<< be Cl"rf,7 �e yVgrr4er X7r� A5 Some ale +Als
Joe- loaf ev p"d
rvr'11 pro bnLI 5iw need -AP he erk?fret/ Per, od.-c, ,,

WASTE UTILIZATION PLAN
h1 fiil'�PrMMPI P1PfPrh1 h1 Mh1MPYfi1 fi7P1Prh1P1Ml'1 P1P7fi�hlPrMfi�P7fi1MP1fi1fi1h1Mfi1 h1MMMMhrP�P1 P1MMfi1P1P7P1MPTMMMfi1hrMMMMPfi
REQUIRED SPECIFICATIONS
1. .Animal Waste Sha; i not reach sur-Face waters C+f th:e state by
runc,ff, drift, manmade conveyances, direct appi ication, or
direct discharge during oper"at i rin r,r- land app I i cation . Any
discharge of waste which reache, surface water" is prohibited.
�. There must �,e s�C,Curnenta'` i ,,r! i rs thie deSl 3r[ f I der that the
producer either owns or has an a3reernent for use of adequate
i any -! c+n whiiCh tc, _r_,per-ly apply thhe waste. If the i,r-odlucer does
nc,t own adequate i and to pro er 1y dispec se of waste, he/she sha l 1
F,r ov i de a c i,py Gf an agreement wi tit a i a.nelr,wner- wh, i s W I thi 3 rh a
r-
eas,,rtab 1 e r,r"ox i m i ty, a I I ow i rig hi i rn/1-,er the use of the I and f,_+r"
Waste app I I Cat i c,r, . i t r s ther"es�„arts i b I l i ty +f the owner of the
fac i I i ty to secure an update of ti-,e Waste Ut i i i zat i on P I art when
there is a change I rr the oilier"at i nn, i nC rease i n the number ftf
anima. isIF meths„j of uti I izatic,n, _,r avai iable land.
An i ma I waste shha I be aT-p I i ed to rneet, bL,t riot exceed, the
n i tr ogen needs f c,r rea I I st I C crop. y I e I ds based on so i I type,
ava I I ab I e rnc, i Sture, h i stizir i ca 1 data, C I i mat I c ccind I t i c,ris, and
Ieve I of management, unless there are regulations that restrict
the rate of app I i cat i on for- other nutr- i ents .
4. An i rna I waste sha 1 l be app. I i ed to I and erod i rig I ess than F tons
per- acre per" year . Waste may be apt, I i ed to I and that i s er od i rig
at 5 or more tors, but I ess than 10 tons per acre per Year
priividirig gran; filter strips are installed where runoff Ieaves
ti[e f i e l d {See F0TG Standard 3,9:3 -F i I ter Str" i p
5. i idors can tie reduced by i reject i rig the waste or d i sk i rig after
Waste a p I I cat i ,in. Waste shoo l d not 'ie app l I ed whhen there i s
dan3er- of drift frc.ir. the irri3atir_,r, field.
_ . When animal waste i s to be app I i ed c,n acres subject to
f I c,C+,.-'[ i rig, i t w I i I be Sr, I I I nc .rc,,.,rated <_,r, C :,r!vc-r,t i o n a I i y t i 11 eIJ
crop+i a.ner, app I I ed to conservat I,,ri t i 1 1 ed cri-,iks
�r-ass I and, the waste may t e 0 +3s�C3S� �,'r",_,': I de - t1 - a�,�, i 1 Cat i _,r:
does not occur dur- i r.'3 d seas n �,r !ine t + f l iii1d i rtg . (See "meat -her'"
an,- C1 irr,ate in N G r t h C:arc,1 i n a for guidance.)
7. Liquid waste shal I be apt 1 i ed at rates not to exceed thhe si_, i
i rif i I tr-at I c,n rate such that runoff does not occur r,f fs i to c,r" to
surface waters and jr, a rnethc,d which does not Cause drift from
the site during apt, l i c at l on. -Nic, pored i ng Sh,jtr i d 4CCur in order"
tc, C12ntr",_, 1 c„acts- ,_hr f I i es.
Art i ma i waste siial i not tie aw, i : ed to saturated SO I s, dur i nq
r-al n f a I I events, r_,r 14heri file surface i s frc,n,.
'a. Animas Waste sha11 be app lfed 4n actively jr!,w3nCr=,pS In SUC%I
r
a manner that th,e Cr-aiF, i s nc.t c,.,vere,� w s };, waste to a der_+th ghat
wou I d i nh i b i t grow-:h . Th,I_ p ,tent i a 1 for sail- i t ,1jamage from an i rna;
Waste Shou I d a I sii bE? c ,rss I der -ell .
Paav- 7

WASTE UTILIZATION PLAN
F1FfF1F1F7FiF1F1FfFfP1F1FfFfFfFiF1F1P1PfF1F1F1FrPfFfP1F1P1F1FtF11rlFfFlFfFtFIFfPiF1F7MPfMF1F1FfPfPfPfFfFfAfF7MFfFfFTFiPfFfFyMFfl7Ff
REQUIRED SPECIFICATIONS
10. Waste nutr- i ents sisal 1, not 'LIP app I i ed i n fa I I cir" w i ricer- for
spr i ng p I a n t ed c r ciPs on su i I s w i th a h i gh poten'% I a. 1 fe_er"
I each i rig. Waste nutr i ent I ,_+ad i rig rates or, these SG i l s 5U i:,U 1 +:, t,e
iieId to a rninimurn and a suita.l+Ie winter cover crop pIanted to
ta'''Ke up r e I eased nuts i ents. Waste sisal I rrot be app l i ed rn,.er-e
than 00 days pr i or t p i an" i rig 4f the Cf-Or, Clt- f'=,rages break i no
+ ,.+rrnancy.
11 . Any n e W sw i ne f a c i I i ty s i t e d on or- after - I_:ctr,,t+er 1 , 1.`-,. F 5+`fa 1 1
comb, i y w i thi the f r+ I I ow i ng. The outer per i meter of th;e I and area.
+_+rrto wh i ch waste I s app I i ed frc,Tn a I agr, eri that s s a CoMF.C,r'ien't of
a swine farm shah be at lease 50 feet From any residential
property boundary and from any perennial strearn or river ( other
than an irrigation di tchr or- canal . Animal waste other than
5w i ne waste from f ac i I i t i es 5 i ted or, or after Cict+ht+er- 1 , 1995) ,
shall not be app I i ed c I _iser- tharr 5 feet to per-enn i al waters.
(See Standard :3';�7; -- F i l ter Strips).
12'. Animal waste sha I I not t+e app I i ed closer than 100 feet tt+
wells.
1:= . An i ma l Waste siia I I not be app 1 i ed c I user than '*42'00 feet of
dweII ings other than those awned by the landowner.
14. Waste sh;al I tie app l i ed In a manner- rir,t to reach other- property
and putt; i c right-of-ways.
15. Anima: waste shal', not tee discharged into surface waters,
dra i nageways, +hr wetlands by a, d i schar-ge or by +aver -spray+ ng.
Animal waste may be app l I ed to prior converted cropland provided,
they have been approved as a land aC+F+ I i c at i'r-rn site try a
"rtecl-irrical special ist". Animal waste shal I not- be appl ied or,
grassed waterways that discharges i1 i sect ly i nt,Dri water courses,
and on o"Chier grassed waterways, Waste Sha l I be app l i ed at
agr-+_+n imi c rates in a manner- that causes no runoff .+r' ?rift fr on-i
the site.
:i6- DC+rnest 3 c arid i n+:,ustr i a 1 14astP f r",hrn was:-`s, owt-i f a i 1 i t i es,
shr_,wers, to : I ets, s I nks, etc , sha. I I n 1t tie +j i sCharge1j i ntis th
an i ma; waste mana;3erner:t system.
17. A protect ive cover- crf appr-o1_+r- i ate vegetat i on wi I I be
es I 't I i shed on a i I d i sturt+ed areas ( I agoon embarile.- cents, 'Derms ,
pipe runs, etc.). Areas s h a I k,e fencers, as necessary, to
Protect the Vegetat+ =r;. Vegeta.t ior; suc`i as trees, shrubs, and
e_,$' '- W,-Crdy S�rK'cIes, etc , 3r-e ( imit'tf tt.r areas wher"w r.rj;wi ier-ed
apprcipr_ i ;3'te. Lagoon areas sh _ell1 d 'lee ',cep t mrr,,, ed art d a c c e s s Ib I e.
E:erns and stract-ures si:ou. d the inspected re9uiar y 'fair- evidence
cif eras i ceri, i ea1-.'.aae c+r i scharge.

WASTE UTILIZATION PLAN
MMMMPfAfPil'iPfAlAi1'irfPfMPfAiAirirfPiPiMPfPiriMPfMririrfMPfP7PfPfl'fPfPff 7PfPfPirfPlPfMMPf!'fPfPfPfPfPfPiMMPiMf'fPfPfPfMAf
REQUIRED SPECIFICATIONS
1 W. I f a i rna I pr-r_,uc t i ,y,n at the f a c i I i ty i s t,--, be susper„ 1e,,1 or
terra i nated, the is rest„_ ns i b l e for o'Clta in i n3 and
i mp I ernent i rig a "C osur e F1 I ar," wh i c h w i l l e I i rn i hate tt:e
puss I b i € i ty C,f an i I i e3a I d i scharge, pIo I I ut I on and eras I-,n.
1':!. Waste hand! ' r,3 structures, I P i ng r pumps, ree i s, etc . , sirc,u I d
izoe I nsC,eCte J a regular" bas i 5 to prevent leaks,
and sp i l 1 s. A r,=-iu I ar ma i n-ter,arrce C €-seCr-'.I I st 'De kept on
s I t e .
20. An i rna I waste Car, be used, I r, a t-c4tat'I !,r, tha-t i nc I ude5 vegetate I es
and other crops for" ,i I reCt human consurnpt i ort. However", I f
an i rnal waste i s used on crops for direct human consurn pt i on i t
Sf"rr_,ul d +]rr I y be app I i ed prep, l. ant w i th no further- arip I I cat! ons ,_,f
an imaI waste dur- i r:-,:; the crop seascln.
1. H i gh I y v i s i L1 I e rna,rr:er-s sha.I 1 ;,e i n s t a I I e11 t-, rna.rk: the t1 F. and
t,ott,-,m e € e v a t i on of the temp,r,rary stcot-a9e ( p,urnp i rr3 v,_, l urne) o f
all waste treatment I a3ocins. Purn p i ng shaI I be mana3ed t„
mair,tai rr tl"re I i quid I e v e I betweer, the markers. A roar k.-.er wi I I
tie requ i red to marl tile max i mum storage vc) I ume f or waste
storage por-rds.
Waste shai I be tester:, w i th i n t_•4) ,lays c,f ut i I i zat i on -arid s,_, i I
shall Lie testell at least annuai ly at crop sites wErer e waste
products are ar,r, i i e,1 . IV i t r 1.13en lira f € 1=1e tare rate - eterrn i n i r,
element. :� i r,c ar, 3 coil=ker I eve f 5 E n the 5c, 11 S Sha I I ,`,e V
m,_er, I t1=+Y"ed anda i terr,at i VE C'r G s I tes sha l l be LlSe,i ',J`iE n tiles
metal s approach excess ive I eve 1 s. pH shall be adjusted for
c,p,t i murn Crr_,p prodiiC t I on ar„ 1 rna i rl-ta i ne11 . So i l and waste
aria I ys i s records sha 1 1 be kept f,_,r- five years. F',_,u 1 try ,try
waste app, I i c at i on rec orris sera 1 l tie ma i rita i ned f or three ('-: )
years. Waste 3p, ,1 iC3;i,Jn records f1_,r" al I other waste sirall 11e
rnaintair,ed fc,r- five (5) years.
Z'D'. Deal] an i ma i s W . 1 € _ d i s „, e-1 5' i -t a m2Lnner tit at rneets "41ort,.
C.ar-o € i na requ,; a i :,r:s.

ANIMAL WASTE UTILIZATION PLAN
rr rr rr,"irrrrrrrr rrri rl r1 rrrrPr ^rr7M!' i r? rl rl r^1 r? ri ,^ r rrr� r7rr r�rrrrrrrrrrM r? rill? 1 y MPI PINK; 111 rr rr rrrirrl 7MPI PI PI r? Prr"rrl ri rrrrrrMAi
WASTE UT I L. I Z^T I 1 hi F='LFRICE-__MIF:
RTay,. 21/ Z400
Name of Farm:
Owner/Manager Agreement
I (we) understand cl.l'd win follow and implement the specifications
and the operation and maintenance proceoures estab l i shed in the
approved animal waste ut i I i zat i on plan for the farm named above. I
(we) know that any expansion to the existing des i ;fin capacity of the
waste treatment and storage system or construction of new
facilities will require a new cer-t i f i cation to be submitted to the
North Carolina Division of Environmental Management (NCDEM) before
the new animals are stocked. I (we) also understand that there
must use no discharge of animal waste from this system to surface
wasters of the state from a storm event less severe than the 25-
year-, 24-i-our storm. The approved plan will be filed on -site at
the farm office and at the office of the local Soil and Water
Conservation District and will be ava i i ab l e for review by NC:DEM
upon request.
Name of Facilit'f Owner: Henry Wa ker
(Please Rr ii rit) �L.(�7L ] a/�
, Signature: ___-- -- -_ Lj D a t e
Name of Manager (If different from owner):----
Signature: _-- Date:
Name of Person Prepar i ng P I an: (1"W"e priA)Fredr i ck Y. A I exander
Affiliation:NRCS Phone No. 336-751-5011
Address (Agency); Room 313 County Office Bldg. 180 S. Main St.
Mocksville NC 27423
Signature: �
Date:
1° EVrSro+J i I 2 d�
�yh"ly wy hynr by r_�1�.,::._rn. non.-..-1. h.. n.: ..: a: .. •___ ... ... ....: _....... .. ... ._ .. .. .. .. �..... ��. ..................,.__.. ... ... ... _..._.._... ._.�.

Landowner/Operator Name:
Address:
Telephone:
TABLE 1 - Field Specifications
IRRIGATION SYSTEM DESIGN PARAMETERS
Henry L. Walker
Coey Rd.
Macksville, NC 27028
County: nav ie
Date: January 21, 2000
FMMIT 1}t
•
Fieldl
Nwnber
Apprushnale
Maalmwn
Useable Size
of F1e1d2
(acres)
Soil Type
Slope
(%)
Crop(s)
Maslmum
Application
Rate
(Whr)
Maslmum
Application
per Irrigation
Cycle
(Inches)
Comments
1. 1
3.1
A B
2-8
Fescue Pasture
.4
1.0
1-2
3.2
ApB
2-8
Fescue Pasture
.4
1.0
1-3
2.2
CeB2
2-8
Fescue Pasture
.4
1.0
1-4
2.8
CeB2
2-8
Fescue Pasture
.4
1.0
ISee attached snap.
11'01al field acreage minus required butler areas.
3Refer to N. C. irrigation Guide, Field Office Technical Guide, Section 11 G. Amutal application must not exceed the agronomic rates for the soil and crop used.
NRCS, NC
NNE, 1996
10

•
•
October 1, 1999
1493 Godbey Rd.
Mocksville, NC 27028
Ms. Susan Cauley
NC Dept. Environment and Natural Resources
Division of Water Quality
1617 Mail Service Center
Raleigh, NC 27699--1617
Subject: Application No. AW000003
Henry Walker Farm
Davie County
Dear Ms. Cauley:
Please find attached the information requested in your letter of
September 1 regarding the permit application for my livestock
facility.
Attached is a response from Fred Alexander, MRCS District
Conservationist, concerning Items 1, 2, and 3 of your letter. I
have completed the checklists referenced in Items 4 and 5 and
they are also attached.
Please let me know if anything more is needed.
Sincerely,
,v
Henr Walker
Attachments
RECEIVED
VVATFQ ('d JAI i`,r iFr Tl1 jt j
'OCT 0 5 19c)
No?-siscbarcge Perm,i�5rc

UNITED STATES
DEPARTMENT OF
AGRICULTURE
OTURAL
RESOURCES
CONSERVATION
SERVICE
Mr. Henry L. Walker
1493 Godbey Road
Mocksville, NC 27028
Re: Animal Waste Operation
Application No. AWC300003
Dear Henry:
Davie CoArvation District
Room 313, Co. Office Bldg.
180 South Main Street
Mocksville, NC 27028
Phone: [phone]
September 28, 1999
l 0$ �y9J
No��;�har9� Ps
I am writing to provide additional information per request of Ms.
Susan Cauley, NC Division of Water Quality, concerning the
permitting of your livestock operation in Davie County.
I will address her concerns by number as she has them in her
letter of September 1, 1999 to you. They are as follows:
1. Plant Available Nitrogen Calculations — Ms. Cauley references
in her letter Table 6B from the NRCS Waste Utilization Standard,
showing the PAN rate as 33 pounds of nitrogen per head capacity
per year. I do not have such a table in the Practice Code 633
Waste Utilization Standard in my NRCS Field Office Technical
Guide, Section IV. The PAN rate of 27 pounds of nitrogen per -
head capacity per year that I used in the Waste Utilization
Plan(WUP) calculations came from the attached Table which was
supplied to me by NRCS Engineering Staff when the Waste Storage
Pond was being designed in 1996.
2. WUP yields higher than currently recommended — The yields
used in the plan are based on yields from the Davie County Soil
Survey, Table 5, which is attached. These were discussed by you
and me in the development of your plan, and you felt they
reflected the yields you had been realistically achieving. I am
not sure where Ms. Cauley is getting her information that these
are higher than currently recommended, because to my knowledge,
there is no list of yields that is mandated for use in developing
plans at the present time.
3. Irrigation parameters listed in the WUP exceed current
recommendations — The information listed on Exhibit D-1 of the
Irrigation Design Parameters does show a Maximum Application per
Irrigation Cycle of 1.6 inches. This was preliminary information
that I provided(from the NRCS Sprinkler Irrigation Guide) to Gra—
Mac Irrigation before the system was designed. However, during
the design by Gra—Mac rates were adjusted for animal waste, and
the maximum depth per irrigation cycle is specified to be .33
inches, as shown in Table 2 which they prepared. Therefore, the
design rate does not exceed one inch.

If you need assistce in filling out(checkin*he BMPs to be
used) the Insect Control, Odor Control, and Mortality Management
Checklists that Ms. Cauley mentions as Items 4 and 5 in her
letter, please let me know.
Please let me know if there are any questions. I will also be
glad to discuss these issues with Ms. Cauley if she desires, or
if more information is needed. If it is determined that the
Waste Utilization Plan needs revising to address any of these
items, also please let me know.
Sincerely,
44zC a*a.�
Fredrick Y. Alexander
District Conservationist
Attachments

I
Table Ef PAVED SURFACE SCRAPED MAMURE
FERT MUTRIEMTS
Type
Animal
Animl Live
Manure
_Total'-'`'
Plan! Plant : _ -
Total
Plant.Avait'.
of
Age
Height
Storage
!:`;Scraped
Nutrient nutrient Nutrients
,
` .I(ytr;may -.
production
CapaC i ty.'y.
` Manum ***
Ava €liability
` bre>dc
lit
................
.:'._.
Coefficients
-----------
snit final mean
ons/'
Its;
ft3/
h`:
braadcssc
has:
head
capaeICY/
'•�`
lbs/
U=/
ca pact : f
•
-----------------------------------------------------------------------------------------------------------------------------
months
------.tbs------
capacity
r::a;,`,v
year-
ten
tan
/yea-
Stocker
5 - 10
425 675 550
28
3.1
M .42
14
5.8
13
PZOS .70
9.3
6.5
d.
K2O .70
13
8.9
2?
Feeder
10 - 15
6010 1000 aOQ'
41
4.6
M .42
•14
5.8
27
P205 .70
9.3
?-
K20 .70
L -
grand caw
loco loco 1000
51
6.1
M .42
14
5.3
_
P205 .70
9.3
6.5
4C
K20 .70
13
8.9
5.
I
* References: Depts. of Biological and Agricultural Engineering. Wool. Science; Morth Carolina Stare University; Jan 1990
Agronmic Division. North Carat€na Department of Agriculture
^ 3-month accumulation of manure and bedding with liquid drainage.
Hamra collected within 1 week.
"^ "Broadcast: surface spread manure uncovered for 1 =nth or longer.
Table 7C. LAMD APPLICATION OF :BEEF PAYED Si1RFACE •SCUPEi] lfAIiURE •; a ' E f, y .`
.
Type Rate- Marva Application Rate':`' Min€mum
Land Area for,ilanure A licat€r
• Limiting --- ------ ---broadcast-- .
-- - broaarast ---
-
aduction Nutrient- --------- ------Ebs/acra/yeor --
+
- lbs/acre) ear- ---- -
�ni t M 50 io0 .150 = ZCO•"400 {,, s "5Q
300 150 2GOa ZSO _ y'3Q0 ' 350 .
4CC
PZOS 20 40 60 80 1Q0 120 160 ":. 20
40 ba 1Z0 i4Q
15C
K20 50 100 150 240 250 3Q0 - .350 460 50
100 '.150 _:ZaO=_-`Z50,;_,`:3Q0 350
4CC
----------------tars/acre/year---------
acres/head 'capacity ------------
Stocker M 8.6 17 26 =+ 43 51 60 6a .37
.la .12 .092 .-.073 ".061 .052
`20
.01.6
P205 3_1 6.2 9.2 12 15 18 22 25 1.0
.=1 .34 .25 .17 -15
.13
K20 5.6 11 17 23 28 34 39 45 .56
.a .19 .14 -.':11 .093 .080
.070
Feeder M 8.6 17 26 :y 43 51 60 68 .53
.27 .18 .13 .'.11 .o89 .076
.067
PZC5 3.1 6.2 9.2 12 .15 is 22 25 1.5
.7+ .49 .37 .30 .25 .21
.19
K20 5.6 11 17 23 28 34 39 45 .81
_4.1 .27 .20 .16 .14 -12
.1C
Brood cow M 8.6 17 26 34 43 51 60 68 .71 .36 .24 _18 .14 .12 .10 .085
PZOS 3.1 6.2 9.2 12 15 i3 22 25 2.0 _99 .66 .49 _40 .33 _Z3 Z5
KZQ 5.6 11 17 23 23 34 39 45 1.1 .?4 .36 .27 .22 .:3 .15 .ts --� References: oepts of 8ialogical 3 AgricjL...raL Engine+_rirsg. Sail Science, Crop sc --me; Nor:S Carolina St Univ; .;an 1994
*" 4 fertilization rate shouLd be cansistant .i:h realistic crap yield.
M leaching and denitrificatian and PZC5 safL ixunbiLization unacccunted for.
r S`-

Davie County, North Carolina
95
TABLE S.--LAND CAPABILzTY AND YIELDS PER ACRE OT CROPS Am PASTIIRS
(Yields are those that can be expected under a high level of management. Absence of a yield indicates that the
soil is not suited to the crop or the crop generally is not grown on the soil)
I I
Map symbol and I Land I
soil name Icapabilityl
I I
Corn
I I
I I
ICorn silage)
I I
I
I
Soybeans I
I
I
I
Tobacco I
I
Wheat
I
I
I Grass-
Ilegume hay
I
I
I Pasture
I
I
I
Bu
I Tons I
Bu I
I.bs I
Bu
I Tons
I AUM*
AaA------------- I
IIx 1
125
1 25 1
45 1
2,800 1
55
1 -'-.
! 11.5
Altavista I
I
I 1
I
I
I
I
ApB------------- I
IIe 1
95
1 19 1
30 1
2,500 1
45
1 4.6
1 6.0
Appling I
I
1
I
I I
I
I
!
I
I
I
ArA------------- I
Vlwr I
---
!
1 --- I
--- I
I
--- 1
---
I
I ---
I
I 6.0
Armenia I
I
I I
I
I
I
I
I
Bus ------------- I
I
w 1
---
I I
I --- !
I
--- I
I
--- !
---
I
i ---
I
I 3.0
Buncombe I
I
I r
I
1
I
I
I
CaB2------------ I
I
IIIe 1
115
I I
1 23 1
!
35 1
I
2,200 1
45
I
1 4.5
I
1 7.5
Cecil I
I
I I
I
I
1
I
I
I
I I
I
I
I
If
ChA------------- I
rw r
130
1 26 1
30 f
2,000 1
30
1 5.4
1 9.0
Chewracla I
I
I 1
I
I
I
I
I
EnB------------- I
I
IIIe r
110
I I
1 --- 1
I
30 I
I
--- I
40
I
1 5.1
I
1 8.5
Enon I
1
f 1
I
1
I
I
I
EnC------------- I
I
IVe 1
85
I I
1 17 1
I
25 }
I
--- I
---
1
I 4.8
I
1 9.0
Enon I
1
1 I
f
1
I
1
I
EaC-------------I
I
VIs
1 ---
I 1
I --- !
I
-'- I
I
--- I
---
I
f ---
r
I 4.5
Enon t
I
I I
I
I
I
I
I
can ------------- I
vie
1
I ---
I I
1 --- !
1
--- I
1
--- I
---
I
I ---
E
I 7.5
Gaston E
I
! I
I
I
I
I
1
GnB2------------ I
IIia
I
1 130
I I
1 25 1
35 1
I I
--' I
50
I
1 5.5
E
1 8.3
Gaston I
I
I 1
I
I
f
I
I
GnC2------------ I
IVe
I
1 115
I I
1 23 1
25 1
I f
--- 1
40
I
1 5.0
I
1 7.6
Gaston I
f
I I
I I
I
I
I
GrB-------------I
Its
I
1 75
I 1
1 --- 1
---
I I
f 2,000 1
35
1
I 4.6
I
1 6.0
Granville I
I
I I
I 1
I
I
I
IrB------------- 1
Iie
!
I 110
I I
1 22 1
--'
I I
1 --- I
30
I
1 3.6
1 8.0
Iredall
I
MaB-------------I
IIe
I
1 120
I I
1 24 1
35
I I
1 --- 1
45
I
I 4.8
1 8.5
Masada E
I
I I
I I
I
1
r
MdB------------- 1
IIe
I
1 95
I I
I --- I
30
I I
1 2,600 1
40
I
1 5.1
I
1 8.0
Mayodan I
r
I I
I I
1
1
I
I
MdC-------------I
IVa
I
1 75
I I
1 --- I
25
I I
! --- I
30
1 4.2
I
1 7.0
Mayodan I
I
I I
f I
I
I
I
I
Mdn-------------I
VI.
I
r ---
I I
I --- I
---
I I
I --- I
---
I -'-
!
1 6.0
Mayodan I
I
1 I
I I
I
I
MdE-------------I
VIIe
I
I ---
I I
I --- I
---
] I
I --- ]
---
I
I ---
1 6.0
Mayodan !
l
I
I
I I
r f
I I
I I
I
I
I
1
See footnote at
and of
table.

96 Soil Survey
TABLE S.--LAND CAPABILITY AND YIELDS PER ACRE OF CROPS AND PASTURE --Continued
I
Map symbol and I
I
Land I
I I
i I
I
I
I
I
I I
I, I
soil name Icapabilityl
Corn
!Corn silagel
Soybeans I
Tobacco I
Wheat
I -Grass- I
Pasture
I
I
I I
I
I
!legume hay I
I
I
Su
I Tons I
Bu I
Lbs I
T
Bu
I Tons I
AUM*
1
MnB2------------ I
1
IIIe 1
85
I !
! -^- 1
1
25 1
I
2,400 1
35
I
1 4.2 1
7.0
Mayodan
I
1 I
I
MnC2------------I
Iva 1
75
1 --` I
I
20 I
I
2,100 I
30
I i
1 3.6 1
6.0
Mayodan I
I
I
I
1 I
1 I
I
I
I
I
t 1
E
MrB2------------I
IIIe I
115
1 23 I
30 1
1,800 I
45
I
! 4.4 I
7.3
Mecklenburg I
I
I I
I
I
I I
I
MrC2------------k
f
Iva (
100
I I
I 20 I
I
--- I
I
--- !
35
I I
I --- I
6.5
Mecklenburg I
1
I f
E
!
! I
I
MsB-------------I
I
IIe 1
95
I I
I 19 1
1
25 1
I
--- 1
40
t E
I 3.6 1
6.0
Mocksville I
I
1 I
I
I
I I
I
MsC-------------k
I
Iva I
70
! I
1 --- 1
I
20 1
I
--- 1
35
I I
1 3.3 1
5.5
Mocksville 1
]
I I
!
1
I I
MsD------------- I
I
vile 1
---
I 1
I --- I
1
--- 1
I
--- I
---
I !
i --- 1
5.0
Mocksville
1
PaD--------------I
I
vile I
---
! I
I --- I
---
I I
I --- I
---
I I
I --- I
5.0
Pacolet I
I
I I
I I
I I
I
PcB2------------I
[
IIIe f
105
I I
1 21 1
30
l f
j 2,200 1
45
I I
1 3.9 I
6.5
Pacolet
PcC2------------1
IVe I
95
I 19 I
25
k 11900 k
35
I 3.6 k
6.0
Pacolet I
!
I I
I I
I I
i t
Pt --------------I
I
VIIIs---
{ I
I I
I I
Pits I
!
I !
! I
I I
RnC-------------!
I
IVe I
---
I 1
I --- I
---
f I
I --- I
__-
I f
1 --- I
4.0
Rion I
I
I I
I I
I I
i
RnD-------------i
I
vlle I
---
1 I
I --- I
---
I I
I --- I
---
I I
I --- I
3.0
Rion I
I
I I
t 1
1 I
I
RvA-------------I
I
IVw I
140
I E
I 28 1
40
f I
I 2,200 1
---
I 1
I 4.8 I
8.0
Riverview I
!
I I
I I
I I
!
RwA-------------I
I
IVw 1
100
t I
! IB 1
35
I I
I --- I
40
I I
1 2.5 !
8.0
Roanoke
I
I 1
1 1
I 1
!
SeB-------------I
I
IIe 1
100
I I
1 20 1
25
I I
1 --- I
---
1 I
! 3.3 I
5.5
Sedgefield 1
1
I
I
t I
1 I
I I
I I
! I
1 I
Ud--------------I
VIIIe !
---
I --- r
---
l --- I
--
I --- I
---
Udorthents
I I
I
Ur --------------I
I
VII13 !
---
I i
I --- I
---
I I
I --- I
---
I --- I
---
Urban land
!
WeB-------------I
I
IIe I
95
I 1
1 19 1
30
1 1
1 2,000 I
35
! f
! 3.6 1
6.0
Wedowee I
I
I I
I I
!
I
WeC-------------I
Iva I
85
1 17 I
---
I --- I
---
I 3.3;
I 5.5
Wedowee I
I
I
I
I I
I f
I
I
{
!
I
I
[
f
* Animal unit month: The amount of forage or feed required to feed one animal unit {one cow, one horse, one
mule, Live sheep, or five goats} for 30 days.

TABLE 2 - Traveling Irrigation Gun Settings Henry Walker Beef Operation, Davie Co. NC
Make, Model and Type of Equipment: Kifco E27A w/ 820 of IT" ID PE Tube, Nelson SR100 Gun w/ .8 Taper Nozzle
Field No`
and
Hydrant No
Travel
Speed
(ft/min)
Precip.
Rate
(intlir)
Application
Depth per
cycle,.,_
f4
Travel Lane
Effective Effective
Width Length
fi ft -
Wetted
Diameter
(feet)
EQUIPMENT SETTINGS
Nozzle Operating Operating; Arc
Diameter Pressure Pressure Pauem
inches Gun(psi) a Ree!(psi) degrees)
COMMENTS
1 -1
3.51
.33
7.33
208
644
295•
.8
70
106
300
1 3.1 acs.
1 -2
351
.33
33
208
675
:- -295
.8
70
106
300
3.2 acs.
1 -3
351
.33
.33
208
467 .. _ .
295 ...
.8
70
106
300
2.2 acs.
1 -4
351
.33
-.33
208
579
295:
8
70
106
300
2.8acs.
y
` See attached map provided by the Field Office for field locations(s).
2 Show separate entries for each hydrant location in each field.
IV
1h

Beef Farip Waste Management Odor Control Checklist
_ Source Catlse BA111's to Minlmixe Udoi- Slle Specific Practices
FaIIIIsICad • BrCf ptoduciion
Vegetative or wooded buflers
CK Recommended best ntanngemenl practices
l( Good judgutciit and common sense
1'avctl lots or Iron alley Wei manure -coveted sui'hices Cl Scrape or flush daily
snl1".1ces
'licdded ideas Uiiue
+ 1'nllial miclohial decomposition
14 1'rantole drying tutus proper Yeti lniion
Itotrthlc cheeks and nullnlcnancl* on wutcrcrs,
hydrants, pipes, stock tanks
I'romolc drying with proper ventilnllon
Replace wel or manure -covered bedding
Ahome dry stacks a hit lial nlicrubial decomposilimi x Provide liquld drnhinge lorstored nmmitc -- — - -
Swiage tmik ur basin a I'ailial microbial decomposition Ilnituut or mid -level loading
sill Ihce • Mixing while lining ; 1 ❑ 'tank covers
Agilalion when emltilying ❑ Basin surface mats of solids;
2t Mhurnlxe lot rtntoff and liquid addilions
❑ Agitate only prior to manure removnl
❑ Proven biological nddilivcs or oxidiuris
Sclrling basin Slit faces • I'-ulinl miciobial decomposition ❑ Liquid drainage from settled solids —
i
• Mixing while filling
❑
Rcinove solids regularly No 5GV1;0j boS 1 k5 u5e4
+_Agiladun when cniplying
hl;tlune, sliniy ur sludge
• Agilllliun when splcading
O
Soil injection of slurry/sludges
S111endel. outlets
. volatile gas cntissluns ,
CI
Wash residual manure from spreader atier use No,� i' C4� k"
❑
Proven biological nddilivcs or oxidmtls
Uncoveled manoic,
vaiiile gas emissions whiic
❑
Soil injection ofslurry/sludges-
slulq ur sludge un field
cltylug
❑
Soil ineorpormlon within 48 lirs
Sul I;Ices
A
Spread fit thin uniform layers for rapid drying;
❑
frovm biological additives or oxidants
ITItusll tanks---
Agilalion of recycled lagomi
Cl
Flush tank covers; ----_. -
liquid while ianks arc filling
❑
Extend fill lines to near bollom of tanks wills N/p -fit, Siv-.144 u t G�
anti -siphon vents
Uulside chain collecliun Agilaliun during wastcwaler I.,Box covers
orjuaclion boxes conveyance
Ate' - Nnvctubcr 11, 1996. Page I _

5nurcc Cause 061113 to Minimize Udur Site Specilic I'rnclices
Lill staliuns Agitation tluring sung, lank 0 Sump funk covers . I �a 1 .`,� S-Eo�-�+'�5 tlSq
filling and drawdown
Eml (if drahipipcs al
Agimllon dIn'!ng waslewalcr
A
Extend discharge point of pipes undcrncallt
laguun
conveyance
lagoon liquid level ,
Lagoon Sul faces
• volatile gals culission;
Proper Ingoou Ilyuid.capacity;
• Biological mixing;
l
Correct Ingoon startup procedures;
• Agitation
Minimum -surface area -to -volume ratio;
Mbthiutitt agitation when pumping;
17
Mecloll ical,nerallon;
O
Proven biological additives
hr iptiun sprinkler
•, I ligh pressure agilulion;
Irrigate al dry days wilt little or no ,,vied;
1rur,zlcs
Wind drill
Miltlmuiii lcconiniended operating procedure;
Pump intake Bear lagoon liquid surface;
O
Pump, from second -stage lagoon; -�--, j1/b �' & 1G
IA
Flush residitnt manure from pipes at end of
lud slurrylsge liumpings
Dead animals • carcass decumhositioln Proper disposition orcarcasses
Slsurding water around • Improper tl1 mange; Grndc and Inndscnlno sucll lint wafer drains
Ihcililics . Microbial dccomhosil#on of away front facilities
mg.anic matter /1", -
Mud luacked unlu public Poorly rrtainlained access roads Farm access road mainlenance
roads front liven access
Additional Itrfuunation : _ Available From :
Catile Manure Manngemew ; 02UO Ituic/111VI1' Packet NCSU, Cotmly Exlcnsiun Ccnlcr
Dairy Educiliunal Unil Manure Manngemcoil System - Lake Wheeler Rond Field Laboratory; EBAC 209-95 NCSU - BA1:
Lagoon Design and Mnungemcnt fur lAyestock Manure'1•rcalment and Storage ; EBAC 103-83 NCSU - BAIs
hVinngemcril of Dairy Wnslctivalcr ; I- DAr, 106-83 NCSU - BAE
Calil,tatiun of Manure and Wastewater Application Equipment ; FBAC Fact Sheet NCSU - 11Ati
Nuisance Concerns in Animal Manure Mmagemenl: Odors and Flies ; PRO107, 1995 Conference Proceedings Florida Cooperative Extension
n AIr,i• r1...•.. 0'.1 1 11 1QW, Maui• )

Insect Control Checklist for Animal Operations
Saul cc Cause BAIPS to Contl•ol insects Silc Specific VI nOICTS
1:1ush iIullels 0 Accurnulaliun ursulids
iRI
Flush syslem Is designed and opernied
sufficicutly to remove accumulnied solids irons
gutters as designed.
Remove bridging of nccuutulnied solids nt
Lagnvus arld Piis iiu•sicri Sul;ils Mali Hit In lagoons, scilling basins and pits where
Elccssive Vcgclalive
Glum I
Fccdcts
f ccd 5tm age
pest breeding is apparent to minimlya lho
crusting orsullds .to a depth oroo mule than G -
8 hrches over morn than 3o% orsurrncc.
Dectlying vcgclutiurl Mninlalo vegotnlivo conlrol slung banks of
Ingoons and other hnpoundinents to prevent
accumulation ordecaying vegetative maller
nlollg walces edge oil irnpollndnrcnt's perimeter.
[ Y c-� aly{ 1 " 6 G
I -Ceti Spillage Design, olmralo and malulnin reed systems (c.g.,
bunkers and troughs) to minimize Ilia
accurnulallon or#caying wostnge.
11 Clean lip sppllagc onra roullne basis (e.g., 7 - 10
day hilervaI,during'suinhier; 15.30 day Irticrvnl
Juringwinte�rriir�•rxr�tr�• , __ - ---. -. �... _ . .
Accunul wimm of Iccd icsiducs Reduce molsturo accumulation wltbhl and
nrottnd immodinic imartreior or read storago
arcns by Instiring'dralnuge owny from silo
and/or providing adequate coulahiment (e.g.,
covered bill •,for-bmwer's grain and similar Itigh
moisture grain products).
0 lirspecl for and reiuove or break tip aecumulaled x� 1
solids In llllcr'strips around reed slorngo as r, I ° I (¢/Yp It '� j e
rlCCdcd.•;.,.•�n ltr!rytf; ; � !
1r�r+r' ; irnr r
C.
AAIIC - November 11, 1996, Page I

_5uulcc callse
ISMI's to Cuulrut Insects Sk Specilic Prslrlicrs
Aniurll I iuldhig Aicas • Accmindalions ul'Nilnnll wasics ❑
Elinfinntc low area Ilinl trap moisture niung
;lull Iced %vuslugc
fcuces and other locations where waste
nccullmlaics and disturbance by nnlntnls is
minimal.
Malulaln fence rows and filler alrips around
animal hulding arras to minimin
nccumulationrs of wastes (i.e., insixct for nml
rcmovc or brcnk up accwnulaled solids as
needed).
Oly Mallnlc I k1111114% AcC1111II11i111ons 11l elnlmal Wastes ❑
Itculove spllingo un n rouline hnsis (e.g., 7 - IU
Syf1e11Is
day Intervni during summer; 15.30 day Intel vul
during whiter) where ntnnurc Is lundgd for hall
ripplicntlun or dlslmsnl.
El
11tovida for adequalo drainage around mamne
alvckltllc�: � � '
❑ :
lnsInct for and rcmovc or break up accunullnicd
rvnstcs in filler strips around stocklrilcs and
mature handflug areas as needed.
I"ur 111111c iUI111111a1iull C1111110 fill: coollelative Exic11Slull Service, Uelmoment of untumoiugy, !lox 7613, Noich CIlu-olim Slate Univeisily,
Ralcigh, NC, 27695-7613.

• 1
Mortality Mana;ement Methods
(check which methods) are bein,, implementedl
Burial three feet beneath the surface of the around within 24 hours after
knowledge of the death. The burial must, be at least 300 feet from any flowing
stream or public body of water.
Rendering at a renderin? plant Iicensed under G.S. 106-163.7
Complete incineration
�1 In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Deparunent of Agriculture
v Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health, (Written approval of the State Veterinarian must be
attached)
Dc�e:ncC:• [S. 1996

t
An&i Waste Management Plan 4ification
(Ptease tvoe or print ail information dhat does nex reuutce a siin.uur(:►
or: lei► ...> ar - : E.panded " ='(please circle. one)
General Information:
Name of Farm:_ f4enry L. K/olker _ Facility No:
Owner(s) Name: f4r_#1t'U L,, Walker' Phone No: 336-49a�s5S�
Mailin a address: 1453 D 5 V, lle_� N C a 70a S
Farm Location: Count; Fain is located in: Oa UrG
Latitude and Longitude: 35° 53` 45" I 90° ;L'` Ste" Integrator:--N%4 - ----
Please attach a copy of a county road map with location identified and describe below (Be specific: road
names. directions. milepost. etc.): LOca�ed on SR 1 /S0 C&6c Ied. a ro abet'
T
3.5rrt !c wes-F c7F C'eh ��-- �o�0564 yeSf /'us4 j'
Operation Description:
Type of s+vine No. of Aizirnals
D Wean to Feeder
* Feeder to Finish
* Farrow to Wean
.7 Farrow to Feeder
•_t Farrow to Finish
Zi Gilts
Boars
Type of Po+ilfrz - eVo: of�kn?iRals' Type of Carrie
.3 Laver :3 Dairy
Z Pullets gBeef
, o. of Anima Is
Ocher Type of Livesrocz: Munher of Animals:
Acreage Available for Application:, , �`� • S Required Acreage: 21 - 0
Number of Lageem / Storage Ponds : Total Capacity: 2`1, (, 2;�_ Cubic Feet (f 3)
Are subsurface drains present on the farm: YES or Q (please circle one)
If YES: axe subsurface drains present in the area of the LAGOON or SPRAY FIELD (please circle one)
300
Owner / Manager Agreement
I (we) verifv that all the above information is cored : id. :will be updated upon changing. I (we) understand the operation
and maintenance procedures established in the approved animal waste management plan for the farm nanted above and %will
implement these procedures. I (we) know that any expansion to the exist.inc design capacity of the waste treatment and
storage system or construction of new facilities will require a new certification to be submitted to the Division or
Envirunrnentai Management before the new animals are stocked. I (we) understand that there must be no discharse of
animal waste from the storage or appiication .ivstem to surface waters of the state eidier directly through a mail -made
conveyance or from a storm event less severe than the 25-year. 24-hour storm and there must not be run-off from the
application of animal waste. I (we) understand that run-off of pollutants from lounging and heavy use areas must be
minimized using technical standards developed by the Natural Resources Conservation Ser•:ice. The approved plan will be
tiled at the farm and at the office of the local Soil and Water Conservation District I (we) know that any modification
must be approved by a technical specialist and submitted to the Soil and Water Conservation District prior to
implementation. a chance in land ownership requires written notification to DEM or a newcertification (if the approved
plan is chanced) within 60 days o'ffa title transfer.
Name of Land Owner: en r L WQI,�er
Signature: Z Dater
came of Nlanager(if di ifere;tt from O%Vner): awry
Signature: Date:
AIVC -- August 1. 1997

*Chnica.1 Specialist Cert4ation
I. As a technical specialist designated by the North Carolina Soil and Water Conservation Commission pursuant to I5A
NCAC 6F .0005. I certify that the animal waste management system for the farm named above has an animal waste
management plan that meets or exceeds standards and specifications of the Division of EnvironntenW Manasetnent
(DEMO as specified in 15A NCAC 2H.0317 and the USDA -Natural Resourc:s Conservation Service (NRCS) an&r the
North Carolina Soil and Water Conservation Commission pursuant to 15A iti'CAC 2H.0217 and 15A NCAC 6F .0001-
.0005. The following elements are included in the plan as applicable. While each category designates a technical specialist
who may sign each certification (SD. SI, WL-P, RC. I), the technical specialist should only ce:tify parts for which they are
technically competent.
II. Certification of Design
A) Collection. Storage. Treatment Svstem
Check the appropriare box
.J Existing facility without retrofit (SD or WUP)
Storage volume is adequate for operation capacity: storage capability consistent with waste utilization
requirements.
l New. exCanded or retrofitted facility (SD) -
animal waste storage and -treatment structures_ such as but not limited to collection systems. lagoons and ponds.
have been designed to meet or exceed the minimum standards and specifications.
Name of Technical Specialist (Please Print): >�reCirrG� K Alernde�r
Affiliation Lt SOA - N2C6 Date Work Completed: �5-` 9
oon� 3 r3
Address (Agency): o276z�f Phone No.:
Signature: Date: - 2 - 5r
B) Land Anolication Site (WUP)
The plan provides for minimum separations (buffers): adequate amount of land for waste utilization; chosen crop is
suitable for waste management: hydraulic and nutrient loading rates.
Name of Technical Specialist (Please Print):_ �rnLLk �• /_AL-K
AffiliationUSDA -NHS Date Work Completed:
Address (Agency):K6aa1 Ig-o sto Mafir ° " � ds9�. Al—:z7af Phone No.: 33�-751--5:21
Signature: Date: 9- Z 8
C) Runoff Controls from Exterior Lots_
Check the appropriate box
=t Facility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
t Facility with exterior lots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas have been designed in
accordance with technical standards developed by NRCS.
Name of Technical Specialist (Please Print): F_reelriC, K A �PKGx�r�
a.ttiliati
Address
Stl2nalur
Work- Completed: S-
�2-7MPlione No.: 3 3 1 - 7S/-So
Date: _9-2� 9F

D). Apolication and Hades Equipment
Chec.t the appropriate box
•
ZI E.-is(ins or tfuanding facility With existing waste j;!Q[icatinn equipment (wU;P or I)
,animal waste application equipment specified in the plan has been either field calibrated or evaluated in
accordance with existing design charts and tables and is able to apply waste as necessary to accommodate the
waste management plan: (existing application equipment can cover the area required by the plan at rates not to
exceed either the specified hydraulic or nutrient loading rates. a schedule for timing of applications has been
established: required buffers can be maintained and calibration and adjusment guidance are c.=� fined as part of
the plan).
$� New. expanded, or existing facility wi0out exi;rin; `.Waste application equirment il.r ;Qrav irri=tcion. (I)
Animal waste application equipment specified in the plan has been designed to appiv waste as necessary to
accommodate the waste management plan: (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hv_ draulic or nutrient loading rates: a schedule for timing of
applications has been established: required buffers can be maintained: caiibruiun and adiustmenc guidance are
cuntained as part of die plan).
New, expanded, or existing fac lily_ withour ex656wz w ate anolic,,idon_eauipntent For land spreading not �1sinU
seem. irrigation. (WUP or I)
Aninial waste application equipment specified in die plan has been selected to apply waste as necessary to
accommodate the waste management plan: (proposed application" -equipment can cover the' area required by the --
plan at rates not to exceed either the specified hvdraulic or nutrient loading rates; a schedule for timing of
applications has been established: required buffers can be maintained: calibrarion and adjustment guidance are
-,contained as part of the plan).
itiarne,of Technical Specialist (Please Print): o V c
Affiliation 6x,6 - rYl�� d� ,s4 4�� Dace Work Completed:_ -1 7- 98
Address (Agency):0310 Nc 4i ru. ,(Y)neL-St"11 honeNo.: 33(,-959-3.�
Signature: Dace: - 36
E) Odor Controi. Insect Control. _'Mortality iManaQement_and Emeaencv Action Plan (SD
SI. WUP. RC or I)
The waste management plan for this facility includes a Waste Management Odor Control Checklist. an Insect
Control Checklist, a Mortality Management Checklist and an Emergency action Plan. Sources of both odors and
insects have been evaluated with respect to this site and Best Management Practices to Minimize Odors and Best
itianagemenc Practices to Control Insects have been selected and included in the waste management plan. Both the
"lormlity Management Plan and the Emergency Action Plan are compiete and can be implemented by this facility.
Name of Technical Specialist (Please Prin€):
Affiliation UTVA- NgjcS Date Wore Completed:
3 (3 vn h� c3� ;
Address (Agency):
Si<`nature:
F) Written Notice of Netiv or Ecoandin, Swine Farm
x a PPhone No.:_
Date:
The FolIoming signature block is only to be used far new or expanding swine Farms tltn[ begin torts after June
'_I. 1996. If the facility was built before June 21. 1996, when was it constructed or last
expanded
I (we) certify that I (we) have attempted to contact by certified mail all a ng property owners and ail property owners
who own propemr located across a public road. scree,_ or highw m this ne�.v or e-aandine swine farm. The notice was
in compliance with the requirements of XCGS 106-305 opy of the notice and a list of the property owners notified is
attached.
Marne of Land Owner:
Si,,nature:
dame o anager (if differ.—ni from owre ):
Si_nature:
Date:
Date:
_ WC -- august 1. 1997

•
•
III. Certification of Installation
A) Collection, Storage. Treatment Installation
New. expanded or retrofitted facility (SI)
Animal waste storage and treatment structures. such as but not limited to lagoons and ponds. have been installed
in accordance with the approved plan to meet or exceed the minimum standards and specifications.
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print): FiYdr,'t k V. Al
Affiliation th5b 4- N U S Date Work Completed:
Address (Agency): 3!3 ux s o ! 9,' n.1G a7 S Phone No.: 336- 75(- 5011
Signature: Date: 9:2L7 =9?._.
B) Land Application Site (WLiP)
check -the appropritue box
The cropping system is in place on all land as specified in the animal waste management plan.
.J Conditional Approval: all required land as specified in the plan is cleared for plandnd:-the cropping system
as specified in the waste utilization plan has not been established and the owner has committed to establish the . .
vegetation as specified in the plan by (momh1day/year); the proposed corer crop is
appropriate for compliance with the wasteutilization plan.
Q Also check this box if appropriate
if the cropping system as specified in the plan can not be established on newly cleared land within 30,days- :
of this certification, the owner has committed to establish an interim crop for erosion control:
Name of Technical Specialist (Please Print): dri
Affiliation 0564 —Alee-C Date Work Completed:_
Address (Ace cy): �'v sa n�. I" .C:LO.A 2rl 7 � Phone No.: 336-?S/-Sat!
Signature: Dace:
This following signature block is only to be used when the box for conditional approval in M. B
above has been checked.
I (we) certifv that I (we) have committed to establish the cropping system as specified in my (our a udiization plan.
and if appropriate to establish the interim crop for erosion control. and will submit to DE --erification of completion
from a Technical Specialist within 15 calendar clays following the hate specified ' e conditional certification. I (%-e)
realize that failure to submit this verification is a violation of the waste Bement plan and will subject me (us) to an
enforcement action from DEM.
Name of Land Owner:
Signature:
Name of v
(if different from owner):
Date:
Signature: Date:
AW.0 august 1. 1997 .4

C) Runoff Controls fro4oxterior Lots (RC)I*
Facility with exterior lou
:Nlt:thuds to minimize the run off of pollutants from lounging and heavy use :ueas have been in. Lifted as so{cif
ill the plan. t
For facilities without exterior lots, no certif-ication is necessary.
Name of Technical Specialist (Please Print): Fr-fdrtck Y A Le, twat r
Affiliation 5 -NO-r-S Date Work Comoleted:
Address (:
Signature:
Phone No.: 336- 7S_ -- Ell/
Date: 1 9;-
D) Apolication and Handling Eauioment Installation (WC:P or I)
Check the appropriate block
Animal waste application and handling equipment specified in the plan is o:,. site and ready for use:
calibration and adjustment materials have been provided to the owners and are contained as part of the plan.
Animal waste application and handling equipment specified in the plan liar not been installed but tine owner
has proposed leasing or third party application and has provided a signed contract: equipment specified in
the contract agrees with the requirements of the plan:--required-buffers-can be maintained-, calibradun-and
adjustment guidance have lien provided to the owners and are contained as part of the plan.
J Conditional approval: Animal waste application and handling equipment specified in the plan has
4 - been purchased and will be on site and installed by (month/day/vear); there is adequate
storage to'hold the waste until the equipment is installed and until the waste can be land applied in
accordance with the cropping system contained in the plan; and calibration and adjustment guidance have
been provided to the owners and are contained as part of the plan.
Name of Technical Specialist (Please Print): ENtgoiCL. .. t.v !
Affiliadonf,QA,= Mn_c;-1b, 1,_A�I 4 __ _ _Date Work Completed: 9--JS-9S. .
Address (Agent a311) NC A.- r-o1 ,u, ; xr c-�s u, Ile- r A]C phone IN, o.: 33il, -9fJ! j-23 z
Signature:
Date: 9-315-98'
The following signature block is only to be used when the box for conditional approval in 11
above has been checked.
I {we) certify that I (we) have committed to purchase the animal waste ap n and handling equipment 35
specified in my (our) waste management plan and will submit to D verification of delivery and installation
from a Technical Specialist within IS calendar da}'s follow' _ e date specified in the conditional certification. I
(we) realize that Failure to submit this vellric:ition ' lolation of the waste management plan and will subject me
(us) to an enforcement action from DEyi
Name of Land Owner:
Signature: Date:
tiame anager (if di.fterent froth owner):
fgnatu ee: Date:
E) Odor Control. insect Control and Mortality llana!jement (SD. SI. WUP. RC or I)
Methods to control odors and insects as specified in the Plan have been installed and are operational- Toe
mortality management system as specified in the Plan has also been installed and is operational.
Name of Technical Specialist (Please Print), FiP_d,-'G V Aie L",
Affiliation l 50A - AJe.G5 Date Won.- Comole:4d: 9' ge
v �i c� [3(elf 33. �51-5d!
Address (Agency): 76?Fr !lone No.: )tcs�.0 a ki•
Signature: Date:
% C -- August 1. 1997

Che Irrigation Association
33�IF6� �--�
sprinkler / Valve key
OTraveler Location on 4" Aluminum Pipe
Water SupplW
Gra—Mac Distributing Co.
2310 NC Hwy. 801 N
Mocksville, NC 27028
Phone [phone]
Fax [phone]
Designed by: Ronnie Wall
Date: 8---17-98
Design No.

Henry Walker
Henry Walker
1493 Godbey Road
Mocksviile, NC 27028
338--492--5556
Pipe key
4" RaanwaU Rang Lock Akxmux.m Pipe
Sprinkler / Valve key
QTraveler Locai ion on 4" A kimuxan Pape
Water Supp 11
Gra—Mac Distributing Co.
2310 NC Hwy. 801 N
Mocksville, NC 27028
Phone [phone]
Fax [phone]
Designed by:
Date:
• Scale: 1" — 160'
Ronnie Wall
8--17-98
I Design No. 83