310271_HISTORICAL_20171231

NUHIHCAROLINA
Department of Environmental Qua

A W- 31 b 2'1
Murphy -Brown, LLC 10/28/2002 P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s):
Farm Name:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Storage Period:
Application Method:
Don LaCoe
CJK 4- k Jl1 `AQN S
>180 days
Irrigation
�C�jvE
c> OR
142009
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but.
less than 10 tons per acre per year providing that adequate filter strips are established
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste shouldbe applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
RECEIVED / DENR / DWQ
AQUIFER PPnTF( TInKI CFCTIQN
1 of 8 APR 01
2009
r.

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have. plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be Flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, A tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 gal/yr
gal/yr
Farrow to Feeder
4015 gal/yr
gal/yr
Farrow to Finish
10585 gal/yr
gal/yr
Wean to Feeder
223 gal/yr
gal/yr
4600
Feeder to Finish
986 gal/yr
4,535,600 gal/ r
Total 4,535,600 gall r
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 Ibs/yr
Ibs/yr
Farrow to Feeder
6.5 Ibs/yr
Ibs/yr
Farrow to Finish
26 Ibs/yr
Ibs/yr
Wean to Feeder
0.48 Ibs/yr
Ibs/yr
4600
Feeder to Finish
2.3 Ibs/ r
10,580 Ibs/ r
Total 10,580 Ibs/ r
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 45.2
Total N Required 1st Year: 12420
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops 12,420.00
Total Nitrogen Produced by Farm 10,580.00
Nitrogen Balance for Crops: (1,840.00)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

Reception Area Specifications
m©m��o�mmm
�ommmmoo
��
m
m©®��o�mmmm�omm�moom
ma®��o�®om®®ommmmoo®®
m©®��o�m0mm�ommmmoom
Imom�o�®mmm�ommmmoom
mmm�o�®omm�ommmmoomm
mom�o�mmmm®ommmmoom®
mmo�a�o�mmmm
,:,
ommmmoom
,:,
mo®��o�mmmm�ommmmoam�
moo��o�m0mm
,:,
ommmmoom
,:,
mm®�tito�®mm®�ommmmoo®�
mm®��o�®om_®�ommmmoo®�_
3(a) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 Ibs N / bushel
B
Hybrid Bermudagrass - Grazed
50 Ibs N / ton
C
Hybrid Bermudagrass - Hay
50 Ibs N / ton
D
Corn - Grain
1.25 Ibs N / bushel
E
Corn - Silage
12 Ibs N / ton
F
Cotton
0.12 Ibs N / Ibs lint
G
Fescue - Grazed
50 Ibs N / ton
H
Fescue- Hay
50 Ibs N / ton
I
Oats
1.3 Ibs N / bushel
J
Rye
2.4 Ibs N / bushel
K
Small Grain - Grazed
50 Ibs N / acre
L
Small Grain - Hay
50 Ibs N / acre
M
Grain Sorghum
2.5lbs N / cwt
N
Wheat
2.4 Ibs N / bushel
O
Soybean
4.0 Ibs N / bushel
P
Pine Trees.
40 Ibs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications
PAN/ r/animal Farm Total/ r
Farrow to Wean
0.84
Farrow to Feeder
1
Farrow to Finish
4.1
Wean to Feeder
0.072
4600 Feeder to Finish
0.36 1656
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 1656 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 8280 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 27 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 66.24 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil Application Rate Application Amount
Tract Hvdrant Tvoe Cron in/hr ' inches
2238
2
Marvyn
C
0.65
2238
3
Orangeburc
B
0.5
2238
4
Marvyn
B
0.65
2238
5
Orangeburc
B
0.5
2238
6
Norfolk
B
0.5
2238
7A
Norfolk
B
0.5
#REF!
7
Norfolk
C
0.5
2238
8A
Orangeburc
B
0.5
2238
8
Orangeburc
B
0.5
2238
9
Orangeburc
B
0.5
2238
10
Marvyn
B
0.65
2238
11
Marvyn
B
0.65
6 of 8

Additional Comments:
` A small grain overseed may be planted on any field specified in thi this plan
for winter oumoino.
Nitrogen may be applied to the small grain at a rate of 50 lbs. per acre.
Follow the application anounts and rates specified on page 6 of this plan
for the small grain crop.
7 of 8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: CJK
Owner: Don LaCoe
Manager:
Owner/Manager Agreement:
/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature:
Don LaCoe
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist: Dawn Williamson
Affiliation: Murphy -Brown, LLC.
Address:
Telephone:
Signature:
_z8 dZ
Date
la-ZS-0z-
8of8

Z� --I
rt Y
Don Lacoe
CJK Farms and K&M Farms
194 Buncombe Ln
Mount Olive, NC 28365
Dear Don Lacoe:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleco H. Sullins, Director
Division of Water Quality
July 1, 2007 '_ , ` F,IVED
JUN 2 6 Z007
Y:
Subject: Certificate of Coverage No. AWS310271
CJK Farms and K&M Farms
Animal Waste Management System
Duplin County
In accordance with your application received on 18-Jan-07, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Don Lacoe, authorizing the operation of the subject animal waste
management system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the CJK Farms and K&M Farms, located in Duplin County, with an animal capacity
of no greater than the following swine annual averages:
Wean to Finish: 0 Feeder to Finish: 4600 Boar/Stud: 0
Wean to Feeder: 0 Farrow to Wean: 0 Gilts: 0
Farrow to Finish: 0 Farrow to Feeder: 0
If this is a Farrow to Wean or Farrow to Feeder operation, there may also' be one boar for each 15 sows.
Where boars are unneccessary, they may be replaced by an equivalent number of sows. Any of the sows
may be replaced by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009 and replaces the NPDES
COC issued to this facility with an expiration date of July 1, 2007. You are required to continue
conducting annual surveys of sludge accumulation in all lagoons at your facility; the one-year extension
in Condition Hl.19 does not apply.
Pursuant to this COC, you are authorized and required to operate the system in conformity with the
conditions and limitations as specified in the General Permit, the facility's CAWMP, and this COC. An
adequate system for collecting and maintaining the required monitoring data and operational information
must be established for this facility. Any increase in waste production greater than the certified design
capacity or increase in number of animals authorized by this COC (as provided above) will require a
modification to the CAWMP and this COC and must be completed prior to actual increase in either
wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Enclosed for your convenience is
a package containing the new and revised forms used, for record keeping and reporting. Please pav
careful attention to the record keeping and monitoring conditions in this permit.
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636
Internet: www.newatergmlity.org Location: 2728 Capital Boulevard Raleigh, NC 27604
An Equal Opportunity/Affirmative Action Employer— 50% Recycledl1096 Post Consumer Paper
Telephone:
Fax 1:
Fax 2:
Customer Service:
N%ltCarolina
Naturally
[phone]
[phone]
[phone]
[phone]

If your Waste Utilization Plan has been developed based on site -specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 02T .0111(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Per 15A NCAC 02T .1306, any containment basin, such as a lagoon or waste storage structure, shall
continue to be subject to the conditions and requirements of the facility's permit until closed to NRCS
standards and the permit is rescinded by the Division.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Aquifer Protection staff may be reached at 910-395-3900. If you need additional information concerning
this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at (919) 733-
3221.
Sincerely,
for Coleen H. Sullins
Enclosures (General Permit AWG100000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Duplin County Soil and Water Conservation District
Wilmington Regional Office, Aquifer Protection Section
AFO Unit Central Files
Permit File AWS310271

a
► Wi Co Aps
Murphy -Brown, LLC 10/28/2002 P.O. Box 856
Warsaw, NC.28398
Grower(s):
Farm Name:
NUTRIENT UTILIZATION PLAN
Don LaCoe
CJK
I - arrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish 4f3nn
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
PREV
D
ION 1 9 20
,V 07
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, 1} tons, etc.):
Capacity T e Waste Produced per Animal Total
Farrow to Wean
3212 gallyr
gal/yr
Farrow to Feeder
4015 gal/yr
gal/yr
. Farrow to Finish
10585 gallyr
gal/yr
Wean to Feeder
223 gal/yr
gallyr
4600
Feeder to Finish
986 al/yr
4,535,600 al/ r
Total 4,535,600 gal/ r
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs
Capacitv Tvoe Nitro en Produced perAnimal Total
to Wean
5.4 Ibs/yr
Ibs/yr
o Feeder
6.5 Ibs/yr
Ibs/yr
FF2rrow
to Finish
26 Ibs/yr
Ibs/yr
o Feeder
0.48 Ibs/yr
Ibs/yr
4600to
Finish
2.3 Ibs/yr
10,580 Ibs/yr
Total 10,580 Ibs/ r
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARN
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 45.2
Total N Required 1st Year: 12420
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops 12,420.00
Total Nitrogen Produced by Farm 10,580.00
Nitrogen Balance for Crops: (1,840.00)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

m©m��o�mmm
��
�ommmmoo
„
mt,
ma®�a�o�m0mm�ommmmoom
mt
ma®��o�mmmm�ommmmoom
mom�o�®0mm�ommmmoom
mmm�o�®omm�ommmmoom
�
mom�o�mmmm
®ommmmoom
mm®�ao�®mm®�om�m�oo®mt
3(a) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Corn - Grain
E Corn - Silage
F Cotton
G Fescue- Grazed
H Fescue - Hay
I
Oats
J
Rye
K
Small Grain - Grazed
L
Small Grain - Hay
M
Grain Sorghum
N
Wheat
O
Soybean
P
Pine Trees
Lbs N utilized / unit yield
1.6 Ibs N ! bushel
50 Ibs N / ton
50 Ibs N / ton
125 Ibs N / bushel
12 Ibs N / ton
0.12 Ibs N / Ibs lint
50 Ibs N / ton
50 Ibs N / ton
1.3 Ibs N / bushel
2.4 Ibs N / bushel
50 Ibs N / acre
50 Ibs N / acre
2.5 Ibs N / cwt
2.4 Ibs N / bushel
4.0 Ibs N / bushel
40 Ibs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications
PAN/ r/animal Farm Total/ r
Farrow to Wean
0.84
Farrow to Feeder
1
Farrow to Finish
4.1
Wean to Feeder
0.072
4600 Feeder to Finish
0.36 1656
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 1656 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 8280 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 27 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 66.24 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
'This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Tract
Hydrant
Soil
Type
Crop
Application Rate
inlhr
Application Amount
*inches
2238
1
Orangeburc
C
0.5
1
2238
2
Marvyn
C
0.65
1
2238
3
Orangeburc
B
0.5
1
2238
4
Marvyn
B
0.65
1
2238
5
Orangeburc
B
0.5
1
2238
6
Norfolk
B
0.5
1
2238
7A
Norfolk
B
0.5
1
#REF!
7
Norfolk
C
0.5
1
2238
8A
Orangeburc
B
0.5
1
2238
8
Orangeburc
B
0.5
1
2238
9
Orangeburc
B
0.5
1
2238
10
Marvyn
B
0.65
1
2238
11
Marvyn
B
0.65
1
6of8

Additional Comments:
A small grain overseed may be planted on any field specified in thi this plan
for winter pumping.
Nitrogen may be applied to the small grain at a rate of 50 lbs. per acre.
Follow the application anounts and rates specified on page 6 of this plan
for the small grain crop.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: CJK
Owner: Don LaCoe
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature:
Don LaCoe
Name of Manager (if different from owner):
Signature:
Date
Name of Technical Specialist: Dawn Williamson
Affiliation: Murphy -Brown, LLC.
Address: 2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
t
Signature:
Date
8 of 8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies-
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

Phosphorus Loss Assessment Tool Completion
Name of
Owner(s)
Mailing
Check the appropriate box below, and sign at the bottom:
63 No fields received a high or very high rating.
❑ Yes, the fields listed below received a high or very high rating:
E�'�:I-'TT4"�
OCT 0 4 LVYJ
BY:_�_
Facility Number:&L-_f ,
Field Number Size (Acres) Rating (High or Very High)
Please use as many additional attachment forms (PLAT-A-10-31-03) as needed for additional fields.
(05
By completing the above, section and any additional attachments and by signing this form, the facility
owner and Technical Specialist acknowledge all application fields were evaluated using the Phosphorus
Loss Assessment Tool. All necessary calculations were completed to conduct the Assessment. A copy will
be kept on site with the Certified Animal Waste Management Plan. Any future modifications must be
approved by a technical specialist and filed with the Soil and Water Conservation District prior to
implementation. Waste plans with fields having a high or very high rating will have to be modified to
address phosphorus loss by the next permit cycle beginning July, 2007.
Owner
Owner
Technical Specialist Name: k Orl 1 l�
Technical
MCA
Phone No: 916—a93 533(-[p
Submit this form to:
Attn: Keith Lorick
Non -Discharge Compliance and Enforcement Unit
NC Division of Water Quality
1617 Mail Service Center
Raleigh, NC 27699-1617
PLAT-12-11-03

\O�OF W AT �q�G
1 --1
O <
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Don LaCoe
194 Buncombe Lane
Mt. Olive NC 28365
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
September 1, 2005
RE: Sludge Management Plan of Action
CJK Farms_andd.K&M Farms
Facility, 12<7�1 r;
Duplin County
Dear Don LaCoe:
Alan W. Klimek, P.E. Director
Division of Water Quality
su 0 9 cuu5
The Division of Water Quality (DWQ) received your sludge survey information on March 1,
2005. Upon review of the information submitted, it was determined that the minimum treatment depth
for Lagoon CJKI is inadequate. Your NPDES General Permit Number NCA231271, Condition IV.16
specifies that within 90 days, a plan of action must be created to document the sludge management
procedures to be used. DWQ has not received an adequate plan of action for this facility.
Attached is the Plan of Action for Lagoon Sludge Reduction form that is to be used. The form
outlines the compliance and reporting timeframes to satisfy Condition IV.16 of your NPDES General
Permit.
Please submit the plan of action within 30 days of receipt of this letter to:
Keith Larick
Division of Water Quality
1636 Mail Service Center
Raleigh, NC 27699-1636
Thank you for your attention to this matter. If you have any questions, please call me at (919)
715-6185, or the Wilmington Regional Office at [phone].
Sincerely,
Keith Larick
Animal Feeding Operations Unit
cc: File# 31-271
Wilmington Regional Office
Nor Carolina
�vatura!/y
North Carolina Division of Water Quality 1636 Mail Service Center Raleigh, NC 27699-1636 Phone [phone] Custom Service
Internet: h2o.ennstate.nc.us 2728 Capital Blvd. Raleigh, NC 27604 FAX [phone]
An Equal Oppottuni /AlSrmatve Acton Employer— 50%Recyded110% Post Consumer Paper

3Is Z I Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
January 14, 2004
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
DON LACOE
194 BUNCOMBE LANE
MT. OLIVE NC 28365
Subject: Notice of Violation and Revocation for Nonpayment
CJK Fauns and K&M Farms
Permit Number: NCA231271
Duplin County
Dear Don LaCoe:
In accordance with North Carolina General Statute 143-215.10G, all animal operations who receive an animal
waste management system permit will be charged in each year of the term an annual permit fee. Annual permit fees are
billed following the issuance of the permit and then annually thereafter on the anniversary of that date. Your animal waste
management system permit was issued on 4/9/2003.
Your annual permit fee for the period of 4/9/2003 - 4/8/2004 is $150.00. Your payment was due 11/8/2003.
Because this fee was not fully paid within 30 days after being billed, this letter initiates action to revoke the subject permit,
pursuant to 15 NCAC 2H .0205 (c) (4). and G.S. 143-215.1 (b) (3).
Effective 60 days from receipt of this notice, the subject permit is hereby revoked unless the required Annual
Animal Waste Management System Permit fee for your animal operation is received within that time. Operation of an
animal waste management system without a valid permit is a violation of North Carolina General Statute 143-215.1 and is
subject to the assessment of a civil penalty of up to $10,000 per day. Your payment should be sent to:
N.C. Department of Environment and Natural Resources
Division of Water Quality
Budget Office
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
If you have any questions, please contact Fran McPherson at [phone] ext. 210.
Sincerely,
� F
Alan W. Klimek, P.E.
cc: Non -Discharge Branch Compliance/Enforcement Unit
Wilmington Regional Office
Duplin County Health Department
Permit File -
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled / 10% post -consumer paper

3� _ 2 lid o
ANIMAL FACILITY ANNUAL CERTIFICATION FORM
Certificate of Coverage or Permit Number AlG,g2 3IP % l County ��/J/nv Year 200 3
Facility Name (as shown on Certificate of Coverage or Permit) C 14 FAem-s Ayq�/ Ksnt FAQmS
Operator in Charge for this Facility TDQ�2.4&0 -, L AGOG Certification # A&I 1G 3»
7Lan application of animal waste as allowed by the above permit occurred during the past calendar year
YES NO. If NO, skip Part I and Part II and proceed to the certification. Also, if animal waste
w generated but not land applied, please attach an explanation on how the animal waste was handled.
Part I : Facility Information:
1. Total number of application Fields ❑ or Pulls (please check the appropriate box) in the Certified Animal
Waste Management Plan (CAWMP): /3 Total Useable Acres approved in the CAWMP
SZ
2. Total number of Fields ❑ or Pulls (please check the appropriate box) on which land application
occurred during the year:
Total Acres on which waste was applied q 19
3. Total pounds of Plant Available Nitrogen (PAN) applied during the year for all application sites:
4. Total pounds of Plant Available Nitrogen (PAN) allowed to be land applied annually by the CAWMP and
the permit: Z . 14 2y
5. Estimated amount of total manure, litter and process wastewater sold or given to other persons and taken
off site during the year NOniG tons ❑ or gallons ❑ (please check the appropriate box)
6. Annual average number of animals by type at this facility during the previous year:
'qg7z-
7. Largest and smallest number of animals by type at this facility at any one time during the previous year:
Largest -q
Smallest - Z
(These numbers are for informational purposes only since the only permit limit on the number of animals
at the facility is the annual average numbers)
8. Facility's Integrator if applicable:
Part II: Facility Status:
IF THE ANSWER TO ANY STATEMENT BELOW IS "NO", PLEASE PROVIDE A WRITTEN
DESCRIPTION AS TO WHY THE FACILITY WAS NOT COMPLIANT, THE DATES OF ANY NON
COMPLIANCE, AND EXPLAIN CORRECTIVE ACTION TAKEN OR PROPOSED TO BE
BRING THIS FACILIT A K INTO COMPLIANCE.
Only animal waste generated at this facility was applied to the permitted sites during LJ Yes []No
the past calendar year.
F;EGE
AR lol
AFACF 3-14-03 1 pay ,

2. The facility was operated in such a way that there was no direct runoff of waste from
P'Yes ❑ No
the facility (including the houses, lagoons/storage ponds and the application sites) during
the past calendar year.
3. There was no discharge of waste to surface water from this facility during the past
P"Yes ❑ N-
calendar year.
4. There was no freeboard violation in any lagoons or storage ponds at this facility during
L4es ❑ No
the past calendar year.
5. There was no PAN application to any fields or crops at this facility greater than the
LuJ"Yes ❑ No
levels specified in this facility's CAWMP during the past calendar year.
6. All land application equipment was calibrated at least once during the past calendar year.
❑ Yes 2 No
7. Sludge accumulation in all lagoons did not exceed the volume for which the lagoon ❑ Yes ❑ NoO
was designed or reduce the lagoon's minimum treatment volume to less than the volume
for which the lagoon was designed. /jA - Gv 1) be q'OvC by tgpa; / 4- 2W y
8. A copy of the Annual Sludge Survey Form for this ff ci]�'ty is nachedd to tag Cert�f ation. ❑ Yes ❑ N
AI A- Gw /f b e we e b y N �-� Z�
9. Annual soils analysis were performed on each field receiving animal waste wring t e LJ Yes ❑ No
past calendar year.
10. Soil pH was maintained as specified in the permit during the past calendar Year? Ries ❑ No
11. All required monitoring and reporting was performed in accordance with the facility's Yes ❑ No
permit during the past calendar year.
12. All operations and maintenance requirements in the permit were complied with during Yes ❑ No
the past calendar year or, in the case of a deviation, prior authorization was received
from the Division of Water Quality.
13. Crops as specified in the CAWMP were maintained during the past calendar year on all CJ Yes ❑ N
sites receiving animal waste and the crops grown were removed in accordance with
the facility's permit.
14. All buffer requirements as specified on the permit and the CAWMP for this facility were YJ Yes ❑ No
maintained during each application of animal waste during the past calendar year.
"I certify under penalty of law that this document and all attachments were prepared under my direction or
supervision in accordance with a system designed to assure that qualified personnel properly gather and
evaluate the information submitted. Based on my inquiry of the person or persons who manage the system, or
those persons directly responsible for gathering the information, the information submitted is, to the best of .
my knowledge and belief, true, accurate, and complete. I am aware that there are significant penalties for
submitting false information, including the possibility of fines and imprisonment for knowing violations."
Fag
or
Mature of [.Operator in Chi
different from Permittee)
Date
AFACF 3-14-03 2

OF
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
DON LACoE
194 BUNCOMBE LANE
Mr. OLivE NC 28365
Dear Don LaCoe:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
December 19, 2002
G1C e
Subject: Notice of Violation and Revocation f"unpayment
CJK Farms and K&M Farms '
Permit Number: AWS310271
Duplin County
In accordance with North Carolina General Statute 143-215.10G, all animal operations who receive an animal
waste management system permit will be charged in each year of the term an annual permit fee. Annual permit fees are
billed following the issuance of the permit and then annually thereafter on the anniversary of that date. Your animal waste
management system permit was issued on 9/21/1998.
Your annual permit fee for the period of 9/21/2002 - 9/20/2003 is $150.00. Your payment was due 11/7/2002.
Because this fee was not fully paid within 30 days after being billed, this letter initiates action to revoke the subject permit.
pursuant to 15 NCAC 2H .0205 (c) (4). and G.S. 143-215.1 (b) (3).
Effective 60 days from receipt of this notice, the subject permit is hereby revoked unless the required Annual
Animal Waste Management System Permit fee for your animal operation is received within that time. Operation of an
animal waste management system without a valid permit is a violation of North Carolina General Statute 143-215.1 and is
subject to the assessment of a civil penalty of up to $10,000 per day. Your payment should be sent to:
N.C. Department of Environment and Natural Resources
Division of Water Quality
Budget Office
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
If you have any questions, please contact Fran McPherson at [phone] ext. 210.
Sincerely
4 �%
✓ r{ s
Alan W. Klimek, P.E.
cc: Non -Discharge Branch Compliance/Enforcement Unit
Wihnington Regional Office
Duplin County Health Department
Permit File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled / 10% post -consumer paper

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C, the Clean Water Act and 40 CFR 122.41 including civil penalties, criminal
penalties, and injunctive relief.
If you wish to continue. the _activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual NPDES Permit by contacting the staff member listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Sue Homewood at [phone] ext. 502.
Sincerely,
-�Zde -/
for Alan W. Klimek, P.E.
Enclosures (General Permit NCA200000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
'Wilmington Regional Office, Water Quality Section
Duplin County Soil and Water Conservation District
Permit File NCA231271
Permit File AWS310271
NDPU Files

Michael F. Easley, Governor
William G. Ross Jr., Secretary
9 North Carolina Department of Environment and Natural. Resources
r Alan W. Klimek, P. E., Director
1 Division of Water Quality
April 9, 2003
Don LaCoe
CJK Farms and K&M Farms
194 Buncombe Lane
Mt. Olive NC 28365
Subject: Certificate of Coverage No. NCA231271
CJK Farms and K&M Farms
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
Dear Don LaCoe:
On March 14, 2003, the North Carolina Division of Water Quality (Division) issued an NPDES General
Permit for swine facilities. The General Permit was issued to enable swine. facilities in North Carolina to
obtain coverage under a single permit that addresses both State and Federal requirements.
In accordance with your application received on February 20, 2003, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Don LaCce, authorizing the operation of the subject animal
waste collection, treatment, storage and land application system in accordance with NPDES General
Permit NCA200000. The issuance of this COC supercedes and terminates your COC Number
AWS310271 to operate under State Non -Discharge Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the CJK Farms and K&M Farms, located in DuphnCounty, with an animal capacity
of no greater than an annual average of 4600 Feeder to Finish swine and the application to land as
specified in the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to
Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are
unneccessary, they may be replaced by an equivalent number of sows. Any of the sows may be replaced
by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until July 1, 2007. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC.-An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed General Permit. Since this is a new joint State and
Federal general permit it contains many new requirements in addition to most of the conditions contained
in the current State general permit Enclosed for your convenience is a package containing the new and
revised fortes used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this permit. The Devices to Automatically Stop Irrigation Events Form
must be returned to the Division of Water Ouality no later than 120 days following receipt of the
Certificate of Coverage. The Animal Facility Annual Certification Form must be completed and returned
to the Division of Water Ouality by no later than March 1st of each year.
Non -Discharge Pertaining Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Customer Service Center
An Equal Opportunity Action Employer
AM
MNR
Internet httpJ/h2o-enr.state.ric.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/10% post -consumer paper

Murphy -Brown, LLC 10/28/2002 P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s): Don LaCoe
Farm Name: CJK
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Storage Structure: Anaerobic
Storage Period: >180 days
Application Method: Irrigation
The waste from your animal facility must be land applied at a specked rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 gal/yr
gal/yr
Farrow to Feeder
4015 gaUyr
gal/yr
Farrow to Finish
10585 gal/yr
gal/yr
Wean to Feeder
223 gaUyr
gal/yr
4600
Feeder to Finish
986 al/ r
4,535,600 all r
Total 4,535,600 gal/ r
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 Ibs/yr
Ibs/yr
Farrow to Feeder
6.5 Ibs/yr
Ibs/yr
Farrow to Finish
26 Ibs/yr
Ibs/yr
Wean to Feeder
0.48 Ibs/yr
Ibs/yr
4600
Feeder to Finish
2.3 Ibs/ r
10,580 Ibs/ r
Total 10,580 Ibs/ r
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 45.2
Total N Required 1st Year: 12420
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops 12,420.00
Total Nitrogen Produced by Farm 10,580.00
Nitrogen Balance for Crops: (1,840.00)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

Reception Area Speclflcatlons
3(a) of 8
3(a) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
A
B
C
D
E
F
G
H
J
K
Crop
Barley
Hybrid Bermudagrass
Hybrid Bermudagrass
Com - Grain
Com - Silage
Cotton
Fescue- Grazed
Fescue - Hay
Oats
Rye
Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
P Pine Trees
Lbs N utilized / unit yield
1.6 Ibs N / bushel
Grazed 50 Ibs N / ton
Hay 50 Ibs N / ton
1.25 Ibs N / bushel
12 Ibs N / ton
0.12 Ibs N / Ibs lint
50 Ibs N / ton
50 Ibs N / ton
1.3 Ibs N / bushel
2.4 Ibs N / bushel
50 Ibs N / acre
50 Ibs N / acre
2.5 Ibs N / cwt
2.4 Ibs N / bushel
4.0 Ibs N / bushel
40 Ibs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications
PAN/ r/animal Farm Total r
Farrow to Wean
0.84
Farrow to Feeder
1
Farrow to Finish
4.1
Wean to Feeder
0.072
4600 Feeder to Finish
0.36 1656
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 1656 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 8280 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 27 acreas of land. If you apply the sludge
to com at a rate of 125 pounds per acre, you will need 66.24 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
"This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

L
Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Tract
Hydrant
Soil
Type
Crop
Application Rate
in/hr
Application Amount
* inches
2238
1
Orangeburc
C
0.5
1
2238
2
Marvyn
C
0.65
1
2238
3
Orangeburc
B
0.5
1
2238
4
Marvyn
B
0.65
1
2238
5
Orangebuq
B
0.6
1
2238
6
Norfolk
B
0.5
1
2238
7A
Norfolk
B
0.5
1
#REF!
7
Norfolk
C
0.5
1
2238
8A
Orangeburc
B
0.5
1
2238
8
Orangeburc
B
0.5
1
2238
9
Orangeburc
B
0.5
1
2238
10
Marvyn
B
0.65
1
2238
11
Marvyn
B
0.65
1
6of8

Additional Comments:
A small grain overseed may be planted on any field specified in thi this plan
for winter pumping.
Nitrogen may be applied to the small grain at a rate of 50 lbs. per acre.
Follow the application anounts and rates specified on page 6 of this plan
for the small grain crop.
7 of 8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: CJK
Owner: Don LaCoe
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
Itwe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature:
Don LaCoe
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist: Dawn Williamson
Affiliation: Murphy -Brown, LLC.
Address: 2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
t
Signature: �� H Dz—
Date
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
.REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
DON LACOE
194 BUNCOMBE LANE
MT. OLIVE NC 28365
Dear Don LaCoe:
1�
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCE5
December 18, 2000
Subject: Notice of Violation and Revocation for Nonpayment
CJK Farms and K&M Farms
Permit Number: AWS310271
Duplin County
In accordance with North Carolina General Statute 143-215.JOG, all animal operations who receive an animal
waste management system permit will be charged in each year of the term an annual permit fee. Annual permit fees are
billed following the issuance of the permit and then annually thereafter on the anniversary of that date. Your animal waste
management system permit was issued on 9/21/1998.
Your annual permit fee for the period of 9/21/2000 - 9/20/2001 is $150.00. Your payment was due 11/4/2000.
Because this fee was not fully paid within 30 days after being billed, this letter initiates action.to revoke the subject permit,
pursuant to 15 NCAC 2H .0205 (c) (4). and G.S. 143-215.1 (b) (3)
Effective 60 days from receipt of this notice, the subject permit is hereby revoked unless the required Annual
Animal Waste Management System Permit fee for your animal operation is received within that time. Operation of an
animal waste management system without a valid permit is a violation of North Carolina General Statute 143-215.1 and is
subject to the assessment of a civil penalty of up to $10,000 per day. Your payment should be sent to:
N.C. Department of Environment and Natural Resources
Division of Water Quality
Budget Office
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
If you have any questions, please contact Fran McPherson at [phone] ext. 210.
Sincer�y,
Kerr T. Stevens
cc: Non -Discharge Branch Compliance/Enforcement Unit
Wilmington Regional Office
Duplin County Health Department
Permit File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled / 10% post -consumer paper

Revised April 20,
JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA DETERMINATION 1999
Facility Number
Farm Name:
On -Site Representative:,/ kw
Inspector/Reviewer's Name: �if/�
Date of site visit:_ , 2-
Date of most recent WUP: FS—%
Annual farm PAN deficit: pounds
Operation is flagged for a wettable
acre determination due to failure of
�rt H eligibility item(s) F1 F2 F3 F4
Operation not required to secure WA
determinatio . e based on
exemption E1 E2 E3 E4
Operation pended for wettable acre
determination based on P1 p2 P3
Z
on Systems) - circle rd-hose traveler2..center-pivot system; 3. linear -move system;
nary sprinkler system w/permanent pipe; 5. stationary sprinkler system w/portable pipe;
nary gun system w/permanent pipe; 7..stationary gun system w/portable pipe
PART 1. WA Determination Exemptions (Eligibility failure, Part II, overrides Part I exemption.)
�El Adequate irrigation design, including map -depicting wettable acres is co and signed by an I or PE. mplete
E2 Adequate D, and D203 irrigation operating parameter sheets, including map
depicting wettable acres, is complete and signed by an I or PE.
E3 Adequate D, irrigation operating parameter sheet, including map depicting
wettable acres, is complete and signed by a WUP.
— E4 75% rule exemption as verified in Part Ill. (NO i E:75 % exemption cannot be
applied to farms that fail the eligibility checklist in Part 11. Complete eligibility
checklist, Part II - F1 F2 F3, before completing computational table in Part HI).
PART 11.75% Rule.Eiigibiiity Checklist and. Documentation of WA Determination
Requirements. WA Determination.required.because operation-failsnne of. the. eligibility
requirements listed below:
F1 . Lack.of:acreage=whichTesulteddnnvermpplication-mf_wastewater_-(PAN) onspray_:
field(s)sccordinadodarm'sdasttwo_yeas:of.- bafion7ecotrJs_.:
F2 Unclear -illegible, -fir lack of information/mao.
F3 Obvious -field iimitations-(numerousiditches;�ailurEfo deductTequired:` buffer/sefback�crsage;:or25%nffotalmcreageddenti i d in'�AWMP_::mcludes _
small,-irreguladonarys d fields -Melds:iessfhan-5scres-forfravelesmr:less-ihan
2 acres -For.�stationarysprinkles).
F4 WA determination required because CAWMP credits field(s)'s acreage in excess
of 75% of the respective field's total acreage as noted in table in Part III.

Facility Number T Revised April 20, 1999
✓ a /
Part III. Field by Field Determination of 75% Exemption Rule for WA Determination
TRACT FIELD TYPE of TOTAL CAWMP FIELD I COMMENTS'
NUMBER NUMBER1-2 IRRIGATION ACRES ACRES %
SYSTEM
- -•-••ti r�+.��„�, .pununumoersmay be used in place offield numbers gependrng on CAWMP
and type of irrication'system. If pulls, etc. cross -more -than one field, inspector/reviewer will have to combine fields to
calculate 75% field by field determination for exemption; -otherwise operation will be subject to WA determination.
FIELD NUMBER' - must be clearly delineated on -nap.
COMMENTS' - back-up fields with CAWMP acFeageiexceedinggS% of its total:acresand having received less. than 50%
of its annual PAN as documented in the tarn'sprevious:two years' (1997 & .1998) of, irrigationTecords,-cannotsevve as the
bsole basis-forrecuidng a WA Determination:_Back-upireldsrrrust-be noted in the-commentsection and mustbe accessible
y irrigation system.
Part IV. Pending WA Determinations -
P1 Plan Jacks: following information:
P2 Plan -revision Tnay_satis y75% rule based on adequate overall PAN deficit and by.
adjusting -all field acreage#o below 75% use rate -
P3 Other (ielin process of installing new irrigation system):

to Stv
+ j
Plan amendment to Include S&WCC Chronic Rainfall Practices and Standards through March 31, 2000
1. If this facility can comply with its existing permit and CAWMP it must do so.
2. Temporary Addition of New Sprayftetds1 f (Chrk-appropriate bows.) -
A. acres of cropland. List crop types used:
B. acres of hardwood woodland @ 100 lbs PAN / are added.
0 C. acres of pine woodland added @ 60 lbs PAN / acre added.
3. Summer Perennial Grass (Check appropriate box.)
Q A. Application window extended for acres of perennial grass tulnl fast killing frost
0 B. An additional 50 lbs of PAN applied to aces of perennial grass prior to killing frost
4. P N Application Increased for Small Grains & Winter Grasses to be harvested. (Check appropriate box.)
PAN application increased up to 200 lbs per are for '3 0 aces of small gains or winter grasses to be harvested.
PAN application increased up to 150 lbs per are for acres of overzeeded summer perennial included in 3. B.
5. Waste Analysis (Check appropriate box.)
0 A. Prior to December 1`. 1999 the calculation of PAN will be based on a 35% reduction of the last analysis taken
prior to the first 25 year 24 hour storm event (Current waste analysis must be used after Dec.I .)
0 B. Use current waste analysis to determine PAN. -
6. Required -Maximum Nitrogen Utilization Measures for Small Grains and Winter Grasses.
A. Use of higher seeding rats
B. Timely harvest of forage to increase yield, and
C. Irrigating during periods of warmer weather.
7. Required -Irrigation Management Techniques to Reduce Runoff and Ponding Potential.
A. Making frequent, light irrigation applications, and
B. Not irrigating immediately before prdired zinfalL
8. The owner / manager is required to manage the movement of animals to and from the facility to minimize environmental
impacts, ensure compliance with the `aciliry's pe nnit and amended CAWMP, and avoid dischame to surface waters.
9. Authorization to use the addidonal pmcdces included in this amendment expires if a facility discharges to surface waters.
Any discharge is a violation and may result in an enforcement action.
10. The owner / operator is required to keep records of all waste applications.
11. This revision must include a map or sketch of new land application areas.
Faciiiry Number
Faciliry Name
�cvt•Ja — �/aGo� / l�/�jr�/� [ A- B5cH
Facility Owner / Manager Nam- RL1
T Trhnical-Spccia]ist Nance (PRIN'r)
tactlity Ow er /Manage; Signatur Technical Spedzlist Signature
Date �� /Z�i / i Date izisl 9 r
This document must be filed at the SWCD office and be attached to the facilities CAWVIP
and be ar-ailable for inspection at the facility.
(') New temporary spra;itelds must meet applicable buffer and setback requirements. Waste must not be appEcd to wetlands.
11110/,1999

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
Donald LaCoe
CJK Farms and K&M Farms
194 Buncombe Lane
Mt. Olive NC 28365
Dear Donald LaCoe:
1� •: '
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
September 21, 1998
Subject: Certificate of Coverage No. AWS310271
CJK Farms and K&M Farms
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
In accordance with your application received on May 21, 1998, we are forwarding this
Certificate of Coverage (COC) issued to Don LaCoe, authorizing the operation of the subject animal
waste collection, treatment, storage and land application system in accordance with General Permit
AWG100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the CJK Farms and K&M Farms, located in Duplin County, with
an animal capacity of no greater than 4600 Feeder to Finishand the application to land as specified in
the Certified Animal Waste Management Plan (CAWMP)._
`
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS t
143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This \
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable.A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS310271 -A_:,u V It
CJK Farms and K&M Farms 5 SEP 2
Page 2 1998
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact Sue Homewood at [phone] ext. 502.
Sincere ,
c
/A. Preston Howard, Jr., P.E.
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
.Wilmington. -Regional: ffice,_Water-Quality-SFction
Duplin County Soil and Water Conservation District
Permit File

1.
2.
State of North Carolina RECEIVED
Department of Environment and Natural Resources WATER QUAUTY SECTION
Division of Water Quality MAY j
Non -Discharge Permit Application Form 2 1998
(THIS FORM MAYBE PHOTOCOPIED FOR USE AS AN ORIGINAL) Non -Discharge pennitung
General Permit - Existing Liquid Animal Waste Qperations
The following questions have been completed utilizing information on file with the Division: PR�se�`-•L'
review the information for completeness and make any corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
GENERAL INFORMATION:
1.1 Facility Name: C1K Farms d- Ks ni Fez, n2
L2 Print Land Owner's name:
1.3 Mailing address:
City, State: Mt. Olive NC On)
Zip: 28365
Telephone Number (include area code): 658-6902
1.4 County where facility is located:
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a copy
of a county road map with the location of the farm identified): On south side of srl357 approx .5 miles south of
intersection of sr1306
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's I Integrator's name (if applicable; please circle which type is listed):
1.8 Date Facility Originally Began Operation: &HO+i92 4 -le57
1.9 Date(s) of Facility Expansion(s) (if applicable): ) 7- .I 5-- 9 Z
OPERATION INFORMATION:
2.1 Facility No.: 31 (county number); 271 (facility number).
2.2 Operation Description: Swine operation
Feeder to Finish
4600- Certified Design Capacity
Is the above information correct? I o yes; F—I no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number for which the waste management structures were designed.
Type of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle No. of Animals
• Wean to Feeder • Layer • Dairy
• Feeder to Finish - Non -Layer • Beef
• Farrow to Wean (# sow) • Turkey
• Farrow to Feeder (# sow)
• Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals:
FORM: AWO-G-E 1/28/98 Page 1 of 4 31 - 271

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 56.00 - Required Acreage (as listed in the AWMP): 41
2.4 Are subsurface drains present within 100' of any of the application fields? YES or NOS (please circle one)
2.5 Are subsurface drains present in the vicinity or under the lagoon(s)? or (please circle one)
2.6 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRC dazds�, etc.) (Swine Only)
YES r NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? A?' r/CJ
What was the date that this facility's land application areas were sited? S A r r e-
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit application
for animal waste operations.
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.)
If your CAWMP includes components not shown on this list, such as an irrigation design,
or site evaluation, please include the additional components with your submittal.
FORM: AWO-G-E 1/28/98 . Page 2 of 4 31 - 271
Applicants Initials
'tl�74

Facility Number: 31 - 271
Facility Name: CJK Farms
4. APPLICANT'S CERTIFICATION:
l 1, �:) ON A 1,11 G L14 Cow (Land Owner's name listed in question 1.2), attest that
this application for _ _C� � /L t K - /"r ) t'Q (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned tg-me-as-0complete. _ /I _
Signature
Date ;-- / '�v 9>
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
(Manager's name listed in question 1.6), attest that this
application for !Facility name listed in question 1. i)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 1/28/98 Page 3 of 4 31 -271

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
July 8, 1998
Donald LaCoe
194 Buncombe Lane
Mt. Olive NC 28365
'ells^p
'v=-cr,ON
•,98
RCDENR
NORTH CAROLINA DEPARTMENT of
ENVIRONMENT AND N wuRAL RESOURCES
Subject: Facility No. 31-0271
Additional Information Request
CJK Farms and K&M Farms
Animal Waste Operation
Duplin County
Dear Donald LaCoe:
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the
subject application. Additional information is required before we can continue our review. Please
address the following by August 10, 1998.
It was noted during the review that your current Waste Utilization Plan (WUP) lists small grain
as a crop option for waste application. In order to use small grain as a crop for waste application,
nitrogen application rates and application windows must be listed in the plan. Please revise your WUP to
properly list small grain into your cropping scheme and throughout the entire WUP.
All revisions / amendments are required to be signed and dated by both the landowner and the
Technical Specialist before they are submitted for review. Please reference the subject facility number
when providing the requested information. All information should be signed and submitted in duplicate
to my attention at the address below. The information requested by this letter must be submitted on or
before August 10, 1998 or the Division will return your application as incomplete in accordance with
15A N.C.A.C. 2H .0200 and your facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid
permit is a violation of North Carolina General Statute 143-215.1 and will subject you to the enforcement
authority of the Environmental Management Commission.
If you have any questions regarding this request, please call me at [phone], extension 533.
Sincerely,
Katharine Keaton
Soil Scientist
Non -Discharge Permitting Unit
cc: Wilmington Regional Office, Water Quality
Permit File
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

WASTE UTILIZATION PLAN
Owners name--:CJF FM/DON LACOE County:DUPLIN
Mail Address -:PINK HILL
Type of production unit ---- :FEED -FIN
Number of animal units-----: 4600
Type of waste facility ----- :Anaerobic Lagoon
Temporary storage period---: 180 days
Method of application ------ :IRRIGATION
Amount of animal waste produced-----------------: 8740 tons/year
Amount of plant available N produced by animals-: 10580 lbs./year
Commercial N to apply on planned acreage--------: 0 lbs./year
Your animal waste utilization plan has been specifically
developed for your swine operation. The plan is based on the
soil types, crops to be grown, and method of application for
your particular operation. The waste must be land applied at a
specified rate to prevent pollution of surface and/or ground
water. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered -to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Soil incorporation
of waste will conserve nutrients and reduce odor problems.

Page 2
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Annual acreage
requirements may be more or less based on the waste analysis
report for your waste management facility.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract
Field
Soil
Crop
Yield
Lbs. N
Acres
Lbs. N
Month to
No.
-----
-----
No.
-----
-----
Type
-----
-----
Code
-----
-----
/Acre
-----
-----
/Unit
-----
-----
-----
-----
Used
-----
-----
Apply
------
------
2238
1
OrB
K
N/A
50.00
3.2
160
S-APRIL
2238
1
OrB
C
6.3
50.00
3.2
1008
MAR-OCT
2238
2
MCC
K
N/A
50.00
3.9
195
S-APRIL
2238
2
MaC
C
6
50.00
3.9
1170
MAR-OCT
2238
3
OrB
K
N/A
50.00
3.2
160
S-APRIL
2238
3
OrB
C
6.3
50.00
3.2
1008
MAR-OCT
2238
4
MCC
K
N/A
50.00
2.1
105
S-APRIL
2238
4
MCC
C
6
50.00
2.1
630
MAR-OCT
2238
5
OrB
K
N/A
50.00
3.3
165
S-APRIL
2238
5
OrB
C
6.3
50.00
3.3
1039.5
MAR-OCT
2238
6
NoA
K
N/A
50.00
3.8
190
S-APRIL
2238
6
NoA
C
6.1
50.00
3.8
1159
MAR-OCT
2238
7
NoA
K
N/A
50.00
4.3
215
S-APRIL
2238
7
NoA
C
6.1
50.00
4.3
1311.5
MAR-OCT
2238
A7
NoA
K
N/A
50.00
4.5
225
S-APRIL
2238
A7
NoA
C
6.1
50.00
4.5
1372.5
MAR-OCT
2238
8
OrA
K
N/A
50.00
3.5
175
S-APRIL
2238
8
OYA
C
6.3
50.00
3.5
1102.5
MAR-OCT
2238
9
OrB
K
N/A
50.00
3.8
190
S-APRIL
2238
9
OrB
C
6.3
50.00
3.8
1197
MAR-OCT
2238
A8
OrB
K
N/A
50.00
4.0
200
S-APRIL
2238
A8
OrB
C
6.3
50.00
4.0
1260
MAR-OCT
2238
10
MCC
K
N/A
50.00
2.2
110
S-APRIL
2238
10
MCC
C
6
50.00
2.2
660
MAR-OCT
2238
11
MCC
K
N/A
50.00
3.5
175
S-APRIL
2238
11
MCC
C
5.1
50.00
3.5
892.5
MAR-OCT
----- ----- ----- ----- ----- ----- -----
Total 90.6 16076
Available Nitrogen (includes commercial) 10580
Surplus Or Deficit -5496
Crop codes: Crop -unit
A=Barley-bu.
B=Bermudagrass(graze)-tons
C=Bermudagrass(hay)-tons
D=Corn(grain)-bu.
E=Corn(silage)-tons
F=Cotton-lbs. lint
G=Fescue(graze)-tons
H=Fescue(hay)-tons
I=Oats-bu.
J=Rye-bu.
K=Small grain(graze)-acre
L=Small grain(hay)-acre
M=Sorghum(grain)-cwt.
W=Wheat-bu.
Y=Fescue(pasture)-tons
Z=Bermudagrass(pasture)-tons

If more commercial fertilizer is used than shown in this plan,
then additional acres of land may be needed. A three to fifteen
feet wide permanent grass filter strip should be seeded along all
ditches in fields that receive animal waste.
Additional comments:
NHS Wju0 WAn OdM.-NQsn `rb S ,C &/ SMAU G,PA/N GwziN6 A;$,Q
Z4 FiAFZ-as . /9Z-4v»445 pF .5-1W,04c 192,046t MAY BE /Pena -7'a
U/FFL�CEKT FEcDS 7,!o ,v .V T AOX / M6,9,RN RAGNN,-EF,
731s SM,4& X 41H !/!/U
ComL 5-/Y ,Wq 5P0x4 l va -
Prepared by: 441pw [D 66465oN Title:T// SP.1z. Date: 4AI&g
Concurred in by: IA CAI V 4 -f Date: ? V' qd'
Producer
I understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1-day storm event. I also
certify that the waste will be applied on the land according to
this plan at the appropriate times and at rates that no runoff
occurs.
Date: �'9d
Producer
'Technical Specialist: % �, _ Date: 8/wyls
(Copy to producer and copy to case file)
L

RECEIVED
WATER QUAIJTYSECTION
MAY 2 9 119918 r .
lication and Handling Eauioment
appropriate boa Non -Discharge Permitting
1fExistino or expanding facility with existing waste application equipment (WUP or I)
D
K
Animal waste application equipment specified in the plan has been either field calibrated or evaluated in
accordance with existing design charts and tables and is able to apply waste as accessary to accommodate the
waste management plan: (existing application equipment can cover the area required by the plan at rates not to
exceed either the specified hydraulic or nutrient loading rates, a schedule for timing of applications has been
established; required buffers can be maintained and calibration and adjustment guidance are contained as part of
the plan).
Animal waste application equipment specified in the plan has been designed to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of
applications has been established; requited buffers can be maintained; calibration and adjustment guidance are
contained as pan of the plan).
spreading not using spray irrigation. (WUP or I)
Animal waste application equipment specified in the plan has been selected to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area requited by the
plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of ,
applications has been established; required buffers can be maintained; calibration and adjustment gaitlanx are
contained as pan of the plan).
Name of Technical Specialist (Please Print)7.44144" R 44d. L
No.-
E)
The waste management plan for this facility includes a Waste Management Odor Control Chedclit:t, an Insect Como,
Checklist, a Monaliry Management Checklist and an Emergency Action Plan. Sources of both odors and insects
have been evaluated with respect to this site and Best Management Practices to Minimize Odors and Best
Manaventent Practices to Control Insects have been selected and included in the wan management plan. Both the
Mortality Management Plan and the Emergency Action Plan are complete and can be implemented by this facility.
Name of Technical Specialist (Please Print):
Affiliation:
Addtess(Aggency): Phone No.:
Sigttatme: Date:
F) Written Notice of New or Expanding Sttine Farm
The following signature blade is only to be used for new or expanding swine farms that begin construction after Jana
21,19%. If the facility was built beiore June 21,19%, when was it constructed or last expanded
I (we) certify, that I (we) have attempted to contact by certified mail all adjoining property owners and all properly owners
who own property located across a public road, street. or highway from this new or expanding swine farm. The notice was in
compliance with the requirements of NCGS 106-805. A copy of the notice and a list of the property owners notified is
attached.
Name of Land Owner :
Si -,nature: Date:
Name of Manager(if different from owner):
Signature Date:
AWC — Januam 1, 1991 3

�-lv
T
ME
k�
I (1
f,l

V
f^
l
d
`e
r
V
is
C
�
�
01
q
IN
C rl

Paramaters
199S
TABLE 4 - Irrigation System Specifications
-- -
Travding 8olld Sat
Irrl aeon Dun Irrl ation
Flow MIS of Sp n ler gpm)
t'
Operating Pressure at PUMP fps)
,
Design Precipitation Rate (INhr)
I 3
Hose Length (last)
xxxxxxxx
Typs of Speed Compensation
r xxxxxxxx
Pump Type (PTO, Engine, Electric)
Pomp Peeer Requlrement (hp)
TABLE 5 - Thrust Block Specifications'
�L...-a Ll....lr .1M.H. nn anna mte Sheet.-
voa,yuv, Lr
LOCATION
THRUST BLOCK
AREA a .It.
9C Bend
Dead End
1 f%
'
Tee
1 N
(
(
tSee USDA-NRCS Field OMcc Technical Uulae, 5ecuon iv, rncucc a,auc
yol,
4.
page-4
n
USDA-NRCS
North Carolina

Name.
Company:
Address:
Phone:
REQUIRED DOCUMENTATION
The following details of design and materials must accompany all irrigation designs:
I. A scale drawing of the proposed irrigation system which includes hydrant locations, travel lanes, pipeline routes, thrust block
locations and buffer areas where applicable.
2. Assumptions and computations for determining total dynamic head and horsepower requirements.
3. Computations used to determine all mainline and lateral pipe sizes.
4. Sources and/or calculations used for determining application rates.
5. Computations used to determine the size of thrust blocks and illustrations of all thrust block configurations required in the system.
6. Manufacturer's specifications for the irrigation pump, traveler and sprinkler(s).
7. Manufacturer's specifications for the irrigation pipe and/or USDA-NRCS standard for Irrigation Water Conveyance,
N.C. Field Office Technical Guide, Section IV, Practice Code 430-DD.
NOTE: A buffer strip Jib feet wide or wider must be maintained between the limits of the irrigation system and all perennial
streams and surface waters per DEHNR-DEM Code Section 15A NCAC 2B .0200 - Waste Not Discharged to Surface
Waters.
Parameters USDA•NRCS
1995 , , page-5 North Carolina

Narrative of Irrigation System Operation
Describe the operation of the system in the space provided below or on a similar sheet most convinient to the designer/supplier.
Include procedures such as start-up, shut -down, winterization and regular maintenance of all equipment.
Paramours USDA-NRCS
1995 Paga-9 North Carolina

EXHIBIT E-5
FORM IRR-1
Farm Owner
J«o
Lagoon Liquid Irrigation Fields Record
For Recording Irrigation Events on Different Fields
Facility Number FXXXXX XXXX
.15 5...... .,r...... r -•-. vr- _
_
Field Size
asprinklersOneraling
Irrigation Time
Number or
Tract #
Field #
Date
d
Crop Type
T,dd1
T10u
/
/
:
r
Mv.lro, ro95
,1/w./P/, 1995
Nw.lrq rags
,r/w.Am, ro95
ow.
Cw.
Bwr.l,
Bwnli
Jr
!?
if
JJ
e:cn....
a:00.....
e:09c r.
a:ar�...
a:0d .,.
S.40 ...
J:AO ..
J;00 .w.
SO
Sa0
Ord
IIO
1
:
,r/w.1, roar
Bwr.G
it
rro
1
T70ar
1
M+ m, No
Cw, i
Jr
009
1
1
16, p r,ISAW-MA
a
a:a0�.,,
r.WA...
6d0
1
1
146' rr,Jr
a:ad�...
9./0.N.
ON
1
T,au
r
r
v,.1,
J...;
!!
S:A7 .,.
/l:00 ...
Jd0
r
J.1. J,
if
J:M .r
12.&V ..
510
1
r
J.a/,
J1
J;Aa ..
1r.V
SO
1

EXHLafT E-7
FORM IRR-2
Tract #
Field Size (acres) = (A)
Farm Owner
Owner's Address
Owner's Phone #
Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Tian _Field #
s
J. o�
rJJN.gR.rl
Mrt, NCmH
wvus 1u1
Facility Number I XXXXX - XXXXX
Irrigation Operator AmP
Irrigation Operator's muh yAd
Address P#&wj NOmr1
Operalc is Phone # 91f& +111
From Waste Utilization Plan
Crop Type B.r+.6Jry Recommended PAN IW
Loading (lb/acre) = (B)
m nm (I11
1
2 9 6 a •
Data
nuNddryr
IrrgaUon
Waste Analysis PAN
(lb/1000 al)
V
PAN Applied
141 `_ 0
Ill
1000
Nitrogen Balance'
(@)acre)
IB) • pe)
Blatt Time
End Time
Total
Minutes
(3) (z)
/of SprinAiers
operating
p
Flow Rate
(inumin)
Total Volume
(gallons)
(0) . (a) . (4)
Volume
per Acre
(BaVecre)
A
.V74'ls
4/AV*
4/7//1'J
44/VJ
4h/l'1
4"
AM..
J.W..
J.W..
J:W .+
JW/.+
J:W .
J.m1.
AM .'
A40 .
Mm .
/l.W.+
/J.W.+
/JO
IJV
IW
J60
1I0
110
/
!
!
!
!
/
/W
IW
IW
IW
IW
IW
/O/,aV
/aaav
milaa
!faro
Imam
Jld&V
J//V
JI/r
J/d!
IOIJ
109
OW
1.J
ZJ
J.1
As
1..5
J.J
/J.1
/J.J
/1.0
!ld
!!.1
/JI
JaO,J
J/J.0
AM
JIJJ
JJJ.O
J!!.d
4///YJ
J.W .
11m1..
sea
I
IW
1/6aV
60.N
1..5
/J./
JW.J
4"
JW .
J,JJ .+
!Jf
!
IW
dt atl
Alro
1..5
5.0
J11r!
Owner's Signature let (pyh d
certified Operator (Print) (To. P91,t,{
Crop Cycle Totals I /,Jozaw
C
1 /ur.0 f
Operator's Signature I.. Aw"Id
Operator's Certincallon No. arpj
A Waste Anaylysls or Equivalent or NRCS Estimate, Technical Guide Section 633.
the value received by subtracting column (10) from (e). Continue subtracting column (10) from column (11) following each Irrigation event.

WECO
ENGINE SPECIFICATIONS
Engine Type........................................................................................................8031
i 05
TIMING
4Strok, Diesel with &ad injection -
Overhead va hm oorma8ed by pufMods and rorioers with
Cylinders. number d anargenw d......................................................................3,
in kne
cartwridt in erWd e.
Bore x stroke............ ................................ ......................................................
104z115mrn
GearEnvan aamshalt
Dcpecernwnt............. ..-.............................................................................................
Z91
Valve tmaing:
Compressionratio........................................................................................................
17:1
-Intake
Maximum ratin9Cl:..... .....................................................................................
44kW(6=V)
Open: before T.D.C....._......................................7
At. ......................... ...__....................................................._....,...........................25M
rpm
Closes after B.D.C......................... _......... ..... ..... 2T
Engine rotation:
-Exhaust
(sae from ftyameel).............. .......................... .......... ...................................................
CCW
Open. belor B.D.C..._............... ..... ...........48' 3M
Dryweight ..... ....... .............. ............. ...... ...................................................................
1354
Closes after T.D.C..... ..... ..._....... ._..---- _..........8'
(-) ISO Fuel Stop Parer
Ckmano bartraen wove Woc ers
-Ambient rrvt a conditions:
....—
for tang checks. ...... _..... —. _----- .0.45 mm
04 ISO 36H; 25 C; 100kPa: 30% relative humidity.
valvYslve
rcd recbrrn.
Oparg deetaruoe becwean
-
cold engine:
FUEL SYSTEM
-intone and exhaust ........ ............................. 0.30 mm
Fuel filtration by replaceable cartridge fiber.
Fuel supply by double diaphragm puny.
Injection pump type: C.A.V. - DPS with rotating piston distributor. atFsPeed
govemor and vadetor advano m orporated
Fiord injection pump delivery start advance.....................................V44- V
Fuel innectom 9eteng........................................................230 . 8 kglan sq
Finngorder ........ _._............................................................................ 1-2-3
LUBRICATION
Food -teed tutriradun by 9eer-Pmy dri~ by orb
Preswre relief vale seated to the ad Pump.
Total and continuous ad fftwo by a repiscaeble uartrrtlge filter.
Oil cooling with oil -fresh water herd exchanger.
Minimum oil pressure:
-at full ti lbe..........................................................25 k9km aq
-WhM 00%........................................................._....0.7 NAM aq
..r.:.....:.�. ,.� L-soot
r.
®.
/AN
eunart w ua eaa.m nr son
C_7045 �_ :_,�5 ._.... C-,G15 �'�-„ d. 12_22-7• 110ELB2 a JOBL

i
06/17/96 MON 13:51 FAX [phone]
;(02) 30LP/1000' ATER-REEL PERFORMANCE _--- ; INCHES DEPTH OF APPLICATION ---_- ;320- '
------- ---------------------- -- --------------------- OGRE
NELSON ; SPRINXLER SYSTM ; IRRIGATED ; TRAVEL SPEED - FEET PER HOUR ;PRE- i
SR100 PERFORMANCE INLET ; AREA ;- ---. ------;CTP I
b NOZ: ; PSI ; GPM ; DIA ; PSI ; NIDTH X LNGTH ; 40 50 ; 75 ; 100 ; 150 ; 200 ; 300 ;RATE
'---------- ------ ----------------------'----------____---------- -;----
.712- ; 50 ; 74 ; 225 ; 67 ; 158 X 1079 ;, 1.0 0.8 ; 0.5 ; 0.4 ; 0.3 ; 0.2 ; 0.1 10.24
' Ring 60 ' 81 ' 240 ; 79 ; 168 X 1084 ' 1.0 0.8 ' 0.5 ' 0.4 ' 0.3 ' 0.2 ; 0.1 '0.23
or .60 ; 70 ; 88 ; 250 ; 90 ; 175 X 1088 ; 1.1 0.8 ; 0.6 ; 0.4 ; 0.3 ; 0.2 ; 0.1 10.23
Taper 80 94 ; 260 101 182 X 1051 1.1 0.4 0.6 0.4 ; 0.3 0.2 0.1 ;0.23
--------------~--------------------_-_-------_-----------' -----'
.768- ; 50 ; 87 ; 235 ; 70 ; 165 X 1082 ; 1.1 0.9 ; 0.6 ; 0.4 ; 0.3 ; 0.2 ; 0.1 ;0.26
Ring ; 60 ; 96 ; 250 ; 82 ; .175 X 1088 ; 1.2 0.9 0.6 ; 0.5 ; 0.3 ; 0.2 ; 0.2 10.26
or .650 ; 70 ; 103 ; 263 ; 93.E 184_ X 109Z_11 1.2 0.9 ; 0.6 ; 0.5 ; 0.3 ; 0.2 ; 0.2 :0.25
Taper 80 ; 110 273 105 191 X 109fi ; 1.2 1.0 0.6 0.5 0.3 ; 0.2 0.2 ;0.25
.812' ; 60 ; 110 ; 260 ; 85 182 X 1091 1.3 1.0 0.7 ; 0.5 ; 0.3 ; 0.3 ; 0.2 10.27
or .70 ; 70 ; 120 ; 275 ; 48 ; 195 X 1096 ; 1.3 i.l ; 0.7 ; 0.5 ; 0.4 ; 0.3 ; 0.2 :0.27
Taper ; 80 ; 128 ; 285 ; 110 ; 200 X 1100 ; 1.4 1.1 ; 0.7 i 0.5 ; 0.4 ; 0.3 ; 0.2 :0.26
.857- 60 ;.126 270 ; 89 ; .189 X 1095 ; 1.4 1.1 0.7 ; 0.6 0.4 ; 0.3 0.2 :0.29 ;I
or .75' ; 70 ; 136 ; 283.; 102 ; 198 X 1099 ; 1.4 ; 1.2 ; 0.8 ; 0.6 ; 0.4 ; 0.3 ; 0.2 :0.28
Taper 80 146 295 116 207 X 1103 1.5 a 1.2 0.8 ; 0.6 0.4 0,3 0.2 :0.26
-- --------------- -- ----------- ----------------------' -----'
i
.895- ; 60 ; 143 ; 280 ; 95 ; 196 X 1098 1.5 1.2 ; 0.8 ; 0.6 ; 0.4 ; 0.3 ; 0.7 :0.31
or .8' ; 70 155 ; 295 ; 109 ; 207 X 1103 ; 1.6 ' 1.3 0.8 0.6 ; 0.4 0.3 0.2 ;0.30
Taper ; 80 ; 165 ; 305 ; 122 ; 214 X 1107 ; 1.6 ' 1.3 ; 0.9 ; 0.7 ; 0.4 ; 0.3 ; 0.2 !O.30
--------------- -----------------------------------=----------
------------' -----'
.921' ; 60 164 ; 288 ; 102 ; 202 X 1101 ; 1.7 " 1.4 0.9 ; 0.7 ; 0.5 ; 0.3 ; 0.2 ;0.33
ar .85' 70 rITI 502 111 ; 211 X 1106 ; 1.8 7 1.4 ; 0.9 ; 0.7 ; 0.5 ; 0.4 ; 0.2 10.33
Taper ; 80 ; 189 ; 314 ; 131 ; 220 X 1110 ; 1.8 1.4 ; 1.0 ; 0.7 ; 0.5 ; 0.4 0.2 :0.32-�
----------------------------------�----------------- ~---' ----
1.0- 50 ; 204 ; 300 108 ; 210 X 1105 ;. 2.0 ;� 1.6 ; 1.1 ; 0.8 ; 0.5 ; 0.4 ; 0.3 10.38
Taper 60 224 316 127 221 X 1111 2.1 1.7 1.1 0.9 0.6 0.4.; 0.3 ;0. 8
10 243 338 146 2) X 1118 ; 2.2 ',� 1.7 1.2 0.9 0.6 0.4 0.3 ;0.36
HOURS FOR 1000 FEET OF TRAVEL:; 25.0 ;j 20.0 ; 13.3 ;10.0 ; 6.7 ; 5.0 ; 3.3 :grow
Notes: System inlet pressure will be approx 10 PSI lower for engine driven machines.
Turbine drives will have higher pressure losses a the higher speeds.
Q 001
= The precipitation rate is in inches per hour and is base, on a sprinkler arc o' 320 degrees.
300-feet per hour pay be possible with the engine drive version only.
---------------------------------------------------------------------------------------------

plpp� SuPPLsnk_�; Tc 91-A�k
WASTE UTILIZATION PLAN
----------------------
Owners name --:DON LACOE County:
Mail Address-: 0
Type of production unit ---- :FEED -FIN
Number of animal units-----: 4600
Type of waste facility ----- :Anaerobic Lagoon
Temporary storage period---: 180 days
Method of application— ---- :IRRIGATION
Amount of animal waste produced-----------------: 8740 tons/year
Amount of plant available N produced by animals-: 10580 lbs./year
Commercial N to apply on planned acreage--------: 0 lbs./year
Your animal waste utilization plan has been specifically
developed for your swine operation. The plan is based on the
soil types, crops to be grown, and method of application for
your particular operation. The waste must be land applied at a
specified rate to prevent pollution of surface and/or ground
water. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an -
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Soil incorporation
of waste will conserve nutrients and reduce odor problems.

WASTE UTILIZATION PLAN
Owners name --:DON LACOE County:DUPLIN
Hail Address-:RT2 BOX 83 MT. OLIVE 28365
Type of production unit--:FEED-FIN
Type of waste facility ---:Anaerobic Lagoon
Your animal waste management facility has been designed for a
given storage capacity: When the waste reaches the designed
level, it must be land applied at a specified rate to prevent
pollution of surface and/or ground water. The plant nutrients
In the animal waste should be used to reduce the amount of
commercial fertilizer required for the crops on the fields
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are 'encouraged so that all plant nutrients can be balanced for
realistic yields "of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of.the _
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Injecting the waste
or disking will conserve nutrients and reduce odor problems.
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Acreage
requirements may be more or less based on the waste analysis
report from your waste management facility.
The design of your waste management facility is based on the
following:

Page 2
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Annual acreage
requirements may be more or less based on the waste analysis
report for your waste management facility.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract
Field
Soil
Crop
Yield
Lbs. N
Acres
Lbs. N
Month to
No.
No.
Type
Code
/Acre
/Unit
Used
Apply
2238
2
ORANGEBC 1y
6
50.00
10.0
3000
MAR-OCT
2238
-1
MARVYN
C
6
50.00
10.0
3000
MAR-OCT
2238
1
ORANG
C
6.3
50.00
10.0
3150
MAR-OCT
2238
1
NOR
C .5
6.1
50.00
7.5
2287.5
MAR-OCT
Total 37.5 11438
Available Nitrogen (includes commercial) 10580
Surplus Or Deficit -858
Crop codes: Crop -unit
A=Barley-bu.
B=Bermudagrass (graze) -tons
C=Bermudagrass(hay)-tons
D=Corn(grain)-bu.
E=Corn(silage)-tons
F=Cotton-lbs. lint
G=Fescue(graze)-tons
H=Fescue(hay)-tons
I=Oats-bu.
J=Rye-bu.
R=Small grain(graze)-acre
L=Small grain(hay)-acre
M=Sorghum(grain)-cwt.
W=Wheat-bu. _
Y=Fescue(pasture)-tons
Z=Bermudagrass(pasture)-tons

more commercial fertilizer is used than shown in this
u,an additional acres of land may be needed. A three to
feet wide permanent grass filter strip should be seeded
ditches in fields that receive animal waste.
Additional comments:
Page 3
plan,
f ifteen
along all
FN27r of F71 CC c� x�- z AWrznx 3•S±c) CMK 64-- vse1
mE
Prepared by: n,�,Q�. � Title: Cogs Date: jbjZLj[�c
Concurred in by: 1CX ^��5 Date: /!7 26 9S
Pro ucer
I understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1-day storm event. I also
certify that the waste will be applied on the land according to
this plan at the appropriate times and at rates that no runoff
occurs.
`9eL'Z Dater (U Z�/gJJ
Proaucer
_� J —q
Technical Specialist: ,,4. Date: a Z6s
(Copy to producer and copy to case file)

arcs C6ry Fria �cz.nt
ANIMAL WASTE MANAGEMENT PLAN CERTIFICATION FOR MR FEEDLOTS
115'I7 NCo
Please return the completed form to the Division of Environmental Management at the address on the reverse side
of this form.
Name of farm (Please print): _CS K F4RM - 1Do►4 LaCoE C7;�Mpicas K¢ M;;6ua
Address:�4-55 Sr=AOT'ANCVS Rosa
MT ©LIVE, N .r. 2B365 Phone No: 4 .52 65 02
County: aJR.IN
Farm location: Latitude and Longitude 35`� g7�az .r4"(required). Also, please attach a copy of county road
map with location identified.
Type of operation (swine, layer, dairy, etc.) : sw I H F
Design capacity (number of animals): -44,00 ;t KtS44HC
Average size of operation (12 month population avg.): 4,,-00
Average acreage needed for land application of waste (acres) 4d
=a=aaaaaaaaaaaaaaaaaaaaaaaaaaaaaaavaeaaaacaaaaaaaaaacaaaaaaaaaaaaaaaaaaaaaaaa-a=aa
Technical Specialist Certification
As a technical specialist' designated by the North Carolina Soil and Water Conservation Commission pursuant to
the 15A NCAC 617.0005, I certify that the new or expanded animal waste management system as installed for the
fast named above has an animal waste management plan that meets the design, construction, operation and
maintenance standards and specifications of the Division of Environmental Management and the USDA -Soil
Conservation Service and/or the North Carolina Soil and Water Conservation Commission pursuant to 15A NCAC
2H.0217 and 15A NCAC 6F .0001-.0005. The following elements and their corresponding minimum criteria have
been verified by me or other designated technical specialists and are included in the plan as applicable: minimum
separations (buffers); liners or equivalent for lagoons or waste storage ponds; waste storage capacity; access or
ownership or proper waste application equipment; schedule for timing of applications; application rates; loading
rates; and the control of the discharge of pollutants from stormwater runoff events less severe than the 25-year,
24-hour storm
Name of Technical Specialist (Please Print): Aewa¢D L. AoSso.s
Affiliation: CAQAMLs L=oo.D5 , ixc
Address (Agency): P.C. basawe2 B5r_ , WARSANd. K.C. 2839$ Phone No.dfln 293-3¢
Owner/Manager Agreement _
I (we) understand the operation and maintenance procedures established in the approved animal waste management
plan for the farm named above and will implement these procedures. I (we) know that any additional expansion
to the existing design capacity of the waste treatment and storage system or construction of new facilities will
require a new certification to be submitted to the Division of Environmental Management before the new animals
are stocked. I (we) also understand that there must be no discharge of animal waste from this system to surface
waters of the state either through a man-made conveyance or through runoff from a storm event less severe than
the 25-year, 24-hour stomt. The approved plan will be fled at the farm and at the office of the local Soil and
Water Conservation District
Name of
Name of Manager,if different from owner (Please print):
Signature: Date:
Note: A change in land ownership requires notification or a new certification (if the approved plan is changed)
to be submitted to the Division of Environmental Management within 60 days of a title transfer.
DEM USE ONLY:ACNEW#

i
`l
WASTE UTILIZATION PLAN
----------------------
Owners name --:DON LaCOE County:DUPLIN
Mail Address -:PINK HILL
Type of production unit ---- :FEED -FIN
Number of animal units-----: 4600
Type of waste facility ----- :Anaerobic Lagoon
Temporary storage period---: 180 days
Method of application ------ :IRRIGATION
Amount of animal waste produced-----------------: 8740 tons/year
Amount of plant available N produced by animals-: 10580 lbs./year
Commercial N to apply on planned acreage--------: 0 lbs./year
Your animal waste utilization plan has been specifically
developed for your swine operation. The plan is based on the
soil types, crops to be grown, and method of application for
your particular operation. The waste must be land applied at a
specified rate to prevent pollution of surface and/or ground
water. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. soil incorporation
of waste will conserve nutrients and reduce odor problems.

r
Page 2
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Annual acreage
requirements may be more or less based on the waste analysis
report for your waste management facility.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract
Field
Soil Crop
Yield
Lbs. N
Acres
Lbs. N
Month to
No.
No.
Type Code -
/Acre-_jUnit
Used
Apply
2238
2
ORANGEBC f
6
50.00
10.0
3000
MAR-OCT
2238
-2
MARVYN C
6
50.00
3.5
1050
MAR-OCT
2238
1
NORFOLKC 51
6.1
50.00
7.5
2287.5
MAR-OCT
2238
1
ORANGEBC >
6.3
50.00
10:0
3150
MAR-OCT
2238
1
MARVYN C
6
50.00
10.0
3000
MAR-OCT
-----
-----
---- -----
-----
----
J*-- -----48
------
Total
41.0
128
Available Nitrogen
(includes comme
10580
Surplus Or
Deficit -1908
Crop codes: Crop -unit
A=Barley-bu.
B=Bermudagrass(graze)-tons
C=Bermudagrass(hay)-tons
D=Corn(grain)-bu.
E=Corn(silage)-tons
F=Cotton-lbs. lint
G=Fescue(graze)-tons
H=Fescue(hay)-tons
I=Oats-bu.
J=Rye-bu.
K=Small grain(graze)-acre
L=Small grain(hay)-acre
M=Sorghum(grain)-cwt.
W=Wheat-bu.
Y=Fescue(pasture)-tons
Z=Bermudagrass(pasture)-tons

r
Page 3
If more commercial fertilizer is used than shown in this plan,
then additional acres of land may be needed. A three to fifteen
feet wide permanent grass filter strip should be seeded along all
ditches in fields that receive animal waste.
Additional comments:
F-,C('T1KC, OrAes AKD CROP =5 Macc -Ma.t A'bec*jAyr fbe FiF.Ro SISE. =m
ADornee( I F+eL.c M= Z MAY BE DJCQSSODOD 14rm SMALL Ct^tK -o -ALLOW
APPLtranow 9= MOTPaiFicm t'7ae," = WI(KTF- AMC E-CLY SPR(u6 =F
►y.EEDj;V • Srs S.)PPLf u(e.erA L Q IA�t . F EC • Z -t6. 2 - 5 Set.✓to 8 Y .0
8Y
R+ gxLaubae- %a �c5 C]�9 �OM\Sh�+�(tw(6•
Prepared by: Title: 6boer C^mwd Date: 2
iTJIG
Concurred in by: ' C)ai—� d A� Date: (O L 9 Producer
I understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1-day storm event. I also
certify that the waste will be applied on the land according to
this plan at the appropriate times and at rates that no runoff
occurs.
�C O� Date: (o Lb/9S�
Producer
Technical Specialist: 4Ll 6L j_ Q,,�_ Date: (016
(Copy to producer and copy to case file)

I i 1 1� 1 1\r1 '1 111 I •���
t.11 tl Iri i4 'III � it 1..1 i. I yl
J, r
�•
1� �,.1;
1
I�•,�
I 1
I
•.
I /
�l0�1'1 (
1 I��
.�111 I r !':JIB' 1
I
C IX

J E 1 rr urrl wlw' . 1 !a zi i:.e�' .:.��.
1
�A
1.^
. '�
!1
•
,r
�
'
to
7
i
�
n
g ,. � •
•�, '�
J .'
i 1 lE �
g
o
�
g� !
, ��
1
,11+
�, g

-.-DoKs Cclq FbR FARMVED
ANIMAL WASTE MANAGEMENT PLAN CERTIFICATION FOR UM W)OKl' SECEC
L�iSfr NCO TION
MAY 2 11996
Please return the completed form to the Division of Environmental Management at the address on the reverse side
of this form. Non -Discharge pWdt6n9
' Name of farm (Please
MT ©LIVE. ty .C. 28365 Phone No: 65e - 69 0 2
County: bopLIN
Farm location: Latitude and Longitude.,Wo 'ff-7-2�Coz.14"(required). Also, please attach a copy of county road
map with location identified.
Type of operation (swine, layer, dairy, etc.) : 5v41 N r
Design capacity (number of animals): 460o r=tn�suarrG
Average size of operation (12 month population avg.): 4.6o0
Average acreage needed for land application of waste (acres) 44
Technical Specialist Certification
As a technical specialist designated by the North Carolina Soil and Water Conservation Commission pursuant to
the 15A NCAC 6F .0005, I certify that the new or expanded animal waste management system as installed for the
farm named above has an animal waste management plan that meets the design, construction, operation and
maintenance standards and specifications of the Division of Environmental Management and the USDA -Soil
Conservation Service and/or the North Carolina Soil and Water Conservation Commission pursuant to 15A NCAC
2H.0217 and 15A NCAC 6F .0001-.0005. The following elements and their corresponding minimum criteria have
been verified by me or other designated technical specialists and are included in the plan as applicable: minimum
separations (buffers); liners or equivalent for lagoons or waste storage ponds; waste storage capacity; access or
ownership or proper waste application equipment; schedule for timing of applications; application rates; loading
rates; and the control of the discharge of pollutants from stormwater runoff events less severe than the 25-year,
24-hour storm.
Name of Technical Specialist (Please Print): llo mb L. 41020004
Affiliation: CAgPtLL!% rOOD5 . 7xc.
Address (Agency): P.o. bw %Aay- 65a , WAPSAVI, N.C. 2839$ Phone No.af/D Z93-34
-------------------------------------------
Owner/Manager Agreement
I (we) understand the operation and maintenance procedures established in the approved animal waste management
plan for the farm named above and will implement these procedures. I (we) know that any additional expansion
to the existing design capacity of the waste treatment and storage system or construction of new facilities will
require a new certification to be submitted to the Division of Environmental Management before the new animals
are stocked. I (we) also understand that there must be no discharge of animal waste from this system to surface
waters of the state either through a man-made conveyance or through runoff from a storm event less severe than
the 25-year, 24-hour storm. The approved plan will be filed at the farm and at the office of the local Soil and
Water Conservation District.
Name of
Name of Manager,if different from owner (Please print): '
Signature: Date:
Note: A change in land ownership requires notification or a new certification (if the approved plan is changed)
to be submitted to the Division of Environmental Management within 60 days of a title transfer.
DEM USE ONLY:ACNEW#

WASTE UTILIZATION PLAN
Owners name--:CJK FM/DON LACOE County:DUPLIN
Mail Address -:PINK HILL
Type of production unit ---- :FEED -FIN
Number of animal units-----: 4600
Type of waste facility ----- :Anaerobic Lagoon
Temporary storage period---: 180 days
Method of application ------ :IRRIGATION
Amount of animal waste produced-----------------: 8740 tons/year
Amount of plant available N produced by animals-: 10580 lbs./year
Commercial N to apply on planned acreage--------: 0 lbs./year
Your animal waste utilization plan has been specifically
developed for your swine operation. The plan is based on the
soil types, crops to be grown, and method of application for
your particular operation. The waste must be land applied at a
specified rate to prevent pollution of surface and/or ground
water. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before.each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Soil incorporation
of waste will conserve nutrients and reduce odor problems.

Page 2
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Annual acreage
requirements may be more or less based on the waste analysis
report for your waste management facility.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract
Field
Soil
Crop
Yield
Lbs. N
Acres
Lbs. N
Month to
No.
No.
Type
Code
/Acre
/Unit
Used
Apply
2238
11
MCC
B
5.1
50.00
3.5
892.5
MAR-OCT
2238
10
MCC
C
6
50.00
2.2
651
MAR-OCT
24G/ A
2238
A8
OrB
C
6.3
50.00
4.0
1244.2
MAR-OCT
31) / 1
2238
9
OrB
C
6.3
50.00
3.8
1209.6
MAR-OCT
3/g /�
2238
8
OrA
C
6.3
50.00
3.5
1115.1
MAR-OCT
3/q,
2238
A7
NoA
C
6.1
50.00
4.5
1372.5
MAR-OCT
365?1'9
2238
7
NoA
C
6.1
50.00
4.3
1317.6
MAR-OCT
30��
2238
6
NOA
C
6.1
50.00
3.8
1143.7
MAR-OCT
3 01/A
2238
2238
5
4
OrB
MCC
C
C
6.3
6
50.00
50.00
3.3
2.1
1033.2
615
MAR-OCT
MAR-OCT
3/3 ,
2'73
2238
3
OrB
C
6.3
50.00
3.2
1004.8
MAR-OCT
/ q
3 0//
2238
1
ORB
C
6.3
50.00
3.2
995.4
MAR-OCT
Total 45.2 13768
Available Nitrogen (includes commercial) 10580
Surplus Or Deficit -3188
Crop codes: Crop -unit
A=Barley-bu.
B=Bermudagrass(graze)-tons
C=Bermudagrass(hay)-tons
D=Corn(grain)-bu.
E=Corn(silage)-tons
F=Cotton-lbs. lint
G=Fescue(graze)-tons
H=Fescue(hay)-tons
I=Oats-bu.
J=Rye-bu.
K=Small grain(graze)-acre
L=Small grain(hay)-acre
M=Sorghum(grain)-cwt.
W=Wheat-bu.
Y=Fescue(pasture)-tons
Z=Bermudagrass(pasture)-tons

If more commercial fertilizer is used than shown in this plan,
then additional acres of land may be needed. A three to fifteen
feet wide permanent grass filter strip should be seeded along all
ditches in fields that receive animal waste.
Additional comments:
--------------------
PLAN REQL-seo To RE Ft_.Ec7- WeTmo AgZes F120M SRRIG.4'1om
QL.Ant.. FIGt� I�u�.nBEeS W�ERF JOC�n C(triN Ea I�AT-'E '
FI EL.D KR It Ls Zit SoLtD S H-r- -QzQ16ATI oat AU- FI ec.D
A2E SulTgacrm Fat SG pVe25EEf71NG I!-,. RAgeD. -rt+H9E Firc�>
WILL 3e Ro7A T-Eo . '
' I �ESOJR[ E
Prepared by: � OwA9Z Title: aD zE eukr Date:
Concurred in by: \VwJ/K r+Gc(St // (vQ Date:
Producer
I understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1-day storm event. I also
certify that the waste will be applied on the land according to
this plan at the appropriate times and at rates that no runoff
occurs.
(� �^ �` ✓J Date: �517
Producer
Technical specialist:rDate: 7
(Copy to producer and copy to case file)

J
a
t4
r

. . . il . ' efi'i.",IR
v"tzf"4F
;i '; 1 .41 4"
IF
IF, 1�;
gyy'I:W. I
I ',I IF.
A14!
Ik I .
.IF mill
fAillrt
I Wr le
Fit F1
j" A.Wlt 1.4 1 e) At 7
4. . I r
D-4
IF
14 92A 41
(A .
m

0
0.00
Plot of ■ll data for the ■urface:
Existing
Project:
Drawing: DON LACOE SPRAY FIELDS
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
by: using Sitswork

z
D I
0
C-)
ui
z
*0
9
MEM."m
0
T4
d

CARROLL'S FOODS, INC.
P. O. Drawer 856
WARSAW, NORTH CAROLINA 28398
FACILITY DESIGN AND
WASTE MANAGEMENT PLAN
FARM NAME OR NUMBER fact)E
FARM DESCRIPTION 3- a V-"NtgVi114 &
LOCATION s . k. l35 9
2�s�>>TA Nc' �7G C _Fl WIN1�191d ITV
COMPANY FARM 1\1 0
CONTRACT GROWER

TABLE OF CONTENTS
41clnity Map ............................................... 1
✓ASCS Field Map ............................................ 2
✓Soils Map ................................................. 3
CGSSoil InvestigationNorksheet .............................. 4
Aaste Treatment Plan ...................................... 5
Aaste Utilization Plan ........ 6
rbperation and Maintenance Plan 7
Xonstruction Specifications For Lagoon .................... 8
weeding Plan (Farm Site) .................................. 9
7mputer Drawing of Existing Ground .o............... ...10
eisting Elevations • .....11
lagoon Cross SectionDiagram .................. .........12
lomputer Drawing of Proposed .Lagoon .b. Building. Pad ......... 13
ite Balance Report .14
Computer Drawing - All Data - Proposed ....................15
vtomputer Drawing - Contour Lines ..........................16
.computer Drawing - Sloping Lines ..........................17
vComputer Drawing - Blov-up of Lagoon Corner ...............Is
NpBuilding Pad Elevations ..................................19
pqokComputer Cross Section - Existing -Proposed - Balanced ...20
,-facility Overlaid on Existing Topo Map ....................21

9 �
M
8 77177
I
w
Z
9
A
Ikk .
WLI-
i

}yy}f 1 � !+/��'YA�3l• +� I fl�� �i �l��j{�I � r 'i/i
tt �y. `.` / 7�. ilW 1•TI'ltr 1� l� •::��it��� + "J
11/. P i� Nir. ti ••.1 i.:.:

Operator:DON LACOE County: DUPLIN
Distance to nearest residence (other than owner):
1. STEADY STATE LIVE WEIGHT
Date: 10/05/92
0.0 feet
0
sows (farrow to finish) x
1417
lbs.
0
lbs
0
sows (farrow to feeder) x
522
lbs.
0
lbs
2640
head (finishing only) x
135
lbs. =
356400
lbs
0
sows (farrow to wean) x
433
lbs.
0
lbs
_
0
head (wean to feeder) x
30
lbs. =
0
lbs
TOTAL STEADY STATE LIVE
WEIGHT
(SSLW) =
356400
lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF
LAGOON
Volume = 356400 lbs. SSLW x Treatment
Volume(CF)/lb.
SSLW
Treatment Volume(CF)/lb. SSLW--
1 CF/lb. SSLW
Volume = 356400 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet ; "Owner requests no sludge storage.
Sludge will be removed as needed."
4. TOTAL DESIGN VOLUME
Inside top length 300.0 feet Inside top width 225.0 feet
Top of dike at elevation 50.6 feet
Freeboard 1.0 feet ; Side slopes 2.5 : 1 (Inside lagoon)
Total design lagoon liquid level at elevation 49.6 feet
Bottom of lagoon elevation 39.6 feet
Seasonal high water table elevation 0.0 feet
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
2.5 2.5 2.5 2.5 295.0 220.0 10.0
AREA OF TOP
LENGTH * WIDTH =
295.0 220.0
AREA OF BOTTOM
LENGTH * WIDTH =
245.0 170.0
64900.0 (AREA OF TOP)
41650.0 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
270.0 195.0 210600.0 (AREA OF MIDSECTION * 4)
CU. FT. = AAREA TOP + (4*AREA MIDSECTION) + AREA BOTTOMO * DEPTH/6
64900.0 210600.0 41650.0 1.7

v VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 528583 CU. FT.
5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
300.0 225.0 67500.0 square feet
-
Buildings (roof and lot water)
Length * Width =
0.0 0.0 0.0 square feet
TOTAL DA 67500.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced .
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume = 356400 Lbs. SSLW * CF of Waste/Lb./Day * 180 days
Volume = 87035 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a -flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 39375.0 cubic feet

5D. Volume of 25 year - 24 hour storm
Volume = 7.5 inches / 12 inches per foot * DA
Volume = 42187.5 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
SA.
87035
cubic
feet
5B.
0
cubic
feet
5C.
39375
cubic
feet
5D.
42188
cubic
feet
TOTAL 168598 cubic feet
6. SUMMARY
Total required volume 524998 cubic feet
Total design volume avail. 528583 cubic feet
Min. req. treatment volume plus sludge accumulation 356400 cubic feet
At elev. 46.8 feet ; Volume is 357933 cubic feet (end pumping)
Total design volume less 25yr-24hr storm is 486396 cubic feet
At elev. 48.8 feet ; Volume is 480629 cubic feet (start pumping)
Seasonalhighwater table elevation 0.0 feet
7. DESIGNED BY: APPROVED BY:
DATE:: ---- � - (3 q 1- DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN

WASTE UTILIZATION PLAN
Owners name --:DON LACOE County:DUPLIN
Mail Address-:RT2 BOX 83 MT. OLIVE 28365
Type of production unit ---- :FEED -FIN
Type of waste facility ----- :Anaerobic Lagoon
Your animal waste management facility has been designed for a
given storage capacity. When the waste reaches the designed
level, it must be land applied at a specified rate to prevent
pollution of surface and/or ground water. The plant nutrients
in the animal waste should be used to reduce the amount of
commercial fertilizer required for the crops on the fields
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Injecting the waste
or disking will conserve nutrients and reduce odor problems.
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Acreage
requirements may be more or less based on the waste analysis
report from your waste management facility.
The design of your waste management facility is based on the
following:

Amount of Waste Produced Per Year:
2640 animals x 1.9 tons waste/animal/yr= 5016 tons
total waste
Page 2
Amount of Plant Available Nitrogen Produced Per Year:
2640 animals x 2.30 lbs. N/animal/year = 6072 lbs./yr
Available N
Applying the above amount of waste is a big job. You should
plan time and have appropriate equipment to apply the waste in
a timely manner. Your facility is designed for 180 days of
storage. Therefore, it will need to be pumped every 6
months.
Tract
Field Soil
Crop Yield Lbs. N Acres
Lbs. N
Month to
No.
-----
No. Type
----- -----
Code Per Ac.
----- ----- ----- -----
Used
-----
Apply
------
T2238
2 OrB
4 5 Tons 275 27.5
7570.7
MAR-AUG
T2238
1 OrB
4 5 Tons 275 27.8
7642.2
MAR-AUG
-----
----- -----
----- ----- ----- -----
Total 55.3
-----
15213
------
Available Nitrogen
6072
Surplus Or Deficit
-9141
Crop codes: 1=Cereal grain; 2=Corn; 3=Fescue; 4=Range Gr. Bermuda
S=Control Grazed Bermuda; 6=Hayland Bermuda
Narrative of Operation:
Call the Soil and Water Conservation District Office after you
receive waste analysis report to obtain the amount per to
apply and the irrigation application rate prior to�AMnq
waste. rk U�j� ll jl�'jA
Prepared by: F �S•�M� 1 AC7I7a I d • �i= Q1L
Name ,�' Title Date
\ S
Concurred in by:�' `T —= /

OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment with minimum odor
control. The time required for the planned fluid level to be
reached may vary due to soil conditions,flushing operations, and
the amount of fresh water added to the system.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent runoff from the field or damage _
to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see Attachment B)
before land application.
3. Begin pump -out of the lagoon when fluid level reaches eleva-
tion 48.8 as marked by permanent markers. Stop pump -out when
the fluid level reaches elevation 46.8 or before fluid depth is
less than 6 feet deep (this prevents the loss of favorable
bacteria) .
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.4
inch per hour.
S. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
8. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

i•
SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
Clearing:
All trees and brush shall be removed from the construction area
before any excavating or fill is started. Stumps will be removed
within the area of the.foundation of the embankment and fill areas
and all excavated areas. All stumps and roots exceeding one (1)
inch in diameter shall be removed to a minimum depth of one (1)
foot. Satisfactory disposition will be made of all debris. The
foundation area shall be loosened thoroughly before placement of
embankment material.
Cut-off Trench:
A cut-off trench (when specified) shall be installed as.shown in
the plans.
Construction:
Construction of excavated and earthfill areas shall be performed to
the neat lines and grades as planned. Deviations from this will
require prior approval of the SCS. Earthfill shall not be placed
in standing water and reasonable compaction of the fills shall be
performed by the construction equipment or sheeps-foot roller during
placement. The embankment of the lagoon shall be installed using
the more impervious materials. Construction of fill heights shall
include ten (10) percent for settlement. To protect against seepage,
when areas of unsuitable material are encountered, they will need to
be excavated a minimum of one (1) foot below grade and backfilled and
compacted with a suitable material (ie-CL,SC,CH). Refer to the soils
investigation information in the plans for special considerations.
Precautions should be taken during construction to prevent excessive
erosion and sedimentation.
Vegetation:
All exposed embankment and other bare constructed areas shall be
seeded to the planned type of vegetation as soon as possible after
construction.

SEEDING RECOMMENDATIONS
AREA TO BE SEEDED: 2.0 ACRES
USE THE SEED MIXTURE INDICATED:
0 LBS. FESCUE GRASS S 60 LBS./ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 15 TO NOVEMBER 30
0 LBS. 'PENSACOLA' BAHIA GRASS S 60 LBS./ACRE
(SEE FOOTNOTE NO. 1)
SEEDING DATES: MARCH 15 TO JUNE 30
16 LBS. HULLED BERMUDA GRASS S 8 LBS./AC.
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
0 LBS. RYE GRAIN S 30 LBS./ACRE (NURSERY FOR FESCUE)
0 LBS. RYE GRASS S 40 LBS./ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
LBS.
APPLY THE FOLLOWING:
2000 LBS. OF 10-10-10 FERTILIZER (1000 LBS./ACRE)
4 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
200 BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED AREA IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A CULTIPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
1. PENSACOLA BAHIAGRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOMMENDED THAT 8
LBS./ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL BAHIAGRASS IS ESTABLISHED.

MJOms;TS BUTsn inq poisdsJd
SJO3swT;s9
SJsumO
SJssuT8u3
:048O PT9
SUOT;soOl
SJOgwnN
T 1HS SOUTMWJO
3OOtll NOO S300FOJd
Ni
sOs}ins quaw OE
0'02 SUOT;si
1101 JBM"
'27
'bC
'9b
'SV
'09
'29
T104USTJO

Daylight
Plot of all data for the surface:
Existing
Project: DON LACOE
Drawing: SHT i
Number:
Location:
Bid Data:
Engineer:
Owner:
Estimator:
Prepared by: using Sitswork
49.00
.30
42.50

cOKFINEVNENj
��1L�INC�
TOP 4 %
EL6V, 5ti O•% /
INVERT of pu'tLET
ELEV, qwlrd
T'jPII:WL vmw of A ONE
� Iq� o oN s��s7-Inn
PVLL K\A pESIC,N
BOTTOM Or SUM/.P
ELtV. -` - 14
To"m bt-slag
5t51K�t
ToELEV, y9•&8
y7, sLu Pa
K 30' I�
SUAAo_�
U TkrATIMF-NT /
LtA000N ID
De#tH
%oTTO'M ELEV.
INVERT 0r-
SErr�t-p TOP OP
So. DVKE EI6V.
,34'

Orientation: -46.0 Z Magnification: 14._3 Inclination: 20.0
Lower Left
7�t
3D Mesh Surface
Proposed
Projects DON LACOE
Drawing: SHT 1
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared by: using Sitework
30 Mash Surface

Surfaces:
Proposed
Existing
Cut:
Fill:
Tight Volumes
14'S54.93
6727.50
Difference: 7827.43
All volumes are in cubic yards.
Expansion (8)
0.00
20.00
Net Export:
Expanded Volumes
14554.93
8072.99
c aaa¢aaaasacaaaaaaaaaaacaaaaa
Grid cell size: 6.02 by 5.97
original scale: 100.00ft/in
a aaacaccaaaacaaaaaaaaaaccaaaa
Project: DON LACOE
Drawing: BHT 1
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
a caaa¢¢a¢caaea¢¢¢¢a¢aacaea¢a¢
Prepared by: using Sitework
¢aaaaaa¢¢aaaaaaa¢a¢¢¢aaaaaaaa
6481.94

Daylight
Plot of all data for the surface:
Proposed
Project: DON LACOE
Drawing: SHT i
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared by: using Sitawork
49.00
.30

Daylight
Plot of the contour data for the surfacs:
Proposed
Project: DON LACOE
Drawing: SHT 1
Number:
Location:
Bid Data:
Engineer:
Owner:
Estimator:
Prepared by: using Sitswork

Daylight
Plot of the sloping lines for the surface:
Proposed
Project: DON LACOE
Drawing: BHT 1
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared by: using Bitawork
49.00
'. 30

Nousts
Plot of the contour data for the surface:
Proposed
Project: DON LACOE
Drawing: SHT 1
Number:
Location:
Bid Data:
Engineer:
Owner:
Estimator:
Prspared by: using Sitswork

♦ - ., .. .'? r 'S - n
WE
gym. i's�
�'�-
it-
------------- -
)perator---=>Don
LaCoe
ounty5-
)ate =_ __________________________===>08/17L95:
)ist. to.nearest residenceCother than owner):
1606 £tt -.
aowe (farrow to
sows.CfarTow
lead (finishing only). _____________________>
1960
>ows (farrow to wean .----------------------
lead (wean to feeder):=====================->
1ve. Live Weight for other operations(lbs.):>
3torage volume for sludge accum. (cu. £t.):=>
treatment Volume (min. 1 cu. ft./lb.):======> 1..0 �d
?5 Year - 24 Hour Rainfall (in.):==_________> 7.5 a
?ainfall in excess of evaporation (in.)=====> 7.0 41P
)rainage area of buildings 8 lots (sq. ft.):>
/olume of wash water (gallons/day)==========>
temporary storage period (days):============> 90
'reeboard
aide elopes (inside lagoon):================> 2.5 1
Inside top length <ft.):____________________> 190
Inside top width (£t.):_____________________> 168.5
"op of dike elevation (£t.):________________> 48
3ottom of lagoon elevation (ft.>:==_________> 30.5
Seasonal high water table(SHWT) elev.(ft.):=>
'otal required volume:=============> '335593 cu. ft.
actual design volume:==============>299320.31 cu. ft.
Stop pumping el. (> or = to 0.0
ft SHWT>
ft.
(> or = to 36.5
ft Min)
tequired m4nimum treatment volume:
264600
cu.
ft.
Folume at stop pumping elevation:
-62913
cu.
ft.
Start pumping elev.:________________________>
ft.
rolume at start pumping elevation:
-62913
cu.
ft.
lctual volume less 25yr-24hr rain:
279311
cu.
ft.
COTE: Verify that temp. storage is adequate:
Req. volume to be pumped:====>
50984
cu.
ft.
Actual volume to be pumped:==>
0
cu.
ft.

4,
"p,
Ok
, If
I p.
V
.
. . . . . . . . . . . . . . . . .
...............
. . . . . . . . . . . . . . . . . . . .

jU n(_EN� =�Y Tc QLanl
WASTE UTILIZATION PLAN
owners name --:DON LACOE County:
Mail Address-: 0
Type of production unit ---- :FEED -FIN
Number of animal units-----: 4600
Type of waste facility ----- :Anaerobic Lagoon
Temporary storage period---: 180 days
Method of application ------ :IRRIGATION
Amount of animal waste produced-----------------: 8740 tons/year
Amount of plant available N produced by animals-: 10580 lbs./year
Commercial N to apply on planned acreage--------: 0 lbs./year
Your animal waste utilization plan has been specifically
developed for your swine operation. The plan is based on the
soil types, crops to be grown, and method of application for
your particular operation. The waste must be land applied at a
specified rate to prevent pollution of surface and/or ground
water. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Soil incorporation
of waste will conserve nutrients and reduce odor problems.

a
Page 2
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Annual acreage
requirements may be more or less based on the waste analysis
report for your waste management facility.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract
Field
Soil Crop
Yield
Lbs. N
Acres
Lbs. N
Month to
No.
No.
Type Code
/Acre
/Unit
Used
Apply
2238
2
ORANGEBC
6
50.00
10.0
3000
MAR-OCT
2238
1
MARVYN C
6
50.00
10.0
3000
MAR-OCT
2238
1
ORANG C
6.3
50.00
10.0
3150
MAR-OCT
2238
1
NOR C
6.1
50.00
7.5
2287.5
MAR-OCT
Available Nitrogen
Crop codes: Crop -unit
----- -----
Total 37.5
(includes commercial)
Surplus Or Deficit
A=Barley-bu.
B=Bermudagrass(graze)-tons
C=Bermudagrass(hay)-tons
D=Corn(grain)-bu.
E=Corn(silage)-tons
F=Cotton-lbs. lint
G=Fescue(graze)-tons
H=Fescue(hay)-tons
11438
10580
-858
I=Oats-bu.
J=Rye-bu.
K=Small grain(graze)-acre
L=Small grain(hay)-acre
M=Sorghum(grain)-cwt.
W=Wheat-bu.
Y=Fescue(pasture)-tons
Z=Bermudagrass(pasture)-tons

Page 3
If more commercial fertilizer is used than shown in this plan,
then additional acres of land may be needed. A three to fifteen
feet wide permanent grass filter strip should be seeded along all
ditches in fields that receive animal waste.
Additional comments:
--------------------
�zr o r —t � z ( a�r�x s.s Acl cam a� �SE�
Prepared by: �d.�/ �. Title: •(QHS• Date: 16 IZII) _Cqc
�/ ct,Pocl's
Concurred in by: �t Lc 1 lea Date: /�7 Z6/9S
Pro ucer
I understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1-day storm event. I also
certify that the waste will be applied on the land according to
this plan at the appropriate times and at rates that no runoff
occurs.
,mil Lk-c' Dater
Producer
Technical Specialist: L Date:
(Copy to producer and copy to case file)