160001_HISTORICAL_20171231

'o 7WS
NORTH CAROLINA
Department of Environmental Quality

Appendix 1. Lagoon Sludge Survey Form Revised August 2008
A. Farm Permit or DWQ Identification Numbe 16-1 Carterette Co.
B. Lagoon Identification #1
C. Person(s)Taking Measurements Sam Edwards _ Edward Stephens �EP �U Z
D. Date of Measurement 8/9/2017
E. Methods/Devices Used for Measurement of:
a. Distance from the lagoon liquid surface to the top of the sludge layer.
b. Distance from the lagoon liquid surface to the bottom(soil)of the lagoon.
Sludge Boat
c.Thickness of the sludge layer if making a direct measurement with"core sampler".
NIA
F. Lagoon Surface Area(using dimensions at inside top of bank): (acres)
(Draw a sketch of the lagoon on a separate sheet, list dimensions, and calculate surface area. The lagoon
may have been built different than designed,so measurements should be made.)
G. Estimate number of sampling points:
a. Less than 1.33 acres: Use 8 points
b. It more than 1.33 ac. acres x 6= with maximum of 24.
(Using sketch and dimensions,develop a uniform grid that has the same number of intersections as the
estimated number of sampling points needed.Number the intersection points on the lagoon grid so that data
recorded at each can be easily matched.)
H. Conduct sludge survey and record data on"Sludge Survey Data Sheet"(Appendix 2). Also,at the
location of the pump intake,take measurements of distance from liquid surface to top of sludge
layer and record it on the Data Sheet(last row);this must be at least 2.5 ft.when irrigating.
I.At the time of the surrey,also measure the distance from the Maximum Liquid Level to the Present Liquid
Level(measure at the lagoon gauge pole): 2.5
J. Determine the distance from the top of bank to the Maximum Liquid Level 1.6
(use lagoon management plan or other lagoon records)
K. Determine the distance from the Maximum Liquid to the Minimum Liquid level: 3.6
(use lagoon management plan or other lagoon records)
L. Calculate the distance from the present liquid surface level to the Minimum Liquid Level 1.1
(Item K Minus Item I,assuming the present liquid level is below the Maximum Liquid Level)
M. Record from the Sludge Surrey Data Sheet the distance from the present liquid surface level to the
lagoon bottom(average for all the measurement points) 6.0
N. Record from the Sludge Survey Data Sheet the distance from the present liquid surface level to the top
of the sludge layer(average for all the measurement points): 5.0
O. Record from the Sludge Survey Data Sheet the average thickness of the sludge layer: 1.0
P. Calculate the thickness of the existing Liquid Treatment Zone(item N minus Item L): 3.9
Q. If Item O is greater than Item P, proceed to the Worksheet for Sludge Volume and Treatment Volume.
If Item O is equal to or less than Item P,you do not have to determine volumes.
Completed by: Sam Edwards Date: 8/9/2017
Print Name/Signature

Appendix 2. Sludge Survey Data Sheet* Revised August 2008
Lagoon Identification_16-1
Completed by: Sam Edwards Date: 8/9/2017
Print Name Signature
(A) (B) (C) (C)-(B)
Grid Point Distance from liquid surface Distance from liquid surface Thickness of sludge layer
No. to top of stud a to lagoon bottom{soil)
Ft. &in. Ft.(tenths) Ft. &in. Ft.(tenths), Ft. &in. Ft. (tenths)
1 0.0 0.0 0.0
2 0.0 0.0 0.0
3 0.0 0.0 0.0
4 0.0 0.0 0.0
5 0.0 0.0 0.0
6 0.0 0.0 0.0
7 0.0 0.0 0.0
8 0.0 0.0 0.0
9 0.0 0.0 0.0
10 0.0 0.0 0.0
11 0.0 0.0 0.0
12 0.0 0.0 0.0
13 0.0 0.0 0.0
14 0.0 0.0 0.0
15 0.0 0.0 0.0
16 0.0 0.0 0.0
17 0.0 0.0 0.0
18 0.0 0.0 0.0
19 0.0 0.0 0.0
20 0.0 0.0 0.0
21 0.0 0.0 0.0
22 0.0 0.0 0.0
23 0.0 0.0 0.0
24 0.0 0.0 0.0
Number of points with readings X X X X
Average of X X 0.0 X X 0.0 X X 0.0
Dints
At pump X X X X X X
intake
*All Grid Points and corresponding sludge layer thicknesses must be shown on a sketch attached to this
Sludge Survey Data Sheet.
Appendix 3.Worksheet for sludge volume and treatment volume Revised August 2008

The average thickness of the sludge layer and the thickness of the existing liquid(sludge-free)treatment zone are determined
from the information on the Lagoon Sludge Survey Form (Items O and P, respectively). In this example,the average sludge
layer thickness is 2.5 feet and the existing liquid treatment zone is 3.5 feet. If the lagoon has a designed sludge storage volume,
see notes at end of the worksheet- The dimensions of the lagoon as measured and the side slope are needed
for calculations of sludge volume and of total treatment volume. If the lagoon is a standard geometric shape,the sludge
volume and the treatment volume in the lagoon can be estimated by using standard equations. For approximate volumes
of rectangular lagoons with constant side slope,calculate length and width at the midpoint of the layer,and multiply by layer
thickness to calculate layer volume, as shown in the example. For irregular shapes,convert the total surface area to a square
or rectangular shape. For exact volumes for lagoons with constant side slope,the"Prismoidal Equations"may be used.
Example Your Lagoon
I.Average sludge Layer Thickness(T) 2.5 ft. 1.0 ft.
2.Depth of the lagoon from top of bank to bottom soil surface(D) 11 ft. 10.0 %
3.Slope=Horizontal/vertical side slope(S) 3 3.0
4. Length at the top of inside bank(L) 457 ft. 430.0 ft.
5.Width at top inside slope(W) 229 ft. 145.0 ft.
6. Length at midpoint of sludge layer L,,=L-2S(D-(T/2)) 398.5 ft. 373.0 ft.
7.Width at midpoint of sludge layer W,„=W-2S(D-(T/2)) 170.5 ft_ 88.0 ft.
8.Volume of sludge(Vs) Vs=Lm Wm T 169,860 ft3 32,824 ft3
9.Volume in gallons:Vs,=V*7.5 gal.tft3. 1,273,950 gal. 246,180 gal.
10.Thickness of existing liquid tmt.zone(Y) 3.5 ft 3.9 ft
11.Thickness of total treatment zone(Z) Z=T+Y 6 ft 4.9 ft
12. Length at midpoint of total tmt.zone Lz=L-2(S)(D-(Z/2) 409 ft. 384.7 ft.
13.Width at midpoint of total tmt.Zone W Z =W 2(S)(D-(Z12) 181 ft. 99.7 ft.
14.Volume of total treatment zone(Vz) Vz=Lz Wz Z 444,174 ft3 187,937 ft3
15. Ratio(R)of sludge layer volume to total Treatment Volume
R=Vs/Vz 0.38 0.17
If the ratio R exceeds 0.50,than a sludge Plan of Action may be required. Check with DWQ for information
on filing the Plan of Action.
Note: If the lagoon has a designed sludge storage volume(DSSV),subtract that volume from both the volume
of sludge(Vs)(Item 8)and from the volume of total treatment zone(Vz) (Item 14),and take the ratio.
Then, R=(Vs-DSSV)I(Vz-DSSV)
Example: If DSSV=86,000 ft3,then R=(169,860-85,000)1(444,174-85,000) =84,860/359,174=0.24.
16. Design sludge storage volume(DSSV) 85,000 0
17. Ratio(R)of sludge layer volume to treatment volume adjusted
for designed sludge storage volume 0.24 0.17

Powell, David C
From: Todd Kelly <[e-mail]>
Sent: Thursday,August 10, 2017 3:33 PM
To: Powell, David C
Subject: Re: 16-1
My address is 303 College Circle Morehead City NC 28557 . Thanks!
From: Powell, David C<[e-mail]>
Sent:Thursday,August 10, 2017 3:27:36 PM
To:Todd Kelly
Subject: RE: 16-1
Hey, Kristin has got you a copy of all files in our records. Please make a second set and send or give to Mr.Joyce. What
is the best address to send these too? Please make sure that he knows he will need these records next year for
inspection as well as keep freeboard and 1 inch rainfall and that he needs to walk and inspect his lagoon wall each of
those rain events. Thanks for your assistance and we will forward you sludge survey info when we have it.
Thanks
David Powell, Environmental Specialist
North Carolina Department of Environmental Quality
Division of Water Resources
Water Quality Regional Operations Section
Wilmington Regional Office
127 Cardinal Drive Extension
Wilmington,NC 28405-3845
Tel.[phone]
Fax[phone]
For any emergency which requires immediate reporting after normal business hours,contact 1-800-858-0368.
E-mail correspondence to and from this address may be subject to the North Carolina Public Records Law and
may be disclosed to third parties.
Disclaimer: The content of this message and all attachments are subject to NC Public Record Law. According to
the law all information except the property of a private individual is considered public record and subject to
disclosure upon request to third parties without prior notification. if you are not the intended recipient of this
message contact the sender immediately and delete the message from your files. Thank you for your
cooperation.
1

RECEIVED/NCDENR/I WT MCCRORY
Governor
E PPNO 'I 2�16VAN DER VAART
Secretary
Wc1ter-Re.sources Water Quality R4giJAY ZIMMERMAN
ENVIRONMENTAL QUALITY'
Operations Section
Wilmington Region-,I! �ttice
August 30, 2016
Robert and Dorothy Joyce Combined Trust
Joyce Hog Farm
383 Cyros Pollard Rd
Newport,NC 28570
Re: Renewal of the Expired Permit
Permit No.: AWI160001
Carteret County
Dear Robert and Dorothy Joyce Combined Trust:
Your facility was approved for operation under one of the Animal Waste Operation Individual Non-
Discharge Permits,which expired on 10/31/2014. Our records indicate that the Division has not received
from you a completed renewal application form to date. In order to maintain coverage under the current
Permit,please complete one of the following actions:
I. Please indicate if your facility is depopulated and the lagoon(s)or storage pond(s) at your facility
have been properly closed according to the NRCS standards. In that case,you may send us a written
request to rescind this permit by submitting a completed Lagoon &Waste Storage Pond Closure
Form. A blank copy of the form can be found at:
htip://deg.nc.gov/about/divisions/water-resources/water-resources-permits/wastewater-branch/animal-
feedin -o eration- ermits/ ortin -forms
2. Please submit a renewal application form that must be completed, signed and returned to this office.
Please include two(2) copies of your most recent Waste Utilization Plan along with the field maps, if
your facility is still active.
The renewal application form for the State or NPDES Individual Permit for Existing Operations can be
found at:
http://deg.ne.gov/about/divi sions/water-resources/water-resources-permits/wastewater-branch/animal_
feedin -o eration- ermits/a lications
3_ If you are a cattle facility that has gone below the threshold animal numbers(< 100), you may request
the rescission of your permit provided if the average size of the confined cattle herd at the cattle facility,
calculated on an annual basis during the three years prior to the request for rescission, is Iess than one
hundred confined cattle.
Please submit the requested information within thirty(30) days of receipt of this letter to the following
address:
NCDENR DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh,North Carolina 27699-1636
Telephone number: [phone]
Continued...
State oTNorth Carolina I Environmental Quality I Water Resources
1636 Marl service Center I Raleigh,North Carolina 27699-1636
919 807 6464

Failure to request renewal of your coverage under a permit within the time period specified may result in a
civil penalty. Operation of your facility without coverage under a valid permit would constitute a violation
of NCGS 143-215.1 and could result in assessments of civil penalties of up to$25,000 per day.
If you have any questions about this request,please feel free to contact me at 919-807-6341.
Sincerely,
J. R. Joshi, Soil Scientist
Animal Feeding Operations Program
cc. Wilmington Regional Office,Water Quality Regional Operations Section
Carteret County Soil and Water Conservation District
WQROS Unit Central Files-AWI1 60001

I�
This site has a Zero Pig Permit. Due to no more Waste will be entering this farms Lagoon,the current
WUP will be altered by this Narrative. Currently,the Bermuda in the original WUP dated 1/24/1997 has
a Nitrogen Rate of 305#on Bermuda Nay. Grower may Graze these Bermuda Fields using a Nitrogen
Rate of 228.75#/ac.This is a 25% reduction from the original WUP.This has been agreed upon by DWR
and DSWC on 6/26/2014. Grower can continue to use the 50# Nitrogen Rate on the Small Grain
overseed.
DWR—
DSWC- s�.-- `' 64' �l`�

ANIMAL WASTE UTILIZATION FLAN
1'fhif''hfhihih]hillf'rhi?'fl'fhl!'i J'1h1'!'fi�PfP�PlhfPflfh]Pff'1P7h]h1l'7r°7Pfl'7hfTyhfhfhf/'fhfMhfPrP1/+1h1Pfl'1l'fhfhfl'fPfhfhfPll'fPfl'fT'�hfhlhfr:'Aih'i�'7r'i
Producer : Ri BERT F' . JOYC:E
Location: 383 C:YRUS POLLARD ROAD
NEW1=ORT NC 25570
Telephone : 919 -2';_3-F,460 , -
Type Operation : Existing Farrow to Wean I i ng Swine
Number of Animals: 621 .00 saws
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
R.ECEI�TED
APPLICATION METHOD: Irrigation
APR a 3 aag
The washy from your animal fac i I i ty must be land EnnP I i ed at a
specified rate to prevent po I I lit I on of surf ace: water an U
groundwater .. The p i ant nutrients in the animal waste should be used
to reduce the amount of commercial fert I I I zer required for the crops
in the fields where the waste is to be applied .
This waste ut i l i za.t i an plan uses nitrogen as the limiting nutrient .
Waste should be analyzed before each app l i cat i can cyc I e . Annual sa i i
tests are strongly encouraged so that all plant nutrients can be
balanced for real i st i c yields of the crop to be grown .
Several factors are important in implementing your waste ut i l i zat i din
plan in order- to hax i m i e the fer-t i t ii zer value of the waste and to
ensure that it is ia.pp l i ed in an environmentally safe manner :
. 1 . Always app i y waste based on the needs of the crop to be
grown and the nutrient content of the waste . Do not aRl_, l y
more ni i:r ogen than the crop can uti I i ;,e .
Soil2. types are important as they have different i of i l tr;a.t i un
rates , leaching potentials , cation dxchange capacities , and
available water hoiding capacities .
. Normally waste shalt be apt, t i ed to land eroding at less than
5 tons per acre per year . Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate f i l ter-
strips are established .
4. Do not apply waste on saturated soils , when it is raining ,
or when the surface is frozen . Either of these conditions
may result in runoff to surface waters which is not al lowea
under DEM regulations .
RECEIVED I DENR I DWQ
AQDIFrR'pR0 TF('Tl0N SECTION
ADD it I )nnn

r foil rr'rrrrrr'rru'rr'rr+rnvruvr'rr'rr'+rrr'rr'rrrr'rr'rr'r+'+rrr'rr'rr'rr'rr'r1'rrrr'rrWWII rrrrvrvrrr'u'rr'rr'tr'rr'rr'rr'r,r'rr'rr'rr'u'rr'rr'rr'rrrr'r1'rrrrrrvrrrr',1 Nrr;
Page : 1
ANIMAL WASTE; UTILIZATION PLAN
rrrr,�rrrrrr�rrrrr�rrrrrrrrrrrirrrt•rrrrrrrr-r�rrrrr�rrrrrrirrrrrrrirrrrrr�rrrrrrrrrrirrrrrrrrrrrrrrrrrrr�rrrrrrtr�rrrrr�rrr�rrrrr�rt rrrrrrrrrrr
.I
5. Wing] conditions should also be. considered to avoid drift and t
downwind odor problems .
6. To maximize the va i uL of the nutrients for crop production
and to reduce the potential for pollution , the waste should
be app l i ed to a growing crop or app l i ed not more than 3121
days pr- i or to planting a crop or forages breaking dormancy.
injecting the waste or disking wi I l conserve nutrients and
reduce odor" probleMS .
This plan is based on the waste application method shown above . if
YOU choose to change methods in the future , you need to revise this
plan . Nutrient levels for different application methods are not the
same .
The estimated acres needed to apply the animal waste is based or,
typical nutrient content for this type of facility . Acreage
requirements should be based on the waste analysis report from your
waste management fiat i l i ty. In some cases you may want to have plant
analysis made , which could allow additional waste to be applied .
Provisions s ha l l be made for the area ve c e i v i ng waste to be flexible
so as to accommodate changing waste analysis content and crop type .
: Lime must be applied to maintain pH in the optimum range for specific
crop production .
This waste ut i l i zat i on p I an , if carried out , fleets the requirements
for comp i i a.nce w i tf1 15.!S iCr;.s.. 2H .021 adopted by the i__n°: i ronmen ta i
' Management c('miii i ss i r:n .-
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, f t?, tons , etc . )
821 sows x 6. 1 tens waste/sows/year = 5008. 1 tiros
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
821 sows x 5.4 i Cis PAN/sows/year .. 4430.4 I bs . PAN/year-
Applying the above amount of waste is a big job . You should plan time anci
have appropriate equipment to apply the waste in a timely manner .
The fo l lowing acreage will be needed for waste app l i cation based on thE,,
crop to be grown , ` o i l type and surface a.pp i i cat iln .

Page .
- a .
ANIMAL. WASTE UTILIZATION PLAN
i i t s
^?llr1,'rhi�irirjijpl.'j;7,t? 7 it'1fIIrSf?tit7n!''jF?F�tfFF'if�ITtFI�7!'tt'?;'It?'71'll°1P?r''lr�rrr�rrrrf�r�rrrr�'lhlr''?r''?1.11i!!t°Th�hfP7f'i`f'?1'7^i:''7P7r^ii'r
TABLE 1 : ACRES OWNED BY PRODUCER
i 1=.AE=l --I F I EI-G I -_96I OIL & CLAS :C=�'.F� - 1 Y I ELD -H T-1 CC�lrlirl-h1 ►E* 3 L ;S_.____
DETERMINING PHASE MODE 1 AN N : PER : ACRES ! AW N �
1 l
1 PER AC : AC: I USED
1 1 ' ------ 1 1 1 tl r 1 ' _- ---- -
1 1 1 1 --
I APPLY 1 1 1 ICES I D. 1 1 APPL.I;C
f 1
: METH : 1 1 N ] : TIME
1 1 1 ! 1 1 1 !
------ 1 ------- 1 ---- 1 -----
; I No I--; )=H : 6. 1 : 305 10 112.5 : 381 _. 5
--._.._...-----------------.._-----------_._-__--------___._.- --__._.___......._....
i 1 11 1 1 1 1 i SI P T—MAF..'
—.-»_...._-_.•-----------..........--.--.—......-..--.. ---.--_--'---^- --------............_.....---.---.....—...-.»...»... -- '"_-----'--- .
1 END
TOTAL 1443 0_,
Indicates that this field is being ,_lverseeded ( i . e . i rater p i anted) or-
winter- annuals follow summer- annuals .
iNIOTE: The applicator is cautioned that P and i•'-. may be over applied wh i i e
meeting the N requirements . in- the future , regulations may require
farmers in some darts of North Carolina to have a nutrient management:
plan that addresses all nutrients . This plan only addresses nitrogen .

rIr•r.r rr rl rr rl rl.r rr rr llrllrlr 11 iffl ff ff ff ff ff!llrlf 11 11 lllflflrll r1 rl 11 if 111111111111111f Il 111!lf 11 I1f Il lr lr rl lr lr lr 111l rr r1 rl rl rill r
Page . _
ANIMAL- WASTE UTILIZATION iN PLAN
"r+`rrr rrrrrrrrirrri,�:flat;'rr'r:'•rPfPrrrrrrrrrr�rfhrrrryt�r;•r;�r•�f°i'!'!P rr,rrrrrrrrrrr•rrrrrlrrlrl rf7PirPrP�!•�hlt rt rf 1f�trlrrrhrrrrrrrrrrrrrrrrrrrrrrrrrr,
TABLE "». ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached . )
(Required only if operator- dues not town adequate land .
See required specification 2. )
)
_ _------_..__- -------�----_-----------_.....---------•-----___--___.�____------------_---_--.__..
I�RACT 1 F I Ei.-D 1 SOIL TYPE CLASS- ! CROP ! YIELD , LBS ! COMM M N : ** l * LB S
DETERMINING PHASE : CODE 1 i AW N 1 PER i ACRES i AW N
1 1 l : PER AC 1 AC: 1 1 USED
1 I 1 1 1 4
1 1 1APPLYI 1 1RESID. 1 I APPLI
: METH 1 1 I N 1 TIME
I 1 1 4 4 ,1 1 1 1 , I
1
, 1 I f
1 E.�l.t I I 1 I 4 1 4
I 4 t i 1 1
I I I ! 1 I 1 I
.-__._--_-_--_.......-•----•-_-._.-....... --"--'-"'-_......---.«»«.--.-----'-----'--__.......«.--..-'- -------- --.-_«..............«.....«»...._.»...-----------------'--.- -_...
Ti_3TAL i 0
Indicates that tnis f i e i d is oe I ng overseeded ( I . e . i nterp l anted ) or
annuals f,fit l i ow summer- annua I s .
in i nter p i anted fields ( i . e . =ma i I ;brain , etc , i nterseeded
in ber-frudaarass) , forage must be removed through grazing ,
hay and/or s i l age . Wher-e. gr-az i ng , plants should be grazed
when they reach a height of six to nine inches . Cattle
,should be removed when plants are grazed to a height of four
inches . In f i e I ds where small grain , etc , is to be removed
for hay or s i I age , care should be exercised not to let small
grain to reach mathrity, especially late in the season ( i . e .
Apr- i l or May) . Shading may result if sma l i grain gets too
high and this will definitely interfere with stand of
hermudagrass . This loss of stand will result in reduced
yields and less nitrogen being ut i l i zed . Father than
cutting sma 1 l gr-a i n for hay or s i I age ,just before heading as
is the normal situation , you are- encouraged to Cut the sma I I
groin ear .i I e-r . You may want to consider harvesting hay or
s i l age two of three times during the season , depending or,
time small grain is planted in the fall .
The i dew time to interplant s I
small a. grain , etc , is late
S4?l:,tember" or early October .. Dr i l l i ng is recommended over
broadcasting . Ber-mudagras 1 should be grazed f_4r" mowed to a
height of about two inches before dr- i i i i ng for best results .
Acreage figures may emceed total acreage i n• fie 1 ds due to overseel_I i ng .

rrvr•eI'rru•rr'rrrr-n-Lrvrrr-Ir/r'it'rrrrrr'rrrr'rrrr`!r•rr-n'rrrrr'rru•rrvrrr'Irrr'rr'rr-rrvrrrL1•rruvI,II'rru'rrrr-rr-It'u'rrrrrr'rrr I'd rrr'n,rrrrrr'IrIIII'IrLI'I er;
Page . 4
ANIMAL WASTE UTILIZATION FLAN
rrr rrrrrrrrrl��rPl PIt rl'rhl Pf r�rrrrrrrrrlrrrrr,�lrrrrr�rr.F.rrrrrrirrrrrrrrr�lrrrrrrrrrrrlrlrrrrrrrrrrrrrrrrrfrf�lrfMAfl'rlrAfMP7 i7 rrr'�rrir'�ir"ir/r"T r"r'
I bs AW N ( arl : m,a. I waste n i tr-=_r3en i equa Is tot i requ i red r, i tr-r_kgen I ess
any cornrnor(. i a l n i t r_Igen (C:f'Mh1 N) sl.lpp i i e d .
..I..he fo I i ow i r)'� i c-;jen:l explains the {_r^k_ki-' G I„kde s Used in tables 1 and aI_I4'de
C-R, rv, -------------- - .--.....----------1.7N I_f5___.__..... PE R, UN:i i-
I
k I ;
R 11) k _ � GRtSS_ Ai ' il 1r 5.QY
C.-i "A.i N i AC•
I
I I
i k I
1 AND Z
-A"'ES - -- - l TBS-i—AW -N- USED___!
I
-------------------
I I 1
I !
I k I
I I 1
1 I
This r)umber- must be less than rlr equal to 0 in corder to
fui iy Lit I ize the animai waste N produced .

I I i f l I I f F!!f l f l!f!!i f:!:f!f:l!i!!I!l i!1!r f l f l f!l l 11!I f f!f i f f u r l!!!I f.f:i I r f f f r r l r l I r I f r f r,l r r f l l f I f f 11 r f•!f f f f f f.f l•r f r..r r.r r.r,••••..,,.,
Page : 5
ANIMAL WASTE UTILIZATION FLAN
f°ir rrrrrrrrrrrrr,RrrrrrrrrrPrArf rPrrrhrl rr rrrrrrrrrrrrrrrrr?'rhlf rr'rPrhrrrrrrrrrf�rrrf�rrrrrrrrrrrrrf�rrrrrrrr rrrrrrrrrrrrrrrrrrrrrrrrrrrr t�,rr^r
I..hl 15 r:.Lsrnrler" rnl.1 i, i-1e i esc trIari CIr egUa. I to 9_f i n order tofL4I I '� UL I I 1
r
the an i ma i 'a,I,'c�to NS p r 0dUCry1.I .
Acres shown in each of the prec:ed i rl,j tables are CI_frls i der Pd to be the Usarr I r-
acres excluding requ i rels bL1f ferS , r i I ter Strips a I C'n,3 d i tcheS , Odd areas
Unable t�. tie irrigated , and perimeter areas neat r e c e i v i n9 f u I I app t i c at i on
rates duce to equ i prlent I i mi tat i ones . A,ctua I total acres in the f i e I ds
i i steel mays , and most i i In-P I wi I I be , mclre than the acres shown I rl the
tables .
See attic hed map `itow I n,=f the i' i e i ris tc, op used f or the Ut i I i zat i -:or, I,-If
it rl i ffi a I w as t e T'
SLUDGE .AF'r='L I, AT I l_IN :
]-he waste Ut i 1 i zat i +an p i an must cCInt_I. 1 rr prIav i s i :frIs f or per I od I c i and
aF,p I i c at i c.n ICIf s I uf:1,3e at a,jI'" -i"tCIrfi I C i'31:t.•.s The s 11.1d3e 14 i i 1 be nUtr- i e n t
i Ch and w I I I re,-_1 u i rF, p r e c a u t i ona.r-y rneasures tG prevent IIVer" app I I C clt I iir'f
of nut r" i erlts C+r C,ther e k ern ents Your pr CId Lict i it rl f a c i I i ty w i I I produce
a p p r ox i rnate I y 722. 8. p0Urlds laf p I ant ava i I a I e n i trogen per year i rl the
1 u d'3 e .
1.f you remove the S'I Ud',3e eVLjf-y yii ars , you wi I I have app'rox irna.te Vy ti;: 1 _. 4
p+aUnds of FAN to Lit i I i ze . As MUm i n3 you app I y th i s FAN to hybr i d
bermudagrass hay i and at the rate of 300 pourids of n i tragen per a.cr-e , you
w i 1 1 need 1' .6%941:_;:=;_;:_;:_;:_;:; acres of I and If YOU apply the S i udge to corn at
the rate I_If 1.c.5 pC+1.lri.1s C+f n i trClgen per acre , y,:IU wI I I need 2 D'.-P9 acres
1„If Ia.nd i=' I ;_ase i_I�:= al.,f_:-re that these a.. Ian ! y estimates I.I_f the PAN arid
I cs.rl1l riE:s 11eI- , s c t u a i r e q u i rei•llents c.C, 1I Ci V ar ry by 5% depend-i rig C+n y1jUr
s I U f7--1w:i s 1-e i L n-_-i. i 'f'?.. _ s so I i I t_V I-$ r e a l i s t I c y i e I x_1 s , a n d i p p 1 1 f=at 1 =f I"I
rn r:i t:h --1
AFFL:I:i:::.+' TICiN OF WASTE DY IRRIGATION
Ttie i rr i ;3at i rlrr a.pp i i cat i on rate should not exceed the i rtta.k:e rate of the
ICI I i at the t i me 1:1f i t"r" i °�i7.t I Cln SUCri that rUrlClff ICIr- pifn+.I I rl C+CCUY"5 . fh I
r'a.te i 5 1 ! rn I tell by i n I t I a I so i I rno I store CLlnterlt , so I I structure , so I i
t.E.?xture , water 6 r o p I P..t s i ze , and o r g a ro i c sc, I i ,ls . The app I I cat i on arnC-Urlt
sh.-,U '1 d rrrit exceed the a.vai I ab I e water- ho I d i ng capacity r_If the so i I at the
I rnf.? <,.F I r'I'' I '."Ia.t 1 on rlC,r` S iII_,L1 i ,I th.E• p 1 el.ri'G ava i I a I e n I tr- erl a E:: cf:'e'cl
i t ,3 '.'n i i e 6 s t i i{.1 c r !I'f ,
:L f silr"f a c e ,Ia t i ri i s the r;Irw-•th C.d co I and ailp I i cat i on f!-Ir" th i s Vf i arl ,
it i s the resp,_-,ris i b i I i ty of th:e �Ir-r,IJLlt:er" aril i rr" i 9 a t i on des i 9rler- to ensi_1re
that ar! i rr i gii.t i Cirs i•yc tern i s i rssta 1 i eCl t1_I pr!iper I i rr i ,=ate the acres
IZ hi r,w ri I n T a.b I e s 1 a.n d f_ Fa 1 I Lire •r,n li rl p r y t hI 4? r[?t~ rl fri fn a r,Cie d rates a rI d

„ ,''",°",""”fill l it It IVIO'W,,"",'m,,,"",,,,,,It'll"",,,nn,"n`mn"`^",m"",v",n,"`,,.,",""',,
. . . Page : 6
. .
. .
ANIMAL WASTE UTILIZATION PLAN
wnnr��mnrm»mn�w��mry,n������r/m���MM�/��/MMM8��MMrM
amounts of nitrogen shown in the tab | es may make this plan invalid .
The following table is provided as a guide for establishing application
rates and amounts .
________________________________________________________________________________
| | | | | App | ication Rate | Appl \ c ' Amount |
;Tract | Field | Soil Type | Crop | ( in/hr ) | ( inches ) |
| ---------------- | __________ | ___-----ow------ | __________________ �
| 346 | 1 | NoD | BH | . 24 | *1 . 30 �
| ------ | ....... | ---------------- | ---------- | ---------------- | __________________�
1346 | ~1 | | SG | | * |
| ------ | ------- | _--------------- | ----------- | ---------------- | __________________ �
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied . in many situations , the application amount shown cannot
be applied because of the nitroqen limitation . The maximum
app | ication amount shown can be appiied under optimum soil
conditions .
;our facility is designed for 180.00 days of temporary storage and the
temporary storage must be removed on the average of once every 6.00 months .
In no instance should tr/e volume of tNe waste be stored in your stracture
ne within the 25 year 24 hour storm storage or 6ne foot of freeboard excePt
in the event of the 25 year 24 hour storm.
It / s the responsibility of the producer and waste applicator to ensure
that the spreader equipment is operated properly to apply the correct ratws
to the acres shown in Tables 1 and 2. Failure to apply the recommended
rates and amounts of nitrogen shown in the tables may make this p | an
inva | \ d .
Call your technica ! specialist after you receive the waste analysis reporr
for assistance in determining the amount of waste per acre and the proper
app \ icatio^ rate prior to applying the waste . . .
^
NAR��TIVE_OF_OP�RATION
. '

1!I f 11 1 f 11////I/e/I/I f r/••I••. ...
Page : 7
WASTE UTILIZATION�N FLAN
r'?hlf'r!'r,^rI^Yhrr'if"ill,"lP�P,hl,r1-r rprr'1.'rr!!fhihlIll Ill ll!'?hrlft7h7r7hlr'iF7hihilrfihfhrhrfrhrhr,'rhihr,"rhrlr!rPr,"1hrf^rl+rhrf'irrr`r,"rr"rr"r+' r'
1. . Animal waste shalt not; reach surface waters of the Mate by
runoff . pair i f+: , rilarirnad_e� conveyances , +� I r"eC'+ �.�:+�+ l I cat I =+n , +:+r-
direct discharge dur- Ing operation or land application . Any
discharge of waste which reaches surface water" is prohibited .
2. There rrra+st be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste . If the producer does
not own adequate land to properly dispose of waste , he/she '_il"sa l i
provide a copy of an agreement with a landowner who is within a
reasonable pr om i m i ty , allowing him/her the use of the land for
waste app l i cation . It is the responsibility of the owner" of the
facility to secure an update of the Waste Ut i 1 i aat i fin Plan when
There is a change in the operation , Increase in the number of
animal < , method of ut i I ization , or ava. i iable? land .
. Animal waste shall be applied to meet , but not emceed , the
nitrogen needs for real i st i s crop yields based on so I l type ,
available moisture , historical data. , climatic conditions , and
level of management , un i ess there are regulations that restrict
the rate of app l i c_at i on for other- nutrients .
mil•. Animal w=s.c;te sha. l 1 be :aI" p l i ed to land eroding less than F tons-,
per acre per year . Waste may be %3.pp l i ed to land that is eroding
at: 5 or more tons , but less than 10 tons per acre per year
providing grass filter strips are i nst;a l led where runoff leaves
the field . (Seep Fi;,,t-TG S tGanclard 39:. -Filter Strip )
5 . Odor's can be reduced by injecting the waste or disking after
waste app I i cgat i on . Waste should not be applied when there is
danger of drift from the irrigation field .
6. When animal waste is to be app l i ed on acres subject to
f l ood i ng , it will be so I l incorporated on conventionally t i l l ei-I
cropland . When applied to conservation t i l i ed crops or
grassland , the w%a+wtto may I.++:: broadcast provided the a.pp l i c.at i on
does not occur- during a season prone to flooding . (See "Weather
ana Climate in Worth M.':.iro l i na" for guidance . )
r' . Liquid waste '_shall be, app i i ed at rates rig»It to exceed the so i l
I of i l t<rat: I on rate such that runoff does not occur offsite or to
surface waters and in a. method which does not cause drift from
the site during at" p l i c_'a.t i n . No pond i ng should occur- in order
to control odor or f I ie. r., .
. Animal waste sha l l not be al1p l i eij to saturated si+ i l s , during
r a i nfa l l events , or when the surface is frozen .
eyn .
9 . Animal waste shall be applied on actively growing crops in suer,
a. manner that: they crop its not covered with waste to a. depth that
would inhibit growth . The potential for salt damage from animai
waste should also he considered .

r'!r"IrN'II'II'Yrlr-L!'Ir'uY+'11'!I'1!'f1'r1'N'f!'!!'r r'r r!!'u'f+'1+v rr+Y+v r'r+'+r rr'rr rI it it it Ir++r+vr rI r+rr'IrII I+'f1'r+Ir rrr+1,u,,it 1,rr a r,re rr,r rr rr a,r
WASTE UTILI2ATIt1N PLAN
rrr'lriririrrPrrrrrrrf rftrl'rri!•rf'rfrrrrrrrAf,'•fPiryrrrrf lrrrrlfrifrrrrrPrPrrrrrrirrlrI'irrrrlrrrlrrrrrrrr•rI°rI'•rr7rrrrrlrrrrffr°fr'rPil rfl,^i�r i
REQU I FED SF'FC I F I CAT I C.NS
ICci 1.4aste nutr- i ents s ha I I nett be app i i ed i rl fa I I or winter f CIr
sp1' I r,'j 111 ante,? crops ,re sio I i s w i th, a h, 1 h pC+tent I a I f,_,r
I each i r, . Waste nuts i e:nt I oad i n0 rates on these s,., i I s shc1u 1 d t,e
h,eId t,, ii minimum and a st_ritable winter cover crop r, Ia.ntt•_d t
ta.r:e up re I eaGsed r,utr i entT, . Vlasrte sria. 1 I not Lie app I i ed more
than, 30 days pr- i 1+r t,_, r, 1 ar,t i rr9 _,-P the t_r-r,I; r,r fnra9es hreaFc i r1'l
,_I,_,r•mar,cy.
i 1 Any new `v.- ! r'Ie -Pzi3c I I I ty 5 I ted or, or =.f ter- Cictober 1. , 199!_5 sha. i `1
coraV, Iy WitI-I the fC, I IciwII`, a : ThC CIuter perImet43r" i,f the Ia,rl,:J art::a.
C,rlto wh, I ch waste i r ap,p I I P. frr_,rn a. I aq c,on that i s a Comp„_,nV. nt of
a swine farm sh,a l I be at i east 50 Feet; from arty res i dent i al
F,rapQrty b :,Lln11ziry and frora ally pererinial strearn or river ( ,_,trier
tha.n a,n i rr i Sat i „n d i tc h !Lr- C arra k . An i ma I waste other: thart
sw i rl.e -4asite frc,m f a c i k i t l Ps si I t e d c,n i,r after" I_ictC,t,er- 1 , 199 5 ,
shall not tie app i i ed closer than '2_15 feet to r,erenn i al waters .
(See Star,,_Iard = . _ - I= i I ter- St r- i Fps
1 c_. S`t i rn<�. I ���a c.'k:ra r,a, i l n,��L ' -j=, , I I @,7 C 1 ��,5 B r- t I`I e r, �.S�fl�I fee t t C,
wel ks .
�. An i ni`c,. 1 wa.stt s1-Ia I I not e a p P 1 ! e;d c 1 oser than ','CMD feet of
J W I I i ,, 0t 1-1 n I t;h r,n t I, h,r 1-
1.4 . Nia.StF:• -ha : i i",e n a mar',rter• n,: t: t,:, teach .,ther F,rc.pe rty
a n a 1.1 1 i r_ 1- i ; 1-1 t .,f a.y 5
15. An imal waste shai I not ne J i schar-,aed into surface waters ,
,ora l nageways , or wet I ands by a d I scharge or by ,aver--spray i r,,3 .
An S ma I 4!ets' te may L,e app I i ed tco pr" i iir ccmnverted c r c.p I acid p r o v S rjeri
they Have been appr ved as, a land app l i cat i or, site by a
'tEChnicaI F,PeU. ic1- 1 i s t " . Animal waste shall ncit be a;;pi led ,}r,
r-aizsC,:j yJater"ways tl-I at ,� I Sl:1,-c - if's ,� l r`ect I y i r,ton water CCrr.It-seta ,
and on other- -ra sed waterways waste* sha I I be app I i ed at
air-!_,rt1:1rnr C r'ate5 S rt a manri er th at causes no rurtc.ff ,jr dr i ft f1"Crn
the s
11 I>oine t i C' a.no i rtdUc1,:!' i D. I Wa 'TP fr- rn wash,+,Wr, fclC A s t i
shCiWerS . 1; i let s , S, inI•:s , e'!. ._ sh,aI I r1C. h I,e disCr,ared iIItr,
a r, i ri+1, I w ai.5 t f.'. frl a r i cl.
17* . A j,r`,:,tect i v e cover Cif I`'C,1 1'' S a e v e g e t a t ion wi l l be
e s t a b I I shG'.,.i c%r, a. l 'I ,_I i Gturine,.i ;7,.r eas ( I agoc,n embankrnents , C,errn� ,
I., 11`1P runs , etc . ) . Art-.'as s h a i i L,e fence-1 , as necessary , tc,
r,r-c.t;•:ct t;r1e vex_eta.t i „n . Ve e t a t i nn such as treks , shrui,,,s , Ft.n,_I
r,t h e r ,,JoC,=7'y spl?C i es r et:t: . , a.r'f? i i rn i ted t0 ar-ea5 where C0 Hs �' e r��,ii 3
cl.pprnpr i atc! L...ag,',,:,n areas sI` cju I d be kept m,-_+wed arld a c c es s l.r, I e .
1�errris ano tructurt Should be in5petted re;4ular- Iy f r e-YiderI C t~.
f er 05 i C,r, , I f:FLka•je Cir" d I S(-1"1ar,Ie .

r rr rr rrnro rrn rr rr r rr r rr a cr rr rr rr It rr I I I I I u u u It rrurrn.rrr.I I I.r.r rr rr rr rr r r r r r r r r r r rr u r r r r rr r r r r I u I I r r If r/II I.
WASTE UTILIZATION PLAN
rrrrrrr�r.hfrr,�rrrrrEr;•rrrrrrrtrrrrrrr�rfrr•rrrrr��rrt��rrr�^rrrrrr•rrrrrrrrrrrrrrrrr�•rrrri�r�rrrrrrrrrrrrrrrrrrrrr�rrrri�r,�rrrrrr�rrrrrr�irrrrr
RE+=!UIEI]_._aF' C_�t=ICATI+DNS
18. If an i ma I production at tne facility is to be suspended Dr
terminated , -I':he owner is reEpGnr i b l e for obtaining and
p ssibi l ity of an i i iegaI discharge , pol Iut ion and erosion .
19. Waste ha.nd I i ng structures ,es , piping , pumps , ree i s , etc . , shoo l ci
be inspected n a regular basis to prevent breakdowns , leaks ,
and spi I i =.s . A. regular- maintenance checklist should be kept on
s i t e .
20. Animal waste can be used in a rotation that includes vegetab i e?�s
sand other crops for direct human consumption . However" , if
animal Waste is used on crops for direct human consumption it
should only be app l i ed pr"ep l ant with no further applications of
animal waste during the crop season .
21 . H i `3h l y visible markers ^sha l I be installed to mark: the top ancl
bottom elevations of the temporary storage ( pumping volume ) of
ail waste treatment Moons . Pumping shall be managed to
maintain the I i qu I r_l l e:?ve l between the markers . A marker w i l i
the l=�rs required '��:� mark s s e maximum storage volume f o r waste
storage ponds .
s .
M. Waste sha, i t be tested within 60 days of ut; I I I s a.t; i ._rn and sr_s i t
:`si' a l l be tested at least annually at Crop sites where waste
products are a"r e I i ed Nitrogen shall be the rate - determining
e l ei1 ent . Zinc and copper l eve i s in the sr_r i l s sha I l be
monitored and alternative crop sites sha l l be used When the
rflti:'I=ai s approach excessive l eve l s . pH shall be adjusted for
optimum crop production and maintained . Sr_r i l and waste
analysis records shall be kept for five years . Poultry dry
waste app i ; c at i on records sna I l be maintained for three ( 3)
years . Waster app I i c»at I n records for all other waste shall be
maintained for five (5) ''years .
23. Dead animals will be disposed of in a manner that meets North
Carol i na requ I a3t i ons .

5 '
ANIMAL WANE i..IT I 1-I%AT I ON PLAN
;'rrtrrl'i,'•frrl'r!•r";�1,`•rArr°rl'rlr!•1 Sri•r,'rl�l=rfrl•J,'•11•r,'"lfr11!'•7��rI•rl•r'•F"•r,'rhr,'•rI•rPrlrhrr�rr,°fPr,°rrrrtirr''rArlr!•rr'•rrrl'rr'rr'•r!•it'i!'r;•r!•ff°r!•ir�7;' 1•!•,
WASTE UTILIZATION PLAN AGREEMENT
Name --rf Farm: .;(_Y('.:1:=.
Owrier/Mana3er Agreernent
I we irr,ders sand and w i i 1 fr. I I ow and i mar I erner,t the Spec i f i cat i ons,
and tl"ie cr},era.t I r_,r! and rna l n t e n a n c e 1:'r-----Cedures esta.b 1 1 shed i r, the
A r"C,Vf?-1 a1-! i 1Y)a I Waste LA i I i t I con I ar, for- t1- e farrn r!arned a ,ve 1.
(we ) i<:+!c,l:J that any expa.n5 i c+n tGr trip existing design Caprac i ty r:'f t1-!e
waste treatment- arid G>tcrrage sy5tern or constrUCtiirn of flew
f-.cI l ities wi 11 require a r!ew C('?rtifIeatiori tr_r rre submitt1'.d t,"r tI-!p
North C:a.rcr I i n a D i v i s i r:'ri crf F1__riv i r-,.,r!rne n t a I Managernant (NC:1)EM) 1=ref.r_rre+
the new anirna 1 s are stack-.od .. I (we ) a s', +.Anderstand that there
rf-1UFtt be r!c, d i sc h a r g e "'I` an i ma I waste frori-i th i s systern to SU[-faCe
�, storm�ter- f the state fron-i a event less severe than the ::'`__,
c
yC...,ar , ., 1-!0ur storm The plan will be f i led on-site a1
the farrn c.fficc- and at the office of the local SoiI and l4ater
Co1.-!c:ear-vat I i_iri 1.1 i :;tr" 1 C:a- and w i I 1 L.'e a`da i I a I e fr_rr rE•'v i E:'w by NCDI:::M
!-A i_r.j 1"! l' 1.1 a::-t - -
Name of Far_ i 1 i ty i 1wr,er : R1=BERT P. .. OYCE
(Please..... 'r„ ir_rt )
S i griatur"e Date
Name of Manager- ( If different from wrier )
S i 3natrrr e : _� --�_ Date :
Name of Person Pr-epar i n3 P k an : ....._..(l' I ease .F!r� i rid ),lames N. Fields
A f f i I i at i r.rn :C:raven SWC:D Phone No 919-6-:37--'Z547
Address (Agency) : :=02 IridListr- i ai Dr- .
New Bern NC:: '. !m5,S2
,Si3riature : �1 .�` _ -. _ Date : --

2=�
NCDENR
North Carolina Department of Environment and Natural Resources
Pat McCrory I John E. Skvada, III
Governor ECEIVE Secretary
November 21,2014 NOV 2 5 2014
Robert and Dorothy Joyce Combined Trust i
Joyce Hog Farm BY.
383 Cyros Pollard Rd
Newport,NC 28570
Re: Renewal of the Expired permit
Permit No.: AWI160001
Carteret County
Dear Robert and Dorothy Joyce Combined Trust:
Your facility was approved for operation under one of the Animal Waste Operation Individual Non-
Discharge Permits,which expired on 10/31/2014. Our records indicate that the Division has not received
a completed renewal application form from your facility to date. In order to maintain coverage under the
current Permit, please complete one of the following actions:
l. Please indicate if your facility is depopulated and the lagoon(s)or storage pond(s)at your facility
have been properly closed according to the NRCS standards. In that case, you may send us a request
to rescind this permit by submitting a completed and the permit is rescinded.A blank Lagoon&
Waste Storage Pond Closure Form can be found at: http:////l2ortal.ncdenr.or weblwq/aps/afo/report
2. Please submit a renewal application form that must be completed, signed and returned to DWR. The
application form for the State or NPDES Individual Permit for Existing Operations can be found at:
http://p,ortal.ncdenr.orWweb/wqlaps/afo/anps. Please include two (2) copies of your most recent
Waste Utilization Plan along with the field maps, if your facility is still active.
3. If you are a cattle facility4hat has gone below the threshold animal numbers(< 100), you may request
the rescission of your permit provided if the average size of the confined cattle herd at the cattle
facility, calculated on an annual basis during the three years prior to the request for rescission, is less
than one hundred confined cattle.
Please submit the requested information within thirty(30)days of receipt of this letter to the following
address:
NCDENR—DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh,North Carolina 27699-1636
Telephone number: [phone]
r
Continued...
1636 Mail Service Center,Raleigh,North Carolina 27699-1636
Phone:[phone] Internet: htto:/lwww.ilcdenr.gov!
An Equal Opportunity 1 Affirmative Aciion Employer—Made in part by recycled paper

Failure to request renewal of your coverage under a permit within the time period specified may result in
a civil penalty. Operation of your facility without coverage under a valid permit would constitute a
violation of NCGS 143-215.1 and could result in assessments of civil penalties of up to S25,000 per day.
If you have any questions about this request, please feel free to contact the Animal Feeding Operations
Program staff at 919-807-6464.
Sincerely,
J. R. loshi, Soil Scientist
Animal Feeding Operations and Ground
Water Protection Branch
Water Quality Regional Operations Section
Division of Water Resources, NCDENR
Enclosures
cc (w/o enclosures): Wilmington Regional Office, Water Quality Regional Operations Section
Carteret County Soil and Water Conservation District
WQROS Unit Central Files-AWI160001

NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
November 24, 2009
Robert and Dorothy Joyce Combined Trust
Joyce Hog Farm
383 Cyrus Pollard Rd.
Newport,NC 28570
Subject: Permit No.AW1160001
Joyce Hog Farm
Animal Waste Management System
Carteret County
Dear Richard Joyce:
In accordance with your application received November 16, 2009,we are hereby forwarding to you this
Permit issued to Robert and Dorothy Joyce Combined Trustauthorizing the operation of the subject
animal waste management system.You had indicated the animal population at this facility to be zero
until such time as the waste storage lagoon at this facility is properly closed.
This approval shall consist of the operation of this system including, but not limited to,the management
of animal waste structures on the Joyce Hog Farm,with an annual capacity of no greater than an annual
average of zero (0) Swine.
The Permit shall be effective from the date of issuance until October 31, 2014 and replaces the COC No.
AWS240041 issued to this facility previously. You are subject to the conditions of this permit until the
closure of all waste storage basins and the rescission of this permit. You must submit a letter to the
Division of Water Quality to request rescission of the Permit by providing documentation of closure of all
containment basins.
The issuance.of this Permit does not excuse the Permittee from the obligation to comply with all
applicable laws,rules, standards, and ordinances(local, state, or federal)nor convey any property rights
in either real or personal property.
Per 15A NCAC 2T. 0111(c), a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards, f IV
shall be maintained between water supply wells and any lagoon, storage pond, or ``""
spray field. DEC 0 3 2009
Please be advised that any violation of the terms and conditions specified in this rt may result in
revocation of this Permit or penalties in accordance with NCGS 143-215.6A thro� - ,
Clean Water Act,and 40 CFR 122.41, including civil penalties, criminal penalties, _ e relief
0 030
1636 Mail service Center,Raleigh,North Carolina 27699-1636
Location: 9-73 Capital FAX:Raleigh,North Carolina r Ser C ��1�
Phone:[phone] FAX:[phone]$$1 Customer Service:1-877-023-6746
Internet:wwnv.npnraterquality.org Naturally
'j�1����//�,
An Equa€Opportunity V Affirmative Action Employer ��/ ` L`J

r
If you wish to continue the activity permitted under this Permit after the expiration date of this Permit,an
application for renewal must be filed at least 180 days prior to expiration.
This Permit is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
This facility is located in a county covered by our Wilmington Regional Office.The Regional Office
Aquifer Protection Staff may be reached at(910)796-7215. If you need additional information
concerning this Permit, please contact the Animal Feeding Operations Unit staff at(919)733-3221.
Sincerely,
for Coleen H. Sullins
cc: Carteret County Health Department
Carteret County Soil and Water Conservation District
Wilmington Regional Office, Aquifer Protection Section
Notebook File AWI160001
Permit File AWI160001

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
INDIVIDUAL SWINE ANIMAL WASTE MANAGEMENT SYSTEM PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina as
amended, and other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
Robert and Dorothy Joyce Combined Trust
Carteret County
FOR THE
continued operation and maintenance of an animal waste management system for the Joyce Hog Farm,
located in Carteret County, consisting of zero(0) Swine and the application to land as specified in the
FaciIity's Certified.Animal Waste Management Plan (CAWMP).
This permit shall be effective from the date of issuance until October 31,2014 and shall be subject to the
following specified conditions and limitations:
I. PERFORMANCE STANDARDS
1. The animal waste management system operated under this Permit shall be effectively
maintained and operated as a non-discharge system to prevent the discharge of pollutants
to surface waters,wetlands, or ditches. Application of waste to terraces and grassed
waterways is acceptable as long as it is applied in accordance with Natural Resources
Conservation Service(MRCS) Standards and does not result in a discharge of waste to
surface waters, wetlands, or ditches. If the Facility has a discharge of waste that reaches
surface waters or wetlands resulting from a storm event more severe than a 25-year, 24-
hour storm, it will not be considered to be in violation of this Permit, as long as the
Facility is in compliance with its CAWMP and this Permit.
2. No discharge of waste shall result in a violation of the water quality standards established
for receiving waters as per Title I5A, Subchapter 213, Section .0200 of the North Carolina
Administrative Code (NCAC)and Title 15A, Subchapter 2L of the NCAC.
3. The facility's CAWMP is hereby incorporated by reference into this Permit. The
CAWMP must be consistent with all applicable laws, rules,ordinances, and standards
(federal, state and local)in effect at the time of siting,design, and certification of the
Facility.
4. Any proposed increase or modification to the annual average that exceeds the thresholds
set by North Carolina General Statues (NCGS) l 43;215.l 013(1)will require a
modification to the CAWMP and the Permit prior to modification of the Facility.

5. Animal waste shall not be applied within one hundred (100)feet of any well,with the
exception of monitoring wells. The allowable distance to monitoring wells shall be
established on a case-by-case basis by the Division.
H. OPERATION AND MAINTENANCE REQUIREMENTS
I. The collection, treatment,and storage facilities, and the land application equipment and
fields shall be properly operated properly and maintained at all times.
2. A vegetative cover shall be maintained as specified in the Facility's CAWMP on all land
application fields and buffers in accordance with the CAWMP. No waste shall be
applied upon areas not included in the CAWMP.
3. Soil pH on all land application fields must be maintained in the optimum range for crop
production.
4. Land application rates shall be in accordance with the CAWMP. In no case shall land
application rates exceed the agronomic rate of the nutrient of concern for the receiving
crop. In no case shall land application rates result in excessive ponding or any runoff
during any given application event.
5. If manure or sludges are applied on conventionally tilled,bare soil, the waste shall be
incorporated into the soil within two (2)days after application on the land. This
requirement does not apply to no-till fields,pastures, or fields where crops are actively
growing.
6. Pesticides,toxic chemicals,and petroleum products shall not be disposed of•in the animal
waste management system.
7. Domestic and/or industrial wastewater from showers toilets sinks etc.shall not be
discharged into the animal waste management system. Washdown of stock trailers
owned by and used to transport animals to and from the Facility only will be permissible
as long as the system has been evaluated and approved to accommodate the additional
volume. Only those cleaning agents and soaps that are EPA-approved according to their
labels,will not harm the cover crop, and will not contravene the groundwater standards
listed in 15A NCAC 2L may be utilized in the Facility covered by this Permit.
Instruction labels are to be followed when using cleaning agents and soaps.
8. Disposal of dead animals resulting from normal mortality rates associated with the
Facility shall be done in accordance with the.Facility's CAWMP and the North Carolina ,
Department of Agriculture and Consumer Services(NCDA&CS)Veterinary Division's
statutes and regulations.
9. Unless accounted for in temporary storage volume,all uncontaminated runoff from the
surrounding property and buildings shall be diverted away from the waste
lagoons/storage ponds to prevent any unnecessary addition to the liquid volume in the
structures.

10. A protective, vegetative cover shall be established and maintained on all earthen
lagoon/storage pond embankments (outside toe of embankment to maximum pumping
elevation), berms, pipe runs, and diversions to surface waters'or wetlands. Trees, shrubs,
and other woody vegetation shall not be allowed to grow on the lagoon/storage pond
embankments. All trees shall be removed in accordance with good engineering practices.
Lagoon/storage pond areas shall be accessible, and vegetation shall be kept mowed.
IL At the time of sludge removal from a lagoon/storage pond, the sludge must be managed
in accordance with the CAWMP. When removal of sludge from the lagoon is necessary,
provisions must be taken to prevent damage to the lagoon dikes and liner.
12. Lagoons/storage ponds shall be kept free of foreign debris including, but not limited to,
tires, bottles, light bulbs, gloves, syringes or any other solid waste.
13. The Facility must have at least one of the following items at all times: (a)adequate
animal waste application and handling equipment, (b) a lease, or other written agreement,
for the use of the necessary equipment, or(c)a contract with a third party applicator
capable of providing adequate waste application.
14. No wasteshall be applied in wind conditions that might reasonably be expected to cause
the mist to reach surface waters or wetlands.
is. The Permittee shall maintain buffer strips or other equivalent practices as specified in the
Facility's CAWMP near feedlots, manure storage areas, and land application areas.
16. Waste shall not be applied on land that is flooded, saturated with water, frozen, or snow
covered at the time of land application.
17. Land application of waste is prohibited during precipitation events. The Permittee shall
consider pending weather conditions in making the decision to land apply waste.
18. Land application activities shall cease on any application site that exceeds a Mehlich 3
Soil Test Index for Copper of greater than 3,000(108 pounds per acre)or Zinc of greater
than 3,000(213 pounds per acre).
19. Any major structural repairs to lagoons/storage ponds must have written documentation
from a technical specialist certifying proper design and installation. However, if a piece
of equipment is being-replaced with a piece of equipment of the identical specifications,
no technical specialist approval is necessary[i.e'.piping,reels,valves,pumps(if the
gallons per minute(gpm)capacity is not being increased or decreased), etc.] unless the
replacement involves disturbing the lagoon/storage pond embankment.
III. MONITORING AND REPORTING REQUIREMENTS
1. An inspection of the animal waste collection,treatment, and storage structures, and
runoff control measures shall be conducted and documented at a frequency to insure
proper operation For example, lagoons/storage ponds,and other structures should be
inspected for evidence of erosion, leakage, damage by animals or discharge.

2. Highly visible waste-level gauges shall be maintained to mark the level of waste in each
lagoon/storage pond that does not gravity feed through a free flowing transfer pipe into a
subsequent structure. The gauge shall have readily visible permanent markings'. The
waste level in each lagoon with a waste level gauge shall be monitored and recorded
weekly on forms supplied by, or approved by,the Division.
3. A representative Standard Soil Fertility Analysis, including pH, phosphorus, copper, and
zinc, shall be conducted on each application field receiving animal waste at least every
three(3)years. An analysis of the animal waste shall be conducted in accordance with
recommended laboratory sampling procedures as close to the time of application as
practical and at.least within sixty (60)days(before or after)of the date of application.
This analysis shall include the following parameters:
Nitrogen Zinc
Phosphorus Copper
4. The Permittee shall record all irrigation and land application event(s) including hydraulic
loading rates, nutrient loading rates and cropping information.The Permittee shall also
record removal of solids and document nutrient loading rates if disposed on-site or record
the off-site location(s). These records must be on forms supplied by, or approved by,the
Division.
5. If, for any reason,there is a discharge from the animal waste management system
(including the land application sites), to surface waters or wetlands,the Permittee is
required to make notification in accordance with Condition III. 4. The discharge
notification shall include the following information:
a. Description of the discharge: A description of the discharge including an estimate of
the volume discharged, a description of the flow path to the receiving surface waters
or wetlands and a site sketch showing the path of the waste. Also, an estimation of
the volume discharged.
b. Time of the discharge: The length of time of the discharge, including the exact dates
and times that it started and stopped, and if not stopped,the anticipated time the
discharge is expected to continue.
c. Cause of the discharge: A detailed statement of the cause of the discharge. If caused
by a precipitation event,detailed information from the on-site rain gauge concerning
the inches and duration of the precipitation event.
d. All steps being taken to reduce, stop and cleanup the discharge. All steps to be taken
to prevent future discharges from the same cause.
e. Analysis of the waste: A copy of the last waste analysis conducted as required by
Condition III. 3.
6. A copy of this Permit, the Facility's permit, certification forms, lessee and landowner
agreements, the CAWMP, and copies of all records required by this Permit and the
Facility's CAWMP shall be maintained by the Permittee in chronological and legible
form for a minimum of three(3)years.

7. Within fifteen (15)working days of receiving the request from the Division,the
Permittee shall provide to the Division one(1)copy of all requested information and
reports related to the operation of the animal waste management system. Once received
by the Division, all such information and reports become public information,unless they
constitute confidential information under North Carolina General Statutes(NCGS) 132-
1.2, and shall be made available to the public by the Division as specified in Chapter 132
of the NCGS.
8. The Division may require any additional monitoring and reporting(including but not
limited to groundwater, surface water or wetland,waste, sludge, soil, lagoon/storage pond
levels and plant tissue)necessary to determine the source, quantity, quality, and effect of
such waste upon the surface waters, groundwaters or wetlands. Such monitoring,
including its scope, frequency, duration and any sampling, testing, and reporting systems,
shall meet all applicable Division requirements.
9. Regional Notification:
The Permittee shall report by telephone to the appropriate Division Regional Office as
soon as possible, but in no case more than twenty-four(24)hours following first
knowledge of the occurrence of any of the following events:
a. Any discharge to ditches, surface waters or wetlands.
b. Failure to maintain storage capacity in a lagoon/storage pond greater than or
equal to that required in Condition V. 2. of this Permit.
C. Over applying waste either in excess of the limits set out in the CAWMP or
where runoff enters surface waters or wetlands.
d. Failure of any component of the animal waste management system resulting in a
discharge to surface waters or wetlands.
e. Any failure of the animal waste management system that renders the Facility
incapable of adequately receiving,treating or storing the waste and/or sludge.
f. Any deterioration or leak in a lagoon/storage pond that poses an immediate threat
to the environment or human safety or health.
For any emergency, which requires immediate reporting after normal business hours,
contact must be made with the Division of Emergency Management at 1-800-858-0368.
The Permittee shall also file a written report to the appropriate Division Regional Office
within five (5)calendar days following first knowledge of the occurrence. This report
shall outline the actions taken or proposed to be taken to correct the problem and to
ensure that the problem does not recur. The requirement to file a written report may not
be waived by the Division Regional Office.

IV. INSPECTIONS AND ENTRY
I. The Permittee shall allow any authorized representative of Department, upon the
presentation of credentials and other documents as may be required by law and in
accordance with reasonable and appropriate biosecurity measures,to:
a. Enter the Permittee's premises where the regulated Facility or activity is located or
conducted, or where records must be kept under the conditions of this Permit;
b. Have access to and copy, at reasonable times,any records that must be kept under the
conditions of this Permit;
c. Inspect,, at reasonable times any facilities, equipment (including monitoring and
control equipment), practices, or operations regulated or required under this Permit;
and,
d. Sample or monitor, at reasonable times, for the purpose of assuring permit
compliance, any substances or parameters at any location.
V. GENERAL CONDITIONS
I. The issuance of this Permit shall not relieve the Permittee of the responsibility for
compliance with all applicable surface water,wetlands,groundwater and air quality
standards or for damages to surface waters,wetlands or groundwaters resulting from the
animal operation.
2. The maximum waste level in lagoonststorage ponds shall not exceed that specified in the
Facility's CAWMP. At a minimum, maximum waste level for lagoons/storage ponds
must not exceed the level that provides adequate storage to contain a 25=year,24-hour
storm event plus an additional one(I)foot of structural freeboard except that there shall
be no violation of this condition if: (a)there is a storm event more severe than a 25-year,
24-hour event, (b)the Permittee is in compliance with its CAWMP, and(c)there is at
least one(1) foot of structural freeboard.
3. Any containment basin, such as a lagoon or a storage pond, used for waste management
shall continue to be subject to the conditions and requirements of this Permit until
.properly closed. When the containment basin is properly closed in accordance with the
Natural Resource Conservation Service (MRCS)North Carolina Standard for Closure of
Waste Impoundments, February 2005 or any subsequent amendment,the containment
basin shall not be subject to the requirements,of this Permit. The Permittee must submit a
letter to the Division to request rescission of the Permit by providing documentation of
closure of all containment basins.
Closure shall also include a minimum of 24 hours pre-notification of the.Division and
submittal of the Animal Waste Storage Pond and Lagoon Closure Report Form to the
address identified on the form within fifteen (15)days of completion of closure.

4. Failure of the Permittee to maintain, in full force and effect, lessee and landowner
agreements, which are required in the CAWMP, shall constitute grounds for revocation
of its COC to operate under this Permit.
5. This Permit is not transferable. In the event there is a desire for the Facility to change
ownership, or there is a name change of the Permittee,a Notification of Change of
Ownership form must be submitted to the Division, including documentation from the
parties involved and other supporting materials as may be appropriate.
6. The issuance of this Permit does not prohibit the Division from reopening and modifying
the Permit, revoking and reissuing the Permit, or terminating the Permit as allowed by the
appropriate laws, rules, and regulations.
7. The Groundwater Compliance Boundary is established by 15A NCAC 2L and 15A
NCAC 02T .0 11 1(c). An exceedance of Groundwater Quality Standards at or beyond the
Compliance Boundary is subject to the requirements of 15A NCAC 2L and the Division
in addition to the penalty provisions applicable under the NCGS.
VI. PENALTIES
1. Failure to abide by the conditions and limitations contained in this Permit;the Facility's
CAWMP; and/or applicable state law; may subject the Permittee to an enforcement
action by the Division including but not limited to the modification of the animal waste
management system,civil penalties,criminal penalties,and injunctive relief.
2. The Permittee must comply with all conditions of this Permit. Any Permit
noncompliance constitutes a violation of state lave-and is grounds for enforcement action;
for Permit coverage termination,revocation and reissuance, or modification; or denial of
Permit coverage renewal application.
3. It shall not be a defense for a Permittee in an enforcement action to claim that it would
have been necessary to halt or reduce the permitted activity in order to maintain
compliance with the conditions of this Permit.
This Permit issued the 24th day of November, 2009.
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
for Coleen H. Sullins, Director
North Carolina Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number AW1160001

r ,
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly E-aves Perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
September 4.2009 ?
Robert and Dorothy Joyce Combined Trust
Joyce Hog Farm �p
383 Cyrus Pollard Rd
°Newport,NC 28570
Subject: Additional Information Request
Application No.AWS160001
Joyce Hog Farm
Carteret County
Dear Robert and Dorothy Joyce Combined Trust:
The Animal Feeding Operation Unit of Division of Water Quality's Aquifer Protection Section has completed a
preliminary review of your renewal permit application package. Additional information is required before we may
continue our review. Please address the following item(s)by September 15,2009:
Change in animal numbers
The number of animals and operation type specified in your waste plan (821 sows)appear to be different
than those specified in your facility's permit application(818 Farrow to Wean)and most recent
certificate of coverage(COC). Please verify these numbers and,submit,if needed,a new Waste
Utilization Plan or Nutrient Management Plan to reflect the correct number of animals and type.
Please reference the subject application number when providing the requested information. All revised and/or
additional documentation shall be signed,sealed and dated, with two(2)copies submitted to my attention at the
address below. Please note that failure to provide this additional information on or before the above requested date
may result in your application being returned as incomplete.
Please be aware that you are responsible for meeting all-requirements set forth in North Carolina rules and
regulations. Any oversights that occurred in the review of the subject application package are still the responsibility
of the applicant. In addition,any omissions made in responding to the above items shall result in future requests for
additional information.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a
civil penalty. Operation of your facility without coverage under a valid general permit would constitute a violation
of NCGS 143-215.1 and could result in assessments of civil penalties of up to $25,000 per day.
If you have any questions regarding this letter,please feel free to contact me at(919) 715-6698
Sincerely.
SEP 0 9 7009
S
J.R.Jos t
Animal Feeding perations Unit
cc: Wilmington Regional Office,Aquifer Protection Section
Carteret County Soil and Water Conservation District
APS Files-AWS160001
NotihCarolina
Alatura!!!1
Aquifer Protection Section 1636 Mail Service Center Raleigh,NC 27699-1636 Telephone: [phone]
Internet:www.newaingualitv.org Location: 2728 Capital Boulevard Raleigh,NC 27604 Fax 1: [phone]
Fax 2: [phone]
An Equal opportunity/Affirmative Action Employer—50%Recyded/10%Post Consumer Paper Customer Service: [phone]

Joyce Farms
2609 W. Forest Drive RE' CEYV.ED
Newport, NC 28570 OCT 0 2 2006
252-223-4752
or 252-223-5763
September 29, 2006
NC Dept of Environment and Natural Resources
Wilmington Regional Office
127 Cardinal Drive Ext.
Wilmington, NC 28405-3845
Attn: John Farnell
Dear Sir:
Enclosed please find the reports that you requested I correct and send
to you. I am still waiting on the Waste Utilization Plan that Mr. Todd Kelly
has promised me since June of this year. As soon as I receive this report
from him, I will send it to you.
I apologize for these reports not being handled within the sixty day
time frame that you requested.
Si cerely,
Richard E. Joyce

87/25/2006 08:25 919-715-6048 DUO NON DISCHARGE BP PAGE K
j"0. Dgmir 01--.r3
Michael F.Easley,Glovemor
Wlillem G.Ross Jr,,Secretary
Qp North Camtlna Departrnent of&Aronment and Natural Resources
y �—� Alan W.Kllmak,P.E.,Director
olvfton of Waterouslity
October 1,2004
Robert Joyce
Joyce Hog Farm
383 Cyrus Pollard Road
Newport NC 28570
Subject: Certificate of Coverage No.AWS160001
Joyce Hog Farm
Swine Waste Collection,Treatment,
Storage and Application System
Carteret County
Dear Robert Joyce:
On June 11,2004,the North Camlins Division of Water Quality(Division)issued a revised State General
Permit fen swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-29).
In accordance with your application received on January 17,2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwardhig to you this Certificate of Coti-erage (COC) issued to Robert
Joyce, authorizing the operation of the subject annual waste collectiora,, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supersedes and terminates your previous COC Number AWS160001 which expires.October 1,2004.
This approval shall consist of the operation.of this system including,but not limited to,the management
of animal. waste from the Joyce Hog Farm, located in Carters County, with,'sn animal capacity of no
greater than an aanulril ayem8e of 8"1"i iaw to-Veac swore and the application to land as alrecifsed ir.
the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow 10 Wean or
Farrov� to Feeder operation,there may also be one boar for each 15 sows. Wltere boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts fot every 3 sows
The COC shall be effective from the date of issuance urztii temp �� �Pwi uant to this COC,
you are authorized and required to operate the system in con with the conditions and limitations as
specified in the General PwmkL,the facility's CAIVMP, and this COC. An adequate system for collecting
and maiauuning the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified desigla capacity or increase in number
of animals authorized by this COC (as prodded above) will require a modification to the CAVvW and
this COC and must be completed prior to actual increase in either wanowater flow or number of animals.
Please carefully mad tb1s COC and the ejaclosed State General Permit. Since this is a revised State
General Permit, it ccmtains now requirements in addition to most of the conditions contained in the
previous State General Pemait._2=—Tose3jh� o -- --_- -----i -----__. ~_- -� - -
.-.. _ cbiiz-etuenoc is a_p�ka$c-cc� ng.�e_nryy,and
-Mvised�-fo= umd f6i rwwd.lre*ng-and-rag titt$ &ge vav carefiil tits to the record F are
Aquifer PrDtectlah S6Ghon-Animal Feeding OWMens Urtn iZC
1&%MO,Service CwAw,Raw4h,North Cerdna 27699.105
IND
orthCarolina
Phow.919-Ma221/FAX:[phone])M/Interm.h2o.enr.suftncars NaturallyAn Ecual Oppor�lq/Affrt�alive Action Employer-50%r�d a&10%Pest ConsumerPaper

_ 25l2006 08:25 919-715-6045 DWO NON DISCHfiRGE BR PAGE 02
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that die current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utihzation Plan developed.
The issuance of this COC does not excuse the Perttaittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon ab�ndonment or depopulation for a period of ur vcars or m-aice the Permittee must submit
documentation to the Division demonstrating that all current MRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c)a compliance boundary is provided for the�%cility and no new water supply
wells shall be constructed w7thin the compliance boundary. or���-standat�.a3l����}�aration�`
-- • -
e learn..__ w8ter��y��c1Fs��d"arty lasoonr-starage���_.�ny-v�ett��xea of
Please be advised that any violation of the terms and conditions specified.in this COC,the General Permit
or the CAWM. P may result in the revocation, of this COC, or penalties in accordance with NCGS 143-
215.6A ibmugh 143-215.6C including civil penalties,criminal penalties,and injunctive relief.
If you wish to continue the activity permltted under the General Permit after the expiration date of the
General Permit,as application for renewal must be filed at least 190 days prior to expiration.
This COC is not automatically trawferable.:A namr�o ership change application mist �u �fo�
she niviiaion priorto-a nagxachanga_or charge fug ownerslii .
If any parts, requiremcnts, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by Contacting the staff member listed beiow for information on this
process. Unless such a request is matte within 30 days,this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. 11h►e Regional Office
Water Quality Staff may be reached at (910).395.3900. If you need additional information concemkg
this COC or the General Pmmmit,please contact Duane Leith at(919)715-6186.
Sincerely,
for Alan W.Klimek,P.E.
Enclosures(General Permit AWG1.00000)
cc: (Certificate of Coverage only for all Dc's)
Wilmington Regional Office, Aquifer Protection Section
Carteret County Health Department
Carteret Couyaty Soil and Water Conservation District
Permit File.AWS160001
APS Central Files

tw�r
N_CD�1&CSrAgronomicfDlvisiou�Phou (91q �7�3,3Z655�,� WebSite:
ety: cagy cUm/agtfl_ mi/ �RepgrtN_w: 3d7,91�' ;Y F�
WGrower. Joyce,Richard Copies To:
2609 W Forest Dr
Newport,NC 28570
m oil Test'Report
Fatal.•
6/19/2006 SERVING N.C.RESIDENTS FOR OVER 60 YEARS Carteret County
Agronomist Comments C _ 12 $
3 x W.
"1 ' 1
1.Fieldwiuformation � °A lied l ime Recatn teudations i ' `.n , ; „I pab P. �
Sample No. Last Crop Mo Yr T/A Crop or Year lime P205 K2 Mg S Cu Zn B Mn See Note
01 1st Crop: Berm Hay/Pas,M 0 180-220 , 0 0-20 0 0 0 0 pH$ 12
2nd Crop; Berm Hay/Pas,M 0 180-220 0 0-20 0 0 0 0 pH$ 12
Test Results
Soil Class HM% W/V CEC BS% Ac pH P-1 K-1 Ca% Mg% Mn-1 Mn-A1(1)Mn-A1(2) Zn-1 Zn-AI Cu-1 S-1 SS-1 NO3-N NH4-N Na
MIN 0.66 1.24 8.3 92.0 0.7 6.6 340 122 59.0 26.0 45 35 35 174 174 35 37 0.1

FORM IRR-2 Lagoon Irrigation Fields Record
One'Form for Each Field per Crop Cycle
Tract# Field# Facility Number -
Field Size(acres) =(A)
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type R000mmendedS lYAN Loading
Z. S.
1 3 4 5 B 8 10 1t
irrigation
Oate of Sprinklers Volume Waste Analysis PAN' PAN Applied N"en Balance
Start Time Total Total Volume per Acre (W1000 gal) (IWeore) (II/�)
mmlddlyr End Time Mutes Operating Flow Rate (81 x(9) (B)-00)
(3)-(2) (gallmin) (e)gallons)5)x(4) r 100D
r
Tr- - a ITAt-, 14 18 'Z1 1`1Z�' I.
1ZbIVa
? O CIAO
,Q %Z0 O 3
CIL- - 20
a o
11: o NO "Or
o
Crop Cycle Totals I 1 V•70 1
Owner's Signature Operator's Signature
Certified Operator(Print) Operator's Certification No.
l NCOA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section 633.
Enter the value received by subtracting column (10)from(B). Continue subtracting column (10)from column(11)following each Irrigation event.

Z�7l1 t
FORM IRR-2 Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Tract# Field# Facility Number -
Field Size(acres) =(A)
Farm Owner irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization plan
Crop Type � � 1 Recommended Leading r`l Z.� `y� Z�n�
M� a (lb/acre)s(�) � 5 lb�. �l� �1 F �.� z ,T
1 2 3 4 5 8 8 9 10 11
Inigatian
Date #of Sprinklers
Volume Waste Analysis PAN' PAN Applied Nitrogen Balance:
mm/ddtyr Stan Time E(3�)-
operating Flow Rate Total Volume per Acre (lW100o QaQ (I[81 x(9) (B)a 0)
End Time (gaVmin {gallons} (gaUacre) 100D
} (6)x(5)x(4) �7
-Z1- v:m vwfzo 4� 1-7 MY A0
• •o o IQ o 00. o
-2.l-aj a a o o� .$ 't zz
ao w.SSL %ZQ ti40 1 8 Z.
' �.'�
S r
-23-o •04 coo t o 0
•C0 4:%*J� Z.cn "M111.5,
IV 7.3 'L
-T :ao 21 l Z
4'c- -e5 W.OA t .
-vt.o o•op 1 1 -L T.1
Crop Cycle Totals
Owner's Signature Operator's Signature
Certified Operator(Print) Operators Certification No.
t NCDA Waste Anaytysis or Equivalent or NRCS Estimate,Technical Guide Section 633.
Enter the value received by subtracting column (10)from(13). Continue subtracting column (10)from column (11)following each irrigation event.

iE
FORM IRR-2 Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Tract# I Field# r Facility Number -
Field Size (acres) =(A)
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN Loading
pblacre)=(B)
1 3 4 5 6 e 9 10 11
Irrigation
Volume Waste Analysis PAN' PAN Applied Nitrogen Balance'
Date Start Time Total of Sprinklers Total Volume per Acre (lb/acre) Qblacre)
mmldd/yr End Time Minutes operating Flow Rate (gallons) (gallacre) Qbl1 D00 98q (8)x(9). (B)-(10)
(3)-(2) (gWmin) (6)x(5)x(4) M 1000
A
7Z I C]4 2
1
Z �
. a
214 1
Crop Cycle Totels —0 o Z 4�, 20
Owner's Signature Operator's Signature Certified Operator(Print) Operator's Certification No.
1 NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section 633.
x Enter the value received by subtracting column(10)from(B). Continue subtracting column (10)from column(11)following each Irrigation event.

r-t1v���
FORM IRR-2 Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Tract# Field# Facility Number 1 1 -
Field Size (acres) =(A)
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN loading
pb/acre)_(B)
1 2 4 5 B 8 9 10 11
Irrigation o-1-_
Volume Waste Analysis PAN' PAN AppAad Nitrogen Balanoa'
Date #of Sprinklers (lblacre) (Iblacre)
mm/dd/yr Start Time Total operating Flow Rate Total Volume per Acre {ib11Uo0 gel) (8)x(9) (B)-00)
End Time Minutes (gallons) (gatlacre)
(gal/min) (8)x(5)x(4) M_ 1000
90,
�.'�. Z�.
1 ►.Z
2— I .
Crop Cycle Totals - O. Z
Owners Signature Operator's Signature
Certified Operator(Print) Operator's Certification No.
t NCDA Waste Anaytysis or Equivalent or NRCS Estimate,Technical Guide Section 633.
s Enter the value received by subtracting column (10)from(B). Continue subtracting column (10)from column (11)following each Irrigation event.

• . . z�ntr � �- 2cf-Zi5 . -
FORM IRR-2 Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Tract# Field# Facility Number -
Field Size (acres) =(A) -
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type R Recommended PAN Loading f
7 (lb/acre)_(B) 3��1 3 1 - aw
1 2 3 4 5 8 B 9 10 11
Irrigation
H aF Sprinklers Volume Waste Analysis PAN' PAN Applied Nitrogen Balance'
Data
Start Time Total Total Volume per Acre (ibl1000 gaq (lblacre) (lb/acre)
mnVdd/yr Operating Flow Fiats _ (B.)-00)
End Time Minutes (geVmin (gallons) (gave")(3)-(2) ) (6)x(5)x(4) M low
UQ 30T 1T
--v-0'S tc: o w 3m) a 140 17 21 ti,aa ► IF-AcAF
4. -03 O C!O OCR. 5*37.cno
•d!t�d z o -1
-os 533.ZZ
:o,--) 1,, 1'ZC 5�•
- a• i Z.• 'ZO 14ZN IT -?-I %16O0 ^LZ b4Y TIT. �,Y
�-•oa o 20 -Zt \,Oo 2- 't o -T21. 9%,.
-� 3: O Z 1 rt?. Sf
a ��• t2� a a Z31,3 17
�S .a 1'L• O o V
to•.�,c tt 3--Z)' COP Z o
-W.%aa o;o
O
71--0a 9too Crop Cycle Totals 3flz' oo Z
Owner's Signature Operator's Signature 01
Cert-tfied Operator(Print) Operator's Certification No.
t NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section 633.
2 Enter the value received by subtracting column(10)from(B). Continue subtracting column (10)from column (11)following each irrigation event.

FORM IRR-2 Lagoon Irrigation Fields Record
One'Form for Each Field per Crop Cycle
Tract# Reid# Facility Number I -
Field Size(acres) =(A)
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN Loading
1 3 4) M8 9 10 11
Irrigation
4 of Sprinkles m Volue Waste Analysis PAN' PAN lied N' Balance=
Cate (Ib/acre) (Ib/acre)
mm/dd/yr Start Time Total Operating Flow Rate Total Volume per Acre (Ib11000 gad _(81 x(9) (B)-00)
End Time Minutes (gallons) (gaUacre)
(3)-(2) (gal/min) (6)x(5)x(4) M 1000
A ,
:o0 3:00 20 o Ll %A9R 1-myc 45 3. Ocyl
3- •4=,0 Z4Q a C0 t,) o
0 5:3c) t ZQ 3 0
�?- tie 4m 2:-:D0 0
Qk-7z- •o
2:as
Cl- Ap 4 3 a ; 17
Crop Cycle totals
Owner's Signature Operator's Signature _
Certified Operator(Print) Operator's Certification No.
1 NCDA Waste Anaylysis or Equivalent or NFICS Estimate,Technical Guide Section 633.
2 Enter the value received by subtracting column(10)from(B). Continue subtracting column (10)from column (11)following each irrigation event.

FORM lRR-2 Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Tract# Field# Facility Number -
Field Size(acres) =(A) Z� t 1•�
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN
Loading= �7
1 2 4 5 B 10 11
Irrigation
Date q of Sprinklers Volume Waste Analysis PAN' P Applied Nitrogen lance'
mm/ddlyr operating Flow Rate
Start Time Total o Total Volume per Acre QG11000 gal) 9l_ (B)-(10)
End Time Minutes (gallons) (gabacre) .
(3)-(2) (gal/min) (6)x(5)x(4) 1000
A
7^O Z drQMvt. �
ZAll . --
��.01
1 ZZ o
� ZO 010
ISO Ti �Qa
4
Z
.7
Crop Cycle Totals ��
Owner's Signature Operator's Signature .
Certified Operator(Print) Operator's Certification No. 1 7 Q "
1 NCDA Waste Anaylysls or Equivalent or NRCS Estimate,Technical Guide Section 633.
Enter the value received by subtracting column (10)from(8). Continue subtracting column (10)from column (11)following each irrigation event.

FORM IRR-2 Lagoon Irrigation Fields Record 5L'
One Form for Each Field per Crop Cycle
Tract# Field# Facility Number
Field Size(acres) =(A)
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop type Recommended PAN Loading
Pb/acre)-(B)
1 2 3 4 5 6 8 9 10 11
Irrigation
Date q of Sprinklers Volume Waste Analysis PAN' PAN Applied Nitrogen Balance
mmlde Start Tlme Total Operating �ow � Total Volume per Acre (ib11000 gal) (l acre) {I6lacre)
End Time Minutes (gallons) (gel/aere) ( )x(9) (B)-(10)
(3)-(2) (gel/min) (6)x(5)x(4) _(� 1000
.T
I • Z o
t
2 11 . Z
3I X,Z94Z:>
Crop Cycle Totals kzl
Owner's Signature Operator's Signature
Certified Operator(Print) Operators Certification No. 1 CZ,3 r
t NCDA Waste Anaylysls or Equivalent or NRCS Estimate,Technical Guide Section 633.
z Enter the value received by subtracting column(10)from(B). Continue subtracting column (10)from column(11)following each Irrigation event.

FORM IRR-2 Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Tract# Field# Facility Number -
Field Size (acres) =(A) = - e.,
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN Loading 2 tY5 X L Al I -1 0p
c.c_ = 547— IV Ar t4%t
1 2 3 a s s e a 10 t1
Irrigation
Volume Waste Analysis PAN' PAN Applied Nitrogen Balance s
Date N of sprinklers (lb/acre) (lb/acre)
mmtdcuyr Start Time Total Operating Flow Rate Total Volume per Acre (Ib11000 gat) (8)x(91 (B)-(10)
End Time Minutes (gallons) (gaVacre}
(3)-(2) (ga(Imin) (6)x(5)x(a) M 1000
S
A:a "21 P.
o Z 335.\.4
:ao t :as :: c� o c Z.• 'z 333.ZZ
S • -'C :oo O Z-`fit 2. o 5-34.8a
a ,p 8
tic•31u az=P a 121 z coo a Vx oN
.A- - Z
:ater2oo
z• t.
• 1.4�oZV t
•mooVz0
a o Z
Crop Cycle Totals 30ZA14,cz.
Owners Signature Operator's Signature
Certified Operator(Print) Operators Certification No.
I NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section 633.
s Enter the value received by subtracting column (10)from(B). Continue subtracting column (10)from column(11)following each Irrigation event.

FOAM IRR-2 Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Tract# Field# Facility Number -
Field Size(acres)_(A)
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN Loading
(lb/acre)_(a) 21 tv•�
1 2 4 5 8 8 9 10 t1
Irrigation
Volume waste Analysis PAN' PAN Applied Nitrogen Balance'
Date p of Sprinklers per Acre (lb/acre) Oblacre)
mnyddlyr Start�� Total Operating Flow Rate Tote)Volume Q6/7000 gal) (8)x(91 (9)•00)
End Time Minutes (gallons) (gaYacre)
(gallmin) (a)x(5)x(4) JZL• 1000
r
C1-?A-aS c o: 0 2c o 7- $ 1.%P+0
o ZZa 3k,spo a .
to• za a
Crop Cycle Totals
Owner's Signature Operator's Signature
Certified Operator(Print) Operator's Certification No.
1 NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section 633.
2 Enter the value received by subtracting column (10)from(9). Continue subtracting column(10)from column (11)following each Irrigation event.

z<�,nt CA-
FORM.IRR-2 Lagoon Irrigation Fields Record
One'Form for Each Field per Crop Cycle
Tract# Field# Facility Number -
Field Size (acres) "(A)
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN Loadfng
1 2 4 5 8 8 10 11
Irrigation
Volume Waste Analysis PAN' PAN Applied Ntragen Balance C
Date #of Sprtnklera pblacre) pbtacre)
mm/dd/yr Stsrt Time Total Operating Flow Rate Total(galloVolumns)
per Acre pW1000 gaff x
End The Minutes (ganons) (gaVecra} _(81 f6} {B)-(10)
(3)-(2) (9allmfn) (6)x(6)x(4) M_' 1000
1 S O
�2
0
4b
S 1
3 5
l'3Z 5
3 a
Crop Cycle Totals 02 S- St
Owners Signature Operator's Signature
Certified Operator(Print) Operators Certification No.
1 NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section 6M.
Enter the value received by subtracting column (10)from(0). Cortinue 90tracting column (10)from column (11)following each irrigation evert.

Z-
FoRm IRR-2 Lagoon Irrigation Fields Record `
One'Form for Each Field per Crop Cycle
Tract# Field# Facility Number I -
Field Size(acres) =(A)
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan C�
Crop Type Recommended PAacre ing
(� 1
1 2 3 4 5 6 a 10 11
Irrigation
Date #a1 Sprinklers Volume Waste Analysis PAN' PAN Applied Nitrogen Balancer
mmlde Start Time Toted Operating Flow Rate Total Volume per Acre (lb11000 gal) pb x e ((lb/(D}
End Time Minutes (gal/min) (gallons) (gaUacre) 1000
(3)-(2) (B)x(5)x(4) _�
l
1-0 `raZ�0 Z -INI
3
Crop Cycle Totals ��
Owners Signature Operator's Signature
Certified Operator(Print) Operator's Certification No.
1 NCDA Waste Anaylysis or Equivalent or NFICS Estimate,Technical Guide Section 633.
°Enter the value received by subtracting column (10)from(B). Continue subtracting column(10)from column (11)following each irrigation event.

FORM IRR-2 Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Tract# Reld# I Facility Number -
Field Size(acres)=(A)
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type `` Recommended PAN Loading J
edA,i�� 13�nt.•.c�c� pb/acre)a(s) 11,-6 cL t-
1 2 3 4 5 B 8 B 1 0 1
Irrigation
Volume Waste Analysis PAN' PAN Appried Nitrogen Balance'
Date p of Sprinklers (lb/acre) (lb/acre)
Start limeQTnime
Total Total Volume per Acre (Ib11000 gal)
mm/dd/yr Minutes Operating Flow Rate (gallons) (9wacre) (8)x(9) R-00)
(3)-(2) (gaVmin) (6)x(5)x(4) M_ 1000
A.t. A 'Z
•o •� t 2 2jwto,JAO 5�1-• eb
a'o .co S6'o. 'm
•.3 1-1 xy -I A 131. d 534.'F'e
:oa H IE
-a 0 2
O Z .
.06, 41,04M Me., 1O
3
-Qa :rro Zc b
.e •o+o :� 7ao .
Crop Cycle Totals 11304,40101
Owners Signature Operator's Signature .
Certified Operator(Print) Operators Certification No.
NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Secdon 633.
2 Enter the value received by subtracting column (10)from(B). Continue subtracting column (10)from column(11)following each irrigation event.

FORM iRR-2 Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Tract# Field# Facility Number
Feld Size(acres)=(A)
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN Loading
(1Waere)a(B) -Z-74.
1 2 3 IAI (5) 8 B 10 11
trrigatlon
Date #of 5prinklers Volume waste Analysis PAN` PAN Applied Nitrogen Balance'
mm/ a Start Time Total Operating Flow Rate Total Volume per Acre (IW1000 gal) (l[W�) �gWa(i o}
End Time Minutes (gallons) (gaVacre}
(3)-(2) (gaVmin) (g)x(5)x(4) —LZ _' 1000
r
4:oo LZo 14Z) ZI 121
-a 3
1.
0 0
Crop Cycle Totals 40Cg
Owner's Signature Operator's Signature
Certified Operator(Print) Operator's Certification No.
i NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section 633.
g.Enter the value received by subtracting column(10)from(B). Continue subtracting column (10)from column(11)following each Irrigation event.

FORM IRR-2 Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Tract# Field# Facility Number 1 -
Field Size(acres) =(A) t
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN Loading
(lb/acre)_(1
1 2 3 4 5 B 8 9 10 11
Irrigation
Volume waste Analysis PAN' PAN Applied Nitrogen Balance'
Datmmld a StBA TIme Total #of Operating rs Flow Rate Total Volume per Acre (Ib/1000 gal) n�81 n e (lb a 0}
End Time Minutes (gallons) (gaVacre)
(3) (2) Wmin) (g)x(5)x(4) �,' 1000
r
Z
� a
1 0
2
1�
Crop Cycle Totals 1 .3
Owners Signature Operator's Signature
Certified Operator(Print) Operators Certification No. t'ICa 35
NCOA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section M.
x Ertter the value received by subtracting column(10)from(B). Continue subtracting column (10)from column(11)following each Irrigation event.

MY
FORWRR-2 Lagoon Irrigation Fields Record S
One Form for Each Field per Crop Cycle
Tract# Field# Facility Number 1 -
Field Size (acres) _(A) ZO c
Farm Owner Irrigation Operator
Owners Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN loading
(lb/acre)-(a?
1 3 4 8 9 10 1t
Irrigation
#of Sprinklers Volume waste Analysis PAN' PAN Applied Nitrogen Balance"
Date p (Iblacre) (Iblacre)
mrNdd/yr Start Time Total Operating Flow Rate Total Volume per Acre (IbItD00 gal} is)x(M (B)-(10)
End Time Minutes (gaVmin) (gallons) (gaUacra) 1�
( ) (2) (6)x(5)x(4) M 19 S. T.)-Q Z1 00 3 ,
3
3 11.7-9
crop Cycle Totals
Owner's Signature Operators Signature
Certified Operator(Print) Operators Certification No. 's'
NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section833.
p Enter the value received by subtracting column (10)from(B). Continue subtracting column(10)from column (11)following each irrigation event.

FORM IRR-2 Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Tract# Field# Facility Number -
Field Size (acres) =(A) V—IT
.�
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN Loading
�. (Ib/acre)-(8) 5 Z t A
1 2 3 4 5 6 B 9 10 11
Irrigation
Date Mot Sprinklers Volume Waste Analysis PAN' PAN Applied Nitrogen Balance
mm/dd/yr Start Time Total Operating Flow Rate Total Volume per Acre Qb11000 gal] ({8 ax 191 (By a 0 0)
End Time Minutes (gaVmin (gallons) (gallacre) 1000
(3)-(2) ) (6)x(5)x(4) �-
r:oo 3:ao o co S+o. qj
ap eA C) r g,ov
•310 110 o IQ IV, 21vo -4 S>>. \A
•as o•o .7 533. ZZ
- 5-cM 1-tim, •Z 2. S��, 5�
O Z. O.41Z F. 34
o: aTVZ
-2 _of o .'Z
-Mq.
20 b
o 3, So IL go It1-1 Zr
3
S: o O lip %IT Z -L
-OS :,C:.o 3 AbCb -Z 7.
"?A :O
Crop Cycle Totals
Owner's Signature Operators Signature
Certified Operator(Print) Operator's Certification No.
NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section 633.
2 Enter the value received by subtracting column(10)from(B). Continue subtracting column(10)from column (11)following each Irrigation event

FORM IRR-2 Lagoon Irrigation Fields Record 4
One Form for Each Field per Crop Cycle
Tract# Field# Facility Number -
Field Size(acres) =(A)
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operators Phone#
From Waste Utilization Plan
Crop Type Recommended PAN Loading
(lb/acre)-(B) Z`7lr. O4
i 3 4 5 8 B 8 40 41
Irrigation
Data Hof Sprinklers Volume Waste Anarysa PAN' PAN WApplied Nitrogen bl Bahme 2
mm/dd/yr Slert lime Total Operatlng Flow Rate Total Volume per Acre (Ibltl>DO el} x
= End Ttme Mlrtutes ) (gallons) (gaUacre) (�-(i o)
(3)-(2) (6)x(5)x(4) M
r
0: Zoo Z a 'Z z7
3SOO
xA
Iza Z
-Crop Cycle Totals jolt o00
Owner's Signature Operator's Signature
Certified Operator(Print) Operators Certification No.
1 NCDA Waste Aneylysis or Equivalent or MRCS Estimate,Technical Guide Section 633.
2 Enter the value received by subtracting column (10)from(B). Continue subtracting column(10)from column(11)following each irrigation event.

Zen t + c�r
FORM IRR-2 Lagoon Irrigation Fieldstecord 4
One'Form for Each Field per Crop Cycle
Tract# Field# Facility Number -
Field Size(acres)_(A) _ $
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utlllzation Plan
Crop Type Recommended PAN Loading
(lb/acre)_(B)
1 z 4 5 B 8 g 10 11
Irrigation
Volume Waste Analysis PAN' PAN Applied Nitrogen Balance'
Data #of Sprinklers (Ib/acre) (lb/acre)
mmldd End Time Minutes/yr 5�rt Time TOW operating Flow Rate T Volume per Acre (Ib/10oo gal) x
(gallons) (gallarxe) )— (B)-(10)
(gal/min) (g)x(5)x(4) M_ 1000
2�
t�
T _ C11 -a o
�z
- �z.
t1
�2
k i
" O
Crop Cycle Totals 3oZ O 2
Owner's Signature Operator's Signature
Certified Operator(Print) Operators Certification
1 NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section SM.
s Enter the value received by subtracting column (10)from(B). Continue subtracting column(10)from column(11)following each Irrigation event.

car
FORM lRR-2 Lagoon Irrigation Fields Record
One'Form for Each Field per Crop Cycle
Tract# Field# Facility Number I -
Field Size(acres) =(A) -C.'bn-t- =
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN Loading
(lb/acre)-(B)
1 2 3 4 5 6 B 9 10 11
Irrigation
Volume Waste Analysis PAN' PAN Applied Nitrogen Balance
Date r4 of sprinklers per Acre (Ib11DD0gal) (lb/acre) (lb/acre)
mMde Start Time Total Operating Flow Rate Total Volume I81 x f91
End Time Minutes (gaUmin) (gallons) (gaUacre) 100( (B)-00)
(3)-.(� (s)x(5)x(4) �_.
11. T
Zo
Z
Crop Cycle Totals 1104=1Z
Owner's Signature Operators Signature
Certified Operator(Print) Operators Certification No.
1 NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section 633.
p Enter the value received by subtracting column(10)from(B). Continue subtracting column(1U)from column(11)following each irrigation event.

zAZ� rn 4r 3
FORD IRR-2 Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Tract# Field# I Facility Number -
Field Size(acres)=(A)
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type _11 Recommended PAN Loading
VLrM (Ib/acre)_(B) 1.`(F-4c. = '%Az-C% NLs .�+t
1 4 5 6 8 $ 10 11
Irrigation
Volume Waste Analysis PAN' PAN Applied Nitrogen Balance 2
Date start Time Total #of sprinklers Totai Volume per Acre {Ibli 000 gal) (lb/acre) pb/acre)
mm/dd/yr End Time Minutes operalirtp Flow Rate (gallons) (gal/acre) -�— (B)-(10)
('3)-(2) (9aUmin) (6)x(5)x(4) ..pL 1l)f10 CS r 4 Z.%
-31-a tv:c;z) 1L:,ta o Z 2, s'qo,48
-4 ao S3T.on.
61 is-US' a Igo ir zip2 sbr. 44
o Z S33.Zz
lzo ?Al- ckz j34b.T-4z
I. rz ' 30 5zg. S4
-zl-as 'gcoo lqtb:oo 11Q 1 2 Amb. Ste}
o o
to• O
.ob
T 3 O
A b %e +� Z�7
Crop Cycle Totals z co
Owner's Signature Operator's Signature .
Certified Operator(Print) Operator's Certification No.
1 NCDA Waste Anaylysis or Equivalent or NFiCS Estimate,Technical Guide Section 633.
x Enter the value received by subtracting column (10)from(9). Continue subtracting column (10)from column (11)following each Irrigation event.

=r Z��4e.- 9
FORM IRR-2 Lagoon Irrigation Fields Record
One'Form for Each Field per Crop Cycle
Tract# Field# Facility Number - 1
Field Size(acres)=(A)
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utlllzation Plan
Crop Type Recommended PAN Loading
(lb/acre)-;) ZZS -
1 2 4 5 B 10 11
Irrigation
Date q o!Sprinklers Volume Waste Analysis PAN' PAN Applied
Nitrogent ��e
mm/dd/yr I Stan Time Total operating Flow Rate Tots!Volume per Acre (lb/1000 gal) x
End Time Minutes (gallons) (gaVacre) -L�1 00
(3)-(2) (gaVmin] (g)x(5)x(4) -M- 100
0
r
Q
•b� :ca lza Z1, C:Q 0 2.
8-z2 +5:eA 1,41,11 io tr v Nocz Vm
I-ei-or a Ma
-'tom- M, a 1131.0 O 3
•aS i'a z� o
a 2S
Crop Cycle Totals 1 57 WE
Owner's Signature Operators SignatureL &2==
Certified Operator(Print) Operators Certification No.
1 NCDA Waste Anaylysis or Equlvalent or NRCS Estimate,Technical Guide Section 633.
2 Enter the value received by subtracting column (10)from(B). Continue subtracting column (10)from column(11)following each irrigation event.

-Z©r7
FORM.IRR-2 Lagoon Irrigation Fields Record
One'Form for Each Field per Crop Cycle
Tract# Field# Facility Number
Field Size(acres)_(A)
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
crop Type Recommended PAN Loading
(lb/acre)_(13)
1 2 3 4 5 9 9 10 11
Irrigation
Volume Waste Analysis PAN t PAN Applied Nitrogen Balance°
Date p of Sprinklers pblacre) pbtacre)
End lime Minutes (gallons) (gailacre)
mm/ddtyr Start T7me Total Operating Flow Rate Total Volume per Acre (Ib11000 gaq �_x(9) (B}•(101
` (gai/min) (6)x(5)x(4) �_. 1000
r
y
QS d� Z 1.2
Z� 1
2
- 393 11,29 at
I CB I
1 l '2.
Crop Cycle Totals a2 0� a 3
Owners Signature Operators Signature �G'g.� _
Certified Operator(Print) Operator's Certification No. —� 1Zp 35
1 NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section 633.
2 Enter the value received by subtracting column(10)from(B). Continue subtracting column (10)from column(11)following each irrigation event.

z 4cn,,.A 3 ca f r
FORM_1RR-2 Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Tract# Feld# Facility Number - ( .
Feld Size(acres) T(A)
Farm Owner Irrigation Operator
Owners Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN Loading
Ab/acre)_(B)
1 2 3 4 5 B B 9 10 11
Irrigation
vokime waste Analysts PAN PAN Applied Nitrogen Balance 3
Date #of Sprinklers (lb/acre) (lblacre)
mmldd/yr Start Time Total Operating Flow Rate Total Volume per Acre {Ib/1000 gal) (a)x to) (B)-(10)
End Time Mlnulea (gallons) (paUacre)
(3)-(2) (gal/min) (6)x(5)x(4) _M low
t>'Z, L.
2
.5 317 1 IjRt-
!j _ ,Z121 OS"
.tbZ
0
Crop Cycle Totals l
Owner's Signature Operator's Signature
Certified Operator(Print) Operator's Certification No.
1 NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section 633.
:Enter the value received by subtracting column(10)from(B). Continue subtracting column (10)from column (11)following each irrigation event.

FORM IRR-2 Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Tract# Field# Facility Number -
Field Size (acres) =tA) =
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN Loading �/ ti ` '
s�a (lb/acre)=(B) �Y 1 . 0.0 f1d� N Z�r7 t,,
1 2 3 4 5 6 B 9 10 11 ,
Irrigation
Volume Waste Analysis PAN' PAN Applied Nitrogen Balance'
Pate #of Sprinklers (lb/acre) (Iblacre)
mmlddlyr start Time Total Operating Flow Rate Total Volume per Acre (Ib11000 gall End Time Minutes (gal/min} (gallons) (gal/acre) (8)x 191 (B)-(10)
1000
44- 1- ' O O ZrC7 Z. O�
-19k-Q5, Y.� 1101o0 2G 5.38.41�+
-es 4 'Z S33.tz
%%v as :eo g� I 5Z 1'r =Vs 1-4 1.4'Z -LCIZ, QtO 'ya
4, 'Z 8 0,,o 5Z8. jv
o
O
{1'.
%O12r Z), 1.
Crop Cycle Totals Z
Owner's Signature Operator's Signature
Certified Operator(Print) Operator's Certification No. p
1 NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section 633,
z Enter the value received by subtracting column (10)from(B). Continue subtracting column (10)from column (11)following each irrigation event.

z<:) �t-t✓ - ...7
FORM IRR-2 Lagoon Irrigation Fields Record `
One-Form for Each Field per Crop Cycle
Tract# Field#_1 Facility Number 1 -
Field Size(acres)=(A)
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN Loading .z
(Iblacre)=(B) F .
1 2 3 4 5 8 7 8 9 10 11
Irrigation
Volume Waste Analysis PAN' PAN Applied Nitrogen Balance'
Data #of Sprinklers (Iblacre) (lb/acre)
meV to Start Time Total Operating Flow Rate Total Volume per Acre {Ib/100o gal) (8)x(9) (B).0 0)
End Time Minutes (gaVmin) (gallons) (gaVacre) 1000
(3)-(2) (8)x(5)x(4) M
A ,
1:OQ 1 Z 00 O
Crop Cycle Totals
Owner's Signature Operator's Signature �—
Certified Operator(Print) Operator's Certification No. Q $�
1 NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section 633.
2 Enter the value received by subtracting column (10)from(B). Continue subtracting column (10)from column (11)following each irrigation event.

FORM IRR-2 Lagoon Irrigation Fields Record 4 `
One'Form for Each Field per Crop Cycle
Tract# I Field# r Facility Number l -
Field Size(acres) =(A) Z<z,n - 1• c..
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utlllzation Plan
Crop Type Recommended PAN Loading
(lb/acre)=(B)
1 2 3 4 5 6 8 9 10 11
Irrigation
volume Waste Analysis PAN PAN Applied Nitrogen Balance°
Date #of sprinklers (lb/acre) (Iblacre)
mmlddlyr Start Time Total Operating Flow Rate Total Volume per Acre (Ib11006 gal) _M x{g} (B) (10)
End Time Minutes (gallons} (gaUacre)
(3) (2) (gal/min) (5)x(5)x(4) _L7)_ 1000
A
Z1 0�0 Ca 155
% ,aZ
4
Z 1 9
51
s.. o
—15
. 5
s z
Crop Cycle Totals -t S z
Owner's Signature Operator's Signature (1 _
Certified Operator(Print) Operator's Certification No. 00,—:D c-, S- T
1 NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section 633.
2 Enter the value received by subtracting column (10)from(B). Continue subtracting column(10)from column (11)following each irrigation event.

FORM IRR-2 Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
I�
Tract# Field# Facility Number
Field Size(acres) =(A) t-
Farm Owner Irrigation Operator
Owner's Address Irrigation Operator's
Address
Owner's Phone# Operator's Phone#
From Waste Utilization Plan
Crop Type Recommended PAN Loading
(Iblacre)=(B)
1 2 3 4 5 $ 8 9 10 11
Irrigation
Volume Waste Analysis PAN` PAN Applied Nitrogen Balance'
Date #of Sprinklers (lb/acre) (Iblacre)
mm End Time Minutes/dd/yr Start Time Total Operating Flow Rate (gallons) (gaUacre)Tom Volume per Acre (lb/1 q0q gal) _{81_x(9) (B).(10)
(3) (2) (gaVmin) (6)x(5)x(4) ___)_, 1000 9.
3
1
Crop Cycle Totals ZZ ZZ.
Owner's Signature Operator's Signature ,^.L
Certified Operator(Print) Operator's Certification No.
1 NCDA Waste Anaylysis or Equivalent or NRCS Estimate,Technical Guide Section 633.
z Enter the value received by subtracting column (10)from(B). Continue subtracting column (10)from column (11)following each irrigation event.

CERTIFIEDU.S. Postal Service
a RECEIPT
(DomesticOnly, • Insurance Coverage • ••
.7
ru f
FICOAL Usa
postage $ • 33 _*�N G TO"0
m 1� r�
M1 Certified Fee ,. "l QI I�ark
t1T Return Receipt Fee n '�
a (Endorsement R squired) Z5`
M (�
p Restricted Delivery Fee _!E 0 1
(Endorsement Required)
(� .. Total Postage 3 Fe" $ Zit
., senr ro
a wP ---- — �/C
C3 Street,Apt.No.;or Box No. p ��
y --•------------------------------------------- -
M1 �,yy:,,sstfe,ZIP"
• t��
See Reverse for Instructio%V
. t :
SENDER:,COMPLETE THIS SECTION COMPLETE THIS SECTION ON DELIVEPY
9-Complete items 1,2,and 3.Also complete A. ived by(Please Print Clearty) 8. Date of Delivery
item 4 if Restricted Delivery is desired.
■ Print your name and address on the reverse a d�
C
so that we can return the card to you. C. Signature
■ Attach this card to the back of the mailpiece, X �r ❑Agent
or on the front it space permits. r"�L-�c�--- ❑Addressee
D. Is delivery add different from item 1? ❑Yes
1. Article Addressed to: If YES,ent delivery address below. ❑No
-ToYce--
/ 3. Service Type
� rrP� / AIiG 0-6'S--PO EV(rtiffed Mail ❑ Express Mail
❑Registered ❑ Return Receipt for Merchandise
❑ Insured Mail ❑C.O.D.
4. Restricted Delivery?(Extra Fee) ❑Yes
2. Article Number(Cop from service label)
7&& f(o7 4ay5 T37� -
PS Form 381 1,July 1999 Domestic Return Receipt 102595-00-M•0952

State of North Carolina
Department of Environment
and Natural Resources
Wilmington Regional Office /
James B.Hunt,Jr.,Governor
Rill Holman, Secretary NCDENR
Division of Water Quality
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
November 22, 2000
Ccrt fcd Mail 9 7000 1670 00IV 7378 5624
Return Receipt Requested
Mr. Richard Joyce
Joyce Farms-
265 Mason Town Road
Newport,North Carolina 28570
Subject: NOTICE OF DEFICIENCY
Joyce Farms
Facility Number: 16-1
Carteret County
Dear Mr..Joyce:
On October 13, 2000, Mr. Brian Wrenn from the Wilmington Regional Office of the
Division of Water Quality, inspected your animal operation and the lagoon(s) serving this operation.
Leaks in the flush tank recycle system were observed. Animal waste was ponded around the flush
tank on the #2 hog house and had runoff into the farm path. It was also observed that the weekly
freeboard levels-were not being recorded.
General•Permit No. AWS 160001 issued to you on April 2, 1999 requires that the collection,
treatment, and storage facilities and land application equipment and fields be maintained at all times
and properly operated. Your General Permit also requires that lagoon freeboard levels be recorded
on a weekly basis. In addition, minor erosion on the inner dike walls of the lagoon should be
repaired. We suggest that you contact your service company, local NRCS or Soil and Water District
office for any assistance they may be able to provide to correct the situation.
To remain a permitted facility, you must notify this office in writing within fourteen (14)
days of the receipt of this notice, what actions will be taken to comply with your waste management
plan. Failure to do so may result in the facility losing it's permitted status, requiring it to obtain an
individual non discharge permit.
127 Cardinal Ur.Ext.,NVihningtoa.North Carolina 28405 'Telephone [phone] FAX [phone]
An Iielual Opportunity AlTirmalive Action Employer 50%recycled/10%,post-consumer paper

Mr. Richard Joyce
November 22_, 2000
Paae 2.
Please be aware it is a violation of North Carolina General Statutes and Rules to discharge
wastewater to the surface waters of the State without a permit and/or to fail to follow a certified
waste management plan. The Department of Environment, Health and Natural Resources has the
authority to levy a civil penalty of not more than $10,000 per day per violation.
When the required corrective actions are complete,please notify this office in writing at the
address below. If you have any questions concerning this matter, please call Stoney Mathis or Brian
Wrenn at 910-395-3900.
Sincerely,
Brian L. Wrenn
Environmental Specialist II
cc: ilntington Files
127 Cardinal Dr.Ext.,Wilmington,Nort s Carolina 28405 Telcphont 910-395-3900 FAX [phone]
An Equal Opportunity Affirmative Action Employer 50%recycled/10%posl-consumer paper

RC 7�-41VED
DEG 0 4 2000 Joyce Farms
Richard E. Joyce
265 Mason Town Road
- -^ Newport, NC 2$52
Facility Nu ber: 16-1
December 1, 2000
Mr. Brian L. Wrenn
State of North Carolina
Dept. of Environmental and Natural Resources
Wilmington Regional Office
127 Cardinal Drive Ext.
Wilmington,NC 28405
Dear Mr. Wrenn,
Since your inspection on October 13, 2000, we have replaced the bucket that
broke during the night prior to your arrival and inspection. Thus stopping the ponding of
hog waste and subsequent runoff onto the farm path. We have tightened the hose clamp,
which stopped the leaking problem on a flush tank. We are keeping accurate weekly
records on the lagoon freeboard levels. This we have been doing since your last
inspection.
We have repaired and seeded the minor erosion on the inter dike wall of the
lagoon. We have been in close contact with Todd Kelly, our local Soil and Water District .
Representative, who has given us vital assistance and guidance in correcting the situation.
As the weather allows, we are reinforcing the lagoon dike on the south end by
adding more dirt. At this point, we are approximately half-way to completion.
Over the years, we have worked very diligently and been very conscientious in
regards to waste management when it comes to pork production in our state and on our
farm.
We hope this letter finds you in good health. And that this is sufficient action in
order to comply with our waste management plan.
Sincerely,
Richard E. Joy e

State of North Carolina
Department of Environment
and Natural Resources
Wilmington Regional Office / •
.lames B. Hunt Jr.,Governor
Bill Holman, Secretary NCDENR
Division of Water Quality
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
November 22, 2000
Certified Mail 9 7000 1670 0005 7378 5624
Return Receipt Requested
Mr. Richard Joyce
Joyce Farms.
265 Mason Town Road
Newport,North Carolina 28570
Subject: NOTICE OF DEFICIENCY
Jovee Farms
Facility Number: 16-1
Carteret County
Dear Mr..Joyce:
On October 13, 2000, Mr. Brian Wrenn from the Wilmington Regional Office of the
Division of Water Quality, inspected your animal operation and the lagoon(s) serving this operation.
Leaks in the flush tank recycle system were observed. Animal waste was ponded around the flush
tank on the 42 hog house and had runoff into the farm path. It was also observed that the weekly
freeboard levels were not being recorded.
General Permit No. AWS 160001 issued to you on April 2, 1999 requires that the collection,
treatment, and storage facilities and land application equipment and fields be maintained at all times
and properly operated. Your General Permit also requires that lagoon freeboard levels be recorded
on a weekly basis. In addition, minor erosion on the inner dike walls of the lagoon should'be
repaired. We suggest that;you contact your service company, local NRCS or Soil and Water District
office for any assistance they may be able to provide to correct the situation.
To remain a permitted facility, you must notify this office in writing within fourteen (14)
days of the receipt of this notice, what actions will be taken to comply with your waste management
plan. Failure to do so may result in the facility losing it's permitted status, requiring it to obtain an
individual non discharge permit.
127(:ardinal Dr.Ext.,Wilmitt-loa.North Carolina 2140; 'Telephone [phone] FAX [phone]
An Ecloal OpporUinity Affirmative Action Employer 50°/6 rcercled/10%post-consumer paper

Mr. Richard Joyce
November 22, 2000
Page 2.
Please be aware it is a violation of North Carolina General Statutes and Rules to discharge
wastewater to the surface waters of the State without a permit and/or to fail to follow a certified
waste management plan. The Department of Environment, Health and Natural Resources has the
authority to levy a civil penalty of not more than $10,000 per day per violation.
When the required corrective actions are complete, please notify this office in writing at the
address below. If you have any questions concerning this matter, please call Stoney Mathis or Brian
Wrenn at 910-395-3900.
Sincerely,
c $ 1�all.- �renri
r
Environmentalpecialist Il
cc: Wilmington Files
f
127(,ardinal Or.Ext.,Wilminglnn,North Carolina 2840.1; Telephone [phone] 1,AX 910-350-2004
An Equal Opportunity Afrirmative Action Employer 50%recycled/10%post-cousumer paper

State of North Carolina
Department of Environment
and Natural Resources ITT V nWA
Wilmington Regional Office AL
James B. Hunt,Jr. Governor
Bill Holman, Secretary NCDENR
Division of Water Quality
NOFRTH CAROLINA DEPARTMENT OF
E mvIRONMENT AND NATURAL RKSOURCE5
October 17, 2000
CertifiedAlid 9-7000 1670 000 77378 5679
Return eipt Requested - - - - - - - - - - - - -
Mr. Robert E. Joyce
Joyce Farms
383 Cyrus Pollard Road
Newport, North Carolina 28570
Subject: NOTICE OF DEFICIENCY
Joyce Farms
Facility Number: 16-1
Carteret County
Dear Mr. Joyce:
On October 13, 2000, Mr. Brian Wrenn from the Wilmington Regional Office of the
Division of Water Quality, inspected your animal operation and the lagoon(s) serving this operation.
Leaks in the flush tank recycle system were observed. Animal waste was ponded around the flush
tank on the 42 hog house and had runoff into the farm path. It was also observed that the weekly
freeboard levels were not being recorded.
General Permit No. AWS 160001 issued to you on April 2, 1999 requires that the collection,
treatment, and storage facilities and land application equipment and fields be maintained at all times
and properly operated. Your General Permit also requires that lagoon freeboard levels be recorded
on a weekly basis. In addition, minor erosion on the inner dike walls of the lagoon should be
repaired. We suggest that you contact your service company,local MRCS or Soil and Water District
office for any assistance they may be able to provide to correct the situation.
To remain a permitted facility, you must notify this office in writing within fourteen (14)
days of the receipt of this notice, what actions will be taken to comply with your waste management
plan. Failure to do so may result in the facility losing it's permitted status, requiring it to obtain an
individual non discharge permit.
127 Cardinal Dr.Ext.,Wilmington,North Carolina 28405 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50%recycled/10%post-consumer paper

Mr. Robert E. Joyce
October 17, 2000
Page 2.
Please be aware it is a violation of North Carolina General Statutes and Rules to discharge
wastewater to the surface waters of the State without a permit and/or to fail to follow a certified
waste management plan. The Department of Environment, Health and Natural Resources has the
authority to levy a civil penalty of not more than$10,000 per day per violation.
When the required corrective actions are complete,please notify this office in writing at the
address below. If you have any questions concerning this matter,please call Stoney Mathis or Brian
Wrenn at 910-395-3900.
Sincerely,
4�- Z-,
xd
Brian L. Wrenn
Environmental Specialist Il
cc: Todd Kelly, Carteret County Soil and Water Conservation
Central Files
ilmingto)~i]es 1
COMPLETE THIS SECTION ON DELIVERY
■ complete'ta
i item 4 if Restricted Delivery isldesi edAso lete
A Received by(Please Print
■ Print your name and address on the reverse stal Service
so that we can return the card to you. i • •
■ Attach this card to the back of the mailpiece, �' Signature
or on the front if space permits. { (Domesi-lc Mail Provided)
1. An Add
to. D. Is delivery address d-
// , P � It YES,enter delivery addre 'n no) � (� � f� (] Tnt fi 11 !1 S (�
1otJC� i/h S u L tt j,�� Cl IVJ JC
Postage $ "
�f /f m
I 117` Certified Fee VD
N Return Receipt Fee t
3. Service Type Q (Endorsement Required)
A J O a
'x/�j o mortified Mail Expr p Restricted Delivery Fee
Registered Retu (Endorsement Required) q ✓��v -1
❑Insured Mail ❑C.O.1 C3 !b Z
2. 4. Restricted Delivery?(
r`- Total Postage&Fees $ �.
d �U'
F .�
Article
mbar(Copy from Service labe , - Sent Tor
vvC� 16 70f
737$ .5�7 :: > o Z7.-------PS Form 38 i 1,July 1999 p St t,Aor.No.;o ao$ox No.
Domestic Retum Receipt g'3
'. tt -C�.ty-}�-�ate.ZlP+4 -------
127 Cardinal Dr.Exi.,Wilmington,[Norm% ,,,,,,..,., . N IfG 29S—?0
An Equal Opportunity Afi-trmalive Action Employer _ PS t

State of North Carolina
Department of Environment , •
and Natural Resources f
Division of Water Quality
James B. Hunt,Jr., Governor
Bill Holman, Secretary NCDENR
Kerr T. Stevens,Director NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
Robert Joyce
Joyce Hog Farm
383 Cyrus Pollard Road
Newport NC 28570
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 16-1
Carteret County
Dear Robert Joyce:
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded,you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals,and commercial fertilizers.
Beginning January 1, 2000,all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. ERR I, IRR2, DRY I, DRY2, DRY3, SLUR1, SLUR2,
SLD1,and SLD2)and maintained in the facility records for review. The Division of Water Quality(DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter,please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at(919)733-5083 ext. 571.
Sincerel
X
Kerr T. Stevens,Director
Division of Water Quality
cc: Wilmington Regional Office
Carteret County Soil and Water Conservation District
Facility File
1617 Mail Service Center,Raleigh,North Carolina 27699-1617 'Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50%recyele&10%post-consumer paper

I �
State of North 'bar olina
Department of Environment
and Natural Resources ffl?X
•
Division of Water Quality f
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
April 2, 1999
Robert Joyce
Joyce Hog Farm
383 Cyrus Pollard Road
Newport NC 28570
Subject: Certificate of Coverage No. AWS160001
Joyce Hog Farm
Swine Waste Collection, Treatment,
Storage and Application System
Carteret County
Dear Robert Joyce:
In accordance with your application received on September 18, 1998, we are forwarding this Certificate
of Coverage (COC) issued to Robert Joyce, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the Joyce Hog Farm, located in Carteret County, with an animal
capacity of no greater than 818 Farrow to Wean and the application to land as specified in the Certified
Animal Waste Management Plan(CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
P.D. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50%recycled/10%post-consumer paper

Certificate of Coverage AWS 160001 � '
Joyce Hog Farm
Page 2 ilfir Ri 2 4
BY:
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the rig t to
apply for an individual non-discharge permit by contacting the engineer listed below'for information on
this process. Unless such a request is made within 30 days,this COC shall be final and binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]_ If you need additional information concerning this COC or the
General Permit,please contact Sue Homewood at [phone] ext. 502.
Sincer ,
�L Kerr T. Stevens
cc: (Certificate of Coverage only for all cc's)
Carteret County Health Department
%Wilmington Regional-Office, Water Quality"Section-]
Carteret County Soil and Water Conservation District
Permit File
NDPU Files

State of North Carolina
Department of Environment
and Natural Resources •
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director NCDENR
NORTH C.ARoumA DEPARTMENT of
ENVIRONMENT AND NIQURAL RESOURCES
August 21, 1998
CERTIFIED MAIL $i�C��V �
RETURN
RECEIPT REQUESTED
o ert oyce
Joyce Hog Farm AUG 2 0 1998
383 Cyrus Pollard Road BY:
Newport NC 28570
Farm Number: 16- 1
Dear Robert Joyce:
You are hereby notified that Joyce Hog Farm,in accordance with G.S. 143-215.1 OC,must apply
for coverage under an Animal Waste Operation General Permit. Upon receipt of this letter,your farm
has six 60 days to submit the attached application and all supporting documentation. In accordance
with Chapter 626 of 1995 Session Laws (Regular Session 1996), Section 19(c)(2),any owner or
operator who fails to submit an application by the date specified by the Department SHALL NOT
OPERATE the animal waste system after the specified date. Your application must be returned
within sixty(60) days of receipt of this letter. Failure to submit the application as required may also
subject your facility to a civil penalty and other enforcement actions for each day the facility is operated
following the due date of the application.
The attached application has been partially completed using information listed in your Animal
Waste Management Plan Certification Form. If any of the general or operation information listed is
incorrect please make corrections as noted on the application before returning the application package.
The signed original application, one copy of the signed application,two copies of a general location
map, and two copies of the Certified Animal Waste Management Plan must be returned to complete the
application package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non-Discharge Permitting Unit
Post Office Box 29535
Raleigh,NC 27626-0535
If you have any questions concerning this letter,please call at(919)733-5083 extension or Dave
Holsinger with the Wilmington Regional Office at(910) 395-3900.
Sin c ely,
MV-
or ston ow , r., .
cc: Permit File(w/o encl.)
Wilmington Regional Office(w/o encl.)
P.D.Sox 29535,Raleigh,North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50%recycled/10%post-consumer paper

Revised April 20, 1999
JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA DETERMINATION
Facility Number Operation is flagged for a wettable
Farm Name: acre determination due to failure of
On-Site Representative: Part H eligibility item(s) Ft F2 F3 F4
InspectorlReviewer's Name: h V Operation not required to secure WA
determination at this time based on
Date of site visit:_ 1 D/Z__ 01 exemption E1 E2 E3 E4
Date of most recent WUP:_ Operation pended for wettable acre
determination based on P1 P2 P3
Annual farm PAN deficit: _ ZO-z� pounds
x
Irri ation S stem s - circle#: 1. hard-hose#i aveler,2: center.-pivot system; 3. linear-move system;
stationary sprinkler system wlpermanent pipe• 5. stationary sprinlcier system wlportable pipe;
G. stationary gun system w perma en e; . stationary gun system wlportable pipe
PART 1. WA Determination Exemptions (Eligibility failure, Part 11, overrides Part I exemption.)
. r
E1 Adequate irrigation design, including map depicting wettable acres, is complete
and signed by an I or PE.
E2 Adequate D, and D�D3 irrigation operating parameter sheets, including map
depicting wettable acres, is complete and signed by an I or PE.
_ZE 3 Adequate D, irrigation operating parameter sheet, including map depicting
wettable acres, is complete and signed by a WUP.
E4 75% rule exemption as verified in Part 111. (NOTE:75 % exemption cannot be
applied to farms that fail the eligibility checklist in Part 11. Complete eligibility
checklist, Part II - F1 F2 F3, before completing computational table in Part ll[).
PART 11. 75% Rule.Eligibility Checklist and Documentation of WA Determination
Requirements. WA Determination required.because operation fails one of the.eligibility
requirements listed below:
_ F1 Lack ofacreagemhich-resultedinmver�appIication:ofwastewater_(PAN) on spray.
fields)accord ingfofarm'sdast-two-years mf-Jrrigabon7ecor=ds.
F2 UnclearjIlegible,-or lack of information/map.
F3 Obvious-field-limitations-(numerousA itches;failurefo:deductTequired.-__
bufferlsetbackmcreage;-or25°/Q nf#otal:acreageddentified:in.CAWMP:includes
small,--irregularly-shaped.fields--#ields:less-t ran-than -for.travelers-or.less�han
2 acres for stationarysprinklers).
F4 WA determination required because CAWMP credits feld(s)'s acreage-in excess
of 75% of the respective field's total acreage as noted in tables in Part III

Revised April 20, 1999
Facility Number 1(, - l
Part 111. Field by Field Determination of 75% Exemption Rule for WA Determination
TRACT FIELD TYPE OF TOTAL CAWMP FIELD COMMENTS3
NUMBER NUMBER',2 IRRIGATION ACRES ACRES %
SYSTEM
3 5.s �Qrm 11,_z- 1_1S ~7 7. z
I
I
FIELD NUMBER' -hydrant,pull,zone, or.point numbers may be used in place of field numbers depending on CAWMP
and type of irrigation system. if pulls,etc.cross more than one field,inspector/reviewer will have to combine fields to
calculate 75%field by field determination for exemption;-otherwise operation will be subject to WA determination.
FIELD NUMBERZ-must be clearly delineated on map_
COMMENTS'- back-up fields with CAWMP acreage-exceeding-75% of its total.acres and having received less than 50%
of its annual PAN as documented in the farm's�revious-two years' (1997&1998)of irrigation records,-cannot serve as the
sole basis for requiring a WA Determination...back-up fields Ynust benoted in the-comment sec-5on-End must be accessible
by irrigation system.
Part IV. Pending WA Determinations -
Pi Plan.lacks.fol lowing-information:
P2 Plan-revision may_sabsfy75% rule based on adequate overall PAN deficit-and by
adjusting all field acreage#o below 75% use rate
P3 Other (ielin process of installing new irrigation system):

. —~
' �
ANIMAL ��� Y k3Ua WASTE UTILIZATION PLAN uu / w /^xu
Producer : ROBERT P. JOYCE
Location : 383 CYRUS POLLARD RD.
NEWPORT NC 28570
Telephone : [phone]
Type Operation : Existing Farrow to Wean } in3 Swine
Number of Animals : 818.00 sows
(Design Capacity)
' STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your anima ; facility must be land applied at a
� specified rate to prevent po | | ution of surface uator and/o
r
groundwater . The plant nutrients in the animai waste should be used
to reduce the amount of commercial f:rtMzcr ,oquireo for the crops
� in the f i e | ds whare the waste is to be app | i ed .
This waste ut i | i zit i on » i ao uses n i tr o9en as the ! i m i t i n8 nutrient .
� Waste should be ana . yzcd before each application cycie . Annual soil
' tests are strong | y encouraged so that all p ) ant nutrients can be
ba | anc�d for rea } / st � c yields of tnc crop to b, grown .
.
� Several factors are important in implementing your waste utilization
� plan in order to maximize the fertilizer value PP the waste and to
ensure that it / n applied in an covironmpntaiiy saVe manner :
1 . Always aoo ; y waste based on the needs of the crop to be
grown one tne nutrient content of the x�ste ' Do not apply
more nin',Uen than the crop can uti | izc .
2. Soil types are important as they have dMcrent infiltration
rates , ` eachin3 potentials , cation cxchao2e capacities , and
available water holding capnc | ties .
. 3. Norma | iy waste shall be appKed to > ano eroding at less than
5 tons ner acre per year . Waste may be aFP | \ ed to land
erodlo3 ^ n 5 or more toms per acre nnnwa | iy' but less than
10 tons pe' acre per year prov ; u \ ng thxo pdequate filter
strips a`a �s�ao ^ ' shed .
4 . Do not vpp i y waite on saturated so i / s ' ,nen it is raining ,
or wheN noe surface ; s frozen ' Either of toese conditions
may result in runoff to s/nfacc wutars wn / ch is not allowed
under DEN ' egu | ations .

rr i fill 11 to it 1i r1 i. .. .. .:...... ....
Page : 1
ANIMAL WASTE UTILIZATION F L4W
1'1f'f!'1fiI1I'1r�Pff1P1f]i'�1 iP7ri:`Yr`'ir`J;^ir ir';i-! ]i'Ir?;r`'r`r'!i''lr`'1r'1r'!r"I{i`r 1r` ."ir";i Flr:�il Jr"ii tr';`r'r'f;r';r';jf;`s'ri F,ii'1Iir7P�C�fdP�,"11°1f1F11'1!'�1'�1"fP1l fi'f
5. Wind conditions 'ic11ou ! o also be - _ Nsiee';•;-ed to avoid drift and
downwind iidQr- problems ,
6. Toma}: i !fF i Q t:ne t�a i ;te o'o f '1':i1:i' nutrients 3:!r crop production
and to reduce the potential for y:or:o : r u i o_n , the Waste should
be applind to a Sro',w i ng crop or applie6 not more than 30
days prior to p i ant 1 n'ra a crop or f ora l`i' i breaking dormancy.
Injt?.ctino the waste or di kin'"_I wi . i conserve nutrients and
reduce odor problems -
This plan is b'a.rk, o _ on ;hr least( appiicRtion Ii'etnon shown above . If
you choose to Cfoi.nge mo,,s;hoo-I's in the future , you need to revise this
plan . Nutrient levisis for d i l`Ppr =i4t ap i i .it i n methods are not the
same .
The estimated acres needed to apply tj e animal waste is based on
typical nutr- igiant r-f,n.;,e" for this tyDe OF faci 1 i 'i;y . Acreage
requirements si oo l _ on briel on the waste a:" a i ys i s report from your
waste management f.a i l i ty . in so!Ile cases you may o,.,•ant to have plant
analysis made , which - ou i d a l l ow additional Waste to be app l i ed .
Provisions shall 6e made for the area ref:QftifIn", waste too be flexible
so as to accrofirmo:�dar:t:� chin' in wisst:e analysis �: � 1 crop 0
,� ,� i �.r� , t, content ri.F e;r and r.. F type .
F e .
Lime must be applied to maintain pH in the optimum range for specific
crop production .
This Waste ut i I i ; ..~ ion p 1 an , i a., carried out , meet,- the requirements
compliance # c i o. �o.. ,0 . L ;i1,ed by the Environmental
f fo r with l l 1:.!,'� � .. 1.: r;.1'� 1,_.: :±.+i o 0
Management Commission .
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons , f t3, tons , etc . )
81 sows M 6. 1 tonn ..a 't;t.-:•/so;ows/v ear.. __ 4989 .a ti_rnr,
AMOUNT i iF" PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
18 sows x 5.4 i ioc ,'iiN oo;c, f r,ra.r- -- 441V.2 ' us . !'-A yewr»
Applying the above r:::.'un . wasne is , l job . , .u should plan time and
equipment C'r;1�`n to apply ;;'' e ,.:.:,'rite in ca t. ime manner" .'
have appropriate - 1 ; . � !; i' I" � Y
The fio l lowing al.:t'f.:':d,ge w i ! be needed for waste "app l i cat; i r=on based on the
crop to be Srfown , soil T'..' n an:I r_'.orf:acc a pi ! Cat : :on

` Pagel 2
ANIMAL._ WASTE_ UTILIZATION FLAN
hl`hfh�hfhthirhlhfhlPlhlhlhl,^fPih�Pil;fff`f,'1,^�hih11 ff�f�;•'!,'!r''!r^i,^!1•�hitif i,^rl•iri,^11•ft•>1•i;9i7;i�-1fr,'•i;;;•1?f,^�h�,^;'h�hfP�h�h�i'�h�h�hfP�h�hfl�h�hl
TABLE 1 : ACRES OWNED BY PRODUCER
TRACT I FIELD I ,CITE_ f4'1=E= i_i_..;�Sfi- {':i i f1- ,':[ES-i) ; s._.PS ; 0MM N 1
DETERMINING PHASE ! CODE ; AN N 1 PER 1 ACRES 1 AW N
PER AC ; AC: ; ; USED
„-- :
Ai"F-1-Y : I 1 RESID. 1 1 APFLIC
t , ,
, , tr,.:. i , N , TIME
346 11 1 NoD i BH i 6. 1 1305 I 111Z.5 :3812.5
1 1 ; }: I 1 ; 1 !FEB-SEPT
`'�1-----TO
;O i---F..._......--__....................»».....-..........._...........»».-_....».....-.»;S. .-...1_�-..-»...-.._;�1'J'- _.»_...;.....--.-._...-i 12.1-i !�'�+-',',�----
: 1 ; I I ; 1 : SETT-MAR
------------------------------------------------- -..-___._..--..._w--.-______---_--._..___-_---
1 I END
TOTAL : 44S7.F,
- Indicates that this field is tieing ovf rseeded ( i . e . i nterp I anted ) or-
winter annuals fn 1 1ow summer annuals .
NOTE: The applicator is cautioned that F and K may be over applied wh i I e
meeting the N requirements . In the future , regulations may require
farmers in some parts of North Carolina to have a nutrient management
plan that addresses all nutrients . This plan only addresses nitrogen .

Page : 3
ANIMAL WASTE UTILIZATION FLAN
Prl'rMrrrflfPrArPrPrPfrr,°r,°rlrtrr rf'ir1 i rtrPf tlr"#I'rr'�r''lriJ'rF'il"rF°#(i,'rr'':,'rrrr#r`r:•f,„-r�'#,d,'1 f'fPir•ii'rl�ir'#Prl'fl�irrPfriPrPrPrPrArArPfl rl'rPfMArP#
TABLE 2: ACRES WITH NOTARIZED AGREEMENT" OR LONG TERM LEASE
(A9r-eerner,t with ad j-ac..ent I a.nd o w n e r s rALl bF. attached
tRe11u re,-i on I `J I f operat r dC,es ri,: t owrl a.derivate land .
e, c e C i f i r:a.t, i i r ri
TRACT ! FIELD : SOIL TYPE CLASS,— ! C:RC)P : YIELD : i_F,S ; COMMH N : LL-,S
! ; D1-TEF; 11:i]I PJ: PHASE ! C ODE ; ; A N I PER ; AC:RES ! AW N
! ; !F ER AC-; AC ! USED
e r i r _
r , AFPl....'Y ! l RESID. ! 1 AF`F'1._,IC
! ;'r+1i=.."i r! ; ; ! N l TIME
! TEND ! ----
Indicates that this f i e i d is be i n:3 overse laded ( i . e . i nterp l anted) or , w i
annuals fol 1C,w 5urnifler annuals .
In inter Fr l ante,! f i e l ,lr l i , e , srn- 1 1 3r a i n , 45'�(_ , i nterseeded
i n t,erraudagrass ) , for-age mlrst be removed through jr-az i ng,
hay avid/or- s i I a.•ge . Where grazing , p l ants should be grazed
when they rear a. hie i ahit ,.,f e i t�� n i r,e inches . Catt I e
should be removed wher, p i an :> are .3rr1..-zed to a height of four
inches . In f i F� i ds where srna I 1 -.3ra. i n , rtc , i s to be removed
f,�r hay �,r s i ! age, c DJ shall i d t e erer"c i sed not to let sma I I
:3 r a i n to reach m a t u r i ty, es�reC i a ! ! y l at:e i n the seas,_,n E i . e .
Apr i I or Play) , Shag i rig may result if sma l I qr-a i n gets too
h i 3h and th i s w i l I de f i n i to l y i nterf ere w i th stand of
trerrnuda.3r-ass . Th i s I c,ss ,_rf st- r-,-1 w i I I resu It in reduced
yields and le- 5 n i trogen tie i rill u ; i I i ed . Father- that,
cutting 5tna I I. ;fir-?. I rl f+,r Iia`y' iJr 5 I I age just before heading as
s the n0r'r0ai 5 i tL1a I= ion , "VOU ar,e encouraged to cut the srnal I
grain rear- l i er . Y,-rl.r may w;7.nt- *r_r cori z i dot- Fr a.r-vest i n-.3 hay err
s i I a,3e twii I;it l';h,r'ee t; I rf}e=". di.lr i n.-I t;he Fieasien , depending on
time srna. I I ;-Ar-airi is I_, Iariti,d ir, the fal l'.
The ideal t i me to i riterp I an*: sma k i gra i rl , etc , i s I ate
September r,r- (2 ar I j! r,i;_toh,er T)r i i r,q i s r e c oinina nded aver
t,rc:-adcast i n .; , ermu ia3ra.ss s h o u l + r;,e graz.pd .r mewed to a
height of about two i nch,t�5. test reSUI tS .
*� Acreage figures e;;r_eer_l tote, l a.c.r f a—' e in fir ! ds due to overseed i ng .

' Page : 4
. . . .
' . .
�
ANIMAL WASTE UTILIZATION PLAN
* | bs AW N ( animal waste nitro3eo ) equa\ s total required nitrogen less
any commercial nitrogen (COMM N) supplied .
The following legend explains the crop codes used in tables 1 and 2 above :
__________________________________________________________________
| CROP CODE CROP | UNITS !PER UNIT |
�___________ ------------------------------------------ | ------------ | __—_—___ |
| BH | HYBRID BERMUDA8RASS-HAY | | 50 |
| SG | SMALL GRAIN | AC | 50 �
\___________ ------------ |________ |
TOTALS FROM TABLES 1 AND 2
_____________
| ACRES � LDS AW N USED |
/ ___________ / __________________ /
TABLE 1 | 12.5 | 443T .5 �
\ ----------- | __________________ �
TABLE 2 | 0 | 0 \
| ___________ | ______ __________ |
TOTAL | 12.5 | 4437 ,5 |
� -------____ � __________________ 1
' *** 8ALANC£ 1 -�8 .3 |
--------------------
This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced .

Page: 5
ANIMAL WASTE UTILIZATION FLAN
a"ilililifilililllililiPllit•1f•flliit�tii r�iPlriPiPl�iFiti��,tritalit{PfPiPiti!'il°itil°1!•filPif•it i�`i/i11r1fiPitltiPfPff1PT!'1!'1PrP11.1P1Ml1Tfli!'•1
* This number- trust bq i ess t a.n r-rr eIual tf, CJ i n rtrdpr to fuI I ut i l i ze
the an i rna I was t_� ;J pr'r_rdLkr er.1 .
Acres shown i n each c f the pr"ered i n,7 t-ab 1 es are cons i tiered to be the usab I e
acres exc i ud i rig rfyqu i red buffers , f i I 'a;er" 5 tr i ps a. l un-1 d i tches , odd areas
unatr I e to be i rr i g�.).tied and pet i nira t�'r a.r eas not receiving f u l l ap I i cation
rates due to egu i pment I i in i tat: i rns . Ai_tt_ta I tota I acres i n the f i e i ds
i sted rr,ay, and mr,7; t: i i r::e I y w i I i be , mr,re Char, the acres shC,wn i n the
tables .
See attached map hc-w i ng the f i e I r:is ' t be use,:l fr_-F' .the ut i I i z a t i on rrf
animal waste .
SLUDGE APPLICATION:
The waste ut 1 l i at i on ' Ian must contain prov i s i r_rns for periodic land
app l i cat i :rn of s l S d,:je at aarorfrrrn i c rates . The sludge will be nutrient
rich and -will require precautionary measures to prevent over application
of nutrients or other" elements . Your production facility wi l I produce
approximately 719. t pourirls rrf R i ant ava. i ! able n i tr ogen per year in the
sludge .
If you remove the sludge every 5 years , YOU wi I I have approximately :5i --'7=f.2
pounds of FAN to utilize . Assurn i n,3 you apply this FAN trr hybrid
bermudagrass hayl anri at the rate of =:00 pounds of nitrogen per acre , you
will need 11 acres of 1 arid . If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre , you wi I I need Z8.79-1:6 acres
r,f 1and . PI ease be aware that tl-iese are only estimates of the FAN and
and needed . Actual requirements could vary by 25% depending orr your
sludge waste analysis , soil types , realistic yields , and application
methods .
APPL I C*AT I ON OF WASTE- 1:,`; 1;-,R'1+. A.T;.0N4'
The i rr i qat i on app I i S_-it i on ri?,t'e shoo I i not i S:Ped the i ritar.:e rate_ of the
sr, i I at the t ime of i rr i oat i un SUCK thta.t rt.inr:4—f or porid i rtg occurs . Th 1 s
rate is I i m i ted by i n i tial so i I moisture c onterit , 1 i structure , so i I
texture , '.later" drop I et size , arid orsan i c 5=r 1 i ds . The app I i cat ion arnount
5hiral! I d not exceed the a.va. i I a.tr l e water h,rr I d ; n_I c a.pa.r- i ty of the sri i I at the
t irne of i rr i gat i on nor- shot.i i d the p i -ant av8. i I i:ub 1 e n i tro—jen app I i ed exceed
the nitrogen need: r+f thn crop ,
If surface irrigation is the method rrf land app i i r;a.t i Crn for this plan ,
it is the respons i b i 1 i ty 4f the proc:ucer r1..n,'s -Jesine t ensure fi
that an i rr i gat i r,rn `-ystem i s i nsta 1 1 ed to rr -,'.,per- i '•,' i rr i gate the acres
shr,wr, i r, .Ta,b I es 1 -arid F—,3.i i :.+r e t-r, app ; '., 71m rer.. c•inir;erided rates and

PaSe 1 6
ANIMAL_ WASTE UTILIZATION FLAN
rrJSrJ^r!•i�rrrrr,nrtrJ^rrr,•r�rr rr•rrr,'•ri•IJ"rJ'>rJprJ^rrrJr>rJ^rJ�rl�rr'•rr`•rJ^IrrJ�iJ}�'z•r�>�J'•rr'•rr�rJr•1J"rirJ`rI•r!-rr'•rt`•r,^rJ'•rl-r�rtrrrr�rrrrrrJ"rJnrri,^r�rrrrrrrrrrrrr�rrr!^r
amounts of nitrogen shown in the tables may make this plan i nva I i d .
The f o l l wing table is Provided as a. 3u i de for establishing application
rates and amounts .
--_____----___--_-_..-_.._.._._.._.._-._._--.___...---�---------..- --_...._--�-------�-----�---- - ---`_--�-----------
i i i i ! Ai':+ l i c at i on Rate i A-+F+ l i C Amount 1
;Tract 1 Field 1 Soil Type 1 Crop 1 ( i n/hr ) 1 ( inches )
1'34r 1 1 1 NAIL. I:H 1 .5 1 *1 1
1 ,
i 3 4 6 i rJ 1 i i .-.1 3 i .5
1 __—............ t t -........-....._.......... __.-..__..__..._.......... ......_. t t -----.-.......—_...—_-----.--,
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
app l i ed . In many situations , the' app l i cat i ,„ n amount shown cannot
be applied because of the nitrogen I i m i tat i on . The maximum
application amount shown can be apt, l i ed under optimum so i l
conditions .
Your fac i l i ty is designed for_ 180.00 Days of temporary storage and the
temporary storage must be removed on the average of once every 6.00 months .
In n1_I instance should the volume of the waste be stored in your stracture
be within the 25 year 24 hour" storm storage or one foot of freeboard except
in the event of the 25 year 24 hour storm.
It is the r-espons i b i l i ty of the pr-,,I,'ucer and waste applicator t1_+ ensure
that the spreader equipment is operated properly to apply the correct rates
to the acres shown in Tables I and 2 . Failure to i,.pp i y the recommended
rates and amounts of nitrogen shown in the take l Fps may make this plan
invalid .
Call your technical specialist after .you receive they waste analysis report
for assistance in oetermi n i ng the arr,=-punt of waste per acre and .the proper
application rate prior to applying- the waste .
NARRATIVE-OF-OPERATION

I'r11!4!IJ,1 I!i i I I I I I I I I I71I 11 I!f!1!!f
Page : 7
WASTE UTILIZATION FLAN
lrMrrrl!'lhrrrrrhrrrhrhrhrhrl"rhrl'r,'rhrr''rhr,"r!+!•rr`li•r,-rl-rl•rl'11`•ii-rlrhrlri„'•71�irr1•rri�ri ri•rlrrrr>rrr!•rr'•1�•Jh!!'1hr!•rPrr"lPrPrPrhrPIPrPIPrPri fF�1
F':;qg Z EED_SF•EC.I F I C.AT I ONS
1 . Animal waste shall not rF„acin -sut-Fare waters of the state by
r"unctff , dr i Ft, , rna.rsmade direct app I i cat i on , or-
direct ,:,i 1 SChia.I ;�e r Isr i n k oper"a.t i or, or 1 a.r,+j a���, l i Cat i f--,n Any
discharge of waste which reaches surf-ace water is prohibited.
2. There must be c,cur pntat i i-in in the ,des i :art fu 1 der that the
producer" either owns or has an agreement for use :if adequate
arid ---ri which tc, properly -apply tests wa.5'ue . wf the producer does
rrr_rt crwri ade-I'u a to I -and t,:, pri,ptr i y.• d i sposp of viaste , he/she sha 1 1
provide a copy of art %3;7r eetnent with a I andriwner who is within a
reasc,riatr I e pr_r.; i m i ty, a I I ow i rig h i m/Fier the use of the I and for
waste app I i C at i ran . It i ?s this r Psporis i t, I I i ty r',f the owner of the
fac i I i ty to =•e•cure aro u.Pdate r_,f the W1a.,t.e Ut i I i z-at i on P1 an where
there" i 5 a cha.n3e i ri the cper a.t i on , i ricrease in the number of
animals , fneth_,d +_-,f U t i I is ation , f,r a v a i Iat, Ie Iar,d .
. Art i rnal waste sha.l i tie a.pp 1 i ed to ineet , but not exceed , the
n i t r o o v n reeds for- r-ea l i st i s crop y i e I ds based on so i I type,
avai Iabie moisture ? h15tc+rical data, c1 imatic conditions, and
level of ma.riagernent , unless tFier-e are regulations that restrict
the rate {.f axa{., 1 i r;.: -,rl for other nutr i erns .
4. An i ma I waste sha I I he a,pp I i ed t,+ I and er,.7,,J i nr i ess than- 5 toris
per acre per year . Waste may tie app l i ed to land that is eroding
at c or
more tons , but less than 10 ton5 per acre per year
providing grass f i I ter strips are instal led where runoff leaves
the f i e I d . (See FCITG Standard ;:) -F i I ter Strip )
5,, Cidors r-art tre r-educ_ed by i ri jec t i rig thte waste "r d i sfr i rr3 after
waste app I i c at i r.,ri . Wlaste shou I d n,_tt tie app I i ed when there i s
danger of drift from the irrigation field .
6. When an i ma I waste i s to be app I i ed ort arres subject to
f i ood i rig, i t w i t I tie so i t i ricr_rrpora.ted on c orivent i ona VI y t i I I ed
crop I and . When app I i ed tr�, c,_,ri s e ry at i on t i I I ed crt}ps 0r-
grassland , the waste may be h,r oadr-ast pr-,.+v i ,Jed the app H cat i on
does nr:rt ,-lcctAr d LitI i ri =r. r:e_ SC,rr pr c,rte to f j fror_I i ng (See "Weather"
a rid Ci i m a t e in 1,4,-,rtl'i f-arc, } iriia" fir- l.lid.ance . )
7. L Iqu i d WG.stC- Sha i 1 fie I i v,� at rates rtC,t to e x.teed the so I I
i r,f i I teat i ort ra.te s+..ich that; rursof f , es riot c,t~CUr +offsite or to
surface. waters and i rl a. d(}F,thrid wh i ch d,_,es not Cause dr i f t frrrrn
the s i to dur- i r,,� app I i c,at i ,"trt pi,rid i no shiiu I d occur- i n order"
to coritrr:+ I ,;fdor- r,r f I i es> .
Ar, i ma I wa.stl seta I I r,n-; i_e a;.,p 1 i ed to saturated so i I s , dur i rig
rainfal l v v e n t s ,_,t• whfiri thle surface is i`rc.zvn .
:f. Animal waste shai I tie appi ied ort act iveiy -.3r-,.,win3 craps in such
a mariner that: t!-,e Cr op i s r,ot rmvE%re4-1 w I t h Wn5 to to a depth that
would inhit, it M1�rr,' i'+ I't . Tlie pat{'rrtiai fr_,r s.ejt ,iarnage frrrrn animal
waste Sh OLI 1 d a i _s'., tie: Cr:rns i dere,_I .

WASTE UTILIZATION PLAN
MI11•iPiCiAftifilihyflFif'1r~ifi�if•ifffiFfPiPif°ifiMfiriritif'ilff�Pihllihlfir^7firi•rfr�f'rr��f;f�rfr�+r•rrrf9liPfP�P1AfPfP1Pt�1f r!'fpfP�P11•]Plf'�
CE�,rU 1 RED SPECIFICATIONS
L
is 10 Waste nutr i ents sI 3 I not be app I i ed in fa I I or winter- for
spring p l ante+l +.+r'i so i Is with a? high potential f or
I each i rig Waste glut:r i ent I grad i rig rates on tl--tese so i Is should be
he l d tQ a rn i n l rnl.lin arkd a Sr-t i tab l e- winter cover- crop planted to
take up released rrUtr- i ants a s t e ssial I n+:rt be a p p I i ed rnore
than 3f relays frr. i c tr} + I ant i ng of the r-rop or- fry+rages breal; i rig
dormancy.
11 . Any new swine fac: i I i ty s i ted +an or- after- 1lct Ober 1 , 19*P5 shall
i
c+-+rnp l y w i th th're f o I I raw i rk-- : The outer per i meter of the land area
Cr r,tc, wh i-ch waste i s it.pp I I ed from a l a goorr that is a comporient of
a sw i ne f ar-rn shall tie at least 50 feet fr rrn any residential-
property bcomdary and from any perennial stream ,_,r- river ( rather-
than an i rr i g-at i on ditch or cart: l Animal waste other . than.
swine Waste from fa.c i I i t leS sited on or- after- October 1 , 1995) ,
E
shale 1 not be a p p I i ed c I Loser tha.rt '_5 feet to perennial waters .
(See Standa.r d =;i: ; - Fi I ter` Str i ps }
12. Ark i rna I waste s Via. I I n o t br aF.,p i i [: d r" i c,ser thtz:+.n 7.00 f e e t to
I wells .
E -
i
'= 13. Animal waste steal I not be appI ied closer Mark 2-_'(40 feet of
i dwe I I i rtgs ot,I",er than t;hr-+se owrrse:d by tV;e i a.ndrrrirker .
i -
14. Waste shot I i be rt.pp I i e+1 i r+ a. roar,ner- n+_rt tr:r reach !ether pr-oper-ty
and pub i i c r- i =31-it--of-ways .
15. An i ma I w ste, sna I i no t be d i schar" .ge+l I f'tt+=+ i�iur face Wat@r"5 ,
draina.geways , c.,r rwlet' iand-, by ;k 61schar'g' e Jr" toy over-spraying .
Animal waste may be app I k e+d to prior coriverted cropland provided
they have been appro-,,,ed a.s a i and A.pp I i cat i +_,n site by a
"techn i c a. I spec i a. l i st" . An i rna. I -waste s.ha 1 1 rk+_,t tie app I i ed on
grassed water ways that d I Sch'iarr,}l?5 d i rect I y i rkton water" courses ,
and +ri -ther 9rassi-7d waterrways , .-paste sh'ka1 1 be appI ied at
air Crn.rkni c Y arCi='S in a. rnarler- that - -,1US@+a 1"10 r'lirioft +_rr di i ft from
n
the site .
16. Domestic and industrial waste fr'clrn washrlr_rwn facilities.,
showers , to i i et s , s I nks , etc . , sha l i not be discharged I rlto the
animal waste rrla.rkageroent system.
17. A protective cc.ver- of appropriate vegetation wi I l toe
i
k established or, all disturbed areas ( I agr—ir_rn erklbar,I::rnents , berms ,
pipe runs , etc . ) . Areas shall L-e fenced , as necessary, to:-
protect the re jetat: i ori . 've'3eta.t i ran sucl-i as trees , shrubs, and
rather" wc-ody species , etc . , are l i rn I t♦:'d to areas where considered
appr-crpr I a.te .. LaL:jo rr'r areas SitCrU I +l be kept mowed and accessible .
I:errns and structures shrauld be Inspected re'3ula-r- ly frir- evidence
raf er-Crt'> I irn , I E.)aka.;3t 4r- rd k =•C !"iarge .

WASTES UTILIZEATION FLAN
rfririririlititiririritltfl ftftiP ititif itltitititit ft ftit Ittit ir•I t I rite:^7tlMtitlt itil it i�Ir°it!`riritiririririririririririr�riririririri
RE��rUIF:ED��F'ECIF�C:A1"Ir_IN5
18. If animal production at the fac i l i ty is to be suspended or
terminated , the oI+JI"Ier is respons i b l e for obtaining and
implementing a "closure plan" which will eliminate the
possibi l ity of an i l lt?gal discharge , pollution and erosion .
19. Waste handling structures , p i FI i ng , pumps , reels , etc . , should
be inspected on ca regular basis to prevent br'eakdowns r leaks ,
and sp i l l s . A regular maintenance checr l i st should be kept on
site .
20. Animal waste can be used in a rotation that i nc I udes vegetables
and other- crops for direct human consumption . However r if
animal waste is used an crops for direct human consumption it
should only be applied prep l ant with no further applications of
animal waste during the croF' season .
21 . Highly visible markers si. al I be installed to marl; the top and
bottom e l oval i Dons of the temporary storage ( pumping volume ) of
all waste treatment i agoons, „ Pumping sha. l l be managed to
maintain the i i qu i d level between the markers . A marker- will
be required to mark the maximum storage volume for waste
storage pl, n- di .
22. Waste shall be tested within 60 days of u i l i at i on and sty i l
shall be tested at least annually at crop sites where waste
products are a.pp l i ed . Nitrogen sna. I l be the rate - determining
element . ._ i nc and copper i eve i s in the so i t s sha l l be
monitored and a. l ternat i vE crop sites sha l i be used when thes
metals appreach: excessive ieveis . PH shall be adjusted for
optimum crop production and maintained . ?o i l and waste
analysis records shall be kept for five year, . Poultry dry
waste app l i cation records sha I l be maintained for three (3)
years . Waste appl icati __n records for all other waste shall be
maintained for five (5) yeas..
23.. Dead animals will be disposed of in a manner that meets North
Carolina re:qu l a.t i ns .

ANIMAL WASTE UTILIZATION FLAN
rrrrrrrr�rrrrrrr!•rr�r•rrif•rr�f•rr'•i,"•i,Fr;•7,�7,^r!•rPfi•r,'if�r,•1hf!'fr''r1•ii•i!•flli•i,•7f•f;•fr�iryFi,•f,ti�`�•,r�rt�,•1r7r'•r,'•rl•rPrfrPrPrPrhrlrr'rPrr�rl'rl'rP1PfPrl'1Pr
WASTE UTILIZATION PLAN AGREEMENT
Name of Farrn:.JOYCE 1-OCi FARi'I
Owner _ L43r-eement
I (we) understand and w i l l f o i low and implement the spec i f i cations
and the c pera.t i +-+n and Ena i r,tenance l:+rc cedur-e s +stab 1 i shed in the
approved an i ma i waste ut i I i zat i on F+ I art for the farm earned above . I
(we ) kn++w that a.ny expar,s i on to the e t i st i ng des i ;3n capac.i ty of the
waste treatment and storage system ++r' C+» nstr-L,c t i vn of new
E faci I ities wi i 1 require a r,t?w certification to be submitted to the
North Carolina Division of Environmental t+iarra;3emer,t (NCDEM) before
the new animals are sttttc k.ed . I (wfl ) a l si-+ understand that there
must be no +_i i sch,_ ;r ::c e of a.r, i rr,a l waste fr-r,+fn this system to surface
wasters of the state fr-,.,rn a Storm event I e5s sFver-e than, the 25-
year- , 24-h our S#:arr,?. i he approved plan will be f i led on-site at
the fat-in office <tnd at the ; ffkcp +.+f t!' p local of I and Water"
Cr--+riservat i or, D i tr- i c t _zr,+_I k+ i I I LEI ava i t ab l e f r review by NCDEIrr
upon request- .
Name of Fac i I ity Owner- : ROI:,ERT P. JOYCE
(i='Iease_pLir,t)
Signature : _ _-_ -- -�_----- Date : _`� / --- ------_--
Nam e of M art a9er- ( If different frorn own er- ) :_W���¢f��
Signature : - - - -= -- - - D a t e : 51_ S/ Z----_-_------
Name of Person F'repar- ,g Flan: _(Please-pri•nt ) Andreaw W. Metts
Af f i I i at i t+n :NRCS F'h+_+r,e No . 919--6.:--'7-2547 -
Address (Agency) : 302 Industrial Dr .\
New F=err, NC 2 56 ZZ
Signature . _ __ �_ __ Date .

d 3n Y C E
Z,;.;flit/
SEP 1 8 1998
"` S 21431
y\ Sp.
`r-
r
�y S�llS
1 N r '
Po
vi
7?,ive w
o
� 1
3
i

Y
' rl.�y�.' ,� :}i�'i'+i'•i', w 4R .w�' .-r T's* -:' c a_„ J+ ~�-•�o„ x�-
-��'+� ate'�r • S,-� - - _.`rr':�� �t• zs '�r^i �j{� *�;��(±•�'g* _„} x � w7^_.'y!t-n �.`��1 --
��• ��1�'.��• • �..�,�tly - ��-�'�Y i�{ �-^..•-`•4t-1 }�".,41�'a�FA�i"N`•��rj'���T^'-d'
-.i '' may+ ; A '�''Y'L''• r' rnS �•�TJ✓'y+hNUF1 , Y Y"i..�� ~•" _ `+ - +r. S? rs..
._ � "� R#! 'SL�`i �„`4*!ys +C; ��,zf�- �y ��-j7'j���• + _ ��j'� ..L-�s;"7.,>��-
Y'j a5 _-L'?�i r � ij r.,�� � v� '' � ..� •r a'J�` ,f'�'R�K.i-.� r
M.�i a'+F'y. .d'_ _ SFµ -�..� '+'J� �Y^.r ,. i+ '�•' ., r'J _ - r A:::•,:
.:1.C-y.� �,^�. 't -ari a"`f+.`L'� ti'�'.W'-• .c.��iC _ -- J`�f .,,,+�- .• �s-jC 'S�w -�=.:.:'�:- _ � ". --
'r� � - a "Z'ti^^�Y',1•�� f �j _ ,��-. '• V v �,r 4„7`. Y•yyj��. k�4� y r".^F j.= +-ti __-.ate_
� ��,W, rr.�.Q'n r �*�+r.`a'�.K,r-�. ti,t.�"�+. � :r" - �• ��'�«a ti a' yR'•t �, r
$.;��Y.r- "y'_�-�'!��' „i'--�st �tr�TF�z+.?.•r..,�+:�. �� ,4�,b:.�"�+iwJ � � .... �'• � �- ",crr�fa�F,,�'� ; ' ,
?i -. -/�• � -:� �,�� �• 'A"�e� raw" - - vti:r �.-Y-_..�.--
�/ ?tr -A.-- `'�y.:i�r � .+i .. .r ar.. '^'- -� - '-may a ,� � -w' '."% '�''�.: �:•x'r
r~- }�Y } -Yl- "'�•�. ��f�y,;��7f r�.e4y �r�•+ ���' - `.}-� 'r•� 1v.Fs y-_- - :,.r.-y-'- -+-F
��� y_., �r .y�� i�. ���`5•++�,«,t - - ��v`.:'�+:a`!�' �•. �r•. ~ 1 .:rf y ��'tv�-�-��C,cc=a��_�
__ t�,a;y-r...�, ��4 i•- �.'J-_-:'�'�'fi��r`.�`�' ►Z�,. Tom. .r« •y'_'-� �T'�«.w.` - ..t`�'"^�•"• - ",tr'"r4.3'�''` `!!r4^:. 'ra.�
JpY�y,. i: OR,
i :I �.d ,f v-� _- r�l �7- •.4•}�� ���.�r 7��M1a
it+:' :«'.. e �=J r -.}..til•'s�r. ors.�-S yyCr:. �'•;��- �i,.. ''� � x.�: '�yr� �•3'��'`-�' t
-� ," .s'3, _ 9���� �;-rr'!'V� ,�v.' .� �.�_f-i _ ':,ytiw.-. `'s. •r fi.,- sar`�"
- � .,. ..►.-+ty.`;,9s��+ a��,. yf �-,:yv�!'' ^�L 1�ic��s�s�.-�"'..�:.' .r�,`„y:; sy'-,•1„}r.•y_ -�7-1°�-�
;y �t. iwr-. '�' :.� :�?..:.y- _�"�f'.`tee. �.�,y�j�,,r.4f'�«�'�j•-r''-,:- �'►�-"��I�r` �f�•,•-�"�''-"�•' -_.
i, 7�-��� s•� � -. }"x; 2';1�.'e:'ar' ,•"fit_j.. � i'�-'�� .,�f7�' y� jti•- may-.: .�
- � ''�„r %�^�••-- •-,r' ��::s�-c�,;G .^�,,,:�- "�" .::��•r'-�.�S,rt "Y�,•�ay�.r��.�, n s�+,+�-�e'te:�,
• •• -r.,a; `;r'rr�'.. � „7. �' f�r�i�r `�va-,.e�� �.��"W -'�+•-+n Y- �t'�� :s � �'
� •y4 -;,.:�r��.�t.-t-'y:�.. ��. - �_ �^?:.c� .2A�r:."4 .:I l�" er.r+- .C•:�•� ..�•Na•j*�:
+FY - �' 's �r W - ''' - _Y '�#�'k:l.�S.:y �• r •r T iC w+:'.=r�:+:
x lam' � �. -!'PB!re. �•r''- 'r. •� �; r'•�'�s "`�.1�- j,._
�„� SL` '-•.4',�.�. �- ��. fir•_-t�r;.�L. `'``?f.'j e- ';.°'-'a' -.ram �'u
�r _ •- .s• �,, •�4}-may r- :.:� -;sx.�„ r a
- - �Ky _ .i+•7 .� = l 5...��1� .„.f�yf`��-+Y»l^�.+I�7v���-�tf�{'
,.�.. 'i«;.� -'+�~�'��; _ shq�. .rye ' :_ -•�-+/sa`'y�"yy+&=r?»'��Cw

THIS DESIGN IS FOR A SINGLE STAGE SWINE LAC;F ION
CLIENTS NAME __________________________. r1:1D JOYC:E
C.OUNJY CARTERET
TODAYS DATE -_=W==w____________________. 1/24/';?7
SITING LAW DISTANCES OKAY (YES OR NO) Yes
NUMBER OF FIGS 1f1FANLING TO FEEDER _----. 0
NUMr:ER OF FIGS FEEDER TO FINISH =--====f _0
r-dl.JMF-:ER-R OF SOWS FARROW TO WEANLING =----. 8:21
NUMBER OF SOWS FARROW TO FEEDER =_=====r 0
NUMBER OF SOWS FARROW TO FINISH -_____ 0
NUMBER OF DEVELOPING GILTS =----__===-=1 !%!
NUMBER OF STUD E=OARS 1=rR GESTATING SOVIS 91
NUMBER 1_1F YEARS OF SLUDGE ACCUMULATION 1
(5 year miriimurn unless retr,tifit)
TOP LENGTH AT NORMAL WATER LEVEL ======> 4 0 FEET
TOP WIDTH AT NORMAL WATER LEVEL =_ __--. 145 0 FEET
NORMAL Ix.rATER LEVEL EL_EVAT10N =_______-_. 16.0 FEET
SEASONAL HIGH WATER TABLE ELEVATION =--_ 14.0 FEET
LAGO,--1N i-i'OTTFIM EL_EVAT ICrN =------------- 1 1 .0 FEET
Depth of Perrnarrent Water 5-0 feet
(rn i rn i rnurn depth i nc l ud i rrg sludge = 6 feet )
(rnax i rnurn depth of sludge = feet )
SIDE SLOPES _._____ _ __________________. L .0: 1 J
Perrnarrerrit Volume Required :_5!Z,—".7 . 1 cubic feet
Perrna.r-perat VO I urne Provided 270125.0 cubic feet
ADDITIONAL DA W/O EVAP . (VEGETATED) _--. kc Sr.;UAR'E FEET
ADDITIONAL_ DA W/O EVAP. (NON-VEGET. ) __:` 0 SQUARE FEET
( i . e . feedlot norr-diverted area)
ADDITIONAL 1). A . WITH EVAPORATION =====> 0 SQUARE FEET
( i .e . purnpout p r,d )
LENGTH OF= PUMPING CYCLE ---------------. 180 DAYS
GALI-OHS OF FRESH WATER ADDED DAILY ====> 0 X LLONS
NORMAL RAINFALL FOR PUMPING CYCLE _----. 27.4 INCHES
PERCENT RUNOFF ON VEGETATED AREAS = -_ 0 PERCENT
PERCENT RUNOFF ON NON-VEGETATED AREAS => 0 PERCENT
NORMAL EVAPORATION FOR PUMPING CYCLE ==> 13.7 INCHES
:f5YR/2'4HR STORM RAINFALL ______________. 7.5 INC:HES
RUNOFF DEPTH FROM VEGETATED AREAS =----. 0.!!f INCHES
RUNOFF DEPTH FROM NAN-VEGETATED AREAS => 0.0 INCHES
INCLUDE HEAVY RAIN (YES=1 , Nit=!_!) ==-===> 0 (NUMBER ONLY)
FREEBOARD 1 .0 FEET
ESTIMATED TOP OF DAM ELEVATION =____===> 21 . 1 FEET
Temporary Storage VO I LIMB Needed 2r3527--3.2' -cut, i c feet
Temporary Storage Volume Provided 2:35455P.3 cubic feet
Top of Darn E 1 evat i Gr, = 21 . 1 feet
I r,s i de D i rnens i c,ns of Lagoon at Top of Darn
Len3th = 4c=.571.6 feet Width = 175.6 feet
ESTIMATED DEPTH Tr-r PUMP _ 3.6 FEET
Volume To I_e Puroped = 234722 cubic feet
V„ I Irmo f,:,r Estimated Depth = 247:-2-76 cubic feet
Begin Pump i n-,j Elevation = 19.6 feet
Stor, Pump:, i ng E I evat i orr = 16.0 feet

STEADY STATE LIVE WEIGHT
0 head wean I i ng to feeder x :e0. Ibs. _ 0 I bs
VQ4 head feeder- to f i n i sh i ng x 1:35 Ibs . - 3Sy►l�i� I bs
�+r1, sows f arrow to wean I i rid rF I k,s I bs
0 st,ws farrow to feeder x 522 Ibs. - 0 Ibs
0 sows farrow to finish 1417 I k,s . _ {f I bs
0 deveIopirig gi Its x 150 Ibs . - 1%1 Ibs
0 stud boars or gestat i rig sows = ;7i
TOTAL STEADY STATE LIVE WEIGHT (SSL1,A0 - 355493 I b s
. SLUDGE ACCUMULATION
Sludge accumulates at varyiri'S rates .
0 pounds wean ing to feeder VI.25 - 0 cu . ft .
0 pounds feeder• t, f i rk i sh i ng x 0.2E W (4) cu. f t .
,54')_ piiUnds far-raw to wears Trig 0. 17 = 60403.81 cu. ft .
Cif 1i,7U rid s farr-c'w to feeder .. 97D . 17 - 0 Cu . ft .
0 poUn,1s far-r-,:,w to f i n i sh - 0 . 25 - 0 Cu. ft .
0 p,-,u rid s of developing g i I is x 0.25 = 0 cu . ft .
0 Ibs . of boar" studs or Best . sows 13. 125= 0 Cu . ft .
TOTAL SLUDGE ACCUMULATION = I Z'O:7-7 c u. f t .
REQUIRED LIQUID VOLUME OF LAGOON
Ile= i gn Treatrnent Vo I urne var- i e s by an i ma I type .
0 F,0unds weanI ing to feeder- x 1 .0 = 0 cu. ft .
!%1 p�-ur„ds feeder to finishing :: 1 .0 = 0 cu. ft .
355451:3 pounds farrow to wean irlg x sc1.67 Ia1;1.:31 cu. ft .
(%; pounds farrow to feeder 0 . 6.7 = 0 CU. ft .
0 p c,u n,1s f arrow to f i ri i sh x 1 . 0 - 0 cu. f t .
0 pounds of deve I op i rig g i I is 1 .0 = 0 cu. f t .
0 Ibs . of br,ar- studs or ;hest . saws * 1 = 0 Cu. ft .
TOTAL LIQUID VOLUME REQUIRED FOR LAGOON = Z":3 18 ) c u. f t .
TOTAL VOLUME FOR TREATMENT AND SLUDGE _ 250267..C172 c u. f t .
4. NAR'MAL- LAGOON LIQUID LEVEL
Maintain n„rmaI lagoon I iquiii I eve I at eIevation 16.0 feet
Construct lagoon br,ttorn elevation 11 .0 f eet
Lagoon size for normal I agoor, liquid volume u5 i rig pr i smod i a I f c,rmu I a
SS/ENDI SS/ENDZ SS/SIDE1 SS/SIDEZ DEPTH
AREA OF TOP
LENGTH *WIDTH =
430.0 145.!%I r Z-51%1.0 (AREA OF TOP)
AREA �+F BOTTOM
Lb * Wb _
400.(%1 1151.!;1 46.0091.0 (AREA OF BOTTOM)
AREA OF MIDESE:C:TION
(Lm * Wrn) -
415.0 130.0 52:950.0 (AREA OF MIDSECTION)

CU • YD. = [AREA TGIF + (4*AREA MIDSECTION) + AREA C-rr_rTTOM I DEPTH/6,
62350.0 i 15800.1J 46000.ki 0.L:",;
VOLUME OF LAGOON AT NORMAL LAGOON LIQUID LEVEL_ =7012 5.1C1 CU. F=T.
VCr!_UME NEEDED = Z5026,7. 1 GU. FT.
THE SURFACE DIMENSIONS OF THE LAGOON AT NORMAL LIQUID LEVEL
ARE 4'-30.01 FEET LONG BY 145.0" FEET WIDE
5. DAM
Place spo i i as a continuous darn to elevation Z1 . 1 feet .
�4•. TEMPf-'1r-.ARY STORAGE REQUIRED
DF- A I NAGE AREA:
La-goorr ( top of darn)
Length * Width
4r-.0.6 175.E *308s81 square f e e t
Aciditic,nal Drainage Area Without Evaporation
Vegetated 0 square feet
Novi-Vegetated 0 square feet
Additional Drainage Area With Evaporat i r-ri
0 square feet
1-1--ETAL DA w:s%i_`:1 square feet
F=•urnp i rp�l cyc I e to tie 1=.1!1 days .
6A. V01urne of ;paste pr 0 dLl1:Pd
0 Mead wean l i ng to feeder- rr 0-5 gals/day - 0 gals/day
0 head feeder- to finishing x . a gals/day = 0 gals/day
G.Z1 sows f arrow to wean I i rig x 7.2 ga I s/day - 5,111 .2 gals/day
0 sows farrow to feeder- :: 113-0 gals/day - 0 gals/day
1%1 sows farr-_-w to finish x 2�3.0 gals/day = 1_4 gals/slay
0 developing gilts >: 2.5 gals/day - 0 gals/day
0 stun kioars or gent . saws x -6•.7 gals/day = 0 gals/day
TOTAL VOLUME OF WASTE - E-91 1 gals/day
volume = 5911 gals/day 1:=0 days in the purAp i n'g
cycle divided by 7 .4,9 gal l runs per cu. ft .
volume = 142248. 1 cubic feet
6B. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest
aLmount .
Excess rairif""ai i ( difference) = 13.7 inches
VI_O urne = Vo i ume from lagoon + volume from feed i ots , etc + volume f turn
V-; Iurne = •27'474 .4 cubic feet

--C. Va I urne of fresh water- added ,
Th i s i s the arnount of f resh water used for wash i rrg f I oors or
ve l urne of f resh water used f or a f I ush systern. Flush systerns
that recycle the la.goor, water are accounted for ire 6A.
.r10 1 urne = 0 ;�a l l orls/day # 180 days i rr pump i rr-
cycle divided by 7 .4-=: gal ions per cu. ft .
Volerne = yl Cubic feet
6D. Vo I urne of 25 year - 24 hour- storm
VC, I urne = Volume from lagoon + volume from feedlots , etc + Vo 1 urne f r,:,rn
volume = 50550.8 cubic feet
6E. Vo_, I urne of "Heavy Rain"
Vo l ufne = VO I urne from l agoon + vo l urne from f eed I ots , etc + vo l ufne from
VoIurne = 0-0 cubit feet
TOTAL REQUIRED TEMPORARY STORAGE
6A. 142Z4:=:. I cub i c feet of waste
6B. Q2474. 4 cubic feet of excess rainfall
6C. 0 .ID cub i c f eet of fresh wash water
61). 5055111. E.' c ub i t feet of t_5yr-2-4hr s t c,rrn water
6E. 0 .Q1 cubic feet of heavy rainfall
TOTAL TFMPOR'ARY STORAGE 2.-'D5 Z 7 :. cubic f ee t
7 . DEPTH OF STORAGE REQUIRED (ABOVE NORMAL LIQUID ELEVATION OF LAGOON)
VOLUME OF TEMPORARY STORAGE WHEN TEMP OF DAM IS 21 . 1 FEET ELEV.
AREA OF E:1'_iTTO11 = r_•'=`35o.fa s q. f t .
AREA OF TCIP = 77100. 2 2 s q . f t .
AREA OF MID•-SEC:T I i+N = r_9'573.* s q. f t .
VOLUME: PROVIDED = 285459 . cubic feet
THE DIMENSIONS CIF THE INSIDE EDGE CJF THE DAM AT ELEVATION 27-1 . 1 FT.
ARE 46PJ.6 FEET BY 175.6 FEET
_ . SET BEGIN PUMPING ELEVATION
PUMPED STORAGE VOLUME
t•A. 142248. I cub 1 c feet of waste
6B. 9Z474 . 4 cubic feet of excess rainfall
r C:. 0. 0 cubic feet of fresh wash water
TOTAL PUMPED VOLUME _ 2347'Z. 5 c ub i c feet
r � _ r
VOLUME UME AT ESTIMATED PUMPING DEPTF-i 0�pe ate,. ���r {
AREA OF L--:i�TTOM = :_.Z350 . 0 s q. f t .
AREA OF TOP = 75'Z:=:6. 6 sq. f t .
AREA OF MID-SECTION = 6.'3 76. 6 s q . f t .
VOLUME PROVIDED = Z47375. � cubic feet
DESIGNED P-Y: APPROVED BY:
DATE: DATE: ��

EMERGENCY ACTICN .PLAN
PHONE NUMBERS
DMGI 41 q-395=39 oo
EMERGENCY MANAGEMENT SYSTEM 919--636-66 ;8
SWC:D 914-129-g078
NRC.S ql9-7zs-yv7S
This plan will be implemented in the event that wastes f rorn
Your operation are leaking , overflowing, or running off
site . You should not wait until wastes reach surface waters
or leave your property to consider that
you have a You should make every effort to ensure that this doeson�,trn.
happen. _This_pian_ahculd be_p4s�ed_ir� an_accessible
coca ion_for_atl_emplayees_at_th�e facility. The f011owing .
are some action items you should take.
1 . Stop the release of wastes. Depending on the
situation, this may or may not be possible. Suggested
responses to some possible problems are listed below.
A. Lagoon overflow-possible solutions are:
a. Add soil to berm to increase elevation of darn. ,
b. Purnp wastes to fields at an acceptable rate.
C . Stop all flows to the lagoon immediately.
d. Call a pumping contractor .
e . Make sure no surface water is entering lagoon .
LA. Rurtc f f frorn waste application field-actions
include -.
a. Immediately strap waste application .
b . Create a temporary diversion to contain waste .
C . Incorporate waste to reduce runoff .
d . Evaluate and eliminate the reason( s ) that
caused the runoff .
e . Evaluate the application rates for the fields
where runoff occurred.
C: Leakage from the waste pipes and sprinklers-action
include:
a. . Stop recycle pump.
b. Stop irrigation purnp.
C . Close valves to e 1 irn i nate Further- discharge .

d Repair aft Ieak:s prim- to-, restarting pumps.
D: Leakage from flush systems, houses , solid
separators-action include:
a. Step recycle pump.
b . Strip 'irrigation pump .
C . Mahe sure no siphon occurs .
d . Stop all flows in the house, flush systems , or-
solid separators.
e . Repair all leaks prior to restarting pumps .
E: Leakage from base or sidewall of lagoon. Often
this is seepage as opposed to flowing leaks-
possible action:
a. Dig a small sump or ditch away from the
embankment to catch all seepage , put in a
submersible pump , and pump back: to Iagoon .
b . If holes are caused by burrowing animals , trap
or remstive .animals and fill holes and compact
with a clay type soil .
C . Have a professional evaluate the condition - of
the side walls and lagoon bottom as soon as
possible.
2. Assess the extent of the spill and note any obvious
damages.
a. Did the waste reach any surface water-%?
b . Approximately how much was released and for what
duration?
C . Any damage noted , such as employee injury, fish
kills , or property damage?
d. Did the spill leave the property?
e . Does the spill have the potential to reach surface
waters?
f . Could a future rain event cause the spill to reach
surface waters?
S. Are potable water- wells in danger (either on or off
of the property)?
h . Haw much reached surface waters?
3: Contact appropriate agencies.
a. During normal . business hours , call your DWQ
(Division of Water Quality) regional office ; Phone
919-946-6481 . After hours , emergency number :919-
733-3942. Your phone call should include: your
name , facility, telephone number , the details of

the i nr i ,dent from i tem 2 above , the exact I ocat ion
of the facility , the location or direction of
movement of the spiII , weather and wind conditions .
The corrective measures that have been under taken ,
and the seriousness of the situation.
b . If spill leaves property or enters surface waters ,
call local EMS Phone number -RS9-72B-$470
C . Instruct EMS to contact local Health Department .
d. Contact CES, phone number- , local SWCD
office phone number 919-72.8-`i07S , and local MRCS
office for advice/technical assistance phone number
g191 -17-S-L4019 , -
4: If none of the above works call 911 or the Sheriff ' s
Department and explain your problem to them and ask
that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair
of problem to minimize off-site damage .
a. Contractors Narne:_�4Lr�Q�-�r (�e!�_____________
b . Contractors Address:__ ----------------
c . Contractors Phone:-_-
h: Contact the technical specialist who certified the
lagoon (NRCS, Consulting Engineer , etc . )
a. Name -._Q AV �� --------------------------
b . P�,r_,r,e _ r 9.� -------------------------
7: implement procedures as advised by DWQ and technical
assistance agencies to rectify the damage , repair the
system, and reassess the waste management plan to keep
problems with release of wastes from happening again.
Claude/nash/word/emgactplan.dcx
Oct 81 1996

f Mortality Managenient i!•iethods
(check which methods) are being implemented)
' Burial three feet beneath the surface of the ground within 74 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water.
J Rznderine at a rendering plant licensed under G.S. 106-163.7
Complete incineration
In the case of dead poultry only. piacing in a disposal pit of a size and design
approved by the Department of Agriculture
Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)

SWINE FARM WASTE MANAGEMENT ODOR CHECKLIST
Source Cause _ BMPs to Minimize Odor Site Specific Practices
Farmstead • Swine production �tative or Nvooded buffers; _ ---
ecommended best management practices;
Good judgment and common sense
Animal body surfaces • Dirty manure-covered animals 0 Dry floors
Floor surfaces • Wet manure-covered floors 0 . Slotted floors;
; eeders
/Waterers located over stoned floors;
Vat high end of solid floors;
2zu
rape manure buildup from floors;
nderfloor ventilation for drying
Manure collection pits 0 Urine; 11 Frequent manure removal by flush,pit recharge,
• Partial microbial decomposition /or scrape;
0 Underfloor ventilation
Ventilation exhaust fans - Volatile gases; Gr/Fan maintenance;
• Dust 6T Efficient air movement
Indoor surfaces • Dust 0 Washdown between groups of animals;
0 Feed additives;
VFeeder covers;
Feed delivery downspout extenders to feeder
covers
Flush tanks • Agitation of recycled lagoon O Flush tank covers;
liquid while tanks are filling Extend fill lines to near bottom of tanks with
anti-siphon vents
Flush'alleys • Agitation during wastewater Underfloor flush with underfloor ventilation
conveyance
Pit recharge points • Agitation of recycled lagoon O Extend recharge lines to near bottom of pits
liquid while pits are filling with anti-siphon vents
Lift stations • Agitation during sump tank EY Sump tank covers -- -- —
filling and drawdown
Outside drain collection • . Agitation during wastewater 0 Box covers
or junction boxes conveyance

Source Cause BMPs to Minimize Odor Site Specific Practices
End of drainpipes at • Agitation during wastewater Mf Extend discharge point of pipes underneath
lagoon conveyance lagoon liquid level
Lagoon surfaces • - Volatile gas emissions; 011 Proper lagoon liquid capacity;
• Biological mixing; ❑ Correct lagoon startup procedures;
• Agitation Q/Minimum surface area-to-volume ratio;
Minimum agitation when pumping;
❑ Mechanical aeration;
O roven biological additives
Irrigation sprinkler 0 High pressure agitation; /irrigate on dry days with little or no wind;
nozzles . Wind drift Minimum recommended operating pressure;
VPump intake near lagoon liquid surface;
❑ Pump from second-stage lagoon
Storage tank or basin • Partial microbial decomposition; lottom or midlevel loading;
surface . Mixing while filling; ZTank covers;
• Agitation when emptying ❑ Basin surface mats of solids;
❑ Proven biological additives or oxidants
Settling basin surface 6 Partial microbial decomposition; ❑ Extend drainpipe outlets underneath liquid
• Mixing while filling; level;
• Agitation when emptying ❑ Remove settled solids regularly
Manure,slurry or sludge • Agitation when spreading; ❑ Soil injection of slurry/sludges;
spreader outlets a Volatile gas emissions ❑ Wash residual manure from spreader after use;
❑ Proven biological additives or oxidants
Uncovered:manure, • Volatile gas emissions while ❑ Soil injection of slurry/sludges
slurry or sludge on field drying ❑ Soil incorporation within 48 hrs.;
surfaces
❑/pread in thin uniform layers for rapid drying;
❑ roven biological additives or oxidants
Dead animals • Carcass decomposition Proper disposition of carcasses
Dead animal disposal • Carcass decomposition Tf omplete covering of carcasses in burial pits;
pits Proper location/construction of disposal pits
Incinerators 0 incomplete combustion 0 Secondary stack burners

Source Cause BMPs to Minimize Odor Site Specific Practices
Standing water around • Improper drainage; Grade and landscape such that water drains
facilities . Microbial decomposition of away from facilities
organic matter
Manure tracked onto • Poorly maintained access roads nf Farm access road maintenance
public roads from farm
access
Additional Information : Available From
Swine Manure Management; 0200 Rule/BMP Packet NCSU,County Extension Center
Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet NCSU- BAE .
Swine Production Facility Manure Management: Pit Recharge- Lagoon Treatment; EBAE 128-88 NCSU- BAE
Swine Production Facility Manure Management: Underfloor Flush -Lagoon Treatment; EBAE 129-88 NCSU - BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage ; EBAE 103-83 NCSU - BAE
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet NCSU- BAE
Controlling Odors from Swine Buildings -, PIH-33 NCSU-Swine Extension
Environmental Assurance Program ; NPPC Manual NC Pork Producers Assoc
Options far Managing Odor; a report from the Swine Odor Task Force NCSU Agri Communications
Nuisance Concerns in Animal Manure Management:Odors and Flies ; PRO107, 1995 Conference Proceedings Florida Cooperative Extension

Insect Control Checklist for Animal Operations -
Source Cause i3MTs to Control Insects Site S ecilic Pructices
f Liquid Systems
Flush Gutters • Accumulation of solids Flush system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed.
0 Remove bridging of accumulated solids at
/discharge
Lagoons and Pits • Crusted Solids CT Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6-
8 inches over more than 30%of surface.
Excessive Vegetative • Decaying vegetation Maintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along waters edge on impoundment's perimeter.
Dry Systems
TFeeders • Feed Spillage Tf Design, operate and maintain feed systems(e.g.,
b nkers and troughs)to minimize the
ccumulation of decaying wastage.
Clean up spillage on a routine basis(e.g., 7 - 10
day interval during summer, 15-30 day interval
_ Auring winter).
Feed Storage • Accumulations of feed residues Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containment(e.g.,
covered bin for brewers grain and similar high
moisture grain products).
Inspect for and remove or break up accumulated
solids in filter strips around feed storage as
needed.
AM1C-November 11, 1996 l

Source Cause 13NIPs to Control insects - Site SEecific Practices
Animal Holding Areas Accumulations of animal wastes 0 Eliminate low areas that trap moisture along
and feed wastage fences and other lucations where waste
accumulates and disturbance by animals is
minimal.
0 Maintain fence rows and filter strips around
animal holding areas to minimize accumulations
of wastes(i.e., inspect for and remove or break
up accumulated solids as needed).
Dry Manure Handling Accumulations of animal wastes ❑ Remove spillage on a routine basis(e.g., 7- 10
Systems day interval during summer; 15-30 day interval
during winter)where manure is loaded for land
application or disposal.
0 Provide for adequate drainage around manure
stockpiles.
❑ Inspect for and remove or break up accumulated
wastes in filter strips around stockpiles and
manure handling areas as needed.
For more information contact the Cooperative Extension Service,Department of Entomology, Box 7613,North Carolina State University,
Raleigh,NC, 27695-7613.
AMC-November 11, 1996 2
i

State. of North Carolina
Department of Environment
and Natural Resources •
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 21, 1998
Robert Joyce
Joyce Hog Farm
383 Cyrus Pollard Road
Newport NC 28570
Subject: Application No. AWS160001
Additional Information Request
Joyce Hog Farm
Animal Waste Operation
Carteret County
Dear Robert Joyce:
The Non-Discharge Permitting Unit has completed a preliminary engineering review of the subject
application. Additional information is required before we can continue our review. Please address the
following by January 20, 1999:
1. Please submit an Operation and Maintenance Plan.
Please note that all WUP revisions must be signed and dated by both the owner and the technical
specialist. Please reference the subject permit application number when providing the requested
information. All information should be signed, sealed, and submitted in duplicate to my attention at the
address below. The information requested by this letter, must be submitted on or before January 20,
1999 or the Division will return your application as incomplete in accordance with 15A N.C.A.C. 2H
.0260 and your facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid permit
is a violation of North Carolina General Statute 143-215.1 and will subject you to the enforcement
authority of the Environmental Management Commission.
If you have any questions regarding this request,please call me at(919) 733-5083, extension 502.
Si2iH
crely,omewood
odonmental Engineer
Non-Discharge Permitting Unit
cc: Wilmington Regional Office, Water Quality
Permit File
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50%recycled/10%post-consumer paper

State of North Carolina
Department of Environment,
Health and Natural Resources 1 ® •
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary ® E�
HMFZ
November 13, 1996
Robert Joyce
Joyce Hog Farm
Rt 2 Box 249
Newport NC 28570
SUBJECT: Operator In Charge Designation
Facility: Joyce Hog Farm
Facility ID#: 16-1
Carteret County
Dear Mr.Joyce:
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on-going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996,
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 919/733-0026.
SiQPreston
AHoward, Jr., ctor
Division of Water Quality
Enclosure
cc: Wilmington Regional Office
Water Quality Files
P.O. Box 27687, FAX [phone]
Raleigh,North Carolina 27611-7687 xmf An Equal Opportunity/Affirmative Action Employer
Voice 919-715-4 100 N50%recycled/100%post-consumer paper

REGISTRATION FORM FOR ANIMAL FEEDLOT OPERATIONS.
Department of Environment, Health and Natural Resources
Division of Envi.-conmental Management
Water Quality Section
If the animal waste management system for your feedlot operation.is_
designed to serve more than or equal to 100 head of cattle,`TS
horses, 250 swine, 1, 000 sheep, or 30, 000 birds that are served by
a liquid waste system, then this; form must be filled out and mailed
by December 31, 1993 pursuant to 15A NCAC 2H. 0217 (c) in order to be
deemed permitted by DEM. Please print clearly .
Farm Name : c/v✓F E ffcIG f;;Ie,&
Mailing Address :. /L_7
Z I P Ga cY
County : P ^ Phone No j "- �-,
Owner (s) Name : 7_ e
Manager (s) Name :
Lessee Name :
Farm Location (Be as specific as possible : road names, direction,
mile ost, etc . ) : nor" ;LE cAn` P r r'nl)
—r-
Latitude/Longitude if known :
Design capacity of animal waste management system (Number and type
of confined anima's. (s) ) : �s'o .S��tis f/��fc'�Lfi 7Fa �i.v�s.� /��ya �vtys
Average animal population on the farm (Number and type of animial (s)
raised) 3a eo z'e
Year Production Began - ASCS Tract No . :
Type of waste Management System Used: 2!'o _,Rf
Acres Available for Land Application of Waste : C'�4fA"p"b 6Q""2iA"1z)
Owner (s) Signature (s) :_ DATE : io
n
DATE : /c
I I 4I L

•! y i5A)Z
State of North Carolina
Department of Environment, Health, and Natural Resources
512.North Salisbury Street • Raleigh, North Carolina 27604
Division of Environmental Management
James B. Hunt, Jr., Governor March 9, 1993 Jonathan B. Howes, Sectary
Robert Joyce
Rt. 2 Box 249
Newport NC 28570
Dear Mr. Joyce,
This is to inform you that your completed registration form required by the recently
modified nondischarge rule has been received by the Division of Environmental Management
(DEM), Water Quality Section.
On December 10, 1992 the Environmental Management Commission adopted a water
quality rule which governs animal waste management systems. The goal of the rule is for animal
operations to be managed such that animal waste is not discharged to surface waters of the state.
The rule allows animal waste systems to be "deemed permitted" if certain minimum criteria are
met (15A NCAC 2H .0217). By submitting this registration you have met one of the criteria for
being deemed permitted.
We would like to remind you that existing feedlots which meet the size thresholds listed
in the rule, and any new or expanded feedlots constructed between February 1, 1993 and
December 31, 1993 must submit a signed cerfilcation form to DEM by December 31., 1997.
New or expanded feedlots constructed after December 31, 1993 must obtain signed certification
before animals are stocked on the farm. Certification of an approved animal waste
management plan can be obtained after the.Soil and Water Conservation Commission adopts
rules later this year.
We appreciate you providing us with this information. If you have any question about
the new nondischarge rule, please contact David Harding at [phone].
Sincerely,
14—S teve Tedder Chief
10/ Water Quality Section
REGIONAL OEFICES
Asheville Fayeaevi-iie Mooresville Raleigh Washington Wilmington Wiaswn�alem
704251-6208 9191496-1541 7041663-1699 919/571-4700 919N46-(481 .919/395-3900 9191896-7007
Pollution Prevention Pays
P.O.Box 29535. Rakigh.North Cazolina 27626-0535 Telephone [phone]
An Equal Opportunity AEfirmaave Action Employer