820367_CORRESPONDENCE_20171231

NORTH CAROLINA .�
Department of Environmental Out

Waste Utilization flan
Producer:
Zack McCullen ill
Name of Farm:
D & Z Farms
Location:
1058 Wynn Road
Clinton NC 28328
Phone:
910-533-3450
Type of Operation:
Feed -Finish
Number of Animal:
1860
Storage Structure:
Anaerobic Lagoon
Method of Application:
Irrigation
Amount of waste produced per year:
Amount of plant available
N (PAN) produced/year:
County: Sampson % ^ r St-o r7
322r9
3534 ton/year`
4278 lbs./year
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface water and/or groundwater. The plant nutrients in the animal waste
should be used to reduce the amount of commercial fertilizer required for the crops in the
fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in the implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an environmentally
safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall not be applied to land eroding at more than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are
established.
4. Do not apply waste on saturated soils , when it is raining, or when the surface is
frozen. Either of these conditions may in runoff to the surface waters which is not
allowed under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor problems.
6. To maximize the value of the nutrients for crops production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied not more than 30 days
prior to planting a crop or forages breaking dormancy. Injecting the waste or disking will
conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change methods
in the future, you need to revise this plan. Nutrient levels for different applications methods are
not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. In some cases you may want to have plant analysis made, which
RECEIVED I DENR I DWQ
Aquifer Protection Section
MAR 21 2009

' D & Z Farms
Page 2
could allow additional waste to be applied. Provisions shall be made for the area receiving
waste to be flexible so as to accommodate changing waste analysis content and the crop type.
Lime must be applied to maintain pH in the optimum range for specific crop production. This
waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract No.
Field No.
Soil Type
Crop
Code
YieldlAc
Lbs. N
unit
Acres
Lbs N
Used
Month to
Apply
Lbs. N
Per Ac.
9852
1 &2
OrB
CB -Graze
5.4
50
3.39
915
MAR-OCT
270
9852
1&2
OrB
SG -Graze
1
50
3.39
170
OCT-MAR
50
9852
3&4
OrB
CB -Graze
5.4
50
5.88
1588
MAR-OCT
270
9852
3&4
OrB
SG -Graze
1
50
5.88
294
OCT-MAR
50
9852
5
OrB
CB -Graze
5.4
50
4.15
1121
MAR-OCT
270
9852
5
OrB
SG-Grazel
1
1 50
4.15
208
OCT-MAR
50
Total 13.42 4294lbs.
CB -Graze = Coastal Bermuda (Graze) Available Nitrogen 4278 lbs.
SG -Graze = Coastal Bermuda Overseeded (Graze) Surplus or deficit -16 lbs.
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to apply
the waste in a timely manner.

%D & Z Farms Page 3
The applicator is cautioned that P and K may be over applied while meeting the N requirements. In the future,
regulations may require farmers in some parts of North Carolina to have a. nutrient management plan that
addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields (i.e. small grain, etc. interseeded in bermudagrass), forage must be removed through
grazing, hay and for silage. Where grazing, plants should be grazed when they reach a height of six to nine
inches. Cattle should be removed when plants are grazed to a height of four inches. In fields where small grain
etc. is to be removed for hay or silage, care should be exercised not to let small grain to reach materity,
especially late in the season ( i.e. April or May) Shading may result if small grain gets too high and this will
definitely interfere with the stand of bermudagrass. This loss of stand will result in reduced yields and less
nitrogen being utilized. Rather than cutting small grain for hay or silage just before heading as is the normal
situation, you are encouraged to cut the small grain earlier. You may want to consider harvesting hay or silage
two to three times during the season, depending on the time small grain is planted in the fail.
The ideal time to interplant small grain, etc. is late September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a height of about two inches before drilling for best
results.
Caution must be exercised in grazing or haying summer annuals under stressed conditions. Nitrate poisoning
may occur in livestock. Sampling forage or hay for nitrate levels is recommended.
Acres shown in the tables are considered to be the usable acres excluding required buffers, filters strips along
ditches, odd areas unable to be irrigated, and perimeter areas not receiving full application rates due to
equipment limitations. Actual total acres in the field listed may, and most likely will be, more than the acres
shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at agronomic rates.
The sludge will be nutrient rich and will require precautionary measures to prevent over application of nutrients
or other elements. Your production facility will produce approximately 134 lbs. of plant available
nitrogen per year in the sludge.
If you remove sludge every 5 years you will have approximately 670 lbs. of PAN to utilize. Assuming
you apply this PAN to hybrid bermudagrass hayland at the rate of 300 lbs/acre you will need 2
acres of land. If you apply the sludge to corn at the rate of 125 lbs. of nitrogen per acre you will need 5
acres of land. Please be aware that these are only estmates of the PAN and the land needed. Actual
requirements could vary by 25% depending on the sludge waste analysis, soil types, realistic yields, and
application methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation such that
runoff or ponding occurs. This rate is limited by initial soil moisture content, soil structure, soil texture, water
droplet size, and organic solids. The application amount should not exceed the available water holding capacity

D & Z Farms
Page 4
of the soil at the time of irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of
the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the producer and
irrigation designer to ensure that an irrigation system is installed to properly irrrigate the acres shown in tables.
Failure to apply the recommended rates and amounts of nitrogen shown in the tables may make this plan
invalid.
The following table is provided as a guide for establishing application rates and amounts.
Tract No.
Field No.
Soil Type
Crop
Code
Applic.
Rate inlhr
Applic.
Amount
9852
1 &2
OrB
CB -Graze
0.5
1
9852
1 &2
OrB
SG -Graze
0.5
1
9852
3&4
OrB
CB -Graze
0.5
1
9852
3&4
OrB
SG -Graze
0.5
1
9852
5
OrB
CB -Graze
0.5
1
9852
5
OrB
SG -Graze
0.5
1

- . D & z Farms
Page 5
This is the maximum application amount allowed for the soil assuming the amount of nitrogen allowed for the
crop is not over applied. In many situations the application amount shown cannot be applied because of the
nitrogen limitations. The maximum application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must be removed on the
average of once every 6 months. In no instances should the volume of the waste be stored in your structure
be within the 25 year 24 hour storm storage or one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and the waste applicator to ensure that the spreader equipment is operate
properly to apply the correct rates shown in the tables. Failure to apply the recommended rates and amounts of
nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you have receive the waste analysis report for assistance in determining the
amount of waste per acre and the proper application rate prior to appling the waste.
NARRATIVE OF OPERATION

• Page 6
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: D & Z Farms
Owner/Manager Agreement Zack McCullen III
I (we) understand and will follow and implement the specifications and the operation and maintenance proce-
dures established in the approved animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the North Carolina Division of Water Quality
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste
from this system to the surface waters of the state from a storm event less severe than the 25-year, 24 hour
storm. T he approved plan will be filed on -site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Zack McCullen III
Signature:
i
Name of Manager (If different from owner)
Signature:
Name of Person Preparing Plan: G. Glenn Clifton
Affiliation: Prestage Farms, Inc. Phone: [phone]
Address: P.O. Box 438
Clinton, NC 28329
Signature:
Date: `/ j,`� U-K_
Date:
Date: ($ 0 S

Michael F. Easley, Governor
A L, 9q
0 li� ­c
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
July 1, 2007 � '
Zack McCullen JUN 2 7 7217
D&Z Farms B
1058 Wynn Rd - ,.
Clinton, NC 28328 ;u _0,
Clinton,
5
Subject: Certificate of Coverage No. AWS820367
D&Z Farms
Animal Waste Management System
Sampson County
Dear Zack McCullen:
In accordance with your application received on 15-Dec-06, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Zack McCullen, authorizing the operation of the subject animal
waste management system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the D&Z Farms, located in Sampson County, with an animal capacity of no greater
than the following swine annual averages:
Wean to Finish: 0 Feeder to Finish: 1860 Boar/Stud: 0
Wean to Feeder: 0 Farrow to Wean: 0 -Gilts: 0
Farrow to Finish: 0 Farrow to Feeder: 0
If this is a Farrow to Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows.
Where boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows
may be replaced by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009 and replaces the NPDES
COC issued to this facility with an expiration date of July 1, 2007. You are required to continue
conducting annual surveys of sludge accumulation in all lagoons at your facility; the one-year extension
in Condition 111.19 does not apply.
Pursuant to this COC, you are authorized and required to operate the system in conformity with the
conditions and limitations as specified in the General Permit, the facility's CAWMP, and this COC. An
adequate system for collecting and maintaining the required monitoring data and operational information
must be established for this facility. Any increase in waste production greater than the certified design
capacity or increase in number of animals authorized by this COC (as provided above) will require a
modification to the CAWMP and this COC and must be completed prior to actual increase in either
wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Enclosed for your convenience is
a package containing the new and revised forms used for record keeping and reporting. Please pa
careful attention to the record keeping and monitoring conditions in this permit.
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636
Internet: www.ncwatggtLaiky.org Location: 2728 Capital Boulevard Raleigh. NC 27604
An Equal opportuniiylAffirmative Action Employer— 50% Regded/10%Post Consumer Paper
one
N&NCarolina
tura!!y
Telephone: [phone]
Fax 1: [phone]
Fax 2: [phone]
Customer Service: [phone]

If your Waste Utilization Plan has been developed based on site -specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 02T .01 I l (c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot, separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Per 15A NCAC 02T .1306, any containment basin, such as a lagoon or waste storage structure, shall
continue to be subject to the conditions and requirements of the facility's permit until closed to NRCS
standards and the permit is rescinded by the Division.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection staff may be reached at 910433-3300. If you need additional information concerning
this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at (919) 733-
3221.
Sincerely,
for Coleen H. Sullins
Enclosures (General Permit AWG100000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Sampson County Health Department
Sampson County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files
Permit File AWS820367

December 1, 2006
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Zack McCullen
D&Z Farms
1058 Wynn Rd
Clinton, NC 28328
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Fnvirvnment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
DEC 06 MM
�l—fAY�TTEVp.�p��
Subject: Application for Renewal of Coverage for Expiring NPDES General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation NPDES General Permits, which expire on
July 1, 2007. Due to changes in federal rules, facilities that do not discharge nor propose to discharge may choose whether or not to
retain coverage under an NPDES General Permit. Copies of the draft animal waste operation NPDES general permits and the State
Non -Discharge General Permits are available at hqp://h2o.enr.state.nc.uslaps/afou/downloads.htm or by writing or calling:
NCDENR — DWQ Animal Feeding Operations Unit
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under one of these two types of generalpermits, You must submit an application forpermit
coverage to the Division. Enclosed you will find a `Request for Certificate of Coverage Facility Currently Covered by an Expirinl;
NPDES General Permit.' The application form must be completed and returned by January 2, 2007. Please note, you must include
two 2) copies of your most recent Waste Utilization Plan with the application form,
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty,
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the draft general permits, the enclosed application, or any related matter please feel free to contact the
Animal Feeding Operations Unit staff at 919-733-3221.
Sincerely,
Ted L. Bush, Jr., Chief
Aquifer Protection Section
Enclosures
cc (w/o enclosures): Sampson County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
A.FO Unit Central Files - 820367
Prestage Farms Inc
Aquifer Protection Section 1636 Mail Service Center
Internet: www.ncwaterquality.org Location: 2728 Capital Boulevard
An Equal Opportuno/Af imiative Action Employer— 50% Recyded110% Post Consumer Paper
Raleigh, NC 27699-1636 Telephone:
Raleigh, NC 27604 Fax 1:
Fax 2:
Customer Service:
o hCarolina
(919) iura!!y
[phone]
[phone]
[phone]

. f .
ANIMAL FACILITY ANNUAL CERTIFICATION FORM
Certificate of Coverage or Permit Number A C-14 -?F) 3 6'7 County Year 200S
Facility blame (as shown on Certificate of Coverage or Permit) 2,q c 1Z
Operator in Charge for this Facility = Al _ Certification #_ / 7866
Land application of animal waste as allowed by the above permit occurred during the past calendar year
—y`� YES NO. If NO, skip Part I and Part I1 and proceed to the certification. Also, if animal waste
was generated but not land applied, please attach an explanation on how the animal waste was handled.
Part I : Facility Information:
1. Total number of application Fields u or Pulls 0 (please check the appropriate box) in the Certified Animal
Waste Management Plan (CAWMP): S Total Useable Acres approved in the CAWMP
2. Total number of Fields ❑ or Pulls X (please check the appropriate box) on which land application
occurred during the year
E
Total Acres on which waste was applied _ / 3. 5+Z
3. Total pounds of Plant Available Nitrogen (PAN) applied during the year for all application sites:
) 7 ?6.6F
4. Total pounds of Plant Available Nitrogen (PAN) allowed to be land applied annually by the CAWMP and
the permit: Ll2 �7 y
5. Estimated amount of total manure, litter and process wastewater sold or given to other persons and taken
off site during the year tons ❑ or gallons ❑ (please check the appropriate box)
6. Annual average number of animals by type at this facility during the previous year:
1A,.29.
7. Largest and smallest number of animals by type at this facility at any one time during the previous year:
Largest �2 0 7 --
Smallest
(These numbers are for informational purposes only since the only permit limit on the number of animals
at the facility is the annual average numbers)
Facility's integrator if applicable: 10i2 t S7}? G7: F /%74".
Part II: Facility Status:
IF THE ANSWER TO ANY STATEMENT BELOW IS "NO", PLEASE PROVIDE A WRITTEN
DESCRIPTION AS TO WHY THE FACILITY WAS NOT COMPLIANT, THE DATES OF ANY NON
COMPLIANCE, AND EXPLAIN CORRECTIVE ACTION TAKEN OR PROPOSED TO BE TAKEN TO
BRING THIS FACILITY BACK INTO COMPLIANCE.
1. Only animal waste generated at this facility was applied to the permitted sites during Yes ❑ No
the past calendar year. R EC
E t fED�
FEB Z 2 2006
AFACF 3-14-03 1 1MR- FATTF UEREGIONAL O;Prr

2. The facility was operated in such a way that there was no direct runoff of waste from
Yes L; No
the facility (including the houses, lagoonsstorage ponds and the application sites) during
the past calendar year.
3_ There was no discharge of waste to surface water from this facility during the past
9 Yes ❑ N
calendar year.
4. There was no freeboard violation in any lagoons or storage ponds at this facility during
Yes ❑ No
the past calendar year.
5. There was no PAN application to any fields or crops at this facility greater than the
21 Yes ❑ No
levels specified in this facility's CAWMP during the past calendar year.
6. AlI land application equipment was calibrated at least once during the past calendar year.
Yes ❑ No
7. Sludge accumulation in all lagoons did not exceed the volume for which the lagoon % Yes ❑ No
was designed or reduce the lagoon's minimum treatment volume to less than the volume
for which the lagoon was designed.
8. A copy of the Annual Sludge Survey Form for this facility is attached to this Certification. Z Yes ❑ No
9. Annual soils analysis were performed on each field receiving animal waste during the Yes ❑ No
past calendar year.
10. Soil pH was maintained as specified in the permit during the past calendar Year?
X Yes ❑ No
11. All required monitoring and reporting was performed in accordance with the facility's
Z Yes ❑ No
permit during the past calendar year.
12. All operations and maintenance requirements in the permit were complied with during
Yes ❑ No
the past calendar year or, in the case of a deviation, prior authorization was received
from the Division of Water Quality.
13. Crops as specified in the CAWMP were maintained during the past calendar year on all
Yes [IN,
sites receiving animal waste and the crops grown were removed in accordance with
the facility's permit.
14. All buffer requirements as specified on the permit and the CAWMP for this facility were
Yes ❑ No
maintained during each application of animal waste during the past calendar year.
I certify under penalty of law that this document and all attachments were prepared under my direction or
supervision in accordance with a system designed to assure that qualified personnel properly gather and
evaluate the information submitted. Based on my inquiry of the person or persons who manage the system, or
those persons directly responsible for gathering the information, the information submitted is, to the best of
my knowledge and belief, true, accurate, and complete. l am aware that there are significant penalties for
submitting false information, including the possibility of fines and imprisonment for knowing violations."
Permittee Name and Title (type or print)
Signature of Operator in Charge
(if different from Permittee)
-2 `-Z i3 D
Date
Date
AFACF 3-14-43 2

Lagoon Sludge Survey Form
A. Farm Permit or DWQ Identification Number.
B. Lagoon Identification Z.
C. Person(s) taking Measurements , 3 a 1,
D. Date of Measurements �' - = i —
E. Methods/Devices Used for Measurement of.
a. Distance from the lagoon liquid surface to the top of the sludge layer:
b. Distance from the lagoon liquid surface to the bottom (soil) of lagoon:
c. Thickness of the sludge layer if making a direct measurement with "core sampler":
F. Lagoon Surface Area (using dimensions at inside top of bank): /, (acres)
(Draw sketch of lagoon on a separate sheet and list dimensions, and calculate surface area.)
G. Estimate number of sampling points:
a. Less than 1.33 acre: Use 8 points
b. if more than 1.33 acre, f ..,� acres x 6 = I } with maximum of 24.
(Using sketch and dimensions, develop a uniform "grid" that has number of intersection points that match
most closely with the estimated number of sampling points needed. Number the grid intersection points on
the lagoon grid to correspond with the data to be recorded for points of measurement.)
H. Conduct sludge survey and record data on "Sludge Survey Data Sheet".
1. At time of sludge survey, also measure the distance from the Maximum Liquid Level
to the Present Liquid Level (measure at the lagoon gage pole):
!. 2
J.
Determine distance from Maximum Liquid Level to Minimum Liquid Level:
. O
(Determine from Plan or other lagoon records)
K.
Calculate distance from present liquid surface level to Minimum Liquid
level: Item J — Item 1, assuming present liquid level is below Max. Liq. Level:
L.
Record from sludge survey data sheet the distance from the present liquid surface level
to the lagoon bottom (average for all the measurement points):
M.
Record from sludge survey data sheet the distance from the present liquid surface level
to the top of the sludge layer (average for all the measurement points):,Q
M
Record from sludge survey data sheet the average thickness of the sludge layer.-
3.9
O.
Calculate the thickness of the existing Liquid Treatment Zone (Item M — Item K):
S. 1
(Note: If Item O is less than 4 ft., a sludge removal and utilization plan may be required by
N. C. DWQ. See your specific permit or contact DWQ for more information.)
P.
Proceed to Sludge Volume Worksheet if desire to calculate sludge volume for rectangular shaped
lagoon with uniform side slope.
Completed by -. ,. ,•,,-,, r ` r, .,, ., ,,1, �.,, Date:
Print Name a Signature
i G�Uir,tG� — C3,D-7
White - Office Yellow - Producer

`.•c5�`rn''s; `'.p'�°r��,-.s'��;»y ;Lt: �S,`�S"': v;;i �.�::,'i: •�,s"'�. ;''�Z 'E-`",.�`.r�. ��'. `:t.; eai , {.r - •i".; �. _ ;9 _:>`_:". �`:r r_.f ,. i'"�r_ •�• ,�—• '--
6.' Prnf
Sludge Survey Data Sheet
Lagoon Identification:
Sludge Survey Data Sheet ; d- 7—
Completed by: .7 Date: S 11 - u5
Print Name Sigfiature ,1
(A)
Grid
Point
No.
(B)
Distance from liquid surface
to top of sludge
(C)
Distance from liquid surface
to lagoo bottom soil
(C)-(B)
Thickness of sludge
la er
Ft. & inches
Feet tenths
Ft. & inches
Feet tenths
Ft. & inches
Feet tenths
2
3
6.1
4
5
y.
s
Lf.4
7
� . 3
8
�.
9
10
S,
--�--
11
12
13
14
15
15
17
18
19
20
21
22
23
24
Average
9
�. `f
3.5
*All_ Grid_ Points and corresponding sludge laver thickness must be shown on a sketch
attached to this Sludge Survev Data Sheet.
See Appendix 6 for conversion from inches to tenths of feet.
White - Office Yellow - Producer

ANIMAL FACILITY ANNUAL CERTIFICATION FORM
Certificate of Coverage or Permit Number IJ6 A 2?-2 3 9 County S 1!'Y�pS l ffYear 200
Facility Name (as shown on Certificate of Coverage or Permit) jc k l Cu, " ('13�,2 )Wfru
Operator in Charge for this Facility c ` L,tt I Z. Certification
Land application of animal waste as allowed by the above permit occurred during the past calendar year
�- YES NO. If NO, skip Part I and Part II and proceed to the certification. Also, if animal waste
was generated but not land applied, please attach an explanation on how the animal waste was handled.
Part I : Facility Information:
1. Total number of application Fields 0 or Pulls 0 (please check the appropriate box) in the Certified Animal
Waste Management Plan (CAWMP): q Total Useable Acres approved in the CAWMP
/4
2. Total number of Fields ❑ or Pulls (please check the appropriate box) on which land application
occurred during the vear: y Total Acres on which waste was applied
3. Total pounds of Plant Available Nitrogen (PAN) applied during the year for all application sites:
/ S .57
4. Total pounds of Plant Available Nitrogen (PAN) allowed to be Iand applied annually by the CAWMP and
the permit: �% 4/
5. Estimated amount of total manure, litter and process wastewater sold or given to other persons and taken
off site during the year _ p_ tons ❑ or gallons ❑ (prease check the appropriate box)
6. Annual average number of animals by type at this facility during the previous year:
1220.,? - _ -
7. Largest and smallest number of animals by type at this facility at any one time during the previous year. -
Largest
Smallest D
(These numbers are for informational purposes only since the only permit limit on the number of animals
at the facility is the annual average numbers)
8. Facility's Integrator if applicable: I OA J5 (-T;'l6- -rqJfMI
Part II: Facility Status:
IF THE ANSWER TO ANY STATEMENT BELOW IS "NO", PLEASE PROVIDE A VX7RJTTEN
DESCRIPTION AS TO WHY THE FACILITY WAS NOT COMPLIANT, THE DATES OF ANY NON
COMPLIANCE, AND EXPLAIN CORRECTIVE ACTION TAKEN OR PROPOSED TO BE TAKEN TO
BRING THIS FACILITY BACK INTO COMPLIANCE.
1. Only animal waste generated at this facility was applied to the permitted sites during I Yes n No
the past calendar year.
AFACF 3-14-03
RECEIVED
FEB 2 4 2005
RENR-FAYE WILLEREGIONALOFFICE

?. The facility was operated in such a way that there was no direct runoff of waste from X Yes ❑ No
the facility (including the houses, lagoons/storage ponds and the application sites) during
the past calendar year. y
3. There was no discharge of waste to surface water from this facility during the past kl-1' Yes ❑ N
calendar year.
4. There was no freeboard violation in any lagoons or storage ponds at this facility during Yes ❑ No
the past calendar year.
5. There was no PAN application to any fields or crops at this facility greater than the 0 Yes ❑ No
Ievels specified in this facility's CAWMP during the past calendar year.
6. All land application equipment was calibrated at least once during the past calendar year. Yes ❑ No
7. Sludge accumulation in all lagoons did not exceed the volume for which the lagoon 0 Yes ❑ No
was designed or reduce the lagoon's minimum treatment volume to less than the volume
for which the lagoon was designed.
8. A copy of the Annual Sludge Survey Form for this facility is attached to this Certification. Yes ❑ No
9. Annual soils analysis were performed on each field receiving animal waste during the Yes ❑ No
past calendar year.
10. Soil pH was maintained as specified in the permit during the past calendar Year? -
Y Yes ❑ No
1 I . All required monitoring and reporting was performed in accordance with the facility's
Yes ❑ No
permit during the past calendar year.
12. All operations and maintenance requirements in the permit were complied with during
Yes ❑ No
the past calendar year or, in the case of a deviation, prior authorization was received
from the Division of Water Quality.
13. Crops as specified in the CAWMP were maintained during the past calendar year on all
W Yes ❑ N,
sites receiving animal waste and the crops grown were removed in accordance with
the facility's permit.
14. All buffer requirements as specified on the permit and the CAWMP for this facility were
Yes ❑ No
maintained during each application of animal waste during the past calendar year.
"I certify under penalty of law that this document and all attachments were prepared under my direction or
supervision in accordance with a system designed to assure that qualified personnel properly gather and
evaluate the information submitted. Based on my inquiry of the person or persons who manage the system, or
those persons directly responsible for gathering the information, the information submitted is, to the best of
my knowledge and belief, true, accurate, and complete. I am aware that there are significant penalties for
submitting false information, including the possibility of fines and imprisonment for knowing violations."
" Il /�'� c 6C1C1 Lam.
Permittee Name and Title (type or print)
Signature of Operator in Charge
(if different from Permittee)
e-0
- zss= ws-
Date
Date
AFACF 3-14-03 2

Lagoon Sludge Survey Form
A. Farm Permit or DWO Identification Number ,�' -Z123
B. Lagoon Identification )�Z
C. Person(s) taking Measurements
D. Date of Measurements q _ _ p c]
E. Methods/Devices Used for Measuement of:
a. Distance from the lagoon liquid surface to the top of the sludge layer:
n
b. Distance from the lagoon liquid surface to the bottom (soil) of lagoon:
P r P a
c. Thickness of the sludge layer if making a direct measurement with "core sampler"
NIM _
F. Lagoon Surface Area (using dimensions at the inside top of bank): Z., 6 (acres)
(Draw sketch of lagoon on a separate sheet and list dimensions, and calculate surface area.)
G. Estimate number of sampling points
a. Less than 1.33 acres: Use 8 points
b. If more than 1.33 acres. / -16 acres x fi = 8 with maximum of 24.
(using sketch and dimensions, develop a uniform "grid" that has number of intersection points that match
most closely with the estimated number of sampling points needed. Number the grid inlersection points on
the lagoon grid to correspond with the data to be recorded for points of measurement.)
H. Conduct sludge survey and record data on "Sludge Survey Data Sheet".
I. At the time of sludge survey, also measure the distance from the Maximum Liquid Level
to the Present Liquid Level (measure at the lagoon gage pole):
J. Determine distance from Maximum Liquid limit to Minimum Liquid Level: O
(Determine from Plan or other lagoon records)
K. Calculate distance from present liquid surface level to Minimum Liquid
Level: Item) - Item I, assuming present liquid level is below Max. Liq. Level: �• a
L. Record from sludge survey data sheet the distance from the present liquid surface level
to the lagoon bottom (average for all the measuement points):
M. Record from the sludge survey data sheet the distance from the present liquid surface level
to the top of the sludge layer (average for all the measurement points): (0.0
N. Record from the sludge survey data sheet the average thickness of the sludge layer: 3. $
O. Calculate the thickness of the existing Liquid Treatment Zone (Item M - Item K):
(Note: If item O is less than 4 ft., a sludge removal and utilization plan may be required by
N.C. DWQ. See your specific permit or contact DWQ for more information.)
P. Proceed to the sludge Volume Worksheet if desire to calculate sludge volume for rectangular shaped
lagoon with uniform side slope.
Completed by: �'r.�S V-yelle _ ,, > 1A Date:
Print Name Signature

Sludge Survey Data Sheet
Completed By: �}1)� r?,
Print Name
Lagoon Identification:
.i'
Signature
Date: 9 - -z -- o k
(A)
Grid
Point
No.
(B)
Distance from liquid surface
to top of sludge
M
Distance from liquid surface
to lagoon bottom (soil)
(D)
Thickness of sludge
layer
Ft. & inches
Feet (tenths)
Ft. & inches
Feet (tenths)
Ft. & inches
Feet (tenths)
i
2
2
U
3
4
.0
.9
6
7
8
.5
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
Average i
//
q
Conversion Table From Inches to Tenths of feet
Inches
Tenths of feet
Inches
Tenths of feet
1
0.1
7
0.6
2
0.2
8
0.7
3
0.2
9
0.7
4
0.3
10
0.8
5
0.4
11
0.9
6
0.5
12
1.0
M

NCDENR
North Carolina Department of Environment and
Michael F. Easley, Governor
April 30,.2004
Zack McCullen III
D & Z Farms, facility # 82-367
1058 Wynn Road
Clinton, NC 28328
Dear Mr. Zack McCullen
Natural Resources
William G. Ross Jr., Secretary
Alan W. Klimek, P.E., Director
Colleen H. Sullins, Deputy Director
Division of Water Quality
It was noted during a routine compliance inspection of D & Z Farms that a current Certificate of Coverage
was not present. I have enclosed a current copy of your Certificate of Coverage and ask that you please
place the copy with your records. If you have any questions please call me at 910-486-1541 ext. 730.
Thank you
Mark Brantley
Environmental Specialist
225 Green Street--- Suite 714, Fayetteville, North Carolina 28301-5043
Phone: [phone] FAX: [phone]nternet: ww.enr.state.nc.us/ENR/
An Equal Opportunity/ Affirmative Action Employer — 50 % Recycled 1 10 % Post C011SUmer Paper
One
NorthCarolina
Aaturally

�F WA rFR Michael F_ Easley, GovernorC
Q William G. Ross Jr., Secretary
7 North Carolina Department of Environment and Natural Resources
j Alan W. Kfimek, P. E., Director
d 'C Division of Water Quality
April 9, 2003
Zack McCullen, III.
D&Z Farms
1058 Wynn Road
Clinton NC 28328
Subject: Certificate of Coverage No. NCA282367
D&Z Farms
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
Dear Zack McCullen, III._
On March 14, 2003, the North Carolina Division of Water Quality (Division) issued an NPDES General
Permit for swine facilities. The General. Permit was issued'to enable swine facilities in North Carolina to
obtain coverage under a single permit that addresses both State and Federal requirements.
In accordance with your application received on March 6, 2003, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Zack McCullen, III., authorizing the operation of the subject
animal waste collection, treatment, storage and land application system in accordance with NPDES
General Permit NCA200000. The issuance of this COC supercedes and terminates your COC Number
AWS820367 to operate under State Non -Discharge Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the D&Z Farms, located in Sampson County, with an animal capacity of no greater
than an annual average of 1860 Feeder to Finish swine and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to
Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may
be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4
gilts for every 3 sows
The COC shall be effective from the date of issuance until July 1, 2007. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed General Permit. Since this is a new joint State and
Federal general permit it contains many new requirements in addition to most of the conditions contained
in the current State general permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pan careful attention to the record keening
and monitoring conditions in this hermit. The Devices to Automaticallv Ston Irrigation Events Form
must be returned to the Division of Water Quality no later than 120 days following recent of the
Certificate of Coverage. The Animal Facility Annual Certification Form must be completed and returned
to the Division of Water Quality by no later than March 1st of each Year.
Non -Discharge Permitting Unit Internet httpl/h2o.enr.stEkte_nc.us/ndpu
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] Fax [phone]
Customer Service Center Telephone [phone]
An Equal Opportunity Action Employer 50% recycfed/10% post -consumer paper

1
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H _0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C, the Clean Water.Act and 40 CFR 122.41 including civil penalties, criminal
penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply forr an individual NPDES Permit by contacting the staff member listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact at [phone] ext. .
Sincerely,
U
for Alan W- Klimek, P.E.
Enclosures (General Permit NCA200000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Sampson County Health Department
Fayetteville Regional Office, Water Quality Section
Sampson County Soil and Water Conservation District
Permit File NCA282367
Permit File AWS820367_
NDPU Files;

WASTE UTTLIZATION PLAA
Producer-­-:2ack McGullen, III
Name of Farm-:D & Z Farms
Location- ----:1058 Wynn Rd.
Clinton NC 28328
Type Operation - - - - - - - - - - - - - ;Faen-Fin
Number of Animal ----------- 18 Q-7
Storage Lagoon
Method U application ------ :Irrigation
,amount of waste prcduced per year ----------------- 2534 tons/year,
Amount of plant available N (PAN) produced/year-: 4278 lbs./year
The waste from ynur animal facility must be land applied at
specified rate to prevent pollution ol surface water and/or
groundwatex. The plant nutrients in the animal waste should be use
to redoce Lho amount of commercial Zertiiizer requifed for the
cropz in the fields whore the waste is to be applied.
ThiE waste utildznrinn plan uses nitrogen as the limiting
nutrientz Waste should be analyzed before each application cycle.
Annual soil tests :ter._- strongly encouraged so that all plant
nutrients con pia balanced for realiatic yields of the crop to be
grown.
Several iaatorn 3re important in implementing your waste
utilization plan in ardor to maHimize the fertili=ar value of the
waste and to ensure that it is applied in an environmentally safe
manner;
1. Always apply waste based an the needs of the crop to be grown
and the nuLyient content of the wQato. Do not apply mnr°-!
nitrogen than the crop can utilize.
2, Soil types are impaytant as they have different infiltration
rates, leaching potentials, cation eNchange capacities, and
available water holding capacities.
S. Normally waste shall not be applied to land eroding at more
than 5 tons per acre per year. Waste may be applied to land
eroding at 1 on more tons per acre annually. but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining, or
when the 8urfaca is frozen. EiChar of tnana condxtions may
In runoij to the suviace waLvIE whiah !E not allowed under DWQ
regulations.
5. Wind conditions should also be conainared to avoild drift and
downwind adore pyubiama.
6. To mamimize the value of the nutrients for crop production and
to redoce tne potential for' pollution, the waste should br,
applied to a growAng crop or applied not more than 30 days
prior to planting a crop or iorageE breaking dormancy.
Injecting tree waste or disking will conserve nutrients and
roducy odor problems
This plan in based on the waste application method Shown above. 117
you choose to change method a in the future, you noed to revise
this plan. Nutriant. levels for different application methods are
not the same.
The estimated aayes, needed to apply the animal waste is based all
typical nutnent content Yor this type of facility. Acreaye
requiram&nts should bo based on the WaEte analysis report from
Y011V waste management facility. In soma cases yo" may want tD have

Pan 2
D & L F::r. ills
plant afialyais made, Wrfi h could allow additional waste to be
applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate hanging waste analysis content
and the crop type. Lime must be applied to maintain PW in the
optimum range for :specific crop production.
Th.ia waats utilization plOn, if carried out, meets tht
r-equi cements for compliance with 15A MCAC 2H .0217 adopted by the
Envinonmont-al Management Commission.
YOUR WASTE U i Ii.a Zn T i N PLAN 13 BASED ON THE FOLLOWING:
Tract
Field
Sail
Crop
Yield
Lbs. N
,Acres.
Lbs.. N
Month to
No.
No.
Type
Cod.
!Acre
/Unit
Used
Apply
9852
1
OrB
B
5.4
50.00
1. 50
405
MAR-OCT
9852
1
Brat
K
NIA
50.00
# 1.50
75
S-APRIL
0852
a
OrB
B
5.4
50.00
4.38
1183
MAR-OCT
985'
2
O B
K
NIA
50.00
* 4.38
219
S-APRIL
9852
: �
ors
B
5.4
50.00
4.52
1220
MAR-OCT
9852
3
OrB
K
NIA
50.00
a 4.52
225
S-APRIL
9852
4
Or B
B
5.4
50.00
-.59
969
MAR-OCT
98S2
4
QrB
K
N E A
50 - 00
3.59
180
S- APRI L
Total
14. 3
4476
A va i 1.3f:
le Nitrogen
(includes commercial)
4278
Surplus Or
Deficit
--19 s
Crop off, codes! Crop -unit
t;=BYx•nr��<�a/;(x-a<�.a C�lay:r --ton 1
FFes�_=3.11 11 lint
.
H=F k?ncue (&ay) '-ton3
I=Gata--bu.
J-Rye-bu.
K=Smal. l bra in i grri e) --aor'e
L.=Small grain(hay)-acre
K=Sor_ghum(grain) -cwt.
W=Whaat-bu .
Y=Fescu=: pasture) -tong.
SBDC soybeans DC"-bu.
App1yLng the abovf amount of waste iz a big ]ob. You should plan
time and have appropriate equipment to apply the waste in a timely
Tip_ nnor.

D & Z FarmPage ..:i
Titer• applicator is caut.i_;I,.ad that p and K may be ovGr applied while=
meet.ino the N regni.refirc:nts. in the future, r egrllat.ionz may require
farmers in _:oi(e p.ar't.s of North Carolina to have a nutrient"
rnanagFinant plan Lhat" addresses all nutrients. This plain only
addresses Ali. Lr ogen .
Tn interplanted fields (i .e. small grain, etc, interseFded in
bermudagra`n), forage must be Ir''=1i1oved throolh grazing, hay and/or
silage. Where grazing, plants .should be grazed when they reach a
height of six to nine inches. Catty should be removed when plant__
are grazed to a height of four inohcs . in fields whale small grain
etc, is to ba removed for hay or silage, care should he ez rcised
not to tom• let amall grain to reach matar'ity, especially late_ in
the . __ son (i.e. April or May). _shading may result if small grain
gets too high .and this will dailnitaly interfere with stand of
'var'm:ld�grao This lQ a stand will result in reduced yields and
Was nitingEn being utilized. Rather than cutting 8mall grain for
hay or silage justbeforeheading as is the normal situation. yolt
at, et]coor god to Cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during thtr-
neasc,n, dµpendAng on time small gtsin ii1• planted in the fall.
The ideal time to interplant small grain, etc, is late September
an early October. Drilling is recommended over broadLasting.
3arrfrudagr ans should be grazed or mowed to a height of about two
inches t;:-lore drilling for best. re6ult.s.
Caution count be exencised in grazing or haying summer annuals -
under stressed conditions. Nitrate poisoning may occur in
livestock. S:-,rr,pi i n Ja forage or hay for nitrate levels is
1_ Cenrrill4e-')ld ed .
creE Shown in tha Lables are considered to be the usable acres
excluding required buffers . filter "trips .along Glitches, odd
areas Linable to he irrigated, and peY'i.raeter areas not receiving
full application raters clue to equipment limitations. Actual total
acres in the field listed may, and moat likely will be, more than
the ac'w a shown in the tAbles.
Ses attached map showing the field ,"w be used for the utilization
of animal w0ate.
SLUDGE APPLICATION:
The= w nt& utiliration plan must contain proviQion for periodic
land y il!_a ioII of aludt e at of e da 1
pr 3- agronomic rat_. The alu �� will c
;,utr,ie.it. rich and will require precautionary measures to pl"eVali=
avar application a? nutrients or other e1aTrrenLn. Your production
#acility will produce approximately 670 Its. of plant available
le
nitrogen per year in the sludge_
if you L"'_1lls=,v LF:i' PAN
e every J years, you will have approximately
1348�. lbs. rrAN to utilize. assuming you apply this PAN to
hybrid hayland at the rate of ?00 lbs. of nitrager"]
per acyn, you will need 11 acres of lanai. Tf you apply the
sludge to _:.::ern at t.le rate of 125 lba. of nitrogen per acre, YOU
will n aL! 27 acres of land. PlwaBe be aware Lhat these
only ewtimanwA of the PAN .and land needed, Actual requirr.mt=l;t__�,
could vary by 25, depending an yQur _sludge waste analy si". sai.l.
types. realistic yield`. and application methods.

,lI _�
11I
AI
S1
,Z
^I a 1 1
111 ;J
C:
J-'.
i 7
!k •.=� !j, rjl •:3 S�
�11 0
iJ -�qI
C :.
(�a
Ii t'• 1I'1 k�II
Q!
ill Q -' '•^{ 'Q i.. '
^1
I) 0 .-^1 'u
! -•
!i t'A ('V ('1 (•4
+31
X Q 111 C : '0
N -•; +1
! 4J �J
S
41 t r10 ! --q as
rl' 4Jn 11, _s]y
s
I ; �^ G?
!+
•''j 1r! iJ ri
C`4
}J S.i M t'J'k •� i4-1--'!
-
Y'1 'Y V 't' +U
•r i
k"Y i.7l1 -1
a
1�
11 �4 III) 'J
!� III 4J
'L
= 1)
iJ 0 > m
r-1 ID
171
Yt 3 al
'-I-I cn •r1 Ill
+J >+ r-! +J rL
-rl
I
-0 N
-
--! f., Ill
.-1
! ':4 r: Ill !1-4 +J
4J •-I -IJ ,ll 4-J
ija
-1 4-1 '[1
r F i 1 s: rl C
.13
' 4 • -1 !U .,-1
" a101
_
1_l r l
^
li -ri ill '?1 11 y1
YY
r 11 i
111
1 I
1 Y r.
II '� y {
;J
1 Z
-Li t-D J
1: N T I
C4 0) M
1-
. . . .
•' J� ')1 r.1 � 111
111 I]j ✓vl
'.1
�. ''
r•{ . !
� J-. k=. J
Il! +1 r-1 ^� .r{
1_i f~
4-!
'� �
!7. :: •r1
I I
i1
'll -t� Jl E, �
4-1 ,11 +J -1
.%
77 7 Ill �1 z7
it . •
,I
3 li
Q S M -1
0 C Jl �1 ;J Ill -1
Ip Iy °zl .••i C-
�-1
.J li
i:. !
�: '.�,. i i .i; --I
r-{ rl `J..il 'll
�i �!-i ••-t Q i
-:j 4l.
l:w iil l?i n7
17 F.! •�
E--
77 !Y] ri •14
ii'i r-1 0
DTI
•;.
- M •.y -r.l '.1 1.1 !?I
ICI -b
a.J
'Jl
I: I ki
it U-1 11-1 U-1 i3-1 LI-1 u-1 l!'1 0
Lw
':G IsF •:-! -s-1 4 --1 wl
.I:, k+-I r7 i^
ry
.-I
II. . . .
`.
1 j 17 0 r-! LTl
V-'
T7'r o?i +11 'J '�!
�J ' ! _T1 2 L.{y
_
r-� �
�^
I f ;� � jI ti.' •.-yl �'; .sh} *�1 �+1i
..,-
i! ?-! a-i J-J J.J
0
«-. :�. kl Jr
!ll
!a, 4-J i.
':�k, lil •-{
II
It
1^ �
11 11
>4 ;fl if)
1 ?fl
r.*
-H 4J
., ,1
r'1 r',I ra r'a r'a la ra ra
ill 4-1I
-�--' IlI
-{ �!l c
1; .,� C 'li
i
a
7 C-1
fi
I: I �7 •-+ �_I ,7 tH —I
J.:I 17 ?4 fl
I:
f.+, V
11 Fr. LC: 1 r.. L[ k-L' 64 1-4 1
L.1 +1
•
{
.I
12.
II (.:1 . IL_I L .�
N ", '., '`r "., '•
.•-1 -ri I;l -H
3
is Il I �^1 1 V
, 111 Jj I
all -�
it
i
11 -N.
II Mwl W f>7 I (-tl Car
_ _
^ 1
7 r 7 41 L1 ra
ITi E
-i
71
IL1
'
SIS +1
41 Ir }
I i
s
--i LI
r-i {J :J1 r-1 {.i •r+. i7
..
I I tiJ. .i.!
T
,•1 I:l is >
1.1 ' 1 L7, 171
.-{ iJi 4-I 17 I r
I I
L L•
;1 f Y•
a Iwl as s-.1 oD (a al gal
aJ
J7 I11 ;11 A L
..
L'� '-�1 rl Ili
k-! S.'.-.l G}+�1 (_1
i�r: t,j
!0) 4-1 F=ia,
^�
•J i-1 -t 1.} -iJ
�--
7J . !;ja ll ;r I..!
--'. '11 :1 ''} 1-•'
1..` �:
i_li F-'
11
-r{ i� :�•
4 -0 :_i 111 SJ. I?i i_I
e-! :71 c7
1?1'
-Ti
,r ri I� l
!
-IJ �^i •r1 •!= 'u j .1.
" "'
Ill N :a4
-1 L
C1 111 ("1
-
!-L
I' -•'! i.l i.;F .,1 -FJ
Ill -'-i 4} -,1 :11
3 ,�I
---1nl
:H
a l l
+-1 i--•I '11 Ul
'•
_
'ri .^.7 k.1 I,•, a� +1i
ITl .i� ;=1 .�. i. -'•i
r-+ •i=
k-L Z
11
�
•
JJ ��
yr�
r 1r,
rn
-'
QI :sl 7] 71 'T1
—0
N !.. 1-i c 4-1
1J iJ
II I"'�i I 1 3."'1 i'', l,1 /
I, I"i I i' I L V l ��
.�. ..-!
Ill 'w!
Ya �� J1
�1 Lll ti
u] C: •r! =L i� 'lI
41 •r!
;.1
It L7 U-1 e' 1 U" u-) 6) U-.9 u')
--'I
a -I
s i ---I ..1 -�
L.
i i^
11�,3
r-+-1!
.
frtrtffl
IT 'DJ• 43 '-i Cj
•'.1 :�i r/J' ��
ID ITI IT' 17) (1M IT.
Sl .�-'lI
•H ..1J11
)1 J:! L
'""'1 .-'{ r1.1 111 IT.i
1.
C-;
Jl if! 3 `l r

» is �41
:j
4-1
it
kl
T,
c
rJ
tr IV
4-1 ill
­4
:7. rl i.,
I I. i Q
�H 4-1
ci
4
U)
�o
Ill 3
T
ill E 04
-TI r U-1
V 0 t".4
'j J-)
111
4-1
i,- LO
11
-.1)
;1j
4-1
01 C4 ---4
0
4j
4i
-V 4J
4
:.4
4-1
4
ka,
I'l
"j)
17.
>
C,
4-J
eq
',4
Q rr
1'.1 >
o) U .-I
41 :)I Q.
--I
--I 01 G.
ill
ri
-�J 4-) 0.
tt "JI 11 A7- rj
-4-1 c-
Lrj Ir
17! �:i 41
r,, m
ri
�4
Irj
4�
7
ti C,
c "::
4-j
4i
17,
3 Xly
�4
-ri 0
'J i1. al 4-J
C, 4j
a
a U) I'L 1
141 111 4 Q
rll Q
W1
3, W 1_1 -
0
0
�1 T
'11 111
04 -Cl
�14 'Si
ter .c
41 .: 4
a, -u
.11
-t-j '.J:l -H --jj
� 111 4J
I'l 4-mi
C 1 1::L

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
I. Animal waste shall not reach surface -waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per re per year. i' L � � � land that is eroding
t"'� •.•��. r 1' ar. r�asL.2 iisa�' i,c applied to
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
5. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or -
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" =or guidance.)
7_ Liczuid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manger that the crop is -not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered_
Page : 8

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates.on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways_
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist"_ Animal waste shall not be applied on
grassed waterways that discharges directly inton water courses,
and on other grassed waterways, waste shall be applied at
agror_omic rates in a manner that causes no runoff or drift from
the site.
16. Dcmastic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
prcc=ct the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge_
P age : 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 50 days of atiliza ion and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when thes
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste aoolication records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five ( 5 ) years .
23. Dead animals will be disposed of in a manner that meets North
Carolina requlations.
Page: 10

Page
WASTE UTIL12ATION PLAN AGREEMEN7
Name r• 2Iltc of Faro: Li _ Z'ar lit;3
Owner/Manager Agreement
I (we) understand and will follow and implement the wpecif.ications
and the opefat.lon and maintenance procedurns established in the
appfoved animal waste utilisation plan !or the farm named abuv=_ i
(we) knuw that any expansion to the existing de_z n rapacity of
the w==1 Le treatment and storage system or construction of no
facilities will requira a new certification to be aubmittEd to the
North Carolina Division of Wat=r Quality (htCDWQ) before the now
animals are stocked. 1 <we) also Lf3�_iorstand that her -ems must be no
discharge of animal waste from this a•y-` - t - r waters
ru ;f� �.o �.�� surface waters.
of the state 1fam a atorm event less severe than the 25-yaar, 24._
hour storm. The approved plan will be !!led on -site at the faun
cff ice and at the office of the local :Soil and Water Conservation
District and will be available for 'review by NCDWO upon request.
Name of Facility Owner: crack McCnlian, ili
;.plisse print)
Signature" Y Date:
Name of Man agn f.1s diffnrent from _wnsr ?
Da t"
Mama of Person
Preparing
Plan: G.
Glenn Clifton
(Please printn
7
nc.
q y
Phone: -592-4776,
Address:
p 0 Box
438
Ext.
24?
Clinton
N 2a329
Signature: Date: AL

IRRIGATION SYSTEM PARAMETERS
Land Owner: D & Z Farms -Zack McCullen, III Date: 7/14100
Address: 1058 Wynn Rd.
Clinton NC 28328 Facility No. 82-367
Telephone: [phone]
County: Sampson
TABLE 1 - Field Specifications
Field No.
and/or
Pull No.
Maximum
Usable
Size of
Field
Soil Type
Slope
%)
Crop(s)
Maximum
Application
Rate
in/hr)
Maximum
Application
per Irrigation
Cycle
(inches)
1
1,50
OrB
2-6
CBISG-GRAZE
0.5
1
2
4.38
OrB
2-6
CB/SG-GRAZE
0.5
1
3
4.52
Orb
2-6
CB/SG-GRAZE
0.5
1
4
3.59
OrB
2-6
CB/SG-GRAZE
0.5
1
Computed By: G. Glenn Clifton
Techn. Specialist
Prestage Farms,lnc

Hard Hose Traveling Gun System
Land owner: D & Z Farms -Zack McCullen, III
Irrigation System
Designation: X Existing Irrigation System
Wetted Diameter: 215 feet
Spacing: 172 feet
Hydrant Layout: X Multiple Hydrants
Facility Number: 82-367
New/Expanding
Irrigation System
Single Hydrant
Length
Computed By: G. Glenn Clifton
.9-AC. Chi --
Techn_ Specialist
Prestage Farms, Inc.

JV.
N=n
gg,
I A
!r
01
4 4�?!Z
13
O-Aq, ­?V
Miss
NN
Ov,
KIM
pp.
J.)
vt 'I
F 03.. 1 Ww- Or.
IM ;.I X51.1 s.
took —
A
'710.1
;; qw
­1 1.01
4
13�
•
2"POWNIVA",
MHO
47M
�
­PW 9
-q!
TP il;
�yq
MST; Lf I-'
4w,
Ne"WL
.......... J N 11 WTFPPP
J

FORM IRR-2
Hydrant # �3 Field q
Field Size (wetted acres) = (A)
Farm Owner
Owner's Address
Owner's Phone N
C'U42 t.tJ
C�_ w L.i X&lv A,)
Lagoon Liquid Irrigation Fields Record
One Form for Each Field per Crop Cycle
Crop Type
it) (2) (31 (4) (51 (6)
Facility Number c� .-
Irrigation Operator
Irrigation Operator's
Address
Operator's Phone N
From Waste Utlllzatlon Plan
Recommended PAN
Loading (lb/acre) = (B)
(7) (81 (91 (101 (111
—Nutrient
Source
Date
(mmlddlyr)
Irri
alien
Waste Analysis
PAN'
(IW1000 gal)
PAN Applied
(Ib/acre)
(8) x (91
1000
Nitrogen
Balance"
(Iblecte)
(B) . (10)
Start
Time
End
Time
Total
Minutes
(3) • (2)
N of
Sprinklers
Operaling
Flow
Rate
(gaVmin)
Total Volume
(gallons)
(6) x (5) x (4)
Volume
per Acre
(gallacre)
(7) 1(A)
B= -5 C}
/l-.22-02
L-22
2,30
1 D
boo
Z y 00
6655
/.
/ o 3
312 rZ
.2 03
ll:30
-2'/
6
/
02 0o
3 as
Crop Cycle Totals
Owner's Signature
Certified operator (Print)
Operator's Signature
Operator's Certification No.
NCDA Waste Anaylsis or Equivalent. Al a minimum, waste analysis is required within 60 days of land application events.
" Enter the value received by subtracting column (10) from (B), Continue subtracting column (10) from column (11) following each irrigation event.
3/14/03
—Enter nutrient source (ie. LagoonlStorage Pond ID. commerical fertilizer, dry litter, etc.)

FORM IRR-2
Hydrant # Field OF
Field Size (wetted acres) = (A)
Farm Owner
Owner's Address
Owner's Phone #
Lagoon Liquid Irrigation Fields Record
One Form for Each Field per Crop Cycle
Crop Type
(1) (2) (3) (4) (5) (6)
Facility Number - 6 7 J
irrigation Operator All °
Irrigation Operator's
Address
Operator's Phone 0
From Waste Utilization Plan
Recommended PAN
Loading (Iblacre) = (B) So
(7) (8) (9) {10) {tt)
"'Nuldent
Source
Date
(mmlddlyr)
Irrigation
Waste Analysis
PAN'
(lbtl000 gal)
PAN Applied
(Iblacre)
(8) x f91
1000
Nitrogen
Balance"
(Iblacre)
-` 00)
Start
Time
End
Time
Tonal
Minutes
(3) . (2)
0 of
Sprinklers
Operating
Flow
Rals
(gallmin)
Total Volume
(gallons)
(6) x (5) x (4)
Volume
per Acre
(gal/acre)
(7) ! {A)
r(W
a=
�y-off
8'.00
ll.00
00
36,000
'' 9 b
1. S
1 y. 33
S 6
- -o
yo
70
70
.o no
?4 000
2
3,
5.5
D, Z0
3-0
:00
Io-ao
�D
1
a
co
SS
3
d
08
Crop Cycle Totals
Owners Signature Operator's Signature
Certified Operator (Print)
Operator's Cerlificalion No.
NCDA Waste Anaylsis or Equivalent. At a minimum, waste analysis is required within 60 days of land application events.
" Enter the value received by subtracting column (10) from (8), Continue subtracting column (10) from column (t 1) following each irrigation event. 3114l03
"'Enter nutrient source (ie. Lagoon/Storage Pond ID, commerical fertilizer, dry litter, etc.)

FORM Inn-2
Hydrant # Feld #
Field Size (wetted acres) = (A)
Farm Owner
Owner's Address
Owner's Phone #
Lagoon Liquid Irrigation Fields Record
One Form for Each Field per Crop Cycle
Crop Type
(1) (2) (3) (4) (5) (6)
Facility Number I I?-;- (-"7
Irrigation Operator ZICA h9 t 4i
Irrigation Operator's
Address
Operator's Phone #
From Waste Utilization Plan
Recommended PAN
Loading (Ib/acre) = (B)
"'Nutrient
Source
Date
(mmlddtyr)
Irri
anon
Waste Analysis
PAN'
(lbl1000 gal)
PAN Applied
(Iblacm)
(8) x 191
1000
Nitrogen
Balance"
(lb/acre)
(B) • 110)
Slarl
Time
End
Time
Total
Minuses
(3) • (2)
M of
Sprinkiers
Operating
Flow
Rale
(gatlmirl)
Total Volume
(gallons)
(6) x (5) x (4)
Volume
per Acre
(gailacre)
(7) l (A)
B=
`/:00
1 O
/
.200
34,000
3.212
7
35,
- ?-42
: O
/):00
9D
00
1�10C,C;�
L)
a 1�
Crop Cycle Totals
Owner's Signature
Certified Operator (Print)
Operator's Signature
Operator's Certification No.
NCDA Waste Anaylsis or Equivalent. At a minimum, waste analysis is required within 60 days of land application events.
Enter the value received by subtracting column (10) from (8). Continue subtracting column (10) from column (11) foilowing each irrigation event. 3/14/03
*"Enter nutrient source (le. Lagoon/Storage Pond ID, commerical fertilizer, dry litter, etc.)

FORM IRR-2
Hydrant q Field fl
Field Size (wetted acres) = (A)
Farm Owner
Owner's Address
Ownor's Phone #
r !�
Lagoon Liquid irrigation Fields Record
One Form for Each Field per Crop Cycle
Crop Type
(1) (2) (3) (4) (5) 16)
Facility Number„ ,� (� •+
Irrigation Operator / ,1
Irrigation Operator's
Address
Operator's Phone p
From Waste Utilization Plan
Recommended PAN }
Loading (Iblacre) = (8) % ri
f7) (e) (9) flol f111
"'Nulrient
Source
Date
(mmlddlyr)
I ' alien
Waste Analysis
PAN'
(IbIl000 gal)
PAN Applied
(Ib/acre)
191 x (81
1000
Nitrogen
Balance"
(tWacrel
Start
Time
End
Time
Total
Minutes
(3) - (2)
q of
Sprinklers
Operating
Flow
Rate
(gal/min)
Total Volume
(gallons)
(6) x (5) x (4)
Volume
per Acre
(gaVacre)
(7) J (A)
6=
Crop Cycle Totals I
Owner's Signature
Operators Signalure
Certilied Operator (Print) Operator's Certification No.
NCDA Waste Anayisis or Equivalent. At a minimum, waste analysis is required within 60 days of land application events.
Enter the value received by subtracting column (10) Irom (B). Continue subtracting column (10) from column (11) following each irrigation event. 3/14/03
"Enter nutrient source (le. Lagoon/Storage Pond ID, commerical fertilizer, dry litter, etc.)

FORM fRR-2
Hydrant p 1 1 Field t1 f
Field Size (welled acres) = (A)
Farm Owner
Owner's Address
Owners Phone #
'0 f- - 3L W.— 2 l S
Lagoon Liquid Irrigation Fields Record
One Form for Each Field per Crop Cycle
Crop Type r G
(1) (2) {3) (4) (5) (6)
Facility Number < 4—
Irrigation Operator G % L (.eZ j .11y
Irrigation Operator's
Address
Operators Phone N
From Waste Utilization Plan
Recommended PAN
f
Loading (Iblacre) = (B) r n
(7) {a) (9) (10) fill
"'Nutrient
Source
Date
(mmlddlyr)
lrri
anon
waste Analysis
PAN'
(lbl1000 gal)
PAN Applied
(IblacrO
(51-M (9i
1000
Nitrogen
Balance"
(Iblacre)
(a)-(10)
Start
Time
End
Time
Total
Minutes
(3) • (2)
If of
Sprinklers
Operating
Flow
Rate
(galtmin)
Total Volume
(gallons)
(6) x (5) x {4)
Volume
per Acre
(gal/acre)
(7) 1(A)
l3= �
Ll-1' 03
15
/IS'
-2oc7
-'23 000
S
-25 7
-� -o
02 'l5
3 '20
IS
..200
9
.7 4/y S
y-.2o-o3
7.,00
8:oo
60
Z
.200
J.2, oo
-02 39
2.
. 9 V
_Z3 6. 9 D
y- 3-03
S:oo
: oo I
I2 o
zoo
.2 o
�2 ,
IS, Y
Q.2 o
9--2 �-o3
8,' o
Io : oo
9f)
/
oo
l L 000
y l O
2, 0Z
I
2 02. O
Crop Cycle Totals
Owner's Signature
Corliiied Operator (Print)
Operators Signature
Operator's Certilication No.
' NCDA Waste Anaylsis or Equivalent. At a minimum, waste analysis is required within 60 days of land application events.
"Enter the value received by subtracting column (10) from (6). Continue subtracting column (10) from column (11) following each irrigation event.
3/14103
"'Enter nutrient source (le. Lagoon/Storage Fond ID, commerical fertilizer, dry litter, etc.)

FORM IRR-2
Hydrant It Field p
Field Size (wetled acres) = (A)
Farm Owner
Owner's Address
Owner's Phone N
Lagoon Liquid Irrigation Fields Record
One Form for Each Field per Crop Cycle
Crop Type
(1) (2) (3) (4) f5) (6)
.— .,
Facility Number f�
Irrigation Operator 2P c'
Irrigation Operator's
Address
Operator's Phone q
From Waste Utilization flan
Recommended PAN
Loading (Iblacre) = (B) '[%
(7) (6) (91 (iM rill
"'Nutrient
Source
Dale
(mm/dd/yr)
1rri alion
Waste Analysis
PAN'
(fb11000 gal)
PAN Applied
(Iblacre)
0 x 0
1000
Nitrogen
Balance"
(lb/acre)
(8) • 110)
Start
T+ma
End
Time
Total
Minutes
(3) • (2)
N of
Sprinklers
Operating
Flow
Rate
(gallmin)
Total Volume
(gallons)
(6) x (5) x (4)
Volume
per Acre
(gavacre)
(7) 1(A)
7
B= a 70
q-1 -03
7:io
9:00
1l0
boo
o00
S'e67
2.5
/ 1
.2
200
/8 000
e251t1,
Crop Cycle Totals
Owner's Signature
Certified Operator (Print)
Operalol's Signature
Operator's Certificalion No.
' NCDA Waste Anaylsis or Equivalent. At a minimum, waste analysis is required within 60 days of land application events,
" Enter the value received by subtracting column (10) from (8). Continue subtracting column (10) from column (11) following each irrigation event. 3/14103
"'Enter nuldent source lie. Lagoon/Storage Pond 1D, commerical fertilizer, dry litter, etc.)

FORM IRR-2
Hydrant # 3 1 Field #
Field Size (wetted acres) = (A)
Farm Owner
Owner's Address
Owner's Phone #
r-P.,? / ry .J ri 1-e
c %0 -5-3 2 2 9.54:)
Lagoon Liquid Irrigation Fields Record
One Form for Each Field per Crop Cycle
Crop Type
(1) (2) (3) (4) (5) (6)
rrr�
Facility Number [a
Irrigation Operator r /'� C �( A/I
Irrigation Operator's
Address
Operator's Phone #
From Waste Utilization Plan
Recommended PAN
Loading (lb/acre) = (B) 0
t7) le) (9) (10) (11)
"'Nutrient
Source
Date
(mmldd/yr)
Irrigation
Waste Analysis
PAN'
(tb11000 gal)
PAN Applied
(Iblacre)
Ial x t91
1000
Nitrogen
Balance"
(Iblacre)
(B) • (10)
Start
Time
End
Time
Total
Minutes
(3) • (2)
q of
Sprinklers
Operating
Flow
Rate
(gavmin)
Total Volume --
(gallons)
(6) x (5) x (4)
Volume
— per Acre
(galfacre)
(7)1(A)
B- a 70
qjIl-02
l: oo
7 y5
4 S
.200
oco
o,;,
6a . 7
Li-- 9- 02
8: O s
60
.2 D O
/.? 0 0 0
2321
a.
6
Zs . D
Crop Cycle Totals
Owner's Signature
Operator's Signature
Certified Operator (Print) Operator's Certilication No.
NCDA Waste Anaylsis or Equivalent. At a minimum, waste analysis is required within 60 days of land application events.
•' Enter the value received by subtracting column (10) from (8). Continue subtracting column (10) from column (11) following each irrigation event. 3114103
"'Enter nutrient source (ie. Lagoon/Storage Pond ID, commerical fertilizer, dry litter, etc.)

FORM IRR-2
Tract #
Field Size (acres) = (A)
Farm Owner
Owner's Address
Owner's Phone #
Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
.. z 952.1
Field #
So
EXHIBIT E-2
Facility Number - ��
Irrigation Operator C, JYI
Irrigation Operato(s
Address j 2S?, ZJ
Operator's Phone # c - - 3 yS0
From Waste Utilization Plan
Crop Type Recommended PAN Loading �7
-r7 rQ.�sT (Iblacre) r (B) v{ Q
111 171 !31 rdl 151 161 r71 MI r91 rinl fill
Date
mmlddlyr
Irrigation
Waste Analysis PAN
(Ih11000 gall
PAN Applied
(lblacre)
B x(9
1000
Nitrogen Balance'
(lb/acre)
(B) - 00)
Start Time
End Time
7olal
Mules
(3) (2)
# or Sprinklers
Operating
Flow Rate
(gallmin)
Total Volume
(gallons)
(g) x (5) x (4)
Volume
per Acre
(gallacre)
JIy
A
-raa
3'Y0
`i'w�ra
v
"-�ca
l�rz n
5'03
Q
�5`I,
Crop Cycle Totals 4 j
Owner's Signature
Certified Operator (Print)
Operator's Signature
Operator's Certification No.
t NCDA Waste Anaylysis or Equivalent or NRCS Estimate, Technical Guide Section 633.
2 Enter the value received by subtracting column (10) from (B). Continue subtracting column (10) from column (11) following each Irrigation event.

FORM IRR-2
Tract #
Field Size (acres) = (A)
Farm Owner
Owner's Address
Owner's Phone #
Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Field #
M ` r:;
N �' c J
2—S 2 3 -o
EXHIBIT E-2
Facility Number I - 1 •? b
Irrigation Operator n/Ml , L u
Irrigation Operator's
Address �3
Operator's Phone # YS D
From Waste Utilization Plan
Crap Type j q cxm 1 ng s_� I Recommended(blac e) = PAN d(B) ing ��� - -- �- - T
(1) (2) (3+) (4) r (s) (6) I (7) (0) (0) (10) fill
Date
mmlddtyr
Irrigation
Waste Analysis PAN'
(Ibr1000 gal)
PAN Applied
(Iblacre)
fg)(8)
1000
Nitrogen Balance'
(lbrecre)
(B)- (1tl)
Start Time
End Time
Total
Minutes
(3)(2)
# of Sprinklers
Operating
Flow male
(gallmin}
Total Volume
(gallons)
(g) . (5) r (4)
Volume
perAcre
(galracre)
-1 L
A
`1-t1-o
S'ao
0:00
I O
I
a
36 9-2
a
/d'.90
o?S
'?o
60
v.
o.a
1- .00
2?'.I b
2Gio
'200
rsv
1 a -3a
;2, 3
?
"7
Crop Cycle Totals
Owner's Signature
Certified Operator (Print)
Operator's Signature
Operator's Certification No.
I NCIbA Waste Anaylysis or Equivalent or MRCS Estimate, Technical Guide Section 633.
'Enter the value received by subtracting column (10) from (B). Continue subtracting column (10) from column (11) following each irrigation event.

FORM IRR-2
Tract #
Field Size (acres) = (A)
Farm Owner
Owner's Address
Owner's Phone #
Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
7, ",
Field #
ye s r4
Zosy
EXHIBIT E-2
Facility Number'
Irrigation Operator C ' M i CC: TZt
Irrigation Operator's
Address L) 'J(VW eov
Operator's Phone #
From Waste Utilization Plan
Crop Type Recommended PAN Loading
$ (lblacre) = (B) „2 7l
rn r91 131 141 r51 ret rat ras 191 riui rill
Dale
mmlddlyr
Irrigation
Waste Analysis PAN
(Ib11o00 gal)
PAN Applied
(lblacre)
—i81 x f9—
1000
Nitrogen Balance'
(lblacre)
(B)' 001
Start Time
End Time
Total
Minutes
(3) • (2)
N of Sprinklers
Opefating
Flow Rate
(gallmin)
Total Volume
(gallons)
(a) m (5) x (4)
Volume
per Acre
(gavacre)
—11_
A
0
a o o
3,
E, 3
-� 5
000
�s
a._
a�.3
.733.Y
L 13-OZ.
' ?o
L :00
2-10
00
1 L
.2.3
.a
SOS
Crop Cycle Totals I J
Owner's Signature
Certified Operator (Print)
Operator's Signature
Operator's Certification No.
1 NCDA Waste Anaylysis or Equivalent or NRCS Estimate, Technical Guide Section 633.
2 Enter the value received by subtracting column (10) from (B). Continue subtracting column (10) from column (11) following each irrigation event.

Form IRR-2
Tract #
Field Size (acres) = (A)
Farm Owner
Owner's Address
Owner's Phone #
Lagoon Liquid lrrigati:in Field Record
One Form for Each Field Per Crop Cycle
- j�5,
Field #
` n K A `
C GIL1,-A'it% _ZZ—
J. f� J/
is O
U- -?3-
501
Facility Number -1361
Irrigation Operator 2,0c k
M ` 6l
Irrigation Operator's
Address
Operator's Phone # U S, .� -- ��
From Animal Waste Management Plan
Crop Type Recommended PAN
Loading (lb/acre) = (9) ,
(1) (2) (3) (4) (5) (6) (7) (3) (9)
(101
0 1)
Irrigation
Date
(mm/dd/yr)
Start Time
(hr:min)
End Time
(hr:min)
Total Minutes
(3) - (2)
# of Sprinklers
Operating
Flow Rate
(gal/min)
Total Volume
(gallons)
(4) x (5) x (6)
Volume Per
Acre (gallac)
(7) * (A)
Waste Analysis 1.
PAN (lb/1000 gal)
PAN Applied
x (lb/a+)
I(a} (9)1 1,000
Nitrogen Balance
( (l / fc) )
B - 10
/y-0-j�
8.00
0 : Y5
Q00
33000
lu.3
.2/. /Y
-7 YR. R
qs
2 ?o
a .�S
D00
ys oo
J.2,53
.2. 3
Crop Cycle Totals
Owner's Signature
Operator's Signature
Certified Operator (Print) Operator Certification #

Form IRR-2
Tract #
Field Size (acres)=(A)
Farm Owner
Owners Address
Owners Phone #
Lagoon Liquid Irrigation Field Record
One Form For Each Field Per Crop Cycle
r- Field #
%- 0
" UZL,.
v S " 4,-.) ' "/v by,,w
- S E 3 t✓
Facility #
Irrigation Operator1/��
Irrigation Operator
Address / DS<� 11J A v,,9,0
Operators Phone # --3
From Animal Waste Management Plan
Crop Type I _ -M Recommended PAN
Loading (Iblacre = (B) [)
ill (21 (3) (4) (51 (6) (71 (8) (91 (101 (11l
Date
(mmldd/yr)
Start Time
(hr:min)
End Time
(3) - (2)
Total Minutes
(3) - (2)
# of Sprinklers
Operating
Flow Rate
(gallmin)
Total Volume
Gallons
(4)x(5)x(6)
Volume Per
Acre (gallac)
(7) - (A)
Waste Analysis
PAN (lb/1000 gal)
PAN Applied
(lblac)
[(B)x(9)-1000
Nitrogen Balance
(Iblac)
(B) - (10)
Owner's Signature
Certified Operator
crop uycle Locals �I I I
Operator's Signature
Operator's Certification #

l }<011��s
State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Kerr T. Stevens, Director
MEMORANDUM
To:
From:
April 4, 2001
Regional Water Quality Supervisor
A I / RIL
NZDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND Nsu-uRAL RESOURCES
Sonya Avant, Environmental Engineer AX6
Non -Discharge Compliance and Enforcement Unit
'APR 9 2001
F;- L '.n'EV;LLE
REu. DFFI%�o
Subject: Wettable Acre Determinations for Certified and Permitted Operations
Attached is a list of the facilities in your respective regions that have been selected to receive
notification letters advising them that they have been flagged or pended for the month of March.
Each facility will be given written notice via certified mail_ The notice will include a copy of the
certification form and a deadline for response.
I will also be sending copies of the final monthly list of selected facilities to the Division of Soil
and Water Conservation Operation Reviewers and Soil Water Conservation District Offices each
month along with an updated copy of all facilities in that county that have been either flagged or
pended. This will hopefully enable the Districts to be better able to schedule their workloads.
If you have any questions, please contact me at 733-5083 extension 571, or
[e-mail].
cc: Coleen Sullins
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]U
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Facilities Flagged/Pended for April 6, 2001
Facility Flagged/Pending
Number Owner Farm Name Address Status WA PAN deficit WA Visit Date Integrator
FRS
09 — 66
Darrell Cable
2209 Old Fay Rd
P2
952
5/17/19"
Murphy Family Farms
Garland NC 28441
Harvey Coble Nursery
09 — 132
Darryl Hardee
3281 Rosindalc Rd
FI
889
5/19/1999
Murphy Family Farms
Clarkton NC 28433
Terra Nova Limited
82 — 35
Rudcar Farms Inc
PO Box 857
F4
393.72
4114/19"
Prestage Farms
Clinton NC 28328
Rudcar Farms [Fie
82 — 88
Ward Parker
9052 Lake Point Dr
F4
491.49
4/23/1999
Prestage Farms
Clinton NC 28328
Ward Parker Farm
82 — 112
Donnie Bradsher
2950 Moseley Ave
F4
557
4122/19"
Murphy Family Farms
Clinton NC 28328
Bradsher Farms 1, 2 & 3
82 — 164 Billy Tyndall 6431 N US 421 Hwy F4 409 5/11/1999 Prestage Farms
Clinton NC 28328
B&B Tyndall Farm
82 — 184 Sherwood F Allcox 255 Fork Lake Drive F4 527.25 4/14/1999 Prestage Farms
Clinton NC 28328
S.E.A. Livestock
82 — 186 Herbert G. Bowden
Herbert G Bowden Farm
11294 Hobbton Highway F2
Clinton NC 28328
516
4/26119" Prestage Farms
W

Facilities Flagged/Pended for April 6, 2001
Facility Flagged/Pending
Number Owner / Farm Name Address Status WA PAN deficit WA Visit Date integrator
82 —189 Roy Horne 73 D&H Lane P2 497 &22/1999 Dogwood Farms
.................•.................. Turkey NC 28393
D&H Farm
82 — 199 Glenn D. Jones 81 Hardy Lane F4 577.8 5/11/1999 Prestage Farms
Clinton NC 28328
Glenn D. Jones Farm
82 _. 318 Carroll's Foods Inc PO Box 856 F2
.................................... Warsaw NC 28398
2703
4710 U19/1999 Carroll's Foods Inc
82 — 319 Carroll's Foods Inc PO Box 856 F2 11428 2/18/1999 Carroll's Foods Inc
. Warsaw NC 28398
2702
82 — 323 John Hendrix 145 Register -Sutton Road F2 575 6/22/1999
Rose Hip NC 28458
John Hendrix
82 — 335 Rexton Simmons 1128 HONEVCV'f'F F4 494 5/5/1999 Murphy Family Farms
. CLINTON, 28328
R&R Farms
`92 — 367 Zack McCullen,111. 1058 Wynn Road F4 423 4/22/1999 Prestage Farms
Clinton NC 28328
D&Z Farms
82 — 376 David Sinclair 6978 Faison Hwy. F4 512.5 3J15/1999 Carroll's Foods, Inc.
. Faison NC 28341
David Sinclair Farm

Facilities Flagged/Pended for April 6, 2001
Facility Flagged/Pending
Number Owner / Farm Name Address Status WA PAN deficit WA Visit Date Integrator
82 — 426 Ben Parham 2391 Isaac Weeks Road F2 552.9684 4/22/19" Prestage Farms
........................... .. Clinton NC 28328
Parham Farms
82 — 439 James Greg' Horrell 9461 Tomahawk Highway F4 529 :V2W1999 Murphy Family Farms
. Tomahawk NC U444
Greg Horrell Farm #2 & Addition
82 — 444 Nash Johnson PO Box 25 F4 398 4/5/1999 Murphy Family Farms
:. Clinton NC 28328
Boykin Lake Farm
82 — 448 Richard Whitfield 1670 Kenan Weeks Rd F4 504.99 4/29/1999 Murphy Family Farms
. Newton Grove 29366
Whitfield Livestock #1
82 _. 466 Carroll's Foods Inc PO Box 856 F2 9411 2/16/19,99 Carroll's Foods Inc
Warsaw NC 28398
2537 and 2538
82 — 472 Carroll's Foods Inc PO Box 856 F2 5275 2117119" Carroll's Foods Inc
Warsaw NC 28398
2142
82 — 473 Carroll's Foods Inc PO Box 856 F2 3597 2/16/1999 Carroll's Foods Inc
Warsaw NC 28398
2141
82 — 475 Carroll's Foods Inc PO Box 856 F4 16510 2/15/1999 Carroll's Foods Inc
Warsaw NC 28398
21" and 2104
'�� J Kc;�'r'- C �-

Facilities Flagged/Fended for April 6, 2001
Facility Flagged/Pending
Number Owner / Farm Name Address Status WA PAN deficit WA Visit Date Integrator
82 — 497 Carroll's Foods Inc PO Box 856 F4 3650 2/18/1999 Carroll's Foods Inc
Warsaw NC 28398
2122
82 --- 598 Robert Naylor 2988 Church Road F4 393.15 4/14/19" Murphy Family Farms
Clinton NC 28328
Robert Naylor #3
82 .-- 611 Mark & Lora Godwin 1177 Eldridge Rd F2 404 3/10119" Murphy Family Farms
Newton Grove 28366
Godwin Nursery SCD #1 & 2
82 — 619 Elbert Pearsall 997 Simmons Road F4 520 4/26/1999 Prestage Farms
. Clinton NC 28328
Elbert Pearsall Farm
82 -- 621 Jody Coombs P.O. Box 612 F4 463.4 4/21/1999 Prestage Farms
Clinton NC 28329
Joshua Coombs Farm

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
Zack McCullen III
D&Z Farms
1058 Wynn Road
Clinton NC 28328
Dear Zack McCullen III:
A
vq*
•
."
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NAwuRAL RESOURCES
March 11, 1999 RECEIVED
MAR 1 6 1999
FAYETTEVILLE
REG. OFFICE
Subject: Certificate of Coverage No. AWS820367
D&Z Farms
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your application received on February 17, 1999, we are forwarding this Certificate of
Coverage (COC) issued to Zack McCullen III, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG 100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the D&Z Farms, located in Sampson County, with an animal
capacity of no greater than 1860 Feeder to Finish and the application to land as specified in the Certified
Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-2I5.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS820367
D&Z Farms
Page 2
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Susan Cauley at [phone] ext. 546.
Sincerely,
r' A. Preston Howard, Jr., P.E_
cc: (Certificate of Coverage only for all cc's)
Sampson County Health Department
Fayetteville Regional Office, Water Quality Section
Sampson County Soil and Water Conservation District
Permit File
NDPU Files

State of North Carolina ����1/�
Department of Environment and Natural Resources Y
Division of Water Quality MAR 1 6 1999
Non -Discharge Permit Application Form
(THIS FORM MAYBE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Existing Liquid Animal Waste OperatA G.O�C
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
1.1 FacilityName: D&Z Farms
1.2 Print Land Owner's name: Zack McCullen
1.3 Mailing address: 1058 Wynn Road
City, State: Clinton NC
Telephone Number (include area code): 533-3450
Zip: 28328
1.4 County where facility is located: Sampson
1.5 Facility Location (Directions from nearest major highway. PIease include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): Hwy. 701 Business from Clinton to SR 1749, turn
right approx 3 miles to SR 1750, farm 1/2 mile on rig�t.
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Prestage Farms
1.8 Date Facility Originally Began Operation: 01/01/88
1.9 Date(s) of Facility Expansion(s) (if applicable): _ ll ilg;r
2. OPERATION INFORMATION:
2.1 Facility No.: 82� (county number); 367 (facility number).
2.2 Operation Description: Swine operation
—Feeder to Finish
1860- Certified Design Capacity
Is the above information correct? yes; no_ If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum num er or which the waste management structures were designed.
Type of Swine No. of Animals
0 Wean to Feeder
0 Feeder to Finish
0 Farrow to Wean (# sow)
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the farm:
Type of Poultry No. of Animals
0 Layer
0 Non -Layer
0 Turkey
Type of Cattle No. of Animals
0 Dairy
0 Beef
No. of Animals:
FORM: AWO-G-E 5/28/98 Page 1 of 4 82 - 367

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): Required Acreage (as listed in the AWMP): 29.38
2.4 Number of lagoons/storage ponds (circle which is applicable): t
2.5 Are subsurface drains present within 100' of any of the application fields? YES or ® (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or l� (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS. Standards, etc.) (Swine Only)
nor. NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? 19 88
What was the date that this facility's land application areas were sited?
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
Applicants initials
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations; Z s ri FW7
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is ]and applied; Zrn -:
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations_
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.1 1 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3. i 3 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
FORM: AWO-G-E 5/28/98 Page 2 of 4 82 - 367

Facility Number: 82 - 367
Facility Name. D&Z Farms
4. APPLICANT'S CERTIFICATION:
ZACK 44C, [-'uc. G E A/ -rr _ (Land Owner's name listed in question i .2), attest that
this application for 2? f Z FARMS (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. 1 understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned to me as ' co plete.
Signature Date
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
(Manager's name Iisted in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5/28/98 Page 3 of 4 82 - 367

,o
A p
T ^ low
I r„ Mll•n `tl"
pill :ql + CF°p•I G p� Irp1-^. d@ n rot rm1 Iry \� t1
.:R l �R°4 ♦ ./:r°r
II $ M•M,w 1 r ' _ loll Ito. ItII
lot,
.i [[� � C
snl � I Inr Iwr r°I' w'LMIN61�
ti`6%
�
W
In° Cr«I.we� '. Izn IR Arr I.l. 6 I HI RD• '�' I•n ...._ r',m! P4ya Y % i/
-4 �`- • G QD' t 1 a ro11E i ye vn M.
A0,
1
' 4 � �E4. I,.•r rr/'� � �`\ vrr nXan
w / ,b� POPE Ablr,. \ �{ !'A W.RO
1 Imr r\ R
Ir,r� � �firr. � 41°� 'I,I I A 'rt1� •,� Y £e• I.0 " FVCNaSS / •. w•I•.«I 1 1, \. a II I•ro _ S
F°' Irl, �� /• i S i I wbha:.�4 v,r rr9. v.,
....,.. r• 1 yt� ' ,� � d Ey j �� .,r eeas„ vn L r y"*w � c6,1 �
,�* .n Ill.. i9' *° I.I.Q /Oy f" ,:.r, {
:..r ,•�� -,.,.+ trrl ` LI. •I. �° N rl' n.r,\
J fQ rll �D �ti\ J 'r r0
�4,ty r .,,P .,. ��`' $ .•i '«a,��' �„ a� � IIr. ,I., s. 'c; �� s ,.,. , Fy.\
•. `_ i� A •.e ' � fP ��:": r f � Cwl/ � �r p \\ v,l £ HIKF/t �� / , ! } ,.v ,\
:•w ' l I•I. 2°Y r�� ` rlld Kil
bubx* 18•lSS Tr \ - / r ,tl III Nf CRFFIC 4+ !\. �.• Q. 1 iorio,l MMN. IIM 'N
A'4
MI R! E _
Irn• vut'. _ 1 i �F.� rol a .Ir. nv °
LI4•.
`CLINTON + t�`� d' j\\ I,.r IPolo L� ` _ f ^ >• ,:
Ln L Po.p, `J. hhh I n
' CX. RD.1 ?q r roll ��3 la• Ino Q •u A.WII, Wlw/I,!'�p 11 RD
r:ly I .� I V BCVLAN '• C .r•pdr C,M+•tfY ' � `_ � I yl rr � « ^'�
lu,` •c I`y � _ �... _` � 1, `y g i \I�-.. 1 _ ::�.
itle
'ot
r ° ,P' le � �. � :q• / lu. uv �" d ,� 'LI ° 02La liux.♦ 1 ,dc, i �Ft
I Q nn ul
4 �r a• — ,. .I - B°rl'j �,1r1�� 1 , f: cRry/j I.l � RSa"� '
Ino M 'K.l 'y w Ilr, li. � /Lr!Ij �v DRID
a•r� ,I,I „9a n'e NE ,r,v ` .*a. j1
$ IIE
. ___ ' Y.. nl'rll hy,.- Zr 111/ �J 'I-r .� loll 666��• I„ .i0. 11JI � 1,111 R �df :.n
- `+5• t �' 11 n]' nw u,a I ° III„ r Iwr uu 4p GCE RO
c—I R. P9 t CrNI A4a]d:SFr I"BLACM F
Iw. y~vf,r Rb au \� .r y.(E a. Ea, fy• 11 ,ypeX' s ..\' RyN SCOWL
"°' qa 4� d' !!v Fp •n ui. � it � /.I I c
,ul
Il•rl 7°° p Irlr 011�,im ,IYR / '71l In14- I�. Ilv tlnl -- w�,e
06
Al d.
J) . I /qN J� RD. B7� PrN pill,r� I C Ro C.nt j1 Po. y C.

ANIMAL WASTE UTILIZATION PLAN
Producer: ZACK McCULLEN III
Location: - 1058 WYNN ROAD
CLINTON NC 28328
Telephone: [phone]
Type Operation: Existing Feeder to Finish Swine "
Number of Animals: 1860.00 hogs
(Design Cagacify)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon _
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrient's in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize 4he fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
.:2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall not be applied to land eroding at less
than 5 tons per acre per gear. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on sate--ated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DEM regulations.
Page: 1

ty
ANIMAL WASTE UTILIZATION PLAN
5. wind conditions should also be considered to avoid drift and
downwind odor problems.
6. -To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems. -
This plan is based on the waste application method shown above. If
you choose -to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
1860 hogs x 1.9 tons waste/hogs/year = 3534 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
1860 hogs x 2.3 lbs PAN/hogs/year = 4278 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan time
and have appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
- page: 2

ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
9852
Z
OrB
BC
5.4
270
0
14.0
3780
I
MAR-OCT
9852 " Z SG 1 150 0 114.0 1700
I SEP-MAIR
9852 2 jOrB FC 3.4 1170 0 11.3 1221
I SEP-MAY
END
I
TOTAL14701
- Indicates that this field is being overseeded (i.e. interplanted)
or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations may
require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This plan
only addresses nitrogen. -
Page: 3

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL10
Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. In fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You may want to consider harvesting hay or
,.silage two to three times during the season, depending on
'time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a
height of about two inches before drilling for best results.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
BC
HYBRID BERMUDAGRASS-CONTROLLED GRAZED
TONS •
50
FC
TALL FESCUE -CONTROLLED GRAZED
TONS
50
SG
SMALL GRAIN OVERSEEDED
AC
50
TABLE 1
TABLE 2
TOTAL,
TOTALS FROM TABLES 1 AND 2
ACRES
LBS AW N USED
15.3
4701
0
0
15.3
4701
* BALANCE
-423
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
T Page: 5

ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full 'application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than the
acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 688.2 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 3441
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 11.47 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 27.528 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25s depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
h•
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
page: 6

ANIMAL.WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
Tract
Field
Soil Type
Crop
Application Rate
(in/hr)
Applic. Amount
(inches)
9852
1
OrB
BC
0.50
*1.00
9852
2
OrB
FC
0.50
*1.00
9852
'1
SG
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and the
temporary stowage must be removed on the average of once every 6.00
months. In no instance should the volume of the waste be stored in
your stracture be within the 25 year 24 hour storm storage or one f oot
of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure -to apply
the recommended rates and amounts of nitrogen shown in the tables may
make. this elan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
Page: 7

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of 'waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or_
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
_and Climate in North Carolina" for guidance.)
7. `Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 8

WASTE UTILIZATION PLAN
REQUIRED_ SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy. .
11. Any new swine facility sited on or after October 1, 1995 shall
comply, with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm - shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly inton water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
15-._ Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementingg-a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site_
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 5o days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sates shall be used when thes
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina requlations.
Page: 10

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:D & Z FARMS
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to -be submitted to the
North Carolina Division of Environmental Management (NCDEM) before
the new animals are stocked. I (we) also understand that there
must be no discharge of animal waste from this system to surface
wasters of the state from a storm event less severe than the 25-
year, 24-hour storm_ The approved plan will be filed on -site at
the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDEM
upon request.
Name of Facility Owner: ZACK McCULLEN III
(Please print)
Signature:&A/v . Date:
Name of Man different from owner):
Signature:
Date:
Name of Person Preparing Plan: (Please print)Wilson Spencer -
Affiliation:NRCS
Add2iess (Agency):
Phone No.
84 County Complex Rd.
Clinton NC 28328
Signature:4 Date:
Page: 13

,r_C/ wttY l .{.�" • F 1S'..;��_nab�Y�_ _ ;t �'r ti.�r �`f• _ +
f•` 1 :t�'- � '.i _� f r "rR'� � . V - L� • 1 'i � � ' �_y
a-
j
��'G\ 3 ] 1 �-5 �F�••� 4 f'Sr� •`5� - ^•t, t•,I . �_ � t 1 •; J•y max. g �, rk; �`-},.
ram., .��• � a" •' : �3 � `3�rrT��� ;��+tt �`+.� `�•7 C's � �' �' � t� � •� �'1. �;S- ,��::
.yV �flfr�ir -� :� �r � �: T r. a. •3..r'% •t. //�yy��/r�-�/� �, y�1 aT t';. F � �:1 . •,_i„
��rcr _- FI+ C 'r 1.-. r �• '�--z� '.--.,"' ::.;f: ��-4.9'u :'-'� ,. �ti
AMI
LWA
NOW
Al
�'Yy.. e 5 _ y °4 .,,;�,-.-1-1� r •s,� - � ;I %.■ Lam, •�tr;. �"� � _ .s.-�iuti �i-
C
'11 F� Fr�r rF�. 1r y,ti. t4 :i? ait[
J- - - _ •Y 4 ] Vim' - r - i!-
k 1
t. -: 1. -•'t'+�: '.� - - _'' >r -CI'+rife _��--'• � 7 j,.` y� _ ���~�Lk - r fp ,
.� .' � r _ _.'�J <;4 -� T a,f ;7n. -.•i * ��� L"--rt f+ � �;i`:
��'y41 {.+
_+ f t � .�- % �„ r fs•.� `� t i S �'
��:. t e � f n � � _} .'.f� 3r { •4 4 �� _� �t : � � �.�o _ ,. � { xf_ i � �w � - *1 rJ _ i�h �� �`.
`fir - � -� • � '` t , - \ _ � YE C - - -
•.xr f+. -k n'r�,r fl ,� _t y4 •'' 1 ar ',:.Cf +Y _r+ '}rt wk
r x i ° 7 •tr-r .-b,•�* z� s Z y< S x � � _ r'. � + � �,y �t'. + rY4.f,. � ' {
-IM
'� 1e...f E•v 4v rr �S _ w1 t-- _ - f' ,� , 'R s
r� 1 4.Lr � � _.^� � + _ zt•: R.. 5, .' , nt h .,.. �:� 'f l� M �r
rre`_ 'fl ;'?�•;T�
� rwoF
1
/., f, _ i f 4.- a -! Y :..� - `•! { `l_+l•V►R dw , J'
+ � 3 � f t.s 1 JT �.I� .�"'� � '•'�'�;e.'��.:::,- : �- .ti r'•r i � r ' � 1 ���_ i =:•';i

t1J7f tit T �ia:5.'n'-f- Fi"•' 's:.:-'k�.... r �_,:., _ __' . ;L ., r.. , av, 7,1.-. :4[i'- i'� "�:�[!:..:..'Y, •..-'[.•l. r _ :J.. .i ^ .. •1.I�.r; �'t ,-z:3,C.^L: •.:�
_
r
r r ,
' r .
r
i
r ,
r _
6.7
IVLAs -
!. a
• 'a
SCALE 1" - i 00'
4 s..3
ZACW- McCV[.t- r-r
A. uJ- L.A000 r-
SFlMPSDN Co•

is �4
O O
O •o
-N10
l7 �
.1
1
!7
l
P S
P
Q
u1 N
o p
a
6
t
o o
o
o
u Q
o o
O
O
�a
r
uo
r I It
U U
0 D
R
O
rm
0
Q
�
x
DK
o
zz
•
N
N
�
I
�
t
I
to
I IF
1
_ a
0
4 sa - ,n Zs
meh
M a
00
u u
p
Q
o
O
u
o
G
hh
1
.
11
1
�II{w
tJ
O�p
�d
� b
'
n�
W
{rn
plw
a
o 0
G
m
G

SAMPSON COUNTY
EMERGENCY ACTION PLAN
DWQ 910-486-1541
EMS 910-592-8996
SWCD 910-592-7963
MRCS 910-592-7963
This plan will be implemented in the event that wastes from your
operation are leaking, overflowing, or running off-. the site_ You should
NOT wait until wastes reach surface waters or leave your property to
consider that you have a problem. You should make every effort to
ensure that,,.this does not happen. This plan should be posted in an
accessible location for all employees at the facility. The following
are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may
or may not be possible. Suggested responses to problems are
listed below:
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam, any
permanent alteration of the dam should be approved by a
qualified technical specialist.
b. Pump wastes to field at an acceptable rate.
c. Stop all additional flow to the lagoon -hold waste in the
house if possible.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field --action include:
a. Immediately stop waste application.
b. Create a temporary diversion or berm to contain the
waste.
c. Incorporate waste to reduce further runoff.
d. Evaluate and eliminate the reason(a) that caused the
runoff.
e. Evaluate the application rates for the fields where
runoff occurred.
4•
`C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
e. Repair all leaks prior to restarting pumps.
D_ Leakage from flush system, houses, solids separators -actions
include:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Make sure no siphon effect has been created.
d. Stop all flows in the house, flush systems, or solid
separators.
e. Repair all leaks prior to -restarting pumps.

5. Contact the contractor of your choice to begin repair of the
problem to minimize off -site damage.
a. Contractors Name: WELLS L'oNs-I• CO.
b. Contractors Address:
c. Contractors Phone: 91e- 592-_-5705
6. Contact the technical specialist who certified the lagoon (NRCS,
Consulting Engineer, etc.)
a-. Name:
b. - Phone: 910 - S92.- 4-77` exT, z49
7. Implement procedures as advised by DWQ and technical assistance
agencies to rectify the damage, repair the system, and reassess
the waste management plan to keep problems with release of wastes
from happening again.
B. If you are a contract swine grower associated with a swine
company integrator, contact the company representative at
1-910-592--5771

Insect Control Checklist for Animal Operations
Source Cause
ILMPs to Control Insects Site Specific Practices
Lignld Systems
Flush Gutters • Accumulation of solids
ta' Flush system is designed and operated
sufticienlly to remove accumulated solids from
gutters as designed.
U'Remove bridging of accumulated solids at
discharge
Lagoons and Pits • Cntsled Solids
Mainlain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 inches over more than 30% of surface.
Excessive Vegetative • Decaying vegetation
11 Mainlain vegetative control along banks of
Growth
lagoons and other impoundments to prevent
accumulation of decaying vegetative mailer
along watees edge on impoundment's perimeter.
Dry Systems
Feeders • Teed Spillage O—Design, operate and maintain feed systems (e.g.,
bankers and troughs) to minimize the
accumulation of decaying wastage.
0---Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
during winter).
Feed Storage • Accumulations of feed residues El Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
andlor providing adequate containment (e.g.,
covered bin for brewer's grain and similar high
moisture grain products).
O Inspect for and remove or break up accumulated
solids in filter strips around feed storage as
needed.
AMIC - November 11, 1996, Page I

Swine Farm Waste Management Odor Control Checklist
Source Cause UM]'s to Minimize Odor Site Specific Practices
Farltt>ticad • S► Ino production O- Vegetative or wooded buffers;
0" Recommended best management practices;
0' Good judgment and common sense
Animal body surfaces • Dirty manure -covered animals Cp-Dry floors
Floor surfaces • Wet manure -covered floors ID" Slotted floors;
E11' Waterers located over slotted floors;
❑ Feeders at high end of solid floors;
Er"Scrape manure buildup from floors;
D"'Underfloor ventilation for drying
Manure collection pits • Urine; ❑' Frequent manure removal by flush, pit recharge,
Partial microbial decomposition or scrape;
CI Underfloor ventilation
Ventilation exhaust fans Volatile gases; ©' Fan maintenance;
Dust EI/ Efficient uir movement
Indoor surfaces • Dust I7 Washdown between groups of animals;
❑ Feed additives;
D�Feeder covers;
0' Feed delivery downspout extenders to feeder
covers
Flush tanks Agitation of recycled lagoon ❑ Flush tank covers;
liquid while tanks are filling ❑ Extend fill lines to near bottom of tanks with
alleys • Agitation during wasicivaler
anli-siphon vents
Underfloor flush with underfloor ventilation
conveyance
Pit recharge points + Agitation of recycled lagoon Extend recharge lines to near bottom of pits '
liquid while pits are filling with anti -siphon vents
Lill stations • Agitation during sump tank 0 Sump lank covers
filling and drawdown
Outside drain collection + Agitation during wastewater 0 Box covers
orjunction boxes conveyance
AMOC - November 11, 1996, Page 3

Source Cause DMZ's to Minimize Oddr Site Specific Practices
End of drainpipes at • Agitation during wastewater 0 Gxlcnd discharge point of pipes underneath
lagoon conveyance lagoon liquid level
Lagoon surfaces • Volatile gas emissions; 0' Proper lagoon liquid capacity;
• Blologlcal mixing,, CI' Correct lagoon startup procedures;
• Agitation Q"" Minimum surface area -to -volume ratio;
O' Minimum agitation when,pumplog;
❑ Mechanical aeration;
❑ Provers biological additives
Irrigation sprinkler • Iligh pressure agitation; 111' Irrigate on dry days wills little or no wind;
nozzles . Wind drill 0" Miirimum recommended operating pressure;.
Storage tank or basin
surface
tK Pump Intake near lagoon liquid surface;
❑ Pump from second -stage lagoon
• Partial microbial decomposition; 0 Bottom or midlevel loading;
• Mixing while filling; ❑ Tank covers;
• Agitation when emptying ❑ Basin surface orals of solids;
0
Proven biological additives or oxidants
Settluig basin surface
• Partial microbial decomposition;
0
Extend drainpipe outlets underneath liquid
• Mixing while tilling;
level;
• Agitation when emptying
❑
Remove settled solids regularly
Manure, slurry or sludge
• Agitation when spreading;
❑
Soil injection of slung/sludges;
spreader outlets
0 Volatile gas emissions
❑
Wash residual manure from spreader after use;
0
Proven biological additives or oxidants
Uncovered manure,
• Volatile gas emissions while
0
Soil injection of slurry/sludges
slurry or sludge on field
drying
❑
Soil incorporation within 48 lrrs.;
surfaces
Cl
,
Spread in thin uniform layers for rapid drying;
0
Proven biological additives or oxidants
Dead animals
• Carcass decomposition
tl'
Proper disposition of carcasses
Dead animal disposal
6 Carcass dcco.mposition
0
Complete covering of carcasses in burial pits;
pits
p'
Proper local ion/conslruction of disposal pits
Incinerators
• Incomplete combustion
❑
Secondary stack burners
AMOC - November 11, 1996, Page 4

•y
Source Cause 11MI's to Minimize Odor Site Specific Practices
Standing water around • Improp erdrainage; 9— Grade and tandscnpe such tint water drains
facilities . Microbial decomposition of away from facilities
organic matter
Manure tracked onto • Poorly maintained access roads 9117arm access road maintenance
public roads Isom farm
access
Additional Information: Available From:
Swine Manure Management; 0200 Rule/DMP Packet NCSU, County Extension Center
Swine Production Farm Potential Odor Sources and Remedies ; EDAE Fact Sheet NCSU -DAE
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment ; EHAE 128-88 NCSU - DAE
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Trcatment ; EDAE 129-88 NCSU - DAE
Lagoon Design and Management for Livestock Manure Treatment and Storage ; EDAE 103-83 NCSU - DAE
Calibration of Manure and Wastewater Application Equipment ; EDAE Fact Sheet NCSU - DAE
Controlling Odors from Swine Buildings; Pill-33 NCSU - Swine Extension
Environmental Assurance Program ; NPPC Manual NC Pork Producers Assoc
Options for Managing Odor; a report from the Swine Odor Task Force NCSU Agri Communications
Nuisance Concerns 1n Animal Manure Management: Odors and Flies ; JIRO107, 1995 Conrcrence Proceedings " Florida Cooperative Extension
AMOC - November 11, 1996, Page 3

Mortality Management Methods
(check which method(s) are being implemented)
❑ _ Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must, be at least 300 feet from any flowing
stream or public body of water.
Rendering at a rendering plant licensed under G.S. 106-168.7
❑ Complete incineration
❑ It'the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agriculture
❑ Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
9
December 18, 1996

NAME: Zack M`CuIlen III
ADDRESS:
TYPE AND SIZE 1240 Tops
OF OPERATION
CLASS II
DESIGNED BY Glenn Clifton
DATE 2-15-88
APPROVED BY Howard Hobson
GATE
PERMAMENT STORAGE
1240 Hogs,x 13S Ibs per hog 1 Cu Ft per lb.
TEMPORARY STORAGE.
167400 Ibs of animal x 1.55 cu. ft. of waste per day
per 1000 lbs of animal wt. x .180 days
RAINFALL LESS EVAPORATION
7" X 3667.4 344 sq. ft. surface area per 12"per ft
RAINFALL 2
167400 Cu Ft
40678 Cu Ft
ZZ 53 I
e4 Cu Ft
5 YR. 1 DAY STORM ZzS51
7" X 39GZ4 L44 s ft. of surface area q• per 12" per ft. J24 Cu Ft
=531f0
TOTAL STORAGE NEEDED 2GG-Yo7-Cu Ft.
Y-7-1-0
Cu
Yds
437r-
TOTAL STORAGE AVAILABLE
Z4-7,9B29
Cu
Ft
99.7-5 4
cu
Yds
AMOUNT OF FILL DIKE
0
Cu
Ft
PAD
E*R4aR_
Cu
Ft
TOTAL
—m�
Cu
Ft
SETTLEMENT 10%
E-R�
Cu
Ft
TOTAL AMOUNT OF FILL
�
Cu
Ft
Cu
Yds
CUT TO F.-ILL RATIO
TOTAL EXCAVATION
D*t`t�R
Cu
Ft
Tp�
Cu
Yds
MANURE AND.URINE PRODUCTION
1240,bogs x 2.1 toes
per year
2604
T./yr.

NAME:
Zlac4< McCu 1
i en
DEPTH
[AREA OF TOP
+ AREA
OF
BOTTOM + 4 X AREA OF MIDSECTION]
VOLUME_
---------
----------------------------------
-----------------
6.0
27
DEPTH
C L X
W }
L
X W+ 4 X L X W I
VOLUME=----------
---------------------------------------
6
27
i t
2 fob
13 ea
Z 3 3 10 3-
1-6:t
C W X
L' X
200
X 70 + 4 X 2-W X -1-an
VOLUME_
---------
--------------
6.0
27
tl
I%j(,1'7L
j
C 1�&O$0'tfJ
VOLUME _
---------
--------
6.0
27
z�� 98z
2,3a00070
CU-. FT.
.VOLUME _
----------
27.0
C} 9 Z5
VOLUME _
Z&2S:S
CU.YDS.
35624.0 sq.ft.
25314a .c
22-0650 -.- cu. ft. needed
SIDE SLOPES 3:1

NAME: .Zack: McCullen III
ADDRESS: Rt. 5
Clinton, NC 28328
INTRODUCTION:
-------------
Mr. McCullen plans to expand his present 1240 finishing operation to 1860,
which includes the construction of one house and adding to the capacity of
the existing lagoon.
SITE CONDITIONS:
----------------
The site is located on Orangeburg (360) loamy sand 2 to 6% slope
TYPE AND SIZE Finishing
OF OPERATION 620
CLASS I
DESIGNED BY Glenn Clifton
DATE 6/89
APPROVED BYaS��•
DATE B I-7[ si
PERMANENT STORAGE
620 Hogs x 135 lbs per hog 1 Cu Ft per lb. 83700 Cu Ft
TEMPORARY STORAGE
83700 lbs of animal x 1.35 cu. ft. of waste per day 20339 Cu Ft
per 1000 lbs of animal wt. x 180 days
RAINFALL LESS EVAPORATION
7" X 22294 sq. ft. surface area per 12"per ft 13005 Cu Ft
RAINFALL — 25 YR. 1 DAY STORM
7" X 22294 sq. ft. of surface area per 12" per ft. 13005 Cu Ft
TOTAL STORAGE NEEDED 117044 Cu Ft
4385 Cu Yds
TOTAL STORAGE AVAILABLE 118000 Cu Ft
4370 Cu Yds
MANURE AND URINE PRODUCTION
620 hogs x 2.1 tons per year 1302 T./yr.

NAME:. , Zack McCu f i erg III
DEPTH CAREA OF TOP + AREA OF BOTTTOM + 4 X AREA OF MIDSECTION]
VOLUME=------------------------------------------------
6.0 27
DEPTH C L X W + L X W+ 4 X L X W
VOLUME= ----- ----- ---------------------
6 27
10.0 C 130 X 145 C 70 X 85 + 4 X 100 X 1153
VOLUME_---------------------------------
6 27
10.0 C 708003
VOLUME =------------------
6 27
118000 CU. FT.
VOLUME =----------
27
VOLUME = 4370 CU.YDS.
22294 s4.ft.
117044 cu. ft. needed r
SIDE SLOPES 3:1
INSIDE TOP MEASUREMENTS fog FT. X 2� I FT.
FLUID (AVEL-
�4;L
T- t 1STu.3

a 04 a
OPERATION AND MAINTENANCE
This lagoon is designed for waste treatment with minimum odor
control. The time required for the planned fluid level to be
reached may vary due to the soil conditions and flushing oper—
ation.
Land application of waste water is recognized as an acceptable
method of disposal. Irrigation by using solid set, center
pivot, gun, or traveler is the preferred and most efficient
method to dispose of the effluent from the lagoon. Care
should be taken when applying waste to prevent damage to the
crops and to prevent runoff from the fields.
The following items are to be carried out:
1. Begin pump —out of the lagoon when fluid level reaches
invert of the outlet pipes or at a pre —determined
elevation.
2. Stop pump —out before the lagoon depth is less than 6 feet
deep or at a pre —determined depth. (This prevents the
loss of favorable bacteria.)
3. The recommended amount to apply per irrigation is one
inch, and maximum recommended application rate is 0.5
inch per hour.
4. It is recommended that the treatment lagoon be precharged
to 1/2 of it's capacity to prevent excessive odors during
beginning stages of the operation. Precharging reduces
the concentration of the initial waste entering the lagoon
thereby reducing odors. Solids should be covered with
water at all times.
5. Keep vegetation on the embankment and areas around the
lagoon and building mowed.
6. Repair any eroded areas and establish in vegetation.
7. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The
Department of Natural Resources and Community Development
(DNRCD), Wastewater Management Section, has the respon—
sibi l ity for enforcing this law.
$. All surface water is to be diverted from the lagoon to an
adequate and stable outlet.
NOTE: An analysis of the waste water can be obtained at
commercial laboratories or at a fee of $3 per sample at:
NC Department of Agriculture Plant Analysis Lab
Agronomic Division
Blue Ridge Road Center
Raleigh, NC 27611
Phone [phone]

Tr. 9ds� c=o3aoa�ieoata
A2 =IAL WASTE MANAGE IMN'^ PLAN CER'^T_?::CATTox FOR =2STI:7G FEZDLOTS
Please return the completed form to the Division of Environmental Management At
the address on the reverse aide of this for=.
Flame of farm (Please print) _ Dr-Z. Farms - _ —
Mailing Address: IDS% Won QeQd C•"kfi,% rPJ ?-93La
Phone No.:
County (of farm) --plan,_
arts location: Latitude and Longitude:3ie _a If;' /1 .� Je (required)
please attach a copy of a county road map with location identified.
!Ype of operation (swine, layer, dairy, etc.) Sic+rns
Design capacity (number of animals) :_ jU6_
Average -size of operation (12 month population avg.): 1240 _
Average acreage needed for land application of waste (acres):
�aaaaasgnssaagaasaaaaasaaasaaaaaaaaaaasaaaasaaaaaaaaaaaZaaaaaaaasaaaaaaaa=aaaa=
Technical Specialist Certification
As a technical specialist designated by the North Carolina Soil and Water
Conservation Commission pursuant to 15A NCAC SF '.0005, 1 certify that the
existing animal waste management system for the farm named above has an animal
.
�n5te ri+aiiage:i-e �. Niai♦ that ...cet.�.. the v- .. �.and...-i..- _••?,•�� Zt.a�.^_=3-=s `r..a
p_�_�
specifications of the Division of Environmental Management and the USDA -Soil
Conservation Service and/or the North Carolina Soil and Water Conservation
Commission pursuant to 15A NCAC 2H.0217 and SSA NCAC 5F .0001-.0005. The
following elements and their corresponding minimum criteria have been verified
v me or other designated technical spec:alists and are included in the plan as
applicable: minimu_n separations (buffers), adequate quantity and amour_ of land
for waste utilization (or use of third party), access or ownership of proper
waste application equipment; schedule for timing of applications; application
rates; loading rates; and the control of the discharge of pollutants from
stogywater runoff events less severe than the 25-year, 24-hour storm.
Name of Technical Specialist; -(Please Print). `4 CO —
Affiliation (Agency)
Add-, ess Phone No ?Zd ` Sq 2- %9C,.T
Signature: Date:
aaaaaaaasaa aa=s sasaaa I;A_
Owner/2Sanagerl (we) understand the operatiomaintenance procedures established i the
approved animal waste management plan for the fa_-m named above and will impleient
these procedures. 1 (we) know that any expansion to the existing design capacity
of the waste treatment and storage system or construction of new facilities will
require a new certification to be submitted to the Division of Environmental
Management before the new animals are stocked. I (we) also understand that there
must be no discharge of animal waste from this system to surface waters of the
state a=the= directly through a man-made conveyance or cnroug:^. ruiaoia _roan a
storm, event less severe than the 25-year, 24-hour storm. The approved plan will
be filed at the farm and at the office of the local Soil and Water Conservation
District.
tiame of Lamed Owaar (Plea Aeint) L — rn ��'�'✓
Signat re: a Date: 006
:lame of Manager, if different from owner (Please print):
Date
NQta: A cha^.ge in land ownership re4uire7 notification or a new certif_te_ic..
(i_ the approved plan is changed) within L.) days of a title transfer.
DZ'-' USE ONLY: ACEit fl
v- 3b�

P
F
Prestage Farms, Inc.
June 26, 1998
Mr. Art Barnhardt
Acting Water Quality Supervisor
North Carolina Department of Environment & Natural Resources
Division of Water Quality, Fayetteville Regional Office
225 Green Street, Suite 714
Fayetteville, North Carolina 28301-5094
Dear W. Barnhardt:
R
lV •�
PAUL-
�ej A
RECEIVED
�? 1 1998
The purpose of this letter is to request your cooperation in providing copies to Prestage
Farms of any inspection reports, notices of deficiency, and/or notices of violation that may
be issued by your office to any swine producer who contracts with Prestage Farms.
Please forward these copies to my attention as follows:
Zack McCullen, III
Prestage Farms, Inc.
P.O. Box 438
Clinton, North Carolina 28329
Thank you for your cooperation and please feel free to contact me at 910.592.5771 if you
wish to further discuss this request.
Sincerely,
1-6a4
ack McCullen, III
Vice President, Swine Division
dj/ZMRO
HIGHWAY 421 SOUTH • P. O. BOX 438 • CLINTON, N. C. 28329-0438 • PHONE [phone]