820341_CORRESPONDENCE_20171231

NUH I H UAHULINA
Department of Environmental Qual

Revels, Rick
From: Greg Carr [[e-mail]
Sent: Saturday, February 06, 2010 10:38 PM
To: Revels, Ricky
Cc: David Nordin; Kraig Westerbeek
Subject: Freeboard
Mr, Revels,
I am sending this email to serve as notification to you and the division that following the rainfall received on 2-5-10 the
following facilities are operating out of compliance.
20463 Facility # 82464 16 inches r,,4cfd e 4 .� fi o � .z O 10 O 0 '7 4
37131 Facility #82-341
18.5 inches
't N ci d t,o-P
J-� O Zv I n 0 0 ­7 5 0
C&MI Facility # 82-038
18 inches
�'_ " }'
�'�' 0 O 0 5
A 30 day POA will be submitted to the division. If you have any questions please feel free to email me or call meat 910-
990-6829,
Greg Carr
Murphy -Brown LLC
1

I *' 3 vlp/
Murphy -Brown, LLC 4/9/2009 822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s): Murphy -Brown, LLC
Farm Name: 3113
County: Sampson_
Farm Capacity:
Farrow to Wean 2411 RECEIVED / DM 1 M
Farrow to Feeder fti fer ProMdIon Secdon
Farrow to Finish
Wean to Feeder APR 1$ 2009
Feeder to Finish
Storage Structure: Anaerobic Lagoon
Storage Period: >180 days
Application Method: Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water andlor groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 11 1 AM' 20 2009
ON-FAYEnEYIiLEKON 0fflCE

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission,
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
Capacity Type Waste Produced per Animal Total
2411
Farrow to Wean
3212 gallyr
7,744,132 gallyr
Farrow to Feeder
4015 gallyr
gallyr
Farrow to Finish
10585 gallyr
gallyr
Wean to Feeder
223 gallyr
gallyr
Feeder to Finish
986 gallyr
gall r
Total 7,744,132 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced per Animal Total
2411
Farrow to Wean
5.4 Ibslyr
13,019 Ibslyr
Farrow to Feeder
6.5 Ibslyr
Ibslyr
Farrow to Finish
26 Ibslyr
Ibslyr
Wean to Feeder
0.48 Ibslyr
Ibslyr
Feeder to Finish
2.3 Ibslyr
Ibslyr
Total 13,019 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 70.52
Total N Required 1st Year: 18120.36
Total N Required 2nd Year: 18549.83
Average Annual Nitrogen Requirement of Crops: 18,335.10
Total Nitrogen Produced by Farm: 13,019.40
Nitrogen Balance for Crops: (5,315.70)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of11

Reception Area Specifications
Tract Field Irrigated —Soll 1 st Crop Timeto IstCrop, lstCrop�NlAc _LbsN__ Total lbs N
C—OdIc Apply Yield lbs NfUnit Residual fAc Utilized
�IMPMPMIMIMMMX_Mr,
�■�■�■io��o�■■�mc�©��©gym®gym
�
m ff MI PM
Totals: 70.52 ,:
3(a) of 11

'Reception Area Specifications Com .,
3(b) of 11
3(b) of 11

OptionalReception Area Specifications
'Tract Field "gated Sail I st Crop Time to Ist Crop Ist Crop Lbs NfAc Lbs N Total.lbs N
Acreage Type Code Apply Yield lbs NIUnit Residual /Ac A
AW.-MIM frr.71 q VMJI

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal lima to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 Ibs N / bushel
B
Hybrid Bermudagrass - Grazed
50 Ibs N I ton
C
Hybrid Bermudagrass - Hay
50 Ibs N 1 ton
D
Corn - Grain
1.25 Ibs N / bushel
E
Corn - Silage
12 Ibs N / ton
F
Cotton
0.12 Ibs N / Ibs lint
G
Fescue - Grazed
50 Ibs N / ton
H
Fescue- Hay
50 Ibs N / ton
I
Oats
1.3 Ibs N / bushel
J
Rye
2.4 Ibs N / bushel
K
Small Grain - Grazed
50 Ibs N / acre
L
Small Grain - Hay
50 Ibs N 1 acre
M
Grain Sorghum
2.5 Ibs N / cwt
N
Wheat
2.4 Ibs N / bushel
0
Soybean
4.0 Ibs N / bushel
P
Pine Trees
40 Ibs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of11

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications
PAN! rlanimal Farm Total/ r
2411 Farrow to Wean
0.84 2025.24
Farrow to Feeder
1
Farrow to Finish
4.1
Wean to Feeder
0,072
Feeder to Finish
0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 2025.24 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 10126.2 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 33 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 81.0096 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
"This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 11

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract Hydrant
Type
Crop
inlhr
* inches
9295 1
Noodingtor
0
0.4
1
2
Noodingtor
0
0.4
1
3
Noodingtor
0
0.4
1
4A
Autryville
0
0.6
1
4B
Noodingtor
0
0.4
1
5A
Lynchburg
0
0.65
1
5B
Woodingtor
0
0.4
1
6A
Noodingtor
0
0.4
1
6B
Woodingtor
0
0.4
1
6C
Lynchburg
0
0.65
1
7A
Norfolk
0
0.5
1
7B
Woodingtor
0
0.4
1
8A
Norfolk
0
0.5
1
8B
V1loodingtor
0
0.4
1
Sub 1
Noodingtor
0
0A
1
6 of 11

Additional Comments:
7of11

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 3113
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
Uwe understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature:
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist: Dawn Williamson
Affiliation: Murphy -Brown, LLC.
Signature:
Address: 2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
Date
Date
Data
8 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year, Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9of11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Wastelnutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal, Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying, Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
10 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption, However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
11 of 11

Waste Management Plan Changes
Facility Z f Farm
RREII/FD
DEC 0 5 4'J05
LOi-FAYEMlA11fflEGI(WgpfflM I
--S1 [3
This farms Waste Management Plan has made the following changes:
❑ Crop changes
❑ Wetted Acres
OrIT'ncreased Acreage
❑ Decreased Acreage
❑ Changed Irrigation Design
❑ Change in Farm type
❑ Plan based on 3 Years On Farm Records
❑ Other
Comments:
Date

A
Murphy -Brown, LLC
Grower(s):
Farm Name:
1212/2005
NUTRIENT UTILIZATION PLAN
Murphy -Brown, LLC
3113
County: -Sampson
Farm Capacity:
Farrow to Wean 2411
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 11

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, W, tons, etc.):
Capacity Type Waste Produced per Animal Total
2411
Farrow to Wean
3212 gal/yr
7,744,132 gallyr
Farrow to Feeder
4015 gallyr
gallyr
Farrow to Finish
10585 gallyr
gallyr
Wean to Feeder
223 gallyr
gallyr
Feeder to Finish
986 gallyr
gallyr
Total 7,744,132 gal/ r
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced per Animal Total
2411
Farrow to Wean
5.4 Ibslyr
13,019 Ibslyr
Farrow to Feeder
6.5 Ibslyr
Ibslyr
Farrow to Finish
26 Ibslyr
lbslyr
Wean to Feeder
0.48 Ibslyr
Ibslyr
Feeder to Finish
2.3 Ibslyr
Ibslyr
Total 13,019 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 70.52
Total N Required list Year: 18120.36
Total N Required 2nd Year: 18549.83
Average Annual Nitrogen Requirement of Crops: 18,335.10
Total Nitrogen Produced by Farm: 13,019.40
Nitrogen Balance for Crops: (5,315.70)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 11

Reception Area Specifications
3(a) of I I
3(a) of I I

'Reception Option:
Tract Field Irrigated Soi I 1st Crop Timeto IstCrop IstCrop LbsN/Ac Lbs N Total ths N;1
Acreage Type Code Apply Yield lbs N[Unit Residual /Ac Utilized
2n rop- fi�me to 2nd—Crop2nd—Crop Ubs-W/A—c Lbs _NT—otal tb—sN!��
Code �pply Yield lbs NfUnit Residual /Ac
1�3_ill:D
11�_
3(b) of 11

OptionalReception Area Specifications
Acreage Type Code Apply Yield lbs NA)nit Residual JAc Utilized
OEM
Totals. 70.52 ,. —

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses ail nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches, Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especia#iy late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October.. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop
Lbs N utilized 1 unit yield
A Barley
1.6 lbs N 1 bushel
B Hybrid Bermudagrass - Grazed
50 lbs N / ton
C Hybrid Bermudagrass - Hay
50 lbs N 1 ton
D Corn - Grain
1.25 Ibs N 1 bushel
E Corn - Silage
12 lbs N 1 ton
F Cotton
0.12 lbs N 1 lbs lint
G Fescue - Grazed
50 lbs N 1 ton
H Fescue- Hay
50 lbs N 1 ton
I Oats
1.3 lbs N / bushel
J Rye
2.4 lbs N 1 bushel
K Small Grain - Grazed
50 lbs N 1 acre
L Small Grain - Hay
50 lbs N / acre
M Grain Sorghum
2.5 lbs N 1 cwt
N Wheat
2.4 lbs N 1 bushel
O Soybean
4.0 lbs N ! bushel
P Pine Trees
40 lbs N 1 acre 1 yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 11

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN/ rlanimal Farm Totall r
2411 Farrow to Wean 0.84 2025.24
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 2025.24 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 10126.2 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 33 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 81.0096 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table, Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. to many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 11

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts,
Soil
Application Rate
Application Amount
Tract Hydrant
Type
Crop
inlhr
* inches
9295 1
VVoodingtor
0
0.4
1
2
Noodingtor
0
0.4
1
3
Woodingtor
0
0.4
1
4A
Autryville
0
0.6
1
4B
vVoodingtor
0
0.4
1
5A
Lynchburg
0
0.65
1
5B
Woodingtor
O
0.4
1
6A
Woodingtor
O
0.4
1
6B
VVoodingtor
0
0.4
1
6C
Lynchburg
0
0.65
1
7A
Norfolk
O
0.5
1
7B
VVoodingtor
0
0.4
1
8A
Norfolk
0
0.5
1
8B
Noodingtor
0
0.4
1
Sub 1
VVoodingtor
0
0.4
1
6 of 11

Additional Comments:
7 of 11

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 3113
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWG before the new
animals are stocked.
/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
!Name of Facility Owner: Murphy -Brown, LLC
Signature:
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist: Dawn Williamson
Affiliation: Murphy -Brown, LLC.
Address: 2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
Signature:
Date
Z-Z-05-
Date
- z,6
Date
8 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
aitowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9of11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc,, shall
not be discharged into the animal waste management system.
10 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 head animals will be disposed of in a manner that meets North Carolina regulations.
11 of 11

Waste Management Plan Changes
Facility SZ -,3 4 1 Farm
F-77 1:
NOV 3 0 2005
.3t i 3
This farms Waste Management Plan has made the following changes:
❑ Crop changes
❑ Wetted Acres
❑ Increased Acreage
❑ Decreased Acreage
❑ Changed Irrigation Design
❑ Change in Farm type
❑ Plan based on 3 Years On Farm Records
21 Other
Comments:
1/-Za-D-5,--
Date

,_0
Murphy -Brown, LLC
Grower(s):
Farm Name:
1112W005
NUTRIENT UTILIZATION PLAN
Murphy -Brown, LLC
3113
County: Sampson
Farm Ca acit :
Farrow to Wean 2411
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 11

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
Capacity Type Waste Produced per Animal Total
2411
Farrow to Wean
3212 gallyr
7,744,132 gallyr
Farrow to Feeder
4015 gallyr
gal/yr
Farrow to Finish
10585 gallyr
gallyr
Wean to Feeder
223 galyr
gallyr
Feeder to Finish
986 gall r
gall r
Total 7,744,132 gall r
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Capacity Type Nitrogen Produced per Animal Total
2411
Farrow to Wean
5.4 Ibslyr
13,019 ibs/yr
Farrow to Feeder
6.5 Ibslyr
lbs/yr
Farrow to Finish
26 Ibslyr
Ibslyr
Wean to Feeder
0.48 Ibslyr
Ibslyr
Feeder to Finish
2.3 Ibslyr
Ibslyr
Total 13,019 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 70.52
Total N Required 1st Year: 18120.36
Total N Required 2nd Year: 18549.83
Average Annual Nitrogen Requirement of Crops: 18,335,10
Total Nitrogen Produced by Farm: 13,019.40
Nitrogen Balance for Crops: (5,315.70)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility, This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of11

Reception Area Specifications
Tract Field Irrigated soij ist Crop Time to 1stCrap 1stcropLbsN/Ac Lbs N Total lbs Pf
Acreage ..._:T * de Apply Yield lbsNfUnit Residual /Ar Utilized
2nd Crop Time to 2rid Crop 2nd Crop Lbs WAc Lbs N TotaF&s
Code Apply Yield lbsNfUnit Residual /Ac Utilized
��
3{a) of 11

ReceptionOption:
Tract Field Irrigated soill Ist Crop Time to 1stCrop 1stCrop LbsN/Ac Lbs N Total lb
Acreage Type Code Apply Yiel-d. Abs WUnit Residual /Ac - Utilized
2nd Crcjj—TijjW-lE& 2nd Crop 2nd Crop Lbs N/Ac Lbs N Taw —Ibqi�
Code Apply Yield lbs NfUnit Residual lAc
■�����o�■�
®��®gym©�������■�®�
3cb> of 11

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In inlerplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definateiy interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Corn - Grain
E Corn - Silage
F Cotton
G Fescue- Grazed
H Fescue- Hay
I Oats
J Rye
K Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
P Pine Trees
Lbs N utilized 1 unit yield
1.6 lbs N 1 bushel
50 lbs N 1 ton
50 lbs N 1 ton
1.25 lbs N 1 bushel
12 lbs N 1 ton
0.12 lbs N 1 lbs lint
50 lbs N / ton
50 lbs N / ton
1.3 lbs N I bushel
2.4 lbs N 1 bushel
50 lbs N I acre
50 lbs N / acre
2.5 lbs N 1 cwt
2.4 lbs N 1 bushel
4.0 lbs N 1 bushel
40 lbs N 1 acre 1 yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of11

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications
PAN! rlanimal Farm Total! r
2411 Farrow to Wean
0.84 2025.24
Farrow to Feeder
1
Farrow to Finish
4.1
Wean to Feeder
0.072
Feeder to Finish
0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 2025.24 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 10126.2 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 33 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 81.0096 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
if surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table, Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
'This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 11

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts,
Soil
Application Rate
Application Amount
Tract Hydrant
Type
Crop
inlhr
* inches
9295 1
VVoodingtor
0
0.4
1
2
VVoodingtor
0
0.4
1
3
VVoodingtor
0
0.4
1
4A
Autryville
0
0.6
1
4B
VVoodingtor
0
0.4
1
5A
Lynchburg
0
0.65
1
5B
VVoodingtor
0
0.4
1
6A
VVoodingtor
0
0.4
1
6B
VVoodingtor
0
0.4
1
6C
Lynchburg
0
0.65
1
7A
Norfolk
0
0.5
1
7B
VVoodingtor
0
0.4
1
8A
Norfolk
0
0.5
1
8B
VVoodingtor
0
0.4
1
Sub 1
VVoodingtor
0
0.4
1
6of11

Additional Comments:
7of11

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 3113
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature:
Date
Name of Manager (if different from owner):
ASignature: / IJ ZS _a
Date
Name of Technical Specialist:
Dawn Williamson
Affiliation:
Mur h -Brown, LLC.
Address:
2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone:
9( 10)293-3434
Signature:
_ U -_A S�
Date
8of11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
a Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste. is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following.
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential properly boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
10 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge,
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
11 of 11

Michael F. Easley, Governor
William G. Ross Jr„ Secretary
North Carolina Department of Environment and Natural Resources
May 20, 2005
Murphy -Brown, LLC
Farm 3113
P.O. Box 856
Warsaw, NC 28398
Alan W. Klimek, P.E. Director
Division of Water Quality
RECEIVED
DENR-FAYUTEOLLE REGIONAL OFFICE
Subject: Certificate of Coverage No. AWS820341
Farm 3113
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
Dear Murphy -Brown, LLC:
In accordance with your request to change in operation type received on May 11, 2005, we are hereby
forwarding to you this Certificate of Coverage (COC) issued to Murphy -Brown, LLC, authorizing the
operation of the subject animal waste collection, treatment, storage and land application system in
accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Farm 3113, located in Sampson County, with an animal capacity of no greater
than an annual average of 2411 Farrow to Wean swine and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to
Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may
be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4
gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009, and shall hereby void
Certificate of Coverage Number AWS820341 dated October 15, 2004. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this permit.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
1""ithucar01 a
atra��
Aquifer Protection section 1636 Mail Service Center Raleigh, NC 27699-1636 Phone [phone] Customer Service
Internet: http://h2o.enr.state.ne.us 2728 Capital Boulevard Raleigh, NC 27604 Fax [phone].623-6748
Fax [phone]
An Equal OpportunitylABlrmativo Action Employer— 50% Recycled110% Post Consumer Paper

The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone], If you need additional information
concerning this COC or the General Permit, please contact 7 R 7oshi at (919) 7I5-6698.
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG 100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
APS Central Files (Permit No. AWS820341)
AFO Files

Murphy -Brown, LLC
3113
PO Box 856
Warsaw NC 28398
Dear Murphy -Brown, LLC:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P. E., Director
Division of Water Quality
October 1, 2004 RECEIVED
OCT 15 2044
OENR - FAWTWLLE REGIONAL OFFICE
Subject: Certificate of Coverage No. AWS820341
3113
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
On June 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on February 13, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to
Murphy -Brown, LLC, authorizing the operation of the subject animal waste collection, treatment, storage
and land application system in accordance with General Permit AWGl000O0. The issuance of this COC
supercedes and terminates your previous COC Number AWS820341 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the 3113, located in Sampson County, with an animal capacity of no greater than an
annual average of 2411 Farrow to Wean swine and the application to land as specified in the facility's
Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to Feeder
operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may be
replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4 gilts
for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this permit.
Aquifer Protection Section — Animal Feeding Operations Unil
1636 Mail Service Center, Raleigh, North Carolina 27699-1638 One
NorthCarolina
Phone: [phone] / FAX: [phone] Internet: h2o.enr.state.nc.us NaturallyAn Equal Opportunity/Affirmative Action Employer — 50% Recycled110% Post Consumer Paper

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone].
Sincerely,
lzde K
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG 100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
Permit File AWS820341
APS Central Files

W A
Michael F. Easley, Governor
O� 9
QG
William G. Ross Jr., Secretary
O�
7
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
October 15, 2004
Murphy -Brown, LLC
Farm 3113
PO Box 856
Warsaw NC 28398
Subject: Certificate of Coverage No. AWS820341
Farm 3113
Swine Waste Collection, Treatment, Storage
and Application System
Sampson County
Dear Murphy -Brown, LLC:
In accordance with your modification request received on October 5, 2004, we are hereby forwarding to
you this Certificate of Coverage (COC) issued to Murphy -Brown, LLC, authorizing the operation of the
subject animal waste collection, treatment, storage and land application system in accordance with
General Permit AWG 100000.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Farm 3113, located in Sampson County, with an animal capacity of no greater
than an annual average of 2000 Farrow to Feeder swine and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to
Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may
be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4
gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009, and shall hereby void
Certificate of Coverage Number AWS820341 dated October 1, 2004, and shall be subject to the
conditions and limitations as specified therein. Pursuant to this COC, you are authorized and required to
operate the system in conformity with the conditions and limitations as specified in the General Permit,
the facility's CAWMP, and this COC. An adequate system for collecting and maintaining the required
monitoring data and operational information must be established for this facility. Any increase in waste
production greater than the certified design capacity or increase in number of animals authorized by this
COC (as provided above) will require a modification to the CAWMP and this COC and must be
completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record kee in
and monitoring conditions in this permit.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
1V� hCaroiina
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636 Phone [phone] Customer Service c� �'0tk01;
Internet: http://h2o,enr,state.ne.us 2728 Capital Boulevard Raleigh, NC 27604 Fax [phone]
Fax [phone]
An Equal OpportunilylAfllrmative Acton Employer-50% Recycled)10% Post Consumer Paper

The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact J R Joshi at [phone].
Sincerely,
U/
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
Permit File AWS820341
APS Central Files

Murphy -Brown, LLC.
3113 Farm
PO Box 856
Warsaw NC 28398
Dear Murphy -Brown, LLC:
Michael F. Easley, Govemor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P. E., Director
Division of Water Quality
June 25, 2004 DENRM_ FRO
JUN 3 0 2004
®t!!! O
Subject: Certificate of Coverage No. AWS820341
3113 Farm
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your request for a change in operation type received on June 9, 2004 and in
accordance with the directive of Senate Bill 733, we are hereby forwarding to you this Certificate of
Coverage (COC) issued to Murphy -Brown, LLC, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the 3113 Farm, located in Sampson County, with an animal capacity of no greater
than an annual average of 2411 Farrow to Wean swine and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to
Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may
be replaced by an equivalent number of sows. Any of the sows may replaced by gilts at a rate of 4
gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004, and shall hereby void
Certificate of Coverage Number AWS820341 dated May 1, 2003, and shall be subject to the conditions
and limitations as specified therein. Pursuant to this COC, you are authorized and required to operate the
system in conformity with the conditions and limitations as specified in the General Permit, the facility's
CAWMP, and this COC. An adequate system for collecting and maintaining the required monitoring data
and operational information must be established for this facility. Any increase in -waste production
greater than the certified design capacity or increase in number of animals authorized by this COC (as
provided above) will require a modification to the CAWMP and this COC and must be completed prior to
actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the Facility. FMA
Non -Discharge Permitting Unit
1617 Mall Service Center, Raleigh, NC 27699-1617
intemet http://h2o.enr.state.nc.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/10% post -consumer paper
Customer Service Center
An Equal Opportunity Action Employer

Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue, the'� activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact J R Joshi at [phone] ext. 363.
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG 100000)
cc: (Certt .Icate._of Coverageonly for all ec's
ayettexilleR�gOffice�W.,aterQualiry Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
Permit File AWS820341
NDPU Files

Waste Management Plan Changes
i
"1 !; Q 2003
LD`ti�r
Facility $ Z - Farm 3- (l 3
This farms Waste Management Plan has made the following changes:
❑ Crop changes
❑ Wetted Acres
❑ increased Acreage
❑ Decreased Acreage
❑ Changed Irrigation Design
❑ Change in Farm type
❑ Plan based on 3 Years On Farm Records
ETI-O,-ther
Comments:
Date
0

'• a
Murphy -Brown, LLC
Grower(s):
Farm Name:
07/16/2003 '5¢t P.O. Box 856
5-1 Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Murphy -Brown, LLC
3113 Amendment
County: Sampson
Farm Capacity:
Farrow to Wean
Farrow to Feeder 2000
Farrow to Finish
Wean to Feeder
Feeder to Finish
Storage Structure: Anaerobic
Storage Period:
Application Method:
>180 days
Irrigation
Lagoon
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

Reception
Trwt Field IrriGated Soil Ist Crop Time to Ist Crop Ist Crop �c Lbs N Total lbs N
hEgi! code Ap& Yield lbs NfUnit Residual /Ac Utilized
_ NfAc Lbs N Total
2nd Crop TOjito 2nd Cmp 2nd Crop LbsActuage
1 code Al-!tv Yield lbsNIUnit Residual IAr- Uwi
MIMI
3(a) of 8

'Reception Area Specifications
Tract Field Irrigated Soil IstCrop Timeto IstCrop 1stCrop LbsKlAc LbsN Totams
..►_
3(h) at 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above,
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded In bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The Ideal time to Interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two Inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Corn - Grain
E Corn - Silage
F Cotton
G Fescue- Grazed
H Fescue- Hay
I Oats
J Rye
K Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
P Pine Trees
Lbs N utilized / unit yield
1,6 lbs N / bushel
50 lbs N i ton
50 lbs N I ton
1.25 lbs N I bushel
12 lbs N / ton
0.12 lbs N / lbs lint
50 lbs N / ton
50 lbs N 1 ton
1.3 lbs N 1 bushel
2.4 lbs N / bushel
50 lbs N I acre
50 lbs N / acre
2.5 lbs N 1 cwt
2.4 lbs N / bushel
4.0 lbs N 1 bushel
40 lbs N I acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

Additional Comments:
The acreage listed on this amendment Is the balance of the total field acreage
minus the wetted acres at this site. The areas not covered by the conventional
Irrigation system are being entered into the pumping records as sub fields
so that the acres can be claimed when making application with an Aerway
machine._ .
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 3113 Amendment
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
Ilwe understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. Ilwe know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature:
Murphy -Brown, LLC
Name of Manager (if different from owner):
3W.AIL�d jr�
Signature:
L. L o- LA ,L["
Date
/1l�J,Z-C-
Name of Technical Specialist: Dawn Williamson
Affiliation: Murphy -Brown, LLC
Address: 2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
Signature:
7-/6-63
Date
Date
8of8

ji
�4. 'lr `. , � r r t, 6? +!' r,. c +> d � } � Y4 �_r; , s t•' � ..
�- t ,... d�' rt• i r,y{7 a€ �e 1155 ri r, ° ,, :� ti� , ' �-ti;. Sl- 1�'f4 , '{., � F [: �; b s'S;• !�. A, ..� � tp FF.' �
;TATF n
i'�• < "r' 1 t Via,. r r A��ti �i'rLi!-€, J f `';.. -j I.[U j,a rrJ � 'l ;� i �i" �t 4, s? 7 "� t �. �t.. r�� r r ! s +t
t r, .. i y ,tl'r k, .A � [` ' •,ti14 a t,�+5d+�.1.� /., z� li �� f R �-�^ ' r � .A
� t ` �' � -� •-� ,e ryiya ! � `i��� w 1 f a • c t � r i;p„aE'r� �� ,..p,^ �i{r�3t �� ,� t ,� 04 �f t tt �;�" � ; , ,`� kSs t r "•; y,
a'�{-„'• '{' "•�'�{i.�S��.��'`P�� r t�. `.ti ��'{• � -1 'I��a„f i, S�. , �Yl n�r�l. � �'� r' r ; n il'6� � i• t ,� .� X� r �'� �,
yt ,f •.ti _ 1• rl,r���p,,,,,, " i{y a �+ 1 �('ar• t r "F1- '0 5 7�.r-t7'�''N r`�f E. r,t s .i#�.; { _r f _{ u.
A
Fr' Y. �� l } ' s }r ih f� t�.tir *, �' { 1.'.t,ry.f kr* - �.•�
4 r I y 1< .,e I*N _ t.} -e E♦ �s,! lr� �t 1�' 44 °�t 7 J[l�r- {
r �,j�y`^�"
� -1 - .'+ d 'tlt , - r • •� ~ - �,a: •.! '
• ' � t- - ''w 'X � [• �` t �. i F •„'� t ' e. aTj .y r 1 {•' 1 •�
{ } , l i •+4 A };,; y! b 'kV t ! 1y,, y, at ' + r�1'+` "tl t t E t « r i{ r T
tr yS1 � �, �l ��x'AA- 1� r�, �yt r ��• n aht�� + � .tw r . E.{ 7 h i !! t �' > �•}+�. �r r
F
rc -_ � " -fiti' 1irZ Y, �, yY , ,• �i: r f! lr�
tr a' (r 7 .: ' "[A!_ • i': ,_ �.: �(•1 1' ) I't!'' ,.r . • r 5r�' 2 7 i'I+y r [' ,: i
kt+5ttr x s ra'ff' t1� ` 1 yr? r1•.
} tr ;tj � •fi � r§ t t q
ft vyt 1�4. f +��. ` �•{r+! ;JL'! i o,' !r 'E1 T,F4 r .
t rTr { 'S � -+t l p e a 'thr d+ +' ''� ,. r, Lj I � :ti 1 ! '; � 4• yyy���Y� t i i5� ! `� .t� 11 q
`Ir ,t � -, �: ,��, �'}i �, rn,. 7.}, �r�t�}' N�',e7, y_' r'_.5"- i'" d. ! .t', �C it�r } •
%•"r3r,� L; r a �t _� , � �'. ,�t'i'{� •w. t�}r�,�t''{jj;ey,•rs {`+yilu„i, e Ate �� - �'�J I=E •
w! i iiY �, �,�a - ?S � t I, i W. �; '1 � .���" �f,��'f •t ,ti.. "'�� j �S 6k'' F r }F 1.i� F t t , }[} ' t rh,�"� r`' •ram } '!�„ r, {� .
SAA
t{11 y #
fy'�] rr'� �! -'•,. -S'+5 ;f.,.. I /@. ,. h.. • , r: .0 �.� F f fir, �r y rreF 1 •h u'X y,{
�y�>i .ti . 1 y `1 �+,i' .� ; X`Ri' ��•'+w.a.•„ '�YR ry'�Sf C� Y f��f}._r4��, �'•k�"� -.ef.��f � �h�ki' �ttry-��� r �, w�� ti+, ":' �Ybr r4
T G �Y {�,l..�� + fk l�iif F wYn✓c j�"Tr.
r l•
TL
�._ b i p • :., 1, P t .� i s ` r t•,,yywE yl hrj7 1 f„� t "W� T4f3-�rj�_r IJFi't 'z°ah N Lit 'ri�s.,f�'I7.l: .�ht,.'�i �![[ 3 �
:1 i
'41
1
t t
?Y gy�yyp Y S ft: .
i
E�•1h;.H rry
J 'Mi *t' �..
il.-:
d�• r�i•t a�' .:,t .. I 91.,
yyua
� t� ' ,� f J n t,� � r��;�t � Ott: ' ��f' 1 •�t{.'^ ��� t `f�'1
rl `� �tl '•i"' e
� t ^t.' tr 1 k shrr r fC " R�� ... � I s •,
l®r:;..
' QNIX
� , `!ief„�rs-��- .�iji}• a �+� .' C1 �rl ��!•`'�{y7.!'yri 1 .� I �;�
ry� �� 1 n � t r ry { ' §antra `fi.j•, %'Q' _ 'a i +. i•r �' I} .'t; t'
r4y,s14ff
$� �"-.�•a I�� �� y-k=-f �`'ii r '. Y'r3. +`�N SS,r+ tR
J'r - ^77 °' t� _ •t - [S 5� � t ;Ti i�. �-t i*'�
'i �69• f;�f:i. tt..:r •i' i"l,�tilli�`�I,:,'F':;Y'�'Y ,1 �"�:t �CF,S^�'ks"ri� .,te P,o[`>•�i�S ....,'JAI

State -of North Carolina
• Department of Environment, Health and Natural Resources
Division of Water Quality
Non -Discharge Permit Application Form / Survey
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL)-
,
General Permit - Liquid Animal Waste Operations '2 r� m
The fallowing questions have been complet g 'nf9r „ tion on file with the L" �;'`'
Division. Please review the information for �fi, nake any correct4ons ^,
which are appropriate. If a question has not been completed by the Division, ple*ce x rn w r,.
complete as best as possible. Do not lej�t ry 19�fstion unanswered.
o
FAYTEM (-
Application Date: _ /- 97 E _ _ •_ S-E
REG- 0FE=(,CE
I. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
1. One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
2. Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is disposed;
3. Two copies of the Certified Animal Waste Management Plan (CAWMP). If the facility does
not have a CAWMP, one must be completed prior to submittal of a general permit application
for animal waste operations.
II. GENERAL INFORMATION:
Farm's name: Farm #
2. Print Land Owner's name: _ Brown's of CUlina INC
3. Land Owner's Mailing address: PO Box 4JJ7
City: Warsaw NC Zip: ,28398
Telephone Number:-94$44
4. County where farm is located: SgMpson
5. Farm Location (Directions from nearest major highway. Please include 5R numbers for state reads. Please include a copy
of a county road map with the location of the farm identified): Hwy NC 9Q3 on Samnson-DuDupl,in Co. line approx. 10
miles W. of Magnolia
6. Print Farm Manager's name (if different from Land Owner):
7. L a name (if applicable; please circle which type is listed): ErowC-.
82 - 341
FORM: AWO-G-E 2/26/97
Page 1 of 3

III. OPERATION INFORMATION:
r
1. Farm No.: _U-34.1
2. Operation Description: Swine r��e ation
Farrow to Feeder
2000 - Certified Design Capacity
Is the above information correct? z yes; 0 no. If no, correct below using the design capacity of the facility
Typc of Swine No, of Animals 'hype of Poultry No. of. -Animals TyK-of,Cattle
0 Wean to Feeder 0 Layer 0 Dairy
0 Feeder to Finish 0 Non -Layer 0 Beef
0 Farrow to Wean (# sow) 0 Turkey
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the farut: No. of Animals
0•
I Acreage cleared and available for application: ; Required Acreage (as listed in the CAWMP): O _•
4. Number of Lagoons: ; Total Capacity: J5g4977 _ Cubic Feet (0)
Number of Storage Ponds: O ; Total Capacity: Cubic Feet 0)
5. Is animal waste being applied on any field which has subsurface drains? or NO (please circle one)
6. Are subsurface drains present in the vicinity of or under the lagoon? YES or ( (please circle one)
I V . APPLICANT'S CERTIFICATION:
I, _ _ymr/ftlu 821r=-J (Land Owner's name listed in question 11.2), attest that
this application for QQ Jr � t�A/A, 1AIC 1 6;bZ,21 J3 (Farm name listed in question II.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are completed and that if all required supporting information and attachments are not included, this application package
will be r med to a as incomplete. r
V . MOAGEWSJCERTIFICATION: (complete only if different from the Land Owner)
I,
(Manager's name listed in question 11.6), attest that this
application for _ _ (Farm name listed in question 1I.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signature Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
PERMITS AND ENGINEERING UNIT
POST OFFICE SOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FORM: AWO•G-E 2/26/97
Paize 2 of 3

ANIMAL WASTE MANAGE' .,..o.;NT PLAN CERTIFICATION F vR EXISTING FEEDLOTS
Please return the completed form to the Division of Environmental Management at the address on the
reverse side of this form.
Name of farm (Please print) • Brown's of Carolina,
Inc.
Farm #
Mailing Address: P.O. Box 487
Warsaw, NC 28398
Phone o.: [phone]
County (of arm):
arm location: Latitude and Longitude: _Jy'e _Jo ,,
—i
IT` (required). Also, please
a c
copy of a county road map with location iden ed.
Type of operation (swine, layer, dairy, etc.) :
S�✓.N�°
Design capacity (number of animals) :
yQod
.00 )*�4P_ea) W F � ---
Average size of operation (12 month population avg.):
g000
s?3v
Average acreage needed for land application of waste (acres)
Ch
�i .&1
Technical Specialist Certification
As a technical specialist designated by the North Carolina Soil and Water Conservation Commission pursuant
m 15A NCAC 6F .0005, ' I certify that the existing animal waste management system for the farm named
above has an animal waste management plan that meets the operation and maintenance standards and
specifications of the Division of Environmental Management and the USDA - Soil Conservation Service
and/or the North Carolina Soil and Water Conservation Commission pursuant to 15A NCAC 2H.0217 and
i5A NCAC 6F .0001 - .0005. The following elements and their corresponding minimum criteria have been
verified by me or other designated technical specialists and are included in the plan as applicable: minimum
separations (buffers); adequate quantity and amount of land for waste utilization (or use _ ).?r-.
access or ownership of proper waste application equipment; schedule for timing of app „a Mori
rates; loading rates; and the control of the discharge of pollutants from stormwater runo evens `less sev1.ere
than the 25 - year, 24 - hour storm.
._il+�. 2 9 1991
When checked, see reverse side of form for conditions/exceptions. FikyiE__ _
Name of Technical Specialist (Please Print): REG. 07r"PiG
Affiliation (Agency): --Brown's r 1' Tn
Address (A cy): 2-7 Wamsmaz- :!n a - Phone No.: a _
Signature: �.svL Date:
Owner/Ma.nac,er Agreement
I (we) understand the operation and maintenance procedures established in the approved animal waste
management plan for the farm named above and will implement these procedures. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
acilities will require a new certification to be submitted to -the Division of Environmental Management
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste
from this system to surface waters of the state either directly through a man-made conveyance or through
runoff from a storm event less severe that the 25-year, 24-hour storm. The approved plan will be filed at the
'arm and at the office of the local Soil and Water Conservation District.
Name of Land
Signature:
Vame of NIap�
signature: �/�
Owner (Please Print): A&e,�,ds—
_ Date:
m owner
ate:
)te: A change in land ownership requires nodfscicion or a new ccrtirication (irthe approved plan is changed) within 60 days of a tide transfer.
DENI USE ONLY: ACE#

All ssttatements checked apply to this certifi '-,)a:
V The installed irrigation system has not been evaluated concerning noale size, spray pattern, spacing. Pump 5LITe, PIpe size;
etc. It is the responsibility of the producer to operate the system with the proper components and to supply the required
maintenance to assure that no runoff occurs.. The producer is encouraged to have an irrigation specialist, possibly the dealer
where the system was purchased, prepare an operation and maintenance plan for the irrigation system so that the produce
knows how to operate the equipment to meet the non -discharge requirements_
The waste management plan for this operation is based upon yields higher than what is now recommended by NRCS;
however, these yields are obtainable under high levels of management. This increase in projected yields is necessary since
the MRCS plan prepared for this operation at the time of construction was based upon these higher yields and the producer
followed NRCS guidelines when building this operation.
Because of limited acres for Iand application, and because the original NRCS waste utilization plan did not require
additional acres for buffers and irrigation inefficiency, it may be necessary for the producer to operate half sprinklers, on
solid set systems, along field edges and ditches. Also for traveling irrigation systems, a pull directly adjacent to the ditch with
only a 180 degree'pumping radius may be needed to irrigate the entire field. Extreme caution should be exercised when .
applying waste close to ditches and wetlands to avoid any discharge.
�,2Ql. i�,rf ��s D�SiE�titp MSM- 0 _BV
CERTIFICATION FOR EMTING FEEDLOTS
INSTRUCTIONS FOR CERTIFICATION OF APPROVED ANIMAL WASTE MANAGEMENT PLANS FOR EXISTING ANIMAL
WASTE MANAGEMENT SYSTEMS SERVING FEEDLOTS
RE QUIREMENTSIPURPOSE
Ia order to be deemed permitted by the Division of Eavironmental Management (DEM), the owner of any existing animal waste -
management system constructed and operational before January 1, 1994 which is designed to serve greater than or equal to the animal
populations listed below is required to submit a signed certification form to DEM before January 1, 1998. Pasture operations are exempt
from the requirement to be certified.
100 head of cattle
75 horses
250 swine
1,000 sheep
30,000 birds with a liquid waste system
The certification must be signed by the owner of the feedlot (and manager if different from the owner) aszd by any technical specialist
designated by the Soil and Water Conservation Commission pursuant to 15A NCAC 6F .0001-.0005. The technical specialist must verify
that all applicable operation and maintenance standards and specifications can be met. Existing systems are not required to meet design
and construction standards and specifications.
Although the actual number of animals on the facility may vary from time to time, the design capacity of the waste handling system should
be used to determine if a farm is subject to the certification requirement. For example, if the waste system for a feedlot is designed to
handle 300 hogs but the average population will be 200 hogs, then the waste management system requires a certification.
This certification is required by regulations governing anima waste management systems adopted by the Eavironmeatal Ma: agemeat
Commission (EifC) on December 10, 1992 (Title 15A NCAC 2H .0217).
CERTIFICATION FORM
On the reverse side of this page is the certification form which must be submitted to DEM before January 1, 1998. Assistance in
completing the form can be obtained from one of the Iocal agricultural agencies such as the Soil and Water Conservation District, the
USDA -Soil Conservation Service, or the N.C.. Cooperative Extension Service. The Completed form should be sent to:
Department of Environment, Health and Natural Resources
Division of Environmental Management
Water Quality Section, Planning Branch
P.O. Box 29535
Raleibh, NC 27626-0535

REGISTRATION FORM FOR AN AL FEEDLOT OPERATIONS
Department of Environment, Health and Natural Resources
Division of Environmental. Management
water Quality section
If the animal waste management system for your feedlot operation is
designed to serve moire than or equal to 100 head of cattle, 75
horses, 250 swine, 1,000 sheep, or 30,000 birds that are served by
a liquid waste system, then this form must be filled out and mailed
by December 31, 1993 pursuant to 15A NCAC 2H.0217 (c) in order to be
deemed permitted by DEM. Please print clearly&
IF
Farm Name: ... �lCI(I )"U
Mailing Address,.
County: Phone No.rflo. 111 3 -3LL!�
Owner (s) Name: `r ,gf'_tC,,►�i� L-
Manager(s) Name:
Lessee Name:
Farm Location (Be as specific as possible: road names, direction,
milepost, etc ) : / �z=�t.� c' c'_f c5-v /cf - Dy P�..�
Latitude/Longitude if known:
Design capacity of animal waste management system (Number and type
of confined animal (s)): -L;L,' -
Average animal population on the farm (Number and type of animal(s)
raised) 45C` (` �.:e:_r r�<:'is 1 ; �7 c_'_<fU "i'e/ ifI 1"i,
Year Production Began: « ASCS 'Tract No.: a�e;j-
Type of Waste Management System Used:-6�'! 40/6 J� �;1 1-41v r-1
Acres Available for La
Owneris) Signature (s) :
11
1JApplication of
Waste:_, r7 L -/ . .
t k-"ti'DATE' ;Z'-/-

NUTRIENT MANAGEMENT PLAN
Grower(s):
Farm Name:
County:
Production Unit:
No. of Animal Units:
Type of Waste Facility:
Temporary Storage Period:
Animal Unit Equiv. Live Wt:
Lbs/Animal Unit /Year.
Lbs of Plant Avail. N:
Brown's of Carolina, Inc.
Farm 13
Sampson
Farrow -Feeder
2000
Anaerobic Lagoon
180 days
522
6.5
13000
This waste utilization plan is based on the following fields, soil types, and crops. If this
information should change, please contact the Soil Conservation Service or Brown's of
Carolina , Inc. so that a new plan can be written .
Tract Field
Soil
Crop
I Yield!
I Ibs N1
Acres
Res N Cr
lbs N
Tlido 4u
Type
I Code
I Actunit
yield
Ibs N/ac
I Required
Apply
9295 1 Ln 0
33
4 20.00 2640.00
Jun-S
9295 1 Ln N
45
2.4 20.00 20.00 1760.00
S-April
9295 1 No 0
33
4 15.00 1980.00
Jun-S
9295 1 No N
60
2.4 15.00 20.00 1860.00
S-April
9295 1 Wo 0
28
4 30.00 3360.00
Jun-S
9295 1 Wo N
40
2.4 30.00 20.00 2280.00
S-April
Tota 1 65 13940.00
Available N 13000.00
;Difference
-940.00
A. Barley (1.6 lb N/bu)
I.
Oats (1.3 lbs N/bu)
B. Bermuda Grazed (50 lbs Mon)
J.
Rye (2.4 lbs Nlbu)
C. Bermuda Hay (50 lbs N/ton)
K.
Sm. Grain Grazed (100 lbs N/ac)
D. Corn Grain (1.25 lbs N/bu)
L.
Sm. Grain Hay (133 lbs N/ac)
E. Com Silage (12 lbs N/ton)
M.
Grain Sorghum (2.5 lbs N/cwt)
F. Cotton (0.12 lbs N/Ibs lint)
N.
Wheat (2.4 lbs N/bu)
G. Fescue Grazed (50 lbs N/ton)
0.
Soybean (4.0 lbs N/bu)
H. Fescue Hay (50 lbs Mon)
" A negative number reflects the total number of lbs of additional N needed to achieve

yields on acreage shown in chart. A positive number means additional land is required
to utilize the N produced by the animals:
This nutrient management plan has been specifically developed for this swine operation.
The plan is based on the soil types, crops to be grown, and method of applicdation for
this particular operation. The waste must be land applied at a specified rate to prevent
pollution of surface and/or ground water. The plant nutrients in the animal waste should
be used to reduce the ammount of commercial fertilizer required for the crops where the
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle and annual soil tests are
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to
be grown.
Several factors are important in implementing this nutrient management plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an environment-
ally safe manner. Always apply waste based on the needs of the crop to be grown and the
nutrient content of the waste. Do not apply more nitrogen than the crop can utilize. Soil
types are important as they have different infiltration rates and leaching potential. Waste
shall not be applied to land eroding at greater than five tons per acre per year. Do not
apply waste on saturated soils or on to land when the surface is frozen. Either of these
conditions may result in runoff to surface waters. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of
nutrients for crop production and to reduce the potential for pollution, the waste should
be applied to a growing crop or not more than 30 days prior to planting. Soil incorporation
of waste will conserve nutrients and reduce odor problems.
The acres needed to apply the animal waste is based on typical nutrient content for this
type of facility. Annual acreage requirements may be more or less depending upon the
waste analysis report for your waste management facility,
Additional Comments:
/V (Z'O
Ua-- ch�.'X 46_ /l /
-7
"K
�&OL�

Prepared by: c,
Title.
Concurred
in by: -�-�--
Producer
Date: S 7-9b
Date: r
understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This
equipment must be available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1-day storm event. I also certify that the waste
will be applied on the land according to this plan at the appropriate times and at rates
which produce no runoff.
Date:
Noder
l
Date:3
Tech i I Speci t

MRCS WASTE UTILIZATION
PLAN SPECIFICATIONS
I. Ari,•nal waste shall not reach surfact waters of the state by runoff; drift, matunadt conveyances, direct application, or
di.cect discharge during operation or land application. Any discharge or waste which reaches surface water is
prohibited.
2. There must be documentation is the design folder that the producer either owns or has a notarized ageement for use
of adequate land on which to properly apply the waste. If the producer does not own adequate land to properly
dispose of waste, he/she shall provide a copy of a notarized agreement with a landowner who is within a reasonable
proximity, allowing Uimlher the use of the land for waste application. It is the responsibility of the cwner of the
facility to secure an update of the Waste Utilization Plan when there is a change in the operaiton, increase in the
number of animals, method of utilization, or available land.
3. Ant.-, al waste shall be applied to meet, but not exceed, the Nitrogen heals for realistic crop yields based on soil type,
available moisture, historical data, climate conditions, and level of managctnent, unless there are regulations that
restrict the rate of application for other nutrients. Actual yields may he used in lieu of realistic yield tables at the
discretioa of the planner.
4. t , al waste shall be applied on lard eroding less than 5 tons per acre per czar. Waste may be applied to lard that
is eroding at more than 5 tons but less than 10 tons per acr ea per year p rovidiny grass biter strips are installed where
runoff leaves the field. (See FOTG Standard 393-Filter Serifs)
5. Odors can be reduced by injecting the waste or dishing after wast.:rppticntiiin. Wa:. ,. should not be applied when
there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be -,()it incutporated on conventionally tilled
cropland. Wixn applied to co=zvation tilled craps or grassland, Ilse wcs,e play be broadcast provided the
application d= not occure during a season prone to flonding. (sec-Whecuhor and Uimate in Norm Carolina' for
guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil 'alf.1tratirrtt rate such that rul'off does sot occure off -site
or to surface waters and in a method wEc% dots snot catse drift Cron-, the :ire durin: No ponding si ould
occur in order to controi odor and flies.
8. Animal waste shall not be applied to saturated soils, during rairifafi ct-cnts, or wlicrt the sup ac. is f ort ;.
9. Animal waste should be applied on actively growing crops in such a marut.r (hot the crop is not covered with waste
to depth that would prohibit grou•4. T-ne potential for salt daruiue li-titu anitnai ua:re sht)uld also be considt!7Zd-
10. Waste nutrients shall not be applied in fall or wi. ter for spi ing plantrd crul» cttt soils %vith a high potential for
leac:: .g. Waste nut; ;ent loadih2 rates on these sails should be ]tcld co a minirr.utn and a ;uitabie %vtnt_r cover crop
plar.,e~+. to tal-. up released nutrients. Waste shall not be applied net re thine dots pritjr tea planting of a crop or
forages breal ing dormancy.
11. A_hy new swine facility sited on or after October l , 1995 shall comply with the foliowing: The out.r perimeter of
the land area onto which waste is applied from a lagoon that is a cunipuner ut'a fazm shall be at least 50 fett
from ary residential property boundary and Isom any perm till strt:att: t:r rivtr utIicr than an irrigation ditch er
canal.. Ax iL-nal waste other tha.rt su,-ine waste front facilities sirod on ur at;tr Occubct' 1. 1995, shall not be applied
close. than 25 feet to surface water. This distance may be. r.due.d tits wltts that ar. slur provided
adequate vegetative filter strips are present (Se. Stand,tr l 39', - Filter

MRCS WASTE UTILIZATION
PLAID' SPECIFICATIONS
(COIN-Tr.
12. Acimmal waste shall not be applied closer than 100 feet from well;.
13. Ani--al waste shall not be applied closer than 200 feet of d%vellings other than those rf«,ied by [andowner.
lei. Waste shall be applied in a manner not to reach other propery and public r�glu-clt'-'c aea.
15. Animal waste shall not be discharged into surface waters, drainageways or %vetlands by a discharge or by over.
spraying. AziataI waste may be applied to prior converted cropland provided it has been approved as a [and
applications site by a "technical specialist". Animal waste applied on grassed watenvays shall be at agronomic rates
and in a manner that causes no runoff or drift from the site.
I6. Domestic and industrial waste from washdown facilities, showers, tni[ecs. ink:, etc:., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be escablislied un all di.turbCcl area: (lagoon embankments,
berms, pipe nzis, etc.). Areas shall be fenced, as necessary, to prt,tect the vt3tratiun. Veg.(atien such as trees,
shrubs, and other woody species, etc. are lirnit_d to areas when: co(isic!erccl appropriate. Lageen areas should be
kept mowed aad accessible. Lagoon berms and structure, AUIUItl I1c; inSj)CC !d regularly tbrevid.-nce of erosion,
leakage, or discharge.
13. If aninaI production at the facility is ter hated, the owner is MSnI Or-Sible for ubtainina and irnplCmentirg a "closure
plan' which will eliminate the possibilit of az illegal dischargC, p1ItItUiuu and erO.io!ri.
19. Waste handling szructures, piping, pumps, reels, etc., should be utspeC te'om a regular baJi: to prevent breakdowns,
leaks, and spills. A regular maintenance check st s�Zould be kept ini siiz.
20. Animal waste can be used in a rotation that it !odes vet=tsiblds and nui1Cr c:•up; for direct hunnan consumption.
Howe:•e-, if a..L—ial waste is used on crops for di: ecc hurnal: .shtwid otfly be applied preplarit wi4`i no
farther applications of animal waste during t�e crop scasoll.
21. High:- visible permanenet mark--rs shall be installed to marl: the top and hommi e[Cvadors of the temporary storage
(purnpi:ig voitatt:e) of all waste treatment lagoons. Pumping shall he mama%:l io niaincain the [iquid'level between
the markers. A marker will be re-uired to ma_''ti t.^.e ma.\r11W.111 Steil':Ir'C <i�[!{rl1C icfl' 1ti1�tC �iUl'^.se ponds, � I
22. Soil tests shall be made even -year, and a liquid waste analysis »Flail [-C tak::l within 60 d_':s of application
consistent w'iuh waste utilization plan. Poultry liner »,hall be tc;tld prior tci zipplicarimi. Sold and (vas:e analysis
records shall be kept for five years.
Dead animals will be disposed of in a *iat ter (liar ri�ut:�' scutr[atio�tt,.

EMERGENCY ACTION PLAN
PHONE NUMBERS
DWQ q10 SG 1554
E-'vfERGEti-CY t'vL.'LtAGEL)vfENT SYSTEM 911
S WCD 910S9 x 79b 3
MRCS 9i0 5'9z 7943
'This plan will be implemented in the event that wastes from your operation are Ieakin&
over-lowirg, or running off site. You should not wait until wastes reach surface waters or leave
your property to consider that you have a problem. You should make every e$art to ensure that
this does not happen. Uia plaWhpuld be post in an acggssib[_e_ locztioa-Fps au employees at the
facriiZy. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be possible.
Suggested responses to some possible problems are lisped below.
A- Lagoon overflow —possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump waste to fields at an acceptable rate.
c. Stop all flows to the lagoon 'u;imediately.
d. Call a pumping contractor.
e. Ma-ke sure no surface water is enter ina lagoon.
B. RurcF ilom waste application field -actions include:
a. L mediately slop waste application.
b. Create a ternporary diversion to contain waste.
C. Incorporate waste to reduce runoff,
d. Evaluate and elL-ninate the reasons) that caused the runoff:
e. Evaluate the application rates for the fields where runoff occurred.
C. Lv-k ge from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restaging pumps.

D. Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E. Le--kage from base or sidewall of lagoon. Often this is seepage as opposed to flowing
leaks -possible action:
a. Dig a small well or ditch to catch all seepage, put in a submersible pump, and pump
back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill holes and
compact with a clay type sail.
e. Have a professional evaluate the condition of the side walls and lagoon bottom as soon
as possible.
2. Assess the -extent of the spill and note any obvious damaves.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage noted, such as employee irijury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality) regional office;
Phone L6 ` S After hours, emergency number: qi_9. 733 39 Your phone can
should include: your name, facility, telephone number, the details of the incident from item
2 above, the exact location ofthe facility, the location or direction of movement of the spill,
weather and wind conditions. The corrective measures that have been under taken, and the
seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EvIS Phone number 911.
c. Instruct EMS to contact local Health Department.
d. Contact CES, phon umber & S"QZ 71(e/ , local S WCD office phone number
59zan�� ocal iti'RCS office For advice/technical assistance phone number
to 541. 7943
4. If none oFthe above works, call 911 or the Sheriffs Department and explain your problem to
them and ask that person to contact the proper agencies for you.

S. Contact the contractor of your choice to begin repair cEproblem to nlininnize off -site damage,
a_ Contractors Naive:
b. Contactors Address: ~�
c. Contractors Phone:
6. Contact the technical specialist who certified the lagoon (NRCS, Consulting Engineer, etc.)
a. Name:
b. Phone: o G I ca /o o Z� 3
7. Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems with
release of wastes from happening again.

1
i1•toittlily Nlnu:wement Methods'
(cllccl; wlticll method(s) arc lleilv! implemented)
I'D
llurial Ihrce feet bellealll dw surface of tic !!round within 24 Tours afler
l;nowled!!c of (he death. The burial must t)c at least 300 feet from oils' flowing
r
stfc:lnt of public holler of stater.
X❑
Renderirl;; at a Tendering plant licensed undc; G.S. 106-163.7
i
Coltlplcle incincTallon
❑
In the case of de d poul lIy only, placilt fr in a disposal pit of a size and' design
approved by the Department of Am-iculturc
Q
Any inethod which i!I the professionai opinion of the state vetcrinirian would '
mai;c possibir till. s;tivav of part of a dead animals v;tlt,c Without Cnd;ltll;crhw
human or animal licalth. (Wrillell approval of ille Stalc Velc.inarian must be
att;tchcd)
insect contl`oi ciiacmist rol' Allima! Operations
• ��ulll'CC f
Tt•�I111S1 l)psIls 111 rI1111111I IIU'4clf �/IIr. �lll�l'lil[ i�l'lll'i1f�S
--
I lu,h Gullets - •� Accnnlnialiult of s1llids U Fltlsh Sylivill II dclil,llcll will upurillclt
SnftlL'II:IIIIjr t;! f1aIlUYC IICGtIll111Iiltl'{I Sall{Is rfllltl •
1;111ICTS as dCIII,lIC11.
Fl Itcltlnvc Iltidl;hll; af;tcculuul;ticll solids 111
Ilisr,Ilarl;u
Lu�u�ws dull Phi L'luslcd
Sulills Ivtuinluiu 1111;1ulals, xclllilir 1111615 Ilnei pils wha-L!
pcsl Ihrccllinl; is nppamil to nt111intizc Ills
crustittl; of sulills lu a depth of no ntofc awn 6 -
I1 illclics Ilvcr nlme plan 30% of surface.
I'f,cMjVC VL:i;L:lalivc • 1),cllyilig vcl;Claliull Ivlllialaill vcl..Clllllvu cunirul alultl,11alllcs ul•
tiluxllt
lal;nuns lulu nlhcr inlpntuldnlcnts to llrevclll
urcuntul:111o,, urdccnyin(; vul;laativc III:IIIrr
nluul; lwille1% edge un impn»udmcui's perimeler.

.`iWl11t? Fal'111 was(c
Management OdolCOili1.01 chocidi ;i
�rllH t't'C
aft 115C
11nirS 111 n11111i111le illl 11 k• - ----- -- Silt srlCllrf[ 1�1'tt l-Ill'c•>I
—
I•ikl!!!)liilll
• N%VIlIC 1110ilklC11U11
_
V+'r;l'1i111VL• 11r woullell Illlllew, _
llccnunncllllcd-llcsl nlallal;cnlcnt jlrattil:cs; .
•
�
�utli(�IU1j;1tlClll :N111 C1111ltlllnl St:IISC
• All mal lar.ly ]1I&ICCi
• 011ty lual1tnC-CI)VCIell allilllals
IIIY Illturs '
1.1.1111 suljaus
• Wet wallnlc•cuvcicd llutllrs
Sllttled llums;
Will'', us liiS ;Ltl ll over Sitllle , rl1f111'S;
n
Fenders lit 1111;II ellll ursrllils floor;
rI
Ncrallc lnanulc IlnildnJs rruul flours;
El
Unllct floor vculilarilm Cur rlrynll:
ALllnlle cullecliuu Mils
Mint:;
hellncol Inalulie rcnlovlll Ily 1111s11, pit lucllurr;e. -
l';lllull 11liCllilli�ll dCCnt1111oSllioll
ur scialll:;
f_l
Un1lcrllnnrvcnlilalinn
VC1161.11illll exhallil falls
• vlllalill: LascS;
_
l'lllt 11111J111C4111iCC;
1h131
Eflicicul uir nlllventew
hullltlr aulf;lct
llusl9,
Wilslltiulvll llellveell I;runlls uruu'tnlals;
I-1
I;Cill lllllfilives;
rJ
Feeder cuvem,
FI
l•ccll delivery 11111VIISIIUuII l:Klullllcl.s III rectler
rnWrs
Ffildl Illlll:i
`• Al-,lt;lllull Ilrlecycled lagootl
I 1
l'Illi11 111111; cllver5;
lilplid lvhil+: WAS Itn: flllilrl:
El
l-,coil fill liucs In near hollnut urlank with
111111-SI tlloll Vcllts
1'11uI11111C'•S
nj-,chili III dilln11; Misletvillcr
I_I
UndCrllmir MIA lvnll Illidt:1110111- v011ll;llltlll
C11lwyalice
I'It Ic lialj;k: Itp1111i
h 1;i1;11illll OfI1-.•yCICd 1;11;tUlll
I-1
1--mclIII IL:Clll11j,.0 lilies III Ileal' Illlntllll of pits
I1111Ii111VI111t: Ails lire filling
1V1111 nnli-sipluln Venls
Lill lRlliuui
AI;i111li+nl duliur; su1u11 folic;
(_!
:ilnup lunl; cuycls
filling lltlll 11(alv:fulvn
(lulildt1111�1111 C1111CCliull
Ar;llutilnl 1111I111t Wilslelvilrer
0
flux covers ,
i
tit jullClitlll hum
ClltlYl y1111C11
'
�_- 1�f.1tW I-Ittvcnllltcr11.1lhG.1'ul,u3

• :�nnl-��:
1.111tiL• ~---
..........uMiar�`
— —'—�`11A.11'5 fit A41111111lize 1`11111r� :;11C';IICI'Illc l'1'1IC11Ccs
1:1111 IIT11tail1111111a 111
• Al',11ilIIIIII dlllull; lYirSft'Waicl
I:xIC1111 discharge 1111utt Itrlllllt:s 111111cr111.'.1111
I moll
i:I1nVl:ynllGC
111 pild lCVG1 .
1.tih11n11 liltI:ICCS
• Vulai11c tits CI1,ISS11111s;
�I Itrllllt:r Ingoun hiluld u.n1jachy;
• lliatuf;lcni nllxinl;:
. }' Correr"l I.11,1tmt stal1111r llroccliures;
• A1;itnfGlll
i lvlinlnnnq self lea urea-111-volume rnlin;
1 Miulnlurrl Firilrlllnu tivllrn.pun,l,illl;;
f_1 htccllanical acrallun;
C1 Provell IliuinglCill a1111illves
fllil-mian lhilitl.lci
• f lil;ll luclsirle 111plaliuu;
1 11lig-illu fill illy days lvilll fitllu firllo 10e111;
nuiilks
Wilill 111i11
' hliuiltnlur rccnuullclUlcll Ilperallul; liressruc;
l hilly hifat.c imir Lagoon liquitl surftice;
f`1 lluulp From secolill-I.Inf:t:laguorl
I-allL fir 11:nill
9I'alli:ll alit uhi:il IIC1 lnlpusiliun;
(:1 I IIIIluu1 or n,idlcvel lu.uliol;;
su11;1C1
MIX1111; while iiliing;
C! Tunk covers;
a Agliatlun when rnllilyinl,
i l 1111sill surface mills orsolills;
CI Novell tl'Inlogicul iiddhives or oxidants
.';c1111nl:11.1111! lInhice
I'.11llal Illiefollial decollymiliu11;
C1
I-XIC1111 III.16111011t: uIl11ell1nldcr1IC11111 tilplid
•
Mixillf;,vllilc f111111;;
fl:VCl;
•
A gi1-111nn wilco clnplyitil1
Cl
Itclnove sclliell solids fegularly
hiluutrc, study fir s11u11;c� •
Ar.huliun ►vlicti sfncaifiuL;
Cl
Soil iltjccliurl ill'S1111ry/slutlgrs;
1prcader unllels .
Vulltlile gas clilissiolls
CI
Wosli*fesirlunl Illaillire rrullr sprcad5r oiler itsc;
C1
Novell liinlrll;irid ndililins or ulrldrulls
I111CIrvcicll mamll-C,
Vnl:ffile 1.115 cullssifins while
Cl
Noit Ill]CU111111 rll shilry/sludges
shllry or sillilgi: fill lield
Ilrying
C1
Soil Incor•1lorlllinll widliu Ala hrs.;
slufilres
Ft
S11rc;rll in lilill 11111 ilrnl Iayt:rs rur rapid ttryinf;;
i
i'rovcn illullig1rill Ilddillvcs or nKiihoils
n1
14;111111IIa11
1_:Ilc11SS11rcliillIloslllull
-
I'ltlfn:I tliSllmilim,of tllrc;lsslx
I IC:III 1116111.11111a111snI -
1�:111::ISS 11�L'lllllllnSi1111t1
f_1
C11n1111CIC CIIVI'011l1 (if 1:111cilms ill I1t111al 11il5;
phs
CI
11rnllef Inculifluli:nnslrllclinn 111'dispusal lilts - —
lu4inlr.duls
1nCI1111111cie CI11111111164111 •
1-1 Sccunthiry 5*It:k I1111na's
1 t ffnr. Us ...... ...1.— 11
Nw1f.
11un11 d

'. _
u..►���4w._..s..w�.�+�.r.r..=*.a.. - - -- __ _ - _ _ _ _ - _ - _-- _ _ _ �-�fR— .cay _.. --�=.a+..w�.•+....wrc...��...s.caa.wc.��-...•.�r.w.....+.�+•..a
� L'�nllt-iC ['ulntl Il�l1'i 111 11111111111tC r11I11i'
r '
Silc S Irt-IIII: I'r:10luts
:J:ulilnll: IY;11[f a1nI1N11 • lullllulrcr lhaitr.Il;c. Gralle and landscalle SIICII Ilial ►viler III-aills
Ia�ili[ics miemijinl IIeC1111 posiiin11 11r away f-flll, facilities
.
url:anle utnuer
hlittilllc llail:ctl 111110 • 1113111ly Illallnalalcll access tl1il11S I j,11,1 ffCE:1:SS COall 111aInlC11i111Ct1
p1111iic rfullls 11111111 ftlfnl
.. ,
1lcccsi
Aildhintlal Inrurulallnn :
Avn11011C Pn1111
5lville killourd Managelllcul ; 11,101l lillh/I1Ml' 1'ltcl ei
IICtil1, ('unnly I.KIt ls111t1 Ctn!►r
Stville 1'n11111c11nn I'ulln 1'oletlt1al 011ur Suurccs nail Ilcme111es ; FDA I: Fucl 51 era
NCSI1 - IIAII '
;1AUC I'n11111c11u11 1'uc1111y,%Iit,lllrc Alaual,r.tlrcul: I'll Iterllarl,r. - Lul,lanl "Tlcalulctll ; FIIA I: 120-011
NCSI1- 11A1i
-
!;%Viltr PIIIIIIICIIIIH 1 ,1Cilily MIIIIIIIII: Mfill III-.CllIL'lll: 01111criluor hlrlsll - Lagoon TucalfllClll ; FBAF [19-08
HCSlI - IIAI:
Lal:111111 I)cj11.11111111 MullIlgemelll rtlr LIYCSInck Mti111trC'I•Ienlmelll and Stllral:C ; MIA 1111-01
NCSI! - IIAI:
Ca1111fat111111irmoulfte 111111 Was le► alerA111111cal1un Iaplllmiwit; Ie11AL I•uel Sllcel
NC I) - IIAI:
Cuulnflliflr othif-I from Swine: 11,111111uti ; I'll1-33
KS11 - .,Mlle i's;Icnsltm
Iiuvltnualenlal Asturunce 1'rnl,rulll ; NI'1'C Manual
NC 11I11k l'rullslcm Aistic
I ,
np11uns fur Alnnul:Ina; 011ur: if rclnul rruw [lie S►vlh,c Otlur'1•usi: 1'nrcc
NCS11 Aod Cnln1n11n1cnllnns
flallance Cuucelus In Allllllhl Mlalnlfe Mandcclllelfl: Odors lulll Flies ; l'II0107, 1991 Cunrcrenct! PruccclltuCx
1 lurldll Clutptrnllvu 1ixlcrlslwl
it�
-
- • . ,
'''..
Altlsf' _►a.,v.•tu►u•r I1. 1111111_ ION! S

Facility Number and Name: Brown's 82-341 Farm #13
Instructions on last page

sa
4� Tt
�r 66)
SS Ua
High F
Freeboards
-�,-W i6ible, Acres,.-,,
r t� � e
Response
S' Hurricanes Dennis and
Since Floyd, Brown's has
a
implemented a number of measures designed to minimize the
-4
potential for future freeboard exceedances and over
application during prolonged or severe wet weather
conditions. These measures include water conservation,
which has reduced Brown's total annual water consumption
-71
4 iCg
hiring by approximately 40 percent; new employees;
3i �F,
t
enhanced training; ning; lagoon freeboard tracking charts; and the
Ik
purchase of additional equipment to maximize utilizati on of
-2,
Y"
our sprayfields and avoid land application under marginal or
-*
unsuitable conditions. Brown's EMS, which will bCISO
t
g -11;-
14000 certified by the end of 2001, will also contribute to
f
improved freeboard and land application management.
MLZ: 4
7
IN -4
In summer of 2000 farm fields were re -shaped to improve
drainage that contributed to high levels in 2000.'
�.4 1
N-A
_3
3
A

1 Concerns are based upon DWQ records consisting of deficiencies noted in state inspection reports, NOVs, penalty assessments and/or reports submitted to DWQ by the farm. Carefully
review your records to identify the specific concern or concerns and then describe the concern under the appropriate heading together with a reference to the specific record and the date of
the record (i.e., inspection report dated or NOV dated ___). With the exception of "discharges," which cover calendar year 2000, concerns are based on DWQ records for the
calendar years beginning January 1, 1996, and ending December 31, 2000.
z Describe in as much detail as possible how the concern has been addressed, or, if it has not been addressed, the measures the farm intends to undertake to address the concern and a
schedule for completing the measures.
31f subsurface drains are present, state whether you know that the drain(s) is discharging groundwater uncontaminated by hog waste, and if so, the basis for that conclusion.
4

North Carolina
Department of Environment and.Natural Resources
Water Pollution Control System Operator Certification Commission
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Coleen H. SulIins, Chairman
February 21, 2001
Brown's of Carolina, Inc.
PO Box 487
Warsaw NC 28398
SUBJECT: Designation of Operator in Charge
Farm Name: Farm #13
Facility ID #: 82-341
County: Sampson
Dear Brown's of Carolina:
NCDENR
MAR12 7 prn1
r ,SET
NEG. C, .
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study Commission on Agricultural
Waste, was enacted by the 1996 North Carolina General Assembly. This legislation requires owner of a certified
operator for each animal waste management system that serves 250 or more swine, 100 or more confined cattle,
75 or more horses, 1,000 or more sheep, or 30,000 or more confined poultry with a liquid waste management
system.
Our records indicate that the operator designated as the Operator In Charge (OIC) for your animal waste
management system is no longer certified. Therefore, you must designate a properly certified animal waste
management system operator as the OIC for your facility. The enclosed designation form must be returned to this
office by April 1, 2001. This office maintains a list of certified operators in your area if you need assistance in
locating a certified operator.
Failure to designate a properly certified Operator in Charge for your facility is a violation of N.C.G.S. 90A-47.2
and 15A NCAC 8F .0201(a) and may result in the initiation of enforcement action. Please be advised that nothing
in this letter should be taken as resolving you of the responsibility and liability for any past or future violations for
your failure to have a properly certified Operator in Charge designated for your animal waste management system.
If you have questions concerning this matter, or if this office can be of further assistance, please call Beth
Buffington at [phone], extension 313.
Sincerely,
Dwight Lancaster, Supervisor
Technical Assistance and Certification Unit
Enclosure
cc: TAC Files
Non -Discharge Compliance/Enforcement Unit
Fayetteville Regional Office
Central Files
1618 Mail Service Center, Raleigh, North Carolina 27699-1618
Phone; 919 — 733-0026 1 FAX: 919 — 733-1338
AN EQUAL OPPORTUNITY 1 AFFIRMATIVE ACTION EMPLOYER - 50% RECYCLED / 10% POST CONSUMER PAPER

Facility Number and Name: Brown's 82-341, Farm #13 Instructions on last pace
Description of Concern
High Freeboards
11/29199= 14"
2/1/00—EPOA
217/00 = 12"
2115/00 = 10"
2/25W = > 19"
4/27/00 — POA
512100 = 18"
514.100 — > 19"
5/30/00 = 18"
6116/00 = > 19"
7/26M = 18"
7/28/00 > 19"
9/1/00 = 16" POA
9/6/00 = 13"
9/20/00 = 17"
9/25/00 = 13"
1014100 = > 19"
2/12199 —NOD Freeboard < 19" 2/8/99
3/16/00 — NOV Freeboard
< 10" 1/31/00
7131100 — NOD Freeboard
< 19" 7126/00
INSPECTIONS
218/99 — Freeboard 12"
6110198 — Freeboard 16"
Freeboard levels < 19"
In Out
01/25/99 — 03/08/99
07/24/99 — 07/31/99
09/18199 — 10/01/99
10/23/99--12/04199
12118/99 — 02/26/00
04/22/00 — 05/06/00
05127/00 — 06103/00
09/05/00 — 09/30/00

High Freeboards
NM
SUF11
R. -n..C-4-1,1010
�-
Response�k
.M _ _
N
Since Hurricanes Dennis and Floyd, Brown's has
implemented a number of measures designed to minimize the
for future freeboard
n X • `
_
potential exceedances and over
application during prolonged or severe wet weather
r
`
'-^T- _ - :=5i:�'� - x • f ie s? -
conditions. These measures include water conservation,
r. r" -' a-'•s. -i"=.x -?
Z�k
Brown's total annual water consumption
which has reduced
v r
s � ,- x�- •
by approximately 40 percent; hiring new employees;
enhanced training; lagoon freeboard tracking charts- and the
-
"' e ti
�. we � �. ':E:e, •` 'gam' x.s.� .. .i� rx^Y"y4er � - w,
_ h
purchase of additional equipment to maximize utilization of
our sprayfields and avoid land application under marginal or�
unsuitable conditions. Brown's EMS, which will be ISO
14000 certified by the end of 2001, will also contribute to
w�
:. �..
i+ y�_ e�� si -'�: z�a c".,,'
improved freeboard and land application management.
In of 2000 farm fields were to improve
•k.--'�-�zRw.� r `�--� 4w3._ .k.ez .3a ?
summer re -shaped
drainage that contributed to high levels in 2000.
:[�'- �y. - - Gr � �� r. �'.- .�•�
...
_. _ .t, a'�'. X'.C. � +....-R` .r �. Y
�-r•«`C : �� Y ��„ � tq �� `:.-' -3F _� � �`"-✓u
1. -_
t
M--• _ram• i �" W
�.G

Facility Number and Name: Brown's 82-341, Farm #13 Instructions on last page
, Wff­ 2-11_1�a4
-�
3'�
Subsurface Drains
Over Application
Structure[sues
_
Cropping Issues
Description of Concern
No documentation of problems either in our
No documentation to support this
4
No documentation of problems either
files or DWQ files.
in our files or DWQ files.
Irrigation records show overapplication
-
of PAN on 4 hydrants on 1999 Summer
crop and on 1 hydrant in 1999-2000_
.~
Winter crop. No other overapplications
appear in our records.`-,
These overapplications occurred after
~
hurricane floyd (9/99)
Response
Subsurface drains present at the farm
Since Hurricanes Dennis and Floyd, Brown's
has implemented a number of measures��
NE
with no known problems. No evidence
��
Farm has had extensive land
that tiles are discharging contaminated
designed to minimize the potential for future
freeboard exceedances and over application
=�
F v _
planning done in order to help out
groundwater
during prolonged or severe wet weather
the field drainage.
conditions. These measures include water
_<
conservation, which has reduced Brown's total
annual water consumption by approximately 40
*; _
percent; hiring new employees; enhanced
training; lagoon freeboard tracking charts; and,µ_
F
the purchase of additional equipment to
maximize utilization of our sprayfields and
.
avoid land application under marginal or
unsuitable conditions. Brown's EMS, which
will be ISO 14000 certified by the end of 2001,,
will also contribute to improved freeboard and
-_
land application management.
C
_

Concerns are based upon DWQ records consisting of deficiencies noted in state inspection reports, NOVs, penalty assessments and/or reports submitted to DWQ by the farm. Carefully
review your records to identify the specific concern or concerns and then describe the concern under the appropriate heading together with a reference to the specific record and the date of
the record (i.e., inspection report dated or NOV dated _). With the exception of "discharges," which cover calendar year 2000, concerns are based on DWQ records for the
calendar years beginning January 1, 1996, and ending December 31, 2000.
` Describe in as much detail as possible how the concern has been addressed, or, if it has not been addressed, the measures the farm intends to undertake to address the concern and a
schedule for completing the measures.
3 If subsurface drains are present, state whether you know that the drain(s) is discharging groundwater uncontaminated by hog waste, and if so, the basis for that conclusion.
4

Soil survey sheet (s) or code nos. Aproximate scale I
14
Prepared by U. S. Department of Agriculture, Soil Conservation Service cooperating
R-Conservation,1
Mac -
No
• � •fx a
�•j" 1 '� � - _ - I Tom,? .� � I •.�.
� •y4�4- M1 , (�ryre� ��'Y.� �� t � � '� 1
A �
Am
OWN-
AW
LAI-
Pe
_c` - fi •
F � :may .�{•;-� � .- �
•. ,lei+^' t _ }1 '��'Rt"-a�1'`�'`'�IiAJ,�!`e`�v -

Y.f